SIMULATION AND DATA XPERIENCE
|
|
- Maximilian Hall
- 5 years ago
- Views:
Transcription
1 SIMULATION AND DATA XPERIENCE AVL Solutions Overview in context of RDE AVL List GmbH Dr. F. Pfister, Dr. C. Schyr, Dr. T. Düser, B. Schick, Dr. B. Behr
2 CHALLENGES OF REAL DRIVING EMISSION Real Driving Emission mandatory for EURO 6c. 7 April 216 2
3 RDE TESTING & ANALYSIS Velocity - km/h Torque - Nm Throttle - % Velocity - km/h Torque - Nm Altitude - m NOx - ppm NOx - ppm NOx Peaks with Acceleration & Purging NOx Torque Time [s] Relevance: Map Transients Event History Engine Speed - rpm Pedal - % NOx Peak after downhill drive cooled down EAS NOx Altitude Torque Time - s Engine Speed - rpm Pedal - % Event selection Threshold limit for emission Stationary Map Condition (Event 1) Torque standard deviation < x Nm Gas standard deviation < x % Transient Condition (Event 2) Torque standard deviation > x Nm Gas standard deviation > x % Event History (Event 3) If not event 1 or 2 7 April 216 3
4 REAL WORLD EMISSION - INFLUENCES Air Temperature Wind and Sidewind Predictive Energy Management Tire Pressure Vehicle Load Air Pressure And Humidity Road Gradient Predictive Energy Management Road Curvature Connected Driving Traffic Calibrating the Powertrain To the People Advanced Driver Assistance Systems Driving Style (aggressive, defensive, moderate) 7 April 216 4
5 GOAL: FRONTLOADING OF RDE WITH MODEL-BASED TESTING METHODS Comparable Results 7 April 216 5
6 RDE USE CASES UC-2: RDE Reference Cycles RDE: Real driving emission test Development Type Approval COP In-Service Compliance UC-3: Virtual Integration Chassis Dyno RDE Chassis Dyno RDE UC-1: Reproduction and Analysis 7 April 216 6
7 base for virtual road catalogue (ref. cycles) WORKFLOW RDE - PRINCIPLE 2 Road and profile generation M.O.V.E to SSQ for igem Vehicle 1 Proceed as usual using M.O.V.E 3 Parameterization and Activation in IGEM Vehicle Tool-Chain using the Pre Test Dialog 4 M.O.V.E and PEMS on the Chassis Dynamometer SADA XP with road gradient visualization virtual road simulated test as usual with parameter studies to get robustness Post processing as usual, also trackbased evaluation 5 7 April 216 7
8 USE CASE: RDE CHASSIS DYNO & ENGINE TESTBED AT TÜV SÜD & TU DARMSTADT 7 April 216 8
9 USE CASE: RDE ON A HIGH-DYNAMIC ENGINE TESTBED Customer Use Case BOSCH - ATZ Extra September Gerstenberg / Hartlief / Tafel 7 April 216 9
10 USE CASE: DRIVING CUBE LK Concept phase Series development System Simulation Model/Hardware-based Testing Road- and traffic models Sensor models 7 April 216 1
11 USE CASE: DRIVING NET TU ILMENAU 7 April
12 USE CASE: VIRTUAL TEST BED FOR CALIBRATION I/O Actuators: e.g.: Throttle body, injectors, EGR valve, real ECU real Loads Closed Loop Full Size HiL System Sensors: e.g.: Pressures, Temperatures, Speeds, AirFuelRatio, 7 April
13 Test Bed Integration Library Simulation Integration Library TECHNOLOGY OUTLOOK: MODULAR SIMULATION KIT - OVERVIEW OF TOOLS Shared Model Library Standardized Model Config.??? E-Motor TB CarSim SIM Battery TB CarMaker SIM Engine TB Stähle SIM PT TB VSM SIM CD TB? SIM Model.CONNECT RT ARTE.Lab 4 TM RT Platform and Hardware (INtime, ARTE)? 7 April
14 DATA MANAGEMENT SOLUTIONS: REAL-TIME CONSISTENCY & REPORTING RDE Road Measurement RDE Testing on Chassis Dyno RDE Testing and Calibration on ETB RDE Calibration on Virtual Test Bed.. INCA M.O.V.E. igem M.O.V.E. INCA.. PUMA igem INCA.. PUMA CRUISE M.. File Formats, Norm Names, Time Sync, Sample Rate, Filter, Offset/Drifts.. INCA M.O.V.E. igem PUMA Intelligent Load Ramps Concerto Script Interpreter CANape CRUISE M CarMaker VSM AVL SANTORIN MX 2 TM Measurement Data Management and Navigator Automated Server Based Post-Processing AVL CONCERTO 4 TM Data Processing Platform Concerto for RDE Concerto for Calibration Concerto for SimGenEasy Concerto for Indication Concerto for igem PC based Post-Processing and Visualization 7 April
15 SUMMARY Early and preventive troubleshooting Reproducibility + parameter studies Efficient variant tests Reduction of calibration efforts Reuse of knowledge, e.g. RDE libraries Driver Model Driving style Normal Defensive Eco Aggressive Vehicle Model RDE Road Measurement Variation of Air Resistance cwa Rolling resistance Rotating inertias Brake losses etc. RDE Testing on Chassis Dyno Road / Environment Model RDE Testing and Calibration on ETB Characteristics Traffic Weather Wind Gradient Curvature Etc. RDE Calibration on Virtual Test Bed 7 April
16 TEST DRIVING STARTS NOW 7 April
RDE - GOING VIRTUAL. Felix Pfister & Rodolph Belleux (AVL) AVL List GmbH
RDE - GOING VIRTUAL Felix Pfister & Rodolph Belleux (AVL) AVL List GmbH CHALLENGE OF REAL DRIVING EMISSION Real Driving Emission will be mandatory as a part of the EURO 6c. Felix Pfister & Rodolph Belleux
More informationVIRTUAL HYBRID ON THE ENGINE TEST BENCH SMART FRONTLOADING
VIRTUAL HYBRID ON THE ENGINE TEST BENCH SMART FRONTLOADING RDE ENGINEERING [EIL] J. GERSTENBERG, DR. S. STERZING-OPPEL, C. FISCHER, B. SEIDEL, D. TRENKLE, M. OFF, DR. M. GLORA Overview RDE tool chain Virtual
More informationAVL Virtual Testbed. Calibrate beyond the limits
AVL Virtual Testbed Calibrate beyond the limits THE CHALLENGE Calibration Complexity The increasing vehicle diversity, combined with a multi tude of worldwide emissions regulations, the future introduction
More informationRDE DEVELOPMENT PROCESS & TOOLS
Daniel Baumann, IT RDE DEVELOPMENT PROCESS & TOOLS Kieran McAleer SIMULATION LAB ROAD AVL Solutions (A comprehensive approach to RDE) Kieran McAleer 9th AVL Calibration Symposium 4 11 월 215 2 Road Testing
More informationModel Based Development and Calibration
Model Based Development and Calibration Guillaume Broustail & Srinivasan Ananthan AVL UK Expo 215 1 Challenges in the Powertrain Development and AVLs Solutions CO2 / Fuel Consumption Real Driving Emissions
More informationAVL CALIBRATION TECHNOLOGIES
Daniel Baumann, IT AVL CALIBRATION TECHNOLOGIES Today s Message G. Vitale AVL List GmbH (Headquarters) Load Load POWERTRAIN CALIBRATION EVOLUTION IN THE LAST 20 YEARS Months Months Months ~500 ~5k ~50k
More informationMoBEO: Model based Engine Development and Calibration
MoBEO: Model based Engine Development and Calibration Innovative ways to increase calibration quality within the limits of acceptable development effort! Dr. Prakash Gnanam, AVL Powertrain UK Ltd 1 25
More informationVehicle Simulation for Engine Calibration to Enhance RDE Performance
Vehicle Simulation for Engine Calibration to Enhance RDE Performance IPG Apply & Innovate 2018 11st and 12nd of September, Karlsruhe, Germany Dr. Yutaka Murata Yui Nishio Dr. Yukihisa Yamaya Masato Kikuchi
More informationRDE ENGINEERING AT THE ENGINE TEST BENCH. Jan Gerstenberg, Dr. Sandra Sterzing-Oppel, Dr. Benjamin Hartmann, Dr. Stephan Tafel Bosch Engineering GmbH
RDE ENGINEERING AT THE ENGINE TEST BENCH Jan Gerstenberg, Dr. Sandra Sterzing-Oppel, Dr. Benjamin Hartmann, Dr. Stephan Tafel Bosch Engineering GmbH Overview RDE challenges Engineering strategies Engine-in-the-loop
More informationTesting of Emissions- Relevant Driving Cycles on an Engine Testbed
Testing of Emissions- Relevant Driving Cycles on an Engine Testbed Dr. Klaus Rothbart RDE as a Challenge for the Development TRAFFIC EXTREME CONDITIONS MOUNTAIN RANDOMNESS Driving style has a strong impact
More informationHolistic Range Prediction for Electric Vehicles
Holistic Range Prediction for Electric Vehicles Stefan Köhler, FZI "apply & innovate 2014" 24.09.2014 S. Köhler, 29.09.2014 Outline Overview: Green Navigation Influences on Electric Range Simulation Toolchain
More informationInstitute for Internal Combustion Engines and Powertrain Systems, TU Darmstadt
Institute for Internal Combustion Engines and Powertrain Systems, TU Darmstadt Hauke Maschmeyer, M.Sc.; Prof. Dr. techn. Christian Beidl Methodology Approaches for Real Driving Emissions-Development at
More informationChip Simulation for Virtual ECUs
Chip Simulation for Virtual ECUs QTronic User Conference 2018 Virtual ECUs and Applications 18th of October, Berlin, Germany Dr. Yutaka Murata Honda R&D Co., Ltd. Automotive R&D Center 1 Contents Background
More informationRDE Engineering via Engine-in-the-loop Test-bench COVER STORY RDE
COVER STORY RDE Bosch RDE Engineering via Engine-in-the-loop Test-bench 16 Bosch Engineering has realised a strategy to support RDE Engineering in an efficient way using an engine-in-the-loop (EiL) engine
More informationDYNA4 Open Simulation Framework with Flexible Support for Your Work Processes and Modular Simulation Model Library
Open Simulation Framework with Flexible Support for Your Work Processes and Modular Simulation Model Library DYNA4 Concept DYNA4 is an open and modular simulation framework for efficient working with simulation
More informationV-CAP TM A FEV VIRTUAL POWERTRAIN CALIBRATION PLATFORM
V-CAP T A FEV VITUAL POWETAIN CALIBATION PLATFO V-CAP T TEST CENTES VITUAL POWETAIN CALIBATION PLATFO V-CAP T VITUAL POWETAIN CALIBATION PLATFO VITUAL TEST BED, EAL ESULTS: A SOLUTION FO PASSENGE CA AND
More informationOptimal energy efficiency, vehicle stability and safety on the OpEneR EV with electrified front and rear axles
Optimal energy efficiency, vehicle stability and safety on the OpEneR EV with electrified front and rear axles Berlin, Monday 17 June 2013 Dr. Stephen Jones, AVL Emre Kural, AVL Alexander Massoner, AVL
More informationCOUPLING HIL-SIMULATION, ENGINE TESTING AND AUTOSAR- COMPLIANT CONTROL UNITS FOR HYBRID TESTING
UNIVERSITY OF PITESTI FACULTY OF MECHANICS AND TECHNOLOGY SCIENTIFIC BULLETIN AUTOMOTIVE series, year XV, no.19, vol. B COUPLING HIL-SIMULATION, ENGINE TESTING AND AUTOSAR- COMPLIANT CONTROL UNITS FOR
More informationSimulation of Collective Load Data for Integrated Design and Testing of Vehicle Transmissions. Andreas Schmidt, Audi AG, May 22, 2014
Simulation of Collective Load Data for Integrated Design and Testing of Vehicle Transmissions Andreas Schmidt, Audi AG, May 22, 2014 Content Introduction Usage of collective load data in the development
More informationCOMBUSTION CONTROLLER DEVELOPMENT AND APPLICATION USING MODEL-BASED DESIGN
COMBUSTION CONTROLLER DEVELOPMENT AND APPLICATION USING MODEL-BASED DESIGN Klaus Rothbart April, 7th 00 AGENDA Introduction Development Application on engine test bed Results Summary INTRODUCTION AVL The
More informationELECTRIFICATION TESTING SYSTEMS
ELECTRIFICATION TESTING SYSTEMS AVL ITA - 5 Luglio - Circuito Tazio Nuvolari Luigi Giordano AVL List GmbH (Headquarters) AVL DEVELOPMENT SYSTEMS FOR ELECTRIFICATION Dedicated application team since 2011
More informationAVL InMotion 4. Test driving starts now
AVL InMotion 4 Test driving starts now THE ADDED VALUE Improved efficiency. Enhanced flexibility. Increased productivity. AVL InMotion 4 is a system driven hardware-in-the-loop test solution for virtual
More informationFive Cool Things You Can Do With Powertrain Blockset The MathWorks, Inc. 1
Five Cool Things You Can Do With Powertrain Blockset Mike Sasena, PhD Automotive Product Manager 2017 The MathWorks, Inc. 1 FTP75 Simulation 2 Powertrain Blockset Value Proposition Perform fuel economy
More informationCo-Simulation of GT-Suite and CarMaker for Real Traffic and Race Track Simulations
Co-Simulation of GT-Suite and CarMaker for Real Traffic and Race Track Simulations GT-Suite Conference Frankfurt, 26 th October 215 Andreas Balazs, BGA-T Agenda Introduction Methodology FEV GT-Drive model
More informationGENERIC EPS MODEL Generic Modeling and Control of an Electromechanical Power Steering System for Virtual Prototypes
GENERIC EPS MODEL Generic Modeling and Control of an Electromechanical Power Steering System for Virtual Prototypes Dipl.-Ing. Roman Mannale, Volker Ewald, Dr.-Ing. Markus Bauer Adam Opel AG, Control Systems
More informationImplementation and application of Simpackmulti-attribute vehicle models at Toyota Motor Europe
Implementation and application of Simpackmulti-attribute vehicle models at Toyota Motor Europe Ernesto Mottola, PhD. Takao Sugai Vehicle Performance Engineering Toyota Motor Europe NV/SA Technical Center
More informationVIRTUAL ELECTRIC VEHICLE
Daniel Baumann, IT VIRTUAL ELECTRIC VEHICLE Hands-on Road Validation J. Balic, 11/2016 josko.balic@avl.com AVL List GmbH Josko Balic Product Manager System Simulation josko.balic@avl.com Confidential for
More informationAVL Media Conditioning Systems
SIMULATION SOLUTIONS TEST SYSTEM SOLUTIONS Electrification TESTING Battery EQUIPMENT E-Motor Dynamometers and Actuators Power Electronics Test Vehicle Systems Testbeds Component Test Cell Mechanics Test
More informationTesting Electrified Drivetrains for Vehicles without the Battery or Engine. Application Reprint of Readout No. 38
Feature Article Feature Article Testing Electrified Drivetrains for Vehicles without the Battery or. Reprint of Readout No. 38 Testing Electrified Drivetrains for Vehicles without the Battery or. Norm
More information9TH CALIBRATION&TESTING SOLUTION SYMPOSIUM
9TH CALIBRATION&TESTING SOLUTION SYMPOSIUM Concerto Applications Morgan Le Cossec AVL List GmbH AVL CONCERTO - OVERVIEW NO MATTER WHERE THE DATA GETS ACQUIRED TESTBED DATA ROAD DATA SIMULATED DATA DATABASE
More information2015 The MathWorks, Inc. 1
2015 The MathWorks, Inc. 1 [Subtrack 2] Vehicle Dynamics Blockset 소개 김종헌부장 2015 The MathWorks, Inc. 2 Agenda What is Vehicle Dynamics Blockset? How can I use it? 3 Agenda What is Vehicle Dynamics Blockset?
More informationAVL India Seminar May 2018 REAL DRIVING EMISSIONS (RDE) Challenges for On-Road Tests. AVL M.O.V.E In-Vehicle Testsystem.
AVL List GmbH (Headquarters) AVL India Seminar May 2018 REAL DRIVING EMISSIONS (RDE) Challenges for On-Road Tests AVL M.O.V.E In-Vehicle Testsystem Schöggl, Marco REAL DRIVING EMISSIONS (RDE) A REAL CHALLENGE
More informationAutomated Testing in Automotive Software Development using Vehicle System Simulation
Automated Testing in Automotive Software Development using Vehicle System Simulation Oliver Philipp, Martin Ehmann TESIS DYNAware GmbH, www.tesis-dynaware.com 1 Defect Rate Cost for Defect Fix Motivation:
More informationUse of automation and simulation in large/commercial engine and application development
TETE Use of automation and simulation in large/commercial engine and application development Göteborg, 19.11.2014, Dr. S.C.Fritz Today s agenda Demands of the exhaust gas legislation Methodology - Which
More informationExperimental Investigations of Transient Emissions Behaviour Using Engine-in-the-Loop
TSI.InP.P_User5.Temperature7 [degc] TSI.InP.P_User4.Temperature [degc] TSI.InP.P_User4.Temperature3 [degc] Car.v [m/s] IO.Emission.CO_ DM.Gas Car.ay [m/s^] Car.ax [m/s^] Experimental Investigations of
More informationMulti-ECU HiL-Systems for Virtual Characteristic Rating of Vehicle Dynamics Control Systems
Multi-ECU HiL-Systems for Virtual Characteristic Rating of Vehicle Dynamics Control Systems Dipl.-Ing. Ronnie Dessort, M.Sc. Philipp Simon - TESIS DYNAware GmbH Dipl.-Ing. Jörg Pfau - Audi AG VDI-Conference
More informationTesting with Virtual Prototype Vehicles on the Test Bench
DEVELOPMENT Real Driving Emissions Testing with Virtual Prototype Vehicles on the Test Bench IPG Automotive AUTHORS Dipl.-Ing. Christian Lensch-Franzen is Head of Engineering at APL Automobil-Prüftechnik
More informationIMPLEMENTATION OF A VEHICLE-IN-THE-LOOP DEVELOPMENT AND VALIDATION PLATFORM
F2010-C-177 IMPLEMENTATION OF A VEHICLE-IN-THE-LOOP DEVELOPMENT AND VALIDATION PLATFORM 1 Albers, Albert *, 1 Düser, Tobias 1 IPEK Institute of Product Engineering at Karlsruhe Institute of Technology
More informationAVL PLU 131U FLOW METER
CONSUMPTION MEASUREMENT TECHNOLOGIES AVL PLU 131U FLOW METER AVL PLU131 UREA FLOW MEASUREMENT SENSORS Function Summary The AVL PLU 131U-020 Flow Sensor has been designed for transient flow rate measurement
More informationSimulink as a Platform for Full Vehicle Simulation
Simulink as a Platform for Full Vehicle Simulation Mike Sasena (Product Manager) Lars Krause (Application Engineer) Ryan Chladny (Development) 2018 The MathWorks, Inc. 1 Fuel Economy Simulation 2 Vehicle
More informationCalibration. DOE & Statistical Modeling
ETAS Webinar - ASCMO Calibration. DOE & Statistical Modeling Injection Consumption Ignition Torque AFR HC EGR P-rail NOx Inlet-cam Outlet-cam 1 1 Soot T-exhaust Roughness What is Design of Experiments?
More informationSESSION 2 Powertrain. Why real driving simulation facilitates the development of new propulsion systems
SESSION 2 Powertrain Why real driving facilitates the development of new propulsion systems CO 2 /Fuel Consumption, Pollutant Emissions, EV Range The real driving values are more and more in the public
More informationDigital Future of Product Development and Validation- The Role of Experiments & Modelling Challenges
Digital Future of Product Development and Validation- The Role of Experiments & Modelling Challenges Sam Akehurst Professor of Automotive Powertrain Systems, University of Bath Overview Vision towards
More informationSpecial Reprint. Determination of Vehicle Emissions under Real-world Driving Conditions. Dr. Ulrich Lauff and Rajesh Reddy. Real Driving Emissions
Special Reprint from HANSER automotive 5-6/2017 Dr. Ulrich Lauff and Rajesh Reddy Determination of Vehicle Emissions under Real-world Driving Conditions Real Driving Emissions Juni 2017 Jahrgang 16 15,80
More informationModelling of Diesel Vehicle Emissions under transient conditions
Modelling of Diesel Vehicle Emissions under transient conditions Dr. Gavin Dober Combustion and Hydraulics Manager, Davide Del Pozzo Delphi Trainee 216-217 Advanced Injection & Combustion Center Delphi
More informationNew results from a 2015 PEMS testing campaign on a Diesel Euro 6b vehicle
New results from a 215 PEMS testing campaign on a Diesel Euro 6b vehicle Cécile Favre, Dirk Bosteels, John May AECC Jon Andersson, Simon de Vries Ricardo 11 th Integer Emissions Summit & AdBlue Forum Europe
More informationUse of Simpack at the DaimlerChrysler Commercial Vehicles Division
Use of Simpack at the DaimlerChrysler Commercial Vehicles Division Dr. Darko Meljnikov 22.03.2006 Truck Product Creation (4P) Content Introduction Driving dynamics and handling Braking systems Vehicle
More informationRDE PN emissions from a GDI vehicle without and with a GPF
RDE PN emissions from a GDI vehicle without and with a GPF Dr. Joachim Demuynck IQPC 4 th international conference on RDE Berlin, 25-27 October 2016 Association for Emissions Control by Catalyst (AECC)
More informationComprehensive and Cross-domain Vehicle Simulation for Electrification
Comprehensive and Cross-domain Vehicle Simulation for Electrification IPG apply & innovate 2014 2014 09-24 Powertrain Systems - Christian Appel, Ralf Kleemann Vehicle Systems - Benjamin Leidel Chassis
More informationitpms-in-the-loop Solution for Comprehensive Validation Tasks for indirect Tire Pressure Monitoring Systems According to the New ECE-R 64 Regulation
Taking you to the next level apply & Innovate 2012, IPG Technology Conference, Karlsruhe, 21 and 22 June 2012 itpms-in-the-loop Solution for Comprehensive Validation Tasks for indirect Tire Pressure Monitoring
More informationExpected Light Duty Vehicle Emissions from Final Stages of Euro 6
Ricardo plc 2017 Expected Light Duty Vehicle Emissions from Final Stages of Euro 6 EU Refining Forum - Dr Nick Powell Ricardo plc 2017 2 Contents What is Euro 6 and what are the stages of its introduction?
More informationReal Driving Emissions
Real Driving Emissions John May, AECC UnICEG meeting 8 April 2015 Association for Emissions Control by Catalyst (AECC) AISBL AECC members: European Emissions Control companies Exhaust emissions control
More informationAECC Clean Diesel Euro 6 Real Driving Emissions Project. AECC Technical Seminar on Real-Driving Emissions Brussels, 29 April 2015
AECC Clean Diesel Euro 6 Real Driving Emissions Project AECC Technical Seminar on Real-Driving Emissions Brussels, 29 April 2015 Contents Background Test Programme Vehicle description & test regime. Baseline
More informationAVL EMISSION TEST SYSTEMS International sight of future emission programs K. Engeljehringer AVL List GmbH, Graz, Austria
AVL EMISSION TEST SYSTEMS International sight of future emission programs K. Engeljehringer AVL List GmbH, Graz, Austria SEMINÁRIO DE EMISSÕES AEA, 25.04.2013 "Our air may be better - A critical approach
More informationIntegrated ADAS HIL System with the Combination of CarMaker and Various ADAS Test Benches. Jinjong Lee, Konrad Yu-Mi Song, Hyundai-Autron
Integrated ADAS HIL System with the Combination of CarMaker and Various ADAS Test Benches Jinjong Lee, Konrad Yu-Mi Song, Hyundai-Autron 1 Agenda Part1. ADAS Sensor Fusion HILS Trend 1.1 The trend of ADAS
More informationPEMS Testing of Porsche Model Year 2018 Vehicles
PEMS Testing of Porsche Model Year 18 Vehicles Report Pursuant to Paragraph 33.e and Paragraph 33.f of the DOJ and California Third Partial Consent Decree Version: Final Report Date: 11/12/18 Project:
More informationHighly dynamic control of a test bench for highspeed train pantographs
PAGE 26 CUSTOMERS Highly dynamic control of a test bench for highspeed train pantographs Keeping Contact at 300 km/h Electric rail vehicles must never lose contact with the power supply, not even at the
More informationBicycle Hardware in the Loop Simulator for Braking Dynamics Assistance System
Bicycle Hardware in the Loop Simulator for Braking Dynamics Assistance System IPG Apply & Innovate 2016 Conference Session: Off Highway Cornelius Bott, Martin Pfeiffer, Oliver Maier, Jürgen Wrede 21.09.2016
More informationModification of IPG Driver for Road Robustness Applications
Modification of IPG Driver for Road Robustness Applications Alexander Shawyer (BEng, MSc) Alex Bean (BEng, CEng. IMechE) SCS Analysis & Virtual Tools, Braking Development Jaguar Land Rover Introduction
More informationHolistic 1D-Model for Cooling Management and Engine Analysis of a Heavy-Duty Truck
Holistic 1D-Model for Cooling Management and Engine Analysis of a Heavy-Duty Truck Dominik Renner Dr. Alexander Schydlo 26 th October 2015 MAN Truck & Bus AG < 1 > Agenda 1 Introduction 2 Model Description
More informationBuilding Fast and Accurate Powertrain Models for System and Control Development
Building Fast and Accurate Powertrain Models for System and Control Development Prasanna Deshpande 2015 The MathWorks, Inc. 1 Challenges for the Powertrain Engineering Teams How to design and test vehicle
More informationSimulated EV Dynamics: Safety & etvc
Simulated EV Dynamics: Safety & etvc Dr. Stephen Jones et. al., AVL List GmbH stephen.jones@avl.com +43 316 787 4484 26.09.11 ARTEMIS ARTEMIS Pollux POLLUX Project Project Process Oriented electronic control
More informationAlfonso PORCEL, Olivier MACCHI - PSA Peugeot Citroen, France
First Type Approval of Electronic Stability Control in Passenger Cars by Means of Vehicle Dynamics Simulation in Accordance with ECE 13-H Challenges, Innovation and Benefits. Alfonso PORCEL, Olivier MACCHI
More informationINCA-RDE V1.1 Getting Started
V1.1 Getting Started Copyright The data in this document may not be altered or amended without special notification from ETAS GmbH. ETAS GmbH undertakes no further obligation in relation to this document.
More informationCRUSADER. A full vehicle integration facility. Crossfunctional unique systemtest approach driven by entire relationships
CRUSADER A full vehicle integration facility Crossfunctional unique systemtest approach driven by entire relationships An innovative vehicle-in-the-loop test bench We're talking about... CRUSADER an Unique
More informationState of the art cooling system development for automotive applications
State of the art cooling system development for automotive applications GT Conference 2017, Frankfurt A. Fezer, TheSys GmbH P. Sommer, A. Diestel, Mercedes-AMG GmbH Content Introduction Cooling system
More informationE-DRIVE: HIGHLY INTEGRATED AND HIGH EFFICIENT
E-DRIVE: HIGHLY INTEGRATED AND HIGH EFFICIENT Korea EV Engineering & Testing Exhibition Roger Perthen AVL List GmbH (Headquarters) KEY ASPECTS FOR BATTERY ELECTRIC VEHICLES (BEVs) E-DRIVE: AFFORDABLE -
More informationPROJECT WORK. NAME Engine base calibration process. TUTORs Amorese Stefano. JOB POSITION Engine calibration test bench engineer
Engine base calibration process TUTORs Amorese Stefano Engine calibration test bench engineer 1) Development of base engine calibration data: Performance optimization (maximum torque and power levels,
More informationTHE FKFS 0D/1D-SIMULATION. Concepts studies, engineering services and consulting
THE FKFS 0D/1D-SIMULATION Concepts studies, engineering services and consulting r e s e a r c h i n m o t i o n. VEHICLE IN MOTION On the basis of constant engine speeds and loads, the combustion engine
More informationUPCOMING CO2 LEGISLATION FOR COMMERCIAL VEHICLES IN EUROPE AND US. Lukas Walter, AVL
UPCOMING CO2 LEGISLATION FOR COMMERCIAL VEHICLES IN EUROPE AND US Lukas Walter, AVL CHALLENGES FOR OUR CUSTOMERS CO2 Legislation Competition in TCO Advanced Emission in Emerging Markets Automated Drivelines
More informationEVOLUTION OF RDE REGULATION
EVOLUTION OF RDE REGULATION Content RDE Background RDE Regulation Development Boundary Conditions RDE Implementation Summary 2 Diesel & Gasoline Systems and Automotive Aftermarket DS/EPD1-GS GS/ESP3 4/28/2016
More informationModeling and Simulate Automotive Powertrain Systems
Modeling and Simulate Automotive Powertrain Systems Maurizio Dalbard 2015 The MathWorks, Inc. 1 Model-Based Design Challenges It s hard to do good Model-Based Design without good models Insufficient expertise
More informationDipl.-Ing. Thorsten Pendzialek Dipl.-Ing. Matthias Mrosek. Model-Based Testing of Driver Assistance Systems for Counterbalance Forklift Trucks
Dipl.-Ing. Thorsten Pendzialek Dipl.-Ing. Matthias Mrosek Model-Based Testing of Driver Assistance Systems for Counterbalance Forklift Trucks Outline Motivation for the Introduction of Model-Based Testing
More informationMachine Learning & Active Safety Using Autonomous Driving and NVIDIA DRIVE PX. Dr. Jost Bernasch Virtual Vehicle Research Center Graz, Austria
Machine Learning & Active Safety Using Autonomous Driving and NVIDIA DRIVE PX Dr. Jost Bernasch Virtual Vehicle Research Center Graz, Austria VIRTUAL VEHICLE Agenda 1 Open vehicle research platform 3 Austrian
More informationA dream? Dr. Jürgen Bredenbeck Tire Technology Expo, February 2012 Cologne
Rolling resistance measurement on the road: A dream? Dr. Jürgen Bredenbeck Tire Technology Expo, 14.-16. February 2012 Cologne Content Motivation Introduction of the used Measurement Equipment Introduction
More informationManeuver based testing of integrated vehicle safety systems
Maneuver based testing of integrated vehicle safety systems Rudolf Ertlmeier 1 Kathrin Sattler 1, Andreas Raith 1, Thomas Brandmeier 1 Daouda Sadou 2, Christian Schyr 3 1 Institute for Applied Research
More informationHDV CO2 emission certification 1 st meeting of the Editing board
HDV CO2 emission certification 1 st meeting of the Editing board DG Growth Maciej Szymański 2.03.2015 Internal market, Industry, Entrepreneurship and SMEs Meeting agenda Work of the Editing board: Objectives
More informationUsing Virtualization to Accelerate the Development of ADAS & Automated Driving Functions
Using Virtualization to Accelerate the Development of ADAS & Automated Driving Functions GTC Europe 2017 Dominik Dörr 2 Motivation Virtual Prototypes Virtual Sensor Models CarMaker and NVIDIA DRIVE PX
More informationSupport of automobile transmission development with co-simulation of vehicle and driver behaviour at virtual driving tests
Support of automobile transmission development with co-simulation of vehicle and driver behaviour at virtual driving tests Michael Matthäi, Christian Petschaelis ZF Friedrichshafen AG Agenda 2 Motivation
More informationAddressing performance balancing in fuel economy driven vehicle programs
EAEC-ESFA 2015 Presenter: Dr. Filip Deblauwe Addressing performance balancing in fuel economy driven vehicle programs Smarter decisions, better products. Introduction Performance balancing Application
More informationHardware-in-the-Loop Testing of Connected and Automated Vehicle Applications
Hardware-in-the-Loop Testing of Connected and Automated Vehicle Applications Jiaqi Ma Assistant Professor University of Cincinnati ITS Midwest Annual Meeting Columbus, Ohio, September 29, 2017 Outline
More informationPredictive Control Strategies using Simulink
Example slide Predictive Control Strategies using Simulink Kiran Ravindran, Ashwini Athreya, HEV-SW, EE/MBRDI March 2014 Project Overview 2 Predictive Control Strategies using Simulink Kiran Ravindran
More informationHardware-In-the-Loop (HIL) Testbed for Evaluating Connected Vehicle Applications
Hardware-In-the-Loop (HIL) Testbed for Evaluating Connected Vehicle Applications Department of Mechanical Engineering University of Minnesota Project Members : Mohd Azrin Mohd Zulkefli Pratik Mukherjee
More informationThe MathWorks Crossover to Model-Based Design
The MathWorks Crossover to Model-Based Design The Ohio State University Kerem Koprubasi, Ph.D. Candidate Mechanical Engineering The 2008 Challenge X Competition Benefits of MathWorks Tools Model-based
More informationFull Vehicle Simulation for Electrification and Automated Driving Applications
Full Vehicle Simulation for Electrification and Automated Driving Applications Vijayalayan R & Prasanna Deshpande Control Design Application Engineering 2015 The MathWorks, Inc. 1 Key Trends in Automotive
More informationHIGH PERFORMANCE 800V E-MOTOR
HIGH PERFORMANCE 800V E-MOTOR FOR AUTOMOTIVE APPLICATION Katrin Wand AVL Trimerics GmbH AVL SOLUTION FOR ALL CUSTOMER SEGMENTS AVL E-Drive Core Competences Powertrain Engineering E-motor EMC Passenger
More informationLandi Renzo experience with Dual Fuel systems. GFV Workshop. Bruxelles, 13/12/2012
Landi Renzo experience with Dual Fuel systems GFV Workshop Bruxelles, Landi Renzo S.p.A. www.landi.it Agenda History of Diesel Dual Fuel in Landi Renzo Integrated Technical Approach Components Layouts
More informationCase study on Selective catalytic reduction(scr) performance improvement over legislative engine cycles using 1D simulation
Case study on Selective catalytic reduction(scr) performance improvement over legislative engine cycles using 1D simulation Presented by Mohak Samant & Hitesh Chaudhari Under the guidance of Dr. N. H.
More informationASM Gasoline Engine Simulation Package. dspace Automotive Simulation Models ASM NEW: Gasoline Engine Model and ASMParameterization
ASM Gasoline Engine Simulation Package dspace Automotive Simulation Models ASM NEW: Gasoline Engine Model and ASMParameterization dspace Automotive Simulation Models Gasoline Engine Simulation Package
More informationState of the Art Development Methodologies for Hybrids and e- Drives
AVL List GmbH (Headquarters) State of the Art Development Methodologies for Hybrids and e- Drives 29.11.2018 PDiM 18, Chalmers Conference Centre Andreas Volk Content Introduction Technology selection -
More informationCombustion Measurement Technology
SIMULATION SOLUTIONS TEST SYSTEM SOLUTIONS Electrification TESTING Battery EQUIPMENT E-Motor Dynamometers and Actuators Power Electronics Test Vehicle Systems Testbeds Component Test Cell Mechanics Test
More informationDesigning for Reliability and Robustness with MATLAB
Designing for Reliability and Robustness with MATLAB Parameter Estimation and Tuning Sensitivity Analysis and Reliability Design of Experiments (DoE) and Calibration U. M. Sundar Senior Application Engineer
More informationThe next revolution in simulation. Dr. Jan Leuridan Executive Vice-President, CTO LMS International
The next revolution in simulation Dr. Jan Leuridan Executive Vice-President, CTO LMS International The industry is facing faster and broader change (IBM CEO Survey 2008) Sustainability Radical new product
More informationValidation of a simulation model for the assessment of CO 2 emissions of passenger cars under real-world conditions
Validation of a simulation model for the assessment of CO 2 emissions of passenger cars under real-world conditions The gap between real-world fuel consumption and manufacturers figures has been increasing
More informationInsights into WLTP and RDE
Insights into and RDE Current test procedures and their implications for fleet customers Editorial Dear Readers, You have already been informed about the first phase of the new Worldwide Harmonised Light
More informationTU Graz work related to PHEM and data collection
TU Graz work related to PHEM and data collection Stefan Hausberger, Martin Rexeis, Claus Matzer, Konstantin Weller TU Graz Lyon, 23. May 2016 1 Topics we would like to discuss Part I: PHEM and PEMS data
More informationVehicle calibration optimization using a dynamic test bed with real time vehicle simulation
Vehicle calibration optimization using a dynamic test bed with real time vehicle simulation G. Burette 1, F. Perez 2, K. Bansal 2 1: D2T Powertrain Engineering Direction Ingénierie du GMP Technopôle du
More informationTuning of ADAS Functions Using Design Space Exploration
5 Tuning of ADAS Functions Using Design Space Exploration Abhishek Ravi 1, Hans Michael Koegeler 1 and Andrea Saroldi 2 1 AVL List Gmbh, Austria 2 C.R.F. S.C.p.A, Italy 5.1 Introduction AnADAS function
More informationNCHRP PROJECT VEHICLE EMISSIONS DATABASE
NCHRP PROJECT 25-11 VEHICLE EMISSIONS DATABASE INTRODUCTION An extensive vehicle emissions testing program was conducted from April 1996 to September 1998 at the College of Engineering-Center for Environmental
More informationFMVSS 126 Electronic Stability Test and CarSim
Mechanical Simulation 912 North Main, Suite 210, Ann Arbor MI, 48104, USA Phone: 734 668-2930 Fax: 734 668-2877 Email: info@carsim.com Technical Memo www.carsim.com FMVSS 126 Electronic Stability Test
More information