ABS and Tire Pressure Warning System

Size: px
Start display at page:

Download "ABS and Tire Pressure Warning System"

Transcription

1 S and Tire Pressure arning System D Data Link 3 * : utomatic /C * : Except * SIL TC TS K 9 L P- 4 K 0 L 7 S Speed Sensor Rear LH 8 S Speed Sensor Rear RH I 5 I IL IL - R - R P- R G LG L - R P- R G J 7(), J 8() J 5(), J () LG L M +S D/G TC TS RL+ RL- RR+ RR- S 3 Skid Control ECU with ctuator INIT PK GND GND FL+ FR- FL- FR F (), F0(E), F(G) Fusible Link lock 30 S 3 G E - R 50 S FL MIN 3. 0 attery T 4 Tire Pressure arning Standardization S L- O 4 0 L- O 3 (*) 3 (*) J8 J 5(), J () P Parking rake S R- L 7 C 0 K 3 7 J 5(), J () 3 S Speed Sensor Front LH L- O 4 S Speed Sensor Front RH Y IE ED SIENN (ED3U)

2 From Power Source System (See Page 58) 0 STOP 0 ECU- IG 0 GUGE C C L S Stop Light S G- J - R 0 R R R 85 7 II3 J8 G- - R 3 P N P Park/Neutral Position S STP IG S 3 Skid Control ECU with ctuator SP 7 9 RL 30 TIR P 4 5 N Y II3 II3 J 5(), J () J0 Y- 005 SIENN (ED3U) 49

3 S and Tire Pressure arning System From Power Source System (See Page 58) 7. 5 GUGE 0 ECU- 5 H 8 C Tire Pressure C0 Combination Meter S RKE Speedometer - R L - L C 7 L Y- - R R - L J 7(), J 8() J9 Y- Y- J rake Fluid Level arning S R - L E IF SIENN (ED3U)

4 System Outline S system controls the respective brake fluid pressures acting on the disc brake cylinders of the four wheels when the brakes are applied in a panic stop, so that the wheels do not lock. This results in improved directional stability and steerability during panic braking. Tire pressure warning system turns on the tire pressure warning light and warns the driver of low tire pressure, when driving with a low tire pressure, which may cause trouble driving. However, this system can detect the low tire pressure condition only if one of the tires has such a condition in particular compared to other tires, and it cannot detect. Therefore, it can not detect natural (Gradual) air loss occurring to the tires.. Input Signals () Speed sensor signal The speed of the wheels is detected and input to TERMINLS FL+, FR+, RL+ and RR+ of the skid control ECU with actuator. () Stop light S signal signal is input to TERMINL STP of the skid control ECU with actuator when the brake pedal is operated. (3) Standardization S Signal signal is input to TERMINL INIT of the skid control ECU with actuator when the tire pressure warning standardization S in operated. (4) Parking position signal signal is input to TERMINL P of the skid control ECU with actuator when the Shift lever at P position. (5) Neutral position signal signal is input to TERMINL N of the skid control ECU with actuator when the Shift lever at N position.. S System Operation During sudden braking the skid control ECU with actuator has signals input from each sensor, which controls the current to the solenoid inside the actuator and lets the hydraulic pressure acting on each wheel cylinder escape to the reservoir. The pump inside the actuator is also operating at this time, and it returns the brake fluid from the reservoir to the master cylinder, thus preventing locking of the vehicle wheels. If the skid control ECU with actuator judges that the hydraulic pressure acting on the wheel cylinder is insufficient, the current on the solenoid is controlled and the hydraulic pressure is increased. Holding of the hydraulic pressure is also controlled by the skid control ECU with actuator, by the same method as above. Pressure reduction, holding and increase are repeated to maintain vehicle stability and to improve steerability during sudden braking. 3. Operation of Tire Pressure arning System In accordance with the reduction of tire pressure, tire diameter becomes small and the tire rotation speed becomes greater. In the relation between the difference of the vehicle speed of normal wheels and the low pressure wheel and the tire pressure, based on the speed signal detected during driving, it detects the change of the tire pressure. s a result, if the system judges that the tire pressure has reduced, it turns on the tire pressure warning light and warn the driver using the signal from the skid control ECU with actuator. Service Hints S3 Skid Control ECU with ctuator, 4-Ground : lways approx. volts 3-Ground : pprox. volts with the ignition S at ON position -Ground : pprox. volts with the brake pedal depressed, 3-Ground : lways continuity 3, 4 S Speed Sensor Front LH, RH - : pprox..07 kω (0 C, 8 F) 7, 8 S Speed Sensor Rear LH, RH - : pprox.. kω (5 C, 77 F) S Stop Light S - : Closed with the brake pedal depressed 005 SIENN (ED3U) 5

5 S and Tire Pressure arning System : Parts Location Code See Page Code See Page Code See Page 3 3 F0 E 3 J F G 3 J J 33 J J 33 P 33 3 J5 3 P 37 C0 35 J 3 S3 33 D 35 J7 3 S 37 F 3 J8 3 T4 37 : lock and ire Harness Code See Page lock and ire Harness ( Location) C 7 Engine Room Main ire and Driver Side J/ (Lower Finish Panel) H K Instrument Panel ire and Driver Side J/ (Lower Finish Panel) 7 L C Engine Room Main ire and Engine Room J/ (Engine Compartment Left) : Joining ire Harness and ire Harness Code See Page Joining ire Harness and ire Harness ( Location) I 4 Engine Room Main ire and Floor No. ire (Left Cowl Side Panel) II3 48 Engine ire and Instrument Panel ire (Right Kick Panel) IL 48 Engine Room Main ire and Floor No. ire (Right Kick Panel) : Ground Points Code See Page Ground Points Location E 44 Front Side of the Right Fender pron ED 44 Front Side of the Left Fender pron IE 4 Left Kick Panel IF 4 Instrument Panel race LH SIENN (ED3U)

ABS 2002 RAV4 (EWD466U) FROM POWER SOURCE SYSTEM (SEE PAGE 46) 40A ABS 1 10A GAUGE 10A ECU IG 30A ABS 2 10A STOP J 5 JUNCTION CONNECTOR R L R W R W

ABS 2002 RAV4 (EWD466U) FROM POWER SOURCE SYSTEM (SEE PAGE 46) 40A ABS 1 10A GAUGE 10A ECU IG 30A ABS 2 10A STOP J 5 JUNCTION CONNECTOR R L R W R W AS FOM POE SOUCE SYSTEM (SEE PAE 46) 0A AUE 30A AS 40A AS 0A ECU I 0A STOP 9 J 5 E 4 E E 8 J () 3 H 5 (P) ID 46 6 () J 5 (S) Y S 8 STOP LIHT S 6 H E 8 ID (P) 3 5 0 +S +M I STP A 4 AS ACTUATO AND ECU PK

More information

Engine Control for 1MZ-FE and 3MZ-FE

Engine Control for 1MZ-FE and 3MZ-FE Engine Control for MZ-FE and MZ-FE CC * : MZ- FE * : TMC Made * : TMMK Made * : Shielded M I ST - Y - Y 7 M I - ST I Ignition S 8 - IF - M - Y - E IF 8 C - - Y - 0 I E 9 C - 0 M /F 0 EFI EFI elay C/OPN

More information

Engine Control (1MZ-FE)

Engine Control (1MZ-FE) Engine Control (MZ-FE) - M CC IG ST - 7 M IG 6 ST - I5 Ignition S IF - - 5 M 3 IF6 C E - G - - - 0 IG - - E 4 9 3 4 C 0 T 30 M 5 /F 0 EFI 5 3 EFI elay C/OPN elay 5 3 /F HT elay 5 3 5 C 6 K 4 D 6 C 7 C

More information

Engine Control COROLLA (EWD533U) B O B W B W I 7 I10. Ignition SW R W R W (A/T) (M/T) E 3 15A AM2. Junction Connector. Clutch Start SW B W B W

Engine Control COROLLA (EWD533U) B O B W B W I 7 I10. Ignition SW R W R W (A/T) (M/T) E 3 15A AM2. Junction Connector. Clutch Start SW B W B W Engine Control O 5 M IG 6 ST 4 I 7 I0 Ignition S 5 M 6 3 IM IM I4 I IC 5 IL 8 IK 5 E 3 3 E 0 E O 3 I II 0 I5 P N 6 E 9 30 MIN 5 EFI 3 5 3 4 IG 9 ID IG II G G FL MIN. 0L 9 E 9 II 4 M 5 G (/T) G C 8 Clutch

More information

Engine Control for 3MZ-FE

Engine Control for 3MZ-FE Engine Control for MZ-FE - Y M CC IG ST - Y - R(*) 7 M IG 6 R- (*) ST I - R I Ignition S 8 IG8 - Y 7. M IG - - - R - Y - - R- E 9 C 8 C - G 0 IG - - 0 T 0 M /F 0 EFI EFI Relay C/ON Relay /F HTR Relay C

More information

HEADLIGHT 10A HEAD 20A HEAD 10A HEAD 20A HEAD (RH UPR) (LH UPR) (RH LWR) (LH LWR) 4 1J 5 1J 8 1J R W R G R B R L R L R B E 1 R Y R Y E 1 R W R B

HEADLIGHT 10A HEAD 20A HEAD 10A HEAD 20A HEAD (RH UPR) (LH UPR) (RH LWR) (LH LWR) 4 1J 5 1J 8 1J R W R G R B R L R L R B E 1 R Y R Y E 1 R W R B HEDLIGHT 4 J 5 J 8 J 3 C 7 J H 4 HEDLIGHT LH (LOW) H 6 HEDLIGHT RH (LOW) R R E R H 3 HEDLIGHT LH (HIGH) R G R G H 5 HEDLIGHT RH (HIGH) E W W R W W W E W W W W F 7 FUSILE LINK LOCK J E W W W 9 J 0 C W W

More information

Theft Deterrent and Door Lock Control

Theft Deterrent and Door Lock Control Theft Deterrent and Door ock Control From Power Source System (See Page 0) 0 HORN (), 7(), (C) ody CU HORN SGND 4 GND CY DCTY PCTY C C RCTY 0 HORN Relay 5 G R J Junction Connector F 7 K S G D G R G IC

More information

HEADLIGHT 10A HEAD 20A HEAD 20A HEAD 10A HEAD (RH- LWR) (LH- LWR) (RH- UPR) (LH- UPR) 4 1J 5 1J 8 1J 7 1J R- W R- G R- B R- L R- B E 1 R- Y R- Y E 1

HEADLIGHT 10A HEAD 20A HEAD 20A HEAD 10A HEAD (RH- LWR) (LH- LWR) (RH- UPR) (LH- UPR) 4 1J 5 1J 8 1J 7 1J R- W R- G R- B R- L R- B E 1 R- Y R- Y E 1 HEDLIGHT 4 J 5 J 8 J 7 J E E H HEDLIGHT LH (LOW) H 4 HEDLIGHT RH (LOW) H HEDLIGHT LH (HIGH) H 3 HEDLIGHT RH (HIGH) R- L R- G R- G E J E 9 J 0 C 0 HED (LH- LWR) 0 HED (RH- LWR) 0 HED (LH- UPR) 0 HED (RH-

More information

A18 Automatic Light Control Sensor. Generator L CLTB CLTS CLTE G 1 Y (USA) G O G Y IG +B CHG CSB CSO CSE. Daytime Running Light Relay. Low.

A18 Automatic Light Control Sensor. Generator L CLTB CLTS CLTE G 1 Y (USA) G O G Y IG +B CHG CSB CSO CSE. Daytime Running Light Relay. Low. From Power Source System (See Page 5) 0 GUGE 0 ECU B G Generator 8 utomatic Light Control Sensor L CLTB CLTS CLTE 3 IG IH W B IG3 IE 3 IE IE 3B 3B W 0 3B 8 3B G G O G B P Parking Brake SW 3 8 0 9 8 IG

More information

Door Lock Control RUNNER (EWD615U) From Power Source System (See Page 62) Body ECU 7. 5A GAUGE 20A DR/LCK 7. 5A ACC 10A DOME 15A IG1 DRLP

Door Lock Control RUNNER (EWD615U) From Power Source System (See Page 62) Body ECU 7. 5A GAUGE 20A DR/LCK 7. 5A ACC 10A DOME 15A IG1 DRLP Door ock ontrol From Power Source System (See Page 6) (), 5(), 6() ody EU 5 IG 0 DOME 7. 5 GUGE 0 D/K 7. 5 D DP DY SPD 8 J Y- J 7 I G - G- W 9 E V- Y W- V- G SP G- 7 I S8 Skid ontrol EU with ctuator Y-

More information

Wireless Door Lock Control

Wireless Door Lock Control ireless Door Lock Control From Power Source System (See Page 8) (), (), 6(C) ody ECU 0 J/ 0 D/LCK 7. CC CC D TLY 8 HLY 7 HZ 8 L- G- TIL elay 9 E C 8 J G- L- HED elay 0 HZ 8 EH D Turn Signal Flasher elay

More information

This manual provides information on the electrical circuits installed on vehicles by dividing them into a circuit for each system.

This manual provides information on the electrical circuits installed on vehicles by dividing them into a circuit for each system. HO TO USE THIS MNUL This manual provides information on the electrical circuits installed on vehicles by dividing them into a circuit for each system. The actual wiring of each system circuit is shown

More information

ELECTRONICALLY MODULATED AIR SUSPENSION

ELECTRONICALLY MODULATED AIR SUSPENSION ELECTRONICLLY MODULTED IR SUSENSION FROM OWER SOURCE SYSTEM (SEE E 56) 40 H/CTRL 0 ECU I 8 F W E 6 6 IR SUS RELY 4 IJ L R L 4 6 6 H0 HEIHT CONTROL EXHUST LE R 0 IM 9 IM 5 IJ IJ L L R H 9 HEIHT CONTROL

More information

ENGINE CONTROL (5VZ-FE)

ENGINE CONTROL (5VZ-FE) ENGINE CONTROL (VZ-FE) SYSTEM OUTLINE The engine control system utilizes a microcomputer and maintains overall control of the engine transmission etc. An outline of engine control is given here.. INPUT

More information

HOW TO PROCEED WITH TROUBLESHOOTING

HOW TO PROCEED WITH TROUBLESHOOTING 2005 BRAKES Anti-Lock Brake System With Electronic Brake Force Distribution (EBD) - Diagnostics - RAV4 HOW TO PROCEED WITH TROUBLESHOOTING Troubleshoot in accordance with the following procedures. Fig.

More information

Before repair, remove the airbag sensor if shocks are likely to be applied to the sensor during repair.

Before repair, remove the airbag sensor if shocks are likely to be applied to the sensor during repair. NOTICE: hen inspecting or repairing the SRS, perform service in accordance with the following precautionary instructions and the procedure, and precautions in the Repair Manual applicable for the model

More information

ANTI-LOCK BRAKING SYSTEM (ABS)

ANTI-LOCK BRAKING SYSTEM (ABS) 35B-1 GROUP 35B ANTI-LOCK BRAKING SYSTEM (ABS) CONTENTS GENERAL DESCRIPTION......... 35B-2 ANTI-SKID BRAKING SYSTEM (ABS) DIAGNOSIS.................... 35B-3 INTRODUCTION TO ANTI-LOCK BRAKE SYSTEM DIAGNOSIS................

More information

ENGINE CONTROL MR2 (EWD498U) R W R W R W B 7 IC1 I10 IGNITION SW R W W R W R 40A MAIN ST 5 AM2 C/OPN RELAY 7. 5A RELAY B Y B Y B L B R G R B Y

ENGINE CONTROL MR2 (EWD498U) R W R W R W B 7 IC1 I10 IGNITION SW R W W R W R 40A MAIN ST 5 AM2 C/OPN RELAY 7. 5A RELAY B Y B Y B L B R G R B Y ENGINE CONTRO 5 M IG 6 R IC R 7 R 0 R R IC I0 IGNITION S ST 4 R 7 IC R R 5 5 5 M 40 MIN ST REY 7. 5 ST C/OPN REY 3 3 R F FUE PUMP R 4 5 Y (*) Y (*) 0 I3 Y (*) F MIN. 0 C 9 CUTCH STRT S M TTERY (*) I K

More information

Headlight TOYOTA TACOMA (EWD614U) W W. From Power Source System (See Page 72) R- B R- B 10A IG1 NO. 2 20A DR LCK. 7. 5A ECU- B DIM Relay 1 2C

Headlight TOYOTA TACOMA (EWD614U) W W. From Power Source System (See Page 72) R- B R- B 10A IG1 NO. 2 20A DR LCK. 7. 5A ECU- B DIM Relay 1 2C Headlight From ower Source System (See age 7) 0A IG NO. 0A D LCK 7. 5A ECU- B DIM elay 3 5 HEAD elay 3 5 C 9 IA A HLY 6 C 5 6 IG ALTB ECUB 30 Y- B Y- B IA 5 A DIM B 5(A) Body ECU B HEAD HF HU GND KB L

More information

ELECTRONICALLY CONTROLLED TRANSMISSION AND A/T INDICATOR

ELECTRONICALLY CONTROLLED TRANSMISSION AND A/T INDICATOR , ELETRONILL ONTROLLE TRNSMISSION N /T INITOR FROM POWER SOURE SSTEM (SEE PGE 8) 0 EFI 0 STOP 7. 5 ST 0 IGN F 6 F 0 F GR- I0 I0 I0 EFI REL 5 7 IG GR- IG S STOP LIGHT SW 5 G- W G- W /T FLUI TEMP. SENSOR

More information

HEADLIGHT (USA, PUERTO RICO)

HEADLIGHT (USA, PUERTO RICO) HEDLIGHT (US, PUETO ICO) W FOM POWE SOUCE SYSTEM (SEE PGE 8) I F FUSILE LINK LOCK 00 LT W C C, C D COMINTION METE I INTEGTION ELY EM C 8 KE 9 9 C C 6 C - L - L D 0 GUGE 6 - G - L - L TIL ELY 6 LG LG LG

More information

AUTOMATIC AIR CONDITIONING

AUTOMATIC AIR CONDITIONING UTOMTIC I CONDITIONING FOM POE SOUCE SSTEM (SEE PGE ) F 9 FUSIBLE LINK BLOCK 0 HETE 9 HETE 7. GUGE 7. DIO NO. 8 G K 0 K K L B B G H D C D E C L B H 8 HETE EL L L IG +B IG L O B, B 7 C, B 8 D BOD ECU B,

More information

Before repairs, remove the airbag sensor if shocks are likely to be applied to the sensor during repairs.

Before repairs, remove the airbag sensor if shocks are likely to be applied to the sensor during repairs. NOTICE: When inspecting or repairing the SRS, perform the operation in accordance with the following precautionary instructions and the procedure and precautions in the Repair Manual for the applicable

More information

ENGINE CONTROL (2RZ FE)

ENGINE CONTROL (2RZ FE) ENGINE CONTROL (RZ FE) IF (A/T) AM IG 6 FROM POER SOURCE SYSTEM (SEE PAGE 44) AM ACC IG ST IF. A STA F FUSE O. A IGN A EFI 0A OD A STOP I4 IGNITION S (A/T) (A/T) F 0 (M/T) Y Y V (A/T) IK3 (A/T) (M/T) 3

More information

Skid Control ECU. HINT: Inspect the ECU from the wire harness side while the connector is connected.

Skid Control ECU. HINT: Inspect the ECU from the wire harness side while the connector is connected. 05968 TERMINALS OF ECU 1. CHECK BATTERY VOLTAGE (a) Measure the battery voltage. Standard: 10 to 14 V 2. SKID CONTROL ECU ASSY INSPECTION (a) Measure the voltage between each terminal or between each terminal

More information

HEADLIGHT (w/ DAYTIME RUNNING LIGHT)

HEADLIGHT (w/ DAYTIME RUNNING LIGHT) HEDLIGHT (w/ DYTIME UNNING LIGHT) - G G- G- 6 5 4 TILLIGHT ELY 40 MIN HED ELY 4 G 8 K DL NO. ELY 4 G 5 G - L 5 HED LH (UP) G - Y 5 HED H (UP) - - - - Y E - F - F F, F 9 0 H- LP LH (LW) 0 H- LP H (LW) 5

More information

ELECTRONICALLY CONTROLLED TRANSMISSION

ELECTRONICALLY CONTROLLED TRANSMISSION ELECTRONICALLY CONTROLLE TRANSMISSION FROM OWER SOURCE SYSTEM (SEE AE 6) 7. A IN 0A EFI A STO 7. A STA F FUSE OX F W 3 7 IF Y EFI RELAY Y Y IF Y 0 IF Y Y W 3C 3C A (*) (*) A (*) (*) S A, STO LIHT SW R

More information

ENGINE CONTROL (5VZ FE)

ENGINE CONTROL (5VZ FE) ENGINE CONTOL (VZ FE) 8 II G I 7 J (/T) G 7 M IG 6 FOM POE SOUCE SYSTEM (SEE PGE 0) ST 8 G I IGNITION S (/T) 0 IGN 0 EFI 0 STOP 0 F F S STOP LIGHT S G Y G L G 7 IG STTE ELY EFI ELY IG 0 M TTEY 0 M 0 LT

More information

35A-1 SERVICE BRAKES CONTENTS BASIC BRAKE SYSTEM ANTI-SKID BRAKING SYSTEM (ABS) <2WD> ACTIVE STABILITY CONTOROL (ASC) SYSTEM

35A-1 SERVICE BRAKES CONTENTS BASIC BRAKE SYSTEM ANTI-SKID BRAKING SYSTEM (ABS) <2WD> ACTIVE STABILITY CONTOROL (ASC) SYSTEM 35A-1 SERVICE BRAKES CONTENTS BASIC BRAKE SYSTEM... 35A ANTI-SKID BRAKI SYSTEM (ABS) ... 35B ACTIVE STABILITY CONTOROL (ASC) SYSTEM... 35C 35A-2 BASIC BRAKE SYSTEM General/On-vehicle Service GENERAL

More information

ENGINE CONTROL (3RZ FE)

ENGINE CONTROL (3RZ FE) ENINE CONTRO (3RZ FE) 7 IF Y R 7 AM I 6 3 I FROM POER SOURCE SYSTEM (SEE PAE 4) AM ACC I 7. A STA 7. A IN 0A EFI 7. A OD 0A STOP ST 30A AM ATTERY P PARK/NEUTRA POSITION S 40A AM 0A AT I4 INITION S P N

More information

Interior Light RUNNER (EWD552U) From Power Source System (See Page 58) Body ECU 7. 5A ACC ACC 22 GND1 4 ILE GND A W- B W- B W W B 3

Interior Light RUNNER (EWD552U) From Power Source System (See Page 58) Body ECU 7. 5A ACC ACC 22 GND1 4 ILE GND A W- B W- B W W B 3 Interior Light From Power Source System (See Page 58) 4(), 5(), 6(C) ody ECU 7. 5 CC CC GND 6 GND 4 3 ILE H 7 8 8 3 3 E (*) (*) I0 Interior Light 3 ON OFF DOO L Luggage Compartment Light 3 ON OFF DOO P

More information

Engine Control for 2TR FE

Engine Control for 2TR FE Engine Control for T FE From ower Source System (See age 7) 0A EFI A A/F HEATE A IN AM I 6 C I ST I 7 Ignition S E 7 EA 0A AM C 0A EFI N. A EFI elay E A 0 A A 0 A A A/F HEATE elay A C/N elay F Fuel Suction

More information

BRAKE CONTROL VEHICLE STABILITY CONTROL SYSTEM. DTC No. DTC Detecting Conditions Trouble Areas

BRAKE CONTROL VEHICLE STABILITY CONTROL SYSTEM. DTC No. DTC Detecting Conditions Trouble Areas 70 RKE CONTROL VEHICLE STILITY CONTROL SYSTEM DTC C0210/33 Rear Speed Sensor RH Circuit DTC C0215/34 Rear Speed Sensor LH Circuit DTC C1238/38 DTC C1239/39 DTC C1273/73 DTC C1274/74 DTC C1277/77 DTC C1278/78

More information

ABS, TRAC, VSC, Auto LSD, DAC and HAC

ABS, TRAC, VSC, Auto LSD, DAC and HAC BS, TC, VSC, uto SD, and HC (BT) (BT) (IG) 0 BS N. 50 BS N. 5 IGN F F 7 C C C 8 4 7 S (), S (C) Skid Control ECU with ctuator 0 NE + + 0 6 5 9 4 4 C B GND GND GND (4D) G B B S 4 Speed Sensor (Front H)

More information

Air Conditioning 4RUNNER (EM03M0U) Y R 15A IG1 60A HEATER Y R Y R Y R Y R E E C E E D. Junction Connector Y R W B HEATER Y R. Relay.

Air Conditioning 4RUNNER (EM03M0U) Y R 15A IG1 60A HEATER Y R Y R Y R Y R E E C E E D. Junction Connector Y R W B HEATER Y R. Relay. ir Conditioning Y (T) (IG) 8 J 60 HETE 5 IG 0 E Y Y Y Y E E C E E D J 3 W 7. 5 HETE NO. 40 G Y IC4 Y 4 Y 5 3 HETE elay 36 IC4 37 IC4 3 C E J D Y 5 3 IC4 IM 43 Y Y IC4 MG CT elay 3 ressure SW 5 Y G IN Y

More information

FOUR-WHEEL ANTI-LOCK BRAKE SYSTEM (4ABS)

FOUR-WHEEL ANTI-LOCK BRAKE SYSTEM (4ABS) 35B-1 GROUP 35B FOUR-WHEEL ANTI-LOCK BRAKE SYSTEM (4ABS) CONTENTS GENERAL DESCRIPTION......... 35B-2 SENSORS..................... 35B-6 BRAKE MODULATOR (ABS-ECU).. 35B-9 SYSTEM OPERATION............ 35B-10

More information

ENGINE CONTROL (2RZ FE)

ENGINE CONTROL (2RZ FE) ENINE CONTRO (RZ FE) 7 IF Y R(A/T) 7 AM I 6 I FROM POER SOURCE SYSTEM (SEE PAE ) AM ACC I 7. A STA 7. A IN 0A EFI 7. A OD 0A STOP ST I INITION S 6 0 Y R E E Y R(A/T) O O I Y Y Y O Y Y 0A AM P PARK/NEUTRA

More information

ANTI-SKID BRAKING SYSTEM (ABS)

ANTI-SKID BRAKING SYSTEM (ABS) GROUP 35B ANTI-SKID BRAKING SYSTEM (ABS) CONTENTS GENERAL INFORMATION........ 35B-2 SERVICE SPECIFICATIONS....... 35B-4 SPECIAL TOOLS................ 35B-5............ 35B-6 STANDARD FLOW OF DIAGNOSTIC................

More information

ENGINE CONTROL RUNNER (EWD425U) B- R II4 G- B GR- B B- R B- R FROM POWER SOURCE SYSTEM (SEE PAGE 48) 4 1I W- L G- B 10A IGN 10A STOP 20A EFI BZ1

ENGINE CONTROL RUNNER (EWD425U) B- R II4 G- B GR- B B- R B- R FROM POWER SOURCE SYSTEM (SEE PAGE 48) 4 1I W- L G- B 10A IGN 10A STOP 20A EFI BZ1 ENINE CONTRO R- I 7 J FROM POER SOURCE SYSTEM (SEE PE 8) 7 M I 6 ST 8 - R I INITION S STRTER REY 0 F - 0 IN EFI REY R- - R 0 EFI - R F 0 STOP 7 I S STOP IHT S - Y - R Z N IE - - R - R - - I I D D D 0 M

More information

RADIATOR FAN AND AIR CONDITIONER

RADIATOR FAN AND AIR CONDITIONER RADIATOR FAN AND AIR CONDITIONER E 7 AM ACC IG ST L I9 IGNITION S EA 6 I H D 7 A C E 5A ECU IG INTEGRATION RELAY 9 9 E 0A GAUGE 5 5 M 0A CDS A A/C CONDENSER FAN MOTOR ENGINE MAIN RELAY 6 D F 5 C D D M

More information

CRUISE CONTROL SYSTEM

CRUISE CONTROL SYSTEM Negative (-) Battery Terminal CRUISE CONTROL CRUISE CONTROL SYSTEM Cable System name METER / GAUGE SYSTEM D033496E01 CRUISE CONTROL SYSTEM PRECAUTION 1 1. DISCONNECT AND RECONNECT CABLE OF NEGATIVE BATTERY

More information

ENGINE CONTROL 2001 AVALON (EWD431U) L- O B- W B- W B- W B- W I15 IGNITION SW W- R B- W B- W B- O B- O I 7 B- O IF1 B- W W- R B- O B- O B- R L- O

ENGINE CONTROL 2001 AVALON (EWD431U) L- O B- W B- W B- W B- W I15 IGNITION SW W- R B- W B- W B- O B- O I 7 B- O IF1 B- W W- R B- O B- O B- R L- O ENINE ONTRO - O 7 M I 6 ST 8 - R I5 INITION S IF I 7 - R - O 7 9 6 F J 7 0 M 5 EFI NO. 7. 5 EFI NO. 5 /F 5 I 5 5 5 EFI REY /F REY I REY 0 F F 6, F 7 FUSIE INK OK 8 II IF - F MIN. 0 TTERY ED 8 00 VON (EDU)

More information

FOUR-WHEEL ANTI-LOCK BRAKE SYSTEM (4ABS)

FOUR-WHEEL ANTI-LOCK BRAKE SYSTEM (4ABS) 35B-1 GROUP 35B FOUR-WHEEL ANTI-LOCK BRAKE SYSTEM (4ABS) CONTENTS GENERAL INFORMATION 35B-2 35B-6 SENSOR 35B-6 ACTUATORS 35B-6 ABS-ECU 35B-7 35B-2 The ABS that ensures directional stability and controllability

More information

PRE-CHECK ABS Warning Light BRAKE Warning Light USA: USA: Canada: Canada: VSC Warning Light SLIP Indicator Light. TRAC OFF Indicator Light

PRE-CHECK ABS Warning Light BRAKE Warning Light USA: USA: Canada: Canada: VSC Warning Light SLIP Indicator Light. TRAC OFF Indicator Light ABS Warning Light BRAKE Warning Light USA: Canada: USA: Canada: VSC Warning Light SLIP Indicator Light TRAC Indicator Light F45096 PRECHECK 05765 05H3Y02 1. DIAGNOSIS SYSTEM (a) Check the warning lights.

More information

DTC C0273/13 OPEN CIRCUIT IN ABS MOTOR RELAY CIRCUIT DTC C0274/14 SHORT CIRCUIT IN ABS MOTOR RELAY CIRCUIT

DTC C0273/13 OPEN CIRCUIT IN ABS MOTOR RELAY CIRCUIT DTC C0274/14 SHORT CIRCUIT IN ABS MOTOR RELAY CIRCUIT 0804 DTC C0273/13 OPEN CIRCUIT IN ABS MOTOR RELAY CIRCUIT 0F1Q09 DTC C0274/14 SHORT CIRCUIT IN ABS MOTOR RELAY CIRCUIT DTC C1361/91 SHORT CIRCUIT IN ABS MOTOR FAIL SAFE RELAY CIRCUIT CIRCUIT DESCRIPTION

More information

Audio System with 8 Speaker

Audio System with 8 Speaker udio System with 8 Speaker From ower Source System (See age 6) 7. 5 D N. 5 D N. 4(C), (), 3() adio and layer CC C C NT+ 3 C H 3 K 4 C - - 4E 0 IK3 0 3K 9 3I 3 4E 6 I J8 Junction Connector 8 4D 4 I I -

More information

ON BOARD DIAGNOSTIC SYSTEM DESCRIPTION Self-diagnosis. Self-diagnosis BR-44 FUNCTION SELF-DIAGNOSIS PROCEDURE ABS

ON BOARD DIAGNOSTIC SYSTEM DESCRIPTION Self-diagnosis. Self-diagnosis BR-44 FUNCTION SELF-DIAGNOSIS PROCEDURE ABS Self-diagnosis ON BOARD DIAGNOSTIC SYSTEM DESCRIPTION Self-diagnosis FUNCTION NABR0095 NABR0095S01 When a problem occurs in the, the warning lamp on the instrument panel comes on. To start the self-diagnostic

More information

DTC C1341/62 MALFUNCTION IN HYDRAULIC SYSTEM (FR) DTC C1342/63 MALFUNCTION IN HYDRAULIC SYSTEM (FL) DTC C1343/64 MALFUNCTION IN HYDRAULIC SYSTEM (RR)

DTC C1341/62 MALFUNCTION IN HYDRAULIC SYSTEM (FR) DTC C1342/63 MALFUNCTION IN HYDRAULIC SYSTEM (FL) DTC C1343/64 MALFUNCTION IN HYDRAULIC SYSTEM (RR) 008 DIAGNOSTIS ELETRONIALL ONTOROLLED RAKE SSTEM DT 4/62 MALFUNTION IN HDRAULI SSTEM (FR) 0IZS0 DT 42/6 MALFUNTION IN HDRAULI SSTEM (FL) DT 4/64 MALFUNTION IN HDRAULI SSTEM (RR) DT 44/6 MALFUNTION IN HDRAULI

More information

DTC C0210/33 RIGHT REAR SPEED SENSOR CIRCUIT DTC C0215/34 LEFT REAR SPEED SENSOR CIRCUIT

DTC C0210/33 RIGHT REAR SPEED SENSOR CIRCUIT DTC C0215/34 LEFT REAR SPEED SENSOR CIRCUIT 05998 IAGNOSTICS ELECTRONICALLY CONTOROLLE RAKE SYSTEM TC C010/33 RIGHT REAR SPEE SENSOR CIRCUIT 05IZC01 TC C015/34 LEFT REAR SPEE SENSOR CIRCUIT CIRCUIT ESCRIPTION Refer to TC C000/31, C005/3 on page

More information

ON-VEHICLE INSPECTION

ON-VEHICLE INSPECTION 32 SUSPENSION CONTROL AIR SUSPENSION SYSTEM ON-VEHICLE INSPECTION 1. CHECK FLUID LEAKAGE Check the connections of tube and parts for fluid leakage. : Supply parts only C099149E01 SUSPENSION CONTROL AIR

More information

ELECTRONICALLY MODULATED AIR SUSPENSION

ELECTRONICALLY MODULATED AIR SUSPENSION ELECTRONICLL MODULTED IR SUSENSION SSTEM OUTLINE THIS SSTEM CONSISTS OF NEUMTIC CLINDER WHICH HS RESSURED IR IN N IR CHMBER, N ECU WHICH UTOMTICLL SWITCHES THE SRING RTE ND VEHICLE HEIGHT BETWEEN TWO RNGES

More information

TRACTION CONTROL SYSTEM 1996 Toyota Supra 1995-96 BRAKES Traction Control Supra DESCRIPTION Toyota Traction Control (TRAC) system controls engine torque and braking of the driving wheels. TRAC system is

More information

WIRELESS DOOR LOCK CONTROL

WIRELESS DOOR LOCK CONTROL WIELESS DOO CONTOL FO POWE SOUCE SYSTE (SEE PGE 8) 5 CC G G 6, 7 ODY ECU 9 CC DCTY PCTY CTY KSW UL L UL L UL 9 6 5 0 H 9 H D8 DOO COUTESY SW E LH - D9 DOO COUTESY SW E H - W D6 DOO COUTESY SW FONT LH D7

More information

ENGINE CONTROL (5VZ-FE 2WD M/T)

ENGINE CONTROL (5VZ-FE 2WD M/T) ENINE CONTRO (Z-FE WD M/T) 7 IF 7 AM I 6 FROM POWER SOURCE SYSTEM (SEE PAE 4) AM ACC I 0A EFI 7. A OD 7. A IN ST W 30A AM W ATTERY 40A AM 0A AT I4 INITION SW - Y- R Y 0 C 9 CUTCH START SW 3 6 8 I F 7.

More information

DTC C0210/33 Rear Speed Sensor RH Circuit. DTC C0215/34 Rear Speed Sensor LH Circuit

DTC C0210/33 Rear Speed Sensor RH Circuit. DTC C0215/34 Rear Speed Sensor LH Circuit RKE CONTROL VEHICLE STILITY CONTROL SYSTEM 65 DTC C0210/33 Rear Speed Sensor RH Circuit DTC C0215/34 Rear Speed Sensor LH Circuit DTC C1238/38 DTC C1239/39 Foreign Object is ttached on Tip of Rear Speed

More information

ANTI-LOCK BRAKING SYSTEM (ABS)

ANTI-LOCK BRAKING SYSTEM (ABS) 35B-1 GROUP 35B ANTI-LOCK BRAKING SYSTEM (ABS) CONTENTS GENERAL DESCRIPTION 35B-2 DIAGNOSIS 35B-4 INTRODUCTION TO ANTI-LOCK BRAKING SYSTEM DIAGNOSIS 35B-4 ABS DIAGNOSTIC TROUBLESHOOTING STRATEGY 35B-4

More information

Taillight and Illumination

Taillight and Illumination Taillight and Illumination L W C 5 L 3 F 5 TIL Relay 0 TIL 3 L W 8 TRLY 9 TIL IL 8 C (), 6(C) 8 ody ECU 50 J/ 8 IH (UZ FE) 0 LT Light Control SW 6 OFF Tail Head C Combination SW F 3 Front Parking Light

More information

DIAGNOSTIC TROUBLE CODE CHART

DIAGNOSTIC TROUBLE CODE CHART 50 DTC chart of ABS DIAGNOSTIC TROUBLE CODE CHART HINT: If a malfunction code is displayed during the DTC check, check the circuit indicated by the DTC. For details of each code, refer to the respective

More information

ABS WITH EBD SYSTEM (April, 2003)

ABS WITH EBD SYSTEM (April, 2003) 05 294 ABS ITH EBD SYSTEM (April, 2003) HO TO PROCEED ITH TROUBLESHOOTI Vehicle Brought to orkshop 057U7 04 2 Customer Problem Analysis (See page 05 296) 3 Check and Clear DTCs and Freeze Frame Data (See

More information

ENGINE CONTROL (3RZ-FE)

ENGINE CONTROL (3RZ-FE) ENGINE CONTO (3Z-FE) - - 7 IF - 7 AM IG 3 I FOM POE SOUCE SYSTEM (SEE PAGE 4) AM ACC IG 7. A STA 7. A IGN 0A EFI 7. A OD 0A STOP ST 30A AM P PAK/NEUTA POSITION S 40A AM 0A AT I4 IGNITION S P N 8 IK 8 -

More information

Text in Illustration

Text in Illustration ON-VEHICLE INSPECTION If using a dropper to adjust the fluid amount, make sure that the dropper has not been used with mineral oils, water or deteriorated brake fluid. Sealed areas may deteriorate and

More information

THEFT DETERRENT SYSTEM

THEFT DETERRENT SYSTEM THEFT DETERRENT THEFT DETERRENT SYSTEM 1 System Name Power Window Control System THEFT DETERRENT SYSTEM PRECAUTION NOTICE: For initialization: When disconnecting the cable from the negative (-) battery

More information

PRE CHECK 1. DIAGNOSIS SYSTEM

PRE CHECK 1. DIAGNOSIS SYSTEM DI710 w/o Tachometer: w/ Tachometer: F18894 PRECHECK ANTILOCK BRAKE SYSTEM DI8CS03 1. DIAGNOSIS SYSTEM (a) Check the indicator. When the ignition switch is turned, check that the ABS warning light is on

More information

Wireless Door Lock Control

Wireless Door Lock Control Wireless Door ock Control (BAT) (IG) (BAT) 0A HORN 0A IG NO. 0A DR CK W G W G HORN Relay 3 HORN IG ATB KSW GND SWD U3 ACTD B (A) Body ECU 0 A 3 A 3 A 9G B G R GR 0 C 0 K 8 H E W R G B W R G B G R 0 IC3

More information

VSC OFF Indicator Light Remains ON

VSC OFF Indicator Light Remains ON 6 RAKE CONTROL VEHICLE STAILITY CONTROL SYSTEM VSC OFF Indicator Light Remains ON DESCRIPTION When the rear differential is locked or during the WD mode, VSC control turns off and the VSC OFF indicator

More information

Wireless Door Lock Control

Wireless Door Lock Control Wireless Door ock Control From Power Source System (See Page 60) 7. A DOM A DOOR 0A CU B B 6(A), B 7(B), B (C) Body CU B BDR DCTY C PCTY A RCTY 0 M B 70 R W 3A 0 3A 4 G J3 Junction Connector FR G R G F

More information

ACTIVE TORQUE CONTROL 4WD SYSTEM

ACTIVE TORQUE CONTROL 4WD SYSTEM 2008 DRIVELINE/AXLES Differential - RAV4 ACTIVE TORQUE CONTROL 4WD SYSTEM PRECAUTION 1. TROUBLESHOOTING PRECAUTION NOTE: Since the Active torque control system (4WD control system) may be influenced by

More information

Engine Control (2KD FTV)

Engine Control (2KD FTV) Engine Control (KD FTV) (T) (T) 80 O 5 EFI J E MIN elay 4 D J J 4 J 8 J J EDU elay D55 VV (E) 5 5 E TT E IE 0 (), (), D(C), D(D) Engine ECU + ME 8 C O elay 4 D D5 low lug 04 HICE (ED6E) 8 D + DUT E VF

More information

DTC C1238/38 FOREIGN MATTER IS ATTACHED ON TIP OF RIGHT REAR SENSOR DTC C1239/39 FOREIGN MATTER IS ATTACHED ON TIP OF LEFT REAR SENSOR

DTC C1238/38 FOREIGN MATTER IS ATTACHED ON TIP OF RIGHT REAR SENSOR DTC C1239/39 FOREIGN MATTER IS ATTACHED ON TIP OF LEFT REAR SENSOR DIAGNOSTICS DTC C00/33 RIGHT REAR SPEED SENSOR 05795 05H3B03 DTC C05/34 LEFT REAR SPEED SENSOR DTC C38/38 FOREIGN MATTER IS ATTACHED ON TIP OF RIGHT REAR SENSOR DTC C39/39 FOREIGN MATTER IS ATTACHED ON

More information

SUSPENSION CONTROL SYSTEM

SUSPENSION CONTROL SYSTEM SUSPENSION CONTROL SYSTEM E SUSPENSION SECTION SCS A SUSPENSION CONTROL SYSTEM B C D CONTENTS SCS TROUBLE DIAGNOSIS FOR ACTIVE DAMPER SUSPENSION... 2 Precautions... 2 PRELIMINARY CHECK... 2 Fail-Safe...

More information

ANTI-LOCK BRAKING SYSTEM (ABS)

ANTI-LOCK BRAKING SYSTEM (ABS) 35B-1 GROUP 35B ANTI-LOCK BRAKING SYSTEM (ABS) CONTENTS GENERAL DESCRIPTION......... 35B-2................ 35B-4 INTRODUCTION TO ANTI-LOCK BRAKING SYSTEM DIAGNOSIS................ 35B-4 ABS DIAGNOSTIC

More information

POWER SOURCE (Current Flow Chart)

POWER SOURCE (Current Flow Chart) POWER SOURCE (Current Flow Chart) The chart below shows the route by which current flows from the battery to each electrical source (Fusible Link, Circuit Breaker, Fuse, etc.) and other parts. The next

More information

Fault Codes P1271 Fuel Regulator Circuit Malfunction DESCRIPTION:

Fault Codes P1271 Fuel Regulator Circuit Malfunction DESCRIPTION: Fault Codes P1271 Fuel Regulator Circuit Malfunction DESCRIPTION: The ECM controls the internal fuel pressure of the common rail by opening and closing the pressure discharge valve. When sudden deceleration

More information

There are 2 ways of brake fluid replacement: using the Techstream or not using the Techstream.

There are 2 ways of brake fluid replacement: using the Techstream or not using the Techstream. REPLACEMENT HINT: There are 2 ways of brake fluid replacement: using the Techstream or not using the Techstream. Perform fluid replacement with park (P) selected and the parking brake applied. As brake

More information

CRUISE CONTROL (VACUUM TYPE)

CRUISE CONTROL (VACUUM TYPE) 3 RUISE ONTROL (VUUM TYPE) FROM POWER SOURE SYSTEM (SEE PGE 5) 5 EU IG 5 GUGE 8 5 E R L 5 T HEK R R R J3 JUNTION 9 3 R L 7 J/ NO. 3 4, 3 RUISE ONTROL INDITOR LIGHT [OM. METER] 6 W L W L IG LG R 4 IG PI

More information

CRUISE CONTROL SYSTEM

CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM CONTROL SYSTEM PARTS LOCATION CRUISE CONTROL CRUISE CONTROL SYSTEM 1 ENGINE ROOM R/B AND J/B MAIN BODY ECU (INSTRUMENT PANEL J/B) B142328E05 2 CRUISE CONTROL CRUISE CONTROL SYSTEM

More information

Before repairs, remove the airbag sensor if shocks are likely to be applied to the sensor during repairs.

Before repairs, remove the airbag sensor if shocks are likely to be applied to the sensor during repairs. NOTICE: When inspecting or repairing the SRS, perform the operation in accordance with the following precautionary instructions and the procedure and precautions in the Repair Manual for the applicable

More information

ENGINE CONTROL (1ZZ-FE)

ENGINE CONTROL (1ZZ-FE) ENGINE ONTO (ZZ-FE) - - - 5 M IG 6 - O 4 IK 6 I - O - - 9 IK I I0 IGNITION S ST 4 IE - - - 6 F 4 H 0 F 4 F 4 3 4 5 6 8 F 9 F 5 7. 5 M 40 MIN ST EY 7. 5 ST 0 EFI NO. 0 EFI NO. 3 3 H 5 /ON EY 3-3 I IE4 4

More information

ENGINE AND EMISSION CONTROL

ENGINE AND EMISSION CONTROL 17-1 GROUP 17 ENGINE AND EMISSION CONTROL CONTENTS ENGINE CONTROL.......... 17-3 GENERAL DESCRIPTION...... 17-3 ENGINE CONTROL SYSTEM DIAGNOSIS.................. 17-3 INTRODUCTION TO ENGINE CONTROL SYSTEM

More information

CRUISE CONTROL SYSTEM

CRUISE CONTROL SYSTEM CRUISE CONTROL CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM PRECAUTION 1 1. HANDLING PRECAUTION FOR CRUISE CONTROL SYSTEM (a) Turn the cruise control main switch OFF when not using the cruise control system.

More information

ANTI-LOCK BRAKES. Section 9. Fundamental ABS Systems. ABS System Diagram

ANTI-LOCK BRAKES. Section 9. Fundamental ABS Systems. ABS System Diagram ANTI-LOCK BRAKES Fundamental ABS Systems Toyota Antilock Brake Systems (ABS) are integrated with the conventional braking system. They use a computer controlled actuator unit, between the brake master

More information

DTC B1140/32 Side Airbag Sensor Assy (RH) Malfunction

DTC B1140/32 Side Airbag Sensor Assy (RH) Malfunction DI428 DIAGNOSTICS DI9HU01 DTC B1140/32 Side (RH) Malfunction CIRCUIT DESCRIPTION The side airbag sensor assy (RH) consists of the safing sensor, diagnosis circuit and lateral deceleration sensor, etc.

More information

BRAKE FLUID BLEEDING. 1. PREPARE FOR BLEEDING a. Move the shift lever to the P position and apply the parking brake.

BRAKE FLUID BLEEDING. 1. PREPARE FOR BLEEDING a. Move the shift lever to the P position and apply the parking brake. BRAKE FLUID BLEEDING CAUTION: Bleeding without the intelligent tester may result in the air not being completely bled. As this can result in an accident, be sure to use the intelligent tester for air bleeding.

More information

Electronic Control System

Electronic Control System Electronic Control System PRECAUTION AT79 Do not open the cover or the case of the ECM and various computer unless absolutely necessary. (If the IC terminals are touched, the IC may be destroyed by static

More information

BRAKE FLUID BLEEDING BR 3

BRAKE FLUID BLEEDING BR 3 DLC3 Intelligent Tester AKE AKE FLUID AKE FLUID BLEEDING 3 CAUTION: Bleeding without the intelligent tester may result in the air not being completely bled. As this can result in an accident, be sure to

More information

Short to GND in CAN Bus Line

Short to GND in CAN Bus Line N COMMUNITION N COMMUNITION SYSTEM 55 Short to GND in N Bus Line DESCRIPTION A short to GND is suspected in the N bus line when there is continuity between terminals and 6 (NH) or terminals and 14 (NL)

More information

ENGINE CONTROL (5VZ-FE)

ENGINE CONTROL (5VZ-FE) ENGINE CONTROL (Z-E) SYSTEM OUTLINE THE ENGINE CONTROL SYSTEM UTILIZES A MICROCOMPUTER AND MAINTAINS OERALL CONTROL O THE ENGINE, TRANSMISSION, ETC. AN OUTLINE O THE ENGINE CONTROL IS GIEN HERE.. INPUT

More information

GROUP 17 CONTENTS WARNINGS REGARDING SERVICING OF SUPPLEMENTAL RESTRAINT SYSTEM (SRS) EQUIPPED VEHICLES

GROUP 17 CONTENTS WARNINGS REGARDING SERVICING OF SUPPLEMENTAL RESTRAINT SYSTEM (SRS) EQUIPPED VEHICLES 17-1 GROUP 17 CONTENTS ENGINE CONTROL 17-4 GENERAL DESCRIPTION 17-4 ENGINE CONTROL SYSTEM DIAGNOSIS 17-4 INTRODUCTION TO ENGINE CONTROL SYSTEM DIAGNOSIS 17-4 ENGINE CONTROL SYSTEM DIAGNOSTIC TROUBLESHOOTING

More information

CH-23 CHASSIS AA80E AUTOMATIC TRANSMISSION. Function of Shift Solenoid Valves. Spool Valve. Hydraulic Pressure. Sleeve. Current. Shift Solenoid Valve

CH-23 CHASSIS AA80E AUTOMATIC TRANSMISSION. Function of Shift Solenoid Valves. Spool Valve. Hydraulic Pressure. Sleeve. Current. Shift Solenoid Valve CH-23 Spool Valve Hydraulic Sleeve Shift Solenoid Valve SL2 Current 036CH29TE Spool Valve Hydraulic Sleeve Shift Solenoid Valve SLU Current 036CH27TE Spool Valve Hydraulic Sleeve Shift Solenoid Valve SLT

More information

DTC B1140/32 Side Airbag Sensor Assembly (RH) Malfunction

DTC B1140/32 Side Airbag Sensor Assembly (RH) Malfunction DI342 DIAGNOSTICS DI6ZW03 DTC B1140/32 Side (RH) Malfunction CIRCUIT DESCRIPTI The side airbag sensor assembly (RH) consists of the safing sensor, diagnosis circuit and lateral deceleration sensor, etc.

More information

DIAGNOSTIC TROUBLE CODE CHART

DIAGNOSTIC TROUBLE CODE CHART 18 Cruise Control System DIAGNOSTIC TROUBLE CODE CHART If a trouble code is indicated while checking DTCs, inspect the listed for that code in the table below, and proceed to the applicable page. DTC No.

More information

ECT and A/T Indicator for 1GR FE

ECT and A/T Indicator for 1GR FE CT and /T Indicator for G F (T) (IG) (IG) (T) 0 FI 5 IGN 0 IG N. 0 ST 5 I C : w/ SC : w/o SC G 5 3 C 5 DD 3 D 0 I I 3 DC DC ST CT elay S0 Stop amp S G G ( ) G FI elay 5 3 30 3 H H 9 33 M + 3 TT + 9 IGS

More information

ECT (ELECTRONIC CONTROLLED TRANSMISSION)

ECT (ELECTRONIC CONTROLLED TRANSMISSION) ECT (ELECTRONIC CONTROLLED TRNSMISSION) ECT (ELECTRONIC CONTROLLED TRNSMISSION) FROM OWER SOURCE SYSTEM (SEE GE 5) 7. 5 IGN 5 EFI 5 STO 7 O 8 H E 5 C 8 E7 IG EFI MIN RELY 0 C I ISC VLVE 7 G R C 7 IG C

More information

ENGINE CONTROL (1MZ-FE)

ENGINE CONTROL (1MZ-FE) NGIN CONTRO (MZ-F) (*) - - R - R - R - G - R K C 7 M IG 6 I6 IGNITION S 0 M C F F 6 F MIN. 0 FUSI INK OCK ST 8 I 8 INJCTOR NO., - (*) S FROM POR SOURC SSTM (S PG ) 7 IK - R K IGN 7 - R STRTR R - R R J

More information

POWER WINDOW AND CONVERTIBLE ROOF (CONVERTIBLE)

POWER WINDOW AND CONVERTIBLE ROOF (CONVERTIBLE) POE INDO ND CONVETIE OOF (CONVETIE) FO POE SOUCE SYSTE (SEE PE ) DOO 0 UE 0 POE POE EY J IC D D S J0, J C J E P POE INDO STE S 0 I8 INTETION EY 0 S C I J0, J D0 DOO COUTESY S H D DOO COUTESY S H J0 V I

More information

STEERING COLUMN VARIABLE GEAR RATIO STEERING SYSTEM CALIBRATION. (a) Check for DTC. Result. DTC C1515/15 is not output DTC C1515/15 is output

STEERING COLUMN VARIABLE GEAR RATIO STEERING SYSTEM CALIBRATION. (a) Check for DTC. Result. DTC C1515/15 is not output DTC C1515/15 is output 56 STEERING COLUMN VRILE GER RTIO STEERING SYSTEM CLIRTION 1. VGRS SYSTEM CLIRTION PROCEDURE (USING SST CHECK WIRE) Use this procedure to center the steering wheel position if: VGRS actuator has been replaced

More information

ECT and A/T Indicator for 2TR FE

ECT and A/T Indicator for 2TR FE ET and /T Indicator for T FE (T) (IG) (IG) (T) 0 EFI IGN 0 IG N. 0 ST I : w/ S : w/o S G ( ) ( ) G ( ) ST T elay S0 Stop amp S 0 I I G ( ) G ( ) ( ) ( ) ( ) ( ) EFI elay 8 ME + TT E E0 7 IGS E (), E (),

More information

Engine Control for 5VZ-FE (Access/Standard Cab)

Engine Control for 5VZ-FE (Access/Standard Cab) ngine ontrol for 5VZ-F (ccess/standard ab) - - 7 M IG 6 FOM O SOU SSTM (S G 9) (/T) ST - I IGNITION S 0 M TT K/NUTL OSITION S N (/T) (/T) 9 6 J8 - (/T) F H - (/T), J9 J, J J8, J9 FI L J8 - - - 5 - - 5

More information

ANTI-SKID BRAKING SYSTEM (ABS)

ANTI-SKID BRAKING SYSTEM (ABS) 35B-1 GROUP 35B ANTI-SKID BRAKING SYSTEM (ABS) CONTENTS GENERAL INFORMATION........ 35B-2 SERVICE SPECIFICATIONS....... 35B-3 SPECIAL TOOLS................ 35B-4............ 35B-5 STANDARD FLOW OF DIAGNOSTIC................

More information

1999 Toyota RAV ACCESSORIES & EQUIPMENT Cruise Control Systems - RAV4

1999 Toyota RAV ACCESSORIES & EQUIPMENT Cruise Control Systems - RAV4 1999 ACCESSORIES & EQUIPMENT Cruise Control Systems - RAV4 DESCRIPTION WARNING: Deactivate air bag system before performing any service operation. See AIR BAG RESTRAINT SYSTEMS article. DO NOT apply electrical

More information