DFRB536 : INTERIOR ASSEMBLY [1/9]

Transcription

1 DFRB536 : INTERIOR ASSEMBLY [1/9] Page 1 of 18

2 DFRB536 : INTERIOR ASSEMBLY [1/9] Ref # Part Number Qty. Description 1 L BRACKET LIGHT AR LAMP, 40 WATT BLUE LIGHT 3 PE LIGHT SOCKET 4 PD SCREW-SM 5 PK COVER LIGHT ASM AF AR BM 36 6 PM SHELF ASM GLASS BM 36 FF 7 PM LADDER SIDE AF M SCREW-SM 9 B CLIP-GROUND HOUSING-LIGHT V PM LADDER CENTER AR G SHELF & SLIDE ASM AR DRAWER,PRODUCE,ASM AR M GROMMET-SCREW 15 PK DUCT MEATSAVOR SPACER 16 PK COVER CONTROL MEAT SAVOR 17 PK DIAL CONTROL MEAT SAVOR 18 PM ROLLER TENSION 19 PK DUCT MEAT SAVOR SXS 42/48 R 20 G DRAWER DELI ASM AR MEAT SAVOR FAN W 22 PK SUPPORT DRAWER MEAT SAVOR SXS 42/48 R 23 PK DRAWER MEAT SAVOR AR BM M SCREW-SM 25 PK SUPPORT SLIDE MEAT SAVOR SXS 42/48 R 26 PD SCR 8-16 PLASTITE PNP 1/4 S 27 PM SLIDE MEAT SAVOR R 28 PM SLIDE MEAT SAVOR L 29 PK SUPPORT SLIDE MEAT SAVOR SXS 42/48 L 30 PK SUPPORT DRAWER MEAT SAVOR 42/48 L MEAT SAVOR LID/DOOR AR/BM36 32 PK SHELF MEATSAVOR AR/BM PK DUCT MEATSAVOR REAR AR PK DUCT MEATSAVOR LEFT 35 M SCREW-SM 36 PK COVER LIGHT Page 2 of 18

3 DFRB536 : SEALED SYSTEM ASSEMBLY [2/9] Page 3 of 18

4 DFRB536 : SEALED SYSTEM ASSEMBLY [2/9] Ref # Part Number Qty. Description 1 PB INSULATION TUBING C LABEL-COMP WARN DAMPER-TUBING.8 4 F TUBE SUCTION AR 36 5 F TUBE DISCHARGE FORMED AF AR 36 6 F TUBE-PROCESS GRN 7 PM COMPRESSOR VCC 8 PD SCREW-SM 9 PD SCREW - SHLDR 10 PE POWER SUPPLY 24 VDC 15 W 11 M CLIP-CORD RED 12 M SCREW - SHLDR GROMMET RUBBER V TUBE-PROCESS GRN 15 M SCREW-SM 16 PE SWITCH POWER 17 G ASM AR SABBATH MODE RELAY 18 M SPLICE TAP 19 K BRACKET GRILLE SUPPORT 20 K PANEL BRACKET INVERTER COMPRESSOR 22 PF LABEL WARNING INVERTER 23 PE JUMPER FAN RESISTOR RING,LOK,.187 DIA 25 PB TUBE CAPILLARY ASM AR K DIVERTER AIR HI SIDE PC HINGE ASSEM UPPER LH 28 PM DRIER - HIGH SIDE HEX SCREW TUBE DRIER COND. 31 F TUBE PROCESS CLIP-DRIER V PB CONDENSER ASM 34 A GASKET-FOAM VA G COND. FAN ASSY NI PK VALVE POP UP ASM Page 4 of 18

5 DFRB536 : CONTROL ASSEMBLY [3/9] Page 5 of 18

6 DFRB536 : CONTROL ASSEMBLY [3/9] Ref # Part Number Qty. Description 1 PF TECH LITERATURE LABEL K CONTROL BOX TOP 3 M NUT-SPEED, VM PD SCREW-SM 5 K BRACKET SWITCH POWER 6 PC POP RIVET 7 K CONTROL BOX 8 PE HARNESS CONTROL BOARD 9 K BRACKET - PC 10 M CLIP-CORD VM FILM,PROTECTIVE 12 M SUPPORT POWER CONTROL BOARD ASM 14 PE HARNESS HIGH VOLT 15 PE HARNESS LOW VOLT 16 PE BOARD LOW VOLTAGE 17 PD TYPE AB NO.6 X 3/8 PH PAN HD. SMS 18 PC POP RIVET SUPP-CONT PANEL 20 K CONTROL BOX FRONT 21 PK PANEL CONTROL AR 36 L OVERLAY SWITCH AR PE SWITCH 24 M SCREW-SHLDR 25 M SCREW-SM 26 A BUSHING-SNAP VA M SUPPORT 28 A GASKET, RED Page 6 of 18

7 DFRB536 : EXTERIOR ASSEMBLY [4/9] Page 7 of 18

8 DFRB536 : EXTERIOR ASSEMBLY [4/9] Ref # Part Number Qty. Description 1 K OC TOP AF AR 36 2 PD X 3/8 GREEN GROUNDING SCREW 3 PK SIDE TRIM 4 M SCREW-SM SOLID, TOE, GRILLE, 36 AF, AR, BM P01 4 NYLON FLAT WASHER V40370P01 7 M SCREW-E SM VENT, TOE, GRILLE, 36 AF, AR, R NI VENT, TOE, GRILLE, 36 AF, AR, L NI GRILLE,TOE,ASM,36 AF,AR,R NI GRILLE,TOE,ASM,36 AF,AR,L Page 8 of 18

9 DFRB536 : LOW SIDE ASSEMBLY [5/9] Page 9 of 18

10 DFRB536 : LOW SIDE ASSEMBLY [5/9] Ref # Part Number Qty. Description 1 PM EVAPORATOR AR PD SCREW-SM 3 G DRAIN PAN ASM UPPER AR36 4 PM MS HEAT EXCH ASM AR PD SRW-8(A)X3/8PH.WFR HD 7/16DIAXNICL 6 PK PAN DRAIN LOWER EVAP AR CLAMP-TUBE V PK DRAIN VERTICAL AR PB TUBE CAPILLARY ASM AR M CLIP-CORD VM F TUBE EVAP AR 36 Page 10 of 18

11 DFRB536 : AIR HANDLING ASSEMBLY [6/9] Page 11 of 18

12 DFRB536 : AIR HANDLING ASSEMBLY [6/9] Ref # Part Number Qty. Description 1 L COVER EVAP AR COVER, EVAP, ASM, AIR, HDLG, AR, 36 3 PD SCR WH HEX WSHR HD SLTD NO.8-18 X 1/2 4 PD WASHER FLAT NYLON NO.10 5 PB /4 X 1/2 CLOSED CELL SPONGE 6 PD SCREW-SM 7 K ANGLE UPR EVAP MNT AR PE FAN EVAP HORIZ AF AR 30 9 PD TYPE AB NO.6 X 3/8 PH PAN HD. SMS 10 B SPACER FAN AR 36/30 11 K BRKT, FAN MTG RT AR GROMMET-VIBRATION 13 M SCREW-SHLDR 14 L WH 1 COVER SUMP UPPER AR L WH 1 COVER SUMP LOWER AR B RIVET-W POP 17 K PLATE TAP LWR EVAP CVR AR L DIVIDER AIR AR K BRKT, FAN MTG LT AR M SCREW-SM 21 C THERMISTOR Page 12 of 18

13 DFRB536 : LOWER UNIT ASSEMBLY [7/9] Page 13 of 18

14 DFRB536 : LOWER UNIT ASSEMBLY [7/9] Ref # Part Number Qty. Description 1 PD STAND OFF LOCK CLIP 2 F SERPENTINE CONDENSER DRAIN 3 PK PAN DRAIN 4 PE PAN HEATER 5 L WH 1 TRAY PAN HEATER 6 K BRACKET CONDENSATE SUPPORT 7 M CLIP-CORD RED AXIAL FAN 9 PD SCR SLTD HEX WSHR HD 8X1.250 BT 10 A BUSHING-SNAP VA M CLIP-CORD VM PM LEVELER ASSEMBLY - R 13 PD SCREW-SM 14 K BRKT GRILLE SUPPORT 15 PE FLOAT SWITCH HORIZONTAL 16 M SCREW-TF 17 B BRACKET HORIZ FLOAT SWITCH 18 A BUSHING-SNAP VA K SHIELD BOTTOM DRAIN 20 PC BAR-WC BOT HINGE LH 21 M SCREW-TC 22 PD BUSHING SWITCH,GRILLE,MT,LH 24 PE SWITCH SPST NC BLACK 25 PM LEVELER MODULE L 26 K BRKT GRILLE SUPPORT 27 PC SPRING EXTENSION 28 M SCREW - SHLDR 29 PD ROUND SPRING SPACER 30 PD BUSHING - WC DOOR LEVEL 31 PD BUSHING - DOOR STOP 32 PC PLATE - WC DOOR SHIM 33 PC PIN - DOOR STOP 34 PC HINGE PLATE SXS LL HEX SCREW 36 PC POP RIVET Page 14 of 18

15 DFRB536 : MC COVER AND UPPER GRILLE ASSEM [8/9] Page 15 of 18

16 DFRB536 : MC COVER AND UPPER GRILLE ASSEM [8/9] Ref # Part Number Qty. Description 1 K MC BACK 36 2 K SUPPORT MC Z 3 G MC COVER COMPLETE ASM 4 K MC TOP 36 5 PC POP RIVET 6 PB MC INSULATION - BACK SIDE 7 K MC SIDE R 8 PD SCREW-SM 9 A GASKET-FOAM VA A BUSHING-SNAP VA PB INSULATION MC COVER 12 K CROSSMEMBER PSM PM COVER - END CAP M SCREW-SM 15 PM ENP CAP GRILLE R 16 M SCREW-SM 17 PK BRACKET GRILLE 18 PM GRILLE LOUVER LOWER AF AR 36 L DES FOL 18 PM GRILLE LOUVER LOWER AF AR 36 R DES FOL 19 PM GRILLE LOUVER MID AF AR 36 DES FOL 20 M SCREW-TC 21 PM SUPPORT GRILLE PM GRILLE LOUVER UPPER AF AR 36 DES FOL 23 K BRACKET GRILLE SUPPORT L 24 PM END CAP GRILLE L 25 PD SCR LAG 5/16-9 GX 5/16X7/16 WAF IHXW 3 S ZN 26 PD BEARING SLEEVE 27 K BRACKET PSM 28 K MC SIDE L NI GRILLE ASM, 36 AF/AR, FOL LH NI G GRILLE ASM 36 FOL R Page 16 of 18

17 DFRB536 : DOOR ASSEMBLY [9/9] Page 17 of 18

18 DFRB536 : DOOR ASSEMBLY [9/9] Ref # Part Number Qty. Description DAIRY MODULE ASSY 2 G DOOR BIN ASM FF 36 BM AND AR HALF 3 G DOOR BIN ASM FF 36 BM AND AR FULL DOOR FOAM ASM AR 36 5 PF LABEL FOL DOOR BOW BRACKET,PNL,FULL OVERLAY 7 PD STRIKER DOOR SWITCH 8 M SCREW-SM 9 PD TORX HEAD SCREW 10 PC PIVOT PL ASM LH LW FOL 11 PC PIVOT PL ASM LH UP FOL GASKET,ASM,36,AFAR NI DOOR ASM COMPLETE AF AR 36 FOL L Page 18 of 18