SELECTION LIST REVISION Form #

Transcription

1 SELECTION LIST REVISION Form # WESTERN PRODUCTS P.O. BOX MILWAUKEE, WISCONSIN A Division of Douglas Dynamics, L.L.C. Printed in the U.S.A. The following are registered trademarks of Douglas Dynamics, L.L.C.: WESTERN, UniMount, and MVP. Western Products reserves the right under its product improvement policy to change construction or design details and furnish equipment when so altered without reference to illustrations or specifications used herein. Western Products and the vehicle manufacturer may require and/or recommend optional equipment for snow removal.

2

3 CONTENTS ABOUT THE SELECTION LIST VEHICLE LAMP IDENTIFICATION GUIDE... DEFINITIONS HOW TO USE THE SELECTION LIST INSTRUCTIONS FOR VEHICLES WITH DIFFERENT FGAWR's iii iv v vi vii 1 CHEVY / GMC DODGE FORD (SPRING CHART) FORD FORD F450 & F OTHER UNIVERSAL WEIGHT AND DIMENSIONAL CHART DIMENSIONAL DIAGRAM UltraMount to UniMount Conversion Kit VEHICLE AND PLOW APPLICATION INQUIRY SHEET WESTERN PRODUCTS 2003 UniMount REV 0 i

4

5 2003 UniMount SELECTION LIST Western Products' published vehicle recommendations are based on the following: Compliance with the vehicle manufacturer s stated gross vehicle and axle weight ratings (found on the driver side door jam of the vehicle) and front and rear weight distribution ratio with the snowplow installed. In some cases, rear ballast may be required to achieve these requirements. Available capacity for the snowplow equipment is based on a representative vehicle as configured by the original vehicle manufacturer. Available capacity decreases as the vehicle is loaded with cargo or by the installation of other truck equipment or accessories. If there is uncertainty as to whether available capacity exists, the actual vehicle as configured must be weighed. For more information, see the weight and dimensional chart located at the end of the Selection List. Installation, modifications and addition of accessories must comply with published Western Products recommendations and instructions. Compliance with applicable FMVSS (Federal Motor Vehicle Safety Standards) must be met. In some cases, there may be additional limitations and requirements such as special vehicle options and specifications, or air bags/lift kits. You will see more specific requirements listed as you use the Selection List to identify plow vehicles including: body style, engine size, ballast requirements, and minimum front gross axle weight ratings (FGAWR). Discuss the following topics with each of your plowing customers and prospective plow purchasers. BALLAST Ballast is an important part of qualifying vehicles for plow eligibility. Rear ballast must be used when recommended to remain in compliance with axle ratings and ratios as specified by the vehicle manufacturer. If ballast is required, it is important that it be secured properly behind the rear axle. A ballast retainer kit is available from Western Products, part # PLOWING RECOMMENDATIONS It is also important to remember that in all plowing applications, Western Products recommends only the driver in the vehicle. Although plowing conditions can vary widely, as a general guideline Western Products recommends the maximum plowing speed of 10 mph and the maximum recommended transport speed of 45 mph. WESTERN PRODUCTS 2003 UniMount REV 0 iii

6 VEHICLE LAMP IDENTIFICATION GUIDE NOTE: The lamp type is usually embossed in the headlamp lens. NOTE: Blue ground wires may be LT or DK BLUE, w/ or w/o WHT stripe, depending on harness. Headlamp Type LF UF 1A1 2A1 2B1 2D1 2E1 HB1 HB3 HB4 HB5 Bulb Type H4703 H4701 H4651 H4652(Chevy/GMC) H6054 H6024 H LAMP TYPE LAMP SIZE CONFIGURATION DESCRIPTION 1A / 2A 4 x 6.5 Quad Rectangular Lamp 2B 5.5 x 7.88 Dual Rectangular Lamp 2D 7 DIA. Dual Round Lamp 2E 4 x 6.5 Dual Rectangular (Small Halogen Lamp) HB1 Can Vary Dual Rectangular Halogen Lamp HB3 / HB4 Can Vary Quad Composite Halogen Lamp HB5 Can Vary Dual Rectangular Halogen Lamp LF / UF 3.64 x 5.93 Quad Rectangular Halogen Lamp GROUND 1A/2A LOW GROUND HIGH GROUND 2B/2D HIGH GROUND HIGH LOW 2E GROUND LOW HB1 HIGH LOW GROUND BLUE (GND) ORANGE (LOW) RED (HIGH) YELLOW (LOW) GREEN (HIGH) BLUE (GND) BLUE (GND) ORANGE (LOW) RED (HIGH) GREEN (HIGH) YELLOW (low) BLUE (GND) LOW HIGH GROUND HIGH LOW GROUND BLUE (GND) RED (HIGH) BLUE (GND) GREEN (HIGH) YELLOW (LOW) ORANGE (LOW) RED (HIGH) BLUE (GND) BLUE (GND) RED (HIGH) BLUE (GND) ORANGE (LOW) RED (HIGH) GREEN (HIGH) YELLOW (LOW) BLUE (GND) HB3/ HB4 Lowside Drive System ( Chevy/GMC Only) HIGH COMMON (12V) LOW HIGH COMMON (12V) LOW GROUND GROUND HIGH LOW HB3/ HB4 Highside Drive System GROUND GROUND HIGH LOW HB5 LF / UF LOW HIGH LOW GROUND GROUND GROUND HIGH LOW GROUND HIGH RED (HIGH) BLUE (COMMON 12V) ORANGE (LOW) BLUE (COMMON 12V) GREEN (HIGH) BLUE or PINK (COMMON 12V) YELLOW (LOW) BLUE (COMMON 12V) BLUE (GND) ORANGE (LOW) BLUE (GND) GREEN (HIGH) BLUE (GND) YELLOW (LOW) ORANGE (LOW) BLUE (GND) RED (HIGH) GREEN (HIGH) BLUE (GND) YELLOW (LOW) GREEN (HIGH) BLUE (GND) YELLOW (LOW) BLUE (GND) YELLOW (LOW) BLUE (GND) BLUE (GND) RED (HIGH)

7 ABBREVIATION 2WD 4x4 A,Q&L B DRL DESCRIPTION Two wheel drive Four wheel drive A-frame, quadrant & lift frame Ballast required Daytime running lights BLADE ABBREVIATIONS DRW Dual rear wheels PLOW TYPE BLADE TYPE BLADE SIZES FGAWR Front gross axle weight rating U - UniMount plow SU - Sport/Utility* /2' GVWR Gross vehicle weight rating LSX - Light Service 7.0-7' HD Heavy duty S - Standard 7.2-7' 2" HW Heavy Weight SY - Standard Poly /2' HYD Hydraulic P - Pro-Plow TM 8.0-8' L Lift frame PY - Poly Pro-Plow TM /2' LSX Light Service HW - Heavy Weight 9.0-9' MIN Minimum MVP - MultiPosition V-plow /2' MVP MultiPosition V-plow ' N No *For non-commercial use only O Plow option P Pro-Plow TM ASSEMBLIES DEFINITION PKG Package BLADE ASSEMBLY UniMount blade PY Poly Pro-Plow TM MVP blade and A-frame REQ Required ATTACHMENT ASSEMBLY UniMount A-frame, quadrant & lift frame S Standard MVP lift frame SU Sport/Utility* SUSP Suspension SY Standard Poly U UniMount plow W With W/O Without X-CAB Extended cab vehicle Y Yes WESTERN PRODUCTS 2003 UniMount REV 0 v DEFINITIONS

8 HOW TO USE THE SNOWPLOW SELECTION LIST Determining plow options: 1.) Locate vehicle by make, 4 wheel (4x4) or 2 wheel (2WD) drive, model, year and body style (columns 1 & 2) 2.) Column 3 labeled "OTHER" will list other requirements or modifications if needed for plow compatibility. 3.) Verify that vehicle meets any engine and FGAWR (front gross axle weight rating) (columns 4 and 5). FGAWR can be found on the driver side door jam. 4.) Identify vehicle headlamp type and whether or not it is DRL (Daytime Running Lights) equipped (columns 6and 7) By answering the DRL question, you have now narrowed your choices down to one row. 5.) Reading across, you will first see the plow model number and type letter code (column 8) U - UniMount PLOW followed by the recommended plow options and ballast requirements available for that vehicle (columns 9 through 36). 6.) Once you have determined which plow option you want, use the letters in the appropriate box along with the plow model number (in this example 3525) and turn to the component list found at the end of each manufacturer's section to find the individual component numbers that make up that plow. You may order two ways: A) By complete plow using the complete plow code. (example: ordering a 3525AA will fill the order for a , 60018, 61720, 56365, 64078, 64077, and NO additional DRL kit) B) By individual component using the corresponding part numbers. (example: ordering just the 62110, you are ordering the 7.5' Standard Poly blade.) 7) Vehicle information that is highlighted in BLACK indicates a change since the last revision of selection list. 8) Vehicles with a? In the ballast columns indicate that there is a mount available for that vehicle but one must weigh completed vehicle to determine plow size and ballast. See "Weight and Dimensional Chart" at end of selection list along with Body Builders Guides for necessary vehicle information. Col. 1 Col. 2 Col. 3 Col. 4 Col. 5 Col. 6 Col. 7 Col. 8 Col (Number of columns vary by plow availability for specific truck manufacturer) CHEVY/GMC FOUR WHEEL DRIVE Vehicle Options Plow Options (O) and Ballast Required (B) MODEL/ BODY OTHER ENGINE(S) MIN HEAD DRL PLOW LSX 7.2 S 7.5 SY 7.5 P 7.5 PY 7.5 P 8.0 PY 8.0 P 8.5 P 9.0 MVP 8.5 CHASSIS STYLE FGAWR LAMP? MODEL O B O B O B O B O B O B O B O B O B O B SILVERADO/SIERRA X-Cab 6.5' Box 6.0L V HB3/HB4 Y 3525 AJ 200 AA 250 AB 300 AC 350 AD 400 AE 350 AF 400 AG 350 AH 400 AI 450 K2500 Pick-up 4x4 Z85 or Snowplow prep. --- U (Bumper notching required) package recommended 4410 HB3/HB4 Y AJ 200 AA 250 AB 300 AC 350 AD 400 AE 350 AF 400 AG 350 AH 400 AI COMPLETE PLOW CHEVY/GMC COMPONENT NUMBERS MODEL OPTION BLADE SIZE MOUNT BLADE ATTACHMENT HYDRAULIC LAMP KIT HARNESS DRL KIT ASSEMBLY ASSEMBLY ASSEMBLY ASSEMBLY KIT 3525 AA S UNIMOUNT PLOW AB SY AC P AD PY AE P AF PY AG P AH P AI MVP AJ LSX

9 Instructions for Vehicles with Different Front Gross Axle Weight Ratings (FGAWR) WARNING 1. Calculate the change in ballast required for alternate FGAWR's using the following formula: Do not exceed GVWR or GAWR, including blade and ballast. The rating label is found on the driver-side vehicle door cornerpost Additional Ballast = (R1 - R2) x L101 (L105-14) NOTE: When ballast is required, it should be Key: secured behind the rear wheels in a manner R1 = FGAWR as found in the Selection List. which prevents it from sliding during normal R2 = FGAWR as indicated on rating label found driving. Western Products offers an optional on the driver-side vehicle door cornerpost. ballast retainer kit (62849) for this purpose. L101 = vehicle's wheelbase L105 = distance from the rear axle to the NOTE: New UNTITLED vehicle installation of a tailgate's rear surface snow plow requires National Highway Traffic Safety Administration altered vehical certification 2. When R2 is higher than R1, the ballast certification labeling. Installer to verify that calculated above can be removed from the selected snow plow and ballast, if required, do amount specified in the Selection List. When R1 not exceed GVWR or GAWR rating label. is higher than R2, the ballast calculated above must be added to the amount specified in the Selection List. WESTERN PRODUCTS 2003 UniMount REV 0 vii

10 FOUR WHEEL DRIVE Vehicle Options CHEVY/GMC Plow Options (O) and Ballast Required (B) MODEL/ BODY OTHER ENGINE(S) MIN HEAD DRL PLOW LSX 7.2 S 7.5 SY 7.5 P 7.5 PY 7.5 P 8.0 PY 8.0 P 8.5 P 9.0 MVP 8.5 CHASSIS STYLE FGAWR LAMP? MODEL O B O B O B O B O B O B O B O B O B O B Tahoe/Yukon 4.8L V HB3/HB4 Y 3515 AK 0 AL 300 4x4 5.3L V HB3/HB4 Y U AK 0 AL 250 (Bumper notching required) --- Suburban/Yukon XL 5.3L V HB3/HB4 Y 3515 AK x4 5.3L V HB3/HB4 Y U AK 300 (Bumper notching required) --- Suburban/Yukon XL 6.0L V HB3/HB4 Y 3525 AK 0 AL 0 AM 0 AN 0 AO 150 AP 50 AQ 200 AR 100 AS x4 8.1L V HB3/HB4 Y U AK 50 (Bumper notching required) --- Avalanche x4 5.3L V HB3/HB4 Y 3515 AK 50 (Major bumper notching required) --- U Avalanche x4 8.1L V HB3/HB4 Y 3525 AK 0 AL 100 AM 300 AN 550 AO 800 AP 650 AQ 800 (Major bumper notching required) --- U Sierra Denali X-Cab 6.5' Box 6.0L V HB3/HB4 Y 3515 AK 100 4x4 --- U (Bumper notching required) --- SILVERADO/SIERRA Reg Cab 6.5' Box 4.3L V HB3/HB4 Y 3515 AK 250 AL 350 AM 400 AN 400 AO 450 AP 450 AQ 450 K1500 Pick-up 4x4 Z85 or Snowplow prep. 4.8L V HB3/HB4 Y U AK 300 AL 400 AM 400 AN 450 AO 500 AP 500 AQ 500 (Bumper notching required) package recommended 5.3L V HB3/HB4 Y AK 300 AL 400 AM 400 AN 450 AO 500 AP 500 AQ ' Box 4.3L V HB3/HB4 Y AK 250 AL 350 AM 400 AN 400 AO 450 AP 450 AQ 450 Z85 or Snowplow prep. 4.8L V HB3/HB4 Y AK 300 AL 400 AM 400 AN 450 AO 500 AP 450 AQ 500 package recommended 5.3L V HB3/HB4 Y AK 300 AL 400 AM 400 AN 450 AO 500 AP 450 AQ 500 X-Cab 6.5' Box 4.8L V HB3/HB4 Y AK 300 AL 400 AM 400 AN 450 AO 550 AP 450 Z85 or Snowplow prep. --- package recommended 5.3L V HB3/HB4 Y AK 300 AL 400 AM 400 AN 450 AO 550 AP ' Box w/ 4 Wheel Steering 5.3L V HB3/HB4 Y AK 50 AL 150 AM 200 AN 400 AO 650 AP 500 AQ 700 Z85 or Snowplow prep. --- package recommended --- Min GVWR ' Box 4.8L V HB3/HB4 Y AK 300 AL 400 AM 400 Z85 or Snowplow prep. --- package recommended 5.3L V HB3/HB4 Y AK 300 AL 400 AM SILVERADO/SIERRA Crew Cab 6.5' Box 6.0L V HB3/HB4 Y 3525 AK 300 AL 400 AM 400 AN 450 AO 500 AP 500 AQ 500 AR 500 AS 500 AT 600 K1500HD Pick-up 4x4 Z85 or Snowplow prep. --- U (Bumper notching required) package recommended ' Box w/ 4 Wheel Steering 6.0L V HB3/HB4 Y AK 100 AL 200 AM 200 AN 250 AO 300 AP 300 AQ 300 AR 300 AS 300 AT 400 Z85 or Snowplow prep. --- package recommended --- Min. 8,600 lb. GVWR --- SILVERADO/SIERRA X-Cab 6.5' Box 6.0L V HB3/HB4 Y 3525 AK 200 AL 250 AM 300 AN 350 AO 400 AP 350 AQ 400 AR 350 AS 400 AT 450 K2500 Pick-up 4x4 Z85 or Snowplow prep. --- U (Bumper notching required) package recommended 4410 HB3/HB4 Y AK 200 AL 250 AM 300 AN 350 AO 400 AP 350 AQ 400 AR 350 AS 400 AT SILVERADO/SIERRA Reg Cab 8.0' Box 6.0L V HB3/HB4 Y 3525 AK 100 AL 200 AM 250 AN 300 AO 300 AP 300 AQ 300 AR 300 AS 350 AT 400 K2500HD Pick-up 4x4 Z85 or Snowplow prep HB3/HB4 Y U AK 100 AL 200 AM 250 AN 300 AO 300 AP 300 AQ 300 AR 300 AS 350 AT 400 (Bumper notching required) package recommended 8.1L V HB3/HB4 Y AK 200 AL 300 AM 350 AN 350 AO 400 AP 400 AQ 400 AR 400 AS 400 AT HB3/HB4 Y AK 200 AL 300 AM 350 AN 350 AO 500 AP 400 AQ 550 AR 500 AS L Diesel 4800 HB3/HB4 Y AK 300 AL 400 AM 400 AN 450 AO 500 AP 450 AQ 500 AR 500 AS 500 AT HB3/HB4 Y AK 300 AL 550 AM 700 AN 950 X-Cab 6.5' Box 6.0L V HB3/HB4 Y AK 200 AL 300 AM 300 AN 350 AO 400 AP 350 AQ 400 AR 400 AS 400 AT 500 Z85 or Snowplow prep HB3/HB4 Y AK 200 AL 300 AM 300 AN 350 AO 400 AP 350 AQ 400 AR 400 AS 400 AT 500 package recommended 8.1L V HB3/HB4 Y AK 300 AL 400 AM 400 AN 450 AO 500 AP 450 AQ 500 AR 500 AS 500 AT HB3/HB4 Y AK 300 AL 400 AM 400 AN 450 AO 500 AP 450 AQ 500 AR 500 AS L Diesel 4800 HB3/HB4 Y AK 350 AL 450 AM 500 AN 500 AO 550 AP 550 AQ 600 AR 550 AS HB3/HB4 Y AK 350 AL 450 AM 600 AN 850 AP 950

11 CHEVY/GMC FOUR WHEEL DRIVE Vehicle Options Plow Options (O) and Ballast Required (B) MODEL/ BODY OTHER ENGINE(S) MIN HEAD DRL PLOW LSX 7.2 S 7.5 SY 7.5 P 7.5 PY 7.5 P 8.0 PY 8.0 P 8.5 P 9.0 MVP 8.5 CHASSIS STYLE FGAWR LAMP? MODEL O B O B O B O B O B O B O B O B O B O B SILVERADO/SIERRA X-Cab 8.0' Box 6.0L V HB3/HB4 Y 3525 AK 150 AL 200 AM 250 AN 300 AO 300 AP 300 AQ 350 AR 300 AS 350 AT 400 K2500HD Pick-up 4x4 (continued) Z85 or Snowplow prep HB3/HB4 Y U AK 150 AL 200 AM 250 AN 300 AO 300 AP 300 AQ 350 AR 300 AS 350 AT 400 (Bumper notching required) package recommended 8.1L V HB3/HB4 Y AK 250 AL 350 AM 350 AN 400 AO 450 AP 400 AQ 450 AR 450 AS 450 AT 900 (continued) 4670 HB3/HB4 Y AK 250 AL 350 AM 400 AN 650 AO 850 AP 750 AQ 900 AR 800 AS L Diesel 4800 HB3/HB4 Y AK 300 AL 400 AM 450 AN 650 AO 900 AP 800 AQ 950 AR 850 AS HB3/HB4 Y AK 300 AL 800 AM 950 Crew Cab 6.5' Box 6.0L V HB3/HB4 Y AK 50 AL 150 AM 200 AN 250 AO 250 AP 250 AQ 250 AR 250 AS 300 AT 350 Z85 or Snowplow prep HB3/HB4 Y AK 50 AL 150 AM 200 AN 250 AO 250 AP 250 AQ 250 AR 250 AS 300 AT 350 package recommended 8.1L V HB3/HB4 Y AK 150 AL 250 AM 300 AN 350 AO 450 AP 350 AQ 500 AR 400 AS 500 Min. 9,200 lb. GVWR 4670 HB3/HB4 Y AK 150 AL 300 AM 500 AN 800 AP 900 AR L Diesel 4800 HB3/HB4 Y AK 250 AL 450 AM 650 AN HB3/HB4 Y AK ' Box 6.0L V HB3/HB4 Y AK 100 AL 200 AM 200 AN 250 AO 300 AP 250 AQ 300 AR 250 AS 300 AT 350 Z85 or Snowplow prep HB3/HB4 Y AK 100 AL 200 AM 200 AN 250 AO 300 AP 250 AQ 300 AR 250 AS 300 AT 350 package recommended 8.1L V HB3/HB4 Y AK 150 AL 250 AM 300 AN 300 AO 500 AP 400 AQ 550 AR 500 AS 600 Min. 9,200 lb. GVWR 4670 HB3/HB4 Y AK 150 AL 400 AM 600 AN 850 AP L Diesel 4800 HB3/HB4 Y AK 250 AL 650 AM HB3/HB4 Y AK 550 SILVERADO/SIERRA All Z85 or Snowplow All All HB3/HB4 Y 3525 AK? AL? AM? AN? AO? AP? AQ? AR? AS? AT? K2500 Chassis Cab 4x4 package recommended --- U (Bumper notching required) Min. 8,500 lb. GVWR --- SILVERADO/SIERRA Reg Cab 8.0' Box 6.0L V HB3/HB4 Y 3525 AR 100 AS 100 AT 200 K3500 Pick-up 4x4 Dual rear wheels 4500 HB3/HB4 Y U AR 100 AS 100 AT 200 (Bumper notching required) Z85 or Snowplow prep. 8.1L V HB3/HB4 Y AR 250 AS 250 AT 350 package recommended 4500 HB3/HB4 Y AR 650 AS L Diesel 4800 HB3/HB4 Y AR 300 AS 300 AT X-Cab 8.0' Box 6.0L V HB3/HB4 Y AR 50 AS 100 AT 150 Dual rear wheels --- Z85 or Snowplow prep. 8.1L V HB3/HB4 Y AR 200 AS 200 AT 500 package recommended L Diesel 4800 HB3/HB4 Y AR 550 AS Crew Cab 8.0' Box 6.0L V HB3/HB4 Y AR 0 AS 50 AT 100 Dual rear wheels --- Z85 or Snowplow prep. 8.1L V HB3/HB4 Y AR 950 package recommended --- SILVERADO/SIERRA All Dual rear wheels All All HB3/HB4 Y 3525 AR? AS? AT? K3500 Chassis Cab 4x4 Min. 8,500 lb. GVWR --- U (Bumper notching required) --- SILVERADO/SIERRA All Dual rear wheels All All HB3/HB4 Y 3525 AR? AS? AT? K3600 Chassis Cab 4x4 Min. 8,500 lb. GVWR --- U (Straight Frame) --- (Bumper notching required) --- WESTERN PRODUCTS 2003 UniMount REV 0 2 CHEVY / GMC

12 TWO WHEEL DRIVE Vehicle Options CHEVY/GMC (TWO WHEEL DRIVE) Plow Options (O) and Ballast Required (B) MODEL/ BODY OTHER ENGINE(S) MIN HEAD DRL PLOW LSX 7.2 S 7.5 SY 7.5 P 7.5 PY 7.5 P 8.0 PY 8.0 P 8.5 P 9.0 MVP 8.5 CHASSIS STYLE FGAWR LAMP? MODEL O B O B O B O B O B O B O B O B O B O B SILVERADO/SIERRA X-Cab 8.0' Box 6.0L V HB3/HB4 Y 3525 AR 0 AS 0 AT 50 C3500 Pick-up 2WD Dual rear wheels 4670 HB3/HB4 Y U AR 0 AS 0 AT 50 (Bumper notching required) Min. 10,000 lb. GVWR 8.1L V HB3/HB4 Y AR 150 AS 150 AT HB3/HB4 Y AR 150 AS 150 AT L Diesel 4800 HB3/HB4 Y AR 200 AS 200 AT HB3/HB4 Y AR 400 AS 550 Crew Cab 8.0' Box 6.0L V HB3/HB4 Y AR 0 AS 0 AT 0 Dual rear wheels 4670 HB3/HB4 Y AR 0 AS 0 AT 0 Min. 10,000 lb. GVWR 8.1L V HB3/HB4 Y AR 100 AS 100 AT HB3/HB4 Y AR 250 AS 350 AT L Diesel 4800 HB3/HB4 Y AR 350 AS 500 AT HB3/HB4 Y AR 950 SILVERADO/SIERRA All Dual rear wheels All All HB3/HB4 Y 3525 AR? AS? AT? C3500 Chassis Cab 2WD Min. 10,000 lb. GVWR --- U (Bumper notching required) --- SILVERADO/SIERRA All Dual rear wheels All All HB3/HB4 Y 3525 AR? AS? AT? C3600 Chassis Cab 2WD Min. 10,000 lb. GVWR --- U (Straight Frame) --- (Bumper notching required) ---

13 CHEVY/GMC COMPLETE PLOW COMPONENT NUMBERS MODEL OPTION BLADE SIZE MOUNT BLADE ATTACHMENT HYDRAULIC LAMP KIT HARNESS DRL KIT ASSEMBLY ASSEMBLY ASSEMBLY ASSEMBLY KIT 1565 AA P UNIMOUNT PLOW AB P AG P AH P AM MVP AN MVP AK LSX UNIMOUNT PLOW AL S AM SY AN P AO PY AP P AQ PY AK LSX UNIMOUNT PLOW AL S AM SY AN P AO PY AP P AQ PY AR P AS P AT MVP WESTERN PRODUCTS 2003 UniMount REV 0 4 CHEVY/GMC

14 DODGE FOUR WHEEL DRIVE Vehicle Options Plow Options (O) and Ballast Required (B) MODEL/ BODY OTHER ENGINE(S) MIN HEAD DRL PLOW S 7.0 LSX 7.2 S 7.5 SY 7.5 P 7.5 PY 7.5 P 8.0 PY 8.0 P 8.5 P 9.0 MVP 8.5 CHASSIS STYLE FGAWR LAMP? MODEL O B O B O B O B O B O B O B O B O B O B O B Durango 4x4 4.7L V HB5 Y 3915 AA 100 AC 0 AE 150 AG 150 Bumper notching N U AB 100 AD 0 AF 150 AH 150 required 5.9L V HB5 Y AA 200 AC 50 AE 300 (Also requires kit # 61185) N AB 200 AD 50 AF 300 Dakota 4x4 Reg Cab 6.5' Box 3.9L V HB5 Y 3915 AA 350 AC 250 AE 400 AG 400 AI 450 AK 500 Bumper notching N U AB 350 AD 250 AF 400 AH 400 AJ 450 AL 500 required 3166 HB5 Y AA 450 AC 250 AE 550 (Also requires kit # 61185) N AB 450 AD 250 AF L V HB5 Y AA 400 AC 300 AE 400 AG 450 AI 450 AK 500 N AB 400 AD 300 AF 400 AH 450 AJ 450 AL 500 Club Cab 6.5' Box 3.9L V HB5 Y AA 350 AC 300 AE 400 AG 400 AI 450 AK 500 N AB 350 AD 300 AF 400 AH 400 AJ 450 AL HB5 Y AC 500 N AD L V HB5 Y AA 400 AC 300 AE 400 AG 450 AI 450 N AB 400 AD 300 AF 400 AH 450 AJ 450 Quad Cab 5.5' Box 3.9L V HB5 Y AA 250 AC 150 AE 250 AG 300 AI 300 AK 450 N AB 250 AD 150 AF 250 AH 300 AJ 300 AL L V HB5 Y AA 250 AC 150 AE 300 AG 300 AI 450 N AB 250 AD 150 AF 300 AH 300 AJ L V HB5 Y AA 250 AC 200 AE 350 N AB 250 AD 200 AF 350 Ram 1500, 2500, 3500 Mount available with UltraMount

15 DODGE COMPLETE PLOW COMPONENT NUMBERS MODEL OPTION BLADE SIZE MOUNT BLADE ATTACHMENT HYDRAULIC LAMP KIT HARNESS DRL KIT ASSEMBLY ASSEMBLY ASSEMBLY ASSEMBLY KIT 3915 AA S UNIMOUNT PLOW AB S AC LSX AD LSX AE S AF S AG SY AH SY AI P AJ P AK PY AL PY WESTERN PRODUCTS 2003 UniMount REV 0 6 DODGE

16 FORD F-SUPER DUTY FRONT SPRING CODES (LOCATED ON LOWER RIGHT HAND CORNER OF DOOR STICKER) A verification of the actual spring rating may be required on F-250/350/450/550 built to date. The FGAWR value may not be correct on the rating label located on the drivers side door cornerpost. To verify this, compare the FIRST LETTER of the spring code located on the lower right hand side of the rating label to the charts below to find the actual spring rating. Tires must be inflated to 65 psi for LT235 and 55 for LT265 to obtain proper tire capacity. A vehicle certification label will have to be attached to the vehicles door cornerpost. Contact the National Truck-Equipment Association (N.T.E.A.) for information and certification labels. (800) Refer to service bulletin SP716 for additional information. Note: Trucks with sway bars may require the removal of the sway bar to clear certain plow mounts. SUPER DUTY F-SERIES / MODEL F WD CODE FGAWR SUPER DUTY CODE FGAWR SUPER DUTY CODE FGAWR F-SERIES / MODEL F-SERIES / MODEL B 3200 F x4 R 3600 F W 5600 C 3350 S 4000 X 6000 D 3500 T 4400 E 3650 U 4800 F 3800 V 5200 G 3950 *W 5600 H 4100 *X 6000 I 4250 J 4400 * These options provide a K 4550 MAXIMUM FGAWR of L 4700

17 FORD FOUR WHEEL DRIVE Vehicle Options Plow Options (O) and Ballast Required (B) MODEL/ BODY OTHER ENGINE(S) MIN HEAD DRL PLOW LSX 7.2 S 7.5 SY 7.5 P 7.5 PY 7.5 P 8.0 PY 8.0 P 8.5 P 9.0 MVP 8.5 CHASSIS STYLE FGAWR LAMP? MODEL O B O B O B O B O B O B O B O B O B O B Excursion 5.4L V HB5 Y 3215 AA 0 AE 0 AI 0 AM 0 AQ 0 AU 50 4x4 N U AB 0 AF 0 AJ 0 AN 0 AR 0 AV L V HB5 Y AA 0 AE 0 AI 150 AQ 250 N AB 0 AF 0 AJ 150 AR 250 F-150 Reg Cab 6.5' Box, Min. GVWR L V HB5 Y 1225 AS 200 AA 350 AC 550 AE 750 Pick-up 4x4 Snowplow prep. N U AT 200 AB 350 AD 550 AF 750 package recommended 3400 HB5 Y AS 500 N AT ' Box, Min. GVWR L V HB5 Y AS 200 AA 300 AC 350 AE 600 AI 700 Snowplow prep. N AT 200 AB 300 AD 350 AF 600 AJ 700 package recommended 3400 HB5 Y AS 350 N AT ' Box, Min. GVWR L V HB5 Y AS 150 AA 650 Snowplow prep. N AT 150 AB 650 package recommended 3200 HB5 Y AS 750 N AT ' Box, Min. GVWR L V HB5 Y AS 200 AA 300 AC 300 AE 350 AG 400 AI 350 AO 400 AK 400 AM 400 AQ 400 Snowplow prep. N AT 200 AB 300 AD 300 AF 350 AH 400 AJ 350 AP 400 AL 400 AN 400 AR 400 package recommended ' Box, Min. GVWR L V HB5 Y AS 250 Snowplow prep. N AT 250 package recommended ' Box, Min. GVWR L V HB5 Y AS 250 AA 600 Snowplow prep. N AT 250 AB 600 package recommended 3400 HB5 Y AS 750 N AT ' Box, Min. GVWR L V HB5 Y AS 200 AA 300 AC 450 Snowplow prep. N AT 200 AB 300 AD 450 package recommended 3400 HB5 Y AS 450 N AT 450 SuperCab 6.5' Box, Min. GVWR L V HB5 Y AS 100 AA 250 AC 250 AE 300 AG 350 AI 300 AO 350 AK 350 AM 350 AQ 450 Snowplow prep. N AT 100 AB 250 AD 250 AF 300 AH 350 AJ 300 AP 350 AL 350 AN 350 AR 450 package recommended ' Box, Min. GVWR L V HB5 Y AS 300 Snowplow prep. N AT 300 package recommended ' Box, Min. GVWR L V HB5 Y AS 150 Snowplow prep. N AT 150 package recommended ' Box 4.6L V HB5 Y AS 200 Snowplow prep. N AT 200 package recommended F-250 Super Duty Reg Cab 8.0' Box 5.4L V HB5 Y 3215 BK 200 AA 300 AE 300 AI 350 AM 400 AQ 350 AU 400 AY 400 BC 400 BG 500 Pick-up 4x4 Snowplow prep. N U BL 200 AB 300 AF 300 AJ 350 AN 400 AR 350 AV 400 AZ 400 BD 400 BH 500 (Vehicles with cab lights package recommended 2B Y BM 200 AC 300 AG 300 AK 350 AO 400 AS 350 AW 400 BA 400 BE 400 BI 500 also require kit # 61185) N BN 200 AD 300 AH 300 AL 350 AP 400 AT 350 AX 400 BB 400 BF 400 BJ 500 (See note on Spring Code 4800 HB5 Y BK 200 AA 300 AE 300 AI 350 AM 400 AQ 350 AU 400 AY 400 BC 400 BG 500 and tire pressure on pg. 7) N BL 200 AB 300 AF 300 AJ 350 AN 400 AR 350 AV 400 AZ 400 BD 400 BH 500 2B Y BM 200 AC 300 AG 300 AK 350 AO 400 AS 350 AW 400 BA 400 BE 400 BI 500 N BN 200 AD 300 AH 300 AL 350 AP 400 AT 350 AX 400 BB 400 BF 400 BJ HB5 Y BK 200 AA 500 AE 650 AI 900 N BL 200 AB 500 AF 650 AJ 900 2B Y BM 200 AC 500 AG 650 AK 900 N BN 200 AD 500 AH 650 AL L V HB5 Y BK 250 AA 350 AE 400 AI 400 AM 450 AQ 450 AU 450 AY 450 BC 450 BG 500 (Air spring kit #63720 N BL 250 AB 350 AF 400 AJ 400 AN 450 AR 450 AV 450 AZ 450 BD 450 BH 500 recommended on 2B Y BM 250 AC 350 AG 400 AK 400 AO 450 AS 450 AW 450 BA 450 BE 450 BI 500 plows 8-1/2' & larger) N BN 250 AD 350 AH 400 AL 400 AP 450 AT 450 AX 450 BB 450 BF 450 BJ HB5 Y BK 250 AA 350 AE 400 AI 400 AM 450 AQ 450 AU 450 AY 450 BC 450 BG 650 N BL 250 AB 350 AF 400 AJ 400 AN 450 AR 450 AV 450 AZ 450 BD 450 BH 650 2B Y BM 250 AC 350 AG 400 AK 400 AO 450 AS 450 AW 450 BA 450 BE 450 BI 650 N BN 250 AD 350 AH 400 AL 400 AP 450 AT 450 AX 450 BB 450 BF 450 BJ HB5 Y BK 350 AA 1000 N BL 350 AB B Y BM 350 AC 1000 N BN 350 AD 1000 WESTERN PRODUCTS 2003 UniMount REV 0 8 FORD

18 FORD FOUR WHEEL DRIVE Vehicle Options Plow Options (O) and Ballast Required (B) MODEL/ BODY OTHER ENGINE(S) MIN HEAD DRL PLOW LSX 7.2 S 7.5 SY 7.5 P 7.5 PY 7.5 P 8.0 PY 8.0 P 8.5 P 9.0 MVP 8.5 CHASSIS STYLE FGAWR LAMP? MODEL O B O B O B O B O B O B O B O B O B O B F-250 Super Duty Reg Cab 8.0' Box 7.3L Diesel 5200 HB5 Y 3215 BK 400 AA 500 AE 550 AI 600 AM 600 AQ 600 AU 600 AY 600 BC 650 BG 850 Pick-up 4x4 (Continued) Snowplow prep. (Air spring kit #63720 N U BL 400 AB 500 AF 550 AJ 600 AN 600 AR 600 AV 600 AZ 600 BD 650 BH 850 (Vehicles with cab lights package recommended recommended on 2B Y BM 400 AC 500 AG 550 AK 600 AO 600 AS 600 AW 600 BA 600 BE 650 BI 850 also require kit # 61185) (Continued) plows 8-1/2' & larger) N BN 400 AD 500 AH 550 AL 600 AP 600 AT 600 AX 600 BB 600 BF 650 BJ 850 (See note on Spring Code 4800 HB5 Y BK 550 and tire pressure on pg. 7) N BL 550 (Continued) 2B Y BM 550 N BN 550 SuperCab 6.75' Box 5.4L V HB5 Y BK 150 AA 250 AE 250 AI 300 AM 350 AQ 300 AU 350 AY 350 BC 350 BG 450 Snowplow prep. N BL 150 AB 250 AF 250 AJ 300 AN 350 AR 300 AV 350 AZ 350 BD 350 BH 450 package recommended 2B Y BM 150 AC 250 AG 250 AK 300 AO 350 AS 300 AW 350 BA 350 BE 350 BI 450 N BN 150 AD 250 AH 250 AL 300 AP 350 AT 300 AX 350 BB 350 BF 350 BJ HB5 Y BK 150 AA 250 AE 250 AI 300 AM 350 AQ 300 AU 350 AY 350 BC 350 BG 450 N BL 150 AB 250 AF 250 AJ 300 AN 350 AR 300 AV 350 AZ 350 BD 350 BH 450 2B Y BM 150 AC 250 AG 250 AK 300 AO 350 AS 300 AW 350 BA 350 BE 350 BI 450 N BN 150 AD 250 AH 250 AL 300 AP 350 AT 300 AX 350 BB 350 BF 350 BJ HB5 Y BK 150 AA 700 AE 900 N BL 150 AB 700 AF 900 2B Y BM 150 AC 700 AG 900 N BN 150 AD 700 AH L V HB5 Y BK 200 AA 300 AE 350 AI 350 AM 400 AQ 400 AU 400 AY 400 BC 400 BG 500 (Air spring kit #63720 N BL 200 AB 300 AF 350 AJ 350 AN 400 AR 400 AV 400 AZ 400 BD 400 BH 500 recommended on 2B Y BM 200 AC 300 AG 350 AK 350 AO 400 AS 400 AW 400 BA 400 BE 400 BI 500 plows 8-1/2' & larger) N BN 200 AD 300 AH 350 AL 350 AP 400 AT 400 AX 400 BB 400 BF 400 BJ HB5 Y BK 200 AA 300 AE 350 AI 350 AM 400 AQ 400 AU 400 AY 400 BC 450 BG 950 N BL 200 AB 300 AF 350 AJ 350 AN 400 AR 400 AV 400 AZ 400 BD 450 BH 950 2B Y BM 200 AC 300 AG 350 AK 350 AO 400 AS 400 AW 400 BA 400 BE 450 BI 950 N BN 200 AD 300 AH 350 AL 350 AP 400 AT 400 AX 400 BB 400 BF 450 BJ HB5 Y BK 700 N BL 700 2B Y BM 700 N BN L Diesel 5200 HB5 Y BK 350 AA 450 AE 500 AI 500 AM 550 AQ 550 AU 550 AY 550 BC 550 BG 1000 (Air spring kit #63720 N BL 350 AB 450 AF 500 AJ 500 AN 550 AR 550 AV 550 AZ 550 BD 550 BH 1000 recommended on 2B Y BM 350 AC 450 AG 500 AK 500 AO 550 AS 550 AW 550 BA 550 BE 550 BI 1000 plows 8-1/2' & larger) N BN 350 AD 450 AH 500 AL 500 AP 550 AT 550 AX 550 BB 550 BF 550 BJ HB5 Y BK 750 N BL 750 2B Y BM 750 N BN ' Box 5.4L V HB5 Y BK 150 AA 250 AE 300 AI 300 AM 350 AQ 350 AU 350 AY 350 BC 350 BG 450 Snowplow prep. N BL 150 AB 250 AF 300 AJ 300 AN 350 AR 350 AV 350 AZ 350 BD 350 BH 450 package recommended 2B Y BM 150 AC 250 AG 300 AK 300 AO 350 AS 350 AW 350 BA 350 BE 350 BI 450 N BN 150 AD 250 AH 300 AL 300 AP 350 AT 350 AX 350 BB 350 BF 350 BJ HB5 Y BK 150 AA 250 AE 300 AI 300 AM 350 AQ 350 AU 350 AY 350 BC 350 BG 950 N BL 150 AB 250 AF 300 AJ 300 AN 350 AR 350 AV 350 AZ 350 BD 350 BH 950 2B Y BM 150 AC 250 AG 300 AK 300 AO 350 AS 350 AW 350 BA 350 BE 350 BI 950 N BN 150 AD 250 AH 300 AL 300 AP 350 AT 350 AX 350 BB 350 BF 350 BJ HB5 Y BK 700 N BL 700 2B Y BM 700 N BN L V HB5 Y BK 250 AA 350 AE 350 AI 400 AM 450 AQ 400 AU 450 AY 400 BC 450 BG 500 (Air spring kit #63720 N BL 250 AB 350 AF 350 AJ 400 AN 450 AR 400 AV 450 AZ 400 BD 450 BH 500 recommended on 2B Y BM 250 AC 350 AG 350 AK 400 AO 450 AS 400 AW 450 BA 400 BE 450 BI 500 plows 8-1/2' & larger) N BN 250 AD 350 AH 350 AL 400 AP 450 AT 400 AX 450 BB 400 BF 450 BJ HB5 Y BK 250 AA 350 AE 350 AI 600 AM 850 AQ 700 AU 900 AY 800 BC 950 N BL 250 AB 350 AF 350 AJ 600 AN 850 AR 700 AV 900 AZ 800 BD 950 2B Y BM 250 AC 350 AG 350 AK 600 AO 850 AS 700 AW 900 BA 800 BE 950 N BN 250 AD 350 AH 350 AL 600 AP 850 AT 700 AX 900 BB 800 BF L Diesel 5200 HB5 Y BK 400 AA 500 AE 500 AI 750 AQ 900 N BL 400 AB 500 AF 500 AJ 750 AR 900 2B Y BM 400 AC 500 AG 500 AK 750 AS 900 N BN 400 AD 500 AH 500 AL 750 AT 900

19 FORD FOUR WHEEL DRIVE Vehicle Options Plow Options (O) and Ballast Required (B) MODEL/ BODY OTHER ENGINE(S) MIN HEAD DRL PLOW LSX 7.2 S 7.5 SY 7.5 P 7.5 PY 7.5 P 8.0 PY 8.0 P 8.5 P 9.0 MVP 8.5 CHASSIS STYLE FGAWR LAMP? MODEL O B O B O B O B O B O B O B O B O B O B F-250 Super Duty Crew Cab 6.75' Box 5.4L V HB5 Y 3215 BK 100 AA 200 AE 250 AI 300 AM 300 AQ 300 AU 300 AY 300 BC 350 BG 400 Pick-up 4x4 Snowplow prep. N U BL 100 AB 200 AF 250 AJ 300 AN 300 AR 300 AV 300 AZ 300 BD 350 BH 400 (Vehicles with cab lights package recommended 2B Y BM 100 AC 200 AG 250 AK 300 AO 300 AS 300 AW 300 BA 300 BE 350 BI 400 also require kit # 61185) N BN 100 AD 200 AH 250 AL 300 AP 300 AT 300 AX 300 BB 300 BF 350 BJ 400 (See note on Spring Code 4800 HB5 Y BK 100 AA 200 AE 250 AI 300 AM 350 AQ 300 AU 400 AY 350 BC 450 and tire pressure on pg. 7) N BL 100 AB 200 AF 250 AJ 300 AN 350 AR 300 AV 400 AZ 350 BD 450 (Continued) 2B Y BM 100 AC 200 AG 250 AK 300 AO 350 AS 300 AW 400 BA 350 BE 450 N BN 100 AD 200 AH 250 AL 300 AP 350 AT 300 AX 400 BB 350 BF HB5 Y BK 800 N BL 800 2B Y BM 800 N BN L V HB5 Y BK 150 AA 250 AE 300 AI 350 AM 400 AQ 350 AU 400 AY 350 BC 400 BG 450 (Air spring kit #63720 N BL 150 AB 250 AF 300 AJ 350 AN 400 AR 350 AV 400 AZ 350 BD 400 BH 450 recommended on 2B Y BM 150 AC 250 AG 300 AK 350 AO 400 AS 350 AW 400 BA 350 BE 400 BI 450 plows 8-1/2' & larger) N BN 150 AD 250 AH 300 AL 350 AP 400 AT 350 AX 400 BB 350 BF 400 BJ HB5 Y BK 150 AA 300 AE 500 AI 750 AQ 900 AY 1000 N BL 150 AB 300 AF 500 AJ 750 AR 900 AZ B Y BM 150 AC 300 AG 500 AK 750 AS 900 BA 1000 N BN 150 AD 300 AH 500 AL 750 AT 900 BB L Diesel 5200 HB5 Y BK 350 AA 450 AE 650 N BL 350 AB 450 AF 650 2B Y BM 350 AC 450 AG 650 N BN 350 AD 450 AH ' Box 5.4L V HB5 Y BK 150 AA 250 AE 250 AI 300 AM 350 AQ 300 AU 350 AY 350 BC 350 BG 400 Snowplow prep. N BL 150 AB 250 AF 250 AJ 300 AN 350 AR 300 AV 350 AZ 350 BD 350 BH 400 package recommended 2B Y BM 150 AC 250 AG 250 AK 300 AO 350 AS 300 AW 350 BA 350 BE 350 BI 400 N BN 150 AD 250 AH 250 AL 300 AP 350 AT 300 AX 350 BB 350 BF 350 BJ HB5 Y BK 150 AA 250 AE 300 AI 650 AM 900 AQ 750 AU 950 AY 850 BC 1000 N BL 150 AB 250 AF 300 AJ 650 AN 900 AR 750 AV 950 AZ 850 BD B Y BM 150 AC 250 AG 300 AK 650 AO 900 AS 750 AW 950 BA 850 BE 1000 N BN 150 AD 250 AH 300 AL 650 AP 900 AT 750 AX 950 BB 850 BF L V HB5 Y BK 200 AA 300 AE 300 AI 350 AM 400 AQ 350 AU 400 AY 400 BC 400 BG 500 (Air spring kit #63720 N BL 200 AB 300 AF 300 AJ 350 AN 400 AR 350 AV 400 AZ 400 BD 400 BH 500 recommended on 2B Y BM 200 AC 300 AG 300 AK 350 AO 400 AS 350 AW 400 BA 400 BE 400 BI 500 plows 8-1/2' & larger) N BN 200 AD 300 AH 300 AL 350 AP 400 AT 350 AX 400 BB 400 BF 400 BJ HB5 Y BK 200 AA 850 N BL 200 AB 850 2B Y BM 200 AC 850 N BN 200 AD L Diesel 5200 HB5 Y BK 350 N BL 350 2B Y BM 350 N BN 350 F-350 Super Duty Reg Cab 8.0' Box 5.4L V HB5 Y 3215 AI 350 AM 400 AQ 350 AU 400 AY 400 BC 400 BG 500 Pick-up 4x4 Single rear wheels N U AJ 350 AN 400 AR 350 AV 400 AZ 400 BD 400 BH 500 (Vehicles with cab lights Snowplow prep. 2B Y AK 350 AO 400 AS 350 AW 400 BA 400 BE 400 BI 500 also require kit # 61185) package recommended N AL 350 AP 400 AT 350 AX 400 BB 400 BF 400 BJ 500 (See note on Spring Code 4800 HB5 Y AI 350 AM 400 AQ 350 AU 400 AY 400 BC 400 BG 500 and tire pressure on pg. 7) N AJ 350 AN 400 AR 350 AV 400 AZ 400 BD 400 BH 500 2B Y AK 350 AO 400 AS 350 AW 400 BA 400 BE 400 BI 500 N AL 350 AP 400 AT 350 AX 400 BB 400 BF 400 BJ HB5 Y AI 900 AQ 1000 N AJ 900 AR B Y AK 900 AS 1000 N AL 900 AT L V HB5 Y AI 400 AM 450 AQ 450 AU 450 AY 450 BC 450 BG 550 (Air spring kit #63720 N AJ 400 AN 450 AR 450 AV 450 AZ 450 BD 450 BH 550 recommended on 2B Y AK 400 AO 450 AS 450 AW 450 BA 450 BE 450 BI 550 plows 8-1/2' & larger) N AL 400 AP 450 AT 450 AX 450 BB 450 BF 450 BJ HB5 Y AI 400 AM 450 AQ 450 AU 450 AY 450 BC 450 BG 750 N AJ 400 AN 450 AR 450 AV 450 AZ 450 BD 450 BH 750 2B Y AK 400 AO 450 AS 450 AW 450 BA 450 BE 450 BI 750 N AL 400 AP 450 AT 450 AX 450 BB 450 BF 450 BJ L Diesel 5200 HB5 Y AI 550 AM 600 AQ 600 AU 600 AY 600 BC 650 BG 800 (Air spring kit #63720 N AJ 550 AN 600 AR 600 AV 600 AZ 600 BD 650 BH 800 recommended on 2B Y AK 550 AO 600 AS 600 AW 600 BA 600 BE 650 BI 800 plows 8-1/2' & larger) N AL 550 AP 600 AT 600 AX 600 BB 600 BF 650 BJ 800 WESTERN PRODUCTS 2003 UniMount REV 0 10 FORD

20 FORD FOUR WHEEL DRIVE Vehicle Options Plow Options (O) and Ballast Required (B) MODEL/ BODY OTHER ENGINE(S) MIN HEAD DRL PLOW LSX 7.2 S 7.5 SY 7.5 P 7.5 PY 7.5 P 8.0 PY 8.0 P 8.5 P 9.0 MVP 8.5 CHASSIS STYLE FGAWR LAMP? MODEL O B O B O B O B O B O B O B O B O B O B F-350 Super Duty Reg Cab 8.0' Box 5.4L V HB5 Y 3215 AY 200 BC 250 BG 300 Pick-up 4x4 (Continued) Dual rear wheels N U AZ 200 BD 250 BH 300 (Vehicles with cab lights Snowplow prep. 2B Y BA 200 BE 250 BI 300 also require kit # 61185) package recommended N BB 200 BF 250 BJ 300 (See note on Spring Code 4800 HB5 Y AY 200 BC 250 BG 300 and tire pressure on pg. 7) N AZ 200 BD 250 BH 300 (Continued) 2B Y BA 200 BE 250 BI 300 N BB 200 BF 250 BJ L V HB5 Y AY 250 BC 250 BG 350 (Air spring kit #63720 N AZ 250 BD 250 BH 350 recommended on 2B Y BA 250 BE 250 BI 350 plows 8-1/2' & larger) N BB 250 BF 250 BJ HB5 Y AY 250 BC 350 BG 850 N AZ 250 BD 350 BH 850 2B Y BA 250 BE 350 BI 850 N BB 250 BF 350 BJ L Diesel 5200 HB5 Y AY 400 BC 400 BG 950 (Air spring kit #63720 N AZ 400 BD 400 BH 950 recommended on 2B Y BA 400 BE 400 BI 950 plows 8-1/2' & larger) N BB 400 BF 400 BJ 950 SuperCab 6.75' Box 5.4L V HB5 Y AI 300 AM 350 AQ 300 AU 350 AY 350 BC 350 BG 450 Single rear wheels N AJ 300 AN 350 AR 300 AV 350 AZ 350 BD 350 BH 450 Snowplow prep. 2B Y AK 300 AO 350 AS 300 AW 350 BA 350 BE 350 BI 450 package recommended N AL 300 AP 350 AT 300 AX 350 BB 350 BF 350 BJ HB5 Y AI 300 AM 350 AQ 300 AU 350 AY 350 BC 350 BG 450 N AJ 300 AN 350 AR 300 AV 350 AZ 350 BD 350 BH 450 2B Y AK 300 AO 350 AS 300 AW 350 BA 350 BE 350 BI 450 N AL 300 AP 350 AT 300 AX 350 BB 350 BF 350 BJ L V HB5 Y AI 350 AM 400 AQ 400 AU 400 AY 400 BC 400 BG 500 (Air spring kit #63720 N AJ 350 AN 400 AR 400 AV 400 AZ 400 BD 400 BH 500 recommended on 2B Y AK 350 AO 400 AS 400 AW 400 BA 400 BE 400 BI 500 plows 8-1/2' & larger) N AL 350 AP 400 AT 400 AX 400 BB 400 BF 400 BJ HB5 Y AI 350 AM 400 AQ 400 AU 400 AY 400 BC 450 BG 900 N AJ 350 AN 400 AR 400 AV 400 AZ 400 BD 450 BH 900 2B Y AK 350 AO 400 AS 400 AW 400 BA 400 BE 450 BI 900 N AL 350 AP 400 AT 400 AX 400 BB 400 BF 450 BJ L Diesel 5200 HB5 Y AI 550 AM 550 AQ 550 AU 550 AY 550 BC 600 BG 1000 (Air spring kit #63720 N AJ 550 AN 550 AR 550 AV 550 AZ 550 BD 600 BH 1000 recommended on 2B Y AK 550 AO 550 AS 550 AW 550 BA 550 BE 600 BI 1000 plows 8-1/2' & larger) N AL 550 AP 550 AT 550 AX 550 BB 550 BF 600 BJ ' Box 5.4L V HB5 Y AI 300 AM 350 AQ 350 AU 350 AY 350 BC 350 BG 450 Single rear wheels N AJ 300 AN 350 AR 350 AV 350 AZ 350 BD 350 BH 450 Snowplow prep. 2B Y AK 300 AO 350 AS 350 AW 350 BA 350 BE 350 BI 450 package recommended N AL 300 AP 350 AT 350 AX 350 BB 350 BF 350 BJ HB5 Y AI 300 AM 350 AQ 350 AU 350 AY 350 BC 350 BG 900 N AJ 300 AN 350 AR 350 AV 350 AZ 350 BD 350 BH 900 2B Y AK 300 AO 350 AS 350 AW 350 BA 350 BE 350 BI 900 N AL 300 AP 350 AT 350 AX 350 BB 350 BF 350 BJ L V HB5 Y AI 400 AM 400 AQ 400 AU 450 AY 400 BC 450 BG 500 (Air spring kit #63720 N AJ 400 AN 400 AR 400 AV 450 AZ 400 BD 450 BH 500 recommended on 2B Y AK 400 AO 400 AS 400 AW 450 BA 400 BE 450 BI 500 plows 8-1/2' & larger) N AL 400 AP 400 AT 400 AX 450 BB 400 BF 450 BJ HB5 Y AI 650 AM 950 AQ 800 AU 1000 AY 900 BC 1000 N AJ 650 AN 950 AR 800 AV 1000 AZ 900 BD B Y AK 650 AO 950 AS 800 AW 1000 BA 900 BE 1000 N AL 650 AP 950 AT 800 AX 1000 BB 900 BF L Diesel 5200 HB5 Y AI 750 AM 1000 AQ 900 AY 1000 (Air spring kit #63720 N AJ 750 AN 1000 AR 900 AZ 1000 recommended on 2B Y AK 750 AO 1000 AS 900 BA 1000 plows 8-1/2' & larger) N AL 750 AP 1000 AT 900 BB ' Box 5.4L V HB5 Y AY 200 BC 200 BG 300 Dual rear wheels N AZ 200 BD 200 BH 300 Snowplow prep. 2B Y BA 200 BE 200 BI 300 package recommended N BB 200 BF 200 BJ HB5 Y AY 400 BC 500 N AZ 400 BD 500 2B Y BA 400 BE 500 N BB 400 BF L V HB5 Y AY 200 BC 250 BG 300 (Air spring kit #63720 N AZ 200 BD 250 BH 300 recommended on 2B Y BA 200 BE 250 BI 300 plows 8-1/2' & larger) N BB 200 BF 250 BJ 300

21 FORD FOUR WHEEL DRIVE Vehicle Options Plow Options (O) and Ballast Required (B) MODEL/ BODY OTHER ENGINE(S) MIN HEAD DRL PLOW LSX 7.2 S 7.5 SY 7.5 P 7.5 PY 7.5 P 8.0 PY 8.0 P 8.5 P 9.0 MVP 8.5 CHASSIS STYLE FGAWR LAMP? MODEL O B O B O B O B O B O B O B O B O B O B F-350 Super Duty Crew Cab 6.75' Box 5.4L V HB5 Y 3215 AI 300 AM 300 AQ 300 AU 300 AY 300 BC 350 BG 400 Pick-up 4x4 Single rear wheels N U AJ 300 AN 300 AR 300 AV 300 AZ 300 BD 350 BH 400 (Vehicles with cab lights Snowplow prep. 2B Y AK 300 AO 300 AS 300 AW 300 BA 300 BE 350 BI 400 also require kit # 61185) package recommended N AL 300 AP 300 AT 300 AX 300 BB 300 BF 350 BJ 400 (See note on Spring Code 4800 HB5 Y AI 300 AM 350 AQ 300 AU 400 AY 300 BC 400 BG 1000 and tire pressure on pg. 7) N AJ 300 AN 350 AR 300 AV 400 AZ 300 BD 400 BH 1000 (Continued) 2B Y AK 300 AO 350 AS 300 AW 400 BA 300 BE 400 BI 1000 N AL 300 AP 350 AT 300 AX 400 BB 300 BF 400 BJ L V HB5 Y AI 350 AM 400 AQ 350 AU 400 AY 350 BC 400 BG 450 (Air spring kit #63720 N AJ 350 AN 400 AR 350 AV 400 AZ 350 BD 400 BH 450 recommended on 2B Y AK 350 AO 400 AS 350 AW 400 BA 350 BE 400 BI 450 plows 8-1/2' & larger) N AL 350 AP 400 AT 350 AX 400 BB 350 BF 400 BJ HB5 Y AI 750 AM 100 AQ 850 AY 950 N AJ 750 AN 100 AR 850 AZ 950 2B Y AK 750 AO 100 AS 850 BA 950 N AL 750 AP 100 AT 850 BB L Diesel 5200 HB5 Y AI 850 AQ 1000 N AJ 850 AR B Y AK 850 AS 1000 N AL 850 AT ' Box 6.8L V HB5 Y AY 200 BC 200 BG 300 Dual rear wheels (Air spring kit #63720 N AZ 200 BD 200 BH 300 Snowplow prep. recommended on 2B Y BA 200 BE 200 BI 300 package recommended plows 8-1/2' & larger) N BB 200 BF 200 BJ ' Box 5.4L V HB5 Y AI 300 AM 350 AQ 300 AU 350 AY 350 BC 350 BG 450 Single rear wheels N AJ 300 AN 350 AR 300 AV 350 AZ 350 BD 350 BH 450 Snowplow prep. 2B Y AK 300 AO 350 AS 300 AW 350 BA 350 BE 350 BI 450 package recommended N AL 300 AP 350 AT 300 AX 350 BB 350 BF 350 BJ HB5 Y AI 600 AM 850 AQ 700 AU 900 AY 800 BC 950 N AJ 600 AN 850 AR 700 AV 900 AZ 800 BD 950 2B Y AK 600 AO 850 AS 700 AW 900 BA 800 BE 950 N AL 600 AP 850 AT 700 AX 900 BB 800 BF L V HB5 Y AI 350 AM 400 AQ 400 AU 400 AY 400 BC 400 BG 500 (Air spring kit #63720 N AJ 350 AN 400 AR 400 AV 400 AZ 400 BD 400 BH 500 recommended on 2B Y AK 350 AO 400 AS 400 AW 400 BA 400 BE 400 BI 500 plows 8-1/2' & larger) N AL 350 AP 400 AT 400 AX 400 BB 400 BF 400 BJ ' Box 6.8L V HB5 Y AY 150 BC 200 BG 450 Dual rear wheels (Air spring kit #63720 N AZ 150 BD 200 BH 450 Snowplow prep. recommended on 2B Y BA 150 BE 200 BI 450 package recommended plows 8-1/2' & larger) N BB 150 BF 200 BJ HB5 Y AY 850 BC 1000 N AZ 850 BD B Y BA 850 BE 1000 N BB 850 BF 1000 F-350 Super Duty All Min. 8,500 GVWR All All HB5 Y 3215 AI? AM? AQ? AU? AY? BC? BG? Chassis Cab 4x4 Single rear wheels (Air spring kit #63720 N U AJ? AN? AR? AV? AZ? BD? BH? (Vehicles with cab lights Snowplow prep. recommended on 2B Y AK? AO? AS? AW? BA? BE? BI? also require kit # 61185) package recommended plows 8-1/2' & larger) N AL? AP? AT? AX? BB? BF? BJ? (See note on Spring Code Min. 8,500 GVWR All All HB5 Y AY? BC? BG? and tire pressure on pg. 7) Dual rear wheels (Air spring kit #63720 N AZ? BD? BH? Snowplow prep. recommended on 2B Y BA? BE? BI? package recommended plows 8-1/2' & larger) N BB? BF? BJ? WESTERN PRODUCTS 2003 UniMount REV 0 12 FORD

22 BODY STYLE FOUR WHEEL DRIVE Vehicle Options MIN FGAWR FORD F450 & F550 HEAD LAMP DRL Plow Options (O) and Ballast Required (B) P 8.5 P 9.0 MVP 8.5 PLOW MVP 9.5 HW 9.0 HW 10.0 MODEL/ CHASSIS OTHER ENGINE(S)? MODEL O B O B O B MODEL O B O B O B F-450 Super Duty All Dual rear wheels All All HB5 Y 3215 AY? BC? BG? 3225 AI? AA? AE? Chassis Cab 4x4 Min. 8,500 GVWR (Air spring kit #63720 N U AZ? BD? BH? U AJ? AB? AF? (Vehicles with cab lights Snowplow prep. recommended on 2B Y BA? BE? BI? AK? AC? AG? also require kit # 61185) package recommended plows 8-1/2' & larger) N BB? BF? BJ? AL? AD? AH? F-550 Super Duty All Dual rear wheels All All HB5 Y 3215 AY? BC? BG? 3225 AI? AA? AE? Chassis Cab 4x4 Min. 8,500 GVWR (Air spring kit #63720 N U AZ? BD? BH? U AJ? AB? AF? (Vehicles with cab lights Snowplow prep. recommended on 2B Y BA? BE? BI? AK? AC? AG? also require kit # 61185) package recommended plows 8-1/2' & larger) N BB? BF? BJ? AL? AD? AH? TWO WHEEL DRIVE Vehicle Options Plow Options (O) and Ballast Required (B) MODEL/ CHASSIS BODY MIN HEAD DRL PLOW P 8.5 P 9.0 MVP 8.5 PLOW MVP 9.5 HW 9.0 HW 10.0 OTHER ENGINE(S) STYLE FGAWR LAMP? MODEL O B O B O B MODEL O B O B O B F450 Super Duty All Dual rear wheels All All HB5 Y 3215 AY? BC? BG? 3225 AI? AA? AE? Chassis Cab 2WD Min. 10,000 GVWR (Air spring kit #63720 N U AZ? BD? BH? U AJ? AB? AF? (Vehicles with cab lights Snowplow prep. recommended on 2B Y BA? BE? BI? AK? AC? AG? also require kit # 61185) package recommended plows 8-1/2' & larger) N BB? BF? BJ? AL? AD? AH? F550 Super Duty All Dual rear wheels All All HB5 Y 3215 AY? BC? BG? 3225 AI? AA? AE? Chassis Cab 2WD Min. 10,000 GVWR (Air spring kit #63720 N U AZ? BD? BH? U AJ? AB? AF? (Vehicles with cab lights Snowplow prep. recommended on 2B Y BA? BE? BI? AK? AC? AG? also require kit # 61185) package recommended plows 8-1/2' & larger) N BB? BF? BJ? AL? AD? AH? PLOW

23 FORD COMPLETE PLOW COMPONENT NUMBERS MODEL OPTION BLADE SIZE MOUNT BLADE ATTACHMENT HYDRAULIC LAMP KIT HARNESS DRL KIT ASSEMBLY ASSEMBLY ASSEMBLY ASSEMBLY KIT 1225 AA S UNIMOUNT PLOW AB S AC SY AD SY AE P AF P AG PY AH PY AI P AJ P AK P AL P AM P AN P AO PY AP PY AQ MVP AR MVP AS LSX AT LSX AA S UNIMOUNT PLOW AB S AC S AD S AE SY AF SY AG SY AH SY AI P AJ P AK P AL P AM PY AN PY AO PY AP PY WESTERN PRODUCTS 2003 UniMount REV 0 14 FORD

24 FORD (continued) COMPLETE PLOW COMPONENT NUMBERS MODEL OPTION BLADE SIZE MOUNT BLADE ATTACHMENT HYDRAULIC LAMP KIT HARNESS DRL KIT ASSEMBLY ASSEMBLY ASSEMBLY ASSEMBLY KIT 3215 (continued) AQ P UNIMOUNT PLOW AR P AS P AT P AU PY AV PY AW PY AX PY AY P AZ P BA P BB P BC P BD P BE P BF P BG MVP BH MVP BI MVP BJ MVP BK LSX BL LSX BM LSX BN LSX AA HW UNIMOUNT PLOW AB HW AC HW AD HW AE HW AF HW AG HW AH HW AI MVP AJ MVP AK MVP AL MVP