INSTALLATION INSTRUCTIONS

Size: px
Start display at page:

Download "INSTALLATION INSTRUCTIONS"

Transcription

1 Accessory Application Publication No. INSTALLATION INSTRUCTIONS HEATED GRIPS P/N 08T72-MGH-N12 VFR1200X/XD Honda Dealer: Please give a copy of these instructions to your customer. MII Issue Date March 2016 PARTS LIST SYSTEM DIAGRAM (3) (2) (1) (10) Bl MAIN 30A BATTERY 2P Identify wire colors : Bl : Black Bu : Blue Br : Brown G : Green Gr : Gray R : Red Y : Yellow W : White V : Violet (4) R R R/Bl (8) R/Bl STOP/TAIL/METER FUSE 15A IGNITION SWITCH (9) HEATER SWITCH HEATER CONTROLLER (5) (6) (7) 4P 10P No. Description Qty Bl/Br Gr Bu G (1) Right heated grip 1 (2) Left heated grip 1 (3) Heater controller 1 (4) Suspension 1 (5) Clip band [Not used.] 6 METER 20P 33P Y/V Bl G W G (6) Wire tie (narrow/short) [Not used.] 6 (7) Wire tie (narrow/long) 6 2P 2P (8) Wire tie (wide/short) [Not used.] 6 (9) Wire tie (wide/long) 3 (10) Installation Instruction URL 1 TOOL AND SUPPLIES REQUIRED Flat-tip screwdriver Side Cutters Marker Scale Electrical tape Pro Honda Handgrip Cement Thread lock Grease Isopropyl alcohol Shop towel LEFT HEATED GRIP RIGHT HEATED GRIP TORQUE INFORMATION Refer to the Service Manual for the torque values of the removed parts American Honda Motor Co., Inc. - All Rights Reserved. 1 of MGH-H201

2 INSTALLATION CAUTION To prevent burns, allow the engine, exhaust system, radiator, etc., to cool before installing the accessory. Be sure to observe all safety messages and precautions described in the Service Manual while removing and installing the fuel tank. NOTE: When working with lifting the fuel tank, always perform this work with two persons; it is recommended that one person lifts the tank. Disconnect the throttle cable from the right grip as instructed in the motorcycle s Service Manual. For secure adhesion of the heated grip s use the recommended adhesive agent (Pro Honda Handgrip Cement) or equivalent. Be sure to open and close the throttle to check for smooth operation after installation of the right heated grip. Take care not to damage the painted surfaces of the motorcycle. Reinstall the removed parts on the motorcycle and make sure that the wires and harnesses are not pinched. Disconnect the negative (-) cable from the battery before installing this accessory. The memories of the tripmeter and clock will be erased when you disconnect the battery. After reconnecting the battery, refer to the motorcycle Owner s Manual and reset the meter. Trim the excess ends off the wire ties after attaching them to the wire harnesses. Do not allow the cut part of the wire tie to interfere with any harness or brake hose. After this accessory installation, check the lights (e.g. right / left turn signal lights and brake lights) for proper operation. 1. Refer to the Service Manual for the motorcycle, remove the motorcycle parts, and disconnect the negative (-) cable from the battery. SEAT NEGATIVE (-) CABLE 2. Refer to the Service Manual for the motorcycle, remove the motorcycle parts. Repeat on the right side. <Left side> LEFT MIDDLE COWL Do not remove yet. Illustration shows VFR1200XD type another type is similar. CLIP LEFT MIDDLE COWL Do not remove yet. 2 of 16 CLIP Continued

3 LEFT MIDDLE COWL Do not remove yet. 3. Remove the left knee cowl as shown. Repeat on the right side. LEFT KNEE COWL COLLAR (Blue) Disconnect. 4. Remove the dummy connectors. LEFT MIDDLE COWL Remove. If installed, disconnect the Front Foglight (sold seperately) switch connector as shown. Remove the dummy connectors. LEFT MIDDLE COWL HARNESS BOOT 4-PIN WATERPROOF 4-PIN WATERPROOF DUMMY (Save) DUMMY (Save) FOGLIGHT SWITCH HARNESS 4-PIN Disconnect. 3 of 16

4 5. Remove the handguard from the motorcycle s left grip as shown. Repeat on the right side. 8. Using isopropyl alcohol, remove all traces of adhesive from the left handlebar pipe. RUBBER WASHER ISOPROPYL ALCOHOL LEFT HANDLEBAR PIPE LEFT HANDGUARD WASHER 9. Mark the left heated grip harness in the positions shown. 6. Remove the handlebar weight from the left grip as shown. Repeat on the right side. LEFT HEATED GRIP MARKER LEFT HEATED GRIP HARNESS 440 mm 650 mm HANDLEBAR WEIGHT 7. Remove the left grip as shown. LEFT GRIP 10. Apply the Pro Honda Handgrip Cement to the left handlebar as shown. Apply evenly to the whole circumferential surface of the left handlebar. Perform the next step 5 minutes after application. LEFT GRIP (Save) PRO HONDA HANDGRIP CEMENT 100 mm LEFT HANDLEBAR ISOPROPYL ALCOHOL 4 of 16

5 11. Spray isopropyl alcohol over the entire inside of the heated grip and outside of the left handlebar. ISOPROPYL ALCOHOL LEFT HEATED GRIP LEFT HANDLEBAR SWITCH LEFT HANDLEBAR Insert until there is contact with the left handlebar switch, then align with the indicated position. <VFR1200X> LEFT HEATED GRIP LEFT HEATED GRIP 12. Slide the left heated grip onto the left handlebar as indicated. Use an assistant to steady the motorcycle while installing the grips. Wipe up any excess adhesive at once. NOTICE Do not tap on the grip end with a hammer and do not twist the grip to install the heated grip onto the handlebar, as it can damage the element. 7 mm <VFR1200XD> LEFT HEATED GRIP Avoid putting pressure on the switch part when inserting the left heated grip. There is a possibility that the switch part will break. Also, install so that there is no gap with the left handlebar switch. Align. If the grip gets stuck halfway during installation, apply isopropyl alcohol to the gap between the heated grip. Do not try to remove the heated grip using force or a screwdriver, etc. Damage to the heated grip wire can result. Do not touch the left handlebar and turn on the heater switch at least one hour after attachment. 5 of 16

6 13. Remove the left inner panel as shown. Support the unmounted upper cowl securely. 14. Lift the fuel tank up as shown. Hold the lifted fuel tank securely. FLANGE COLLAR COLLAR FUEL TANK Lift up. CLAMP UPPER COWL Support. UPPER COWL STAY Temporarily remove. CLIP BREATHER TUBE Release. DRAIN TUBE Release. 15. Remove the connector from the ECM as shown. 4-PIN WATERPROOF ECM CLIP LEFT INNER PANEL Remove. 2-PIN 6 of 16

7 16. Pull out the ECM as shown. 18. Route the left heated grip harness as shown. ECM LEFT HEATED 17. Route the left heated grip harness as shown. <Left side> MOTORCYCLE S CLAMP (Reuse) LEFT HEATED LEFT HEATED 19. Pass the left heated grip harness as shown. <VFR1200X> LEFT HEATED LEFT HEATED 7 of 16

8 20. Connect the left heated grip harness as shown. 4-PIN WATERPROOF (Black) LEFT HEATED 22. Remove the right grip as shown. NOTE Disconnect the throttle cable from the right grip as instructed in the motorcycle s Service Manual. Do not try to disconnect the cable with force using pliers, etc. (Black) THROTTLE CABLES 21. Remove the screws from the motorcycle as shown. <Right side> RIGHT HANDLE SWITCH HOLDER RIGHT GRIP (Save) 23. Mark the right heated grip harness in the positions shown. GRIP 715 mm 485 mm 125 mm RIGHT HANDLE SWITCH HOLDER SCREW 8 of 16 MARKER

9 24. Wind electrical tape on the marked position as shown. 26. Apply grease to the parts of the throttle cables and inner grip as shown. GRIP GREASE GREASE MARK ELECTRICAL TAPE THROTTLE CABLES 20 mm GRIP INNER GRIP MARK (125 mm) ELECTRICAL TAPE Wind up 2-3 laps centering on the mark. 27. Install the right heated grip and right switch holder in the reverse order of removal. After installation, refer to the Service Manual and adjust the throttle freeplay. 25. Mark the right heated grip harness in the position shown. GRIP ELECTRICAL TAPE GRIP ELECTRICAL TAPE MARKER Mark the center of the electrical tape. 9 of 16

10 28. Open and close the throttle grip as shown. Check that the throttle opens and automatically closes smoothly in any steering position. 30. Route the right heated grip harness as shown. MOTORCYCLE S HARNESS MOTORCYCLE S CLAMP (Reuse) GRIP 29. Route the right heated grip harness as shown. RIGHT HEATED GRIP 31. Route the right heated grip harness as shown. THROTTLE CABLE AIR CLEANER 10 of 16

11 32. Route the right heated grip harness as shown. 34. Remove the dummy connector as shown. AIR CLEANER DUMMY (Save) Remove the connector from the clip band. CLIP BAND 33. Turn up the rubber guard as shown. AIR CLEANER Remove from the clip band. 35. Route the right heated grip harness as shown. RUBBER GUARD Turn up. 11 of 16

12 36. Connect the right heated grip harness as shown. 37. Remove the wire tie and dummy connector. <Right side> Remove the dummy connector. 10-PIN WATERPROOF 10-PIN WATERPROOF DUMMY (Save) RIGHT HEATED GRIP HARNESS Secure the right heated grip harness to the clip band. CLIP BAND 38. Install the suspension as shown. After connecting, secure to the clip band. SUSPENSION HEATER CONTROLLER 12 of 16

13 39. Connect the heater controller as shown. 10-PIN WATERPROOF HEATER CONTROLLER 41. Secure the left heated grip harness using a wire tie as shown. <Left side> HEATER CONTROLLER After connecting, store the heater controller in the motorcycle s stay. WIRE TIE (narrow/long) Secure the left heated grip harness to the motorcycle s harness. LEFT HEATED 42. Secure the left heated grip harness using a wire tie as shown. LEFT HEATED MOTORCYCLE S STAY 40. Secure the right and left heated grip harness using the wire ties as shown. <Front side> WIRE TIE (wide/short) Secure at the mark on the right and left heated grip harness to the motorcycle s harness. MARK (485 mm) MARK (440 mm) WIRE TIE (wide/short) Secure at the mark on the left heated grip harness to the motorcycle s harness. MARK (650 mm) LEFT HEATED 13 of 16

14 43. Secure the right heated grip harness using a wire tie as shown. Check that the throttle opens and automatically closes smoothly in any steering position. <Right side> 45. Secure the right heated grip harness using a wire tie as shown. <Right side> AIR CLEANER WIRE TIE (narrow/long) Bundle the excess right heated grip harness, and secure it to the motorcycle s harness. 5 mm MARK TAPED PART WIRE TIE (narrow/long) Secure the mark on the taped part of the right heated grip harness and the motorcycle s harness. RIGHT HEATED GRIP HARNESS 44. Secure the right heated grip harness using a wire tie as shown. Move the handlebar right and left and check that the harnesses are not pinched by the neighboring components and that they are not pulled taut. <Right side> WIRE TIE (wide/short) Secure at the mark on the right heated grip harness to the motorcycle s harness. 46. Install the rubber guard and fuel tank in the reverse order of removal. 47. Reinstall the handguard as shown. Clean up threads with isopropyl alcohol before applying thread lock. Be sure to apply thread lock to the threads of the bolt. Repeat on the right side. HANDLEBAR WEIGHT (Reuse) RUBBER WASHER (Reuse) MARK (715 mm) (Reuse) LEFT HANDGUARD (Reuse) WASHER (Reuse) THREAD LOCK 3-4 mm THREAD LOCK AREA 5-6 mm (Reuse) 14 of 16

15 48. Check the throttle cables do not to interfere with the handguard as shown. THROTTLE CABLE HANDGUARD 49. Check each harness for sufficient play. Move the handlebar right and left and check that the harnesses are not pinched by the neighboring components and that they are not pulled taut. 50. Install the motorcycle s parts in the reverse order of removal. Confirm that the harness is not caught or too tight. 51. Move the handlebar right and left, and check that this accessory is not interfere with the motorcycle parts. 52. Check the heated grip, throttle, headlight and the other lights for proper operation. Perform the operation check at least one hour after attaching the left heated grip. Do not set the heater level at more than 3 as the adhesive may soften. Make sure to turn off the heater switch after the operation check. Please convey the following information to the customer during delivery. Do not set the heater level higher than 1 for one week after installation to allow the adhesive to fully cure. 15 of 16

16 DEALER TROUBLESHOOTING Stop the engine and turn the ignition switch OFF when you check the parts and circuits other than those of the heated grips. Symptom Meter shows the E of the level display and heater indicator. The level display and heater indicator flashes. Check Check for loose or poor contact in the connectors. Refer to the SYSTEM DIAGRAM of this manual and check for blown fuse. LEVEL DISPLAY HEATER INDICATOR E1 status displayed pattern: Check for E1 status (Low battery voltage) : 1. Check the battery voltage. E2 status displayed pattern: Check for E2 status (Open or short circuit) : 1. Heated grip inspection Check for resistance between the terminals. Standard: <Right> 8.2 ohms +/- 10% / <Left> 8.2 ohms +/- 10% 2. Refer to the SYSTEM DIAGRAM of this manual and check for an open or short circuit in the heated grip related wires. 3. If no abnormality is found after the above checks 1 and 2, but the heated grip still does not operate properly, replace the heated grip (heater controller) with a new one. E3 status displayed pattern: Check for E3 status (Faulty heated grip switch) : 1. Replace the heated grip (heater switch) with a new one. It is hard to check the switch with ordinary inspection methods (for continuity, voltage, etc.) because it contains an integrated circuit. 16 of 16

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS HEATED GRIP ATTACHMENT KIT P/N 08T70-MKA-D80 After 15 NC700X/XD Honda Dealer: Please give a copy of these instructions to your customer.

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS HEATED GRIPS P/N 08T71-MKK-D00 After 17 CRF1000L/LD Honda Dealer: Please give a copy of these instructions to your customer. MII 16656 Issue

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS S ATTACHMENT KIT P/N 08T70-MJW-D90 After 15 CB500X/XA Honda Dealer: Please give a copy of these instructions to your customer. MII 15802

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS ATTACHMENT P/N 08T70-MGZ-D80 CB500X/XA MII 14565 Issue Date May 2013 PARTS LIST KIT Sold separately (1) (2) (4) (2) (1) (3) BOOT (1 piece.)

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS HEATED GRIP ATTACHMENT P/N 08T70-MJE-D00 CBR650F/FA MII 14960 Issue Date April 2014 PARTS LIST HEATED GRIP Sold separately (1) (2) (4) (2)

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS HEATED GRIPS ATTACHMENT KIT P/N 08T70-MJL-D30 2014-2015 NC700X/XD Honda Dealer: Please give a copy of these instructions to your customer.

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory LED FOGLIGHT ATTACHMENT KIT P/N 08V70-MKC-A00 Application GL1800/B/BD/D/DA Honda Dealer: Please give a copy of these instructions to your customer. Publication No. MII

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS NAVI ATTACHMENT P/N 08B70-MJL-D30 NC750X/XA/XD MII Issue Date November 2013 PARTS LIST RELAY SET Sold separately (4) (9) (5) (1) (2) (10)

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS 12V ACCESSORY SOCKET P/N 08U79-MKC-A00 GL1800/B/BD/D/DA Honda Dealer: Please give a copy of these instructions to your customer. MII 16426

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS LED HEADLIGHT P/N 08V71-HL4-A00 SXS1000M3/M3P/M5P Honda Dealer: Please give a copy of these instructions to your customer. MII 15262 Issue

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS P/N 08E86-MKC-A00 GL1800/B/BD/D/DA Honda Dealer: Please give a copy of these instructions to your customer. MII Issue Date September 2017

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory TRUNK INSTALLATION KIT P/N 08L73-MKC-A10ZA Application GL1800B/BD Honda Dealer: Please give a copy of these instructions to your customer. Publication No. MII 16426

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS 3.5 mm AUXILIARY CORD P/N 08A87-MKC-A00 GL1800/D/B/BD GL1800DA (go to page 7) Honda Dealer: Please give a copy of these instructions to your

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS HORN MOUNT P/N 08Z77-HL4-A00 SXS1000M3/M3P/M5D/M5P Honda Dealer: Please give a copy of these instructions to your customer. MII 15262 Issue

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS P/N 08E79-MKC-A00 GL1800/D/DA GL1800B/BD Honda Dealer: Please give a copy of these instructions to your customer. MII 16426 Issue Date January

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS DCT FOOT SHIFTER P/N 08U71-MKC-A00 GL1800BD/D/DA Honda Dealer: Please give a copy of these instructions to your customer. MII 16426 Issue

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS QUICK SHIFTER P/N 08U70-MKJ-D00 CB1000RA Honda Dealer: Please give a copy of these instructions to your customer. MII 16775 Issue Date August

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. MII 13125 CHROME (PIAA) VT1300CR/CT Issue Date P/N 08V31-MFW-100 VT1300CS February 2010 Honda Dealer: Please give a copy of these instructions

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. MII 11775 AUDIO ATTACHMENT KIT P/N 08B08-MEA-100 VTX1300S/R Issue Date October 2006 Honda Dealer: Please give a copy of these instructions

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory LED BRAKE LIGHT P/N 08U76-MKC-A00 Application GL1800/D/DA GL1800B/BD Honda Dealer: Please give a copy of these instructions to your customer. Publication No. MII 16426

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS HOMELINK P/N 08U77-MKC-A00 GL1800/B/BD/D/DA Honda Dealer: Please give a copy of these instructions to your customer. MII 16426 Issue Date

More information

Honda Genuine Accessories

Honda Genuine Accessories Honda Genuine Accessories (NC700S/SA/SD) Sold separately (P/N 08A71-MGS-D10) Applicable model INSTALLATION INSTRUCTIONS Publications No. ---------- NC700X/XA/XD/S/SA/SD Issue Date Honda Dealer: Please

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS WINCH MOUNT P/N 08L73-HL4-F01 After 16 SXS1000M3/M3P/M3LE SXS1000M5P/M5D/M5LE MII 16083 Issue Date February 2017 PARTS LIST No. Description

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS CHROME TRUNK RACK P/N 08L70-MKC-A00 GL1800/D/DA GL1800B/BD Honda Dealer: Please give a copy of these instructions to your customer. MII 16426

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Heated Grips Kit P/N 0ST71-HR3-A00 Application After 13 TRX420 All (except 14 TRX420FA/FPA) After 13 TRX500 All (except 14 TRX500FA/FPA) Honda Dealer: Please give a

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS PARTS LIST Accessory Application Publications No. TRX420 (All) MII 13032 WINCH KIT P/N 08L94-HP5-100 Accessory Weight 35 lbs (16 kg) Honda Dealer: Please give a copy of these

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Honda Dealer: Please give a copy of these instructions to your customer. PARTS LIST (15) (8) (12) (14) (13) (10) (11) (18) (17) (1) Accessory Application Publications No. TRX500FA/FGA

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS PARTS LIST Accessory Application Publications No. MII 13038 GL1800 P/N 08E75-MCA-100K Issue Date November 2009 Honda Dealer: Please give a copy of these instructions to your customer.

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS SADDLEBAG STAY P/N 08L73-MJF-A00ZP CTX700N/ND (Pages 1-6) CTX700/D (Pages 6-11) MII 14476 Issue Date March 2013 PARTS LIST INNER SUPPORT

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS SADDLEBAG P/N 08L70-MGZ-A80 COMMON Honda Dealer: Please give a copy of these instructions to your customer. MII 15802 Issue Date March 2016

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publication No. After 13 TRX420 All MII 15067 KIT (except 14 TRX420FA/FPA) Issue Date P/N 08T71-HR3-A20 After 13 TRX500 All (except 14 TRX500FA/FPA) September

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS P/N 08M70-MJM-D00 VFR800F/D MII 14983 Issue Date June 2014 PARTS LIST (6) (7) (2) (15) (12) (8) TOOLS AND SUPPLIES REQUIRED Socket (12 and

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS QUICK SHIFTER P/N 08U70-MKF-D40 After 16 CBR1000RR/RA Honda Dealer: Please give a copy of these instructions to your customer. MII 16210

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. BII 31129 REARVIEW CAMERA 2006 RL Issue Date OCT 2005 PARTS LIST Attachment Kit P/N: 08B21-SJA-B00 Template Rear camera trim 6-Pin connector

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publication No. PUSH TO TALK SWITCH P/N 08E96-MCA-101B GL1800 MII 13574 Issue Date February 2011 Honda Dealer: Please give a copy of these instructions to

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. ELEMENT AII 33021 Issue Date JULY 2006 PARTS LIST Trailer Hitch Kit P/N 08L92-SCV-101 4 Bolts, 12 x 35 mm Trailer hitch U-bolt 2 Nuts, 8

More information

INSTALLATION INSTRUCTIONS Accessory Application 2010 CR-V Publications No. AII 42592 Issue Date AUG 2009 PARTS LIST Bass Works Attachment kit (sold separately) P/N 08B54-SWA-100 Bass system harness 4 Washer-bolts,

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. CD CHANGER ATTACHMENT KIT 2004 CR-V AII 26118 Issue Date SEP 2003 PARTS LIST CD Changer Attachment Kit (sold separately): P/N 08B26-S9A-100

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 30518 KIT 2006 PILOT Issue Date NOV 2005 NOTE: Accessory ATF and power steering coolers are required when installing the trailer hitch.

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory S P/N 08E10-TP6-100 Application 2010 ACCORD CROSSTOUR Publications No. AII 41935 Issue Date NOV 2009 PARTS LIST TOOLS AND SUPPLIES REQUIRED Ambient Light Kit Ambient

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 43458 XM RADIO SYSTEM 2011 RIDGELINE Issue Date JUNE 2010 PARTS LIST 4 Washer-screws, 5 x 8 mm Attachment Kit: P/N 08B15-SJC-100A 2

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. CASSETTE/MP3/ AII 30664 2006 ACCORD IN-DASH CD 2- AND 4-DOOR Issue Date ATTACHMENT AUG 2005 PARTS LIST cable Attachment Kit (sold separately):

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. XM RADIO SYSTEM 2009 RIDGELINE AII 40319 Issue Date AUG 2008 PARTS LIST 4 Washer-screws, 5 x 8 mm Attachment Kit: P/N 08B15-SJC-100A 2 XM

More information

INSTALLATION INSTRUCTIONS Accessory Application Publications No. All 38163 XM SATELLITE RADIO SYSTEM 2008 ODYSSEY Issue Date OCT 2007 PARTS LIST XM Radio Attachment (sold separately): P/N 08B15-SHJ-100A

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 32459-34084 XM RADIO SYSTEM 2007 RIDGELINE Issue Date NOV 2006 PARTS LIST 4 Washer-screws, 5 x 8 mm Attachment Kit: P/N 08B15-SJC-100A

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. CD CHANGER ATTACHMENT KIT 2005 CIVIC SI AII 27936 Issue Date AUG 2004 PARTS LIST CD Changer Attachment Kit (sold separately): P/N 08B26-S5T-100

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AUTOMATIC AII 27160 2005 CR-V Issue Date ATTACHMENT KIT SEP 2004 PARTS LIST Automatic Day/Night Mirror Attachment Kit (sold separately)

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 27996 ATTACHMENT KIT 2005 CIVIC HYBRID Issue Date AUG 2004 PARTS LIST Changer Attachment Kit: P/N 08B26-S5B-100 4 Washer-screws, 4 x

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS WINCH MOUNT KIT P/N 08L77-HL3-A00 SXS700M4/M2 Honda Dealer: Please give a copy of these instructions to your customer. MII 14607 Issue Date

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory XM RADIO SYSTEM Application 2009 CIVIC 2-AND 4-DOOR (Si) Publications No. AII 40186 Issue Date AUG 2008 PARTS LIST XM Radio Attachment (sold separately): P/N 08B15-SNA-100B

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. All 27176 2005 CR-V Issue Date P/N 08V31-S9A-114 SEP 2004 PARTS LIST 25 Wire ties Left fog light 6 Washer-bolts Right fog light 6 Spring

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory REMOTE CONTROL Application 2012 ODYSSEY (EXCEPT LX) Publications No. AII 46745 Issue Date SEP 2011 PARTS LIST Remote Control Engine Starter Unit Kit P/N 08E91-E22-101A

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 26031 2004 ODYSSEY Issue Date AUG 2003 NOTE: You cannot install the subwoofer in a vehicle equipped with both an under seat Navigation

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory NIGHT Application CR-V Publications No. AII 32951 Issue Date SEP 2006 PARTS LIST Automatic Day/Night Mirror Attachment Kit P/N 08V03-SWA-100 Harness cover set Automatic

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publication No. INSTALLATION INSTRUCTIONS PANNIER SUPPORT STAY P/N 08L71-MJJ-D30 NC700X/XA/XD NC700S/SA/SD NC700D MII Issue Date February 2013 PARTS LIST No. Description Qty (1) (((

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory REMOTE CONTROL Application 2011 ODYSSEY (EXCEPT LX) Publications No. AII 43923 Issue Date SEP 2010 PARTS LIST Remote Control Engine Starter Unit Kit P/N 08E91-E22-101A

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory HITCH Application 2012 CROSSTOUR Publications No. AII 46198 Issue Date JULY 2011 PARTS LIST Trailer Hitch Kit P/N 08L92-TP6-101 Upper spacer A (5 mm) (Some are not used.)

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AUTOMATIC WITH COMPASS 2006 CIVIC HYBRID AII 30315-32247 Issue Date MAY 2006 PARTS LIST Automatic Day/Night Mirror With Compass P/N 08V03-SDA-100B

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. RECOIL STARTER KIT P/N 08U78-HP7-100 TRX420FA/FE/FM/TE/TM TRX420FPA/FPE/FPM Honda Dealer: Please give a copy of these instructions to your

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory REMOTE CONTROL Application 2008 CR-V Publications No. AII 35843-38422 Issue Date DEC 2007 PARTS LIST Caution label Remote Engine Starter Kit P/N 08E91-E22-100B Transmitter

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. XM SATELLITE RADIO SYSTEM (EX) 2008 PILOT All 37110 Issue Date JUN 2007 PARTS LIST XM Radio Attachment (sold separately) P/N 08B15-S9V-100A

More information

INSTALLATION INSTRUCTIONS Accessory Application Publications No. XM RADIO SYSTEM 2006-2008 CIVIC 2- AND 4-DOOR (Si) AII 37662 Issue Date AUG 2007 PARTS LIST XM Radio Attachment (sold separately): P/N 08B15-SNA-100B

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory S P/N 08E12-T2A-100B Application 2014 ACCORD 4-DOOR Publications No. AII 49980 Issue Date AUG 2013 PARTS LIST Right front illuminated door sill trim Fuse label 2 Alcohol

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 37978 XM RADIO SYSTEM 2008 CIVIC HYBRID Issue Date SEP 2007 PARTS LIST XM Radio Attachment (sold separately): P/N 08B15-SNA-100B 7 Wire

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AUTOMATIC PILOT AII 23597 Issue Date MAY 2002 PARTS LIST Automatic Day/Night Mirror Attachment Kit P/N 08V03-S9V-100A Day/night mirror Upper

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 25877 PILOT Issue Date AUG 2003 Optional ATF and power steering coolers are required when installing the trailer hitch. 2 Spacers PARTS

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publication No. SADDLEBAG SUPPORT BRACKETS P/N 08L73-MGS-A30 2012 Only NC700X/XD Honda Dealer: Please give a copy of these instructions to your customer.

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. 2003 ELEMENT AII 24318 Issue Date DEC 2002 PARTS LIST Trailer Hitch Kit P/N 08L92-SCV-100 4 Bolts, 12 x 35 mm Trailer hitch U-bolt 2 Nuts,

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 23642 P/N 08L91-S9V-100 2003 PILOT Issue Date MAY 2002 PARTS LIST Trailer hitch harness 2 Short wire ties 2 Long wire ties Clip Bolt

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. S 1998 CIVIC 2/3/4-DOOR All 18767 Issue Date SEP 1997 PARTS LIST Fog Light Kit: P/N 08V31-S01-100 Right fog light (marked R ) Fuse label

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory XM RADIO SYSTEM Application 2012 RIDGELINE Publications No. AII 12045 Issue Date NOV 2011 PARTS LIST Attachment Kit: P/N 08B15-SJC-100A 4 Flange nuts, 6 mm 4 Washer-screws,

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. CD CHANGER ATTACHMENT KIT ODYSSEY AII 22030 Issue Date AUG 2000 PARTS LIST CD Changer Attachment Kit: P/N 08B12-S0X-100 Right side rail

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. All 30528 INTERFACE 2006 CR-V Issue Date SEP 2005 PARTS LIST XM Radio Unit Kit (sold separately): P/N 08A15-EX5-000 2 Wire tie with clips

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. XM RADIO SYSTEM 2006 CIVIC 4 DOOR (EX) AII 30852 Issue Date JAN 2006 PARTS LIST XM Radio Attachment (sold separately): P/N 08B15-SNA-100A

More information

PRELIMINARY INSTALLATION INSTRUCTIONS. 8 Wire ties. PARTS LIST CD Changer Attachment Kit (sold separately): P/N 08B26-S9V-100A

PRELIMINARY INSTALLATION INSTRUCTIONS. 8 Wire ties. PARTS LIST CD Changer Attachment Kit (sold separately): P/N 08B26-S9V-100A INSTALLATION INSTRUCTIONS Accessory Application Publications No. ATTACHMENT KIT (LX) 2006 PILOT All 30489 Issue Date SEP 2005 PARTS LIST CD Changer Attachment Kit (sold separately): P/N 08B26-S9V-100A

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 24307 SYSTEM 2003 ELEMENT Issue Date DEC 2002 NOTE: An optional keyless entry system (sold seperately) must be installed before you

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. BASS SYSTEM ATTACHMENT 2009 CIVIC 4-DOOR (DX, LX, EX) All 40126 Issue Date AUG 2008 PARTS LIST Bass Speaker System Attachment Kit (sold

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory REMOTE CONTROL Application 2012 CR-V Publications No. AII 12085 Issue Date DEC 2011 PARTS LIST Remote Control Engine Starter Unit Kit P/N 08E91-E22-101A Accessory User

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 27367 HITCH 2005 ODYSSEY Issue Date DEC 2004 NOTE: An optional heavy-duty power steering cooler, ATF cooler and air duct are required

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. MII 12455 DIGITAL METER KIT MUV700 P/N 08E80-HL1-100 Issue Date July 2008 Honda Dealer: Please give a copy of these instructions to your

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory XM RADIO SYSTEM Application 2013 CIVIC 2 AND 4-DOOR Publications No. AII 13055 Issue Date NOV 2012 PARTS LIST XM Radio Attachment Kit P/N 08B15-TR0-100 Bus cable Clip

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. / IN-DASH (LX) 005 PILOT AII 806 Issue Date SEP 004 PARTS LIST Cassette Player (sold separately): P/N 08A03-5B-050 In-Dash CD Changer (sold

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory S P/N 08V31-SWA-100 Application 2009 CR-V Publications No. AII 40437 Issue Date AUG 2008 PARTS LIST Switch Right fog light Relay Left fog light Bracket Fog light harness

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publication No. WINCH MOUNT P/N 08L74-HR3-A20 After 13 TRX420 (All except TRX420FA/FPA) After 13 TRX500 (All except TRX500FA/FPA) MII 15067 Issue Date Revised:

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. in- ENTERTAINMENT SYSTEM 2004 TSX BII 24811 Issue Date APRIL 2003 PARTS LIST Attachment Kit P/N 08B23-SDA-101A Monitor bracket harness FM

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory NIGHT Application 2007 CR-V Publications No. Issue Date SEP. 2006 PARTS LIST Automatic Day/Night Mirror Attachment Kit P/N 08V03-SWA-300 Harness cover set Automatic

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. XM RADIO SYSTEM (EXCEPT LX) 2006 ODYSSEY All 30392 Issue Date AUG 2005 PARTS LIST XM Radio Attachment (sold separately): P/N 08B15-SHJ-100

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory REMOTE CONTROL Application 2014 TSX (L4) Publications No. BII 50198 Issue Date SEPT 2013 PARTS LIST Remote Engine Starter Unit Kit P/N 08E91-TK4-200A Fuse label Transmitter

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. BII 25830 2004 MDX Issue Date SEP 2003 PARTS LIST 2 Clips Trailer Hitch Kit: P/N 08L92-S3V-200A Receiver cover Trailer hitch Harness Kit:

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. ELEMENT AII 24282 Issue Date DEC 2002 PARTS LIST 2 Screw-grommets CD Changer Attachment Kit: P/N 08B26-SCV-100 CD changer plate 2 Self-tapping

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application 2010 RDX Publications No. BII 41807 Issue Date JULY 2009 PARTS LIST 2 Bolts, 12 x 40 mm Trailer Hitch Kit P/N 08L92-STK-200A Trailer hitch Hitch pin Ball

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publication No. MII 15249 WINCH MOUNT KIT P/N 08L70-HL3-A41 SXS700/M4/M2 Issue Date September 2015 PARTS LIST No. Description Qty (1) Winch bracket 1 (2)

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory REMOTE CONTROL Application 2013 ACCORD 2 AND 4-DOOR Publications No. AII 13039 Issue Date AUG 2012 PARTS LIST Remote Engine Starter Unit Kit P/N 08E91-E54-100 Transmitter

More information

INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 38133-38406 HITCH 2008 ODYSSEY Issue Date NOV 2007 NOTE: A required heavy-duty power steering cooler, ATF cooler and air duct are required

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. Bll 27035-29095 2005 RL Issue Date MAY 2005 PARTS LIST Trunk spoiler Right support strut Left support strut 4 Washer-bolts 4 Adhesive seals

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. P/N 08E49-S2A-100 2004 S2000 AII 26325 Issue Date OCT 2003 PARTS LIST Hood switch harness TOOLS AND SUPPLIES REQUIRED #2 Phillips screwdriver

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory S Application 2010 CR-V Publications No. AII 42602-42850 Issue Date OCT 2009 PARTS LIST Fog Light Kit (With Auto Lights) P/N 08V31-SWA-100A Fog Light Kit (Without Auto

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. S P/N 08V31-SHJ-100A 2010 ODYSSEY AII 41829-43750 Issue Date MARCH 2010 PARTS LIST Relay Left fog light 22 Wire ties Right fog light Wire

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory REMOTE CONTROL ENGINE STARTER Application 2010 CR-V Publications No. AII 42612-42916 Issue Date OCT 2009 PARTS LIST Remote Engine Starter Unit Kit P/N 08E91-E22-101B

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory P/N 08E10-TA0-110A Application 2012 ACCORD 2- AND 4-DOOR Publications No. AII 46501 Issue Date AUG 2011 PARTS LIST Ambient Light Kit Fuse label 2 Ambient lights Washer

More information