Parts List for The 36 & 42 Wright Stander Mower (For Serial Numbers and Higher Until Superseded)

Transcription

1 Parts List for The & Wright Stander Mower (For Serial Numbers 00 and Higher Until Superseded) Replace with newer revisions as they become available 00 Wright Manufacturing, Inc. All rights reserved Revised: 0/0

2 TABLE OF CONTENTS Assembly Name Figure Page Brake Assembly Figure Caster Assembly Figure Control Lever Assembly Figure Dash board Assembly Figure Deck & Pulley Configuration Figure Deck Assembly Figure Electrical Start Assembly Figure Electrical Start Diagram Figure Recoil Start Wiring Harness Figure Electric Start (European Models) Figure 0 Engine & Muffler Assembly Figure Engine Deck Assembly Figure Foot Plate Assembly Figure Fuel System Assembly Figure Hydraulic Assembly Figure Motor Support Assembly Figure Upright Assembly Figure Decals Figure 00 Wright Manufacturing, Inc. All Rights Reserved?

3 BRAKE ASSEMBLY (-) Figure,a 0 00 Mach Bushing, ½ ID x / OD x Ga. 00 Pump Lock Lever, Left, Stander 000 Pump Lock Lever, Right, Stander 00 Bolt, shldr Allen ½ x / 00 Nut, Toplock / 000 Spring Ext. 000 Spring, Deck Cog 000 Bolt, Flange / x ¾ Z 000 Nut, Lock Flange / Z Brake, Lateral Link Bar 000 E-Clip ½ 00 Brake Shoe 00 Brake Push Bar, Stander 000 Nut, Nylock / Z 000 H-Bush.00 x.0 x x x. 00 Bolt, shldr Allen ½ x ¼ 000 Parking Brake Handle Assembly ( incl. # and #a ) a 000 Handle grip for brake

4 CASTER ASSEMBLY (-) Figure ,a 000 x 00 Wheel Assembly a 000 Tire Only 000 Rim Only 000 LT Race, For Bearing 000 LT Tapered Roller Bearing 000 LT Grease Seal 000 LT Wheel Spacer 00 LT Bearing Kit ( ea. #, #, # and # ) 00 Nut, Nylock Jam ¾ Bolt, Hex HD ¾ - 0 x ½ Z Bolt, Flange / x ¾ Z 000 Nut, Flange Lock / Z 000 Nut, Nylock / Z 000 Washer, USS F/W / Z 00 Bolt, / x ¼ Z 00 Caster Bolt Kit ( Bolts, Nuts, Washers ) 00 L S Caster Arm ( incl. #, #0 ) 000 Caster Adjustment Bracket 000 Zerk Fitting for Caster Arm 00 Mach Bushing ¼ x 0 Ga Bronze Bushing 00 C Spacer 000 L S Caster Yoke 00 Lynch Pin

5 CONTROL LEVER ASSEMBLY (-) Figure 0 00 Hitch Pin Clip # 000 Swivel End, / 00 Control Rod x 000 Hitch Pin Clip # 00 Bolt, Hex / x ¾ Z 00 Pump Lever Spacer. x., Stander 00 Pump Lever Spacer. x.0, Stander 00 Nut, Nylock / Z 00 Bolt, Hex / x ¼ Z 0 00 Pump Lever 000 Groove Pin ½ x. Z 000 E Clip ½ 000 Bushing, Bronze ½ Long 000 Left Control Lever Assembly ( incl. #, # ) 000 Right Control Lever Assembly ( Incl. #, # ) 00 Mach Bushing ½ ID / OD Ga. 000 Foam Grip

6 DASH BOARD ASSEMBLY (-) Figure 0,a 00 Nut, kep 0 00 Screw, Truss HD mach 0 x ½ Z 000 Throttle Cable 000 Choke Cable incl. Retaining Nut 000 Clutch Switch, Red Push/Pull 000 Ammeter incl. Retainer and Hardware 000 Plug, Panel, Black 000 Hour Meter incl. Retainer 0000 Ignition Switch, Electric Start (incl. Key and Hardware ) a 0000 Ignition Switch, Recoil (incl. Key and Hardware) Wire Harness, Dash Panel, Electric Start 00 Screw, Truss HD mach ¼ - 0 x ¾ Z 000 Instrument Panel 000 Plug, Panel, Black

7 DECK ASSEMBLY Figure,a 0 0 0,a 00 Washer, Flat USS / 000 Blade,, For Deck a 000 Blade,, For Deck 00 Spindle Assembly / 000 Washer, Flat USS / Z 000 Bolt, Hex / x Z 00 Nut, Toplock / 000 Pulley, Idler ¾ x / x / Bore 000 Nut, Nylock / Z 000 Blade Spacer / x ½ x ¼ Threaded Rod, Idler Adjust / 000 Bushing Bronze 00 Bolt, Flange / x ¾ Z 000 Nut, Lock Flange / Z 00 Nut, Lock Flange / Z 000 / Rod Stand 000 E Clip / 00 MACH Bushing, / ID / OD Ga. 000 Idler Arm Base, / 000 Nut, Lock Flange ½ - Z Idler Arm (incl. #) 000 Hitch Pin Clip # 000 Spring, Stander Deck Idler Rod 00 Bolt, Hex ¼ - 0 x / P 000 Bushing, Split Tapered 00 Bolt, Flange ½ x ¼ Z 000 Pulley, Single Grv ¾ OD A/B 000 Nut, Hex / Z,For Blades 00 Bolt, Hex / x Z Stander / 000 Machine Key, ¼ x ¼ x Chute Deflector, WS 00 Bolt, Hex / x Z 000 Bolt, Hex / x ½ Z 00 Nut, Nylock / Z 000 Spring, Torsion for Chute Deflector 000 Bolt, Flange / x ¾ Z 000 Caster Adjustment Bracket 000 Cutter Deck, w/caps and decals a 000 Cutter Deck, w/caps and decals 000 Cap, Vinyl / x 000 Nut, Lock Flange / Z

8 DECK & PULLEY CONFIGURATION & DECK COVERS (-),a,a Figure,a 0,a (Right and left),a 000 Deck Cover, a 000 Deck Cover, 000 Cutter Deck, w/caps and Decals a 000 Cutter Deck, w/caps and Decals 00 Belt, Engine to Blade a 000 Belt, Engine to Blade 000 Tube Closure For Deck Cover 000 Knob, Black Plastic For Deck Covers 000 Bolt, Hex / x ½ Z 000 Bolt, Hex / x Z 000 Fender Spacer Short, Stander 00 Fender Spacer Long, Stander 0 00 Nut, Toplock / 00 Fender Left, Stander a 00 Fender Right, Stander 000 Mulch Kit, Curved a 000 Mulch Kit, Curved 000 Bolt, Flange / x ¾ Z 000 Nut, Lock Flange / Z Return of Table Contents

9 ELECTRICAL ASSEMBLY (-) Figure,a,a Cable, Battery, Red with Lug Insul. 00 Cable, Battery, Black ½ 00 Cable, Battery Red ½ 000 Solenoid 000 Wire, Grounding 000 Harness, Main, Electric with Relay 00 Wire Harness, Engine ( Kaw HP. R/E and // HP ) 000 Switch, OPC, lb. Internal Spring 00 Relay for Main Harness Ammeter incl. Retainer and Hardware 000 Hour Meter, incl. Retainer 000 Wire Harness Instrument Panel, Electric a 00 Wire Harness Instrument Panel, Recoil 0000 Ignition Switch, Electric Start ( Incl. Key and Hardware ) a 0000 Ignition Switch, Recoil (incl. Key and Hardware) 000 Clutch Switch, Red Push/ Pull 000 Battery, v, 00 CCA Maint. Free

10

11

12

13 ENGINE AND MUFFLER ASSEMBLY (-) Figure *,a, b 0, a,a 0 * Engine, HP Kawasaki, Recoil a* Engine, HP Kawasaki, Recoil b* Engine, HP Kawasaki, Recoil/Electric 000 Setscrew, /- x / 000 Pulley. OD x A GRV x mm ( Hydro Pumps) 000 Machine Key mm x mm x mm 000 Oil Drain Valve 000 Fitting, Male Barb, 0 Deg (Kaw) 00 Tube, Oil Drain 00 Nipple, Brass, / NPT close 00 Coupling, Brass, / NPT Fitting, Male Barb ½ Strt 000 Machine Key ¼ Sq. x 000 Pulley. OD x A GRV x 000 Clutch/Brake 000 D Spacer, for Clutch 000 Washer, Lock / Z 000 Bolt, Hex /-0 x ¾ Z 00 Muffler Guard, Kawasaki HP (CE Models only) a 00 Muffler Guard, Kawasaki,, HP ( CE Models only) 00 Bolt, Hex M. x Z a 000 Bolt, Flange / x ¾ Z For HP 000 Bolt, Hex / x ½ Z Washer, Flat USS ¼ Z 00 Nut, Lock Flange / Z * NOTE Exhaust & Muffler Available Through Kawasaki

14 ENGINE DECK ASSEMBLY Figure Nut, Lock Flange / Z 00 Bolt, Hex / x ¾ Z 00 Bolt, SHLDR Allen / x ¾ 00 MACH Bushing / ID OD Ga. 000 Pulley. OD x A Grv x mm 00 Nut, Nylock Jam ½ Wheel, Plastic, x ¾ w// Bore 00 Nut, Hex ¼ - 0Z 000 Washer, Lock ¼ Z 0 00 Nut, Nylock ¼ - 0 Z 000 Solenoid 000 Bolt, Hex ¼ - 0 x ¾ Z 000 Switch, OPC 000 Nut, Lock Flange / Z 000 T Stud, Stander OPC 000 Cap, Vinyl / x 000 Clip, Half / 00 Nut, Nylock 0 00 Screw, PHLPS Pan 0 x ¾ Z Washer, Flat SAE #0 Z 00 Waterproof Relay 00 Fuel Tank Stand 000 Hydro Oil Filter Housing Block 000 Washer, Lock ¼ Z 000 Bolt, Hex ¼ - 0 x ¾ Z 000 Bolt, Hex / x ½ Z 000 Washer, Flat USS / Z 000 Washer, Flat USS / Z 000 Bolt, Hex / x Z 0 00 Spacer, For Engine Idler Spring 000 Nut, Lock Flange / Z 000 Spring, Pump Idler 00 Nut, Toplock / 000 Pulley, Idler ½ x x / Bore 000 E- Clip / 00 MACH Bushing / ID / OD Ga. 000 Bushing, Bronze 000 Idler Arm Assembly, Hydro 000 Idler Arm Base 0 00 Pulley Guard Plate 00 Screw, Truss HD MACH ¼ - 0 x ¾ SS 00 Belt, Hydro 000 Hose Hold Bracket 00 Nut, Nylock / Washer, Flat ¼ Z 00 Bolt, Hex / x ¾ Z 00 Battery Strap 00 Battery Stand 000 Battery v. Maint. Free Battery Case, Base and Lid 00 Tractor Frame Weldment 00 Hose Hold Clip 000 Bolt, Flange / x ¾ Z

15 FOOT PLATE ASSEMBLY (-) Figure 00 Bolt, Hex ½ - 0 x Z 000 Foot Plate Joint, Zinc Plated 000 Washer, Flat USS / Z 00 Nut, Nylock Jam ½ Foot Platform 00 Nut, Nylock ¼ - 0 Z 00 Bolt, Hex ¼ - 0 x Z 00 OPC Actuator, Stander 000 Spring Large Compression

16 FUEL ASSEMBLY (-) Figure, a 00 Fuel Line, (Kohler Engine) a 00 Fuel Line, (Kawasaki) 00 Screw, Round PHLP ¼ - 0 x Z 000 Nut, Lock Flange ¼ - 0 Z 000 Hose Clamp, ¼ 000 Valve, Ball 0 Deg. For Fuel Tank 000 Bushing For Fuel Tank Valve 000 Fuel Tank Strap 000 Fuel Tank, incl. # and # 000 Fuel Tank Cap w/vent

17 HYDRAULIC ASSEMBLY (-) Figure 0 0,a,a,a 0,a,a,a,a 000 Hydro High Pressure Hose Assembly ¾ a 00 O-ring ( / x / x / ) 000 Hydro High Pressure Hose Assembly ½ a 00 O-ring ( / x / x / ) 000 Elbow, STRT O ring, / x / a 00 O-ring ( / x / x / ) 000 Hydro Pump Right 000 Hydro Pump Left 000 Elbow, STRT O-ring ½ x / a 00 O ring ( / x / x / ) 000 Elbow, Swivel JIC ½ 000 Hydro Motor ( MF ) 000 Tee Hose,. x. x Hose Assembly ½ 000 Hydro Oil Filter 000 Hydro Filter Housing 000 Elbow / Street 00 Brass Tee, Female / 000 Hydro Tank 000 Hydro Tank Cap 00 Elbow, Degree, O-Ring, ½ (incl. #a) 000 Connector, STRT Oring ½ (incl. #a) 00 Plug, Steel /

18 MOTOR SUPPORT (-) Figure,a 0,a, b, c,a 000 Rim Only, x 0, For Mower a 000 Rim Only, x 0, For Mower b 000 Wheel Assembly, X 0-, c 000 Wheel Assembly, X 0-, 00 Pin, Cotter / x 00 Woodruff Key / x ¾ 00 Bolt, Hex / x Z 00 Right Hydro Motor Support Weldment a 00 Left Hydro Motor Support Weldment 000 Nut, Lock Flange / Z 00 Bolt, Carriage, / x Z 000 Hydro Motor (MF ) 00 Stud, For Tapered Wheel Hub 0 00 Wheel Hub, Tapered 00 Nut, Castle ¾ Nut, Lug ½ Turf Tire, For Mower a 000 Turf Tire, For Mower

19 UPRIGHT ASSEMBLY (-) Figure 0,a,a Nut, Lock Flange / - 00 Pump Guard Bars ( incl. a ) a 000 Foam for Pump Guard Bars 000 Bolt, Flange / x ¾ Z 000 Nut, Lock Flange / Z 000 Washer, Flat ¼ Z 000 Clip, Half / 00 Bolt, Flange / x ¾ Z 00 Nut, U ¼ Upright Weldment a 00 Upright Weldment CE Only Serial Number Break # 0 00 Bolt, Hex / x Z 000 Washer, Lock / Z 000 Washer, Flat / Z 000 Cushion 000 Stationary Handle Bar

20 DECALS (-) Figure (QTY. ) 0 (QTY. ) 000 Decal, Deck Size 00 Decal, Deck Size 000 Decal, Throttle/Instructions 00 Decal, Main, Inst. Panel 00 Decal, Speed, Sensit. Adjust 00 Decal, CE Throttle/Instructions 00 Decal, Circle with W 000 Decal, All Logos 00 Decal, Choke Decal, Stander, Front 00 Decal, CE Shield Missing 000 Decal, Shield Missing 000 Decal, CE Main, Inst.Panel 00 Decal, CE Noise, Danger, CE Blade Hazard 000 Decal, Danger Blade Hazard