WARRANTY COVERAGE AT A GLANCE

Transcription

1 DESCRIPTION 1 Yr/ 2 Yr/ 3 Yr/ 3 Yr/ 3 Yr/ 5 Yr/ 5 Yr/ 7 Yr/ 7 Yr/ 8 Yr/ 12,000 24,000 36,000 50,000 Unlmtd 50, ,000 70, ,000 80,000 Lifetime Basic Limited Warranty Coverage WARRANTY COVERAGE AT A GLANCE Special Extended Warranty Coverage Powertrain Limited Warranty ($100 Deductible) Anti-Corrosion Perforation Limited Warranty: All Panels Outer Panels Federal Emission Warranty -Light Duty Truck Federal Emission Warranty - Specified Components - Light Duty Truck Federal Emission Warranty - Heavy Duty Truck California Emission Warranty - Light & Medium Duty Truck California Emission Warranty - Specified Components - Light/Med Duty & Med Duty Diesel Cummins Diesel Engine Components Limited Warranty ($100 Deductible after 5 Years) Noise Emission Warranty - Heavy Duty 2nd Owner if Powertrain Not Transferred& 3rd (And After) Owners 1st Owner & 2nd Owner with Paid Powertrain Transfer 2nd Owner if Powertrain Not Transferred and 3rd (And After) Owners 1st Owner & 2nd Owner w/paid Powertrain Transfer 1

2 TABLE OF CONTENTS 1. Your Legal Rights Under These Limited Warranties What s Covered Under DaimlerChrysler's Warranties 2.1 Basic Limited Warranty Powertrain Limited Warranty Cummins Diesel Engine Limited Warranty Corrosion Warranty What s Not Covered 3.1 Modifications Not Covered Environmental Factors Not Covered Maintenance Costs Not Covered Incidental and Consequential Damages Not Covered Racing Not Covered Certain Kinds of Corrosion Not Covered When Powertrain Limited Warranty Does Not Apply & Less Cummins Diesel Engine Limited Warranty Coverage Applies Other Exclusions Total Loss, Salvage, Junk, or Scrap Trucks Not Covered Restricted Warranty Other Terms of Your Warranties 4.1 Exchanged Parts May Be Used in Warranty Repairs Pre-Delivery Service Production Changes Governing Law and Other Terms

3 TABLE OF CONTENTS 5. Emission Warranties Required by Law 5.1 Federal Emission Warranty - Light Duty Truck Emission Performance Warranty Federal Emission Warranty - Heavy Duty Truck California Emission Warranty Noise Emission Warranty How to Get Warranty Service 6.1 Where to Take Your Truck Emergency Warranty Repairs Getting Service Under the Federal Emission Performance Warranties Getting Service Under the California Emission Warranties How to Deal with Warranty Problems 7.1 Steps to Take Helpful Addresses and Telephone Numbers Optional Service Contract Maintenance 9.1 General Maintenance Where to Go For Maintenance

4 LEGAL RIGHTS 1. Your Legal Rights Under These Limited Warranties The warranties contained in this booklet are the only express warranties that DaimlerChrysler Motors Company LLC ("DaimlerChrysler") makes for your truck. These warranties give you specific legal rights. You may also have other rights that vary from state to state. For example, you may have some implied warranties, depending on the state where your truck is registered: An implied warranty of merchantability means that your truck is reasonably fit for the general purpose for which it was sold. An implied warranty of fitness for a particular purpose means that your truck is suitable for your special purposes if those special purposes were specifically disclosed to DaimlerChrysler itself not merely to the dealer before your purchase, and DaimlerChrysler not just the dealer told you the truck would be suitable for that purpose. These implied warranties are limited, to the extent allowed by law, to the time periods covered by the express written warranties contained in this booklet. If you use your truck primarily for business or commercial purposes, then these implied warranties do not apply and DaimlerChrysler completely disclaims them to the extent allowed by law. And the implied warranty of fitness for a particular purpose does not apply if your truck is used for racing, even if the truck is equipped for racing. Some states do not allow limitations on how long an implied warranty lasts, so the above limitations may not apply to you. 4

5 2. What's Covered Under DaimlerChrysler's Warranties 2.1 Basic Limited Warranty A. Who Is Covered? You are covered by the Basic Limited Warranty if you are a purchaser for use of the vehicle. B. What s Covered The Basic Limited Warranty covers the cost of all parts and labor needed to repair any defective item on your truck supplied by DaimlerChrysler Corporation that is defective in material, workmanship or factory preparation. There is no list of covered parts since the only exception is tires. WHAT'S COVERED UNDER DAIMLERCHRYSLER'S WARRANTIES You pay nothing for these repairs. These warranty repairs or adjustments including all parts and labor connected with them will be made by your dealer at no charge, using new or remanufactured parts. C. Items Covered by Other Warranties The following are covered by separate warranties offered by their makers. They are not covered by the Basic Limited Warranty: tires; or items added or changed after the truck left DaimlerChrysler Corporation's manufacturing plant, such as accessories or protection products, or items changed because of customization or van conversion. 5

6 WHAT'S COVERED UNDER DAIMLERCHRYSLER'S WARRANTIES Be sure you get a copy of any warranty that applies to these items from your dealer, or from the maker of the product. You can find the tire warranty statements in your Owner s Literature Package. D. Towing Costs Are Covered Under Certain Circumstances The Basic Limited Warranty covers the cost of towing your truck to the nearest Chrysler, Dodge or Jeep dealer if your truck can t be driven because a covered part has failed. E. When It Begins The Basic Limited Warranty begins on either of the following dates, whichever is earlier: the date you take delivery of the truck; or the date when the truck was first put into service for example, as a dealer demo or as a DaimlerChrysler Corporation company truck. F. When It Ends The Basic Limited Warranty lasts for 36 months from the date it begins or for 36,000 miles on the odometer, whichever occurs first. But the following items are covered only for 12 months or for 12,000 miles on the odometer, whichever occurs first: brakes (rotors, pads, linings, and drums); wiper blades; clutch discs; windshield and rear window; and wheel alignment and wheel balancing 6

7 G. Registration and Operation Requirements The Basic Limited Warranty covers your truck only if: it was built for sale in the U.S.; it s registered in the U.S.; it s driven mainly in the U.S. or Canada; and it s operated and maintained in the manner described in your Owner s Manual. H. If Your Truck Leaves the United States (We Include U.S. Possessions and Territories as Part of the United States for Warranty Purposes): EXCEPT WHERE SPECIFICALLYREQUIRED BY LAW, THERE IS NO WARRANTY COVER- AGE ON THIS TRUCK IF IT IS SOLD IN OR REGISTERED IN COUNTRIES OTHER THAN THE UNITED STATES. WHAT'S COVERED UNDER DAIMLERCHRYSLER'S WARRANTIES This policy does not apply to trucks that have received authorization for export from Daimler- Chrysler. Dealers may not give authorization for export. You should consult an authorized dealer to determine this truck's warranty coverage if you have any questions. This policy does not apply to trucks registered to U.S. government officials or military personnel on assignment outside of the United States. 2.2 Powertrain Limited Warranty A. Who is Covered? You are covered by the Powertrain Limited Warranty if you are the first purchaser for use of the vehicle. You are also covered if you are the second purchaser for use of the vehicle, and have paid the $150 transfer fee within 30 days of purchase. See Section 2.2.F for more information about transfer of coverage. 7

8 WHAT'S COVERED UNDER DAIMLERCHRYSLER'S WARRANTIES B. What s Covered The Powertrain Warranty covers the cost of all parts and labor needed (less a $100 deductible per repair visit at the end of the 3 Year/36,000 Mile Basic Limited Warranty) to repair a defective powertrain component on your vehicle listed in section 2.2.I below supplied by DaimlerChrysler Corporation that is defective in material, workmanship or factory preparation. C. Towing Costs Are Covered The Powertrain Warranty covers the cost of towing your truck to the nearest Chrysler, Dodge or Jeep dealer if your truck can t be driven because a covered part has failed. D. When It Begins The Powertrain Warranty begins at the end of the Basic Limited Warranty, on either of the following dates, whichever is earlier: the date your truck has been in service for more than 36 months; or the date you've put more than 36, 000 miles on the odometer. E. When It Ends The Powertrain Warranty lasts for 7 years from the date your truck has been in-service or 70,000 miles on the odometer, whichever occurs first, to the first owner. 8

9 WHAT'S COVERED UNDER DAIMLERCHRYSLER'S WARRANTIES F. Transfer of Powertrain Warranty For Vehicles Built On or After 10/1/2003 You can determine if your vehicle was built on or after 10/1/2003 by looking for the bar coded label on the driver's door frame or door opening. Locate the "MDH" entry on the label. The 1st two numbers are the month and the 2nd two numbers are the day. The "DATE OF MFR" entry shows month and year the vehicle was built. To transfer the Powertrain Warranty, you must have an authorized Chrysler, Dodge or Jeep dealer process a "Transfer of Coverage Application" for you. The cost for this service is $150. You pay this fee directly to the dealer. You must apply for a coverage transfer within 30 days from the date you buy the vehicle. Transfer of coverage under the Cummins Diesel Engine Warranty is included in the transfer of coverage under the Powertrain Warranty. G. No Coverage to Second Purchaser if Transfer Fee is Not Paid If you do not transfer the remainder of the 7 year/ 70,000 mile Powertrain Limited Warranty coverage and pay the transfer fee, or if you are the third (or subsequent) owner of the vehicle, the Powertrain Limited Warranty described in this Section 2.2 does not apply to you. H. Some Commercial Vehicles Are Excluded Vehicles used as a police vehicle, taxi, limousine, postal delivery vehicle, ambulance or rental vehicle are not covered by the 7 Year/70,000 Mile Powertrain Limited Warranty. 9

10 WHAT'S COVERED UNDER DAIMLERCHRYSLER'S WARRANTIES 10 I. Parts Covered: The Powertrain Warranty covers these parts and components of your truck's powertrain: Gasoline Engine: cylinder block and all internal parts; cylinder head assemblies; timing case, timing chain, timing belt, gears and sprockets; vibration damper; oil pump; water pump and housing; intake and exhaust manifolds; flywheel with starter ring gear; core plugs; valve covers; oil pan; turbocharger housing and internal parts; turbocharger wastegate actuator; supercharger; serpentine belt tensioner; seals and gaskets for listed components only. Rear Wheel Drive: rear axle housing and all internal parts; axle shafts; axle shaft bearings; drive shaft assemblies; drive shaft center bearings; universal joints and yokes; seals and gaskets for listed components only. Diesel Engine: cylinder block and all internal parts; cylinder head assemblies; core plugs; fuel injection pump and injectors; intake and exhaust manifolds; oil pan; oil pump; timing gear drive belts and/or chains and cover; turbocharger housing and internal parts; valve covers; water pump and housing; seals and gaskets for listed components only. Transmission: transmission case and all internal parts; torque converter; drive/flex plate; transmission range switch; transmission control module; bell housing; oil pan; seals and gaskets forlisted components only. NOTE: MANUAL TRANSMISSION CLUTCH PARTS ARE NOT COVERED AT ANY TIME.

11 WHAT'S COVERED UNDER DAIMLERCHRYSLER'S WARRANTIES Four-Wheel Drive (4X4): transfer case and all internal parts; transfer case control module and shift mode motor assembly; axle housing and all internal parts; axle shafts; axle shaft bearings; drive shafts assemblies (front and rear); drive shaft center bearings; universal joints and yokes; disconnect housing assembly; seals and gaskets for the listed components only. 2.3 Cummins Diesel Engine Limited Warranty A. Who Is Covered? You are covered by the Cummins Diesel Engine Limited Warranty for up to 7 years or 100,000 miles on the odometer, whichever comes first, if you are the first purchaser for use of the vehicle. You are also covered for 7 years or 100,000 miles (whichever comes first) if you are the second purchaser for use of the vehicle, and have paid the $150 transfer fee within 30 days of purchase. See section 2.2.F for more information about transfer of coverage. You are covered by the Cummins Diesel Engine Limited Warranty for up to 5 years of 100,000 miles on the odometer, whichever comes first, if you are the second owner for use of the vehicle and have not transferred the 7 year coverage and paid the transfer fee, or if you are a 3rd (or subsequent) owner for use of the vehicle. B. What's Covered In vehicles equipped with a Cummins Diesel Engine, ONLY the following engine parts and components are covered by the Cummins Diesel Engine Limited Warranty: 11

12 WHAT'S COVERED UNDER DAIMLERCHRYSLER'S WARRANTIES cylinder block and all internal parts cylinder head assemblies core plugs fuel injection pump & injectors gaskets and seals for listed components intake and exhaust manifold oil pan oil pump timing gear drive belts and/or chains and cover turbocharger housing and internal parts valve covers water pump and housing A $100 deductible per repair visit applies after your truck has been in use for 5 years, regardless of mileage. If you do not transfer the remainder of the 7 year/70,000 mile Powertrain Limited Warranty coverage, the only warranty applicable for is the remainder of both the 3 year/36,000 mile Basic Limited Warranty and 5 year/ 100,000 mile Cummins Diesel Engine Limited Warranty. See section 2.2.F for full transfer details. C. When It Begins The Cummins Diesel Engine Warranty begins at the end of the Basic Limited Warranty, on either of the following dates, whichever is earlier: the date your truck has been in service for more than 36 months; or the date you've put more than 36, 000 miles on the odometer. 12

13 WHAT'S COVERED UNDER DAIMLERCHRYSLER'S WARRANTIES D. Towing Costs Are Covered The Cummins Diesel Engine Limited Warranty covers the cost of towing your truck to the nearest Dodge dealer if your vehicle cannot be driven because a covered part has failed. E. Transfer of Cummins Diesel Engine Limited Warranty for Vehicles Built On or After 10/1/2003 When you transfer coverage under your Powertrain Warranty, coverage to 7 years or 100,000 miles (whichever comes first) under the Cummins Diesel Engine Limited Warranty is automatically transferred. F. Less Coverage to Second Purchaser If Transfer Fee Is Not Paid If you do not transfer the remainder of the 7 year/ 70,000 mile Powertrain Limited Warranty coverage, together with the 7 year/100,000 mile Cummins Diesel Engine Limited Warranty, and pay the transfer fee, or if you are the 3rd (or subsequent) owner of the vehicle, your Cummins Diesel Engine Limited Warranty runs for 5 years or 100,000 miles on the odometer, whichever comes first. G. Some Commercial Vehicles Receive 5 Year/ 100,000 Mile Coverage Vehicles used as a police vehicle, taxi, limousine, postal delivery vehicle, ambulance or rental vehicle are covered by the Cummins Diesel Engine Limited Warranty for 5 years or 100,000 miles on the odometer, whichever comes first. 13

14 WHAT'S COVERED UNDER DAIMLERCHRYSLER'S WARRANTIES 2.4 Corrosion Warranty A. Who Is Covered? You are covered if you are a purchaser for use of the vehicle. B. What's Covered This warranty covers the cost of all parts and labor needed to repair or replace any sheet metal panels that get holes from rust or other corrosion. If a hole occurs because of something other than corrosion, this warranty does not apply. Cosmetic or surface corrosion resulting, for example, from stone chips or scratches in the paint is not covered. For more details on what isn t covered by this warranty, see 3.6. C. How Long It Lasts This warranty starts when your Basic Limited Warranty begins under 2.1(E). This warranty has two time-and-mileage limits: For sheet metal panels, the limit is 36 months, with no mileage limit. For an outer-body sheet metal panel one that is finish-painted and that someone can see when walking around the truck the limits are 5 years or 100,000 miles on the odometer, whichever occurs first. 14

15 WHAT'S NOT COVERED 3. What's Not Covered 3.1 Modifications Not Covered A. Some Modifications Don t Void the Warranties But Aren t Covered Certain changes that you might make to your truck do not, by themselves, void the warranties described in this booklet. Examples of some of these changes are: installing non-daimlerchrysler Motors Company LLC ("DaimlerChrysler") parts, components, or equipment (such as a non- DaimlerChrysler radio or speed control); and using special non-daimlerchrysler materials or additives. But your warranties don t cover any part that DaimlerChrysler didn t supply or is not certified for use on your truck. Nor do they cover the costs of any repairs or adjustments that might be caused or needed because of the installation or use of non- DaimlerChrysler parts, components, equipment, materials, or additives. Performance or racing parts are considered to be non-daimlerchrysler parts. Repairs or adjustments caused by their use are not covered under your warranties. Examples of the types of alterations not covered are: installing accessories except for genuine DaimlerChrysler / MOPAR accessories installed by an authorized Chrysler, Dodge or Jeep dealer; 15

16 WHAT'S NOT COVERED applying rustproofing or other protection products; or using any refrigerant that DaimlerChrysler or DaimlerChrysler Corporation has not approved. B. Modifications That WILL Void Your Warranties These actions will void your warranties: disconnecting, tampering with, or altering the odometer will void your warranties, unless your repairing technician follows the legal requirements for repairing or replacing odometers; or attaching any device that disconnects the odometer will also void your warranties. 3.2 Environmental Factors Not Covered Your warranties don t cover damage caused by environmental factors such as airborne fallout, chemicals, tree sap, salt, ocean spray, acid rain, and road hazards. Nor do your warranties cover damage caused by hailstorms, windstorms, tornadoes, sandstorms, lightning, floods, and earthquakes. Your warranties do not cover conditions resulting from anything impacting the truck. This includes cracks and chips in glass, scratches and chips in painted surfaces, or damage from collision. 3.3 Maintenance Costs Not Covered Your warranties don t cover the costs of repairing damage caused by poor or improper maintenance. Nor do they cover damage caused by the use of contaminated fuels, or by the use of fuels, oils, lubricants, 16

17 cleaners or fluids other than those recommended in your Owner s Manual. The warranties don t cover the costs of your truck s normal or scheduled maintenance the parts and services that all trucks routinely need. Some of these parts and services, which your warranties don t cover, include: lubrication; engine tune-ups; replacing filters, coolant, spark plugs, bulbs, or fuses (unless those costs result from a covered repair); cleaning and polishing; and replacing worn wiper blades, worn brake pads and linings, or clutch linings. WHAT'S NOT COVERED 3.4 Incidental and Consequential Damages Not Covered Your warranties don t cover any incidental or consequential damages connected with your truck s failure, either while under warranty or afterward. Examples of such damages include: lost time; inconvenience; the loss of the use of your truck; the cost of rental trucks, gasoline, telephone, travel, or lodging; the loss of personal or commercial property; and the loss of revenue. Some states don t allow incidental or consequential damages to be excluded or limited, so this exclusion may not apply to you. 17

18 WHAT'S NOT COVERED 3.5 Racing Not Covered Your warranties don t cover the costs of repairing damage or conditions caused by racing, nor do they cover the repair of any defects that are found as the result of participating in a racing event. 3.6 Certain Kinds of Corrosion Not Covered Your warranties don t cover the following: corrosion caused by accident, damage, abuse, or truck alteration; surface corrosion caused by such things as industrial fallout, sand, salt, hail, and stones; corrosion caused by the extensive or abnormal transport of caustic materials like chemicals, acids, and fertilizers; and corrosion of special bodies, body conversions, or equipment not made or supplied by DaimlerChrysler Corporation or DaimlerChrysler. 3.7 When Powertrain Limited Warranty Does Not Apply and Less Cummins Diesel Engine Limited Warranty Coverage Applies You are not covered by the Powertrain Limited Warranty if you are a second owner and a transfer of coverage was not made; if you are the third (or subsequent) owner of the vehicle; or if the vehicle was used as a police vehicle, taxi, limousine, postal delivery vehicle, ambulance or rental vehicle. If you do not transfer the remainder of the 7 year/ 70,000 mile Powertrain Limited Warranty coverage, together with the 7 year/100,000 mile Cummins Diesel 18

19 WHAT'S NOT COVERED Engine Limited Warranty, and pay the transfer fee, or if you are the 3rd (or subsequent) owner of the vehicle, your Cummins Diesel Engine Limited Warranty runs for 5 years or 100,000 miles on the odometer, whichever comes first. 3.8 Other Exclusions Your warranties don t cover the costs of repairing damage or conditions caused by any of the following: fire or accident; abuse or negligence; misuse for example, driving over curbs or overloading; tampering with the emission systems, or with a part that could affect the emission systems; use of used parts, even if they were originally supplied by DaimlerChrysler (however, authorized DaimlerChrysler or MOPAR remanufactured parts are covered); windshield or rear window damage from external objects; any changes made to your truck that don t comply with DaimlerChrysler Corporation specifications; or using any fluid that doesn't meet the minimum recommendations in your Owner's Manual. 19

20 WHAT'S NOT COVERED 3.9 Total Loss, Salvage, Junk, or Scrap Trucks Not Covered A truck has no warranty coverage of any kind if: the truck is declared to be a total loss by an insurance company; the truck is rebuilt after being declared to be a total loss by an insurance company; or the truck is issued a certificate of title indicating that it is designated as salvage, junk, rebuilt, scrap, or some similar word Restricted Warranty Your warranties can also be restricted by DaimlerChrysler. DaimlerChrysler may restrict the warranty on your truck if the truck is not properly maintained, or if the truck is abused or neglected, and the abuse or neglect interferes with the proper functioning of the truck. If the warranty is restricted, coverage may be denied or subject to approval by DaimlerChrysler before covered repairs are performed. DaimlerChrysler will deny warranty coverage without notice if it learns that a truck is ineligible for coverage for any of these reasons. 20

21 OTHER TERMS OF YOUR WARRANTIES 4. Other Terms of Your Warranties 4.1 Exchanged Parts May Be Used in Warranty Repairs In the interest of customer satisfaction, DaimlerChrysler Motors Company LLC ("DaimlerChrysler") may offer exchange service on some truck parts. This service is intended to reduce the amount of time your truck is not available for your use because of repairs. Parts used in exchange service may be new, remanufactured, reconditioned, or repaired, depending on the part involved. All exchange parts that might be used meet DaimlerChrysler Corporation standards, and have the same warranties as new parts. Examples of the kinds of parts that might be serviced in this way are: engine assemblies; transmission assemblies; instrument cluster assemblies; radios, tape and CD players; speedometers; and powertrain control modules. To help control suspected ozone-depleting agents, the EPA requires the capture, purification, and reuse of automotive air-conditioning refrigerant gases. As a result, a repair to the sealed portion of your airconditioning system may involve the installation of purified reclaimed refrigerant. 21

22 OTHER TERMS OF YOUR WARRANTIES 4.2 Pre-Delivery Service A defect in or damage to the mechanical, electrical, sheet-metal, paint, trim, and other components of your truck may have occurred at the factory or while it was being shipped to the dealer. Such a defect or damage is usually detected and corrected at the factory. In addition, dealers must inspect each truck before delivery. They repair any defects or damage detected before the truck is delivered to you. 4.4 Governing Law and Other Terms All of the warranties, except for the Federal Emissions and noise warranty and the California Emissions warranties, are made under Michigan law, and Michigan law will be used to interpret them. Punitive, exemplary or multiple damages may not be recovered unless applicable state or local law prohibits their disclaimer. No person, including DaimlerChrysler employees or dealers may modify or waive any part of these warranties. 4.3 Production Changes DaimlerChrysler Corporation, DaimlerChrysler and its dealers reserve the right to make changes in trucks built or sold by them at any time without incurring any obligation to make the same or similar changes on trucks previously built or sold. 22

23 EMISSION WARRANTIES REQUIRED BY LAW 5. Emission Warranties Required By Law 5.1 Federal Emission Warranty - Light Duty Truck A. Parts Covered for 2 Years or 24,000 Miles Federal law requires DaimlerChrysler Motors Company LLC ("DaimlerChrysler") to warrant the following emissions parts for 2 years or 24,000 miles, whichever occurs first. DaimlerChrysler covers all of these parts under the Basic Limited Warranty for 3 years or 36,000 miles, whichever occurs first. Air system controls; distributor and its components; electronic fuel injection system, including injector; evaporative-emission canister and controls; exhaust manifold; exhaust gas recirculation valve and control system; exhaust pipes (between exhaust manifold and catalyst); fuel cap and tank assembly, pump, and fuel lines; ignition coil and ignition module; intake manifold; on-board diagnostic-system components; oxygen sensors; positive crankcase-ventilation (PCV) valve or orifice; 23

24 EMISSION WARRANTIES REQUIRED BY LAW secondary ignition wires; spark plugs; throttle body; transmission-control module; vacuum hoses, clamps, and fittings, as well as tubing used for these components; vacuum, temperature, altitude, speed, timesensitive valves, sensors, and switches used in these components and systems. B. Parts Covered for 8 years or 80,000 miles If your truck has one of the following parts, this Federal Emission Warranty covers that part for a period of 8 years or 80,000 miles, whichever occurs first. These limits are counted from the time when your Basic Limited Warranty begins under 2.1(E). The covered parts are: catalytic converter; and powertrain control module. 24

25 EMISSION WARRANTIES REQUIRED BY LAW C. Additional Emission Warranties If your truck is equipped with a California Certified Emission Control System and is registered in California, Massachusetts, Maine or Vermont, the California Emission Warranty described in Section 5.4 also applies. 5.2 Emission Performance Warranty This warranty supplements the federal warranty under 5.1. It lasts for 2 years or 24,000 miles on the odometer, whichever occurs first. If your truck has one of the following parts, catalytic converter and powertrain control module, this Federal Emission Warranty covers that part for a period of 8 years or 80,000 miles, whichever occurs first. These limits are counted from the time when your Basic Limited Warranty begins under 2.1(E). The Emission Performance Warranty covers the cost of repairing or adjusting any components or parts that might be needed for your truck to pass Federal Emission Standards for a federally approved state or local emissions test, but only if: your truck has failed a federally approved state or local emissions test; your truck has been maintained and operated properly up until it fails such a test; and you face a real penalty for example, a fine or the loss of the use of your truck because the truck has failed the test. Section 6.3 explains how to get service under this warranty. 25

26 EMISSION WARRANTIES REQUIRED BY LAW 5.3 Federal Emission Warranty - Heavy Duty Truck A. Parts Covered for 5 Years or 50,000 Miles Heavy duty trucks are trucks over 10,000 GVW (designated by an "M" in the 4th position of the truck identification number); or any truck equipped with a heavy duty gasoline or diesel engine (designated by a "5, 6, 7 or W" in the 8th position of the truck identification number). Federal law requires DaimlerChrysler to warrant the following emissions parts for 5 years or 50,000 miles, whichever occurs first. Air system controls; catalytic converter; distributor and its components; electronic fuel injection system, including injector; evaporative-emission canister and controls; exhaust manifold; exhaust gas recirculation valve and control system; exhaust pipes (between exhaust manifold and catalyst); fuel cap and tank assembly, pump, and fuel lines; ignition coil and ignition module; intake manifold; on-board diagnostic-system components; oxygen sensors; positive crankcase-ventilation (PCV) valve or orifice; 26

27 EMISSION WARRANTIES REQUIRED BY LAW powertrain control module; secondary ignition wires; spark plugs; throttle body; transmission-control module; vacuum hoses, clamps, and fittings, as well as tubing used for these components; vacuum, temperature, altitude, speed, timesensitive valves, sensors, and switches used in these components and systems. B. Parts Covered for 5 Years or 100,000 Miles Diesel equipped heavy duty trucks, as described in 5.3 (A), have a separate diesel engine Emission Warranty which covers the following items for 5 years or 100,000 miles. These limits are counted from the time when your Basic Limited Warranty begins under 2.1 (E). The covered parts are: exhaust manifold fuel injection system injector intake manifold, and turbocharger. NOTE: The Performance Warranty 5.2 does not apply to heavy duty cycle engine equipped trucks. 27

28 EMISSION WARRANTIES REQUIRED BY LAW California Emission Warranty Light/Medium Duty Trucks Equipped With Gasoline Engines Your Warranty Rights and Obligations (Applies Only to Trucks Certified for Sale and Registered in the State of California) The California Air Resources Board is pleased to explain the emission control system warranty on your 2004 model truck. In California, new motor trucks must be designed, built and equipped to meet the State's stringent anti-smog standards. DaimlerChrysler Motors Company LLC ("DaimlerChrysler") must warrant the emission control system on your truck for the periods of time listed below provided there has been no abuse, neglect or improper maintenance of your truck. Your emission control system may include parts such as the fuel-injection system, the ignition system, catalytic converter, and powertrain control module. Also included may be hoses, belts, connectors and other emission-related assemblies. Where a warrantable condition exists, DaimlerChrysler will repair your truck at no cost to you, including diagnosis, parts and labor. MANUFACTURER'S WARRANTY COVERAGE For 3 years or 50,000 miles, whichever first occurs: 1. If your truck fails a Smog Check inspection, all necessary repairs and adjustments will be made by DaimlerChrysler to ensure that your truck passes the inspection. This is your emission control system PERFORMANCE WARRANTY.

29 EMISSION WARRANTIES REQUIRED BY LAW 2. If any emission-related part on your truck is defective, the part will be repaired or replaced by DaimlerChrysler. This is your short-term emission control system DEFECTS WARRANTY. For 7 years or 70,000 miles, whichever first occurs: 1. If an emission-related part listed in this warranty booklet specially noted with coverage for 7 years or 70,000 miles is defective, the part will be repaired or replaced by DaimlerChrysler. This is your long-term emission control system DEFECTS WARRANTY. 5.4 California Emission Warranty Contd. Owner's Warranty Responsibilities: -- As the truck owner, you are responsible for the performance of the required maintenance listed in your owner's manual. DaimlerChrysler recommends that you retain all receipts covering maintenance on your truck, but DaimlerChrysler cannot deny warranty solely for the lack of receipts or for your failure to ensure the performance of all scheduled maintenance. -- You are responsible for presenting your truck to a Chrysler, Dodge or Jeep dealer as soon as a problem exists. The warranty repairs should be completed in a reasonable amount of time, not to exceed 30 days. 29

30 EMISSION WARRANTIES REQUIRED BY LAW 5.4 California Emission Warranty Contd. -- As the truck owner, you should also be aware that DaimlerChrysler may deny your warranty coverage if your truck or a part has failed due to abuse, neglect, improper maintenance or unapproved modifications. If you have any questions regarding your warranty rights and responsibilities, you should contact the DaimlerChrysler National Customer Relations at (800) or the California Air Resources Board at PO Box 8001, El Monte, CA A. Parts and Performance Covered for 3 Years or 50,000 Miles, Whichever Occurs First California law requires DaimlerChrysler to warrant that if any emission-related part on your truck is defective, DaimlerChrysler will repair or replace the part. The repair or replacement will be made at no charge to you for diagnosis, parts or labor. Any other parts damaged by the failure of a defective part will also be repaired or replaced. In addition, if your truck fails a smog check inspection, DaimlerChrysler will make all necessary repairs and adjustments to ensure that your truck passes the inspection. Your emission control system may include parts such as the fuel injection system, ignition system, catalytic converter and powertrain control module. Also included may be hoses, belts, connectors and other emission-related assemblies. 30

31 EMISSION WARRANTIES REQUIRED BY LAW 5.4 California Emission Warranty Contd. B. Parts Covered for 7 Years or 70,000 Miles, Whichever Occurs First DaimlerChrysler also warrants that every part listed below if installed as original equipment is free from defects. These parts are: fuel pump module (on 34 gallon fuel tank only) - 3.7L, 4.7L, 5.7L fuel tank intake manifold - 4.7L C. Parts Covered for 8 Years or 80,000 Miles, Whichever Occurs First (See Federal Emission Warranty 5.1.B). catalytic converter powertrain control module D. Getting Service Under This Warranty Section 6.4 explains how to get service under this warranty. Where parts are scheduled for replacement as required maintenance, this warranty applies until the first scheduled maintenance point listed in the owner's manual. 31

32 EMISSION WARRANTIES REQUIRED BY LAW Diesel Engine Medium Duty Trucks Products Warranted This Emission Control System Warranty applies to Diesel Engine Medium Duty Trucks certified with the California Air Resources Board beginning with the 2004 model year, marketed by DaimlerChrysler, and registered in California for use in Medium Duty Vehicle applications. Your Warranty Rights and Obligations The California Air Resources Board and DaimlerChrysler Corporation, are pleased to explain the emission control system warranty on your 2004 truck. In California, new motor vehicles, must be designed, built, and equipped to meet the State's stringent anti-smog standards. DaimlerChrysler must warrant the emission control system on your truck for the periods of time listed below provided there has been no abuse, neglect or improper maintenance on your truck. Your emission control system may include parts such as the fuel injection system and engine electronic control module. Also included may be hoses, connectors and other emission-related assemblies. Where a warrantable condition exists, DaimlerChrysler will repair your truck at no cost to you including diagnosis, parts and labor. 32

33 EMISSION WARRANTIES REQUIRED BY LAW MANUFACTURER'S WARRANTY COVERAGE For 5 years or 100,000 miles, whichever first occurs: 1. If an emission-related part on your truck is defective, the part will be repaired or replaced by DaimlerChrysler. This is your SHORT-TERM EMISSION CONTROL SYSTEM DEFECTS WARRANTY. For 7 years or 70,000 miles, whichever first occurs: 1. Where a warrantable condition exists on a long-term emission-related part, DaimlerChrysler will repair your truck at no cost to you including diagnosis, parts and labor. This is your LONG-TERM EMISSION CONTROL SYSTEM DEFECTS WARRANTY. 5.4 California Emission Warranty Contd. OWNER'S WARRANTY RESPONSIBILITIES: As the truck owner, you are responsible for the performance of the required maintenance listed in your owner's manual. DaimlerChrysler recommends that you retain all receipts covering maintenance on your truck, but DaimlerChrysler cannot deny warranty solely for the lack of receipts or for your failure to substantiate the performance of all scheduled maintenance. You are responsible for presenting your truck to a Chrysler, Dodge or Jeep dealer as soon as a problem exists. The warranty repairs should be completed in a reasonable amount of time, not to exceed 30 days. As the truck owner, you should also be aware that DaimlerChrysler may deny you warranty coverage if your truck or a part has failed due to abuse, neglect, improper maintenance or unapproved modifications. 33

34 EMISSION WARRANTIES REQUIRED BY LAW 5.4 California Emission Warranty Contd. If you have any questions regarding your warranty rights, and responsibilities, you should contact the DaimlerChrysler National Customer Relations at (800) or the California Air Resources Board at PO Box 8001, El Monte, CA A warranted part which is scheduled for replacement as required maintenance is warranted up to the first scheduled replacement point. Prior to the expiration of the applicable warranty, Owner must give notice of any warranted emission control failure to an authorized Chrysler, Dodge or Jeep dealer and deliver the truck to such facility for repair. Owner is responsible for incidental costs such as: communication expenses, meals, lodging incurred by Owner or employee of Owner as a result of a Warrantable Condition. Owner is responsible for "downtime" expenses, cargo damage, fines, all applicable taxes, all business costs, and other losses resulting from a warrantable condition. Coverage LONG-TERM EMISSION-RELATED PARTS: Intake Manifold Turbocharger Charge Air Cooler Fuel System Oxidation Catalyst Fuel Pump Injectors Electronic Control Module SHORT-TERM EMISSION-RELATED PARTS: A warranted part is any part which can affect emissions. 34

35 EMISSION WARRANTIES REQUIRED BY LAW 5.4 California Emission Warranty Contd. Replacement Parts DaimlerChrysler recommends that any service parts used for maintenance, repair or replacement of emission control systems be new, genuine DaimlerChrysler / MOPAR or DaimlerChrysler / MOPAR approved rebuilt parts and assemblies, and that the truck be serviced by an authorized Chrysler, Dodge or Jeep dealer. The owner may elect to have maintenance, replacement or repair of the emission control parts performed by a facility other than an authorized Chrysler, Dodge or Jeep dealer and may elect to use parts other than new genuine DaimlerChrysler / MOPAR or DaimlerChrysler / MOPAR approved rebuilt parts and assemblies for such maintenance, replacement or repair; however, the cost of such service or parts and subsequent failures resulting from such service or parts will not be covered under this emission control system warranty, except for Emergency Repairs as described below. DaimlerChrysler Motors Company LLC's Responsibilities The warranty coverage begins when the truck is delivered to the ultimate purchaser. Repairs and service will be performed by any authorized Chrysler, Dodge or Jeep dealer using new, genuine DaimlerChrysler / MOPAR or DaimlerChrysler / MOPAR approved rebuilt parts and assemblies. DaimlerChrysler will repair any of the emission control parts found by DaimlerChrysler to be defective without charge for parts or labor (including diagnosis which results in determination that there has been a failure of a warranted emission control part). 35

36 EMISSION WARRANTIES REQUIRED BY LAW 5.4 California Emission Warranty Contd. Emergency Repairs In the case of an emergency where an authorized Chrysler, Dodge or Jeep dealer is not available, repairs may be performed by any available repair location or by any individual using any replacement parts. A part not being available within 30 days or a repair not being complete within 30 days constitutes an emergency. DaimlerChrysler will reimburse the owner for expenses (including diagnosis), not to exceed the manufacturer's suggested retail price for all warranted parts replaced and labor charges based on the manufacturer's recommended time allowance for the warranty repair and the geographically appropriate hourly labor rate. Replaced parts and paid invoices must be presented to the DaimlerChrysler Customer Center as a condition of reimbursement for emergency repairs not performed by a Chrysler, Dodge or Jeep authorized dealer. Warranty Limitations DaimlerChrysler is not responsible for failures or damage resulting from what DaimlerChrysler determines to be abuse or neglect, including, but not limited to: operation without adequate coolants or lubricants; overfueling; overspeeding; lack of maintenance of cooling, lubricating or intake systems; improper storage, starting, warm-up, run-in or shut down practices; unauthorized modifications to the engine. DaimlerChrysler is also not responsible for failures caused by incorrect oil or fuel or by water, dirt or other contaminants in the fuel or oil. DaimlerChrysler is not responsible for failures resulting from improper repair or the use of parts which are not genuine DaimlerChrysler / MOPAR or DaimlerChrysler / MOPAR approved parts. 36

37 EMISSION WARRANTIES REQUIRED BY LAW 5.4 California Emission Warranty Contd. DaimlerChrysler is not responsible for the material and labor costs of emission control parts and assemblies replaced during Scheduled Maintenance of the truck as specified in the Owner's Manual. THIS WARRANTY, TOGETHER WITH THE EXPRESS COMMERCIAL WARRANTIES ARE THE SOLE AND EXCLUSIVE WARRANTIES MADE BY DAIMLERCHRYSLER. THERE ARE NO OTHER WARRANTIES, EXPRESS OR IMPLIED, OR OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. 5.5 Noise Emission Warranty - Heavy Duty Truck A. Description of Coverage DaimlerChrysler warrants that this vehicle as manufactured by DaimlerChrysler Corporation, was designed, built and equipped to conform to all applicable U.S. EPA Noise Control Regulations at the time it left DaimlerChrysler Corporation's control. This warranty covers this vehicle as designed, built and equipped by DaimlerChrysler Corporation, and is not limited to any particular part, component or system of the vehicle manufactured by DaimlerChrysler Corporation. Defects in design, assembly or in any part, component or system of the vehicle as manufactured by DaimlerChrysler Corporation, which, at the time it 37

38 EMISSION WARRANTIES REQUIRED BY LAW left DaimlerChrysler Corporation's control, caused noise emissions to exceed Federal standards, are covered by this warranty for the life of the vehicle. B. Products Warranted All vehicles built over 10,000 lbs. Gross Vehicle Weight Rating and manufactured for sale and use in the United States are required to comply with the Federal Government's Exterior Noise Regulations. These vehicles can be identified by the Noise Emission Control Label located in the operator's compartment. 38

39 EMISSION WARRANTIES REQUIRED BY LAW C. Tampering with Noise Control System Prohibited Federal law prohibits the following acts or the causing thereof: the removal or rendering inoperative by any person, other than for purposes of maintenance, repair, or replacement, of any device or element of design incorporated into any new vehicle for the purpose of noise control prior to its sale or delivery to the ultimate purchaser or while it is in use; or the use of the vehicle after such device or element of design has been removed or rendered inoperative by any person. Among those acts presumed to constitute tampering are the acts listed below: AIR CLEANER removal of the air cleaner; inverting the air cleaner lid; or removal of the air ducting. AIR INJECTION SYSTEM removal of the air pump filter canister or canister lid; removal of the air pump filter elements from the canister; or disconnection, removal, or plugging of any hose or tube of the air injection system. 39

40 EMISSION WARRANTIES REQUIRED BY LAW EXHAUST SYSTEM removal or rendering inoperative exhaust system components including the muffler or tailpipe. ENGINE COOLING SYSTEM removal or rendering inoperative the fan clutch; or removal of the fan shroud. 40

41 HOW TO GET WARRANTY SERVICE 6. How to Get Warranty Service 6.1 Where to Take Your Truck A. In the United States (We Include U.S. Possessions and Territories as Part of the United States for Warranty Purposes): Warranty service must be done by an authorized Chrysler, Dodge or Jeep dealer. We strongly recommend that you take your truck to your Selling Dealer. They know you and your truck best, and are most concerned that you get prompt and high quality service. If you move within the United States, warranty service may be requested from any authorized Chrysler, Dodge or Jeep dealer. B. In Canada and Mexico: If you are traveling temporarily in Canada or Mexico, and your truck remains registered in the United States, your DaimlerChrysler warranty still applies. Service may be requested at any authorized Chrysler, Dodge or Jeep dealership. C. In a Foreign Country Outside of North America: If you are traveling temporarily outside of North America, and your truck remains registered in the United States: You should take your truck to an authorized Chrysler, Dodge or Jeep dealer. They should give you the same warranty service you receive in the United States. 41

42 HOW TO GET WARRANTY SERVICE If the authorized dealership charges you for repairs which you feel should be covered under your warranty, please get a detailed receipt for the work done. Make sure that this receipt lists all warranty repairs and parts that were involved. (This receipt will be similar to the one used by the dealer who normally services your truck.) When your truck returns to the United States, contact the DaimlerChrysler Customer Assistance Center (section 7.2) for reimbursement consideration. You will normally need to provide a copy of the receipt, your truck registration and any other relevant documents. Reimbursement will not be considered if the truck does not return to the United States. D. If You Move: If you move to another country, be sure to contact the DaimlerChrysler Customer Assistance Center (section 7.2) and the customs department of the destination country before you move. Vehicle importation rules vary considerably from country to country. You may be required to present documentation of your move to DaimlerChrysler in order to continue your warranty coverage. You may also be required to obtain documentation from DaimlerChrysler in order to register your truck in your new country. 42

43 HOW TO GET WARRANTY SERVICE E. Notice: If your truck is registered outside of the United States, and you have not followed the procedure set out above, your truck will no longer be eligible for warranty coverage of any kind. (Trucks registered to United States government officials or military personnel on assignment outside of the U.S. will continue to be covered.) 43

44 HOW TO GET WARRANTY SERVICE 6.2 Emergency Warranty Repairs If you have an emergency and have to get a warranty repair made by someone other than an authorized Chrysler, Dodge or Jeep dealer, follow the reimbursement procedure in 6.1(C). 6.3 Getting Service Under the Federal Emission Performance Warranties A. What to Do If your truck has failed an emissions test described in 5.2: Take it to an authorized Chrysler, Dodge or Jeep dealer as soon as possible. Give the service representative the printout showing that your truck failed the test. If possible, bring all service receipts, maintenance logs, and records proving that your truck has been properly maintained, since you may be required to show them. B. Further Steps You Can Take, and How to Get More Information If you think your dealer has wrongly denied you emission-warranty coverage, follow the steps described in 7.1. DaimlerChrysler will reply to you in writing within 30 days after receiving your complaint (or within the time limit required by local or state law). If the owner is not notified within 30 days that a performance warranty claim is denied, the manufacturer must repair the truck free of charge. 44