Product Specification

Size: px
Start display at page:

Download "Product Specification"

Transcription

1 PRODUCT RELEASE Date: November 05 Description: OME Suspension System Application: L00 Mitsubishi MQ Triton Part No. & Barcode : Refer To Application Sheets Fitting: Hours Product Specification Aftermarket WD suspension is extremely complex. Determining the right solution for your vehicle and your requirements demands special attention to many factors. Unlike numerous after market suspension systems, which are only available in a single configuration targeting lift height, OME offers a range of tuned and matched integrated suspension systems to ensure the right suspension is available to suit how the vehicle is outfitted and the conditions it will encounter. The OME engineer s objective was to develop an integrated suspension system for the Mitsubishi MQ Triton. The key areas that were considered were lift, load carrying and comfort. With limited opportunity for lift increases due to factory geometry constraints, particular focus was given to ride comfort and control. Although some components were carry over from the previous model the OME engineers took the opportunity to reassess the complete suspension system with the major changes to leaf spring design and a new strut and tune. Mitsubishi Triton MQ 05 on - OME Suspension System - 5

2 Front Suspension: Springs Four spring options were chosen to cater for No Bar, Bar, Bar/Winch and Bar/Winch/ Accessories vehicle setups. With additional front accessories now available such as under body protection, recovery points, side rails, dual batteries etc a fourth coil option has been added to cater for the additional load these accessories provide. Factory geometry allowed for a 5mm lift to be achieved as the amount of down travel is limited by the front control arm droop stop. Struts An extensive development and tuning project was undertaken to correctly match the ride quality to the spring rate and resulted in front strut options depending on spring selection. Improved tuning has resulted in a more comfortable ride while maintaining excellent control in both on road and off road applications. Rear Suspension: Springs A 0mm lift was achieved and chosen to slightly reduce the large amount of factory rake with the original suspension set up. With a large payload capacity, the factory leaf spring design was orientated towards load carrying and at times affected the ride quality. The OME engineers have developed a range of 3 springs and an extra leaf to improve ride quality and cater for different loading options. Medium loads (0kg to GVM, optimal performance at loads of 0-300kg) Constant 300kg (300kg to GVM, optimal performance at loads of kg) Constant 600kg (600kg to GVM, optimal performance at loads of 600kg plus) Shock Absorbers To provide comfort, control and to cater for the three spring options, three new tuned and matched absorbers were developed. Rear length was increased by 0mm to improve wheel travel. Please note rear part number 600 is specifically targeted towards very heavily loaded vehicles and is best suited for constant rear loads in excess of 800kg Shackles and Bushes As the new leaf spring design is 60mm wide where previous model was 70mm wide, a new greasable shackle and bush kit was developed for ease of servicing and ensuring longevity of bushes. Mitsubishi Triton MQ 05 on - OME Suspension System - 5

3 Specifications: Shocks/Struts Nitrocharger Sport Part Number Coils Open Length (mm) Closed Length (mm) Upper Mount Bush Kit Part Number Original Kit Bushes only Lower Mount Bush Kit Part Number Original Kit Bushes only N/A N/A N/A N/A N/A N/A SMP73 N/A N/A SMP73 N/A N/A Spring Part Number X5K Steel Bar Dia. Mm Free Height Coil Spring Rate mm No. of Weight turns A B kg Lbf/in N/mm OE Spring Rate Lbs 30 X X X X Leaf Springs Eye Diameter Primary Spring Stack Spring Rate No. of mm Weight Free Part Height Leaves (kg) Camber Number (mm) Front Rear mm Lbf/in N/mm EL086R /368 35/65 EL087R /398 /70 EL088R /558 65/98 Mitsubishi Triton MQ 05 on - OME Suspension System 3-5

4 Product Availability: Product Part Number Barcode Coil Spring Coil Spring Coil Spring Coil Spring Leaf Spring EL086R Leaf Spring EL087R Leaf Spring EL088R Extra Leaf ELXL Strut Sport Strut Sport Strut Top Hat Kit OMETH Upper Strut bushes OME Greasable Shackle Kit OMEGS Spring Bush Kit OMESB U bolts OMEU U bolts OMEU53A Mitsubishi Triton MQ 05 on - OME Suspension System - 5

5 PAGE MITSUBISHI TRITON MQ ALL X MODELS FRONT Estimated Lift: 5mm PART NUMBER QTY SPRING: NO BAR SPRING: BAR SPRING: BAR / WINCH SPRING: BAR / WINCH / ACCESSORIES UPPER STRUT BUSHES STRUT TOP HAT KIT OME3 OMETH00 REAR Estimated Lift: 0mm ALL MODELS PART NUMBER QTY SPRING: MEDIUM LOAD SPRING: CONSTANT 300KGS SPRING: CONSTANT 600KGS GREASABLE SHACKLE KIT SPRING BUSH KIT U BOLTS EL086R 6038 EL087R 6039* / 6038 EL088R 600* / 6039 OMEGS3 OMESB3 OMEU53 OMEU53A 3 5 EXTRA LEAF ELXL 6 REMARKS: No top mounting bushes supplied use OME339. OE bushes may be re-used if in good condition. No dirt shield supplied, please re-use OE 3 Strut Top Hat Kit OMETH00 may be required if original equipment is worn Shock absorber 600 is suited for constant rear loading in excess 800kg OMESB3 suits OE Shackle and OME Greasable Shackle, OMEGS3 5 6 Use OMEU53 when fitting EL086R Use OMEU53A when fitting EL087R and EL088R ELXL will give approximately 0mm extra list or increase loading capacity at design height by approximately 00KGS. ARB EUROPE Na Dlouhém č.80, DC 5 0 Říčany - Jažlovice Czech Republic t F W arbeurope.com Mitsubishi Triton MQ 05 on - OME Suspension System 5-5

Product Specification

Product Specification PRODUCT RELEASE Date: October 2015 Description: Old Man Emu Suspension System Application: Nissan Navara NP300 Part No. & Barcode: Refer table page 4 Price: Refer to application sheets page 5 (Including

More information

Product Specification

Product Specification PRODUCT RELEASE Date: May 06 Description: Old Man Emu Suspension System Application: 06+ Toyota Tacoma Part No. & Pricing Refer To Application Table Availability Date: May 06 Product Specification Aftermarket

More information

PRODUCT SPECIFICATION

PRODUCT SPECIFICATION DATE: December 2014 DESCRIPTION: Old Man Emu Suspension System APPLICATION: Ford F250/350 2011+ Ford F250/350 2008 to 2010 PART NO. : Refer to Application PRICING: Refer to Page 5 & 6 AVAILABILITY DATE:

More information

OLD MAN EMU SUSPENSION SELECTOR

OLD MAN EMU SUSPENSION SELECTOR OLD MAN EMU SUSPENSION SELECTOR TOYOTA LANDCRUISER/PRADO 70 SERIES 2007 on 79 SERIES DUAL CAB V6 PETROL - INTERNATIONAL NO BULL BAR / LIGHT OR ALLOY BULL BAR The Toyota LandCruiser 79 Series Dual Cab is

More information

Product Specification

Product Specification PRODUCT RELEASE Date: May 06 Description: OME BP-5 High Performance Bypass Shock Absorbers Application: 005-05 Toyota Tacoma 06+ Toyota Tacoma Part No. & Pricing : Refer To Application Table Currently

More information

TOYOTA LANDCRUISER 70 SERIES LANDCRUISER 79 SERIES I LANDCRUISER 76 SERIES I LANDCRCRUIER 78 SERIES

TOYOTA LANDCRUISER 70 SERIES LANDCRUISER 79 SERIES I LANDCRUISER 76 SERIES I LANDCRCRUIER 78 SERIES TOYOTA LANDCRUISER 70 SERIES LANDCRUISER 79 SERIES I LANDCRUISER 76 SERIES I LANDCRCRUIER 78 SERIES COMPANY OVERVIEW ARB Corporation Ltd. is Australia s leading developer, manufacturer and exporter of

More information

Product Specification

Product Specification PRODUCT RELEASE Date: March 2016 Description: OME BP-51High Performance Bypass Shock Absorbers Application: Toyota Hilux 2015 on Part No. : Refer to Table Price: Refer to Table (Including VAT7%, excluding

More information

A B N P. I. B. # 353 P a g e 1 5

A B N P. I. B. # 353 P a g e 1 5 Date: April 2017 Description: ARB Classic Plus Canopy Application: Mitsubishi L200/ Triton MQ Dual Cab 2015+ Part No. & Barcode: Refer table page 4 & 5 Product Group: 122 Smooth Classic Canopy Plus Fitting:

More information

MITSUBISHI MQ L200 AND FIAT FULLBACK Suspension Installation Instructions

MITSUBISHI MQ L200 AND FIAT FULLBACK Suspension Installation Instructions INSTALLATION GUIDE MITSUBISHI MQ L200 AND FIAT FULLBACK 2015+ Suspension Installation Instructions NOTE: Occupational Health & Safety procedures must be observed at all times. IMPORTANT: Installations

More information

PRODUCT SPECIFICATIONS. Product Specification SRS AIRBAG AS ADR. Description: Toyota Hilux StealthBar

PRODUCT SPECIFICATIONS. Product Specification SRS AIRBAG AS ADR. Description: Toyota Hilux StealthBar PRODUCT SPECIFICATIONS Description: Toyota Hilux StealthBar Part No. SA190BL190 (Non Winch) SA190BL191 (Winch) Application: Toyota HiLux 2015+ Models Availability Date in Europe: December 2018 PROUDLY

More information

Product Specification

Product Specification PRODUCT RELEASE Date: November 2015 Description: ARB Summit Bar Application: Toyota Hilux 2015 on Wide Body 4x4 and 4x2 Hi Rider Part No. & Barcode : 3414530-9332018040718 Product Group: 010 Bull Bars

More information

ARB DELUXE BULL BARS & WINCH BARS YEAR MODEL FEATURES WINCHES PART NO. TO 1992 BULL BAR NON WINCH ALL WINCH BAR 9000LB, 12XE ,2

ARB DELUXE BULL BARS & WINCH BARS YEAR MODEL FEATURES WINCHES PART NO. TO 1992 BULL BAR NON WINCH ALL WINCH BAR 9000LB, 12XE ,2 ARB DELUXE BULL BARS & WINCH BARS YEAR MODEL FEATURES WINCHES PART NO. TO 99 BULL BAR NON WINCH 6080 ALL WINCH BAR 9000LB, XE 460, IPF LIGHTING & ACCESSORIES YEAR ALL ALL Coil Spring Models RECOMMENDED

More information

triton To suit: Triton 4wd on MN, ML Coil over Frt, MK T/Bar Frt, MJ T/Bar Frt 4WD

triton To suit: Triton 4wd on MN, ML Coil over Frt, MK T/Bar Frt, MJ T/Bar Frt 4WD triton Since 1950 Pedders has been designing and manufacturing suspension products specifically for Australian conditions to ensure your vehicle is always performing at its best. That s why at Pedders

More information

OLD MAN EMU. Designed for superior performance over all types of terrain.

OLD MAN EMU. Designed for superior performance over all types of terrain. OLD MAN EMU Designed for superior performance over all types of terrain. 90-91 OLD MAN EMU SHOCKS AND SUSPENSION Few products can transform the performance and ability of a 4WD like a vehicle specific

More information

1. SPECIFICATIONS 2. WHEEL ALIGNMENT

1. SPECIFICATIONS 2. WHEEL ALIGNMENT 441101 083 1. SPECIFICATIONS Front Suspension Rear Suspension Description Suspension type Spring type Shock absorber type Stabilizer bar type Suspension type Spring type Shock absorber type Stabilizer

More information

PRODUCT SPECIFICATION

PRODUCT SPECIFICATION DATE: September 2015 DESCRIPTION: OME BP-51 High Performance Bypass Shock Absorbers APPLICATION: Jeep JK Wrangler PART NO. : Refer Table below PRICE: Refer Table below PRODUCT GROUP: Refer Table below

More information

PRODUCT SPECIFICATION

PRODUCT SPECIFICATION DATE: June 2015 DESCRIPTION: OME BP-51 High Performance Bypass Shock Absorbers APPLICATION: Toyota Hilux 2005 on Toyota Landcruiser 200 Series 2007 on PART NO. : Refer Table Page 2 PRICE: Coil over Assembly

More information

Product Specification

Product Specification PRODUCT RELEASE Date: July 2016 Description: ARB Summit Bull Bar Application: Toyota Landcruiser 200 Series MY16 VX and Sahara only Part No. & Barcode : 3215210-9332018043399 Product Group: 010 Bull Bars

More information

CONTENTS 2 SHOCK ABSORBER & STEERING STABILISER APPLICATIONS... GUIDE TO SELECTION..

CONTENTS 2 SHOCK ABSORBER & STEERING STABILISER APPLICATIONS... GUIDE TO SELECTION.. CONTENTS PAGE GUIDE TO SELECTION.. & STEERING STABILISER APPLICATIONS... SUSPENSION APPLICATIONS CHRYSLER... 9 FORD.... HOLDEN / ISUZU / GM.. 5 HONDA... 9 HYUNDAI.... 9 KIA.. 0 LADA NIVA. 0 LAND ROVER......

More information

ARB s engineers have designed and developed a Summit Bull Bar to suit the GX and GXL models of the recently released MY Series.

ARB s engineers have designed and developed a Summit Bull Bar to suit the GX and GXL models of the recently released MY Series. PRODUCT RELEASE Date: May 2016 Description: ARB Summit Bull Bar Application: Toyota Landcruiser 200 Series MY16 GX and GXL only Part No. & Barcode : 3215200-9332018042866 Product Group: 010 Bull Bars Fitting:

More information

Product Specification

Product Specification Date: September 2017 Description: ARB Summit Bar Application: Isuzu Dmax 11/16on Part No. & Barcode: 3448530-9332018046598 Product Group: 026 Summit Bull Bars Fitting: 5 Hours Availability Date: Available

More information

Hilux. To suit: Toyota Hilux 05-On 4WD WD WD Leaf Spring WD IFS WD WD

Hilux. To suit: Toyota Hilux 05-On 4WD WD WD Leaf Spring WD IFS WD WD Hilux Since 1950 Pedders has been designing and manufacturing suspension products specifically for Australian conditions to ensure your vehicle is always performing at its best. That s why at Pedders Suspension

More information

A B N P. I. B. # 346 P a g e 1 5

A B N P. I. B. # 346 P a g e 1 5 Date: April 2017 Description: ARB Classic Plus Canopy Application: Chevrolet Colorado Dual Cab 2012+ Part No. & Barcode: Refer table page 4 & 5 Product Group: 122 Smooth Classic Canopy Plus Fitting: 3.5

More information

PRODUCT SPECIFICATION

PRODUCT SPECIFICATION DATE: July 2015 DESCRIPTION: OME BP-51 High Performance Bypass Shock Absorbers APPLICATION: Toyota Hilux - 2005+ Toyota Land Cruiser 200 Series - 2007+ PART NO. : Refer to Table Page 2 PRICE: Coil Over

More information

1. SPECIFICATIONS 2. WHEEL ALIGNMENT Front Suspension. (gas type) Rear Suspension. (gas type)

1. SPECIFICATIONS 2. WHEEL ALIGNMENT Front Suspension. (gas type) Rear Suspension. (gas type) 441101 053 1. SPECIFICATIONS Front Suspension Rear Suspension Description Suspension type Spring type Shock absorber type Stabilizer bar type Suspension type Spring type Shock absorber type Stabilizer

More information

PRODUCT SPECIFICATIONS. Product Specification SRS AIRBAG AS ADR HIC. Publication Date: September, Description: Toyota Prado 150 Smartbar

PRODUCT SPECIFICATIONS. Product Specification SRS AIRBAG AS ADR HIC. Publication Date: September, Description: Toyota Prado 150 Smartbar PRODUCT SPECIFICATIONS Publication Date: September, 2018 Description: Toyota Prado 150 Smartbar Application: Toyota Prado 150 10/2017+ Fitting: Minimum 4 Hours (Non Winch) Minimum 5 Hours (Winch) Refer

More information

TOYOTA HILUX Suspension Installation Instructions. NOTE: Occupational Health & Safety procedures must be observed at all times.

TOYOTA HILUX Suspension Installation Instructions. NOTE: Occupational Health & Safety procedures must be observed at all times. INSTALLATION GUIDE TOYOTA HILUX 2015+ Suspension Installation Instructions NOTE: Occupational Health & Safety procedures must be observed at all times. IMPORTANT: Installations should only be done by a

More information

Part# ZX WD/4WD PRO RUNNER SS Lift PRO COMP SUSPENSION. Suspension Systems that Work!

Part# ZX WD/4WD PRO RUNNER SS Lift PRO COMP SUSPENSION. Suspension Systems that Work! 2360 Boswell Road Chula Vista, CA 91914 Phone 619.216.1444 Fax 619.216.1474 E-Mail tech@explorerprocomp.com PRO COMP SUSPENSION Suspension Systems that Work! Part# 1999-2006 Toyota Tundra 2WD/4WD PRO RUNNER

More information

1 M-3000-H4 F150 4X4 Lowering Kit

1 M-3000-H4 F150 4X4 Lowering Kit READ INSTRUCTIONS COMPLETELY THROUGH BEFORE STARTING. IT IS RECOMMENDED THAT INSTALLATION BE DONE BY A QUALIFIED MECHANIC. REPLACE ALL STOCK PARTS THAT ARE DAMAGED OR WORN. ALWAYS WEAR EYE PROTECTION.

More information

Control Arms. Toyota Tundra 4WD Part#:

Control Arms. Toyota Tundra 4WD Part#: Part#: 128253 Control Arms Toyota Tundra 4WD 2007-2016 Rev. 091117 491 W. Garfield Ave., Coldwater, MI 49036. Phone: 517-279-2135 E-mail: tech-bds@sporttruckusainc.com Read And Understand All Instructions

More information

READ AND UNDERSTAND ALL INSTRUCTIONS AND WARNINGS PRIOR TO INSTALLATION OF SYSTEM AND OPERATION OF VEHICLE.

READ AND UNDERSTAND ALL INSTRUCTIONS AND WARNINGS PRIOR TO INSTALLATION OF SYSTEM AND OPERATION OF VEHICLE. #021700, 021701 7 Suspension System 2000-2004 Chevy/GMC 1500 2wd Extended Cab w/ Front Coil Springs READ AND UNDERSTAND ALL INSTRUCTIONS AND WARNINGS PRIOR TO INSTALLATION OF SYSTEM AND OPERATION OF VEHICLE.

More information

ON Road comfort OFF Road control

ON Road comfort OFF Road control ON Road comfort OFF Road control Shock Absorbers Heavy Duty Coil Springs Leaf Springs Torsion Bars Air Bag Kits Bushes Brakes Skid Plates Straight advice, specialists you understand and... range overview

More information

PRODUCT SPECIFICATION

PRODUCT SPECIFICATION DATE: July 2015 DESCRIPTION: OME BP-51 High Performance Bypass Shock Absorbers APPLICATION: Jeep Wrangler JK 2007+ PART NO. : Refer to Table Page 2 PRICE: Shock Absorber - $510 Vehicle Fit Kits - Refer

More information

SPRINGS. Heavy Duty Coil Springs Leaf Springs Torsion Bars. Straight advice, specialists you understand and...

SPRINGS. Heavy Duty Coil Springs Leaf Springs Torsion Bars. Straight advice, specialists you understand and... SPRINGS Heavy Duty Coil Springs Leaf Springs Torsion Bars Straight advice, specialists you understand and... Springs - The Facts The primary function of springs, whether they be Leaf, Coil or Torsion Bars,

More information

LOAD CARRYING & TOWING SOLUTIONS

LOAD CARRYING & TOWING SOLUTIONS LOAD CARRYING & TOWING SOLUTIONS The place to go before you TOW Shock Absorbers Heavy Duty Coil Springs Leaf Springs Torsion Bars Air Bag Kits Tow Bars & Accessories Bushes Brakes Straight advice, specialists

More information

Control Arms. Chevy WD Part#:

Control Arms. Chevy WD Part#: Part#: 121151 Control Arms Chevy 1500 4WD 2007-2013 Rev. 020518 491 W. Garfield Ave., Coldwater, MI 49036. Phone: 517-279-2135 E-mail: tech-bds@sporttruckusainc.com Read And Understand All Instructions

More information

2. Remove front wheels.

2. Remove front wheels. Read all instructions before beginning work. Following instructions in the proper sequence will ensure the best and easiest installation. Thank you for purchasing Maximum Motorsports Caster/Camber Plates.

More information

Superlift Leveling System / 6 Upgrade System for 2004 and Newer Ford F-150 4WD INSTALLATION INSTRUCTIONS

Superlift Leveling System / 6 Upgrade System for 2004 and Newer Ford F-150 4WD INSTALLATION INSTRUCTIONS FORM #9905.02-032907 PRINTED IN U.S.A. PAGE 1 OF 7 INTRODUCTION Superlift 0.5-2 Leveling System / 6 Upgrade System for 2004 and Newer Ford F-150 4WD INSTALLATION INSTRUCTIONS Installation requires a professional

More information

High-Performance Leaf Springs for Commercial Vehicles New Generation Design

High-Performance Leaf Springs for Commercial Vehicles New Generation Design ARISTOTLE UNIVERSITY OF THESSALONIKI LABORATORY OF MACHINE ELEMENTS & MACHINE DESIGN G. Savaidis, M. Malikoutsakis MAN TRUCK & BUS SA Chr. Ertelt, F. Schwaiger High-Performance Leaf Springs for Commercial

More information

5.5 Gas & 6 Diesel Radius Arm Suspension System. Dodge Ram WD Pickup Dodge Ram WD Pickup

5.5 Gas & 6 Diesel Radius Arm Suspension System. Dodge Ram WD Pickup Dodge Ram WD Pickup Part#: 012610 5.5 Gas & 6 Diesel Radius Arm Suspension System Dodge Ram 3500 4WD Pickup 2013-17 Dodge Ram 2500 4WD Pickup 2014-17 491 W. Garfield Ave., Coldwater, MI 49036. Phone: 517-279-2135 Web: www.bds-suspension.com.

More information

pedders.com.au Pedders / 1

pedders.com.au Pedders / 1 pedders.com.au Pedders / 1 SportsRyder Few companies have played such a significant role in the manufacture of aftermarket performance suspension and brake components like Pedders. Since the 1950 s, Pedders

More information

CONTENTS CONTENTS. NISSAN RESOURCES FORD

CONTENTS CONTENTS.     NISSAN RESOURCES FORD v18 FIT GUIDE CONTENTS USING THE RIDEPRO CATALOGUE Pages in this catalogue have been laid out in the simplest form and require the fitter to carry out a proper assessment of a vehicle to ensure correct

More information

2.5 & 4.5 Rear Coil Spring & 2.5 Spacer Kits. Dodge 2500 Pickup Part#: , ,

2.5 & 4.5 Rear Coil Spring & 2.5 Spacer Kits. Dodge 2500 Pickup Part#: , , Part#: 012259, 012258, 012458 2.5 & 4.5 Rear Coil Spring & 2.5 Spacer Kits Dodge 2500 Pickup 2014 Rev. 040915 491 W. Garfield Ave., Coldwater, MI 49036. Phone: 517-279-2135 Web/live chat: www.bds-suspension.com.

More information

05-07 F250 6 SUSPENSION KIT

05-07 F250 6 SUSPENSION KIT 92159300 Stabilizer Drop Brackets Track Bar Bracket Control Arm Bracket Brake Line Drop Bracket Sway Bar Link Ext. Hardware Bags Pitman Arm 6111 Add-a-leaf 6578 3 Block and U-Bolt Kit 05-07 F250 6 SUSPENSION

More information

SUSPENSION 2-1 SUSPENSION TABLE OF CONTENTS

SUSPENSION 2-1 SUSPENSION TABLE OF CONTENTS DN SUSPENSION 2-1 SUSPENSION TABLE OF CONTENTS page ALIGNMENT... 1 FRONT SUSPENSION - 4x2... 6 page FRONT SUSPENSION - 4x4... 14 REAR SUSPENSION... 23 ALIGNMENT TABLE OF CONTENTS page AND OPERATION WHEEL

More information

Installation Instructions

Installation Instructions Installation Instructions Eibach Springs, Inc. 264 Mariah Circle Corona, California 92879-1751 USA Tech Support 800-222-8811 Ext 114 Eibach Multi-Pro R1 Coilovers - #6049.712 2008-2009 Mitsubishi Lancer,

More information

»Product» Safety Warning

»Product» Safety Warning C2402, C2602 Installation Instructions 2007-2013 Chevy 1/2 Ton 2wd Pickup 4.5", 6.5" Suspension System Read and understand all instructions and warnings prior to installation of product and operation of

More information

SHACKLE INSTALLATION INSTRUCTIONS

SHACKLE INSTALLATION INSTRUCTIONS SHACKLE INSTALLATION INSTRUCTIONS Read and understand all instructions, warnings, cautions, and notes in this sheet and in your owners manual before you begin the installation of this shackle kit. Proper

More information

prado > touring > expedition > outback

prado > touring > expedition > outback prado Since 1950 Pedders has been designing and manufacturing suspension products specifically for Australian conditions to ensure your vehicle is always performing at its best. That s why at Pedders Suspension

More information

Silverado 2500HD 2WD & 4WD 8 Lug 2-1/2 Front Torsion Key Kit w/ 1-1/2 Rear Block

Silverado 2500HD 2WD & 4WD 8 Lug 2-1/2 Front Torsion Key Kit w/ 1-1/2 Rear Block PRO COMP SUSPENSION 63161K 2011-2015 Silverado 2500HD 2WD & 4WD 8 Lug 2-1/2 Front Torsion Key Kit w/ 1-1/2 Rear Block This document contains very important information that includes warranty information

More information

4, 6 Suspension System. Ford F250/350 4WD Part#: ,

4, 6 Suspension System. Ford F250/350 4WD Part#: , Part#: 013411, 013611 4, 6 Suspension System Ford F250/350 4WD 2005-2007 Rev. 071917 491 W. Garfield Ave., Coldwater, MI 49036. Phone: 517-279-2135 E-mail: tech-bds@sporttruckusainc.com Read And Understand

More information

SECTION 2C FRONT SUSPENSION TABLE OF CONTENTS

SECTION 2C FRONT SUSPENSION TABLE OF CONTENTS SECTION 2C FRONT SUSPENSION TABLE OF CONTENTS Description and Operation... 2C-2 Front Suspension... 2C-2 Specifications... 2C-4 Component Locator... 2C-5 Front Suspension Assembly... 2C-5 Cross-Sectional

More information

Installation Instructions

Installation Instructions Installation Instructions Eibach Springs, Inc. 264 Mariah Circle Corona, California 92879-1751 USA Tech Support 800-222-8811 Ext 114 Eibach Pro Street-S Coilovers - #28110.711 2011-13 Dodge Challenger

More information

Control Arms. Toyota Tacoma 4WD Part#:

Control Arms. Toyota Tacoma 4WD Part#: Part#: 128252 Control Arms Toyota Tacoma 4WD 2005-2016 Rev. 090817 491 W. Garfield Ave., Coldwater, MI 49036. Phone: 517-279-2135 E-mail: tech-bds@sporttruckusainc.com Read And Understand All Instructions

More information

PN# PLT Toyota Tacoma/ Toyota Tundra/ Toyota 4- Runner/ Toyota Sequoia 2WD & 4WD Spacer Kit

PN# PLT Toyota Tacoma/ Toyota Tundra/ Toyota 4- Runner/ Toyota Sequoia 2WD & 4WD Spacer Kit 2360 Boswell Road Chula Vista, CA 91914 Phone 619.216.1444 Fax 619.216.1474 E-Mail tech@explorerprocomp.com PRO COMP SUSPENSION Suspension Systems that Work! PN# 1996-2004 Toyota Tacoma/ 1996-2006 Toyota

More information

»Product» Safety Warning

»Product» Safety Warning #J1200 Installation Instructions 1987-1995 Jeep Wrangler YJ 2" Suspension Lift Read and understand all instructions and warnings prior to installation of product and operation of vehicle. Zone Offroad

More information

patrol To suit: > touring > expedition > outback

patrol To suit: > touring > expedition > outback KITS patrol 1997-on Y61 GU, 1999-on, Ute (Leaf), 1997-on Y61 GU, 1997-on, Wagon Petrol and Diesel, 4/99 GU Cab- Chassis Coils F & R, 91-99 Y60 GQ Ute Coils F & R, 1988- Y60 GQ & GQII, 1988-1997 Ute (Leaf),

More information

INTERNATIONAL APPLICATION CATALOGUE NUMBER JULY 2012

INTERNATIONAL APPLICATION CATALOGUE NUMBER JULY 2012 INTERNATIONAL APPLICATION CATALOGUE NUMBER 8 JULY 0 OME Features SPORT SHOCK ABSORBERS LARGE BORE 5MM TWIN TUBE DESIGN - Allows greater oil volume for cooling and sustained valving performance and strong.6mm

More information

ETKA :28 JEM Model. Restrictions. Illustration. Year EPIS 200. et_bild.frm

ETKA :28 JEM Model. Restrictions. Illustration. Year EPIS 200. et_bild.frm -0 3:8 et_bild.frm -0 3:8 Pos Part Number Name Remarks Qty track control arm suspension wheel bearing housing front ABA,ACC,AAZ, AHU H0 5 track control arm 9 75 retainer plate (3) + N 0 77 06 bolt, hex.

More information

Pedders Load Carrying and Towing Solutions pedders.com.au

Pedders Load Carrying and Towing Solutions pedders.com.au Pedders Load Carrying and Towing Solutions pedders.com.au Pedders / 1 Load Carrying & Towing Solutions A vehicle s suspension and brakes are designed to provide optimum handling and comfort under a normal

More information

2.5, 3.5 & 5 Rear Air Ride Lift Systems. Dodge 2500 Pickup Part#: , ,

2.5, 3.5 & 5 Rear Air Ride Lift Systems. Dodge 2500 Pickup Part#: , , Part#: 012257, 012359, 012529 2.5, 3.5 & 5 Rear Air Ride Lift Systems Dodge 2500 Pickup 2014-16 Rev. 101016 491 W. Garfield Ave., Coldwater, MI 49036. Phone: 517-279-2135 Web/live chat: www.bds-suspension.com.

More information

"Engineered to Ride, Built to Last "

Engineered to Ride, Built to Last Congratulations on your purchase of an Arnott air suspension product. We at Arnott Incorporated are proud to offer a high quality product at the industry s most competitive pricing. Thank you for your

More information

2216 (STOCK) / 2224 (3 LOWER) 2WD SPORT SWAY BAR SET 97-UP DODGE DAKOTA INSTALLATION OF HOTCHKIS PERFORMANCE FRONT SWAY BAR

2216 (STOCK) / 2224 (3 LOWER) 2WD SPORT SWAY BAR SET 97-UP DODGE DAKOTA INSTALLATION OF HOTCHKIS PERFORMANCE FRONT SWAY BAR 2216 (STOCK) / 2224 (3 LOWER) 2WD SPORT SWAY BAR SET 97-UP DODGE DAKOTA Thank you for your purchase from our line of Dodge Dakota & Durango suspension parts. Please call us at (877) 4NO-ROLL if you have

More information

NOVEMBER 2009 UPDATE CATALOGUE

NOVEMBER 2009 UPDATE CATALOGUE NOVEMBER 009 UPDATE international APPLICATION CATALOGUE NUMBER OME FEATURES SPORT SHOCK ABSORBERS LARGE BORE 5MM TWIN TUBE DESIGN - Allows greater oil volume for cooling and sustained valving performance

More information

PRODUCT BROCHURE. Straight advice, specialists you understand and...

PRODUCT BROCHURE. Straight advice, specialists you understand and... PRODUCT BROCHURE Shock absorbers PEDDERS STEERING EQUIPMENT Pedders Shock Absorbers Replacement, Sports, Towing, Load Carrying & 4WD Bilstein Shock Absorbers Replacement Shocks to suits European Makes

More information

PN# 64660K Nissan Frontier/ Xterra Suzuki Equator 2WD/4WD 2 1/2 Front & 1 1/2 Rear Spacer Kit PRO COMP SUSPENSION

PN# 64660K Nissan Frontier/ Xterra Suzuki Equator 2WD/4WD 2 1/2 Front & 1 1/2 Rear Spacer Kit PRO COMP SUSPENSION 2360 Boswell Road Chula Vista, CA 91914 Phone 619.216.1444 Fax 619.216.1474 E-Mail tech@explorerprocomp.com PRO COMP SUSPENSION Suspension Systems that Work! PN# 64660K 2005-2011 Nissan Frontier/ Xterra

More information

Ford Passenger Cars Mustang II Independent Front Suspension Installation Instructions

Ford Passenger Cars Mustang II Independent Front Suspension Installation Instructions 1935-1948 Ford Passenger Cars Mustang II Independent Front Suspension Installation Instructions 1-866-925-1101 www.totalcostinvolved.com The installation of the Total Cost Involved's Mustang Independent

More information

(877) MON-FRI 7AM-5PM PST OR WEBSITE: ReadyLIFT.COM **Please retain this document in your vehicle at all times**

(877) MON-FRI 7AM-5PM PST OR   WEBSITE: ReadyLIFT.COM **Please retain this document in your vehicle at all times** IF YOUR ReadyLIFT PRODUCT IS MISSING A OR HAS A DAM- AGED PART, PLEASE CONTACT CUSTOMER SERVICE DIRECTLY. For warranty issues please return to the place of installation and contact ReadyLIFT. A NEW REPLACEMENT

More information

700 Pine Ridge Road Golden CO Tel (303) (888) 4X4 SLEE Fax (303)

700 Pine Ridge Road Golden CO Tel (303) (888) 4X4 SLEE Fax (303) 700 Pine Ridge Road Golden CO 80403 Tel (303) 278 8287 1(888) 4X4 SLEE Fax (303) 278 7182 2005+ Toyota Tacoma OME Suspension Kit - Installation Instructions Qty Part Included Tools/ Materials Suggested

More information

»Product» Safety Warning

»Product» Safety Warning D1402 Installation Instructions 2013-14 Ram 3500, 2014 Ram 2500 4.5" Replacement Radius Arm Suspension Lift Read and understand all instructions and warnings prior to installation of product and operation

More information

1988 Chevrolet Pickup V SUSPENSION - FRONT (4WD)' 'Front Suspension - "V" Series 1988 SUSPENSION - FRONT (4WD) Front Suspension - "V" Series

1988 Chevrolet Pickup V SUSPENSION - FRONT (4WD)' 'Front Suspension - V Series 1988 SUSPENSION - FRONT (4WD) Front Suspension - V Series 1988 SUSPENSION - FRONT (4WD) Front Suspension - "V" Series DESCRIPTION NOTE: Vehicle serial numbers used in this article has been abbreviated for common reference to Chevrolet and GMC models. Chevrolet

More information

Superduty Coilover Conversion. Ford F-150/ F-350 Superduty 4WD Part#:

Superduty Coilover Conversion. Ford F-150/ F-350 Superduty 4WD Part#: Part#: 123612 Superduty Coilover Conversion Ford F-150/ F-350 Superduty 4WD 2005-2016 Rev. 011018 491 W. Garfield Ave., Coldwater, MI 49036. Phone: 517-279-2135 Web: www.bds-suspension.com. E-mail: tech-bds@sporttruckusainc.com

More information

UNIBODY/FRAME/WHEEL ALIGNMENT II ABCT 2212

UNIBODY/FRAME/WHEEL ALIGNMENT II ABCT 2212 UNIBODY/FRAME/WHEEL ALIGNMENT II ABCT 2212 A. Course Description Credits: 6.00 Lecture Hours/Week: 1.00 Lab Hours/Week: 5.00 OJT Hours/Week: 0 Prerequisites: None Corequisites: None MnTC Goals: None This

More information

Sports Ryder Coil Spring Suits models from 07/2007 with a spring seat

Sports Ryder Coil Spring Suits models from 07/2007 with a spring seat Make Model Year &/or Code Model Var Description 2002 2008, BA & BF incl Mk2 Sedan 8/02 03/08 Part Number Description Comment / Installation Directions 1 Coil Over Kits [Full Car] 160022 Extreme XA Coilover

More information

SUSPENSION 2-1 SUSPENSION TABLE OF CONTENTS

SUSPENSION 2-1 SUSPENSION TABLE OF CONTENTS XJ SUSPENSION 2-1 SUSPENSION TABLE OF CONTENTS page ALIGNMENT... 1 FRONT SUSPENSION... 7 page REAR SUSPENSION... 16 ALIGNMENT TABLE OF CONTENTS page AND WHEEL ALIGNMENT...1 DIAGNOSIS AND TESTING SUSPENSION

More information

Part # Lincoln Level 2 Air Suspension Package

Part # Lincoln Level 2 Air Suspension Package 350 S. St. Charles St. Jasper, In. 47546 Ph. 812.482.2932 Fax 812.634.6632 www.ridetech.com Part # 12060299 64-69 Lincoln Level 2 Air Suspension Package Front Components: 1 12060999 CoolRide Kit 1 12060601

More information

BAG 3 (2) 2.25 x 1 Sleeves (4) 1/4 Nylock Nuts (4) 1/4 x 2 Bolts (4) 3/8 Nylock Nuts (4) 3/8 Flat Washers (2) 3/8 U-Bolts

BAG 3 (2) 2.25 x 1 Sleeves (4) 1/4 Nylock Nuts (4) 1/4 x 2 Bolts (4) 3/8 Nylock Nuts (4) 3/8 Flat Washers (2) 3/8 U-Bolts INSTALLATION INSTRUCTIONS PART # DESCRIPTION 799 Lincoln Ave. Riverside, CA 90 Phone: 9.689.ICON Fax: 9.689.06 90 00+ RAPTOR REAR BUMPSTOP SYSTEM ** READ ALL INSTRUCTIONS THOROUGHLY FROM START TO FINISH

More information

Part # PLF Ford F250-F550 4WD Coil Spacer Kit PRO COMP SUSPENSION. Suspension Systems that Work!

Part # PLF Ford F250-F550 4WD Coil Spacer Kit PRO COMP SUSPENSION. Suspension Systems that Work! 2360 Boswell Road Chula Vista, CA 91914 Phone 619.216.1444 Fax 619.216.1474 E-Mail tech@explorerprocomp.com PRO COMP SUSPENSION Suspension Systems that Work! Part # 2005-2008 Ford F250-F550 4WD Coil Spacer

More information

Installation Instructions

Installation Instructions Installation Instructions Product: ACOS Pro Part Number: PN 2700 Applications: Jeep Wrangler TJ, 1997-06 (front or rear) Jeep Grand Cherokee ZJ, 1993-98 (front only) Jeep Cherokee XJ, 1984-01 (front only)

More information

Installation Instructions

Installation Instructions Installation Instructions Eibach Springs, Inc. 264 Mariah Circle Corona, California 92879-1751 USA Tech Support 800-222-8811 Ext 114 Eibach Pro Street-S Coilovers - #2895.711 2009 Dodge Challenger, R/T,

More information

US Patent You will find many features that set our Caster/Camber Plates apart from the rest.

US Patent You will find many features that set our Caster/Camber Plates apart from the rest. 3430 Sacramento Dr., Unit D San Luis Obispo, CA 93401 Telephone: 805/544-8748 Fax: 805/544-8645 www.maximummotorsports.com US Patent 6485223 Read all instructions before beginning work. Following instructions

More information

Part # CHEVY 2500 HD 4WD STEERING STABILIZER KIT PRO COMP SUSPENSION. Suspension Systems that Work!

Part # CHEVY 2500 HD 4WD STEERING STABILIZER KIT PRO COMP SUSPENSION. Suspension Systems that Work! 2360 Boswell Road Chula Vista, CA 91914 Phone 619.216.1444 Fax 619.216.1474 E-Mail tech@explorerprocomp.com PRO COMP SUSPENSION Suspension Systems that Work! Part #226010 2011-2012 CHEVY 2500 HD 4WD STEERING

More information

CONTENTS. RESOURCES FORD FOTON GREAT WALL HOLDEN ISUZU LANDROVER

CONTENTS.   RESOURCES FORD FOTON GREAT WALL HOLDEN ISUZU LANDROVER Fit Guide v16 CONTENTS RESOURCES Competition ROX Shocks 8 Strut Assemblies (pre-assembled) 6 Warranty Claim Form 111 Warranty Registration Form 110 FORD 1987 on Courier/Raider 9 2015 on Everest 10 1988-94

More information

»Product» Safety Warning

»Product» Safety Warning J1455, J1456 Installation Instructions 1984-2001 Jeep Cherokee XJ 4.5 Suspension Lift Read and understand all instructions and warnings prior to installation of product and operation of vehicle. Zone Offroad

More information

eurotechnik autoteile Technical Information Manual

eurotechnik autoteile Technical Information Manual eurotechnik autoteile Technical Information Manual 1 Common Fitting Tips KYB, the world s largest supplier of shock absorbers to vehicle manufacturers, shares some technical tips and advice on handling

More information

SCION xb LOWERING SPRINGS Preparation

SCION xb LOWERING SPRINGS Preparation Preparation Part Number: PTR07-52080 Kit Contents Item # Quantity Reqd. Description 1 2 Front Springs 2 2 Rear Springs 3 1 Instruction Form Hardware Bag Contents Item # Quantity Reqd. Description 1 2 3

More information

Jeep Wrangler (JK)

Jeep Wrangler (JK) 89109 Rev B Suspension Systems RS66109BR5 and RS66109BR9 2007 2013 Jeep Wrangler 4 Door Sport and Rubicon Models (2 SPORT SYSTEM) Jeep Wrangler (JK) 2007-2013 89109 Rev B READ ALL INSTRUCTIONS THOROUGHLY

More information

Installation Instructions

Installation Instructions Installation Instructions Product: ACOS Pro Part Number: PN 2710 Application: Jeep Wrangler JK, 2007+ (front only) Important MOST VEHICLES REQUIRE additional parts or modifications to accommodate the immediate

More information

PN# Toyota Tundra 2wd/4wd Sequoia 2wd/4wd 3 Front Spacer PRO COMP SUSPENSION. Suspension Systems that Work!

PN# Toyota Tundra 2wd/4wd Sequoia 2wd/4wd 3 Front Spacer PRO COMP SUSPENSION. Suspension Systems that Work! 2360 Boswell Road Chula Vista, CA 91914 Phone 619.216.1444 Fax 619.216.1474 E-Mail tech@explorerprocomp.com PRO COMP SUSPENSION Suspension Systems that Work! This document contains very important information

More information

6 Suspension System. Dodge wd Part#:

6 Suspension System. Dodge wd Part#: Part#: 012622 6 Suspension System Dodge 2500 4wd 2009-2013 Rev. 010218 491 W. Garfield Ave., Coldwater, MI 49036. Phone: 517-279-2135 E-mail: tech-bds@sporttruckusainc.com Read And Understand All Instructions

More information

4 Suspension System. Ford Super Duty 4WD Part#:

4 Suspension System. Ford Super Duty 4WD Part#: Part#: 013414 4 Suspension System Ford Super Duty 4WD 2017 Rev. 092617 491 W. Garfield Ave., Coldwater, MI 49036. Phone: 517-279-2135 E-mail: tech-bds@sporttruckusainc.com Read And Understand All Instructions

More information

4 & 6 4-Link Suspension System. Dodge Ram 3500 Pickup 4WD Dodge Ram 2500 Pickup 4WD Part#: ,

4 & 6 4-Link Suspension System. Dodge Ram 3500 Pickup 4WD Dodge Ram 2500 Pickup 4WD Part#: , Part#: 012414, 012604 4 & 6 4-Link Suspension System Dodge Ram 3500 Pickup 4WD 2013-2016 Dodge Ram 2500 Pickup 4WD 2014-2016 Rev. 032417 491 W. Garfield Ave., Coldwater, MI 49036. Phone: 517-279-2135 E-mail:

More information

pedders.com.au ON Road comfort OFF Road control Pedders / 1

pedders.com.au ON Road comfort OFF Road control Pedders / 1 ON Road comfort OFF Road control Suspension Kits Spring & Shock Combo Kits Shock Absorbers Coil Springs Leaf Springs Torsion Bars 4 Lift Kits GVM Upgrade Kits Air Bag Kits Bushes Brake Upgrades Skid Plates

More information

»Product» Safety Warning

»Product» Safety Warning D1402 Installation Instructions 2013-14 Ram 3500, 2014 Ram 2500 4.5" Replacement Radius Arm Suspension Lift Read and understand all instructions and warnings prior to installation of product and operation

More information

»Product» Safety Warning

»Product» Safety Warning D1201 Installation Instructions 2013 Dodge Ram 3500 4WD 2014 Dodge Ram 2500 4WD Leveling Kit D1201 Read and understand all instructions and warnings prior to installation of product and operation of vehicle.

More information

COBB SPORT SPRINGS

COBB SPORT SPRINGS 915760 - COBB SPORT SPRINGS 2008-2013 Subaru WRX/STi Congratulations on your purchase of the COBB Sport Springs for your 2008-2013 Subaru WRX/STi. The following instructions will assist you through your

More information

Read and understand all instructions and warnings prior to installation of system and operation of vehicle.

Read and understand all instructions and warnings prior to installation of system and operation of vehicle. 491 W. Garfield Ave., Coldwater, MI 49036 Phone: 517-279-2135 Web/live chat: www.bds-suspension.com E-mail: tech@bds-suspension.com Part#: 023624 Product: 4 & 6" Suspension System Application: 2009-2013

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Product: ACOS Pro Part Number: JKS2711 INSTALLATION INSTRUCTIONS Applications: Wrangler JL, 2018 (front only) 517-278-1226 jks@sporttruckusainc.com www.jksmfg.com 491 W. Garfield Avenue, Coldwater, MI

More information

»Product» Safety Warning

»Product» Safety Warning #J1302, J1303 Installation Instructions 1984-2001 Jeep XJ 3 Front Coil Spring/Rear Leaf Spring Lift Read and understand all instructions and warnings prior to installation of product and operation of vehicle.

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS 1075 North Ave. Sanger, CA 93657-3539 local: 559-875-0222 fax: 559-876-2259 toll free: 800-445-3767 av1075 North Ave Sanger, CA 93657-3539 local: 559-875-8883 fax: 559-875-9883

More information