Spare parts catalogue U.S.A. DUCATI

Size: px
Start display at page:

Download "Spare parts catalogue U.S.A. DUCATI"

Transcription

1 Spare parts catalogue U.S.A. DUCATI

2

3 GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the part's code number followed by its description; quantity needed; 2) the motorcycle's serial number, stamped on the steering head. Reference to right and left apply to the vehicle in terms of its direction of move-ment. Spare parts drawings are general and do not represent the part. The contents of this catalogue are general and can undergo changes without prior notice. VALIDITY f.m. d.m. f.m.m. d.m.m. LIST CAL CDN Until V.I.N. From V.I.N. Up to engine number From engine number California Canada Ducati Motor Holding S.p.A. Commercial and Administation Office: Via A. Cavalieri Ducati n Bologna, Italy Telefono 05 3 Fax Internet

4 Paints Paint Code "Rosso Anniversary DUCATI" "Nero Lucido DUCATI" "Bianco Perla" "Smalto" "Trasparente" (PPG) 73.0 (PPG) 2.5 (PPG) (PPG) *000 (PPG)

5 page Contents a 00b 00c a a 00 0 Workshop service tools Workshop service tools Dds tester Workshop service tools Gearchange control Gearbox Clutch Clutch-side crankcase cover Connecting rods Cylinders - pistons Timing system Filters and oil pump Crankcase halves Alternator-side crankcase cover Electric starting and ignition Cylinder head : timing system Vertical cylinder head Horizontal cylinder head Intake manifolds Exhaust system Stands Electrical system Battery support Headlight & instr. panel Number plate holder - tail light Front forks Front and rear wheels Rear wheel axle Handlebar and controls Clutch control Front brake Rear brake Frame R.h. footrests L.h. footrests Swingarm Rear suspension Air intake - oil breather Oil cooler Fuel tank Fuel system Seat Headlight fairing Fairing Evaporative emissions canister Data plate positions 3

6 DRAWING 00 Workshop service tools

7 DRAWING 00 Workshop service tools NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY Wrench for holding timing belt rollers ring nuts Head nuts holder wrench Head mounting base Degree wheel Degree wheel holder tool for ignition advance check Wrench to tighten oil filter cartridge Wrench for tightening primary transmission ring nut Tool for assembling closing rocker and spring Tool to drive valve seal ring ø Wrench for camshaft pulley ring nut adjustment Crankshaft gear holder wrench for tightening nut Belt roller timing of two-valva head Valve lift gauge Extractor for primary drive gear Spacer and fork feeler gauge 0,2/0,3 mm Reaction tool for wet "FCC" clutch Tool to hold crankshaft in TDC position Spacer for checking lower valve shim Flywheel Wrench Crankcases assembling cap Plate for positioning gear engagement fork Drive roller puller T.D.C. control gauge Torque wrench 5

8 DRAWING 00a Workshop service tools

9 DRAWING 00a Workshop service tools NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY Stopper for driving the half bearing of the steering head base Stopper for assembling the rear fork roller bearings Bush for installing/removing the fork plug Wrench for adjusting the eccentric hub Tool for balancing rear wheel Tool for assembling the swingarm ball bearings Wrench for assembling the steering head cap Wrench for front wheel spindle Tool for assembling the steering head bearings Stopper for assembling the rocker needle bearings Bushing support bar Tool for installing the sliding bushings Tool for assembling chain Union for exhaust gas suction Tool for removing the sliding bushings Bar guide tool Frame/engine mount Bench for engine repair 7

10 DRAWING 00b Dds tester

11 DRAWING 00b Dds tester NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY DDS (Ducati Diagnosis System) + manifold vacuum meter. kit Belt tensioning kit Sensor Bracket Battery Feeder DDS manual (USB) Memory card reader Main cable Fuse Software DDS CD (USB) Cable extension Black case with sponge rubber Amperometer plier Battery charger 9

12 DRAWING 00c Workshop service tools

13 DRAWING 00c Workshop service tools NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Fuel pressure line HS A Fuel pressure line ST/SS/M A Oil pressure line A Fitting - cylinder compression M A Fitting - cylinder compression M A Cable Volt PF DUC Main cable (MARELLI)...A Oil pressure fitting A Cable for supplementary tests A Red clamp cable A Black clamp cable A Temperature probe Battery connection adapter A Electric lighter connection adapter (ST) A Battery connection adapter A Red case with sponge rubber 75.2T DUCATI sticker RH/LH side (USB) Adaptor Depressure sensor A Pressure sensor Feeder Depressure/pressure line Union Pressure kit C Cable for potentiometer adjustement

14 DRAWING 002 Gearchange control

15 DRAWING 002 Gearchange control NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Return spring A Washer A Special screw A Gear stopper assembly A Gasket th A Switch A Special screw Gasket Gear selector spring Ball A st,th-2nd,3rd gear selector fork A 5th,th gear selector fork Fork pin A Shim th Circlip A Needle retaining ring (square cross-section) A Pin A Complete gearbox drum Shim th A Shim th A Fork return spring Shim th Shim th A Ring A Nut A Gearbox drum control fork Gearchange lever pin A Pin with gearchange lever Gearchange lever return spring Z Screw A Special screw Z Screw A Gasket A Centering ring A Stopper plate Shim th Shim th A Ball A Spring A Spacer 3

16 DRAWING 003 Gearbox

17 DRAWING 003 Gearbox NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY Shim th A Gearbox main shaft Shim th A Needle bearing A Driving gear 5th sp A Grooved washer th Snap ring A Driving gear 3rd/th sp A Driving gear th sp B Driving gear 2nd sp E Shim th A Chain sprocket A Lock washer A O-ring A Spacer th. 3, A Grooved washer th Needle bearing B Driven gear st sp Shim th A Driven gear 5th sp A Driven gear th sp A Driven gear 3rd sp A Driven gear th sp B Driven gear 2nd sp A Gearbox lay shaft Shim th A Complete main shaft A Gearbox lay shaft A Nut A Spacer 5

18 DRAWING 00 Clutch

19 DRAWING 00 Clutch NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Clutch spring A Retainer C Screw A Pressure plate "FCC" A Clutch control pin B Screw A Hexagon nut A Spring washer A Clutch plates set A Spring washer "FCC" A Spring A Plate holder hub "FCC" A Spacer A Clutch housing A Spacer A Clutch control rod O-ring A O-ring A Piston assembly 7

20 DRAWING 005 Clutch-side crankcase cover

21 DRAWING 005 Clutch-side crankcase cover NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY AF Clutch protection cover B Screw B Screw A Oil level sight glass B Screw A Panel (BLACK) B Screw Bush A Seal ring A Shim th A Circlip A O-ring A Locating bush..05.a Holder A Complete cap A Washer A Cover A Engine oil pressure sensor A Screw A Gasket th A Gasket th A Cap A Spacer 9

22 DRAWING 00 Connecting rods

23 DRAWING 00 Connecting rods NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY.2.09.A Crankshaft A Special screw A Nut A Special screw A Connecting rods pair A Bush Pin AB Half-bearing (BLUE) AC Half-bearing (YELLOW) A Special screw A Woodruff key K Shim th. 2, H Shim th L Shim th. 2, M Shim th N Shim th A Shim th B Shim th C Shim th D Shim th. 2, E Shim th. 2, F Shim th. 2, G Shim th I Shim th J Shim th A Lock washer A Ring nut A Spring washer A Primary drive front sprocket 2

24 DRAWING 007 Cylinders - pistons

25 DRAWING 007 Cylinders - pistons NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Piston rings set 2..0.A Piston pin circlip A Piston pin AB Vertical cylinder-piston fit A Head-cylinder gaskets set 7..0.A Cylinder-crankcase gasket th A Bush AB Horizontal cylinder-piston fit A Complete piston A Head-cylinder gasket A Bush A Vibration damper pad 23

26 DRAWING 00 Timing system

27 DRAWING 00 Timing system NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Vertical timing belt cover (CARBON) A Screw A Screw A Horizontal timing belt cover (CARBON) A Woodruff key A Fixed tensioner assembly A Complete vertical cylinder tensioner roller A Screw A Lay shaft A Timing gears pair A Lock washer Hexagon nut A Spacer A Snap ring A Timing belt roller Z= A Belt roller separating washer A Spacer A Elastic-stop ring nut A Timing drive toothed belt 2 25

28 DRAWING 009 Filters and oil pump

29 DRAWING 009 Filters and oil pump NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Complete oil pump A Cap A Aluminium gasket..037.a O-Ring A Bypass valve A Bypass cap A Bypass spring B Screw A Washer B Screw A Washer A Pump drive gear A Bush A Bypass spring Locating bush A Gasket A Oil drain plug with magnet A Gasket th., A Oil filter A Oil filter cartridge A Nipple A O-ring A Cap A Snap ring A Circlip Reduction bush A Cap A Gasket th.2 27

30 DRAWING 00 Crankcase halves

31 DRAWING 00 Crankcase halves NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Complete half-crankcases pair A Special screw A Bush B Screw Fluid sealant B Stud bolt for fastening head cylinder A Special washer A Nut A Bearing Screw A Keep plate A Bearing A Seal ring A Spacer B Screw A Seal ring Bearing Circlip A Aluminium gasket th A Bearing A Bearing holder bush A Seal ring A Locating dowel B Screw A Bearing holder bush A Bearing B Screw A O-ring A Aluminium gasket th., A Special screw A Nipple A Bush B Breather valve O-ring Bearing A Bearing 29

32 DRAWING 0 Alternator-side crankcase cover

33 DRAWING 0 Alternator-side crankcase cover NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Generator Circlip A Bearing A Chain cover (BLACK) B Screw B Screw A Aluminium gasket..095.a O-ring AD Cover C Screw Seal ring A Sensor B Screw A Screw Fluid sealant B Screw B Screw A Locating bush AD Generator cover A Bracket B Screw A Gasket th.0, AA Gasket th.0, AB Gasket th., A O-ring B Screw A Washer A Holder A Spring washer A Cap A Spacer 3

34 DRAWING 02 Electric starting and ignition

35 DRAWING 02 Electric starting and ignition NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Complete starter motor A Spring washer A Nut A Starter motor gasket A Screw A Starter motor sprocket A Circlip A Intermediate gear pin A Washer A Intermediate gear assembly Circlip B Screw A Flange A Locating pin A Check ring C Ignition flywheel A Shim..03.A Inner ring A Needle bearing A Electric starter driven gear A Starter clutch B Screw A Screw A Flexible bush 33

36 DRAWING 03 Cylinder head : timing system

37 DRAWING 03 Cylinder head : timing system NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Elastic-stop ring nut A Washer A Timing belt roller A Screw A Vertical belt inner cover A Horizontal belt inner cover A Seal ring A Woodruff key A Vertical head camshaft B Screw A O-ring BD Side cap A Aluminium gasket A Screw A Screw A Horizontal head camshaft A Stud bolt 7..0.A Stud bolt A Flange A Special washer A Screw 35

38 DRAWING 0 Vertical cylinder head

39 DRAWING 0 Vertical cylinder head NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY CA Complete vertical head B Intake valve seat BB Oversize intake valve seat BC Oversize intake valve seat B Exhaust valve seat BB Oversize exhaust valve seat BC Oversize exhaust valve seat C Intake valve guide CA Intake valve guide magg. 0, CB Intake valve guide magg. 0, CC Intake valve guide magg. 0, AA Exhaust valve guide magg. 0, AB Exhaust valve guide magg. 0, AC Exhaust valve guide magg. 0, A Valve seal A Closing rocker spring Shim th Shim th Shim th Shim th A O-ring BB Valve cover B Screw Shim A Spring A Opening rocker A Rocker shaft A Closing rocker See table E Split rings 9... See table A O-ring A Exhaust valve A Intake valve A Gasket A Screw A Vibration damper pad A Closing rocker spring A Washer A Hose guide B Screw A Spacer 2 37

40 DRAWING 05 Horizontal cylinder head

41 DRAWING 05 Horizontal cylinder head NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY CA Complete horizontal head AA Exhaust valve guide magg. 0, AB Exhaust valve guide magg. 0, AC Exhaust valve guide magg. 0, C Intake valve guide CA Intake valve guide magg. 0, CB Intake valve guide magg. 0, CC Intake valve guide magg. 0, B Intake valve seat BB Oversize intake valve seat BC Oversize intake valve seat B Exhaust valve seat BB Oversize exhaust valve seat BC Oversize exhaust valve seat A Intake valve A Exhaust valve Shim th Shim th Shim th Shim th A Closing rocker spring A Rocker shaft..3.a O-ring BB Valve cover B Screw A Opening rocker E Split rings A Spring See table A Closing rocker See table Shim A Valve seal A Gasket A Vibration damper pad BB Intake valve cover A Rubber cap Snap ring A Spacer A O-Ring A Aluminium gasket A Ring nut A Holder sensor A Sensor A Screw 3..0.A O-ring A Closing rocker spring 39

42 DRAWING 0 Intake manifolds

43 DRAWING 0 Intake manifolds NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Feed unit assembly A Nut A Clamp A Hose A Potentiometer B Screw B Intake duct B Clamp A Stepper motor A Injector A Hose guide 2

44 DRAWING 07 Exhaust system

45 DRAWING 07 Exhaust system NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Horizontal head exhaust pipe A Vertical head exhaust pipe A Nut Exhaust gasket A Gasket th A Cap A Thermal protection B Screw A Washer B Compensator B Balancer/silencer exhaust pipe A Gasket C Exhaust silencer 7..0.A Rubber pad A Vibration damper pad A Washer A Special screw 0...2A Thermal protection A Spring A Lambda sensor A Nut A Spacer A Vibration damper pad A Bracket B Screw B Screw A Clamp A Gasket A Spring clamp 3

46 DRAWING 0 Stands

47 DRAWING 0 Stands NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY C Plate B Screw A Side stand (BLACK) A Screw A Switch B Inner spring B Outer spring B Plate D Pivot C Nut Hose guide 5

48 DRAWING 09 Electrical system

49 DRAWING 09 Electrical system NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Spark plug A Electric wiring A Rubber holder B Screw A Hose guide A Hose guide Hose guide A Hose guide C Coil A Spacer B Screw B Screw A Spark plug cable (R.H.) A Spark plug cable (L.H.) A Spark plug cable (R.H.) A Spark plug cable (L.H.) B Horn (BLACK) A Screw A Holder sensor A Air temperature sensor A Relay B Bracket B Bracket A Fuse 3A A Fuse 20A A Fuse 5A A Fuse 0A A Fuse 5A B Spring washer C Screw A Clamp Hose guide A Fuse 30A A Resistor 7

50 DRAWING 020 Battery support

51 DRAWING 020 Battery support NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Battery box mount A Battery carpet C Battery A Plate B Screw A Remote switch A Rubber cap A Plate A Rubber pad A Spacer B Screw C Injection control unit B Screw A Solenoid starter - starter motor cable C Voltage rectifier A Nut A Spring washer B Screw A Screw A Battery - solenoid starter cable 9

52 DRAWING 02 Headlight & instr. panel

53 DRAWING 02 Headlight & instr. panel NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY C Complete headlight A Rubber pad B Spacer B Screw A Headlight and headlight fairing support B Screw B Screw C Complete instrument panel A Hose guide A Nut A Mobile healdight fairing support A Bulb A Bulb 2..0.A Spring washer A Bulb 2V-55W H 5

54 DRAWING 022 Number plate holder - tail light

55 DRAWING 022 Number plate holder - tail light NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY B Tail light B Headlight holder B Screw B Screw B Washer A Spacer A Rubber pad 52...B Washer A Plate B Screw A Plate A Reflector C Washer B Nut B Spacer A Thermal protection A Nut with clip A Rear wiring A Nut A Washer A RH rear indicator body A LH rear indicator body A Taillight glass A Washer A Two-light bulb 2V 5/2W Bulb A O-ring A Holder A Reflector A Bulb 2V-5W C5W A Washer 53

56 DRAWING 023 Front forks

57 DRAWING 023 Front forks NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A L.H. fork leg assembly (OHLINS) A R.H. fork leg assembly (OHLINS) B Screw A Overhaul kit A Seat kit A Cat's eye (AMBER) 2 55

58 DRAWING 02 Front and rear wheels

59 DRAWING 02 Front and rear wheels NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY 7..0.C Nut A Spacer (L.H.) A Valve A Screw A Brake disc A Seal ring AB Wheel rim (rear) (BLACK) A Bearing A Spacer (internal) AB Wheel rim (front) (BLACK) A Front wheel spindle A Clip B Nut A Washer A Special washer A Bush A Spacer (R.H.) A Spring washer 2 57

60 DRAWING 025 Rear wheel axle

61 DRAWING 025 Rear wheel axle NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Clip C Nut A Washer AB Nut C Rear sprocket flange A Washer A Bush A Bush A Rubber cush drive hub B Ring gear assembly Z= D Pin A Spacer A Wheel spindle A Screw A Washer A O-Ring A Caliper holder plate.5.00.a Circlip B Screw A Rear brake disc B Bracket A Mudflap A Nut B Screw B Final drive kit A Chain 59

62 DRAWING 02 Handlebar and controls

63 DRAWING 02 Handlebar and controls NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Nut B Special screw A Steering head base A Washer B Seal ring A Bearing B Screw A Cables unit A Screw B Screw A Mudflap A Ring nut A Bush A L.H. switch B Antenna A Handlebar B Screw C Key-operated switch B Single U-bolt A Throttle control B Counterweight B Screw C Steering head A Bracket B R.H. switch A Bush B Screw A Cover A Vibration damper pad E Locks kit A Spacer AB Nut B Washer A Washer A Spring pin A Wrench with Transponder A Wrench without Transponder

64 DRAWING 027 Clutch control

65 DRAWING 027 Clutch control NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Clutch drive pump A Clutch control lever A Spare lever pin C Spare bracket A Microswitch AB Special screw A Dust seal Bleed A Special screw A Clutch control pipe (METAL PLAITED) A Gasket th A Complete oil tank A Cap 3

66 DRAWING 02 Front brake

67 DRAWING 02 Front brake NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Front brake pump B Screw B Bracket A Complete oil tank A Spare lever pin A Brake control lever A Tank cap A Microswitch A Plate A Gasket th AB Special screw B Screw C Fairlead A Spring A Spare pins and spring A Plate A Dust seal A Spare bleed union A Pads pair B Screw A L.H. brake caliper A R.H. brake caliper A Front brake line A Washer A Special screw 5

68 DRAWING 029 Rear brake A A 2 25

69 DRAWING 029 Rear brake NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Rear brake pump A Hose guide A Tube A Complete oil tank A Cap A Gasket th AB Special screw A Adjuster rod A Nut A Fork A Quik fastening B Screw A Rear brake line (METAL PLAITED)..03.AB Rear brake caliper B Screw A Pads pair A Spare pins and spring 3..0.A Bleed A Dust seal A Screw A Speed sensor B Screw A Bush A Brake lever A Rubber pad B Screw B Adjusting screw B Nut B Brake master cylinder lever A Return spring A Washer B Switch A Washer A Spacer A Hose guide A O-ring 2 7

70 DRAWING 030 Frame

71 DRAWING 030 Frame NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY CF Frame (RED) CB Frame (BLACK) CK Frame (GREY) A Special screw A Nut A Cap AA Pillion rider grip (RED) AT Pillion rider grip (BLACK) AW Pillion rider grip (WHITE) A Screw A Nut A Washer A Cap B Fairing / headlight / radiator supporting subframe A Screw B Screw AB Nut..0.A Rubber pad A Stud bolt 9

72 DRAWING 03 R.h. footrests

73 DRAWING 03 R.h. footrests NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY..037.A Rear foot peg (R.H.) A Ring B Plate B Pin A Rear heel guard B Screw A Rear foot peg holder plate (R.H.) A Screw A Front foot peg (R.H.) A Special screw A Foot peg holder plate (R.H.) A Rubber pad A Vibration damper B Spring A Ball A Washer B Spring A Screw B Washer 2 7

74 DRAWING 03a L.h. footrests

75 DRAWING 03a L.h. footrests NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY B Washer A Vibration damper A Rubber pad A Foot peg holder plate (L.H.) A Special screw a Ring A Washer A Bush B Spring B Screw A Pin A Gearchange lever A Rubber pad A Screw AB Special screw..023.a Gearbox transmission rod A Nut A Chain cover B Screw A Gearchange control lever B Screw B Screw A Front foot peg (L.H.) A Screw A Rear foot peg holder plate (L.H.) B Screw A Rear heel guard B Pin A Ball B Plate B Spring A Rear foot peg (L.H.) 33...A O-ring 2 73

76 DRAWING 032 Swingarm

77 DRAWING 032 Swingarm NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY B Swingarm A Bearing A Spacer A Seal ring A Bush A Needle bearing A Spacer A Spacer (L.H.) A Swingarm pivot A Special nut C Pin B Screw A Cap 7..0.A Upper chain sliding shoer B Screw A Lower chain sliding shoe A Upper chain guard A Lower chain guard A Cap A Chain adjustment sticker A Screw A Heat guard A Plate 75

78 DRAWING 033 Rear suspension

79 DRAWING 033 Rear suspension NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Shock absorber A Tie rod B Nut A Bush B L.H. nut..027.a Ball joint A Ball joint A Rocker assembly A Seal ring A Needle bearing A Spacer A Screw A Spacer AB Nut A Screw A Special nut A L.H. cap A R.H. cap B Screw B Screw A Nut C Screw B Screw A Bracket A Washer 2 77

80 DRAWING 03 Air intake - oil breather

81 DRAWING 03 Air intake - oil breather NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Lower filter box A Filter case cover A Air filter B Hook Spring pin A Stud bolt A Rubber pad B Spacer B Screw A Oil reservoir-airbox hose 7..0.A Oil reservoir-engine pipe A Clamp A Pressure pick-up point A Tube 79

82 DRAWING 035 Oil cooler

83 DRAWING 035 Oil cooler NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Oil cooler A Vibration damper pad A Spacer B Screw A Oil return pipe A Oil delivery pipe A Nipple A Aluminium gasket th A Spacer A Gasket th A Thermistor A Fairlead Hose guide B Screw A Washer 2

84 DRAWING 03 Fuel tank

85 DRAWING 03 Fuel tank NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY 5..0.AA Tank (RED) 5..0.AT Tank (BLACK) 5...BW Tank (WHITE) A Sticker "DUCATI" (for RED, BLACK) AT Sticker "DUCATI" (for WHITE) A RH front rubber element A LH front rubber element A Washer B Special screw A L.H. bracket A R.H. bracket B Pin A Pin A Screw B Screw A Pad B Washer A Tank cap A Screw A O-ring 3

86 DRAWING 037 Fuel system

87 DRAWING 037 Fuel system NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A Complete flange A Filter A Thermistor 52...A Washer A Flange fuel level sensor A collar A O-ring A Screw B Screw C Cover A Fuel level sensor A Union A Gasket B Screw B Nut A Reservoir breather valve A Gasket A Plate B Screw B Tube A Hose guide A Fluid recovery reservoir A Screw A Tube A Hose guide A Union A O-ring A O-ring A Special screw A Quick-coupling union 2 5

88 DRAWING 03 Seat

89 DRAWING 03 Seat NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY A R.H. plate A L.H. plate B Screw D Rider seat D Pillion rider seat A Spring A Retainer..025.A Circlip A Washer B Screw..0.A Rubber pad A Cover B Screw BA R.H. body panel (RED) BT R.H. body panel (BLACK) BW R.H. body panel (WHITE) A R.H. body panel (unpainted) BA Sticker "MULTISTRADA" (for RED, BLACK) BT Sticker "MULTISTRADA" (for WHITE) A Mudflap A Washer B Screw A L.H. pad A R.H. pad A Cover A Screw A Rubber pad A Screw A Washer BA L.H. body panel (RED) BT L.H. body panel (BLACK) BW L.H. body panel (WHITE) A L.H. body panel (unpainted) A Helmet anti-theft wire A Seat lock A Screw A Screw A L.H. cap A R.H. cap A Sticker A Vibration damper pad 7

90 DRAWING 039 Headlight fairing

91 DRAWING 039 Headlight fairing NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY..02.AA Mobile headlight fairing (RED)..02.AT Mobile headlight fairing (BLACK)..02.BW Mobile headlight fairing (WHITE).3.02.A Mobile headlight fairing (unpainted) B Screw AA Fixed headlight fairing (RED) AT Fixed headlight fairing (BLACK) BW Fixed headlight fairing (WHITE) A Fixed headlight fairing (unpainted)..07.a Stud bolt A Insert 0..5.A Headlight fairing cover A Screw A Windshield AB Special screw A Nylon washer A Nut A Gasket B Screw C RH mirror - turn indicator A Bulb A Cup C LH mirror - turn indicator A Cup A Wiring (R.H.) A Wiring (L.H.) 9

92 DRAWING 039a Fairing

93 DRAWING 039a Fairing NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY BA Upper half-fairing (L.H.) (RED) BT Upper half-fairing (L.H.) (BLACK) BW Upper half-fairing (L.H.) (WHITE) A Upper half-fairing (L.H.) (unpainted) A Front mudguard (CARBON) A Vibration damper pad..03.a Rubber pad AA Lower half-fairing (L.H.) (RED) AT Lower half-fairing (L.H.) (BLACK) AW Lower half-fairing (L.H.) (WHITE) A Lower half-fairing (L.H.) (unpainted) 0..2.BA Upper half-fairing (R.H.) (RED) 0..2.BT Upper half-fairing (R.H.) (BLACK) 0..2.BW Upper half-fairing (R.H.) (WHITE) A Upper half-fairing (R.H.) (unpainted) A Spring A Quik fastening AA Lower half-fairing (R.H.) (RED) AT Lower half-fairing (R.H.) (BLACK) AW Lower half-fairing (R.H.) (WHITE) A Lower half-fairing (R.H.) (unpainted) A Special screw AA Air manifold (RED)..07.AT Air manifold (BLACK)..07.BW Air manifold (WHITE).3.07.A Air manifold (unpainted) B Screw A Clamp A Plate A Cable limiting top case opening A Nut C Screw A Pin A Spring washer A Rubber pad A Spring washer B Nut B Washer B Screw A Screw A Lock latch A Gasket A Panniers lock A Tool bag B Screw A Pin A Spring F Owner's manual AA Sticker "MULTISTRADA 00S" (for RED) AB Sticker "MULTISTRADA 00S" (for BLACK) AT Sticker "MULTISTRADA 00S" (for WHITE) A Hose guide

94 DRAWING 00 Evaporative emissions canister

95 DRAWING 00 Evaporative emissions canister NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY..79.A Union A Gasket B Canister filter..3.a Shunt valve A Union/filter pipe A Filter/fuel tank outlet pipe A Tube A Tube A Fuel pipe A Hose guide A Clamp A Hose guide Aluminium gasket A Bracket A Plate A Rubber pad B Spacer A Screw A Nut A Holder A Hose guide A Union A Tube 7x3x335 93

96 DRAWING 0 Data plate positions 3 2 9

97 DRAWING 0 Data plate positions NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY NOTES NO. CODE NO. DESCRIPTION VALIDITY Q.TY 33...A Sticker A Plate A Sticker A Sticker 95

98 Index CODE No. Drwg. POS. N. CODE No. Drwg. POS. N. CODE No. Drwg. POS. N. CODE No. Drwg. POS. N. CODE No. Drwg. POS. N A A AF A A A A A A B A A A A A C A A A A A A A A A A C A A A A A A A A A AB B A A 03a AC A A AD A A A A A A A A AB B A A AB B A A A A A A A A A C A A A A B A BD A A A BB A A A BB A A A BB C A A AD B A A A CA 0 A

99 Index CODE No. Drwg. POS. N. CODE No. Drwg. POS. N. CODE No. Drwg. POS. N. CODE No. Drwg. POS. N. CODE No. Drwg. POS. N CA C C A AW 039a C A A B BA 039a C A C A BT 039a CA A B A 03a BW 039a CA A A A 03a BA 039a CB A B A BT 039a CB A A A BW 039a CC A A A A 039a CC B A A A 039a AA A A A A 039a AA A A A A 039a AB B A A AA AB A A A AT AC C AT A BW AC A BA A AA B A BT A 03a AT B A AA 039a A BW BB A AB 039a A 03a A BB A AT 039a CB A BC A A CF BA BC A A CK BT B A A B BW B A A AA 039a BA BB A A AT 039a BT BB A A AW 039a BW BC A A AA 039a A BC A A AT 039a A 03 2 B

100 Index CODE No. Drwg. POS. N. CODE No. Drwg. POS. N. CODE No. Drwg. POS. N. CODE No. Drwg. POS. N. CODE No. Drwg. POS. N...07.AA 039a C A A 00c 2..0.A AT 039a C A A 00c A BW 039a B A A A A 039a A A B A A A A A A A A A A A A A D A A A A A A A B A C A A A A A B C AB A A A A AB A A 039a A A A A A D B A B B D A A A A A 039a A A A A E A A 00c A B A 039a A A 00c C C A A A 00c A A A A A 00c A A A B A 00c A A A A A 00c A A A C A A 00c 5..0.AA AB A A A 00c AT A A B A 00c BW A E B A 00c A A E C A A A A 09 C

101 Index CODE No. Drwg. POS. N. CODE No. Drwg. POS. N. CODE No. Drwg. POS. N. CODE No. Drwg. POS. N. CODE No. Drwg. POS. N A A A A A A A A A A A A A A A A A A A A A A A A A A A A B A B A A B A A A A B A A A A A A A A A 03a A A A A E A A A A A B A A A A A A A A A A A A 039a A A A 00c A A A 039a A A A A B A A A A A A A B A A A A A A A A A 03a A A C A A A A A A A A A A A A A A A A A A A A A A A A A 039a D

102 Index CODE No. Drwg. POS. N. CODE No. Drwg. POS. N. CODE No. Drwg. POS. N. CODE No. Drwg. POS. N. CODE No. Drwg. POS. N A A B B A A B B A A Z B 03a A A B B B 03a A A A B B AB A A B B 03a AB B B B A A B B B AB A 03a A B B A A A B B A A A B B A 03a A A B B AB A A 03a C B B A A B B B 039a A A B B C A B B B B A A B A A A 03a A B B A A A B C C A A B A B A 039a B Z A A A 039a B B A A A B B A A A B B A A A 039a B B A A A B B C A A B B B E

103 Index CODE No. Drwg. POS. N. CODE No. Drwg. POS. N. CODE No. Drwg. POS. N. CODE No. Drwg. POS. N. CODE No. Drwg. POS. N B A A A A B AB A A A B 03a B A B A B A AB 03a A A B A A B B B A 039a B A B B A A A B B B A A B 03a B A A A A B A A A A B B 03a A 03a A A 039a B B A A A B 039a B A A A B A A A A B 039a A A 039a A A B A B A A B C A AA B B B 039a AB AB B 03a B C 039a AB A A B A AB A A B A A A A B A A A 039a A B B A A A 039a B A A A A B A A 03a A B A A A A A A A a F

Spare parts catalogue 1100 S U.S.A. DUCATIMULTISTRADA

Spare parts catalogue 1100 S U.S.A. DUCATIMULTISTRADA Spare parts catalogue 00 S U.S.A. DUCATIMULTISTRADA GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the part's code number followed by its description;

More information

Spare parts catalogue 695 U.S.A. DUCATIMONSTER

Spare parts catalogue 695 U.S.A. DUCATIMONSTER Spare parts catalogue 95 U.S.A. DUCATIMONSTER GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the part's code number followed by its description;

More information

model year 2010 U.S.A. Spare parts catalogue part number: D

model year 2010 U.S.A. Spare parts catalogue part number: D Revision n 00 Spare parts catalogue model year 200 U.S.A. Spare parts catalogue part number: GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the

More information

Spare parts catalogue 620 U.S.A. DUCATI MULTISTRADA

Spare parts catalogue 620 U.S.A. DUCATI MULTISTRADA Spare parts catalogue 620 U.S.A. DUCATI MULTISTRADA GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the part's code number followed by its description;

More information

Spare parts catalogue SPORT 1000 U.S.A. SPORTCLASSIC

Spare parts catalogue SPORT 1000 U.S.A. SPORTCLASSIC Spare parts catalogue SPORT 000 U.S.A. SPORTCLASSIC GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the part's code number followed by its description;

More information

Spare parts catalogue SPORT 1000 SPORTCLASSIC

Spare parts catalogue SPORT 1000 SPORTCLASSIC Spare parts catalogue SPORT 000 SPORTCLASSIC SPORT 000 M.Y. '07 Spare Parts Department P.N. 95252C Ottobre - October '06 Edizione - Edition 00 SPORT 000 M.Y. '07 Spare Parts Department P.N. 95252C Ottobre

More information

Spare parts catalogue S2R1000 U.S.A. DUCATIMONSTER

Spare parts catalogue S2R1000 U.S.A. DUCATIMONSTER Spare parts catalogue S2R000 U.S.A. MONSTER GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the part's code number followed by its description;

More information

Spare parts catalogue 999 U.S.A. DUCATI SUPERBIKE

Spare parts catalogue 999 U.S.A. DUCATI SUPERBIKE Spare parts catalogue 999 U.S.A. DUCATI SUPERBIKE GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the part's code number followed by its description;

More information

Spare parts catalogue 400

Spare parts catalogue 400 Spare parts catalogue 00 DUCATIMONSTER MOTOR HOLDING MONSTER 00 M.Y. '0 Spare Parts Department P. 95022F Ottobre - October '0 Edizione - Edition 0 DUCATIMOTOR HOLDING MONSTER 00 M.Y. '0 Spare Parts Department

More information

Spare parts catalogue 999R XEROX U.S.A DUCATI SUPERBIKE

Spare parts catalogue 999R XEROX U.S.A DUCATI SUPERBIKE Spare parts catalogue 999R XEROX U.S.A DUCATI SUPERBIKE GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the part's code number followed by its

More information

Spare parts catalogue 400 DUCATIMONSTER

Spare parts catalogue 400 DUCATIMONSTER Spare parts catalogue 00 DUCATIMONSTER MOTOR HOLDING MONSTER 00 M.Y. '07 Spare Parts Department P.N. 9502G Maggio - May '0 Edizione - Edition 00 DUCATIMOTOR HOLDING MONSTER 00 M.Y. '07 Spare Parts Department

More information

Spare parts catalogue ST3 S ABS U.S.A DUCATI SPORTTOURING

Spare parts catalogue ST3 S ABS U.S.A DUCATI SPORTTOURING Spare parts catalogue ST S ABS U.S.A DUCATI SPORTTOURING GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the part's code number followed by its

More information

Spare parts catalogue 749S U.S.A. DUCATI SUPERBIKE

Spare parts catalogue 749S U.S.A. DUCATI SUPERBIKE Spare parts catalogue 79S U.S.A. SUPERBIKE MOTOR HOLDING 79S M.Y. '06 U.S.A. Spare Parts Department P.N. 952062C Settembre - September '06 Edizione - Edition 0 MOTOR HOLDING 79S M.Y. '06 U.S.A. Spare

More information

GENERAL INFORMATION. The present spare parts order exactly the right spare parts. When ordering specify:

GENERAL INFORMATION. The present spare parts order exactly the right spare parts. When ordering specify: GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the part's code number followed by its description; quantity needed; 2) the motorcycle's serial

More information

Spare parts catalogue 999 U.S.A. DUCATI SUPERBIKE

Spare parts catalogue 999 U.S.A. DUCATI SUPERBIKE Spare parts catalogue 999 U.S.A. DUCATI SUPERBIKE MOTOR HOLDING 999 M.Y. '06 U.S.A. Spare Parts Department P.N. 9562D Settembre - September '06 Edizione - Edition 0 DUCATIMOTOR HOLDING 999 M.Y. '06 U.S.A.

More information

GENERAL INFORMATION. The present spare parts order exactly the right spare parts. When ordering specify:

GENERAL INFORMATION. The present spare parts order exactly the right spare parts. When ordering specify: GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the part's code number followed by its description; quantity needed; 2) the motorcycle's serial

More information

Model year 2012 U.S.A. Spare parts catalogue. Revision n 00. Spare parts catalogue part number: B

Model year 2012 U.S.A. Spare parts catalogue. Revision n 00. Spare parts catalogue part number: B Spare parts catalogue Model year 202 U.S.A. Revision n 00 Spare parts catalogue part number: GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the

More information

Spare parts catalogue S4Rs U.S.A.

Spare parts catalogue S4Rs U.S.A. Spare parts catalogue S4Rs U.S.A. /05'4 /4*.&+0) M.Y. 0 U.S.A. 5RCTG2CTVU&GRCTVOGPV 20 # /CT\Q/CTEJ 'FK\KQPG'FKVKQP /4*.&+0) M.Y. 0 U.S.A. 5RCTG2CTVU&GRCTVOGPV 20 # /CT\Q/CTEJ 'FK\KQPG'FKVKQP /4*.&+0)

More information

GENERAL INFORMATION. The present spare parts order exactly the right spare parts. When ordering specify:

GENERAL INFORMATION. The present spare parts order exactly the right spare parts. When ordering specify: GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the part's code number followed by its description; quantity needed; 2) the motorcycle's serial

More information

GENERAL INFORMATION. The present spare parts order exactly the right spare parts. When ordering specify:

GENERAL INFORMATION. The present spare parts order exactly the right spare parts. When ordering specify: GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: 1) the part's code number followed by its description; quantity needed; 2) the motorcycle's serial

More information

Spare parts catalogue 400

Spare parts catalogue 400 Spare parts catalogue 00 MONSTER MOTOR HOLDING MONSTER 00 M.Y. '05 Spare Parts Department P. 95022E Febbraio - February '05 Edizione - Edition 0 MOTOR HOLDING MONSTER 00 M.Y. '05 Spare Parts Department

More information

GENERAL INFORMATION. The present spare parts order exactly the right spare parts. When ordering specify:

GENERAL INFORMATION. The present spare parts order exactly the right spare parts. When ordering specify: GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: 1) the part's code number followed by its description; quantity needed; 2) the motorcycle's serial

More information

Spare parts catalogue 999 U.S.A.

Spare parts catalogue 999 U.S.A. Spare parts catalogue 999 U.S.A. DUCATISUPERBIKE MOTOR HOLDING 999 M.Y. '05 U.S.A. Spare Parts Department P.N. 9151162C Novembre - November '05 Edizione - Edition 01 DUCATIMOTOR HOLDING 999 M.Y. '05 U.S.A.

More information

Model year 2012 U.S.A. Spare parts catalogue. Revision n 00. Spare parts catalogue part number: B

Model year 2012 U.S.A. Spare parts catalogue. Revision n 00. Spare parts catalogue part number: B Spare parts catalogue Model year 0 U.S.A. Revision n 00 Spare parts catalogue part number: GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the

More information

GENERAL INFORMATION The present spare parts order exactly the right spare parts. When ordering specify:

GENERAL INFORMATION The present spare parts order exactly the right spare parts. When ordering specify: GENERAL INFORMATION The present spare parts order exactly the right spare parts. When ordering specify: 1) the part's code number followed by its description; 2) the motorcycle's serial number, stamped

More information

GENERAL INFORMATION The present spare parts order exactly the right spare parts. When ordering specify:

GENERAL INFORMATION The present spare parts order exactly the right spare parts. When ordering specify: GENERAL INFORMATION The present spare parts order exactly the right spare parts. When ordering specify: ) the part's code number followed by its description; 2) the motorcycle's serial number, stamped

More information

Spare parts catalogue part number: D

Spare parts catalogue part number: D Revision n 00 Spare parts catalogue model year 200 U.S.A. Spare parts catalogue part number: GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the

More information

Model year 2011 U.S.A. Spare parts catalogue. Revision n 00. Spare parts catalogue part number: D

Model year 2011 U.S.A. Spare parts catalogue. Revision n 00. Spare parts catalogue part number: D Spare parts catalogue Model year 20 U.S.A. Revision n 00 Spare parts catalogue part number: GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the

More information

M.Y. '04. Spare Sparts Department P.N B Giugno - June '04 Edizione - Edition 01

M.Y. '04. Spare Sparts Department P.N B Giugno - June '04 Edizione - Edition 01 DUCATIMOTORHOLDING 999S M.Y. '04 U.S.A. Spare Sparts Department P.N. 91511772B Giugno - June '04 Edizione - Edition 01 DUCATIMOTORHOLDING 999S M.Y. '04 U.S.A. Spare Sparts Department P.N. 91511772B Giugno

More information

GENERAL INFORMATION. The present spare parts order exactly the right spare parts. When ordering specify:

GENERAL INFORMATION. The present spare parts order exactly the right spare parts. When ordering specify: GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the part's code number followed by its description; quantity needed; 2) the motorcycle's serial

More information

GENERAL INFORMATION The present spare parts order exactly the right spare parts. When ordering specify:

GENERAL INFORMATION The present spare parts order exactly the right spare parts. When ordering specify: GENERAL INFORMATION The present spare parts order exactly the right spare parts. When ordering specify: ) the part's code number followed by its description; 2) the motorcycle's serial number, stamped

More information

Spare parts catalogue U.S.A. DUCATISUPERBIKE

Spare parts catalogue U.S.A. DUCATISUPERBIKE Spare parts catalogue U.S.A. DUCATISUPERBIKE MOTOR HOLDING M.Y. '0 U.S.A. Spare Parts Department P.N.9525B Dicembre - December 0 Edizione - Edition 00 DUCATIMOTOR HOLDING M.Y. '0 U.S.A. Spare Parts Department

More information

DUCATI M 400. GENERAL INFORMATION The present spare parts list enables one to order exactly the right spare parts. When ordering specify:

DUCATI M 400. GENERAL INFORMATION The present spare parts list enables one to order exactly the right spare parts. When ordering specify: GENERAL INFORMATION The present spare parts list enables one to order exactly the right spare parts. When ordering specify: ) the part s code number followed by its description; 2) the motorcycle s serial

More information

GENERAL INFORMATION The present spare parts order exactly the right spare parts. When ordering specify:

GENERAL INFORMATION The present spare parts order exactly the right spare parts. When ordering specify: DUCATISS GENERAL INFORMATION The present spare parts order exactly the right spare parts. When ordering specify: ) the part's code number followed by its description; 2) the motorcycle's serial number,

More information

749S DUCATIMOTORHOLDING U.S.A. M.Y. '04. Edizione - Edition 01. Spare Sparts Department P.N A Maggio - May '04 U.S.A.

749S DUCATIMOTORHOLDING U.S.A. M.Y. '04. Edizione - Edition 01. Spare Sparts Department P.N A Maggio - May '04 U.S.A. DUCATIMOTORHOLDING 749S M.Y. '04 U.S.A. Spare Sparts Department P.N. 91512062A Maggio - May '04 Edizione - Edition 01 DUCATIMOTORHOLDING 749S M.Y. '04 U.S.A. Spare Sparts Department P.N. 91512062A Maggio

More information

Model year 2011 U.S.A. Spare parts catalogue. Revision n 00. Spare parts catalogue part number: B

Model year 2011 U.S.A. Spare parts catalogue. Revision n 00. Spare parts catalogue part number: B Spare parts catalogue Model year 0 U.S.A. Revision n 00 Spare parts catalogue part number: GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the

More information

DUCATI M 750. GENERAL INFORMATION The present spare parts list enables one to order exactly the right spare parts. When ordering specify:

DUCATI M 750. GENERAL INFORMATION The present spare parts list enables one to order exactly the right spare parts. When ordering specify: GENERAL INFORMATION The present spare parts list enables one to order exactly the right spare parts. When ordering specify: ) the part s code number followed by its description; 2) the motorcycle s serial

More information

DUCATI. 996Two seater

DUCATI. 996Two seater GENERAL INFORMATION The present spare parts list enables one to order exactly the right spare parts. When ordering specify: 1) the part s code number followed by its description; 2) the motorcycle s serial

More information

Model year 2011 U.S.A. Spare parts catalogue. Revision n 00. Spare parts catalogue part number: B

Model year 2011 U.S.A. Spare parts catalogue. Revision n 00. Spare parts catalogue part number: B Spare parts catalogue Model year 20 U.S.A. Revision n 00 Spare parts catalogue part number: GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the

More information

DUCATI 748S. GENERAL INFORMATION The present spare parts list enables one to order exactly the right spare parts. When ordering specify:

DUCATI 748S. GENERAL INFORMATION The present spare parts list enables one to order exactly the right spare parts. When ordering specify: GENERAL INFORMATION The present spare parts list enables one to order exactly the right spare parts. When ordering specify: 1) the part s code number followed by its description; 2) the motorcycle s serial

More information

GENERAL INFORMATION The present spare parts order exactly the right spare parts. When ordering specify:

GENERAL INFORMATION The present spare parts order exactly the right spare parts. When ordering specify: GENERAL INFORMATION The present spare parts order exactly the right spare parts. When ordering specify: ) the part's code number followed by its description; 2) the motorcycle's serial number, stamped

More information

GENERAL INFORMATION The present spare parts order exactly the right spare parts. When ordering specify:

GENERAL INFORMATION The present spare parts order exactly the right spare parts. When ordering specify: GENERAL INFORMATION The present spare parts order exactly the right spare parts. When ordering specify: ) the part's code number followed by its description; 2) the motorcycle's serial number, stamped

More information

Spare parts catalogue U.S.A. DUCATISUPERBIKE

Spare parts catalogue U.S.A. DUCATISUPERBIKE Spare parts catalogue U.S.A. DUCATISUPERBIKE GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the part's code number followed by its description;

More information

Technical data. Part Thread (mm) Nm ±10% Tolerance Sidestand

Technical data. Part Thread (mm) Nm ±10% Tolerance Sidestand section 3 - Torque settings Frame torque settings Sidestand Stand sensor bolt 5 Pre-applied threadlocker Stand plate fixing screw M10x25 43 Pre-applied threadlocker Side stand fastening pin Side stand

More information

Model year 2012 U.S.A. Spare parts catalogue. Revision n 00. Spare parts catalogue part number: B

Model year 2012 U.S.A. Spare parts catalogue. Revision n 00. Spare parts catalogue part number: B Spare parts catalogue Model year 202 U.S.A. Revision n 00 Spare parts catalogue part number: GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the

More information

Torque settings Torque settings. Frame torque settings. Note

Torque settings Torque settings. Frame torque settings. Note 3 - Torque settings Frame torque settings Part Thread (mm) Nm ±10% Tolerance Side stand Stand sensor screw M6x1 5 LOCK 2 Stand plate fixing screw M10x1.5 43 LOCK 2 Side stand fastening pin M8x1.25 Side

More information

ATV 90 UTILITY GREEN (A2006KUB2BUSG) Page 1 of 60 AIR INTAKE ASSEMBLY

ATV 90 UTILITY GREEN (A2006KUB2BUSG) Page 1 of 60 AIR INTAKE ASSEMBLY 2006 ATV 90 UTILITY GREEN (A2006KUB2BUSG) Page 1 of 60 AIR INTAKE ASSEMBLY 2006 ATV 90 UTILITY GREEN (A2006KUB2BUSG) Page 2 of 60 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3303-005

More information

Model year 2010 U.S.A. Spare parts catalogue. Revision n 00. Spare parts catalogue part number: B

Model year 2010 U.S.A. Spare parts catalogue. Revision n 00. Spare parts catalogue part number: B Spare parts catalogue Model year 200 U.S.A. Revision n 00 Spare parts catalogue part number: GENERAL INFORMATION The present spare parts order exactly the right spare parts When ordering specify: ) the

More information

ATV 50 DVX BLACK-RED (A2008KSA2BUSD) Page 1 of 60 AIR INTAKE ASSEMBLY

ATV 50 DVX BLACK-RED (A2008KSA2BUSD) Page 1 of 60 AIR INTAKE ASSEMBLY 2008 ATV 50 DVX BLACK-RED (A2008KSA2BUSD) Page 1 of 60 AIR INTAKE ASSEMBLY 2008 ATV 50 DVX BLACK-RED (A2008KSA2BUSD) Page 2 of 60 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3303-005

More information

ATV 90 UTILITY CALIFORNIA GREEN (A2008KUB2BCAG) Page 1 of 58 AIR INTAKE ASSEMBLY

ATV 90 UTILITY CALIFORNIA GREEN (A2008KUB2BCAG) Page 1 of 58 AIR INTAKE ASSEMBLY 2008 ATV 90 UTILITY CALIFORNIA GREEN (A2008KUB2BCAG) Page 1 of 58 AIR INTAKE ASSEMBLY 2008 ATV 90 UTILITY CALIFORNIA GREEN (A2008KUB2BCAG) Page 2 of 58 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description

More information

Parts Diagrams RR/RS Models

Parts Diagrams RR/RS Models Parts Diagrams 2008-2009 RR/RS Models Table Of Contents Description Page # front fork 1 handlebar, clutch pump, meter (RR Models) 2 handlebar, clutch pump, meter (RS Models) 3 frame, subframe 4 rear shock,

More information

DVX 90 MODEL NUMBER A2008KSB2BUSD (BLACK-RED) MODEL NUMBER A2008KSB2BUSE (BLACK-CAT GREEN) MORE TO GO ON. TM

DVX 90 MODEL NUMBER A2008KSB2BUSD (BLACK-RED) MODEL NUMBER A2008KSB2BUSE (BLACK-CAT GREEN) MORE TO GO ON. TM 2008 DVX 90 Illustrated Parts Manual MODEL NUMBER A2008KSB2BUSD (BLACK-RED) MODEL NUMBER A2008KSB2BUSE (BLACK-CAT GREEN) MORE TO GO ON. TM TABLE OF CONTENTS Black-Red (Model No. A2008KSB2BUSD) Black-Cat

More information

ATV 300 DVX CAT GREEN (A2011KSF2BUSZ) Page 1 of 56 AIR INTAKE ASSEMBLY

ATV 300 DVX CAT GREEN (A2011KSF2BUSZ) Page 1 of 56 AIR INTAKE ASSEMBLY 2011 ATV 300 DVX CAT GREEN (A2011KSF2BUSZ) Page 1 of 56 AIR INTAKE ASSEMBLY 2011 ATV 300 DVX CAT GREEN (A2011KSF2BUSZ) Page 2 of 56 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3303-705

More information

90 Utility Model Number A2013KUB2BUSZ SHARE OUR PASSION.

90 Utility Model Number A2013KUB2BUSZ SHARE OUR PASSION. 2013 90 Utility Model Number A2013KUB2BUSZ TM SHARE OUR PASSION. TABLE OF CONTENTS 2013 ATV 90 (Model No. A2013KUB2BUSZ) BODY PANEL AND HEADLIGHT ASSEMBLY... 1 FRONT AND REAR RACK ASSEMBLY... 2 FRAME AND

More information

MicrofichesExcel. Tavola Posizione Codice Quant Ing

MicrofichesExcel. Tavola Posizione Codice Quant Ing Tavola Posizione Codice Quant Ing 1 1 T1P52MI-A-011200 1 LH Crankcase 1 2 T1P52MI-A-011300 1 RH Crankcase 1 3 T11119 1 Crankcase gasket 1 4 TOR00037 4 Screw M5 6 1 5 T1P52MI-011400 2 Bush 1 6 T11118 2

More information

X4 (GREEN) (A2000ATF2AUSG) Page 1 of 80 AIR INTAKE ASSEMBLY

X4 (GREEN) (A2000ATF2AUSG) Page 1 of 80 AIR INTAKE ASSEMBLY 2000 300 2X4 (GREEN) (A2000ATF2AUSG) Page 1 of 80 AIR INTAKE ASSEMBLY 2000 300 2X4 (GREEN) (A2000ATF2AUSG) Page 2 of 80 AIR INTAKE ASSEMBLY Ref # Part Number Qty S/P/F Description 1 3570-001 1 /P Intake,

More information

400 4x4 Euro MODEL NUMBER A2008IDG4BEUR (RED) MODEL NUMBER A2008IDG4BEUG (GREEN) MODEL NUMBER A2008IDG4BEUZ (CAT GREEN) MORE TO GO ON.

400 4x4 Euro MODEL NUMBER A2008IDG4BEUR (RED) MODEL NUMBER A2008IDG4BEUG (GREEN) MODEL NUMBER A2008IDG4BEUZ (CAT GREEN) MORE TO GO ON. 2008 400 4x4 Euro Illustrated Parts Manual MODEL NUMBER A2008IDG4BEUR (RED) MODEL NUMBER A2008IDG4BEUG (GREEN) MODEL NUMBER A2008IDG4BEUZ (CAT GREEN) MORE TO GO ON. TM TABLE OF CONTENTS 2008 ATV 400 4x4

More information

DVX 300 Euro. Model Number A2012KSF2BEUK SHARE OUR PASSION.

DVX 300 Euro. Model Number A2012KSF2BEUK SHARE OUR PASSION. ATV 2012ATV Illustrated Parts Manual DVX 300 Euro Model Number A2012KSF2BEUK TM SHARE OUR PASSION. TABLE OF CONTENTS 2012 ATV DVX 300 Euro (Model No. A2012KSF2BEUK) BODY PANEL AND HEADLIGHT ASSEMBLY...

More information

400 2x4/4x4 EFT SHARE OUR PASSION ṬM

400 2x4/4x4 EFT SHARE OUR PASSION ṬM SHARE OUR PASSION ṬM 400 2x4/4x4 EFT Model Number A2009IDG2BETR (Red - 2x4) Model Number A2009IDG2BETZ (Cat Green - 2x4) Model Number A2009IDG4BETR (Red - 4x4) Model Number A2009IDG4BETG (Green - 4x4)

More information

ZH5CR0005H /03/2017

ZH5CR0005H /03/2017 VIN Nmber: ZH5CR0005H00000 Release: /03/07 D-: CRANKSHAFT & CRANKCASE A005 RH CRANKCASE 89997 CRAKSHAFT ASS'Y 3 A0059 LH CRANKCASE 873 COUNTERSHAFT 5 876 COUNTERSHAFT DRIVE GEAR 6 8756 COUNTERSHAFT DRIVEN

More information

Motorcycle parts compatibility on ebay.co.uk

Motorcycle parts compatibility on ebay.co.uk Motorcycle parts compatibility on ebay.co.uk Review the full list of categories and subcategories in which you can list motorcycle and scooter parts. Last updated: 10 August 2016 Motorcycle Parts (10063)

More information

Hexhead Torque Values

Hexhead Torque Values Contents: 11: Engine 12: Engine Electrical 13: Fuel Preparation 16: Fuel Supply 17: Cooling 18: Exhaust 21: Clutch 23: Gearbox 31: Front Axle, Front Wheel Steering 32: Steering 33: Rear axle, rear-wheel

More information

D-1: CRANKSHAFT & CRANKCASE

D-1: CRANKSHAFT & CRANKCASE VIN Nmber: ZH5CR0005H00000 Release: /05/07 D-: CRANKSHAFT & CRANKCASE A005 CHANGED IN a005887- a005887- RH CRANKCASE 89997 CRAKSHAFT ASS'Y A0059 CHANGED IN a005886- a005886- LH CRANKCASE 87 COUNTERSHAFT

More information

FRONT RACK, BODY PANEL, AND HEADLIGHT ASSEMBLIES

FRONT RACK, BODY PANEL, AND HEADLIGHT ASSEMBLIES FRONT RACK, BODY PANEL, AND HEADLIGHT ASSEMBLIES 0747-506 1 2506-107 1 Rack, Front - Assembly (inc. 2) 2 0411-576 1 Decal, Warning - Load 3 0441-592 4 Bushing 4 8410-835 4 Screw, Cap 5 0423-669 4 Spacer

More information

DESMOSEDICI RR Model Year 2008 DESMOSEDICI RR SPARE PARTS CATALOGUE. Chassis prefix: D100AA,1ZDFW Cylinder capacity: 1000.

DESMOSEDICI RR Model Year 2008 DESMOSEDICI RR SPARE PARTS CATALOGUE. Chassis prefix: D100AA,1ZDFW Cylinder capacity: 1000. DESMOSEDICI RR Model Year 00 DESMOSEDICI RR Chassis prefix: D00AA,ZDFW Cylinder capacity: 000 00.0 en-us GENERAL INFORMATION The present spare parts order exactly the right spare parts. When ordering

More information

Illustrated Parts Manual. Model Number A2011ICS4BUSG (Green) A2011ICS4BOSG (Green - International)

Illustrated Parts Manual. Model Number A2011ICS4BUSG (Green) A2011ICS4BOSG (Green - International) Illustrated Parts Manual 2 1 10 650 Model Number A2011ICS4BUSG (Green) A2011ICS4BOSG (Green - International) S H A R E O U R PAS S IO N. TM TABLE OF CONTENTS 2011 ATV 650 Green (Model No. A2011ICS4BUSG)

More information

XC 450 EFT Model Number A2013KCK4CETT SHARE OUR PASSION.

XC 450 EFT Model Number A2013KCK4CETT SHARE OUR PASSION. 2013 XC 450 EFT Model Number A2013KCK4CETT TM SHARE OUR PASSION. TABLE OF CONTENTS 2013 XC 450 EFT Green (Model No. A2013KCK4CETT) FRONT BODY ASSEMBLY... 1 REAR BODY AND TAILLIGHT ASSEMBLY... 2 BUMPER,

More information

Illustrated Parts Manual. Model Number A2011KSF2BEUZ (Black-Cat Green) A2011KSF2BEOJ (White-Cat Green)

Illustrated Parts Manual. Model Number A2011KSF2BEUZ (Black-Cat Green) A2011KSF2BEOJ (White-Cat Green) Illustrated Parts Manual 2 1 10 DVX 300 Euro Model Number A2011KSF2BEUZ (Black-Cat Green) A2011KSF2BEOJ (White-Cat Green) S H A R E O U R PAS S IO N. TM TABLE OF CONTENTS 2011 ATV DVX 300 Euro Black-Cat

More information

enduro / motard ZH5SMX???H /07/2017

enduro / motard ZH5SMX???H /07/2017 enduro / motard VIN Nmber: ZH5SMX???H00000 Release: /07/07 D-: CRANKSHAFT & CRANKCASE A005887- RH CRANKCASE 89997 CRANKSHAFT 3 A005886- LH CRANKCASE 873 COUNTERSHAFT 5 876 COUNTERSHAFT DRIVE GEAR 6 8756

More information

ATV I l. l u. r a. Parts Manual ARCTIC CAT. 250 cc/300 cc

ATV I l. l u. r a. Parts Manual ARCTIC CAT. 250 cc/300 cc 2000 I l l u st ATV 250 cc/300 cc Model No. A2000ATE2AUSG (250 - Green) Model No. A2000ATE2AUSR (250 - Red) Model No. A2000ATF2AUSG (300 2x4 - Green) Model No. A2000ATF2AUSR (300 2x4 - Red) Model No. A2000ATF4AUSG

More information

CYLINDER HEAD. Ref. Part No. Number Description Qty Remarks

CYLINDER HEAD. Ref. Part No. Number Description Qty Remarks A1 A2 A3 A4 CYLINDER HEAD 1 3FA-11110-01-00 CYLINDER HEAD ASSY...... 1 2 90116-06541-00. BOLT, STUD............. 2 3 22F-11134-10-00. GUIDE, EXHAUST VALVE... 2 4 93440-10109-00. CIRCLIP.................

More information

MAINTENANCE SXV / RXV

MAINTENANCE SXV / RXV MAINTENANCE SXV / RXV 450-550 3.1.12. HANDLEBAR AND CONTROLS Screw securing clutch control to handlebar M6 10 Throttle control screw M6 4 Ignition switch screw M8 24 FOOTRESTS Footrest support bracket

More information

10th letter in VIN: J

10th letter in VIN: J 08 0th letter in VIN: J Headlight G Br Speedometer Headlight Light Switch B Br Ignition Switch R B Y/R Brake Light Switch B G/Y Starter Relay Fuse A + G Starter Motor Rear Brake Light G/Y Br G Speed Sensor

More information

Illustrated Parts Manual

Illustrated Parts Manual 1 10 Illustrated Parts Manual 2 425 CR EFT Model Number A2011IRK4CETR (Red) S H A R E O U R PA S S IO N. TM TABLE OF CONTENTS 2011 ATV 425 CR EFT Red (A2011IRK4CETR) FRONT RACK, BODY PANEL, AND HEADLIGHT

More information

CYLINDER - CYLINDER HEAD

CYLINDER - CYLINDER HEAD A1 CYLINDER - CYLINDER HEAD 1 3FA-11110-00-00 CYLINDER HEAD ASSEMBLY. 1 2 95612-06625-00. BOLT, STUD............. 2 3 22F-11134-10-00. GUIDE, EXHAUST VALVE... 2 4 93440-10109-00. CIRCLIP.................

More information

ETON America PARTS CATALOG. Matrix R4-150

ETON America PARTS CATALOG. Matrix R4-150 ETON America PARTS CATALOG w.getitparts.com Matrix R4-50 www.getitparts.com Parts and drawing are subject to change without notice. ETON America reserves the right to substitute parts that have engineering

More information

SMF / DSF / DTF SMF / DSF / DTF 200

SMF / DSF / DTF SMF / DSF / DTF 200 2006 SMF / DSF / DTF 200 1 The drawings in this parts book have been scaled so that parts can be easily recognized. 1 CYLINDER ASSY 2 CYLINDER ASSY Ref # Part # Description 1 410 0001A CYLINDER HEAD COVER

More information

CYLINDER HEAD. Ref. Part No. Number Description Qty Remarks

CYLINDER HEAD. Ref. Part No. Number Description Qty Remarks A1 A2 A3 A4 CYLINDER HEAD 1 15A-11110-03-00 CYLINDER HEAD ASSY...... 1 2 93440-10085-00. CIRCLIP................. 2 3 90153-06029-00. SCREW, HEXAGON........ 1 4 90430-06014-00. GASKET................ 1

More information

CS340ES. Property of - Not for Resale A1

CS340ES. Property of   - Not for Resale A1 A1 CYLINDER HEAD - CYLINDER 1 8G8-11111-00-00 HEAD, CYLINDER 1......... 1 2 8G8-11121-00-00 HEAD, CYLINDER 2......... 1 3 NGK-BR9ES-00-00 PLUG, SPARK............. 2 4 8G8-11181-01-00 GASKET, CYLINDER HEAD

More information

GTS150. Dune Buggy MINIMUM RECOMMENDED OPERATOR AGE: FOR OFF-ROAD USE ONLY. 10th letter in VIN: D-G

GTS150. Dune Buggy MINIMUM RECOMMENDED OPERATOR AGE: FOR OFF-ROAD USE ONLY. 10th letter in VIN: D-G 0-06 GTS50 0th letter in VIN: D-G Dune Buggy MINIMUM RECOMMENDED OPERATOR AGE: 6 FOR OFF-ROAD USE ONLY This vehicle is designed and manufactured for off-road use only. USA only: It does not conform to

More information

SPARE PARTS CATALOGUE

SPARE PARTS CATALOGUE SPARE PARTS CATALOGUE Liberty 50 2T Historical catalogs 1998-2005 345 Index Finished products... 4 Alphanumeric index... 5 Electrical equipment... 10 Table T36 - Electrical devices... 10 Table T37 - Optical

More information

Triumph Tiger 800. Torque settings. Torque (Nm) Camshaft cover to cylinder head 10 Camshaft drive chain tensioner to head 9

Triumph Tiger 800. Torque settings. Torque (Nm) Camshaft cover to cylinder head 10 Camshaft drive chain tensioner to head 9 Triumph Tiger 800 Torque settings Cylinder Head Camshaft cover to cylinder head 10 Camshaft drive chain tensioner to head 9 Camshaft bearing ladder to head Camshaft sprocket to camshaft 10 Camshaft drive

More information

11/14/ U. Baja Motorsports Inc. P.O. Box Phoenix, AZ Toll Free: PARTS AND PRICES ARE SUBJECT TO CHANGE 1 of 53

11/14/ U. Baja Motorsports Inc. P.O. Box Phoenix, AZ Toll Free: PARTS AND PRICES ARE SUBJECT TO CHANGE 1 of 53 250U Toll Free: 888-863-2252 PARTS AND PRICES ARE SUBJECT TO CHANGE 1 of 53 FIG. 1 PNEUMATIC MECHANISM 1-1 250U-100 883099019951 CAMSHAFT 1 1 1-2 250U-101 883099019968 KEY, WOODRUFF 1 1 1-3 250U-102 883099019975

More information

CYLINDER. Ref. Part No. Number Description Qty Remarks

CYLINDER. Ref. Part No. Number Description Qty Remarks A1 A2 A3 A4 CYLINDER 1 2GU-11111-00-00 HEAD, CYLINDER 1......... 1 2 NGK-B8ES0-00-00 PLUG, SPARK (NGK B8ES)... 2 3 90116-08394-00 BOLT, STUD.............. 8 4 95917-08640-00 BOLT, STUD.............. 2

More information

90 Y-12 Youth. Model Number A2005H4B2BUSR (Red) Model Number A2005H4B2BUSZ (Cat Green) Illustrated Parts Manual

90 Y-12 Youth. Model Number A2005H4B2BUSR (Red) Model Number A2005H4B2BUSZ (Cat Green) Illustrated Parts Manual 90 Y-12 Youth Model Number A2005H4B2BUSR (Red) Model Number A2005H4B2BUSZ (Cat Green) Illustrated Parts Manual 2005 TABLE OF CONTENTS 2005 ATV 90 Y-12 Youth Red (Model No. A2005H4B2BUSR) Cat Green (Model

More information

CYLINDER HEAD. Ref. Part No. Number Description Qty Remarks

CYLINDER HEAD. Ref. Part No. Number Description Qty Remarks A1 CYLINDER HEAD 1 55V-11101-01-00 CYLINDER HEAD ASSEMBLY. 1 2 30X-11133-10-00. GUIDE, INTAKE VALVE..... 4 3 93440-10109-00. CIRCLIP................. 4 4 99510-08016-00. PIN, DOWEL............. 8 5 90105-06153-00.

More information

CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks

CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks A1 CYLINDER HEAD 1 4JY-11111-00-00 HEAD, CYLINDER 1 (4JY-11111-01-00).......... 1 2 90116-08394-00 BOLT, STUD.............. 5 3 90176-08026-00 NUT, CROWN............. 5 4 90201-08087-00 WASHER, PLATE...........

More information

CYLINDER HEAD. Ref. Part No. Number Description Qty Remarks

CYLINDER HEAD. Ref. Part No. Number Description Qty Remarks A1 A2 A3 A4 CYLINDER HEAD 1 1UY-11110-02-00 CYLINDER HEAD ASSY...... 1 2 3Y1-11133-11-00. GUIDE, INTAKE VALVE..... 2 3 93440-12052-00. CIRCLIP................. 2 4 90401-06001-00. BOLT, UNION............

More information

CYLINDER HEAD - CYLINDER

CYLINDER HEAD - CYLINDER A1 CYLINDER HEAD - CYLINDER 1 8AY-11111-00-00 HEAD, CYLINDER 1......... 1 2 8A7-12499-00-00 JOINT................... 1 3 NGK-BR9ES-00-00 PLUG, SPARK............. 2 4 8AY-11181-00-00 GASKET, CYLINDER HEAD

More information

CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks

CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks A1 CYLINDER HEAD 1 4JY-11111-00-00 HEAD, CYLINDER 1 (4JY-11111-01-00).......... 1 2 90116-08394-00 BOLT, STUD.............. 5 3 90176-08026-00 NUT, CROWN............. 5 4 90201-08087-00 WASHER, PLATE...........

More information

CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks

CYLINDER HEAD CONTINUED ON NEXT FRAME. Ref. Part No. Number Description Qty Remarks A1 CYLINDER HEAD 1 3BM-11101-00-00 CYLINDER HEAD ASSEMBLY. 1 2 4H7-11133-10-00. GUIDE, INTAKE VALVE..... 2 3 93440-12052-00. CIRCLIP................. 2 4 3BM-11101-10-00 CYLINDER HEAD ASSEMBLY. 1 5 4H7-11133-10-00.

More information

View Catalogs Online at

View Catalogs Online at ML125-5 Frame Parts 12551-1 Grip, LH 12551-2 Front Brake Lever Comp. 12551-3 Handlebar Switch, LH 12551-4 Rearview Mirror, LH 12551-5 Rearview Mirror, RH 12551-6 Handlebar Switch, RH 12551-7 Clutch Lever

More information

Illustrated Parts Manual

Illustrated Parts Manual Illustrated Parts Manual 2 1 10 550 PS EFT Model Number A2011IBO1PETS (Metallic Gray) S H A R E O U R PAS S IO N. TM TABLE OF CONTENTS 2011 ATV 550 PS EFT Metallic Gray (A2011IBO1PETS) FRONT RACK, BODY

More information

View Catalogs Online at

View Catalogs Online at Catalog ML125-5 2015Edition ML125-5 Frame Parts 12551-1 Grip, LH 12551-2 Clutch Lever Comp. 12551-3 Handlebar Switch, LH 12551-4 Rearview Mirror, LH 12551-5 Rearview Mirror, RH 12551-6 Handlebar Switch,

More information

D-1: FAN COVER. DESCRIPTION 1 Asm., Shroud, Upper

D-1: FAN COVER. DESCRIPTION 1 Asm., Shroud, Upper D-: FAN COVER Asm., Shroud, Upper 9639-000 Screw, Tappinmg 9390-305068-00K 3 Clamp 9689-000 Plug, Rubber 96339-000 5 Elbow, Outlet 9650-000 6 Bolt 96000-06058-08C 3 7 Cover Set, Fly Wheel 9609-00 8 Cap

More information

D-1:CYLINDER HEAD. DESCRIPTION C 4 2 Cover, Cylinder Head 3 Gasket 4 Breather, Crankcase, Lower A

D-1:CYLINDER HEAD. DESCRIPTION C 4 2 Cover, Cylinder Head 3 Gasket 4 Breather, Crankcase, Lower A CROSSLAND 300 D-1:CYLINDER HEAD 1 Bolt 96000-060258-08C 4 2 Cover, Cylinder Head 1230950A-000 1 3 Gasket 1230350A-000 1 4 Breather, Crankcase, Lower 1230250A-000 1 5 Screw 93903-1040088-00K 4 6 Gasket,

More information

700 Diesel EFT Model Number A2013TBT4DETG SHARE OUR PASSION.

700 Diesel EFT Model Number A2013TBT4DETG SHARE OUR PASSION. 2013 700 Diesel EFT Model Number A2013TBT4DETG SHARE OUR PASSION. TM TABLE OF CONTENTS 2013 ATV 700 Diesel EFT Green (Model No. A2013TBT4DETG) FRONT RACK, BODY PANEL, AND HEADLIGHT ASSEMBLIES... 1 REAR

More information

1. COVER COMP CYLINDER HEAD

1. COVER COMP CYLINDER HEAD CONTENTS FIG. 1 COVER COMP CYLINDER HEAD FIG. 2 CAMSHAFT COMP FIG. 3 HOLDER CAMSHAFT COMP FIG. 4 CYLINDER HEAD COMP FIG. 5 CARBURETOR FIG. 6 AIR CLEANER FIG. 7 LEFT CRANKCASE COVER FIG. 8 DRIVE PULLEY

More information

Figure 1. - Cylinder / Cylinder Head

Figure 1. - Cylinder / Cylinder Head Page 1 of 42 Figure 1. - Cylinder / Cylinder Head Figure 1. Cylinder / Cylinder Head 1 11111-STG-00 Cylinder comp 1 2 11121-STG-00 Head comp, cylinder 1 3 11127-CHP-00 Nut, cylinder head 1 4 11141-ROA-00

More information