Illustrated Parts List. Model Series. TYPE NUMBERS 0110 through TABLE OF CONTENTS

Size: px

Start display at page:

Download "Illustrated Parts List. Model Series. TYPE NUMBERS 0110 through TABLE OF CONTENTS"

Brianne Welch
5 years ago
Views:

1 Illustrated Parts List Model Series TYPE NUMBERS 0110 through TABLE OF CONTENTS FORM MS10113 REV G 07/12/2012 REPLACES FORM MS10113 REV F 02/07/2012 FILE IN SECT. 2 OF SERVICE MANUAL Air Cleaner... 6 Blower Housing... 7 Camshaft... 2 Carburetor... 4 Controls... 5 Crankcase Cover... 2 Crankshaft... 2 Cylinder... 2 Cylinder Head... 3 Exhaust System... 6 Flywheel... 7 Fuel Supply... 4 Gear Reduction... 7 Governor Spring... 5 Ignition... 5 Kits/Gaskets - Carburetor... 4 Kits/Gaskets - Engine... 2 Kits/Gaskets - Valve... 3 Lubrication... 2 Piston Group... 2 Rewind Starter... 7 PRINTED IN U.S.A. COPYRIGHT by BRIGGS & STRATTON CORPORATION All rights reserved. No part of this material may be reproduced or transmitted, in any form or by any means, electronic or mechanical, including photocopying, recording or by any information storage and retrieval system, without permission in writing from Briggs & Stratton Corporation.

2 1319 WARNING LABEL REQUIRED when replacing parts with warning labels affixed. 1319A WARNING LABEL REQUIRED when replacing parts with warning labels affixed OPERATOR S MANUAL REPAIR MANUAL A A A 29B 32B A 46A EMISSIONS LABEL ENGINE GASKET SET B A Assemblies include all parts shown in frames. 07/12/2012 2

3 A D :1 Gear- Reduction Assemblies include all parts shown in frames. 07/12/2012 3

4 A A VALVE GASKET SET A 914B Assemblies include all parts shown in frames. 07/12/2012 4

5 125A B 108C 97A 633B 163B C 130B 95A A 133A 104A 190B A 137A 276A 117A 276A 118A 276A 125E 163D 122B C A 121B CARBURETOR OVERHAUL KIT 104A 127C 187A C A 163B 633B A 187B A Assemblies include all parts shown in frames. 07/12/2012 5

6 222F A A D A A 356B 356C 356D A Assemblies include all parts shown in frames. 07/12/2012 6

7 C C B A 11 11B D 300E 836E 994D B 832A 613B 613A 836C 300A 676A 677A A A Assemblies include all parts shown in frames. 07/12/2012 7

8 A C Assemblies include all parts shown in frames. 07/12/2012 8

9 REF. PART REF. PART REF. PART NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION Cylinder Assembly S Seal--Oil (Magneto Side) Head--Cylinder Gasket--Cylinder Head Tube--Breather (Flat Panel Air Cleaner) 11B Tube--Breather (Oil Bath Air Cleaner) Gasket--Crankcase Screw (Cylinder Head) Plug--Oil Drain (Square Head) 15A Plug--Oil Drain (Flush) Crankshaft Crankshaft 0113, 4120, Crankshaft 0111, 0167, 4139, Crankshaft 4137, Crankshaft 0112, 4159, Crankshaft Bearing--Ball 17A Bearing--Ball 18A Cover--Crankcase 0110, Cover-- Crankcase 0112, 4120, 4121, 4137, 4138, 4159, 5120, D Cover--Crankcase 0111, 0167, 4139, Seal--Oil (PTO Side) S Cap--Oil Fill Screw (Crankcase Cover/Sump) Flywheel Key--Flywheel Piston Assembly (Standard) Piston Assembly (.010 Oversize) Piston Assembly (.020 Oversize) Ring Set (Standard) Ring Set (.010 Oversize) Ring Set (.020 Oversize) Lock--Piston Pin Pin--Piston Rod--Connecting (.020 Undersize) 29B Rod--Connecting Dipper--Connecting Rod Screw (Connecting Rod) 32A Screw (Connecting Rod) 32B Screw (Connecting Rod) ) Screw (Connecting Rod) Date ) Valve--Exhaust Valve--Intake Spring--Valve (Intake) Spring--Valve (Exhaust) Guard--Flywheel Screw (Shut Off Valve) Retainer--Valve Tappet--Valve 46A Camshaft Gasket--Intake Gasket--Intake 0111, Stud (Carburetor) 55 Housing--Rewind Starter ). (Not Serviced Separate. Service With Rewind Assembly.) Note Housing-- Rewind Starter Date ) Rope--Starter (Cut to Required Length) ) Rope--Starter (Cut to Required Length) Date ) Grip--Starter Rope (2 Piece) Assemblies include all parts shown in frames. 07/12/2012 9

10 REF. PART REF. PART REF. PART NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION Screw (Rewind Starter) Screw (Flywheel Guard) Screw (Gear Reduction Case) Cover--Gear Gasket--Gear Reduction Cover 95A Screw (Throttle Valve) 97A Shaft--Throttle 98B Kit--Idle Speed 104A Pin--Float Hinge Valve--Float Needle 108C Valve--Choke 117A Jet--Main (Standard) 117C Jet--Main (Standard) 0111, A Jet--Main (High Altitude) 118C Jet--Main (High Altitude) 0111, B Kit--Carburetor Overhaul Spacer--Carburetor 122B Spacer--Carburetor 0111, A Carburetor 125E Carburetor 0111, C Plug--Welch 130B Valve--Throttle 133A Float--Carburetor 137A Gasket--Float Bowl Kit--Choke Shaft Key--Timing Plate--Cylinder Head ) Plate--Cylinder Head Date ) Base--Air Cleaner (Metal) (Flat Panel Air Cleaner) 163B Gasket--Air Cleaner (Flat Panel Air Cleaner) 163D Gasket--Air Cleaner 0111, Tank--Fuel (Metal) Cap--Fuel Tank (Metal) 187A Line--Fuel (Molded) 187B Line--Fuel (Molded) Screw (Control Bracket) Screw (Fuel Tank) 190B Screw (Fuel Tank) Adjuster--Rocker Arm ) Adjuster--Rocker Arm Date ) Spring--Governor 0110, Spring-- Governor 0111, 0112, 0113, 0167, 4120, 4121, 4137, 4139, 4159, 5120, 5139, A Spring--Governor Idle Gear--Governor Washer (Governor Gear) 222D Bracket--Control (Used With Plastic Fuel Tank) 0110, Bracket-- Control (Used With Metal Fuel Tank) 0111, 0112, 0167, 4120, 4121, 4139, 4159, 5120, 5139, F Bracket--Control 4137, Lever--Governor Control Screw (Choke Valve) Valve--Cap Clamp--Casing Screw (Casing Clamp) Casing--Control Wire (Cut to Required Length) Wire--Control (Cut to Required Length) Nut (Control Wire Casing) Lever--Control 271A Lever--Control 276A Washer--Sealing Panel--Control Panel--Control 0111, 0112, Panel--Control 0167, 4120, 4121, 4139, 4159, 5120, 5139, Assemblies include all parts shown in frames. 07/12/

11 REF. PART REF. PART REF. PART NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION Module--Oil Sensor Screw (Dipstick Tube) 300A Muffler 300E Muffler Housing--Blower Screw (Blower Housing) Shield--Cylinder Screw (Cylinder Shield) Nut (Flywheel) Armature--Magneto Screw (Magneto Armature) Plug--Spark (EMS) S Plug--Spark (Resistor) Screw (Spark Arrestor) Screw (Spark Arrestor) Switch--Rocker 0110, 0113, 4137, 4138, 5110, 5137, Switch--Rocker 0111, 0112, 0167, 4120, 4121, 4139, 4159, 5120, 5121, 5139, B Wire--Stop 356C Wire--Stop 356D Wire--Stop Key--Drive Pulley Key--Drive Pulley Gasket Set--Engine Puller--Flywheel Terminal--Oil Plug Screw (Carburetor) 365A Screw (Carburetor) 0111, Key--Timing S Wrench--Spark Plug 383A Wrench--Spark Plug Plug Screw (Air Cleaner Cover) Nut (Control Bracket) Nut (Control Bracket) Filter--Air Cleaner Cartridge (Flat Panel) Cup--Flywheel 456 Plate--Pawl Friction ). (Not Serviced Separate. Service With Rewind Assembly.) Note Plate--Pawl Friction Date ). 459 Pawl--Ratchet ). (Not Serviced Separate. Service With Rewind Assembly.) Note S Pawl-- Ratchet Date ) Seal--O Ring (Fuel Shut Off Valve) Washer Set--Friction Nut (Governor Control Lever) Plug--Dipstick/Fill Dipstick S Seal--Dipstick Tube Filter--Air Cleaner Foam 535A Filter--Air Cleaner Foam 0111, Bushing--Governor Crank Bolt (Governor Control Lever) Screw (Control Cover) 564A Screw (Control Cover) 597 Screw (Pawl Friction Plate) ). (Not Serviced Separate. Service With Rewind Assembly.) Note Screw (Pawl Friction Plate) Date ) Clamp--Hose Cover--Control 608C Starter--Rewind Screw (Muffler) 613A Screw (Muffler) 613B Screw (Muffler) Screw (Muffler) Retainer--Governor Shaft Crank--Governor Screw (Cylinder Head Plate) Switch--Stop Spring/Link-- Mechanical Governor 633B Seal--Choke/Throttle Shaft Boot--Spark Plug 635A Boot--Spark Plug Retainer--Air Filter Screw (Support Bracket) Assemblies include all parts shown in frames. 07/12/

12 REF. PART REF. PART REF. PART NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION 652A Screw (Support Bracket) Screw (Carburetor) Screw (Control Panel) Spacer Deflector--Muffler 676A Deflector--Muffler Screw (Muffler Deflector) Screw (Muffler Deflector) 677A Screw (Muffler Deflector) 689 Spring--Friction ). (Not Serviced Separate. Service With Rewind Assembly.) Note Spring-- Friction Date ) Pin--Locating Gear--Timing Retainer--E Ring Gear--Idler Retainer Screw (Oil Sensor) Screw (Muffler Bracket) 819A Screw (Muffler Bracket) Screw (Muffler Adapter) Stud--Rocker Arm ) Stud--Rocker Arm Date ). 832A Guard--Muffler 832D Guard--Muffler 836B Screw (Muffler Guard) 836C Screw (Muffler Guard) 836E Screw (Muffler Guard) Seal--O Ring (Dipstick Tube) 843A Sleeve--Lever Dipstick/Tube Assembly S Terminal--Spark Plug Bracket--Muffler Adapter--Muffler Seal--Valve 875C Base--Air Cleaner (Oil Bath Air Cleaner) Gasket--Exhaust 883A Gasket--Exhaust Bracket--Control Screw (Rocker Cover) (Bottom) 914A Screw (Rocker Cover) (Quantity 1, Top Or Center) ) Screw (Top) Date ). 914B Screw (Rocker Cover) (Center) Date ) Cap--Fuel Tank (Text Free) 957A Cap--Fuel Tank (Carbon In Cap) Valve--Fuel Shut Off 958A Valve--Fuel Shut Off (Plastic) Filter--Pre Cleaner (Flat Panel) Cover--Air Cleaner (Flat Panel) Cover-- Air Cleaner (Flat Panel) 4137, C Cover--Air Cleaner (Oil Bath Air Cleaner) Screw (Air Cleaner Base) Screw (Air Cleaner Base) Tank--Fuel 975A Bowl--Float Seal--Throttle Shaft Gasket--Cylinder Head Plate 994D Arrester--Spark Fan--Flywheel 1005A Fan--Flywheel 1022 K Gasket--Rocker Cover Cover--Rocker Arm Rod--Push Arm--Rocker ) Arm--Rocker Date ) Guide--Push Rod Assemblies include all parts shown in frames. 07/12/

13 REF. PART REF. PART REF. PART NO. NO. DESCRIPTION NO. NO. DESCRIPTION NO. NO. DESCRIPTION 1036 Label--Emissions (Available From An Authorized Briggs & Stratton Service Dealer) Sensor--Oil Operator s Manual Screw (Flywheel Fan) Pan--Oil Gasket Set--Valve 1210 Pulley/Spring Assembly (Pulley) ). (Not Serviced Separate. Service With Rewind Assembly.) Pulley/Spring Assembly (Pulley) Date ) Pulley/Spring Assembly (Pulley) ). (Not Serviced Separate. Service With Rewind Assembly.) Pulley/Spring Assembly (Pulley) Date ) Stud (Control Bracket) Screw (Oil Sensor Module) Label--Warning Repair Manual Filter--Filler Neck 1345A Filter--Filler Neck Sprocket--Gear Reduction Chain--Gear Reduction Shaft--Output Gear Reduction Screw (Gear Reduction Sprocket) Washer (Gear Reduction Sprocket) Assemblies include all parts shown in frames. 07/12/

Illustrated Parts List 12D100

Illustrated Parts List 12D100 FORM MS 3399 08/23/2007 REPLACES FORM MS 3399 05/22/2007 FILE IN SECT. 2 OF SERVICE MANUAL Illustrated Parts List Model Series TYPE NUMBERS 0110 through 0940. TABLE OF CONTENTS Blower Housing/Shrouds............