DIESEL GENERATOR SET DE110E2. Output Ratings. Technical Data. EU stage II emissions compliant. Image shown may not reflect actual package.

Transcription

1 DIESEL GENERATOR SET DE110E2 EU stage II emissions compliant. Image shown may not reflect actual package Output Ratings Generator Set Model - 3 Phase Prime* Standby* 400/230 V, 480/277 V, * Refer to ratings definitions on page 4. Ratings at 0.8 power factor. kva kw kva kw kva kw kva kw Technical Data Engine Make & Model: C4.4 Generator Model: LC3114F Control Panel: EMCP 4.1 Base Frame Type: Heavy Duty Fabricated Steel Circuit Breaker Type: 3 Pole MCCB Frequency: Engine Speed: RPM Fuel Tank Capacity: litres (US gal) Fuel Consumption, Prime: l/hr (US gal/hr) Fuel Consumption, Standby : l/hr (US gal/hr) (66.0) 21.7 (5.7) 25.7 (6.8) 23.8 (6.3) 28.5 (7.5)

2 DIESEL GENERATOR SET Engine Technical Data Physical Data Manufacturer: Model: No. of Cylinders/Alignment: Cycle: Induction: Cooling Method: Governing Type: Governing Class: Compression Ratio: Displacement: l (cu.in) Bore/Stroke: Moment of Inertia: kg m² (lb. in²) Engine Electrical System: Air System Air Filter Type: Combustion Air Flow: m³/min (cfm) -Standby: Max. Combustion Air Intake Restriction: kpa (in H 2 O) Radiator Cooling Air Flow: m³/min (cfm) -Voltage/Ground: -Battery Charger Amps: Weight: kg (lb) - Dry: - Wet: External Restriction to Cooling Air Flow: Pa (in H 2 O) Cooling System Cooling System Capacity: l (US gal) Water Pump Type: Heat Rejected to Water & Lube Oil: kw (Btu/min) -Standby: Heat Radiation to Room: Heat radiated from engine and alternator kw (Btu/min) -Standby: Radiator Fan : kw (hp) Replaceable Element 6.3 (221) 6.0 (212) 8.0 (32.1) (6632) 125 (0.5) Caterpillar C4.4 4 / In Line 4Stroke Turbocharged Air To Air Charge Cooled Water Electronic ISO 8528 G2 18.3:1 4.4 (268.5) (4.1)/127.0 (5.0) 17.5 (4.6) 50.7 (2883) 46.1 (2622) 15.3 (870) 13.7 (779) 2.8 (3.8) 1.51 (5160) 12/Negative Cooling system designed to operate in ambient conditions up to 50 C (122 F). Contact your local Cat dealer for power ratings at specific site conditions (1102) 520 (1146) 7.8 (275) 7.8 (274) 8.0 (32.1) (8624) Centrifugal 125 (0.5) 17.5 (4.6) 64.0 (3640) 57.7 (3281) 17.7 (1007) 15.7 (893) 4.8 (6.4) Lubrication System Oil Filter Type: Total Oil Capacity l (US gal): Oil Pan l (US gal): Oil Type: Cooling Method: Performance Engine Speed: RPM Gross Engine Power: kw (hp) BMEP: kpa (psi) -Standby: -Standby: Regenerative Power: kw Fuel System Fuel Filter Type: Recommended Fuel: Fuel Consumption: l/hr (US gal/hr) Prime Standby 110% 100% 50% (based on diesel fuel with a specific gravity of 0.85 and conforming to BS2869, Class A2) Exhaust System Silencer Type: Silencer Model & Quantity: Pressure Drop Across Silencer System: kpa (in Hg) Silencer Noise Reduction Level: db 23.8 (6.3) 28.5 (7.5) Max. Allowable Back Pressure: kpa (in. Hg) Exhaust Gas Flow: m³/min (cfm) -Standby: Exhaust Gas Temperature: C ( F) -Standby: (126.0) (271.7) 8.2 Spin-On, Full Flow Replaceable Element Class A2 Diesel or BSEN (5.7) 25.7 (6.8) 23.8 (6.3) 28.5 (7.5) 8.0 (2.1) 7.0 (1.8) API CC/SE Water (138.0) (158.0) (143.0) (258.3) (246.9) (234.8) 16.5 (4.4) 19.6 (5.2) 18.0 (4.8) 21.5 (5.7) 2.10 (0.620) (5.3) 16.3 (576) 15.2 (537) 543 (1009) 514 (957) Industrial EXSY1 (1) (3.1) 14.1 (3.7) 12.6 (3.3) 15.2 (4.0) 3.56 (1.051) (4.4) 20.4 (720) 18.4 (650) 574 (1065) 517 (963)

3 DIESEL GENERATOR SET Generator Performance Data Data Item 415/240V 400/230V 230/115V 200/115V 380/220V 220/110V 220/127V 480/277V 240/139V 380/220V 220/110V 240/120V 208/120V 230/115V 440/254V 220/127V Motor Starting Capability* kva Short Circuit Capacity** % Reactances: Per Unit Xd X'd X''d Reactances shown are applicable to prime ratings. *Based on 30% voltage dip at 0.6 power factor and SHUNT excitation system. ** With optional Permanent Magnet generator. Generator Technical Data Physical Data Operating Data Overspeed: RPM 2250 Model: LC3114F Voltage Regulation: (steady state) +/- 0.5% No. of Bearings: 1 Wave Form NEMA = TIF: 50 Insulation Class: H Wave Form IEC = THF: 2.0% Winding Pitch - Code: 2/3-6 Total Harmonic Content LL/LN: 2.0% Wires: 12 Radio Interference: Suppression is in line with European Standard EN Ingress Protection Rating: IP23 Radiant Heat: kw (Btu/min) Excitation System: SHUNT -: 7.8 (444) AVR Model: R250 -: 8.3 (472)

4 DIESEL GENERATOR SET Technical Data Voltage Prime Standby Voltage Prime Standby kva kw kva kw kva kw kva kw 415/240V 480/277V 400/230V 220/127V 380/220V 380/220V 230/115V 240/120V 220/127V 230/115V 220/110V 440/254V 200/115V 220/110V 208/120V 240/139V Weights & Dimensions Weights: kg (lb) Dimensions: Net (+ lube oil) 1129 (2490) Length 2089 (82.2) Wet (+ lube oil & coolant) 1147 (2529) Width 1120 (44.1) Fuel, lube oil & coolant 1358 (2994) Height 1375 (54.1) Note: General configuration not to be used for installation. See general dimension drawings for detail. Definitions Standby Rating Prime Rating Output available with varying load for an unlimited time. Average power output is 70% of the prime power rating. Typical peak demand is 100% of prime rated ekw with 10% overload capability for emergency use for a maximum of 1 hour in 12. Overload opeation cannot exceed 25 hours per year. General Data Documents A full set of operation and maintenance manuals and circuit wiring diagrams. Quality Standards The equipment meets the following standards: IEC , IEC , ISO3046, ISO8528, NEMA MG 1-32, NEMA MG 1-33, 2004/108/EC, 2006/42/EC, 2006/95/EC. Ṡtandard Reference Conditions Note: Standard reference conditions 25 C (77 F) air inlet temp, 100m (328ft) A.S.L. 30% relative humidity. Fuel consumption data at full load with diesel fuel with specific gravity of 0.85 and conforming to BS2869: 1998, Class A Caterpillar All rights reserved. Materials and specifications are subject to change without notice. The International System of Units (SI) is used in this publication. CAT, CATERPILLAR, their respective logos, "Caterpillar Yellow," the "Power Edge" trade dress, as well as corporate and product identity used herein, are trademarks of Caterpillar and may not be used without permission.

5 E N C L O S U R E S SOUND ATTENUATED LEVEL 1 ENCLOSURES kva Features DURABLE AND ROBUST CONSTRUCTION Galvanised steel protected by powder coat paint Zinc plated / stainless steel fasteners SECURITY AND SAFETY lockable enclosure door exterior below control panel access doors safety TRANSPORTABILITY EXCELLENT SERVICE AND MAINTENANCE ACCESS Removable front and rear access panels Lube oil and coolant drain valves LEHE0XXX-00 LEHE

6 E N C L O S U R E S Sound Pressure Levels (dba) Generator Set Model Prime Standby Prime Standby Prime Standby Prime Standby Prime Standby Prime Standby Prime Standby Prime Standby Prime Standby Generator Set Model Prime Standby Prime Standby Prime Standby LEHE0XXX-00 LEHE

7 E N C L O S U R E S C D B A Generator Set Model Three Phase A: B: C: D*: Fuel Capacity: l (US gal) Weight: kg (lb) DE33E (14.8) DE50E0 145 (38.3) DE55E0 145 (38.3) DE65E0 145 (38.3) DE88E0 188 (49.6) DE110E2 212 (56.0) DE165E0 289 (76.3) DE200E0 384 (101.4) DE220E0 384 (101.4) Generator Set Model Single Phase A: B: C: D*: Fuel Capacity: l (US gal) Weight: kg (lb) 2291 (90.2) 1026 (40.4) 1426 (56.1) 145 (38.3) 2291 (90.2) 1026 (40.4) 1426 (56.1) 145 (38.3) 2761 (108.7) 1126 (44.3) 1535 (60.4) 212 (56.0) LEHE0XXX-00 LEHE (10/14) (07-14) CAT, CATERPILLAR, their respective logos, Caterpillar Yellow, the Power Edge trade dress, as well as corporate and product identity used herein, are trademarks

8 Accessories SBOX CEE FORM SOCKETS The socket box option enhances the suitability of the standard generator set for use in rental applications by providing power outlets via IP67 CEE form sockets on the outside of the generator set enclosure. The sockets are fitted into a fully integrated recessed panel on the side of the generator set enclosure, ensuring there is no impact to noise levels or generator set footprint. RCD devices protect customer outlet sockets up to 32A via RCBO s. Protection is 30mA with 0 trip response. Protection for the 63A sockets is provided via MCB s. Please note, the socket box option is only available for European Sourced three phase EU Stage IIIA Compliant, generator sets fitted LC Frame alternator and SA Level 2 enclosure. Standard Features IP67 sockets and trip covers Recessed sockets for damage protection MCB / RCBO connection access from front of socket box Visible indication & simple reset of tripped sockets Robust connections Excellent socket box access via end panel Customer electrical connections Socket Configurations SBOX for DE33E3, DE65E3, DE88E3 & DE110E3 4 Sockets: 2 x 16A Sockets 1 x 32A Socket 1 x 63A Socket *SBOX for DE165E3, DE175E3 & DE200E3 6 Sockets: 2 x 16A Sockets 2 x 32A Sockets 2 x 63A Sockets *Available as DTO only. LEHE (10/16) Caterpillar All rights reserved. Materials and specifications are subject to change without notice. CAT, CATERPILLAR, their respective logos ACERT, Caterpillar Yellow, the Power Edge trade dress as well as corporate and product identity used herein, are trademarks of Caterpillar and may not be used without permission.