CHALLENGER USt capacity All Terrain Crane Datasheet imperial CHALLENGER 3180

Size: px

Start display at page:

Download "CHALLENGER USt capacity All Terrain Crane Datasheet imperial CHALLENGER 3180"

Piers Barrett
6 years ago
Views:

1 CHALLENGER USt capacity All Terrain Crane Datasheet imperial CHALLENGER 31

2 CONTENTS CHALLENGER 31 Page: Dimensions Counterweight Specifications Equipment HA Main boom HAV Folding swingaway jib MSF2 Runner Technical description

3 KEY CHALLENGER 31 Counterweight Slewing Liing capacities on outriggers 0 Boom telescoping Radius Boom elevation Main boom Workings speeds Folding swingaway jib Max. line pull Runner Rope diameter Max. axle loads Rope length Mechanism Hook block (capacity sheaves rope diameter) Tires Number of lines Hook block Possible load of hook block Hoist Weight of hook block Travel speed Distance head sheave axle hook ground Gradeability road Number of sheaves in boom head Gradeability off road Supporting force Engine Length of stroke (support cylinders) Payload incl. rear storage box 3

4 DIMENSIONS CHALLENGER 31 * 385/95R25 ** 445/95R25 ( ) Equipped with polyamide outrigger pads (2) steering mode 2 * outer turning radius, axle 1 (3) steering mode 3* ** inner turning radius, axle 1 see page 6 4

5 COUNTERWEIGHT CHALLENGER 31 Parts When using HW2, counterweight g is not applicable Configurations 5 lb 8,0 lb 9,000 lb,0 lb,0 lb 15,000 lb,300 lb,700 lb,700 lb 200 lb a 1,300 lb b 00 lb c 8,0 lb d 00 lb e 00 lb f lb g 00 lb

6 SPECIFICATIONS CHALLENGER 31 Total 26,500 lb 26,500 lb 26,500 lb 26,500 lb,700 lb 30,0 lb 3 lb 79,0 lb 79,0 lb 79,0 lb 79,0 lb 800 lb 90,0 lb 1,0 lb 6 x 4 x 6 6 x 4 x 6 6 x 6 x 6 6 x 6 x 6 6 x 6 x 6 6 x 6 x 6 6 x 6 x 6 2 kw 265 kw 2 kw 265 kw 265 kw 265 kw 265 kw 385/95R25 385/95R25 445/95R25 445/95R25 445/95R25 445/95R25 445/95R B 503B 503B 503,0 lb lb 8,0 lb lb,0 lb,700 lb 200 lb ,760 lb 1,0 lb 8 lb 8 lb 1,0 lb 1,760 lb 1,760 lb 1 Highway > 27.8 mph 4* Offwall 2 City < 27.8 mph 5* Crab steer mode 3* Minimum turning radius < 3.1 mph 6* All wheel steering * must be activated 70,600 lb,0 lb 52.8 mph 1) ) Depending on tire type, size and country specific legislation 1 15, lb kw 2 29, lb /95R25.00R25 445/95R25.00R25 525/R25.50R lb % 50 % 50 % 4 58, ,2 lb 5.9 > % > % > % 5 73, ,2 lb kw ,2 lb /95R25.00R25 445/95R25.00R25 525/R25.50R25 % 35 % 35 % 75 % 70 % 70 % 394 /min (265kW) 3 /min (2kW) 394 /min (265kW) 3 /min (2kW) 15.0 lb 15.0 lb ,8 rpm ca. 490 s ( ) ca. 50 s (5 82 ) 6

7 EQUIPMENT CHALLENGER 31 HAV lb 8 lb 1,650 lb MSF2 450 lb Line 0 7 * 385/95R25 ** 445/95R25

8 HA CHALLENGER 31 8

9 9 CHALLENGER 31 HA 22.6 x kw* 85 % 200 lb ,0 87,1 8 81,3 75,0 69, ,1 8,0,8 6 61, ,6 78,0,3 67, , ,9 7 69,1,8 60,5 5 44,1 38,4 3, ,6 78,6, ,3 51,2 4 38,5 33,0 2 21,2,7.1 71,6 66,6 6 59,2,2 50,8 4 38,0,5 27,4,9 1, ,8 5 51,7 4,1 3 31,1 26,5 21,4, ,4 37, ,2 29,4 27,2,7 1 13, ,3 2,8 2 21,2,6,1 1,8 9,5 8, ,4 2,5,8,3,3,8,9 9,0 6,5 5, ,6, ,4 1 11,8,4 8,7 4, ,2,6,7 13,0 11,3,2 8,1 6,6 1.0,9,7,1,9 8,8 7,8 6,6 ** 0 * see page 23 ** Capacity class 1) Capacities with horzontal boom 31,3 31,3 2 17,6,3 9,5 1,8 0 1) 1)

10 CHALLENGER 31 HA 22.6 x kw* 85 %,700 lb ,1 8 79,5,3 6 59, ,6 78,0,3 66,6 60,8 4, ,9 7 69,1,8 60,2 4 41,7 34,1,7, ,6 78,6, ,4 4 34,1,7,0, ,6 66,6 6 59,2,2 49,8 41,1 3,0,0,7,7 11, ,8 5 51,7 4 38,4,2 27,4,2,2,4,0, ,4 37, ,2 27,4 2 1,5 11, ,3 2,8 2 21,2 17,8 13,7 9, ,4 2,5,8,0 13,7 11,1 9,1 5, ,6, ,0,7 8,4 5,0 4, ,2,6,7,6,2 8,0 1.0,9,7,1,9 9,5 31,3 2 17,6 1, ) 1) 22.6 x kw* 85 %,300 lb ,1 8 79,1 71,7, ,6 78,0,3 6 46,5,6 29, ,9 7 69,1,2 58,8 4 37,4 30,0 25,0, ,6 78,6, ,6 46,6 37,4 29,8 2 21,6,4,8.1 71,6 66,6 6 59,2 5 4, ,6 1,8, ,8 5 51,4 41,1 3 29,6 2,9 15,9,8,2 8, ,4 37,8 3,5 2 2,3 15,9,5,1 6,6 5, ,3 2,6 2,3 1,4 7,8 5,0 4, ,4 2,2, , ,6,7 1 1,4 8,9 3, ,2,6 1,5 8,5 1.0,9,7 1 9,8 1,6 31,3 2 15,4 11,2 8,6 4,6 1, ) 1) * see page 23 1) Capacities with horzontal boom

11 11 CHALLENGER 31 HA 22.6 x kw* 85 %,0 lb ,1 8 79,0 71,1 6, ,6 78,0,0,9 57,6 45,0 34, ,9 7 69, ,5 3,4 23, ,6 78,6,6 6 61,1 55,0 4 3,4 23,7,7 1,0.1 71,6 66,6 6 58, ,4,6,5 1, ,8 5 49,4 39,1,6,5,0 1 1,2 7, ,4 37,8 3 31,6 26, , ,3 2,3 21,8 19,4 15,0 11,7 4, ,4 2 19,8,0,5 11,3 8, ,6,7,9 1 1,7 8, ,2,5 13,0 3,7 1.0,9,7 11,7 9,2 31,3 21,4,8,6 1, ) 1) 22.6 x kw* 85 % 8,0 lb ,1 8 78,8 70, ,6 78,0 71,5,1, , ,9 7 69,1 6,7 44, , ,6 78,6, , ,6,7 11,4.1 71,6 66,6 6,9 51,1,4,8 27,4 2 19,4,8 11, ,8 5 47,2 3 31,8 27,2 2 19,0,8 11,4 9, ,4 37,8 35,0 30,2 2 21,5 19,2,5 11,3 9,0 7, ,3 2,0 21,2,3,2,9 8,6 4, ,4 21,8 19,4 1,0, ,6,7,4,9 13,0 9,8 8, ,0,1 9,5 1.0,9,7 11,3 8,4 31,3,3 1 3, ) 1) * see page 23 1) Capacities with horzontal boom

12 CHALLENGER 31 HA 22.6 x kw* 85 % lb ,1 8 78,8 70, ,6 78,0 71,0 6 55,9 4,2 25, ,9 7 69, ,3 2, ,6 78,6,6 6 59,2 5 41, ,0,2,9.1 71,6 66,6 6,2 49,6 39,1 31,7 2 2,8,5 11,2 8, ,8 5 4,2 31,4 26,3 2,6,2,9 8, ,4 37,8 3 29,2,5 21,1,8,2,9 8, ,2 2 23,7,7 17,8 1, ,3 21,5 19,1 1 1,3 4,6 1, ,6,3,0,4,5 4, ,7 1 11,4 9,1 1.0,9,7,9 31,3 19, ) 1) 22.6 x kw* 85 % 200 lb ,5 78,6 70,2 6 54,1 45, ,6 79,6 71,2,2 5 47,4 35, ,5 79,0 71,2,4 5,3 3 27,8 2 19,5, ,6 78,4 70,9 61,4 53,7,3 3 27,8 2 19,8,6,6.1 71,6 6 58,0 51,0 4 3,7 2 19,6,9,8,1 8, ,6 5 4,8 3,0 2 19,4,6,7,0 8, ,4 3, ,5,6, ,9 2 2,8,4,4 9,6 4, ,6 2,8,4,0,0 7, ,6 19,4 17,6 1 11,6 9,4 7, ,5 11,1 9,0 1.0,9,7,8 8,4 6,6 3,0,9 17,2,1 8,8 6,6 3,7 1, ) 1) * see page 23 1) Capacities with horzontal boom

13 HA CHALLENGER 31,0 lb 22.6 x kw* 85 % ,6 37, ,3 7 61,3 49,4,2,3 2 17,8, ,4 68,4 5 47,8,2 3,8 19,2 1,7, ,4 6 51,7 4 37,8 34,1 2 19,4 1,9,8 7,8 5, ,1,7,3 31,7 25,0 1 15,9 1 11,0 8,0 6, ,9 30,6 29,1 27,8,3 2 19,6 19, ,9,8,8 8,0 7,8 5,9 4, ,1 21,2 1 1,6,5 7, ,8,3 1 1,1 7, ,4 7,4 9.0,1,3 8,6 6,3 4, ),5,8 3,7 1, ) 9,1 5,4 lb 22.6 x kw* 85 % , ,9 70,7 5 4,6 2 21,2,1,6 57.1,7,7 5 4,5 30, ,7 11, ,0 57,2 4 39,5 34,8 30,8 2 1,0 11,7.1 50,3 4 37,6,8,6 2,0,3,0 7,2 5, ,5 34,1 30,0,4 2 25,4 2,6 1 1,1,0 11,7 11,6 9, , , ,6,5,1,4 8,8 6,3 4, ,7,0 8,4 6,1 9.0,5 9, ),5 9,5 6, ) * see page 23 1) Capacities with horzontal boom 4,1 13

14 HA CHALLENGER 31,300 lb 22.6 x kw* 85 % ,1 51,5 38,7 30,5 25,4,9 45.6,0 51,2 41,3,8 27, , ,4 47,6 3 3,9,2,2,2 9,6 8, ,0,7,4,4,5,7 11,8 9,8.1,7 34,8 30,9 27,4,2,9 1,0,1 8, ,6,5 25, ,3,4 1,7,5,0 11,8,1 9,8 8,4 6,1 5, , ,2 9,5 8, ,0,4,3 8,8 1, ,8,0 8,5 7, , ) 1 3,7 1, ),0 lb 22.6 x kw* 85 % ,2 2, ,0,0,7 8, ,0 3,9,3,3 1 11,7 9,4 7, , ,5 1,1 8,0 6, ,9 2,1 1, ,1 1,7 17,4 1,1,2 11,6 9,6 8,1 8,0 6,5 1.5,1 13,0,7 8, ,8 8, , , ),6 1, ) lb 22.6 x kw* 85 % ,4 38,6,7 2,3, ,0 38,9 31,1,6,4,8,3 7, ,4,8 30,7 2 21,8,1 1,4 6,6 5, ,1 3,6,6 21,3,4 1,6 8,5.1 31,3 2 2,5,0,1,9 8,8 7,2 4, ,5 21,3,8 1,5 15,4 1,4,7,1 8,5 8,3 7,1 1.5,1 11,3 9,2 7,6 6,3 6.0,2 8, , ) 9, ) * see page 23 1) Capacities with horzontal boom

15 15 CHALLENGER 31 HA Telescoping capacities kw* 85 % ,5 31,2 31,1 30,8 29,6, ,0,7,4,0 23, , ,8 21,2,7,3,0 19,6, , ,6 21,1,5 19,8 19,1,6,2,8,7, ,7 1 1,5 17,8 17,1,7,3 1,4,4, ,4,9,1 17,4,7,1 1,2 11,7 11,1,4 8,8 7,4 1.5,6 17,2 15,4 1,6,7,1 9,6 8, ,6,0 11,6 11,2,4 9,1 8,6 8, ,2 11,7 11,3,7 9,2 8,5 6,5 5,9 3, ,6 11,0,5 9,1 7,8 6,6 5,0 1.0 * see page 23 1) Capacities with horzontal boom 2 17,6 1,8 1,5 1) 1)

16 HAV CHALLENGER 31

17 17 CHALLENGER 31 HAV ,6 6,6 6,1 5,4 7,4 6,1 3,0 6,3 5, ,7 3,0 3,0 1, ,8,4 9,2 8,4 4,8 3,7 9,8 9,0 7,4 6,6 5,4 9,0 7,6 3, ,8 1,8 1, ,9,2 11,3,1 8,8 6,6 5,4 1,8,2 11,0 9,1 4,8 3,7,8 8,8 8,0 5, ,1 7,4 7,1 6,5 5,0 5,4 4,1 5,0 3,0 1, ,1,4 1,1,4,7 9,1 4,8 13,7,2,9 9,5 6,1,0,8 8, ,2 8,7 8,5 8,0 5,9 5,4 1, * see page x kw* 85 % 200 lb ,7 19,8, ,6 6,1 1 15,0 1 11,6,0 8,5 7,4 6,3 4,6 1,8,4 8,6 7,4 6, ,4,1 9,6 8,9 8,3 7,1 6,3 5,9 4,6 4, ,5,9,1 27, ,3,2,5,8,5 21,1,3 19,5,2,9,0 1,5 15,4,8,2 1 13, ,2,6,1 1 1,2,9,7 9,1 6,1 9,2 8,7 7,

18 HAV CHALLENGER 31,0 lb x kw* 85 % ,6,8,3 8,5 6,6 3,7 1,8 1,6 4, ,9,1 8,1 17,1,4 1 9,2 9,4 4,6,0,4 8,6 7,4 6,3 3,0 5,0 4,6,5,2 1,6 8,9 7,1 11,1 9,2 8,7 8,1 5, * see page ,7 19,8,1,3,1,4,1 29,5,9,1 27,1 21,1 17,2,6,1 1 13,0,8 8,8 1 11,0 9,1 1 9,5 8,0 3,0 9,6 8,7 6,6 4,1 4,6 3, ,3,2,5,8,5,3 19,5,2,9,0 1,5 15,4,8,2 1 13,7 1,2,9,7 9,1 6,1 9,2 8,7 7,6

19 HAV CHALLENGER 31 lb x kw* 85 % ,6 7,2 9.0,8 9,8 8,5 6,5 7,1 4,8 4,6 3, ,8,8 11,7 8,1 17,1 1,5,9 9,2 6,5 1,8 9,4 1,6 4,1 11,7 3,0,3,7,5 8,5 8,6 7,6 1,8 1, * see page , ,0,4,1 29,5,9,1 27,1 21,1 17,2,6,1 1,6,0 4,6 1,8,8,5 8,6 3,0 1,8 9,0 9,4 8,3 7,2 1,8 4, ,3,2,5,8,5,3 19,5,2,9,0 1,5 15,4,8,2 1 13,7 1,2,9,7 9,1 9,2 8,7 7,6 6,1 19

20 MSF2 CHALLENGER 31

21 21 CHALLENGER 31 MSF x kw* 85 % 200 lb ,3 5 43, , ,0, ,1 51,3 44,1 38,0,5 2 21, ,2 50,6 4 37,6,1,3 21,4,8.1 57,6 55,0 5 4,5,0 3 27,8,9,5, ,1 41, ,8 2,1,8 1 11,1 9, ,0 31,6, ,8,0,7 11,3 9,4 1.5, ,3 19,4,7,6,8,4 9, ,5 1, ,7,4 8,6 5, , ,0 11,3 8,1 6,6 5,4 3, ,7,2,9 5, ,2,1 9,2 5,9 3,7 29,8 21,8 17,4 13,0,4 1, ) 1) * see page 23 1) Capacities with horzontal boom

22 22 CHALLENGER 31 MSF x kw* 85 %,0 lb , ,8 46,3 3,0 23, ,4 29,0,2,1, ,4 55, ,1,2, ,6 5 50,7 3 3,3 2, , ,1 3 26,5 2, , ,0 31,6, ,2 1 11,6 1.5,2 2 2,2,2,2 8, ,5 19,1 17,1,2 11,0 8, ,0,4 1, ,3 9,2 1.0,9 8,5 6,3,2 1, ) 1) 22.6 x kw* 85 % lb ,9 41,6 31, ,3,8 43,0,5 2 21,8 57.1,5 5 4,7 2 2,5, ,4 51, ,6,2,9.1 57, ,9 31,7 2 21,7 19,0,0 11,0 8, ,7,2 29,5,6 21,7,5,2,9 8, ,0 31,6 27,4,1,8,1 1,7 8,4 3,0 1.5,2 25, ,3 1, ,7,0, ,1 1,0 9, ,0 8,5 6, ,4,2 2,3 11,0 8, ) 1) * see page 23 1) Capacities with horzontal boom

23 NOTES TO LIFTING CAPACITY CHALLENGER 31 Ratings are in compliance with ASME B30.5. Liing capacities do not exceed 85% of tipping load. Weight of hook blocks and slings is part of the load, and is to be deducted from the capacity ratings. Consult operation manual for further details. Note: Data published herein is intended as a guide only and shall not be construed to warrant applicability for liing purposes. Crane operation is subject to the computer charts and operation manual both supplied with the crane. Liing capacities may vary slightly when equipped with the 2 kw engine due to the lower vehicle gross weight. The telescopic loads stated in the capacity chart are valid under the following conditions: The sliding areas of the telescopes must be lubricated well. The surroundings temperature has to be normal (considerable reductions must be expected below 0 C). The radius in the chart is given for the end length of the telescopic sequence. The capacities are valid for extending and retracting the telescopic section. The telescopic loads are only valid for moving the last section of the sequence. The curve for e. g % is only valid for telescoping from % to % and back, but not for % to %! The telescopic loads are based on the telescoping ability of the boom. The loads to be telescoped must never exceed the loads in the load chart as tipping of the crane may occur. The most advantageous individual telescoping sequence is shown. Other telescoping sequences for the same boom length will result in lower liing capacities for tele scoping. Refer to the machine s documentation for these liing capacity values. 23

24 TECHNICAL DESCRIPTION CHALLENGER 31 Basic equipment Carrier P540 / P0 Engine 23b MTU (Mercedes); output 2 kw (6 HP), torque 1300 Nm, certifications in accordance with EURO MOT 3b, TIER 4i, CARB; MTU (Mercedes) exhaust system made of stainless steel with SCR catalyst. Fuel tank 0 85 gallons Diesel;.5 gallons AdBlue. Transmission ASMID ZF ASTronic Mid; automated gearbox with forward speeds and 2 reverse; 2stage transfer case with switchable offroad gear and switchable longitudinal lock. Axles 6 x 4 x 6 6 x 4 x 6; 3 axles, axles 1 and 3 permanently driven and equipped with shiable transverse lock; all axles steered. Suspension Hydropneumatic suspension with axle load compensation; hydraulically lockable; manual or automatic levelling alternatively, ± 4.3. Steering Dual circuit hydro servocom steering with emergency steering pump; active rear axle steering. Brakes Pneumatic dual circuit service brake with antilock system, acting on all wheels; disc brakes; additional exhaust brake and constant throttle valve; springloaded parking brake. Wheels F 385/95R25 (.00R25); steel rims 9,525/1,7ET90; 170F. Cab carrier 2550 Type 8.4 ; adjustable driver seat with seat heating, armrests and pneumatic suspension; steering wheel height and tilt adjustable; power door windows; tinted glass; aircondition and radio preparation; 2 integrated rotary beacons; storage area. Drive lights With low beam, upper beam, daytime running lights. Cruise control Automatic speed control including automatic brake control. Dry sideways compartment Dry sideways compartment on codriver s side. StorageBox Top opening storage box in the carrier tail; not possible in combination HookBox. ChainBox Special storage box for 4stranded liing chain, behind carrier cab. Electronic immobiliser system Prevents uncontrolled carrier mobilisation; incl. 2 electronic keys. Pneumatic tire filling plug Pneumatic tire filling plug for selffilling of the wheels. Crane Telescopic boom HA50 Counterweight 5 Outriggers Outrigger pads 0 Boom luffing Rotary drive H1 Drive Control system Operator aids Cab crane 0875 Diverse VarioHeat Illumination Rotary beacons 2 Jump starting device NATO 1 Contour safety marking ; single cylinder telescoping system, automatic telescoping; attachments for all equipment and extensions; 3 sheaves integrated in boom head for max. capacity of 8 lb.,0 lb; automatic rigging system; expandable to max. 200 lb; 200 lb can be carried on board serially. H4Point design; vertical and horizontal movement fully hydraulic; manual or automatic levelling alternatively on both sides of carrier; 3 outrigger bases. 4 round outrigger pads A = with transport position at vertical cylinder. Single luffing cylinder with automatic lowering brake valve. Single slewing gear unit with springloaded multidisc brake. Hoist with springloaded multidisc brake; resolver (hoist rotation indicator). Hydraulic system with power control; hydraulic oil cooler. Enabling 4 simultaneous working movements; electric pilot controls via 2 twoaxis joysticks. IC1, with integrated load moment indicator acc. EN13000; colour display; displaying of current operating conditions, load charts, fault indicator; signal lights indicating LMIload; crane data logger. Type 2.9 ; tilt variable ; seat heating; foldout front window; extendable side and foldable front pedestal; handrails; tinted safety glass; pulldown sun visor and light curtains; aircondition and radio preparation. Enginedependent warm water heating with kw heating power; switchable between carrier cab and crane cab. 1 x adjustable for work prefield at crane cab, 4 x for outriggers. 2 x integrated on carrier cab, 2 x disconnectable on crane tail. Jump starting device according to NATOstandard; enabling jump start by using separate energy source. Continuous, white reflecting bands at carrier sides and tail. Power train variant Engine 2653b MTU (Mercedes); output 265 kw (0 HP), torque 1750 Nm, certifications in accordance with EURO MOT 3b, TIER 4i, CARB; MTU (Mercedes) exhaust system made of stainless steel with SCR catalyst. Transmission ASINT ZF ASTronic; automated gearbox with integrated hydraulic retarder, forward speeds and 2 reverse; 2stage transfer case with switchable offroad gear and switchable longitudinal lock; not possible in combination with eddycurrent brake.

25 TECHNICAL DESCRIPTION CHALLENGER 31 Optionen (free configurable) Carrier Axles 6 x 6 x 6 Wearless auxiliary brake 6 x 6 x 6; all 3 axles steered, axles 1 and 3 permanently driven, axle 2 shiable, all axles equipped with shiable transverse lock. Telma; wearless auxiliary eddycurrent brake at 3rd axle. Only together with engine 23b. Wheels F 445/95R25 (.00R25); steel rims 15/1,7ET90; 174F. Wheels E 525/R25 (.50R25); steel rims 15/1,7ET50; incl. carrier broadening to 9. Long range fuel tank 150 gallons; for total 5 gallons Diesel and.5 gallons AdBlue; not possible in combination with hook block storage. Crane Remote control RK H2 Additional counterweight 7 Outrigger load indicator Outrigger basis monitoring Moving out of crane cab Full control of rigging and crane movements via wireless remote control. 2. hoist; springloaded multidisc brake; resolver (hoist rotation indicator); incl. quick couplings and transport storage; enables 2hook operation with all extensions.,300 lb; for max. 200 lb. Displayed in LMI crane cab. Surveillance of each outrigger beam for visual comparison with the programmed outrigger basis; displayed in LMI crane cab (Attention, there is no automatic linkage with the LMIsystem). Control of carrier out of crane cab, enables machine moving when rigged, possible even under load. Extensions HAV MSF2 R / 52.5 ; double folding swingaway jib, with spindle bolting, manual offset / ; 1sheave head; incl. transport storage; includes HAV ; fixed assembly jib; 2sheave for max. capacity 58,700 lb; incl. transport storage at carrier tail (not possible together with KombiBoxes at tail). Swingaway rooster sheave, incl. transport storage; for singlereeving operation with elevated hook height. Diverse VarioCool 7 VarioHeat Plus VarioHook 503BD VarioHook 503BE Hook block 503D Hook block 503E Hook block 1E Hook VE Aircondition with 7 kw cooling power; switchable between carrier cab and crane cab. Auxiliary, engine independent Diesel heating system with kw heating power; remote control with programmable timer; switchable between engine block, carrier cab and crane cab. 503BD (6621,2 lb); hook block with adjustable ballast and ramshorn hook, variable usage as 1 and 3sheave hook block; white with red signal stripes. 503BE (6621,2 lb); hook block with adjustable ballast and single hook, variable usage as 1 and 3sheave hook block; white with red signal stripes 503D (1,2 lb); hook block with ramshorn hook; white with red signal stripes. 503E (1,2 lb); hook block with single hook; white with red signal stripes. 1E (662 lb); hook block with single hook; white with red signal stripes. VE (374 lb); single hook with vertical swivel; red. Weight data may deviate from posted values based on road / travel configuration, equipment configuration, and component weight tolerances. 25

26 Effective Date: October. Product specifications and prices are subject to change without notice or obligation. The photographs and/or drawings in this document are for illustrative purposes only. Refer to the appropriate Operator s Manual for instructions on the proper use of this equipment. Failure to follow the appropriate Operator s Manual when using our equipment or to otherwise act irresponsibly may result in serious injury or death. The only warranty applicable to our equipment is the standard written warranty applicable to the particular product and sale and Terex makes no other warranty, express or implied. Products and services listed may be trademarks, service marks or tradenames of Terex Corporation and/or its subsidiaries in the USA and other countries. All rights are reserved. Terex is a registered trademark of Terex Corporation in the USA and many other countries. Copyright Terex Corporation Terex Cranes, Global Marketing, Dinglerstraße, 662 Zweibrücken, Germany Tel. +49 (0) , info.cranes@terex.com, Brochure Reference: TCDSIEChallenger 31 /

120 USt capacity class All terrain crane Datasheet imperial AC 100/4 (L) Tier 4 / Euromot 4

120 USt capacity class All terrain crane Datasheet imperial AC 100/4 (L) Tier 4 / Euromot 4 USt capacity class All terrain crane Datasheet imperial AC 0/4 (L) Tier 4 / Euromot 4 CONTENTS Page: Dimensions... 5 Specifications... 6 Equipment... 7 Counterweight... 8 HA (HA50, HA60) Main boom... HAV