CUYAHOGA COUNTY, OHIO ADDENDUM NUMBER 2 FOR THE CLEANING AND TELEVISING OF SEWERS IN VARIOUS COMMUNITIES FOR A TWO-YEAR PERIOD,

Transcription

1

2 CUYAHOGA COUNTY, OHIO ADDENDUM NUMBER 2 FOR THE CLEANING AND TELEVISING OF SEWERS IN VARIOUS COMMUNITIES FOR A TWO-YEAR PERIOD, FOR THE CUYAHOGA COUNTY DEPARTMENT OF PUBLIC WORKS RQ# BIDS DUE ON: April 20, 2017, 2:00 P.M. COUNTY OF CUYAHOGA Armond Budish, County Executive DEPARTMENT OF PUBLIC WORKS Michael Dever, MPA, Director PREPARED BY: The Cuyahoga County Department of Public Works

3 CLEANING AND TELEVISING OF SEWERS IN VARIOUS COMMUNITIES FOR A TWO-YEAR PERIOD, ADDENDUM NUMBER 2 1. QUESTION: Is this a Prevailing Wage project? ANSWER: See Specifications Section 2, Instructions to Bidders, Paragraph 2.13, Miscellaneous, paragraph (c), Wage Rates, which reads, in part, as follows: Any cleaning, televising, and maintenance of sanitary and storm sewers is not subject to prevailing wage law. However, if, during the course of cleaning, televising and/or maintenance of the various sanitary and storm sewers, it is determined that a repair needs to be completed, any repair work shall be paid at the prevailing wage rate as determined by the State of Ohio Rates of Wages. Accordingly, the attention of the Bidders is directed to the provisions of the Revised Code of the State of Ohio, which requires that the Contractor to whom the award is made and all of his Subcontractors shall pay not less than the prevailing rate of wages for any repair work which may occur during the course of this public improvement, in the locality where the work is to be performed. 2. QUESTION: The Specifications mentions a county approved disposal site ; please clarify. ANSWER: See the General Provisions, Section , Paragraph A, Disposal of Waste Material and Construction Debris and Excavation of Borrow on the Project Rightof-Way or on Other County-Owned Property, as follows: 2. If the Contract Documents do not identify locations for the disposal of waste material and construction debris or excavation of borrow material within the Project Right-of-Way or on other County-owned property, then do not bid assuming that the County will make such locations available. Since there are no county approved disposal sites identified and/or listed, then do not bid assuming that the County will make such locations available. Therefore, it is the Contractor s responsibility to locate proper disposal sites per the requirements of the referenced Specification sections including, but not limited to: Detailed Specifications DS-24, Disposal of Materials, Bid Items 29 and 30, Detailed Specifications DS-19, Manual Sewer Cleaning with Confined Space Entry, Debris Removal & Disposal, Bid Item 24, Special Provisions SP-3, Disposal of Waste Materials. 3. QUESTION: Please provide a list of prices in the previous contract. ANSWER: See the attached spreadsheet: Attachment 1, 2016 Bid Tab. Page 1 of 4

4 CLEANING AND TELEVISING OF SEWERS IN VARIOUS COMMUNITIES FOR A TWO-YEAR PERIOD, ADDENDUM NUMBER 2 4. QUESTION: What is the total footage to date on the current contract? ANSWER: For the previous contracts, the footages were as follows (includes cleaning and CCTV inspection): Sanitary: 250,082 lf. 276,269 lf. Storm: 145,317 lf. 146,760 lf. Total: 395,399 lf. 423,029 lf. 5. QUESTION: Who were the SBEs on the previous contracts? ANSWER: For the previous contract entitled Cleaning And Televising Of Sewers In Various Communities For A Three-Year Period, , the SBEs were as follows: The Safety Company, LLC dba M Tech Company, 7401 First Place, Suite G, Oakwood Village, Oh 44146, Phone: Pete & Pete Container Service, Inc., 4830 Warner Road, Garfield Heights, OH 44125, Phone: For the sewer cleaning contract prior to the above contract, the SBE was as follows: Broadway Excavating, Wolf Road, Bay Village, OH 44140, Phone: QUESTION: For Bid Item 27, Temporary Bypass Pumping Systems, what size pumps are to be bid? ANSWER: The requirements for Item 27, Temporary Bypass Pumping Systems shall remain the same and in full force except as revised herein in Addendum Number 2. Item 27, Temporary Bypass Pumping Systems shall be revised to include the following two bid items: Item 27A, Temporary Bypass 4-inch Pumping System Item 27B, Temporary Bypass 6-inch Pumping System All pumps used by the Contractor for temporary bypass pumping shall be sewage pumps capable of passing three-inch (3-inch) solids. The Contractor may include bypass pumping in any Task Order in which he believes it would be necessary to facilitate the work of this Contract; however, the County shall make the final decision as to whether or not the Contractor will be paid for the bypass pumping for a given Task Order. If the County concludes that the bypass pumping is not necessary for a given Task Order, the Page 2 of 4

5 CLEANING AND TELEVISING OF SEWERS IN VARIOUS COMMUNITIES FOR A TWO-YEAR PERIOD, ADDENDUM NUMBER 2 bypass pumping shall be at the sole cost of the Contractor, and the Contractor shall not receive any payment for this bypass pumping. Since the County does not know where bypassing may be required, and since the actual conditions of the existing flow rate in the specific runs of sewer to be bypassed are unknown, the bidding conditions are herein established to provide a common item for all bidders to bid on. Thus, Contractors shall bid on the conditions as stated herein for bidding purposes only. If and/or when bypassing is required by mutual agreement between the County and the Contractor in an actual Task Order, the Contractor shall be expected to provide sufficient bypass pumping as required by the Contract Documents, regardless of the conditions specified for bidding. The Contractor shall be paid at the bid unit price and no additional payment, nor decrease in payment, shall be considered. Item 27A, Temporary Bypass 4-inch Pumping System The 4-inch Pump shall meet at least 90% of the following pumping capacities at the operating conditions shown: Item 27B, Temporary Bypass 6-inch Pumping System The 6-inch Pump shall meet at least 90% of the following pumping capacities at the operating conditions shown: The bid item shall include five-hundred (500) feet of all necessary suction and discharge piping of the proper size. Page 3 of 4

6 CLEANING AND TELEVISING OF SEWERS IN VARIOUS COMMUNITIES FOR A TWO-YEAR PERIOD, ADDENDUM NUMBER 2 Measurement and Payment Payment shall be at the contract unit bid price per 24-hour day, or portion thereof, that the pumping system is actually operating. The measurement shall be provided by the tamper-proof time measurement and recording device which is attached to the pumping system, and which shall record and print out the actual number of hours that the pumping system is in operation. The printout shall be attested to by the signature(s) of the operator(s) assigned to monitor the bypass pumping system. If conflicts in time recording and/or totals claimed occur, the decision of the County shall be final. The accepted quantities shall be paid for at the unit price bid, which price and payment shall be full compensation for all labor, equipment, and materials necessary, including but not limited to, provide, set-up, complete, operate, remove the bypass pumping system, fuel and oil and/or electricity to power and lubricate the pumping equipment, piping, sewer plugs, including incidentals, and for all necessary restoration work for this item as specified, and the bid price shall constitute full compensation. 7. REVISED ITEMIZED UNIT PRICE BID TABULATION FORM See Attachment 2 for the Revised Itemized Unit Price Bid Tabulation Form that shall be used for all bidding for this Project. Page 4 of 4

7 Attachment #1, 2016 Bid Tab ITEM 1 DESCRIPTION High Priority Response Task Order Work -- Mobilization ESTIMATED QUANTITY UNIT UNIT PRICE BID by C&K 2016 TOTAL AMOUNT BID 25 EA $ $3, Light Sanitary Sewer Cleaning 8" to 18" 200,000 LF $0.85 $170, Heavy Sanitary Sewer Cleaning 8" to 18" 200,000 LF $1.00 $200, Light Sanitary Sewer Cleaning 21" to 24" 25,000 LF $2.14 $53, Heavy Sanitary Sewer Cleaning 21" to 24" 25,000 LF $3.00 $75, Light Sanitary Sewer Cleaning 27" to 36" 12,000 LF $2.16 $25, Heavy Sanitary Sewer Cleaning 27" to 36" 12,000 LF $2.20 $26, Light Storm Sewer Cleaning 8" to 18" 25,000 LF $1.75 $43, Heavy Storm Sewer Cleaning 8" to 18" 25,000 LF $2.00 $50, Light Storm Sewer Cleaning 20" to 36" 22,000 LF $2.00 $44, Heavy Storm Sewer Cleaning 20" to 36" 22,000 LF $2.25 $49, Light Storm Sewer Cleaning 42" to 60" 5,500 LF $2.55 $14, Heavy Storm Sewer Cleaning 42" to 60" 5,500 LF $2.75 $15, Manhole Cleaning 8,000 VF $2.10 $16, Lateral Cleaning 3,000 LF $5.00 $15, Lateral Vacuuming 4,500 LF $5.00 $22, Catch Basin Cleaning 4,500 EA $50.00 $225, Remove Hard Deposits From Pipe 22,000 LF $1.65 $36, Root Cutting 3,500 LF $2.35 $8,225.00

8 Attachment #1, 2016 Bid Tab ITEM DESCRIPTION ESTIMATED QUANTITY UNIT UNIT PRICE BID by C&K 2016 TOTAL AMOUNT BID 20 Herbicide Treatment 1,100 LF $1.40 $1, Reverse Set Up for Cleaning or Inspection 30 EA $0.00 $ Locate Only -- Test Tee and Riser (Per House or Per User) 150 EA $70.00 $10, Locate Only -- Buried Manhole 60 EA $50.00 $3, Manual Sewer Cleaning with Confined Space Entry, Debris Removal & Disposal 80 HR $ $36, Pump Station Wet Well Vacuuming 1,200 HR $ $192, Hydro Excavation (Vacuum Excavation) 5 DAY $3, $15, Temporary Bypass Pumping Systems 2,100 HR $62.00 $130, Additional Cost for Work Out of Street 6,000 LF $0.00 $ Disposal of Materials: Sediment/Grit/Solids 10 TON $ $2, Disposal of Materials: Liquified Materials 10 M Gallons $ $3, Sewer Televised with Report 300,000 LF $1.45 $435, Manhole Inspection 1,000 VF $22.00 $22, Walk-Through CCTV Inspection of Large Diameter Sewers -- Under 300 feet Length Walk-Through CCTV Inspection of Large Diameter Sewers feet and longer NASSCO Pipeline Assessment and Certification Program (PACP) Training 900 LF $5.25 $4, ,000 LF $4.75 $9, HR $ $11, Project Contingency Allowance 1 LS $100, $100, GRAND TOTAL BID $2,071,670.00

9 Attachment #2, CLEANING AND TELEVISING OF SEWERS IN VARIOUS COMMUNITIES FOR A TWO-YEAR PERIOD, ITEMIZED UNIT PRICE BID ITEM 1 DESCRIPTION High Priority Response Task Order Work -- Mobilization ESTIMATED QUANTITY 35 EA 2 Light Sanitary Sewer Cleaning 8" to 18" 300,000 LF 3 Heavy Sanitary Sewer Cleaning 8" to 18" 300,000 LF 4 Light Sanitary Sewer Cleaning 21" to 24" 37,500 LF 5 Heavy Sanitary Sewer Cleaning 21" to 24" 37,500 LF 6 Light Sanitary Sewer Cleaning 27" to 36" 18,000 LF 7 Heavy Sanitary Sewer Cleaning 27" to 36" 18,000 LF 8 Light Storm Sewer Cleaning 8" to 18" 50,000 LF 9 Heavy Storm Sewer Cleaning 8" to 18" 50,000 LF 10 Light Storm Sewer Cleaning 20" to 36" 50,000 LF 11 Heavy Storm Sewer Cleaning 20" to 36" 50,000 LF 12 Light Storm Sewer Cleaning 42" to 60" 8,250 LF 13 Heavy Storm Sewer Cleaning 42" to 60" 8,250 LF 14 Manhole Cleaning 1,000 VF 15 Lateral Cleaning 1,000 LF 16 Lateral Vacuuming 1,000 LF 17 Catch Basin Cleaning 1,000 EA UNIT UNIT PRICE BID TOTAL AMOUNT BID Page 4 of 9

10 Attachment #2, CLEANING AND TELEVISING OF SEWERS IN VARIOUS COMMUNITIES FOR A TWO-YEAR PERIOD, ITEMIZED UNIT PRICE BID ITEM DESCRIPTION ESTIMATED QUANTITY 18 Remove Hard Deposits From Pipe 33,000 LF 19 Root Cutting 5,250 LF 20 Herbicide Treatment 1,650 LF 21 Reverse Set Up for Cleaning or Inspection 45 EA 22 Locate Only -- Test Tee and Riser (Per House or Per User) 225 EA 23 Locate Only -- Buried Manhole 90 EA 24 Manual Sewer Cleaning with Confined Space Entry, Debris Removal & Disposal 120 HR 25 Pump Station Wet Well Vacuuming 1,800 HR 26 Hydro Excavation (Vacuum Excavation) 8 DAY 27A Temporary Bypass 4-inch Pumping System 7 DAY 27B Temporary Bypass 6-inch Pumping System 7 DAY 28 Additional Cost for Work Out of Street 9,000 LF 29 Disposal of Materials: Sediment/Grit/Solids 15 TON 30 Disposal of Materials: Liquified Materials 15 M Gallons 31 Sewer Televised with Report 500,000 LF 32 Manhole Inspection 1,500 VF UNIT UNIT PRICE BID TOTAL AMOUNT BID 33 Walk-Through CCTV Inspection of Large Diameter Sewers -- Under 300 feet Length 1,350 LF Page 5 of 9

11 Attachment #2, CLEANING AND TELEVISING OF SEWERS IN VARIOUS COMMUNITIES FOR A TWO-YEAR PERIOD, ITEMIZED UNIT PRICE BID ITEM 34 DESCRIPTION Walk-Through CCTV Inspection of Large Diameter Sewers feet and longer ESTIMATED QUANTITY 8,000 LF 35 Smoke Testing 20 DAY 36 Dye Testing 5,000 LF 37 NASSCO Pipeline Assessment and Certification Program (PACP) Training 32 HR UNIT UNIT PRICE BID TOTAL AMOUNT BID 38 Project Contingency Allowance 1 LS $200, $200, GRAND TOTAL BID Page 6 of 9