2013 Consumer Replacement Tire Guide, Limited Warranty & Registration Booklet For Cooper, Mastercraft, Starfire & Roadmaster Tires

Transcription

1 2013 Consumer Replacement Tire Guide, Limited Warranty & Registration Booklet For Cooper, Mastercraft, Starfire & Roadmaster Tires SAFETY WARNING: Disregarding any of the safety precautions and instructions contained in this booklet may result in tire failure or explosion causing serious personal injury or death. For tire care reminders, please visit our website at THIS BOOKLET IS VALUABLE and must be presented with your proof of purchase for all replacement tire warranty service. This replacement tire warranty applies to the original purchaser and is not transferable.

2 ELIGIBILITY This warranty applies to the original purchaser of a replacement Cooper passenger or light truck tire and is not transferable. Eligible tires must be purchased new and used on the vehicle which they were originally installed. Proof of purchase is required for all warranty claims. Additionally, they must be the size, load index, and speed rating equivalent States and the District of Columbia. For warranty exclusions see WHAT ISN T COVERED. STANDARD COVERAGE If your replacement Cooper branded radial tire becomes unserviceable as a result of an eligible adjustable condition replacement tire. You must present proof of purchase and be the original owner when requesting a replacement for your tire. The replacement charge will be determined by multiplying the dealer's current selling price by the percentage of original tread depth worn from the tire. You must pay for mounting, balancing, and any other additional charges, such as taxes or the acceptance of a higher priced replacement tire. EXTRA COVERAGE FOR PREMIUM TIRES The following No-Charge Warranty covers eligible adjustable conditions only, and should not be confused with the mounting and balancing. You must present this warranty booklet, proof of purchase, and be the original owner when requesting a replacement for your tire. 45-DAY ROAD TEST A any reason, other than the conditions that are listed in the What Isn t Covered section, you may return them to your original You must present this warranty booklet, proof of purchase, and be the original owner when requesting a replacement or refund. Passenger & Light Truck Tire Limited Warranty Tire Miles Warranted Tire Miles Warranted Trendsetter SE *Mileage Warranty applies to Passenger and Light Truck lines. The Tread Wear warranty is available provided that you: 1. are the original owner. 2. present this warranty booklet when requesting an adjustment and your original purchase receipt, date of purchase, vehicle type, model, odometer reading and rotation record are properly recorded. If the tire wears to the tread wear indicators in less than the miles warranted, a pro-rated adjustment will be made according to actual mileage delivered. Your replacement cost will be determined by dividing the actual mileage delivered by the miles warranted and multiplying the result times the current selling price of an equivalent Cooper tire. You must pay for mounting and balancing and any other additional charges, such as taxes or the acceptance of a higher priced replacement tire. TREAD LIFE WARNING for important safety information, you must read the section HOW TO OBTAIN AN ADJUSTMENT Tire adjustments must be presented to your local Cooper dealer. You must present this booklet, proof of purchase WHAT ISN T COVERED Adjustments will not be made for: A. Tires that become unserviceable due to: Conditions such as, but not limited to, uneven, cupping, spotty, feathering tread wear resulting from to follow recommended rotation practices. of tread wear. is required. Without proof of purchase the manufacture date will be used to determine eligibility. F. Tires stored improperly., OR purchase is required. Without proof of purchase the manufacture date will be used to determine eligibility. Protection provided herein. NO ROAD HAZARD COVERAGE REPLACEMENT WARRANTY If you receive a replacement tire under the terms of this Warranty, the replacement tire will be covered by the Warranty then This warranty applies to the original purchaser and is not transferable. WHERE TO GO FOR WARRANTY REPLACEMENT See your Cooper dealer listed in the yellow pages under Tire Dealers Retail. In the event you are unable to locate a Cooper dealer, you can obtain assistance by contacting the Consumer Relations Department, telephone number CONDITIONS AND EXCLUSIONS Any tire, no matter how well constructed, may fail in service or otherwise become unserviceable due to conditions beyond the control of the manufacturer. Nothing in this Warranty is intended to be a representation by Cooper that tire failure cannot occur. TIRE SERVICE LIFE undamaged and have not reached their tread wear limits. In some cases, a vehicle manufacturer may make a recommendation for USED TIRES Never purchase used tires! Previous usage may have damaged internal components. This damage may lead to sudden tire failure. COOPER DISCLAIMS ANY LIABILITY STEMMING FROM THE USE OF A USED TIRE FOR LOSS OF TIME, OR USE, INCONVENIENCE, OR ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES TO THE EXTENT PERMITTED BY LAW. Some states do not allow exclusion of incidental or consequential damages. As a result, this limitation or exclusion may not apply to you. CONSUMER RIGHTS OWNER S OBLIGATION When making a claim, you must return the tire to be replaced to your Cooper dealer and sign the customer signature section of the Tire Claim Form. Proper vehicle and tire care is necessary to obtain the expected wear from a tire. It is your obligation to properly maintain We recommend that you have your Cooper dealer inspect your tires any time you notice irregular or uneven tread wear and rotate them, if necessary. Also, they should be inspected by your dealer any time your vehicle is brought in for service. For additional safety information please visit: TREAD WEAR PROTECTION received, and is separate from the Standard Coverage & Extra Coverage Warranties just covered. No manufacturer or dealer can guarantee you a certain number of miles from a given tire. Driving habits, driving conditions, tire and vehicle maintenance all play a part in the tread life of a tire and all differ with each purchaser. The following replacement Cooper radial tires only are warranted against tread wear out prior to the applicable indicated mileage: 1 currently given by Cooper for the replacement tire

3 Passenger & Light Truck Tire Limited Warranty ELIGIBILITY Eligible tires must be purchased new and used on the vehicle which they were originally installed. Proof of purchase is required for all warranty claims. Additionally, they must be the size, load index, and speed rating equivalent or greater than that Columbia. For warranty exclusions see WHAT ISN T COVERED. STANDARD COVERAGE must present proof of purchase and be the original owner when requesting a replacement for your tire. The replacement charge will be determined by multiplying the dealer's current selling price by the percentage of original tread depth worn from the tire. You must pay for mounting, balancing, and any other additional charges, such as taxes or the acceptance of a higher priced replacement tire. EXTRA COVERAGE FOR PREMIUM TIRES The following No-Charge Warranty covers eligible adjustable conditions only, and should not be confused with the prorated Tread balancing. You must present this warranty booklet, proof of purchase, and be the original owner when requesting a replacement for your tire. 45 DAY ROAD TEST radial tire for any reason, other than the conditions that are listed in the What Isn t Covered section, you may return them to your mounting and balancing. You must present this warranty booklet, proof of purchase, and be the original owner when requesting a replacement or refund. TREAD WEAR PROTECTION is separate from the Standard Coverage & Extra Coverage Warranties just covered. No manufacturer or dealer can guarantee you a certain number of miles from a given tire. Driving habits, driving conditions, tire and vehicle maintenance all play a part in the warranted against tread wear out prior to the applicable indicated mileage: Tire Miles Warranted Tire Miles Warranted Courser HTR Courser STR *Mileage Warranty applies to Passenger and Light Truck lines. The Tread Wear warranty is available provided that you: 1. are the original owner. vehicle type, model, odometer reading and rotation record are properly recorded. If the tire wears to the tread wear indicators in less than the miles warranted, a pro-rated adjustment will be made according to actual mileage delivered. Your replacement cost will be determined by dividing the actual mileage delivered by the miles warranted tire. You must pay for mounting and balancing and any other additional charges, such as taxes or the acceptance of a higher priced replacement tire. TREAD LIFE WARNING for important safety information, you must read the section titled Tire Service HOW TO OBTAIN AN ADJUSTMENT WHAT ISN T COVERED Adjustments will not be made for: A. Tires that become unserviceable due to: 1. recommended rotation practices. required. Without proof of purchase the manufacture date will be used to determine eligibility. F. Tires stored improperly., OR purchase is required. Without proof of purchase the manufacture date will be used to determine eligibility. Protection provided herein. NO ROAD HAZARD COVERAGE REPLACEMENT WARRANTY If you receive a replacement tire under the terms of this Warranty, the replacement tire will be covered by the Warranty then WHERE TO GO FOR WARRANTY REPLACEMENT This warranty applies to the original purchaser and is not transferable. CONDITIONS AND EXCLUSIONS Any tire, no matter how well constructed, may fail in service or otherwise become unserviceable due to conditions beyond cannot occur. TIRE SERVICE LIFE if the tires appear to be undamaged and have not reached their tread wear limits. In some cases, a vehicle manufacturer recommendations for their vehicle. USED TIRES Never purchase used tires! Previous usage may have damaged internal components. This damage may lead to sudden tire failure. MASTERCRAFT DISCLAIMS ANY LIABILITY STEMMING FROM THE USE OF A USED TIRE FOR LOSS OF TIME, OR USE, INCONVENIENCE, OR ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES TO THE EXTENT PERMITTED BY LAW. Some states do not allow exclusion of incidental or consequential damages. As a result, this limitation or exclusion may not apply to you. CONSUMER RIGHTS OWNER S OBLIGATION section of the Tire Claim Form. Proper vehicle and tire care is necessary to obtain the expected wear from a tire. It is your obligation to properly and rotate them, if necessary. Also, they should be inspected by your dealer any time your vehicle is brought in for service. For additional safety information please visit:

4 Passenger & Light Truck Tire Limited Warranty ELIGIBILITY transferable. Eligible tires must be purchased new and used on the vehicle which they were originally installed. Proof of purchase is required for all warranty claims. Additionally, they must be the size, load index, and speed rating STARFIRE TIRES COVERAGE WHAT IS COVERED AND FOR HOW LONG OTHER THAN FIRST QUALITY TIRES TREAD LIFE from a given tire. Driving habits, driving conditions, tire and vehicle maintenance all play a part in the tread life of a tire and all differ with each purchaser. WARNING for important safety information, you must read the section titled REPLACEMENT CHARGE The replacement charge will be determined by multiplying dealer s current selling price by the percentage of original tread depth worn from the tire. You must pay for mounting, balancing, and any other additional charges, such as taxes or the acceptance of a higher priced replacement tire. HOW TO OBTAIN AN ADJUSTMENT WHAT ISN T COVERED Adjustments will not be made for: A. Tires that become unserviceable due to: 2. Conditions such as, but not limited to, uneven, cupping, spotty, feathering tread wear resulting from pro-rated basis. E. of purchase is required. Without proof of purchase the manufacture date will be used to determine eligibility. F. Tires stored improperly., OR determine eligibility. NO ROAD HAZARD COVERAGE from them. REPLACEMENT WARRANTY If you receive a replacement tire under the terms of this Warranty, the replacement tire will be covered by the WHERE TO GO FOR WARRANTY REPLACEMENT CONDITIONS AND EXCLUSIONS Any tire, no matter how well constructed, may fail in service or otherwise become unserviceable due to conditions beyond the control of the manufacturer. Nothing in this Warranty is intended to be a representation TIRE SERVICE LIFE be replaced even if the tires appear to be undamaged and have not reached their tread wear limits. In some This warranty applies to the original purchaser and is not transferable. USED TIRES Never purchase used tires! Previous usage may have damaged internal components. This damage may lead to sudden tire failure. STARFIRE DISCLAIMS ANY LIABILITY STEMMING FROM THE USE OF A USED TIRE FOR LOSS OF TIME, OR USE, INCONVENIENCE, OR ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES TO THE EXTENT PERMITTED BY LAW. Some states do not allow exclusion of incidental or consequential damages. As a result, this limitation or exclusion may not apply to you. CONSUMER RIGHTS OWNER S OBLIGATION signature section of the Tire Claim Form. Proper vehicle and tire care is necessary to obtain the expected wear from a tire. It is your obligation to properly and before long trips. tread wear and rotate them, if necessary. Also, they should be inspected by your dealer any time your vehicle is brought in for service. For additional safety information please visit:

5 All-Steel Radial Truck Tire Limited Warranty ELIGIBILITY This warranty applies to the original purchaser of a Roadmaster All-Steel Radial truck tire and is not transferable. Eligible tires must be purchased new and used on the vehicle which they were originally installed. Proof of purchase is required for all warranty claims. Additionally, they must be the size, load index, and speed rating equivalent or greater than that specified by the vehicle manufacturer. This warranty applies of Columbia and Canada. For warranty exclusions see WHAT ISN T COVERED. WHAT IS COVERED AND FOR HOW LONG Roadmaster warrants to the original purchaser that if a Roadmaster tire becomes unserviceable due to an eligible OTHER THAN FIRST QUALITY TRUCK TIRES except for ride complaints and the appearance or other conditions which caused the tires to be classified as other than TREAD LIFE maintenance all play a part in the tread life of a tire and all differ with each purchaser. WARNING - for important safety REPLACEMENT CHARGE The Replacement Charge will be determined by multiplying the dealer s current selling price by the percentage of original tread depth worn from the tire. You must pay for mounting, balancing and any other additional charges, such as taxes or the acceptance of a higher priced replacement tire. CASING ALLOWANCE Radial medium truck tire becomes unserviceable and is not retreadable due to an adjustable condition in the casing, or First Retread = $90.00 Second Retread = $60.00 First Retread = $60.00 Second Retread = $30.00 First Retread = $30.00 Second Retread = $15.00 eligible for a casing allowance. HOW TO OBTAIN AN ADJUSTMENT Tire adjustments must be presented to your local Roadmaster dealer. You must present this booklet, proof of purchase WHAT IS NOT COVERED Adjustments will not be made for: A. Tires that become unserviceable due to: vandalism. credited on a pro-rated basis for the original Roadmaster factory tread. purchase is required. Without proof of purchase the manufacture date will be used to determine eligibility. F. Tires stored improperly., OR Proof of purchase is required. Without proof of purchase the manufacture date will be used to determine eligibility. NO ROAD HAZARD COVERAGE REPLACEMENT WARRANTY If you receive a replacement tire under the terms of this Warranty, the replacement tire will be covered by the Warranty then currently given by Roadmaster for the replacement tire. WHERE TO GO FOR WARRANTY REPLACEMENT See your Roadmaster dealer. They are listed in the yellow pages under Tire Dealers Retail. In the event you are unable to locate a Roadmaster dealer, you can obtain assistance by contacting the Consumer Relations Department, CONDITIONS AND EXCLUSIONS Any tire, no matter how well constructed, may fail in service or otherwise become unserviceable due to conditions beyond the control of the manufacturer. Nothing in this Warranty is intended to be a representation by Roadmaster that tire failure cannot occur. This warranty applies to the original purchaser and is not transferable. TIRE SERVICE LIFE Roadmaster recommends that all passenger, light truck and commercial tires, including full-size spare tires, that are be replaced even if the tires appear to be undamaged and have not reached their tread wear limits. In some cases, a upon their understanding of the specific vehicle characteristics and application. If so, you should follow those vehicle manufacturer's specific recommendations for their vehicle. USED TIRES Never purchase used tires! Previous usage may have damaged internal components. This damage may lead to sudden tire failure. ROADMASTER DISCLAIMS ANY LIABILITY STEMMING FROM THE USE OF A USED TIRE FOR LOSS OF TIME, OR USE, INCONVENIENCE, OR ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES TO THE EXTENT PERMITTED BY LAW. Some states do not allow exclusion of incidental or consequential damages. As a result, this limitation or exclusion may not apply to you. CONSUMER RIGHTS This Warranty gives you specific legal rights, and you may also have other rights which vary from state to state. OWNER S OBLIGATION When making a claim, you must return the tire to be replaced to your Roadmaster dealer and sign the customer signature section of the Tire Claim Form. Proper vehicle and tire care is necessary to obtain the expected wear from a tire. It is your obligation to properly We recommend that you have your Roadmaster dealer inspect your tires any time you notice irregular or uneven tread wear and rotate them, if necessary. Also, they should be inspected by your dealer any time your vehicle is brought in for service. For additional safety information please visit:

6 Tires are designed and built with great care to provide thousands of miles of excellent service. The most important factors in tire care are: TIRE INFLATION PRESSURE With the right amount of air pressure, your tires wear longer, save fuel and help prevent the front and rear tires on your particular model car or light truck. The correct air pressure is box door. If your vehicle doesn t have a placard, check the owner s manual or consult with the The tire placard tells you the maximum vehicle load, the cold tire pressures and the tire size If you don t take proper care of your tires, the results can be serious. There is a safety warning molded on the sidewall of your tire. It is shown to the right. There are additional safety warnings in this booklet and on website. Only specially trained persons should demount or mount tires. An explosion of a tire and wheel assembly can result from improper or careless mounting procedures and cause serious injury or death. 9 Tire Placard and Safety Warning Your tire contains a lot of useful information molded into the sidewall. It shows the name of the Shown here on the left is the sidewall of a popular in inches. Some speed-rated tires carry a Service Description instead of showing the speed symbol in the example, consists of the load index and speed symbol. means diagonal bias construction. units of measurement. The letters DOT certify compliance with all applicable safety standards established by the number. This serial number is a code with up to eleven digits that are a combination of numbers and letters. Example: Dept. of Transportation code No. Tire Size Code No. 2 digit wk, 2 digit yr DOT MA L9 ABCD 0307 The Sidewall Story The sidewall also shows the type of cord and number of plies in the sidewall and in the tread region. The DOT requires tire manufacturers to grade passenger car tires based on three performance factors: Treadwear, Traction, and Temperature Resistance. TREADWEAR: The treadwear grade is a comparative rating based on the wear rate of However, it is erroneous to link treadwear grades with your projected tire mileage. The relative performance of tires depends upon the actual conditions of their use and may vary due to driving habits, service practices, differences in road characteristics and climate. TRACTION: government test surfaces of asphalt and concrete. TEMPERATURE: indoor laboratory test wheel. normal operation, follow pressure recommendations in owner s manual or on vehicle placard. markings on the sidewall have the same meaning as described for the passenger car tire.

7 Safety Warnings DRIVING ON ANY TIRE THAT DOES NOT HAVE THE CORRECT INFLATION PRESSURE IS DANGEROUS - on tire sidewall. CHECK TIRE INFLATION PRESSURES (INCLUDING THE SPARE) AT LEAST ONCE A MONTH WHEN TIRES ARE COLD AND BEFORE LONG TRIPS. ALL TIRES LOSE AIR OVER TIME. rapid and irregular tire wear, sudden tire destruction, loss of vehicle control and serious per- and always prior to long distance trips. Any tire is susceptible to losing air pressure if not properly maintained. on. Driving, even for a short distance, causes tires to heat up and air pressure to increase. HIGH SPEED DRIVING CAN BE DANGEROUS - high speed reduces the reaction time available to avoid accidents and bring your vehicle to a safe stop. Never exceed the legal speed limit. INSPECT YOUR TIRES, DO NOT DRIVE ON A DAMAGED TIRE OR WHEEL Any time you see any damage to your tires or wheels replace with a suitable spare at once and immediately see your tire dealer. When inspecting your tires, including the spare, check your air pressures. If your pressure check indicates that one of your tires has lost pressure of two pounds or more, look for signs of penetrations, valve leakage, or other tire or wheel damage that may account for the air loss. 11 For more information on safety, visit and select Tire Safety. Always look for bulges, cracks, cuts, penetrations and abnormal tire wear, particularly If any such damage is found, the tire must be replaced with a suitable spare tire at once and should be inspected by any tire dealer at once. Use of a damaged tire could result in sudden tire destruction. All tires will wear out faster when subjected to high speeds, as well as hard cornering, rapid starts, sudden stops, frequent driving on roads which are in poor condition, and off-road use. Roads with holes and rocks or other objects can damage tires and cause misalignment of your vehicle. When you drive on such roads, drive on them carefully and slowly, and before driving at normal or highway speeds, examine your tires for any damage, such as cuts or penetrations. WORN OUT TIRES ARE DANGEROUS DO NOT OVERLOAD DRIVING ON ANY OVERLOADED TIRE IS DANGEROUS The maximum load rating of your tires is marked on the tire sidewall. Do not exceed these load ratings. Follow the loading instructions of the manufacturer of your vehicle and this will insure that your tires are not overloaded. Tires which are loaded beyond their maximum allowable loads for the particular application will build up excessive heat that may result in sudden tire destruction. Do not exceed the gross axle weight ratings for any axle on your vehicle. TRAILER TOWING If you anticipate towing a trailer, you should see any tire dealer for advice concerning the correct size of tire and pressures. Tire size and pressures will depend upon the type and size of trailer exceeded. Check the tire placard and the owner s manual supplied by the manufacturer of your vehicle for further recommendations on trailer towing. Safety Warnings WHEEL ALIGNMENT AND BALANCING ARE IMPORTANT FOR SAFETY AND MAXIMUM MILEAGE FROM YOUR TIRES INSPECT YOUR TIRES REGULARLY neglect. If not corrected, further tire damage will occur. These conditions not only shorten the life of your tires, they adversely affect the handling characteristics of your vehicle which could be dangerous. If any of these conditions exist, the cause may often be corrected at your tire dealer s or other service facility. TIRE ROTATION The rotation pattern or procedure indicated in your limited warranty and vehicle manufacturer s owner s manual should be followed. If irregular wear becomes apparent or if the rate of wear on the tires is uneven, the tires should be inspected by a tire dealer. Check your vehicle for any equalize the rate of wear. See additional tire rotation information at the end of this pamphlet. TIRE MIXING CAN BE DANGEROUS: When tires need to be replaced, do not guess what tire is right for the vehicle. You must consult the tire placard, which is normally located on the vehicle door edge, door post, glove box or fuel placard, check the owner s manual or consult with the vehicle manufacturer or tire manufacturer. IMPORTANT: For more information on safety, visit and select Tire Safety. different size and construction. It is not always possible - usually due to temporary emergency conditions - to select the same tire size for a replacement tire. Never choose a smaller size The following is a passage from the RMA Replacement Guidelines for Passenger & Light Truck Tires manual. Manual & Supplement TIRE MIXING It is recommended that all four tires be of the same size, speed rating, and construction light truck sized tires on the same vehicle. If two radial tires and two non-radial tires must be used on a vehicle, put radials on the rear axle. If radial and non-radial tires are used on a vehicle equipped with dual rear tires, the radial tires may be used on either axle. Speed rated tires 1 tires, the replacement tires must have the same or higher speed rating to maintain vehicle speed capability 2. the vehicle s speed must be restricted to that of the replacement tire. Also, vehicle handling could be affected. Consult your dealer, the vehicle manufacturer or tire manufacturer for tire when the emergency is over. used, it is recommended that lower speed rated tires should always be placed on the front axle. This is to prevent a potential oversteer condition. 12

8 Safety Warnings Four-wheel drive (4WD) and All-wheel drive (AWD) vehicles - If no instructions for tire mixing appear in the vehicle owner s manual, follow these guidelines: o DO NOT mix tire sizes. All four tires must be marked with the same tire size, unless o DO NOT mix radial and non-radial tires. All four must be either radial or non-radial. o DO NOT mix tread pattern types such as all-terrain and all-season. Winter/Snow tires or unlawful manner. 3 APPLICATION OF WINTER/SNOW TIRES AND STUDDED WINTER/SNOW TIRES The initial movement and acceleration of any vehicle in winter or other adverse driving conditions are dependent on the traction available from the tires on the driving axle. However, the handling, cornering and braking of a vehicle after it is in motion, especially in any adverse weather conditions, are dependent on the traction from both the front and rear tires. The rear tires of any vehicle must have comparable or higher traction capabilities than the front tires in order to optimize vehicle mobility and control, especially during sudden maneuvers. Winter/Snow tires 1 including duals, to maintain vehicle mobility and control. traction qualities to the tires on the front axle, the vehicle may experience adverse handling characteristics. This may result in loss of vehicle control, which could cause serious injury or death. For more information on safety, visit and select Tire Safety. also be installed on the front axle. Studded Winter/Snow tires 2 most winter weather conditions. tires on the rear axle can cause adverse vehicle handling characteristics. This may result in loss of vehicle control, which could cause serious injury or death. tires are installed on all wheel positions of a vehicle will optimum handling characteristics be achieved. 1 2 REPLACING LESS THAN FOUR TIRES: When replacing tires on a vehicle, it is recommended and preferred that all four tires be replaced at the same time for continued optimal vehicle performance. However, for those emergency cases where this is not feasible, below are some general guidelines to consider when replacing less than four tires for a light vehicle, whether it is one or two tires. If the vehicle manufacturer has alternate recommendations, always follow their recommendations. IMPORTANT: replacing less than all four tires. Always check and follow the recommendations in the vehicle cause drive-train damage or mechanical malfunction. Safety Warnings Replacing Two (2) Tires - When a pair of replacement tires is selected in the same size and construction as those on the vehicle, the two newer tires should be installed on the rear axle more effectively, which is important as a driver approaches hydroplaning situations. Placing greater traction on the rear axle on wet surfaces is necessary to prevent possible oversteer condition and possible loss of vehicle control, especially during sudden maneuvers. Replacing One (1) Tire - Replacing a single tire on a vehicle can have an adverse affect on suspension systems, gear ratios, transmission, and tire treadwear. If single tire replacement is unavoidable, it is recommended that the single new tire be paired with the tire that has the deepest tread and both be placed on the rear axle. Placing greater traction on the rear axle on wet surfaces is necessary to prevent a possible oversteer condition and possible loss of vehicle control, especially during sudden maneuvers. TIRE ALTERATIONS ARE DANGEROUS Do not perform any alterations on your tires. Alterations may prevent proper performance, leading to tire damage, which can result in sudden tire destruction. Tires which have been altered are excluded from warranty coverage. REPAIRS SEE A TIRE DEALER AT ONCE Truck. If any tire has sustained a puncture, have the tire dismounted and inspected internally by a tire dealer for possible damage that may have occurred. Punctures in certain areas of the the use of both a plug and patch. Do not use externally-applied plug repairs. Although it is possible to properly repair many tires, repaired tires should be considered temporary and repaired tires should be replaced as soon as possible. For more information on safety, visit and select Tire Safety. PUNCTURE REPAIR PROCEDURES FOR PASSENGER AND LIGHT TRUCK TIRES FAILURE TO FOLLOW THE RMA RECOMMENDED PROCEDURES COULD LEAD TO SUDDEN TIRE FAILURE! Plug type repairs made from the outside of a tire, pressure sealants and blowout patches are repair is made, you are WARNED that the repair is temporary and that you must drive cautiously to the nearest full service tire facility for a proper repair. Driving on an improperly or temporarily repaired tire can lead to sudden tire failure, injury or death. NEVER PURCHASE A PASSENGER OR LIGHT TRUCK USED TIRE Consumers should be aware of possible serious risk associated with the installation and use of previously used tires. While tires are designed and built to provide many thousands of miles of excellent service, they must be maintained properly throughout their service life to achieve to abuse or improper service, poor maintenance, improper repairs, punctures, road hazards, or unsuitable storage conditions. Such damage can eventually lead to tire failure. Only the original owner of a new tire can know the full extent of a particular tire s service and maintenance, and

9 Safety Warnings Consumers should also be wary of used tires that: PLUS SIZING Manual & Supplement. characteristics: other than the OE is desired, always follow the vehicle manufacturers recommendations and consider the following: Aspect Ratio: Additional consideration should be made for substitute tires that are lower in as- but they provide a less comfortable ride. High performance, low aspect ratio tires may also wear Overall Diameter: Check to be sure that the overall diameter of all four tires is within the accepted tolerance of the vehicle manufacturer. tire placard to adequately carry the load. If so, the installer should inform the owner of the new For more information on safety, visit and select Tire Safety. Load Carrying Capacity: Speed Symbol/Category: capability is to be maintained. Rim Width/Off-Set: Rim/Wheel Selection: Vehicle Clearances: Steering tires must be checked in full left and right turns. All wheel positions should be checked for proper clearance in fender walls, brake components, shock towers, and other suspension components. These wheel positions must be checked for full suspension jounce and rebound. approved by the vehicle or tire manufacturer can adversely affect vehicle handling and stability. State/Local Laws: STORAGE Tires should be stored in a cool dry place indoors so there is no danger of water collecting inside them. Serious problems occur with tube-type tires when they are mounted with water trapped between the tire and the tube. Due to pressurization, the liquid can pass through the inner liner nature, encountered with tube type tires, have been due to improper storage which permitted water to enter the casing between the tire and tube prior to mounting. When tires are stored they should be stored in a cool dry place away from sources of heat stored are clean and free from grease, gasoline or other substances which could deteriorate the during storage may be weakened and subject to sudden failure. Safety Warnings DRIVING ON STUDDED PASSENGER TIRES WHERE LEGAL in handling and braking will not be realized. NEVER MOUNT STUDDED TIRES ON FRONT WHEELS ONLY. TIRE SPINNING IS DANGEROUS Excessive spinning can cause a tire to explode. Avoid tire spinning. The centrifugal forces created by a rapidly spinning tire can cause an explosion by tearing the tire apart. These forces act on the complete tire structure and can be of such magnitude as to break beads, as well as rupturing the entire carcass. When stuck on ice, snow, mud, or wet grass, etc., the vehicle should be rocked gently or directly ahead of or behind a spinning tire. result from the explosion of a spinning tire. SPEED RATED TIRES do not have speed ratings, the appropriate size tire with any speed rating may be applied for emergency use. When the placard tire size nomenclature contains a speed symbol, for example rating symbol if the speed capability of the vehicle is to be maintained. section, above. For more information on safety, visit and select Tire Safety. TIRE MOUNTING CAN BE DANGEROUS Tire mounting can be dangerous and should be done by trained persons using proper tools and procedures. Tire mounting done by an untrained person or using improper tools can lead to tire, bead and wheel damage. Your tires should be mounted on wheels which are in good, clean recommendations are followed. The inside of the tire must be free of foreign material. Never Old valves may leak. When new tubeless tires are mounted, have new valves of the correct tires require special tubes. Radial tubes should be used with radial tube-type tires. The use of other tubes not designed for radial tires will result in tube failure causing sudden tire destruction. Always use a new tube when mounting a new tube-type tire. Do NOT use tubes in Tubeless type tires. HIGH PERFORMANCE TIRES High performance tires are designed with stiff sidewalls for responsive it is important to be sure the top bead is in the rim well area during mounting. stresses on tire beads that are manner. Such stresses may cause damage to tire components and may result in tire failure.

10 TIRE SERVICE LIFE RECOMMENDATION: minimum or maximum service life for passenger and light truck tires. However, Cooper service life issue. Accordingly, Cooper recommends that all tires, including full-size spares, or more years old should be replaced even if the tires appear to be undamaged and have not conditions. This may be necessary even if the tire has not yet reached its tread wear limits. as an expected service life. Tires must be removed from service for several reasons, including In some cases a vehicle manufacturer may make a recommendation for tire replacement characteristics and application. If so, the consumer should follow those vehicle manufacturer s DOT description in the section titled The Sidewall Story. Safety Warnings Additional Safety Information For additional safety information visit: Rubber Manufacturers Association 1400 K. Street NW Ste. 900 Washington D.C NHTSA Headquarters 1200 New Jersey Ave. SE West Building Washington D.C National Safety Council 1121 Spring Lake Dr. Itasca, IL Tire ID# Consumer Name Claim/Line#C Purchase Date Adj. Date Mileage On Mileage Off Mileage Received Tire ID# Consumer Name Claim/Line#C Purchase Date Adj. Date Mileage On Mileage Off Mileage Received Tire ID# Consumer Name Claim/Line#C Purchase Date Adj. Date Mileage On Mileage Off Mileage Received Tire ID# Consumer Name Claim/Line#C Purchase Date Adj. Date Mileage On Mileage Off Mileage Received Tire ID# Consumer Name Claim/Line#C Purchase Date Adj. Date Mileage On Mileage Off Mileage Received

11 Tire Rotation Tire Mileage & 8,000 Mile Tire Rotation Record TIRE ROTATION There is a close working relationship between your tires and several mechanical systems in your vehicle. Tires, wheels, brakes, shock absorbers, drive train, steering and suspension systems must all function together smoothly to give you a comfortable ride and good tire mileage. All of whenever you have an indication of trouble. Proper tire maintenance includes the proper rotation of tires. Tires must be rotated at the rotation patterns. For safety purposes have your tires inspected by a tire professional every time they are rotated. Refer to your vehicle owner s manuals for rotation recommendations to your vehicle. Failure to rotate your tires within these requirements will void the mileage portion of your warranty. APPROVED TIRE ROTATION PATTERNS Date of Purchase Consumer Name Vehicle Year a matching full size tire as a spare and wish to include it in the rotation process, use the rotation pattern which applies to your vehicle but insert the spare in the right rear position. The tire that would normally have rotated to the right rear position should then become the spare. 19 NOTE: Non-radial tires must not be used in a rotation program.

12 Remember! TO AVOID DAMAGE TO YOUR TIRES AND POSSIBLE ACCIDENT: COOPER NATIONWIDE TIRE SERVICE INFORMATION This special warranty covers Cooper tires anywhere within the 48 contiguous continental United States and the District of Columbia. If you are traveling and have a tire problem, to learn the location of your nearest Cooper dealer, simply call us or For Customer Service assistance Note outboard sidewall of the tire. It is always just above the rim and preceded by the letters DOT, as shown in the photo below. An example of how to IMPORTANT In case of a recall, we can reach you only if we have your name and address. You MUST send in this card to be on our recall list. Do it today. DATE OF PURCHASE ADDRESS CUSTOMER S NAME (Please Print) CUSTOMER S ADDRESS CITY STATE ZIP CODE NAME OF DEALER WHICH SOLD TIRE OMB No Instead of mailing this form, you can register online at SHADED AREAS MUST BE FILLED IN BY SELLER TIRE IDENTIFICATION NUMBERS QTY P.O. BOX 550 FINDLAY, OHIO Visit Our Website at: DEALER S ADDRESS CITY STATE ZIP CODE 22

13 Dealer Copy IMPORTANT In case of a recall, we can reach you only if we have your name and address. You MUST send in this card to be on our recall list. Do it today. DATE OF PURCHASE ADDRESS OMB No Instead of mailing this form, you can register online at SHADED AREAS MUST BE FILLED IN BY SELLER TIRE IDENTIFICATION NUMBERS QTY CUSTOMER S NAME (Please Print) CUSTOMER S ADDRESS CITY STATE ZIP CODE NAME OF DEALER WHICH SOLD TIRE DEALER S ADDRESS CITY STATE ZIP CODE

14 Special Kit Available Air pressure gauge Tread depth gauge Four tire valve caps Protective plastic pouch FREE with proof of purchase Published in cooperation with: American Automobile Association American Petroleum Institute National Safety Council National Tire Dealers and Retreaders Association IMPORTANT: In case of recall, we can reach you only if we have your name and send in this card or register at to be on our recall list. IMPORTANT In case of a recall, we can reach you only if we have your name and address. You MUST send in this card to be on our recall list. Do it today. DATE OF PURCHASE ADDRESS CUSTOMER S NAME (Please Print) CUSTOMER S ADDRESS CITY STATE ZIP CODE NAME OF DEALER WHICH SOLD TIRE DEALER S ADDRESS Instead of mailing this form, you can register online at SHADED AREAS MUST BE FILLED IN BY SELLER OMB No TIRE IDENTIFICATION NUMBERS QTY Send Request to: COOPER TIRE SAFETY KIT, P.O. Box 235, Findlay, Ohio CITY STATE ZIP CODE

15 AFFIX POSTAGE STAMP COOPER TIRE & RUBBER COMPANY P.O. BOX 1000 FINDLAY, OHIO