VOLVO XC60. Wiring diagram 2010 TP

Transcription

1 VOLVO XC0 Wiring diagram 00 TP 90

2 Vehicles with SRS (Airbag)/SIPS bag/ic (Inflatable Curtain) Warning! Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/ic in order to avoid:. Personal injuries when performing repair work.. Damage or malfunction of the SRS/SIPS bag/ic system. Work involving the SRS/SIPS bag/ic systems or other components in the vehicle that may affect the SRS/SIPS bag/ic systems must always be performed by an authorized Volvo workshop. In case of doubt, consult the SRS and SIPS bag/ic service manual. Is the vehicle equipped with SRS/SIPS bag/ic? Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the dashboard above the glove compartment. SRS vehicles from 99 and onward also have explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 99 and onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with IC can be recognized by the letters IC on the C/D panel ( door) or the B panel ( door). General recommendations Be especially careful when working on or around SRS, SIPS, and IC components. Make sure that no wires are pinched, frayed, or pierced. Never install accessories by the sensors. Where applicable, work on the steering wheel, steering shaft, or steering gear must be done in accordance with the methods in the SRS section of VIDA. Certain components of the aforementioned systems must be grounded while working. Read the appropriate sections in VIDA. Install no accessories in the areas between the A and Bposts, the B and Cposts, and the C and Dposts. Test terminal Data link connector in the passenger compartment. Changes implemented up to and including December 008 Any changes made to the vehicles after this date are not included in the manual. If necessary refer to service bulletins. Volvo models are sold in versions adapted for different markets. These adaptations depend on factors such as legal requirements, taxation, and market demands. This manual may therefore include illustrations and text that do not apply to the vehicles in your country. Ordering: Electronic Wiring Diagrams (EWDs) can be ordered from the Technical Information Shop (TIS) at We reserve the right to make modifications. Volvo Car Corporation

3 Table of Contents : Vehicles with SRS (Airbag)/SIPS bag/ic (Inflatable Curtain)... Explanations... Abbreviations... How to use the wiring diagrams :... Electrical distribution :... 8 Fuses Distribution box in engine compartment FF Distribution box in engine compartment F9F... Distribution box in engine compartment FF0... Distribution box in engine compartment FF7... Distribution box in engine compartment F8F... Central Electronic Module () F F... Central Electronic Module () F F9... Central Electronic Module () F0 F Rear electrical center FAFA... 8 Distribution box in cargo compartment FBFB... 9 Rear electrical center FDFD Battery PFPF... Relays Relays in the engine compartment R... Relays in the engine compartment R8R9... Relays in the engine compartment R0R... Distribution box in cargo compartment RA... Central Electronic Module ()... Ground connections Overview... 7 / / /0 / continues... 9 / / /8 /89... /90 /XX0... /XX /TRM... Control modules Overview locations... Overview designations... Central Electronic Module () :... Data communication high speed... 9 Data communication intermediate speed, LHD... 0 Data communication intermediate speed, RHD... Data communication Local... Data communication, :... Data communication MOST... Steering Wheel Module (SWM)... Group Fuel system Engine management system Cyl. :... 7 Engine management system, Cyl. BS :... 9 Engine management system, Cyl. Turbo :... Engine management system, Cyl. Diesel EURO :... Emission control Cyl.... Group Cooling system Cooling fan Cyl. Diesel EURO... 7 Cooling fan Cyl Group 7 Engine controls Cruise control...9 Group Alternator and voltage regulator Power supply... 0 Group Starting system Starting system... Group Lighting High and low beam... High and low beam (Dual Xenon)... Beam length adjustment, manual... Running/Parking light, Tail lights... Running/Parking light, Tail lights (Dual Xenon)... Fog lights... 7 Brake lights... 8 Reversing lights... 9 Followmehome lighting LHD Followmehome lighting RHD... 7 Interior lighting, LHD :... 7 Interior lighting, RHD :... 7 Active headlight... 7 Lighting in door sill trims xiliary lights Group Additional electrical equipment Rain sensor Direction indicator and hazard warning flashers LHD Direction indicator and hazard warning flashers RHD... 8 Wiper/Washer windshield... 8 High pressure headlight washer... 8 Wiper/Washer rear window... 8 Horn... 8 Keyless vehicle :... 8 Antitheft alarm Parking assistance Collision warning with power brake booster Tire pressure monitoring system (TPMS)... 9 Alcohol lock... 9 TP90 XC0 00

4 Table of Contents : Group 7 Wiring and fuses Diagnostics system... 9 Outlet V... 9 Cable harness towbar/tow hitch pin... 9 Cable harness towbar/tow hitch 7pin... 9 Cable harness towbar/tow hitch pin USB unit (AUU) Group 8 Instruments Seat belt reminder Driver information module Group 9 Other dio Premium :... 0 dio :... 0 Cellular phone :... 0 DAB Radio Telephone system Bluetooth Bluetooth Handsfree... 0 Multimedia & Traffic information... Satellite radio... Parking camera... Group Transmission Transmission M... tomatic transmission, TF80SC AWD... Differential electronic module (DEM)... Group Parking brake Electric parking brake... 7 Group 9 Brake system Brake control system & DSTC... 8 Group Steering Speed dependent power steering... 9 Group 7 Shock absorbers FourC... 0 Group 8 Doors and openings Central locking front doors LHD... Central locking front doors RHD... Central locking rear doors... Central locking tailgate... Central locking fuel filler flap... Signal receiver central locking... Power windows front doors LHD... 7 Power windows front doors RHD... 8 Power windows rear doors... 9 Power sunroof... 0 Group 8 Exterior decorative elements, etc. Power door mirrors LHD... Power door mirrors RHD... Heated door mirrors LHD... Heated door mirrors RHD... Blind spot information system LHD... Blind spot information system RHD... Heated rear window... 7 Group 8 Interior equipment Power driver s seat with memory function, LHD... 8 Power driver s seat with memory function, RHD... 9 Power passenger seat, LHD... 0 Power passenger seat, RHD... Heated front seats... Heated rear seat... Group 87 Climate control system Climate control system PTCelement... Climate control system :... Parking heater, auxiliary heater... 7 Parking heater, remote start... 8 Group 88 Internal equipment Rearview mirror with automatic dimming... 9 Supplemental restraint system :... 0 Remote controlled garage opening... Index :... List of components :... TP90 XC0 00

5 Explanations Abbreviations Groups Group Group Group 7 Group Group Group Group Group 7 Group 8 Group 9 Group Group Group 9 Group Group 7 Group 8 Group 8 Group 8 Group 87 Group 88 = Fuel system = Cooling system = Engine controls = Alternator and voltage regulator = Starting system = Lighting = Additional electrical equipment = Wiring and fuses = Instruments = Other = Transmission = Parking brake = Brake system = Steering = Shock absorbers = Doors and openings = Exterior decorative elements, etc. = Interior equipment = Climate control system = Internal equipment Ignition switch symbols X = Accessories (audio position) S = Powered upon insertion of key = Contact remains connected during start l = Contact is broken while starting 0 = Constant power from the battery 0 = Start Countries/Markets A = stria AUS = stralia B = Belgium CDN = Canada CH = Switzerland D = Germany DK = Denmark E = Spain EU/OS = Markets outside USA and Canada FIN = Finland GB = Great Britain ISR = Israel J = Japan KOR = Korea N = Norway NL = Netherlands S = Sweden USA = United States of America WEU = Western Europe Other ACC AUTO BLIS DPY ECC ETA EXC GDL HS IR LH LHD MAN MEMORY MS MMS PETROL RH RHD SCR SRS T W/O WD CYL, I CYL, I CYL, I 8CYL, V8 Colors, SB BN, BL GN GY, GR LGN NL OG, OR PK, P, R VT, VO, W, Y = Adaptive Cruise Control = Silver plated = Gold plated = tomatic transmission = Blind spot information system = communication = Display = Electronic climate control system = Throttle unit = Exclusive = Gas discharge lamp = High speed data bus = Infrared sensor = communication = Lefthand side = Lefthand drive = Manual transmission = Memory driver s seat = Midspeed data bus = Mass Movement Sensor = Gasoline = Righthand side = Righthand drive = Screened = Airbag = Turbocharged engine = Without = Twowheel drive = cylinder engine = cylinder engine = cylinder engine = 8cylinder engine = Black = Brown = Blue = Green = Gray = Light Green = Natural = Orange = Pink = Red = Violet = White = Yellow TP90 XC0 00

6 How to use the wiring diagrams : The descriptions below apply in general to all wiring diagram manuals, although not all sections are necessarily contained in this manual. A. Component designation Every component has a component designation that consists of two parts. The first part is a type number that describes the type of component in question, for example /xx. The second part of the designation is a serial number, e.g. x/. Together, this constitutes a component designation, e.g. /. At the end of the manual is a list of components, where, with the help of the component designation, you can read off the name of the component, for example, / = light switch. List of type numbers The list shows which type of component that respective type numbers refer to, for example, /x = switch, /x = electric motor, etc. Battery Relay Switch Control module Driver information module Electric motor 7 Sensor 8 Actuator 9 Heating element 0 Light Fuse Electrical distribution rail/box dio 7 Service/diagnostics 8 Contact reel 9 Meter 0 Ignition component/shunt 7 Optics Ground connection 7 Branching point 7 Connector B. Branching points The wiring diagrams contain numbered branching points, for example 7/0. This manual contains a section with a list of branching points. This list shows all the components that are connected to each branching point. The location of the branching points is shown in the "Cable harness routing in vehicle" section. C. Connectors Connectors provide a bridge between two cable harnesses and are described in the "Connectors" section. D. Electrical distribution Operation of the fuses and relays is shown in the "Electrical distribution" section. E. Data communication Today s cars contain, and MOST networks that transfer information. Connections to these networks are not shown in their entirety in the respective wiring diagram. Complete information on, and MOST communication is found in the section "Control modules". F. Abbreviations A number of different abbreviations are used in the manual. These are explained in the section "Abbreviations". G. Component location The end of the manual contains a section that describes component appearance and location in numerical order. TP90 XC0 00

7 How to use the wiring diagrams : List of symbols = System voltage = Ground connection via wiring = Ground connection in component/chassis = Screened wire = Junction point = Twisted cable = Electrical connection = Variant = communication = high data signal ( H) = low data signal ( L) = communication = communication = DIN cable, coaxial cable, etc. = Data communication = communication = MOST communication = MOST communication = Connection with distribution box = Further connection to... = Connector between cable harnesses = Connector connected in component TP90 XC0 00 7

8 Electrical distribution : Overview, Electrical center and Cold zone in engine compartment GYVT / / B/9 B/8 GYVT B/7 B/ GYVT 7/08 B/9 B/7 OG B/0 B/ B/ B/8 GYVT B/9 OG B/ / R / B/8 B/7 B/ / R R0 B/ B/0 B/ B/ VT VT VT 7/0 GY /7 R /C: /C:8 7/08 /B: VTGN VT CYL GY A/ A/ A/ B/0 B/ B/ B/ / R /9 R9 B/ B/ / R8 A/ A/ A/ A/ A/ A/ A/7 B/ B/ B/ B/9 B/ B/0 B/8 GNVT _ GN GY BN /C: 9/ /C: /C: / / / B/ B/ / V PF PF / 7/07 C: / B+ ACM G / M 0 C: TP90 XC0 00 8

9 Electrical distribution : Overview, rear electrical center 0+ / A/ A/ A/ GY GN BN 7/0B GY BN GN 7/07 GN GN VT GN GN GN / D/A D/A D/A D/A D/A D/A D/A7 D/A8 D/A9 D/A0 D/A D/A NL D/B D/B D/B D/B D/B D/B D/B7 D/B8 D/B9 D/B0 D/B D/B VT GY GY GY 7/00 / RA RB 7/0 VT /8 RA A B D /88 RB D/D D/D D/D D/D GY VT GY D/D D/D D/D7 D/D8 D/D9 D/D0 D/D D/D BN G097 TP90 XC0 00 9

10 Fuses Distribution box in engine compartment FF7 / Distribution box in engine compartment No. No. Fuse function via A F A/ Main fuse for fuses in 0 F A/ Main fuse for fuses in 0 F A/ D/AD/A Fuses in cargo compartment fuse box 0 F A/ /88 Relay, feed rear 0 D/BD/B8 Fuses in cargo compartment fuse box /88 D/B9D/B Fuses in cargo compartment fuse box F A/ D/DD/D7 Fuses in cargo compartment fuse box 0 F7 A/7 9/ PTCelement 00 continues TP90 XC0 00 0

11 Fuses Distribution box in engine compartment F9F / Distribution box in engine compartment No. No. Fuse function via A F9 B/9 / Wiper motor module (WMM) 0 F0 B/0 /7 Combustion preheater module (CPM) F B/ / Fan control module /8 Motor, passenger compartment fan F B/ / Brake Control Module (BCM), pump 0 F B/ / Brake Control Module (BCM), valves 0 F B/ /8 Headlamp Control Module (HCM) 0/ Lamp housing, front left 0/ Lamp housing, front right F7 B/7 FF Fuses in the Central Electronic Module () 0 F8 B/8 /80 Forward Sensing Module (FSM) 7/0 Forwardaimed radar (FLR) F9 B/9 /99 Electronic power steering control module F0 B/0 /9 Supplemental restraint system module (SRS) /8 Transmission control module (TCM) / Engine control module (ECM) F B/ 9/ Heated windshield washer nozzle, left 9/ Heated windshield washer nozzle, right F B/ / Light switch module (LSM) F B/ /0 High pressure headlight washer motor continues TP90 XC0 00

12 Fuses Distribution box in engine compartment FF0 / Distribution box in engine compartment No. No. Fuse function via A F B/ 9/ Front V outlet 9/ Outlet V rear F B/ /7 Switch unit, ceiling light / Panoramic roof control module /8 Damper Motor Module (DMM), recirculation /9 Damper Motor Module (DMM), temperature, lefthand side /9 Damper Motor Module (DMM), temperature, righthand side /0 Damper Motor Module (DMM), defroster /0 Damper Motor Module (DMM), floor/ventilation 7/9 Air quality sensor (AQS) F7 B/7 / Relay, feed /9 Relay, comfort functions F8 B/8 / Relay auxiliary lights 0/ xiliary light, front right 0/9 xiliary light, front left F9 B/9 /7 Relay, horn /0 Horn F0 B/0 / Main relay, engine management system / Engine Control Module (ECM), Cyl. continues / / /7 0 0 TP90 XC0 00

13 Fuses Distribution box in engine compartment FF7 / Distribution box in engine compartment No. No. Fuse function via A F B/ /8 Transmission control module (TCM) F B/ 8/ Electromagnetic clutch, climate control system / F B/ / Relay, climate control system F B/ / Starter motor / 0 F B/ /09 Glow plug control module, Cyl. Diesel 0 0/8 Spark plug with ignition coil, Cyl. 0/ Capacitor, Cyl. F B/ / Engine control module (ECM), Cyl. Diesel /0 Throttle unit, Cyl. Diesel / Engine Control Module (ECM), Cyl. /0 Throttle unit, Cyl. F7 B/7 7/7 Mass air flow sensor MAF, Cyl. Diesel 8/98 Control valve fuel pressure, Cyl. Diesel 8/ Control valve fuel flow, Cyl. Diesel / Engine Control Module (ECM), Cyl. 7/7 Mass air flow sensor MAF, Cyl. 8/ Injection valves, Cyl. continues / / 0 0 TP90 XC0 00

14 Fuses Distribution box in engine compartment F8F / Distribution box in engine compartment No. No. Fuse function via A F8 B/8 / Control motor, turbo, Cyl. Diesel 7/ Oil level sensor, Cyl. Diesel 8/ Electromagnetic clutch, climate control system, Cyl. Diesel 8/ Bypass valve, EGR cooling, Cyl. Diesel 8/0 EGR valve, Cyl. Diesel / Engine Control Module (ECM), Cyl. /9 Upper actuator motor intake manifold, Cyl. W/O Turbo. /0 Lower actuator motor intake manifold, Cyl. W/O Turbo. 8/ Electromagnetic clutch, climate control system, Cyl. 8/8 Turbocharger control valve, Cyl. Turbo 8/8 Relief valve, Cyl. Turbo 8/7 Solenoid, variable valve timing, intake, Cyl. Turbo 8/ Solenoid cam profile front, Cyl. W/O Turbo 8/ Solenoid cam profile rear, Cyl. W/O Turbo F9 B/9 7/ Front heated oxygen sensor, Cyl. Diesel 0 7/ Front heated oxygen sensor bank, Cyl. Turbo 7/8 Rear heated oxygen sensor bank, Cyl. Turbo 7/0 Front heated oxygen sensor, bank Cyl. W/O Turbo 7/0 Rear heated oxygen sensor, bank Cyl. W/O Turbo 8/8 EVAP valve, Cyl. Turbo F0 B/0 9/8 Heated fuel filter, Cyl. Diesel 0 F B/ /7 Pump fuel leakage control Cyl. Turbo 7/00 Sensor coolant temperature 9/ PTC resistor crankcase ventilation, Cyl. Diesel F A/ 0/ Glow plug, Cyl. Diese /09 70 F A/ /7 Cooling fan control module 80 / 0 TP90 XC0 00

15 Fuses Central Electronic Module () F F / Central Electronic Module () No. Fuse function via A F 7/9 Rain sensor module (RSM) F /9 Supplemental restraint system module (SRS) 7/9 Occupant weight sensor (OWS) / Closing velocity module (CVM) F / Brake control module (BCM) F / Switch, heated rear seat 7/ Accelerator pedal sensor 8/8 todimming rearview mirror 9/ PTCelement F /8 Infotainment control module (ICM) / Integrated dio Module (IAM) / Accessory USB unit (AUU) F7 / Steering wheel switch left (SWSL) / Steering wheel switch right (SWSR) / RTI switch F9 0/ Lamp housing, front left 0/ Lamp housing, front right /0 /0 /0, / F0 / Panoramic roof control module 0 F 0/8 Reversing light, right 0/ Reversing light, left F 0/ Fog light, front left 0/ Fog light, front right continues K K K K K K TP90 XC0 00

16 Fuses Central Electronic Module () F F9 / Central Electronic Module () No. Fuse function via A F /7 Washer motor KA, KB F /80 Forward Sensing Module (FSM) 0 F7 /7 Switch unit, power passenger seat /7 Switch, driver s door power window /9 Tailgate closing switch /7 Remote control unit for garage door opener 7/8 Alcolock sensor 0/ Ceiling light 0/ Ceiling light cargo compartment 0/9 Glove compartment lighting 0/ Vanity mirror lighting, left 0/ Vanity mirror lighting, right 0/ Lefthand front courtesy lighting 0/ Righthand front courtesy lighting 0/0A Rear reading light 0/0B Rear reading light 7/ Alcolock outlet / Converter/control module, sill moldings, driver s side /7 Converter/control module, sill moldings, passenger side /8 Alcolock charging cradle F8 / Driver Information module (DIM) F9 / Power seat module (PSM) continues 7. TP90 XC0 00

17 Fuses Central Electronic Module () F0 F8 / Central Electronic Module () No. Fuse function via A F0 / Rear window wiper motor / F /9 Remote Keyless Entry (RKE) /9. Remote Receiver Module (RRX) 7/ Mass Movement Sensor Module (MMS), front 7/99 Ultrasonic sensor (IMS) 7/ Heart beat sensor (HBS) F /8 Control module fuel pump / Fuel pump K8 K8, /8 F /0 Steering column lock module (SCL) K9 0 F K Relay, soldered /7 Lock motor, fuel filler flap F / Climate control module (CCM) / Siren control module (SCM) 7/ Data link connector F7 / Start control module (SCU) F8 /9 Contact brake light /9 Keyless vehicle module (KVM) K 0 0 TP90 XC0 00 7

18 Fuses Rear electrical center FAFA / Rear electrical center No. No. Fuse function via A FA D/A / Driver door module (DDM) FA D/A /7 Passenger door module (PDM) FA D/A /8 Left rear door module (LDM) FA D/A /9 Right rear door module (M) FA D/A 7/9 V outlet, cargo compartment FA7 D/A7 /8 Relay, heated rear window 9/ Heated rear window FA9 D/A9 7/9 pin outlet, tow hitch cable harness FA0 D/A0 / Power seat module (PSM) FA D/A /0 Trailer module (TRM) 0 FA D/A / Power Operated Tailgate Module (POT) 0 /8 0 TP90 XC0 00 8

19 Fuses Distribution box in cargo compartment FBFB / Rear electrical center No. No. Fuse function via A FB D/B /8 Parking Assistance Module (PAM) /0 Trailer module (TRM) /0 Parking Assistance Camera (PAC) FB D/B /8 Suspension module (SUM) FB D/B 9/ Seat Heating Module (SHM), driver s side FB D/B 9/ Seat Heating Module (SHM), passenger side FB D/B 9/ Control module, rear right seat heater FB D/B /8 Differential electronic module (DEM) 0 FB7 D/B7 9/ Control module, rear left seat heater FB9 D/B9 /7 Switch unit, power passenger seat FB0 D/B0 /9 Keyless vehicle module (KVM) 0 FB D/B / Lock motor, rear left brake disc / 0 FB D/B /7 Lock motor, rear right brake disc / 0 TP90 XC0 00 9

20 Fuses Rear electrical center FDFD7 / Rear electrical center No. No. Fuse function via A FD D/D / High Level Display Front (HLDF) /08 Multimedia module (MMM) FD D/D /79 Subwoofer module (SUB) FD D/D / Remote Digital dio Receiver (AR) / Digital dio Broadcast Module (DABM) FD D/D /0 dio module (AUD) FD D/D /8 Infotainment control module (ICM) / Accessory USB unit (AUU) / Integrated dio Module (IAM) FD7 D/D7 /0 Phone module (PHM) /7 Bluetooth phone module (BPM) 0 TP90 XC0 00 0

21 Fuses Battery PFPF / Battery No. Fuse function via A PF A/A/7 Main fuses in engine compartment fuse box 0 A/A/ Main fuses in engine compartment fuse box B/8B/ Fuses in engine compartment fuse box B/B/ Fuses in engine compartment fuse box / B/ Fuses in engine compartment fuse box B/B/ Fuses in engine compartment fuse box /9 B/7B/ Fuses in engine compartment fuse box B/ Fuses in engine compartment fuse box / B/ Fuses in engine compartment fuse box B/B/ Fuses in engine compartment fuse box / PF / Starter motor / Alternator control module (ACM) 0 TP90 XC0 00

22 Relays Relays in the engine compartment R / Engine compartment cold zone Pos Relay function R /7 Relay, horn TP90 XC0 00

23 Relays Relays in the engine compartment R8R9 / Distribution box engine compartment Pos Relay function R8 / Relay, feed R9 /9 Relay, comfort functions TP90 XC0 00

24 Relays Relays in the engine compartment R0R / Distribution box engine compartment Pos Relay function R0 / Main relay, engine management system R / Relay preheater fuel filter R / Relay, starter motor R / Relay, climate control system TP90 XC0 00

25 Relays Distribution box in cargo compartment RA / Rear electrical center Pos Relay function RA /8 Relay, heated rear window RA / Relay, rear window wiper RB /88 Relay, feed rear RB Mounting TP90 XC0 00

26 Relays soldered Central Electronic Module () / Central Electronic Module () Pos K K K KA KB K8 K9 K0A K Relay function Front fog lights High beam Reversing lights Washer motor Washer motor Fuel pump Steering column lock module (SCL) Interior lighting Lock motor, fuel filler flap TP90 XC0 00

27 Ground connections Overview / XX /89 /88 /90 /9 / XX0 /AL / XX /9 / / /9 /9 /XX / / /8 /0 /7 / /8 / / /7 / /8 /7 /TRM / / INFOT /8 G09 TP90 XC0 00 7

28 Ground connections / /7 / Ground connection, PTC 9/ PTCelement / LH wheel housing /7 Cooling fan control module / Body, battery / Battery / Engine /XX Ground connection / Rear edge roof 9/ Heated rear window / Bottom rail, left /7 Switch unit, power passenger seat, RHD / Driver Door Module (DDM), LHD /7 Passenger Door Module (PDM), RHD /8 Left rear door module (LDM) /7 Switch, driver s door power window, LHD /7 Lock contact, LH front door /7 Lock contact, left rear door / Power Seat Module (PSM), LHD / Lock motor, central locking, LH front door /7 Lock motor, central locking, LH rear door 9/ Seat Heating Module (SHM), driver s side, LHD 9/ Seat Heating Module (SHM), passenger side, RHD /7 Bottom rail, left /7 Contact, immobilizer, clutch pedal, LHD /8 Diagnostic contact, brake light, LHD / Central Electronic Module (), RHD 7/ Accelerator pedal sensor, LHD 7/7 Weight sensor passenger seat, seat belt reminder, RHD 8/ Igniter side airbag front left, LHD 8/ Igniter side airbag front right, RHD TP90 XC0 00 8

29 Ground connections /0 / continues /0 Bottom rail, left / Switch, hazard warning flashers /7 Switch unit, ceiling light / Fan control module / Panoramic roof control module /7 Remote control unit for garage door opener /0 Steering column lock module (SCL) /9 Remote Keyless Entry (RKE) /9. Remote Receiver Module (RRX) / Closing velocity module (CVM) /8 Damper Motor Module (DMM), recirculation /9 Damper Motor Module (DMM), temperature, lefthand side /9 Damper Motor Module (DMM), temperature, righthand side /0 Damper Motor Module (DMM), defroster /0 Damper Motor Module (DMM), floor/ventilation 7/9 Rain sensor module (RSM) 7/9 Air quality sensor (AQS) 7/99 Ultrasonic sensor 7/8 Alcolock sensor 8/8 todimming rearview mirror 0/ Ceiling light 0/9 Glove compartment lighting 0/ Vanity mirror lighting, left 0/ Vanity mirror lighting, right 0/0A Rear reading light 0/0B Rear reading light 7/ Data link connector 7/ Alcolock outlet /8 Alcolock charging cradle / Bottom rail, right /7 Switch unit, power passenger seat, LHD / Switch, heated rear seat / Driver Door Module (DDM), RHD /7 Passenger Door Module (PDM), LHD /9 Right rear door module (M) / Gear Selector Module (GSM), RHD /7 Switch, driver s door power window, RHD /7 Lock contact, RH front door /7 Lock contact, RH rear door / Power Seat Module (PSM), RHD / Lock motor, central locking, RH front door / Lock motor, central locking, RH rear door 7/ Mass Movement Sensor Module (MMS), front continues TP90 XC0 00 9

30 Ground connections / /8 / Bottom rail, right 8/ Solenoid, reverse interlock, manual, RHD 9/ Front V outlet 9/ Seat Heating Module (SHM), driver s side, RHD 9/ Seat Heating Module (SHM), passenger side, LHD 9/ Outlet V rear 0/7 Front ashtray lighting /8 Rear headphone sockets /7 Rear bumper abutment, left / Relay, rear window wiper / Trunk handle switch /0 Trailer module (TRM) / Park Brake Module (PBM) / Power Operated Tailgate Module (POT) /8 Central locking motor, tailgate / Rear window wiper motor 0/ License plate lighting 0/8 Lamp housing, rear left 0/9 Brake light extra /8 Rear bumper abutment, right /9 Keyless vehicle module (KVM) /7 Lock motor, fuel filler flap 7/ Heart beat sensor (HBS) 0/7 Lamp housing, rear right 7/9 V outlet, cargo compartment / Rear seat riser, lefthand side /8 Differential electronic module (DEM) 9/ Control module, rear left seat heater / Rear seat riser, lefthand side /8 Control module fuel pump / Fuel pump /7 Rear seat riser, righthand side /8 Suspension module (SUM) /8 Parking Assistance Module (PAM) 9/ Control module, rear right seat heater 0/ Fog light, rear right 0/ Fog light, rear left /8 Rear seat riser, RH side / Fuel pump, auxiliary heater 9/8 Electrically heated fuel filter TP90 XC0 00 0

31 Ground connections /8 /89 /8 Bottom rail, left / Steering wheel switch left (SWSL) /7 Contact horn / Light switch module (LSM) /0 Steering wheel module (SWM) / Steering wheel switch right (SWSR) / Start control module (SCU) /7 Parking brake contact /8 Infotainment control module (ICM) /9 Handsfree control panel cellular phone / Climate control module (CCM) /80 Forward Sensing Module (FSM) / Accessory USB unit (AUU) / Driver Information module (DIM) 7/0 Interior temperature sensor 9/ PTCelement 0/ Lamp housing, front left 0/ Lamp housing, front right / Integrated dio Module (IAM) /0 Phone module (PHM) /7 Bluetooth phone module (BPM) /9 Control module, cellular phone handsfree 7/ Data link connector /8 Bottom rail, right /7 Contact, immobilizer, clutch pedal, RHD /8 Diagnostic contact, brake light, RHD / Central Electronic Module (), LHD 7/ Accelerator pedal sensor, RHD 7/9 Occupant weight sensor (OWS) 7/7 Weight sensor passenger seat, seat belt reminder, LHD 8/ Igniter side airbag front driver s seat, RHD 8/ Igniter side airbag front passenger seat, LHD /88 Engine ignition coils 0/ Spark plug with ignition coil, Cyl 0/ Spark plug with ignition coil, Cyl 0/ Spark plug and ignition coil 0/ Spark plug and ignition coil /89 Engine ignition coils 0/ Spark plug and ignition coil 0/ Spark plug and ignition coil 0/7 Spark plug and ignition coil 0/8 Spark plug and ignition coil 0/ Capacitor, Cyl TP90 XC0 00

32 Ground connections /90 /XX0 /90 Engine ignition coils 0/ Spark plug with ignition coil, Cyl Turbo 0/ Spark plug with ignition coil, Cyl Turbo 0/ Capacitor, Cyl Turbo /9 LH wheel housing /99 Electronic power steering control module 7/ Washer fluid level sensor 9/ Heated windshield washer nozzle, left 9/ Heated windshield washer nozzle, right 0/ Lamp housing, front left 0/ Fog light, front left /9 RH wheel housing /0 High pressure headlight washer motor 0/ Lamp housing, front right 0/ Fog light, front right /0 Horn /9 LH wheel housing / Central Electronic Module (), RHD /8 Headlamp Control Module (HCM) 7/ Brake fluid level sensor / Siren control module (SCM) /9 RH wheel housing / Hood alarm contact / Central Electronic Module (), LHD 7/7 Coolant level sensor 7/0 Forwardaimed radar (FLR) 0/ Running/parking light, front left 0/ Running/parking light, front right /XX Engine Body / Ground connection /XX0 LH wheel housing /0 Reversing light contact /8 Switch indicator st gear, ID /8 Transmission control module (TCM) / Engine control module (ECM) /9 Upper actuating motor, intake manifold /0 Lower actuating motor, intake manifold 7/00 Sensor coolant temperature 9/ PTC resistor, crankcase ventilation TP90 XC0 00

33 Ground connections /XX /TRM /XX LH wheel housing / Brake control module (BCM) /XX RH wheel housing /7 Combustion preheater module (CPM) /0 Control module, remote parking heater start / Wiper motor module (WMM) /AL xiliary lights 0/ xiliary light, front right 0/9 xiliary light, front left /INFOT Infotainment /0 Parking Assistance Camera (PAC) / High Level Display Front (HLDF) /79 Subwoofer module (SUB) /0 dio module (AUD) /08 Multimedia module (MMM) / Remote Digital dio Receiver (AR) / Digital dio Broadcast Module (DABM) /TRM Accessories 7/7 pin outlet, tow hitch cable harness 7/8 7pin outlet, tow hitch cable harness 7/9 pin outlet, tow hitch cable harness TP90 XC0 00

34 PSM 7/ AR DEM UM KV DDM SWM SAS LCM LSM DIM RRX RSM HLDF BCM AQS DMM ECM TCM WMM /7 BP M FLR SCM ACM HCM CVM CPM / FSM SCU RCM IAM PDM ICM PHM CCM AUD SCL PAM GSM SHM BSC M OWS Control modules Overview locations TP90 XC0 00 / SHM LDM RKE SRS POT MMM PBM PAC TRM DABM S M G007

35 Control modules Overview designations Unit Designation Unit Designation ACM / Alternator control module (ACM) PAC /0 Parking Assistance Camera (PAC) AQS 7/9 Air quality sensor (AQS) PAM /8 Parking Assistance Module (PAM) AUD /0 dio Module (AUD) PBM / Park Brake Module (PBM) BCM / Brake control module (BCM) PDM /7 Passenger door module (PDM) BPM /7 Bluetooth phone module (BPM) PHM /0 Phone module (PHM) BSC 7/ Body sensor cluster stability sensor (BSC) POT / Power Operated Tailgate Module (POT) CCM / Climate Control Module (CCM) PSM / Power seat module (PSM) / Central electronic module () RCM 7/ Right Camera Module (RCM) CPM /7 Combustion preheater module (CPM) AR / Remote Digital dio Receiver (AR) CVM / Closing velocity module (CVM) M /9 Right rear door module (M) DABM / Digital dio Broadcast Module RKE /9 Remote Keyless Entry (RKE) (DABM) DDM / Driver door module (DDM) RRX /9. Remote Receiver Module (RRX) DEM /8 Differential electronic module (DEM) RSM 7/9 Rain sensor module (RSM) DIM / Driver Information module (DIM) SAS /8 Steering wheel angle sensor module (SAS) DMM Damper motor module (DMM) SCL /0 Steering column lock module (SCL) ECM / Engine control module (ECM) SCM / Siren control module (SCM) FLR 7/0 Forwardaimed radar (FLR) SCU / Start control module (SCU) FSM /80 Forward Sensing Module (FSM) SHM 9/ Seat Heating Module (SHM), driver s side GSM / Gear selector module (GSM) SRS /9 Supplemental restraint system module (SRS) HCM /8 Headlamp Control Module (HCM) SUM /8 Suspension module (SUM) HLDF / High Level Display Front (HLDF) SWM /0 Steering wheel module (SWM) IAM / Integrated dio Module (IAM) TCM /8 Transmission control module (TCM) ICM /8 Infotainment control module (ICM) TRM /0 Trailer module (TRM) KVM /9 Keyless vehicle module (KVM) WMM / Wiper motor module (WMM) LCM 7/ Left Camera Module (LCM) / / Fan control module LDM /8 Left rear door module (LDM) / / Panoramic roof control module LSM / Light switch module (LSM) /7 /7 Cooling fan control module MMM /08 Multimedia module (MMM) 7/ 7/ Data link connector OWS 7/9 Occupant weight sensor (OWS) TP90 XC0 00

36 Control modules Central Electronic Module () : / + 0+ B/7 A/ A/ GY / C: K0A F C:7 VTBN 7/9: F C: GYVT /80C: F F7 C: /9:, 0/:, /7, /7: C:7 0/C:, 0/9:, 0/:, 0/:,0/:, 0/:, F8 C:9 0/0A, 0/0B /C: F9 C: VTGN / F0 C:7 GY /:, /: F C:7 BN 7/:, 7/: F K8 C: BN 7/99: C: BN /9:,/9.: C:7 OG /8:, /: F K9 C:7 C:7 /0: C: F F K C:7 /7: F C:7 /: C:7 7/:, /C: F7 C:7 VT /: F8 C: /9: B A TP90 XC0 00 G0

37 Control modules Central Electronic Module () : B A GY / C: F C: GY /8C:, /C: F7 F8 C:70 GN /0C:8 F9 K C:7 VTOG 0/:, 0/:9 C:7 GYBN 0/:, 0/:9 F0 C:7 BN /: K F C: GYVT 0/7: C:7 GNBN 0/8: F K F C:8 OG 0/: C:9 0/: KA F C:7 GY /7: KB C:7 VTGN /7: C: F C: GN /9C:7, 7/9:, /C: F C: GN /C:8 C:8 F C: 7/: C:8 /:, 9/C: C:8 8/8: F G0 TP90 XC0 00 7

38 Control modules Central Electronic Module () : / 0/: 0/:, 0/: 7/7: /99: 0/: /: 7/: /0: 7/: /: /:LHD, /:RHD / 0/:, 0/: / /: /7: /0: /9: 7/: 7/: 7/: 0/: 0/: VT C: GNOG C:0 GN C: C:7 GN C:9 OG C: VT C: C: GYVT C:7 C: C: VTBN C:7 GY C:0 VTOG C: GNVT C: VTGN C: C:7 GNVT C:8 GN C: BNGN C: VT C: GN C:7 C:7 7/00 LHD 7/0 GN RHD C: C: GN /: C:7 GNVT /: C:8 /: C:9 GN C:0 /7: OG /8:, /8: C: GNOG 7/: C: BNGN /8: C: GY /9C:8, /:, /C: C:7 GYBN /C:0 C:8 GNOG 0/7: C: BN 7/7: C: C: 0/7: /8: C:7 GYBN /7:, / C:9 OG 7/: C:0 VT /: C: 7/:, 7/: C: GY 0/9: C: GYOG 0/8: C:8 0/: C:9 BNGN / 0/:, 0/: C:0 GYBN /9C:, /C:7 C: GNOG /: C: GYBN /: C: /88: C:7 VTGN 7/: C:8 GN /: C:0 VT 0/8: C: VT 0/: C: VT /9:, /9C: C:9 VTBN 0/8:, 0/7: C:7 GYBN /8:, /8: C: BN 7/: C: GY 7/: C: OG 7/: C:8 GY /: C: GY /C:8 C: /0C:0 C:8 /9C:, /0C:7 C:9 GY 0/: C: /7:, 0/7:, /8: C: VT 7/: C: /:, /, /9C: C:7 GY 0/: C:9 GN C: GNOG C: BN C: GY C:9 GY C:0 GY C: GN C: GNVT C: VTOG C: OG C: GYBN C:7 VT C:8 GY C: VT C:0 GY 9/C: /: 8/: 7/: /0: /: /0C:7 /: /7C:8 /: /9:, /9.: 7/99: 7/9: /: 0/C: GN /9 /9 /7 /8 C: LHD RHD GN GN G0 TP90 XC0 00 8

39 TP90 XC / C: C: GN GN GN 7/0 7/0 7/0 7/0 GN A: A: TCM /8 B: B: ECM ID EU CYL DIESEL CYL / GN B: B: ECM I MAN MAN AUTO AUTO AUTO AUTO AUTO AUTO AUTO AUTO / 7/0 TCM /8 C:7 C: / PBM C: C: HCM /8 C: C: BCM / 7/0 7/ GN GN C:8 C:7 DEM /8 GN GN GN A: A: C: C: SUM /8 7/ C: C:7 FSM /80 SWM /0 SAS /8 C:8 GN GN GN C:7 / C: C: CVM / 7/ 0 0 7/0 GN 7/90 GN GN 7/09 GN GN GN GN GN GN GN GN GN GN GN GN GN GN GN GN GN GN GN 7/097 7/007 7/008 7/098 7/00 7/0 7/0 7/0 7/0 7/00 7/0 7/0 7/08 7/07 7/8 BS IT G0 Control modules Data communication high speed

40 / / DDM /9 SRS /7 PDM /8 ICM / / CCM HLDF C /F C:0 C:9 7/07 C: C: C:7 C:8 7/00 7/0 7/0 GYOG VTOG C: 7/09 7/00 7/0 7 GYOG VTOG 7/00 GYOG GYOG GYOG GYOG GYOG 7/00 VTOG GYOG VTOG GYOG GYOG VTOG GYOG VTOG C: 7/08 GYOG VTOG VTOG GYOG 7/00 VTOG VTOG VTOG VTOG VTOG 7/00 7/0 7/00 7/00 GYOG VTOG GYOG GYOG GYOG 7/00 GYOG 7/009 VTOG GYOG VTOG GYOG VTOG GYOG VTOG C:0 C:8 RTI RTI C: C: 9 0 7/09 7/0 9 0 VTOG VTOG VTOG 7/0 7/00 C: C: GYOG VTOG GYOG VTOG GYOG VTOG VTOG GYOG 7/0 7/0 7/0 7/ C: PSM C: 7/0 / DIM GN C: C: Control modules Data communication intermediate speed, LHD /0 TRM /9 KVM /8 PAM GN / C: C: POT PAC /0 TP90 XC C: C: GYOG VTOG VTOG GYOG VTOG GYOG VTOG VTOG GYOG GYOG C: VTOG C: GYOG C: VTOG C:7 GYOG C: VTOG C: C: C: /7 GYOG VTOG GYOG 7/9 CPM / C: /0 C: GN GN D: D:7 0 PHM 7/00 7 # 8 0 OG OG 9 G09 /7

41 / / DDM /7 PDM /8 ICM / / CCM HLDF C /F 7/08 7/0 7 GYOG VTOG 7/09 GYOG GYOG GYOG 9 GYOG VTOG VTOG VTOG 0 VTOG 7/0 7/0 7/00 7/009 7/0 7/00 7/0 7/00 GYOG C:0 C:9 C: VTOG C: 7/07 VTOG GYOG GYOG VTOG GYOG VTOG GYOG VTOG GYOG VTOG GYOG VTOG C:0 C:8 RTI RTI C: C: GYOG 7/00 GYOG GYOG VTOG VTOG VTOG 7/00 7/00 7/0 9 0 GYOG GYOG VTOG VTOG 7/0 7/00 C: VTOG C: GYOG GYOG C: VTOG C: GYOG VTOG 7/00 / DIM 7/0 7/ GN C: C: Control modules Data communication intermediate speed, RHD /9 KVM /8 /9 PAM SRS PAC /0 /0 TRM C:7 C:8 C: C: GYOG VTOG GYOG VTOG GYOG VTOG 7/0 C: PSM C: TP90 XC0 00 7/00 GYOG VTOG GYOG VTOG GYOG VTOG GYOG C: VTOG C: C: C: C: C:7 7/0 GN / POT VTOG GYOG C: C: / 7/00 0 C: /0 PHM 7 # C: OG OG G070 /7

42 Control modules Data communication Local MS LHD / CVM MS RHD / CVM / BCM /80 FSM HS /9 SRS C:7 C:7 C: C: VT 7/90 VT 7/ VT 7/09 VT VT C: C: VT 7/90 VT 7/ VT GNOG GNOG C:9 C: /0 C:9 C:8 GY GY 7/ 0 9 GN 0 7/9 OWS 7/ 7/09 VT C:7 C:7 /9 SRS 7/ BSC 7/0 FLR G00977 TP90 XC0 00

43 Control modules Data communication, : /8 TCM 7/0 7/ 7/0 A:7 BNVT BNVT 0 BNVT BNVT A: / GSM 7/ HBS 7/99 IMS / SCM / LSM /8 ICM C: GNVT GNOG /0 / SWM VT C: C:7 C: C: 7/ MMS 7/0 C: C: GN C:7 / SCU / LHD / RHD S S C:0 GY WMM WMM S C:9 GY /0 SCL 7/9 RSM GY 7/90 7 GY C: C:8 S S 0 C:7 GYBN C:0 /9. RRX C: GYBN GYBN /9 RKE GYBN GYBN C: /9 KVM G07 TP90 XC0 00

44 Control modules Data communication, : / 9/ SHM 9/ SHM / CCM 8/8 A: A: C: C:7 BNVT 7/0 7/ GN BNVT BNVT 7/0 BNVT GN LHD GN RHD BNVT RHD BNVT LHD 7/0 7/ 8 GN BNVT BNVT 7/00 BNVT 7/0 7/09 9/ 9/ SHM SHM / ECM CYL. A: GN GN 7/09 A:9 BN BS BN BS 7/09 / BN BS ACM G GN 7/00 BN / ECM CYL A:9 GN BNVT BNVT 7/7 A: / S /9 DMM C: / ECM CYL.D GN S /0 DMM BN A: /0 BLIS BLIS RHD RHD GN GN GN DMM /8 /7 7/ LCM / DDM /7 PDM 7/ RCM GN DMM /9 GN DMM LHD BLIS GN GN LHD GN RHD GN C: GN /8 LDM C:0 7/09 C:0 /9 C: M GN BLIS LHD GN LHD GN RHD 7/07 7/09 GN GN GN 7/0 7/08 GN 7 G07 TP90 XC0 00

45 O Control modules Data communication MOST O O OG OG / IAM C: OG O C: /7 BPM OG O /0 C: OG C: PHM C: O OG OG OG OG O O O OG O C: OG O 7/0 OG OG OG /8 C: ICM C: O O O OG O OG O OG O /0 AUD C: O OG C: O OG O OG /08 MMM C: / C: AR C: O OG O OG C: O OG 7/9 OG OG OG OG OG /79 C: SUB C: OG / C: DABM C: OG O O OG / AR / DABM AR/DABM C: 7/9 O OG C: O OG /79 C: SUB OG O C: G07 TP90 XC0 00

46 TP90 XC0 00 Control modules Steering Wheel Module (SWM) /7 A/ 0+ A/ / /0 C:70 GN GN C: C: C:8 C:0 C:7 C: C: F7 7/0 7/07 C: C: / C:0 C:9 C: C: C: C: SWM C: C: C: C: SAS /8 7/9 8/ WIPER A: A: A: C: C: / /9 SWSL SWSR / / B: B: B: B: B: C:8 BNOG OG OG OG C: C:7 C: C: C: C: C: SRS 8/0 8/ ICM /8 C: 0 0 C: C: GNOG LHD RHD RHD /8 TURN G07

47 TP90 XC W/O Turbo MAF R0 / 8/9 8/0 (8) (8) (0) (87) 8/8 8/7 8/ 7/7 VT GY OG /89 /88 0/ 0/ VTBN 0/8 0/ OG GY VT GY GY GY GY GY 0/7 7/08 7/00 GNVT GN BN 7/00 7/09 / 7/ GN B A A:8 A:80 A:8 A:79 A:8 A: A: A:0 A:9 A: A: A:0 A:8 A:7 A: A: A: A:9 CYL ECM GN GN GY GN GN GN GN GN A: D GY C 7/ VT GNBN A:0 A: 7/ VTOG GY A: A:9 A: A:7 A: P 7/ GY GY GY GY BN OG BN BN A:70 VTBN A: OG VTGY GY GN BN A: A:7 / B/7 B/ B/ B/0 7/0 7/00 7/009 8/ A:78 GN GYVT VT A:8 GN A:9 /9 /0 B/8 7/ A:7 ETA /0 GN OG A:7 A: A:7 A:7 A:7 VT GNVT A:8 A: M M M OG GY 0/ 7/8 P GY GY GY 7/ A:8 /XX0 7/09 QLT 0/ + GY G000 Group Fuel system Engine management system Cyl. :

48 Group Fuel system Engine management system Cyl. : A B / VT GYVT B:7 B: / B/0 0+ B/7 A/ / B/7 R8 VTBR GNVT 7/0 / 7/0 B: VTBN VTBN GY C: ECM VTBN /8 B: GYBN A: F TCM A: 7/0 7/8 B: GNBN GNBN B: BN BN P B: GYBN GYBN C: K8 C: F F8 B:0 B: CYL VTBN VTOG 8 0 VTBN VTOG 7/ GNOG OG VTGN C:7 C: C: C:9 C:7 C: W/O Turbo /8 BNGN C: OG C:7 VT C: C: /9 /9 KVM B: B: OG B: B: OG 7/0 7 8 OG 7/ 7 7/ VT C: OG OG B: B: B: B: B: 7/0 RHD RHD LHD LHD 7/07 7/07 RHD LHD 7/ / M x M y 7/9 M F OG OG /8 PEM GY BN B: MEM X MEM Y B: 7/09 OG / M C D GY /XX0 /8 /7 / TP90 XC G00

49 TP90 XC MAF R0 / 8/9 8/0 (8) (8) (0) (87) 8/8 8/7 0+ 8/ 7/7 VT GY OG /89 /88 0/ 0/ VTBN 0/8 0/ OG GY VT GY GY GY GY GY 0/7 BN BN 7/08 7/00 GNVT GN BN 7/00 7/09 / 7/ GN B A A:8 A:80 A:8 A:79 A:8 A: A: A:0 A:9 A: A: A:0 A:8 A:7 A: A: A: A:9 BS CYL ECM GN GN GY GN GN GN GN GN A: D GY C 7/ VT GNBN A:0 A: 7/ VTOG GY A: A:9 A: A:7 A: P 7/ GY GY GY GY BN OG BN BN A:70 VTBN A: OG VTGY GY GN BN A: A:7 / B/7 B/ B/ B/0 7/0 7/00 7/009 8/ A:78 GN GYVT VT A:8 GN A:9 /9 /0 B/8 B/ 7/ A:7 ETA /0 GN OG A:7 A: A:7 A:7 A:7 VT GNVT A:8 A: M M M OG GY 0/ 7/8 BN A:9 P GY GY GY 7/ 7/00 A:8 7/ 7/09 /XX0 QLT 0/ + GY ACM G / C: 7/09 G00 Group Fuel system Engine management system, Cyl. BS :

50 Group Fuel system Engine management system, Cyl. BS : A B / VT GYVT B:7 B: / B/0 0+ B/7 A/ / B/7 R8 VTBR GNVT 7/0 / 7/0 B: VTBN VTBN GY C: ECM VTBN /8 B: GYBN A: F TCM A: 7/0 7/8 B: GNBN GNBN B: BN BN P B: GYBN GYBN C: K8 C: F F8 B:0 B: CYL BS VTBN VTOG 8 0 VTBN VTOG 7/ GNOG OG VTGN C:7 C: C: C:9 C:7 C: /8 BNGN C: OG C:7 VT C: C: /9 /9 KVM B: B: OG B: B: OG 7/0 7 8 OG 7/ 7 7/ VT C: GN GN B: B: B: B: B: B: B: 7/0 7/09 OG 7/ /07 / M x M y 7/9 MEM X M F MEM Y OG OG /8 PEM GY BN / M C D GY /XX0 /7 / G00 TP90 XC0 00 0

51 TP90 XC0 00 Turbo MAF R0 / 8/9 8/0 (8) (8) (0) (87) 8/8 8/7 0+ 8/ 7/7 VT GY OG /90 /89 0/ 0/ VTBN 0/8 0/ OG GY VT GY GY GY GY GY 0/7 7/08 7/00 GNVT GY GN BN 7/00 / 7/ GN B A A:8 A:80 A:8 A:79 A:8 A: A: A:0 A:9 A: A: A:0 A:8 A:7 A: A: A: A:9 CYL ECM GN GN GY GN GN GN GN GN A: D GY C 7/ VT GNBN A:0 A: 7/ VTOG GY A: A:9 A: A:7 A: P 7/ GY GY GY GY BN OG BN BN A:70 VTBN A: OG VTGY GY GN BN A: A:7 / B/7 B/ B/ B/0 7/0 7/00 7/009 8/ A:78 GN GYVT VT A:9 OG A:90 B/8 7/ A:7 A: OG GY 0/ 7/8 P GY GY 7/ A:8 7/09 QLT 0/ + OG GY 8/8 8/8 7/ A:7 GNBN A: BN GYOG GY A:7 P GY /88 ETA /0 GN OG VT GNVT M OG A:7 A:7 A:7 A:7 A:8 A: G07 Group Fuel system Engine management system, Cyl. Turbo :

52 Group Fuel system Engine management system, Cyl. Turbo : A B / VT GYVT B:7 B: / B/0 0+ B/7 A/ / B/7 R8 VTBN GNVT 7/0 B: 7/0 VTBN VTBN ECM B: GYBN 7/0 7/8 B: GNBN GNBN B: BN BN P B: GYBN GYBN GY VTBN /8 A: TCM / C: F A: C: K8 C: F F8 B:0 B: CYL Turbo VTBN VTOG 8 0 VTBN VTOG 7/ /8 GNOG OG VTGN C:7 C: C: C:9 C:7 C: BNGN C: OG C:7 VT C: C: /9 /9 KVM B: B: OG B: B: OG 7/0 7 8 OG 7/ 7 7/ VT C: OG OG B: B: B: B: B: 7/0 RHD RHD LHD LHD 7/07 7/07 RHD LHD 7/ / M x M y 7/9 M F OG OG /8 PEM GY BN B: B: 7/09 OG MEM X MEM Y / M C D GY G078 /XX0 /8 /7 / TP90 XC0 00

53 Group Fuel system Engine management system, Cyl. Diesel EURO : / 0+ B/0 / R0 (8) (0) / R (8) (0) (8) (87) (8) (87) A/ B/ B/ B/ B/8 B/9 B/7 B/0 OG OG 8/ 8/7 8/8 8/9 8/0 GYVT GN GY OG GNOG GY VTGY GN OG / A:9 A: A:7 A: ECM B: A: A:7 A:0 A: A:7 A: 7/ GYVT A:9 GNBN A:7 DIESEL 7/90 BN A:89 ID VTOG A: EURO 7/9 GY A: GYVT A:0 7/ A: BNGN A: A VT GY GNBN GY VT 7/0 GY VT 7/ 7/7 MAF GY VT GN GN VTGN A: A:8 A:8 A:77 A:9 A:7 A:90 A: 7/09 VTGN A:0 A: OG A: 8/ GY VT A:7 7/ / M GY A: A:7 / GCU ID 7/0 7 7/0 7 7/ 8/98 VT GY A: 9/ 9/8 8/ M VT GN A:9 7/08 OG 7/ QLT GY GY A:8 GN A: 0/ 0/ 0/ 0/ 0/ 7/09 /XX0 OG 8 /8 7/ GNBN TP90 XC0 00 B G00

54 Group Fuel system Engine management system, Cyl. Diesel EURO : 0+ / A / B:7 ECM DIESEL VTBN VTBN ID B: GNBN B:8 BN B: GYBN EURO B: GYVT AUTO A: B: GYBN /8 TCM AUTO MAN A: VTBN 7/0 7/0 GNBN BN GYBN 7/0 VTBN VTBN AUTO 7/8 P B/0 MAN 7/ B/7 GY BNGN VT GN C: C: C: C: / / R8 GNVT F B/7 C: K8 A/ C: F F8 B:9 B: VTBN VTOG 8 0 VTBN VTOG 7/ GNOG OG VTGN C:7 C: C: C:9 C:7 C: B:0 9 B: B: 7 /8 7/0 7 BNGN C: OG C:7 VT C: C: /9 /9 KVM VT C: OG OG 7/ RHD RHD LHD LHD 7/07 7/07 7/ OG B: B: RHD LHD B: B: B: B: GNBN B: GNBN B: GNBN 7/0 7/00 / M x M y 7/9 MEM X M F MEM Y / M GN 7/09 B GNBN /XX0 /8 /7 / G00 TP90 XC0 00

55 Group Fuel system Engine management system, Cyl. Diesel EURO : / 7/ GN VT A:87 A:8 ECM 7/8 P GY GN BN A:0 A: A: 7/7 VT VTGY GNBN A: A: A: DIESEL ID 8/0 BNVT A:9 A:7 GY VTGN A:79 A: A:9 7/ P BN A: A: GY A: EURO 7/ P 7/8 P GNBN BN BN A: GN GNBN A:80 A: A:8 A:78 A:8 A:8 /0 ETA GN VT VT A: A:8 A:8 A:0 VT A: G00 TP90 XC0 00

56 Group Fuel system Emission control Cyl. / 0+ B/0 / R0 (0) (8) (87) (8) B/8 B/9 B/ / GYVT 7/0 7 GNOG 8/8 GY A:8 ECM B:7 7/0 8 7/ O GN A:7 A:0 A:9 B: GNOG GNOG 7/ GNOG /7 7 CYL. 7/8 O GNBN GN, VTBN (IT) VTGN A:77 (BS) A:88 (I, IT) A:8 A:0 GY VTOG M 7/0 W/O Turbo 7/0 BS 8/ W/O Turbo 8/ W/O Turbo O O GY GY GY VTBN GN GYVT GN 7/09 7/00 A:77 A: A: A:89 A: A: VT A:90 OG A:9 I IT BS B: B: B: B: GY VTOG 7/ GY GY 7/0 9 VTOG VTOG 7 8/7 GY VT A:8 7/7 GNBN A: VT A:7 A: 7/7 GNBN A: BN A:8 GNVT A: G00 TP90 XC0 00

57 Group Cooling system Cooling fan Cyl. Diesel EURO 0+ / A/ A/ 7/ BNGN / A: ECM A: DIESEL ID EURO 7/8 P BN GNBN GYBN 7/0 BN GNBN GYBN B:8 B: B: /7 VT A:8 B: B: / G0 TP90 XC0 00 7

58 Group Cooling system Cooling fan Cyl. 0+ / A/ A/ 7/ 7/8 P BN GNBN GYBN 7/0 BN GNBN GYBN / A:8 ECM A: CYL B: B: B: /7 VT I IT BS B: B:8 B: / G008 TP90 XC0 00 8

59 Group 7 Engine controls Cruise control 7/ N 7/00 / C: C: BCM BN BN C: C: 7/0 BN BN 7/ N / 0+ 7/0 7/ VT C: VT C:8 GN C:7 C: 7/0 B/7 R8 / B/7 A/ A/ /0 SWM C: MAN 7/ 7/ BNGN VT GN GY GNOG OG VTGN / C: C: C: C: C:9 C:0 C: C:9 C:7 C: C:7 C:8 F GNVT C: C: F7 C:70 GN C: GN F8 C: 7/0 LHD RHD RHD 7/07 C:8 C:7 C: A: 8/ C: C: C: /8 AUTO TCM 7/0 7/ 7/0 A:7 BNVT BNVT BNVT BNVT 0 / SWSL / A: GSM 7/07 RHD RHD LHD OG 7/07 OG LHD /8 /7 7/0 7 CYL. D RHD 8/ M OG LHD C: /8 CYL. BNGN 7/0 9 /0 ETA VT C: / 7/0 VT VT GN M /9 B/7 C: R0 / /8 0+ B/0 GYVT B:, B:0(ID) A: A: / B: ECM B: B:(ID) B: A:9 VT GN OG GNVT A:7 A:7 A:7 A:7 A:8 A: I IT BS & ID EU CYL. CYL.D B:7 GYBN 7/ GY GY 7/0 FLR /80 C:8 FSM C:9 C:7 / ACC DIM C: C: C: G0 TP90 XC0 00 9

60 Group Alternator and voltage regulator Power supply / V + PF 7/07 / C: C: M /XX / / C: B+ / ACM ECM CYL VOLT. REG. A:9 I IT C: / ECM CYL BN BN 7/09 BN A:9 BS / ECM CYL DIESEL BN A: ID / G0 TP90 XC0 00 0

61 Group Starting system Starting system / B/ / (0) R (8) B:(ID), B: / ECM C: / B+ ACM G B/7 / R8 (87) (8) GN B:(ID), B:9 A/ A/ B/7 B/0 7/07 PF PF / V / C: M /0 SCL C: / GY C:9 C:7 C: K9 F C: GNVT GY C: C: F7 C: C:7 C: C:0 C:7 C:7 GYBN MAN GYBN VTBN VTOG VTBN 7/0 GYBN /7 7/ 7/07 GYBN 7/0 7/0 VTBN MAN 7/0 VTBN VTBN 0 VTOG 8 VTBN 0 GYBN MAN GY VT AUTO B: B:(ID), B: B:9(ID), B:0 B:(ID) B:(ID), B:7 ID EU I IT BS / SCU 7/0 C:7 C: OG MAN LHD OG 7/07 RHD 7/07 7/0 G07 / /0 /7 /8 /8 TP90 XC0 00

62 Group Lighting High and low beam 0+ /0 / / SWM DIM C: A/ A/ B/ C: C:7 GN / C: C: C: 7/ / C:7 F9 C: GNVT LSM C:7 C:9 C:0 K C:7 C:7 OG VT GYBN 7/0 7/0 VTOG GN OG VT RHD LHD 0/70 0/8 0/ 0 0/ 0/ 0/ 0 7/07 RHD M + L LOW HIGH POS TURN M LOW HIGH POS TURN + L 9 9 7/0 /9 /9 /8 TP90 XC0 00 G08

63 Group Lighting High and low beam (Dual Xenon) 0+ /0 / / SWM DIM C: A/ A/ B/ C: C:7 GN / C: C: C: 7/ / C:7 C:9 F9 C: C:7 GNVT GN LSM C:0 K RHD LHD C:7 C:7 VTOG OG OG 7/0 VT VT 0/8 0/70 0/ 0/ GN OG VT 7/07 7/07 GYBN 7/07 0/ 0 7/0 0/ 0 RHD GYBN GYBN TURN POS HIGH XENON HIGH / LOW M TURN POS HIGH XENON HIGH / LOW M VTOG VTOG 9 9 7/0 /9 /9 /8 TP90 XC0 00 G09

64 Group Lighting Beam length adjustment, manual / 0+ B/ R8 / B/7 A/ A/ B/ GNVT / C: C: C: C: GNVT 0/ 7 0/ M LOW HIGH POS TURN L M LOW HIGH POS TURN L 8 8 LHD RHD RHD 7/ / LSM VTGN RHD LHD /8 /9 VTGN VTGN 7/ LHD 7/07 LHD 7/0 /8 G00 TP90 XC0 00

65 Group Lighting Running/Parking light, Tail lights 0+ / / DIM C: A/ A/ B/ C: / C: C: C:9 C:0 C: C:0 7/0 9 VT VT C: C: 7/ C:0 7/09 GNOG 7/097 GY C:0 GNOG GY 7/09 GNOG 8 M 7/09 9 GY GNVT + L LOW HIGH POS TURN M + L RHD LHD 0/ 0 0/ 0 GNOG GY / LSM 0/ 0/ POS 0/ POS 0/ RHD 7/07 7/0 OG LOW HIGH POS TURN VT 0/ / 7/0 7/0 7/00 0/8 0/7 REV POS STOP TURN TURN STOP POS 7/09 7/0 REV OG OG GND 0/ GND OG 7/0 0/ VT OG 7/00 OG 7/0 OG 7/00 7/0 OG /7 /8 /9 /9 /8 /9 TP90 XC0 00 G0

66 Group Lighting Running/Parking light, Tail lights (Dual Xenon) 0+ / / A/ A/ B/ DIM C: C: 7/09 8 GNOG 0/ POS / C: C: 7/09 9 GY 0/ 7/0 POS 7/ GNOG GY / LSM C:9 C:0 C: C:0 7/0 9 VT VT 0/ / C: C: C:0 7/09 GNOG 7/097 GY C:0 0/ GNOG GY GNVT 0/ TURN POS HIGH 0 XENON HIGH / LOW M 0/ 0/ 0 TURN POS HIGH XENON HIGH / LOW RHD LHD M RHD 7/07 7/0 OG VT 7/0 7/0 7/00 7/09 0/8 0/7 REV POS STOP TURN OG TURN STOP POS REV OG 7/0 GND 0/ OG GND 0/ VT OG 7/00 OG 7/0 OG 7/00 7/0 OG /9 /7 /8 /9 /9 /8 G0 TP90 XC0 00

67 Group Lighting Fog lights 0+ / / A/ A/ B/ DIM C: C: 0/ OG 0/ / C: C: C:9 C:8 7/ / LSM F GNVT K OG C: 7/07 RHD LHD RHD VT 7/0 7/0 C:9 C:0 C:9 7/ BNGN LHD RHD 7/ 7/0 BNGN BNGN 7/7B 7/7A 7/7A 7/7B BNGN BNGN 0/ FOG FOG 0/ OG GND GND VT 7/09 7/7B 7/7A /9 7/ 7/09 GN GN /7 /8 /9 TP90 XC G0

68 Group Lighting Brake lights 0+ / A/ A/ / C: C: F8 C: /9 /9 KVM C:9 C:0 C: VT VT C: C: GY 7/0 0 C:8 0/9 LHD 7/ C:9 VTBN OG 7/00 7/7A 7/7B VTBN VTBN 0/ 7/09 FOG GND 0/8 7/0 REV POS OG GND STOP TURN 0/0 OG 7/0 TURN STOP GND 0/ POS REV 0/7 7/0 7/00 7/0 OG OG OG 7/7B 7/7A 7/ 7/09 GN GN /7 /7 /8 G0 TP90 XC0 00 8

69 Group Lighting Reversing lights 0+ /8 AUTO 7/0 7/ 7/0 A:7 BNVT BNVT BNVT BNVT TCM 0 / A: GSM / A: A/ A/ A: / C: C: F C:7 K C:8 MAN C: C:7 C: 7/0 MAN MAN MAN /0 7/ GNBN GYVT 0/8 0/7 0/ REV POS STOP TURN TURN STOP POS OG GND GND OG 7/0 7/09 7/0 7/00 REV OG 0/8 /XX0 /7 /8 G0 TP90 XC0 00 9

70 Group Lighting Followmehome lighting LHD 0+ / A/ 7/0B GN GN GN 7/07 / D/A D/A 7/07 7/08 / C: /7 C: DDM PDM C: C: C: C: C: C: C: C: C:0 C:0 C: C: VT VT / My M x M F GN GN KEYLESS KEYLESS / GN 7/07 0 7/08 0 VT GN VT GN VT VT 7/07 MEM X MEM Y 7/0 My 0/8 0/9 M x M F MEM X MEM Y 7/0 7/0 / / G07 TP90 XC

71 Group Lighting Followmehome lighting RHD 0+ / A/ GN 7/0B GN GN 7/07 / D/A D/A 7/08 /7 / PDM DDM VT VT KEYLESS KEYLESS VT GN GN 7/07 0 7/08 0 VT GN 7/07 C: C: C: C: VT C: C: VT C: C: C: C: C:0 C:0 C: C: 7/0 / My M x M F MEM X MEM Y 0/8 7/07 / My M x M F MEM X MEM Y 0/9 7/0 7/0 VT / GN / G08 TP90 XC0 00 7

72 Group Lighting Interior lighting, LHD : / 0+ /8 M POT /9 0/ 7/0 7/0 A/ A/ /9 R9 B/ B/7 /8 VTGN M OG 7/ 7/0 / K0A C: C: C:8 OG OG 7/00 0/9 0/ BN GY GY C: C: C: C:7 C:9 F7 7/0 7/09 0/ GY C:7 7/ 7 OG OG 7/00 0/ 7/ PANROOF 0/ C: C: C: C:0 GY PANROOF 7/0 7/ On Off Ctsy MAP READING /7 C: C: 0/ C: /7 7/0 PANROOF 0/0B PANROOF 7/00 GYVT PANROOF 7/0 7/0 7/ 0/0A /0 /7 7/0 7 7/0 7/0 7/0 7/0 /8 / GN TP90 XC GN GN GN 8 GN 0/7 /8 G09

73 TP90 XC /7 C: C: C: PDM C: / GN GN /7 GN GN GNVT / DDM C:8 C: C:7 C:9 C: C: C: C: / C: C: VT VT VT VT VT VT VT GN VT / GN GN GN GN GN 8 / GNVT /8 LDM /9 M 7/07 7/07 7/07 7/0 7/0 7/09 7/08 0 7/09 7/07 7/08 7/0 A/ 0+ GN GN GN / D/A D/A / 7/0B 7/07 7/0 7/ / GN GN KEYLESS KEYLESS KEYLESS KEYLESS KEYLESS KEYLESS GN GN 7/0 7/0 7/0 C:9 C:0 / DOUBLE CENTRAL LOCK SWITCH LOCK AJAR GROUND LOCK LOCKING COMMON DL CL CENTRAL LOCK SWITCH LOCK AJAR AJAR LOCK CHILD DOUBLE LOCK LOCKING COMMON DL CL GROUND CENTRAL LOCK DOUBLE LOCK LOCKING COMMON DL CL CHILD LOCK PCL GROUND AJAR LOCK CHILD CENTRAL LOCK DOUBLE LOCK LOCKING COMMON DL CL CHILD LOCK PCL GROUND GN G00 Group Lighting Interior lighting, LHD :

74 Group Lighting Interior lighting, RHD : / 0+ /8 M POT /9 0/ 7/0 7/0 A/ A/ /9 R9 B/ B/7 /8 VTGN M OG 7/ 7/0 / K0A C: C: C:8 OG OG 7/00 0/9 0/ BN GY GY C: C: C: C:7 C:9 F7 7/0 7/09 0/ GY C:7 7/ 7 OG OG 7/00 0/ 7/ PANROOF 0/ C: C: C: C:0 GY PANROOF 7/0 7/ On Off Ctsy MAP READING /7 C: C: 0/ C: /7 7/0 PANROOF 0/0B PANROOF 7/00 GYVT PANROOF 7/0 7/0 7/ 0/0A /0 /7 7/07 7/0 7 7/0 7/0 7/0 7/0 /8 / GN TP90 XC GN GN GN 8 GN 0/7 /8 G0