Fuel Pump Electrical Circuit Diagnosis

Size: px
Start display at page:

Download "Fuel Pump Electrical Circuit Diagnosis"

Transcription

1 1999 Chevrolet/Geo Tahoe - 4WD Fuel Pump Electrical Circuit Diagnosis Refer to Fuel Controls. Circuit Description When the ignition switch is turned ON, the VCM energizes the fuel pump relay which powers the in-tank fuel pump ON. The in-tank fuel pump remains ON as long as the engine is cranking or running and the VCM is receiving the distributor reference pulses. If there are no reference pulses, the VCM shuts the fuel pump OFF within 2 seconds after the ignition was turned ON or if the engine stops. The VCM will also turn ON the fuel pump for 2 seconds when the ignition is turned to the OFF position. Diagnostic Aids If the fuel pump relay circuit checks out OK, refer to Fuel System Diagnosis. Excessive fuel may also cause long cranking times which is accompanied by the following conditions: A start that is not as fast as normal. A puff of black smoke at the tailpipe. An improperly connected or faulty EVAP component can cause this problem. Refer to Evaporative Emission (EVAP) Control System Diagnosis. One or more leaking poppet nozzles (CSFI injectors) may also extend the cranking time. Perform the Injector Balance Test. Refer to Fuel Injector Balance Test with Tech 2. Test Description Number(s) below refer to step number(s) on the Diagnostic Table. 1. The Powertrain OBD System Check prompts the technician to complete some basic checks and stores the freeze frame and failure records data on the scan tool, if applicable. This creates an electronic copy of the data taken when the malfunction occurred. The information is then stored in the scan tool for later reference. 3. If the no start condition was due to a open fuse, locate and repair any shorts that may have caused the fuse to open before replacement. 4. This step determines if the fuel pump circuit can be controlled by the VCM. The VCM should energize the fuel pump relay and turn the fuel pump ON when commanded by the scan tool. If the engine is not cranking or running, the VCM should de-energize the relay and turn OFF the fuel pump after 2 seconds. 5. Jumpering the fuel pump positive voltage terminal to the fuel pump relay ignition positive voltage terminal verifies that the fuel pump relay ignition positive voltage circuit, the fuel pump positive voltage circuit, the fuel pump and fuel ground are all OK. 8. This step checks for an open ground circuit. 17. Replacement VCMs must be reprogrammed. Refer to the latest Techline information for programming

2 procedures. 18. This step checks the fuel pump ground circuit on the fuel tank side of the body harness connector only. If the fuel pump ground circuit is OK, then the fuel pump positive voltage circuit or the fuel pump ground circuit in the fuel tank harness or the fuel pump itself is malfunctioning. 21. This test will determine if a short to ground on the fuel pump positive voltage circuit caused the fuse to open. To prevent mis-diagnosis, be sure the fuel pump harness is disconnected before the test. Fuel Pump Circuit Diagnosis Step Action Was the Powertrain On-Board Diagnostic (OBD) System Check performed? 1 Value (s) Yes No Go to Powertrain On Board Diagnostic (OBD) System Go to Step 2 Check 2 Does the fuel pump run continuously with the ignition key OFF? Go to Step 26 Go to Step Inspect the fuel pump relay fuse. Is the fuse OK? 1. Turn the ignition switch ON. 2. Install a scan tool. 3. Using the scan tool, command the fuel pump relay ON. Does the in-tank fuel pump run when commanded ON? 1. Disconnect the fuel pump relay. 2. Using a fused jumper wire, connect the fuel pump positive voltage terminal to the fuel pump relay ignition positive voltage terminal. Go to Step 4 Go to Step 21 Go to Engine Cranks but Does Not Run Go to Step Does the fuel pump run? 1. With a test lamp connected to ground, probe the fuel pump relay control terminal. 2. Command the fuel pump ON with the scan tool. With a test lamp connected to ground, probe the ignition positive voltage terminal to the fuel pump relay. With a test lamp connected to B+, probe the ground terminal to the fuel pump relay. Check for an open or short to ground in the fuel pump control circuit and repair as necessary. 1. Reinstall the fuel pump relay. 2. Disconnect the fuel pump electrical harness at the rear body harness connector. 3. Probe the fuel pump positive voltage terminal (body side) Go to Step 6 Go to Step 7 Go to Step 8 Go to Step 9 Go to Step 10 Go to Step 11 Go to Step 12 Go to Step 13 Go to Step 31 Go to Step 14

3 10 with a test lamp connected to ground. 4. Command the fuel pump ON with the scan tool. Go to Step 15 Go to Step Repair the open in the ignition positive voltage circuit for the fuel pump relay. Go to Step Replace the fuel pump relay. Refer to Fuel Pump Relay Replacement. Go to Step Repair the open ground circuit to the fuel pump relay. Go to Step Inspect connections and terminals at the VCM and repair as necessary. Go to Step 31 Go to Step With a test lamp connected to B+, probe the fuel pump ground circuit (body harness side). Go to Step 18 Go to Step Repair the open or short to ground in the fuel pump positive voltage circuit. Go to Step Replace the VCM. 2. Refer to VCM Replacement/Programming. 3. Perform the Passlock Reprogramming Procedure. 4. Perform the Crankshaft Variation Learn Procedure. Refer to CKP System Variation Learn Procedure. Go to Step Check the fuel pump positive voltage and ground circuits at the body connector (tank side) for an open. Repair the circuit as necessary, refer to Connector Repairs in Wiring Systems. Go to Step 31 Go to Step Repair the open fuel pump ground circuit. Go to Step 31 Before replacing the fuel sender, refer to Intermittents and Poor Connections Diagnosis. 20 Replace the fuel pump. Refer to Fuel Sender Assembly Replacement. Go to Step 31 Caution

4 The fuel pump will operate for 2 seconds after you have turned off the ignition. Make sure that all the fuel pipes and fittings are securely fastened in order to prevent personal injury Turn the ignition switch OFF. 2. Disconnect the fuel pump electrical harness at the rear body harness connector. 3. Disconnect the fuel pump relay. 4. Probe the fuel pump positive voltage terminal at the relay connector with a test lamp connected to B+. Go to Step 22 Go to Step Repair the short to ground in the fuel pump positive voltage circuit. Go to Step With the test lamp still connected to B+, probe the fuel pump relay ignition positive voltage circuit terminal. Go to Step 24 Go to Step Repair the short to ground in the fuel pump relay ignition positive voltage circuit. Go to Step Check the fuel pump positive voltage circuit in the fuel pump harness (tank side) for a short to ground and repair as necessary. Go to Step 31 Go to Step Disconnect the fuel pump relay. Does the fuel pump continue to run? Go to Step 30 Go to Step With a test lamp connected to ground, probe the fuel pump relay control cavity with the ignition key in the OFF position. Go to Step 29 Go to Step Replace the fuel pump relay. Refer to Fuel Pump Relay Replacement Go to Step Check for a short to voltage on the fuel pump relay control line. Go to Step Check for a short to voltage on the fuel pump positive voltage line from the fuel pump relay to the fuel pump. Go to Step Using the scan tool, clear the DTCs. 2. Attempt to start the engine. Does the engine start and continue to run? Go to Step 32 Go to Step 4

5 32 1. Allow the engine to idle until normal operation temperature is reached. 2. Check if any DTCs are set. Are any DTCs displayed that have not been diagnosed? Go to applicable DTC table System OK

DTC P1351 Ignition Coil Control Circuit High Voltage

DTC P1351 Ignition Coil Control Circuit High Voltage Page 1 of 5 1996 Chevrolet Chevy K Pickup - 4WD Chevy Pickup, GMC Pickup, Suburban, Tahoe, Yukon (VIN C/K) Service Manual Document ID: 34079 DTC P1351 Ignition Coil Control Circuit High Voltage Circuit

More information

DTC P0341 Camshaft Position (CMP) Sensor Performance

DTC P0341 Camshaft Position (CMP) Sensor Performance Page 1 of 5 1998 Chevrolet Cavalier : Diagnostics > Diagnostic Routines > Powertrain > Engine Controls - 2.2L > DTC P0341 Camshaft Position (CMP) Sensor Performance DTC P0341 Camshaft Position (CMP) Sensor

More information

Fuel Pump Electrical Circuit Diagnosis

Fuel Pump Electrical Circuit Diagnosis Page 1 of 6 Document ID# 599891 2000 Chevrolet Camaro Feedback Print Fuel Pump Electrical Circuit Diagnosis Circuit Description When the ignition switch is ON, the powertrain control

More information

DTC P0102 Mass Air Flow (MAF) Sensor Circuit Low Frequency

DTC P0102 Mass Air Flow (MAF) Sensor Circuit Low Frequency Seite 1 von 5 Document ID# 187823 1998 Chevrolet/Geo Tahoe - 2WD Print DTC P0102 Mass Air Flow (MAF) Sensor Circuit Low Frequency Circuit Description The mass air flow (MAF) sensor is

More information

Idle Air Control (IAC) System Diagnosis

Idle Air Control (IAC) System Diagnosis 2000 GMC Truck GMC K Sierra - 4WD Idle Air Control (IAC) System Diagnosis Circuit Description The vehicle control module (VCM) controls idle RPM with the idle air control (IAC) valve. To increase idle

More information

Enhanced Ignition System Diagnosis

Enhanced Ignition System Diagnosis Page 1 of 7 1998 Chevrolet Chevy K Pickup - 4WD Chevy Pickup, GMC Pickup, Suburban, Tahoe, Yukon (VIN C/K) Service Manual Engine Engine Controls - 5.0L and 5.7L Diagnostic Information and Procedures Enhanced

More information

DTC P0336 Crankshaft Position (CKP) Sensor Performance

DTC P0336 Crankshaft Position (CKP) Sensor Performance Page 1 of 5 1998 Chevrolet Chevy K Pickup - 4WD Chevy Pickup, GMC Pickup, Suburban, Tahoe, Yukon (VIN C/K) Service Manual Document ID: 188141 DTC P0336 Crankshaft Position (CKP) Sensor Performance Circuit

More information

DTC P1336 Crankshaft Position (CKP) System Variation Not Learned

DTC P1336 Crankshaft Position (CKP) System Variation Not Learned Page 1 of 5 Document ID# 243256 1998 Chevrolet/Geo Express Print DTC P1336 Crankshaft Position (CKP) System Variation Not Learned Circuit Description The crankshaft position (CKP) sensor

More information

DTC P1406 Exhaust Gas Recirculation (EGR) Position Sensor Performance

DTC P1406 Exhaust Gas Recirculation (EGR) Position Sensor Performance 1996 Chevrolet Blazer - 4WD DTC P1406 Exhaust Gas Recirculation (EGR) Position Sensor Performance Circuit Description The VCM constantly monitors the linear EGR valve pintle position sensor in order to

More information

DTC P0341 Camshaft Position (CMP) Sensor Performance

DTC P0341 Camshaft Position (CMP) Sensor Performance Page 1 of 5 1999 Buick Century Century, Regal VIN W Service Manual Document ID: 345654 DTC P0341 Camshaft Position (CMP) Sensor Performance Circuit Description During cranking, the Ignition Control Module

More information

DTC P1655 Evaporative Emission (EVAP) Purge Solenoid Control Circuit

DTC P1655 Evaporative Emission (EVAP) Purge Solenoid Control Circuit Page 1 of 5 1997 Pontiac Grand Am Achieva, Grand Am, Skylark (VIN N) Service Manual Document ID: 58460 DTC P55 Evaporative Emission (EVAP) Purge Solenoid Control Circuit Circuit Description Output Driver

More information

No signal from the CMP sensor for 3 seconds with the PCM receiving an engine start signal.

No signal from the CMP sensor for 3 seconds with the PCM receiving an engine start signal. DTC P0340 Circuit Description The DTC P0340 Camshaft Position (CMP) Sensor Circuit diagnostic monitors the output of the CMP sensor. The CMP sensor is located in the distributor and consists of a signal

More information

DTC P Shift Solenoid Circuit Electrical

DTC P Shift Solenoid Circuit Electrical 1998 Pontiac Grand Prix DTC P0753 1-2 Shift Solenoid Circuit Electrical Circuit Description The 1-2 Shift Solenoid Valve Assembly (1-2 SS Valve Assy.) controls the transmission fluid pressure on the 1-2

More information

1999 Chevrolet Tahoe - 4WD. DTC P1345 Crankshaft Position (CKP)-Camshaft Position (CMP) Correlation

1999 Chevrolet Tahoe - 4WD. DTC P1345 Crankshaft Position (CKP)-Camshaft Position (CMP) Correlation 1999 Chevrolet Tahoe - 4WD DTC P1345 Crankshaft Position (CKP)-Camshaft Position (CMP) Correlation Circuit Description This diagnostic trouble code (DTC) monitors the crankshaft position (CKP) and the

More information

Fuel System Diagnosis

Fuel System Diagnosis Page 1 of 6 2001 Chevrolet Express Express, Savana (VIN G) Service Manual Engine Engine Controls - 5.0L and 5.7L Diagnostic Information and Procedures Document ID: 720867 Fuel System Diagnosis Circuit

More information

DTC P1404 Exhaust Gas Recirculation (EGR) Closed Position Performance

DTC P1404 Exhaust Gas Recirculation (EGR) Closed Position Performance Page 1 of 5 DTC P1404 Exhaust Gas Recirculation (EGR) Closed Position Performance Circuit Description The PCM monirs the EGR valve pintle position input ensure that the valve responds properly commands

More information

DTC P0341 Camshaft Position (CMP) Sensor Performance

DTC P0341 Camshaft Position (CMP) Sensor Performance Page 1 of 7 1997 Buick Riviera Aurora, Riviera (VIN G) Service Manual Document ID: 53298 DTC P0341 Camshaft Position (CMP) Sensor Performance Circuit Description The camshaft position PCM input is produced

More information

Engine Cranks But Does Not Run

Engine Cranks But Does Not Run Page 1 of 5 2000 GMC Truck GMC K Sierra - 4WD Sierra, Silverado, Suburban, Tahoe, Yukon (VIN C/K) Service Manual Engine Engine Controls - 4.8L, 5.3L, and 6.0L Diagnostic Information and Procedures Engine

More information

DTC P Shift Solenoid Circuit Electrical

DTC P Shift Solenoid Circuit Electrical 1998 Pontiac Grand Prix DTC P0753 1-2 Shift Solenoid Circuit Electrical Circuit Description The 1-2 Shift Solenoid Valve (1-2 SS Valve) controls the fluid flow acting on the 1-2 and 3-4 shift valve. The

More information

Distributor Ignition DI System Diagnosis

Distributor Ignition DI System Diagnosis Page 1 of 8 2004 Chevrolet K Silverado - 4WD Sierra, Silverado VIN C/K Service Manual Engine Engine Controls - 4.3L Diagnostic Information and Procedures Document ID: 848577 Distributor Ignition DI System

More information

Fuel System Diagnosis

Fuel System Diagnosis Page 1 of 9 1999 Chevrolet Express Express, Savana (VIN G) Service Manual Engine Engine Controls - 5.0L and 5.7L Diagnostic Information and Procedures Document ID: 412957 Fuel System Diagnosis Circuit

More information

The engine is running. DTC P0351, P0352, P0353, and P0354 run continuously once the above condition has been met.

The engine is running. DTC P0351, P0352, P0353, and P0354 run continuously once the above condition has been met. Page 1 of 6 DTC P0351-P0354 Circuit Description DTCs P0351 through P0354 Ignition Coil Primary/Secondary Feedback Circuit diagnostic monitors the primary circuitry of individual ignition coils for the

More information

Fuel System Diagnosis

Fuel System Diagnosis 1996 Chevrolet Impala Caprice, Impala, Roadmaster (VIN B) Service Manual Engine Engine Controls - 4.3L (Caprice Only) and 5.7L Diagnostic Information and Procedures Document ID: 37723 Fuel System Diagnosis

More information

DTC P0216 Injection Timing Control Circuit

DTC P0216 Injection Timing Control Circuit Page 1 of 5 1998 Chevrolet Chevy K Pickup - 4WD Chevy Pickup, GMC Pickup, Suburban, Tahoe, Yukon (VIN C/K) Service Manual Document ID: 177428 DTC P0216 Injection Timing Control Circuit Circuit Description

More information

1 of 6 3/7/2013 9:56 AM 2002 Chevrolet TrailBlazer - 4WD Bravada, Envoy, TrailBlazer VIN S/T Service Manual DTC P1481 Circuit Description The powertrain control module (PCM) uses the cooling fan speed

More information

Fuel System Diagnosis

Fuel System Diagnosis Page 1 of 6 2001 Chevrolet Malibu Malibu (VIN N) Service Manual Engine Engine Controls - 3.1L (LG8) Diagnostic Information and Procedures Document ID: 704675 Fuel System Diagnosis System Description When

More information

DTC P1431 Fuel Level Sensor 2 Performance

DTC P1431 Fuel Level Sensor 2 Performance Page 1 of 8 Document ID# 610929 2000 Chevrolet Corvette Feedback Print DTC P1431 Fuel Level Sensor 2 Performance Circuit Description The right fuel level sensor 2, mounted in the rear

More information

System Description. Diagnostic Aids. Enhanced Ignition System Diagnosis

System Description. Diagnostic Aids. Enhanced Ignition System Diagnosis Enhanced Ignition System Diagnosis System Description This system includes the distributor, the CAM position sensor ignition coil with the ignition coil driver, the secondary wires, spark plugs, the knock

More information

DIAGNOSTIC TROUBLE CODE (DTC) P0430 AMPLITUDE RATIO OF POST AND PRE HEATED OXYGEN SENSORS BANK 2 (3.2L DOHC)

DIAGNOSTIC TROUBLE CODE (DTC) P0430 AMPLITUDE RATIO OF POST AND PRE HEATED OXYGEN SENSORS BANK 2 (3.2L DOHC) 1F366 ENGINE CONTROLS DIAGNOSTIC TROUBLE CODE (DTC) P0430 AMPLITUDE RATIO OF POST AND PRE HEATED OXYGEN SENSORS BANK 2 (3.2L DOHC) System Description The vehicle with 6 cylinder has two independent manifold

More information

DTC P0102 Mass Air Flow (MAF) Sensor Circuit Low Frequency

DTC P0102 Mass Air Flow (MAF) Sensor Circuit Low Frequency Page 1 of 5 1997 Pontiac Grand Prix Grand Prix (VIN W) Service Manual Engine Engine Controls - 3.8L Diagnostic Information and Procedures Document ID: 106986 DTC P0102 Mass Air Flow (MAF) Sensor Circuit

More information

2002 Buick Rendezvous - AWD

2002 Buick Rendezvous - AWD 2002 Buick Rendezvous - AWD DTC P0410 Description The control module activates the secondary air injection (AIR) system by grounding both the pump relay and the vacuum control solenoid control circuits.

More information

DTC P1515 Control Module Throttle Actuator Position Performance

DTC P1515 Control Module Throttle Actuator Position Performance Page 1 of 6 Document ID# 317225 1999 Chevrolet/Geo Corvette Print DTC P1515 Control Module Throttle Actuator Position Performance Refer to Cell 20: TP and APP Sensors for complete circuit

More information

DTC P0502 Vehicle Speed Sensor (VSS) Circuit Low Input (3.1L VIN M)

DTC P0502 Vehicle Speed Sensor (VSS) Circuit Low Input (3.1L VIN M) Page 1 of 5 1996 Pontiac Grand Am Achieva, Grand Am, Skylark (VIN N) Service Manual Document ID: 49145 DTC P0502 Vehicle Speed Sensor (VSS) Circuit Low Input (3.1L VIN M) Circuit Description The Vehicle

More information

DTC P1518 Throttle Actuator Control (TAC) Module Serial Data Circuit

DTC P1518 Throttle Actuator Control (TAC) Module Serial Data Circuit Page 1 of 6 DTC P1518 Throttle Actuator Control (TAC) Module Serial Data Circuit Circuit Description The throttle acuator control (TAC) module and the powertrain control module (PCM) communicate via a

More information

DTC P1223, P1226, P1229, P1232, P1235, P1238, P1241, or P1244

DTC P1223, P1226, P1229, P1232, P1235, P1238, P1241, or P1244 Page 1 of 5 005 Chevrolet Kodiak C-Series (Conventional) C/C5 Kodiak, TopKick C-Series Service Manual Document ID: 16600 DTC P13, P16, P1, P13, P135, P138, P11, or P1 Circuit Description The engine control

More information

DTC P0118 Engine Coolant Temperature (ECT) Sensor Circuit High Voltage

DTC P0118 Engine Coolant Temperature (ECT) Sensor Circuit High Voltage Document ID# 546741 2000 Chevrolet Chevy K Silverado - 4WD Print DTC P0118 Engine Coolant Temperature (ECT) Sensor Circuit High Voltage Circuit Description The engine coolant temperature

More information

Fuel System Diagnosis

Fuel System Diagnosis Page 1 of 8 Document ID# 104786 1997 Chevrolet Corvette Feedback Print Fuel Diagnosis (1) Fuel Pressure Gauge Bleed Hose (2) J 37287 Fuel Line Shut-off Adapters (3) Return Pipe (4) Feed

More information

Document ID# Chevrolet Corvette

Document ID# Chevrolet Corvette Page 1 of 6 Document ID# 610892 2000 Chevrolet Corvette Feedback Print D T C P 0 4 6 2 F u e l L e v e l S e n s o r C i r c u i t L o w V o l t a g e C i r c u i t D e s c r i p t i

More information

DTC P1415 Secondary Air Injection (AIR) System Bank 1

DTC P1415 Secondary Air Injection (AIR) System Bank 1 Page 1 of 5 2000 GMC Truck GMC K Sierra - 4WD Sierra, Silverado, Suburban, Tahoe, Yukon (VIN C/K) Service Manual Document ID: 546887 DTC P1415 Secondary Air Injection (AIR) System Bank 1 Circuit Description

More information

DTC P0201, P0202, P0203, P0204, P0205, P0206, P0207, or P0208

DTC P0201, P0202, P0203, P0204, P0205, P0206, P0207, or P0208 Page 1 of 9 2004 Chevrolet Chevy K Silverado - 4WD Sierra, Silverado (VIN C/K) Service Manual Document ID: 850614 DTC P0201, P0202, P0203, P0204, P0205, P0206, P0207, or P0208 Circuit Description The fuel

More information

Fuel System Diagnosis

Fuel System Diagnosis 2000 Chevrolet Corvette Corvette (VIN Y) Service Manual Document ID: 609667 Page 1 of 7 Fuel Diagnosis (1) Fuel Feed Pipe (2) Auxiliary Fuel Feed Rear Pipe (left tank to jet pump) (3) Auxiliary Fuel Return

More information

DTC P0174 Fuel Trim System Lean Bank 2

DTC P0174 Fuel Trim System Lean Bank 2 2000 Chevrolet/Geo S10 Pickup - 4WD DTC P0174 Fuel Trim System Lean Bank 2 Circuit Description In order to provide the best possible combination of driveability, fuel economy, and emission control, the

More information

The following flow charts and schematics are courtesy of General Motors Corp. Chart No. No Malfunction Indicator Lamp (MIL)

The following flow charts and schematics are courtesy of General Motors Corp. Chart No. No Malfunction Indicator Lamp (MIL) Page 1 of 13 DIAGNOSTIC CHARTS NOTE: The following flow charts and schematics are courtesy of General Motors Corp. DIAGNOSTIC CHARTS Malfunction (1) Chart No. No Malfunction Indicator Lamp (MIL) (2) A1-1

More information

# : Revised Engine Cranks But Does Not Run Diagnostic - (Sep 26, 2003)

# : Revised Engine Cranks But Does Not Run Diagnostic - (Sep 26, 2003) #03-06-04-046: Revised Engine Cranks But Does Not Run - (Sep 26, 2003) Subject: Revised Engine Cranks But Does Not Run Models: 2001-2004 Chevrolet Silverado 2003-2004 Chevrolet Kodiak 2001-2004 GMC Sierra

More information

Document ID: General Motors Corporation. All rights reserved.

Document ID: General Motors Corporation. All rights reserved. Page 1 of 6 2005 Chevrolet TrailBlazer - 4WD Envoy, Rainier, TrailBlazer, Ascender (VIN S/T) Service Manual Document ID: 1489377 DTC P0053 or P0054 Circuit Description The heated oxygen sensor (HO2S) must

More information

DTC P0300-P0308. Diagnostic Instructions. DTC Descriptors. Circuit/System Description. Conditions for Running the DTC

DTC P0300-P0308. Diagnostic Instructions. DTC Descriptors. Circuit/System Description. Conditions for Running the DTC Page 1 of 5 2009 GMC Truck Sierra - 2WD Sierra, Silverado (VIN C/K) Service Manual Engine Engine Mechanical - 4.8L, 5.3L, 6.0L, 6.2L, or 7.0L Description and Operation DTC P0300-P0308 Diagnostic Instructions

More information

# : SMU - Revised DTC P0201-P (Sep 16, 2002)

# : SMU - Revised DTC P0201-P (Sep 16, 2002) Page 1 of 8 2001 Chevrolet Chevy K Silverado - 4WD Sierra, Silverado, Suburban, Tahoe, Yukon (VIN C/K) Service Manual #02-06-04-049: SMU - Revised DTC P0201-P0208 - (Sep 16, 2002) Subject: Revised DTC

More information

1 of 14 9/4/2016 4:05 PM

1 of 14 9/4/2016 4:05 PM 1 of 14 9/4/2016 4:05 PM P0068-MANIFOLD PRESSURE/THROTTLE POSITION CORRELATION P0068-Manifold Pressure/Throttle Position Correlation Theory of Operation This DTC sets when an unexpected high intake manifold

More information

Document ID# Chevrolet Chevy Suburban - 4WD

Document ID# Chevrolet Chevy Suburban - 4WD Page 1 of 8 Document ID# 757392 2003 Chevrolet Chevy Suburban - 4WD Print DTC C0455 Circuit Description The steering wheel position sensor (SWPS) provides one analog signal and 3 digital

More information

DTC P0172 Fuel Trim System Rich

DTC P0172 Fuel Trim System Rich Page 1 of 6 1997 Chevrolet Cavalier Cavalier, Sunfire (VIN J) Service Manual Document ID: 47788 DTC P0172 Fuel Trim System Rich System Description A Closed Loop air/fuel metering system is used to provide

More information

Idle Air Control (IAC) System Diagnosis

Idle Air Control (IAC) System Diagnosis Page 1 of 6 2002 Chevrolet Tahoe - 4WD Avalanche, Escalade, Suburban, Tahoe, Yukon VIN C/K Service Manual Engine Engine Controls - 4.8L, 5.3L, and 6.0L Diagnostic Information and Procedures Document ID:

More information

# : SMU - Revised DTC P0341 Camshaft Position (CMP) Sensor Performance - (Feb 20, 2002)

# : SMU - Revised DTC P0341 Camshaft Position (CMP) Sensor Performance - (Feb 20, 2002) Page 1 of 7 2002 Buick Regal Century, Regal (VIN W) Service Manual Engine Document ID: 861441 #02-06-04-008: SMU - Revised DTC P0341 Camshaft Position (CMP) Sensor Performance - (Feb 20, 2002) Subject:

More information

DTC P3401, P3425, P3441, or P3449

DTC P3401, P3425, P3441, or P3449 Page 1 of 5 2008 Chevrolet Avalanche - 4WD Avalanche, Escalade, Suburban, Tahoe, Yukon VIN C/K Service Manual Document ID: 1914310 DTC,,, or Diagnostic Instructions Perform the Diagnostic System Check

More information

Fuel Metering System Component Description

Fuel Metering System Component Description 1999 Chevrolet/Geo Tahoe - 4WD Fuel Metering System Component Description Purpose The function of the fuel metering system is to deliver the correct amount of fuel to the engine under all operating conditions.

More information

DTC P0135, P0141, P0155, or P0161 (w/lr4 and LM7 w/ Delphi HO2S)

DTC P0135, P0141, P0155, or P0161 (w/lr4 and LM7 w/ Delphi HO2S) Page 1 of 5 2001 GMC Truck GMC K Sierra - 4WD Sierra, Silverado, Suburban, Tahoe, Yukon (VIN C/K) Service Manual DTC P0135, P0141, P0155, or P0161 (w/lr4 and LM7 w/ Delphi HO2S) Circuit Description This

More information

Scan Tool Does Not Communicate with Class 2 Device (W/O Immobilizer)

Scan Tool Does Not Communicate with Class 2 Device (W/O Immobilizer) Page 1 of 5 2002 GMC Truck Envoy - 4WD Bravada, Envoy, TrailBlazer (VIN S/T) Service Manual Body and Accessories Data Link Communications Diagnostic Information and Procedures Document ID: 754548 Scan

More information

Idle Air Control (IAC) System Diagnosis

Idle Air Control (IAC) System Diagnosis 2001 Oldsmobile Alero Idle Air Control (IAC) System Diagnosis Circuit Description The idle air control (IAC) valve is located in the throttle body. It consists of a movable pintle, driven by a gear attached

More information

DTC P20B9-P20BF or P20C0-P20C4

DTC P20B9-P20BF or P20C0-P20C4 Page 1 of 8 2014 Chevrolet Silverado 2500/3500-4WD Document ID: 3339878 DTC P20B9-P20BF or P20C0-P20C4 Diagnostic Instructions Perform the Diagnostic System Check - Vehicle prior to using this diagnostic

More information

P0882-TCM POWER INPUT LOW

P0882-TCM POWER INPUT LOW - JK - JEEP WRANGLER - L V6 (SMPI) P-TCM POWER INPUT LOW BATTERY BATT A FUSE J 5A POWER DIESEL GAS Z 6 BK Z 4 BK Z 6 BK 5 7A 7 6 ELECTRONICS 6 C C T6 6 T5 YL/OR YL/BR 5 C C T6 6 T5 YL/OR YL/BR S6 T6 T6

More information

VEHICLE SPEED CONTROL SYSTEM

VEHICLE SPEED CONTROL SYSTEM J VEHICLE SPEED CONTROL SYSTEM 8H - 1 VEHICLE SPEED CONTROL SYSTEM CONTENTS page DIAGNOSIS... 2 GENERAL INFORMATION... 1 page SERVICE PROCEDURES... 9 GENERAL INFORMATION The vehicle speed control system

More information

DRIVEABILITY - GAS. All symptoms listed above are diagnosed using the same tests. The title for the tests will be P0300-MULTIPLE CYLINDER MIS-FIRE.

DRIVEABILITY - GAS. All symptoms listed above are diagnosed using the same tests. The title for the tests will be P0300-MULTIPLE CYLINDER MIS-FIRE. Symptom List: P0300-MULTIPLE CYLINDER MIS-FIRE P0301-CYLINDER #1 MISFIRE P0302-CYLINDER #2 MISFIRE P0303-CYLINDER #3 MISFIRE P0304-CYLINDER #4 MISFIRE P0305-CYLINDER #5 MISFIRE P0306-CYLINDER #6 MISFIRE

More information

HVAC Compressor Clutch Does Not Engage

HVAC Compressor Clutch Does Not Engage Page 1 of 6 2004 Pontiac GTO GTO (VIN V) Service Manual HVAC HVAC Systems - Manual Diagnostic Information and Procedures Document ID: 1378425 HVAC Compressor Clutch Does Not Engage Test Description The

More information

P O2 SENSOR 1/1 HEATER CIRCUIT

P O2 SENSOR 1/1 HEATER CIRCUIT Page 1 of 8 P0030 - O2 SENSOR 1/1 HEATER CIRCUIT Page 2 of 8 For a complete wiring diagram Refer to Section 8W Page 3 of 8 When Monitored: With the ignition on and the Oxygen Sensor Heater command on.

More information

P0688-AUTO SHUTDOWN SENSE CIRCUIT LOW

P0688-AUTO SHUTDOWN SENSE CIRCUIT LOW - DS - RAM 5 PICKUP - 5.7L V HEMI MDS V.V.T. (EZH) P6- SHUTDOWN SENSE CIRCUIT LOW BATT A B(+) ELECTRONICS TOTALLY INTEGRATED POWER 5 SHUT DOWN 6 FUSE M 5A C C5 K5 C C K5 S4 C 4.7L/ C C C.7L 5.7L S S4 BLACK/BLACK

More information

BASIC DIAGNOSTIC PROCEDURES

BASIC DIAGNOSTIC PROCEDURES BASIC DIAGNOSTIC PROCEDURES 2001 Chevrolet Camaro 2001 ENGINE PERFORMANCE Basic Diagnostic Procedures - Cars Except Metro & Prizm MODEL IDENTIFICATION MODEL IDENTIFICATION Body Code (1) Model C... Park

More information

Service Manual. Liquefied Petroleum Gas (LPG) Fuel System For 1999 and 2000 GM 7.4L Medium Duty Chassis. Website 5/29/03

Service Manual. Liquefied Petroleum Gas (LPG) Fuel System For 1999 and 2000 GM 7.4L Medium Duty Chassis. Website 5/29/03 Service Manual Liquefied Petroleum Gas (LPG) Fuel System For 1999 and 2000 GM 7.4L Medium Duty Chassis Liquefied Petroleum Gas (LPG) Fuel System For 1999 and 2000 GM 7.4L Medium Duty Chassis This manual

More information

Control Module Command EVAP Canister Purge Valve EVAP Canister Vent Valve ON Open Closed OFF Closed Open

Control Module Command EVAP Canister Purge Valve EVAP Canister Vent Valve ON Open Closed OFF Closed Open DTC P0440 System Description The control module tests the evaporative emission (EVAP) system for a large leak. The control module monitors the fuel tank pressure (FTP) sensor signal to determine the EVAP

More information

Page 1 of 11 2009 Hummer H2 6.2L Eng 1Search Print Date: SHIFT LOCK CONTROL SYSTEM Repair Instructions Automatic Transmission Shift Lock Control Actuator Replacement Removal Procedure NOTE: After assembling

More information

SCHEMATIC AND ROUTING DIAGRAMS

SCHEMATIC AND ROUTING DIAGRAMS 2004 ACCESSORIES & EQUIPMENT Theft Deterrent - Corvette SCHEMATIC AND ROUTING DIAGRAMS THEFT DETERRENT SYSTEM SCHEMATICS Fig. 1: Theft Deterrent Relay, Security Indicator, Lighting and Horn References

More information

Fuel System (Central SFI)

Fuel System (Central SFI) Page 1 of 6 1997 GMC Truck GMC K Pickup - 4WD Chevy Pickup, GMC Pickup, Suburban, Tahoe, Yukon (VIN C/K) Service Manual Engine Engine Controls - 5.0L, 5.7L, and 7.4L Description and Operation Document

More information

Repair content for 2005 GMC W4500 Forward

Repair content for 2005 GMC W4500 Forward Page 1 of 8 Your Current Vehicle: 2005 GMC W4500 Forward DTC P2135 DTC P2135 Circuit Description The throttle position (TP) sensor incorporates two ratiometric TP sensors into one housing. TP sensor 1

More information

Evaporative Emission Control System Operation Description (Enhanced)

Evaporative Emission Control System Operation Description (Enhanced) Page 1 of 7 1999 Chevrolet Chevy Suburban - 2WD Escalade, Pickup (Classic), Suburban, Tahoe, Yukon (VIN C/K) Service Manual Document ID: 222842 Evaporative Emission Control System Operation Description

More information

Page 1 of 6 1Search Print Date: B3140 Power Door Lock Switch Malfunction - DTC B3140, B3145, B3150, Or B3155 Diagnostic Instructions Perform the Diagnostic System Check - Vehicle prior to using this diagnostic

More information

Document ID: Open/High Resistance DTC C DTC C

Document ID: Open/High Resistance DTC C DTC C Page 1 of 6 2010 Chevrolet Suburban - 4WD Avalanche, Escalade, Suburban, Tahoe, Yukon VIN C/K Service Manual Document ID: 1912824 DTC C0387 Diagnostic Instructions DTC Descriptor Perform the Diagnostic

More information

Printable View Page 1 of 18 11/26/2013 Year = 2011 Model = E

Printable View   Page 1 of 18 11/26/2013 Year = 2011 Model = E Page 1 of 18 Year = 2011 Model = Escape Engine = VIN = IDS Version = t Available Misfire Detection Monitor WARNING: Crown Victoria Police Interceptor vehicles equipped with fire suppression system, refer

More information

DTC P1811 Maximum Adapt and Long Shift

DTC P1811 Maximum Adapt and Long Shift 2000 Buick Century DTC P1811 Maximum Adapt and Long Shift Circuit Description The transmission pressure is modified by an adaptive modifier which controls the shift execution time. This test checks the

More information

DTC P0743 sets when the TCM detects an open circuit, a short to power, or a short to ground in the TCC PWM solenoid circuit for 1.5 seconds.

DTC P0743 sets when the TCM detects an open circuit, a short to power, or a short to ground in the TCC PWM solenoid circuit for 1.5 seconds. Page 1 of 5 2005 GMC Truck GMC K Sierra - 4WD Sierra, Silverado VIN C/K Service Manual Document ID: 1492351 DTC P0743 Circuit Description The torque converter clutch (TCC) solenoid is a pulse width modulated

More information

DIAGNOSTIC INFORMATION AND PROCEDURES > WIPERS INOPERATIVE - ONE OR MORE MODES

DIAGNOSTIC INFORMATION AND PROCEDURES > WIPERS INOPERATIVE - ONE OR MORE MODES 1 of 6 2/1/2015 8:12 PM 2005 Chevrolet Colorado 3.5L Eng Vehicle Reference: WIPER SYSTEMS & WASHER SYSTEMS DIAGNOSTIC INFORMATION AND PROCEDURES > WIPERS INOPERATIVE - ONE OR MORE MODES Wipers Inoperative

More information

1998 ENGINE PERFORMANCE. General Motors Corp. - Basic Diagnostic Procedures - 5.7L

1998 ENGINE PERFORMANCE. General Motors Corp. - Basic Diagnostic Procedures - 5.7L INTRODUCTION 1998 ENGINE PERFORMANCE General Motors Corp. - Basic Diagnostic Procedures - 5.7L The following diagnostic steps will help prevent overlooking a simple problem. This is also where to begin

More information

Page 1 of 5 1Search Print Date: P0179 DTC P0179: Fuel Composition Sensor Circuit High Frequency Diagnostic Instructions Perform the Diagnostic System Check - Vehicle prior to using this diagnostic procedure.

More information

Malfunction Criteria and Threshold Value Adaptive value. Secondary Parameters with Enable Conditions. >50.8 S Engine load 9-45% Delta fuel adaptation

Malfunction Criteria and Threshold Value Adaptive value. Secondary Parameters with Enable Conditions. >50.8 S Engine load 9-45% Delta fuel adaptation DTC Error Message P0171 System Too Lean (Bank 1) Diagnostic Procedure Check fuel pump delivery and quantity. Refer to page 126. Check Fuel pressure regulator and residual pressure. Refer to Fuel Injection

More information

Alternative Fuel Engine Control Unit

Alternative Fuel Engine Control Unit 1999 Chevrolet/Geo Cavalier (CNG) Alternative Fuel Engine Control Unit Table 1: AF ECU Function Parameters The (AF ECU) controls alternative fuel engine operation. The control unit monitors various engine

More information

P0344-CAMSHAFT POSITION SENSOR INTERMITTENT

P0344-CAMSHAFT POSITION SENSOR INTERMITTENT - WK - JEEP GRAND CHEROKEE -.7L MAGNUM V6 P44- SENSOR INTERMITTENT S4 S4 S9 EXCEPT 6.L 6.L F856 YL/PK K9 DB/DG F855 PK/YL F855 8 K9 PK/YL DB/DG CRANKSHAFT 5.7/6.L.7L.7L 5.7L/6.L F856 YL/PK K44 GY/DB K44

More information

P0401-EGR SYSTEM PERFORMANCE

P0401-EGR SYSTEM PERFORMANCE P0401-EGR SYSTEM PERFORMANCE P0401-EGR SYSTEM PERFORMANCE http://dh.identifix.com/searchfixes/index?roid=176514061&vid=2189101&vsm=2&locationid=2#kw=p0401&soption=1&vetid=8&stmode=1&p 1/6 For a complete

More information

Page 1 of 6 2007 Chevrolet Tahoe 5.3L Eng 1Search Print Date: P0036 DTC P0030, P0036, P0053, P0054, P0135, Or P0141 DTC Descriptors DTC P0030 HO2S Heater Control Circuit Bank 1 Sensor 1 DTC P0036 HO2S

More information

DIAGNOSTIC INFORMATION AND PROCEDURES > CHARGING SYSTEM TEST

DIAGNOSTIC INFORMATION AND PROCEDURES > CHARGING SYSTEM TEST Page 1 of 5 Service Manual: BATTERY, CHARGING SYSTEM AND Print Date: STARTING SYSTEM DIAGNOSTIC INFORMATION AND PROCEDURES > CHARGING SYSTEM TEST Charging System Test 2005 Pontiac Montana SV6 3.5L Eng

More information

Dtc P128E. Print Chevrolet Silverado 6.6L Eng 2500 Hd. 1Search P128E REQUESTED INFORMATION. Diagnostic Instructions

Dtc P128E. Print Chevrolet Silverado 6.6L Eng 2500 Hd. 1Search P128E REQUESTED INFORMATION. Diagnostic Instructions Print 1Search REQUESTED INFORMATION Dtc Diagnostic Instructions 2012 Chevrolet Silverado 6.6L Eng 2500 Hd Perform the Diagnostic System Check - Vehicle prior to using this diagnostic procedure. Review

More information

ALTERNATOR REQUESTED INFORMATION. Vehicles With Dual Generator [ Engine Mount - LH ] 2007 Ford Pickup 6.0L Eng F350 Super Duty

ALTERNATOR REQUESTED INFORMATION. Vehicles With Dual Generator [ Engine Mount - LH ] 2007 Ford Pickup 6.0L Eng F350 Super Duty ALTERNATOR 2007 Ford Pickup 6.0L Eng F350 Super Duty REQUESTED INFORMATION Vehicles With Dual Generator [ Engine Mount - LH ] Fig 1: Rotating Drive Belt Tensioner Clockwise 1. Remove the accessory drive

More information

DTC P0420. Circuit Description. Conditions for Running the DTC.

DTC P0420. Circuit Description. Conditions for Running the DTC. Page 1 of 5 DTC P0420 2003 Buick LeSabre LeSabre (VIN H) Service Manual Document ID: 792202 Circuit Description In order to control emissions of hydrocarbons (HC), carbon monoxide (CO), and oxides of nitrogen

More information

Repair content for 2005 GMC W4500 Forward

Repair content for 2005 GMC W4500 Forward Page 1 of 7 Your Current Vehicle: 2005 GMC W4500 Forward DTC P2101 DTC P2101 Circuit Description The commanded throttle position (TP), based on accelerator pedal position (APP) and possibly other limiting

More information

P0088-FUEL RAIL PRESSURE TOO HIGH

P0088-FUEL RAIL PRESSURE TOO HIGH 2008 - KA - DODGE NITRO - 2.8L 4 CYL TURBO DIESEL 28 - DTC-Based Diagnostics/MODULE, Engine Control (ECM)/Diagnosis and Testing P0088- RAIL TOO HIGH BATT A0 30 RELAY- AUTO SHUT DOWN MODULE- TOTALLY INTEGRATED

More information

1 of 8 9/11/2015 3:59 PM

1 of 8 9/11/2015 3:59 PM 1 of 8 9/11/2015 3:59 PM P013C-O2 SENSOR 2/2 SLOW RESPONSE - RICH TO LEAN For complete wiring diagrams refer to Diagrams/Electrical. - When Monitored: With the engine running, vehicle speed between 32

More information

Powertrain DTC Summaries OBD II

Powertrain DTC Summaries OBD II Powertrain DTC Summaries Quick Reference Diagnostic Guide Jaguar X-TYPE 2.5L and 3.0L 2002 Model Year Revised January, 2002: P0706, P0731, P0732, P0733, P0734, P0735, P0740, P1780 POSSIBLE CAUSES Revised

More information

P0716-INPUT SPEED SENSOR 1 CIRCUIT PERFORMANCE

P0716-INPUT SPEED SENSOR 1 CIRCUIT PERFORMANCE Page 1 of 10 P0716-INPUT SPEED SENSOR 1 CIRCUIT PERFORMANCE Circuit Schematic 2007 Dodge Nitro 3.7L Eng SXT Page 2 of 10 Fig 1: Speed Sensor Circuit Schematic Additional Wiring For complete wiring diagrams

More information

2008 Hummer H2 - Engine Performance & Emission Controls > Engine Controls - 4.8L, 5.3L,

2008 Hummer H2 - Engine Performance & Emission Controls > Engine Controls - 4.8L, 5.3L, Page 1 of 7 2008 Hummer H2 : Engine Performance & Emission Controls > Engine Controls - 4.8L, 5.3L, 6.0L, 6.2L, Or 7.0L > Diagnostic Information And Procedures > DTC P0011 DTC P0011 DTC P0011 Diagnostic

More information

TRANSMISSION - NGC. Symptom: P0706-CHECK SHIFTER SIGNAL. When Monitored and Set Condition:

TRANSMISSION - NGC. Symptom: P0706-CHECK SHIFTER SIGNAL. When Monitored and Set Condition: Symptom: P0706-CHECK SHIFTER SIGNAL When Monitored and Set Condition: P0706-CHECK SHIFTER SIGNAL When Monitored: Continuously with the ignition on. Set Condition: After 3 occurrences in one ignition cycle

More information

HD: Misfire Detection Monitor

HD: Misfire Detection Monitor 2009 PCED Gasoline Engines SECTION 5: Pinpoint Tests Procedure revision date: 12/10/2008 HD: Misfire Detection Monitor HD: Introduction HD1 CHECK FOR DIAGNOSTIC TROUBLE CODES (DTCS) Are DTCs P0300, P0301,

More information

Power Supply Circuit For Transfer Control Unit

Power Supply Circuit For Transfer Control Unit Page 1 of 7 2005 Nissan Xterra 4.0L Eng S Power Supply Circuit For Transfer Control Unit CONSULT-II REFERENCE VALUE IN DATA MONITOR MODE Data are reference value. DATA MONITOR MODE REFERENCE Monitored

More information

FUEL SYSTEM DIAGNOSIS - HIGH PRESSURE SIDE

FUEL SYSTEM DIAGNOSIS - HIGH PRESSURE SIDE 2003 Chevy Truck C 2500 Truck 2WD V8-6.6L DSL Turbo VIN 1 Vehicle > Powertrain Management > Computers and Control Systems > Testing and Inspection > Component Tests and General Diagnostics FUEL SYSTEM

More information

Active Grille Air Shutter 1 Malfunction

Active Grille Air Shutter 1 Malfunction Page 1 of 5 Active Grille Air Shutter 1 Malfunction 2015 Cadillac ATS 2.0L Eng Premium Print Date: Diagnostic Instructions Perform the Diagnostic System Check - Vehicle prior to using this diagnostic procedure.

More information