Rotary Dropper. Universal Friction Feeder. Mechanical Components Guide

Transcription

1 Rotary Dropper Universal Friction Feeder

2 Part Number: /Rev. A (November, 2002) 2002 Streamfeeder, LLC. All rights reserved. No part of this publication may be reproduced, photocopied, stored on a retrieval system, or transmitted without the express written consent of Streamfeeder, LLC. Streamfeeder and Universal Friction Feeders are registered trademarks, and Reliant is a trademark of Streamfeeder, LLC. Streamfeeder, LLC 103 Osborne Road Minneapolis, MN USA TEL: FAX: service@streamfeeder.com WEB: Printed in the USA.

3 Contents Section 1: Mechanical Components...3 Right Hand Side Plate Assembly... 4 Left Hand Side Plate Assembly... 6 Dual Cover Assembly... 8 Creel Wheel Assembly Material Stop Assembly Spring Hold Down Assembly Knock Down Assembly Motor Assembly ST Accessory Box Top Protect Cover Sheet Back Stop Assembly Warranty Streamfeeder Rotary Dropper Universal Friction Feeders i

4 ST ROTARY DROPPER 115V MECHANICAL COMPONENTS DIAGRAM PART NUMBER QTY DESCRIPTION NUMBER 1 1 Right-Hand Side Plate Assembly 2 1 Left-Hand Side Plate Assembly 3 1 Dual Cover Assembly 4 1 Creel Wheel Assembly 5 1 Material Stop Assembly 6 1 Spring Hold Down Assembly 7 1 Knock Down Assembly 8 1 Motor Assembly 9 1 ST Accessory Box Right Side Extension Rail Left Side Extension Rail Top Protect Cover Short (To replace existing on ST1250) 13 1 Stop Back Lever Adjustable Ratchet 1/ NS 1 Pulley, Timing 24XL KDFA (To replace existing on ST1250) NS 1 Belt, Timing 180XL (To replace existing on ST1250) 2 Streamfeeder Rotary Dropper Universal Friction Feeders

5 Mechanical Components Rotary Dropper Mechanical Components Streamfeeder Rotary Dropper Universal Friction Feeders 3

6 ROTARY DROPPER 1: RIGHT HAND SIDE PLATE ASSEMBLY DIAGRAM PART NUMBER QTY DESCRIPTION NUMBER Right Hand Side Plate Belt Tensioner Adjustment Block Support Slide Bar Belt Tensioner Shaft Ball Bearing R Grip Ring 3/ SHCS S/S x 3/ SHCS x 5/ Bracket Medium Knob x 7/16" BHCS S/S X 3/8 LG Foot Pad Acorn Nut Rubber Foot SHCS 8/32 X 1/2" Streamfeeder Rotary Dropper Universal Friction Feeders

7 Diagram 1 Rotary Dropper Right Hand Side Plate Assembly Streamfeeder Rotary Dropper Universal Friction Feeders 5

8 ROTARY DROPPER 2: LEFT HAND SIDE PLATE ASSEMBLY DIAGRAM PART NUMBER QTY DESCRIPTION NUMBER Left Hand Side Plate Support Slide Bar Proximity Sensor W/Nuts Sensor Bracket Cord Grip Safety Switch Spring Load Key Nylock Nut SHCS S/S x 3/ SHCS S/S x 1/ Bracket Foot Pad Acorn Nut Rubber Foot SHCS 8-32 X 1/ BHCS X 3/8 LG Medium Knob, 3 Lobe 1dia X 7/ SHCS x 3/ #10 Flat Washer Streamfeeder Rotary Dropper Universal Friction Feeders

9 Diagram 2 Rotary Dropper Left Hand Side Plate Assembly Streamfeeder Rotary Dropper Universal Friction Feeders 7

10 ROTARY DROPPER 3: DUAL COVER ASSEMBLY DIAGRAM PART NUMBER QTY DESCRIPTION NUMBER Electrical Service Cover Creel Service Cover Cover Pivot Shaft Emergency Stop Button Emergency Stop Legend Switch Block & Base E Stop, NC BHCS x 3/ Creel Cover Pivot Sleeve Electrical Cover Pivot Sleeve Creel Wheel Guard Nylock Nut BHCS X 1/ NS 2 Label Pinch Point NS 1 Name Plate, Serial Number 8 Streamfeeder Rotary Dropper Universal Friction Feeders

11 Diagram 3 Rotary Dropper Dual Cover Assembly Streamfeeder Rotary Dropper Universal Friction Feeders 9

12 ROTARY DROPPER 4: CREELWHEEL ASSEMBLY DIAGRAM PART NUMBER QTY DESCRIPTION NUMBER Creel Wheel Creel Shaft Creel Washer Interior Creel Spacer Exterior Creel Spacer Flight Wheel Outboard Bearing Holder Ball Bearing R Lock Nut, Flanged 5/ Pulley, Drive Timing 60XLO Drive Belt 220XLO E Clip 1/ Set Screw, x 3/8 Brass Tip Set Screw, 8-32 x 1/4 Brass Tip Streamfeeder Rotary Dropper Universal Friction Feeders

13 Diagram 4 Rotary Dropper Creel Wheel Assembly Streamfeeder Rotary Dropper Universal Friction Feeders 11

14 ROTARY DROPPER 5: MATERIAL STOP ASSEMBLY DIAGRAM PART NUMBER QTY DESCRIPTION NUMBER Material Stop Stop Strike Plate Small Stop Cushion Support (Large Material) Large Stop Cushion Support (Small Material) Upper Stop Mounting Bracket Lower Material Stop Mounting Bracket Rubber Pad #10 Flat Washer SHCS x 3/ BHCS x 3/ O-Ring Cover Supports Streamfeeder Rotary Dropper Universal Friction Feeders

15 Diagram 5 Rotary Dropper Material Stop Assembly Streamfeeder Rotary Dropper Universal Friction Feeders 13

16 ROTARY DROPPER 6: SPRING HOLD DOWN ASSEMBLY DIAGRAM PART NUMBER QTY DESCRIPTION NUMBER Spring Hold Down Mount Spring Hold Down Adjustment Indicator Spring Hold Down BHCS x 3/ #10 Flat Washer SHCS S/S x 1/ Streamfeeder Rotary Dropper Universal Friction Feeders

17 Diagram 6 Rotary Dropper Spring Hold Down Assembly Streamfeeder Rotary Dropper Universal Friction Feeders 15

18 ROTARY DROPPER 7: KNOCK DOWN ASSEMBLY DIAGRAM PART NUMBER QTY DESCRIPTION NUMBER Deflector Mount Inside Deflector Plate Outside Deflector Plate BHCS x 3/ #10 Washer Medium Knob 3 Lobe 1dia X 7/ Streamfeeder Rotary Dropper Universal Friction Feeders

19 Diagram 7 Rotary Dropper Knock-Down Assembly Streamfeeder Rotary Dropper Universal Friction Feeders 17

20 ROTARY DROPPER 8: MOTOR ASSEMBLY DIAGRAM PART NUMBER QTY DESCRIPTION NUMBER Electrical Cubical Motor Mount Stand-of f Motor Mount Extension Drive Motor 1/2 Keyed Cable Interconnect 5 Foot O-Ring Cover Support Drive Timing Pulley 16XLO Set Screw X 1-1/ See Fig 4, item Rubber Grommet Ground Screw X 3/ Nylock Nut X 1/8 Set Screw Streamfeeder Rotary Dropper Universal Friction Feeders

21 Diagram 8 Rotary Dropper Motor Assembly Streamfeeder Rotary Dropper Universal Friction Feeders 19

22 ROTARY DROPPER 9: ST ACCESSORY BOX DIAGRAM PART NUMBER QTY DESCRIPTION NUMBER Box Control Control Box Cover Insert 7mm Square Cam Latch Lock Graphic Harness Receptacle Interconnect IQ Box Module, AC Power Entry w/o Fuses DPDT Fuse 3.15A250V Slo-Blo Type 218 5x20mm Cycle Button Assembly Accessory Box Cable Communication DB9 Female IQ Box Power Pack, Transformer/DC Supply Assy IQ Nut, Nyloc Screw, PHMSPH 6-32 X 3/ Tie, Cable Black 435SO263 Connector, Power Supply J Connector, Pins Power Supply, Switching 5V& 12V 2.5X Terminal Female Sheathing #0 HP Black Plate Mount Terminal Disconnect Female Ga Wire 18 Ga Lt Blue Stranded UL Wire 18 Ga Brown Stranded UL Terminal Disc Female AWG Transformer, (ST/Reliant) Power 380VA Streamfeeder Rotary Dropper Universal Friction Feeders

23 ROTARY DROPPER 9: ST ACCESSORY BOX (continued) DIAGRAM PART NUMBER QTY DESCRIPTION NUMBER Bracket Mounting CPU Board Board CPU w/96 Pin Connector Deflector Plate Fan Assy STBox Board Stepper Drive BLD NS 2 Bolts, U Square Bend 3 3/8" NS 1 Plate Mounting IQuipped Box NS 2 Retainer Mounting IQuipped Box NS 1 Gasket V Model NS 1 Power Cord, 15 VAC IEC 3 Prong Grounded V Model NS 1 Power Cord, Cont. Europe 230V 10-A NS 1 ST Rotary Dropper Mode (EPROM 128K) NS 1 Cable Null Modem Comm 6Ft DB9M-M Streamfeeder Rotary Dropper Universal Friction Feeders 21

24 ROTARY DROPPER 9: ST ACCESSORY BOX (continued) DIAGRAM PART NUMBER QTY DESCRIPTION NUMBER NS 1 Key 7mm Square NS 1 Harness Drive Control NS 1 Harness Power Supply DC Outputs Streamfeeder Rotary Dropper Universal Friction Feeders

25 Streamfeeder Rotary Dropper Universal Friction Feeders 23

26 ROTARY DROPPER 12: TOP PROTECTCOVER SHORT DIAGRAM PART NUMBER QTY DESCRIPTION NUMBER Top Protect Cover Short Assembly (to replace existing on ST 1250) Key Interlock BHCS 8-32 x 1/ Nyloc Nut Warning Label Streamfeeder Rotary Dropper Universal Friction Feeders

27 (Assembled View) Diagram 12 Top Protect Cover Short Assembly Streamfeeder Rotary Dropper Universal Friction Feeders 25

28 ROTARY DROPPER 13: BACK STOP ASSEMBLY DIAGRAM PART NUMBER QTY DESCRIPTION NUMBER Stop Back (for ST 1250) Mount Back Stop (for ST 1250) FHS x 1/ #10 Nylock Nut Streamfeeder Rotary Dropper Universal Friction Feeders

29 Diagram 13 Back Stop Assembly Streamfeeder Rotary Dropper Universal Friction Feeders 27

30 Notes 28 Streamfeeder Rotary Dropper Universal Friction Feeders

31 Warranty STREAMFEEDER LIMITED WARRANTY Streamfeeder, LLC (Streamfeeder) warrants this product to be free from defects in materials and workmanship, when used under recommended operating conditions, for a period of one year from the date of original retail purchase. If you discover a defect during the warranty period, please notify the authorized Streamfeeder distributor from whom you purchased this product, who will make repairs at no charge to you. If the defect is not field-repairable, and if you return it to Streamfeeder during the warranty period, Streamfeeder will, at its sole option, repair or replace this product, at no charge to you other than shipping charges to and from the Streamfeeder facility in Minneapolis, Minnesota. If you return this product to Streamfeeder for warranty repair or replacement, please attach to the returned product your name and your company s name, address, telephone number and fax number; a description of the problem; and a copy of the bill of sale or invoice that shows the appropriate serial number for the product. All returns must be accompanied by an authorized Streamfeeder Returned Goods Authorization (RGA) number. An authorized RGA number can be obtained from Streamfeeder Sales/Service Department. This warranty applies only to products manufactured by Streamfeeder. This warranty does not apply if the product has been damaged by accident, abuse, misuse, neglect, improper maintenance, misapplication, or as a result of being attached to equipment not supplied by Streamfeeder; if the product has been modified without the written permission of Streamfeeder; or if the product s serial number has been removed or defaced. This warranty further does not apply to the failure of any rubber-based or consumable components including, but not limited to, O rings, rollers, feed belts, fuses, or bulbs. ALL IMPLIED WARRANTIES INCLUDING WITHOUT LIMITATION THE IMPLIED WARRANTY OF FITNESS FOR A PARTICULAR PURPOSE AND THE IMPLIED WARRANTY OF MERCHANTABILITY ARE HEREBY DISCLAIMED. Streamfeeder is not responsible for special, incidental, or consequential damages resulting from any breach of warranty or under any other legal theory, including lost profits, downtime, goodwill, or damage to or replacement of equipment or property. This warranty and the remedies set forth above are exclusive and are in lieu of all others, oral or written, express or implied. There are no warranties that extend beyond the description on the face hereof. No Streamfeeder employee, distributor, or agent is authorized to make any modification, extension, or addition to this warranty.

32 2002 Streamfeeder, LLC Printed in the USA. 103 Osborne Road Minneapolis, MN USA TEL: FAX: WEB: