Alabama State Permits

Transcription

1 Oversize/ Overweight Permit Manual Alabama State Permits Specialized Carriers & Rigging Association 5870 Trinity Parkway, Suite 200 Centreville, Virginia PHONE: (703) FAX: (571) Website:

2 Legal Notice This SC&RA Oversize/Overweight Permit Manual is intended only to provide concise, easily read information, useful in planning movements of overdimensional and overweight loads. This Permit Manual is not intended to be an accurate summary of all the applicable laws and regulations. Users of the Permit Manual should confirm the information contained herein before dispatching vehicles and loads. The SC&RA cautions Permit Manual users that state laws and regulations are subject to change without notice, and that some time elapses between the effective date of such changes and the amendment of the Permit Manual to reflect those changes. The SC&RA assumes no responsibility for accident, injury, loss or claim, penalties or any other damage resulting from reliance on the contents of this Permit Manual. Copyright by the Specialized Carriers & Rigging Association. All rights reserved. No part of this publication may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, scanning, or otherwise, without the prior written permission of the publisher, Joel M. Dandrea, Executive Vice President, Specialized Carrier & Rigging Association. Requests to the publisher for permission should be addressed to Joel M. Dandrea, Specialized Carriers & Rigging Association, 5870 Trinity Parkway, Suite 200, Centreville, VA Specialized Carriers & Rigging Association. All rights reserved. Reproduction in any form prohibited without prior written permission of the Specialized Carriers & Rigging Association. Specialized Carriers & Rigging Association 5870 Trinity Parkway, Suite 200 Centreville, Virginia PHONE: (703) FAX: (571) Website: info@scranet.org ii 09/12 SC&RA Oversize/Overweight Permit Manual

3 Foreword The Specialized Carriers & Rigging Association is pleased to publish this Oversize/ Overweight Permit Manual. The Permit Manual is updated three times a year. Each state analysis includes information in a standardized format: contact, legal limits, special permit limits, general restrictions, types of permits available, fees, escort needs, fines, and restricted travel areas. Telephone numbers, locations, and hours of operation are listed for ports of entry and permit branches. However, readers are always advised to check with the state offices on current laws and procedures. This project could not have been completed without the advice and consultation of many state officials. We thank all of those who provided permit manuals, maps, laws, regulations, and various other forms of documentation. iii 09/12 SC&RA Oversize/Overweight Permit Manual

4 ALABAMA CONTACT: Alabama Highway Department 1409 Coliseum Boulevard Montgomery, AL PO Box :00am 4:45pm, M - F Phone: (334) Toll Free: (800) Fax: alabamapermits@dot.state.al.us LEGAL LIMITS Interstate Non-Interstate GVW 80,000 o (steer) 12,000 o 20,000 20,000 oo 34,000 36,000 ooo 42,000 42,000 TOLERANCE: 10% on state, county roads No tolerance on interstates. WIDTH 8' (lanes less than 12') 8'6" (designated hwys.) HEIGHT 13'6" LENGTH 40' single unit 57' semitrailer des. Hwys. OVERHANG 10' front, 5' rear, must be within length limits PERMIT LIMITS o 22,000 oo 44,000 ooo 66,000 oooo 88,000 5 axles - 110,000 6 axles - 122,000 7 axles - 142,000 8 axles - 150,000 All weights subject to bridge analysis. Over 150,000 lbs. considered a super load WIDTH 16' (16' on 24' pavement, designated routes) HEIGHT 16' LENGTH 150' Maximum overhang 20' Width over 16' wide considered super load Height over 16' considered super load PERMIT RESTRICTIONS General - Permits are valid for five days. Travel is allowed from one-half hour before sunrise to one-half hour after sunset Monday through Saturday. No travel is permitted on Sundays or major holidays. Operators must remove all pieces which can feasibly be removed (buckets, counterweights). Blades or buckets, which protrude trailer, do not need to be removed; however, they must be loaded to the rear of the trailer. Vehicles over 100,000 lbs. GVW must have routing authority, and must have proper insurance (based on annual permit limits). Divisible load permits are not available. Insurance ACCORD FORM 25 Valid Certificates: The company name on the certificate of insurance must be identical to the company name on the permit orders; this includes both Single Trip Permits and Annual permits. AL-1 07/12 SC&RA Oversize/Overweight Permit Manual

5 Vehicle Identification Number (VIN): VIN(s) are required on the certificate of insurance when obtaining an Annual permit. Who needs Insurance? All house moves and Annual permits require a certificate of Insurance. Any Single trip with the following: over 14 wide, over 16 high or over 150,000lbs Effective Dates: Our office requires that all certificates of insurance have an effective and expiration date. The certificate expiration date must be a minimum of six (6) months from the policy effective date. Annual Coverage Amounts: $100,000- Bodily Injury (per person) Auto liability only $300,000- Bodily Injury (per accident) $300,000- Property Damage If combined single limit policy, $1,000,000 minimum is required For Super loads the amounts may be higher Original Certificate: This office requires an original certificate of insurance to be typed and signed by an authorized agent. The CERTIFICATE HOLDER should read and be mailed as the following: Alabama Department of Transportation Permit Office Room H-102 P.O. Box Coliseum Blvd. Montgomery, Al Cancellation: In the event of cancellation or change of coverage in the policy or policies by the company, Ten (10) day notice of such cancellation or change of coverage will be given. If you have any questions please call or Ms. Karen Boyles at select 5 or boylesk@dot.state.al.us Fax Insurance forms directly to or to alabamapermits@dot.state.al.us. An original must follow in the mail. Weekend/Night Travel Allowed all day Saturday, no Sunday travel. Holiday 2012 Month JAN FEB APRIL *MAY JUNE *JULY *SEPT Alabama Department of Transportation Holiday Restrictions ATTENTION: Our office will be closed Monday, January 16th for Robert E. Lee's Birthday and Martin Luther King Jr. Holiday. Travel is allowed with a valid permit only from 30 minutes before sunrise until 30 minutes after sunset on Monday, January 16th. ATTENTION: Our office will be closed Monday, February 20th for George Washington! Thomas Jefferson's Birthday. Travel is allowed with a valid permit only from 30 minutes before sunrise until 30 minutes after sunset on Monday, February 20th. ATTENTION: Our office will be closed Monday, April 23rd for Confederate Memorial Day. Travel is allowed with a valid permit only from 30 minutes before sunrise until 30 minutes after sunset on Monday, April 23rd ATTENTION: Our office will be closed Monday, May 28thfor National Memorial Day. NO permitted travel is allowed from 30 minutes after sunset Friday, May 25th until 30 minutes before sunrise Tuesday, May 29th. ATTENTION: Our office will be closed Monday, June 4th for Jefferson Davis's Birthday. Travel is allowed with a valid permit only from 30 minutes before sunrise until 30 minutes after sunset on Monday, June 4th. ATTENTION: Our office will be closed Wednesday, July 4th for Independence Day, NO permitted travel is allowed from 30 minutes after sunset Tuesday, July 3rd until 30 minutes before sunrise Thursday, July 5th ATTENTION: Our office will be closed Monday, September 3rd for Labor Day. NO permitted travel is allowed from 30 minutes after sundown Friday August 31st until 30 minutes before sunrise Tuesday September 4th AL-2 07/12 SC&RA Oversize/Overweight Permit Manual

6 OCT NOV *NOV *DEC *JAN 2012 ATTENTION: Our office will be closed Monday, October 8th for Columbus Day, Travel is allowed with a valid permit only from 30 minutes before sunrise until 30 minutes after sunset on Monday, October 8th. ATTENTION: Our office will be closed Friday November 12th, for Veteran's Day. Travel is allowed with a valid permit only from 30 minutes before sunrise until 30 minutes after sunset on Friday November 12th. ATTENTION: Our office will be closed Thursday and Friday November 22nd & 23rd for Thanksgiving. NO permitted travel is allowed from 30 minutes after sunset Wednesday November 21st until 30 minutes before sunrise Monday, November 26th. ATTENTION: Merry Christmas! Our office will be closed Monday and Tuesday December 24th & 25th for Christmas. NO permitted travel is allowed from 30 minutes after sunset Friday December 21st until 30 minutes before sunrise Wednesday, December 26th. ATTENTION: Our office will be closed Tuesday, January 1st for New Years Day. NO permitted travel is allowed from 30 minutes after sunset Monday, December 31st until 30 minutes before sunrise Wednesday January 2nd. * Special Travel Restrictions on these Holidays Weather No spring weight restrictions. Permit Information Required - Load description; overall dimensions; gross weight; trailer license number and state; origin and destination (request original points of origin and final destination also); routes to be traveled; effective dates; and commodity containerized. PERMIT TYPES Single Trip-Annual - For machinery with GVW of 150,000 lbs., but no more than 16' in width or 75' in length, and 14' high. FEES Single Trip Overdimensional Load Permits: Overheight - $10 Overweight Load Permits: Weight Only With Oversize 80, ,000 $ 10 $ , , , , over 150,000 (requested by letter) Annual Permits available for $100 ESCORTS AND SIGNS Labeling A sign shall be mounted on the front and rear of any overwidth or overlength vehicle or combination of vehicles and loads. When escorts are required, a sign shall be mounted on the front of the escort vehicle (for a front escort) and to the rear of the escort vehicle (for a rear escort). The sign shall contain the wording OVERSIZE LOAD and be seven (7) feet wide by eighteen (18) inches high in black letters ten (10) inches high with 1 5/8 inch (series C ) brush stroke on a yellow or orange background. Red flags 18" square must be displayed at the front and rear corners of all oversize loads. Escort Vehicles and Personnel - Escort vehicles must be equipped with amber flashing or revolving lights. They must also have oversize load signs. Must be able to communicate with driver of oversize vehicle or vehicles. Vehicles over 12' in width must be accompanied by front and rear escorts. Vehicles over 16' in height must have one front escort. A single rear escort is required for a vehicle 76 to 105, with a front and rear escort required for lengths in excess of 105. Vehicles with overhang of more than 5' in the rear must have a rear escort, while a vehicle with more than a 10' overhang in front requires an escort preceding the vehicle. If bulldozer blades overhang, a minimum of one escort is required. Two 5 flashing amber lights shall be mounted approximately 6 feet from ground level on rear corners of mobile homes. Certification - Pilot Car Escort Certification is not currently required. AL-3 07/12 SC&RA Oversize/Overweight Permit Manual

7 FINES Fines are set by individual counties, and may range from a minimum of $100 to a maximum of $500 per violation. Operators may shift the load to avoid an over-axle citation unless the vehicle is over the gross weight allowed. RESTRICTED TRAVEL Vehicles over 150' in length must travel between 9:00 am and 3:00 pm Monday through Friday in the metropolitan areas. Moving heavy equipment at railroad grade crossings. (a) No person shall operate or move any crawler-type tractor, steam shovel, derrick, roller or any equipment or structure having a normal operating speed of 10 or less miles per hour or a vertical body or load clearance of less than one-half inch per foot of the distance between any two adjacent axles or in any event of less than nine inches, measured above the level surface of a roadway, upon or across any tracks at a railroad grade crossing without first complying with this section. (b) Before making any such crossing the person operating or moving any such vehicle or equipment shall first stop the same not less than 15' nor more than 50' from the nearest rail of such railroad and while so stopped shall listen and look in both directions also on such track for any approaching train and for signals indicating the approach of a train, and shall not proceed until the crossing can be made safely. (c) No such crossing shall be made when warning is given by automatic signal or crossing gates or a flagman is provided by the railroad, movement over the crossing shall be under his direction. PORTS OF ENTRY Port Of Entry-Birmingham Port Information Port Code: 1904 Location Address: nd Street, Suite 550 Birmingham, AL Mailing Address: P.O. Box Birmingham, AL Port Director: David Pond General Phone: (205) General Fax: (205) Operational Hours: 8:00 AM-5:00 PM(Central) Weekdays (Monday-Friday) Port Of Entry-Huntsville Port Information Port Code: 1910 Location Address: 2850 Wall-Triana Highway Huntsville, AL Mailing Address: Same As Above Port Director: Richard Hale General Phone: (256) General Fax: (256) Operational Hours: 8:00 AM-5:00 PM(Central) Weekdays (Monday-Friday) AL-4 07/12 SC&RA Oversize/Overweight Permit Manual

8 PERMIT ORDERING Permits can be ordered online at: Companies not in the system must fill out the New Haulers Form. Once the information is verified the customer will be added to the Alabama DOT database (approximately 2hours) to order permits online. All permit forms can be accessed at: and submitted electronically or faxed to or ed to SPECIAL NOTES Recent Changes Securement Effective June 1, 2009 any driver picking up or delivering steel, aluminum, or other metal coils in the state of Alabama will be required to be trained and certified in proper load securement of coils. Specifically, Alabama law states: 32-9A-2(a) (4)a: No motor carrier may initiate or terminate in Alabama the commercial transport of metal coils, as defined in 49 CFR , unless the commercial vehicle operator is certified in proper load securement 32-9A-4(d): Any motor carrier violating Section 32-9A-2(a) (4)a shall be guilty of a misdemeanor and punished by a fine of not less than five thousand dollars ($5,000) nor more than ten thousand dollars ($10,000). Required Information - The City and State of origin and destination are now required information on all permit/routing request! Route Restrictions - Pending Changes The State of Alabama does not currently require certification for the pilot car drivers who escort oversize/overweight vehicles. The Alabama Department of Transportation contracted The University Transportation Center for Alabama to investigate such certification. AL-5 07/12 SC&RA Oversize/Overweight Permit Manual