CIRRUS AIRPLANE MAINTENANCE MANUAL MODELS SR22 AND SR22T CHAPTER 28-00: FUEL GENERAL. Fuel 28-00: FUEL. 1. General

Size: px
Start display at page:

Download "CIRRUS AIRPLANE MAINTENANCE MANUAL MODELS SR22 AND SR22T CHAPTER 28-00: FUEL GENERAL. Fuel 28-00: FUEL. 1. General"

Transcription

1 CIRRUS AIRPLANE MAINTENANCE MANUAL Fuel CHAPTER 28-00: GENERAL 28-00: 1. General This chapter contains information on the storage, distribution, and indicating components of the fuel system. The engine is supplied with fuel drawn out of the left or right integral fuel tank (depending on the fuel selector valve position). Fuel flows through a flapper assembly (SR22 Serials: swing check valve), integral collector tank, selector valve, electric auxiliary fuel pump, gascolator, engine-driven fuel pump, fuel flow sensor, throttle body, fuel injection manifold, and is then distributed to the fuel nozzles. All fuel line fittings installed in the cabin area of the fuselage are enclosed in a vented and drained enclosure. Fuel system layout: (See Figure ) Fuel system schematic: (See Figure ) (See Figure ) For maintenance practices pertinent to the engine-driven fuel pump, fuel flow sensor, and fuel nozzles refer to Chapter 73, Engine Fuel Systems. (Refer to 73-00) 1

2 CHAPTER 28-00: 2. Troubleshooting CIRRUS AIRPLANE MAINTENANCE MANUAL Trouble Probable Cause Remedy Filler cap leaks. Filler cap improperly installed. Install filler cap properly. Seal improperly installed. Deteriorated seal. Improperly tightened cap fuel nuts. Replace fuel cap seal. Replace fuel cap seal. Tighten or loosen fuel cap nuts as required. Fuel connector(s) leak. Loose connector(s). Inspect and tighten connector(s). Defective seals. Defective thread. Replace seals. Replace threaded component. Insufficient fuel flow. Restricted fuel filter/screen. Clean filter or screen. Normal starting procedures result in difficult starting. No fuel flow to engine driven fuel pump. Defective mechanical fuel pump. Defective fuel pressure sensor or insufficient voltage supplied. Cracked fuel line. Faulty electric fuel pump. Fuel selector valve not in the on position. Fuel tanks empty. Fuel line disconnected or broken. Fuel tank screen plugged. Defective fuel selector valve. Plugged gascolator. Fuel line plugged. Frozen fuel line. Replace pump. Replace pressure sensor. Find voltage problem. Replace line. Replace pump. Turn selector valve on. Fill tanks with approved fuel. Repair or replace line. Clean or replace screen. Replace selector valve. Clean or replace gascolator. Remove obstruction. Thaw and drain complete fuel system. 2

3 CIRRUS AIRPLANE MAINTENANCE MANUAL CHAPTER 28-00: Trouble Probable Cause Remedy Fuel starvation after start up. Insufficient fuel flow. See remedies from above. No fuel output indicated from fuel flow gage when auxiliary pump is operated. NOTE: If the auxiliary pump is turned on when the engine is off, the fuel flow gage will show a momentary fuel flow. Fuel quantity indicator indicates inaccurate fuel level. Malfunction of engine-driven fuel pump or fuel system. Fuel vents plugged. Water in fuel. Mixture control set in lean position and throttle lever is pulled back. Fuel line disconnected before fuel flow sensor. Defective fuel pump switch. Open or defective circuit breaker. Loose connections or open circuit. Defective electric fuel pump. Defective engine-driven fuel pump bypass or defective fuel system. Defective fuel sensor. Incorrectly adjusted fuel sensor. Faulty fuel system wiring. Replace pump. Remove obstruction. Remove water. Adjust mixture control richer and move throttle lever forward. Check all fuel lines and connect. Replace switch. Reset or replace circuit breaker. Tighten connections/repair wire. Replace pump. Replace pump/troubleshoot fuel system. Replace sensor. Adjust sensor. Repair/Replace wire(s). Defective engine airframe unit. Replace GEA 71. (Refer to 77-40) 3

4 CHAPTER 28-00: CIRRUS AIRPLANE MAINTENANCE MANUAL Trouble Probable Cause Remedy No fuel quantity indication. Fuel tanks empty. Fill with approved fuel. QTY circuit breaker open or defective. Loose connections or open circuit. Reset or replace circuit breaker. Tighten connections/repair wire. Incorrect power to fuel level indicator in console. Resistance to fuel level indicator from fuel level sending units are unstable and/or greater than 70 ohms (depending on fuel level). Disconnect airplane harness from indicator and verify voltage between pins 1 & 9 measures between ~24-28v. Check airplane power source and resolve. Disconnect airplane harness from indicator and verify resistance of RH wing (pins 4 & 9) and LH wing (pins 2 & 9) is stable and measures between 0-70 ohms (depending on fuel level). Check continuity in airplane wire harness between indicator and sending units. Perform Adjustment/Test - Fuel Quantity Indication. (Refer to 28-40) Defective fuel sensor. Defective fuel quantity indicator. Incorrectly adjusted fuel sensor. Faulty fuel system wiring. Replace sensor. Replace indicator. Adjust sensor. Repair/Replace wire(s). Defective engine airframe unit. Replace GEA 71. (Refer to 77-40) 4

5 CIRRUS AIRPLANE MAINTENANCE MANUAL CHAPTER 28-00: Trouble Probable Cause Remedy Fluctuating fuel level indications. Incorrect power to fuel level indicator in console. Disconnect airplane harness from indicator and verify voltage between pins 1 & 9 measures between ~24-28v. Resistance to fuel level indicator from fuel level sending units are unstable and/or greater than 70 ohms (depending on fuel level). Check airplane power source and resolve. Disconnect airplane harness from console indicator and verify resistance of RH wing (pins 4 & 9) and LH wing (pins 2 & 9) is stable and measures between 0-70 ohms (depending on fuel level). Check continuity in airplane wire harness between indicator and sending units. Perform Adjustment/Test - Fuel Quantity Indication. (Refer to 28-40) Fluctuating fuel flow indications. Fuel flow indicator/transducer. Replace fuel flow indicator/transducer. Fuel leaks from electric fuel pump drain manifold fitting. Vapor in fuel lines. Faulty internal fuel pump seal. Turn on auxiliary fuel pump. Replace electric fuel pump. 5

6 CHAPTER 28-00: CIRRUS AIRPLANE MAINTENANCE MANUAL Figure : Fuel System LEGEND 1. Fuel System Vent, NACA (Underside of Wing) 2. Fuel Tank 3. Fuel Tank Strainers 4. Collector Tank 5. Selector Valve 6. Fuel Gage 7. Engine Driven Fuel Pump 8. Gascolator 9. Electric Boost Pump SR22_MM28_4490 6

7 CIRRUS AIRPLANE MAINTENANCE MANUAL Figure : Fuel System Schematic - SR22 Serials VENT FILLER ANNUNCIATOR MFD INDICATION FILLER CHAPTER 28-00: VENT L. WING TANK R. WING TANK L. WING COLLECTOR R. WING COLLECTOR CHECK CHECK FLAPPER SELECTOR FLAPPER DRAIN (5 PLACES) FIREWALL SELECTOR OPERATIO N ELECTRIC AUXILIARY PUMP RELAY BOOST PUMP RIGHT RETURN FEED ENGINE DRIVEN PUMP MIXTURE CNTL. GASCOLATOR PRIME OIL PRESSURE SENSOR (LOW PRESSURE) RETURN FEED LEFT ENGINE AIRFRAME UNIT OFF THROTTLE METERING NOTE In Prime mode, relay allows high-speed pump operation until 10 psi oil pressure is reached then drops to low-speed operation. PRESSURE SWITCH INJECTOR MANIFOLD FLOW INDICATOR SR22_MM28_4491 7

8 CHAPTER 28-00: CIRRUS AIRPLANE MAINTENANCE MANUAL Figure : Fuel System Schematic - SR22T Serials VENT FILLER ANNUNCIATOR MFD INDICATION FILLER VENT L. WING TANK R. WING TANK L. WING COLLECTOR R. WING COLLECTOR FLAPPER SELECTOR FLAPPER DRAIN (5 PLACES) FIREWALL SELECTOR OPERATIO N ELECTRIC AUXILIARY PUMP RELAY BOOST PUMP RIGHT RETURN FEED ENGINE DRIVEN PUMP MIXTURE CNTL. GASCOLATOR HIGH BOOST/ PRIME ENGINE SPEED SENSOR (LOW RPM) RETURN FEED LEFT OFF ENGINE AIRFRAME UNIT MAP SENSOR (HIGH in Hg) NOTE In HIGH BOOST/PRIME mode, relay allows fuel pump operation only when manifold pressure is greater than 24 in Hg or, - to facilitate engine starting - when engine speed is less than 500 RPM. THROTTLE METERING PRESSURE SWITCH INJECTOR MANIFOLD FLOW INDICATOR SR22_MM28_4492 8

CIRRUS AIRPLANE MAINTENANCE MANUAL

CIRRUS AIRPLANE MAINTENANCE MANUAL 1. GENERAL This chapter contains information on the storage, distribution, and indicating components of the fuel system. The engine is supplied with fuel drawn out of the left or right integral fuel tank

More information

C I R R U S DISTRIBUTION DESCRIPTION

C I R R U S DISTRIBUTION DESCRIPTION MODELS SR AND SRT DISTRIBUTION. DESCRIPTION This section contains information on the distribution system. The fuel distribution system consists of electric and mechanical (engine-driven) fuel pumps, fuel

More information

C I R R U S CONTROLLING DESCRIPTION

C I R R U S CONTROLLING DESCRIPTION CONTROLLING 1. DESCRIPTION Serials 22-0002 & subs: An electric two-speed fuel pump provides boost (low speed) and prime (high speed) for the engine. A console mounted rocker switch located on the center

More information

CIRRUS AIRPLANE MAINTENANCE MANUAL

CIRRUS AIRPLANE MAINTENANCE MANUAL POWER PLANT 1. GENERAL This chapter describes maintenance practices for the airplane systems which provide the means to induce and convert fuel-air mixture into power such as the engine, baffling, cowling,

More information

INTEGRATED ENGINE INSTRUMENT SYSTEMS

INTEGRATED ENGINE INSTRUMENT SYSTEMS All INTEGRATED ENGINE INSTRUMENT SYSTEMS. DESCRIPTION This section describes that portion of the engine indicating system which is used to analyze engine performance, temperature, and condition. Serials

More information

CIRRUS AIRPLANE MAINTENANCE MANUAL

CIRRUS AIRPLANE MAINTENANCE MANUAL ANALYZERS - ENGINE MONITORING. DESCRIPTION This section describes that portion of the engine indicating system which is used to analyze engine performance, temperature, and condition. Serials 00 thru 8

More information

CIRRUS AIRPLANE MAINTENANCE MANUAL

CIRRUS AIRPLANE MAINTENANCE MANUAL All INDICATING. DESCRIPTION A. Fuel Quantity Serials 005 thru 885: A fuel quantity gage is installed in the center console directly forward of the fuel selector valve. The fuel quantity gage indicates

More information

Indicating. 1. General. A. Fuel Quantity. B. Fuel Flow

Indicating. 1. General. A. Fuel Quantity. B. Fuel Flow Indicating GENERAL 28-40: INDICATING. General A. Fuel Quantity A dual reading fuel quantity indicator is displayed in the Fuel Qty block of the ENGINE page along calibrated vertical bars. The fuel quantity

More information

Attitude And Direction

Attitude And Direction CIRRUS AIRPLANE MAINTENANCE MANUAL Attitude And Direction CHAPTER 34-20: ATTITUDE AND DIRECTION GENERAL 34-20: ATTITUDE AND DIRECTION 1. General This section contains information pertaining to those portions

More information

CIRRUS AIRPLANE MAINTENANCE MANUAL

CIRRUS AIRPLANE MAINTENANCE MANUAL PROPELLER 1. GENERAL The airplane employs a 3 blade, constant speed, non-feathering propeller. The blades (composite or aluminum) are mounted in an aluminum hub which contains the pitch changing mechanism

More information

CIRRUS AIRPLANE MAINTENANCE MANUAL

CIRRUS AIRPLANE MAINTENANCE MANUAL INDICATING 1. DESCRIPTION This section describes that portion of the oil system which is used to indicate the quantity, temperature, and pressure of the oil. Components included are the oil filler cap/dipstick,

More information

DC3Training.com N28AA DC-3 Pilot s Handbook

DC3Training.com N28AA DC-3 Pilot s Handbook SECTION 9 FUEL SYSTEM Index General page 2 Operation page 5 Limitations page 6 Troubleshooting page 6 5/15/2012 crew@dc3training.com 1 GENERAL A. Fuel Tanks The dual fuel system has a total capacity of

More information

Trouble Shooting Guide EWA, 3-phase (D2422)

Trouble Shooting Guide EWA, 3-phase (D2422) Trouble Shooting Guide EWA, 3-phase (D2422) Trouble Shooting Guide Problem Possible Cause Possible Remedy Unit does not start Breaker tripped, no power to unit Loose wire Defective contactor or coil Close

More information

CIRRUS AIRPLANE MAINTENANCE MANUAL

CIRRUS AIRPLANE MAINTENANCE MANUAL PASSENGER COMPARTMENT 1. DESCRIPTION This section covers the passenger compartment lighting. A. Passenger Eyeball Lights Individual eyeball-type reading lights are installed in the headliner above each

More information

C I R R U S PROPELLER GENERAL

C I R R U S PROPELLER GENERAL PROPELLER 1. GENERAL The airplane employs a 3 blade, constant speed, non-feathering propeller. The blades (composite or aluminum) are mounted in an aluminum hub which contains the pitch changing mechanism

More information

CIRRUS AIRPLANE MAINTENANCE MANUAL

CIRRUS AIRPLANE MAINTENANCE MANUAL STORAGE 1. DESCRIPTION A. Fuel Storage System - Serials 1005 thru 1885 The fuel storage system consists primarily of a vented integral 30.3-gallon (114.5-liters) capacity fuel tank in each wing, a fuel

More information

CIRRUS AMM TEMPORARY REVISION

CIRRUS AMM TEMPORARY REVISION CIRRUS AMM TEMPORARY REVISION MODEL SF50 SF50 AMM Temporary Revision --01 Brakes Affected Manuals: SF50 Airplane Maintenance Manual (18-001, Revision 1) Serial Numbers: SF50 Serials 0005 & subs Filing

More information

Storage. 1. General. A. Fuel Storage System

Storage. 1. General. A. Fuel Storage System CIRRUS AIRPLANE MAINTENANCE MANUAL Storage CHAPTER 28-10: STORAGE GENERAL 28-10: STORAGE 1. General A. Fuel Storage System The fuel storage system consists primarily of a vented integral 47.5-gallon (180-liters)

More information

Operating and Installation Instructions

Operating and Installation Instructions Model Number 40401-c (-sp) Electronic Fuel Pump Operating and Installation Instructions This Product is Patent Pending. Application available upon request CAUTION! This product is to be installed only

More information

A. Stall Warning System - Serials w/o Ice Protection

A. Stall Warning System - Serials w/o Ice Protection Stall Warning System GENERAL 27-31: STALL WARNING SYSTEM 1. General A. Stall Warning System - Serials w/o Ice Protection The airplane uses an electro-pneumatic stall warning system. As the angle of attack

More information

Flaps System. 1. General

Flaps System. 1. General CIRRUS AIRPLANE MAINTENANCE MANUAL Flaps System CHAPTER 27-50: FLAPS SYSTEM GENERAL 27-50: FLAPS SYSTEM 1. General This section describes that portion of the flight control system which controls the position

More information

STALL WARNING SYSTEM 1. DESCRIPTION A.

STALL WARNING SYSTEM 1. DESCRIPTION A. STALL WARNING SYSTEM 1. DESCRIPTION A. Stall Warning System - Serials w/o Perspective Avionics The airplane uses an electro-pneumatic stall warning system. As the angle of attack increases and the airplane

More information

CIRRUS AIRPLANE MAINTENANCE MANUAL

CIRRUS AIRPLANE MAINTENANCE MANUAL MODEL SR0 FLIGHT ENVIRONMENTAL SYSTEMS. DESCRIPTION This section covers that portion of the system which senses environmental conditions and uses the data to influence navigation of the airplane. This

More information

DESCRIPTION AND OPERATION FUEL SYSTEM

DESCRIPTION AND OPERATION FUEL SYSTEM 2.14. The fuel system total capacity is 1597 LTS (421.9 U.S. Gallons) and the total usable fuel capacity is 1583 LTS (418.2 U.S. Gallons). Each engine is fed by its own fuel system consisting of four interconnected

More information

Trouble Shooting Guide for WS1 - WS2 Control Valves

Trouble Shooting Guide for WS1 - WS2 Control Valves Trouble Shooting Guide for WS1 - WS2 Control Valves Page 2 Trouble Shooting Guide for WS1 - WS2 Control Valves 1. No Display on Troubleshooting TC control valves do not have meters so shaded ares are not

More information

Yaw Control and Trim. 1. General. A. Yaw Control System. B. Yaw Trim System

Yaw Control and Trim. 1. General. A. Yaw Control System. B. Yaw Trim System CIRRUS AIRPLANE MAINTENANCE MANUAL MODELS SR AND SRT Yaw Control and Trim CHAPTER 7-0: YAW CONTROL AND TRIM GENERAL 7-0: YAW CONTROL AND TRIM. General This section describes that portion of the flight

More information

CIRRUS AIRPLANE MAINTENANCE MANUAL

CIRRUS AIRPLANE MAINTENANCE MANUAL MODEL SR FLIGHT ENVIRONMENTAL SYSTEMS. DESCRIPTION This section covers that portion of the system which senses environmental conditions and uses the data to influence navigation of the airplane. This includes

More information

CIRRUS AIRPLANE MAINTENANCE MANUAL

CIRRUS AIRPLANE MAINTENANCE MANUAL ELECTRICAL LOAD DISTRIBUTION. DESCRIPTION The power distribution system for this airplane consists of the main distribution bus and the essential distribution bus in the MCU along with the associated buses

More information

Service Instruction ENGINE COMPONENTS, INC.

Service Instruction ENGINE COMPONENTS, INC. Title: Service Instruction S.I. No.: 89-5-1 Page: 1 of 5 Issued: 05/05/89 Revision: 1 (09/01/01) Technical Portions of FAA DER Approved. FAILURE OF ENGINE TO START 27 points 1. Lack of fuel 2. Ignition

More information

CIRRUS AIRPLANE MAINTENANCE MANUAL

CIRRUS AIRPLANE MAINTENANCE MANUAL STALL WARNING SYSTEM 1. DESCRIPTION A. Stall Warning System - Serials 05 thru 2015, 2016 & subs w/o Perspective Avionics The airplane uses an electro-pneumatic stall warning system. As the angle of attack

More information

ELECTRONIC FUEL INJECTION

ELECTRONIC FUEL INJECTION Table of Contents ELECTRONIC FUEL INJECTION Section 3B - Troubleshooting and Diagnostics TROUBLESHOOTING AND DIAGNOSTICS Specifications........................... 3B-1 Special Tools...........................

More information

SERVICE BULLETIN REFERENCES 1983

SERVICE BULLETIN REFERENCES 1983 J a I) SERVICE BULLETIN REFERENCES 1983 19.35 TROUBLE SHOOTING Engine Won t Start or Hard Starting Possible Cause ALL MODELS No fuel in tank. Fuel valve off. Insufficient or excessive priming. Spark plug

More information

Flight Environmental Systems

Flight Environmental Systems CIRRUS AIRPLANE MAINTENANCE MANUAL Flight Environmental Systems CHAPTER 34-0: FLIGHT ENVIRONMENTAL SYSTEMS GENERAL 34-0: FLIGHT ENVIRONMENTAL SYSTEMS. General This section covers that portion of the system

More information

Fuel Metering System Component Description

Fuel Metering System Component Description 1999 Chevrolet/Geo Tahoe - 4WD Fuel Metering System Component Description Purpose The function of the fuel metering system is to deliver the correct amount of fuel to the engine under all operating conditions.

More information

Table of Contents Illustrations

Table of Contents Illustrations Principals of Operation Inspection & Troubleshooting Principles of Operation Inspection & Troubleshooting Form No. F 1031 Section 1000 Issue Date 09/19/94 Rev. Date 02/07/07 Table of Contents Illustrations

More information

13. FUEL SYSTEM/CARBURETOR/

13. FUEL SYSTEM/CARBURETOR/ 13 FUEL SYSTEM/CARBURETOR/FUEL PUMP FUEL SYSTEM --------------------------------------------------------- 13-1 SCHEMATIC DRAWING ---------------------------------------------- 13-2 OPERATION OF CARBURETOR

More information

k. Components not properly adjusted. Refer to machine technical manual for proper adjustment of components.

k. Components not properly adjusted. Refer to machine technical manual for proper adjustment of components. General Troubleshooting Charts General Troubleshooting Charts Use the charts on the following pages to help in listing all the possible causes of trouble when you begin diagnosing and testing of a machine.

More information

INSTALLATION AND DETAIL SPECIFICATIONS FOR THE SILVER HAWK TM EX-5VA1 TM SERVO KIT

INSTALLATION AND DETAIL SPECIFICATIONS FOR THE SILVER HAWK TM EX-5VA1 TM SERVO KIT INSTALLATION AND DETAIL SPECIFICATIONS FOR THE SILVER HAWK TM EX-5VA1 TM SERVO KIT 25-020_C.DOC 2-23-2015 Precision Airmotive LLC fuel systems are produced using the highest quality materials and components.

More information

CIRRUS AIRPLANE MAINTENANCE MANUAL

CIRRUS AIRPLANE MAINTENANCE MANUAL MODEL SR0 INSTRUMENT AND CONTROL PANEL. DESCRIPTION Serials 00 thru 336, 337 thru w/o PFD: The airplane uses standard flight instruments arranged in the basic-six pattern. The airspeed indicator, attitude

More information

Fuel System Diagnosis

Fuel System Diagnosis Page 1 of 6 2004 Chevrolet Chevy K Silverado - 4WD Sierra, Silverado (VIN C/K) Service Manual Engine Engine Controls - 6.6L (LLY) Diagnostic Information and Procedures Document ID: 1460257 Fuel System

More information

Oregon Fuel Injection

Oregon Fuel Injection Cummins PT Fuel Pump Diagnostic No Start, with no smoke 1. This could be caused by the fuel pump not turning or a seized gear pump. Remove the fuel supply hose and the fuel inlet fitting from the gear

More information

Tornado Alley Turbo, Inc.

Tornado Alley Turbo, Inc. MAINTENANCE MANUAL with TROUBLE SHOOTING MANUAL For the TURBONORMALIZED CIRRUS DESIGN SR22 Series Airplane L/H INTERCOOLER UPPER DECK REFERENCE FUEL MANIFOLD VALVE SCAVENGE PUMP MP CONTROLLER PRESSURE

More information

CIRRUS AIRPLANE MAINTENANCE MANUAL

CIRRUS AIRPLANE MAINTENANCE MANUAL ELEVATOR AND PITCH TRIM SYSTEM 1. DESCRIPTION This section describes that portion of the flight control system which controls the position and movement of the elevator. Included are; elevator system torque

More information

CIRRUS AIRPLANE MAINTENANCE MANUAL

CIRRUS AIRPLANE MAINTENANCE MANUAL MODEL SR0 YAW CONTROL AND TRIM. GENERAL This section describes that portion of the flight control system which controls the position and movement of the rudder. Included are; rudder system rigging, rudder

More information

Fuel Injection System

Fuel Injection System 7. Fuel Injection System XCITING 400i Fuel Injection System This chapter covers the location and servicing of the fuel system components for the KYMCO XCITING 400i. Air box... 7-2~7-5 Fuel Tank... 7-6~7-10

More information

33-10 FLIGHT COMPARTMENT

33-10 FLIGHT COMPARTMENT FLIGHT COMPARTMENT. DESCRIPTION Flight compartment interior lighting consists of instrument lights, glareshield flood lights, overhead dome light, individual reading lights, pilot control lights, CAPS

More information

CIRRUS AIRPLANE MAINTENANCE MANUAL

CIRRUS AIRPLANE MAINTENANCE MANUAL POWER CONTROL. DESCRIPTION This section describes those components which furnish a means of controlling engine power. Engine controls for the airplane include the following: control quadrant, throttle

More information

53-40 ATTACH FITTINGS

53-40 ATTACH FITTINGS ATTACH FITTINGS. DESCRIPTION Attach fittings are provided for attachment of the seats (Refer to -0), baggage straps (Refer to -0), rear seat harnesses (Refer to -0), cargo net straps (Refer to -0), cabin

More information

Maintenance Manual and Illustrated Parts Catalogue Extra EA Chapter 37 Vacuum. Page Date: 8. December Page 1

Maintenance Manual and Illustrated Parts Catalogue Extra EA Chapter 37 Vacuum. Page Date: 8. December Page 1 Chapter 37 Page Date: 8. December 1999 37 Page 1 Table of Contents 37-00-00 GENERAL...3 Description...3 System Surview...4 System Components...5 Troubleshooting...6 37-10-00 DISTRIBUTION...8 37-10-01 Pump...8

More information

SR22 Airplane Flight Manual (AFM) Temporary Change

SR22 Airplane Flight Manual (AFM) Temporary Change Cirrus Design TPOH Airplane Flight Manual (AFM) Temporary Change Information in this Temporary Change adds to, supersedes, or deletes information in the basic Pilot s Operating Handbook. Affected Publications:

More information

26 - COOLING SYSTEM CONTENTS ENGINE COOLING - DESCRIPTION... 3 ENGINE COOLING - OPERATION... 9 COOLING SYSTEM FAULTS... 1

26 - COOLING SYSTEM CONTENTS ENGINE COOLING - DESCRIPTION... 3 ENGINE COOLING - OPERATION... 9 COOLING SYSTEM FAULTS... 1 26 - COOLING SYSTEM CONTENTS Page LAND ROVER V8 DESCRIPTION AND OPERATION ENGINE COOLING - DESCRIPTION... 3 ENGINE COOLING - OPERATION... 9 FAULT DIAGNOSIS COOLING SYSTEM FAULTS... 1 REPAIR COOLANT - DRAIN

More information

CIRRUS AIRPLANE MAINTENANCE MANUAL

CIRRUS AIRPLANE MAINTENANCE MANUAL NOISE SUPPRESSOR 1. DESCRIPTION Noise suppression is accomplished through use of a heat exchanger (Serials 0002 thru 019) or a heat exchanger and muffler (Serials 020 & subs) connected to the exhaust header

More information

Dash8 - Q400 - Pneumatics

Dash8 - Q400 - Pneumatics 12.19.1 Introduction The Auxiliary Power Unit (APU) replaces the standard composite tailcone with a titanium tailcone and firewall. The APU is accessed by two clamshell type doors on the bottom of the

More information

DTC P1431 Fuel Level Sensor 2 Performance

DTC P1431 Fuel Level Sensor 2 Performance Page 1 of 8 Document ID# 610929 2000 Chevrolet Corvette Feedback Print DTC P1431 Fuel Level Sensor 2 Performance Circuit Description The right fuel level sensor 2, mounted in the rear

More information

GROUP 13C 13C-1 CONTENTS GENERAL DESCRIPTION... 13C-2 FUEL TANK... 13C-11 FUEL SUPPLY DIAGNOSIS... 13C-3 SPECIAL TOOLS... 13C-8

GROUP 13C 13C-1 CONTENTS GENERAL DESCRIPTION... 13C-2 FUEL TANK... 13C-11 FUEL SUPPLY DIAGNOSIS... 13C-3 SPECIAL TOOLS... 13C-8 13C-1 GROUP 13C CONTENTS GENERAL DESCRIPTION......... 13C-2 DIAGNOSIS....... 13C-3 INTRODUCTION TO DIAGNOSIS........................ 13C-3 TROUBOLESHOOTING STRATEGY..... 13C-3 SYMPTOM CHART...................

More information

FUEL SYSTEM/CARBURETOR/FUEL PUMP

FUEL SYSTEM/CARBURETOR/FUEL PUMP 13 FUEL SYSTEM/CARBURETOR/FUEL PUMP FUEL SYSTEM-------------------------------------------------------------------------------------13-1 SCHEMATIC DRAWING-------------------------------------------------------------------------13-2

More information

Preflight Inspection Cabin EMPENNAGE RIGHT WING Trailing Edge RIGHT WING NOSE

Preflight Inspection Cabin EMPENNAGE RIGHT WING Trailing Edge RIGHT WING NOSE Preflight Inspection Cabin 1. Control Wheel Lock REMOVED 2. Ignition Switch OFF 3. Avionics Power Switch OFF 4. Master Switch ON 5. Fuel Quantity Indicators CHECK QUANTITY 6. Master Switch OFF 7. Fuel

More information

This chapter contains information on DC Generation, External Power, and Electrical Load Distribution.

This chapter contains information on DC Generation, External Power, and Electrical Load Distribution. CIRRUS AIRPLANE MAINTENANCE MANUAL Electrical Power CHAPTER 24-00: ELECTRICAL POWER GENERAL 24-00: ELECTRICAL POWER 1. General This chapter contains information on DC Generation, External Power, and Electrical

More information

NORMAL CHECKLIST ATTENTION!

NORMAL CHECKLIST ATTENTION! Avion Training CHECKLIST Normal Checklist CESSNA 172R / TC-STS Cessna 172 R TC-STS NORMAL CHECKLIST ATTENTION! DO NOT STOW THIS CHECKLIST IN DIRECT SUNLIGHT Avion Training - Doc.nr. 212 Revision 1 / 02022018

More information

CIRRUS AIRPLANE MAINTENANCE MANUAL

CIRRUS AIRPLANE MAINTENANCE MANUAL SCHEDULED MAINTENANCE 1. DESCRIPTION These inspections meet the intent of 14 CFR 91.409 and Part 43, Appendix D. In addition to the inspections prescribed by this schedule, the altimeter instrument and

More information

TURBOCHARGER Toyota Celica DESCRIPTION OPERATION TURBOCHARGING SYSTEMS All Models

TURBOCHARGER Toyota Celica DESCRIPTION OPERATION TURBOCHARGING SYSTEMS All Models TURBOCHARGER 1988 Toyota Celica 1988 TURBOCHARGING SYSTEMS All Models DESCRIPTION Most models use a water-cooled turbocharger, mounted directly to the exhaust manifold with a wastegate assembly attached

More information

OWNER S MANUAL. Model: FS-ATV-15 ( ) (15 Gallon Lawn & Garden/ATV Sprayer) Technical Specifications. Assembly Instructions. General Information

OWNER S MANUAL. Model: FS-ATV-15 ( ) (15 Gallon Lawn & Garden/ATV Sprayer) Technical Specifications. Assembly Instructions. General Information OWNER S MANUAL Model: FS-ATV-15 (5301169) (15 Gallon Lawn & Garden/ATV Sprayer) Technical Specifications 15 Gal. Corrosion-Resistant Polyethylene Tank 12 Volt Diaphragm Pump, 1.8 g.p.m. 60 psi Spot Sprayer

More information

Oregon Fuel Injection

Oregon Fuel Injection 2001 2006 Dodge Mercedes - Freightliner Sprinter Diagnostics In order to do proper diagnostics you will need a scan tool and some special tools available from Mopar Special Tools http://mopar.snapon.com.

More information

LANCAIR LEGACY PRE-TEST FLIGHT INSPECTION (8-04)

LANCAIR LEGACY PRE-TEST FLIGHT INSPECTION (8-04) LANCAIR LEGACY PRE-TEST FLIGHT INSPECTION (8-04) OWNER PHONE # ADDRESS N SERIAL # AIRCRAFT TYPE DATE / / TACH TIME hrs. TOTAL TIME hrs. EMPTY WEIGHT CG. PAINT & INTERIOR? YES NO ENGINE TYPE PROPELLER ALL

More information

INTAKE AND EXHAUST GROUP CONTENTS CHARGE AIR COOLER <2.0L ENGINE> GENERAL DESCRIPTION SERVICE SPECIFICATIONS...

INTAKE AND EXHAUST GROUP CONTENTS CHARGE AIR COOLER <2.0L ENGINE> GENERAL DESCRIPTION SERVICE SPECIFICATIONS... 15-1 GROUP 15 INTAKE AND EXHAUST CONTENTS GENERAL DESCRIPTION 15-2 SERVICE SPECIFICATIONS 15-2 DIAGNOSIS 15-2 INTRODUCTION 15-2 TROUBLESHOOTING STRATEGY 15-2 SYMPTOM CHART 15-2 SYMPTOM PROCEDURES 15-3

More information

CARENADO COPYRIGHTS. Normal & Emergency Checklist

CARENADO COPYRIGHTS. Normal & Emergency Checklist NORMAL PROCEDURES CHECKLIST PREFLIGHT CHECK Control wheel -- RELEASE BELTS Avionics -- OFF Master Switch -- ON Fuel quantity gauges -- CHECK Master switch -- OFF Ignition -- OFF Exterior -- CHECK FOR DAMAGE

More information

Holley High Performance Intake System* For Port 13B Engines (Includes B 6-Port engines converted to 4-Port)

Holley High Performance Intake System* For Port 13B Engines (Includes B 6-Port engines converted to 4-Port) Holley High Performance Intake System* For 1974-1978 4-Port 13B Engines (Includes 1984-85 13B 6-Port engines converted to 4-Port) Installation Instructions I-18038 Note: These instructions assume: The

More information

SCHEDULED MAINTENANCE

SCHEDULED MAINTENANCE SCHEDULED MAINTENANCE 1. DESCRIPTION These inspections meet the intent of 14 CFR 91.409 and Part 43, Appendix D. In addition to the inspections prescribed by this schedule, the altimeter instrument and

More information

Installation, Operation, and Maintenance Manual Outdoor Glycol Feed System JWOP /055/100

Installation, Operation, and Maintenance Manual Outdoor Glycol Feed System JWOP /055/100 Installation, Operation, and Maintenance Manual Outdoor Glycol Feed System JWOP-53-030/055/100 Rev. 1 3/21/11 K.G. Type - John Wood #JWOP-53-030/055/100, Outdoor Glycol Feed System Capacity 30/55/100 Gallons

More information

WS2H/ WS3 Error Codes

WS2H/ WS3 Error Codes WS2H & WS3 Troubleshooting Page 1 WS2H/ WS3 Error Codes Possible Errors Code Description 1001 No Encoder Pulses 1002 Unexpected Stall, Main Drive 1003 Run Time To Long, Main Drive 14001 Message Queue Full

More information

CHAPTER 13 INSTRUMENTS

CHAPTER 13 INSTRUMENTS CHAPTER 13 INSTRUMENTS Section Title Page 13.000 Description.............................................. 13.1 13.100 Pitot-Static System......................................... 13.3 13.200 Primary Instruments........................................

More information

CIRRUS AIRPLANE MAINTENANCE MANUAL

CIRRUS AIRPLANE MAINTENANCE MANUAL AIR INTAKES 1. DESCRIPTION This section describes that portion of the power plant which directs mass air flow to the engine. Induction air enters the engine through a filter mounted on the left, forward

More information

Storage. 1. General. A. Fuel Storage System

Storage. 1. General. A. Fuel Storage System Storage GENERAL 28-10: STORAGE 1. General A. Fuel Storage System The fuel storage system consists primarily of a vented integral 149.25-gallon (1009-liter) capacity main fuel tank in each wing, an integral

More information

SECTION 3.00 WARNING WARNING ENGINE STARTUP AND SHUTDOWN PRESTART INSPECTION

SECTION 3.00 WARNING WARNING ENGINE STARTUP AND SHUTDOWN PRESTART INSPECTION SECTION 3.00 ENGINE STARTUP AND SHUTDOWN PRESTART INSPECTION Be sure that the clutch, circuit breaker, or other main power transmission device is disconnected. Generators develop voltage as soon as the

More information

EMISSION CONTROL (AUX. EMISSION CONTROL DEVICES) H6DO

EMISSION CONTROL (AUX. EMISSION CONTROL DEVICES) H6DO EMISSION CONTROL (AUX. EMISSION CONTROL DEVICES) H6DO SYSTEM OVERVIEW 1. System Overview There are three emission control systems, which are as follows: Crankcase emission control system Exhaust emission

More information

Robinson R44. Systems

Robinson R44. Systems Robinson R44 Systems The airframe is primarily a metal construction. The primary fuselage is welded steel tubing and riveted aluminium sheet. The tailcone is an aluminium semi-monocoque structure where

More information

Fuel Supply Component Description

Fuel Supply Component Description 1999 Chevrolet/Geo Tahoe - 4WD Fuel Supply Component Description FIGURE Central SFI Fuel System with Fuel Pressure Gauge(c) (1) Fuel Inlet (2) Bleed Hose (3) J 34730-1A Fuel Pressure Gage Assembly (4)

More information

CHAPTER 28 FUEL SYSTEM

CHAPTER 28 FUEL SYSTEM CHAPTER 28 P/N 135A-970-100 Chapter 28 REVISION E Page 1 of 60 Copyright 2009 All rights reserved. The information contained herein is proprietary to Liberty Aerospace, Incorporated. It is prohibited to

More information

Honda Accord/Prelude

Honda Accord/Prelude Honda Accord/Prelude 1984-1995 In Tank Fuel Pumps TEST 1. Turn the ignition OFF. 2. On the Accord, remove the screws securing the underdash fuse box to its mount. Remove the fuel cut off relay from the

More information

N123AX Piper SARATOGA II HP (PA-32R-301) HANDLING NOTES

N123AX Piper SARATOGA II HP (PA-32R-301) HANDLING NOTES N123AX Piper SARATOGA II HP (PA-32R-301) HANDLING NOTES 1. ENGINE OPERATIONS Recommended starting procedures and checklists are supplied in the aeroplane Note: Oil capacity is 12 qts. Minimum for flight

More information

PIERBURG. Carburetor: 2E3

PIERBURG. Carburetor: 2E3 PIERBURG Carburetor: 2E3 1 fast idle adjusting screw 2 throttle lever 3 fuel mixture adjusting screw 4 main body 5 idle cut off valve 6 stop screw 7 accelerator pump cover 8 diaphragm 9 spring 10 valve

More information

Page 1 of 8 HW7 DTC P1443: CHECK THE VOLTAGE ON THE PURGE FLOW (PF) SENSOR CIRCUIT VOLTAGE WITH ENGINE RUNNING Continuous Memory Diagnostic Trouble Code (DTC) P1443 indicates an incorrect evaporative system

More information

Fuel System Diagnosis

Fuel System Diagnosis Page 1 of 6 2001 Chevrolet Express Express, Savana (VIN G) Service Manual Engine Engine Controls - 5.0L and 5.7L Diagnostic Information and Procedures Document ID: 720867 Fuel System Diagnosis Circuit

More information

SERVICE BULLETIN NUMBER CT 125 including MODIFICATION M186 ISSUE 1 PAGE 1 of 6

SERVICE BULLETIN NUMBER CT 125 including MODIFICATION M186 ISSUE 1 PAGE 1 of 6 SERVICE BULLETIN NUMBER CT 125 including MODIFICATION M186 ISSUE 1 PAGE 1 of 6 TITLE Fuel System CLASSIFICATION The CAA have classified this bulletin as Mandatory. COMPLIANCE Fuel flow check before further

More information

4A.2 AIRSPEEDS FOR NORMAL OPERATING PROCEDURES

4A.2 AIRSPEEDS FOR NORMAL OPERATING PROCEDURES Normal Operating DA 40 AFM 4A.1 INTRODUCTION Chapter 4A contains checklists and describes extended procedures for the normal operation of the airplane. 4A.2 AIRSPEEDS FOR NORMAL OPERATING PROCEDURES Flight

More information

INSTALLATION MANUAL EAGLE EMS ELECTRONIC ENGINE MANAGEMENT SYSTEM EMSINSTL001 REV 0.2 2/12/08

INSTALLATION MANUAL EAGLE EMS ELECTRONIC ENGINE MANAGEMENT SYSTEM EMSINSTL001 REV 0.2 2/12/08 INSTALLATION MANUAL EAGLE EMS ELECTRONIC ENGINE MANAGEMENT SYSTEM EMSINSTL001 REV 0.2 2/12/08 The information contained in this publication is intended as a guide to install your Eagle EMS Engine Management

More information

ATTITUDE AND DIRECTION

ATTITUDE AND DIRECTION All ATTITUDE AND DIRECTION 1. DESCRIPTION This section contains information pertaining to those portions of the system which use magnetic, gyroscopic, and inertia forces. Included is the magnetic compass,

More information

Vso 61. Vs1 63. Vr 70. Vx 76. Vxse 78. Vy 89. Vyse. 89 (blue line) Vmc. 61 (radial redline) Vsse 76. Va 134) Vno 163

Vso 61. Vs1 63. Vr 70. Vx 76. Vxse 78. Vy 89. Vyse. 89 (blue line) Vmc. 61 (radial redline) Vsse 76. Va 134) Vno 163 PA34-200T Piper Seneca II Normal procedures V-speeds Knots Vso 6 Vs 63 Vr 70 Vx 76 Vxse 78 Vy 89 Vyse Vmc 89 (blue line) 6 (radial redline) Vsse 76 Va 2-36(@4507lbs 34) Vno 63 Vfe 38 (0*)/2(25*)/07(40*)

More information

CHAPTER FUEL SYSTEM

CHAPTER FUEL SYSTEM Vol. 1 13--00--1 FUEL SYSTEM Table of Contents REV 3, May 03/05 CHAPTER 13 --- FUEL SYSTEM Page TABLE OF CTENTS 13-00 Table of Contents 13--00--1 INTRODUCTI 13-10 Introduction 13--10--1 FUEL STORAGE 13-20

More information

Enstrom Helicopter Corp.

Enstrom Helicopter Corp. Enstrom Helicopter Corp. Enstrom Helicopter Corp. Field Adjustment of the Fuel Servo. F & C Models Disclaimer The procedures outlined in this presentation are intended to supplement the Maintenance Manual

More information

Principals of Operation... 1 Rotary Vane Priming Pump VPE and VPES... 2 Rotary Vane Priming Pump VPO and VPOS Priming Valve...

Principals of Operation... 1 Rotary Vane Priming Pump VPE and VPES... 2 Rotary Vane Priming Pump VPO and VPOS Priming Valve... Priming Systems Installation Priming Systems Operation & Maintenance Form No. F 1031 Section 2312 Issue Date 10/07/94 Rev. Date 02/27/06 Table of Contents Illustrations Principals of Operation...........................

More information

OWNER S MANUAL. Model: UTL-60-12V ( ) (60 Gallon Lawn & Garden Utility Sprayer w/5-nozzle Boom)

OWNER S MANUAL. Model: UTL-60-12V ( ) (60 Gallon Lawn & Garden Utility Sprayer w/5-nozzle Boom) OWNER S MANUAL Model: UTL-60-12V (5301347) (60 Gallon Lawn & Garden Utility Sprayer w/5-nozzle Boom) Technical Specifications 60 Gal. Corrosion-Resistant Polyethylene Tank Deluxe Pistol-Grip Handgun w/25

More information

CIRRUS SR2X SB 2X Service Bulletin. Issued: February 27, SNS SUBJECT: TEMPERATURE CONTROL - Cabin Air Coupler Actuator Rigging

CIRRUS SR2X SB 2X Service Bulletin. Issued: February 27, SNS SUBJECT: TEMPERATURE CONTROL - Cabin Air Coupler Actuator Rigging CIRRUS SR2X Service Bulletin Number: Issued: February 27, 2012 SNS SUBJECT: 21-60 TEMPERATURE CONTROL - Cabin Air Coupler Actuator Rigging 1. COMPLIANCE Recommended, On Condition: Accomplish this Service

More information

INDEX: Normal Procedures Emergency Procedures Pre Flight Inspection NORMAL PROCEDURES BEFORE STARTING ENGINE

INDEX: Normal Procedures Emergency Procedures Pre Flight Inspection NORMAL PROCEDURES BEFORE STARTING ENGINE INDEX: Normal Procedures Emergency Procedures Pre Flight Inspection NORMAL PROCEDURES BEFORE STARTING ENGINE 1. Preflight Inspection -- COMPLETE 2. Seats, Belts, Shoulder Harnesses -- ADJUST and LOCK 3.

More information

Basic Ice Protection System

Basic Ice Protection System Cirrus Design Section 9 Pilot s Operating Handbook and FAA Approved Airplane Flight Manual Supplement for Basic Ice Protection System When the Ice Protection System is installed on the aircraft, this POH

More information

Diagnostic Trouble Code (DTC) memory, checking and erasing

Diagnostic Trouble Code (DTC) memory, checking and erasing Page 1 of 49 01-12 Diagnostic Trouble Code (DTC) memory, checking and erasing Check DTC Memory (function 02) - Connect VAS5051 tester Page 01-7 and select vehicle system "01 - Engine electronics". Engine

More information

CESSNA 182 CHECKLIST. LEFT WING Trailing Edge 1. Aileron CHECK freedom of movement and security

CESSNA 182 CHECKLIST. LEFT WING Trailing Edge 1. Aileron CHECK freedom of movement and security CESSNA 182 CHECKLIST PRE-FLIGHT INSPECTION CABIN 1. Pilot s Operating Handbook AVAILABLE IN THE AIRPLANE (A.R.R.O.W.E) 2. Landing Gear Lever DOWN 3. Control Wheel Lock REMOVE 4. Ignition Switch OFF 5.

More information

Model 990 & 990V INSTALLATIONS AND OPERATING INSTRUCTIONS

Model 990 & 990V INSTALLATIONS AND OPERATING INSTRUCTIONS Model 990 & 990V Advanced Marine Technologies, Inc. 212 Yacht Club Drive Saint Augustine FL 32084 866-922-4804 904-829-1800 FAX 904-829-2800 pumps@x-change-r.com www.x-change-r.com INSTALLATIONS AND OPERATING

More information

FLIGHT SIMULATOR SYSTEMS

FLIGHT SIMULATOR SYSTEMS FLIGHT SIMULATOR SYSTEMS 1. GENERAL This section describes systems required for simulator operation. This equipment includes the Cirrus Landing Gear Simulator (CLGS). 2. DESCRIPTION The intent of the CLGS

More information

SYMPTOM POSSIBLE CAUSES CORRECTIVE ACTION

SYMPTOM POSSIBLE CAUSES CORRECTIVE ACTION Troubleshooting SYMPTOM POSSIBLE CAUSES CORRECTIVE ACTION WILL NOT RUN RUNS BUT WON'T SPRAY LOW SPRAY AT NOZZLE UNEVEN SPRAY PATTERN WILL NOT PRODUCE HOT WATER Pump switch in OFF position Place switch

More information