WARNING DO NOT EXCEED THE MANUFACTURER S RECOMMENDED GROSS VEHICLE WEIGHT RATING (GVWR).

Size: px
Start display at page:

Download "WARNING DO NOT EXCEED THE MANUFACTURER S RECOMMENDED GROSS VEHICLE WEIGHT RATING (GVWR)."

Transcription

1

2 WARNING DO NOT EXCEED THE MANUFACTURER S RECOMMENDED GROSS VEHICLE WEIGHT RATING (GVWR). As in any suspension installation, it is the installer s responsibility to assure a correct installation. The installer is also responsible for providing adequate clearances between vehicle components such as axles, shocks, exhaust and mechanical linkages to ensure a safe and reliable installation. Instructions: 1. Remove truck bed. Use care to insure that the OEM lighting wire harness connectors, fuel filler neck and grounding straps are disconnected prior to lifting the bed from its mounts. 2. Chalk front tires to ensure truck does not roll. 3. Jack rear of truck up and secure with jack stands. Duplicate on both sides. Remove wheels, shocks, leaf springs, gas tank, gas tank cross member, charcoal canister and mounts. 4. Measure and draw your cut line as shown. Cut both sides on the line and pull rear half away from the frame.

3 5. After you cut the rear half off, the notches will slide on from the rear of the truck towards the front. You will need to make sure you sand/grind all the undercoating and dirt from the frame where the new notches will go. Lift the rear of the notch up and down as you push it toward the cab. The notches will be tight and will probably need some tapping with a rubber mallet to get them into position. You will see on the drawing that there are several holes that will line up with existing holes on the frame. Once you have these holes lined up, bolt the notches on and then use the other holes as a template to drill out the remaining holes. 6. Then install the front gas tank cross member. They will bolt on top of the notches and through the frame. 7. Install the rear bag link cross member inside the frame rails. In the center of this cross member there are 2 tank mounting tabs, these need to point towards the cab when the cross member is installed. 8. Install the top cross member between the two notches.

4 9. Remove the differential cover and drain the fluid, lower the differential mount onto the axle with a slight angle towards the back. If you try and install it from the bottom it will give you trouble but from the top it should go right on. It is required to install a differential gasket between the diff. mount, the diff. and the diff. cover and the diff. mount. Next install the axle mounts onto the axle where the leaf springs were installed. Hand tighten the u bolts until the rest of the axle assembly is installed. Once all the pieces are installed go back through and tighten all the hardware. 10. Once you have the frame rails, cross members, and axle assembly installed then position the axle underneath the frame sections.

5 11. Install the lower link with the urethane bushing connecting to the frame and the heim joint installed under the axle. Since all the links are fully adjustable you can center your wheels when the truck is layed out. 12. Install the bushings and sleeves into the gas tank cross member. These install from the inside of the tube out. The heim joint on the upper wishbone link will then fit in between with washers on both sides of the heim. The long 5/8" bolt will run inside the tube that is welded to the front cross member, all the way through to the other.

6 13. Attach the wishbone to the differential bracket. 14. Install the bag links to the rear bag link cross member towards the axle.

7 15. Next connect the bag links to the axle with the 3/4" heim joints. The adjustment holes on the lift bar axle mounts are for customers with smaller diameter tires than 30. By moving the heim joint to one of the higher holes will allow the truck to lift more since it will compress the bag more when laid out. They also affect the angle between the heims and the forward lower link bars at ride height. At ride height the angle between the heims and these lower link bars should be as close to 90 degrees as possible without going over. If it is over the truck will be fine it might just have more of a tendency to wheel hop. 16. Install the bags with a 3/8 bolt going through the bottom of the bag link and install them to the bag mounts on the rear frame sections.

8 17. Next install the shocks from the axle up to the top cross member. It is easiest to install them on the cross member first and then down to the axle. 18. Cycle the suspension, adjust the length of the links and pinion angle and check for driveshaft clearance on the cab. After this you can install all the factory parts i.e. gas tank, charcoal canister.

9

10

11

12

13

14

Dodge Ram 2500/3500 Tow Kit Installation Instructions

Dodge Ram 2500/3500 Tow Kit Installation Instructions 2003-2010 Dodge Ram 2500/3500 Tow Kit Installation Instructions Congratulations! You have just purchased the best engineered, highest quality air suspension kit available on the market for your 2003-2010

More information

GM HD Heavy Duty 4 Link Tow Kit Installation Instructions

GM HD Heavy Duty 4 Link Tow Kit Installation Instructions 2001-2010 GM HD Heavy Duty 4 Link Tow Kit Installation Instructions Congratulations! You have just purchased the best engineered, highest quality air suspension kit available on the market for your 2001-2010

More information

Toyota Tundra Tow Kit Installation Instructions

Toyota Tundra Tow Kit Installation Instructions 2007-2013 Toyota Tundra Tow Kit Installation Instructions Congratulations! You have just purchased the best engineered, highest quality air suspension kit available on the market for your 07-14 Toyota

More information

Super Duty Front Air Bag Installation Instructions

Super Duty Front Air Bag Installation Instructions 2005-2010 Super Duty Front Air Bag Installation Instructions Congratulations! You have just purchased the best engineered, highest quality front air suspension kit available on the market for your 2005-2010

More information

K20 4x4 Radius Arm Conversion Installation Instructions

K20 4x4 Radius Arm Conversion Installation Instructions 1973-1991 K20 4x4 Radius Arm Conversion Installation Instructions 1- Radius arm Hangers 2- Bracket, Driver Lower 3- Bracket, Passenger Upper 4- Radius Arm 5- Bracket, Driver Upper 6- Bracket, Passenger

More information

STREETSCRAPER INSTALL DO NOT CUT FRAME BEFORE INSTALLATION

STREETSCRAPER INSTALL DO NOT CUT FRAME BEFORE INSTALLATION s Chevy 1500 Chevy S10 Dodge Dakota Ford Ranger Mitsi Nissan Isuzu Mazda STREETSCRAPER INSTALL DO NOT CUT FRAME BEFORE INSTALLATION 100% BOLT-ON add $85 & we will assemble Support support vehicle with

More information

GM Street Scraper Instructions

GM Street Scraper Instructions GM 92-00 3500 Street Scraper Instructions 1. Remove bed from truck. 2. Using floor jack, jack up rear of truck at axle till the tires are off the ground. 3. Support truck at the frame in front of axle

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS ----1075 North Ave. Sanger, CA 93657-3539 toll free: 800-445-3767 web: www.belltechcorp.com---- 6907 REAR LOWERING KIT 97-00 CHEVY 1-TON C-3500 Congratulations! You were selective

More information

kelderman air ride 2003 & Newer Dodge Rear 5-6 Lift Kit Warranty Disclaimer Notice Read Before Beginning Installation

kelderman air ride 2003 & Newer Dodge Rear 5-6 Lift Kit Warranty Disclaimer Notice Read Before Beginning Installation Air Ride Conversion System Installation Instructions kelderman air ride The difference in the ride is like night and day Inside this manual: 2003 & Newer Dodge Rear 5-6 Lift Kit Tools required for installation

More information

CSS-C SUSPENSION LIFT KIT

CSS-C SUSPENSION LIFT KIT 115 W. La Cadena Dr. Ste 100 Riverside, CA 92501 (951) 328-9902 phone (951) 328-9908 fax 2000-2006 CHEVROLET SILVERADO 1500 4WD CSS-C3-2 6-8 SUSPENSION LIFT KIT WARNING: CALIFORNIA SUPERTRUCKS RECOMMENDS

More information

KIT # CSS-C SUSPENSION LIFT KIT

KIT # CSS-C SUSPENSION LIFT KIT 14385 Veterans Way Moreno Valley, CA 92553 Phone: (951) 571-0212 Fax: (951) 571-0215 2001-2010 CHEVROLET SILVERADO 1500 AND 2500 HD 4WD AND 2WD PICK-UP 1999-2010 CHEVY 2500 4WD PICK-UPS 2001-2010 2500

More information

Instruction Package. RC-114K Rear Coilover Suspension Kit NOTE... PLEASE READ ALL INSTRUCTIONS INCLUDED WITHIN THIS PACKAGE.

Instruction Package. RC-114K Rear Coilover Suspension Kit NOTE... PLEASE READ ALL INSTRUCTIONS INCLUDED WITHIN THIS PACKAGE. ROD & CUSTOM Motorsports INCORPORATED Instruction Package RC-114K Rear Coilover Suspension Kit NOTE... PLEASE READ ALL INSTRUCTIONS INCLUDED WITHIN THIS PACKAGE. IF AFTER READING YOU STILL NEED ASSISTANCE

More information

kelderman air suspension BIGGER. BOLDER. BETTER.

kelderman air suspension BIGGER. BOLDER. BETTER. A i r S u s p e n s i o n S y s t e m I n s t a l l a t i o n I n s t r u c t i o n s D4R42/3X1010 800 334-6150 www.kelderman.com kelderman air suspension BIGGER. BOLDER. BETTER. Inside this manual: 2010

More information

2014 GM 1500 TRUCK STOP---READ THIS FIRST! 7" Lift KIT. **Read These Entire Instructions Before Starting Anything**

2014 GM 1500 TRUCK STOP---READ THIS FIRST! 7 Lift KIT. **Read These Entire Instructions Before Starting Anything** STOP---READ THIS FIRST! **Read These Entire Instructions Before Starting Anything** 2014 GM 1500 TRUCK LIFT KIT INSTRUCTIONS (PART #50768 & #50769 ) 5680 W. Barstow, Fresno, CA 93722 PH: (559) 226-8196

More information

2011-UP CHEVY/GM 2500HD 2WD/4WD 5 NTD LIFT KIT

2011-UP CHEVY/GM 2500HD 2WD/4WD 5 NTD LIFT KIT 921260X00F *1260BAG6* 1260BAG6 2011-UP CHEVY/GM 2500HD 2WD/4WD 5 NTD LIFT KIT Thank you for choosing Rough Country for all of your suspension needs. Rough Country recommends a certified technician installs

More information

Jeep Wrangler JK 2.5" Suspension Lift Installation Instructions # /

Jeep Wrangler JK 2.5 Suspension Lift Installation Instructions # / Jeep Wrangler JK 2.5" Suspension Lift Installation Instructions #18401.50 / 18415.50 Congratulations on your purchase of a Rugged Ridge suspension kit. To fully enjoy and understand this product we ask

More information

Part # Chevy C-10 Rear CoolRide Kit w/ StrongArms

Part # Chevy C-10 Rear CoolRide Kit w/ StrongArms Components: 2 90006781 267c air spring 350 S. St. Charles St. Jasper, In. 47546 Ph. 812.482.2932 Fax 812.634.6632 www.ridetech.com Part # 11336799 63-72 Chevy C-10 Rear CoolRide Kit w/ StrongArms 1 90000626

More information

C-10 Rear 4Link

C-10 Rear 4Link Part # 11367199-1973-1987 C10 Rear 4Link Recommended Tools 1973-1987 C-10 Rear 4Link Installation Table of contents Page 2... Included Components Page 3... Hardware List & Getting Started Page 4... Disassembly

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS ----3300 W. Pontiac Way Clovis, CA 93612 toll free: 1-800-445-3767 web: www.belltech.com---- 6605-6607 FLIP KIT CHEVROLET C/K 1500 / 2500 PICK UP Thank you for being selective

More information

Carli Suspension Front Instructions

Carli Suspension Front Instructions Carli Suspension Front Instructions 94-08 DODGE 2500-3500 4X4 SUSPENSION SYSTEM Note: Prior to installation, carefully inspect the vehicle=s steering and drive train components. Be sure to check ball joints,

More information

Part # GM F Body Rear R-Joint Bolt-in 4 Link GM F Body Rear Bolt-in 4Link. Table of contents. Installation Instructions

Part # GM F Body Rear R-Joint Bolt-in 4 Link GM F Body Rear Bolt-in 4Link. Table of contents. Installation Instructions Part # 11167199-1967-1969 GM F Body Rear R-Joint Bolt-in 4 Link Recommended Tools 1967-1969 GM F Body Rear Bolt-in 4Link Installation Table of contents Page 2-3... Included Components Page 4... Hardware

More information

2013-UP 3500 Dodge 5 Lift Kit SRW

2013-UP 3500 Dodge 5 Lift Kit SRW 92369200 2013-UP 3500 Dodge 5 Lift Kit SRW Thank you for choosing Rough Country Suspension for your Off Road needs. Rough Country recommends a certified technician installs this system. In addition to

More information

kelderman air ride 2003 & Newer Dodge Rear 8-10 Lift Kit Warranty Disclaimer Notice Read Before Beginning Installation

kelderman air ride 2003 & Newer Dodge Rear 8-10 Lift Kit Warranty Disclaimer Notice Read Before Beginning Installation Air Ride Conversion System Installation Instructions 800 334-6150 www.keldermanairride.com kelderman air ride The difference in the ride is like night and day Inside this manual: 2003 & Newer Dodge Rear

More information

Installation Instructions

Installation Instructions Installation Instructions FTS24071BK 97-06 Jeep Extended Rear Link Kit w/ Stock Dana 44 Axle NON UNLIMITED Qua Part # Description 2 FT50275BK Rear Lower Link Ext. 1 FT50276BK Wish Bone Ext. 1 FT50277BK

More information

Installation Instructions

Installation Instructions Installation Instructions FTS24070BK 97-06 Jeep Extended Rear Link Kit w/ DYNA TRAC PRO ROCK 60 REAR AXLE NON UNLIMITED FTS24070BK Qu a Part # Description 2 FT50275BK Rear Lower Link Ext. 1 FT50276BK Wish

More information

kelderman air ride 2001 & Newer Chevy / GM 2500 Rear Lift Warranty Disclaimer Notice Read Before Beginning Installation

kelderman air ride 2001 & Newer Chevy / GM 2500 Rear Lift Warranty Disclaimer Notice Read Before Beginning Installation Air Ride Conversion System Installation Instructions 800 334-6150 www.keldermanairride.com kelderman air ride The difference in the ride is like night and day Inside this manual: Tools required 2 for installation

More information

2017 Current Ford Raptor Bump Stop Kit Installation Instructions

2017 Current Ford Raptor Bump Stop Kit Installation Instructions 2017 Current Ford Raptor Bump Stop Kit Installation Instructions PREPARATION 1. Disconnect the negative terminal on the battery. Park the vehicle on level ground and set the emergency brake. 2. We recommend

More information

USE THE PARTS LIST BELOW TO MAKE SURE YOUR KIT IS COMPLETE BEFORE INSTALLATION. IF ANY PIECES ARE MISSING, PLEASE CONTACT:

USE THE PARTS LIST BELOW TO MAKE SURE YOUR KIT IS COMPLETE BEFORE INSTALLATION. IF ANY PIECES ARE MISSING, PLEASE CONTACT: 60-65 Ford Falcon Triangulated 4-Link Suspension Installation Instructions Tech Line: 1-855-693-1259 www.totalcostinvolved.com Read and understand these instructions before starting any work! USE THE PARTS

More information

2011-UP CHEVY/GM 2500/3500 HD 7.5 NTD DROP LIFT KIT

2011-UP CHEVY/GM 2500/3500 HD 7.5 NTD DROP LIFT KIT 921253X00B 2011-UP CHEVY/GM 2500/3500 HD 7.5 NTD DROP LIFT KIT Thank you for choosing Rough Country for all of your suspension needs. Rough Country recommends a certified technician installs this system.

More information

COMPETITION ENGINEERING. 80 Carter Drive P.O. Box 1470 Guilford, CT Phone: (203) Fax: (203)

COMPETITION ENGINEERING. 80 Carter Drive P.O. Box 1470 Guilford, CT Phone: (203) Fax: (203) INSTALLATION INSTRUCTIONS P/N: C2094 SLIDE-A-LINK The Slide-A-Link by Competition Engineering is designed for use in Stock Eliminator and Bracket Racing vehicles. The rigid front mount assembly clamps

More information

67 [ ] OR [ ] REAR BRACKETS BARS Shocks Includes: Includes: Includes: Includes:

67 [ ] OR [ ] REAR BRACKETS BARS Shocks Includes: Includes: Includes: Includes: 1967-1969 Firebird Mini Tub 4-Link Install Instructions 1-866-925-1101 www.totalcostinvolved.com CHECK ALL PARTS INCLUDED IN THIS KIT TO THE PARTS LIST BEFORE INSTALLATING OF THE KIT. IF ANY PIECES ARE

More information

For Technical Assistance, call Competition Engineering's Tech Line at (203) , 8:30am-5:00pm Eastern Time COMPETITION ENGINEERING

For Technical Assistance, call Competition Engineering's Tech Line at (203) , 8:30am-5:00pm Eastern Time COMPETITION ENGINEERING INSTALLATION INSTRUCTIONS C2099 SLIDE-A-LINK The Slide-A-Link by Competition Engineering is designed for use in Stock Eliminator and Bracket Racing vehicles. The rigid front mount assembly clamps around

More information

CSS-C CHEVROLET SUBURBAN & TAHOE WD AND 2WD CHEVROLET AVALANCHE WD AND 2WD 6-8 SUSPENSION LIFT KIT

CSS-C CHEVROLET SUBURBAN & TAHOE WD AND 2WD CHEVROLET AVALANCHE WD AND 2WD 6-8 SUSPENSION LIFT KIT 14385 Veterans Way Moreno Valley, CA 92553 Phone: (951) 571-0212 Fax: (951) 571-0215 WWW.CSTSUSPENSION.COM CSS-C3-3 2000-2006 CHEVROLET SUBURBAN & TAHOE 1500 4WD AND 2WD 2002-2006 CHEVROLET AVALANCHE 1500

More information

2017 Ford Super Duty Recoil Traction Bar System. Part#:

2017 Ford Super Duty Recoil Traction Bar System. Part#: Part#: 123417 2017 Ford Super Duty Recoil Traction Bar System Rev. 011917 491 W. Garfield Ave., Coldwater, MI 49036. Phone: 517-279-2135 E-mail: tech-bds@sporttruckusainc.com Read And Understand All Instructions

More information

COMPETITION ENGINEERING. 80 Carter Drive P.O. Box 1470 Guilford, CT Phone: (203) Fax: (203)

COMPETITION ENGINEERING. 80 Carter Drive P.O. Box 1470 Guilford, CT Phone: (203) Fax: (203) INSTALLATION INSTRUCTIONS P/N S: C2090 & C2092 SLIDE-A-LINK The Slide-A-Link by Competition Engineering is designed for use in Stock Eliminator and Bracket Racing vehicles. The rigid front mount assembly

More information

*1333BAG1* 1333BAG DODGE LIFT KIT

*1333BAG1* 1333BAG DODGE LIFT KIT 921333300 *1333BAG1* 1333BAG1 2012-18 DODGE 1500 4 LIFT KIT Thank you for choosing Rough Country for all your suspension needs. Rough Country recommends a certified technician install this system. In addition

More information

IRS-151 INSTALLATION INSTRUCTIONS `55-57 CHEVY INDEPENDENT REAR SUSPENSION

IRS-151 INSTALLATION INSTRUCTIONS `55-57 CHEVY INDEPENDENT REAR SUSPENSION IRS-151 INSTALLATION INSTRUCTIONS `55-57 CHEVY INDEPENDENT REAR SUSPENSION Please read these instructions completely before starting your installation. Remember the basic rule for a successful installation:

More information

Detroit Speed, Inc. Mini-Tub Kit Chevy Nova, Oldsmobile Omega, Pontiac Ventura P/N: &

Detroit Speed, Inc. Mini-Tub Kit Chevy Nova, Oldsmobile Omega, Pontiac Ventura P/N: & Detroit Speed, Inc. Mini-Tub Kit 1968-74 Chevy Nova, Oldsmobile Omega, Pontiac Ventura P/N: 041207 & 041208 Item Component Quantity 1 DSE Mini Tubs 1968-74 X-Body 2 2 Rear Upper Shock Crossmember 1 3 Upper

More information

FAX

FAX INSTALLATION INSTRUCTIONS 6299 Air Suspension Kit (pat. pending) 2009+ Dodge 1500 Pickup with Rear Coil Springs Thank you for purchasing a quality Hellwig Product. PLEASE READ THIS INSTRUCTION SHEET COMPLETELY

More information

4WD FORD F150 BRONCO 4 OR 6 SERIES II RADIUS ARM SYSTEM

4WD FORD F150 BRONCO 4 OR 6 SERIES II RADIUS ARM SYSTEM BOX KIT # 63000 4WD 81-96 FORD F150 BRONCO 4 OR 6 SERIES II RADIUS ARM SYSTEM INTRODUCTION Installation requires two professional mechanics. Be sure the vehicle is in excellent working condition-repair

More information

2011-UP CHEVY/GM 2500/3500HD 2WD/4WD 7.5 NTD LIFT KIT

2011-UP CHEVY/GM 2500/3500HD 2WD/4WD 7.5 NTD LIFT KIT 921253X00H *1253BAG16* 1253BAG16 2011-UP CHEVY/GM 2500/3500HD 2WD/4WD 7.5 NTD LIFT KIT Thank you for choosing Rough Country for all of your suspension needs. Rough Country recommends a certified technician

More information

97-06 Jeep Wrangler TJ Installation Instructions Kit #: TJ251K-SVX / TJ253K-SVX TJ401K-SVX / TJ403K-SVX

97-06 Jeep Wrangler TJ Installation Instructions Kit #: TJ251K-SVX / TJ253K-SVX TJ401K-SVX / TJ403K-SVX www.skyjacker.com 97-06 Jeep Wrangler TJ Installation Instructions Kit #: TJ251K-SVX / TJ253K-SVX TJ401K-SVX / TJ403K-SVX Before beginning the installation, read these instructions and the enclosed driver

More information

Part # C-10 Level 2 Complete Air Suspension System

Part # C-10 Level 2 Complete Air Suspension System 350 S. St. Charles St. Jasper, In. 47546 Ph. 812.482.2932 Fax 812.634.6632 www.ridetech.com Part # 11340299 63-70 C-10 Level 2 Complete Air Suspension System Front Components: 1 11330999 Front CoolRide

More information

KPC 4LBO-F FORD F-150 BOLT ON 4-LINK

KPC 4LBO-F FORD F-150 BOLT ON 4-LINK KPC 4LBO-F71 97-03 FORD F-150 BOLT ON 4-LINK INSTALLATION INSTRUCTIONS 1. Jack the vehicle and support it with stands under the frame on all four corners. The suspension must be left handing. 2. Remove

More information

Kit No KIT FITS 2" & 4" DROPS

Kit No KIT FITS 2 & 4 DROPS Kit No 59104 KIT FITS 2" & 4" DROPS NOTE: If the bottom of the frame to the leaf spring is 70 or less, we do not fit your application Please read these instructions completely before proceeding with installation

More information

84-01 Jeep XJ Cherokee ZJ Grand Cherokee 3" Suspension Lift Installation Instructions

84-01 Jeep XJ Cherokee ZJ Grand Cherokee 3 Suspension Lift Installation Instructions www.skyjacker.com 84-01 Jeep XJ Cherokee 93-98 ZJ Grand Cherokee 3" Suspension Lift Installation Instructions Before beginning the installation, read these instructions and the enclosed driver s WARNING

More information

HEIDTS RF-110. INSTALLATION INSTRUCTIONS Fairlane Comet Rear 4-Link

HEIDTS RF-110. INSTALLATION INSTRUCTIONS Fairlane Comet Rear 4-Link HEIDTS RF-110 INSTALLATION INSTRUCTIONS 66-67 Fairlane 66-67 Comet Rear 4-Link Please read these instructions completely before starting your installation. Remember the basic rule for a successful installation:

More information

4WD RANGER/BRONCO II WD EXPLORER CLASS II INSTALLATION INSTRUCTIONS

4WD RANGER/BRONCO II WD EXPLORER CLASS II INSTALLATION INSTRUCTIONS 4WD RANGER/BRONCO II 8-97 4WD EXPLORER 90-94 CLASS II INSTALLATION INSTRUCTIONS Before beginning the installation, read these instructions and the enclosed driver s WARNING NOTICE thoroughly and completely.

More information

NOTICE TO DEALER AND VEHICLE OWNER

NOTICE TO DEALER AND VEHICLE OWNER 921332300 *1332BAG1* 1332BAG1 2012-18 DODGE 1500 6 LIFT KIT Thank you for choosing Rough Country for all your suspension needs. Rough Country recommends a certified technician install this system. In addition

More information

4 & 6 Suspension System. Toyota Tacoma 4WD Part#: , ,

4 & 6 Suspension System. Toyota Tacoma 4WD Part#: , , Part#: 028601, 028611, 028621 4 & 6 Suspension System Toyota Tacoma 4WD 2005-2017 Rev. 092017 491 W. Garfield Ave., Coldwater, MI 49036. Phone: 517-279-2135 E-mail: tech-bds@sporttruckusainc.com Read And

More information

Installation Instructions

Installation Instructions Installation Instructions FTS23022 & FTS23023 Ram 2500/3500 Traction Bars FTS23022 Traction Bar Gas FT44161 Hardware Sub-Assembly Qty. Part # Description Qty. Part # Description 2 FT44138BK Traction Bars

More information

Ford F-150 4WD 6" Suspension Lift Installation Instructions

Ford F-150 4WD 6 Suspension Lift Installation Instructions 2004-2008 Ford F-150 4WD 6" Suspension Lift Installation Instructions www.skyjacker.com Required Tool List: Safety Glasses Metric / Standard Sockets & Wrenches Spring Compressor Floor Jack Jack Stands

More information

2017+ Ford F-250/350 4X4 Rear Lift Kit Installation Instructions

2017+ Ford F-250/350 4X4 Rear Lift Kit Installation Instructions A 13/64 drill bit and 1/4-20 tap is required. 7/8 drill bit is required 2017+ Ford F-250/350 4X4 Rear 10-12 Lift Kit Installation Instructions 1 1. Before you remove anything off the truck, measure the

More information

Mustang GT / GT500 / V6 1 Piece CV Driveshaft

Mustang GT / GT500 / V6 1 Piece CV Driveshaft 2005 2014 Mustang GT / GT500 / V6 1 Piece CV Driveshaft Not checking this will void the warranty: Please Note: Vehicles with a live rear axle (2005 2014 Mustang) must be checked with the rear suspension

More information

97-06 Jeep TJ Wrangler Installation Instructions Models Kit# TJ251K/TJ401K-SX -DX 03 Models Kit# TJ253K/TJ403K-SX -DX

97-06 Jeep TJ Wrangler Installation Instructions Models Kit# TJ251K/TJ401K-SX -DX 03 Models Kit# TJ253K/TJ403K-SX -DX 97-06 Jeep TJ Wrangler Installation Instructions 97-02 Models Kit# TJ251K/TJ401K-SX -DX 03 Models Kit# TJ253K/TJ403K-SX -DX Before beginning the installation, read these instructions and the enclosed driver

More information

82-04 S10 PICKUP / BLAZER & ZR2 MODELS 2.5 LIFT

82-04 S10 PICKUP / BLAZER & ZR2 MODELS 2.5 LIFT 921242N200 82-04 S10 PICKUP / BLAZER & ZR2 MODELS 2.5 LIFT Thank you for choosing Rough Country for all your suspension needs. Rough Country recommends a certified technician install this system. In addition

More information

DODGE RAM PICKUP INSTALLATION INSTRUCTIONS

DODGE RAM PICKUP INSTALLATION INSTRUCTIONS DODGE RAM PICKUP INSTALLATION INSTRUCTIONS Kit #: D501K/KN/KS/KSN D451K/KN/KS/KSN D551K/KN/KS/KSN D502K/KN/KS/KSN D452K/KN/KS/KSN D552K/KN/KS/KSN February 9, 1994 and Newer Models Before beginning the

More information

INSTALLATION INSTRUCTION 88578

INSTALLATION INSTRUCTION 88578 INSTALLATION INSTRUCTION 88578 For Rancho Suspension System RS6579B: 4WD Dodge 1500 & 2500 READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH BEFORE BEGINNING INSTALLATION Rev E IMPORTANT NOTES! WARNING:

More information

DO NOT GRIND ANY WELDS

DO NOT GRIND ANY WELDS 1 READ FIRST! PLEASE READ THROUGH ALL OF THE INSTRUCTIONS AND ENSURE THAT YOU UNDERSTAND THEM. BE SURE THAT YOU HAVE ALL THE REQUIRED GSI COMPONENTS, BASIC TOOLS, AND SKILLS. CUTTING THIS KIT REQUIRES

More information

FORD F150/BRONCO CLASS II INSTALLATION INSTRUCTIONS

FORD F150/BRONCO CLASS II INSTALLATION INSTRUCTIONS FORD F50/BRONCO 80-96 CLASS II INSTALLATION INSTRUCTIONS Before beginning the installation, read these instructions and the enclosed driver s WARNING NOTICE thoroughly and completely. Also affix the WARNING

More information

INSTALLATION INSTRUCTIONS P/N S: C2091 & C2093 SLIDE-A-LINK

INSTALLATION INSTRUCTIONS P/N S: C2091 & C2093 SLIDE-A-LINK INSTALLATION INSTRUCTIONS P/N S: C2091 & C2093 SLIDE-A-LINK The Slide-A-Link by Competition Engineering is designed for use in Stock Eliminator and Bracket Racing vehicles. The rigid front mount assembly

More information

09-UP FORD F150 6 LIFT KIT

09-UP FORD F150 6 LIFT KIT 92159800 09-UP FORD F150 6 LIFT KIT THANK YOU FOR CHOOSING ROUGH COUNTRY FOR YOUR SUSPENSION NEEDS. Rough Country recommends a certified technician install this system. In addition to these instructions,

More information

'99-03 CHEVROLET/GMC IFS 4WD 6" SUSPENSION SYSTEM P/N INSTALLATION INSTRUCTIONS

'99-03 CHEVROLET/GMC IFS 4WD 6 SUSPENSION SYSTEM P/N INSTALLATION INSTRUCTIONS 1/16/04 '99-03 CHEVROLET/GMC IFS 4WD 6" SUSPENSION SYSTEM P/N. 10-41099 INSTALLATION INSTRUCTIONS NOTE: Each Lift Kit and options to Lift Kits are packaged separately. Therefore, installation procedures

More information

TORQUE ARM CONVERSION INSTALLATION INSTRUCTIONS Camaro and Firebird

TORQUE ARM CONVERSION INSTALLATION INSTRUCTIONS Camaro and Firebird TORQUE ARM CONVERSION INSTALLATION INSTRUCTIONS 1967-1969 Camaro and Firebird Please take note before proceeding with this installation: This product may interfere with certain exhaust kits. Exhaust crossovers

More information

P/N 59511, NEVER EXCEED THE MANUFACTURERS MAXIMUM GROSS VEHICLE WEIGHT RATING. DO NOT INSTALL THE AIR SPRING AS THE PRIMARY SUSPENSION SPRING.

P/N 59511, NEVER EXCEED THE MANUFACTURERS MAXIMUM GROSS VEHICLE WEIGHT RATING. DO NOT INSTALL THE AIR SPRING AS THE PRIMARY SUSPENSION SPRING. MN-260 (10901) ECR6622 P/N 59511, 59611 NEVER EXCEED THE MANUFACTURERS MAXIMUM GROSS VEHICLE WEIGHT RATING. DO NOT INSTALL THE AIR SPRING AS THE PRIMARY SUSPENSION SPRING. THIS PRODUCT IS INTENDED FOR

More information

1 M-3000-H4 F150 4X4 Lowering Kit

1 M-3000-H4 F150 4X4 Lowering Kit READ INSTRUCTIONS COMPLETELY THROUGH BEFORE STARTING. IT IS RECOMMENDED THAT INSTALLATION BE DONE BY A QUALIFIED MECHANIC. REPLACE ALL STOCK PARTS THAT ARE DAMAGED OR WORN. ALWAYS WEAR EYE PROTECTION.

More information

USE THE PARTS LIST BELOW TO MAKE SURE YOUR KIT IS COMPLETE BEFORE INSTALLATION. IF ANY PIECES ARE MISSING, PLEASE CONTACT:

USE THE PARTS LIST BELOW TO MAKE SURE YOUR KIT IS COMPLETE BEFORE INSTALLATION. IF ANY PIECES ARE MISSING, PLEASE CONTACT: 1955-1959 Chevy Truck Rear Leaf Spring Kit Install Instructions Tech Line: 1-855-693-1259 www.totalcostinvolved.com Read and understand these instructions before starting any work! USE THE PARTS LIST BELOW

More information

PARTS LIST: 8581 DODGE LONG ARM BRACKETS 03-13

PARTS LIST: 8581 DODGE LONG ARM BRACKETS 03-13 SYNERGY MFG. 870 INDUSTRIAL WAY, SAN LUIS OBISPO, CA (805) 242-0397 8580 03-12 DODGE 2500/3500 4X4, 06-08 1500 MEGACAB 4X4 LONG ARM SUSPENSION KIT V3.0 GENERAL NOTES: These instructions are also available

More information

/3500 Dodge 5 Long Arm Kit

/3500 Dodge 5 Long Arm Kit 92137900A 11-12 2500/3500 Dodge 5 Long Arm Kit Thank you for choosing Rough Country Suspension for your Off Road needs. Rough Country recommends a certified technician installs this system. In addition

More information

Step 5 Install the frame rail insert into the frame.

Step 5 Install the frame rail insert into the frame. COR-6372S, COR-6372D 63-72 C-10 Rear Coil-over KIT Tool s for the job Car Lift Floor Jack Chalks Jack Stands Standard Wrench set Standard Socket set Spring Compressor Phneumatic/ Electric Grinder Phneumatic/

More information

WRANGLER TJ INSTALLATION INSTRUCTIONS Kit #: TJ251K/KN/KST/KSTN TJ401K/KN/KST/KSTN

WRANGLER TJ INSTALLATION INSTRUCTIONS Kit #: TJ251K/KN/KST/KSTN TJ401K/KN/KST/KSTN WRANGLER TJ INSTALLATION INSTRUCTIONS Kit #: TJ251K/KN/KST/KSTN TJ401K/KN/KST/KSTN Before beginning the installation, read these instructions and the enclosed driver s WARNING NOTICE thoroughly and completely.

More information

INSTALLATION INSTRUCTIONS Cherokee / Grand Cherokee 3" Value Flex Lifts

INSTALLATION INSTRUCTIONS Cherokee / Grand Cherokee 3 Value Flex Lifts INSTALLATION INSTRUCTIONS Cherokee / Grand Cherokee 3" Value Flex Lifts Before beginning the installation, read these instructions and the enclosed driver s WARNING NOTICE thoroughly and completely. Also

More information

4 & 6 Suspension System. Toyota Tacoma 4WD Part#: ,

4 & 6 Suspension System. Toyota Tacoma 4WD Part#: , Part#: 028601, 028611 4 & 6 Suspension System Toyota Tacoma 4WD 2005-2016 Rev. 091817 491 W. Garfield Ave., Coldwater, MI 49036. Phone: 517-279-2135 E-mail: tech-bds@sporttruckusainc.com Read And Understand

More information

STOP---READ THIS FIRST!

STOP---READ THIS FIRST! STOP---READ THIS FIRST! **Read These Entire Instructions Before Starting Anything** 2007-2013 GM 1500 TRUCK LIFT KIT INSTRUCTIONS (PART# 50700 & 50720) 5680 W. Barstow, Fresno, CA 93722 PH: (559) 226-8196

More information

Part # Mustang Complete CoilOver Kit

Part # Mustang Complete CoilOver Kit Front Components: Part # 12100109 67-70 Mustang Complete CoilOver Kit 1 12103509 Non Adjustable Front CoilOvers 1 12102899 Lower StrongArms 1 12103699 Upper StrongArms Rear Components: 1 12106509 Non Adjustable

More information

2008 & Newer Ford F-350 Chassis Cab 4-Link Rear Installation Instructions

2008 & Newer Ford F-350 Chassis Cab 4-Link Rear Installation Instructions KLM18100 2686 Highway 92 - Oskaloosa, IA 52577 phone: 641.673.0468 - fax: 641.673.4168 2008 & Newer Ford F-350 Chassis Cab 4-Link Rear Installation Instructions Installation 1. Before doing anything, measure

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS --300 W PONTIAC WAY CLOVIS, CA 93612 local: 559-875-0222 fax: 559-876-2249 toll free: 800-445-3767-- 6446 5.5 REAR AXLE FLIP-KIT 2015+ FORD F-150 2WD SHORT BED Thank you for being

More information

Read and understand all instructions and warnings prior to installation of system and operation of vehicle.

Read and understand all instructions and warnings prior to installation of system and operation of vehicle. 491 W. Garfield Ave., Coldwater, MI 49036 Phone: 517-279-2135 Web/live chat: www.bds-suspension.com E-mail: tech@bds-suspension.com Part#: 014300, 014301 Product: 3" Suspension System Application: Jeep

More information

97-06 Jeep TJ Wrangler 2. 5 " & 4 " S u s p e n s i o n L i f t Installation Instructions

97-06 Jeep TJ Wrangler 2. 5  & 4  S u s p e n s i o n L i f t Installation Instructions 97-06 Jeep TJ Wrangler 2. 5 " & 4 " S u s p e n s i o n L i f t Installation Instructions Safety Glasses Metric / Standard Wrenches & Sockets Drill / Assorted Drill Bits Floor Jack Jack Stands Measuring

More information

This suspension system was developed using a Maximum tire size of 33 X 12.5 with a 17 x 9 aftermarket wheel with 4 1/2-5 backspacing..

This suspension system was developed using a Maximum tire size of 33 X 12.5 with a 17 x 9 aftermarket wheel with 4 1/2-5 backspacing.. 92174700 Thank you for choosing Rough Country for your suspension needs. 2005-15 TACOMA 6 Kit Rough Country recommends a certified technician install this system. In addition to these instructions, professional

More information

»Product» Safety Warning

»Product» Safety Warning Zone C2350 Installation Instructions 2007-2013 Chevy 1500 3.5" Lift Read and understand all instructions and warnings prior to installation of product and operation of vehicle. Zone Offroad Products recommends

More information

Ford Super Duty Recoil Traction Bar System. Part#: ,123409

Ford Super Duty Recoil Traction Bar System. Part#: ,123409 Part#: 123418,123409 Ford Super Duty Recoil Traction Bar System Rev. 011017 491 W. Garfield Ave., Coldwater, MI 49036. Phone: 517-279-2135 Web/live chat: www.bds-suspension.com. E-mail: tech-bds@sporttruckusainc.com

More information

MOR/ryde Drive Axle Suspension System

MOR/ryde Drive Axle Suspension System MOR/ryde Drive Axle Suspension System (Double Eye Leaf Spring) RL Installation Instructions MOR/ryde International 1966 Moyer Avenue Elkhart, IN 46516 574-293-1851 www.morryde.com RL153-003 Rev.1 MOR/ryde

More information

80-96 Ford F150 / Bronco 4WD Class II 4"- 6" Suspension Lift Installation Instructions

80-96 Ford F150 / Bronco 4WD Class II 4- 6 Suspension Lift Installation Instructions www.skyjacker.com Required Tool List: 80-96 Ford F150 / Bronco 4WD Class II 4"- 6" Suspension Lift Installation Instructions Safety Glasses Metric / Standard Wrenches & Sockets Floor Jack Jack Stands Measuring

More information

Hardware List...In the box (Kit# )

Hardware List...In the box (Kit# ) Part # 33799-963-97 C0 Rear StrongArms Recommended Tools 963-97 C-0 Rear StrongArms Table of contents Page... Included components Page 3... Hardware List and Getting Started Page 4... Disassembly and Front

More information

STOP---READ THIS FIRST!

STOP---READ THIS FIRST! STOP---READ THIS FIRST! **Read These Entire Instructions Before Starting Anything** 2009-2014 FORD F-150 6.5 LIFT KIT LIFT KIT INSTRUCTIONS (PART# 57000 & #57050) NOTE: * The factory wheels and tires WILL

More information

Installation Instructions

Installation Instructions Installation Instructions Jeep TJ Long Arm Suspension System 1997-2002 JEEP TJ 4WD 6 1997-2002 JEEP TJ 4WD FTS24002 & BK / FTS24003 & BK / FTS44002 & BK PARTS LIST FTS24002BK Jeep TJ 6' Box Kit 1 FTS24003BK

More information

04-08 FORD F150 4 KIT

04-08 FORD F150 4 KIT 9257700 04-08 FORD F50 4 KIT THANK YOU FOR CHOOSING ROUGH COUNTRY FOR YOUR SUSPENSION NEEDS. Rough Country recommends a certified technician install this system. In addition to these instructions, professional

More information

INSTALLATION INSTRUCTION 88148

INSTALLATION INSTRUCTION 88148 INSTALLATION INSTRUCTION 88148 Rev C For Rancho Suspension Systems RS6548, RS6549 & RS6550: GM 2500HD, 2500, and 1500HD Trucks READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH BEFORE BEGINNING INSTALLATION

More information

Toyota Tacoma 1"- 3 Performance Strut Installation Instructions

Toyota Tacoma 1- 3 Performance Strut Installation Instructions www.skyjacker.com 2005-2015 Toyota Tacoma 1"- 3 Performance Strut Installation Instructions REQUIRED TOOL LIST: Safety Glasses Metric / Standard Wrenches & Sockets Ball Joint Remover Tie Rod Remover Strut

More information

INSTALLATION INSTRUCTIONS 97 FORD EXPEDITION

INSTALLATION INSTRUCTIONS 97 FORD EXPEDITION INSTALLATION INSTRUCTIONS 97 FORD EXPEDITION 1. Read the instructions completely and carefully before you begin. Check the kit for proper contents (refer to the part s list and the picture diagrams). Before

More information

115 W. La Cadena Dr. Ste 100 Riverside, CA (909) phone (909) fax 2004 NISSAN TITAN 2WD (CSS-N3-1) 8 SUSPENSION LIFT KIT

115 W. La Cadena Dr. Ste 100 Riverside, CA (909) phone (909) fax 2004 NISSAN TITAN 2WD (CSS-N3-1) 8 SUSPENSION LIFT KIT 115 W. La Cadena Dr. Ste 100 Riverside, CA 92501 (909) 328-9902 phone (909) 328-9908 fax 2004 NISSAN TITAN 2WD (CSS-N3-1) 8 SUSPENSION LIFT KIT PLEASE READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH

More information

97-06 JEEP TJ 3 1/4 PROGRESSIVE COIL/SPACER KIT

97-06 JEEP TJ 3 1/4 PROGRESSIVE COIL/SPACER KIT 92PERF1641 97-06 JEEP TJ 3 1/4 PROGRESSIVE COIL/SPACER KIT Thank you for choosing Rough Country for your suspension needs. Rough Country recommends a certified technician installs this system. In addition

More information

PRE-INSTALLATION. INSTALLATION INSTRUCTIONS Front Dodge Ram WD 6" Suspension Lift Kit

PRE-INSTALLATION. INSTALLATION INSTRUCTIONS Front Dodge Ram WD 6 Suspension Lift Kit 2012-2015 Dodge Ram 1500 4WD 6" Suspension Lift Kit PRE-INSTALLATION 35015 2 - Knuckle (Driv/Pass) 2 - Crossmember (Front/Rear) 2 - Differential Bracket (Driv/Pass) 1 - Diff. Brace Bracket (Pass) 2 - Front

More information

Part # Lincoln Level 2 Air Suspension Package

Part # Lincoln Level 2 Air Suspension Package 350 S. St. Charles St. Jasper, In. 47546 Ph. 812.482.2932 Fax 812.634.6632 www.ridetech.com Part # 12060299 64-69 Lincoln Level 2 Air Suspension Package Front Components: 1 12060999 CoolRide Kit 1 12060601

More information

INSTALLATION INSTRUCTIONS 6298 Air Suspension Kit (pat. pending) Thank you for purchasing a quality Hellwig Product.

INSTALLATION INSTRUCTIONS 6298 Air Suspension Kit (pat. pending) Thank you for purchasing a quality Hellwig Product. 559-734-7451 800-367-5480 TechSupport@HellwigProducts.com INSTALLATION INSTRUCTIONS 6298 Air Suspension Kit (pat. pending) Thank you for purchasing a quality Hellwig Product. PLEASE READ THIS INSTRUCTION

More information

M H F150 4X4 Rear Lowering Kit

M H F150 4X4 Rear Lowering Kit READ INSTRUCTIONS COMPLETELY THROUGH BEFORE STARTING. IT IS RECOMMENDED THAT INSTALLATION BE DONE BY A QUALIFIED MECHANIC. REPLACE ALL STOCK PARTS THAT ARE DAMAGED OR WORN. ALWAYS WEAR EYE PROTECTION.

More information

Class 8.8 Class MM 18ft/lbs 23 ft/lbs 10MM 32ft/lbs 45ft/lbs 12MM 55ft/lbs 75ft/lbs 14MM 85ft/lbs 120ft/lbs

Class 8.8 Class MM 18ft/lbs 23 ft/lbs 10MM 32ft/lbs 45ft/lbs 12MM 55ft/lbs 75ft/lbs 14MM 85ft/lbs 120ft/lbs 92190500 Jeep Grand Cherokee 93-98 ZJ 4 Longarm Thank you for choosing Rough Country for all your suspension needs. Rough Country recommends a certified technician install this system. In addition to these

More information

INSTALLATION INSTRUCTION 88051

INSTALLATION INSTRUCTION 88051 INSTALLATION INSTRUCTION 88051 For Rancho Suspension System RS6551: Chevrolet 2500 Suburban & 2500 Avalanche READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH BEFORE BEGINNING INSTALLATION Rev C IMPORTANT

More information

Installation Guide for the TJ LCG PRO Suspension System (Low Center of Gravity) Available 4 or 5

Installation Guide for the TJ LCG PRO Suspension System (Low Center of Gravity) Available 4 or 5 INSTALLATION GUIDE Installation Guide for the TJ LCG PRO Suspension System (Low Center of Gravity) Available 4 or 5 Take every precaution to make this installation a safe procedure. Make safety the number

More information