Technical Service Bulletin

Size: px
Start display at page:

Download "Technical Service Bulletin"

Transcription

1 Steering wheel shimmy vibration and/or oscillation (8T) /1 July 9, 2008 Model(s) Year VIN Range Vehicle-Specific Equipment A5, S All Not Applicable Condition Complaints of steering wheel vibration and/or steering wheel oscillation while driving at highway speeds (typically between mph). This condition does not result in any handling concerns or loss of vehicle control. Technical Background The above stated conditions may be caused by the following: Imbalanced wheel and tire assembly. Tires with high road force values. Production Solution Not applicable. Page 1 of 5

2 Service Before the test drive: It is critical to address all of the points in section Before the test drive in order to ensure that the conditions observed during the test drive are valid concerns. 1. Check tire pressures, which must be set according to what is recommended in the owner s manual or according to the table below. 2. Check wheels and tires for any damage. 3. Make sure that Audi-approved wheels and tires are installed. (See table below.) 4. Always address any concerns with the customer prior to further diagnosis. 5. Warm tires by driving the vehicle for at least 10 miles (16km) at 45 mph (72 km/h) or faster. Tires must be warm in order for the test drive to be effective since cold tires may produce a vibration due to temporary flat spotting. Tire designations for Front Rear all engine sizes Normal load PSI (up to 2 occupants) Full load PSI Normal load PSI (up to 2 occupants) Full load PSI 245/45 R17 95 H All Season 245/40 R18 97 H /35 R19 96H XL Summer Performance 8-cylinder 4.2 Only 255/35 R19 96Y XL /30 ZR20 94Y XL /35 R19 96Y XL /30 ZR20 94Y XL During the test drive Drive the vehicle with customers to verify their concern and establish whether the concern is heard, felt, observed, or a combination. Repair options based on conditions observed on the test drive 1. If the steering wheel vibrates (it may also oscillate/shimmy), proceed with the following: Page 2 of 5

3 a. Drive vehicle for at least 10 miles (16km) at speed of 45 mph (72 km/h) or above to warm up the tires. b. Immediately after the drive, raise vehicle to prevent temporary flat spotting and check road force and balance of each tire using VAS 6230 or Hunter 9700 Tire Balancer. The following points must be followed to ensure accuracy: Do not use Quick Match mode since this does not measure road force. Ensure that the wheel is centered and properly secured on the shaft of the balancer. Use adequate lubrication to ensure that tires are properly seated when they are installed on the wheel or are moved on a wheel to change mounting position. Be aware that excessive lubricant can cause a tire to slip on the wheel, which will have an impact on the balance and road force values. Make sure to print out the before and after values for each wheel and save this documentation with the repair order. Failure to provide a copy of these measurements may result in nonpayment of this claim. c. Follow all on-screen instructions to improve balance and reduce road force values (e.g. Force Matching ). It is recommended to reduce road force to the lowest possible value on all tires with a maximum value of 27 lbs. If it is not possible to reduce the road force below 27 lbs., replace the affected tire. (See tire replacement warranty information in this bulletin.) Tip: In case of high roadforce values in the replacement tire, it may be necessary to repeat steps A through C. d. Install wheels/tires with the lowest road force values closest to the driver. Keep in mind that directional tires may not allow every tire to be installed in its ideal position on the vehicle. Lowest road force value - left front. Second lowest road force value - right front. Third lowest road force value - left rear. Fourth lowest road force value - right rear. e. Test drive vehicle and verify repair. Page 3 of 5

4 2. If the above steps do not eliminate the steering wheel oscillation, please create a TACS ticket. In order to receive proper assistance, it is important to provide the following in the TACS case: Exact speed range at which the vibration or steering wheel oscillation occurs. List of all repairs performed prior to contacting TACS. List of all road force values and their position on the vehicle. Tire brand, model and size (including speed and load ratings). The Technical Assistance Center will provide further repair instructions. All warranty claims submitted including parts and labor that are outside the scope of this TSB will be declined. Any additional repairs have to be authorized by the Audi Technical Assistance Center. Warranty TIRES For current model year vehicles with low mileage, submit a claim for ride disturbance through the Dealer Tire program. All warranty claims for tires must have the before and after roadforce values attached. When procedure applies to vehicles under warranty, use the following: SAGA Claim Type: 110 Service Number: 4410 Damage Code: 0013 Labor Operations: Wheel balance Copy of the before-and-after road force and balance values must be attached to the repair order Actual time Vehicle front + rear measured 90 TU Diagnostic Time: Diagnostic time reimbursement follows guidelines printed in Section 2.2 of the Audi Warranty Policies and Procedures Manual Claim Comment: As per TSB # /1 All warranty claims submitted for payment must be in accordance with the Audi Warranty Policies and Procedures Manual. Claims are subject to review or audit by Audi Warranty. Required Parts and Tools Page 4 of 5

5 Tools Use VAS6230 Vibration Control Tire Balancer or Road Force Measurement System to check balance, Road Force values, and to make necessary adjustments. VETRONIX MTS4100 NVH Analyzer is helpful when diagnosing vibration concerns and can help narrow down the list of possible sources of the vibration. Additional Information More information can be found in the following resources: ElsaWeb: Wheel and Tire Guide >> Fault Finding SSP: Noise, Vibration, and Harshness The following repair procedure(s) will be necessary to complete this procedure: Chassis >> Wheel and Tire Guide>> Fault Finding Transmission >> Rear Final Drive 0BD >> 39 Rear Final Drive, Differential >> Drive Shaft, Removal and Installation All parts and service references provided in this TSB are subject to change and/or removal. Always check with your Parts Department and service manuals for the latest information. Page 5 of 5

Technical Service Bulletin Jul 9, Broad code

Technical Service Bulletin Jul 9, Broad code Technical Service Bulletin Topic Market area Brand Transaction No. Level Status Steering wheel shimmy vibration and/or oscillation (8T) United States 444 Volkswagen of America, Inc. (6444),Canada 999 Volkswagen

More information

Technical Service Bulletin

Technical Service Bulletin 40 Steering wheel oscillation 40 15 46 2024687/4 July 13, 2015. Supersedes Group 40 number 12-25 dated August 7, 2012 for reasons listed below. Model(s) Year VIN Range Vehicle-Specific Equipment A5 2008-2009

More information

/15 September 23, Supersedes Technical Service Bulletin Group 46 number dated July 26, 2016 for reasons listed below.

/15 September 23, Supersedes Technical Service Bulletin Group 46 number dated July 26, 2016 for reasons listed below. 46 Brake noise analysis and handling 46 16 50 2034181/15 September 23, 2016. Supersedes Technical Service Bulletin Group 46 number 16-48 dated July 26, 2016 for reasons listed below. Model(s) Year VIN

More information

Technical Service Bulletin

Technical Service Bulletin 01 MIL on (P2004, P2005, P2006, P2007, P2015, P2020 in ECM) 24 11 08 2023343/2 December 14, 2011. Supersedes Technical Service Bulletin Group 24 number 10 18 dated May 17, 2010 for reasons listed below.

More information

T e ch n ica l Se r v ice B u l l e t in

T e ch n ica l Se r v ice B u l l e t in 01 Coolant loss from coolant valve, engine warning light on, "Limp Home" mode active, cabin heating is insufficient 01 15 31 2033806/7 July 21, 2015. Supersedes Technical Service Bulletin Group 80 number

More information

Technical Service Bulletin

Technical Service Bulletin 17 Engine oil consumption - Customer complaints, 3.0T TFSI Model Year 2009 2012 17 15 61 2030197/15 April 24, 2015. Supersedes Technical Service Bulletin Group 17 number 15-59 dated March 17, 2015 for

More information

/6 March 31, Supersedes Technical Service Bulletin Group 27 number dated October 31, 2016 for reasons listed below.

/6 March 31, Supersedes Technical Service Bulletin Group 27 number dated October 31, 2016 for reasons listed below. 27 Vibrations felt at 1000 rpm and 3000 rpm 27 17 29 2036392/6 March 31, 2017. Supersedes Technical Service Bulletin Group 27 number 16-27 dated October 31, 2016 for reasons listed below. Model(s) Year

More information

Technical Service Bulletin

Technical Service Bulletin MIL on (DTC P0642, P2004, P2008, P3137, P3138 in ECM) 24 08 10 2016868/2 March 3, 2008. Supersedes Technical Service Bulletin Group 24 number 08-02 dated Jan. 17, 2008 to add a reference to RVU CH. Model(s)

More information

Technical Service Bulletin

Technical Service Bulletin 17 Oil pressure light on and/or rattle noise from engine at cold start 17 08 23 2015411/6 November 21, 2008. Supersedes Technical Service Bulletin Group 17 number 08-05 dated July 22, 2008 for reasons

More information

Technical Service Bulletin

Technical Service Bulletin Bucking when accelerating from a standstill 38 07 02 Jan. 9, 2007, 2011722/3. Supersedes Technical Service Bulletin Group 37 number 06-01 dated Jan. 27, 2006 due to slight content changes. Model(s) Year

More information

Technical Service Bulletin

Technical Service Bulletin 46 Squeal from front brakes 46 16 47 2042182/4 July 12, 2016. Supersedes Group 46 number 16-39 dated May 31, 2016 for reasons listed below. Model(s) Year VIN Range Vehicle-Specific Equipment Q5 2013 047567-999999

More information

Purpose. Revised Service

Purpose. Revised Service Technical Service Bulletin Transaction No.: 2022733/2 60 Noises from sunroof Release date: Apr 29, 2010 Condition REVISION HISTORY Revision Date Purpose 2 - Revised header data (Added models) Revised Service

More information

Model(s) Year Eng. Code Trans. Code VIN Range From VIN Range To. Passat Wagon 2007 BPY (2.0L) All 3C_7E C_7E051587

Model(s) Year Eng. Code Trans. Code VIN Range From VIN Range To. Passat Wagon 2007 BPY (2.0L) All 3C_7E C_7E051587 Model(s) Year Eng. Code Trans. Code VIN Range From VIN Range To Passat 2006 BPY (2.0L) All All All Passat 2007 BPY (2.0L) All 3C_7E000001 3C_7P000001 3C_7E051587 3C_7P045144 Passat Wagon 2007 BPY (2.0L)

More information

Model(s) Year Eng. Code Trans. Code VIN Range From VIN Range To. All All All

Model(s) Year Eng. Code Trans. Code VIN Range From VIN Range To. All All All Model(s) Year Eng. Code Trans. Code VIN Range From VIN Range To Touareg 2004 3.2L (BAA) All All All Condition 01 08 11 March 6, 2008 2015134 Supersedes Technical Bulletin Group 01 number 07-52 dated June

More information

SI B Intermediate and Special Transmission. September 2015 Technical Service

SI B Intermediate and Special Transmission. September 2015 Technical Service SI B27 04 15 Intermediate and Special Transmission September 2015 Technical Service SUBJECT Shudder from the Driveline on Vehicles with xdrive MODEL E90 (3 Series xdrive Sedan) E91 (3 Series xdrive Sports

More information

Model(s) Year Eng. Code Trans. Code VIN Range From VIN Range To All All All All

Model(s) Year Eng. Code Trans. Code VIN Range From VIN Range To All All All All Model(s) Year Eng. Code Trans. Code VIN Range From VIN Range To Golf, Tiguan, CC, Passat, Golf SportWagen, Jetta SportWagen 2013-2017 All All All All Condition 87 16 12 July 19, 2016 2043704 Supersedes

More information

F-53 MOTORHOME ISSUE

F-53 MOTORHOME ISSUE SUSPENSION VIBRATION/SHAKE FELT IN Article No. STEERING WHEEL OR SEAT 72-120 KM/H (45-75 00-21-9 MPH) VIBRATION VIBRATION/SHAKE FELT IN STEERING WHEEL OR SEAT 72-120 KM/H (45-75) MPH FORD: 1999-2001 F-53

More information

# G: Shake/Vibration in Steering Wheel, Floor, Seat at Highway Speeds on Smooth Roads (Diagnose/Balance Tires/Wheels) - (Oct 1, 2004)

# G: Shake/Vibration in Steering Wheel, Floor, Seat at Highway Speeds on Smooth Roads (Diagnose/Balance Tires/Wheels) - (Oct 1, 2004) Page 1 of 7 2004 Buick LeSabre LeSabre (VIN H) Service Manual Document ID: 1552616 #00-03-10-007G: Shake/Vibration in Steering Wheel, Floor, Seat at Highway Speeds on Smooth Roads (Diagnose/Balance Tires/Wheels)

More information

Wheels/Tires - Steering Wheel Nibble/Vibration

Wheels/Tires - Steering Wheel Nibble/Vibration Page 1 of 5 Wheels/Tires - Steering Wheel Nibble/Vibration Notes TSB 08-24-2 12/08/08 VIBRATION DIAGNOSTICS - STEERING WHEEL NIBBLE - TIRE WHEEL RUNOUT AND BALANCE FORD: 2005 Excursion, Explorer Sport

More information

Drivetrain Binding/Tires Scrubbing During Low Speed Maneuvering, ESP Light in Instrument Cluster ON or Flashing

Drivetrain Binding/Tires Scrubbing During Low Speed Maneuvering, ESP Light in Instrument Cluster ON or Flashing Condition Drivetrain Binding/Tires Scrubbing During Low Speed Maneuvering, ESP Light in Instrument Cluster ON or Flashing During low speed turns/maneuvering, vehicle drivetrain feels as if it is binding

More information

V8 XJ Series/XK. Vibration/Shimmy Tire Radial Force Variation Optimizing Wheels And Tires

V8 XJ Series/XK. Vibration/Shimmy Tire Radial Force Variation Optimizing Wheels And Tires SERVICE V8 XJ Series/XK DATE 04/02 Amended 04/03 TECHNICAL BULLETIN Vibration/Shimmy Tire Radial Force Variation Optimizing Wheels And Tires Remove and destroy Bulletin 204-17, dated 4/02. Replace with

More information

Technical Service Bulletin

Technical Service Bulletin RVU - Fuel pressure sensor replacement (CL / 24M4) 24 08 41 2017843/3 September 25, 2008. Supersedes Technical Service Bulletin Group 24 number 08-28 dated June 11, 2008 to clarify Warranty information.

More information

Model Year Eng. Code Trans. Code VIN Range From VIN Range To

Model Year Eng. Code Trans. Code VIN Range From VIN Range To Model Year Eng. Code Trans. Code VIN Range From VIN Range To Passat 2012-2014 2.0L TDI (CKRA) ALL ALL ALL Condition 21 15 05 June 15, 2015 2036110 Supersedes Technical Bulletin V211503 dated January 21,

More information

Technical Journal TITLE: Test schedule for vehicle speed dependent vibrations at highway speeds ISSUING DEPARTMENT: Technical Service FUNC DESC:

Technical Journal TITLE: Test schedule for vehicle speed dependent vibrations at highway speeds ISSUING DEPARTMENT: Technical Service FUNC DESC: VOLVO CAR SERVICE AND PARTS BUSINESS Technical Journal TITLE: Test schedule for vehicle speed dependent vibrations at highway speeds REF NO: TJ 20803.12.0 ISSUING DEPARTMENT: Technical Service CAR MARKET:

More information

REQUIRED VEHICLE UPDATE TECHNICAL BULLETIN (RVUTB) PERFORM ON ALL APPLICABLE VEHICLES WITHIN THE LIMITED NEW VEHICLE WARRANTY

REQUIRED VEHICLE UPDATE TECHNICAL BULLETIN (RVUTB) PERFORM ON ALL APPLICABLE VEHICLES WITHIN THE LIMITED NEW VEHICLE WARRANTY REQUIRED VEHICLE UPDATE TECHNICAL BULLETIN (RVUTB) PERFORM ON ALL APPLICABLE VEHICLES WITHIN THE LIMITED NEW VEHICLE WARRANTY 20 08 03 Jul. 17, 2008 2018345 Supersedes RVUTB 20 08 02 dated July 16, 2008

More information

Model(s) Year Eng. Code Trans. Code VIN Range From VIN Range To 2.0L TDI (CBEA) 2.0L TDI (CJAA) 2.0L TDI (CJAA) 2.0L TDI (CJAA)

Model(s) Year Eng. Code Trans. Code VIN Range From VIN Range To 2.0L TDI (CBEA) 2.0L TDI (CJAA) 2.0L TDI (CJAA) 2.0L TDI (CJAA) Model(s) Year Eng. Code Trans. Code VIN Range From VIN Range To Jetta, Jetta Wagon 2009 (CBEA) Golf 2010-2014 Jetta Sedan, Jetta SportWagen, Golf Wagon 2010-2014 Beetle, Beetle Convertible 2013-2014 Condition

More information

Technical Service Bulletin

Technical Service Bulletin 01 MIL on (P0491 and P0492 stored at same time) 01 14 97 2033001/7 October 2, 2014. Supersedes Technical Service Bulletin Group 01 number 14-89 dated August 19, 2014 for reasons listed below. Model(s)

More information

ATTENTION: This Technical Service Bulletin was issued by Southeast Toyota Distributors, LLC.

ATTENTION: This Technical Service Bulletin was issued by Southeast Toyota Distributors, LLC. ATTENTION: This Technical Service Bulletin was issued by Southeast Toyota Distributors, LLC. For Toyota Dealers located within the Southeast Region: Please refer to SET Dealer Daily to obtain instructions

More information

Service Bulletin

Service Bulletin Service Bulletin 16-009 February 12, 2016 03177 Version 1 Vibration Felt in Floor at Highway Speed AFFECTED VEHICLES Year Model Trim VIN Range 2015 TLX AWD 19UUB3F..FA000001 thru 19UUB3F..FA004363 BACKGROUND

More information

Secondary Boom Angle Sensor Calibration

Secondary Boom Angle Sensor Calibration _SN 130004 Information Date: July 29, 2013 Model Affected: Subject: Allowable Hours: Z-135/70 Secondary Boom Angle Sensor Calibration 60 minutes Issue: Genie has become aware of secondary boom angle sensor

More information

2012 General Motors. All rights reserved.

2012 General Motors. All rights reserved. 2001 Saturn L300/LW300 L100, L200,LW200, L300, LW300 VIN J Service Manual Document ID: 1551949 #99-00-91-002E: Steering Wheel Shake or Vibration at Highway Speeds (Balance Tire/Wheel Assemblies, Replace

More information

Info - Product Quality Center for Engine and Transmission Assembly and Transfer Case Replacement # F - (Oct 3, 2005)

Info - Product Quality Center for Engine and Transmission Assembly and Transfer Case Replacement # F - (Oct 3, 2005) Document ID# 1709018 2004 Cadillac CTS Info - Product Quality Center for Engine and Transmission Assembly and Transfer Case Replacement #02-07-30-029F - (Oct 3, 2005) Product Quality Center for Engine

More information

Model(s) Year Eng. Code Trans. Code VIN Range From VIN Range To (1.8L) AEB, ATW, AUG, AWM

Model(s) Year Eng. Code Trans. Code VIN Range From VIN Range To (1.8L) AEB, ATW, AUG, AWM Model(s) Year Eng. Code Trans. Code VIN Range From VIN Range To (B5 ) Passat, Passat Wagon 1998 2004 (1.8L) AEB, ATW, AUG, AWM All All All Condition 17 09 06 May 18, 2009 2013233 Supersedes T. B. Group

More information

Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan Ford Customer Service Division

Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan Ford Customer Service Division Michael A. Berardi Ford Motor Company Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan 48121 Ford Customer Service Division TO: All U.S. Ford and Lincoln Dealers July 1, 2014 SUBJECT:

More information

ADMINISTRATIVE GUIDE Revised February, 2010

ADMINISTRATIVE GUIDE Revised February, 2010 MOPAR 3-YEAR/100,000-MILE REMANUFACTURED POWERTRAIN PARTS WARRANTY ADMINISTRATIVE GUIDE Revised February, 2010 Mopar s 3-Year/100,000-Mile Remanufactured Powertrain Parts Warranty (3/100) available on

More information

Product Update Circular

Product Update Circular IMPORTANT INFORMATION Please inform and provide a copy of this document to every person in your dealership with campaign-related responsibilities, including Service, Parts and Accounting personnel. By

More information

https://www.bmwtis.net/tiscode/cgi-bin/bulletin.aspx?sie_path=/tsb/bulletins/htm_store/216...

https://www.bmwtis.net/tiscode/cgi-bin/bulletin.aspx?sie_path=/tsb/bulletins/htm_store/216... Page 1 of 5 SI B12 33 14 Engine Electrical Systems March 2015 Technical Service This Service Information bulletin supersedes SI 12 33 14 dated December 2014. designates changes to this revision SUBJECT

More information

Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan Ford Customer Service Division

Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan Ford Customer Service Division Michael A. Berardi Ford Motor Company Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan 48121 Ford Customer Service Division TO: SUBJECT: REF: All U.S. Ford and Lincoln Dealers

More information

INFORMATION. PQC Assembly Replacement Process For Dealers Required to Contact PQC Prior to Replacing an Assembly (U.S.

INFORMATION. PQC Assembly Replacement Process For Dealers Required to Contact PQC Prior to Replacing an Assembly (U.S. Service Bulletin File in Section: 07 - Transmission/Transaxle Bulletin No.: 02-07-30-029Z Date: May, 2016 INFORMATION Subject: Models: Attention: PQC Assembly Replacement Process For Dealers Required to

More information

Update Programming Transmission Control Module (TCM) for Improved Upshifting. Condition. Production

Update Programming Transmission Control Module (TCM) for Improved Upshifting. Condition. Production Subject: Model(s): Update Programming Transmission ontrol Module (TM) for Improved Upshifting (OE) Touareg 3.2L V6 (eng. code BMX) 2005 2006 Group: Number: Date: 01 05 16 Dec. 20, 2005 Update Programming

More information

#04039B: Special Coverage Adjustment - Injectors- Replace - (Nov 19, 2007)

#04039B: Special Coverage Adjustment - Injectors- Replace - (Nov 19, 2007) Page 1 of 6 Document ID: 2038809 #04039B: Special Coverage Adjustment - Injectors- Replace - (Nov 19, 2007) Subject: 04039B - Special Policy Adjustment - Injector - Replace Models: 2001-2004 Chevrolet

More information

Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan Ford Customer Service Division

Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan Ford Customer Service Division Michael A. Berardi Ford Motor Company Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan 48121 Ford Customer Service Division TO: All U.S. Ford and Lincoln Dealers March 16, 2015

More information

OVERVIEW: This bulletin involves performing a Transmission Adaptation Learn procedure based on a subjective shift quality rating evaluation.

OVERVIEW: This bulletin involves performing a Transmission Adaptation Learn procedure based on a subjective shift quality rating evaluation. NUMBER: GROUP: 21-012-14 REV. B and Transfer Case DATE: September 26, 2014 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may

More information

OVERVIEW: This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software.

OVERVIEW: This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. NUMBER: 18-032-03 GROUP: Vehicle Performance DATE: Sep. 12, 2003 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,

More information

All Dealer Principals, General Managers, Service Managers, and Parts Managers

All Dealer Principals, General Managers, Service Managers, and Parts Managers April 19, 2016 To: Subject: All Dealer Principals, General Managers, Service Managers, and Parts Managers Warranty Enhancement Program - ZLG Certain 2006 2007 GS 430, 2007 2011 GS 450h, 2008 2011 GS 460,

More information

FOOTWELL MODULE (FRM): LIMITED WARRANTY EXTENSION INCREASEDTO 10 YEARS/156,000. Complaint

FOOTWELL MODULE (FRM): LIMITED WARRANTY EXTENSION INCREASEDTO 10 YEARS/156,000. Complaint Page 1 of 9 BMW Group - AIR: 2018-08-18 / 16:21 Dealer: 32711/06 Model: - Development code: - Model code: - Lead type: - Order number: - Service Information Bulletin FOOTWELL MODULE (FRM): LIMITED WARRANTY

More information

Technical Information

Technical Information Technical Service 2/14 ENU WE02 9 WE02 - Re-programming Instrument Cluster (Workshop Campaign) Important Note: CRITICAL WARNING - THIS CAMPAIGN INCLUDES STEPS WHERE SEVERAL CONTROL UNITS IN THE VEHICLE

More information

Campaign No , September 2006

Campaign No , September 2006 Campaign No. 2006080004, September 2006 Effective Serial Number Range Models Chassis End Number From To Every vehicle in the VIN range may not be included in the campaign. VMI must always be checked before

More information

FILE: SERVICE: GROUP 00 OF SERVICE INFORMATION BINDER PARTS: GROUP I OF INFORMATION _ PARTS & ACCESSORIES BINDER

FILE: SERVICE: GROUP 00 OF SERVICE INFORMATION BINDER PARTS: GROUP I OF INFORMATION _ PARTS & ACCESSORIES BINDER FILE: SERVICE: GROUP 00 OF SERVICE INFORMATION BINDER PARTS: GROUP I OF INFORMATION _ PARTS & ACCESSORIES BINDER Campaign No. 2006080004, November 2006 Revision History Revision Date Purpose A 11/03/06

More information

Safety Recall Circular

Safety Recall Circular IMPORTANT INFORMATION Please inform and provide a copy of this document to every person in your dealership with campaign-related responsibilities, including Service, Parts and Accounting personnel. By

More information

The following vital information is provided to inform you and your staff of the program notification schedule and your degree of involvement.

The following vital information is provided to inform you and your staff of the program notification schedule and your degree of involvement. To: Subject: All Toyota Dealer Principals, Service Managers, Parts Managers Customer Support Program (CSP) Specific Malfunction Indicator Light ON and/or Harsh Shift of Automatic Transaxle on Certain 2001

More information

ALLDATAdiy.com Mercedes Benz Truck ML 320 ( ) V6-3.2L ( ) -... Page 1 of 14

ALLDATAdiy.com Mercedes Benz Truck ML 320 ( ) V6-3.2L ( ) -... Page 1 of 14 ALLDATAdiy.com - 2000 Mercedes Benz Truck ML 320 (163.154) V6-3.2L (112.942) -... Page 1 of 14 Welcome SCOTT AMOROSO Leading source of Online Diagnostic & Repair Information Your Vehicle: 2000 Mercedes

More information

Mazda North American Operations Irvine, CA

Mazda North American Operations Irvine, CA Service Bulletin Mazda North American Operations Irvine, CA 92618-2922 Subject: ENGINE CRANKS NO START Bulletin No: 01-015/08 2004-2008 RX-8 - ENGINE CRANKS NO START BULLETIN NOTE This bulletin supersedes

More information

OUR BEGINNING FUNCTION DRIVEN DESIGN

OUR BEGINNING FUNCTION DRIVEN DESIGN OUR BEGINNING IT ALL STARTED WHEN A TEAM OF TIRE DESIGNERS AND CAR ENTHUSIASTS JOINED FORCES WITH ONE PROJECT IN MIND: TO CREATE A RANGE OF TIRES SUITED TO THE NEEDS OF TODAYS DRIVERS. THEIR GOAL: TO DEVELOP

More information

#08020: Special Coverage Adjustment Extended Catalytic Converter Warranty Coverage (Jan 13, 2010)

#08020: Special Coverage Adjustment Extended Catalytic Converter Warranty Coverage (Jan 13, 2010) Document ID: 2382008 #08020: Special Coverage Adjustment Extended Catalytic Converter Warranty Coverage (Jan 13, 2010) Subject: 08020 SPECIAL COVERAGE ADJUSTMENT EXTENDED CATALYTIC CONVERTER WARRANTY COVERAGE

More information

DELINTE LIMITED TIRE WARRANTY DH2 D7 D8, D8+ DH7 DX9, DX10, DX11, DV2

DELINTE LIMITED TIRE WARRANTY DH2 D7 D8, D8+ DH7 DX9, DX10, DX11, DV2 DELINTE LIMITED TIRE WARRANTY DH2 D7 D8, D8+ DH7 DX9, DX10, DX11, DV2 The limited warranty applies to tires purchased after March 1, 2016. The limited warranty applies to tires purchased after October

More information

Condition/concern. Recommendations/Instructions

Condition/concern. Recommendations/Instructions #PI1354C: Information on Vibration Analysis and Diagnostic - (Aug 14, 2015) Subject: Information on Vibration Analysis and Diagnostic 2014 Chevrolet Silverado 1500 2015 Chevrolet Silverado 1500 Models:

More information

Jiffy Lube Brakes & Services National Warranty Program. Deployment Materials Nov 2013

Jiffy Lube Brakes & Services National Warranty Program. Deployment Materials Nov 2013 Jiffy Lube Brakes & Services National Warranty Program Deployment Materials Nov 2013 1 National Warranty - Benefits Customer Provides peace of mind when selecting a repair facility Easy issue resolution

More information

FOOTWELL MODULE (FRM): LIMITEDWARRANTY EXTENSION INCREASED TO 10 YEARS/156,000. Complaint

FOOTWELL MODULE (FRM): LIMITEDWARRANTY EXTENSION INCREASED TO 10 YEARS/156,000. Complaint Page 1 of 9 BMW Group - AIR: 2018-08-22 / 07:35 Dealer: 32711/06 Model: - Development code: - Model code: - Lead type: - Order number: - Service Information Bulletin FOOTWELL MODULE (FRM): LIMITEDWARRANTY

More information

PRELIMINARY INFORMATION

PRELIMINARY INFORMATION Service Bulletin File in Section: - Bulletin No.: PI1354A Date: December, 2014 PRELIMINARY INFORMATION Subject: Information on Vibration Analysis and Diagnostic Models: 2014 Chevrolet Silverado 1500 2015

More information

MIL ON - DTC'S P047F, P0477, P048A, P048B, P048C OR P0401 STORED IN ECM FAULT MEMORY

MIL ON - DTC'S P047F, P0477, P048A, P048B, P048C OR P0401 STORED IN ECM FAULT MEMORY 2011 Volkswagen 2.0L Eng TDI MIL ON - DTC'S P047F, P0477, P048A, P048B, P048C OR P0401 STORED IN ECM FAULT MEMORY TECHNICAL SERVICE BULLETIN Reference Number(s): GROUP 26, NO. 15-07 (2031583), Date of

More information

SECTION Wheels and Tires

SECTION Wheels and Tires 204-04-i Wheels and Tires 204-04-i SECTION 204-04 Wheels and Tires CONTENTS PAGE DIAGNOSIS AND TESTING Wheels And Tires... 204-04-2 Inspection and Verification... 204-04-2 Tire Wear... 204-04-3 Symptom

More information

Computers and Control Systems: Monitors, Trips, Drive Cycles and Readiness Codes

Computers and Control Systems: Monitors, Trips, Drive Cycles and Readiness Codes 1998 Volvo V70 AWD L5-2.4L Turbo VIN 56 B5254T Page 1 Computers and Control Systems: Monitors, Trips, Drive Cycles and Readiness Codes Generic Drive Cycle Readiness Code Resetting Procedure (Generic Drive

More information

Mazda Dealership General Managers, Service Managers, and Parts Managers

Mazda Dealership General Managers, Service Managers, and Parts Managers TO: Mazda Dealership General Managers, Service Managers, and Parts Managers DATE: April 2012 SUBJECT: Heavy White Exhaust Smoke Warranty Extension Program SSP 86 2007-2009 CX-7, 2007-2008, 2006-2007 Mazdaspeed6

More information

Technical Service Bulletin

Technical Service Bulletin 1301 Stahley Drive Building #42 Nappanee, IN 46550 Newmar Corporation Warranty Department Technical Service Bulletin Date Issued Model Year(s) Affected TSB # 3/24/2016 2015, 2016 450 rev. A Brand Bay Star

More information

LIMITED TIRE WARRANTY

LIMITED TIRE WARRANTY LANDSAIL LIMITED TIRE WARRANTY Effective July 1, 2017 LS388 LS588 uhp LS588 suv/cuv CLV2 4 SEASONS CLX9 CLX10 CLX11 LSV88 Sentury Tire USA Landsail Limited Tire Warranty This limited warranty only applies

More information

2004 Audi A4 ENGINE, OIL PRESSURE LOW ENGINE, OIL PRESSURE LOW TECHNICAL SERVICE BULLETIN

2004 Audi A4 ENGINE, OIL PRESSURE LOW ENGINE, OIL PRESSURE LOW TECHNICAL SERVICE BULLETIN TECHNICAL SERVICE BULLETIN Reference Number(s): GROUP 17, NO. 04-03, Date of Issue: August 05, 2004 A4 (Eng. Codes AEB, AMB, ATW & AWM), 1997-2004; Cabriolet (Eng. Code AMB), 2003- AUDI: 2004 SUBJECT Engine,

More information

NOTE: This bulletin applies to vehicles built on or after July 29, 2013 (MDH 0729XX) and on or before September 19, 2013 (MDH 0919XX).

NOTE: This bulletin applies to vehicles built on or after July 29, 2013 (MDH 0729XX) and on or before September 19, 2013 (MDH 0919XX). NUMBER: 19-002-14 GROUP: Steering DATE: February 13, 2014 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,

More information

10134C Special Coverage Adjustment Catalytic Converter Warranty Extension

10134C Special Coverage Adjustment Catalytic Converter Warranty Extension 10134C Special Coverage Adjustment Catalytic Converter Warranty Extension 2006-2007 Chevrolet Malibu Equipped with 2.2L Engine (L61) 2008 Chevrolet Malibu 2006-2008 Pontiac G6 2008 Saturn AURA Equipped

More information

#05551: Special Policy Adjustment - Catalytic Converter - (Sep 14, 2005)

#05551: Special Policy Adjustment - Catalytic Converter - (Sep 14, 2005) #05551: Special Policy Adjustment - Catalytic Converter - (Sep 14, 2005) Subject: 05551 - SPECIAL POLICY ADJUSTMENT - CATALYTIC CONVERTER Models: 2001-02 CHEVROLET IMPALA, MONTE CARLO 2001-02 PONTIAC GRAND

More information

Mazda North American Operations Irvine, CA

Mazda North American Operations Irvine, CA Service Bulletin Mazda North American Operations Irvine, CA 92618-2922 Subject: WHITE OR BLUE SMOKE FROM TAIL PIPE AFTER LONG IDLE PERIOD Bulletin No: 01-002/11 2007-2009 MAZDASPEED3 / CX-7 - WHITE OR

More information

LIMITED TIRE WARRANTY Effective January 1, 2018 VOYAGER GT VOYAGER HP VOYAGER SV VOYAGER HT VOYAGER AT VOYAGER MT

LIMITED TIRE WARRANTY Effective January 1, 2018 VOYAGER GT VOYAGER HP VOYAGER SV VOYAGER HT VOYAGER AT VOYAGER MT LIMITED TIRE WARRANTY Effective January 1, 2018 VOYAGER GT VOYAGER HP VOYAGER SV VOYAGER HT VOYAGER AT VOYAGER MT Sentury Tire USA GroundSpeed Limited Tire Warranty This limited warranty applies only to

More information

Vibration Analysis Worksheet

Vibration Analysis Worksheet Vibration Analysis Worksheet 2015 and Prior GM Passenger Cars and Trucks This Bulletin has been revised to add the 2015 Model Year and to edit the ring gear backlash measurements in the Vibration Analysis

More information

#16-NA-338: PQC Assembly Replacement Process - Dealers Required to Contact PQC Prior to Replacing an Assembly - (Oct 7, 2016)

#16-NA-338: PQC Assembly Replacement Process - Dealers Required to Contact PQC Prior to Replacing an Assembly - (Oct 7, 2016) Page 1 of 8 Document ID: 4579188 #16-NA-338: PQC Assembly Replacement Process - Dealers Required to Contact PQC Prior to Replacing an Assembly - (Oct 7, 2016) Subject: PQC Assembly Replacement Process

More information

All Toyota Dealer Principals, Service Managers, Parts Managers

All Toyota Dealer Principals, Service Managers, Parts Managers To: Subject: All Toyota Dealer Principals, Service Managers, Parts Managers Warranty Enhancement Program ZE7 Certain 2007-2009 Camry Certain 2007-2011 Camry Hybrid Certain 2007-2008 Camry Solara Certain

More information

#16-NA-338: PQC Assembly Replacement Process - Dealers Required to Contact PQC Prior to Replacing an Assembly - (Oct 7, 2016)

#16-NA-338: PQC Assembly Replacement Process - Dealers Required to Contact PQC Prior to Replacing an Assembly - (Oct 7, 2016) Page 1 of 5 Document ID: 4579188 #16-NA-338: PQC Assembly Replacement Process - Dealers Required to Contact PQC Prior to Replacing an Assembly - (Oct 7, 2016) Subject: PQC Assembly Replacement Process

More information

B-017 May 6, 1999 NEW DDFI CALIBRATION AND REMOTE IDLE ADJUSTER KITS RETURN THIS TO: INITIAL HERE TECHNICIAN NO. 1 LEAD TECHNICIAN

B-017 May 6, 1999 NEW DDFI CALIBRATION AND REMOTE IDLE ADJUSTER KITS RETURN THIS TO: INITIAL HERE TECHNICIAN NO. 1 LEAD TECHNICIAN 5 SERVICE BULLETIN B-017 May 6, 1999 NEW DDFI CALIBRATION AND REMOTE IDLE ADJUSTER KITS GENERAL The purpose of this service bulletin is to inform you of the release of two new kits and to provide installation

More information

Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan Ford Customer Service Division

Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan Ford Customer Service Division Michael A. Berardi Ford Motor Company Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan 48121 Ford Customer Service Division TO: SUBJECT: REF: All U.S. Ford and Lincoln Dealers

More information

6.0L DIESEL DRIVEABILITY NO START, HARD TSB START, RUNS ROUGH FUEL INJECTION CONTROL MODULE DIAGNOSIS

6.0L DIESEL DRIVEABILITY NO START, HARD TSB START, RUNS ROUGH FUEL INJECTION CONTROL MODULE DIAGNOSIS 6.0L DIESEL DRIVEABILITY NO START, HARD TSB 08-26-3 START, RUNS ROUGH FUEL INJECTION CONTROL MODULE DIAGNOSIS FORD: 2003-2005 Excursion 2003-2007 F-Super Duty 2004-2009 E-350, E-450, E-550 This article

More information

Course Delivery Platform Course Description Length D1 Virtual Classroom Training (VCT) Noise, Vibration and Harshness (NVH) 1.

Course Delivery Platform Course Description Length D1 Virtual Classroom Training (VCT) Noise, Vibration and Harshness (NVH) 1. Bulletin No.: Pl1354D Service Bullet,in Date: 23-Jun-2016 Subject: Information on Vibration Analysis and Diagnostic Models: 2014 Chevrolet Silverado 1500 2015-2016 Chevrolet Silverado 2014 GMC Sierra 1500

More information

REASON FOR THIS SUPPLEMENT

REASON FOR THIS SUPPLEMENT Michael A. Berardi Ford Motor Company Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan 48121 Ford Customer Service Division TO: All U.S. Ford and Lincoln Dealers August 16, 2016

More information

THE witech SOFTWARE LEVEL MUST BE AT OR HIGHER TO PERFORM THIS PROCEDURE.

THE witech SOFTWARE LEVEL MUST BE AT OR HIGHER TO PERFORM THIS PROCEDURE. NUMBER: 21-001-15 GROUP: and Transfer Case DATE: January 10, 2015 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,

More information

General Service Bulletin (GSB): GSB Overview. Table of Contents: Overview:

General Service Bulletin (GSB): GSB Overview. Table of Contents: Overview: General Service Bulletin (GSB): GSB Overview Wiring Repair / Harness Replacement - Best Practices for Warranty Claiming This publication provides information and Best Practices for developing and completing

More information

4 Wheel Alignment Steering and Suspension Diagnosis

4 Wheel Alignment Steering and Suspension Diagnosis JOB SHEET A4E1: Diagnose Tire Wear Problems Start Date: Name: End Date: Make: Model: Year: VIN: Mileage: Learning Objective/NATEF Task Diagnose vehicle wander, drift, pull, hard steering, bump steer, memory

More information

Service Action Campaign Code: 20T8

Service Action Campaign Code: 20T8 IMPORTANT INFORMATION Please inform and provide a copy of this document to every person in your dealership with campaign-related responsibilities, including Service, Parts and Accounting personnel. By

More information

07126 SPECIAL COVERAGE ADJUSTMENT LOSS OF POWER STEERING ASSIST

07126 SPECIAL COVERAGE ADJUSTMENT LOSS OF POWER STEERING ASSIST 2005 G6 Subject: 07126 SPECIAL COVERAGE ADJUSTMENT LOSS OF POWER STEERING ASSIST Report a problem with this article Models: 2005 CHEVROLET MALIBU, MALIBU MAXX 2005 PONTIAC G6 Condition Some customers of

More information

DELINTE. LIMITED TIRE WARRANTY Effective July 1, 2017 DH2 D7 D8, D8+ DS8 DH7 DX9, DX10 DX11, DV2

DELINTE. LIMITED TIRE WARRANTY Effective July 1, 2017 DH2 D7 D8, D8+ DS8 DH7 DX9, DX10 DX11, DV2 DELINTE LIMITED TIRE WARRANTY Effective July 1, 2017 DH2 D7 D8, D8+ DS8 DH7 DX9, DX10 DX11, DV2 Sentury Tire USA Delinte Limited Tire Warranty This limited warranty only applies to the original purchaser

More information

Secondary Boom Angle Sensor Calibration

Secondary Boom Angle Sensor Calibration Safety Notice 130005 _SN 130004 Information Date: July 29, 2013 Model Affected: Subject: Allowable Hours: Z-135/70 Secondary Boom Angle Sensor Calibration 60 minutes ue Issue: Genie has become aware of

More information

Technical Service Bulletin No.LTB March 2008

Technical Service Bulletin No.LTB March 2008 Technical Service Bulletin No.LTB00123 18 March 2008 Models: Discovery 3 / LR3 Range Rover Sport (LS) VIN-range: 000360 Onwards VIN-range: 900290 Onwards Markets: All Section: 204-01 Summary: A customer

More information

DELINTE. LIMITED TIRE WARRANTY Effective July 1, 2017 DH2 D7 D8, D8+ DS8 DH7 DX9 DX10 DX11,, DX12 DV2 AW 5

DELINTE. LIMITED TIRE WARRANTY Effective July 1, 2017 DH2 D7 D8, D8+ DS8 DH7 DX9 DX10 DX11,, DX12 DV2 AW 5 DELINTE LIMITED TIRE WARRANTY Effective July 1, 2017 DH2 D7 D8, D8+ DS8 DH7 DX9 DX10 DX11,, DX12 DV2 AW 5 Sentury Tire USA Delinte Limited Tire Warranty This limited warranty only applies to the original

More information

14329A - SPECIAL COVERAGE ADJUSTMENT - LOSS OF POWER STEERING ASSIST

14329A - SPECIAL COVERAGE ADJUSTMENT - LOSS OF POWER STEERING ASSIST 1 of 12 5/25/2015 2:07 PM 2008 Buick Enclave 3.6L Eng CX 14329A - SPECIAL COVERAGE ADJUSTMENT - LOSS OF POWER STEERING ASSIST TECHNICAL SERVICE BULLETIN Reference Number(s): 14329A, Date of Issue: December

More information

DIAGNOSIS AND TESTING

DIAGNOSIS AND TESTING 204-04-1 Wheels and Tires 204-04-1 DIAGNOSIS AND TESTING Tire Pressure Monitoring System Special Tool(s) Principles of Operation Activation Tool, Tire Pressure Monitor 204-363 Digital Tire Gauge 204-354

More information

#04017A: Special Policy - Tail Lamps/Stop Lamps - (Aug 6, 2004)

#04017A: Special Policy - Tail Lamps/Stop Lamps - (Aug 6, 2004) Page 1 of 9 2004 Chevrolet TrailBlazer - 4WD Bravada, Envoy, Rainier, TrailBlazer (VIN S/T) Service Manual Campaigns Special Policy #04017A: Special Policy - Tail Lamps/Stop Lamps - (Aug 6, 2004) Subject:

More information

Frequently Asked Questions. June v4

Frequently Asked Questions. June v4 Frequently Asked Questions June 2016 5132016.v4 Frequently Asked Questions June 2016 1. Program Parameters and Pricing... 4 1.1. Model Year 2017 Program Parameters for VW Care... 4 1.2. Model Year 2015

More information

ALLDATA Online Buick Lucerne V6-3.8L VIN 2 - Recall - Heated Windshield... Recall - Heated Windshield Washer Module Short Circuit

ALLDATA Online Buick Lucerne V6-3.8L VIN 2 - Recall - Heated Windshield... Recall - Heated Windshield Washer Module Short Circuit Page 1 of 8 Recall - Heated Windshield Washer Module Short Circuit SAFETY Bulletin No.: 10153B Date: July 20, 2010 Subject: 10153A - Heated Windshield Washer Module Short Circuit - Permanently Disable

More information

Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan Ford Customer Service Division

Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan Ford Customer Service Division Michael A. Berardi Ford Motor Company Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan 48121 Ford Customer Service Division TO: SUBJECT: All U.S. Ford and Lincoln Dealers Customer

More information

Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan Ford Customer Service Division

Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan Ford Customer Service Division Michael A. Berardi Ford Motor Company Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan 48121 Ford Customer Service Division TO: All U.S. Ford and Lincoln Dealers June 27, 2017

More information

Title: FRONT BRAKE VIBRATION Models: Tundra. Front Brake Caliper & Rotor Replacement (2WD, Both Sides)

Title: FRONT BRAKE VIBRATION Models: Tundra. Front Brake Caliper & Rotor Replacement (2WD, Both Sides) Technical Service BULLETIN September 16, 2002 Title: FRONT BRAKE VIBRATION Models: 00-03 Tundra BR004-02 BRAKES TSB REVISION NOTICE: S March 5, 2004: A torque speification on page 10, step 24, was changed.

More information

Mazda North American Operations Irvine, CA

Mazda North American Operations Irvine, CA Service Bulletin Mazda North American Operations Irvine, CA 92618-2922 Subject: POPPING AND/OR SQUEAKING NOISE FROM FRONT SHOCK ABSORBER AND/ OR CREAKING NOISE FROM FRONT LOWER ARM BUSHING Bulletin No:

More information

Technical Service Bulletin

Technical Service Bulletin Technical Service Bulletin Group Number TRANSAXLE 07-40-006 Subject REMANUFACTURED AUTOMATIC TRANSAXLE (ATM) PROGRAM Date Model APRIL, 2007 ALL This TSB supercedes bulletin 01-40-004 to include 6-speed

More information