TROUBLESHOOTING FLOW CHARTS

Size: px
Start display at page:

Download "TROUBLESHOOTING FLOW CHARTS"

Transcription

1 TROUBLESHOOTING FLOW CHARTS

2

3 Bowl Style Carburetor Troubleshooting Hunts and Surges Will Run only on Prime Will run only if the choke is used Determine that the governor system is functioning properly using the proper isolation techniques Does the engine still hunt and surge? Troubleshoot governor system Partially engage choke or gently touch primer bulb Does the engine improve? Inspect, clean or replace mainjet and retest Does the engine still hunt and surge? Remove and clean carburetor, retest engine Does the engine still hunt and surge? Replace Carburetor

4 Compression Diagnostics Troubleshooting Flow Chart Low Power Check for proper top no load speed by model and type number Is the top no load speed OK? Is there a parasitic load? Check bowden wire/throttle control for full range travel Low or High Yes Don t Know Is it correct? Disengage load by removing belts, etc. Repair as needed Still low power? Repair load issues as needed Partially engage choke Is leakage detected? Check for intake tract leaks, gasket leaks, loose/leaking carburetor space blocks, loose/leaking crossover tubes Does speed increase or engine run more smoothly? Repair as needed Perform leakdown test Overhaul carburetor looking closely for obstructed jets Is leakage detected? Reading acceptable Adjust valve lash Leakage unacceptable Repair as needed

5 Compression Troubleshooting Flow Chart Engine Smokes What color is the smoke? Black/Gray Check/repair fuel system Excessive Oil Consumption White/Blue Is Engine Smoking? Does oil level drop more than one ounce per hour? Was engine tipped? Check for oil fouled filter element Check for overfilled oil level Check for fuel contaminated oil Check for proper viscosity Oil use acceptable Is the filter fouled? Leakage unacceptable Rapair/replace faulty components Replace and run Engine for ten minutes Is leakage detected? Reading acceptable Perform Crankcase Vacuum Test Is it still smoking? Perform Leakdown Test Is Vacuum Test OK? Low External oil leaks present? Re-check all work Check breather system Check crankcase seals Check block for porosity Repair as needed Is vacuum now ok?

6 Fuel System Troubleshooting Flow Chart Engine Won t Start/Run Check for: Clean, fresh fuel supply, shutoff valve open, carb adjustments properly made, controls functioning All ok? Correct and recheck Check carburetor mounting gasket Check spark plug Is the spark plug wet? Check for: Clogged air cleaner, stale fuel, oil/water in fuel, misadjusted controls, choke plate closed, damaged needle valve Does the engine start/run? Does the engine start/run? Check fuel supply/passages Check carburetor Put fuel in carburetor Put fuel in spark plug hole Does the engine start/run? Does it have a Flo-jet Carburetor? What kind of carburetor? Diaphragm Carburetor Recheck other work Flo-jet Carburetor Check for: Gummy/dirty inlet screen, valve stuck, bad diaphragm, restricted passages in tank/carburetor Check Compression Check for: Inlet valve stuck open, improper float level, dirt in the carburetor, loose nozzle(s) Check for: Clogged fuel line/filter, fuel inlet valve closed, improper float level, carburetor fuel passages plugged/restricted, faulty fuel pump

7 Systematic Troubleshooting Electrical System Flow Chart Engine Won t Start Check for spark to ground. OK Check spark plug/replace if necessary. Try to start engine. ne Will engine start? Check armature air gap. Incorrect OK Adjust armature air gap Check/replace flywheel key Will engine start? Will engine start? Isolate engine from equipment Check fuel system Check compression system Check for spark to ground. ne Check coil to block ground. ne OK OK Fix Check for misadjusted controls Check interlock switching Check grounding wire diode (if equipped) Replace Coil

8 Governor Troubleshooting Flow Chart Air Vane Governor Overspeeding Air Vane Governor Overspeeding Check the cooling system Is the cooling system ok? Remove dirt and debris from outside and inside of blower housing, test engine Still overspeeding? Check flywheel fins Are the flywheel fins ok? Replace flywheel if fins are missing or broken, test engine Still overspeeding? Check for uneven or binding resistance in air vane travel from stop to stop Resistance problem? Indentify resistance and repair, test engine Still overspeeding? Inspect governor spring and controls for damage or improper installation Replace governor spring or controls, test engine

9 Governor Troubleshooting Flow Chart Air Vane Governor Engine Runs Too Slow Air Vane Governor Engine Runs Too Slow Move trottle control to idle, check for binding or uneven resistance in air vane travel from stop to stop Resistance problem? Indentify resistance and repair, re-test engine Engine still runs too slow? Inspect governor spring and controls for damage or improper installation Replace governor spring or controls, re-test engine

10 Governor Troubleshooting Flow Chart Hunting and Surging Hunting and Surging Adjust carburetor idle speed, idle fuel, and top no load fuel, test engine Still hunting and surging? Perform static governor adjustment procedure, test engine Still hunting and surging? Inspect governor link spring for damage or improper installation Link spring need repair or replacement? Repair or replace link spring as needed, test engine Still hunting and surging? Disconnect governor spring, check for binding or uneven resistance in governor arm travel from stop to stop Resistance problem? Indentify resistance and repair, test engine Still hunting and surging? Inspect governor spring and controls for damage or improper installation Replace governor spring or controls, test engine

11 Governor Troubleshooting Flow Chart Mechanical Governor Engine Runs Too Slow Mechanical Governor Engine Runs Too Slow Perform the static governor adjustment procedure, test engine Engine still runs too slow? Adjust governor spring tension, test engine Engine still runs too slow? Disconnect governor spring, check for binding or uneven resistance in governor arm travel from stop to stop Resistance problem? Indentify resistance and repair, test engine Engine still runs too slow? Inspect governor spring and controls for damage or improper installation Replace governor spring or controls, test engine

12 Governor Troubleshooting Flow Chart Mechanical Governor Engine Overspeeds Mechanical Governor Engine Overspeeds Perform the static governor adjustment procedure, test engine Still overspeeding? Adjust governor spring tension, test engine Still overspeeding? Disconnect governor spring, check for binding or uneven resistance in governor arm travel from stop to stop Resistance problem? Indentify resistance and repair, test engine Still overspeeding? Move throttle plate to the wide open position and start engine Does engine return to idle? Remove crankcase cover or sump and inspect or replace internal governor mechanism, test engine Still overspeeding? Inspect governor spring and controls for damage or improper installation Replace governor spring or controls, test engine

13 Compression System Troubleshooting Flow Chart Leakdown Test Perform Leakdown Test Is leakdown test ok? Reading acceptable Recheck other work Leakage unacceptable Where is the air primarily leaking from? Muffler Dipstick Tube Air Cleaner Cylinder Head Reset exhaust valve Check rings Reset intake valve Check head gasket

14 Gaseous Fueled Engine Troubleshooting Engine does not accelerate from low speed to high speed or run smoothly when loaded. Frost forming on the regulator or on the fuel line liquid (not vapor) entering the system. Plugged vent ports on the regulator. Remove plastic shipping plugs. Wrong type of propane tank set up for liquid withdrawal. Replace the fuel tank or change to the vapor withdrawal port. Less than 11 inches of water pressure at the inlet of the secondary regulator. Adjust the output of the primary regulator to 11 inches of water pressure. If natural gas supply is lower than 11 inches of water, a different secondary regulator may be required consult factory. Tank is positioned wrong (typically tanks that lay on their side). Fuel tanks have a receptacle for a locator pin that orients the tank for a specific withdrawal. Pin may be in the wrong location or missing. Reposition tank. More than 14 inches of water pressure at the inlet of the secondary regulator at full load. Adjust the primary regulator to achieve 11 inches of water pressure while under load. te: if pressure at inlet of secondary regulator increases upon starting the engine, check primary regulator for holes or tears in the diaphragm or dirt on the inlet seat. Fuel tank is overfilled. Fuel tank is too small, especially if the ambient is low. Fill to labeled tank capacity only. Increase the size of the fuel tank to increase the vaporization rate of the fuel. Consult with local gas supplier. Plugged fuel filter. Replace fuel filter. Restriction within the fuel line. Remove restriction or replace damaged part. Kinked or obstructed fuel hose. Remove the kink and/or replace the hose. or low fuel in tank. Refuel the tank. Gas will not stop flowing after engine is stopped. Propane tank is too small. Appropriately size the fuel tank for the engine horsepower and lowest ambient temperature. Regulator is not adjusted properly. Adjust the regulator so that when the outlet tube is placed in water, a gas bubble just begins to form. Back off on the adjustment so that the bubble is maintained but does not grow. Fuel transfer solenoid in the wrong position. When the fuel solenoid is energized or if the main mixture adjustment screw is completely seated, the engine is configured for propane gas (too lean of a mixture for natural gas). If the fuel solenoid is not energized, the engine is configured for natural gas (too rich mixture with propane). Atmospheric side of the secondary regulator is pressurized. Remove plastic shipping plugs or revise the regulator venting. Carburetor not adjusted properly (natural gas only). Readjust the mixture needles on the carburetor. Debris on inlet needle of secondary regulator. Clean the system of debris and install a fuel filter. Use liquid pipe sealant do not use Teflon tape. Air leak in the fuel line from secondary to carburetor. Tighten the clamps or replace the hose. Regulator not positioned vertically. Regulator may only be positioned with the outlet pointing straight up. A directional arrow is also shown on the smooth side of the regulator. Holes, tears or damaged diaphragm in secondary regulator. Replace damaged part. Gas leak from fuel line. Debris on inlet needle of regulator. Clean system of debris and add a fuel filter. Use liquid pipe sealant do not use Teflon tape. Loose fitting. Tighten fitting replace if damaged. Engine will not start. Damaged, cracked or worn hose. Replace hose. Out of fuel. Refuel the tank. Gas leak from regulator. Fuel supply shut off. Open fuel tank. Filter or vacuum lock off is not opening. Check for proper operation of all fuel lock off (safety) devices. If electrically actuated, check for dead battery or blown fuse. Replace lock off device if it is not functioning properly Damaged diaphragm in regulator. Replace damaged part. Vacuum leak in the vacuum lock off device. Replace vacuum line or tighten clamps. Replace vacuum lock off if damaged. Filter is plugged. Replace filter. Symptom Potential Cause

15

16 CE /08 Briggs&Stratton corporation Customer Education PO BOX 702 Milwaukee, WI USA

WEBER CARBURETOR TROUBLESHOOTING GUIDE

WEBER CARBURETOR TROUBLESHOOTING GUIDE This guide is to help pinpoint problems by diagnosing engine symptoms associated with specific vehicle operating conditions. The chart will guide you step by step to help correct these problems. For successful

More information

FUEL SYSTEM. Table of Contents. Specifications. Section 3A Fuel Delivery System. Models 6/8/9.9/10/15 CARBURETOR SPECIFICATIONS

FUEL SYSTEM. Table of Contents. Specifications. Section 3A Fuel Delivery System. Models 6/8/9.9/10/15 CARBURETOR SPECIFICATIONS FUEL SYSTEM Section 3A Fuel Delivery System Table of Contents Specifications............................. 3A-1 WMC Carburetor Specifications............. 3A-2 WMC Carburetor Specifications.............

More information

SERVICE BULLETIN REFERENCES 1983

SERVICE BULLETIN REFERENCES 1983 J a I) SERVICE BULLETIN REFERENCES 1983 19.35 TROUBLE SHOOTING Engine Won t Start or Hard Starting Possible Cause ALL MODELS No fuel in tank. Fuel valve off. Insufficient or excessive priming. Spark plug

More information

5. FUEL SYSTEM 5-0 FUEL SYSTEM MXU 250R/300R

5. FUEL SYSTEM 5-0 FUEL SYSTEM MXU 250R/300R 5 FUEL SYSTEM 5 SERVICE INFORMATION------------------------------------------------ 5-2 TROUBLESHOOTING----------------------------------------------------- 5-3 FUEL TANK -----------------------------------------------------------------

More information

13. FUEL SYSTEM/CARBURETOR/

13. FUEL SYSTEM/CARBURETOR/ 13 FUEL SYSTEM/CARBURETOR/FUEL PUMP FUEL SYSTEM --------------------------------------------------------- 13-1 SCHEMATIC DRAWING ---------------------------------------------- 13-2 OPERATION OF CARBURETOR

More information

COLT 2310, 2510, AND 2712 COM PACT TRACTORS CHAPTER 9 TROUBLESHOOTING AND ANALYSIS

COLT 2310, 2510, AND 2712 COM PACT TRACTORS CHAPTER 9 TROUBLESHOOTING AND ANALYSIS COLT 2310, 2510, AND 2712 COM PACT TRACTORS CHAPTER 9 TROUBLESHOOTING AND ANALYSIS 9-A-1 UPON RECEIVING ANENGINE FORRE- PAIR. Learn the history of the unit from the customer. While the customer is present

More information

FUEL SYSTEM/CARBURETOR/FUEL PUMP

FUEL SYSTEM/CARBURETOR/FUEL PUMP 13 FUEL SYSTEM/CARBURETOR/FUEL PUMP FUEL SYSTEM-------------------------------------------------------------------------------------13-1 SCHEMATIC DRAWING-------------------------------------------------------------------------13-2

More information

Typical Install Instructions

Typical Install Instructions Typical Install Instructions Read & understand all steps of these instructions before beginning this installation. WEBER Conversion Kit, VW T-1/2, up to 1835cc 32 / 36 DFEV Weber Carburetor These instructions

More information

CARBURETOR. Preliminary Check. Removal of DuraForce Carburetor

CARBURETOR. Preliminary Check. Removal of DuraForce Carburetor Fuel Leaks From Carburetor (Leaking starts after running, stops after shutdown) Note: This condition which does NOT drain the fuel tank is called spit-back. Possible Causes Engine RPM out of proper range

More information

4. FUEL SYSTEM CK 1 4-0

4. FUEL SYSTEM CK 1 4-0 4 4 4-0 SERVICE INFORMATION... 4-1 FLOAT LEVEL INSPECTION... 4-5 TROUBLESHOOTING... 4-2 CARBURETOR INSTALLATION... 4-6 THROTTLE VALVE DISASSEMBLY... 4-3 THROTTLE VALVE ASSEMBLY... 4-6 CARBURETOR REMOVAL...

More information

SECTION 4 - FUEL SYSTEMS AND CARBURETION

SECTION 4 - FUEL SYSTEMS AND CARBURETION SECTION - FUEL SYSTEMS AND CARBURETION FUEL SYSTEMS - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -62 FUEL PUMP - - - - - - -

More information

Service Instruction ENGINE COMPONENTS, INC.

Service Instruction ENGINE COMPONENTS, INC. Title: Service Instruction S.I. No.: 89-5-1 Page: 1 of 5 Issued: 05/05/89 Revision: 1 (09/01/01) Technical Portions of FAA DER Approved. FAILURE OF ENGINE TO START 27 points 1. Lack of fuel 2. Ignition

More information

5. FUEL SYSTEM FUEL SYSTEM 5-0

5. FUEL SYSTEM FUEL SYSTEM 5-0 5 FUEL SYSTEM 5-0 SERVICE INFORMATION GENERAL INSTRUCTIONS SERVICE INFORMATION...5-1 CARBURETOR INSTALLATION...5-9 TROUBLESHOOTING...5-1 PILOT SCREW ADJUSTMENT...5-10 CARBURETOR REMOVAL...5-2 AUTO BYSTARTER...5-3

More information

~. a~' ~ ( I o~~~ 4-0. ~Sj~' AO~ i/~ CB1000C (ij)aon'da in-ib) ~ "" ~ ~!~~P. ~ J N m (6-12 kg-em,

~. a~' ~ ( I o~~~ 4-0. ~Sj~' AO~ i/~ CB1000C (ij)aon'da in-ib) ~  ~ ~!~~P. ~ J N m (6-12 kg-em, e V ~. a~' ~ I ~ J C t \"" 8.0- ( I o~~~ ~ "" ~ ~. ~!~~P. C8 0 & 0,-t. ~ CB1000C (ij)aon'da 0.6-1.2 N m (6-12 kg-em, 5-10 in-ib) 4-0 / 4.0-6.0 N m (40-60 kg-em, 35-52 in-i b) t$ "'07~ / c;:::/ j ~Sj~'

More information

5. FUEL SYSTEM 5-0 FUEL SYSTEM UXV 500

5. FUEL SYSTEM 5-0 FUEL SYSTEM UXV 500 5 FUEL SYSTEM 5 SERVICE INFORMATION------------------------------------------------ 5-02 TROUBLESHOOTING----------------------------------------------------- 5-03 FUEL TANK -----------------------------------------------------------------

More information

Name Date. True-False. Multiple Choice

Name Date. True-False. Multiple Choice Name Date True-False T F 1. Oil film thickness increases with an increase in oil temperature. T F 2. Displacement is the volume that a piston displaces in an engine when it travels from top dead center

More information

Body type location. Model number location. Small Engine Parts

Body type location. Model number location. Small Engine Parts Body type location Model number location Small Engine Parts FUEL PUMP SYSTEM SYSTEMS AND OPERATION The fuel pump on a diaphragm carburetor uses the vacuum and pressure pulse from the engines crankcase

More information

7. FUEL SYSTEM ('04 - '05)

7. FUEL SYSTEM ('04 - '05) 7. FUEL SYSTEM ('04 - '05) SYSTEM COMPONENTS 7-2 CARBURETOR DISASSEMBLY 7-81 SERVICE INFORMATION 7-3 CARBURETOR ASSEMBLY 7-14 TROUBLESHOOTING 7-4 CARBURETOR INSTALLATION 7-21 AIR CLEANER HOUSING 7-5 PILOT

More information

11. CARBURETOR 11-0 CARBURETOR ZX / SCOUT 50

11. CARBURETOR 11-0 CARBURETOR ZX / SCOUT 50 11 CARBURETOR SERVICE INFORMATION... 11-2 TROUBLESHOOTING... 11-2 THROTTLE VALVE DISASSEMBLY... 11-3 THROTTLE VALVE INSTALLATION... 11-4 CARBURETOR REMOVAL... 11-5 AUTO BYSTARTER... 11-6 FLOAT CHAMBER...

More information

TROUBLE SHOOTING - BASIC PROCEDURES

TROUBLE SHOOTING - BASIC PROCEDURES TROUBLE SHOOTING - BASIC PROCEDURES 1990 Nissan 240SX GENERAL TROUBLE SHOOTING * PLEASE READ THIS FIRST * NOTE: This is GENERAL information. This is not intended to be specific to any unique situation

More information

Oregon Fuel Injection

Oregon Fuel Injection Cummins PT Fuel Pump Diagnostic No Start, with no smoke 1. This could be caused by the fuel pump not turning or a seized gear pump. Remove the fuel supply hose and the fuel inlet fitting from the gear

More information

Hydraulic Pumping System

Hydraulic Pumping System Hydraulic Pumping System Easy-Kleen Pressure Systems LTD. 41 Earnhardt Road Sussex Corner, NB E4E 6A1 1 800 315 5533 1 HD SERIES PUMPING SYSTEM WITH HYDRAULIC MOTOR: OPERATION 1. Place unit on level and

More information

Illustrated Parts List. Model Series 31A600. TYPE NUMBERS 0111 Through TABLE OF CONTENTS

Illustrated Parts List. Model Series 31A600. TYPE NUMBERS 0111 Through TABLE OF CONTENTS Illustrated Parts List Model Series 31A600 TYPE NUMBERS 0111 Through 4139. TABLE OF CONTENTS FORM MS3735 REV S 11/21/2012 REPLACES FORM MS3735 REV R 05/08/2012 FILE IN SECT. 2 OF SERVICE MANUAL 31A600

More information

Mfg. No: 49T G1

Mfg. No: 49T G1 Parts Manual Mfg. No: 49T877-0004-G1 Copyright Briggs and Stratton. All Rights reserved 28-Feb-2018 Model Components Table Of Contents Page Blower Housing, Air Cleaner............................................................................

More information

Minuteman International s Trouble Shooting the Kawasaki 17 HP Engine Engine Will Not Start.

Minuteman International s Trouble Shooting the Kawasaki 17 HP Engine Engine Will Not Start. Minuteman International s Trouble Shooting the Kawasaki 17 HP Engine Instructions: Follow these steps until the problem is resolved Engine Will Not Start. (Battery is good and engine is cranking) 1. Do

More information

CARBURETOR SERVICE INFORMATION TROUBLESHOOTING THROTTLE VALVE DISASSEMBLY THROTTLE VALVE INSTALLATION...

CARBURETOR SERVICE INFORMATION TROUBLESHOOTING THROTTLE VALVE DISASSEMBLY THROTTLE VALVE INSTALLATION... 11 CARBURETOR SERVICE INFORMATION... 11-2 TROUBLESHOOTING... 11-2 THROTTLE VALVE DISASSEMBLY... 11-3 THROTTLE VALVE INSTALLATION... 11-4 CARBURETOR REMOVAL... 11-5 AUTO BYSTARTER... 11-6 FLOAT CHAMBER...

More information

Troubleshooting the Transmission Hydraulic System

Troubleshooting the Transmission Hydraulic System Testing and Adjusting IT28F INTEGRATED TOOLCARRIER POWER TRAIN Testing And Adjusting Introduction Reference: For Specifications with illustrations, refer to SENR5974, IT28F Integrated Toolcarrier Power

More information

TECH INFORMATION EMPI D Performance 2-Barrel Carburetor

TECH INFORMATION EMPI D Performance 2-Barrel Carburetor TECH INFORMATION EMPI D Performance 2-Barrel Carburetor The New EMPI D 2-Barrel Performance Carburetor.Built specifically for the VW Aftermarket. With all the features that you have asked for More Progression

More information

k. Components not properly adjusted. Refer to machine technical manual for proper adjustment of components.

k. Components not properly adjusted. Refer to machine technical manual for proper adjustment of components. General Troubleshooting Charts General Troubleshooting Charts Use the charts on the following pages to help in listing all the possible causes of trouble when you begin diagnosing and testing of a machine.

More information

4. FUEL SYSTEM 4-0 FUEL SYSTEM NEXXON 50

4. FUEL SYSTEM 4-0 FUEL SYSTEM NEXXON 50 4 FUEL SYSTEM SERVICE INFORMATION ------------------------------------------------ 4-2 TROUBLESHOOTING----------------------------------------------------- 4-3 AIR CLEANER REMOVAL -----------------------------------------------

More information

Illustrated Parts List. Model Series 31Q700. TYPE NUMBERS 0036 Through TABLE OF CONTENTS

Illustrated Parts List. Model Series 31Q700. TYPE NUMBERS 0036 Through TABLE OF CONTENTS Illustrated Parts List Model Series 31Q700 TYPE NUMBERS 0036 Through 3136. TABLE OF CONTENTS FORM MS5767 REV P 05/17/2012 REPLACES FORM MS5767 REV M 01/16/2012 FILE IN SECT. 2 OF SERVICE MANUAL 31Q700

More information

Illustrated Parts List. Model Series 31A700. TYPE NUMBERS 0112 through TABLE OF CONTENTS

Illustrated Parts List. Model Series 31A700. TYPE NUMBERS 0112 through TABLE OF CONTENTS Illustrated Parts List Model Series 31A700 TYPE NUMBERS 0112 through 2454. TABLE OF CONTENTS FORM MS5533 REV R 11/30/2012 REPLACES FORM MS5533 REV P 05/08/2012 FILE IN SECT. 2 OF SERVICE MANUAL 31A700

More information

Reproduction. Not for. Illustrated Parts List 44S700. Model Series TYPE NUMBERS 0001 THROUGH 0003, 0005, 0007, 0009, 0011, 0013 THROUGH 0020.

Reproduction. Not for. Illustrated Parts List 44S700. Model Series TYPE NUMBERS 0001 THROUGH 0003, 0005, 0007, 0009, 0011, 0013 THROUGH 0020. FORM MS10464 REV B 06/03/2016 MS10464 REV A 06/10/2015 FILE IN SECT. 2 OF SERVICE MANUAL 44S700 Illustrated Parts List Model Series 44S700 TYPE NUMBERS 0001 THROUGH 0003, 0005, 0007, 0009, 0011, 0013 THROUGH

More information

12. CARBURETOR/FUEL PUMP

12. CARBURETOR/FUEL PUMP 12 CARBURETOR/FUEL PUMP SERVICE INFORMATION... 12-2 TROUBLESHOOTING... 12-2 THROTTLE VALVE DISASSEMBLY... 12-3 THROTTLE VALVE INSTALLATION... 12-4 CARBURETOR REMOVAL... 12-5 AUTO BYSTARTER... 12-6 FLOAT

More information

12. CARBURETOR 12-0 CARBURETOR VITALITY 50

12. CARBURETOR 12-0 CARBURETOR VITALITY 50 12 12 CARBURETOR SERVICE INFORMATION (2-STROKE)... 12-2 SERVICE INFORMATION (4-STROKE)... 12-3 THROTTLE VALVE (2-STROKE)... 12-5 CARBURETOR (2-STROKE)... 12-7 AIR SCREW ADJUSTMENT (2-STROKE)... 12-13 REED

More information

20. TROUBLESHOOTING ENGINE DOES NOT START OR IS HARD TO START XL200

20. TROUBLESHOOTING ENGINE DOES NOT START OR IS HARD TO START XL200 20. ENGINE DOES NOT START OR IS HARD TO START 20-1 ENGINE LACKS POWER 20-2 POOR PERFORMANCE AT LOW AND IDLE SPEED 20-3 POOR PERFORMANCE AT HIGH SPEED 20-4 POOR HANDLING 20-4 ENGINE DOES NOT START OR IS

More information

CARBURETION. Carburetor Identification. Models , , , , , , , , , , ,

CARBURETION. Carburetor Identification. Models , , , , , , , , , , , Carburetor Identification Models 110400, 110600, 111400, 111600, 113400, 120400, 120600, 121400, 121600, 122600, 123400, 123600 Models 28S700, 311700 Service Carburetor Briggs & Stratton/Walbro LMS Models

More information

Illustrated Parts List 31L700

Illustrated Parts List 31L700 FORM MS 5070 06/30/2004 REPLACES FORM MS 5070 02/20/2004 FILE IN SECT. 2 OF SERVICE MANUAL 31L700 Illustrated Parts List Model Series 31L700 TYPE NUMBERS 0036 Through 0192 TABLE OF CONTENTS Alternator..........................

More information

Reproduction. Not for. Illustrated Parts List 49T800. Model Series TYPE NUMBERS 0001 THROUGH 0021.

Reproduction. Not for. Illustrated Parts List 49T800. Model Series TYPE NUMBERS 0001 THROUGH 0021. FORM MS10496 REV C 02/05/2016 REPLACES FORM MS10496 REV B 04/22/2014 FILE IN SECT. 2 OF SERVICE MANUAL Illustrated Parts List Model Series TYPE NUMBERS 0001 THROUGH 0021. PRINTED IN U.S.A. COPYRIGHT by

More information

Table 6-1. Problems and solutions with pump operations. No Fluid Delivery

Table 6-1. Problems and solutions with pump operations. No Fluid Delivery Table 6-1. and solutions with pump operations No Fluid Delivery Fluid level in the reservoir is low. Oil intake pipe or inlet filter is plugged. Air leak in the inlet line prevents priming or causes noise

More information

CHEM-TEX POWER MAX 25 GOLD EDITION TRUCK MOUNT MANUAL

CHEM-TEX POWER MAX 25 GOLD EDITION TRUCK MOUNT MANUAL CHEM-TEX POWER MAX 25 GOLD EDITION TRUCK MOUNT MANUAL Congratulations On your purchase of a Power Max 25 Gold Edition Truck mount. The Power Max 25 Gold Edition are designed for the professional cleaning

More information

1. GENERAL INFORMATION

1. GENERAL INFORMATION GENERAL INFORMATION ENGINE SERIAL NUMBER ---------------------------------------------- - SPECIFICATIONS ---------------------------------------------------------- - 2 SERVICE PRECAUTIONS ------------------------------------------------

More information

Illustrated Parts List. Model Series AIR COOLED

Illustrated Parts List. Model Series AIR COOLED FORM MS6154--06/10/2010 REPLACE FORM MS6154--03/06/2010 FILE IN SECT. 2 OF SERVICE MANUAL Illustrated Parts List Model Series AIR COOLED TYPE NUMBERS 0035, 0038, 0048, 0076, 0078, 0079, 0100, 0111, 0113,

More information

Illustrated Parts List

Illustrated Parts List FORM MS 56 08/11/2004 REPLACES FORM MS 56 11/14/2002 FILE IN SECT. 2 OF SERVICE MANUAL 312700 Illustrated Parts List Model Series 312700 TYPE NUMBERS 0101 through 01. TABLE OF CONTENTS Air Cleaner.........................

More information

INSIDE YOUR HOLLEY CARBURETOR FUEL INLET SYSTEM

INSIDE YOUR HOLLEY CARBURETOR FUEL INLET SYSTEM INSIDE YOUR HOLLEY CARBURETOR The carburetor is quite simply a fuel metering device that operates under the logical and straightforward laws of physics. It has evolved over the years from a very simple

More information

Illustrated Parts List. Model Series. TYPE NUMBERS 0113 through TABLE OF CONTENTS

Illustrated Parts List. Model Series. TYPE NUMBERS 0113 through TABLE OF CONTENTS Illustrated Parts List Model Series 219800 TYPE NUMBERS 0113 through 4389. TABLE OF CONTENTS FORM MS5709 REV P 11/08/2012 REPLACES FORM MS5709 REV N 04/24/2012 FILE IN SECT. 2 OF SERVICE MANUAL 219800

More information

Do not bend or twist the control cable. Damaged control cable will not operate smoothly and may stick or bind.

Do not bend or twist the control cable. Damaged control cable will not operate smoothly and may stick or bind. XL200 4. FUEL SYSTEM SERVICE INFORMATION 4-1 TROUBLESHOOTING 4-2 CARBURETOR 4-3 PILOT SCREW ADJUSTMENT 4-14 ACCELERATOR PUMP ADJUSTMENT 4-15 AIR CLEANER HOUSING 4-15 FUEL TANK 4-16 SERVICE INFORMATION

More information

Illustrated Parts List 31G700

Illustrated Parts List 31G700 FORM MS 64 11/18/2004 REPLACES FORM MS 64 10/13/2004 FILE IN SECT. 2 OF SERVICE MANUAL 31G700 Illustrated Parts List Model Series 31G700 TYPE NUMBERS 0026 through 0294. TABLE OF CONTENTS Air Cleaner.........................

More information

Reproduction. Not for. Illustrated Parts List 31E800. Model Series TYPE NUMBERS 1502, 1630, 4502.

Reproduction. Not for. Illustrated Parts List 31E800. Model Series TYPE NUMBERS 1502, 1630, 4502. FORM MS10271 REV J 01/29/2016 REPLACES FORM MS10271 REV H 05/08/2015 FILE IN SECT. 2 OF SERVICE MANUAL 31E800 Illustrated Parts List Model Series 31E800 TYPE NUMBERS 1502, 1630, 4502. PRINTED IN U.S.A.

More information

Illustrated Parts List. Model Series 31P600

Illustrated Parts List. Model Series 31P600 FORM MS3748 REV W 02/19/2016 REPLACES FORM MS3748 REV U 04/17/2015 FILE IN SECT. 2 OF SERVICE MANUAL 31P600 Illustrated Parts List Model Series 31P600 TYPE NUMBERS 0114, 01, 0110, 0113, 0113, 0113, 0116,

More information

Illustrated Parts List

Illustrated Parts List FORM MS 54 08/11/2004 REPLACES FORM MS 54 11/14/2002 FILE IN SECT. 2 OF SERVICE MANUAL 311700 Illustrated Parts List Model Series 311700 TYPE NUMBERS 0005 through 0209. TABLE OF CONTENTS Air Cleaner.........................

More information

365-SUB Engine : Engine Assembly 365-SUB [1/1] Page 1 of 5

365-SUB Engine : Engine Assembly 365-SUB [1/1] Page 1 of 5 Page 1 of 5 1 951-11012 Bolt 2 951-11054 Valve Cover 2 951-11054 1 Valve Cover 3 731-07059 Breather Hose 4 726-04101 Hose Clamp 6 N/A 1 Intake Valve Spring Seat 7 751-11124 Pivot Locking Nut 7 751-11124

More information

Illustrated Parts List. Model Series 21A900. TYPE NUMBERS 0101 through TABLE OF CONTENTS

Illustrated Parts List. Model Series 21A900. TYPE NUMBERS 0101 through TABLE OF CONTENTS Illustrated Parts List Model Series TYPE NUMBERS 0101 through 0199. TABLE OF CONTENTS FORM MS--5069--03/17/2009 REPLACES FORM MS--5069--06/17/2008 FILE IN SECT. 2 OF SERVICE MANUAL Air Cleaner... 7 Alternator...

More information

Illustrated Parts List. Model Series. TYPE NUMBERS 0001 through TABLE OF CONTENTS

Illustrated Parts List. Model Series. TYPE NUMBERS 0001 through TABLE OF CONTENTS Illustrated Parts List Model Series 215800 TYPE NUMBERS 0001 through 4529. TABLE OF CONTENTS FORM MS5497 REV R 12/19/2014 REPLACES FORM MS5497 REV P 10/30/2012 FILE IN SECT. 2 OF SERVICE MANUAL 215800

More information

Illustrated Parts List

Illustrated Parts List FORM MS 4183 10/31/2006 REPLACES FORM MS 9748 7/1997 FILE IN SECT. 2 OF SERVICE MANUAL 290700 Illustrated Parts List Model Series 290700 TYPE NUMBERS 0100, 0102, 0106, 0107, 0108, 0333, 0402, 0410. TO

More information

February 26, ch.12.notebook. Ch. 12. Preventative Maintenance and Troubleshooting. Feb 23 5:03 PM

February 26, ch.12.notebook. Ch. 12. Preventative Maintenance and Troubleshooting. Feb 23 5:03 PM Ch. 12 Preventative Maintenance and Troubleshooting Feb 23 5:03 PM 1 Why PM? preventive maintenance certain maintenance tasks must be performed regularly to keep an engine working properly helps premature

More information

Reproduction. Not for. Illustrated Parts List. Model Series. John Deere B1 TYPE NUMBER B1. 10/13/2009 MSC PRINTED IN U.S.A.

Reproduction. Not for. Illustrated Parts List. Model Series. John Deere B1 TYPE NUMBER B1. 10/13/2009 MSC PRINTED IN U.S.A. 10/13/2009 MSC000147 John Deere 407777-0232 -B1 Illustrated Parts List Model Series 407777 TYPE NUMBER 0232--B1. PRINTED IN U.S.A. COPYRIGHT by BRIGGS & STRATTON CORPORATION All rights reserved. No part

More information

Reproduction. Not for. Illustrated Parts List. Model Series VERTICAL SHAFT AIR COOLED TYPE NUMBER(S): 0113, 1113, 2113.

Reproduction. Not for. Illustrated Parts List. Model Series VERTICAL SHAFT AIR COOLED TYPE NUMBER(S): 0113, 1113, 2113. Illustrated Parts List Model Series VERTICAL SHAFT AIR COOLED FORM MS3867 REV C--06/17/2016 REPLACES FORM MS3867 -- REV B -- 03/21/2014 FILE IN SECT. 2 OF SERVICE MANUAL TYPE NUMBER(S): 0113, 1113, 2113.

More information

Illustrated Parts List. Model Series. TYPE NUMBERS 0026 through TABLE OF CONTENTS

Illustrated Parts List. Model Series. TYPE NUMBERS 0026 through TABLE OF CONTENTS Illustrated Parts List Model Series 331800 TYPE NUMBERS 0026 through 4449. TABLE OF CONTENTS FORM MS3911 REV S 05/19/2012 REPLACES FORM MS3911 REV R 05/18/2012 FILE IN SECT. 2 OF SERVICE MANUAL 331800

More information

Mfg. No: 124P F1

Mfg. No: 124P F1 Parts Manual Mfg. No: 124P02-0001-F1 Copyright Briggs and Stratton. All Rights reserved 15-Jan-2018 Model Components Table Of Contents Page Blower Housing and Air Cleaner Group..................................................................

More information

CARBURETION. Flo-Jet Carburetors. One Piece. One-Piece Flo-Jet. Main Jet Adjustment N eedle

CARBURETION. Flo-Jet Carburetors. One Piece. One-Piece Flo-Jet. Main Jet Adjustment N eedle One Piece One-Piece Flo-Jet The small One-Piece Flo-Jet carburetor is illustrated in Fig. 122 and was used on early Model 170700. These are float feed carburetors with adjustable orifice main jet needle

More information

FUEL SYSTEM CIRCUIT D'ESSENCE KRAFTSTOFFSYSTEM

FUEL SYSTEM CIRCUIT D'ESSENCE KRAFTSTOFFSYSTEM CIRCUIT D'ESSENCE KRAFTSTOFFSYSTEM 41 FUEL SYSTEM SERVICE INFORMATION TROUBLESHOOTING FUEL TANK AIR CLEANER CARBURETOR REMOVAL VACUUM CHAMBER FLOAT CHAMBER 4-1 PILOT SCREW 4-2 CARBURETOR SEPARATION 4-3

More information

Mfg. No: 104M F1

Mfg. No: 104M F1 Parts Manual Mfg. No: 104M02-0126-F1 Copyright Briggs and Stratton. All Rights reserved 12-Jan-2018 Model Components Table Of Contents Page Air Cleaner Group.....................................................................................

More information

Engine Does Not Start or Is Hard to Start Cause of Trouble. 1. Open the drain screw, and check Fuel not supplied (1) Fuel tank empty

Engine Does Not Start or Is Hard to Start Cause of Trouble. 1. Open the drain screw, and check Fuel not supplied (1) Fuel tank empty 20. Engine Does Not Start or Is Hard to Start 20-1 Engine Output Insufficient 20-2 Poor Performance at Low Speed and Idling 20-3 Poor Performance at High Speed 20-3 Unsatisfactory Operation 20-4 Fuel Gauge

More information

Illustrated Parts List

Illustrated Parts List FORM MS 3745 12/21/2006 FILE IN SECT. 2 OF SERVICE MANUAL 613700 Illustrated Parts List Model Series 613700 TYPE NUMBERS 0110. TABLE OF CONTENTS Air Cleaner......................... 6 Alternator..........................

More information

Illustrated Parts List

Illustrated Parts List 01/08/2010 FILE IN SECT. 2 OF SERVICE MANUAL PRO DRIVE 613777-0113 -E1 Illustrated Parts List Model Series AIR COOLED 613777 TYPE NUMBERS 0113. TABLE OF CONTENTS Air Cleaner... Alternator... Blower Housing/Shrouds...

More information

Illustrated Parts List. Model Series 31N800 TYPE NUMBERS TABLE OF CONTENTS

Illustrated Parts List. Model Series 31N800 TYPE NUMBERS TABLE OF CONTENTS Illustrated Parts List Model Series 31N800 TYPE NUMBERS 0440. TABLE OF CONTENTS FORM MS--3593--04/20/2009 REPLACES FORM MS--3593--09/25/2008 FILE IN SECT. 2 OF SERVICE MANUAL 31N800 Air Cleaner... 5 Alternator...

More information

Reproduction. Not for. Illustrated Parts List MTD. Model 126T B1 10/22/2009 MSC PRINTED IN U.S.A.

Reproduction. Not for. Illustrated Parts List MTD. Model 126T B1 10/22/2009 MSC PRINTED IN U.S.A. Illustrated Parts List Model MTD 10/22/2009 MSC000173 PRINTED IN U.S.A. COPYRIGHT by BRIGGS & STRATTON CORPORATION All rights reserved. No part of this material may be reproduced or transmitted, in any

More information

WORKSHOP MANUAL. 63,4 cm³ chainsaws

WORKSHOP MANUAL. 63,4 cm³ chainsaws WORKSHOP MANUAL General failures analysis Suggested tools I. Emak tool kit II. Compression tester: to check thermal group III. Electronic tachometer: for 2 and 4 stroke engines, measurement range from

More information

CIRRUS AIRPLANE MAINTENANCE MANUAL

CIRRUS AIRPLANE MAINTENANCE MANUAL POWER PLANT 1. GENERAL This chapter describes maintenance practices for the airplane systems which provide the means to induce and convert fuel-air mixture into power such as the engine, baffling, cowling,

More information

Illustrated Parts List. Model Series 31F700. TYPE NUMBERS 0110 through TABLE OF CONTENTS

Illustrated Parts List. Model Series 31F700. TYPE NUMBERS 0110 through TABLE OF CONTENTS Illustrated Parts List Model Series 31F700 TYPE NUMBERS 0110 through 0403. TABLE OF CONTENTS FORM MS--5035--04/27/2009 REPLACES FORM MS--5035--09/29/2008 FILE IN SECT. 2 OF SERVICE MANUAL 31F700 Air Cleaner...

More information

Mfg. No: B1

Mfg. No: B1 Parts Manual Mfg. No: 295777-0002-B1 Copyright Briggs and Stratton. All Rights reserved 01-Apr-2018 Model Components Table Of Contents Page Air Cleaner...........................................................................................

More information

Mfg. No: 121P F1

Mfg. No: 121P F1 Parts Manual Mfg. No: 121P02-0002-F1 Copyright Briggs and Stratton. All Rights reserved 31-Dec-2017 Model Components Table Of Contents Page Blower Housing and Air Cleaner Group..................................................................

More information

Illustrated Parts List. Model Series. TYPE NUMBERS 0026 through TABLE OF CONTENTS

Illustrated Parts List. Model Series. TYPE NUMBERS 0026 through TABLE OF CONTENTS Illustrated Parts List Model Series TYPE NUMBERS 0026 through TABLE OF CONTENTS Air Cleaner... 5 Alternator... 7 Blower Housing... 5 Camshaft... 2 Carburetor... 4 Controls... 7 Crankshaft... 2 Cylinder...

More information

PLEASE NOTE: This is a PRELIMINARY copy of the Carburetor Reference Manual.

PLEASE NOTE: This is a PRELIMINARY copy of the Carburetor Reference Manual. PLEASE NOTE: This is a PRELIMINARY copy of the Carburetor Reference Manual. Carburetor Service Kits The carburetors for most current production engines are serviced with convenient kits, which include

More information

A SYSTEMATIC SEQUENCE FOR PM INSPECTIONS

A SYSTEMATIC SEQUENCE FOR PM INSPECTIONS A SYSTEMATIC SEQUENCE FOR PM INSPECTIONS TYPE OF INSPECTION UNDER THE HOOD GASOLINE AND DIESEL 1 Fuel, oil, exhaust leaks - inspect 2 Oil and fuel lines inspect for kinks and wear 3 Automatic transmission

More information

Illustrated Parts List. Model Series. TYPE NUMBERS 0001 through TABLE OF CONTENTS

Illustrated Parts List. Model Series. TYPE NUMBERS 0001 through TABLE OF CONTENTS Illustrated Parts List Model Series 305700 TYPE NUMBERS 0001 through 3033. TABLE OF CONTENTS FORM MS6008 Rev B--04/17/2014 REPLACES FORM MS--6008--09/05/2007 FILE IN SECT. 2 OF SERVICE MANUAL 305700 Air

More information

Illustrated Parts List

Illustrated Parts List FORM MS--9727--09/04/2007 REPLACES FORM MS--9727--11/01/2006 FILE IN SECT. 2 OF SERVICE MANUAL 303700 Illustrated Parts List Model Series 303700 TYPE NUMBERS 0007 through 1206. TABLE OF CONTENTS Air Cleaner...

More information

Illustrated Parts List. Model Series 31C700 TYPE NUMBERS 0005 THROUGH TABLE OF CONTENTS

Illustrated Parts List. Model Series 31C700 TYPE NUMBERS 0005 THROUGH TABLE OF CONTENTS Illustrated Parts List Model Series 31C700 TYPE NUMBERS 0005 THROUGH 3346. TABLE OF CONTENTS Air Cleaner... 5 Alternator... 7 Blower Housing... 5 Camshaft... 2 Carburetor... 4 Controls... 7 Crankshaft...

More information

Illustrated Parts List 31F700

Illustrated Parts List 31F700 FORM MS 5035 09/08/2004 REPLACES FORM MS 5035 08/04/2004 FILE IN SECT. 2 OF SERVICE MANUAL Illustrated Parts List Model Series TYPE NUMBERS 0110 through 0318. TABLE OF CONTENTS Air Cleaner.........................

More information

Illustrated Parts List. Model Series 31B700. TYPE NUMBERS 0005 through TABLE OF CONTENTS

Illustrated Parts List. Model Series 31B700. TYPE NUMBERS 0005 through TABLE OF CONTENTS Illustrated Parts List Model Series TYPE NUMBERS 0005 through 0420. TABLE OF CONTENTS FORM MS--5534--04/15/2009 REPLACES FORM MS--5534--10/23/2008 FILE IN SECT. 2 OF SERVICE MANUAL Air Cleaner... 6 Alternator...

More information

CARBURETOR - HITACHI 2-BBL

CARBURETOR - HITACHI 2-BBL CARBURETOR - HITACHI 2-BBL 1986 Isuzu Trooper II 1986 Hitachi Carburetors HITACHI DCH340, DCR384, DFP340, DFP384 & DHP340 2-BARREL P UP & Trooper II DESCRIPTION Carburetor is a 2-barrel downdraft type

More information

Illustrated Parts List 28B700

Illustrated Parts List 28B700 FORM MS 0153 10/07/2004 REPLACES FORM MS 0153 4C 5/2002 FILE IN SECT. 2 OF SERVICE MANUAL 28B700 Illustrated Parts List Model Series 28B700 TYPE NUMBERS 0001 through 1201. TABLE OF CONTENTS Air Cleaner.........................

More information

Nikki Carburetor Vertical Models , ,

Nikki Carburetor Vertical Models , , Nikki Carburetor Vertical Models 280000, 310000, 330000 Disassemble Carburetor 1. Remove fuel bowl screws (A, Figure 56). Remove the fuel bowl (B) from the carburetor body. WARNING Before servicing the

More information

TILLOTSON LTD., CLASH INDUSTRIAL ESTATE, TRALEE, CO. KERRY, IRELAND PHONE: FAX:

TILLOTSON LTD., CLASH INDUSTRIAL ESTATE, TRALEE, CO. KERRY, IRELAND PHONE: FAX: TILLOTSON LTD., CLASH INDUSTRIAL ESTATE, TRALEE, CO. KERRY, IRELAND PHONE: +353 66 7121911 FAX: +353 66 7124503 e-mail: sales@tillotson.ie HR SERIES SERVICE MANUAL INTRODUCTION Tillotson has developed

More information

Illustrated Parts List

Illustrated Parts List FORM MS 2264 07/20/2005 REPLACES FORM MS 2264 03/04/2005 FILE IN SECT. 2 OF SERVICE MANUAL 350700 Illustrated Parts List Model Series 350700 TYPE NUMBERS 0034 through 1171. TABLE OF CONTENTS Air Cleaner.........................

More information

Illustrated Parts List. Model Series 31X700 TYPE NUMBERS TABLE OF CONTENTS

Illustrated Parts List. Model Series 31X700 TYPE NUMBERS TABLE OF CONTENTS FORM MS--3506--01/19/2006 REPLACES FORM MS--3506--08/01/2005 FILE IN SECT. 2 OF SERVICE MANUAL 31X700 Illustrated Parts List Model Series 31X700 TYPE NUMBERS 0777. TABLE OF CONTENTS Air Cleaner... 5 Alternator...

More information

Illustrated Parts List 28N700

Illustrated Parts List 28N700 FORM MS 0148 09/14/2004 REPLACES FORM MS 0148 4C 12/1/2003 FILE IN SECT. 2 OF SERVICE MANUAL Illustrated Parts List Model Series TYPE NUMBERS 0026 through 1205. TABLE OF CONTENTS Air Cleaner.........................

More information

TILLOTSON LTD., CLASH INDUSTRIAL ESTATE, TRALEE, CO. KERRY, IRELAND PHONE: FAX:

TILLOTSON LTD., CLASH INDUSTRIAL ESTATE, TRALEE, CO. KERRY, IRELAND PHONE: FAX: TILLOTSON LTD., CLASH INDUSTRIAL ESTATE, TRALEE, CO. KERRY, IRELAND PHONE: +353 66 7121911 FAX: +353 66 7124503 e-mail: sales@tillotson.ie HS SERIES SERVICE MANUAL INTRODUCTION The demand for a miniature

More information

Illustrated Parts List 283H00

Illustrated Parts List 283H00 FORM MS 5449 09/07/2006 REPLACES FORM MS 5449 09/12/2005 FILE IN SECT. 2 OF SERVICE MANUAL 283H00 Illustrated Parts List Model Series 283H00 TYPE NUMBERS 0105, 0197, 0399, 0400 TABLE OF CONTENTS Air Cleaner.........................

More information

Illustrated Parts List Industrial/Commercial to

Illustrated Parts List Industrial/Commercial to FORM MS-9479 6/95 REPLACES FORM MS-9479 10/94 FILE IN SECT. 2 OF SERVICE MANUAL 402700 to 402799 Illustrated Parts List Industrial/Commercial Model Series 402700 to 402799 TYPE NUMBERS 1115 through 1117,

More information

Catalytic Failures. Engine running too hot.

Catalytic Failures. Engine running too hot. Catalytic Failures It is not uncommon for technicians to misdiagnose a driveability or emissions issue by blaming the converter. In many cases, it s not the converter s fault, but rather one of the engine

More information

Illustrated Parts List AA0101 AA0101. Model Series TABLE OF CONTENTS TYPE NUMBER 0001, 0005, 0020, Blower Housing/Cowl Carburetor...

Illustrated Parts List AA0101 AA0101. Model Series TABLE OF CONTENTS TYPE NUMBER 0001, 0005, 0020, Blower Housing/Cowl Carburetor... FORM MS 5131 10/27/2004 REPLACES FORM MS 5131 09/01/2003 AA0101 Illustrated Parts List TABLE OF CONTENTS Model Series AA0101 TYPE NUMBER 0001, 0005, 0020, 0025. Blower Housing/Cowl.....................

More information

Remove Air Cleaner Cover and. Filter

Remove Air Cleaner Cover and. Filter Remove Air Cleaner Cover and Inspect paper filter for tears Foam pre-cleaner is washable if equipped Replace if necessary Filter Remove Trim Panel Pull throttle lever knob off Remove 3, 8mm screws Remove

More information

Illustrated Parts List. Model Series AIR COOLED

Illustrated Parts List. Model Series AIR COOLED FORM MS5959--REV D--06/10/2016 REPLACES FORM MS5959--REV C--03/28/2014 FILE IN SECT. 2 OF SERVICE MANUAL 385700 Illustrated Parts List Model Series 385700 AIR COOLED TYPE NUMBERS 0001, 0003, 0005, 0006,

More information

SPECIFICATIONS ITEM TORQUE NOTES. Air cleaner backplate screw 7-9 ft-lbs Nm LOCTITE THREADLOCKER 242 (blue), page 4-19

SPECIFICATIONS ITEM TORQUE NOTES. Air cleaner backplate screw 7-9 ft-lbs Nm LOCTITE THREADLOCKER 242 (blue), page 4-19 4 SPECIFICATIONS CARBURETOR JET SIZES CARBURETOR ADJUSTMENTS Main jet 195 Slow jet 42 FUEL TANK CAPACITY GALLONS LITERS Total (including reserve) 4.0 15.14 Reserve 0.6 2.27 Engine fast idle speed (using

More information

Illustrated Parts List. Model Series 21B700 TYPE NUMBERS 0453, TABLE OF CONTENTS

Illustrated Parts List. Model Series 21B700 TYPE NUMBERS 0453, TABLE OF CONTENTS Illustrated Parts List Model Series 21B700 TYPE NUMBERS 0453, 0505. TABLE OF CONTENTS FORM MS--3675--10/20/2009 REPLACES FORM MS--3675--07/08/2009 FILE IN SECT. 2 OF SERVICE MANUAL 21B700 Air Cleaner...

More information

Illustrated Parts List

Illustrated Parts List FORM MS 2247 11/29/2004 REPLACES FORM MS 2247 10/05/2004 FILE IN SECT. 2 OF SERVICE MANUAL 286700 Illustrated Parts List Model Series 286700 TYPE NUMBERS 0102 through 4529. TABLE OF CONTENTS Air Cleaner.........................

More information

TILLOTSON LTD., CLASH INDUSTRIAL ESTATE, TRALEE, CO. KERRY, IRELAND PHONE: FAX:

TILLOTSON LTD., CLASH INDUSTRIAL ESTATE, TRALEE, CO. KERRY, IRELAND PHONE: FAX: TILLOTSON LTD., CLASH INDUSTRIAL ESTATE, TRALEE, CO. KERRY, IRELAND PHONE: +353 66 7121911 FAX: +353 66 7124503 e-mail: sales@tillotson.ie SERIES SERVICE MANUAL INTRODUCTION The gasoline engine industry

More information

Illustrated Parts List 21B700

Illustrated Parts List 21B700 FORM MS 3675 02/29/2008 REPLACES FORM MS 3675 11/05/2007 FILE IN SECT. 2 OF SERVICE MANUAL Illustrated Parts List Model Series TYPE NUMBERS 0453, 0505. TABLE OF CONTENTS Air Cleaner.........................

More information