MAINTENANCE SCHEDULES

Size: px

Start display at page:

Download "MAINTENANCE SCHEDULES"

Clara Copeland
5 years ago
Views:

1 O mission ontrol ystem aintenance...44 chedule B aintenance chedules...44 chedule...463

2 44 O ORO Y he cheduled maintenance services, listed in bold type must be done at the times or mileages specified to assure the continued proper functioning of the emission control system. hese, and all other maintenance services included in this manual, should be done to provide best vehicle performance and reliability. ore frequent maintenance may be needed for vehicles in severe operating conditions such as dusty areas and very short trip driving. nspection and service also should be done any time a malfunction is suspected. O: aintenance, replacement, or repair of the emission control devices and systems on your vehicle may be performed by any automotive repair establishment or individual using any automotive part which has been certified pursuant to.. P or, in the tate of alifornia, alifornia ir Resources Board regulations. here are two maintenance schedules that show the required service for your vehicle. First is chedule B. t is for vehicles that are operated under the conditions that are listed below and at the beginning of the schedule. ay or night temperatures are below 32 F(0 ). top and go driving. xtensive engine idling. riving in dusty conditions. hort trips of less than 10 miles (16 km). ore than 50% of your driving is at sustained high speeds during hot weather, above 90 F (32 ). railer towing.

3 axi, police, or delivery service (commercial service). Off-road or desert operation. O: ost vehicles are operated under the conditions listed for chedule B. econd is chedule. t is for vehicles that are not operated under any of the conditions listed under chedule B. se the schedule that best describes your driving conditions. Where time and mileage are listed, follow the interval that occurs first. O! Failure to perform the required maintenance items may result in damage to the vehicle. t ach top for Fuel 449 heck the engine oil level about 5 minutes after a fully warmed engine is shut off. hecking the oil level while the vehicle is on level ground will improve the accuracy of the oil level reading. dd oil only when the level is at or below the or mark. heck the windshield washer solvent and add if required. Once a onth heck tire pressure and look for unusual wear or damage. nspect the battery and clean and tighten the terminals as required. heck the fluid levels of coolant reservoir, brake master cylinder and transmission; add as needed.

4 450 heck all lights and all other electrical items for correct operation. t ach Oil hange hange the engine oil filter. nspect the exhaust system. nspect the brake hoses. nspect the V joints and front suspension components. heck the automatic transmission fluid level. heck the coolant level, hoses, and clamps.

5 B Follow schedule B if you usually operate your vehicle under one or more of the following conditions. hange the automatic transmission fluid and filter every 60,000 miles ( km) if the vehicle is usually operated under one or more of the conditions marked with an. ay or night temperatures are below 32 F(0 ). top and go driving. xtensive engine idling. riving in dusty conditions. hort trips of less than 10 miles (16 km). ore than 50% of your driving is at sustained high speeds during hot weather, above 90 F (32 ). railer towing. axi, police, or delivery service (commercial service). Off-road or desert operation. B 451

6 452 B iles 3, 000 6, 000 9, , , 000 1, 000 (Kilometers) (5 000 ) ( ) (15 000) (20 000) (25 000) (30 000) hange engine oil and engine oil filter. Rotate ires nspect the brake linings. nspect the engine air cleaner filter, replace if necessary. * Replace the engine air cleaner filter. * nspect and adjust the power steering pump belt tension on 2.4 liter engines. nspect the generator belt on 2.4 liter engines, replace if necessary. Replace the air conditioning filter.

7 B 453 iles 21, , , , , , 000 (Kilometers) (35 000) (40 000) (45 000) (50 000) (55 000) (60 000) hange engine oil and engine oil filter. Rotate ires nspect the brake linings. nspect the engine air cleaner filter, replace if necessary. * Replace the engine air cleaner filter. Replace the spark plugs 2.4 liter engines. nspect the tie rod ends and boot seals. nspect and adjust the power steering pump belt tension on 2.4 liter engines. nspect the generator belt on 2.4 liter engines, replace if necessary. nspect the PV valve and replace as necessary.* Replace the air conditioning filter.

8 454 B iles 39, , , 000 4, , , 000 (Kilometers) (65 000) (70 000) (75 000) (0 000) (5 000) (90 000) hange engine oil and engine oil filter. Rotate ires nspect the brake linings. nspect the engine air cleaner filter, replace if necessary. * Replace the engine air cleaner filter. * nspect and adjust the power steering pump belt tension on 2.4 liter engines. nspect the generator belt on 2.4 liter engines, replace if necessary. Replace the air conditioning filter.

9 B 455 iles 57, , , , , , 000 (Kilometers) (95 000) ( ) ( ) ( ) ( ) ( ) hange engine oil and engine oil filter. Rotate ires nspect the brake linings. nspect the engine air cleaner filter, replace if necessary. * Replace the engine air cleaner filter. Replace the spark plugs on 2.4 liter engines. Replace the ignition cables on 2.4 liter engines. nspect the tie rod ends and boot seals. nspect and adjust the power steering pump belt tension on 2.4 liter engines. nspect the generator belt on 2.4 liter engines, replace if necessary. nspect the PV valve and replace if necessary.* nspect the serpentine drive belt on 3.3 liter and 3. liter engines, replace if necessary. hange the automatic transmission fluid and filter. Replace the air conditioning filter.

10 456 B iles 75, 000 7, 000 1, 000 4, 000 7, , 000 (Kilometers) ( ) ( ) ( ) ( ) ( ) ( ) hange engine oil and engine oil filter. Rotate ires nspect the brake linings. nspect the engine air cleaner filter, replace if necessary. * Replace the engine air cleaner filter Replace the spark plugs on 3.3 liter and 3. liter engines. Replace the ignition cables on 3.3 liter and 3. liter engines. Replace the spark plugs on 2.4 liter engines. nspect and adjust the power steering pump belt tension on 2.4 liter engines. nspect the generator belt on 2.4 liter engines, replace if necessary. nspect the tie rod ends and boot seals.

11 B 457 iles 75, 000 7, 000 1, 000 4, 000 7, , 000 (Kilometers) ( ) ( ) ( ) ( ) ( ) ( ) nspect the serpentine drive belt on 3.3 liter and 3. liter engines, replace if necessary. heck the PV valve and replace if necessary. ot required if previously changed.* Replace the engine timing belt on 2.4 liter engines. * Replace the air conditioning filter.

12 45 B iles 93, , , , , 000 (Kilometers) ( ) ( ) ( ) ( ) ( ) hange engine oil and engine oil filter. Rotate ires nspect the brake linings. nspect the engine air cleaner filter, replace if necessary. * Replace the engine air cleaner filter * nspect and adjust the power steering pump belt tension on 2.4 liter engines. nspect the generator belt on 2.4 liter engines, replace if necessary. nspect the serpentine drive belt on 3.3 liter and 3. liter engines, replace if necessary. Flush and replace the engine coolant. Replace the air conditioning filter.

13 B 459 iles 10, , , , , 000 (Kilometers) (10 000) (15 000) ( ) ( ) ( ) hange engine oil and engine oil filter. Rotate ires nspect the brake linings. nspect the engine air cleaner filter, replace if necessary. * Replace the engine air cleaner filter. Replace the spark plugs on 2.4 liter engines. Replace the ignition cables on 2.4 liter engines. nspect and adjust the power steering pump belt tension on 2.4 liter engines. nspect the generator belt on 2.4 liter engines, replace if necessary. nspect the serpentine drive belt on 3.3 liter and 3. liter engines, replace if necessary. nspect the tie rod ends and boot seals. nspect the PV valve and replace as necessary.* hange the automatic transmission fluid and filter. Replace the air conditioning filter.

14 460 B iles 123, , , , , 000 (Kilometers) ( ) ( ) ( ) ( ) ( ) hange engine oil and engine oil filter. Rotate ires nspect the brake linings. nspect the engine air cleaner filter, replace if necessary. * Replace the engine air cleaner filter. nspect and adjust the power steering pump belt tension on 2.4 liter engines. nspect the generator belt on 2.4 liter engines, replace if necessary. nspect the serpentine drive belt on 3.3 liter and 3. liter engines, replace if necessary. Replace the air conditioning filter.

15 B 461 iles 13, , , , , 000 (Kilometers) ( ) ( ) ( ) ( ) ( ) hange engine oil and engine oil filter. Rotate ires nspect the brake linings. nspect the engine air cleaner filter, replace if necessary. * Replace the engine air cleaner filter. Replace the spark plugs on 2.4 liter, 3.3 liter and 3. liter engines. nspect and adjust the power steering pump belt tension on 2.4 liter engines. nspect the generator belt on 2.4 liter engines, replace if necessary. nspect the serpentine drive belt on 3.3 liter and 3. liter engines, replace if necessary.

16 462 B iles 13, , , , , 000 (Kilometers) ( ) ( ) ( ) ( ) ( ) nspect the tie rod ends and boot seals. nspect the PV valve and replace as necessary.* Replace the air conditioning filter. * his maintenance is recommended by the manufacture to the owner but is not required to maintain the emissions warranty. his maintenance is not required if previously replaced. his maintenance is required only for police, taxi, limousine type operation, or trailer towing. nspection and service should also be performed anytime a malfunction is observed or suspected. Retain all receipts.

17 463 iles 6, , 000 1, , , , 000 (Kilometers) (10 000) (20 000) (30 000) ( ) (50 000) (60 000) [onths] [6] [12] [1] [24] [30] [36] hange engine oil and engine oil filter. Rotate ires nspect the brake linings. nspect the engine air cleaner filter, replace if necessary. * Replace the engine air cleaner filter. Replace the spark plugs on 2.4 liter engines. nspect the tie rod ends and boot seals. nspect and adjust the power steering pump belt tension on 2.4 liter engines. Replace the air conditioning filter.

18 464 iles 42, 000 4, , , , , 000 (Kilometers) (70 000) (0 000) (90 000) ( ) ( ) ( ) [onths] [42] [4] [54] [60] [66] [72] hange engine oil and engine oil filter. Rotate ires nspect the brake linings. nspect the engine air cleaner filter, replace if necessary. * Replace the engine air cleaner filter. Replace the spark plugs on 2.4 liter engines. Replace the ignition cables 2.4 liter engines. nspect and adjust the power steering pump belt tension on 2.4 liter engines. nspect the tie rod ends and boot seals. nspect the generator belt on 2.4 liter engines, replace if necessary.

19 465 iles 42, 000 4, , , , , 000 (Kilometers) (70 000) (0 000) (90 000) ( ) ( ) ( ) [onths] [42] [4] [54] [60] [66] [72] heck the PV valve and replace, if necessary.* nspect the serpentine drive belt on 3.3 liter and 3. liter engines, replace if necessary. Flush and replace the engine coolant at 60 months or 100,000 miles, whichever comes first. Replace the air conditioning filter.

20 466 iles 7, 000 4, , , , 000 (Kilometers) ( ) ( ) ( ) ( ) ( ) [onths] [7] [4] [90] [96] hange engine oil and engine oil filter. Rotate ires nspect the brake linings. nspect the engine air cleaner filter, replace if necessary. * Replace the engine air cleaner filter. Replace the spark plugs on 2.4 liter engines. nspect the tie rod ends and boot seals. nspect and adjust the power steering pump belt tension on 2.4 liter engines. heck and replace the PV valve, if necessary.* nspect the serpentine drive belt on 3.3 liter and 3. liter engines, replace if necessary.

21 467 iles 7, 000 4, , , , 000 (Kilometers) ( ) ( ) ( ) ( ) ( ) [onths] [7] [4] [90] [96] Replace the spark plugs 3.3 liter and 3. liter engines. Replace the ignition cables 3.3 liter and 3. liter engines. Flush and replace the engine coolant at 60 months or 100,000 miles, whichever comes first. Replace the air conditioning filter.

22 46 iles 102, , , , 000 (Kilometers) ( ) (10 000) ( ) ( ) [onths] [102] [10] [114] [120] hange engine oil and engine oil filter. Rotate ires nspect the brake linings. nspect the engine air cleaner filter, replace if necessary. * Replace the engine air cleaner filter. Replace the spark plugs on 2.4 liter engines. Replace the ignition cables 2.4 liter engines. nspect and adjust the power steering pump belt tension on 2.4 liter engines. nspect the generator belt on 2.4 liter engines, replace if necessary. nspect the tie rod ends and boot seals. heck the PV valve and replace, if necessary.*

23 469 iles 102, , , , 000 (Kilometers) ( ) (10 000) ( ) ( ) [onths] [102] [10] [114] [120] nspect the serpentine drive belt on 3.3 liter and 3. liter engines, replace if necessary. Replace the engine timing belt on 2.4 liter engines only. Flush and replace the engine coolant at 120 months, if not done at 100,000 miles ( km). Replace the air conditioning filter.

24 470 iles 126, , , , , 000 (Kilometers) ( ) ( ) ( ) ( ) ( ) [onths] [126] [132] [13] [144] [150] hange engine oil and engine oil filter. Rotate ires nspect the brake linings. nspect the engine air cleaner filter, replace if necessary. * Replace the engine air cleaner filter. Replace the spark plugs on 2.4 liter engines. nspect and adjust the power steering pump belt tension on 2.4 liter engines. nspect the generator belt on 2.4 liter engines, replace if necessary. nspect the tie rod ends and boot seals. heck the PV valve and replace, if necessary.*

25 iles 126, , , , , 000 (Kilometers) ( ) ( ) ( ) ( ) ( ) [onths] [126] [132] [13] [144] [150] nspect the serpentine drive belt on 3.3 liter and 3. liter engines, replace if necessary. Replace the air conditioning filter. * his maintenance is recommended by the manufacture to the owner but is not required to maintain the emissions warranty. his maintenance is not required if previously replaced. nspection and service should also be performed anytime a malfunction is observed or suspected. Retain all receipts. WRG! 471 You can be badly injured working on or around a motor vehicle. o only that service work for which you have the knowledge and the right equipment. f you have any doubt about your ability to perform a service job, take your vehicle to a competent mechanic.

MAINTENANCE SCHEDULES

MAINTENANCE SCHEDULES M O mission ontrol ystem Maintenance...426 chedule B...429 Maintenance chedules...426 chedule...440 M M 426 M MO ORO YM M he cheduled maintenance services, listed in bold type must be done at the times