DIAGNOSIS AND TESTING

Size: px
Start display at page:

Download "DIAGNOSIS AND TESTING"

Transcription

1 Automatic Transmission 5R55S DIAGNOSIS AND TESTING Transmission Connector Layouts Connector Reference and Terminal Readings Powertrain Control Module (PCM) C175b 1 Shift Solenoid A (SSA) 2 Shift Solenoid B (SSB) 7 Pressure Control Solenoid A (PC A) 8 Shift Solenoid C (SSC) 9 Digital Transmission Range sensor TR3A to (PCM) 10 Digital Transmission Range sensor TR4 to (PCM) 12 Pressure Control Solenoid C (PC C) 13 Pressure Control Solenoid B (PC B) 14 Signal return 17 Shift Solenoid D (SSD) 18 Digital Transmission Range sensor TR2 to (PCM) 20 Torque Converter Clutch (TCC) Solenoid 21 Intermediate shaft speed sensor signal input 22 Digital Transmission Range sensor TR1 to (PCM) 23 Transmission Fluid Temperature (TFT) Sensor 26 Output Shaft Speed (OSS) sensor signal input 27 Turbine Shaft Speed (TSS) sensor signal input Copyright 2002, Ford Motor Company Last updated: 10/09/2002

2 Automatic Transmission 5R55S Transmission Solenoid Body C199 1 Pressure control (PCB) solenoid B 2 Transmission fluid temperature (TFT) sensor input 3 Solenoid power 4 Pressure control (PCC) solenoid C 5 Shift solenoid D (SSD) 6 Shift solenoid C (SSC) 11 Pressure control (PCA) solenoid A 1 14 Torque converter clutch (TCC) solenoid 15 Shift solenoid B (SSB) 16 Shift solenoid A (SSA) Digital Transmission Range (TR) Sensor C167 3 Digital transmission range (TR) sensor TR3A 4 Digital transmission range (TR) sensor TR1 5 Digital transmission range (TR) sensor TR2

3 Automatic Transmission 5R55S Digital transmission range (TR) sensor TR4 7 Ground 8 Neutral switch sense input 9 Fused power feed 10 Starter solenoid central power 11 Reverse lamps 12 Starter relay (overload protected) Turbine Shaft Speed (TSS) Sensor C143 1 Turbine shaft speed (TSS) sensor signal Output Shaft Speed (OSS) Sensor C193 1 Output shaft speed (OSS) sensor signal

4 Automatic Transmission 5R55S Intermediate Shaft Speed Sensor Harness Connector 1 Intermediate shaft speed sensor signal Digital Transmission Range (TR) Sensor Diagnosis Chart Select Base Shift Shift Selector Lever Lever Position Indicator Indicator PID: TR V PID: TR D (volts) TR3A (PCM pin 64 to TR4 TR3A TR2 TR1 sigrtn) PARK P P REVERSE R R NEUTRAL N N OVER- D5/D4 D DRIVE Manual 3 3 D

5 Automatic Transmission 5R55S Digital Transmission Range (TR) Sensor Diagnosis Chart (Continued) Select Base Shift Shift Selector Lever Lever Position Indicator Indicator PID: TR V PID: TR D (volts) TR3A (PCM pin 64 to TR4 TR3A TR2 TR1 sigrtn) Manual Manual 1 Man A. TR V is the voltage at the PCM pin 64 (TR3A Circuit) to signal return. B. TR D: 1= Open digital TR switch, 0= Closed digital TR switch. C. EEC-V Control System Breakout Box Readings: Taken from PCM signal pins for TR1, TR2, TR3A, TR4 to signal return. Voltages for TR1, TR2, TR4: 0 = 0.0 volts. 1 = volts. Voltage for TR3A: 0 = 0.0 volts. 1 = volts. Wiggle Test Information for Open/Shorts A. TR4, TR3A, TR2, and TR1 are all closed in PARK. PARK is a good position to check for intermittent open circuits (with scan tool monitoring TR D). B. TR4, TR3A, TR2, and TR1 are all open in OVERDRIVE, so OVERDRIVE is a good position to check for shorts to ground. To determine the shorted components while observing TR D, unplug the TR and see if the short goes away. If the short is still present unplug the transmission harness and see if the short goes away. If the short is still present, then the short is in the PCM or vehicle harness. Remove the suspect circuit(s) wire terminal from the PCM connector. If the short is still present, then the PCM has an internal failure, otherwise the failure is in the vehicle harness.

DIAGNOSIS AND TESTING

DIAGNOSIS AND TESTING 307-01-1 Automatic Transaxle/Transmission 307-01-1 DIAGNOSIS AND TESTING Transmission Connector Layouts Connector Reference and Terminal Readings Powertrain Control module (PCM) 1 Pressure control solenoid

More information

DIAGNOSIS AND TESTING

DIAGNOSIS AND TESTING 307-01-1 Automatic Transaxle/Transmission 307-01-1 DIAGNOSIS AND TESTING Pinpoint Tests OSC Equipped Vehicle Special Tool(s) Transmission Fluid Pressure Gauge 307-004 (T57L-77820-A) Special Tool(s) MLP-TR

More information

Pinpoint Tests OSC Equipped Vehicle

Pinpoint Tests OSC Equipped Vehicle SECTION 307-01: Automatic Transaxle/Transmission 5R55S 2009 Mustang Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 11/19/2008 Pinpoint Tests OSC Equipped Vehicle Special Tool(s) 73 III

More information

2002 Explorer/Mountaineer Workshop Manual

2002 Explorer/Mountaineer Workshop Manual Page 1 of 20 SECTION 307-01: Automatic Transmission - 5R55W/S 2002 Explorer/Mountaineer Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 10/20/2004 Pinpoint Tests OSC Equipped Vehicles Special

More information

DIAGNOSIS AND TESTING

DIAGNOSIS AND TESTING 307-01-1 Automatic Transaxle/Transmission 307-01-1 DIAGNOSIS AND TESTING Diagnostic Trouble Code Charts Diagnostic Trouble Code Chart P0102, MAF MAF concerns MAF system High/low EPC REFER to the P0103,

More information

Diagnostic Trouble Code (DTC) Charts

Diagnostic Trouble Code (DTC) Charts SECTION 307-01: Automatic Transaxle/Transmission 5R55S 2009 Mustang Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 06/30/2009 Diagnostic Trouble Code (DTC) Charts DTC Chart **May also be

More information

Shift Solenoid B (SSB) and Shift Solenoid D (SSD) Inverse Proportional VFS 2761

Shift Solenoid B (SSB) and Shift Solenoid D (SSD) Inverse Proportional VFS 2761 Item Description 1 Shift Solenoid A (SSA) Variable Force Solenoid (VFS) 2 Shift Solenoid C (SSC) VFS SSB and SSD use inverse proportional operation. As the current from the PCM decreases, the pressure

More information

2006 F-150/Mark LT Workshop Manual

2006 F-150/Mark LT Workshop Manual Page 1 of 14 SECTION 307-01: Automatic Transaxle/Transmission 4R70E/4R75E DIAGNOSIS AND TESTING Procedure revision date: 09/26/2008 Pinpoint Tests OSC Equipped Vehicle Printable View (485 KB) Special Tool(s)

More information

27 E. Front wheel drive. 1. Transmission Description (Ford Focus 2000 only) 4 4 Speed Transmission F

27 E. Front wheel drive. 1. Transmission Description (Ford Focus 2000 only) 4 4 Speed Transmission F 1. Transmission Description (Ford Focus 2000 only) 4 4 Speed Transmission F Front wheel drive 27 E Maximum input torque after torque converter: 270 Lb-ft (365 N-m) Fully Electronic control Note: Mazda

More information

DIAGNOSIS AND TESTING Procedure revision date: 09/23/2004

DIAGNOSIS AND TESTING Procedure revision date: 09/23/2004 2002 Excursion Subarticles Report a problem with this article On-Board Diagnostics with Scan Tool Transmission Drive Cycle Test After On-Board Diagnostics Before Pinpoint Tests Diagnostic Trouble Code

More information

Transmission Electronic Control System

Transmission Electronic Control System SECTION 307-01: Automatic Transaxle/Transmission 5R55S 2009 Mustang Workshop Manual DESCRIPTION AND OPERATION Procedure revision date: 05/23/2008 Transmission Electronic Control System Electronic System

More information

TROUBLE SHOOTING > SYMPTOM DIAGNOSIS > SOME OR ALL SHIFTS MISSING TROUBLE SHOOTING > SYMPTOM DIAGNOSIS > NO 1-2, 2-3 OR 3-4 UPSHIFT (AUTOMATIC)

TROUBLE SHOOTING > SYMPTOM DIAGNOSIS > SOME OR ALL SHIFTS MISSING TROUBLE SHOOTING > SYMPTOM DIAGNOSIS > NO 1-2, 2-3 OR 3-4 UPSHIFT (AUTOMATIC) AUTOMATIC TRANSMISSION - DIAGNOSIS - E4OD A/T TROUBLE SHOOTING 1997 Ford Pickup 7.3L Eng F350 Question: overdrive off light is on steady TROUBLE SHOOTING > SYMPTOM DIAGNOSIS Question: Repeat OD planetary

More information

Automatic Transmission 5R44E and 5R55E

Automatic Transmission 5R44E and 5R55E 307-01-1 Automatic Transmission 5R44E and 5R55E 307-01-1 IN-VEHICLE REPAIR Main Control Valve Body Special Tool(s) Aligner, Valve Body 307-333 (T95L-70010-B) Aligner, Valve Body 307-334 (T95L-70010-C)

More information

Special Testing Procedures

Special Testing Procedures SECTION 307-01: Automatic Transaxle/Transmission 5R55S 2009 Mustang Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 06/30/2009 Special Testing Procedures Special Tool(s) Air Test Plate and

More information

DISASSEMBLY. Transmission. All vehicles

DISASSEMBLY. Transmission. All vehicles 307-01-1 Automatic Transmission 5R44E and 5R55E 307-01-1 DISASSEMBLY Transmission Special Tool(s) Holding Fixture, Transmission 307-262 (T93T-77002-AH) Special Tool(s) Remover, Servo 307-347 (T97T-7D021-A)

More information

Pinpoint Test A: Shift Solenoid

Pinpoint Test A: Shift Solenoid Procedures 2004 Ford Freestar 3.9L Eng SES P0731 Pinpoint Test A: Shift Solenoid NOTE: Refer to TRANSAXLE INTERNAL HARNESS DIAGRAM for the transaxle internal harness diagram illustration. NOTE: Refer to

More information

Page 1 of 7 PINPOINT TEST F: TURBINE SHAFT SPEED (TSS) SENSOR AND OUTPUT SHAFT SPEED (OSS) SENSOR NOTE: Refer to the OSS-Sensor or TSS-Sensor Connector illustration preceding these pinpoint tests. CONDITIONS

More information

FORD 6R80 UPDATES Presented by: David Chalker ATRA Technical Advisor 6R80

FORD 6R80 UPDATES Presented by: David Chalker ATRA Technical Advisor 6R80 FORD UPDATES Presented by: David Chalker ATRA Technical Advisor Welcome To Today s Presentation Sponsored By: Any Questions Or Comments Please Send Emails To webinars@atra.com Any Questions That You

More information

2002 Ford Explorer AUTOMATIC TRANSMISSIONS' '5R55W/S Diagnosis 2002 AUTOMATIC TRANSMISSIONS. 5R55W/S Diagnosis

2002 Ford Explorer AUTOMATIC TRANSMISSIONS' '5R55W/S Diagnosis 2002 AUTOMATIC TRANSMISSIONS. 5R55W/S Diagnosis 2002 AUTOMATIC TRANSMISSIONS 5R55W/S Diagnosis APPLICATION WARNING: Vehicles are equipped with Supplemental Inflatable Restraint (SIR) system. When servicing vehicle, use care to avoid accidental air bag

More information

DIAGNOSIS AND TESTING

DIAGNOSIS AND TESTING 307-01-1 Automatic Transaxle/Transmission 307-01-1 DIAGNOSIS AND TESTING Special Testing Procedures Special Tool(s) Air Test Plate, Transmission 307-405 Transmission Fluid Pressure Gauge 307-004 (T57L-77820-A)

More information

Page 1 of 9 2004 Ford Pickup 5.4L Eng VIN L F250 Super Duty 1Search Print Date: P0720 Pinpoint Test F: Turbine Shaft Speed (TSS) And Output Shaft Speed () Sensors NOTE: Refer to the Output Shaft Speed

More information

1998 Ford F Diagnostics > Diagnostic Routines > Powertrain > Automatic Transmission > A... Page 1 of 63

1998 Ford F Diagnostics > Diagnostic Routines > Powertrain > Automatic Transmission > A... Page 1 of 63 1998 Ford F-150 - Diagnostics > Diagnostic Routines > Powertrain > Automatic Transmission > A... Page 1 of 63 1998 Ford F-150 : Diagnostics > Diagnostic Routines > Powertrain > Automatic Transmission >

More information

ZF4HP16. Technical Bulletin # Signal Combination L1 L2 L3 L4 P R N D

ZF4HP16. Technical Bulletin # Signal Combination L1 L2 L3 L4 P R N D Transmission: Subject: Application: Issue Date: Technical Bulletin # 1308 ZF4HP16 Electronical Components Description 2005 Suzuki Forenza L4-2.0L February, 2010 ZF4HP16 Electronical Components Description

More information

ASSEMBLY. Transmission Automatic Transmission 5R44E and 5R55E. Special Tool(s)

ASSEMBLY. Transmission Automatic Transmission 5R44E and 5R55E. Special Tool(s) 307-01-1 Automatic Transmission 5R44E and 5R55E 307-01-1 ASSEMBLY Transmission Special Tool(s) Holding Fixture, Transmission 307-262 (T93T-77002-AH) Special Tool(s) Installer, Transmission Extension Housing

More information

Kit Number Used with the TE Transmission Simula. Reference Guide /05/06

Kit Number Used with the TE Transmission Simula. Reference Guide /05/06 62TE Transmission Simula ulator Adapter Harness Manual Kit Number 9944 Used with the 8333 Transmission Simulator Reference Guide 541263 12/05/06 Copyright 2006 by SPX Corporation INTRODUCTION The following

More information

TRANSMISSION - NGC. Symptom: P0706-CHECK SHIFTER SIGNAL. When Monitored and Set Condition:

TRANSMISSION - NGC. Symptom: P0706-CHECK SHIFTER SIGNAL. When Monitored and Set Condition: Symptom: P0706-CHECK SHIFTER SIGNAL When Monitored and Set Condition: P0706-CHECK SHIFTER SIGNAL When Monitored: Continuously with the ignition on. Set Condition: After 3 occurrences in one ignition cycle

More information

Ford CFT 30 Introduction. Presented by: Bill Brayton ATRA Senior Research Technician

Ford CFT 30 Introduction. Presented by: Bill Brayton ATRA Senior Research Technician Ford CFT 30 Introduction Presented by: Bill Brayton ATRA Senior Research Technician Connections Handout Webinars@ATRA.com Questions Survey Welcome To Today s Presentation Sponsored By: Thank you to our

More information

Torque Converter Clutch (TCC) Solenoid

Torque Converter Clutch (TCC) Solenoid Torque Converter Clutch (TCC) Solenoid The torque converter clutch (TCC) solenoid provides torque converter clutch control by shifting the converter clutch control valve to apply or release the TCC. PINPOINT

More information

INTRODUCTION PRELIMINARY DIAGNOSIS

INTRODUCTION PRELIMINARY DIAGNOSIS NO: 21-11-98 SUBJECT: Transmission Simulator Diagnostic Tool DATE: Dec. 11, 1998 NOTE: THIS INFORMATION APPLIES TO VEHICLES EQUIPPED WITH A 45RFE TRANSMISSION. DISCUSSION: A new transmission simulator

More information

Shift Solenoids (SS)

Shift Solenoids (SS) 2011 Mustang Report a problem with this article 307-01 Automatic Transaxle/Transmission 6R80 2011 Mustang IN-VEHICLE REPAIR Procedure revision date: 02/23/2011 Shift Solenoids (SS) Material Item Motorcraft

More information

Fuel Selector Valve- Diagnosis/Replacement

Fuel Selector Valve- Diagnosis/Replacement 1983 Ford Truck F 250 2WD Pickup V8-460 7.5L Copyright 2007, ALLDATA 9.90 Page 1 Technical Service Bulletin # 832221 Date: 831101 Fuel Selector Valve- Diagnosis/Replacement Article No. 83-22-21 FUEL SYSTEM

More information

Welcome To Today s Presentation Sponsored By:

Welcome To Today s Presentation Sponsored By: Welcome To Today s Presentation Sponsored By: Any Questions Or Comments Please Send Emails To webinars@atra.com Any Questions That You May Have During The Webinar Please Feel Free To Text Them In At Any

More information

P0706-TRANSMISSION RANGE SENSOR RATIONALITY

P0706-TRANSMISSION RANGE SENSOR RATIONALITY Page 1 of 7 28 - DTC-Based Diagnostics/MODULE, Powertrain Control (PCM), 545RFE/Diagnosis and Testing P0706-TRANSMISSION RANGE SENSOR RATIONALITY Special Tools: Click to display a list of tools used in

More information

PRESSURE SWITCH SENSE CIRCUIT

PRESSURE SWITCH SENSE CIRCUIT Symptom: P0876-UD PRESSURE SWITCH SENSE CIRCUIT When Monitored and Set Condition: P0876-UD PRESSURE SWITCH SENSE CIRCUIT When Monitored: Whenever the engine is running. Set Condition: This DTC is set if

More information

2001 Cougar Workshop Manual

2001 Cougar Workshop Manual Page 1 of 7 SECTION 303-06: Starting System 2001 Cougar Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 09/14/2001 Starting System Refer to Wiring Diagrams Section 303-06 for schematic and

More information

P0760-OD SOLENOID CIRCUIT

P0760-OD SOLENOID CIRCUIT - JC - DGE JOURNEY -.5L V6 V MPI - HIGH OUTPUT P6- CIRCUIT BATT A RELAY-PCM MULE- TOTALLY INTEGRATED POWER A FUSE J A 6 C T6 6 C T6 D C5 T6 S T6 6 L/R / /TRS EMCC VFS C LR UD 6 5 T6 T6 T6 T5 T T T T YL/TN

More information

P0716-INPUT SPEED SENSOR 1 CIRCUIT PERFORMANCE

P0716-INPUT SPEED SENSOR 1 CIRCUIT PERFORMANCE Page 1 of 10 P0716-INPUT SPEED SENSOR 1 CIRCUIT PERFORMANCE Circuit Schematic 2007 Dodge Nitro 3.7L Eng SXT Page 2 of 10 Fig 1: Speed Sensor Circuit Schematic Additional Wiring For complete wiring diagrams

More information

Transmission. Special Tool(s) Installation. All vehicles

Transmission. Special Tool(s) Installation. All vehicles Transmission Special Tool(s) Installation All vehicles 1. CAUTION: Prior to the installation of the transmission, the fluid, cooler lines and the cooler bypass valve must be cleaned. Transmission failure

More information

Technical Bulletin Listing 2010

Technical Bulletin Listing 2010 Technical Bulletin Listing 2010 January, 2010 Transmission Bulletin # # Pages Subject January Allison LCT 1000 1300 1 Sets P0872, No 4th, 3rd Gear Start 4L80E 1301 4 Shift Shuttle/No Line Rise RE4F04A

More information

DIAGNOSIS AND TESTING

DIAGNOSIS AND TESTING 307-01B-1 DIAGNOSIS AND TESTING Special Testing Procedures The special tests are designed to aid the technician in diagnosing the hydraulic and mechanical portion of the transmission. Engine Idle speed

More information

DP: Vehicle Speed Sensor (VSS)/Transfer Case Speed Sensor (TCSS) DP: Introduction

DP: Vehicle Speed Sensor (VSS)/Transfer Case Speed Sensor (TCSS) DP: Introduction PPT DP: VEHICLE SPEED SENSOR... PPT DP: VEHICLE SPEED SENSOR ()/TRANSFER CASE SPEED SENSOR (TCSS) (GASOLINE ENGINES) 2005 PCED Gasoline Engines SECTION 5: Pinpoint Tests Procedure revision date: 03/30/2005

More information

FORD 6F50, 6F55 ZIP KIT

FORD 6F50, 6F55 ZIP KIT FORD 6F0, 6F ZIP KIT PART NUMBER 6F0-ZIP QUICK GUIDE Parts are labeled here in order of installation. See other side of sheet for details on Zip Kit contents. CAUTION: Ensure shuttle valve is installed

More information

1998 Ford EXPEDITION. Submodel: Engine Type: V8 Liters: 5.4 Fuel Delivery: FI Fuel: GAS. Transmission

1998 Ford EXPEDITION. Submodel: Engine Type: V8 Liters: 5.4 Fuel Delivery: FI Fuel: GAS. Transmission 1998 Ford EXPEDITION Submodel: Engine Type: V8 Liters: 5.4 Fuel Delivery: FI Fuel: GAS SECTION 307-01C: Automatic Transmission 4R100 1998 Expedition/Navigator Workshop Manual REMOVAL Procedure revision

More information

05/01/06 1er mai 2006 Cruise Control - Diagnostic Updates General Service Procedure Service Procedure Speed Control Diagnostic Tips Additional

05/01/06 1er mai 2006 Cruise Control - Diagnostic Updates General Service Procedure Service Procedure Speed Control Diagnostic Tips Additional 05/01/06 1er mai 2006 General Service Procedure Service Procedure Speed Control Diagnostic Tips Additional Reference Information SPEED CONTROL DIAGNOSTICS - W/O SCP FORD: 2000-2003 Escort 2000-2004 Crown

More information

2001 Lincoln LS V6-3.0L DOHC VIN S Vehicle > Powertrain Management > Diagrams > Electrical - Interactive Color (Non OE) Engine Controls - Page 1 of 4

2001 Lincoln LS V6-3.0L DOHC VIN S Vehicle > Powertrain Management > Diagrams > Electrical - Interactive Color (Non OE) Engine Controls - Page 1 of 4 /0/0 Engine Controls (Powertrain Management) - ALLDATA 00 Lincoln LS V-.0L DOHC VIN S Vehicle > Powertrain Management > Diagrams > Electrical - Interactive Color (Non OE) Engine Controls - Page of https://my.alldata.com/repair/#/repair/article//component//itype//nonstandard/0

More information

AUTO TRANS DIAGNOSIS - 4T65-E

AUTO TRANS DIAGNOSIS - 4T65-E AUTO TRANS DIAGNOSIS - 4T65-E 1998 Pontiac Bonneville 1997-98 AUTOMATIC TRANSMISSIONS General Motors - 4T65-E Electronic Controls Buick; LeSabre, Park Avenue, Regal, Riviera Chevrolet; Lumina, Monte Carlo

More information

Cruise Control Diagnosis

Cruise Control Diagnosis 1999 Pontiac Firebird Cruise Control Diagnosis Circuit Description The Cruise Control system is a speed control system that maintains a desired vehicle speed under normal driving conditions. The cruise

More information

Intake Air Temperature (IAT) Sensor

Intake Air Temperature (IAT) Sensor Page 1 of 5 Year = 2011 Model = Mustang Engine = 5.0L VIN = IDS Version = t Available Intake Air Temperature (IAT) Sensor This pinpoint test is intended to diagnose the following: IAT sensor (12A697) integrated

More information

SECTION Automatic Transaxle/Transmission 4R70E/4R75E

SECTION Automatic Transaxle/Transmission 4R70E/4R75E 307-01-i Automatic Transaxle/Transmission 4R70E/4R75E 307-01-i SECTION 307-01 Automatic Transaxle/Transmission 4R70E/4R75E CONTENTS PAGE Transmission Four Wheel Drive (4WD)... 307-01-2 307-01-2 Automatic

More information

FORD 6F50, 6F55 ZIP KIT

FORD 6F50, 6F55 ZIP KIT FORD 6F0, 6F ZIP KIT PART NUMBER 6F0-ZIP QUICK GUIDE Parts are labeled here in order of installation. See other side of sheet for details on kit contents. CAUTION: Ensure shuttle valve is installed with

More information

DA: Intake Air Temperature (IAT) Sensor

DA: Intake Air Temperature (IAT) Sensor 2007 PCED On Board Diagnostics SECTION 5: Pinpoint Tests Procedure revision date: 03/29/2006 DA: Intake Air Temperature () Sensor DA: Introduction DA1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS) Are DTCs

More information

DIAGNOSIS AND TESTING

DIAGNOSIS AND TESTING 307-05-1 Automatic Transaxle/Transmission External Controls 307-05-1 DIAGNOSIS AND TESTING Visual Inspection Chart External Controls Mechanical Electrical Refer to Wiring Diagrams Cell 37 for schematic

More information

P0876-UD PRESSURE SWITCH RATIONALITY

P0876-UD PRESSURE SWITCH RATIONALITY Page 1 of 14 P0876-UD PRESSURE SWITCH RATIONALITY Page 2 of 14 For a complete wiring diagram Refer to Section 8W When Monitored: Continuously with the ignition on and engine running. Set Condition: This

More information

SECTION Automatic Transaxle/Transmission 6R80

SECTION Automatic Transaxle/Transmission 6R80 307-01-i Automatic Transaxle/Transmission 6R80 307-01-i SECTION 307-01 Automatic Transaxle/Transmission 6R80 CONTENTS PAGE Main Control... 307-01-2 307-01-2 Automatic Transaxle/Transmission 6R80 Main Control

More information

P0750-LR SOLENOID CIRCUIT

P0750-LR SOLENOID CIRCUIT 9 - JS - DGE AVENGER -.L CYL DOHC V DUAL V.V.T. P-LR CIRCUIT BATT A B(+) CONTROL OUTPUT ELECTRONICS TOTALLY INTEGRATED POWER C T S T C T C T S T - - UD / T T YL/TN YL/DG T9 DG/TN T9 T T9 T YL/DB DG/WT

More information

Transmission. All vehicles

Transmission. All vehicles INSTALLATION: TRANSMISSION (A... INSTALLATION: TRANSMISSION (AUTOMATIC TRANSAXLE/TRANSMISSION) 307 01 Automatic Transaxle/Transmission 2006 Mustang INSTALLATION Procedure revision date: 07/11/2008 All

More information

2000 MY OBD System Operation Summary for 7.3L Diesel Engine

2000 MY OBD System Operation Summary for 7.3L Diesel Engine 2000 MY OBD System Operation Summary for 7.3L Diesel Engine Table of Contents Introduction OBD-I and OBD-II... 2 OBD-II Systems...2 OBD-I Systems...2 Misfire Monitor... 3 Low Data Rate System...3 Misfire

More information

DS: Air Conditioning Pressure (ACP) Transducer Sensor

DS: Air Conditioning Pressure (ACP) Transducer Sensor 2009 PCED Gasoline Engines SECTION 5: Pinpoint Tests Procedure revision date: 08/12/2009 DS: Air Conditioning Pressure () Transducer Sensor DS: Introduction DS1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS)

More information

P0750-LR SOLENOID CIRCUIT

P0750-LR SOLENOID CIRCUIT 6 - HB - DODGE DURANGO - 5.7L HEMI V - MDS P75-LR CIRCUIT BATT A FUSE 5 5A INTEGRATED POWER 5-6 7 C 7 C 9 C4 Z95 T5 BK YL/BK 4 G T C T S T T TO OTHER MODULES /TRS 7 9 7 T5 YL/BK T T T T6 YL/RD T DG T9

More information

2002 F-150 Workshop Manual

2002 F-150 Workshop Manual Page 1 of 23 SECTION 310-03: Speed Control 2002 F-150 Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 08/07/2006 Speed Control Refer to Wiring Diagrams Cell 31, Speed Control for schematic

More information

DISASSEMBLY AND ASSEMBLY

DISASSEMBLY AND ASSEMBLY 307-01-1 Automatic Transaxle/Transmission 4R70E/4R75E 307-01-1 DISASSEMBLY AND ASSEMBLY Main Control Valve Body Disassembly Main Control Valve Body Disassembled View Item Part Number Description Item Part

More information

STARTING SYSTEMS 8B - 1 STARTING SYSTEMS CONTENTS

STARTING SYSTEMS 8B - 1 STARTING SYSTEMS CONTENTS TJ STARTING SYSTEMS 8B - 1 STARTING SYSTEMS CONTENTS page DESCRIPTION AND OPERATION STARTER MOTOR... 2 STARTER RELAY... 3 STARTING SYSTEM... 1 DIAGNOSIS AND TESTING STARTER MOTOR... 8 STARTER MOTOR NOISE

More information

P0750-LR SOLENOID CIRCUIT

P0750-LR SOLENOID CIRCUIT 2008 Dodge Pickup 4.7L Eng R1500 P0750-LR SOLENOID CIRCUIT Circuit Schematic Fig 1: Transmission Solenoid/TRS Assembly Circuit Schematic Courtesy of CHRYSLER LLC Additional Wiring For complete wiring diagrams

More information

IN-VEHICLE REPAIR. Output Shaft Speed (OSS) Sensor. Removal

IN-VEHICLE REPAIR. Output Shaft Speed (OSS) Sensor. Removal 307-01-1 Automatic Transaxle/Transmission 6F50 307-01-1 IN-VEHICLE REPAIR Output Shaft Speed (OSS) Sensor Material Item MERCON V Automatic Transmission Fluid XT-5-QM (or XT-5-QMC) (US); CXT-5-LM12 (Canada)

More information

2/2/2018 Feed Circuit Test (Starting System) - ALLDATA

2/2/2018 Feed Circuit Test (Starting System) - ALLDATA 2005 Jeep Truck Grand Cherokee 2WD V8-5.7L VIN 2 Vehicle > Starting and Charging > Starting System > Testing and Inspection > Component Tests and General Diagnostics FEED CIRCUIT TEST The starter feed

More information

TRANSMISSION CONTROL SYSTEM (4L30 E)

TRANSMISSION CONTROL SYSTEM (4L30 E) TRANSMISSION CONTROL SYSTEM (4L30 E) 7A1 1 RODEO TRANSMISSION TRANSMISSION CONTROL SYSTEM (4L30 E) CONTENTS Service Precaution...................... 7A1 2 General Description..................... 7A1 2

More information

1995 Town Car/Crown Victoria/Grand Marquis

1995 Town Car/Crown Victoria/Grand Marquis Page 1 of 11 PINPOINT TEST A: SHIFT SOLENOIDS Pinpoint Test A Shift Solenoids DTCs: P0781, P0782, P0783 Shift Errors P0750, P0755 Solenoid Circuit Failures P0751, P1751 Shift Solenoid. 1 Malfunction P0756,

More information

Page 1 of 10 SECTION 307-01: Automatic Transaxle/Transmission 2005 Focus Workshop Manual ASSEMBLY Procedure revision date: 04/04/2008 Transaxle Printable View (2476 KB) Special Tool(s) Alignment Tool,

More information

M: Fuel System M: Introduction

M: Fuel System M: Introduction Page 1 of 7 2011 PCED 6.7L Diesel SECTION 5: Pinpoint Tests Procedure revision date: 12/14/2010 M: Fuel System M: Introduction M1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS) te: Repair any fuel injector

More information

Ford. After rebuilding a 5R55W/S model transmission, during the road test you may encounter a are on the 2 3 shift.

Ford. After rebuilding a 5R55W/S model transmission, during the road test you may encounter a are on the 2 3 shift. 112 Erratic Transmission Operation After rebuilding a model transmission, during the road test you may encounter a are on the 2 3 shift. This concern can be caused by a new solenoid pack. Over the years,

More information

M1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS)

M1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS) TEST PROCEDURE M1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS) 2011 Ford Pickup 6.7L Eng F250 Super Duty NOTE: Repair any fuel injector circuit related DTCs before entering this pinpoint test. Are any DTCs

More information

DTC P Shift Solenoid Circuit Electrical

DTC P Shift Solenoid Circuit Electrical 1998 Pontiac Grand Prix DTC P0753 1-2 Shift Solenoid Circuit Electrical Circuit Description The 1-2 Shift Solenoid Valve Assembly (1-2 SS Valve Assy.) controls the transmission fluid pressure on the 1-2

More information

Zoom and Print Options

Zoom and Print Options Vehicle» A L L Diagnostic Trouble Codes ( DTC )» Testing and Inspection» P Code Charts» P0707» CVT Automatic Transaxle P0707-TRANSMISSION RANGE SENSOR CIRCUIT LOW http://repair.alldata.com/alldata/article/display.action?componentid=3926&itypeid=423&nonstandardid=1733324&vehicleid=42661&windowname=m

More information

FA: AMBIENT AIR TEMPERATURE (AAT) SENSOR: PINPOINT TEST

FA: AMBIENT AIR TEMPERATURE (AAT) SENSOR: PINPOINT TEST 2014 Ford Taurus FWD V6-35L Vehicle > Powertrain Management > Computers and Control Systems > Testing and Inspection > Pinpoint Tests FA: AMBIENT AIR TEMPERATURE (AAT) SENSOR: PINPOINT TEST FA: Ambient

More information

SECTION Electronic Engine Controls

SECTION Electronic Engine Controls 303-14-i Electronic Engine Controls 303-14-i SECTION 303-14 Electronic Engine Controls CONTENTS PAGE DIAGNOSIS AND TESTING Electronic Engine Controls... 303-14-2 DTC Charts... 303-14-2 303-14-2 Electronic

More information

DTC P1811 Maximum Adapt and Long Shift

DTC P1811 Maximum Adapt and Long Shift 2000 Buick Century DTC P1811 Maximum Adapt and Long Shift Circuit Description The transmission pressure is modified by an adaptive modifier which controls the shift execution time. This test checks the

More information

Document ID# Chevrolet Corvette

Document ID# Chevrolet Corvette Page 1 of 6 Document ID# 610892 2000 Chevrolet Corvette Feedback Print D T C P 0 4 6 2 F u e l L e v e l S e n s o r C i r c u i t L o w V o l t a g e C i r c u i t D e s c r i p t i

More information

AISIN WARNER. 1. With the selector lever in Park, start the engine and warm it to operating temperature.

AISIN WARNER. 1. With the selector lever in Park, start the engine and warm it to operating temperature. AISIN WARNER 249 Manual Code Retrieval Preliminary Test: 1. With the selector lever in Park, start the engine and warm it to operating temperature. 2. Turn the ignition switch to the Off position, then

More information

PINPOINT TEST B: TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR

PINPOINT TEST B: TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR PINPOINT TEST B: TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR NOTE: Refer to the Transmission Vehicle Harness Connector illustration preceding these pinpoint tests. NOTE: This vehicle is equipped with a

More information

DX: Engine Coolant Temperature (ECT) Sensor

DX: Engine Coolant Temperature (ECT) Sensor 2009 PCED Gasoline Engines SECTION 5: Pinpoint Tests Procedure revision date: 12/10/2008 DX: Engine Coolant Temperature (ECT) Sensor DX: Introduction DX1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS) Are DTCs

More information

2003 F-Super Duty /Excursion Workshop Manual

2003 F-Super Duty /Excursion Workshop Manual 3//2011 SECTION 310-03: Speed Control 2003 F-Super Duty 250-550/Excursion Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 08/01/2006 Speed Control Printable View (331 KB) Refer to Wiring

More information

DIAGNOSIS AND TESTING

DIAGNOSIS AND TESTING 308-07A-1 DIAGNOSIS AND TESTING Electronic Shift Visual Inspection Chart Mechanical Electrical 308-07A-1 Refer to Wiring Diagrams Cell 34 for schematic and Halfshafts Junction box (JB) mini connector information.

More information

P0688-AUTO SHUTDOWN SENSE CIRCUIT LOW

P0688-AUTO SHUTDOWN SENSE CIRCUIT LOW - DS - RAM 5 PICKUP - 5.7L V HEMI MDS V.V.T. (EZH) P6- SHUTDOWN SENSE CIRCUIT LOW BATT A B(+) ELECTRONICS TOTALLY INTEGRATED POWER 5 SHUT DOWN 6 FUSE M 5A C C5 K5 C C K5 S4 C 4.7L/ C C C.7L 5.7L S S4 BLACK/BLACK

More information

INDEX AUTOMATIC TRANSMISSION SERVICE GROUP S.W. 107 AVENUE MIAMI, FLORIDA (305) Copyright ATSG 2008

INDEX AUTOMATIC TRANSMISSION SERVICE GROUP S.W. 107 AVENUE MIAMI, FLORIDA (305) Copyright ATSG 2008 UPATE HANBOOK JF0E INEX BELL HOUSING IENTIFICATION... CUT-AWAY AN INTERNAL COMPONENT LOCATIONS... COMPONENT APPLICATION CHART AN GEAR RATIOS... RANGE SELECTOR SWITCH CONNECTOR IENTIFICATION... OIL PAN

More information

Intake Air Temperature 2 (IAT2 ) Sensor

Intake Air Temperature 2 (IAT2 ) Sensor Page 1 of 6 Year = 2011 Model = Mustang Engine = 5.0L VIN = IDS Version = t Available Intake Air Temperature 2 ( ) Sensor This pinpoint test is intended to diagnose the following: sensor (12A697) harness

More information

Fuel Injector Control Module (FICM ) Low Voltage

Fuel Injector Control Module (FICM ) Low Voltage Page 1 of 6 Year = 2006 Model = F-Super Duty Engine = VIN = Fuel Injector Control Module (FICM ) Low Voltage Circuit Function The FICM requires a 12-volt power source. The FICM receives power from the

More information

"A Unique Name, A Unique Company!" Sensor Simulator Tester III TOOL TIME. Stevie Lavallee

A Unique Name, A Unique Company! Sensor Simulator Tester III TOOL TIME. Stevie Lavallee TOOL TIME Sensor Simulator Tester III routines. In the coming months, this column will feature tools and equipment from both the aftermarket and OEM. When possible, we ll use actual diagnostic or repair

More information

2002 Taurus/Sable Workshop Manual

2002 Taurus/Sable Workshop Manual Page 1 of 69 SECTION 412-00: Climate Control System - General Information 2002 Taurus/Sable Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 02/05/2005 Climate Control System Refer to Wiring

More information

STARTING SYSTEM TEST STARTING SYSTEM

STARTING SYSTEM TEST STARTING SYSTEM 2013 Dodge or Ram Truck RAM 1500 Truck 2WD V8-5.7L Vehicle > Starting and Charging > Starting System > Testing and Inspection > Component Tests and General Diagnostics STARTING SYSTEM TEST STARTING SYSTEM

More information

SECTION 5 DIAGNOSTIC TROUBLE CODES (DTC)

SECTION 5 DIAGNOSTIC TROUBLE CODES (DTC) 5 1. DTC MEMORY SECTION 5 Diagnostic Trouble Codes (DTCs) are logged in a list in TCM memory. The DTCs contained in the list have information recorded as shown in Table 5 1 (DTC example). The TCM is capable

More information

DIAGNOSIS AND TESTING

DIAGNOSIS AND TESTING 412-00-1 Climate Control System - General Information 412-00-1 DIAGNOSIS AND TESTING Climate Control System Refer to Wiring Diagrams Cell 54, Air Conditioning/Heater for schematic and connector information.

More information

If the PCM detects a counter value of two during one trip, then DTC P1811 sets. DTC P1811 is a type C DTC.

If the PCM detects a counter value of two during one trip, then DTC P1811 sets. DTC P1811 is a type C DTC. Page 1 of 6 2001 Pontiac Montana Montana, Silhoutte, Venture (VIN U) Service Manual Document ID: 654706 DTC P1811 Circuit Description The transmission pressure is modified by an adaptive modifier which

More information

750 Paso Wiring Upgrade

750 Paso Wiring Upgrade 750 Paso Wiring Upgrade Supplies required: 2 Bosch 30A/12V Relays # #0 332 209 150 (with mounting tab) 1 30 Amp fuse holder 1 10 Amp fuse holder 12 inches of brown 12 gauge wire 60 inches of red 14 gauge

More information

AIR CONDITIONING BLOWER CONTROL MODULE/BLOWER RESISTOR TEST G - BLOWER MOTOR OPERATES AT HIGH SPEED AT ALL SPEED SETTINGS

AIR CONDITIONING BLOWER CONTROL MODULE/BLOWER RESISTOR TEST G - BLOWER MOTOR OPERATES AT HIGH SPEED AT ALL SPEED SETTINGS 1996 Ford Taurus 3.0L Eng LX AIR CONDITIONING BLOWER CONTROL MODULE/BLOWER RESISTOR TEST G - BLOWER MOTOR OPERATES AT HIGH SPEED AT ALL SPEED SETTINGS 1. Check Blower Operation Disconnect RCC module harness

More information

MASS AIR FLOW (MAF) SENSOR, CHECKING - BOSCH

MASS AIR FLOW (MAF) SENSOR, CHECKING - BOSCH 2004 Audi A6 Sedan (4B2) V6-2.7L Turbo (BEL) Vehicle > Powertrain Management > Computers and Control Systems > Testing and Inspection > Component Tests and General Diagnostics > Component Tests > Mass

More information

6T30/6T40/6T45 - AUTOMATIC TRANSMISSION

6T30/6T40/6T45 - AUTOMATIC TRANSMISSION 2010 GMC Truck Terrain AWD L4-2.4L Vehicle > ALL Diagnostic Trouble Codes ( DTC ) > Testing and Inspection > P Code Charts > P0717 6T30/6T40/6T45 - AUTOMATIC TRANSMISSION DTC P0716 or P0717 Diagnostic

More information

STARTER CIRCUIT TROUBLESHOOTING

STARTER CIRCUIT TROUBLESHOOTING 2000 Honda Accord EX Sedan V6-3.0L Vehicle > Starting and Charging > Starting System > Starter Motor > Testing and Inspection > Component Tests and General Diagnostics STARTER CIRCUIT TROUBLESHOOTING Starter

More information

U660E, U660F, U760E, U760F

U660E, U660F, U760E, U760F Transmission: Subject: Application: Issue Date: Technical Bulletin #1632 U660E, U660F, U760E, U760F Delayed or Harsh Reverse Engagements Toyota August, 2014 U660E, U660F, U760E, U760F Delayed or Harsh

More information

HYDRAULIC PRESSURE SWITCH CIRCUIT

HYDRAULIC PRESSURE SWITCH CIRCUIT Symptom: P1726-UD HYDRAULIC PRESSURE SWITCH CIRCUIT When Monitored and Set Condition: P1726-UD HYDRAULIC PRESSURE SWITCH CIRCUIT When Monitored: In any forward gear with engine speed above 1000 RPM shortly

More information

1. Range Reference Chart

1. Range Reference Chart . Range Reference Chart Range Gear Sol A N.C. Sol B N.C. O/D Roller Clutch Overrun Clutch (OC) Fouth Clutch (C4) Third Clutch (C) Reverse Clutch (RC) Second Clutch (C) Principle Sprag Assembly Band Assembly

More information