Rear HVAC Vents Blow Hot Air with A/C "ON"
|
|
- Noel Waters
- 6 years ago
- Views:
Transcription
1 T-SB July 30, 2008 Service Category Vehicle Interior Section Heating/Air Conditioning Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION Avalon TSB SUPERSESSION NOTICE The information contained in this TSB supersedes TSB No. AC Step 5 of the Repair Procedure has been updated with additional views and procedures. TSB No. AC is Obsolete and any printed versions should be discarded. Be sure to review the entire content of this service bulletin before proceeding. Introduction Some customers may experience a condition where the rear center vents blow warmer air than the front center vents. A new HVAC servo motor has been designed to correct this concern. Follow the procedures listed in this bulletin to remove and replace the HVAC servo motor. Production Change Information This TSB applies to vehicles produced BEFORE the Production Change Effective VIN shown below. MODEL Avalon PRODUCTION CHANGE EFFECTIVE VIN 4T1BK36B*8U Warranty Information OP CODE DESCRIPTION TIME OFP T1 T2 AC7007 R & R Damper Servo Sub-assembly A 50 APPLICABLE WARRANTY This repair is covered under the Toyota Comprehensive Warranty. This warranty is in effect for 36 months or 36,000 miles, whichever occurs first, from the vehicle s in-service date. Warranty application is limited to correction of a problem based upon a customer s specific complaint. Page 1 of 9
2 T-SB July 30, 2008 Page 2 of 9 Parts Information PREVIOUS PART NUMBER CURRENT PART NUMBER PART NAME QTY Servo Sub-assembly, Damper 1 Required Tools & Equipment REQUIRED EQUIPMENT SUPPLIER QTY Robinair ROB34200* (or equivalent) * Toyota Approved Dealer Equipment R-134a Refrigerant Recovery/Recycling Machine 1 NOTE Additional refrigerant service equipment may be ordered by calling Toyota Approved Dealer Equipment (ADE) at Repair Procedure 1. Remove the air conditioning unit. Refer to the Technical Information System (TIS), applicable model and model year Repair Manual: 2005 model year Avalon Repair Manual, Vehicle Interior Heating/Air Conditioning Blower Assy: Overhaul 2006 or 2007 model year Avalon Repair Manual, Vehicle Interior Heating/Air Conditioning Air Conditioning: Air Conditioning Unit: Removal 2. Remove the No. 2 air duct sub-assembly by releasing the 2 claws as shown in Figure 1. Figure 1. 1 Claw
3 T-SB July 30, 2008 Page 3 of 9 3. Remove the blower assembly. A. Remove the connector and clamp, and disconnect the wire harness. Figure 2. B. Remove the 6 screws and then the blower assembly with the cooler-evaporator sub-assembly. Figure 3.
4 T-SB July 30, 2008 Page 4 of 9 4. Remove the air outlet control servo motor. A. Disconnect the 2 connectors and remove the air conditioner harness. Figure 4. B. Remove the 3 screws and then remove the air outlet control servo motor. Figure 5.
5 T-SB July 30, 2008 Page 5 of 9 5. Install the NEW air outlet control servo motor. A. Align the air conditioning unit servo arms and gears. Refer to Figure 6 and sub-steps (1)-(6). Figure 6.
6 T-SB July 30, 2008 Page 6 of 9 (1) Rotate arm A clockwise until the end of travel. Figure 7. Arm "A" (2) Rotate arm B counter-clockwise until the end of travel. Figure 8. Arm "B" (3) Rotate arm C counter-clockwise until the end of travel. Figure 9. Arm "C"
7 T-SB July 30, 2008 Page 7 of 9 (4) Rotate cam D clockwise until the end of travel. Figure 10. Cam "D" (5) Rotate arm E counter-clockwise until the end of travel. Figure 11. Arm "E" (6) Align the leading edge of Cam F with the line casting in the case. Figure 12. Cam "F"
8 T-SB July 30, 2008 Page 8 of 9 B. Install the air outlet control servo motor with the 3 screws. Figure 13. C. Install the air conditioner harness and connect the 2 connectors. Figure Install the blower assembly. A. Install the blower assembly with the 6 screws. Figure 15.
9 T-SB July 30, 2008 Page 9 of 9 B. Connect the wire harness and install the connector and clamp. Figure Install the No. 2 air duct sub-assembly by engaging the 2 claws. Figure Claw 8. Install the air conditioning unit. Refer to the TIS, applicable model and model year Repair Manual: 2005 model year Avalon Repair Manual, Vehicle Interior Heating/Air Conditioning Blower Assy: Overhaul 2006 or 2007 model year Avalon Repair Manual, Vehicle Interior Heating/Air Conditioning Air Conditioning: Air Conditioning Unit: Installation 9. Verify the heater and air conditioner operate correctly in all modes.
YEAR(S) MODEL(S) ADDITIONAL INFORMATION. The information contained in this TSB supersedes TSB No. T-SB
T-SB-0163-11 October 20, 2011 Service Category Vehicle Interior Section Heating/Air Conditioning Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2006 2011 Avalon 2007 2011 Camry, Camry
More informationTechnical Service Bulletin
INTRODUCTION: Technical Service Bulletin March 3, 2009 Title: DECREASED AIR VOLUME FROM HVAC VENTS Models: 07-09 Tacoma Some customers may experience decreased air volume from the HVAC vents when the temperature
More informationTelescopic Lever Detent Clip Replacement
T-SB-0147-13 September 27, 2013 Service Category Steering Section Steering Column Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 2012 Avalon SUPERSESSION NOTICE The information contained
More informationSmart Key Intermittent No Crank / No Start
T-SB-0003-09 Rev1 January 7, 2009 Service Category Vehicle Interior Section Theft Deterrent/Keyless Entry Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 2008 Avalon 2007 2008 Camry,
More informationYEAR(S) MODEL(S) ADDITIONAL INFORMATION
T-SB-0061-12 April 6, 2012 Service Category Vehicle Interior Section Heating/Air Conditioning Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 2012 Tacoma Introduction In a limited
More informationNoise from Auxiliary Port with External Device
T-SB-0067-08 May 2, 2008 Service Category Audio/Visual/Telematics Section Audio/Video Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2006 2008 4Runner, Prius, RAV4 2007 Camry, Camry HV,
More informationFront Brake Rattle Noise
T-SB-0046-08 April 22, 2008 Service Category Brake Section Brake (front) Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2003 2008 Corolla, Matrix TSB SUPERSESSION NOTICE The information
More informationSteering Intermediate Shaft Noise
T-SB-0296-08 September 16, 2008 Service Category Steering Section Steering Gear/Linkage Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2006 Highlander HV 2004 2005 Highlander 2004 2006
More informationM.I.L. "ON" DTC P2237, P2238, P2240, or P2241
T-SB-0278-08 September 5, 2008 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2008 Avalon 2008 2009 Camry Introduction Some
More informationFront Seat Squeak Noise
T-SB-0288-08 Rev1 September 8, 2008 Service Category Vehicle Interior Section Seat Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2004 2010 4Runner, Avalon, Camry, Corolla, Echo, FJ Cruiser,
More informationCenter Console Wood Grain Panel Cracked
L-SB-0040- July 3, 20 Service Category Vehicle Interior Section Interior Panels/Trim Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 20 LS460, LS600H Introduction Some 2007-20 model
More informationMarket USA. The information contained in this bulletin supersedes SB No. EG
T-SB-0231-12 November 29, 2012 Service Category Engine/Hybrid System Section Cooling Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2004 2007 Prius SUPERSESSION NOTICE The information
More informationSRS Airbag Light "ON" - B0111/B0116 Open Side Squib Circuit
T-SB-0069-12 May 1, 2012 SRS Airbag Light "ON" - B0111/B0116 Open Side Squib Circuit Service Category Vehicle Interior Section Supplemental Restraint Systems Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL
More informationFront Seat Squeak Noise
T-SB-0288-08 September 8, 2008 Service Category Vehicle Interior Section Seat Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2004 2009 4Runner, Avalon, Camry, Camry HV, Celica, Corolla,
More informationRear Spring Harsh Ride
T-SB-0305-08 Rev1 September 30, 2008 Service Category Suspension Section Rear Suspension Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 2008 Tacoma Body Type(s): Access Cab, Double
More informationHigh Beam/DRL Bulb Inoperative
T-SB-0044-10 Rev2 January 27, 2010 Service Category Vehicle Exterior Section Lighting (ext) Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2008 2010 Avalon TSB REVISION NOTICE October
More information2GR-FE Engine Ticking Noise and / or MIL ON P0014, P0015, P0024, P0025, P0017, or P0018
T-SB-0094-09 March 19, 2009 2GR-FE Engine Ticking Noise and / or MIL ON P0014, P0015, P0024, P0025, Service Category Engine/Hybrid System Section Engine Mechanical Market USA Applicability YEAR(S) MODEL(S)
More informationSRS LIGHT "ON" - B0111/B OPEN SIDE SQUIB CIRCUIT TECHNICAL SERVICE BULLETIN Reference Number(s): T-SB , Date of Issue: June 23, 2010
SRS LIGHT "ON" - B0111/B0116 - OPEN SIDE SQUIB CIRCUIT -2006 Toyota Sienna... Page 1 of 27 SRS LIGHT "ON" - B0111/B0116 - OPEN SIDE SQUIB CIRCUIT TECHNICAL SERVICE BULLETIN Reference Number(s): T-SB-0162-10,
More information2GR-FE Engine Ticking Noise and/or MIL "ON" P0014, P0015, P0024, P0025, P0017, or P0018
T-SB-0094-09 Rev1 March 19, 2009 2GR-FE Engine Ticking Noise and/or MIL "ON" P0014, P0015, P0024, P0025, Service Category Engine/Hybrid System Section Engine Mechanical Market USA Applicability YEAR(S)
More informationPower Steering Rack Leak from Right Side: Overhaul Procedure
T-SB-0030-14 April 17, 2014 Power Steering Rack Leak from Right Side: Overhaul Procedure Service Category Steering Section Steering Gear/Linkage Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION
More informationSecondary Air Injection System - Water Intrusion: MIL "ON" DTC P0418, P0419, and/or P244#
T-SB-060- October 7, 20 Secondary Air Injection System - Water Intrusion: MIL "ON" DTC P048, P049, Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S)
More information2nd Row Tip-Up Style Seat Lower Cushion Excessive Movement
T-SB-0180-12 September 20, 2012 2nd Row Tip-Up Style Seat Lower Cushion Excessive Movement Service Category Vehicle Interior Section Seat Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION
More informationDriveline Vibration Between MPH
T-SB-0249-12 December 21, 2012 Service Category Drivetrain Section Drive Shaft/Propeller Shaft Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 2013 Tacoma Body Type(s): Double Cab,
More informationInstrument Panel Rattle Noise
T-SB-0333-08 Rev1 November 3, 2008 Service Category Vehicle Interior Section Interior Panels/Trim Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2009 Corolla, Matrix TSB REVISION NOTICE
More informationMIL "ON" P043E, P043F, P2401, P2402, & P2419 Due to Water Intrusion into Charcoal Canister
T-SB-0200- December 6, 20 MIL "ON" P043E, P043F, P240, P2402, & P249 Due to Water Intrusion into Service Category Engine/Hybrid System Section Emission Control Market USA Applicability YEAR(S) MODEL(S)
More informationYEAR(S) MODEL(S) ADDITIONAL INFORMATION
T-SB-0102-11 August 17, 2011 Service Category Brake Section Brake (rear) Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010 2011 Introduction Some 2010 2011 vehicles may experience rear
More informationUpper/Lower Windshield/Rear Glass Tick Noise
T-SB-0142-08 Rev1 July 29, 2008 Service Category Vehicle Exterior Section Window/Glass Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2003 2009 4Runner, Avalon, Camry, Camry HV, Celica,
More informationMoon Roof Assembly Structure Noise
T-SB-05-3 Rev2 October 2, 203 Service Category Vehicle Exterior Section Exterior Panels/Trim Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 203 205 Avalon, Avalon HV WMI(s): 4T 202 206
More informationTitle: FUEL GAUGE INACCURACY Models: 04 Prius
Technical Service BULLETIN August 24, 2004 Title: FUEL GAUGE INACCURACY Models: 04 Prius EL010-04 ELECTRICAL TSB REVISION September 23, 2004: PANT Bulletin search clarified in Note in Parts Information;
More informationOil Filter Cap Assembly Precautions
T-SB-0104-09 Rev1 April 10, 2009 Service Category Engine/Hybrid System Section Lubrication Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010 2011 4Runner, Camry, FJ Cruiser, Prius 2009
More informationTechnical Service BULLETIN
Technical Service BULLETIN July 4, 2007 Title: Models: 07 Avalon, Camry (NAP), Camry HV (NAP), & Solara EG035-07 ENGINE TSB REVISION NOTICE: August 22, 2007: Two parts have been added to the Parts Information
More informationTechnical Service BULLETIN
Technical Service BULLETIN Title: Models: 01 03 Sequoia TSB UPDATE NOTICE: The information contained in this TSB supercedes TSBs AC001 01 and AC001 02. The previous TSBs, AC001 01 and AC001 02, should
More information2WD Rear Propeller Shaft (Driveshaft) Clunk/Thunk Noise
T-SB-0250-2 Rev2 December 2, 202 Service Category Drivetrain Section Drive Shaft/Propeller Shaft Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 203 Tacoma Transmission(s): 5AT, 4AT
More informationTechnical Service BULLETIN
Technical Service BULLETIN February 16, 2006 Title: Models: 03 06 Camry, 04 05 Highlander, & 04 06 Solara, ST001-06 STEERING TSB REVISION NOTICE: July 20, 2006: 2004 2005 model year Highlander vehicles
More informationTechnical Service BULLETIN
Technical Service BULLETIN December 22, 2005 Title: Models: 04 05 BR006-05 BRAKES TSB REVISION NOTICE: December 4, 2006: The Old Part Identification column of the Parts Identification table has been updated.
More informationMIL "ON" DTC P0A0F, P3190, P3191, P0171 Due to Purge VSV Vacuum Line Separation
T-SB-0041-15 June 30, 2015 MIL "ON" DTC P0A0F, P3190, P3191, P0171 Due to Purge VSV Vacuum Line Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL
More informationSmart Key Intermittent No Crank/No Start
L-SB-0161-08 Rev1 November 11, 2008 Service Category Vehicle Interior Section Theft Deterrent/Keyless Entry Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2008 ES350, GS350, GS450H,
More informationSide Window Glass Noise During Operation
T-SB-0077-12 May 21, 2012 Service Category Vehicle Exterior Section Window/Glass Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2012 Camry, Camry HV Introduction Some 2012 Camry and Camry
More informationTechnical Service BULLETIN
Technical Service BULLETIN December 15, 2007 Title: Models: 04 07 Sienna EL011-07 ELECTRICAL Introduction Some customers may experience difficulty when using the power close feature of the power back door
More informationM.I.L. "ON" DTC B2799 "No Start" Due to Harness Water Intrusion
T-SB-0220-08 Rev1 August 11, 2008 M.I.L. "ON" DTC B2799 "No Start" Due to Harness Water Intrusion Service Category Vehicle Interior Section Theft Deterrent/Keyless Entry Market USA Applicability YEAR(S)
More informationYEAR(S) MODEL(S) ADDITIONAL INFORMATION. 1. Review DTC P0705 Freeze Frame Data to determine if this TSB may be applicable.
T-SB-0277-09 August 18, 2009 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 2009 Tacoma Introduction Some 2005
More informationTechnical Service BULLETIN
Technical Service BULLETIN November 10, 2005 Title: Models: 05 Tacoma SU002-05 SUSPENSION TSB REVISION NOTICE: November 11, 2005: Production Change Production Change Effective VINs have been updated. Warranty
More informationAB60 Transmission C1 Clutch Damage
T-SB-0170-09 June 4, Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2008 Sequoia Drive Type(s):, 2WD Engine(s): 3UR
More informationM.I.L. "ON" DTC P0101, P0121, P0171, P0172, P035#, P223#
T-SB-0379-08 November 26, 2008 M.I.L. "ON" DTC P0101, P0121, P0171, P0172, P035#, P223# Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL
More informationTechnical Service BULLETIN
Technical Service BULLETIN January 12, 2005 Title: Models: 03 05 4Runner BO001-05 BODY TSB REVISION NOTICE: November 30, 2005: The note in step 9 of the section has been updated. In the Reassembly section,
More informationAbnormal Noise when Brake Pedal Released
T-SB-0363-10 December 22, 2010 Service Category Brake Section Brake Control/Dynamic Control System Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010 2011 Prius Introduction Some 2010
More information6-Speed Manual Clutch Release Bearing Squeak or Rattle Noise
T-SB-0365-10 December 22, 2010 6-Speed Manual Clutch Release Bearing Squeak or Rattle Noise Service Category Drivetrain Section Manual Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL
More informationTransaxle Whine Noise
T-SB-030-2 August 8, 202 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2006 202 RAV4 Drive Type(s): 4WD, 2WD Engine(s):
More informationTechnical Service BULLETIN
Technical Service BULLETIN July 2, 2004 Title: Models: 03 04 Matrix (ZZ FE) EG026-04 ENGINE TSB REVISION NOTICE: October 8, 2004: Part number for replacement (PCM) in Figure 2 on page 5 has been updated;
More informationATF Leak from Transfer Case
T-SB-0335-08 November 3, 2008 Service Category Drivetrain Section Transfer/4wd/Awd Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2008 Highlander Drive Type(s): 4WD Engine(s): 2GR Transmission(s):
More informationAutomatic Transmission Serial Number Locations
T-SB-0200-08 August 7, 2008 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) (S) ADDITIONAL INFORMATION 2006 2009 4Runner, Avalon, Camry, Corolla, FJ
More informationYEAR(S) MODEL(S) ADDITIONAL INFORMATION
T-SB-0008-14 Rev1 July 28, 2014 Service Category Drivetrain Section Drive Shaft/Propeller Shaft Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2005 2014 Tacoma Engine(s): 1GR Transmission(s):
More information3rd Row Seat Rear Leg Latch Squeak/Rattle - Manual Seat Only
T-SB-0147-14 November 19, 2014 3rd Row Seat Rear Leg Latch Squeak/Rattle - Manual Seat Only Service Category Vehicle Interior Section Seat Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION
More informationMIL "ON" DTC P030#, Intermittently Runs Rough, and/or Engine Oil Consumption
L-SB-0124-12 November 30, 2012 MIL "ON" DTC P030#, Intermittently Runs Rough, and/or Engine Oil Consumption Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S)
More informationHesitation on Acceleration
L-SB-0033-08 Rev2 June 6, 2008 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2012 LS460 2008 2012 LS600H REVISION NOTICE
More informationTechnical Service BULLETIN
Technical Service BULLETIN December 22, 2007 Title: Models: 08 Scion xb BO022-07 BODY Introduction Some customers may experience a condition where the left hand upper cowl reinforcement cover may become
More informationVibration Between MPH
T-SB-0069-08 Rev1 May 21, 2008 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2009 Camry Engine(s): 2AZ Transmission(s):
More informationTitle: TCM CALIBRATION UPDATE: M.I.L. ON DTC P2716 Models: 07 Camry (2GR -FE, 6 -Speed A/T)
Technical Service BULLETIN December 12, 2006 Title: TCM CALIBRATION UPDATE: M.I.L. ON DTC P2716 Models: 07 Camry (2GR -FE, 6 -Speed A/T) TSB REVISION NOTICE: S January 12, 2007: Production Change has been
More informationTechnical Service BULLETIN
Technical Service BULLETIN July 20, 2007 Title: Models: 05 06 Tacoma 4x4 & PreRunner SU006-07 SUSPENSION Introduction Some customers may experience a harsh ride from the rear suspension while carrying
More informationRoof Drip Molding Loose
T-SB-0053-12 March 6, 2012 Service Category Vehicle Exterior Section Exterior Panels/Trim Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010 2012 Highlander VDS(s): BK3EH, DK3EH, YK3EH,
More informationUpper/Lower Windshield/Rear Glass Tick Noise
T-SB-0141-10 Rev1 June 4, 2010 Service Category Vehicle Exterior Section Window/Glass Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2003 2013 4Runner, Avalon, Avalon HV, Camry, Camry
More informationTechnical Service BULLETIN
Technical Service BULLETIN February 8, 2005 Title: Models: 04 05 Camry (V6) EG009-05 ENGINE Introduction Under certain driving conditions, some 2004 and 2005 model year Camry vehicles may exhibit a M.I.L.
More informationMoisture in Rear Combination Light / Water Intrusion Into Vehicle
S-SB-0002-13 January 16, 2013 Moisture in Rear Combination Light / Water Intrusion Into Vehicle Service Category Vehicle Exterior Section Lighting (ext) Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL
More informationGrille Wind Whistle Noise
T-SB-0144-13 September 23, 2013 Service Category Vehicle Exterior Section Exterior Panels/Trim Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2012 2013 Tacoma Introduction Some 2012 2013
More informationWater Leak At Back Door Hatch
T-SB-0008-12 January 6, 2012 Service Category Vehicle Exterior Section Door/Hatch Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2006 2007 Highlander HV 2001 2007 Highlander Introduction
More informationRubbing Noise from Steering Shaft/Column Area
L-SB-0084-13 October 25, 2013 Service Category Steering Section Steering Gear/Linkage Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2011 2013 LS460 Drive Type(s): 4WD VDS(s): CL1EF,
More informationMIL "ON" DTC P0012 and/or P0022
T-SB-0019-10 January 0, 010 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 010 Sequoia, Tundra Engine(s): 1UR, 3UR Introduction
More informationTechnical Service BULLETIN
Technical Service BULLETIN July 1, 2004 Title: Models: 02 04 Camry (2AZ FE) (Non PZEV) EG024-04 ENGINE TSB REVISION NOTICE: April 3, 2007: A new step 3 and Figure 2 have been added to the (regarding removal
More informationWhine Noise From Rear of Vehicle
T-SB-003-8 February 6, 208 Service Category Drivetrain Section Axle/Differential Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMION 206-207 Tacoma Body Type(s): D CAB Introduction Some 206
More informationDriveline Vibration Under Deceleration Around MPH
T-SB-0171-16 Rev1 December 6, 2016 Driveline Vibration Under Deceleration Around 10-30 MPH Service Category Drivetrain Section Drive Shaft/Propeller Shaft Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL
More informationCharging System Inoperative
T-SB-0055-12 March 13, 2012 Service Category Power Source/Network Section Battery/Charging Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2011 Avalon, RAV4, Venza 2011 2012 Camry, Highlander,
More informationHID Headlamp Housing Paint Bubble / Poor Appearance
L-SB-0005-12 Rev1 February 1, 2012 Service Category Vehicle Exterior Section Lighting (ext) Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2011 2013 IS F, IS250, IS250C, IS350, IS350C
More information2009 Corolla, Matrix Drive Type(s): 2WD Engine(s): 2ZR VDS(s): BL40E, BU40E, KU40E
T-SB-0175-09 Rev1 June 11, 2009 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2009 Corolla, Drive Type(s): 2WD Engine(s):
More informationIntermittent Battery Discharge
L-SB-0035-16 July 8, 2016 Service Category Power Source/Network Section Battery/Charging Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2013-2014 ES350, GS350 2014-2015 IS250, IS350 Introduction
More informationTechnical Service BULLETIN
Technical Service BULLETIN March 9, 004 Title: Models: 03 04 4Runner BO005-04 BODY TSB REVISION NOTICE: April 8, 004: A note has been added to step 4 on page 3 to clarify the removal of the roof rack.
More informationMIL "ON" DTC P0A80 due to Dust or Debris in HV Battery Cooling Fan
T-SB-0098-12 July 13, 2012 MIL "ON" DTC P0A80 due to Dust or Debris in HV Battery Cooling Fan Service Category Engine/Hybrid System Section Hybrid/Battery Control System Market USA Applicability YEAR(S)
More informationYEAR(S) MODEL(S) ADDITIONAL INFORMATION. The Warranty Information and Parts Information sections have been updated.
T-SB-0044-14 Rev1 July 7, 2014 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2012 2014 Tacoma REVISION NOTICE October 14,
More informationWind (Reed/Buzz) Noise From Front Doors - Cross- Wind Conditions
T-SB-0170-16 Rev1 December 2, 2016 Wind (Reed/Buzz) Noise From Front Doors - Cross- Wind Conditions Service Category Vehicle Exterior Section Door/Hatch Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL
More informationTechnical Service BULLETIN
Technical Service BULLETIN June 14, 2006 Title: Models: 01 06 Sequoia EL007-06 ELECTRICAL Introduction Some 2001 2006 model year Sequoia vehicles may experience a condition where the back door power window
More informationATTENTION: This Technical Service Bulletin was issued by Southeast Toyota Distributors, LLC.
ATTENTION: This Technical Service Bulletin was issued by Southeast Toyota Distributors, LLC. For Toyota Dealers located within the Southeast Region: Please refer to SET Dealer Daily to obtain instructions
More information2ZR-FXE Engine Oil Consumption Inspection Procedure
T-SB-0168-16 November 16, 2016 Service Category Engine/Hybrid System Section Engine Mechanical Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010, 2012-2014 Prius PHV 2012-2014 Prius
More informationYEAR(S) MODEL(S) ADDITIONAL INFORMATION
T-SB-0007-11 January 7, 2011 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2009 2011 RAV4 Drive Type(s):, Engine(s):
More informationTechnical Service BULLETIN
Technical Service BULLETIN April 6, 2007 Title: Models: 04 & EG07-07 ENGINE Introduction Under certain driving conditions, some 2004 model year and vehicles may exhibit a M.I.L. ON condition with DTC P033
More informationTechnical Service BULLETIN July 1, 2004
2004 Camry (L4 2AZFE) Technical Service BULLETIN July 1, 2004 Title: M.I.L. "ON" DTC P0420 Models: 02 04 Camry (2AZ FE) (Non PZEV) Report a problem with this article TSB REVISION NOTICE: April 3, 2007:
More informationFront Differential Growl/Howl/Rumble Noise at MPH
T-SB-0121-08 Rev1 June 30, 2008 Service Category Drivetrain Section Axle/Differential Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2008 Tundra Body Type(s): Double Cab, Crew Max,
More informationECM Calibration: Shift Feeling Enhancements
T-SB-0077-16 July 14, 2016 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2016 Tacoma VDS(s): AZ5CN, BZ5DN, CZ5AN,
More informationRepair Manual Supplement: Vehicle Pulling to One Side
T-SB-0391-08 Rev1 December 24, 2008 Service Category Suspension Section Alignment/Handling Diagnoses Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2002 2014 4Runner, Avalon, Camry, Corolla,
More informationMIL "ON" DTC P2195, P0138, and/or P0031
T-SB-0066-10 February 5, 2010 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010 Corolla Engine(s): 2ZR Transmission(s):
More informationFront Bumper Cover Paint Peeling or Chipping
L-SB-0151-10 November 17, 2010 Service Category Vehicle Exterior Section Paint/Coatings Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010 2011 GX460 Introduction Some 2010 2011 model
More informationMIL "ON" DTC P2195, P0138, and/or P0031
T-SB-0065-10 February 5, 2010 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2009 Corolla Engine(s): 2ZR Transmission(s):
More informationTechnical Service BULLETIN
Technical Service BULLETIN May 28, 2004 Title: Models: 03 04 Corolla EG016-04 ENGINE Introduction Some customers may complain of excessive sulfur dioxide odor on 2003 2004 model year Corolla vehicles under
More informationRear Differential Coupling Growl Noise
T-SB-0080-13 Rev1 June 14, 2013 Service Category Drivetrain Section Axle/Differential Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2006 2012 RAV4 Drive Type(s): 4WD Transmission(s):
More informationTechnical Service BULLETIN
Technical Service BULLETIN August 21, 2006 Title: Models: 03 07 4Runner BO016-06 BODY TSB REVISION NOTICE: August 25, 2006: The Warranty Information table has been updated to include warranty. Previous
More informationECM/TCM Calibration: Shift Feeling Enhancement
T-SB-0287-10 October 13, 2010 Service Category Engine/Hybrid System Section Engine Control Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2010 2011 Camry Engine(s): 2AR Transmission(s):
More informationWindow Freezing, Losing Initialization
S-SB-0001-14 January 9, 2014 Service Category Vehicle Exterior Section Window/Glass Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2013 FR-S Introduction Some 2013 model year Scion FR-S
More informationTorque Converter Flex Lock-up Shudder
T-SB-0023-5 Rev May 2, 205 Service Category Drivetrain Section Automatic Transmission/Transaxle Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 203 205 RAV4 REVISION NOTICE August 3, 207
More informationTechnical Service BULLETIN
Technical Service BULLETIN September 16, 2002 Title: Models: 01 02 Sequoia BR005-02 BRAKES TSB REVISION NOTICE: March 5, 2004: A torque specification on page 9, step 24, was changed. September 8, 2003:
More informationHeadlamp Durability Enhancement
T-SB-004- Rev October 7, 0 Service Category Vehicle Exterior Section Lighting (ext) Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 00-0 Prius REVISION NOTICE October 7, 07 Rev: The Repair
More informationTechnical Service BULLETIN
Technical Service BULLETIN September 12, 2002 Title: Models: 00 05 Tundra BR004-02 BRAKES TSB REVISION NOTICE: April 4, 2005: Applicable Vehicles has been updated to include 2003 2005 model years. The
More information2AZ Engine Oil Consumption Inspection Procedure
T-SB-0158-14 Rev2 December 12, 2014 Service Category Engine/Hybrid System Section Lubrication Market USA Applicability YEAR(S) MODEL(S) ADDITIONAL INFORMATION 2007 2011 Camry HV Engine(s): 2AZ VDS(s):
More information