Benefits of VI Improver Selection on Passenger Car Fuel Economy Part 2
|
|
- Vivian Gardner
- 5 years ago
- Views:
Transcription
1 Benefits of VI Improver Selection on Passenger Car Fuel Economy Part 2 May 16, 2016 Las Vegas, NV Don Smolenski, Thorsten Bartels, Jackie Liu, Michael Seemann, Joan Souchik
2 Outline Introduction Oils Tested Test details, results Engine dynamometer Chassis dynamometer Summary Conclusions
3 Introduction Lubricants are cost effective means to improve fuel economy VI Improvers can provide a significant benefit Fuel economy improvement extremely important to OEMs - and progressively more costly! Fuel economy is defined by appropriate chassis dynamometer test: US FTP Europe NEDC, WLTC Japan JC08 Test precision is extremely important!
4 EPA Minimum Corporate Average Fuel Economy Requirements Extremely ambitious fuel economy improvement is mandated 54.5 BY 2025 mpg Year
5 Benefit of Optimized Viscosity Profile Viscosity Area of fuel economy improvement Optimized Conventional Temperature. C
6 SAE 5W-30 Oils Tested Physical Properties Oils Unit Reference Viscosity Index Improver Conv. 1 Conv. 2 Adv. 1 Adv. 2 KV40C mm 2 /s KV100C mm 2 /s VI HTHS 80 C mpas HTHS 100 C mpas HTHS 150 C mpas
7 Engine Dyno Testing
8 Fuel Economy - Engine Dyno Testing German Technical University Well equipped engine dynamometers with fuel scale and emissions measurements capabilities Ability to run FTP75 city, NEDC, WLTC, JC08 cycles Opel 2.0L turbo engine; calibration for Insignia with manual transmission Excellent repeatability, 3 runs each oil, each cycle
9 Fuel Economy in FTP75 City Cycle Comparison of Different VIIs Fuel Economy Improvement over Reference 2.00% 1.80% 1.60% 1.40% 1.20% 1.00% 0.80% 0.60% 0.40% 0.20% 0.00% max min avg Conv. Oil 2 Adv. Oil 1 Adv. Oil 2 Advanced Oil 2: 0.97% improvement in FE over Reference
10 Fuel Economy in NEDC Cycle Comparison of Different VIIs Fuel Economy Improvement over Reference 2.00% 1.75% 1.50% 1.25% 1.00% 0.75% 0.50% 0.25% 0.00% -0.25% -0.50% max min avg Conv. Oil 2 Adv. Oil 1 Adv. Oil 2 Adv. Oil 2:1.54% improvement over Reference
11 Chassis Dyno Testing
12 Chassis Dyno Test Illustrate benefit of proper VI improver selection Validate engine dyno data on chassis dyno FE gold standard - chassis Midwest US lab
13 Test Protocol Chassis Dyno Buick Regal (American equivalent to Insignia) Turbo (same engine at German engine dyno, but calibrated for US emissions), with an automatic transmission Chassis dynamometer Same oils and FE cycles as engine dyno, except: dropped JC08 replaced WLTC with FTP Highway
14 FTP City Cycle Results FE Change Over Average Reference 3.60% 3.00% 2.40% 1.80% 1.20% 0.60% 0.00% -0.60% -1.20% Conv. Reference Advanced Oil 2 Advanced Oil 2: 1.23% improvement over reference
15 FTP City Cycle Oils Are Statistically Different One Factor Fuel Economy FE1 emissions % confidence level 21.4 (8350/1) (8302/2) Reference Oil Advanced Oil 2
16 NEDC Results 1.30% FE Change over Average Reference 1.10% 0.90% 0.70% 0.50% 0.30% 0.10% -0.10% -0.30% -0.50% Conventional Ref. Advanced Oil 2 Advanced Oil 2: 0.87% improvement over Reference
17 NEDC Oils are Statistically Different One Factor 22.9 Fuel Economy FE % confidence level 22.4 (8350/1) (8302/2) Reference Oil Advanced Oil 2
18 Results FTP Highway High variability in reference oil results Slight improvement observed with Advanced Oil 2 Work is ongoing
19 Fuel Economy and Viscometrics Fuel economy results from engine and chassis tests were plotted against several key viscometric properties Fuel economy trends as expected with viscometrics Optimized viscosity profile better fuel economy
20 Fuel Economy and Viscometrics KV40C HTHS 150 C KV100C HTHS 100 C Conventional HTHS 80 C Advanced VII FE Change over average Reference 3.60% 3.00% 2.40% 1.80% 1.20% 0.60% 0.00% -0.60% -1.20%
21 Summary NEDC and FTP City cycle FE tests were conducted with good precision on meticulously controlled engine and chassis dynamometers Fuel Economy improvement measured in NEDC and FTP City cycles show similar ranking of oils Oils with optimized viscometrics demonstrate a significant fuel economy advantage over conventional formulations
22 Conclusion Optimized VI improver selection can provide significant fuel economy improvement
23 Questions?? Dankeschön Merci Gracias Xie Xie 谢谢 Thank you
The Role of VI Improvers in the Formulation of Fuel Efficient Engine Oils with Long Drain Intervals
The Role of VI Improvers in the Formulation of Fuel Efficient Engine Oils with Long Drain Intervals Yasushi Naitoh, Evonik Degussa Japan Co., Ltd Frank Lauterwasser, Phil Hutchinson, Christoph Wincierz,
More informationDRIVON technology. Fuel-efficient powertrain solutions
DRIVON technology Fuel-efficient powertrain solutions MEET CHANGING FUEL EFFICIENCY REQUIREMENTS The transportation industry faces significant challenges from ever more stringent requirements for improved
More informationCASE STUDY 1612C FUEL ECONOMY TESTING
CASE STUDY 1612C FUEL ECONOMY TESTING INCREASE IN FUEL ECONOMY BY CLEANING THE INTERNAL ENGINE COMPONENTS AND REDUCING FRICTION THIRD PARTY THE OHIO STATE UNIVERSITY CENTER FOR AUTOMOTIVE RESEARCH TEST
More information# of tests Condition g/mile ± g/mile ± g/mile ± (miles/gal) ± Impact of Diesel Extreme on emissions and fuel economy USDS results:
Executive Summary Fuel Additive EPA based fuel economy testing was completed at the Ohio State University Center of Automotive Research. The purpose of the testing was to take a commercial Fedex truck
More informationNEW FRICTION DURABLE ADDITIVE TECHNOLOGY AND ITS APPLICATION IN AUTOMATIC TRANSMISSIONS
Samuel H. Tersigni et al. Nova tehnologija aditiva... Samuel H. Tersigni, Lee D. Saathoff, Christopher Cleveland, Mark S. Jones ISSN 0350-350X GOMABN 49, 2, 131-146 Stručni rad/professional Paper UDK 621.892:621.83.069.2
More informationDELIVERING OPTIMAL FUEL ECONOMY AND WEAR PROTECTION THROUGH LUBRICANT DESIGN
Blucher Engineering Proceedings Agosto de 2014, Número 2, Volume 1 DELIVERING OPTIMAL FUEL ECONOMY AND WEAR PROTECTION THROUGH LUBRICANT DESIGN Dean Clarke, Isabella Goldmints, Jorge Manes, Katherine Richard
More informationExperimental Research on the Impact of Lubricating Oils on Engine. Friction and Vehicle Fuel Economy
3rd International Conference on Material, Mechanical and Manufacturing Engineering (IC3ME 2015) Experimental Research on the Impact of Lubricating Oils on Engine Friction and Vehicle Fuel Economy Yimin
More informationOlson-EcoLogic Engine Testing Laboratories, LLC
Olson-EcoLogic Engine Testing Laboratories, LLC Fuel Economy Comparison TEST REPORT With Toyota and Hyundai Automobiles When Tested Over the CARB Approved AMA Road Test Cycle For: SaviCorp 2530 South Birch
More informationTHERMOELECTRIC SAMPLE CONDITIONER SYSTEM (TESC)
THERMOELECTRIC SAMPLE CONDITIONER SYSTEM (TESC) FULLY AUTOMATED ASTM D2983 CONDITIONING AND TESTING ON THE CANNON TESC SYSTEM WHITE PAPER A critical performance parameter for transmission, gear, and hydraulic
More information76th UNECE GRPE session
Submitted by the IWG on PMP Informal document GRPE-74-33 76 th GRPE, 11-12 January 2018 Agenda item 7 76th UNECE GRPE session PMP IWG Progress Report Geneva, 10 th -11 th January 2018 UNITED NATIONS PMP
More informationCASE STUDY 1612B FUEL ECONOMY TESTING
CASE STUDY 1612B FUEL ECONOMY TESTING INCREASE IN FUEL ECONOMY BY CLEANING THE FUEL SYSTEM AND BOOSTING CETANE THIRD PARTY THE OHIO STATE UNIVERSITY CENTER FOR AUTOMOTIVE RESEARCH TEST SUBJECT 2006 FREIGHTLINER
More informationStudy of Fuel Economy Standard and Testing Procedure for Motor Vehicles in Thailand
Study of Fuel Economy Standard and Testing Procedure for Motor Vehicles in Thailand MR.WORAWUTH KOVONGPANICH TESTING MANAGER THAILAND AUTOMOTIVE INSTITUTE June 20 th, 2014 Overview Background Terminology
More informationGaseous Fuels in Transportation -- Prospects and Promise
Gaseous Fuels in Transportation -- Prospects and Promise Dr. James J. Eberhardt, Director U.S. Department of Energy Presented at the Gas Storage Workshop Kingston, Ontario, Canada July 11-12, 2001 OHVT
More informationVT2+: Further improving the fuel economy of the VT2 transmission
VT2+: Further improving the fuel economy of the VT2 transmission Gert-Jan Vogelaar, Punch Powertrain Abstract This paper reports the study performed at Punch Powertrain on the investigations on the VT2
More informationLubricants Development to Meet Fuel Economy & Reduction on CO 2 Emission on Light & Heavy Duty Diesel Vehicles
Lubricants Development to Meet Fuel Economy & Reduction on CO 2 Emission on Light & Heavy Duty Diesel Vehicles Dr. Mathew Abraham Mahindra & Mahindra Ltd., India Drivers for Vehicle Design Regulatory Sustainability
More informationContribution of Gasoline Particulate Filter (GPF) and Lubricant to the TGDi System Solution
Contribution of Gasoline Particulate Filter (GPF) and Lubricant to the TGDi System Solution Dr Ian Bell April 2018 Outline GPFs: The need for change What is a GPF? Engine Oil: Part of the solution Lubricant
More informationMODELING ENGINE FRICTION WITH TEMPERATURE DEPENDENCE FOR VEHICLE THERMAL MANAGEMENT
MODELING ENGINE FRICTION WITH TEMPERATURE DEPENDENCE FOR VEHICLE THERMAL MANAGEMENT Roberto Rastelli, Xiaobing Liu BorgWarner Inc. Brad Tillock EngSim Corporation Objective and Approach Simulation and
More informationPower Pack Testing at Environment Canada s Testing Facilities Heavy-Duty Vehicle and Engine Greenhouse Gas Emission Regulations
Power Pack Testing at Environment Canada s Testing Facilities Heavy-Duty Vehicle and Engine Greenhouse Gas Emission Regulations San Francisco, CA, USA October 22, 2013. Outline Background Heavy-Duty Vehicle
More informationReport On Sequence IVB Evaluation Version. Conducted For. NR = Non-reference oil test RO = Reference oil test
Report On Evaluation Version Conducted For V = Valid I = Invalid N = Results cannot be interpreted as representative of oil performance (Nonreference oil) and shall not be used for multiple test acceptance
More informationWorld Light duty Test Procedures: Fiction or Reality?
World Light duty Test Procedures: Fiction or Reality? Philippe Jean Head of Unit Sustainable Mobility and Automotive Industry DG Enterprise and Industry Brussels, 6 May 2015 World Light duty Test Procedures
More informationOn-Going Development of Heavy-Duty Vehicle GHG / Fuel Economy Standards
On-Going Development of Heavy-Duty Vehicle GHG / Fuel Economy Standards Rachel Muncrief October 10, 2012 Resources for the Future 1616 P Street NW, Washington DC Geographic Scope: Top Vehicle Markets Top
More informationGeorgia Tech Sponsored Research
Georgia Tech Sponsored Research Project E-20-F73 Project director Pearson James Research unit Title GEE Automotive Exhaust Analysis fo Additive Project date 8/9/2000 Automotive Exhaust Analysis for a New
More informationA Fast Track to Group III Base Oils
A Fast Track to Group III Base Oils 14 June 2011 ICIS Asian Base Oils and Lubricants Conference - Seoul, Republic of Korea Harry Kwon Marketing Manager Contents 1. Engine Oil Future Trend 2. Base Oil Future
More informationApplications and Impact of ACEA and European Passenger Car OEM Specifications in Asia Pacific
Applications and Impact of ACEA and European Passenger Car OEM Specifications in Asia Pacific RICHARD VAN DEN BULK RICHARD HOGENDOORN JEROEN VAN LEEUWEN GARY PARSONS CHEN GANG PRESHIT DALVI Agenda ACEA
More informationHeavy-Duty Vehicle GHG Regulatory Developments Around the World
Heavy-Duty Vehicle GHG Regulatory Developments Around the World Opportunities and Challenges of Moving Towards Global Alignment Ben Sharpe! Heavy Duty Vehicle GHG and Fuel Efficiency in Canada Conference
More informationDOC design & sizing using GT-SUITE European GT Conference Gauthier QUENEY 09/10/2017
DOC design & sizing using GT-SUITE European GT Conference 2017 Gauthier QUENEY 09/10/2017 Background Simulation tool target Predict exhaust outlet emissions Thermal modeling Chemical modeling This presentation
More informationMarch th session March 16 18, 2011, Ann Arbor, USA
March 2011 HDH informal working group HDH informal working group 5 th session March 16 18, 2011, Ann Arbor, USA Hybrid Powertrain Testing Overview Presentation of Hybrid System Development Potential Test
More informationStudy of Fuel Oxygenate Effects on Particulates from Gasoline Direct Injection Cars
ENVIRONMENTAL SCIENCE FOR THE EUROPEAN REFINING INDUSTRY Study of Fuel Oxygenate Effects on Particulates from Rod Williams Corrado Fittavolini Cambridge Particle Meeting June 27, 2014 Background It is
More informationUSING ENGINE OIL TO IMPROVE FUEL ECONOMY
USING ENGINE OIL TO IMPROVE FUEL ECONOMY Everything you need to know about HTHS viscosity Brian Humphrey, OEM Technical Liaison - HD Driveline, Petro-Canada Lubricants 1 CONTENT OUTLINE 1. What is HTHS
More informationA new methodology for the experimental evaluation of organic friction reducers additives in high fuel economy engine oils. M.
A new methodology for the experimental evaluation of organic friction reducers additives in high fuel economy engine oils M. Lattuada Outline CO 2 emission scenario Engine oil: contribution to fuel economy
More informationProgress Report DTP Subgroup Lab Process Internal Combustion Engines (LabProcICE) Geneva,
Progress Report Lab Process Internal Combustion Engines () Geneva, 08.06.2011 slide 1 Overview 1) State of the working progress 2) issues on DTP level 3) Work in progress items / proposals / open issues
More informationTechnology and policy drivers of the fuel economy of new light-duty vehicles Comparative analysis across selected automotive markets
Technology and policy drivers of the fuel economy of new light-duty vehicles Comparative analysis across selected automotive markets Pierpaolo Cazzola, International Energy Agency Content GFEI and the
More informationEmissions Characterization for D-EGR Vehicle
Emissions Characterization for D-EGR Vehicle Cary Henry Advance Science. Applied Technology Baseline GDI Vehicle 2012 Buick Regal GS Buick Regal GS uses state-of-the-art turbocharged, direct-injected gasoline
More informationThe following report discusses effect on HTHS Viscosity of Proton's Engine Oils by addition of X-1R Engine Treatment.
Technical Report The following report discusses effect on HTHS Viscosity of 's s by addition of X-1R Engine. Introduction: Oxidation stability is a chemical reaction that occurs with a combination of the
More informationSequence VH Report Forms Version Conducted For
Report Forms Version Conducted For V = Valid I = Invalid N = Results cannot be interpreted as representative of oil performance (Non-Reference Oil) and shall not be used in determining an average test
More informationEngine Oil Requirements for Volkswagen s Light Duty Diesel Engines Dr.-Ing. Sven-Oliver Kossmehl, VOLKSWAGEN AG
Engine Oil Requirements for Volkswagen s Light Duty Diesel Engines Dr.-Ing. Sven-Oliver Kossmehl, VOLKSWAGEN AG Clean Diesel Engines for the North American Market Motivation/Targets: Very low fuel consumption
More informationSetting the Standard in Oil Filtration Keep It Clean! & Keep It Green!
Setting the Standard in Oil Filtration Keep It Clean! & Keep It Green! Oil Characteristics Oil does not wear out It oxidizes during the combustion process It becomes contaminated due to high temperatures,
More informationSHELL ROTELLA CK-4 AND FA-4 DELIVERING THE NEXT GENERATION OF HEAVY DUTY ENGINE OILS.
SHELL ROTELLA CK-4 AND FA-4 DELIVERING THE NEXT GENERATION OF HEAVY DUTY ENGINE OILS. www.alliedoil.com 2 CATEGORY: 1. What is changing? The Environmental Protection Agency (EPA), the National Highway
More informationSystem Analysis of the Diesel Parallel Hybrid Vehicle Powertrain
System Analysis of the Diesel Parallel Hybrid Vehicle Powertrain Kitae Yeom and Choongsik Bae Korea Advanced Institute of Science and Technology ABSTRACT The automotive industries are recently developing
More informationNVH vs. Vehicle Fuel Economy Trade-off
NVH vs. Vehicle Fuel Economy Trade-off Mario Felice, Jack Liu, Imad Khan Ford Motor Company Jonathan Zeman, Llorenc Gomez Gamma Technologies Wulong Sun MSC Software Michael Platten Romax Technology 2015
More informationRDE DEVELOPMENT PROCESS & TOOLS
Daniel Baumann, IT RDE DEVELOPMENT PROCESS & TOOLS Kieran McAleer SIMULATION LAB ROAD AVL Solutions (A comprehensive approach to RDE) Kieran McAleer 9th AVL Calibration Symposium 4 11 월 215 2 Road Testing
More informationVehicle Performance. Pierre Duysinx. Research Center in Sustainable Automotive Technologies of University of Liege Academic Year
Vehicle Performance Pierre Duysinx Research Center in Sustainable Automotive Technologies of University of Liege Academic Year 2015-2016 1 Lesson 4: Fuel consumption and emissions 2 Outline FUEL CONSUMPTION
More informationWorld Light Duty Test Procedure
World Light Duty Test Procedure Validation-2 i 2S Summary &W Way Forward Presentation from India 03 rd - 04 th Dec, 15 th DHC Meeting Brussels, Belgium. Validation 2 Results on Class I / II Vehicles 2
More informationV-CAP TM A FEV VIRTUAL POWERTRAIN CALIBRATION PLATFORM
V-CAP T A FEV VITUAL POWETAIN CALIBATION PLATFO V-CAP T TEST CENTES VITUAL POWETAIN CALIBATION PLATFO V-CAP T VITUAL POWETAIN CALIBATION PLATFO VITUAL TEST BED, EAL ESULTS: A SOLUTION FO PASSENGE CA AND
More informationLubrication Needs for Next Generation Gasoline Passenger Car Engine Technology
Lubrication Needs for Next Generation Gasoline Passenger Car Engine Technology V Simpósio de Lubrificantes, Aditivos e Fluidos São Paulo, Brasil, October 24, 2012 Ravi Tallamraju Passenger Car Motor Oil
More informationApplication Note #1013 Measuring the Behavior of Brake Materials More Efficiently: Correlation Between Benchtop and Dynamometer Tests
Deceleration Test Brake Material Screening Tester UMT TriboLab Application Note #1013 Measuring the Behavior of Brake Materials More Efficiently: Correlation Between Benchtop and Dynamometer Tests Testing
More informationThin. Not Too. Thick, Around the world. What Viscosity Index Improvers Can Do for ATFs. November/December 2008 Number 10. By Bill Dimitrakis
November/December 2008 Number 10 Not Too Thick, Not Too Thin What Viscosity Index Improvers Can Do for ATFs By Bill Dimitrakis Around the world there is increasing focus on conserving energy and reducing
More informationApproach for determining WLTPbased targets for the EU CO 2 Regulation for Light Duty Vehicles
Approach for determining WLTPbased targets for the EU CO 2 Regulation for Light Duty Vehicles Brussels, 17 May 2013 richard.smokers@tno.nl norbert.ligterink@tno.nl alessandro.marotta@jrc.ec.europa.eu Summary
More informationFuel Economy, ACEA 2016 and other challenges for European Passenger Car Oils Richard van den Bulk
Fuel Economy, ACEA 2016 and other challenges for European Passenger Car Oils Richard van den Bulk Presented at UNITI, Stuttgart, April 5 th, 2017 2017Chevron Oronite. Agenda Key drivers for European Specs
More informationAnalytical and Experimental Evaluation of Cylinder Deactivation on a Diesel Engine. S. Pillai, J. LoRusso, M. Van Benschoten, Roush Industries
Analytical and Experimental Evaluation of Cylinder Deactivation on a Diesel Engine S. Pillai, J. LoRusso, M. Van Benschoten, Roush Industries GT Users Conference November 9, 2015 Contents Introduction
More information2018 HORIBA, Ltd. All rights reserved. 1
2018 HORIBA, Ltd. All rights reserved. 1 HORIBA Ltd, Automotive Measurement R&D Dept. Shun Fukami Development Tools for Advanced On-Board Emissions Measurements of NMHC and Particulates, Plus a Coaching
More informationPEMS Testing of Porsche Model Year 2018 Vehicles
PEMS Testing of Porsche Model Year 18 Vehicles Report Pursuant to Paragraph 33.e and Paragraph 33.f of the DOJ and California Third Partial Consent Decree Version: Final Report Date: 11/12/18 Project:
More informationWLTP PEV Range test procedure : End of test criteria
WLTP PEV Range test procedure : End of test criteria PROPRIÉTÉ RENAULT Content 1. Present situation in GTR draft 2. Problem with Light commercial vehicle 3. Possible solutions 4. Proposal from ACEA PROPRIÉTÉ
More informationMnI Diesel, LLC MnI Maintenance, LLC. Setting the Standard in Oil Filtration Keep It Clean! & Keep It Green!
MnI Diesel, LLC MnI Maintenance, LLC Setting the Standard in Oil Filtration Keep It Clean! & Keep It Green! Oil Characteristics Oil does not wear out It oxidizes during the combustion process It becomes
More informationHigh Octane Fuels, Making Better use of Ethanol
High Octane Fuels, Making Better use of Ethanol Brian West Fuels, Engines, and Emissions Research Center EESI High-Octane Fuels Briefing Washington, DC November 13, 2017 Work supported by DOE Office of
More informationDEVELOPMENT OF A DRIVING CYCLE FOR BRASOV CITY
DEVELOPMENT OF A DRIVING CYCLE FOR BRASOV CITY COVACIU Dinu *, PREDA Ion *, FLOREA Daniela *, CÂMPIAN Vasile * * Transilvania University of Brasov Romania Abstract: A driving cycle is a standardised driving
More informationLubricants for a Healthier Planet
Lubricants for a Healthier Planet Made in the USA SKU 0255 800.527.9439 Effects of Viscosity on Overall Pump Efficiency Poor Volumetric Efficiency (area above purple line is internal pump leakage) Lubricants
More informationOlson-EcoLogic Engine Testing Laboratories, LLC
Olson-EcoLogic Engine Testing Laboratories, LLC ISO 9001:2008 Registered A White Paper Important Planning Considerations for Engine and/or Vehicle Emission Testing Objectives Including Fuel Economy and
More informationStatus report of the WLTP Informal Working Group
Submitted by the Chair of the WLTP IWG Informal document GRPE-71-24 71st GRPE, 8-12 June 2015, agenda item 3(b) Status report of the WLTP Informal Working Group Report to the 71st GRPE session by Stephan
More informationEPA Advanced Technologies
Clean Automotive Technology Innovation that Works EPA Advanced Technologies China November 2004 Charles L. Gray, Jr. Advanced Technology Division Office of Transportation and Air Quality World Crude Oil
More informationCopyright Statement FPC International, Inc
Copyright Statement All rights reserved. All material in this document is, unless otherwise stated, the property of FPC International, Inc. Copyright and other intellectual property laws protect these
More informationAPI Engine Oil Licensing and Certification System. API Lubricants Group November 2012
API Engine Oil Licensing and Certification System API Lubricants Group November 2012 1 Engine Oil Program Participation As of 11/5/2012 538 licenses in 56 countries 3 Africa 196 Asia 28 Central America
More informationOlson-EcoLogic Engine Testing Laboratories, LLC
Olson-EcoLogic Engine Testing Laboratories, LLC Fuel Economy Comparison TEST REPORT With Kia and Hyundai Automobiles When Tested Over the CARB Approved AMA Road Test Cycle For: SaviCorp 2530 South Birch
More informationProven custom solutions from a leader in ATF viscometrics. Evonik shifts fuel economy into high gear
Proven custom solutions from a leader in ATF viscometrics Evonik shifts fuel economy into high gear VISCOPLEX viscosity index improvers and DRIVON technology Evonik sees the big picture driving fuel efficiency,
More informationLow Temperature Aftertreatment for Future Engines Challenges and Opportunities
Low Temperature Aftertreatment for Future Engines Challenges and Opportunities Is it needed? Is high possible?? Is it affordable??? Kushal Narayanaswamy Propulsion Systems Research Lab General Motors Global
More informationDevelopment of the Japan s RDE (Real Driving Emission) procedure
Informal document GRPE-76-18 76 th GRPE, 9-12 January 2018 Agenda item 13 Development of the Japan s RDE (Real Driving Emission) procedure Environmental Policy Division, Road Transport Bureau, Ministry
More informationEPA Heavy Duty Vehicle Emissions Program
EPA Heavy Duty Vehicle Emissions Program Cheryl L. Bynum Team Lead, Technology and Fuels US EPA SmartWay Transport Partnership ICCT/NESCCAF Workshop: Improving Fuel Economy of Heavy Duty Fleets II 20 February
More informationRDE PN emissions from a GDI vehicle without and with a GPF
RDE PN emissions from a GDI vehicle without and with a GPF Dr. Joachim Demuynck IQPC 4 th international conference on RDE Berlin, 25-27 October 2016 Association for Emissions Control by Catalyst (AECC)
More informationTechnologies for Euro 4 and higher emissions standards - International experiences and recommendations. Zifei Yang
Euro 4 emission standard and labelling for manufactured, assembled and imported cars workshop July 26, 2017 Hanoi, Vietnam Technologies for Euro 4 and higher emissions standards - International experiences
More informationDriving Efficiency In Commercial Vehicle Engine Lubricants. Nigel Britton, Technical Manager
Driving Efficiency In Commercial Vehicle Engine Lubricants Nigel Britton, Technical Manager 5 th April 2017 Topics The drivers for greater efficiency in heavy duty commercial vehicles Why fuel economy
More informationNon-Obvious Relational Awareness for Diesel Engine Fluid Consumption
Non-Obvious Relational Awareness for Diesel Engine Fluid Consumption Brian J. Ouellette Technical Manager, System Performance Analysis Cummins Inc. May 12, 2015 2015 MathWorks Automotive Conference Plymouth,
More informationEnvironmental Technology Verification Will This Thing Really Work? Douglas VanOsdell RTI Texas Technology Showcase
Environmental Technology Verification Will This Thing Really Work? Douglas VanOsdell RTI Texas Technology Showcase Overview Introduction What is ETV? Status of Mobile Sources ETV Decisions, Decisions Lots
More informationReducing GHG Emissions from Cars and Light Trucks
Reducing GHG Emissions from Cars and Light Trucks John German American Honda Motor Co. NAMVECC November 3, 2003 GHG from Vehicles GHG emissions a function of fuel burned Gasoline & diesel fuel are about
More informationProgress at LAT. October 23, 2013 LABORATORY OF APPLIED THERMODYNAMICS
LABORATORY OF APPLIED THERMODYNAMICS October 23, 2013 Progress at LAT ARISTOTLE UNIVERSITY THESSALONIKI SCHOOL OF ENGINEERING DEPT. OF MECHANICAL ENGINEERING 1 Contents Vehicle selection Incl. vehicles
More informationGroup III Base Stock Technology and Performance
Group III Base Stock Technology and Performance ICIS Conference, London February 24 th 2011 Y R Cho M G Brown J Z Trocki Agenda SK Lubricants Introduction Group III Base Stocks Manufacturing Processes
More informationLITENS ADVANCED THERMAL MANAGEMENT SOLUTIONS FOR IMPROVING ENGINE WARM-UP AND FUEL ECONOMY
LITENS ADVANCED THERMAL MANAGEMENT SOLUTIONS FOR IMPROVING ENGINE WARM-UP AND FUEL ECONOMY Jason Zheng, Noel Abreu, Bin Cheng Litens Automotive Partnership Company Logo Here Outline Introduction Litens
More informationANALYTICAL EVALUATION OF ENGINE AND VEHICLE HARDWARE EFFECTS ON VEHICLE RESPONSE. Drew Raftopoulos
ANALYTICAL EVALUATION OF ENGINE AND VEHICLE HARDWARE EFFECTS ON VEHICLE RESPONSE Drew Raftopoulos WHY IS TRANSIENT RESPONSE IMPORTANT? The focus on vehicle transient response has become important with
More informationFuel Properties and Vehicle Emissions. Emissions
Fuel Properties and Vehicle Emissions AVECC 24 at Beijing, April 26-28, 28, 24 Yasunori TAKEI Fuel & Lubricant committee Japan Automobile Manufacturers Association Automobiles and the Environment Global
More informationCRC Project No. CM-136
1 CRC Project No. CM-136 136-09-1B Engine Durability Study of Mid-Level Ethanol Blends Mid-Level Ethanol Research Coordination Group Meeting May 5, 2010 Presented by Coleman Jones, GM Jaime Dettore, Henning
More informationTest Method D5967 Mack T-8. Version. Method: Conducted For
Method D5967 Mack T-8 Version Method: Conducted For T-8A: T-8: T-8E: V = Valid I = Invalid N = Not Interpretable The Reference Oil/Non-Reference Oil was evaluated in accordance with the test procedure.
More informationModeling the Electrically Assisted Variable Speed (EAVS) Supercharger
Modeling the Electrically Assisted Variable Speed (EAVS) Supercharger Eaton Corporation Vehicle Group Brian Smith Brandon Biller Overview of EAVS Technology 2 EAVS System Development at Eaton Hardware
More informationVehicle Simulation for Engine Calibration to Enhance RDE Performance
Vehicle Simulation for Engine Calibration to Enhance RDE Performance IPG Apply & Innovate 2018 11st and 12nd of September, Karlsruhe, Germany Dr. Yutaka Murata Yui Nishio Dr. Yukihisa Yamaya Masato Kikuchi
More informationDevelopment of Two-stage Electric Turbocharging system for Automobiles
Development of Two-stage Electric Turbocharging system for Automobiles 71 BYEONGIL AN *1 NAOMICHI SHIBATA *2 HIROSHI SUZUKI *3 MOTOKI EBISU *1 Engine downsizing using supercharging is progressing to cope
More informationASIAN & EUROPEAN WLTP RRT
WLTP 19th / JARI-UTAC ASIAN & EUROPEAN WLTP RRT Geneva, 6th of June 2017 JARI / UTAC Takahiro HANIU / Céline VALLAUDE WLTP 19th / JARI-UTAC Objectives Check the understanding and the application of the
More informationSuperior Performance. VISCOPLEX ADDITIVES FOR MOBILE HYDRAULIC EQUIPMENT
Superior Performance. VISCOPLEX ADDITIVES FOR MOBILE HYDRAULIC EQUIPMENT AGRICULTURE CONSTRUCTION MINING FORESTRY In the field of agriculture, equipment can be a cost driver and the lifeblood for operation.
More informationDetails RDE Legislation Europe. Speaker: Nikolas Kühn June 27th ECMA
Details RDE Legislation Europe Speaker: Nikolas Kühn June 27th 2017 - ECMA 1 Starter A not to serious but quite interesting statement (quote from a German radiobroadcast show around 2010): If, from the
More informationDiesel Fleet Fuel Economy in Stop-and-Go City Driving Conditions
Field Study Diesel Fleet Fuel Economy in Stop-and-Go City Driving Conditions In two scenarios, AMSOIL synthetic lubricants increased fuel economy compared to conventional lubricants. Engine oil alone:
More informationWind Turbine Gear Lubricants
October 2015 Wind Turbine Gear Lubricants PCIMA TIR: External 2 JLPrince 2015 Exxon Mobil Corporation. All rights reserved. Overview Wind Turbine Gear boxes Challenges and Lubrication Impact Lubricant
More informationAdvanced Catalyst Systems for HDD On-Road BS VI and Off-Road Trem IV
ECMA 11 th International Conference & Exhibition - 2018, Pune, India, Oct. 25-26, 2018 Advanced Catalyst Systems for HDD On-Road BS VI and Off-Road Trem IV Weiyong Tang, Ph.D. Mobile Emissions Catalysts
More informationLubricants Group eballot on Revised Seq. IIIH to Seq. IIIG Equivalency in ILSAC GF-5
To: API Lubricants Group Cc: Lubricants Group Mailing List API Lubricants Group eballot on Revised Seq. IIIH to Seq. IIIG Equivalency in ILSAC GF-5 At the May 10, 2017 Lubricants Group meeting a revision
More informationAECC/Concawe 2016 GPF RDE PN Test Programme: PN Measurement Above and Below 23nm
AECC/Concawe 2016 GPF RDE PN Test Programme: PN Measurement Above and Below 23nm Jon Andersson 1, Joachim Demuynck 2, Heather Hamje 3 (1) Ricardo UK; (2) AECC; (3) Concawe June 19th - 22nd, 2017, ETH Zurich,
More informationNOx reduction effect on CO 2. NOX Reductions are achievable without significant penalties in CO 2
NOx reduction effect on CO 2 NOX Reductions are achievable without significant penalties in CO 2 Source (ICCT): http://www.theicct.org/sites/default/files/publications/euro-viversus-6_icct_briefing_06012017.pdf
More informationProject 16FT1: Simulation, Rheology and Efficiency of Polymer Enhanced Solutions
Marquette University Milwaukee School of Engineering Purdue University University of California, Merced University of Illinois, Urbana-Champaign University of Minnesota Vanderbilt University Project 16FT1:
More informationEPA Registration. 1. Attached is the EPA letter confirming the registration of the MPG-CAPS.
EPA Registration 1. Attached is the EPA letter confirming the registration of the MPG-CAPS. 2. Registration # is 218820001, 218820002, 218820003, 218820004 21882005. 3. Please note that the EPA does not
More informationTesting and Evaluation Challenges of Electrified Vehicles
Testing and Evaluation Challenges of Electrified Vehicles Henning Lohse-Busch, Ph.D. APRF (Advanced Powertrain Research Facility) emobility in the USA Hannover, Germany April 6 th, 2011 Disclaimer This
More informationADVANCEMENTS IN POWERTRAIN TEST ENVIRONMENT DELIVERING PRODUCTIVITY THROUGH STRATEGIC CHOICE OF TEST ENVIRONMENT
DELIVERING PRODUCTIVITY THROUGH STRATEGIC CHOICE OF TEST ENVIRONMENT Dr. Philip Lawson & Sulabh Dhingra 28 Jun 2018 AVL Product Development in Motion Outline Why? What? How? Motivations Brief history of
More informationFE151 Aluminum Association Inc. Impact of Vehicle Weight Reduction on a Class 8 Truck for Fuel Economy Benefits
FE151 Aluminum Association Inc. Impact of Vehicle Weight Reduction on a Class 8 Truck for Fuel Economy Benefits 08 February, 2010 www.ricardo.com Agenda Scope and Approach Vehicle Modeling in MSC.EASY5
More informationFLEET MAINTENANCE COUNCIL
SHELL LUBRICANTS PRESENTATION FOR: FLEET MAINTENANCE COUNCIL October 17, 2017 Milwaukee, WI 1 Introduction/Safety Safety No planned fire drills today Exit is Introduction Doug Peterson Transport Business
More informationCertification Procedures for Advanced Technology Heavy-Duty Vehicles. Evaluating Test Methods and Opportunities for Global Alignment
Working Paper No. HDH-09-04 (9th HDH meeting, 21 to 23 March 2012) Certification Procedures for Advanced Technology Heavy-Duty Vehicles Evaluating Test Methods and Opportunities for Global Alignment Ben
More informationSmart Emissions Reducer Test Results
Smart Emissions Reducer Test Results Testing Performed by: Roush Industries, Inc Livonia, MI Vehicles Tested: 2005 Chevrolet Silverado 2500 2005 Dodge Ram 2500 HD 2004 Ford Passenger Van E-150 Testing
More information