Equipment Maintenance

Size: px
Start display at page:

Download "Equipment Maintenance"

Transcription

1 with Notes Equipment# = 65 Kuesel Excavating Co Inc C CAT 11, /09/ hr service Walt Change engine oili and filter Fuel filters Replace batteries 09/28/2017 Repair Changed out Lights Misc Repair 09/27/2017 Service Changed Oil Changed Fuel Filters Changed Air Filter Fixed Grease Zerts and Greased Worked on shifting Linkage Misc Repair 08/21/2017 Repair Rebuild tilt cylinder R&R bucket segment plates 02/08/ hr service hr service Dane Pogrelis All the filters All the fluids Report [Private] Page 1

2 01/30/2017 Repair Repair door handles and latches R&R bucket teeth 11/23/2016 repair Jerry Huber replace pedal shafts and bearings Calibrate transmission and install belly pand 07/30/2016 undercarriage Note We are going to sell after 3-4k hours on machine R&R track tension cyl. seals R&R equalizer bar bearings/pins R&R trunion seal R&R rails, pads, rollers, idlers, & sprockets 01/07/ hr service Replaced engine oil & filter, 2 fuel filters, primary air filter 11/10/2015 repair install belly pans & shields 10/28/2015 repair Install cab,weld wear plates on bottom of bucket. R&R teeth, blow radiator, tighten belts 01/21/2015 sprochet segments replaced sprochet segments 01/21/ hr service replaced 10wt in hydraulic compartment and splitter box compartment 08/14/2014 service replaced oil filter and 3-fuel filters 01/09/ hour service replaced oil filter--2- fuel filters-water separator -hydraulic filter-2- transmission filters and primary air filter 03/27/2013 repair replaced parking brake switch and transmission pressure switch Report [Private] Page 2

3 01/11/ hour service replaced oil filter--2-fuel filter--water separator--3- hydraulic filters and primary air filter 09/14/2012 service replaced oil filter and 3- fuel filters 02/22/2012 repair replaced front engine oil seal and fitting on hydraulic pump----daryl 02/03/2012 repair resealed both tilt cylinders 02/03/2012 sprochet segments replaced sprochet segments 02/03/ hour service replaced 10wt in hydraulic compartment and splitter box compartment 09/20/2011 service replaced oil filter--2- fuel filter and water separator 09/11/2011 starter replaced starter----warranty 08/16/2011 radiator S&S Radiator cleaned and boiled out radiator 08/16/2011 rebuilt engine Engine Rebuilders rebuilt engine----replaced all fuel injectors--replaced muffler-radiator hoses--heater hoses--outside splitter box seal--fan and water pump belts 06/20/2011 starter replaced starter 05/26/2011 service replaced oil filter--2- fuel filters--water separator 02/22/2011 repair replaced all fan pulleys and belts replaced front engine seal replaced front engine cover gasket--- side plate gaskets--valve cover gasket line-bored lower bucket pin holes---new pins--bushings and seals Report [Private] Page 3

4 02/22/2011 water pump replaced water pump 11/29/2010 service replaced oil filter---2- fuel filters--water separator and primary air filter 05/18/2010 service replaced oil filter---2- fuel filters and water separator 03/04/2010 repair replaced right front idler with fabick rebuilt 01/22/ hour service replaced 10wt in hydraulic compartment and splitter box compartment 10/05/2009 batteries replaced 2- batteries ( Wholesale ) 10/01/2009 repair Quality Hydostatics resealed 2- drive pumps and replaced shafts and seals in hydraulic lift pump ( 3 pumps total ) replaced 4- drive motor hoses replaced bearings and seals in splitter box 08/11/ hour service replaced oil filter--2- fuel filters--water separator--3- hydraulic filters and primary air filter 05/08/2009 service replaced oil filter --2- fuel filters and water separator 02/04/2009 repair rebuilt loader bucket tilt cylinder replaced ignition switch 02/04/ hour service replaced oil filter--2- fuel filters--water separator--3- hydraulic filters and primary air filter replaced 10wt in hydraulic--splitter box compartments 10/22/2008 service replaced oil filter--2- fuel filters and water separator 07/25/ hour service Report [Private] Page 4

5 04/16/2008 service replaced oil filter--2- fuel filter and water separator 02/01/2008 repair replaced fan belts--water pump belt and water pump idler pulley 02/01/ hour service replaced oil filter--2- fuel filters--water separator--3- hydraulic/transmission filters---primary and secondary air filters replaced 10wt in transmission/hydraulic compartment replaced 10wt in splitter box compartment replaced 50wt in right and left final drive compartment 11/08/2007 service replaced oil filter--water separator--2- fuel filters 08/24/2007 repair recalibrate transmission replaced right corner shank and replaced all teeth 07/18/ hour service replaced oil filter---2- fuel filters--water separator--2- hydraulic filters--transmission filter and primary air filter 05/09/2007 service replaced oil filter--replaced 2- fuel filters and water separator 01/25/ hour service replaced oil filter--2- fuel filters--water separator--2--hydraulic filters--transmission filter replaced 10wt in hydraulic tank and splitter box replaced 50wt in final drives 11/02/2006 repair replaced hydraulic pump----replaced 2-hydraulic filters and transmission filter 11/02/2006 repair replaced oil filter--2- fuel filters--coolant filter 09/28/2006 undercarriage replaced rails--rollers--pads--sprocket segments rebuilt both final drives rebuilt both idlers--replaced lower pivot pin on the idler arm on each side ( 2 per side ) rebuilt both grease cylinders with new seals and bushings---replaced outer 1/2 of each grease cylinder 07/17/ hour service replaced oil filter--2 fuel filters-water separator--2 hydraulic filters--transmission filter Report [Private] Page 5

6 05/07/2006 service replaced oil filter/2-fuel filters and water separator 03/01/2006 repair replaced exhaust manifold and retapped bolt holes--replaced turbo, coupler and clamp--replaced bucket segments and welded wear strips on bottom of bucket 02/13/2006 repair replaced alternator---replaced muffler---replaced 2 fan belts--replaced 1 water pump belt 01/26/ hour service replaced 2-fuel filters, replaced oil filter, repaced hydraulic filter, replaced 2-transmission filters, and replaced primary air fiter.replaced 10wt in transmission and hydraulic compartments--replaced 50wt in final drive compartment--replaced 15w-40 in the splitter box service performed by Walt---replaced back up alarm 10/26/2005 fuel / oil filters /12/2005 fuel / oil / trans / hydr filters hour - BS 06/09/2005 repair resealed right / left final drives 05/26/2005 fuel / oil filters /14/2005 repair repaired oil pressure sending unit 02/05/2005 fuel / oil / trans / hydr filters hour - walt / changed oil in splitter box - 10w-40 11/04/2004 fuel / oil filters /23/2004 fuel / oil / trans / hydr filters /28/2004 repair service work by faibik - replaced drive motor / left track motor 04/20/2004 fuel / oil filters /25/2004 repair product improvement done by faibik - replaced new implement relief valve 02/11/2004 repair put 10wt in splitter box / replaced 2 fan belts & 1 water pump belt / replaced hydraulic pump & 1 suction hose Report [Private] Page 6

7 02/04/2004 fuel / oil / hydraul filters Report [Private] Page 7 of 7

Township Road 262 Millersburg, OH Toll Free. Local.

Township Road 262 Millersburg, OH Toll Free. Local. New Manufacturing Facility 2008 Dealer Catalog Toll Free 877.774.0081 Local 330.674.0081 www.paintvalleyequipment.com 10550 Township Road 262 Millersburg, OH 44654 Fax 330.674.4031 www.paintvalleyequipment.com

More information

Parts Manual. 450C & 455C Crawler

Parts Manual. 450C & 455C Crawler J.I. Case Parts Manual 450C & 455C Crawler Parts Manual THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF J.I. CASE OR IT S SUCCESSORS. J.I. CASE AND IT S SUCCESSORS ARE NOT RESPONSIBLE

More information

ENGINE 3116 PRODUCT RANGE

ENGINE 3116 PRODUCT RANGE ENGINE 3116 PRODUCT RANGE Part No. 1005864 TURBOCHARGER 1005865 TURBOCHARGER Description 1005991 CARTRIDGE, TURBO 1005992 CARTRIDGE, TURBO 1006298 CAMSHAFT AS 1006915 CARTRIDGE, TURBO 1006916 CARTRIDGE,

More information

2000 Nissan Altima SE

2000 Nissan Altima SE Removal 1. Release fuel pressure. See FUEL PRESSURE RELEASE. Drain coolant from radiator and cylinder block. Drain engine oil. Disconnect all necessary coolant hoses, electrical connectors, vacuum hoses,

More information

Complete Component Catalog

Complete Component Catalog Complete Component Catalog Valuepart for the Best in Quality Valuepart is committed to providing customers with the Highest Quality products available in the industry. Rigid Quality and Application standards

More information

TRACK LOADERS. Inspector: MWK Inspection #

TRACK LOADERS. Inspector: MWK Inspection # TRACK LOADERS Date Created: 12-12-18 Location: SMITHVILLE Inspector: MWK Inspection # Manufacturer: CAT Model: 963C Serial #: 2DS1165 Year: 00 Engine SN:? Transmission SN:? SMU/Hrs: 3975 Last Scheduled

More information

Fecon FTX128L. Walk Around Guide

Fecon FTX128L. Walk Around Guide Fecon FTX128L Walk Around Guide FTX128L Specifications Specification FTX128L Fuel Consumption 4 gph Fuel Tank Capacity 45 gal. / 170 ltr Horsepower 128hp / 95.4 kw Engine Make / Model Cummins QSB4.5 Maximum

More information

TransLift TL 2550K Parts Manual

TransLift TL 2550K Parts Manual TransLift TL 2550K Parts Manual Tink, I nc. 2361 D urham Dayton H w y D urham, C A 95938 Toll Free 888-367-8465 Fax 530-895-0751 w w w.tink inc.co ṁ Table of Contents Full Assembly View... 2 Tank View...

More information

XC 450 EFT Model Number A2013KCK4CETT SHARE OUR PASSION.

XC 450 EFT Model Number A2013KCK4CETT SHARE OUR PASSION. 2013 XC 450 EFT Model Number A2013KCK4CETT TM SHARE OUR PASSION. TABLE OF CONTENTS 2013 XC 450 EFT Green (Model No. A2013KCK4CETT) FRONT BODY ASSEMBLY... 1 REAR BODY AND TAILLIGHT ASSEMBLY... 2 BUMPER,

More information

CNH Capital AssetsAsset Appraisal System

CNH Capital AssetsAsset Appraisal System Page 1 of 12 Customer Name UNIT # 8U0536 Location: Decatur TX Account Number Note Number Date Mode of Offer Available Asset Return ID for Sale Hazel R Loan 3787900126 61031001 N/A 697689 Greenwood Repossession

More information

DISASSEMBLED VIEWS. Disassembled Views. Engine Covers and Component Assemblies (1 of 2) (LF1, LFW or LFX)

DISASSEMBLED VIEWS. Disassembled Views. Engine Covers and Component Assemblies (1 of 2) (LF1, LFW or LFX) 2012 Cadillac CTS Wagon AWD V6-3.0L Vehicle > Engine, Cooling and Exhaust > Engine > Locations > Components DISASSEMBLED VIEWS Disassembled Views Engine Covers and Component Assemblies (1 of 2) (LF1, LFW

More information

Failure Codes and Labor Time

Failure Codes and Labor Time Air Cleaner 1501.3 Anchor, Clutch 1701.2 Arm Clutch w/bearings 1081-4 1.0 562-2 1.0 Arm Deck Lift 1105-1.5 Arm Idler Mule Drive 1504-8.5 1104-8.4 Arm Idler Pump / Trans. 334.5 1036.5 529-3.5 1103-5.7 1702.3

More information

John Deere. MODEL: 450-C Crawler JD-O-OMT71338

John Deere. MODEL: 450-C Crawler JD-O-OMT71338 John Deere MODEL: 450-C Crawler THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF JOHN DEERE OR IT'S SUCCESSORS. JOHN DEERE AND IT'S SUCCESSORS ARE NOT RESPONSIBLE FOR THE QUALITY

More information

1999 Nissan Altima GLE

1999 Nissan Altima GLE TIMING CHAIN CAUTION: If cylinder head is installed and timing chain is disconnected, DO NOT rotate camshaft or crankshaft; valves will contact pistons, resulting in bent valves. NOTE: Following procedure

More information

FRONT RACK, BODY PANEL, AND HEADLIGHT ASSEMBLIES

FRONT RACK, BODY PANEL, AND HEADLIGHT ASSEMBLIES FRONT RACK, BODY PANEL, AND HEADLIGHT ASSEMBLIES 0747-506 1 2506-107 1 Rack, Front - Assembly (inc. 2) 2 0411-576 1 Decal, Warning - Load 3 0441-592 4 Bushing 4 8410-835 4 Screw, Cap 5 0423-669 4 Spacer

More information

Prowler XTX SHARE OUR PASSION ṬM

Prowler XTX SHARE OUR PASSION ṬM SHARE OUR PASSION ṬM Prowler XTX Model Number U2009P3T4EUSV (Steel Blue) Model Number U2009P3T4EOSV (Steel Blue) International Model Number U2009P3T4EUSC (M4 Camo) Model Number U2009P3T4EUSQ (Black - LE)

More information

Illustrated Parts Manual

Illustrated Parts Manual 1 10 Illustrated Parts Manual 2 425 CR EFT Model Number A2011IRK4CETR (Red) S H A R E O U R PA S S IO N. TM TABLE OF CONTENTS 2011 ATV 425 CR EFT Red (A2011IRK4CETR) FRONT RACK, BODY PANEL, AND HEADLIGHT

More information

Prowler XTZ Model Number U2013P4W1PUSU Model Number U2013P4W1POSU - International SHARE OUR PASSION.

Prowler XTZ Model Number U2013P4W1PUSU Model Number U2013P4W1POSU - International SHARE OUR PASSION. 2013 Prowler XTZ Model Number U2013P4W1PUSU Model Number U2013P4W1POSU - International TM SHARE OUR PASSION. TABLE OF CONTENTS 2013 Prowler XTZ (Model No. U2013P4W1PUSU) (Model No. U2013P4W1POSU - International)

More information

MZ 52LE. Parts Manual. Zero Turn Mower /

MZ 52LE. Parts Manual. Zero Turn Mower / Parts Manual MZ 52LE Zero Turn Mower / 9677406-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. When you need spare parts or support

More information

Table Of Contents B & 735B

Table Of Contents B & 735B Table Of Contents Last Updated - 10/08 Table Of Contents... 725B & 735B SECTION DESCRIPTION PAGE UP Upper Turntable Components A.2 EE Electronic (Cummins) Engine A.3 OC Operator Cab Components A.3 ES Electrical

More information

941 Traxcavator S/n 16U, 70H, 80H & up

941 Traxcavator S/n 16U, 70H, 80H & up Caterpillar Service Manual 941 Traxcavator S/n 16U, 70H, 80H & up Service Manual THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF CATERPILLAR OR IT S SUCCESSORS. CATERPILLAR AND

More information

939C Hystat Track-Type Loader

939C Hystat Track-Type Loader Engine Four-stroke cycle, in-line six cylinder Cat 3046 turbocharged diesel engine. Ratings at 2400 RPM* kw HP Gross power 74.6 100 Net power 67.9 90 The following ratings apply at 2400 RPM when tested

More information

MODEL: 310A and 3108 Tractor, Loader and Backhoe Volume 1 of 2

MODEL: 310A and 3108 Tractor, Loader and Backhoe Volume 1 of 2 John Deere MODEL: 310A and 3108 Tractor, Loader and Backhoe Volume 1 of 2 THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF JOHN DEERE OR IT'S SUCCESSORS. JOHN DEERE AND IT'S SUCCESSORS

More information

PARTIAL ENGINE ASSY COMPONENTS. Clip. Radiator Grille. Clip. Front Bumper Cover. Engine Under Cover LH. N m (kgf cm, ft lbf) : Specified torque

PARTIAL ENGINE ASSY COMPONENTS. Clip. Radiator Grille. Clip. Front Bumper Cover. Engine Under Cover LH. N m (kgf cm, ft lbf) : Specified torque ENGINE MECHANICAL 1417 COMPONENTS 141FP01 Radiator Grille Front Bumper Cover Engine Under Cover RH Engine Under Cover LH A79361 962 1418 ENGINE MECHANICAL Heater Outlet Water Hose 7.0 (71, 62 in. lbf)

More information

1000 Mud Pro Model Number A2013MLW1PUSN Model Number A2013MLW1POSN - International SHARE OUR PASSION.

1000 Mud Pro Model Number A2013MLW1PUSN Model Number A2013MLW1POSN - International SHARE OUR PASSION. 2013 1000 Mud Pro Model Number A2013MLW1PUSN Model Number A2013MLW1POSN - International TM SHARE OUR PASSION. TABLE OF CONTENTS 2013 ATV 1000 Mud Pro (Model No. A2013MLW1PUSN) (Model No. A2013MLW1POSN

More information

TRACK- TYPE TRACTOR DATE OF INSPECTION: MAKE: SERIAL NUMBER: TOTAL HOURS:

TRACK- TYPE TRACTOR DATE OF INSPECTION: MAKE: SERIAL NUMBER: TOTAL HOURS: YEAR: MAKE: MODEL: SERIAL NUMBER: HOUR (METER): TOTAL HOURS: DATE OF INSPECTION: INSPECTOR: LOCATION: INSTALLED EQUIPMENT EROPS / OROPS A/C ENG ENCLOSURES PAD SIZE U/C OVERALL % SWEEPS TRANS TYPE FIRE

More information

2002 CATERPILLAR D8RII Customer Owned Certified

2002 CATERPILLAR D8RII Customer Owned Certified S P E C I F IC A T I O N S 2002 CATERPILLAR D8RII Customer Owned Certified TRACK TYPE TRACTORS Serial #: Engine Serial #: Transmission Serial #: SMU/Hrs: 1 Last Scheduled Oil Sample: Last Cat Track System

More information

Boxer 532DX Parts Manual

Boxer 532DX Parts Manual BIG POWER IN ALL PLACES Boxer 5DX Parts Manual SN and Higher Part No. 5- Phone: Sales - 00--00, Parts and Service - 00-55- www.boxerequipment.com Manufactured by: Morbark, Inc. 50 S. Winn Rd., P.O. Box

More information

ARMTRAC 75T-230 CAB SPECIFICATIONS T H I S I S A C O N T R O L L E D D O C U M E N T. SPEC/A75T/1CAB/3.00/ Page 1 of 5

ARMTRAC 75T-230 CAB SPECIFICATIONS T H I S I S A C O N T R O L L E D D O C U M E N T. SPEC/A75T/1CAB/3.00/ Page 1 of 5 ARMTRAC 75T-230 CAB SPECIFICATIONS SPEC/A75T/1CAB/3.00/08.2018 Page 1 of 5 SPEC/A75T/1CAB/3.00/08.2018 Page 2 of 5 STATIC DIMENSIONS A Track length (Diameter) 3091 mm H Track width outside 2023.5 mm B

More information

ARMTRAC 75T-230 CABLESS

ARMTRAC 75T-230 CABLESS ARMTRAC 75T-230 CABLESS SPECIFICATIONS SPEC/A75T/0CAB/2.00/08.2018 Page 1 of 5 E 45 C F S B A D Machine - At widest points N M J G H I L K SPEC/A75T/0CAB/2.00/08.2018 Page 2 of 5 STATIC DIMENSIONS A Track

More information

1991 Volkswagen Vanagon Syncro

1991 Volkswagen Vanagon Syncro corner of radiator. See Fig. 1. Fig. 1: Bleeding Cooling System 2. Open bleeder valve in engine compartment (turn counterclockwise). See Fig. 1. Fill expansion tank until full. Start and run engine at

More information

Ferguson Cylinder Diesel Engine Parts catalogue and price list. Discount Tractor Parts. Ph

Ferguson Cylinder Diesel Engine Parts catalogue and price list. Discount Tractor Parts. Ph Ferguson 35 3 Cylinder Diesel Engine Parts catalogue and price list Discount Tractor Parts Ph 0800 872 272 Prices in this catalogue are plus GST and subject to change Front Axle With inner brg I.D. 32mm

More information

Parts Manual MZ5225 /

Parts Manual MZ5225 / Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine. The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty. Parts Manual MZ5225 / 966690502 Please

More information

Parts Manual MZ52 /

Parts Manual MZ52 / Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine. The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty. Parts Manual MZ52 / 962401 Please

More information

Boxer 700HDX Parts Manual

Boxer 700HDX Parts Manual BIG POWER IN ALL PLACES Phone: Sales - 800-831-0042, Parts and Service - 800-255-8839 www.boxerequipment.com Boxer 700HDX Parts Manual SN 5082 and Higher Part No. 76345-820 Manufactured by: Morbark, LLC.

More information

1000 XT Model Number A2013AGW1PUSW Model Number A2013AGW1POSW - International SHARE OUR PASSION.

1000 XT Model Number A2013AGW1PUSW Model Number A2013AGW1POSW - International SHARE OUR PASSION. 2013 1000 XT Model Number A2013AGW1PUSW Model Number A2013AGW1POSW - International TM SHARE OUR PASSION. TABLE OF CONTENTS 2013 ATV 1000 XT (Model No. A2013AGW1PUSW) (Model No. A2013AGW1POSW - International)

More information

Parts Manual M-ZT52 /

Parts Manual M-ZT52 / Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine. The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty. Parts Manual M-ZT52 / 961001 Please

More information

Retriever PARTS LIST Advance MODEL 5200G(OBSOLETE)

Retriever PARTS LIST Advance MODEL 5200G(OBSOLETE) Retriever PARTS LIST Advance MODEL 5200G(OBSOLETE) 5/85 revised 2/01 FORM NO. 56042131 TABLE OF CONTENTS DESCRIPTION PAGE OUTER BODY...1-2 HYDRAULIC PUMP, ENGINE & FUEL TANK...3-4 HYDRAULIC OIL FILTER,

More information

PARTIAL ENGINE ASSY (2ZZ GE)

PARTIAL ENGINE ASSY (2ZZ GE) COMPONENTS 14189 140R701 7.0 (71, 62 in. lbf) Cylinder Head Cover No. 2 19 (194, 14) Radiator Support Upper 19 (194, 14) Radiator Hose Inlet Cruise Control Actuator Assy 6.0 (61, 53 in. lbf) Radiator Assy

More information

Illustrated Parts Manual. Model Number A2011ICS4BUSG (Green) A2011ICS4BOSG (Green - International)

Illustrated Parts Manual. Model Number A2011ICS4BUSG (Green) A2011ICS4BOSG (Green - International) Illustrated Parts Manual 2 1 10 650 Model Number A2011ICS4BUSG (Green) A2011ICS4BOSG (Green - International) S H A R E O U R PAS S IO N. TM TABLE OF CONTENTS 2011 ATV 650 Green (Model No. A2011ICS4BUSG)

More information

COMPONENT LOCATOR > DISASSEMBLED VIEWS

COMPONENT LOCATOR > DISASSEMBLED VIEWS Page 1 of 45 2006 Pontiac Grand Prix 3.8L Eng Base Service Manual: ENGINE MECHANICAL - 3.8L COMPONENT LOCATOR > DISASSEMBLED VIEWS Fig 1: Engine Block Component Views Callout Component Name 100 Engine

More information

955L Traxcavator S/n 64J, 71J & 85J Volume 1 of 2

955L Traxcavator S/n 64J, 71J & 85J Volume 1 of 2 Caterpillar Service Manual 955L Traxcavator S/n 64J, 71J & 85J Volume 1 of 2 Service Manual THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF CATERPILLAR OR IT S SUCCESSORS. CATERPILLAR

More information

Terex 820 Backhoe Loader Service And Repair Manual

Terex 820 Backhoe Loader Service And Repair Manual Terex 820 Backhoe Loader Service And Repair Manual DOWNLOAD HERE Service manual for the Terex 820 backhoe loader. Covers the following models 820 860/880 SX & ELITE 970/980 ELITE TX760B TX860B TX970B TX980B

More information

COMP C M O ACT COMPP C A T ACT Boxer Parts Manual

COMP C M O ACT COMPP C A T ACT Boxer Parts Manual Boxer Parts Manual Boxer Parts List.indd 1 6/9/06 11:04:01 AM Boxer Parts List.indd 2 6/9/06 11:04:02 AM Table of Contents Parts List and Illustrations Page Number Routine Maintenance Replacement Parts...iv

More information

TH406 / TH407 Recommended Parts List

TH406 / TH407 Recommended Parts List Basic Engine & Related System (Mechanical) Primary Fuel Filter - Mechanical 1R-1804 Secundary Fuel Filter - Mechanical 252-6338 Air Filter Primary Element 206-5234 Air Filter Secondary Element 206-5235

More information

John Deere. MODEL: 350C Crawler Loader, Bulldozer JD-O-OMT79469

John Deere. MODEL: 350C Crawler Loader, Bulldozer JD-O-OMT79469 John Deere MODEL: 350C Crawler Loader, Bulldozer THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF JOHN DEERE OR IT'S SUCCESSORS. JOHN DEERE AND IT'S SUCCESSORS ARE NOT RESPONSIBLE

More information

M-ZT 61. Parts Manual. Zero Turn Mower /

M-ZT 61. Parts Manual. Zero Turn Mower / Parts Manual M-ZT 61 Zero Turn Mower / 967177008-01 Please read the operator manual carefully and make sure you understand the instructions before using the machine. When you need spare parts or support

More information

Crawler Tractor PR 734-4

Crawler Tractor PR 734-4 Crawler Tractor PR 734-4 litronic` Engine output: 150 kw / 204 HP Operating weight: 17,960 20,000 kg Basic machine Engine Liebherr Diesel engine Rating (ISO 9249) Rating (SAE J1349) Rated speed Displacement

More information

MTS-T4-6 APU Warranty SRT Time Guide (Caterpillar/Perkins Engines)

MTS-T4-6 APU Warranty SRT Time Guide (Caterpillar/Perkins Engines) MTS-T4-6 APU Warranty SRT Time Guide (Caterpillar/Perkins Engines) Air Conditioning System A/C Condenser Replacement RP9-011 A/C Condenser 2.5 RP9-027B Receiver/Dryer Filter 0.5 A/C Compressor Replacement

More information

Fastener Tightening Specifications Specification

Fastener Tightening Specifications Specification 2008 G6 Applies to: 3.5L Report a problem with this article Fastener Tightening s A/C Compressor Bracket Bolt Camshaft Position Actuator Assembly Bolt 16 Y 12 lb ft Camshaft Position Actuator Magnet Bolt

More information

955L Traxcavator S/N 8Y1, 13X1, & 57M1 Volume 1 of 3

955L Traxcavator S/N 8Y1, 13X1, & 57M1 Volume 1 of 3 Caterpillar Service Manual 955L Traxcavator S/N 8Y1, 13X1, & 57M1 Volume 1 of 3 Service Manual THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF CATERPILLAR OR IT S SUCCESSORS. CATERPILLAR

More information

1150B Volume 1 of 3

1150B Volume 1 of 3 J.I. Case Service Manual 1150B 1965-1978 Volume 1 of 3 Service Manual THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF J.I. CASE OR IT S SUCCESSORS. J.I. CASE AND IT S SUCCESSORS

More information

ILLUSTRATED PARTS MANUAL

ILLUSTRATED PARTS MANUAL ILLUSTRATED PARTS MANUAL 700 EFT Model Number A2014IBT4EETG TM SHARE OUR PASSION. www.arcticcat.com TABLE OF CONTENTS 2014 ATV 700 EFT (Model No. A2014IBT4EETG) FRONT RACK, BODY PANEL, AND HEADLIGHT ASSEMBLIES...

More information

550 EFT Model Number A2013IBO4EETP SHARE OUR PASSION.

550 EFT Model Number A2013IBO4EETP SHARE OUR PASSION. 2013 550 EFT Model Number A2013IBO4EETP SHARE OUR PASSION. TM TABLE OF CONTENTS 2013 ATV 550 EFT Black (Model No. A2013IBO4EETP) FRONT RACK, BODY PANEL, AND HEADLIGHT ASSEMBLIES... 1 REAR RACK, BODY PANEL,

More information

1991 Nissan 240SX. 2.4L 4-CYL - VINS [F,M,S] 1991 ENGINES Nissan 2.4L 4-Cylinder

1991 Nissan 240SX. 2.4L 4-CYL - VINS [F,M,S] 1991 ENGINES Nissan 2.4L 4-Cylinder NOTE: Use illustration for component reference. See Fig. 7. 1. Remove spark plug wires. Set No. 1 piston at TDC on its compression stroke. Remove vacuum hoses, electrical harnesses, connectors, and harness

More information

EXTENDED WARRANTY POLICY

EXTENDED WARRANTY POLICY EXTENDED WARRANTY POLICY EXTENDED WARRANTY TERMS AND CONDITIONS CONTENTS CONTENTS... 2 GENERAL INFORMATION... 3 EXTENDED WARRANTY: TERMS & CONDITIONS... 4 COMPONENT LIST... 11 FULL MACHINE COVERAGE...

More information

Technical description LR 622 Crawler loader

Technical description LR 622 Crawler loader Technical description LR 622 Crawler loader Engine output 97 kw/132 HP Operating weight 15.4 17.0 t /34,000 37,500 lb Bucket capacity 1.54 1.80 m 3 /2.01 2.35 cu.yd. Hydrostatic travel drive with electronic

More information

700 XT EFT Model Number A2013AGT1PETV SHARE OUR PASSION.

700 XT EFT Model Number A2013AGT1PETV SHARE OUR PASSION. 2013 700 XT EFT Model Number A2013AGT1PETV SHARE OUR PASSION. TM TABLE OF CONTENTS 2013 ATV 700 XT EFT Steel Blue (Model No. A2013AGT1PETV) FRONT RACK, BODY PANEL, AND HEADLIGHT ASSEMBLIES... 1 REAR RACK,

More information

Illustrated Parts Manual

Illustrated Parts Manual Illustrated Parts Manual 2 1 10 550 PS EFT Model Number A2011IBO1PETS (Metallic Gray) S H A R E O U R PAS S IO N. TM TABLE OF CONTENTS 2011 ATV 550 PS EFT Metallic Gray (A2011IBO1PETS) FRONT RACK, BODY

More information

Boxer 525DX Parts Manual

Boxer 525DX Parts Manual BIG POWER IN ALL PLACES Boxer DX Parts Manual SN Part No. 3-13 Phone: Sales - 00-31-00, Parts and Service - 00--3 www.boxerequipment.com Manufactured by: Morbark, Inc. 0 S. Winn Rd., P.O. Box 00, Winn,

More information

ILLUSTRATED PARTS MANUAL

ILLUSTRATED PARTS MANUAL ILLUSTRATED PARTS MANUAL TRV 1000 XT EFT Model Number A2014TGW1PETL TM SHARE OUR PASSION. www.arcticcat.com TABLE OF CONTENTS 2014 TRV 1000 XT EFT (Model No. A2014TGW1PETL) FRONT RACK, BODY PANEL, AND

More information

PC Hour Meter Jul-09 Hour Meter m3 Bucket Into Service Nov. 2000

PC Hour Meter Jul-09 Hour Meter m3 Bucket Into Service Nov. 2000 Printed:1/16/01 Component Tracking - Lac des Iles Mines Ltd. Surface Mine Equipment 1 4 5 6 7 8 9 10 11 1 1 14 15 16 17 18 19 0 1 4 5 6 7 8 9 0 1 4 5 6 7 8 9 40 41 4 4 44 45 46 47 48 49 50 51 5 5 54 55

More information

Engine Removal/Installation

Engine Removal/Installation Engine Removal/Installation Make sure jacks and safety stands are placed properly and hoist brackets are attached to correct positions on the engine. (See Section 1). Apply parking brake and block rear

More information

5.7L ENGINE PARTS BOOK. Not for. Reproduction

5.7L ENGINE PARTS BOOK. Not for. Reproduction 5.7L ENGINE PARTS BOOK Engine Model: Engine Family: PSI, Industrial Engine Spec N.: 39004120-39004248 Parts Book Revision: December, 2015 TABLE OF CONTENTS SECTION PAGE CYLINDER BLOCK... 3-5 CYLINDER HEAD...

More information

1991 TOYOTA Electrical Components MR2. evaporator. compartment. ARTICLE BEGINNING BUZZERS, RELAYS & TIMERS

1991 TOYOTA Electrical Components MR2. evaporator. compartment. ARTICLE BEGINNING BUZZERS, RELAYS & TIMERS ELECTRICAL COMPONENT LOCATOR Article Text ARTICLE BEGINNING 1991 TOYOTA Electrical Components MR2 BUZZERS, RELAYS & TIMERS A/C Compressor Clutch Relay Under right side of dash, on evaporator. Circuit Opening

More information

1 of 12 11/20/2016 9:32 PM

1 of 12 11/20/2016 9:32 PM 1 of 12 11/20/2016 9:32 PM Caution: After removing timing chain, do not turn crankshaft and camshaft separately, or valves will strike piston heads. Apply new engine oil to the sliding surfaces when Installing

More information

ILLUSTRATED PARTS MANUAL

ILLUSTRATED PARTS MANUAL ILLUSTRATED PARTS MANUAL Wildcat X LTD Model Number U2014WTW1PUSE Model Number U2014WTW1PUSJ Model Number U2014WTW1POSE - International Model Number U2014WTW1POSJ - International TM SHARE OUR PASSION.

More information

Illustrated Parts List MODEL Reproduction. Not for. 48,000 Watt Home Generator System

Illustrated Parts List MODEL Reproduction. Not for. 48,000 Watt Home Generator System Illustrated Parts List MODEL 076035-0 48,000 Watt Home Generator System Rev. A 4/14/2011 Table Of Contents PRODUCT COMPONENTS Main Unit... 4 Alternator... 6 Control Panel... 7 Enclosure... 8 Engine -

More information

550 TRV EFT Model Number A2013TBO4EETP SHARE OUR PASSION.

550 TRV EFT Model Number A2013TBO4EETP SHARE OUR PASSION. 2013 550 TRV EFT Model Number A2013TBO4EETP TM SHARE OUR PASSION. TABLE OF CONTENTS 2013 550 TRV EFT (Model No. A2013TBO4EETP) FRONT RACK, BODY PANEL, AND HEADLIGHT ASSEMBLIES... 1 REAR BODY PANEL, FOOTWELL,

More information

400 4x4 Euro MODEL NUMBER A2008IDG4BEUR (RED) MODEL NUMBER A2008IDG4BEUG (GREEN) MODEL NUMBER A2008IDG4BEUZ (CAT GREEN) MORE TO GO ON.

400 4x4 Euro MODEL NUMBER A2008IDG4BEUR (RED) MODEL NUMBER A2008IDG4BEUG (GREEN) MODEL NUMBER A2008IDG4BEUZ (CAT GREEN) MORE TO GO ON. 2008 400 4x4 Euro Illustrated Parts Manual MODEL NUMBER A2008IDG4BEUR (RED) MODEL NUMBER A2008IDG4BEUG (GREEN) MODEL NUMBER A2008IDG4BEUZ (CAT GREEN) MORE TO GO ON. TM TABLE OF CONTENTS 2008 ATV 400 4x4

More information

Specialty Equipment Division. CC-DC-SS Deep Cut Saw PARTS BOOK REVISED:

Specialty Equipment Division. CC-DC-SS Deep Cut Saw PARTS BOOK REVISED: Specialty Equipment Division CC-DC-SS Deep Cut Saw PARTS BOOK REVISED: 3-1-05 CC-DC-SS SPECIFICATION SHEET Dimensions: Engine: Blade Sizes: Length 70 Height 53 Frame Width 30 Weight 2550lbs Blade Shaft

More information

Parts Manual MZ5225ZT / MZ6128ZT / MZ6128ZT /

Parts Manual MZ5225ZT / MZ6128ZT / MZ6128ZT / Gasoline containing up to 10% ethanol (E10) is acceptable for use in this machine. The use of any gasoline exceeding 10% ethanol (E10) will void the product warranty. Parts Manual MZ5225ZT / 966690501

More information

Replacement parts to fit FORD ALPHABETICAL INDEX

Replacement parts to fit FORD ALPHABETICAL INDEX ALPHABETICAL INDEX A Adaptor, Hydraulic, 247, 249 to 250 Adaptor, PTO Shaft, 210 Air Cleaner, 157 to 158 Bowl, 157 Door, 273 Gasket, 159 Hose, 159 Spring, 158 Tube, 158 Air Conditioning Compressors, 282

More information

Parts Manual Rev. 5

Parts Manual Rev. 5 0-0- CL 0 - Rev. Parts Manual MZ / 0-00 Please read the operator manual carefully and make sure you understand the instructions before using the machine. Gasoline containing a maximum of % ethanol (E)

More information

5. Engine Control Module (ECM) I/O Signal

5. Engine Control Module (ECM) I/O Signal 5. A: ELECTRICAL SPECIFICATION B134 B135 B136 B137 17 16 15 14 13 12 11 10 9 8 27 26 25 24 23 22 21 20 19 18 34 33 32 31 30 29 28 19 18 17 16 15 14 13 12 11 10 9 8 27 26 25 24 23 22 21 20 35 34 33 32 31

More information

Fuel supply system components, removing and installing

Fuel supply system components, removing and installing 20-1 Fuel supply system components, removing and installing Checking fuel system for leaks Removing and installing fuel filter and draining water, engine code AAZ: Repair Manual, 1.9 Liter 4-Cyl. 2V Eco-Diesel

More information

Mini Excavator 8018 CTS

Mini Excavator 8018 CTS NEW Mini Excavator Operating Weight: 1822 kg (4016 lb) Net Engine Power: 14.2 kw (19 hp) A Product of Hard Work MINI EXCAVATORS OPERATING WEIGHT: 1822 kg (4016 lbs) NET ENGINE POWER: 14.2 kw (19hp) K D

More information

FORDSON TRACTOR REPLACEMENT PARTS CATALOGUE DISCOUNT TRACTOR PARTS. Ph

FORDSON TRACTOR REPLACEMENT PARTS CATALOGUE DISCOUNT TRACTOR PARTS. Ph FORDSON TRACTOR REPLACEMENT PARTS CATALOGUE DISCOUNT TRACTOR PARTS Ph 0800 872 272 Email sales@discounttractorparts.co.nz All prices listed are plus GST and subject to change 7B Manga Rd, Silverdale Water

More information

T550 COMPACT TRACK LOADER SPECIFICATIONS

T550 COMPACT TRACK LOADER SPECIFICATIONS T550 COMPACT TRACK LOADER SPECIFICATIONS Loader Dimensions Dimensions are given for loader equipped with standard tracks and 68 in. Construction and Industrial bucket and may vary with other bucket types.

More information

1992 CATERPILLAR D6H II LGP BULLDOZER SWAMPY

1992 CATERPILLAR D6H II LGP BULLDOZER SWAMPY 2 3 Serial No: 4GG 04262, Arrangement No: 4Y6779, Engine No: 3306-022-4249 DATE HOURS DETAILS COST CARRIED OUT BY 4 5 6 7 30/07/05 879 /08/05 8820 26/09/05 8970 6/0/05 9072 Service - oil, fuel and transmission

More information

Pavement Services, Inc.

Pavement Services, Inc. MG68 Parts Manual Pavement Services, Inc. Page 30 29 30 29 25 25 24 30 4 26 29 4 25 26 4 Page 2 The Decal Kit for the Model MG68 Maintainer is Item Part # Description 056859 DECAL, ANTI-FREEZE (BLACK)

More information

Hydraulic Excavator R 9250 Arctic

Hydraulic Excavator R 9250 Arctic ydraulic Excavator R 9250 Arctic Operating Weight with Backhoe Attachment: 250,000 kg / 551,155 lb with Shovel Attachment: 253,500 kg / 558,870 lb Engine Output: 960 kw / 1287 hp Bucket Capacity: 13,00

More information

FORDSON TRACTOR REPLACEMENT PARTS CATALOGUE. Updated February 2017 DISCOUNT TRACTOR PARTS

FORDSON TRACTOR REPLACEMENT PARTS CATALOGUE. Updated February 2017 DISCOUNT TRACTOR PARTS FORDSON TRACTOR REPLACEMENT PARTS CATALOGUE Updated February 2017 DISCOUNT TRACTOR PARTS Ph 0800 872 272 Updated February 2017 E mail sales@discounttractorparts.co.nz All prices listed are plus GST and

More information

PARTS BOOKS INSTRUCTIONS

PARTS BOOKS INSTRUCTIONS PARTS BOOKS INSTRUCTIONS To Use DRACO Equipment Parts Books Follow the instructions listed below: From The Main Index Page: Click on the PARTS TAB on the top of the page: Open parts books for your particular

More information

Defect bonnet needs adjusting Defect filter blocked Defect minor hydraulic hose leaking in artic area 12521

Defect bonnet needs adjusting Defect filter blocked Defect minor hydraulic hose leaking in artic area 12521 Defect bonnet needs adjusting 7642 Defect filter blocked 11654 Defect minor hydraulic hose leaking in artic area 12521 Defect Defect needs new wiper blade blade replaced pos 2 strut low wiper blade front

More information

Parts for Arbor Shaft Assembly

Parts for Arbor Shaft Assembly Parts for Arbor Shaft Assembly ITEM PART DESCRIEPTION 1 P110715 Key, 3/8 x 2-3/4 2 P416808 Arbor nut RH thread 3 P110640 Bushing SK x 1-11/16 888-634-4289 (14, 18, 20, 26 ) 4 P111022 Sheave 6 GR - 3V-

More information

SPEEDZTR Parts Manual

SPEEDZTR Parts Manual SPEEDZTR / SPEEDZTR / SPEEDZTR / SPEEDZTR Parts Manual SPEEDZTR / SPEEDZTR / 0 SPEEDZTR / SPEEDZTR / Please read the operator s manual carefully and make sure you understand the instructions before using

More information

Boxer 322D Parts Manual

Boxer 322D Parts Manual BIG POWER IN ALL PLACES Boxer D Parts Manual Serial No.s and Higher Part No. -80 Phone: Sales - 800-8-00, Parts and Service - 800--88 www.boxerequipment.com Manufactured by: Morbark, Inc. 80 S. Winn Rd.,

More information

Boxer 320 Parts Manual

Boxer 320 Parts Manual BIG POWER IN ALL PLACES Boxer 20 Parts Manual Serial No.s 9 & Higher Part No. 765-808 Phone: Sales - 800-8-002, Parts and Service - 800-255-889 www.boxerequipment.com Manufactured by: Morbark, Inc. 8507

More information

ILLUSTRATED PARTS MANUAL

ILLUSTRATED PARTS MANUAL ILLUSTRATED PARTS MANUAL TRV 700 XT EFT Model Number A2014TGT1PETN Model Number A2014TGT1PETX TM SHARE OUR PASSION. www.arcticcat.com TABLE OF CONTENTS 2014 ATV 700 XT EFT (Model No. A2014TGT1PETN) (Model

More information

Parts Description 2 1/2 Ton Multi-Fuel Part Number NSN

Parts Description 2 1/2 Ton Multi-Fuel Part Number NSN Parts Description 2 1/2 Ton Multi-Fuel Part Number NSN Filter, M49C Fuel Tanker 4330-00-983- CP20452-0 0998 Tube, M49C Fuel Tanker Pickup Element, Air cleaner 2940-00-804-10912373 7898 Cable, Engine Stop

More information

PARTIAL ENGINE ASSY (2TR FE)

PARTIAL ENGINE ASSY (2TR FE) COMPONENTS 147 1421Z01 Clip Hood Subassy x9 Radiator Support to Frame Seal LH 30 (306, 22) 30 (306, 22) Fan and Generator V Belt 5.0 (51, 44 in. lbf) Fan Shroud Fan Pulley Fan w/ Fluid Coupling PRE RUNNER

More information

Fig. 6: Assembling Piston & Rod. NOTE: Notch must face forward Toyota Starlet CRANKSHAFT MAIN BEARINGS

Fig. 6: Assembling Piston & Rod. NOTE: Notch must face forward Toyota Starlet CRANKSHAFT MAIN BEARINGS connecting rods are marked for reassembly. 3. Thoroughly clean and inspect all components. Coat pin with engine oil and heat piston to 158-176 F (70-80 C). Pin should push fit with thumb pressure through

More information

MODEL S-32, 3200, ALL AMERICAN

MODEL S-32, 3200, ALL AMERICAN MODEL S-32, 3200, ALL AMERICAN 1. 1 3201-7001 Chassis Weldment 2. 1 3204-7010 Bell Crank Weld 3. 1 3204-7009 Seconday Lift Weld 4. 1 3204-2018 Primary Lift Arm 6. 1 340-3025-S0 Seat Spring 6. 3 847-2803

More information

DOOSAN COMMON PARTS MODEL: G20/25/30/32E-3 SERIAL: KN (LP), KP (DUEL FUEL) GAS/LP, MITSUBISHI (G424E / 4G64), 2.7 LITRE, 4 CYL

DOOSAN COMMON PARTS MODEL: G20/25/30/32E-3 SERIAL: KN (LP), KP (DUEL FUEL) GAS/LP, MITSUBISHI (G424E / 4G64), 2.7 LITRE, 4 CYL DOOSAN COMMON PARTS MODEL: G20/25/30/32E-3 SERIAL: KN (LP), KP (DUEL FUEL) GAS/LP, MITSUBISHI (G424E / 4G64), 2.7 LITRE, 4 CYL SERIAL NUMBER INFO PREFIX MODEL ENGINE FUEL/TRANS BRAKE KN G20/25/30/32E-3

More information

Please read the operator manual carefully and make sure you understand the instructions before using the machine.

Please read the operator manual carefully and make sure you understand the instructions before using the machine. 967327901-00 Parts Zero Manual Turn Mower Please read the operator manual carefully and make sure you understand the instructions before using the machine. When you need spare parts or support in service

More information

Excavator Service Manual 331 (S/N & Above) 331E (S/N & Above) 334 (S/N & Above)

Excavator Service Manual 331 (S/N & Above) 331E (S/N & Above) 334 (S/N & Above) Excavator Service Manual 331 (S/N 512913001 & Above) 331E (S/N 517711001 & Above) 334 (S/N 516711001 & Above) Melroe Company 1998 6900464 (2 98) Printed in U.S.A. 1 of 525 2 of 525 Dealer Copy -- Not for

More information

400 2x4/4x4 EFT SHARE OUR PASSION ṬM

400 2x4/4x4 EFT SHARE OUR PASSION ṬM SHARE OUR PASSION ṬM 400 2x4/4x4 EFT Model Number A2009IDG2BETR (Red - 2x4) Model Number A2009IDG2BETZ (Cat Green - 2x4) Model Number A2009IDG4BETR (Red - 4x4) Model Number A2009IDG4BETG (Green - 4x4)

More information

SECTION 4 -ENGINE & ATTACHING PARTS

SECTION 4 -ENGINE & ATTACHING PARTS SECTION 4 -ENGINE & ATTACHING PARTS ENGINE & ATTACHING PARTS Power Unit Assembly 49 46 9 40 44 50 61 11 14 5 51 60 20 27 45 41 21 0 7 7 12 16 4 20 27 45 52 58 VIEW SHOWING TUBE ASSEMBLY AT MAIN PUMP FOR

More information

Boxer 530X Parts Manual

Boxer 530X Parts Manual BIG POWER IN ALL PLACES Boxer 50X Parts Manual Part No. 999-1 (SN 10 and Higher) Table of Contents Parts List and Illustrations Page Number Routine Maintenance Replacement Parts...iv Creep Valve... 2

More information