Alvis 12/50 Maintenance - Schedule Date =
|
|
- Percival Holland
- 5 years ago
- Views:
Transcription
1 Weekly ,000 2,000 Annual 3,000 4,000 10,000 Ad Hoc 10 years AlvisMaintenanceSchedule-August of 9 Alvis 12/50 Maintenance - Schedule Date = Frequency < Frequency - assuming 2,000 miles per year in a six month period > <<< Other >>> TVAM - Chapter/Para reference!!! Tasks Mileage = Weekly Tyre pressures; write in your own pressures - Front = and Rear = , 10/Table 2 1 Battery - Routine checks miles Front Axle - King pins; several shots of grease every miles - 5.5b and lubrication chart ,000 miles Brakes - Brake cams; grease every 1,000 miles (or miles in the rain) - 5.5c and lubrication chart 1 1 Brakes - Rear brake camshafts; every 1,000 miles use Castrolease Medium b and lubrication chart 1 1 Brakes - Cross shaft; grease every 1,000 miles (or miles in the rain) - Lubrication chart 1 1 Clutch - Operating cross-shaft; grease every 1,000 miles - Lubrication chart 1 1 Clutch - Clutch withdrawal gear; grease every 1,000 miles (or miles in the rain) - Lubrication chart 1 1 Dynamo - Two drops of oil every 1,000 miles a, and lubrication chart 1 1 Magneto - Two drops of oil every 1,000 miles a, and lubrication chart 1 1 Road Springs - Grease shackle pins every 1,000 miles (or miles in the rain) - 4.5b and lubrication chart Starter - Two drops of oil every 1,000 miles a, and lubrication chart Steering - Track rod ends; grease every 1,000 miles (or miles in the rain) - 5.5c and lubrication chart 2,000 miles Engine - Change engine oil and clean gauze sump filter every 2,000 miles b, and lubrication chart 1 Engine - Change PRV filter , Gearbox - Check oil level every 2,000 miles and top up until oil reaches the upper bend of the swan neck to and lubrication chart 1 Gearbox - Use a multigrade oil such as Castrol 20/ Propellor shaft - Grease each end of shaft every 2,000 miles using Castrol LM c and lubrication chart 1 Rear Axle - Lubrication; use SAE 90 EP every 2,000 miles (I use 85/140) b & 7.14a and lubrication chart 1 Spark plugs - Adjust gaps every 2,000 miles b, , 17.12, Appendix 4/page 10 1 SU fuel pump - Clean pump filter every 2,000 miles or annually
2 Weekly ,000 2,000 Annual 3,000 4,000 10,000 Ad Hoc 10 years AlvisMaintenanceSchedule-August of 9 Alvis 12/50 Maintenance - Schedule Frequency <<< Frequency - assuming 2,000 miles per year in six months >>> <<< Other >>> Tasks TVAM - Chapter/Para reference!!! 3,000 miles Distributor - Lubricate every 3,000 miles and check points gap of 15 thou , Appendix 4/page 10 and lubrication chart (2,000) 1 Magneto - Clean and reset points to 12 thou every 3,000 miles (NB See below!) Spark plugs - Adjust gaps to 18 thou (Mag) or 25 thou (Coil) every 3,000 miles , , 17.12, , Appendix 4/page ,000 miles Engine - Adjust rocker clearances and check oil feed every 4,000 miles c, Appendix 4/page 9 1 Magneto - Check and adjust contact breaker points every 4,000 miles (NB See above!) c, , Appendix 4/page ,000 miles Engine - Top end overhaul every 10,000 miles d 1 Front Axle - Hubs; pack with grease every 10,000 miles - 5.5a and lubrication chart 1 Rear Axle - Rear wheel hubs; pack with grease every 10,000 miles c and lubrication chart 1 Annual Antifreeze - various discussions , 14.33, Appendix 4/page 10 1 Brakes - Adjustments; 2 inch * 2 inch block of wood between footbrake and footplate, annually Brakes - Balance Brakes - Efficiency Clutch - Set 3 clutch lever gaps on perimeter between lever and plunger to 15 thou; annually f, Appendix 4/page 10 1 Clutch - Clutch Pedal Lever gaps are 10 thou , Appendix 4/page 10 1 Coil Ignition timing , Appendix 4/page 10 1 Dynamo - Remove inspection cover annually and clean commutator Gearbox - Change oil every 10,000 miles or annually, whichever is less; capacity is 2 pints Magneto - Timing the magneto spark, 13.5 teeth BTDC and full manual advance , , , Appendix 4/page 10 1 Pre-MOT test - No longer obligatory, but an excellent annual health check - Appendix 1 1 Radiator - Drain and refill annually; use soft water , 14.35, 14.37/38 1 Rear Axle - Annual Inspection particularly Banjo Casing Breather Holes (7.17b) and various nuts Shock Absorbers - Check tension settings - 8/Table 1, Appendix 4/page 12 1 Shock Absorbers - Adjustment and Lightly grease wooden discs annually to 8.11, Starter - Remove inspection cover annually and clean commutator Steering - Steering box; fill to bottom of hole with SAE 90 or Penrite steering grease b and lubrication chart (Steering) 1 Steering - Steering wheel boss; few drop at top of column to lubricate the felt bush Upholstery - Treat with Hide Food annually Windscreen wipers - Oil electrical wipers occasionally a 1
3 Weekly ,000 2,000 Annual 3,000 4,000 10,000 Ad Hoc 10 years AlvisMaintenanceSchedule-August of 9 Alvis 12/50 Maintenance - Schedule Frequency <<< Frequency - assuming 2,000 miles per year in six months >>> <<< Other >>> Tasks TVAM - Chapter/Para reference!!! Ad Hoc Front Axle - Camber = 2.5 degrees , 5.24, 10.40, 10.42a and Appendix 4/page 12 1 Front Axle - Castor = 2 degrees , & and Appendix 4/page 12 1 Front Axle - King Pin inclination = 7.5 degrees c, 5.24, & 10.42b and Appendix 4/page 12 1 Front Axle - Toe-In = 1/8 inch - 5.8b, & and Appendix 4/page 12 1 Magneto - Maintenance and onwards 1 Radiator - Use soft water - (I use Halfords distilled )de-mineralised) water) , years Dynamo - Clean and check every 10 years !!! Brakes - Oil leakage on to rear brake shoes Engine - Oil capacity; maximum = 8 pints, recommended = 6 pints - Appendix 4/page 9 1 Magneto - Caveat on use of suppressors Maintenance tools - Brake shoe extractor etc , 1.65 Radiator - Overheating Rear Axle - Leakage on to brakes Solex - Check fuel level c 1 Solex - Carburettor settings; jet, cap, main, pilot, choke - Appendix 4/page 10 Spark plugs - Different chapters suggest setting gaps at 2,000, 3,000 or 5,000 miles *** see earlier comments on frequency of checking gaps 1 Starter - Check Tab washer on Bendix starter drive - the voice of experience! , Torque settings - Appendix 4/page 13 1 Other - 1 Other - 2 Other - 3 Other - 4 Other - 5
4 AlvisMaintenanceSchedule-August of 9 ALL TASKS
5 AlvisMaintenanceSchedule-August of MILES
6 AlvisMaintenanceSchedule-August of 9 1,000 MILES
7 AlvisMaintenanceSchedule-August of 9 2,000 MILES
8 AlvisMaintenanceSchedule-August of 9 STEERING
9 AlvisMaintenanceSchedule-August of 9 10,000 MILES
Alvis Six Maintenance - Schedule
AlvisMaintenanceSchedule- SIX- June- 23-2014.xlsx 1 of 9 Alvis Six Maintenance - Schedule Frequency < Frequency - assuming 2,000 miles per year in a six month period > > TVAM - Chapter/Para
More informationHillman Minx Maintenance Schedule
Hillman Minx Maintenance Schedule The maintenance schedule for most Series Minxes can be found as a large fold-out sheet, pasted inside the back cover of the Owner's Handbook. Series V and VI have a much
More informationlbs sq. Camshaft bush ID 0.5 ± Clearance bush to camshaft ±
GENERAL Cubic capacity 347 C.C. Stroke 93 mm. / 3.6614 Cylinder bore Compression ratio Max compression at kick starter speed 2 23 /32 = 2.7187 ± 0.0005 (Re-bore to + 0.02 when wear exceeds 0.008 ). Note:
More informationMG RV8 Maintenance Schedule
Action required at 6, 12 & 24 months page 6 12 24 3 Check engine & transmission Check for oil leaks from engine, gearbox & rear axle 3 Engine oil & filter Check oil level & top up Every 12 months or 20,000km
More informationSECTION O. LUBRICATION/MAINTENANCE. Section Description. Page No.
SECTION O. LUBRICATION/MAINTENANCE. Section Description. Page No. O.1. General Page 2 O.2. Periodic Services Page 2 O.3. Air Horns Lubrication Page 7 O.4. Recommended Lubricants Page 7 O.5. Exhaust Emission
More informationAUTO MECHANICS. PAPER 1: will consist of forty multiple-choice objective questions all of which are to be answered in 1 hour for 40 marks.
SCHEME OF EXAMINATION AUTO MECHANICS There will be three papers, Papers1, 2 and 3 all of which must be taken. Papers 1 and 2 shall be a composite paper to be taken at one sitting. PAPER 1: will consist
More informationSECTION O LUBRICATION AND MAINTENANCE. Section Description Page No. O.1 MAINTENANCE GENERAL 3 O.2 FREE AFTER SALES SERVICE (300 MILES) 3
SECTION O LUBRICATION AND MAINTENANCE Section Description Page No. O.1 MAINTENANCE GENERAL 3 O.2 FREE AFTER SALES SERVICE (300 MILES) 3 O.3 FREE AFTER SALES SERVICE (1,200 MILES) 4 O.4 'A ' SERVICE 5 O.5
More informationMotorcycle parts compatibility on ebay.co.uk
Motorcycle parts compatibility on ebay.co.uk Review the full list of categories and subcategories in which you can list motorcycle and scooter parts. Last updated: 10 August 2016 Motorcycle Parts (10063)
More informationBuilding Level Technology Issues
Session: Technology Is Great, But What if We Can t Manage It? Paul Kistler Naval Facilities Engineering And Expeditionary Warfare Center August 11, 2016 Rhode Island Convention Center Providence, Rhode
More informationA SYSTEMATIC SEQUENCE FOR PM INSPECTIONS
A SYSTEMATIC SEQUENCE FOR PM INSPECTIONS TYPE OF INSPECTION UNDER THE HOOD GASOLINE AND DIESEL 1 Fuel, oil, exhaust leaks - inspect 2 Oil and fuel lines inspect for kinks and wear 3 Automatic transmission
More informationService Schedule Chevrolet Utility
1. This Service Schedule will have preference over the Owner's Manual and Warranty & Service Guide 2. Refer to the Warranty and Service Guide for Severe Driving Conditions. 3. Consult the Owner/Customer
More informationTABLE OF CONTENTS: GEAR CHANGE LEVERS 108 GEAR CHANGE RUBBERS 108 GEARBOX BEARINGS 108 GEARBOX SPROCKETS GENERATOR SPARES 47-50
AIR FILTERS & HOSE 19-21 AIR LEVERS 143 ALLEN SCREW SETS 102 ALTERNATOR ROTOR 44 ALTERNATOR STATOR 44 AMMETERS 64 ANTISUMP VALVES 100 ARMATURES 47 AXLE SPINDLE CAPS 156 AXLES WHEEL SPINDLE 164 BADGES TANK
More informationCITROËN QUICK SERVICE FACTS
CITROËN QUICK SERVICE FACTS CITROEN QUICK SERVICE FACTS KNOW YOUR CITROËN-YOU'LL BE SEEING MORE 0F THIS REMARKABLE CAR CITROEN CARS CORPORATION, 300 PARK AVENUE, NEW YORK 22, NEW YORK 8423 WILSHIRE BOULEVARD,
More informationOliver 80 and 90 tractors
Oliver 80 and 90 tractors Important Notice This document has been put together using motor trader service data sheets produced in 1941 and other information of unknown origin saved by my father as a reference.
More informationSUBJECT CROSS-INDEX OF OCTAGON HEAVEN J2 TECHNICAL ARTICLES
SUBJECT CROSS-INDEX OF OCTAGON HEAVEN J2 TECHNICAL ARTICLES ACCELERATOR LINKAGE 107 Location on bulkhead AXLE, FRONT 13 Specifications 35 Steering angles 36 Toe-in 62 Heat treatment 134 Axle stop (buffer)
More information90 Y-12 Youth. Model Number A2005H4B2BUSR (Red) Model Number A2005H4B2BUSZ (Cat Green) Illustrated Parts Manual
90 Y-12 Youth Model Number A2005H4B2BUSR (Red) Model Number A2005H4B2BUSZ (Cat Green) Illustrated Parts Manual 2005 TABLE OF CONTENTS 2005 ATV 90 Y-12 Youth Red (Model No. A2005H4B2BUSR) Cat Green (Model
More informationSeabee Annual/100-Hour Inspection
Date Completed Seabee Annual/100-Hour Inspection ENGINE Mechanic s Initials 1 Drain engine oil and check for foreign material 2 Check oil screen for proper rotation or looseness 3 Safety Oil Plug 4 Refill
More informationTerraplane Hudson Six Hudson Eight FRONT AXLE
1936 Service Information and Adjustments Terraplane Terraplane Hudson Hudson 8 Hudson 8 Hudson 8 Hudson 8 Deluxe Custom Six Deluxe Custom Deluxe Custom ( 115 WB) (115 WB) (120 WB) (120 W B) (120 WB) (127
More informationMaintaining the Teledyne Bendix D-3200 series Magneto
Maintaining the Teledyne Bendix D-3200 series Magneto GENERAL: Good standard shop practices and safety precautions should be observed at all times to avoid injury to personnel and damage to equipment.
More informationVehicle and Engine Technology
Vehicle and Engine Technology Second Edition List of Chapters: Preface to the first edition Preface to the second edition 1 Vehicle body and chassis layout 1.1 The motor car 1.2 Commercial vehicles 1.3
More information2019 TECHNICAL REGULATIONS FOR THE HISTORIC PRODUCTION CAR GROUP 1 SALOON CARS (161684/144)
2019 TECHNICAL REGULATIONS FOR THE HISTORIC PRODUCTION CAR GROUP 1 SALOON CARS (161684/144) Permissions: With the exception of the under mentioned allowance, no other additions or modifications whatsoever
More informationSRT OPERATIONS MANUAL
MAINTENANCE SECTION PAGE # VEHICLE DAILY INSPECTION.......................................1 P.M. INSPECTION #1.................................................3 P.M. INSPECTION #2.................................................6
More informationMAINTENANCE SXV / RXV
MAINTENANCE SXV / RXV 450-550 3.1.12. HANDLEBAR AND CONTROLS Screw securing clutch control to handlebar M6 10 Throttle control screw M6 4 Ignition switch screw M8 24 FOOTRESTS Footrest support bracket
More informationATV 50 DVX BLACK-RED (A2008KSA2BUSD) Page 1 of 60 AIR INTAKE ASSEMBLY
2008 ATV 50 DVX BLACK-RED (A2008KSA2BUSD) Page 1 of 60 AIR INTAKE ASSEMBLY 2008 ATV 50 DVX BLACK-RED (A2008KSA2BUSD) Page 2 of 60 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3303-005
More informationG85CS Parts list. Frank Kyul, Netherlands
G85CS Parts list Frank Kyul, Netherlands http://home.wanadoo.nl/fxkuyl/ CYLINDER BARREL & HEAD 022298 Barrel Cylinder 1 022515 Washer Cylinder Base 1 015351 Nut. Sleeve Cylinder Head 4 042157 Washer Sleeve
More information1983 Mazda RX-7 GSL TUNE-UP' 'Mazda Rotary
TESTING ENGINE COMPRESSION The manufacturer recommends using a special compression tester (49 0820 280K). Compression testers for piston engines will read only the highest pressure of the 3 combustion
More informationBrief Technical Sheet
The Dorset Austin Seven Club A member of the Austin Seven Clubs Association (A7CA) Brief Technical Sheet In conjunction with GM Seven Services The Dorset Austin 7 Club was formed in 1976 as a club for
More informationNot for Reproduction ADVANCE PRODUCT SERVICE INFORMATION APSI NO: 101 DATE: AUGUST SERIES UTILITY ENGINE 130G00 OHV HORIZONTAL SHAFT
ADVANCE PRODUCT SERVICE INFORMATION APSI NO: 101 DATE: AUGUST 2014 SUBJECT: MODELS: 950 SERIES UTILITY ENGINE 130G00 OHV HORIZONTAL SHAFT This APSI provides basic servicing information in advance of the
More informationService Manual 344 & 384
Leyland Service Manual 344 & 384 Service Manual THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF LEYLAND OR IT S SUCCESSORS. LEYLAND AND IT S SUCCESSORS ARE NOT RESPONSIBLE FOR THE
More informationIllustrated Parts List Vanguard to Compliance
Non-Compliance Illustrated Parts List Vanguard Model Series 104700 to 104799 FORM MS-9878 7/93 REPLACES FORM MS-9878 5/92 FILE IN SECT. 2 OF SERVICE MANUAL 104700 to 104799 Compliance TYPE NUMBERS 0101,
More information615 Service Manual SERVICE MANUAL. 615 Series Axle
SERVICE MANUAL 615 Series Axle Issue 1 - February 2002 CONTENT: 1 INTRODUCTION... Page - 1-2 GENERAL DESCRIPTION... Page - 1-3 IDENTIFICATION... Page - 1-4 GENERAL SERVICE INFORMATION... 4.1 Routine Maintenance...
More informationATV 90 UTILITY GREEN (A2006KUB2BUSG) Page 1 of 60 AIR INTAKE ASSEMBLY
2006 ATV 90 UTILITY GREEN (A2006KUB2BUSG) Page 1 of 60 AIR INTAKE ASSEMBLY 2006 ATV 90 UTILITY GREEN (A2006KUB2BUSG) Page 2 of 60 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3303-005
More informationPart No. AJS & MATCHLESS SINGLE ENGINE - NEW PARTS Price (incl 17.5% VAT)
Part No. AJS & MATCHLESS SINGLE ENGINE - NEW PARTS Price (incl 17.5% VAT) Price (excl VAT) 000217 Nut for cylinder base stud, double hexagon 2.90 2.47 000300 Cylinder base stud 3.20 2.72 022516 Stud, cylinder,
More informationATV 90 UTILITY CALIFORNIA GREEN (A2008KUB2BCAG) Page 1 of 58 AIR INTAKE ASSEMBLY
2008 ATV 90 UTILITY CALIFORNIA GREEN (A2008KUB2BCAG) Page 1 of 58 AIR INTAKE ASSEMBLY 2008 ATV 90 UTILITY CALIFORNIA GREEN (A2008KUB2BCAG) Page 2 of 58 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description
More informationATV 300 DVX CAT GREEN (A2011KSF2BUSZ) Page 1 of 56 AIR INTAKE ASSEMBLY
2011 ATV 300 DVX CAT GREEN (A2011KSF2BUSZ) Page 1 of 56 AIR INTAKE ASSEMBLY 2011 ATV 300 DVX CAT GREEN (A2011KSF2BUSZ) Page 2 of 56 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3303-705
More informationPeriodic Lubrication and Attention
PERIODIC LUBRICATION AND ATTENTION. 13 CHAPTER II Periodic Lubrication and Attention LUBRICANTS RECOMMENDED Rolls-Royce Limited recommend a first quality oil of viscosity S.A.E. 30 for the engine and gearbox
More informationDVX 90 MODEL NUMBER A2008KSB2BUSD (BLACK-RED) MODEL NUMBER A2008KSB2BUSE (BLACK-CAT GREEN) MORE TO GO ON. TM
2008 DVX 90 Illustrated Parts Manual MODEL NUMBER A2008KSB2BUSD (BLACK-RED) MODEL NUMBER A2008KSB2BUSE (BLACK-CAT GREEN) MORE TO GO ON. TM TABLE OF CONTENTS Black-Red (Model No. A2008KSB2BUSD) Black-Cat
More informationSECTION 1 - CHASSIS 1.1 CHASSIS FRAME
5TH CATEGORY - HISTORIC RACING GROUP Nb APPROVED VEHICLE SPECIFICATION This form details the approved specifications of individual vehicle models in the 5th Category Historic car group. To be issued with
More informationGENTRY RESTORATIONS LTD Physical Stock Worksheet 20 June 2017
Gentry Restorations Parts Price List - 22/11/2018 Terms and Conditions - Please Read Carefully All part numbers, descriptions and pricing of products were believed to be correct at the time this document
More informationRELIANT REBEL 700 & 750
RELIANT REBEL 700 & 750 Saloon, Estate and Van Workshop Manual The Reliant Motor Company Limited July 1967 Remastered June 2012 by Atodini Page 1 Introduction This Workshop Manual contains all the relevant
More informationPRICE LIST. Rolls-Royce & Bentley Spare Parts
PRICE LIST Rolls-Royce & Bentley Spare Parts This is a list of stock currently held, most of which are genuine parts and where it becomes necessary to manufacture replacement items, we employ in most cases
More informationRiley Club Used Spares Stocktake 30/06/2012. Index. Page
Index Page A Engine 2 B Fuel and Induction 3 C Ignition 4 D Cooling System 5 E Clutch 6 F Gearbox 7 H Rear Axle and Drive Train 8 K Front Susp & Steering 9 M Brakes 10 N Electrical 11 R Body 12 T Wheels
More information20. Install and tighten the cap screws that hold the end frame and field frame together
4006-30 19. Fill the oil reservoir in the bearing bore of the end frame with SAE 10 engine oil. Then put the the end frame on the armature shaft. Align the marks on the end frame and field frame and push
More informationX4 (GREEN) (A2000ATF2AUSG) Page 1 of 80 AIR INTAKE ASSEMBLY
2000 300 2X4 (GREEN) (A2000ATF2AUSG) Page 1 of 80 AIR INTAKE ASSEMBLY 2000 300 2X4 (GREEN) (A2000ATF2AUSG) Page 2 of 80 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3570-001 1 /P Intake,
More informationReplacement parts to fit FORD ALPHABETICAL INDEX
ALPHABETICAL INDEX A Adaptor, Hydraulic, 247, 249 to 250 Adaptor, PTO Shaft, 210 Air Cleaner, 157 to 158 Bowl, 157 Door, 273 Gasket, 159 Hose, 159 Spring, 158 Tube, 158 Air Conditioning Compressors, 282
More informationIllustrated Parts List. Model Series TYPE NUMBERS 0001 THROUGH TABLE OF CONTENTS
Illustrated Parts List Model Series 100800 TYPE NUMBERS 0001 THROUGH 3136. TABLE OF CONTENTS FORM MS10086 REV R 09/30/2015 REPLACES FORM MS10086 REV P 05/15/2014 FILE IN SECT. 2 OF SERVICE MANUAL 100800
More informationD-1: FAN COVER. DESCRIPTION 1 Asm., Shroud, Upper
D-: FAN COVER Asm., Shroud, Upper 9639-000 Screw, Tappinmg 9390-305068-00K 3 Clamp 9689-000 Plug, Rubber 96339-000 5 Elbow, Outlet 9650-000 6 Bolt 96000-06058-08C 3 7 Cover Set, Fly Wheel 9609-00 8 Cap
More informationPERIODIC MAINTENANCE SCHEDULE (months or km whichever occurs earlier)
PERIODIC SCHEDULE (months or km whichever occurs earlier) Period 1 month 3 months 6 months 9 months 1 months 15 months Item Km 500-750 500-3000 5000-6000 8500-9000 11500-1000 1500-15000 Engine cum transmission
More informationSERVICE DATA Date: August 1, 2007
SERVICE DATA Date: August 1, 2007 Model: LT-A450XK8 VALVE + VALVE GUIDE Valve diam. 30.6 IN. (1.20) EX. 27.0 (1.06) Tappet clearance (when cold) 0.05 0.10 IN. (0.002 0.004) EX. 0.17 0.22 (0.007 0.009)
More information00-36A-04 CS-350T, CS-350TES, CS-350WES 1
00-36A-04,, 1 0 INTRODUCTION We are constantly working on technical improvement of our products. For this reason, technical data, equipment and design are subject to change without notice. All specifications,
More informationDVX 300 Euro. Model Number A2012KSF2BEUK SHARE OUR PASSION.
ATV 2012ATV Illustrated Parts Manual DVX 300 Euro Model Number A2012KSF2BEUK TM SHARE OUR PASSION. TABLE OF CONTENTS 2012 ATV DVX 300 Euro (Model No. A2012KSF2BEUK) BODY PANEL AND HEADLIGHT ASSEMBLY...
More information11/14/ U. Baja Motorsports Inc. P.O. Box Phoenix, AZ Toll Free: PARTS AND PRICES ARE SUBJECT TO CHANGE 1 of 53
250U Toll Free: 888-863-2252 PARTS AND PRICES ARE SUBJECT TO CHANGE 1 of 53 FIG. 1 PNEUMATIC MECHANISM 1-1 250U-100 883099019951 CAMSHAFT 1 1 1-2 250U-101 883099019968 KEY, WOODRUFF 1 1 1-3 250U-102 883099019975
More informationBSA Goldstar Parts - Price List Feb Exhaust Lifter Cable Exhaust Lifter Cable Holder S/S 9.00
Rocker Boxes 65-1137 Exhaust Lifter Cable 15.00 65-1163 Exhaust Lifter Cable Holder S/S 9.00 2-443 Exhaust Lifter Cable Holder Nut S/S 0.50 65-401 Exhaust Lifter Spindle Felt 2.00 65-387 Exhaust Lifter
More informationHudson-Essex. Service Manual Supplement. Hudson Cars 750,001 up
1 9 2 6 Hudson-Essex Service Manual 1927 Supplement Hudson Cars 750,001 up Hudson Rear Axle (Cars numbered 750,001 and upward) Brakes (Cars numbered 750,001 and upward) See page 18 Transmission Group
More informationFirst Edition Quality Parts & Service
First Edition 190.869 2 Van Gestel B&C 2013 Engine Parts Gaskets Bearings 016.133 Head gasket set 016.134 Conversion gasket set 016.135 Head gasket 016.136 Gasket, inlet rocker cover 016.137 Gasket, exhaust
More informationALL YOU SOURCE FROM NEED FOR SINGLE POINT COMMERCIAL VEHICLES
ALL YOU NEED FOR COMMERCIAL VEHICLES SOURCE FROM SINGLE POINT PRIVILEGE OF SUPPLYING ALL NEEDS FOR COMMERCIAL VEHICLES FROM A SINGLE POINT WITH RANTECH! RANTECH offers its partners a business model which
More informationATV 50 Y-6 YOUTH CAT GREEN (A2004ATA2BUSZ) Page 1 of 50 A-ARM, FLOOR PANEL, AND BUMPER ASSEMBLY
2004 ATV 50 Y-6 YOUTH CAT GREEN (A2004ATA2BUSZ) Page 1 of 50 A-ARM, FLOOR PANEL, AND BUMPER ASSEMBLY 2004 ATV 50 Y-6 YOUTH CAT GREEN (A2004ATA2BUSZ) Page 2 of 50 A-ARM, FLOOR PANEL, AND BUMPER ASSEMBLY
More informationLilac LS-18 Motorcycle Maintenance Standards Chart English Translation
Lilac LS-18 Motorcycle Maintenance Standards Chart English Translation The original of this manual was produced only in Japanese. The Marusho/Lilac Register has enlisted the assistance of Mr. Michimasa
More informationSUPER MULTIPLE JUNCTION (SMJ) Installation
Installation SUPER MULTIPLE JUNCTION (SMJ) Installation NEEL0146 To install SMJ, tighten bolts until orange fulltight mark appears and then retighten to specified torque as required. :3-5N m (0.3-0.5 kg-m,
More information5TH CATEGORY - HISTORIC RACING. GROUP Nb APPROVED VEHICLE SPECIFICATION
5TH CATEGORY - HISTORIC RACING GROUP Nb APPROVED VEHICLE SPECIFICATION This form details the approved specifications of individual vehicle models in the 5th Category Historic car group. To be issued with
More informationCYLINDER. Ref. Part No. Number Description Qty Remarks
A1 CYLINDER 1 J38-11102-00-00 CYLINDER HEAD ASSEMBLY. 1 2 J38-11133-09-00. GUIDE, INTAKE VALVE..... 2 3 99510-12016-00 PIN, DOWEL.............. 2 4 95811-08070-00 BOLT, FLANGE............ 3 5 95811-08045-00
More informationSeabee Annual Inspection Procedures
Procedures Due to the wide variety of Seabee s flying out there, these procedures should be modified to fit YOUR Seabee. Make sure that all AD s are complied with as well as any required Service Bulletins
More information5TH CATEGORY - HISTORIC RACING. GROUP Nc APPROVED VEHICLE SPECIFICATION
5TH CATEGORY - HISTORIC RACING GROUP Nc APPROVED VEHICLE SPECIFICATION This form details the approved specifications of individual vehicle models in the 5th Category Historic car group. To be issued with
More informationENGINE - V8. Seal - crankshaft - rear. Refit 1. Ensure both seal location and running surface on crankshaft are clean.
REPAIRS Seal - crankshaft - rear 1. Ensure both seal location and running surface on crankshaft are clean. 1. Automatic gearbox models: converter drive plate. ENGINE - V8, REPAIRS, Plate - drive - automatic.
More informationIllustrated Parts Manual. Model Number A2011KSF2BEUZ (Black-Cat Green) A2011KSF2BEOJ (White-Cat Green)
Illustrated Parts Manual 2 1 10 DVX 300 Euro Model Number A2011KSF2BEUZ (Black-Cat Green) A2011KSF2BEOJ (White-Cat Green) S H A R E O U R PAS S IO N. TM TABLE OF CONTENTS 2011 ATV DVX 300 Euro Black-Cat
More information5TH CATEGORY - HISTORIC RACING. GROUP Nc APPROVED VEHICLE SPECIFICATION
5TH CATEGORY - HISTORIC RACING GROUP Nc APPROVED VEHICLE SPECIFICATION This form details the approved specifications of individual vehicle models in the 5th Category Historic car group. To be issued with
More information3. INSPECTION/ADJUSTMENT
3 SERVICE INFORMATION...3-0 FINAL REDUCTION GEAR OIL...3-7 MAINTENANCE SCHEDULE...3-2 DRIVE BELT...3-7 FUEL FILTER...3-3 BRAKE SHOE...3-8 THROTTLE OPERATION...3-3 BRAKE ADJUSTING NUT...3-8 AIR CLEANER...3-4
More information5TH CATEGORY - HISTORIC RACING. GROUP Nb APPROVED VEHICLE SPECIFICATION
5TH CATEGORY - HISTORIC RACING GROUP Nb APPROVED VEHICLE SPECIFICATION This form details the approved specifications of individual vehicle models in the 5th Category Historic car group. To be issued with
More informationSECTION 9 CRANKING SYSTEM CONTENTS
SECTION 9 CRANKING SYSTEM CONTENTS 9-1. 9-2. 9-3. 9-4. 9-5. 9-6. 9-7. 9-8. GENERAL DESCRIPTION.,...,..., 9-2 SPECIFICATIONS.......................................... 9-4 LUBRICATION 9-5 REMOVAL AND INSTALLATION...
More informationBikeSelection ML100-A ML125-7 LF150-7 LF250GY-4 ML200-16D ML250-4 ML200ZH-3
M EILUN M OTORCYCLE PARTS ML200-16D 2018Edition BikeSelection ML100-A LF110-7A LF1200DT ML125-5 ML125-7 ML125T-26 LF150-7 LF150GY-3B LF200GY-4 LF250GY-4 LF150-10F LF150-10S ML200-16D ML250-4 ML200ZH-3
More informationTC Maintenance & Safety Check
TC Maintenance & Safety Check TC MAINTENANCE AND SAFETY CHECK Do-It-Yourself Mechanical Checks (As of August 27, 2005) This list was originally assembled by Mike Goodman with the TC Motoring Guild in 1993.
More informationDEPARTMENT OF THE ARMY TECHNICAL MANUAL TECHNICAL MANUAL OPERATOR AND ORGANIZATIONAL MAINTENANCE MANUAL TRUCK, LIFT, FORK, POWER SHIFT G.E.D.
TM 10-3930-624-12 DEPARTMENT OF THE ARMY TECHNICAL MANUAL TECHNICAL MANUAL OPERATOR AND ORGANIZATIONAL MAINTENANCE MANUAL TRUCK, LIFT, FORK, POWER SHIFT G.E.D., 6,000 LB CAPACITY, SRT. 180 IN. LIFT (ALLIS
More informationIllustrated Parts List. Model Series TYPE NUMBERS 0001 THROUGH TABLE OF CONTENTS
Illustrated Parts List Model Series 100800 TYPE NUMBERS 0001 THROUGH 3136. TABLE OF CONTENTS FORM MS10086 REV S 03/24/2016 REPLACES FORM MS10086 REV R 09/30/2015 FILE IN SECT. 2 OF SERVICE MANUAL 100800
More informationB B B
FIG CYLINDER Suzuki Worldwide Motorcycle-ATV Page: of -0B00-00 0-00 0-000 0-00 0-0B0-0B0 0-0 0-0 Head, Cylinder Gasket, Cylinder Head Spark Plug (ngk,bphs) Spark Plug (nd,wfp-u) Cylinder Gasket, Cylinder
More informationTHE VINTAGE AUSTIN REGISTER LIMITED SPARES LIST, FEBRUARY
THE VINTAGE AUSTIN REGISTER LIMITED SPARES LIST, FEBRUARY 2018 Steven Newton, Spares Secretary, Tel: 01332 834003 Parts are of new manufacture, and Items are priced individually, unless shown otherwise
More informationIllustrated Parts List
FORM MS 56 08/11/2004 REPLACES FORM MS 56 11/14/2002 FILE IN SECT. 2 OF SERVICE MANUAL 312700 Illustrated Parts List Model Series 312700 TYPE NUMBERS 0101 through 01. TABLE OF CONTENTS Air Cleaner.........................
More information1950 Pacemaker. Specifications & Adjustments
Specifications & Adjustments Specifications & Adjustments ENGINE: Valve Arrangement Bore and Stroke Piston Displacement Maximum Torque Horsepower Actual Taxable Compression Ratio: Cast Iron Head (Std.)
More informationUpdated September DISCOUNT TRACTOR PARTS PH Aidrie Rd, Box Ranui, Auckland
FERGUSON FE 35 Petrol Engine Models Parts catalogue and price list Updated September 2011 DISCOUNT TRACTOR PARTS PH 0800 872272 7 Aidrie Rd, Box 70059 Ranui, Auckland Ph 09 8337483 Fax 09 8335186 E mail
More informationIllustrated Parts List. Direct Overhead Valve TYPE NUMBERS 0111, TABLE OF CONTENTS. Air Cleaner... 4 Blower Housing/Shroud...
Illustrated Parts List 090600 Direct Overhead Valve TYPE NUMBERS 0111, 0113. TABLE OF CONTENTS Air Cleaner... 4 Blower Housing/Shroud... 5 Brake... 6 Cam Gear... 2 Carburetor... 3 Carburetor Overhaul Kit...
More informationGear change & shift cables Gearchange balljoints and bushes. Globes 12 and 24 volt Grilles
A Accessories Air Bags Air compressor assembly and components Air conditioner idler pulleys and condensers Air dryer assemblies and repair kits Air filter elements Air master assembly and repair kits Air
More informationPage 1 of HP B&S Vanguard Engine
1405 Page 1 of 41 14 HP B&S Vanguard Engine 1405 Page 2 of 41 14 HP B&S Vanguard Engine Ref # Part Number Qty S/P/F Description BS-28Q777-0647-E1 1 14 HP B&S Vanguard Engine 1 BS-496412 1 Cylinder Assembly
More informationIllustrated Parts List
01/08/2010 FILE IN SECT. 2 OF SERVICE MANUAL PRO DRIVE 613777-0113 -E1 Illustrated Parts List Model Series AIR COOLED 613777 TYPE NUMBERS 0113. TABLE OF CONTENTS Air Cleaner... Alternator... Blower Housing/Shrouds...
More informationSno Pro 120. Model Number S2012ACAAAUSG SHARE OUR PASSION.
2012Snowmobile Illustrated Parts Manual Sno Pro 120 Model Number S2012ACAAAUSG TM SHARE OUR PASSION. TABLE OF CONTENTS 2012 Sno Pro 120 (Model No. S2012ACAAAUSG) SKI AND SPINDLE ASSEMBLY... 1 A-ARM ASSEMBLY...
More informationSTEERING SYSTEM Introduction
STEERING SYSTEM Introduction The steering makes it possible to change direction. The steering must be reliable and safe; there must not be too much play in the steering. It must be possible to steer accurately.
More informationIllustrated Parts List
FORM MS 3745 12/21/2006 FILE IN SECT. 2 OF SERVICE MANUAL 613700 Illustrated Parts List Model Series 613700 TYPE NUMBERS 0110. TABLE OF CONTENTS Air Cleaner......................... 6 Alternator..........................
More informationPOST-REBUILD PREPARATIONS AND START-UP PROCEDURE FOR INDIAN WARRIOR
POST-REBUILD PREPARATIONS AND START-UP PROCEDURE FOR INDIAN WARRIOR This procedure assumes the engine and gearbox are assembled properly and with assembly lube, installed in the bike frame, the electrical
More information3400, 3500, 3550, 4400, 4500, 5500, & 5550 Volume 1 of 5
Ford Service Manual 3400, 3500, 3550, 4400, 4500, 5500, & 5550 Volume 1 of 5 Service Manual THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF FORD OR IT S SUCCESSORS. FORD AND IT
More informationIllustrated Parts List 28N700
FORM MS 0148 09/14/2004 REPLACES FORM MS 0148 4C 12/1/2003 FILE IN SECT. 2 OF SERVICE MANUAL Illustrated Parts List Model Series TYPE NUMBERS 0026 through 1205. TABLE OF CONTENTS Air Cleaner.........................
More informationSERVICE MANUAL ALLARD MOTOR COMPANY LTD 24/28 CLAPHAM HIGH STREET CLAPHAM, LONDON S.W.4 PUBLISHED 1953
SERVICE MANUAL ALLARD MOTOR COMPANY LTD 24/28 CLAPHAM HIGH STREET CLAPHAM, LONDON S.W.4 PUBLISHED 1953 This manual has been reproduced from an original copy using an Optical Character Recognition (OCR)
More informationBristol 2 Litre Top End Parts List
February 2018 Edition Bristol 2 Litre Top End Parts List Cylinder Head Valve Operating Dynamo Starter Distributor Solex Carbs Fuel Pump Engine Type 85, 100, 110 Original Bristol part numbers are used for
More informationSERVICE MANUAL. 915 Series Axle
SERVICE MANUAL 915 Series Axle Issue 1 September 2003 CONTENT: 1 INTRODUCTION Page 3-2 GENERAL DESCRIPTION Page 3-3 IDENTIFICATION Page 3-4 GENERAL SERVICE INFORMATION Page 5 -.1 4.1 Routine Maintenance
More informationSERVICE DATA. CS-310 (Serial number : ) (Serial number : ) CHAIN SAW 01-30A-00 CS CONTENTS INTRODUCTION
01-30A-00 CS-310 1 0 SERVICE DATA CHAIN SAW CS-310 (Serial number : 11000001-11999999) (Serial number : 12000001-12999999) INTRODUCTION We are constantly working on technical improvement of our products.
More informationAT2403 VEHICLE MAINTENANCE
AT2403 VEHICLE MAINTENANCE UNIT I MAINTENANCE OF RECORDS AND SCHEDULES 1. Why daily maintenance is required for a vehicle? (Nov 2012) 2. State the importance of Job card. (Nov 2012) 3. What are the safety
More information3. INSPECTION/ADJUSTMENT
SERVICE INFORMATION...3-0 FINAL REDUCTION GEAR OIL...3-7 MAINTENANCE SCHEDULE...3-2 DRIVE BELT...3-7 FUEL FILTER...3-3 BRAKE SHOE...3-8 THROTTLE OPERATION...3-3 BRAKE ADJUSTING NUT...3-8 AIR CLEANER...3-4
More informationCYLINDER. Ref. Part No. Number Description Qty Remarks
A1 A2 A3 A4 CYLINDER 1 2GU-11111-00-00 HEAD, CYLINDER 1......... 1 2 NGK-B8ES0-00-00 PLUG, SPARK (NGK B8ES)... 2 3 90116-08394-00 BOLT, STUD.............. 8 4 95917-08640-00 BOLT, STUD.............. 2
More informationPart No. Part No. Part No. Part No. Part No. Description
Model T Tool List Part No. Part No. Part No. Part No. Part No. Description L4681 Lug nut speed wrench - Walden Worchester T1243 Headlight rim removal tool T1349 Hub cap wrench T1387 Adjustable wrench T1902
More informationBriggs & Stratton Illustrated Parts List Model Series Manual Free Download from
Briggs & Stratton Illustrated Parts List Model Series 92200 Manual Free Download from www.allotment-garden.org FORM MS 0523 06/03/2008 REPLACES FORM MS 0523 04/15/2008 FILE IN SECT. 2 OF SERVICE MANUAL
More informationMGA Gearbox Conversion Kit. Fitting Instructions
MGA Gearbox Conversion Kit Fitting Instructions KIT CONTENTS Mazda MX-5 5 Speed Transmission: Vitesse Gearbox Case Vitesse Bellhousing Vitesse Machined Front Plate Modified rear case to accept Mazda mechanical
More informationIllustrated Parts List
FORM MS 4183 10/31/2006 REPLACES FORM MS 9748 7/1997 FILE IN SECT. 2 OF SERVICE MANUAL 290700 Illustrated Parts List Model Series 290700 TYPE NUMBERS 0100, 0102, 0106, 0107, 0108, 0333, 0402, 0410. TO
More information550 & 555 Tractor, Loader & Backhoe Volume 1 of 2
Ford Service Manual 550 & 555 Tractor, Loader & Backhoe Volume 1 of 2 Service Manual THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF FORD OR IT S SUCCESSORS. FORD AND IT S SUCCESSORS
More information