LM Test Report for OSRAM SYLVANIA INC. 100 Endicott Street Danvers, MA 01923

Transcription

1 LM Test Report for OSRAM SYLVANIA INC. 100 Endicott Street Danvers, MA Model(s) This test report presents the results of measurements performed on the product Spectrum Lighting SX1605RDLED18W35KE1/SM/OP DL1100 LED Luminaire, in accordance with LM Electrical and Photometric Measurements of Solid State Lighting Products. Test Personnel: P. Donhauser K. Phan Test Date: 12/30/2011 1/11/2012 NVLAP Signatory: Mark B. Sapcoe Laboratory: Report Number: Metrology & Analytics Services NVLAP Code: OSRAM SYLVANIA INC. 71 Cherry Hill Drive Beverly, MA Voice: Fax: mark.sapcoe@sylvania.com FOR THE SCOPE OF ACCREDITATION UNDER NVLAP LAB CODE This report does not imply product certification, approval or endorsement by NVLAP, NIST or any agency of the federal government. Page 1 of 12

2 General Information Product tested The product tested is the Spectrum Lighting SX1605RDLED18W35KE1/SM/OP LED Luminaire containing a Sylvania DL1100 LED module, and an OSRAM Optotronic OT17/700C/UNV driver (NAED 51597). This test report is prepared on behalf of OSRAM SYLVANIA INC. in accordance with American National Standards Institute standards, Illumination Engineering Society of North America Lighting Methods and International Commission on Illumination (CIE) publications listed below: IESNA LM 79 08, Approved Method for the Electrical and Photometric Testing of Solid State Lighting Products IESNA LM , Guide for the Selection, Care and Use of Electrical Instruments in the Photometric Laboratory CIE Publication No , Method of Measuring and Specifying the Color Rendering of Light Sources. The objective is to demonstrate compliance of the product evaluated to LM Electrical and Photometric Measurements of Solid State Lighting Products. Laboratory Accreditation Metrology & Analytics Services (MAS) is a department of the Central Research and Services Laboratory of OSRAM SYLVANIA INC. MAS is located at 71 Cherry Hill Drive, Beverly, MA MAS is accredited under the National Voluntary Laboratory Accreditation Program (NVLAP), Energy Efficient Lighting (EEL) program. NVLAP is a division of the National Institute of Standards and Technology. MAS NVLAP Laboratory Code is Page 2 of 12

3 Test Equipment Goniometric Description Manufacturer Model No. Serial No. Calibration (Cycle in yrs.) High Speed Goniophotometer Lighting Sciences, Inc TE0168T 4/5/2011 (1) OL 770 Multi channel Spectroradiometer Gooch and Housego 770VIS/NIR /5/2011 (1) Digital Power Meter Yokogawa WT V /19/11 (1) Power Supply Kikusui PCR4000L DJ Not Required Digital Thermometer Fluke /23/2011 (1) Calibrated for luminous intensity and spectral irradiance using NIST intensity standard lamp NBS Assigned candela reading per 844/ is 1466 cd. Integrating Sphere Description Manufacturer Model No. Serial No. Calibration (Cycle in years) Integrating Sphere 2.4 Meter Not required Monochromator Optronics 750 M D Not required Silicon Detector Head Optronics DH Not required Detector Support Module Optronics DSM 1D Not required Flux Cal Lamp Hoffman 1000W FEL /1/2008 (4) Flux Cal Lamp Hoffman 1000W FEL /1/2008 (4) AC Line Conditioner ELGAR 5006B Not required Digital Power Meter Yokogawa AW /01/2010 (3) D.C. Power Supply Hewlett Packard 6030A 3332A03465 Not required Shunt (S2) Biddle Co /18/2011 (1) Multimeter Keithley /30/2010 (3) Multimeter Keithley /30/2010 (3) Thermistor Indicator/Controller Omega DP25 TH A1 R /13/2010(3) Calibration intervals are based on critical evaluations of equipment and standards behavior as per ANS/ISO/IEC 17025:2005(E) All calibrations are directly traceable to a NMI (NIST) through an unbroken chain of calibrations or comparisons. Page 3 of 12

4 Procedure Goniometry The luminaire was operated in its intended orientation in application. The luminaire reference plane was located at the center of the luminaire goniometer at a test distance of 45 feet from the detectors. The luminaire was operated at an input voltage of 120VAC supplied by a four contact connection. The luminaire was stabilized per the criteria of LM 79 prior to the measurement. 5 vertical scans were taken due to symmetry of the source output. Color uniformity was measured at two horizontal angles, 0 and 90. Total operating time prior to measurement is approximately 2 hours. Ambient temperature during testing was maintained at 25 C ± 1 C. Integrating Sphere Radiometry Calibration of the sphere spectroradiometer system was performed using the flux calibration lamp. The lamp was mounted in the sphere in its intended orientation in application. The lamp was operated at 120VAC. The lamp was stabilized per the criteria of LM 79 prior to the measurement. After the lamp was stabilized inside the sphere, electrical and spectrophotometric measurements were simultaneously performed. Ambient temperature during testing was maintained at 25 C ± 1 C. Page 4 of 12

5 Measured and Derived Performance Parameters Integrating Sphere Values Integrating Sphere Values Voltage /V Current /A Special Color Rendering Indices Wattage /W R1 83 Power Factor R2 87 ITHD 7.00% R3 88 Lumens 716 R4 83 Efficacy /LPW 48.2 R5 80 x R6 79 y R7 91 u R8 76 v R9 38 Duv R10 66 CCT /K 3301 R11 79 CRI 83 R12 53 R9 38 R13 83 S/P 1.38 R14 92 T amb / C 24.8 Goniophotometer Values Goniometric Values Voltage /V Current /A Wattage /W Power Factor ITHD 7.32% Lumens 724 Efficacy /LPW 48.8 T amb / C 24.8 Goniophotometer Values Second Input Voltage Goniometric Values Voltage /V Current /A Wattage Power ITHD 25.64% Tamb / C 24.8 Page 5 of 12

6 Absolute Spectral Radiant Flux 1.40E 2 W/nm Spectrum Lighting SX1605RDLED18W35KE1/SM/OP DL1100 LED Luminaire 1.20E E E E E E E nm Page 6 of 12

7 Absolute Spectral Radiant Flux Absolute Spectral Flux nm W/nm nm W/nm nm W/nm nm W/nm nm W/nm E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E 04 Page 7 of 12

8 Spatial Distribution Photometry Manufacturer: Spectrum Lighting Luminaire: SX1605RDLED18W35/SM/OP Lamp: Sylvania DL1100 Driver Desc: OT17W/700C/UNV Driver Cat: Luminaire Output: 725 Lumens Max Candela: at Horizontal: 0, Vertical: 0 Input Wattage: 14.8 Luminous Opening: Circular (Dia: 11.04") Test: Test Lab: OSRAM SYLVANIA Photometry : Type C Zonal Lumen Summary Zone Lumens % Luminaire % % % % % % % % % Lumens Per Zone Zone Lumens % Total Zone Lumens% Total % % % % % % % % % % % % % % % % % % % % % % % % % % % % % % % % % % % % Page 8 of 12

9 Spatial Distribution Photometry (continued) Candela Table - Type C Candela Table - Type C Page 9 of 12

10 Spatial Color Deviation Average Weighted u', v' Horizontal Vertical Spatial u', v' Du'v' Page 10 of 12

11 Compliance to Specification for Chromaticity of Solid State Lighting Products 0.46 Nominal CCT Categories ANSI_NEMA_ANSLG C Planckian locus 3500 K 3000 K 2700 K K y K 5000 K 4500 K K 3000 K 2500 K K 5000 K K 7000 K x Page 11 of 12

12 Page 12 of 12