REPLACEMENT LIQUID FILTER BAGS FOR HOUSINGS PRODUCTS FOR A CLEAR SOLUTION PRODUCTS FOR A CLEAR SOLUTION

Transcription

1 REPLACEMENT LIQUID FILTER BAGS FOR HOUSINGS Quality of design Quality of manufacturing Quality of performance Quality of service Quality of technical advice PRODUCTS FOR A CLEAR SOLUTION PRODUCTS FOR A CLEAR SOLUTION LSRFB-705

2 Technical Data CONVERSION FACTORS MESH MICRON INCHES SUSPENDED SOLID CONVERSION TABLE P PM % 10,000 8,000 6,000 4,000 2,000 1, lbs./1000 gal VISCOSITY EQUIVALENTS SSU (SAYBOLT SECONDS UNIVERAL) ,000 CPS (CENTIPOISE) Other Product Available... Adapter Heads & Adapter Head Filter Bags Tie-on Filter bags Special Design Filter Bags Filter Media Die Cut Products MULTIPLY BY Atmosphere PSI TO GET Barrels of Oil Gallons (U.S.) Centimeters Feet Centimeters Inche s Centipoises 0.01 Poises Centistokes 0.01 Stokes Centimeters inches Centimeters Gallons (liq.) Feet Gallons (liq.) Feet inches feet/minute Gallons per minut e inches Gallons inches cm. inches Feet meters Gallons (liq.) meters feet Feet Centimeter s Feet Meters Feet of water PSI Feet of water Inches of Hg MULTIPLY BY TO GET Feet/minute Miles per hour Feet/second Miles per hour Gallons 3, cm. Gallons inches Gallons Imp. Gallons Gallons feet Gallons per minute feet/min. Inches Meters Inches of Hg Feet of water Inches of Hg PSI Kilograms Pounds (avdp.) Kilograms/sq. cm PSI Kilograms/sq. mm PSI Liters Gallons Meters Feet Poise Centipoise Pounds of water Gallons PSI 2.31 Feet of water PSI Inches of Hg. Square inches Square cm. 32

3 Technical Data FLOW-RATE PRESSURE DATA The graphs below give the clean pressure drop through a #2 size bag for water, 1 o F. P - PSI - #2 Bag FELT & MESH BAGS &10 25 & & 100 Flow Rate of Water (1 68 F) GPM 200 P - PSI - #2 Bag HIGH EFFICIENCY BAGS.15 To determine the pressure drop caused by the filter bag, follow these steps: Step 1 Step 2 Step 3 Using the type of bag, micron rating and flow rate, determine the pressure drop for water, 1 68 o F., for a size #2 bag. Correct for bag size from the Bag Correction table at the right if the bag size is different than a #2 size. If the viscosity of the liquid is greater than 1 cps 68 o F.),multiply the result from step 2 by the proper correction factor from the Viscosity Correction table at the right. The value obtained in Step 3 is the clean pressure drop caused by the filter bag. FELT FILTER BAG MICRON RATINGS & Flow Rate of Water (1 68 F) GPM For years filter bag manufactuers have used nominal ratings, i.e., about 50% efficiency for polyester and polypropylene felt filter bags. The table at the right gives the micron ratings at about 95% efficiency. P - PSI - #2 Bag KIMBERY-CLARK FATHOM TM BAGS VISCOSITY CORRECTION VISCOSITY CPS CORRECTION FACTOR , NOMINAL MICRON RATING - 50% 500 & & 530, Flow Rate of Water (1 68 F) GPM BAG SIZE BAG SIZE CORRECTION DIA. X LENGTH MULTIPLY BY X X X X X X X X X X CO1 7.5 X CO2 7.5 X RP1 8.0 X RP X X X HIGH EFFICIENCY MICRON RATING - 95% CONTENTS GENERAL INFORMATION Filter Bag Information... 1 RING TYPE FILTER BAGS FELT - &... 5 FELT - & Extended Life... 6 MESH - Multifilament... 7 MESH - Nylon Monofilament... 9 HIGH EFFICIENCY - Microfiber HIGH EFFICIENCY - Microfiber FDA APPROVED MEDIA MOLDED SUPER SEAL TOP TYPE FILTER BAGS FELT - & FELT - & Extended Life MESH - Multifilament MESH - Nylon Monofilament HIGH EFFICIENCY - Microfiber HIGH EFFICIENCY - Microfiber FDA APPROVED MEDIA ALL WELDED FILTER BAGS WITH MOLDED SUPER SEAL TOPS FELT - & FELT - & Extended Life FILTER BAGS FOR SPECIFIC BRAND HOUSINGS Filter Specialists (FSI) & Hayward Housings Filter Specialists (FSI) X100 Plastic Housings Pentair (Plymouth Products) Big Blue Housings RP Products (Ronningen-Petter) Side Entry Housings Parker Filtration (Commercial Filters) C Style Housings OTHER FILTER BAGS Replacement 3M Brand Pleated Filter Bags TECHNICAL DATA Flow Rate Pressure Drop Data Felt s Conversion Factors

4 General Information Pleated Filter Bags POLYESTER & POLYPROPYLENE FELT - TRADE SIZE 2 All industry standard sizes ratings Choice of sewn bags or all welded bags Metal ring tops or molded polypropylene tops with molded polyester optional Handles on all bags, polyester & nylon materials FDA Approved Kimberly Clark media choice FILTER BAG MATERIALS Super Seal Tops 2 1 PO1-PL2POSS 2 5 PO5-PL2POSS 2 10 PO10-PL2POSS 2 25 PO25-PL2POSS 2 50 PO50-PL2POSS PO100-PL2POSS PO200-PL2POSS Snap-Lok Tops 2 1 PO1-PL2POL 2 5 PO5-PL2POL 2 10 PO10-PL2POL 2 25 PO25-PL2POL 2 50 PO50-PL2POL PO100-PL2POL PO200-PL2POL Super Seal Tops HIGH EFFICIENCY POLYPROPYLENE & POLYESTER MICROFIBER - TRADE SIZE PE1-PL2POSS 2 5 PE5-PL2POSS 2 10 PE10-PL2POSS 2 25 PE25-PL2POSS 2 50 PE50-PL2POSS PE100-PL2POSS PE200-PL2POSS Snap-Lok Tops 2 1 PE1-PL2POL 2 5 PE5-PL2POL 2 10 PE10-PL2POL 2 25 PE25-PL2POL 2 50 PE50-PL2POL PE100-PL2POL PE200-PL2POL FELT MULTIFILAMENT MESH MONOFILAMENT MESH FELT filter bag materials are made from synthetic fibers in polypropylene or polyester. The proper combination of fiber diameters, weights and thickness results in an ecomonical depth type filter media. & polyester bags are suppled with a glazed finish to reduce fiber migration. These bags have a nominal micron rating MULTIFILAMENT MESH materials are offered in polyester and are woven from threads made of small fibers twisted together. Bags made of this material are low cost and considered disposable. They have lower efficiencies than the monofilament mesh. About 80% vs 90%. MONOFILAMENT MESH is offered in nylon and is a woven material. Each thread is a single filament. The openings are square,. They have excellent strength and are considered to be cleanable. Filter efficiency is 90% or more MICRONS 1, 5, 10, 25, 50, 100 & 200 MICRONS 100, 150, 200, 250, 300, 400, 600, 800, 1000 & 1500 MICRONS 5, 10, 25, 50, 75, 100, 150, 200, 250, 300, 400, 600, 800 & 1000 CLEAN FLUID GLAZED OUTER FINISH DEPTH FELT FILTER MEDIA TRAPS DIRT PARTICLES DIRTY FLUID CLEAN FLUID DIRTY FLUID PLAIN INNER FINISH Operates on the principle of surface filtration Wide range of micron ratings Reusable or disposable Non-fiber releasing Good efficiencies Can hold large quantities of contaminants under the right conditions Super Seal Tops POMF1.0-PL2POSS POMF2.5-PL2POSS POMF5.0-PL2POSS POMF10.0-PL2POSS POMF25.0-PL2POSS Snap-Lok Tops POMF1.0-PL2POL POMF2.5-PL2POL POMF5.0-PL2POL POMF10.0-PL2POL POMF25.0-PL2POL 100% welded construction Molded polypropylene tops and end caps #1 elements available Microfiber pleated bags have high efficiency micron ratings - 95% plus Super Seal Tops Snap-Lok Tops PEMF1.0-PL2POSS PEMF2.5-PL2POSS PEMF5.0-PL2POSS PEMF10.0-PL2POSS PEMF25.0-PL2POSS PEMF1.0-PL2POL PEMF2.5-PL2POL PEMF5.0-PL2POL PEMF10.0-PL2POL PEMF25.0-PL2POL Rosedale, Krystil Klear, Technologies & Strainrite size #1 & #2 housings - use polypropylene Super Seal tops Hayward & Filter Specialists (FSI) size #1 & #2 housings - use polypropylene Snap-Lok tops MICROFIBER MICROFIBER extended life filter bags provide high efficiency, 95% plus, and high contaminant holding capacity at low micron ratings with high efficiency. A felt pre-filter layer provides multilayer technology with precise and consistant filtration. These bags are available in polypropylene and polyester. MICRONS 1, 2.5, 5, 10 & 25 FELT PREFILTER INNER LAYER INNER COVER MICROFIBER MICROFILBER FINAL FILTER OUTER COVER SPUN BONDED 1 30

5 3M Brand Replacement Filter Bags & 500 Series HIGH EFFICIENCY POLYPROPYLENE MICROFIBER - TRADE SIZE 1 & SERIES Stainless Steel Rings ( A Ring) PO113A PO114A PO115A PO116A PO118A Stainless Steel Bands ( C Band) CO1 1.0 PO113C CO1 2.5 PO114C CO1 5.0 PO115C CO PO116C CO PO118C Stainless Steel Rings ( A Ring) Stainless Steel Bands ( C Band) HIGH EFFICIENCY POLYESTER MICROFIBER - TRADE SIZE 1 & SERIES Stainless Steel Rings ( A Ring) PE113A PE114A PE115A PE116A Stainless Steel Bands ( C Band) CO1 1.0 PE113C CO1 2.5 PE114C CO1 5.0 PE115C CO PE116C Stainless Steel Rings ( A Ring) PE123A PE124A PE125A PE126A Stainless Steel Bands ( C Band) HIGH EFFICIENCY POLYPROPYLENE MICROFIBER & FELT - TRADE SIZE 1 & SERIES Stainless Steel Rings ( A Ring) PO513A PO515A PO517A PO519A Stainless Steel Rings ( A Ring) HIGH EFFICIENCY POLYESTER MICROFIBER & FELT - TRADE SIZE 1 & SERIES Stainless Steel Rings ( A Ring) PE513A PE515A PE517A Silicone free thread High efficiency micron ratings - 95% plus PO123A PO124A PO125A PO126A PO128A CO2 1.0 PO123C CO2 2.5 PO124C CO2 5.0 PO125C CO PO126C CO PO128C CO2 1.0 PE123C CO2 2.5 PE124C CO2 5.0 PE125C CO PE126C PO523A PO525A PO527A PO529A Stainless Steel Rings ( A Ring) PE523A PE525A PE527A Rosedale, Krystil Klear, Technologies, Strainrite, Filtration Systems, Hayward & Parker Filtration G style, sizes #1 & #2 Parker Filtration (Commercial Filters) C style sizes CO1 & CO2 General Information KIMBERLY-CLARK BAG MATERIALS MICRON RATINGS FILTER BAG MATERIAL Felt Cross Section of FATHOM Media at x30 - showing Dual Zone Structure DOWN STREAM ZONE Multifilament Mesh Monofilament Mesh High Efficiency Microfiber Kimberly-Clark FATHOM KIMBERLY-CLARK FATHOM TM Bag Material FIBER Nylon UP STREAM ZONE MICRONS - 10, 20, 30, 40 & 50 OIL REMOVAL MATERIAL SPECIAL MATERIALS Bi-component Polyethylene From the top down, FATHOM TM Liquid Media is engineered to provide exceptional filtration performance. This unique fiber structure provides the power in FATHOM TM Media. Thermal bonding of the continuous fibers used to create FATHOM Media also prevents fiber shedding that can be encountered with some other media. Its patented nonwoven structure is designed with an upstream pre-filter zone for high particle loading capacity and, for enhamced performance, a downstream efficiency zone to deliver the right efficiency for your application. But the difference goes deeper: With a gradient density fiber structure, FATHOM TM Liquid Bag Media provdes premium depth filtration, trapping a wide range of particles for cleaner fluid streams. Chemically compatible with most liquid applications, FATHOM TM Liquid Bag Media contains no binders which could interfere with fluid chemistry. AVAILABLE MICRON RATINGS FDA A Approval Series 500, 510, 520, 530 & 540 materials 21 CFR approval for food contact except for edible oils. The fibers in the FATHOM TM material are becomponent polypropylene/polyethylene. Chemilcally compatible with most liquid applications, the media contains no binders which could interfere with fluid chemistry. Dirt holding capacities of 2 to 3 times conventional felt bags & comparable to microfiber bags at less cost. 200 o F. Max. temperature Kimberly-Clark Corporation used with permission Filter bags are also available that remove oil from water and water based-coolants. These bags are manufactured from melt blown polypropylene materials and can hold up to 3 to 4 pounds (2000 grams) in a #2 size filter bag. The standard micron rating is 25. When sizing these bags, the flow should be as low as possible for maximum oil removal. Special materials include polypropylene and polyester monofilaments, teflon felt and many more. Contact us with your requirements

6 General Information TOP DESIGNS RING TYPE TOP 3 MOLDED SUPER SEAL TOP MOLDED SNAP-LOK TOP AVAILABLE MATERIALS & CODE SYMBOL IN BAG CODE S - Galvanized Carbon Steel S-SS Stainless Steel HOUSING APPLICATIONS Rosedale Hayward Krystil Klear Technologies Filtration Systems 1 Strainrite 2 SIZE 7, 8 & 9 Rosedale Krystil Klear Technologies SIZE 12 Rosedale KrystiI Klear POSS - POL - PESS - PEL - Rosedale Krystil Klear Technologies Strainrite SIZE 7, 8 & 9 Rosedale Krystil Klear Technologies SIZE 12 Rosedale KrystIl Klear SIZE X01 Filter Specialists SIZE CO1 & CO2 Parker Filtration (Commercial) - C style FILTER BAG DESIGN & CONSTRUCTION NOTES: Standard filter bags are typically manufactured with a metal ring, either galvanized carbon steel or stainless steel, sewn in the top of the filter bag. Handles are also sewn in. Another design incorporates a molded plastic top. These tops typically are polypropylene or polyester with the handles molded in. Various types of tops are available to fit specific manufacturers housings. The top can be sewn or welded to a sewn bag in one case or supplied in an all-welded construction with either glazed polyester or polypropylene felt in another option. All-welded advantages include: There are no needle holes hence efficiencies are increased. No sewing thread is used resulting in the elimination of the possiblity of silicone contamination due to thread. The glazed finish and fused edges of the bags greatly reduce or eliminate fiber migration. MOLDED TOPS - RP PRODUCTS SIZE RPI SIZE RPI52 MOLDED TOP PENTAIR (PLYMOUTH PRODUCTS) P - P - No Code Symbol SIZE 1, 2, 3 & 4 SIZE 1, 2, 3 & 4 SIZE 1 & 2 SIZE 1 SIZE 152 SIZE 410 & 420 Filter Specialists 3 RP Products RP Products Hayward 4 Side Entry Side Entry Pentair (Plymouth Products) 1 Filtration Systems does not offer size #3 housings 2 Strainrite does not offer standard size #3 & 4 housings 3 Ring Type bags will not fit Filter Specialists (FSI) sizes #1, 2, 3 & 4 housings 4 Molded top filter bags not available for Filter Specialists (FSI) or Hayward size #3 & 4 housings at this time Sewn Bag With Metal Ring All-welded Bag With Molded Top Parker Filtration (Commercial Filters) C Style Housing Filter Bags - TRADE SIZES CO1 & CO2 - ALL BAGS HAVE POLYPROPYLENE SUPER SEAL TOPS & Felt Multifilament Mesh Nylon Monofilament Mesh CO1 1 PE1GCO1POSS PO1GCO1POSS CO1 5 PE5GCO1POSS PO5GCO1POSS CO1 10 PE10GCO1POSS PO10GCO1POSS CO1 25 PE25GCO1POSS PO25GCO1POSS CO1 50 PE50GCO1POSS PO50GCO1POSS CO1 100 PE100GCO1POSS PO100GCO1POSS CO1 200 PE200GCO1POSS PO200GCO1POSS CO1 100 PEM100PCO1POSS CO1 150 PEM150PCO1POSS CO1 200 PEM200PCO1POSS CO1 250 PEM250PCO1POSS CO1 300 PEM300PCO1POSS CO1 400 PEM400PCO1POSS CO1 600 PEM600PCO1POSS CO1 800 PEM800PCO1POSS CO PEM1000PCO1POSS CO PEM1500PCO1POSS Nylon CO1 5 NMO5PCO1POSS CO1 10 NMO10PCO1POSS CO1 25 NMO25PCO1POSS CO1 50 NMO50PCO1POSS CO1 75 NMO75PCO1POSS CO1 100 NMO100PCO1POSS CO1 150 NMO150PCO1POSS CO1 200 NMO200PCO1POSS CO1 300 NMO300PCO1POSS CO1 400 NMO400PCO1POSS CO1 600 NMO600PCO1POSS CO1 800 NMO800PCO1POSS CO NMO1000PCO1POSS High Efficiency Microfiber - & CO1 1.0 POMF1.0POCO1POSS CO1 2.5 POMF2.5POCO1POSS CO1 5.0 POMF5.0POCO1POSS CO POMF10.0POCO1POSS CO POMF25.0POCO1POSS CO1 1.0 PEMF1.0PECO1POSS CO1 2.5 PEMF2.5PECO1POSS CO1 5.0 PEMF5.0PECO1POSS CO PEMF10.0PECO1POSS C02 1 PE1GCO2POSS PO1GCO2POSS C02 5 PE5GCO2POSS PO5GCO2POSS C02 10 PE10GCO2POSS PO10GCO2POSS C02 25 PE25GCO2POSS PO25GCO2POSS C02 50 PE50GCO2POSS PO50GCO2POSS C PE100GCO2POSS PO100GCO2POSS C PE200GCO2POSS PO200GCO2POSS CO2 100 PEM100PCO2POSS CO2 150 PEM150PCO2POSS CO2 200 PEM200PCO2POSS CO2 250 PEM250PCO2POSS CO2 300 PEM300PCO2POSS CO2 400 PEM400PCO2POSS CO2 600 PEM600PCO2POSS CO2 800 PEM800PCO2POSS CO PEM1000PCO2POSS CO PEM1500PCO2POSS Oil Removal Bags Oil Removal CO OR25.0POCO1POSS CO OR25.0POCO2POSS Nylon CO2 5 NMO5PCO2POSS CO2 10 NMO10PCO2POSS CO2 25 NMO25PCO2POSS CO2 50 NMO50PCO2POSS CO2 75 NMO75PCO2POSS CO2 100 NMO100PCO2POSS CO2 150 NMO150PCO2POSS CO2 200 NMO200PCO2POSS CO2 300 NMO300PCO2POSS CO2 400 NMO400PCO2POSS CO2 600 NMO600PCO2POSS CO2 800 NMO800PCO2POSS CO NMO1000PCO2POSS CO2 1.0 POMF1.0POC02POSS CO2 2.5 POMF2.5POC02POSS CO2 5.0 POMF5.0POC02POSS CO POMF10.0POC02POSS CO POMF25.0POC02POSS CO2 1.0 PEMF1.0PECO2POSS CO2 2.5 PEMF2.5PECO2POSS CO2 5.0 PEMF5.0PECO2POSS CO PEMF10.0PECO2POSS Kimberly-Clark FATHOM TM Media - FDA Approved / Polyethylene CO KC500BCO1POSS CO KC510BCO1POSS CO KC520BCO1POSS CO KC530BCO1POSS CO KC540BCO1POSS Super Seal tops Super Seal tops available Silicone free thread CO KC500BCO2POSS CO KC510BCO2POSS CO KC520BCO2POSS CO KC530BCO2POSS CO KC540BCO2POSS Parker Filtration housings - C style size CO1 & CO2 28

7 Parker Filtration (Commercial Filters) C Style Housing Filter Bags TRADE SIZES CO1 & CO2 - ALL BAGS HAVE STAINLESS STEEL BANDS & Felt Nylon Monofilament Mesh CO1 1 PE1GCO1B PO1GCO1B CO1 5 PE5GCO1B PO5GCO1B CO1 10 PE10GCO1B PO10GCO1B CO1 25 PE25GCO1B PO25GCO1B CO1 50 PE50GCO1B PO50GCO1B CO1 100 PE100GCO1B PO100GCO1B CO1 200 PE200GCO1B PO200GCO1B Multifilament Mesh CO1 100 PEM100PCO1B CO1 150 PEM150PCO1B CO1 200 PEM200PCO1B CO1 250 PEM250PCO1B CO1 300 PEM300PCO1B CO1 400 PEM400PCO1B CO1 600 PEM600PCO1B CO1 800 PEM800PCO1B CO PEM1000PCO1B CO PEM1500PCO1B Nylon CO1 5 NMO5PCO1B CO1 10 NMO10PCO1B CO1 25 NMO25PCO1B CO1 50 NMO50PCO1B CO1 75 NMO75PCO1B CO1 100 NMO100PCO1B CO1 150 NMO150PCO1B CO1 200 NMO200PCO1B CO1 300 NMO300PCO1B CO1 400 NMO400PCO1B CO1 600 NMO600PCO1B CO1 800 NMO800PCO1B CO NMO1000PCO1B High Efficiency Microfiber - & CO1 1.0 POMF1.0POCO1B CO1 2.5 POMF2.5POCO1B CO1 5.0 POMF5.0POCO1B CO POMF10.0POCO1B CO POMF25.0POCO1B CO1 1.0 PEMF1.0PECO1B CO1 2.5 PEMF2.5PECO1B CO1 5.0 PEMF5.0PECO1B CO PEMF10.0PECO1B CO2 100 PEM100PCO2B CO2 150 PEM150PCO2B CO2 200 PEM200PCO2B CO2 250 PEM250PCO2B CO2 300 PEM300PCO2B CO2 400 PEM400PCO2B CO2 600 PEM600PCO2B CO2 800 PEM800PCO2B CO PEM1000PCO2B CO PEM1500PCO2B Nylon CO2 5 NMO5PCO2B CO2 10 NMO10PCO2B CO2 25 NMO25PCO2B CO2 50 NMO50PCO2B CO2 75 NMO75PCO2B CO2 100 NMO100PCO2B CO2 150 NMO150PCO2B CO2 200 NMO200PCO2B CO2 300 NMO300PCO2B CO2 400 NMO400PCO2B CO2 600 NMO600PCO2B CO2 800 NMO800PCO2B CO NMO1000PCO2B Oil Removal Bags Oil Removal CO OR25.0POCO1B CO OR25.0POCO2B CO2 1.0 POMF1.0POC02B CO2 2.5 POMF2.5POC02B CO2 5.0 POMF5.0POC02B CO POMF10.0POC02B CO POMF25.0POC02B CO2 1.0 PEMF1.0PECO2B CO2 2.5 PEMF2.5PECO2B CO2 5.0 PEMF5.0PECO2B CO PEMF10.0PECO2B Kimberly-Clark FATHOM TM Media - FDA Approved / Polyethylene CO KC500BCO1B CO KC510BCO1B CO KC520BCO1B CO KC530BCO1B CO KC540BCO1B Stainless steel bands 27 Silicone free thread CO2 1 PE1GCO2B PO1GCO2B CO2 5 PE5GCO2B PO5GCO2B CO2 10 PE10GCO2B PO10GCO2B CO2 25 PE25GCO2B PO25GCO2B CO2 50 PE50GCO2B PO50GCO2B CO2 100 PE100GCO2B PO100GCO2B CO2 200 PE200GCO2B PO200GCO2B CO KC500BCO2B CO KC510BCO2B CO KC520BCO2B CO KC530BCO2B CO KC540BCO2B Parker Filtration housings - C style size CO1 & CO2 General Information FILTER BAG SIZES Dimensions are approximate depending on top design. TRADE SIZE OUTSIDE DIAMETER - IN. LENGTH - IN. PLEATED FILTER BAGS TEMPERATURE LIMITS Pleated filter bags are available, as a standard product, in polyester and polypropylene felt and polyester and polypropylene microfiber materials in trade size #2 to fit the following manufacturers housings. #1 elements available on special order. #2 Pleated Filter Bag Element AREA 2 - FT EXTENDED LIFE FILTER BAGS TRADE SIZE Rosedale Hayward MICRON RATINGS TRADE SIZE OUTSIDE DIAMETER - IN. Krystil Klear Technologies or polypropylene High efficiency microfiber or polypropylene Felt - nominal ratings OUTSIDE DIAMETER - IN. The extended life feature is available for felt bags in most sizes. A prefilter layer of polyester or polypropylene felt, which provides graded density filtration, results in an increase in service life of 100% to 300%. The extended life feature is standard on polypropylene & polyester microfiber filter bags. LENGTH - IN. LENGTH - IN. AREA 2 - FT X CO CO RP RP AREA - FT Filter Specialists (FSI) Strainrite 1.0, 2.5, 5.0, 10.0, , 5, 10, 25, 50, 100, 200 POLYPROPYLENE o F Max. KIMBERLY-CLARK FATHOM TM Bag Material o F Max. POLYESTER o F Max. NYLON o F Max. Maximum temperature also depends on liquid. Consult the factory. The #2 size pleated filter bag elements have 20+ft 2. of filter area compared to 4-1/2 ft 2. for a standard #2 size bag. This will result in an increase in filter service life of 600% to 700%. FELT PREFILTER INNER LAYER FELT OUTER FINAL FILTER 4

8 Felt Filter Bags - Ring Type POLYESTER & POLYPROPYLENE FELT - TRADE SIZES 1, 2, 3, 4, 7, 8, 9 & 12 Galvanized Carbon Steel Rings Glazed finish * PE1G1S PO1G1S 1 5 PE5G1S PO5G1S 1 10 PE10G1S PO10G1S 1 25 PE25G1S PO25G1S 1 50 PE50G1S PO50G1S PE100G1S PO100G1S PE200G1S PO200G1S 2 1 PE1G2S PO1G2S 2 5 PE5G2S PO5G2S 2 10 PE10G2S PO10G2S 2 25 PE25G2S PO25G2S 2 50 PE50G2S PO50G2S PE100G2S PO100G2S PE200G2S PO200G2S 3 1 PE1G3S PO1G3S 3 5 PE5G3S PO5G3S 3 10 PE10G3S PO10G3S 3 25 PE25G3S PO25G3S 3 50 PE50G3S PO50G3S PE100G3S PO100G3S PE200G3S PO200G3S 4 1 PE1G4S PO1G4S 4 5 PE5G4S PO5G4S 4 10 PE10G4S PO10G4S 4 25 PE25G4S PO25G4S 4 50 PE50G4S PO50G4S PE100G4S PO100G4S PE200G4S PO200G4S 7 1 PE1G7S PO1G7S 7 5 PE5G7S PO5G7S 7 10 PE10G7S PO10G7S 7 25 PE25G7S PO25G7S 7 50 PE50G7S PO50G7S PE100G7S PO100G7S PE200G7S PO200G7S 8 1 PE1G8S PO1G8S 8 5 PE5G8S PO5G8S 8 10 PE10G8S PO10G8S 8 25 PE25G8S PO25G8S 8 50 PE50G8S PO50G8S PE100G8S PO100G8S PE200G8S PO200G8S 9 1 PE1G9S PO1G9S 9 5 PE5G9S PO5G9S 9 10 PE10G9S PO10G9S 9 25 PE25G9S PO25G9S 9 50 PE50G9S PO50G9S PE100G9S PO100G9S PE200G9S PO200G9S 12 1 PE1G12S PO1G12S 12 5 PE5G12S PO5G12S PE10G12S PO10G12S PE25G12S PO25G12S PE50G12S PO50G12S PE100G12S PO100G12S PE200G12S PO200G12S * Plain finish available at same price - change G in bag code to P i.e., PO25G!S becomes PO25P1S 304 Stainless Steel Steel Rings 1 1 PE1G1S-SS PO1G1S-SS 1 5 PE5G1S-SS PO5G1S-SS 1 10 PE10G1S-SS PO10G1S-SS 1 25 PE25G1S-SS PO25G1S-SS 1 50 PE50G1S-SS PO50G1S-SS PE100G1S-SS PO100G1S-SS PE200G1S-SS PO200G1S-SS 2 1 PE1G2S-SS PO1G2S-SS 2 5 PE5G2S-SS PO5G2S-SS 2 10 PE10G2S-SS PO10G2S-SS 2 25 PE25G2S-SS PO25G2S-SS 2 50 PE50G2S-SS PO50G2S-SS PE100G2S-SS PO100G2S-SS PE200G2S-SS PO200G2S-SS 3 1 PE1G3S-SS PO1G3S-SS 3 5 PE5G3S-SS PO5G3S-SS 3 10 PE10G3S-SS PO10G3S-SS 3 25 PE25G3S-SS PO25G3S-SS 3 50 PE50G3S-SS PO50G3S-SS PE100G3S-SS PO100G3S-SS PE200G3S-SS PO200G3S-SS 4 1 PE1G4S-SS PO1G4S-SS 4 5 PE5G4S-SS PO5G4S-SS 4 10 PE10G4S-SS PO10G4S-SS 4 25 PE25G4S-SS PO25G4S-SS 4 50 PE50G4S-SS PO50G4S-SS PE100G4S-SS PO100G4S-SS PE200G4S-SS PO200G4S-SS 7 1 PE1G7S-SS PO1G7S-SS 7 5 PE5G7S-SS PO5G7S-SS 7 10 PE10G7S-SS PO10G7S-SS 7 25 PE25G7S-SS PO25G7S-SS 7 50 PE50G7S-SS PO50G7S-SS PE100G7S-SS PO100G7S-SS PE200G7S-SS PO200G7S-SS 8 1 PE1G8S-SS PO1G8S-SS 8 5 PE5G8S-SS PO5G8S-SS 8 10 PE10G8S-SS PO10G8S-SS 8 25 PE25G8S-SS PO25G8S-SS 8 50 PE50G8S-SS PO50G8S-SS PE100G8S-SS PO100G8S-SS PE200G8S-SS PO200G8S-SS 9 1 PE1G9S-SS PO1G9S-SS 9 5 PE5G9S-SS PO5G9S-SS 9 10 PE10G9S-SS PO10G9S-SS 9 25 PE25G9S-SS PO25G9S-SS 9 50 PE50G9S-SS PO50G9S-SS PE100G9S-SS PO100G9S-SS PE200G9S-SS PO200G9S-SS 12 1 PE1G12S-SS PO1G12S-SS 12 5 PE5G12S-SS PO5G12S-SS PE10G12S-SS PO10G12S-SS PE25G12S-SS PO25G12S-SS PE50G12S-SS PO50G12S-SS PE100G12S-SS PO100G12S-SS PE200G12S-SS PO200G12S-SS Rosedale, Krystil Klear & Technologies all sizes Hayward sizes 1, 2, 3 & 4 Parker sizes 1 & 2 G style Filtration Systems sizes 1, 2 & 4 Filter Specialists (FSI) - will not fit sizes 1, 2, 3 & 4 - See page 22 & 23 Ring type bags will also fit housings made by other manufacturers which are not seen as frequently as the above. Contact the factory for recommendations. RP Products (Ronningen-Petter) Side Entry Housing Filter Bags TRADE SIZES RPI & RPI52 - ALL BAGS HAVE MOLDED POLYPROPYLENE TOPS & Felt Multifilament Mesh RP1 100 PEM100PRP1P RP1 150 PEM150PRP1P RP1 200 PEM200PRP1P RP1 250 PEM250PRP1P RP1 300 PEM300PRP1P RP1 400 PEM400PRP1P RP1 600 PEM600PRP1P RP1 800 PEM800PRP1P RP1 600 PEM1000PRP1P RP1 800 PEM1500PRP1P Nylon Monofilament Mesh Nylon RP1 5 NMO5PRP1P RP1 10 NMO10PRP1P RP1 25 NMO25PRP1P RP1 50 NMO50PRP1P RP1 75 NMO75PRP1P RP1 100 NMO100PRP1P RP1 150 NMO150PRP1P RP1 200 NMO200PRP1P RP1 300 NMO300PRP1P RP1 400 NMO400PRP1P RP1 600 NMO600PRP1P RP1 800 NMO800PRP1P RP NMO1000PRP1P High Efficiency Microfiber - & RP1 1.0 POMF1.0PORP1P RP1 2.5 POMF2.5PORP1P RP1 5.0 POMF5.0PORP1P RP POMF10.0PORP1P RP POMF25.0PORP1P RP1 1.0 PEMF1.0PERP1P RP1 2.5 PEMF2.5PERP1P RP1 5.0 PEMF5.0PERP1P RP PEMF10.0PERP1P Molded polypropylene tops RP KC500BRP1P RP KC510BRP1P RP KC520BRP1P RP KC530BRP1P RP KC540BRP1P RP1 1 PE1GRP1P PO1GRP1P RP1 5 PE5GRP1P PO5GRP1P RP1 10 PE10GRP1P PO10GRP1P RP1 25 PE25GRP1P PO25GRP1P RP1 50 PE50GRP1P PO50GRP1P RP1 100 PE100GRP1P PO100GRP1P RP1 200 PE200GRP1P PO200GRP1P Oil Removal Bags RP OR25.0PORP1P RP PEM100PRP152P RP PEM150PRP152P RP PEM200PRP152P RP PEM250PRP152P RP PEM300PRP152P RP PEM400PRP152P RP PEM600PRP152P RP PEM800PRP152P RP PEM1000PRP152P RP PEM1500PRP152P Nylon RP152 5 NMO5PRP152P RP NMO10PRP152P RP NMO25PRP152P RP NMO50PRP152P RP NMO75PRP152P RP NMO100PRP152P RP NMO150PRP152P RP NMO200PRP152P RP NMO300PRP152P RP NMO400PRP152P RP NMO600PRP152P RP NMO800PRP152P RP NMO1000PRP152P RP POMF1.0PORP152P RP POMF2.5PORP152P RP POMF5.0PORP152P RP POMF10.0PORP152P RP POMF25.0PORP152P RP PEMF1.0PERP152P RP PEMF2.5PERP152P RP PEMF5.0PERP152P RP PEMF10.0PERP152P RP OR25.0PORP152P RP KC500BRP152P RP KC510BRP152P RP KC520BRP152P RP KC530BRP152P RP KC540BRP152P RP152 1 PE1GRP152P PO1GRP152P RP152 5 PE5GRP152P PO5GRP152P RP PE10GRP152P PO10GRP152P RP PE25GRP152P PO25GRP152P RP PE50GRP152P PO50GRP152P RP PE100GRP152P PO100GRP152P RP PE200GRP152P PO200GRP152P Kimberly-Clark FATHOM TM Media - FDA Approved / Polyethylene RP Products side entry housings - RP! & RP152 26

9 Pentair (Plymouth Products) Big Blue Housing Filter Bags TRADE SIZES 410 & ALL BAGS HAVE MOLDED POLYPROPYLENE TOPS Felt - All Welded High Efficiency Extended Life Microfiber and / or Felt BN BN BN BN BN BN BN BN BN BN BN BN BN BN BN BN BN BN BN BN Kimberly-Clark FATHOM TM Media - FDA Approved / Polyethylene BP BP BP BP BP BP BP BP BPHE BPHE BPHE BPHE BPHE BPHE BPHE BPHE Nylon Monofilament Mesh BKC BKC BKC BKC BKC Molded polypropylene tops Sewn or all-welded construction on sewn bags BP BP BP BP BP BP BP BP BPHE BPHE BPHE BPHE BPHE BPHE BPHE BPHE BKC BKC BKC BKC BKC Pentair Big Blue housings s PBH-410-1, PBH , PBH-420-1, PBH Felt Filter Bags Extended Life - Ring Type POLYESTER & POLYPROPYLENE FELT - TRADE SIZES 1, 2, 3, 4, 7, 8, 9 & 12 Galvanized Carbon Steel Rings Glazed finish * 1 1 PEXL1G1S POXL1G1S 1 5 PEXL5G1S POXL5G1S 1 10 PEXL10G1S POXL10G1S 1 25 PEXL25G1S POXL25G1S 1 50 PEXL50G1S POXL50G1S PEXL100G1S POXL100G1S PEXL200G1S POXL200G1S 2 1 PEXL1G2S POXL1G2S 2 5 PEXL5G2S POXL5G2S 2 10 PEXL10G2S POXL10G2S 2 25 PEXL25G2S POXL25G2S 2 50 PEXL50G2S POXL50G2S PEXL100G2S POXL100G2S PEXL200G2S POXL200G2S 3 1 PEXL1G3S POXL1G3S 3 5 PEXL5G3S POXL5G3S 3 10 PEXL10G3S POXL10G3S 3 25 PEXL25G3S POXL25G3S 3 50 PEXL50G3S POXL50G3S PEXL100G3S POXL100G3S PEXL200G3S POXL200G3S 4 1 PEXL1G4S POXL1G4S 4 5 PEXL5G4S POXL5G4S 4 10 PEXL10G4S POXL10G4S 4 25 PEXL25G4S POXL25G4S 4 50 PEXL50G4S POXL50G4S PEXL100G4S POXL100G4S PEXL200G4S POXL200G4S 7 1 PEXL1G7S POXL1G7S 7 5 PEXL5G7S POXL5G7S 7 10 PEXL10G7S POXL10G7S 7 25 PEXL25G7S POXL25G7S 7 50 PEXL50G7S POXL50G7S PEXL100G7S POXL100G7S PEXL200G7S POXL200G7S 8 1 PEXL1G8S POXL1G8S 8 5 PEXL5G8S POXL5G8S 8 10 PEXL10G8S POXL10G8S 8 25 PEXL25G8S POXL25G8S 8 50 PEXL50G8S POXL50G8S PEXL100G8S POXL100G8S PEXL200G8S POXL200G8S 9 1 PEXL1G9S POXL1G9S 9 5 PEXL5G9S POXL5G9S 9 10 PEXL10G9S POXL10G9S 9 25 PEXL25G9S POXL25G9S 9 50 PEXL50G9S POXL50G9S PEXL100G9S POXL100G9S PEXL200G9S POXL200G9S 12 1 PEXL1G12S POXL1G12S 12 5 PEXL5G12S POXL5G12S PEXL10G12S POXL10G12S PEXL25G12S POXL25G12S PEXL50G12S POXL50G12S PEXL100G12S POXL100G12S PEXL200G12S POXL200G12S * Plain finish available at same price - change G in bag code to P i.e., POXL25G1S becomes POXL25P1S 304 Stainless Steel Steel Rings 1 1 PEXL1G1S-SS POXL1G1S-SS 1 5 PEXL5G1S-SS POXL5G1S-SS 1 10 PEXL10G1S-SS POXL10G1S-SS 1 25 PEXL25G1S-SS POXL25G1S-SS 1 50 PEXL50G1S-SS POXL50G1S-SS PEXL100G1S-SS POXL100G1S-SS PEXL200G1S-SS POXL200G1S-SS 2 1 PEXL1G2S-SS POXL1G2S-SS 2 5 PEXL5G2S-SS POXL5G2S-SS 2 10 PEXL10G2S-SS POXL10G2S-SS 2 25 PEXL25G2S-SS POXL25G2S-SS 2 50 PEXL50G2S-SS POXL50G2S-SS PEXL100G2S-SS POXL100G2S-SS PEXL200G2S-SS POXL200G2S-SS 3 1 PEXL1G3S-SS POXL1G3S-SS 3 5 PEXL5G3S-SS POXL5G3S-SS 3 10 PEXL10G3S-SS POXL10G3S-SS 3 25 PEXL25G3S-SS POXL25G3S-SS 3 50 PEXL50G3S-SS POXL50G3S-SS PEXL100G3S-SS POXL100G3S-SS PEXL200G3S-SS POXL200G3S-SS 4 1 PEXL1G4S-SS POXL1G4S-SS 4 5 PEXL5G4S-SS POXL5G4S-SS 4 10 PEXL10G4S-SS POXL10G4S-SS 4 25 PEXL25G4S-SS POXL25G4S-SS 4 50 PEXL50G4S-SS POXL50G4S-SS PEXL100G4S-SS POXL100G4S-SS PEXL200G4S-SS POXL200G4S-SS 7 1 PEXL1G7S-SS POXL1G7S-SS 7 5 PEXL5G7S-SS POXL5G7S-SS 7 10 PEXL10G7S-SS POXL10G7S-SS 7 25 PEXL25G7S-SS POXL25G7S-SS 7 50 PEXL50G7S-SS POXL50G7S-SS PEXL100G7S-SS POXL100G7S-SS PEXL200G7S-SS POXL200G7S-SS 8 1 PEXL1G8S-SS POXL1G8S-SS 8 5 PXLE5G8S-SS POXL5G8S-SS 8 10 PEXL10G8S-SS POXL10G8S-SS 8 25 PEXL25G8S-SS POXL25G8S-SS 8 50 PEXL50G8S-SS POXL50G8S-SS PEXL100G8S-SS POXL100G8S-SS PEXL200G8S-SS POXL200G8S-SS 9 1 PEXL1G9S-SS POXL1G9S-SS 9 5 PEXL5G9S-SS POXL5G9S-SS 9 10 PEXL10G9S-SS POXL10G9S-SS 9 25 PEXL25G9S-SS POXL25G9S-SS 9 50 PEXL50G9S-SS POXL50G9S-SS PEXL100G9S-SS POXL100G9S-SS PEXL200G9S-SS POXL200G9S-SS 12 1 PEXL1G12S-SS POXL1G12S-SS 12 5 PEXL5G12S-SS POXL5G12S-SS PEXL10G12S-SS POXL10G12S-SS PEXL25G12S-SS POXL25G12S-SS PEXL50G12S-SS POXL50G12S-SS PEXL100G12S-SS POXL100G12S-SS PEXL200G12S-SS POXL200G12S-SS Rosedale, Krystil Klear & Technologies all sizes Hayward sizes 1, 2, 3 & 4 Parker sizes 1 & 2 G style Filtration Systems sizes 1, 2 & 4 Filter Specialists (FSI) - will not fit sizes 1, 2, 3 & 4 - See page 22 & 23 Ring type bags will also fit housings made by other manufacturers which are not seen as frequently as the above. Contact the factory for recommendations. 6

10 Mesh Filter Bags - Ring Type POLYESTER MULTIFILAMENT MESH - TRADE SIZES 1, 2, 3, 4, 7, 8, 9 & 12 Galvanized Carbon Steel Rings Galvanized Carbon Steel Rings PEM100P1S PEM150P1S PEM200P1S PEM250P1S PEM300P1S PEM400P1S PEM600P1S PEM800P1S PEM1000P1S PEM1500P1S PEM100P2S PEM150P2S PEM200P2S PEM250P2S PEM300P2S PEM400P2S PEM600P2S PEM800P2S PEM1000P2S PEM1500P2S PEM100P3S PEM150P3S PEM200P3S PEM250P3S PEM300P3S PEM400P3S PEM600P3S PEM800P3S PEM1000P3S PEM1500P3S PEM100P4S PEM150P4S PEM200P4S PEM250P4S PEM300P4S PEM400P4S PEM600P4S PEM800P4S PEM1000P4S PEM1500P4S Plain finish PEM100P7S PEM150P7S PEM200P7S PEM250P7S PEM300P7S PEM400P7S PEM600P7S PEM800P7S PEM1000P7S PEM1500P7S PEM100P8S PEM150P8S PEM200P8S PEM250P8S PEM300P8S PEM400P8S PEM600P8S PEM800P8S PEM1000P8S PEM1500P8S PEM100P9S PEM150P9S PEM200P9S PEM250P9S PEM300P9S PEM400P9S PEM600P9S PEM800P9S PEM1000P9S PEM1500P9S PEM100P12S PEM150P12S PEM200P12S PEM250P12S PEM300P12S PEM400P12S PEM600P12S PEM800P12S PEM1000P12S PEM1500P12S Rosedale, Krystil Klear & Technologies all sizes Hayward sizes 1, 2, 3 & 4 Parker sizes 1 & 2 G style Filtration Systems sizes 1, 2 & 4 Filter Specialists (FSI) - will not fit sizes 1, 2, 3 & 4 - See page 22 & 23 Ring type bags will also fit housings made by other manufacturers which are not seen as frequently as the above. Contact the factory for recommendations. Filter Bags for Filter Specialists (FSI) X100 Housings TRADE SIZE XO1 - ALL BAGS HAVE POLYPROPYLENE SUPER SEAL TOPS Felt High Efficiency Microfiber X01 1 PO1GX01POSS X01 5 PO5GX01POSS X01 10 PO10GX0POSS X01 25 PO25GX01POSS X01 50 PO50GX01POSS X PO100GX01POSS X PO200GX01POSS Felt - All Welded X01 1 PO1GX01POSS-WE X01 5 PO5GX01POSS-WE X01 10 PO10GX0POSS-WE X01 25 PO25GX01POSS-WE X01 50 PO50GX01POSS-WE X PO100GX01POSS-WE X PO200GX01POSS-WE Multifilament Mesh X PEM100X01POSS X PEM150X01POSS X PEM200X01POSS X PEM250X01POSS X PEM300X01POSS X PEM400X01POSS X PEM600X01POSS X PEM800X01POSS X PEM1000X01POSS X PEM1500X01POSS X POMFX1.0POX01POSS X POMFX2.5POX01POSS X POMFX5.0POX01POSS X POMFX10.0POX01POSS X POMFX25.0POX01POSS Sewn or all-welded construction on sewn bags Molded polypropylene Super Seal tops Propylene X KC500BX01POSS X KC510BX01POSS X KC520BX01POSS X KC530BX01POSS X KC540BX01POSS Felt Extended Life X01 1 POXL1GX01POSS X01 5 POXL5GX01POSS X01 10 POXL10GX01POSS X01 25 POXL25GX01POSS X01 50 POXL50GX01POSS X POXL100GX01POSS X POXL200GX01POSS Felt Extended Life - All Welded X01 1 POXL1GX01POSS-WE X01 5 POXL5GX01POSS-WE X01 10 POXL10GX01POSS-WE X01 25 POXL25GX01POSS-WE X01 50 POXL50GX01POSS-WE X POXL100GX01POSS-WE X POXL200GX01POSS-WE Nylon Monofilament Mesh X01 5 NMO5PX01POSS X01 10 NMO10PX01POSS X01 25 NMO25PX01POSS X01 50 NMO50PX01POSS X01 75 NMO75PX01POSS X NMO100PX01POSS X NMO150PX01POSS X NMO200PX01POSS X NMO300PX01POSS X NMO400PX01POSS X NMO600PX01POSS X NMO800PX01POSS X NMO1000PX01POSS Oil Removal Bags Kimberly-Clark FATHOM TM Media - FDA Approved / Polyethylene X OR25.0POX01POL Filter Specialist, Inc., X100 filter housing 7 24

11 Filter Bags for Filter Specialists (FSI) & Hayward Housings TRADE SIZES 1 & 2 - ALL BAGS HAVE POLYPROPYLENE SNAP-LOK TOPS Multifilament Mesh PEM100P1POL PEM150P1POL PEM200P1POL PEM250P1POL PEM300P1POL PEM400P1POL PEM600P1POL PEM800P1POL PEM1000P1POL PEM1500P1POL PEM100P2POL PEM150P2POL PEM200P2POL PEM250P2POL PEM300P2POL PEM400P2POL PEM600P2POL PEM800P2POL PEM1000P2POL PEM1500P2POL High Efficiency Microfiber POMFXL1.0PO1POL POMFXL2.5PO1POL POMFXL5.0PO1POL POMFXL10.0PO1POL POMFXL25.0PO1POL POMFXL1.0PO2POL POMFXL2.5PO2POL POMFXL5.0PO2POL POMFXL10.0PO2POL POMFXL25.0PO2POL Molded polypropylene Snap-Lok tops Snap-Lok tops available Oil Removal Bags Oil Removal OR25.0PO1POL OR25.0PO2POL Nylon Monofilament Mesh 1 5 NMO5P1POL 1 10 NMO10P1POL 1 25 NMO25P1POL 1 50 NMO50P1POL 1 75 NMO75P1POL NMO100P1POL NMO150P1POL NMO200P1POL NMO250P1POL NMO300P1POL NMO400P1POL NMO600P1POL PNMO800P1POL NMO1000P1POL 2 5 NMO5P2POL 2 10 NMO10P2POL 2 25 NMO25P2POL 2 50 NMO50P2POL 2 75 NMO75P2POL NMO100P2POL NMO150P2POL NMO200P2POL NMO250P2POL NMO300P2POL NMO400P2POL NMO600P2POL PNMO800P2POL NMO1000P2POL High Efficiency Microfiber PEMFXL1.0PE1POL PEMFXL2.5PE1POL PEMFXL5.0PE1POL PEMFXL10.0PE1POL PEMFXL1.0PE2POL PEMFXL2.5PE2POL PEMFXL5.0PE2POL PEMFXL10.0PE2POL Kimberly-Clark FATHOM TM Media - FDA Approved / Polyethylene KC500B1POL KC510B1POL KC520B1POL KC530B1POL KC540B1POL KC500B2POL KC510B2POL KC520B2POL KC530B2POL KC540B2POL Filter bags with molded Snap-Lok tops fit FSI & Hayward sizes #1 & #2 housings Molded Snap-Lok top not available for size 3 & 4 FSI or Hayward housings at this time Ring type bags will fit Hayward size 3 & 4 housinga but not FSI. Mesh Filter Bags - Ring Type POLYESTER MULTIFILAMENT MESH - TRADE SIZES 1, 2, 3, 4, 7, 8, 9 & Stainless Steel Rings 304 Stainless Steel Rings PEM100P1S-SS PEM150P1S-SS PEM200P1S-SS PEM250P1S-SS PEM300P1S-SS PEM400P1S-SS PEM600P1S-SS PEM800P1S-SS PEM1000P1S-SS PEM1500P1S-SS PEM100P2S-SS PEM150P2S-SS PEM200P2S-SS PEM250P2S-SS PEM300P2S-SS PEM400P2S-SS PEM600P2S-SS PEM800P2S-SS PEM1000P2S-SS PEM1500P2S-SS PEM100P3S-SS PEM150P3S-SS PEM200P3S-SS PEM250P3S-SS PEM300P3S-SS PEM400P3S-SS PEM600P3S-SS PEM800P3S-SS PEM1000P3S-SS PEM1500P3S-SS PEM100P4S-SS PEM150P4S-SS PEM200P4S-SS PEM250P4S-SS PEM300P4S-SS PEM400P4S-SS PEM600P4S-SS PEM800P4S-SS PEM1000P4S-SS PEM1500P4S-SS Plain finish PEM100P7S-SS PEM150P7S-SS PEM200P7S-SS PEM250P7S-SS PEM300P7S-SS PEM400P7S-SS PEM600P7S-SS PEM800P7S-SS PEM1000P7S-SS PEM1500P7S-SS PEM100P8S-SS PEM150P8S-SS PEM200P8S-SS PEM250P8S-SS PEM300P8S-SS PEM400P8S-SS PEM600P8S-SS PEM800P8S-SS PEM1000P8S-SS PEM1500P8S-SS PEM100P9S-SS PEM150P9S-SS PEM200P9S-SS PEM250P9S-SS PEM300P9S-SS PEM400P9S-SS PEM600P9S-SS PEM800P9S-SS PEM1000P9S-SS PEM1500P9S-SS PEM100P12S-SS PEM150P12S-SS PEM200P12S-SS PEM250P12S-SS PEM300P12S-SS PEM400P12S-SS PEM600P12S-SS PEM800P12S-SS PEM1000P12S-SS PEM1500P12S-SS Rosedale, Krystil Klear & Technologies all sizes Hayward sizes 1, 2, 3 & 4 Parker sizes 1 & 2 G style Filtration Systems sizes 1, 2 & 4 Filter Specialists (FSI) - will not fit sizes 1, 2, 3 & 4 - See page 22 & 23 Ring type bags will also fit housings made by other manufacturers which are not seen as frequently as the above. Contact the factory for recommendations. 23 8

12 Mesh Filter Bags - Ring Type NYLON MONOFILAMENT MESH - TRADE SIZES 1, 2, 3, 4, 7, 8, 9 & 12 Galvanized Carbon Steel Rings Galvanized Carbon Steel Rings NMO5P1S 1 10 NMO10P1S 1 25 NMO25P1S 1 50 NMO50P1S 1 75 NMO75P1S NMO100P1S NMO150P1S NMO200P1S NMO300P1S NMO400P1S NMO600P1S NMO800P1S NMO1000P1S 2 5 NMO5P2S 2 10 NMO10P2S 2 25 NMO25P2S 2 50 NMO50P2S 2 75 NMO75P2S NMO100P2S NMO150P2S NMO200P2S NMO300P2S NMO400P2S NMO600P2S NMO800P2S NMO1000P2S 3 5 NMO5P3S 3 10 NMO10P3S 3 25 NMO25P3S 3 50 NMO50P3S 3 75 NMO75P3S NMO100P3S NMO150P3S NMO200P3S NMO300P3S NMO400P3S NMO600P3S NMO800P3S NMO1000P3S 4 5 NMO5P4S 4 10 NMO10P4S 4 25 NMO25P4S 4 50 NMO50P4S 4 75 NMO75P4S NMO100P4S NMO150P4S NMO200P4S NMO300P4S NMO400P4S NMO600P4S NMO800P4S NMO1000P4S Plain finish Plain finish Sewn construction Nominal Generally micron cleanable ratings 7 5 NMO5P7S 7 10 NMO10P7S 7 25 NMO25P7S 7 50 NMO50P7S 7 75 NMO75P7S NMO100P7S NMO150P7S NMO200P7S NMO300P7S NMO400P7S NMO600P7S NMO800P7S NMO1000P7S 8 5 NMO5P8S 8 10 NMO10P8S 8 25 NMO25P8S 8 50 NMO50P8S 8 75 NMO75P8S NMO100P8S NMO150P8S NMO200P8S NMO300P8S NMO400P8S NMO600P8S NMO800P8S NMO1000P8S 9 5 NMO5P9S 9 10 NMO10P9S 9 25 NMO25P9S 9 50 NMO50P9S 9 75 NMO75P9S NMO100P9S NMO150P9S NMO200P9S NMO300P9S NMO400P9S NMO600P9S NMO800P9S NMO1000P9S 12 5 NMO5P12S NMO10P12S NMO25P12S NMO50P12S NMO75P12S NMO100P12S NMO150P12S NMO200P12S NMO300P12S NMO400P12S NMO600P12S NMO800P12S NMO1000P12S Rosedale, Krystil Klear & Technologies all sizes Hayward sizes 1, 2, 3 & 4 Parker sizes 1 & 2 G style Filtration Systems sizes 1, 2 & 4 Filter Specialists (FSI) - will not fit sizes 1, 2, 3 & 4 - See page 22 & 23 Ring type bags will also fit housings made by other manufacturers which are not seen as frequently as the above. Contact the factory for recommendations. Filter Bags for Filter Specialists (FSI) & Hayward Housings POLYESTER & POLYPROPYLENE FELT - TRADE SIZES 1 & 2 Snap-Lok Tops POLYESTER & POLYPROPYLENE EXTENDED LIFE FELT - TRADE SIZES 1 & PE1G1POL PO1G1POL 1 5 PE5G1POL PO5G1POL 1 10 PE10G1POL PO10G1POL 1 25 PE25G1POL PO25G1POL 1 50 PE50G1POL PO50G1POL PE100G1POL PO100G1POL PE200G1POL PO200G1POL 2 1 PE1G2POL PO1G2POL 2 5 PE5G2POL PO5G2POL 2 10 PE10G2POL PO10G2POL 2 25 PE25G2POL PO25G2POL 2 50 PE50G2POL PO50G2POL PE100G2POL PO100G2POL PE200G2POL PO200G2POL Snap-Lok Tops - All Welded 1 1 PE1G1POL-WE PO1G1POL-WE 1 5 PE5G1POL-WE PO5G1POL-WE 1 10 PE10G1POL-WE PO10G1POL-WE 1 25 PE25G1POL-WE PO25G1POL-WE 1 50 PE50G1POL-WE PO50G1POL-WE PE100G1POL-WE PO100G1POL-WE PE200G1POL-WE PO200G1POL-WE 2 1 PE1G2POL-WE PO1G2POL-WE 2 5 PE5G2POL-WE PO5G2POL-WE 2 10 PE10G2POL-WE PO10G2POL-WE 2 25 PE25G2POL-WE PO25G2POL-WE 2 50 PE50G2POL-WE PO50G2POL-WE PE100G2POL-WE PO100G2POL-WE PE200G2POL-WE PO200G2POL-WE Snap-Lok Tops 1 1 PEXL1G1POL POXL1G1POL 1 5 PEXL5G1POL POXL5G1POL 1 10 PEXL10G1POL POXL10G1POL 1 25 PEXL25G1POL POXL25G1POL 1 50 PEXL50G1POL POXL50G1POL PEXL100G1POL POXL100G1POL 2 1 PEXL1G2POL POXL1G2POL 2 5 PEXL5G2POL POXL5G2POL 2 10 PEXL10G2POL POXL10G2POL 2 25 PEXL25G2POL POXL25G2POL 2 50 PEXL50G2POL POXL50G2POL PEXL100G2POL POXL100G2POL Snap-Lok Tops - All Welded 1 1 PEXL1G1POL-WE POXL1G1POL-WE 1 5 PEXL5G1POL-WE POXL5G1POL-WE 1 10 PEXL10G1POL-WE POXL10G1POL-WE 1 25 PEXL25G1POL-WE POXL25G1POL-WE 1 50 PEXL50G1POL-WE POXL50G1POL-WE PEXL100G1POL-WE POXL100G1POL-WE 2 1 PEXL1G2POL-WE POXL1G2POL-WE 2 5 PEXL5G2POL-WE POXL5G2POL-WE 2 10 PEXL10G2POL-WE POXL10G2POL-WE 2 25 PEXL25G2POL-WE POXL25G2POL-WE 2 50 PEXL50G2POL-WE POXL50G2POL-WE PEXL100G2POL-WE POXL100G2POL-WE Glazed Finish* Sewn or all-welded construcltion on sewn bags *Plain finish available for sewn bags at same price - change G in bag code to P i.e., PO25G1POL becomes PO25PIPOL Snap-Lok Tops 1 1 PE1G1PEL 1 5 PE5G1PEL 1 10 PE10G1PEL 1 25 PE25G1PEL 1 50 PE50G1PEL PE100G1PEL PE200G1PEL 2 1 PE1G2PEL 2 5 PE5G2PEL 2 10 PE10G2PEL 2 25 PE25G2PEL 2 50 PE50G2PEL PE100G2PEL PE200G2PEL Snap-Lok Tops - All Welded 1 1 PE1G1PEL-WE 1 5 PE5G1PEL-WE 1 10 PE10G1PEL-WE 1 25 PE25G1PEL-WE 1 50 PE50G1PEL-WE PE100G1PEL-WE PE200G1PEL-WE 2 1 PE1G2PEL-WE 2 5 PE5G2PEL-WE 2 10 PE10G2PEL-WE 2 25 PE25G2PEL-WE 2 50 PE50G2PEL-WE PE100G2PEL-WE PE200G2PEL-WE Snap-Lok Tops 1 1 PEXL1G1PEL 1 5 PEXL5G1PEL 1 10 PEXL10G1PEL 1 25 PEXL25G1PEL 1 50 PEXL50G1PEL PEXL100G1PEL 2 1 PEXL1G2PEL 2 5 PEXL5G2PEL 2 10 PEXL10G2PEL 2 25 PEXL25G2PEL 2 50 PEXL50G2PEL PEXL100G2PEL Snap-Lok Tops - All Welded 1 1 PEXL1G1PEL-WE 1 5 PEXL5G1PEL-WE 1 10 PEXL10G1PEL-WE 1 25 PEXL25G1PEL-WE 1 50 PEXL50G1PEL-WE PEXL100G1PEL-WE 2 1 PEXL1G2PEL-WE 2 5 PEXL5G2PEL-WE 2 10 PEXL10G2PEL-WE 2 25 PEXL25G2PEL-WE 2 50 PEXL50G2PEL-WE PEXL100G2PEL-WE Filter bags with molded Snap-Lok tops fit FSI & Hayward sizes #1 & #2 housings Molded Snap-Lok top not available for size 3 & 4 FSI or Hayward housings at this time Ring type bags will fit Hayward size 3 & 4 housinga but not 22

13 All Welded Extended Life Felt Filter Bags - Molded Super Seal Top Type POLYESTER & POLYPROPYLENE FELT - TRADE SIZES 1, 2, 3, 4, 7, 8, 9 & 12 Mesh Filter Bags - Ring Type NYLON MONOFILAMENT MESH - TRADE SIZES 1, 2, 3, 4, 7, 8, 9 & 12 Super SealTops Super SealTops 304 Stainless Steel Rings 304 Stainless Steel Rings 1 1 PEXL1G1POSS-WE POXL1G1POSS-WE 1 5 PEXL5G1POSS-WE POXL5G1POSS-WE 1 10 PEXL10G1POSS-WE POXL10G1POSS-WE 1 25 PEXL25G1POSS-WE POXL25G1POSS-WE 1 50 PEXL50G1POSS-WE POXL50G1POSS-WE PEXL100G1POSS-WE POXL100G1POSS-WE PEXL200G1POSS-WE POXL200G1POSS-WE 2 1 PEXL1G2POSS-WE POXL1G2POSS-WE 2 5 PEXL5G2POSS-WE POXL5G2POSS-WE 2 10 PEXL10G2POSS-WE POXL10G2POSS-WE 2 25 PEXL25G2POSS-WE POXL25G2POSS-WE 2 50 PEXL50G2POSS-WE POXL50G2POSS-WE PEXL100G2POSS-WE POXL100G2POSS-WE PEXL200G2POSS-WE POXL200G2POSS-WE 3 1 PEXL1G3POSS-WE POXL1G3POSS-WE 3 5 PEXL5G3POSS-WE POXL5G3POSS-WE 3 10 PEXL10G3POSS-WE POXL10G3POSS-WE 3 25 PEXL25G3POSS-WE POXL25G3POSS-WE 3 50 PEXL50G3POSS-WE POXL50G3POSS-WE PEXL100G3POSS-WE POXL100G3POSS-WE PEXL200G3POSS-WE POXL200G3POSS-WE 4 1 PEXL1G4POSS-WE POXL1G4POSS-WE 4 5 PEXL5G4POSS-WE POXL5G4POSS-WE 4 10 PEXL10G4POSS-WE POXL10G4POSS-WE 4 25 PEXL25G4POSS-WE POXL25G4POSS-WE 4 50 PEXL50G4POSS-WE POXL50G4POSS-WE PEXL100G4POSS-WE POXL100G4POSS-WE PEXL200G4POSS-WE POXL200G4POSS-WE 7 1 PEXL1G7POSS-WE POXL1G7POSS-WE 7 5 PEXL5G7POSS-WE POXL5G7POSS-WE 7 10 PEXL10G7POSS-WE POXL10G7POSS-WE 7 25 PEXL25G7POSS-WE POXL25G7POSS-WE 7 50 PEXL50G7POSS-WE POXL50G7POSS-WE PEXL100G7POSS-WE POXL100G7POSS-WE PEXL200G7POSS-WE POXL200G7POSS-WE 8 1 PEXL1G8POSS-WE POXL1G8POSS-WE 8 5 PEXL5G8POSS-WE POXL5G8POSS-WE 8 10 PEXL10G8POSS-WE POXL10G8POSS-WE 8 25 PEXL25G8POSS-WE POXL25G8POSS-WE 8 50 PEXL50G8POSS-WE POXL50G8POSS-WE PEXL100G8POSS-WE POXL100G8POSS-WE PEXL200G8POSS-WE POXL200G8POSS-WE 9 1 PEXL1G9POSS-WE POXL1G9POSS-WE 9 5 PEXL5G9POSS-WE POXL5G9POSS-WE 9 10 PEXL10G9POSS-WE POXL10G9POSS-WE 9 25 PEXL25G9POSS-WE POXL25G9POSS-WE 9 50 PEXL50G9POSS-WE POXL50G9POSS-WE PEXL100G9POSS-WE POXL100G9POSS-WE PEXL200G9POSS-WE POXL200G9POSS-WE 12 1 PEXL1G12POSS-WE POXL1G12POSS-WE 12 5 PEXL5G12POSS-WE POXL5G12POSS-WE PEXL10G12POSS-WE POXL10G12POSS-WE PEXL25G12POSS-WE POXL25G12POSS-WE PEXL50G12POSS-WE POXL50G12POSS-WE PEXL100G12POSS-WE POXL100G12POSS-WE PEXL200G12POSS-WE POXL200G12POSS-WE Glazed finish * All- welded construction Silicone-free 1 1 PEXL1G1PESS-WE 1 5 PEXL5G1PESS-WE 1 10 PEXL10G1PESS-WE 1 25 PEXL25G1PESS-WE 1 50 PEXL50G1PESS-WE PEXL100G1PESS-WE PEXL200G1PESS-WE 2 1 PEXL1G2PESS-WE 2 5 PEXL5G2PESS-WE 2 10 PEXL10G2PESS-WE 2 25 PEXL25G2PESS-WE 2 50 PEXL50G2PESS-WE PEXL100G2PESS-WE PEXL200G2PESS-WE 3 1 PEXL1G3PESS-WE 3 5 PEXL5G3PESS-WE 3 10 PEXL10G3PESS-WE 3 25 PEXL25G3PESS-WE 3 50 PEXL50G3PESS-WE PEXL100G3PESS-WE PEXL200G3PESS-WE 4 1 PEXL1G4PESS-WE 4 5 PEXL5G4PESS-WE 4 10 PEXL10G4PESS-WE 4 25 PEXL25G4PESS-WE 4 50 PEXL50G4PESS-WE PEXL100G4PESS-WE PEXL200G4PESS-WE 7 1 PEXL1G7PESS-WE 7 5 PEXL5G7PESS-WE 7 10 PEXL10G7PESS-WE 7 25 PEXL25G7PESS-WE 7 50 PEXL50G7PESS-WE PEXL100G7PESS-WE PEXL200G7PESS-WE 8 1 PEXL1G8PESS-WE 8 5 PEXL5G8PESS-WE 8 10 PEXL10G8PESS-WE 8 25 PEXL25G8PESS-WE 8 50 PEXL50G8PESS-WE PEXL100G8PESS-WE PEXL200G8PESS-WE 9 1 PEXL1G9PESS-WE 9 5 PEXL5G9PESS-WE 9 10 PEXL10G9PESS-WE 9 25 PEXL25G9PESS-WE 9 50 PEXL50G9PESS-WE PEXL100G9PESS-WE PEXL200G9PESS-WE 12 1 PEXL1G12PESS-WE 12 5 PEXL5G12PESS-WE PEXL10G12PESS-WE PEXL25G12PESS-WE PEXL50G12PESS-WE PEXL100G12PESS-WE PEXL200G12PESS-WE Rosedale, Krystil Klear & Technologies all sizes 1 5 NMO5P1S-SS 1 10 NMO10P1S-SS 1 25 NMO25P1S-SS 1 50 NMO50P1S-SS 1 75 NMO75P1S-SS NMO100P1S-SS NMO150P1S-SS NMO200P1S-SS NMO300P1S-SS NMO400P1S-SS NMO600P1S-SS NMO800P1S-SS NMO1000P1S-SS 2 5 NMO5P2S-SS 2 10 NMO10P2S-SS 2 25 NMO25P2S-SS 2 50 NMO50P2S-SS 2 75 NMO75P2S-SS NMO100P2S-SS NMO150P2S-SS NMO200P2S-SS NMO300P2S-SS NMO400P2S-SS NMO600P2S-SS NMO800P2S-SS NMO1000P2S-SS 3 5 NMO5P3S-SS 3 10 NMO10P3S-SS 3 25 NMO25P3S-SS 3 50 NMO50P3S-SS 3 75 NMO75P3S-SS NMO100P3S-SS NMO150P3S-SS NMO200P3S-SS NMO300P3S-SS NMO400P3S-SS NMO600P3S-SS NMO800P3S-SS NMO1000P3S-SS 4 5 NMO5P4S-SS 4 10 NMO10P4S-SS 4 25 NMO25P4S-SS 4 50 NMO50P4S-SS 4 75 NMO75P4S-SS NMO100P4S-SS NMO150P4S-SS NMO200P4S-SS NMO300P4S-SS NMO400P4S-SS NMO600P4S-SS NMO800P4S-SS NMO1000P4S-SS Plain finish 7 5 NMO5P7S-SS 7 10 NMO10P7S-SS 7 25 NMO25P7S-SS 7 50 NMO50P7S-SS 7 75 NMO75P7S-SS NMO100P7S-SS NMO150P7S-SS NMO200P7S-SS NMO300P7S-SS NMO400P7S-SS NMO600P7S-SS NMO800P7S-SS NMO1000P7S-SS 8 5 NMO5P8S-SS 8 10 NMO10P8S-SS 8 25 NMO25P8S-SS 8 50 NMO50P8S-SS 8 75 NMO75P8S-SS NMO100P8S-SS NMO150P8S-SS NMO200P8S-SS NMO300P8S-SS NMO400P8S-SS NMO600P8S-SS NMO800P8S-SS NMO1000P8S-SS 9 5 NMO5P9S-SS 9 10 NMO10P9S-SS 9 25 NMO25P9S-SS 9 50 NMO50P9S-SS 9 75 NMO75P9S-SS NMO100P9S-SS NMO150P9S-SS NMO200P9S-SS NMO300P9S-SS NMO400P9S-SS NMO600P9S-SS NMO800P9S-SS NMO1000P9S-SS 12 5 NMO5P12S-SS NMO10P12S-SS NMO25P12S-SS NMO50P12S-SS NMO75P12S-SS NMO100P12S-SS NMO150P12S-SS NMO200P12S-SS NMO300P12S-SS NMO400P12S-SS NMO600P12S-SS NMO800P12S-SS NMO1000P12S-SS Rosedale, Krystil Klear & Technologies all sizes Hayward sizes 1, 2, 3 & 4 Parker sizes 1 & 2 G style Filtration Systems sizes 1, 2 & 4 Filter Specialists (FSI) - will not fit sizes 1, 2, 3 & 4 - See page 22 & 23 Ring type bags will also fit housings made by other manufacturers which are not seen as frequently as the above. Contact the factory for recommendations