SECTION 6 3 SERVICE PROCEDURES AND SPECIFICATIONS. Chassis
|
|
- Elinor Lynch
- 6 years ago
- Views:
Transcription
1 SERVICE PROCEDURES AND SPECIFICATIONS Chassis SECTION 6 3 Specifications Checking brake fluid Checking power steering fluid Checking tire pressure Rotating tires Checking and replacing tires Installing snow tires and chains Replacing wheels Aluminum wheel precautions
2 SPECIFICATIONS AUTOMATIC TRANSMISSION Fluid capacity Drain and refill Fluid type 1.9 L (2.0 qt., 1.7 Imp.qt.) Automatic transmission fluid Type T II or equivalent DIFFERENTIAL Oil capacity Oil type Oil viscosity 1.3 L (1.4 qt., 1.1 Imp.qt.) Hypoid gear oil API GL 5 Above 18 C (0 F): SAE 90 Below 18 C (0 F): SAE 80W or SAE 80W 90 BRAKES Pedal clearance Pedal freeplay Brake pad wear limit Parking brake lining wear limit Parking brake adjustment Fluid type 70 mm (2.8 in.) Min. 1 6 mm ( in.) Front: 3.0 mm (0.12 in.) Rear: 2.5 mm (0.10 in.) 1.0 mm (0.04 in.) 5 7 clicks SAE J1703 or FMVSS No. 116 DOT 3 208
3 STEERING Freeplay Power steering fluid Less than 30 mm (1.2 in.) Automatic transmission fluid DEXRON II TIRES AND WHEELS Tire size Tire inflation pressure Recommended cold tire inflation pressure Vehicle load up to four occupants Vehicle loaded up to vehicle capacity weight Wheel size Wheel nut torque P225/ 60R16 97V Front Rear 200 kpa (2.0 kgf/cm 2 or bar, 29 psi) 200 kpa (2.0 kgf/cm 2 or bar, 29 psi) Front 220 kpa (2.2 kgf/cm 2 or bar, 32 psi) Rear 220 kpa (2.2 kgf/cm 2 or bar, 32 psi) For sustained high speeds above 160 km/h (100 mph), in countries where such speeds are permitted by law, add 80 kpa (0.9 kgf/cm 2, 0.8 bar, 12 psi) to the front tires and rear tires, but never exceed the maximum cold tire pressure molded on the tire sidewall. 16 x 7 JJ 103 N. m (10.5 kgf. m, 76 ft. lb.) 209
4 CHECKING BRAKE FLUID CAUTION Take care when filling the reservoir because brake fluid can harm your eyes and damage painted surfaces. If fluid gets in your eyes, flush your eyes with clean water. NOTICE (For vehicles with traction control system only): Idle the engine while pouring brake fluid into the reservoir. To check the fluid level, simply look at the see through reservoir. The level should be between the MAX and MIN lines on the tank. It is normal for the brake fluid level to go down slightly as the brake pads wear. So be sure to keep the reservoir filled. If the reservoir needs frequent refilling, it may indicate a serious mechanical problem. If the level is low, add FMVSS No.116 DOT 3 or SAEJ1703 brake fluid to the brake reservoir. Remove and replace the reservoir cover by hand. Add brake fluid up to the MAX line. Use only newly opened brake fluid. Once opened, brake fluid absorbs moisture from the air, and excess moisture can cause a dangerous loss of braking efficiency. 210
5 CHECKING POWER STEERING FLUID Check the fluid level on the dipstick. If necessary, add automatic transmission fluid DEXRON II. If the vehicle has been driven around 80 km/h (50 mph) for 20 minutes (a little more in frigid temperatures), the fluid is hot (60 C 80 C or 140 F 175 F). You may also check the level when the fluid is cold (about room temperature, 10 C 30 C or 50 F 85 F) if the engine has not been run for about five hours. 1 If cold O.K. 2 lf hot O.K. 3 Add fluid 1. Clean all dirt off the reservoir. 2. Remove the filler cap by turning it counterclockwise and wipe the dipstick clean. 3. Reinstall the filler cap. 4. Remove the filler cap again and look at the fluid level. If the fluid is cold, the level should be in the COLD range on the dipstick. Similarly, if it is hot, the fluid level should be in the HOT range. If the level is at the low side of either range, add automatic transmission fluid DEXRON II to bring the level within the range. 5. After replacing the filler cap, visually check the steering box case, vane pump and hose connections for leaks or damage. 211
6 CAUTION CHECKING TIRE PRESSURE The reservoir may be hot so be careful not to burn yourself. NOTICE Avoid overfilling, or the power steering could be damaged. When adding the power steering fluid, avoid spilling it. The generator under the power steering reservoir could be damaged if fluid is spilled on it. The recommended cold tire pressures, tire size and the vehicle capacity weight are given on the label inside the glovebox lid. You should check the tire pressures every two weeks, or at least once a month. And don t forget the spare! The pressure for the spare tire should be 220 kpa (2.2 kgf/cm 2 or bar, 32 psi). Incorrect tire pressure can reduce tire life and make your vehicle less safe to drive. Low tire pressure results in excessive wear, poor handling, reduced fuel economy, and the possibility of blowouts from overheated tires. Also, low tire pressure can cause poor sealing of the tire bead. If the tire pressure is excessively low, there is the possibility of wheel deformation and/ or tire separation. So keep your tire pressures at the proper level. If a tire needs frequent refilling, have it checked by your Lexus dealer. 212
7 High tire pressure produces a harsh ride, handling problems, excessive wear at the center of the tire tread, and a greater possibility of tire damage from road hazards. The following instructions for checking tire pressure should be observed: The pressure should be checked only when the tires are cold. If your vehicle has been parked for at least 3 hours and has not been driven for more than 1.5 km or 1 mile since, you will get an accurate cold tire pressure reading. Always use a tire pressure gauge. The appearance of the tire can be misleading. Besides, tire pressures that are even just a few pounds off can degrade handling and ride. Do not bleed or reduce tire pressure after driving. It is normal for the tire pressure to be higher after driving. Never exceed the vehicle capacity weight. The passengers and luggage weight should be located so that the vehicle is balanced. Be sure to reinstall the tire valve caps. Without the valve caps, dirt or moisture could get into the valve core and cause air leakage. If the caps have been lost, have new ones put on as soon as possible. ROTATING TIRES To equalize tire wear and help extend tire life, Lexus recommends that you rotate your tires approximately every km (7500 miles). However, the most appropriate timing for tire rotation may vary according to your driving habits and road surface conditions. The wheel assemblies must be rotated as illustrated above. If the optional chrome plated wheels are mounted, rotate them as pattern A. For the standard wheels, use pattern B. When rotating tires, check for uneven wear and damage. Abnormal wear is usually caused by incorrect tire pressure, improper wheel alignment, out of balance wheels, or severe braking. Before storing radial, snow or studded tires, mark the direction of rotation and be sure to install them in the same direction when using them again. Tires should be stored in a cool dry place. 213
8 CHECKING AND REPLACING TIRES When to replace your tires 1 New tread 2 Tread wear indicator 3 Worn tread Replace the tires when the tread wear indicators show. The location of the tread wear indicators is shown by the TWI or marks molded on the sidewall of each tire. The tires on your Lexus have built in tread wear indicators to help you know when the tires need replacement. When the tread depth wears to 1.6 mm (0.06 in.) or less, the indicators will appear. If you can see the indicators in two or more adjacent grooves, the tire should be replaced. The effectiveness of snow tires is lost if the tread wears down below 4 mm (0.16 in.). If you have tire damage such as cuts, splits, cracks deep enough to expose the fabric, or bulges indicating internal damage, the tire should be replaced. If a tire often goes flat or cannot be properly repaired due to the size or location of a cut or other damage, it should be replaced. If you are not sure, consult with your Lexus dealer. If an air loss occurs while driving, do not continue driving with a deflated tire. Driving even a short distance can damage a tire beyond repair. Any tires which are over 6 years old must be checked by a qualified technician even if damage is not obvious. Tires deteriorate with age even if they have never or seldom been used. This also applies to the spare tire and tires stored for future use. 214
9 Uniform tire quality grading This information has been prepared in accordance with regulations issued by the National Highway Traffic Safety Administration of the U.S. Department of Transportation. It provides the purchasers and/ or prospective purchasers of Lexus vehicles with information on uniform tire quality grading. Your Lexus dealer will help answer any questions you may have as you read this information. DOT quality grades All passenger vehicle tires must conform to Federal Safety Requirements in addition to these grades. These quality grades are molded on the sidewall. Treadwear The treadwear grade is a comparative rating based on the wear rate of the tire when tested under controlled conditions on a specified government test course. For example, a tire graded 150 would wear one and a half (1 1/2) times as well on the government course as a tire graded 100. The relative performance of tires depends upon the actual conditions of their use, however, and may depart significantly from the norm due to variations in driving habits, service practices and differences in road characteristics and climate. Traction A, B, C The traction grades, from highest to lowest, are A, B and C, and they represent the tire s ability to stop on wet pavement as measured under controlled conditions on specified government test surfaces of asphalt and concrete. A tire marked C may have poor traction performance. Warning: The traction grade assigned to this tire is based on braking (straight ahead) traction tests and does not include cornering (turning) traction. Temperature A, B, C The temperature grades are A (the highest), B, and C, representing the tire s resistance to the generation of heat and its ability to dissipate heat when tested under controlled conditions on a specified indoor laboratory test wheel. Sustained high temperature can cause the material of the tire to degenerate and reduce tire life, and excessive temperature can lead to sudden tire failure. The grade C corresponds to a level of performance which all passenger car tires must meet under the Federal Motor Vehicle Safety Standard No Grades B and A represent higher levels of performance on the laboratory test wheel than the minimum required by law. Warning: The temperature grade of this tire established for a tire that is properly inflated and not overloaded. Excessive speed, underinflation, or excessive loading, either separately or in combination, can cause heat buildup and possible tire failure. 215
10 Tire selection When replacing a tire, use only the same size and construction as originally installed and with the same or greater load capacity. Using any other size or type of tire may seriously affect handling, ride, speedometer/ odometer calibration, ground clearance, and clearance between the body and tires or snow chains. Do not mix radial, belted, or conventional tires on your vehicle. It can cause dangerous handling characteristics, resulting in loss of control. If you need to change from conventional tires to radial tires or vice versa, replace them as a set. INSTALLING SNOW TIRES AND CHAINS When to use snow tires or chains Snow tires or chains are recommended when driving on snow or ice. On wet or dry roads, conventional or radial tires provide better traction than snow or studded tires. Snow tire selection If you need snow tires, select the same size, construction and load capacity as the original tires on your Lexus. Do not use tires other than stated above. Since your vehicle has radial tires as original equipment, make sure your snow tires also have radial construction. Do not install studded tires without first checking local regulations for possible restrictions. Snow tire installation Snow tires should be installed on all wheels. Installing snow tires on the rear wheels only can lead to an excessive difference in road grip capability between the front and rear tires which could cause loss of vehicle control. CAUTION Do not drive with the snow tires incorrectly inflated. Never drive over 120 km/h (75 mph) with any type of snow tires. 216
11 Tire chain selection Regulations regarding the use of tire chains vary according to location or type of road. Always check the local regulations before installing chains. Use SAE Class S type radial tire chains, with the exception of radial cable chains or V bar type chains. Chain installation Install the chains on the rear tires as tightly as possible. Do not use tire chains on the front tires. Retighten chains after driving km (1/4 1/2 mile). When installing chains on your tires, carefully follow the instructions of the chain manufacturer. CAUTION Do not exceed 50 km/h (30 mph) or the chain manufacturer s recommended speed limit, whichever is lower. Drive carefully avoiding bumps, holes, and sharp turns, which may cause the vehicle to bounce. Avoid sharp turns or locked wheel braking, as use of chains may adversely affect vehicle handling. REPLACING WHEELS When to replace your wheels If you have wheel damage such as bending, cracks or heavy corrosion, the wheel should be replaced. If you fail to replace damaged wheels, a tire may slip off a wheel or they may cause loss of handling control. Replacement with used wheels is not recommended as they may have been subjected to rough treatment or high mileage and could fail without warning. Also, bent wheels which have been straightened may have hidden structural damage and therefore should not be used. Never use an inner tube in a leaking wheel which is designed for a tubeless tire. Wheel selection When replacing wheels, care should be taken to ensure that they are equivalent to those removed in load capacity, diameter, rim width, and offset. Correct replacement wheels are available at your Lexus dealer. A wheel of a different size or type may adversely affect handling, wheel and bearing life, brake cooling, speedometer/ odometer calibration, stopping ability, headlight aim, bumper height, vehicle ground clearance, and tire or snow chain clearance to the body and chassis. 217
12 ALUMINUM WHEEL PRECAUTIONS After driving your vehicle the first 1600 km (1000 miles), check that the wheel nuts are tight. If you have rotated, repaired, or changed your tires, check that the wheel nuts are still tight after driving 1600 km (1000 miles). When using tire chains, be careful not to damage the aluminum wheels. Use only the Lexus wheel nuts and wrench designed for your aluminum wheels. When balancing your wheels, use only Lexus balance weights or equivalent and a plastic or rubber hammer. As with any wheel, periodically check your aluminum wheels for damage. If damaged, replace immediately. 218
SECTION 6 3 SERVICE PROCEDURES AND SPECIFICATIONS. Chassis
SECTION 6 3 SERVICE PROCEDURES AND SPECIFICATIONS Chassis Specifications 206 Checking brake fluid 208 Checking power steering fluid 209 Checking tire pressure 210 Rotating tires 211 Checking and replacing
More informationSECTION 6 3 SERVICE PROCEDURES AND SPECIFICATIONS. Chassis
SERVICE PROCEDURES AND SPECIFICATIONS Chassis SECTION 6 3 Specifications........................................... 204 Checking brake fluid...................................... 206 Checking brake pedal
More informationSECTION 6 3 SERVICE PROCEDURES AND SPECIFICATIONS. Chassis
SERVICE PROCEDURES AND SPECIFICATIONS Chassis SECTION 6 3 Specifications........................................... 178 Checking clutch pedal freeplay............................ 180 Checking brake and
More informationSECTION 6 3 SERVICE PROCEDURES AND SPECIFICATIONS. Chassis
SERVICE PROCEDURES AND SPECIFICATIONS Chassis SECTION 6 3 Specifications........................................... 174 Checking brake fluid...................................... 176 Checking brake pedal
More informationPart 7 DO IT YOURSELF MAINTENANCE
Part 7 DO IT YOURSELF MAINTENANCE Chapter 7 2 Engine and Chassis Checking the engine oil level Checking the engine coolant level Checking brake fluid Checking power steering fluid Checking tire pressure
More informationSECTION 8 2 DO IT YOURSELF MAINTENANCE. Chassis
DO IT YOURSELF MAINTENANCE Chassis SECTION 8 2 Checking the coolant level of the traction motor................ 184 Checking the radiator....................................... 185 Checking brake fluid........................................
More informationSECTION 7 2 DO IT YOURSELF MAINTENANCE MR2 U. Engine and Chassis
SECTION 7 2 DO IT YOURSELF MAINTENANCE Engine and Chassis Checking the engine oil level................................. 168 Checking the engine coolant level............................ 169 Checking brake
More informationTire Information. Example of a wear indicator mark
Tire Information Maintenance To safely operate your vehicle, your tires must be of the proper type and size, in good condition with adequate tread, and properly inflated. Inflation Guidelines Properly
More informationAbout Tires. Tire Function. Tire Size Designation For
About Tires Tire Function Over one hundred years' experience of tire technology has enabled Pirelli to combine in their products maximum levels of security, longevity, comfort and attention to the environment.
More informationTires. We recommend that you visually check your tires every day. If you think a tire might be low, check it immediately with a tire gauge.
To safely operate your vehicle, your tires must be the proper type and size, in good condition with adequate tread, and correctly inflated. The following pages give more detailed informationonhowandwhento
More informationWe recommend that you visually check your tires every day. If you think a tire might be low, check it immediately with a tire gauge.
To safely operate your car, your tires must be the proper type and size, in good condition with adequate tread, and correctly inflated. The following pages give more detailed information on how and when
More informationTire Pressures ! WARNING: Tire Information. Tire Pressures
R Tire Pressures Tire Information Tire Information Tires of the correct type, manufacture and dimensions, with correct cold inflation pressures are an integral part of every vehicle s design. Regular maintenance
More informationEverything Rides on It
Everything Rides on It tudies of tire safety show that maintaining proper tire pressure, observing tire and vehicle load limits (not carrying more weight in your vehicle than your tires or vehicle can
More informationTIRES AND WHEELS 22-1 TIRES AND WHEELS CONTENTS
ZJ TIRES AND WHEELS 22-1 TIRES AND WHEELS CONTENTS TIRES... 1 WHEELS... 7 TIRES INDEX DESCRIPTION AND OPERATION RADIAL-PLY TIRES... 2 REPLACEMENT TIRES... 3 SPARE TIRE TEMPORARY... 2 TIRE INFLATION PRESSURES...
More informationMaintenance data (fuel, oil level, etc.)
Maintenance data (fuel, oil level, etc.) Dimensions and weight Overall length Overall width Overall height * 1 Wheelbase Tread Vehicle capacity weight (Occupants + luggage) 2WD models AWD models Front
More informationConsumer information and Reporting safety defects
Consumer information and Reporting safety defects For U.S.A.... 13-2 Tire information... 13-2 Tire labeling... 13-2 Recommended tire inflation pressure... 13-4 Glossary of tire terminology... 13-5 Tire
More informationTire Care And Maintenance Guide
Tire Care And Maintenance Guide Highway Auto Tires Light Truck Tires TIRE CARE AND MAINTENANCE GUIDE The easiest way to help ensure satisfactory mileage and performance from your Dunlop tires is to give
More informationTyres OVERVIEW TYRE PRESSURES TYRE PRESSURES. R performance wheels
Tyres OVERVIEW Tyres of the correct type, manufacturer and dimensions, with correct cold inflation pressures are an integral part of every vehicle s design. Regular maintenance of tyres contributes not
More informationTires and wheels. Introduction
Tires and wheels Applicable only in the United States and Canada Introduction In this section you ll find information about: Tire and wheel handling Wheel rims Tire inflation pressure Tire inflation pressure
More informationSECTION 5 MAINTENANCE
SECTION 5 Maintenance requirements................................ 166 General maintenance..................................... 167 Does your vehicle need repairing?......................... 170 Scheduled
More informationMaintenance data (fuel, oil level, etc.)
752 Maintenance data (fuel, oil level, etc.) Dimensions and weight Overall length Overall width * 1 : Unladen vehicle * 2 : Vehicles with 265/35R19 tires 190.7 in. (445mm) 72.4 in. (140 mm) Overall height*
More informationTyres OVERVIEW TYRE PRESSURES
Tyres OVERVIEW Tyres of the correct type, manufacturer and dimensions, with correct cold inflation pressures are an integral part of every vehicle s design. Regular maintenance of tyres contributes not
More informationDOT Tire Quality Grading (U.S. Cars)
DOT Tire Quality Grading (U.S. Cars) The tires on your car meet all U.S. Federal Safety Requirements. All tires are also graded for treadwear, traction, and temperature performance according to Department
More information3 Protecting Your Xedos Vehicle FUEL REQUIREMENTS EMISSION CONTROL SYSTEM BEFORE DRIVING RUNNING-IN ECONOMICAL OPERATION SPECIAL DRIVING CONDITIONS LABEL INFORMATION 3-2 3-2 3-3 3-4 3-4 3-5 3-8 3-1 3-2
More informationTIRES AND WHEELS 22-1 TIRES AND WHEELS CONTENTS
PL TIRES AND WHEELS 22-1 TIRES AND WHEELS CONTENTS page page TIRES... 1 WHEELS... 8 TIRES INDEX page DESCRIPTION AND OPERATION RADIAL-PLY TIRES... 2 REPLACEMENT TIRES... 3 SPARE TIRE TEMPORARY... 2 TIRE
More informationI: INSPECT AND CLEAN, ADJUST, LUBRICATE OR REPLACE IF NECESSARY C: CLEAN A: ADJUST R: REPLACE L: LUBRICATE I: INSPECTION D: DIAGNOSE
2. Periodic Maintenance > Periodic Maintenance Chart XCITING 400i Maintenance Schedule Perform the pre-ride inspection (Owner's Manual) at each scheduled maintenance period. This interval should be judged
More informationMaintenance data (fuel, oil level, etc.)
Maintenance data (fuel, oil level, etc.) Dimensions and weights Overall length Overall width Overall height * 1 Wheelbase Tread Vehicle capacity weight (Occupants + luggage) Front Rear 189.0 in. (4800
More informationReturn To Main Table of Contents GENERAL... 2 STRUT ASSEMBLY LOWER ARM STABILIZER BAR CENTER MEMBER WHEEL AND TIRE...
FRONT SUSPENSION Return To Main Table of Contents GENERAL... 2 STRUT ASSEMBLY... 11 LOWER ARM... 13 STABILIZER BAR... 17 CENTER MEMBER... 19 WHEEL AND TIRE... 21 GENERAL GENERAL SPECIFICATIONS Suspension
More informationMaintenance and service
Maintenance and service Maintenance schedule... 11-3 Maintenance precautions... 11-3 Before checking or servicing in the engine compartment... 11-4 When checking or servicing in the engine compartment
More informationLight condition and operation Windshield glass condition Wiper blade condition Paint condition and corrosion Fluid leaks Door and hood lock condition
GENERAL CHECKS Engine Compartment The following should be checked regularly: Engine oil level and condition Transmission fluid level and condition Brake fluid level Clutch fluid level Engine coolant level
More informationMaintenance data (fuel, oil level, etc.)
Maintenance data (fuel, oil level, etc.) Dimensions and weights Overall length Overall width Overall height* 1 Wheelbase Tread Vehicle capacity weight (occupants + luggage) Front Rear Towing capacity (trailer
More information2001 IMPREZA SERVICE MANUAL QUICK REFERENCE INDEX
2001 IMPREZA SERVICE MANUAL QUICK REFERENCE INDEX CHASSIS SECTION FRONT SUSPENSION FS REAR SUSPENSION RS WT This service manual has been prepared to provide SUBARU service personnel with the necessary
More informationEngine oil. Introduction. Warning and indicator lights WARNING
Engine oil Introduction In this section you ll find information about: Warning and indicator lights Engine oil specifications Engine oil capacities Checking the engine oil level and adding oil Engine oil
More informationTyre Care & Safety for Agricultural Tires
Tyre Care & Safety for Agricultural Tires Operating Instructions Some Points Worth Remembering; The BKT Agricultural tires are designed for Agricultural tractors, Trailers & Implements. Before using them
More informationMaintenance data (fuel, oil level, etc.)
Maintenance data (fuel, oil level, etc.) Dimensions and weights Overall length Overall width Overall height * 1 Wheelbase Tread Vehicle capacity weight (Occupants + luggage) Front Rear Trailer weight rating
More informationSECTION 3 2 STARTING AND DRIVING. Driving tips
STARTING AND DRIVING Driving tips SECTION 3 2 Break-in period.......................................... 140 Operation in foreign countries............................. 140 Tips for driving in various conditions........................
More informationLimited Warranty. Highway Auto Tires Light Truck Tires
Limited Warranty Highway Auto Tires Light Truck Tires DUNLOP LIMITED WARRANTY HIGHWAY AUTO AND LIGHT TRUCK REPLACEMENT AND ADJUSTMENT POLICY WHO IS ELIGIBLE? You are eligible for the benefits of this Limited
More informationMaintenance and service
Maintenance and service Maintenance schedule... 11-3 Maintenance precautions... 11-3 Before checking or servicing in the engine compartment... 11-4 When checking or servicing in the engine compartment
More informationMaintenance data (fuel, oil level, etc.)
Maintenance data (fuel, oil level, etc.) Dimensions and weight Overall length Overall width Overall height * Wheelbase Tread Front Rear 197.6 in. (5020 mm) 72.8 in. (1850 mm) 58.5 in. (1485 mm) 111.0 in.
More informationChapter. Tire, Wheel, and Wheel Bearing Fundamentals
Chapter 74 Tire, Wheel, and Wheel Bearing Fundamentals Objectives After studying this chapter, you will be able to: Identify the parts of a tire and wheel assembly. Describe different methods of tire construction.
More informationTires and wheels. Introduction
Tires and wheels Introduction In this section you ll find information about: Tire and wheel handling Wheel rims New and replacement tires Tire inflation pressure Tire inflation pressure in cold tires Tire
More information3. INSPECTION/ADJUSTMENT
3 3 INSPECTION/ADJUSTMENT SERVICE INFORMATION-------------------------------------------------- 3-1 MAINTENANCE SCHEDULE---------------------------------------------- 3-3 FUEL LINE---------------------------------------------------------------------
More informationTire Care Basics: Inflate. Rotate. Evaluate... 3 Tire Maintenance and Safety Information... 6 Tire Failure While Driving...
Tire Care Basics: Inflate. Rotate. Evaluate............... 3 Tire Maintenance and Safety Information.............. 6 Tire Failure While Driving.......................... 6 Tire Inflation Pressure............................
More informationWarranty Policy Omni United
1 of 6 1/27/2017 3:14 PM omni-united.com Warranty Policy Omni United ABOUT RADAR TIRES LIMITED WARRANTY This limited warranty only applies to the original purchaser of new replacement Radar tires sold
More informationTyres TYRE CARE WARNING WARNING. Wear indicators
Tyres TYRE CARE Defective tyres are dangerous. Do not drive the vehicle if a tyre is damaged, excessively worn, or incorrectly inflated. Avoid contaminating the tyres with vehicle fluids, as they may cause
More informationPart 8 SPECIFICATIONS
Part 8 SPECIFICATIONS Dimensions and weight Engine Fuel Service specifications Tires Fuses Dimensions and weight P195/70R 14 tire Overall length 4783 (188.3) Overall width 1780 (70.1) Overall height 1416
More informationENGINE LUBRICATION & COOLING SYSTEMS SECTIONLC CONTENTS. ENGINE LUBRICATION SYSTEM...2 Precautions...2
ENGINE LUBRICATION & COOLING SYSTEMS SECTIONLC CONTENTS ENGINE LUBRICATION SYSTEM...2 Precautions...2 LIQUID GASKET APPLICATION PROCEDURE...2 Preparation...2 SPECIAL SERVICE TOOLS...2 Lubrication Circuit...3
More informationTires and wheels. Introduction
Tires and wheels Introduction In this section you ll find information about: Tire and wheel handling Wheel rims Tire inflation pressure Tire inflation pressure in cold tires Tread depth and tread wear
More informationTire 16 inch 225/75R inch 255/60R 18
417009 133 1. SPECIFICATIONS Description Specification Tire 16 inch 225/75R 16 Tire inflation pressure 18 inch 255/60R 18 Front: 32 psi Rear: 32 psi (44 psi: when the vehicle is fully laden with luggage)
More informationTire Pressure Monitoring System (TPMS) Introduction. Indicator light (telltale) More information: In this section you ll find information about:
Tire Pressure Monitoring System (TPMS) Introduction In this section you ll find information about: Indicator light (telltale) Your vehicle's Tire Pressure Monitoring System (TPMS) uses the Anti-lock Brake
More information2004 SUSPENSION. Tires And Wheels - Corvette. Fastener Tightening Specifications Specification Application Wheel Nuts In Sequence 140 N.
2004 SUSPENSION Tires And Wheels - Corvette SPECIFICATIONS FASTENER TIGHTENING SPECIFICATIONS Fastener Tightening Specifications Specification Application Metric English Wheel Nuts In Sequence 140 N.m
More information3. INSPECTION/ADJUSTMENT
3 3 INSPECTION/ADJUSTMENT SERVICE INFORMATION -------------------------------------------- 3-1 MAINTENANCE SCHEDULE ---------------------------------------- 3-2 FUEL LINE/FUEL FILTER -------------------------------------------
More informationHandout Activity: HA511
Using a tire pressure gauge Engines: Motive Power Types: Handout Activity: HA511 HA511-2 Student/Intern information: Name Date Class Using a tire pressure gauge Summary There are two main types of tire
More informationOwner s Manual Enclosed Cargo
Owner s Manual Enclosed Cargo 1 This manual contains safety information and instructions for your trailer. You must read this manual before loading or towing your trailer. You must follow all safety precautions
More informationTires with inner tubes were used until the 50s. Inner tube tires
Tires Back in the day Way back in the day Pneumatic Tires Dunlop patented them for bicycles in 1888 Michelin put them on cars in 1895 Goodyear was started in 1898. Named after the inventor of vulcanized
More informationIndicator light (telltale) TPMS-DIRECT EMPTY MODULE for REUSE Tire Pressure Monitoring System (TPMS) and recalibration with the MFI
Tire Pressure Monitoring System (TPMS) Introduction In this section you ll find information about: Indicator light (telltale) TPMS-DIRECT EMPTY MODULE for REUSE Tire Pressure Monitoring System (TPMS) and
More informationSECTION 8 SPECIFICATIONS 05 HIGHLANDER_U (L/O 0409) Specifications. Dimensions and weights Service specifications
SPECIFICATIONS SECTION 8 Specifications Dimensions and weights.................................... 406 Engine.................................................... 406 Fuel.......................................................
More informationTire Pressure Monitoring System (TPMS) Introduction
Tire Pressure Monitoring System (TPMS) Applicable only in the United States Introduction In this section you ll find information about: Indicator light (telltale) Indicator light (telltale) Tire Pressure
More informationUTQG BOOKLET 2009 CONTENT: PAGE: General Information. 1 UTQG Information. 2 UTQG Codes (sorted in alphabetical order). 3-60
GLOBAL INFORMATION Dr. Friedrich Lux 2700 Wr. Neustadt, Franz Gruber Gasse 22 Austria, Europe Phone: +43-2622 - 21993 Fax: +43-2622 - 21993 e-mail: lux@tgi.co.at website: http://www.tgi.co.at UTQG BOOKLET
More informationATV-320 R OWNER S MANUAL
ATV-320 R OWNER S MANUAL FOREWORD May we, the manufacturer, take this opportunity to thank you for choosing our ATV to serve you. This Owner s Manual is prepared for you to properly operate in safety.
More informationMaintenance and service
Maintenance and service Maintenance schedule... 11-3 Maintenance precautions... 11-3 Before checking or servicing in the engine compartment... 11-4 When checking or servicing in the engine compartment...
More informationEd Kelley Service Consultant. M. Rhoades Certified Technician
Thank you for allowing us to help you maintain your vehicle. In our effort to help you keep your vehicle operating at peak performance, we have assembled this customized Recommended Action Plan that addresses
More informationTRUCK TIRE DATA AND REFERENCE BOOK
TRUCK DATA AND REFERENCE BOOK TABLE OF CONTENTS 1 STEER S 5 DRIVE S 9 TRAILER S 11 MIXED SERVICE S 17 WARRANTY INFORMATION PREMIUM STEER/ ALL-POSITION DA20 (Y201) STEER 5-rib tread pattern including wide
More informationATV-320 S/U ATV-320SD S/U OWNER S MANUAL V
ATV-320 S/U ATV-320SD S/U OWNER S MANUAL V1.0 2014.03.01 0 FOREWORD May we, the manufacturer, take this opportunity to thank you for choosing our ATV to serve you. This Owner s Manual is prepared for you
More informationTires and wheels. Introduction
Tires and wheels Introduction In this section you ll find information about: Tire and wheel handling Wheel rims New and replacement tires Tire inflation pressure Tire inflation pressure in cold tires Tread
More informationSECTION 2E TIRES AND WHEELS TABLE OF CONTENTS
SECTION 2E TIRES AND WHEELS TABLE OF CONTENTS Specifications........................ 2E-1 General Specifications.................. 2E-1 Fastener Tightening Specifications......... 2E-1 Diagnosis...........................
More informationINSPECTION/ADJUSTMENT
3 3 INSPECTION/ADJUSTMENT SERVICE INFORMATION----------------------------------------------------------------------- 3-1 MAINTENANCE SCHEDULE-------------------------------------------------------------------
More informationItems Vehicles with 4G63 engine Vehicles with 4D56 engine. Type 4-speed full automatic 4-speed full automatic. 2nd rd
23-2 AUTOMATIC TRANSMISSION General Information/ Service Specifications GENERAL INFORMATION 23100010141 Items Vehicles with 4G63 engine Vehicles with 4D56 engine Transmission model R4AW2-6 V4AW2-6 Type
More informationSECTION Wheels and Tires
204-04-i Wheels and Tires 204-04-i SECTION 204-04 Wheels and Tires CONTENTS PAGE DIAGNOSIS AND TESTING Wheels And Tires... 204-04-2 Inspection and Verification... 204-04-2 Tire Wear... 204-04-3 Symptom
More information9-2 In case of emergency
In case of emergency If you park your vehicle in case of an emergency... 9-2 Temporary spare tire... 9-2 Maintenance tools... 9-3 Flat tires... 9-5 Changing a flat tire... 9-5 Tire pressure monitoring
More informationSECTION 8 SPECIFICATIONS. 06Camry_U (L/O 0507) Specifications. Dimensions and weights Service specifications
SPECIFICATIONS SECTION 8 Specifications Dimensions and weights.................................... 336 Engine.................................................... 336 Fuel.......................................................
More informationPRODUCT INFORMATION. Important information regarding the SAFE operation of your BFGoodrich truck tyres!
PRODUCT INFORMATION TB- BFG warranty May/15 Important information regarding the SAFE operation of your BFGoodrich truck tyres! For safety and good performance you must take care of your tyres. Follow the
More informationWheels and tyres GENERAL INFORMATION. Tyre markings
Wheels and tyres GENERAL INFORMATION Tyre markings 1 2 3 4 5 6 7 8 9 15 14 10 13 12 11 E80640 1. P indicates that the tyre is for passenger vehicle use. 2. The width of the tyre from sidewall edge to sidewall
More informationSECTION 5 MAINTENANCE. For scheduled maintenance information, please refer to the separate Owner s Manual Supplement/ Maintenance Schedule.
SECTION 5 Maintenance requirements 180 General maintenance 181 Does your vehicle need repairing? 184 For scheduled maintenance information, please refer to the separate Owner s Manual Supplement/ Maintenance
More informationMaintenance data (fuel, oil level, etc.)
Maintenance data (fuel, oil level, etc.) Dimensions 2WD models Cab type Regular Cab Double Cab Bed type Standard Long Standard Long Overall length 210.2 in. (5340 mm) 229.1 in. (5820 mm) 248.0 in. (6300
More informationMaintenance. Lubricants and Fluids Maintenance Minder General Information... Maintenance Main Items... Maintenance Sub Items...
Maintenance Lubricants and Fluids... 3-2 Maintenance Minder General Information.... 3-4 Maintenance Main Items.... 3-7 Maintenance Sub Items.... 3-8 Lubricants and Fluids For details of the lubrication
More informationTire & Wheel Fundamentals
Tire & Wheel Fundamentals 1 Tire Function Provide traction (friction) with the road surface Provide cushion between the road and the metal wheel 2 Tire Construction Tube Tires Have a tube inside the tire
More informationSECTION 6 2 SERVICE PROCEDURES AND SPECIFICATIONS. Engine. Specifications
SERVICE PROCEDURES AND SPECIFICATIONS Engine SECTION 6 2 Specifications........................................... 162 Fuel.................................................... 164 Facts about engine oil
More informationSECTION 3 INFORMATION BEFORE DRIVING YOUR TOYOTA
INFORMATION BEFORE DRIVING YOUR TOYOTA SECTION 3 Off road vehicle precautions................................. 130 Break in period............................................ 131 Operation in foreign countries................................
More informationTIRE MAINTENANCE & SAFETY INSTRUCTIONS
TIRE MAINTENANCE & SAFETY INSTRUCTIONS Any tire, no matter how well constructed, may fail in use as a result of punctures, impact damage, improper inflation, overloading, or other conditions resulting
More informationOwner s Manual Hybrid/Crossover
Owner s Manual Hybrid/Crossover This manual contains safety information and instructions for your trailer. You must read this manual before loading or towing your trailer. You must follow all safety precautions
More informationENGINE COOLING SYSTEM
B ENGINE A SECTION ENGINE COOLING SYSTEM CO C D CONTENTS E PRECAUTIONS... 2 Precautions for Liquid Gasket... 2 REMOVAL OF LIQUID GASKET SEALING... 2 LIQUID GASKET APPLICATION PROCEDURE... 2 PREPARATION...
More informationLUBRICATION AND MAINTENANCE
DN LUBRICATION AND MAINTENANCE 0-1 LUBRICATION AND MAINTENANCE TABLE OF CONTENTS LUBRICANTS... 1 MAINTENANCE SCHEDULES... 3 JUMP STARTING, TOWING AND HOISTING... 8 LUBRICANTS TABLE OF CONTENTS SERVICE
More informationO U R V A L U E D C U S T O M E R
O U R V A L U E D C U S T O M E R Cori Nastro Service Consultant D. don juan Certified Technician Y O U R V E H I C L E Year 2005 Make Cadillac Model CTS Engine Type 3.6L V6 7 DOHC (MFI) Odometer 125,843
More informationTire / Safety Information
Tire / Safety Information Kaufman Trailers www.kaufmantrailers.com 1 Tire Safety Information 1.1 Steps for Determining Correct Load Limit Trailer 1.2 Steps for Determining Correct Load Limit Tow Vehicle
More informationMaintenance and service
Maintenance and service Maintenance schedule... 11-3 Maintenance precautions... 11-3 Before checking or servicing in the engine compartment... 11-4 When checking or servicing in the engine compartment...
More informationTIRE MAINTENANCE, SAFETY and WARRANTY MANUAL
TIRE MAINTENANCE, SAFETY and WARRANTY MANUAL REPLACEMENT MARKET PASSENGER and LIGHT TRUCK TIRES Including Tires with Run-Flat Technology effective January 2008 1 Congratulations! You have just purchased
More informationSECTION 3 STARTING AND DRIVING MR2 U
STARTING AND DRIVING SECTION 3 Before starting the engine................................... 122 How to start the engine...................................... 122 Tips for driving in various conditions...........................
More informationSECTION 6 2 SERVICE PROCEDURES AND SPECIFICATIONS. Engine. Specifications
SERVICE PROCEDURES AND SPECIFICATIONS Engine SECTION 6 2 Specifications........................................... 170 Fuel.................................................... 172 Facts about engine oil
More informationREPLACEMENT EQUIPMENT WARRANTY POLICIES
REPLACEMENT EQUIPMENT WARRANTY POLICIES (905) 564-0882 1 CONSUMER LIMITED WARRANTY FOR KUMHO & MARSHAL BRAND PASSENGER & LIGHT TRUCK TIRES I. WHAT IS WARRANTED AND WHO IS ELIGIBLE UNDER THIS WARRANTY Kumho
More informationc) same tread pattern type (mixed asymmetric, directional, normal highway, traction, winter tyre tread (Figure 7-1-2).
Correct as at 23rd April 2014. It may be superseded at any time. Extract taken: from NZTA Vehicle Portal > VIRMs > In-service certification (WoF and CoF) > General trailers > Tyres, wheels and hubs > Tyres
More informationPart 8 Dimensions and weight Engine SPECIFICATIONS
Part 8 Dimensions and weight Engine SPECIFICATIONS Dimensions and weight Engine Fuel Service specifications Tires Fuses Overall length mm (in.) 4515 (177.7) Overall width mm (in.) 1810 ( 71.3) Overall
More information~ HONDA CB1000C IIOIL PUMP. rw_u LUBRICATION ENGINE LUBRICATION DIAGRAM. Date of Issue: Sept., 1982 HONDA MOTOR CO., ltd.
LUBRICATION ENGINE LUBRICATION DIAGRAM EXHAUST CAMSHAFT ~ HONDA CB1000C INTAKE CAMSHAFT,t Oil FilTER Oil COOLER PRIMARY CHAIN TENSIONER IIOIL PUMP PRIMARY SHAFT TRANSMISSION MAINSHAFT 01 COUNTERSHAFT Oil
More informationTire Safety. IMPORTANT! Refer to the vehicle owner s manual for any specific safety advice regarding the application of replacement tires.
Tire Safety Index Adverse Weather Driving Conditions 66 Aerosol Puncture Sealant 56 Contact Toyo Technical Service 68 Damaged Tires 55 DOT Quality Grades 69 Explanation of Tire Speed Symbols 63 Factors
More informationTIRE PRODUCT KNOWLEDGE Just the Facts!
K + M Tire TIRE PRODUCT KNOWLEDGE Just the Facts! TIRE FUNCTIONS Carry the Vehicle s Weight and Load Transmit Acceleration Forces Transmit Braking Forces Transmit Cornering Forces Cushion Road Irregularities
More informationLUBRICATION AND MAINTENANCE
PL LUBRICATION AND MAINTENANCE 0-1 LUBRICATION AND MAINTENANCE CONTENTS GENERAL INFORMATION... 1 JUMP STARTING, TOWING AND HOISTING... 7 MAINTENANCE SCHEDULES... 3 GENERAL INFORMATION INDEX GENERAL INFORMATION
More informationAir / Hydraulic Pump
Form No. 538016 Parts List & Operating Instructions for: 2510A Original Instructions Air / Hydraulic Pump Maximum Capacity: 690 bar (10,000 psi) Description: The 2510A air/hydraulic pump is designed to
More informationTIME LAG TEST Check the automatic transmission (each clutch, brake and gear) for wear.
AT2 TROUBLESHOOTING 1. GENERAL INFORMATION (a) Troubles occurring with the automatic transmission can be caused by either the engine, electrical control or the transmission itself. These 3 areas should
More informationPERIODIC MAINTENANCE
PERIODIC MAINTENANCE CONTENTS PERIODIC MAINTENANCE SCHEDULE 2 1 MAINTENANCE PROCEDURES 2 3 2 BATTERY 2 3 CYLINDER HEAD NUTS AND EXHAUST PIPE NUTS 2 4 CYLINDER HEAD AND CYLINDER 2 4 SPARK PLUG 2 4 FUEL
More informationWINTER ENGINEERED FOR THE ELEMENTS TOYOTIRES.COM TOYO TIRE U.S.A. CORP. P.O. BOX 6052 CYPRESS, CA
TOYOTIRES.COM TOYO TIRE U.S.A. CORP. P.O. BOX 6052 CYPRESS, CA 90630 800.442.8696 WINTER ENGINEERED FOR THE ELEMENTS 2014 Toyo Tire U.S.A. Corp. Published August 2014 #0180242 WE ARE STURDY AND STRONG
More information