Powertrain & Thermal Systems
|
|
- Clara Parrish
- 6 years ago
- Views:
Transcription
1 Powertrain & Thermal Systems L'électrification et composants 48V des fonctions moteur et auxiliaires O. COPPIN N. DEVIENNE Électrification des fonctions et des auxiliaires Flins - 15 Décembre 2016 Flins 15 Décembre
2 Agenda Drivers for hybridization Low voltage Hybrid systems and functions Alternative boosting : electric supercharger Function electrification Low voltage Road-Map Conclusion Flins 15 Décembre
3 Driver for hybridization : CO 2 regulations Main issue of hybrid / electric: COST! China 2020(cars only):106 Diesel : the upper limit customers are willing to pay To develop in mass-market, hybrids need to be cheaper : Why 12V+12V and 48V make sense Flins 15 Décembre
4 Powertrain Solutions for CO 2 3 main technical Areas Internal Combustion Engine Downsizing Turbocharger/Supercharger Gasoline Direct Injection Gasoline Cooled EGR Variable Valve Activation Thermal management Electrification Stop-Start Mild Hybrid Full Hybrid Plug-in Hybrid Range Extender Battery Electric Vehicles Energy management Downspeeding & Automation Double Clutch Transmission Automatic Early lock-up Downspeeding Flins 15 Décembre
5 Hybrid Architectures P3 P1 P2 P4 P4 P4 P0 P0 / P1 P2 P3 P4 E-motor linked to ICE E-motor decoupled from ICE, at same speed E-motor decoupled from ICE, at a speed multiple than ICE E-motor in driveline or in rear axle or in wheels 48V can address all hybrid architectures and enhance hybrid functions benefits Flins 15 Décembre
6 Functions availability P0 Belt 12V P0 Belt «12V + 12V» P0 Belt «12V + 12V» + esc P0 Belt 48V (+ esc) 48V P2/P3/P4 Cold start o o o o / o / (P2) Change of Mind Stop & Start High Efficiency generator Durability (1mcy) Comfort Start Stalling help Coasting o / Regenerative braking o Torque Assist o o Torque Monitoring o o Downspeeding Engine Dowsizing ZEV o / Electrical Take off o / : Possible o : Limited : Impact on fuel savings Voltage increase will enhance hybrid functions P2, P3, P4 architectures increase hybrid energy management benefits Flins 15 Décembre
7 Why 48V Hybrid is affordable Low voltage Small battery Cheap battery Belt Starter-Generator All-in-one : Just replaces the alternator with integrated inverter Standard powertrain architecture Limited power : air cooling possible if <8kW permanent 48V < 60V : No electric safety issues Limited insulation on wiring and connectors, easy passive safety Constant challenge : component right sizing Flins 15 Décembre
8 Funded project Peugeot Volt Electric AWD : Essencyele. Association of a 48V P0 belt machine and a 48V electric rear axle All Hybrid functions including electric driving Cost effective thanks to 48V P4 hybrid architecture efficiency Up to 22%* CO2 emission reduction on NEDC, up to 16%* WLTP AWD mobility function as added value for end customer. * Valeo estimate based on simulation, will vary per vehicle application Flins 15 Décembre
9 Alternative Boosting : efficiency analysis Mechanical supercharger Electrical supercharger 17,4 100 > 82,6 100 > 100 High mechanical losses, only 82% of generated torque goes to the wheels No Mechanical losses. 100% of the generated torque is transferred to the wheels With e-supercharger there is no friction while boosting. Energy is free while recovered during braking Flins 15 Décembre
10 Interest of alternative boosting : efficiency Hybrid system Electrical supercharger 25 kw 25kW 5 kw 25kW To get 25kW on the wheels, need ~25 kw from the e-motor. With 300Amps limit, 100V necessary To get 25kW on the wheels, need ~5 kw on the air thanks to combustion COP. With 300Amps limit, 48V is far enough With the electric supercharger there is fundamentally efficiency benefit linked to combustion COP For the same power at wheels, the hybrid voltage can be reduced from high voltage to 12V or 48V: the electric system, including batteries, is then far cheaper. Flins 15 Décembre
11 Electric Supercharger = instantaneous response 26 BMEP (bar) Electric supercharger after 0.5s Turbo after 2.0s Turbo after 1.0s Turbo after 0.5s Turbo engine Naturally aspirated engine Engine speed (RPM) The higher the downsizing, the longer the turbo low RPM. The turbo is unable to compensate the lag. Response time is the key parameter Flins 15 Décembre
12 Renault Fluence: SURAL-HY Supercharging system for hybrid gasoline engines with high downsizing Funded project Electric supercharger 3 kw, 12 Volts Integration of 1.2L Renault turbo engine with the Electric Supercharger 12V NiZn battery esc dedicated Design and integration of a larger Turbo to achieve 100kW / L Gearbox downspeeding (15%) Partial 'free' power boost, symmetry braking phases: energy recovery and energy use with 12V Engine downsizing and downspeeding thanks to esc integration Flins 15 Décembre
13 Electric Supercharger 3 main applications More Power Better Fuel Efficiency Less pollutants Audi RS5 TDI 386HP Valeo NA Democar 8% FE Volvo edrive 450HP Ricardo HyBoost 20% FE Valeo-FEV : Euro6 w/o SCR 48V 12V Diesel Flins 15 Décembre
14 Electrical board net : modular building 12V -> 48V 12V regen network Optional Piloted switch 12V clean network Reversible Machine Starter + Alternator 12V 12V + 12V Basic Set Starter 12V Battery 1 12V NON Sensitive Loads 12V Battery 2 12V Sensitive Loads 12V regen network Optional Piloted switch 12V clean network Reversible Machine Starter + Alternator 12V Starter 12V + 12V Extented Set 12V Battery 1 12V NON Sensitive Loads esc 12V Battery 2 12V Sensitive Loads 48V regen network DCDC V 12V clean network Reversible Machine 48V 12V + 48V 48V Battery 48V NON Sensitive Loads esc 12V Battery Starter 12V Sensitive Loads Flins 15 Décembre
15 Future steps Develop P2, P3 & P4 48V application to enhance efficiency 48V : a way to address low cost small electric vehicle? Power level compatible with 80 to 100 km/h max Autonomy up to 100km by battery sizing Keep cost and component modularity with 48V hybrids Flins 15 Décembre
16 12+12V & 48V Road Map First 12V application : Stop & Start % CO2 Reduction Systems CO2 gains / cost position STT system cost Flins 15 Décembre
17 12+12V & 48V Road Map 48V mild hybrid : more power and more energy available First and easier step : belt e-machine. % CO2 Reduction Systems CO2 gains / cost position system cost Flins 15 Décembre
18 12+12V & 48V Road Map A better cost / CO 2 gain ratio than high voltage systems 48V : An increasing potential with boosted hybrid and power devices electrification A continuous extension : accessories electrification, P3/P4 hybrid architectures, new concepts. % CO2 Reduction Systems CO2 gains / cost position system cost Flins 15 Décembre
19 48V board net opportunity : more power available 12V systems have a limit around 4 kw (~300 Amps max) BMW 750i Diesel 3.0L WLTC 40 C + comfort function ON Power (W) Lights Board Fuel Pump ABS, CBC and DBC Actuators Small Power consumers Blower Fan defog (front and rear screen) Compressor Power 4000 Estimated limit of 12V systems time (s) Flins 15 Décembre
20 Analysis of vehicle measurements Electric mean power Electric max power Mean/Max power per load Mechanical mean power Mechanical max power Vehicle measurements and analysis of load power during use different conditions / static tests) Measures on WLTC (nominal conditions) Measures on WLTC (specific conditions) Static tests Accessories with 48V electrification potential Accessories for belt suppression THS VDA test T amb. = 45 C 40% humidity Powe er (W) Estimated T amb. < 0 C T amb. < 15 C, cold sta art T amb. = 28 C, hot st tart T amb. = 28 C, ho ot start T amb. = -7 C, cold start Estimated Real mountain road Controllers * Windshield included Power Devices for comfort Property ** CBC & of DBC: Valeo Cornering Duplication Brake Prohibited Control & Dynamic Brake Control Small Power Machine & Devices Electrohydraulic Machines Flins 15 Décembre
21 Comfort Auxiliaries 48V 12V 48V regen network DCDC V 12V clean network Reversible Machine 48V 12V + 48V 48V Battery 48V NON Sensitive Loads esc 12V Battery Efficiency Weight Starter 12V Sensitive Loads 12V Non Sensitive Loads Switching Auxiliaries from 12V to 48V allows to gain Weight DC/DC Efficiency Additional gains Wire harness weight and costs Resistive losses in wires Other gains to be confirmed Efficiency in electrical machines thanks to finest wires and copper density increase Flins 15 Décembre
22 48V 12V / Diversity On the same vehicle several Power train are co existing. Voltage of components shall be manage as a version Common mechanical interfaces For several years 48V components won t reach the same production volume Production cost difficult to converge with 12V A major stake is to communalize Industrial tooling between 12V and 48V 12 V 48 V Adapted to connectors design Power electronics - Adapted MOSFET - Driver 48V - Adapted Inductor - Adapted Capacitor PCB lay out New Connectors with CPA Carry over Carry over Winding adaptation (wire gage, nber turns, ) Carry over Dedicated to each HVAC application Dedicated to each HVAC application Flins 15 Décembre
23 Conclusion Hybridization: a necessity for CO 2 reduction Cost is always a driver : Affordable cars require simpler / cheaper solutions Modular Electric Architectures & topology as way to reduce integration cost Extended 12V & 48V mild hybrid systems address basis hybrid functions and allow superior fuel economy for best value equation Low voltage dual battery architectures are gateway to Extended regen capability Extended boost with electric supercharger Coasting and valuable driver functions Electrification can also address new board net functions i-stars 0 Start er 12V Battery 1 12V NON Sensitive loads Piloted switch 12V Battery 2 (AGM/NiMH) 12V Sensitive loads Flins 15 Décembre
24 Thank you for your attention Flins 15 Décembre
12+12V and 12+48V a modular approach for components and electric architectures.
12+12V and 12+48V a modular approach for components and electric architectures. Dr. Ing. Olivier COPPIN Abstract Among the various hybridization levels, the 12+12 volts affordable architecture represents
More information12V / 48V Hybrid Vehicle Technology Steven Kowalec
12V / 48V Hybrid Vehicle Technology Steven Kowalec www.continental-corporation.com Powertrain Division Powertrain Electrification Technology Sy ystem Costs CO2 Reduction Potenttial Mi Micro-hybrids h b
More informationTENSION 12 V TO 800 V EFFICIENT POWERTRAIN SOLUTIONS
TENSION 12 V TO 800 V EFFICIENT POWERTRAIN SOLUTIONS FISITA 2015 K. Küpper, T. Pels, M. Deiml, A. Angermaier, T. Bürger, A. Weinzerl, G. Teuschl AVL List GmbH Public CHANGE OF BOUNDARIES POWERTRAIN ELECTRIFICATION
More informationHybrid4All: A low voltage, low cost, mass-market hybrid solution
Hybrid4All: A low voltage, low cost, mass-market hybrid solution Daniel BENCHETRITE, System and Integration Dept. Manager Valeo Powertrain Systems IQPC Automotive Power Supply System 48V Frankfurt 13th
More informationPowertrain Electrification for the 21st Century
Powertrain Electrification for the 21st Century by Dr. Matti Vint PTS Engineering R&D Director Powertrain Strategies for the 21st Century: Preparing for the Midterm CAFE Assessment Valeo Valeo property
More informationENABLING COST OPTIMIZED HYBRID POWERTRAINS
ENABLING COST OPTIMIZED HYBRID POWERTRAINS Jack Martens DAF Trucks N.V. www.ecochamps.eu General Information Project full title: Coordinator: Consortium: European COmpetitiveness on Commercial Hybrid and
More informationTransmission Technology contribution to CO 2 roadmap a benchmark
Transmission Technology contribution to CO 2 roadmap a benchmark Martin Bahne Director Attribute System Engineering Ulrich Frey Technical specialist Agenda Introduction Transmission Technology Benchmark
More informationApplication of the SuperGen Electro-Mechanical Supercharger to Miller-Cycle Gasoline Turbocharged Engines
Application of the SuperGen Electro-Mechanical Supercharger to Miller-Cycle Gasoline Turbocharged Engines A. H. Guzel, J. Martin North American GT Conference 2017 11/14/2017 1 Overview Program Goal & Technology
More informationCO 2 Pilot From hybrid vehicles eco-driving to automated driving
CO 2 Pilot From hybrid vehicles eco-driving to automated driving Vanessa Picron 15 e cycle de conférences : Utilisation rationnelle de l énergie et environnement March 18 th, 2014 I 1 May 28 th, 2013 March
More informationSuperGen - Novel Low Cost Electro-Mechanical Mild Hybrid and Boosting System. Jason King, Chief Engineer
SuperGen - Novel Low Cost Electro-Mechanical Mild Hybrid and Boosting System Jason King, Chief Engineer FPC2015 Quick overview of Integral Powertrain (IPT) SuperGen concept Analysis results Test results
More informationMagna Powertrain edrive System: One-Stop-Shop for Hybrids and Electric vehicles
Magna Powertrain edrive System: One-Stop-Shop for Hybrids and Electric vehicles Drivetrain Forum 2016, Untergruppenbach Magna Powertrain, Werner Neß, Global Product Manager for Hybrids & Electric Vehicles
More informationTHINK ELECTRIC. THINK MAGNA.
THINK ELECTRIC. THINK MAGNA. TABLE OF CONTENTS 4 GLOBAL MEGATRENDS 6 POWERTRAIN ARCHITECTURES 8 OUR EXPERIENCE 10 ROAD TO emobility 12 48 VOLT HYBRID 16 PLUG-IN HYBRID 20 PURE ELECTRIC 24 ELECTRIFIED COMPONENTS
More informationThermoelectric Network Meeting Engineering Challenges and the Thermoelectric Roadmap Market Applications and Future Activities
Thermoelectric Network Meeting Engineering Challenges and the Thermoelectric Roadmap Market Applications and Future Activities Dr Cedric Rouaud, Chief Engineer, Engines Product Group 2 Content Key market
More informationApproach for determining WLTPbased targets for the EU CO 2 Regulation for Light Duty Vehicles
Approach for determining WLTPbased targets for the EU CO 2 Regulation for Light Duty Vehicles Brussels, 17 May 2013 richard.smokers@tno.nl norbert.ligterink@tno.nl alessandro.marotta@jrc.ec.europa.eu Summary
More informationTHERMAL MANAGEMENT SYNERGY THROUGH INTEGRATION PETE BRAZAS
THERMAL MANAGEMENT SYNERGY THROUGH INTEGRATION PETE BRAZAS 1 Propulsion System Trends Evolution of the TMM A Closer Look at Electrification System Integration Approach Outlook Powertrain Technology Roadmap
More informationE-MOBILITY TESTING ALONG THE V-CYCLE EMPHASIS ON THE INTEGRATION TESTBENCH. Markus Maier, RBM Germany
E-MOBILITY TESTING ALONG THE V-CYCLE EMPHASIS ON THE INTEGRATION TESTBENCH Markus Maier, RBM Germany AGENDA Overview AVL Testing Solutions Electrification for Subsystem Electrification Summary Markus Maier,
More informationDesign of a 14V nominal dual battery system. Audi AG, Gehrmann, Johannes
Design of a 14V nominal dual battery system Audi AG, Gehrmann, Johannes Agenda Introduction and background Functions Design and architecture of a 14V dual battery system Challenges and key requirements
More informationTransitioning SuperTruckTechnologies to Commercial and Military Applications June 17 th, 2014 Ted Bloch-Rubin, Jean-Baptiste Gallo, CALSTART
Transitioning SuperTruckTechnologies to Commercial and Military Applications June 17 th, 2014 Ted Bloch-Rubin, Jean-Baptiste Gallo, CALSTART Agenda Background Overview of SuperTruck Review of Technologies
More informationPowertrain Strategies for the 21st Century: Revolution and Evolution. John Shutty Chief Engineer July 22 nd, 2015
Powertrain Strategies for the 21st Century: Revolution and Evolution John Shutty Chief Engineer July 22 nd, 2015 Agenda BorgWarner Company Background Forecasts and Technology Trends Advanced Components
More informationSwitching Control for Smooth Mode Changes in Hybrid Electric Vehicles
Switching Control for Smooth Mode Changes in Hybrid Electric Vehicles Kerem Koprubasi (1), Eric Westervelt (2), Giorgio Rizzoni (3) (1) PhD Student, (2) Assistant Professor, (3) Professor Department of
More informationUtilizing a Small Efficient DCT for the Chinese Market
Utilizing a Small Efficient DCT for the Chinese Market Drivetrain Forum 2016, Untergruppenbach Sascha K. Mierbach GETRAG, Platform Director Small DCT, Magna Powertrain Utilizing a Small Efficient DCT for
More informationScaling Functions for the Simulation of Different SI-Engine Concepts in Conventional and Electrified Power Trains
Scaling Functions for the Simulation of Different SI-Engine Concepts in Conventional and Electrified Power Trains Dipl.-Ing. Michael Huß BMW Group (05/2007 04/2010) Prof. Dr.-Ing Georg Wachtmeister LVK
More informationDevelopment of Two-stage Electric Turbocharging system for Automobiles
Development of Two-stage Electric Turbocharging system for Automobiles 71 BYEONGIL AN *1 NAOMICHI SHIBATA *2 HIROSHI SUZUKI *3 MOTOKI EBISU *1 Engine downsizing using supercharging is progressing to cope
More informationThermoelectric Vehicular Applications Status Mid 2009
Thermoelectric Vehicular Applications Status Mid 2009 John W. Fairbanks Department of Energy Vehicle Technologies August 12, 2009 MIT-NESCAUM Symposium on Energy Dedham, MA International Thermoelectric
More informationPowertrain Technologies Strategies for Advanced Propulsion
Powertrain Technologies Strategies for Advanced Propulsion Rob Rickell Senior Vice President Global Engineering, GKN Driveline Principal Engineer, GKN plc Drivers for technology change are significant,
More informationTechnology and research perspective
Session: Intelligent Mobility and Low Carbon Vehicles Technology and research perspective Ricardo F Martinez-Botas Mechanical Engineering Department Imperial College London Summary An equation Demand Energy
More informationIt s been almost 14 years since 48V SYSTEMS SHOW POTENTIAL NUMBERS GAME:
NUMBERS GAME: 48V SYSTEMS SHOW POTENTIAL BY KARL SEYFERT Once seen as a remedy for tappedout 12V vehicle electrical systems, 48V systems have shown great potential in new applications that boost engine
More informationVehicle Powertrain CO 2 Emissions in Review
Vehicle Powertrain CO 2 Emissions in Review August 17-18, 2011 MIT/NESCAUM Forum Endicott House Tim Johnson JohnsonTV@Corning.com The US EPA (and CARB) are considering 5%/yr reduction in light-duty (LD)
More information1/7. The series hybrid permits the internal combustion engine to operate at optimal speed for any given power requirement.
1/7 Facing the Challenges of the Current Hybrid Electric Drivetrain Jonathan Edelson (Principal Scientist), Paul Siebert, Aaron Sichel, Yadin Klein Chorus Motors Summary Presented is a high phase order
More informationIntegrated Powertrain Simulation for Energy Management of Hybrid Electric Vehicles
Integrated Powertrain Simulation for Energy Management of Hybrid Electric Vehicles October 24 th, 2011 Kentaro Watanabe Nissan Motor Co., Ltd. 1 Outline 1. Motivation 2. Simulation technology 3. Recent
More informationFocus on the Future Powertrain Strategies for the 21st Century
Focus on the Future Powertrain Strategies for the 21st Century University of Michigan July 12, 2011 1 / P ES / Guenther Raab / July 2011 Continental Agenda Challenges in Future Mobility Continental Powertrain
More informationPaving the way for a cleaner, more energy-efficient world.
Paving the way for a cleaner, more energy-efficient world. Wherever the journey the propulsion solution Whether in a highly efficient combustion engine, an intelligent hybrid system or the very latest
More informationBalancing operability and fuel efficiency in the truck and bus industry
Balancing operability and fuel efficiency in the truck and bus industry Realize innovation. Agenda The truck and bus industry is evolving Model-based systems engineering for truck and bus The voice of
More informationHybrids & Electromobility New prerequisites and customer values
Hybrids & Electromobility New prerequisites and customer values Robert Eriksson Volvo Cars Group 2018-02-26 2018-03-05 OuTline Volvo cars vision History and studies CO2 comparison and reductions Requriement
More information8 January
8 January 2019 BlueMatter @CES Propulsion solutions for growth markets Power electronics Gasoline fuel systems CV diesel fuel systems 1 BlueMatter innovation 1 Intelligent driving demo vehicle 2 Intelligent
More informationOptimising Aeristech FETT (Fully Electric Turbocharger Technology) for Future Gasoline Engine Requirements
Optimising Aeristech FETT (Fully Electric Turbocharger Technology) for Future Gasoline Engine Requirements Dr Sam Akehurst, Dr Nic Zhang 25 th April 2017 1 Contents Introduction to the Fully Electric Turbocharging
More informationUPCOMING CO2 LEGISLATION FOR COMMERCIAL VEHICLES IN EUROPE AND US. Lukas Walter, AVL
UPCOMING CO2 LEGISLATION FOR COMMERCIAL VEHICLES IN EUROPE AND US Lukas Walter, AVL CHALLENGES FOR OUR CUSTOMERS CO2 Legislation Competition in TCO Advanced Emission in Emerging Markets Automated Drivelines
More information2018 Schaeffler Symposium 9/6/2018 Markus Steinberger Hybrid Modules Supporting Many Needs
1 Market U.S. light vehicle sales? FWD RWD 17.2 million Market U.S. light vehicle sales? RWD 6.5 million 2 6.5 million RWD vehicles Market RWD 6.5 million vehicles Electrification: series hybrids Fleet
More informationKen Pendlebury. Director, Gasoline Engines Ricardo UK Ltd. Sponsors
Ken Pendlebury Director, Gasoline Engines Ricardo UK Ltd Sponsors Gasoline Engines in an Electrified World CENEX LCV September 2017 Ken Pendlebury, Director, Technical Consultants, Ricardo A decade of
More informationFUTURE TRANSMISSION TRENDS TRANSMISSION AND DRIVELINE SYSTEMS. Collaboration for a Sustainable Future. 40 th Automotive/Petroleum Industry Forum
Collaboration for a Sustainable Future FUTURE TRANSMISSION TRENDS TRANSMISSION AND DRIVELINE SYSTEMS 40 th Automotive/Petroleum Industry Forum Dearborn, MI - USA April 17, 2018 Dr. Kiran Govindswamy, VP
More informationControlled Power Technologies CPT SpeedStart. Belt-Integrated Starter Generator
Controlled Power Technologies CPT SpeedStart Belt-Integrated Starter Generator CPT SpeedStart Belt-Integrated Starter Generator CPT SpeedStart is a highly adaptable 48V motor-generator to support the next
More informationCo-Simulation of GT-Suite and CarMaker for Real Traffic and Race Track Simulations
Co-Simulation of GT-Suite and CarMaker for Real Traffic and Race Track Simulations GT-Suite Conference Frankfurt, 26 th October 215 Andreas Balazs, BGA-T Agenda Introduction Methodology FEV GT-Drive model
More informationControlled Power Technologies. COBRA Water Cooled Electric Supercharger
Controlled Power Technologies COBRA Water Cooled Electric Supercharger COBRA Water Cooled Electric Supercharger COBRA (Controlled Boosting for Rapid response Applications) is a liquid cooled Switched Reluctance
More informationHybrid Architectures for Automated Transmission Systems
1 / 5 Hybrid Architectures for Automated Transmission Systems - add-on and integrated solutions - Dierk REITZ, Uwe WAGNER, Reinhard BERGER LuK GmbH & Co. ohg Bussmatten 2, 77815 Bühl, Germany (E-Mail:
More informationArdalan Vahidi. Clemson Renewable Energy Systems Lab Mechanical Engineering Clemson University
Ardalan Vahidi Clemson Renewable Energy Systems Lab Mechanical Engineering Clemson University Ultracapacitor-assisted conventional powertrains Ultracapacitor-assisted fuel cells Future research plan: Ultracapacitor
More informationThe Chances and Potentials for Low-Voltage Hybrid Solutions in Ultra-Light Vehicles
Switzerland, Schlatt, 9 th -10 th October 2014 The Chances and Potentials for Low-Voltage Hybrid Solutions in Ultra-Light Vehicles Dipl.-Ing. Robert Steffan Prof. Dr. Peter Hofmann Prof. Dr. Bernhard Geringer
More informationEBSF_2 Energy Strategies and Auxiliaries
EBSF_2 Energy Strategies and Auxiliaries EBSF_2 Lyon Demonstration Event Paris, June 14, 2016 Juhani Laurikko, VTT (FI) @ebsf_2project Agenda Comparing Topologies for ICE and e-busses Energy Balance of
More informationhofer powertrain GmbH
HEV 2017 Symposium Braunschweig hofer powertrain GmbH A company of the hofer AG 72622 Nürtingen Ohmstr. 15 email: info@hofer.de Comparison of high power edrive solutions High Current edrives are mainly
More informationSUSTAINABLE TECHNOLOGIES THE CHANGING FACE OF MOBILITY.
Munich, November 4, 2011 SUSTAINABLE TECHNOLOGIES THE CHANGING FACE OF MOBILITY. PHILIP KOEHN VICE PRESIDENT VEHICLE ARCHITECTURES AND CONCEPTS BMW Group, Dr. Ing. Philip Koehn, November 4, 2011, Page
More informationCorporate Presentation
Corporate Presentation 2016 I 1 2016 Valeo in the automotive value chain Service Suppliers represent 75 % of cars added-value* *Source CLEPA 2016 I 2 A well-balanced customer base 14.5 Bn sales (1) Others
More informationBoosting the Starting Torque of Downsized SI Engines GT-Suite User s Conference 2002
GT-Suite User s Conference 2002 Hans Rohs Inst. For Combustion Engines (VKA) RWTH Aachen Knut Habermann, Oliver Lang, Martin Rauscher, Christof Schernus FEV Motorentechnik GmbH Acknowledgement: Some of
More informationA technology factsheet on Volvo Cars T8 Twin Engine AWD powertrain technology ELECTRIFICATION CLEAN EFFICIENCY RESPONSIVE POWER
A technology factsheet on Volvo Cars T8 Twin Engine AWD powertrain technology ELECTRIFICATION CLEAN EFFICIENCY RESPONSIVE POWER Contents Twin Engine (PHEV) Technology 3 - Introducing Twin Engine Technology
More informationBenefits of SiC MOSFET technology in powertrain inverter of a Formula E racing car
Benefits of SiC MOSFET technology in powertrain inverter of a Formula E racing car Dr.-Ing. Felipe Filsecker Application Engineer ROHM Semiconductor GmbH ROHM SiC device development 18 years of experience
More informationA zero-emission future is only impossible until it isn t.
A zero-emission future is only impossible until it isn t. TABLE OF CONTENTS 4 Automotive trends 6 Powertrain architectures 8 Scalability 12 edrive Engineering 14 Road to emobility 18 Hybrid Transmissions
More informationChina Euro Vehicle Technology AB
China Euro Vehicle Technology AB Developing cars for a different tomorrow Börje Grandin Vice President Electric Propulsion Systems This is CEVT Our purpose Developing cars for a different tomorrow Corporate
More informationControlled Power Technologies CPT SpeedTorq. Driveline Motor-Generator Unit
Controlled Power Technologies CPT SpeedTorq Driveline Motor-Generator Unit CPT SpeedTorq Driveline Motor-Generator Unit CPT SpeedTorq is an evolution of the CPT SpeedStart product developed to address
More informationMagna Powertrain - Roadmap into future driveline solutions
Magna Powertrain - Roadmap into future driveline solutions Drivetrain Forum 2016, Untergruppenbach Magna Powertrain, Walter Sackl, Director Product Management, Global Driveline Systems Agenda Requirements
More informationDefining Future Li-Ion Stop-Start Battery Systems for Low-Voltage Hybrid Applications
Defining Future Li-Ion Stop-Start Battery Systems for Low-Voltage Hybrid Applications 3rd WORLD MOBILITY SUMMIT, München, 19. Oktober 2017 Dr Christian Rosenkranz VP Engineering EMEA Johnson Controls Power
More informationThe Nature and Promise of 42 V Automotive Power: An Update
The Nature and Promise of 42 V Automotive Power: An Update Power Area and CEME Seminar, December 2002 P. T. Krein Grainger Center for Electric Machinery and Electromechanics Department of Electrical and
More informationModelling and Simulation Specialists
Modelling and Simulation Specialists Multi-Domain Simulation of Hybrid Vehicles Multiphysics Simulation for Autosport / Motorsport Applications Seminar UK Magnetics Society Claytex Services Limited Software,
More informationThe Poclain hydrostatic transmission for an affordable 4x4 solution
The Poclain hydrostatic transmission for an affordable 4x4 solution Poclain Powertrain s technical proposal is a surprise in the automobile industry: a hydrostatic transmission in order to enjoy four driving
More informationStirling machine as auxiliary power unit for range extender hybrid electric vehicles
Stirling machine as auxiliary power unit for range extender hybrid electric vehicles Sylvie BEGOT, Steve DJETEL, François LANZETTA Femto st Wissam BOU NADER Groupe PSA Context and short term solutions
More informationDirect Injection Ethanol Boosted Gasoline Engines: Biofuel Leveraging For Cost Effective Reduction of Oil Dependence and CO 2 Emissions
Direct Injection Ethanol Boosted Gasoline Engines: Biofuel Leveraging For Cost Effective Reduction of Oil Dependence and CO 2 Emissions D.R. Cohn* L. Bromberg* J.B. Heywood Massachusetts Institute of Technology
More informationPowertrain Efficiency Technologies. Turbochargers
Powertrain Efficiency Technologies Turbochargers Turbochargers increasingly are being used by automakers to make it possible to use downsized gasoline engines that consume less fuel but still deliver the
More informationE-DRIVE: HIGHLY INTEGRATED AND HIGH EFFICIENT
E-DRIVE: HIGHLY INTEGRATED AND HIGH EFFICIENT Korea EV Engineering & Testing Exhibition Roger Perthen AVL List GmbH (Headquarters) KEY ASPECTS FOR BATTERY ELECTRIC VEHICLES (BEVs) E-DRIVE: AFFORDABLE -
More informationLabcar hybride réalisé par le groupement d entreprises
Labcar hybride réalisé par le groupement d entreprises Le premier groupement de PME soutenu par Mov eo DAS CTGE, conférence "électrification des fonctions et des auxiliaires" 15 décembre 2016, Flins 0
More informationDriving dynamics and hybrid combined in the torque vectoring
Driving dynamics and hybrid combined in the torque vectoring Concepts of axle differentials with hybrid functionality and active torque distribution Vehicle Dynamics Expo 2009 Open Technology Forum Dr.
More informationLooking ahead into the future of turbocharging. Knowledge Library. borgwarner.com
Looking ahead into the future of turbocharging Knowledge Library borgwarner.com Knowledge Library Looking ahead into the future of turbocharging Turbocharging system manufacturers are steadily increasing
More informationHySYS: Fuel Cell Hybrid Vehicle System Component Development
HySYS: Fuel Cell Hybrid Vehicle System Component Development Project Overview Final Event 22.09.2010 Stuttgart, Germany Jörg Wind Daimler AG FC Hybrid Vehicle System Component Development FACTS Coordinator:
More informationCost Efficient CO2 Reduction Vehicle Results based on 12V & 48V Architectures
Recuperation Pure Electric Driving Torque Split Boost Advanced Stop/Start esc* BSG esc* 48V BSG 48BSG esc* Cost Efficient CO2 Reduction Vehicle Results based on & 48V Architectures M. Weissbaeck 1, C.
More informationEnergy Efficiency of Automobiles A Pragmatic View
Energy Efficiency of Automobiles A Pragmatic View Bob Lee Vice President Powertrain Product Engineering Chrysler Group LLC IEEE Vehicle Power and Propulsion Conference Dearborn, Michigan September 9, 29
More informationCorrelation NEDC WLTP Proposed additional vehicles for testing
Correlation NEDC WLTP Proposed additional vehicles for testing 18.11.2013 Agenda ACEA was asked to suggest additional vehicles to be measured for calibration and validation purpose, to cover most of the
More informationGT-Suite European User Conference
GT-Suite European User Conference E-Charging on a High Performance Diesel engine D. Peci, C. Venezia EMEA Region - Powertrain Engineering Powertrain Research&Technology Frankfurt, Germany October 26th,
More informationThe Road to Electrification The Magna Powertrain Approach. Dr. Stephan Weng EVP GETRAG Global, Magna Powertrain
The Road to Electrification The Magna Powertrain Approach Dr. Stephan Weng EVP GETRAG Global, Magna Powertrain Technology Drivers Legal Requirements End Consumer Expectations OEM Brand DNA OEM Global Product
More informationBorgWarner s growing hybrid and electric product portfolio delivers clean, efficient vehicle propulsion
News Release BorgWarner s growing hybrid and electric product portfolio delivers clean, efficient vehicle propulsion BorgWarner delivers a growing lineup of propulsion solutions for customers electric
More informationRare Earth Magnets for hybrid and electric cars
Rare Earth Magnets for hybrid and electric cars Dr. Ing. Jérôme LEGRANGER Simulation Manager August 2014 I 1 August 2014 Agenda Introduction : VALEO Presentation Motivation : why more hybrid and electric
More informationAnalysis of regenerative braking effect to improve fuel economy for E-REV bus based on simulation
EVS28 KINTEX, Korea, May 3-6, 2015 Analysis of regenerative braking effect to improve fuel economy for E-REV bus based on simulation Jongdai Choi 1, Jongryeol Jeong 1, Yeong-il Park 2, Suk Won Cha 1 1
More informationVehicle Impact due to E- Mobility 5. Bayerischer Innovationskongress 23.June 2016 Techbase
Vehicle Impact due to E- Mobility 5. Bayerischer Innovationskongress 23.June 2016 Techbase Matthias Töns www.continental-automotive.com Division Powertrain BU Hybrid Electric Vehicle Agenda 1 Business
More informationElectric cars: Technology
In his lecture, Professor Pavol Bauer explains all about how power is converted between the various power sources and power consumers in an electric vehicle. This is done using power electronic converters.
More informationInvestor Presentation
Investor Presentation March 2018 The BorgWarner Strategic Difference Technology Leadership Customer, Geographic and Efficient Propulsion System Diversity Financial Strength and Discipline BorgWarner Inc.
More informationResearch Report. FD807 Electric Vehicle Component Sizing vs. Vehicle Structural Weight Report
RD.9/175.3 Ricardo plc 9 1 FD7 Electric Vehicle Component Sizing vs. Vehicle Structural Weight Report Research Report Conducted by Ricardo for The Aluminum Association 9 - RD.9/175.3 Ricardo plc 9 2 Scope
More informationInto the Future with E-Mobility
Into the Future with E-Mobility ZF products for hybrid and electric vehicles 2 Content 3 01 Electric Mobility 04 Electric Mobility A Megatrend with Potential 02 03 Drive Systems Products 09 10 11 12 13
More informationNew propulsion systems for non-road applications and the impact on combustion engine operation
Research & Technology, New Propulsion Systems (TR-S) New propulsion systems for non-road applications and the impact on combustion engine operation London, 14 th March 2014, Benjamin Oszfolk Content 1
More informationFUTURE OF POWERTRAIN TECHNOLOGY
Craig Balis July 31, 2018 FUTURE OF POWERTRAIN TECHNOLOGY C.A.R. Management Briefing Conference 2 HONEYWELL OVERVIEW $40.5B in sales for 2017 54% of sales outside the U.S. 23,000 engineers worldwide 11,000
More informationZOE Battery Durability, Field Experience and Future Vision
ZOE Battery Durability, Field Experience and Future Vision Dr. Bruno DELOBEL, Dr. Isabel JIMENEZ GORDON, Dr. Lucie LEVEAU Renault Battery Development Department 1 World EV Market ZOE Fluence / SM3 Twizy
More informationFuture Propulsion Systems
Future Propulsion Systems John Kirwan Chief Engineer Advanced Research & Development Driven to make a difference Millions Light-duty hybrids expected to grow Annual hybrids sold forecasted to increase
More informationProgress at LAT. October 23, 2013 LABORATORY OF APPLIED THERMODYNAMICS
LABORATORY OF APPLIED THERMODYNAMICS October 23, 2013 Progress at LAT ARISTOTLE UNIVERSITY THESSALONIKI SCHOOL OF ENGINEERING DEPT. OF MECHANICAL ENGINEERING 1 Contents Vehicle selection Incl. vehicles
More informationPowertrain: New Technologies and Strategies. Contents
Contents Table of Figures... 5 Introduction... 8 Industry Drivers... 13 Legislation and regulation... 13 Sulphur... 18 Meeting consumer requirements... 20 Gasoline Engine Technology... 22 Fuel efficiency...
More informationFuel Cell Hybrid Vehicle System Component Development
Fuel Cell Hybrid Vehicle System Component Development EU Projekt HySYS: Fuel Cell Hybrid Vehicle System Component Development Dr. Jörg Wind, Daimler AG HySYS Technical Workshop, Esslingen, 17.06.2009 FC
More informationEuropean Green Cars Initiative: a coordinated approach
European Green Cars Initiative: a coordinated approach Transport Directorate, DG Research and Innovation - European Commission EUROPEAN COMMISSION 1 A European Economic Recovery Plan Adopted by the EC
More informationDevelopment of Motor-Assisted Hybrid Traction System
Development of -Assisted Hybrid Traction System 1 H. IHARA, H. KAKINUMA, I. SATO, T. INABA, K. ANADA, 2 M. MORIMOTO, Tetsuya ODA, S. KOBAYASHI, T. ONO, R. KARASAWA Hokkaido Railway Company, Sapporo, Japan
More informationHIGH PERFORMANCE 800V E-MOTOR
HIGH PERFORMANCE 800V E-MOTOR FOR AUTOMOTIVE APPLICATION Katrin Wand AVL Trimerics GmbH AVL SOLUTION FOR ALL CUSTOMER SEGMENTS AVL E-Drive Core Competences Powertrain Engineering E-motor EMC Passenger
More informationThe Future of Powertrain The Voltage is Rising!
Bitte decken Sie die schraffierte Fläche mit einem Bild ab. Please cover the shaded area with a picture. (24,4 x 7,6 cm) Dr. Oliver Maiwald, Thomas Müller, Continental AG Dresden, November 13 th, 2017
More informationDr. Terry Alger. Southwest Research Institute. Southwest Research Institute. San Antonio, Texas
Gasoline Engine Technology for High Efficiency Dr. Terry Alger Southwest Research Institute Southwest Research Institute San Antonio, Texas Losses and Opportunities for Improvement in Gasoline Engines
More informationJames Goss, Mircea Popescu, Dave Staton. 11 October 2012, Stuttgart, Germany
Implications of real-world drive cycles on efficiencies and life cycle costs of two solutions for HEV traction: Synchronous PM motor vs Copper Rotor - IM James Goss, Mircea Popescu, Dave Staton 11 October
More informationMODELING, VALIDATION AND ANALYSIS OF HMMWV XM1124 HYBRID POWERTRAIN
2014 NDIA GROUND VEHICLE SYSTEMS ENGINEERING AND TECHNOLOGY SYMPOSIUM POWER & MOBILITY (P&M) TECHNICAL SESSION AUGUST 12-14, 2014 - NOVI, MICHIGAN MODELING, VALIDATION AND ANALYSIS OF HMMWV XM1124 HYBRID
More informationElectro Hydrostatic Actuation Highly efficient implement solution with energy recovery
Electro Hydrostatic Actuation Highly efficient implement solution with energy recovery Dale Vanderlaan Outline Off Highway Technology Trends EHA Technology Journey Application Test Results Key Conclusions
More informationValidation of a simulation model for the assessment of CO 2 emissions of passenger cars under real-world conditions
Validation of a simulation model for the assessment of CO 2 emissions of passenger cars under real-world conditions The gap between real-world fuel consumption and manufacturers figures has been increasing
More informationReal-world to Lab Robust measurement requirements for future vehicle powertrains
Real-world to Lab Robust measurement requirements for future vehicle powertrains Andrew Lewis, Edward Chappell, Richard Burke, Sam Akehurst, Simon Pickering University of Bath Simon Regitz, David R Rogers
More informationMODULAR WATER CHARGE AIR COOLING FOR COMBUSTION ENGINES
DEVELOPMENT Thermal management MODULAR WATER CHARGE AIR COOLING FOR COMBUSTION ENGINES Valeo shows which considerations were taken into account with the development of a modular water charge air cooling
More information