August 2006 Distributor/Dealer Service Instructions for: Safety Recall F33 Directional Signal Bulb Function
|
|
- Maurice Garrison
- 5 years ago
- Views:
Transcription
1 August 2006 Distributor/Dealer Service Instructions for: Safety Recall F33 Directional Signal Bulb Function Models 2005 (LX) 300/Magnum (International Markets) 2006 (LE) 300/Magnum/Charger (International Markets) 2006 (PT) PT Cruiser (International Markets) NOTE: This information applies to all LX models, LE (Graz built) models built through June 22, 2006 (MDH ), and PT models built through January 10, 2006 (MDH ) with side repeater lamps (Sales Code LMF). IMPORTANT: Some of the involved vehicles may be in distributor/dealer used vehicle inventory. Distributors/Dealers should complete this recall service on these vehicles before retail delivery. Distributors/Dealers should also perform this repair on vehicles in for service. Involved vehicles can be determined by using the VIP inquiry process. Subject The driver s telltale for directional signal bulb failure may not provide feedback to the driver if a problem exists with the signal bulb(s) for vehicles built with side repeaters. Copyright 2006, DaimlerChrysler Corporation, All Rights Reserved
2 Repair The Front Control Module (FCM) on LX/LE models or Totally Integrated Power Module (TIPM) on PT models must be reprogrammed. Parts Information No parts required to perform this service procedure. Special Tools The following Special Tools are required to perform this service procedure: NPN Battery Charger CH9401 StarSCAN Tool CH9404 StarSCAN Vehicle Cable CH9409 StarSCAN Documentation Kit CH9410 StarSCAN Ethernet Cable, 3.7 m (12 ft.) CH9412 StarSCAN Software Update Device Kit TechCONNECT PC or equivalent Service Procedure Reprogram the FCM/TIPM Module NOTE: Before performing this Repair Procedure, the operating software in the StarSCAN must be programmed with software release level 7.01 or higher. The software release level is visible in the blue header at the top of the StarSCAN screen. CAUTION: Follow the flash reprogramming procedure carefully on LX/LE models. The FCM does not support abort/recovery. If an error occurs, the FCM will require replacement.
3 Service Procedure cont. NOTE: The StarSCAN diagnostic scan tool fully supports Internet connectivity. However, to take advantage of this feature you must first configure the StarSCAN for your dealership's network. Make sure the StarSCAN is configured to the dealership's network before proceeding. For instruction on setting up your StarSCAN for the dealer's network refer to either: DealerCONNECT > Service > StarSCAN and StarMOBILE tools > Online Documentation, or refer to the StarSCAN Quick Start Networking Guide. The StarSCAN Quick Start Networking Guide is also available on the website under the "Download Center". 1. Install a battery charger and verify that the charging rate provides approximately volts. Set the battery charger to continuous charge. Do not allow the charger to time out during the flash process. Remove the charger from the battery when the flash process is complete. 2. Connect the CH9410 StarSCAN ethernet cable to the StarSCAN and the dealer's network drop. 3. Connect the CH9404 StarSCAN vehicle cable to the StarSCAN and the vehicle. 4. Power ON the StarSCAN. 5. Select "ECU View". 6. Touch the screen to highlight the TIPM/CGW or Front Control/Central Gateway in the list of modules. 7. Select "More Options". 8. Select "ECU Flash" 9. Record the part number at the top of the "Flash" screen for later reference. 10. Select "Browse for New File". Follow the on screen instructions. 11. Highlight the appropriate calibration then select "Download to Scantool" 12. Select "Close" after the download is complete, and then select "Back". 13. Highlight the listed calibration. 14. Select "Update Controller". Follow the on screen instructions. 15. When the update is complete, select "OK".
4 Service Procedure cont. 16. Verify the part number at the top of the "Flash screen has updated to the new part number. NOTE: Due to FCM/TIPM programming, a DTC may be set in other modules (PCM, TCM, BCM, MIC, SKREEM, etc.) within the vehicle, if so equipped. Some DTC's may cause the MIL to illuminate. From the "Home" screen select "System View". Then select "All DTCs". Press "Clear All Stored DTCs" if there are any DTCs shown on the list. Completion Reporting and Reimbursement Claims for vehicles that have been serviced must be submitted on the DealerCONNECT Claim Entry Screen located on the Service tab. Claims submitted will be used by DaimlerChrysler to record recall service completions and provide dealer payments. Use the following labor operation number and time allowance: Labor Operation Number Time Allowance Reprogram FCM - LX/LE (B) 18-F hours Reprogram TIPM - PT (B) 18-F hours NOTE: See the Warranty Administration Manual, Recall Claim Processing Section, for complete recall claim processing instructions. Distributor/ Dealer Notification and Vehicle List Regional offices will receive an electronic list of involved vehicles. The Vehicle List is arranged by Distributor/Dealer code and in Vehicle Identification Number (VIN) sequence. The lists are for Distributor/Dealer reference in arranging for service of involved vehicles.
5 Owner Notification and Service Scheduling All involved vehicle owners should be notified of the service requirement by their Distributor/Dealer. Owners are requested to schedule appointments for this service. A sample copy of the owner notification letter is attached. Vehicle Lists, Global Recall System, VIP and Distributor/Dealer Follow up All involved vehicles have been entered into the Global Recall System (GRS) and Vehicle Information Plus (VIP) for Distributor/Dealer inquiry as needed. GRS provides involved Distributors/Dealers with an updated VIN list of their incomplete vehicles. Completed vehicles are removed from GRS within several days of repair claim submission. Distributors/Dealers must perform this repair on all unsold vehicles before retail delivery. Distributors/Dealers should also use the VIN list to follow up with all owners to schedule appointments for this repair. Additional Information If you have any questions or need assistance in completing this action, please contact your International Service and Parts Manager. International Service and Parts DaimlerChrysler Corporation
6 SAFETY RECALL - DIRECTIONAL SIGNAL BULB FUNCTION Dear 300/Charger/Magnum/PT Cruiser Owner: Customer satisfaction is very important to DaimlerChrysler. Accordingly, we are recommending the following service on 2005 model 300/Magnum vehicles and some /Magnum/Charger/PT Cruiser vehicles. The problem is... The driver s telltale for directional signal bulb failure may not provide feedback to the driver if a problem exists with the signal bulb(s). What your dealer will do... What you must do... If you need help... DaimlerChrysler will repair your vehicle free of charge (parts and labor). To do this, your dealer will reprogram the Central Gateway Module with new software. The work will take about ½ hour to complete. However, additional time may be necessary depending on how dealer appointments are scheduled and processed. Simply contact your dealer right away to schedule a service appointment. If you have trouble getting your vehicle serviced, please contact the DaimlerChrysler Distributor nearest your location. A representative will assist you in getting your vehicle serviced. This information can be found in the Customer Assistance section of your Owner's Manual. If you have already experienced the problem described above and have paid to have it repaired, contact the DaimlerChrysler Distributor nearest your location for reimbursement procedures. We apologize for any inconvenience, but we are sincerely concerned about your satisfaction with your DaimlerChrysler vehicle. Thank you for your attention to this important matter. International Service & Parts DaimlerChrysler Corporation Notification Code F33 Copyright 2006, DaimlerChrysler Corporation, All Rights Reserved
October 2006 Dealer Service Instructions for: Safety Recall F43 Reprogram PCM Transmission Shift Logic
October 2006 Dealer Service Instructions for: Safety Recall F43 Models 2007 (KA) Dodge Nitro (built through August 9, 2006 - MDH 080916). 2007 (KJ) Jeep Liberty (built through August 9, 2006 - MDH 080916).
More informationDecember Distributor/Dealer Service Instructions for: Safety Recall G31 TIPM Re-Configure, Headlamp Leveling
December Distributor/Dealer Service Instructions for: Safety Recall G31 TIPM Re-Configure, Headlamp Leveling Models 2007 2008 (JS/PM/MK) Sebring, Avenger, Caliber, Compass and Patriot vehicles (International
More informationOctober 2006 Dealer Service Instructions for: Safety Recall F43 Reprogram PCM Transmission Shift Logic
October 2006 Dealer Service Instructions for: Safety Recall F43 Models 2007 (KA) Dodge Nitro (built through August 9, 2006 - MDH 080916). 2007 (KJ) Jeep Liberty (built through August 9, 2006 - MDH 080916).
More information2007 (PM) Dodge Caliber
July 2006 Dealer Service Instructions for: Emissions Recall F29 Effective immediately, all repairs on involved vehicles are to be performed according to this notification. Service Bulletin (TSB) # 18-020-06
More information2006 (LX) Chrysler 300, Dodge Magnum and Charger
Dealer Service Instructions for: Emissions Recall F47 Catalytic Converter and Reprogram PCM March 2007 Effective immediately all repairs on involved vehicles are to be performed according to this notification.
More information(KL) Jeep Cherokee
Dealer Service Instructions for: Customer Satisfaction Notification S78 Reprogram Engine Control Module October 2016 Effective immediately all repairs on involved vehicles are to be performed according
More informationTHE StarSCAN FLASH FILES FOR THIS BULLETIN MUST BE RETRIEVED FROM THE INTERNET.
NUMBER: GROUP: 18-003-07 REV. A Vehicle Performance DATE: March 7, 2007 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be
More informationDecember 2004 Distributor/Dealer Service Instructions for: Safety Recall D47 - Upper Ball Joints (AN) Dodge Dakota 4x4 Pick-Up Truck
December 2004 Distributor/Dealer Service Instructions for: Safety Recall D47 - Upper Ball Joints Models 2000-2003 (AN) Dodge Dakota 4x4 Pick-Up Truck 2000-2003 (DN) Dodge Durango 4x4 NOTE: This notification
More informationCustomer Satisfaction Notification No. C42 Powertrain Control Module Connectors
Distributor/Dealer Service Instructions for: February 2004 Customer Satisfaction Notification No. C42 Effective immediately, all repairs on involved vehicles are to be performed according to this notification.
More informationDistributor/Dealer Service Instructions for: Customer Satisfaction Notification M04 Engine Oil Addendum Card
Distributor/Dealer Service Instructions for: Customer Satisfaction Notification M04 March 2012 Models 2012 (LC/LD) Dodge Challenger SRT and Charger SRT (LX) Chrysler 300 SRT NOTE: This notification applies
More informationJune 2014 Dealer Service Instructions for: Safety Recall P31 Reprogram Adaptive Cruise Control Module
June 2014 Dealer Service Instructions for: Safety Recall P31 Reprogram Adaptive Cruise Control Module Models 2014 (WD) Dodge Durango (WK) Jeep Grand Cherokee and Grand Cherokee SRT (KL) Jeep Cherokee NOTE:
More informationIMPORTANT: A small number of the above vehicles have already been reprogrammed and, therefore, have been excluded from this recall.
Dealer Service Instructions for: Safety Recall No. C33 Reprogram BCM Vehicle Lighting November 2003 Models 2003 (ZB) Dodge Viper IMPORTANT: A small number of the above vehicles have already been reprogrammed
More information(WK) Jeep Grand Cherokee (XK) Jeep Commander
Dealer Service Instructions for: Customer Satisfaction Notification P73 Reprogram Final Drive Control Module May 2015 Models 2005-2010 (WK) Jeep Grand Cherokee 2006-2010 (XK) Jeep Commander NOTE: This
More informationTHE StarSCAN FLASH FILES FOR THIS BULLETIN MUST BE RETRIEVED FROM THE INTERNET. StarSCAN SOFTWARE LEVEL MUST BE AT RELEASE 8.03 OR HIGHER.
NUMBER: GROUP: 21-002-07 REV. E Transmission DATE: December 21, 2007 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,
More informationDecember 2004 Distributor/Dealer Service Instructions for: Safety Recall D55 Right Steering Knuckle. Models
December 2004 Distributor/Dealer Service Instructions for: Safety Recall D55 Right Steering Knuckle Models 2005 (JR) Dodge Stratus Sedan and Chrysler Sebring Sedan/Convertible NOTE: This recall applies
More information5/6/2018 Rc-M38-13 Customer Satisfaction Notification M38 - Reprogram Powertrain Control Module 2013 Dodge Caravan - RT MotoLogic
2013 Caravan - RT Report a problem with this article Dealer Service Instructions for: Customer Satisfaction Notification M38 January 2013 Effective immediately all repairs on involved vehicles are to be
More informationTHE StarSCAN FLASH FILES FOR THIS BULLETIN MUST BE RETRIEVED FROM THE INTERNET.
NUMBER: GROUP: 18-006-08 REV. A Vehicle Performance DATE: April 8, 2008 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be
More informationNovember 2009 Dealer Service Instructions for: Customer Satisfaction Notification J21 Hot Start Engine Cranking
November 2009 Dealer Service Instructions for: Customer Satisfaction Notification J21 Effective immediately all repairs on involved vehicles are to be performed according to this notification. Rapid Response
More informationSUBJECT: Long Engine Crank Time And/Or MIL Illumination Due To DTC P0340 / P0344
NUMBER: GROUP: 08-001-08 REV. A Electrical DATE: February 23, 2008 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,
More information2016 (WK) Jeep Grand Cherokee
Revision II August 2016 Dealer Service Instructions for: Safety Recall S28 Shift Interlock Solenoid Electrical Connector NOTE: The service procedure has been updated. Models 2016 (WK) Jeep Grand Cherokee
More informationDistributor/Dealer Service Instructions for: Customer Satisfaction Notification L10 Coolant Reservoir Outlet Hose
Distributor/Dealer Service Instructions for: Customer Satisfaction Notification L10 April 2011 Effective immediately all repairs on involved vehicles are to be performed according to this notification.
More informationJune 2014 Dealer Service Instructions for: Safety Recall P31 / NHTSA 14V-293 Reprogram Adaptive Cruise Control Module
June 2014 Dealer Service Instructions for: Safety Recall P31 / NHTSA 14V-293 Reprogram Adaptive Cruise Control Module Models 2014 (WD) Dodge Durango (WK) Jeep Grand Cherokee and Grand Cherokee SRT (KL)
More information(KL) Jeep Cherokee
Dealer Service Instructions for: Safety Recall S41 Wheel Flare Protection Spats Revised November 2016 NOTE: Inspection LOP changed to 0.1 hours and $5 inspection fee eliminated. Models 2014-2016 (KL) Jeep
More informationRevised October 2014 Dealer Service Instructions for: Customer Satisfaction Notification P56 Reprogram Transmission Control Module
Revised October 2014 Dealer Service Instructions for: Customer Satisfaction Notification P56 NOTE: Labor operation numbers for the related operations have been revised. Models 2014-2015 (KL) Jeep Cherokee
More informationDealer Service Instructions for: Customer Satisfaction Notification M04 Engine Oil Addendum Card and Tip Card
Dealer Service Instructions for: Customer Satisfaction Notification M04 March 2012 Models 2012 (LC/LD) Dodge Challenger SRT and Charger SRT (LX) Chrysler 300 SRT NOTE: This notification applies only to
More informationSeptember 2010 Dealer Service Instructions for: Customer Satisfaction Notification K17 Reprogram HVAC Control Head and Inspect/Replace Actuators
September 2010 Dealer Service Instructions for: Customer Satisfaction Notification K17 Reprogram HVAC Control Head and Inspect/Replace Actuators Models 2009-2010 (DS) Ram Truck (1500 series) 2010 (DJ)
More information2014 (DS) RAM Pick Up Truck (1500 series) NOTE: This recall applies only to the above vehicles built with Hitachi rear shock
Dealer Service Instructions for: Safety Recall P37 Rear Suspension Shock Absorbers September 2014 Models 2014 (DS) RAM Pick Up Truck (1500 series) NOTE: This recall applies only to the above vehicles built
More information(WK) Jeep Grand Cherokee (WD) Dodge Durango
Dealer Service Instructions for: Safety Recall S16 Left Front Brake Caliper Revised May 2016 Models NOTE: The wheel lug nut torque specification has been updated. 2015-2016 (WK) Jeep Grand Cherokee (WD)
More informationDealer Service Instructions for: Safety Recall G15 Rear Wheel Hub Mounting Bolts
Dealer Service Instructions for: Safety Recall G15 Rear Wheel Hub Mounting Bolts May 2007 Models 2007 (MK) Jeep Compass and Patriot 2007 (PM) Dodge Caliber NOTE: This recall applies only to the above vehicles
More informationDealer Service Instructions for: Safety Recall H37 Gearshift Cable
Dealer Service Instructions for: Safety Recall H37 Gearshift Cable Revised December 2008 Please remove and discard from your files all prior copies of Safety Recall H37 (dated November 2008). The repair
More information2012 (WK) Jeep Grand Cherokee SRT8
April 2013 Dealer Service Instructions for: Customer Satisfaction Notification N06 Models 2012 (WK) Jeep Grand Cherokee SRT8 NOTE: This notification applies only to the above vehicles equipped with a 6.4L
More informationDealer Service Instructions for: Customer Satisfaction Notification L10 Coolant Reservoir Outlet Hose
Dealer Service Instructions for: Customer Satisfaction Notification L10 April 2011 Effective immediately all repairs on involved vehicles are to be performed according to this notification. Rapid Response
More information(LX) Chrysler 300, Chrysler 300 SRT8, Dodge Charger and Dodge Charger SRT8
Dealer Service Instructions for: Safety Recall J27 Front Wheel Hub Nuts November 2009 Models 2009-2010 (LX) Chrysler 300, Chrysler 300 SRT8, Dodge Charger and Dodge Charger SRT8 (LC) Dodge Challenger and
More information2011 (LC) Dodge Challenger (LD) Dodge Charger
Dealer Service Instructions for: Customer Satisfaction Notification L28 March 2012 Models 2011 (LC) Dodge Challenger (LD) Dodge Charger NOTE: This notification applies only to the above vehicles built
More information2014 (LC) Dodge Challenger (LD) Dodge Charger (LX) Chrysler 300 (WD) Dodge Durango (WK) Jeep Grand Cherokee
Dealer Service Instructions for: Safety Recall T75 / NHTSA 17V-741 Alternator December 2017 Models 2014 (LC) Dodge Challenger (LD) Dodge Charger (LX) Chrysler 300 (WD) Dodge Durango (WK) Jeep Grand Cherokee
More informationSafety Recall D21 Rear Floorpan Reinforcement Spot Welds
Dealer Service Instructions for: July 2004 Safety Recall D21 Rear Floorpan Reinforcement Spot Welds Models 2005 (LX) Chrysler 300 and Dodge Magnum NOTE: This recall applies only to the certain vehicles
More information(KL) Jeep Cherokee
Dealer Service Instructions for: Safety Recall S63 / NHTSA 16V-590 Seat Fastener Torque October 2016 Models 2014-2016 (KL) Jeep Cherokee NOTE: This recall applies only to the above vehicles built from
More information2004 RAM 1500, 2500 Pickup (4.7L V8 Magnum Flex Fuel) - DR
2004 RAM 1500, 2500 Pickup (4.7L V8 Magnum Flex Fuel) - DR Report a problem with this article https://www.motologic.com/car/2004_dodge_dr_ram_1500_2500_pickup_4_7l_magnum_v8_ffv/article/73fed3bad56c749babc23c6c5340f378?return
More informationDealer Service Instructions for: Safety Recall H28 Park Brake Lever
Dealer Service Instructions for: Safety Recall H28 Park Brake Lever October 2008 Models 2007-2008 (KA) Dodge Nitro 2008 (KK) Jeep Liberty NOTE: This recall applies only to the above vehicles equipped with
More information2003 (LH) Dodge Intrepid, Chrysler Concorde and 300M (PT) Chrysler PT Cruiser (PL) Dodge Neon (JR) Dodge Stratus Sedan
Dealer Service Instructions for: Customer Satisfaction Notification No. C08 March 2003 Effective immediately, all repairs on involved vehicles are to be performed according to this notification. Rapid
More information(DM) RAM Truck (4500/5500 Cab Chassis) (DP) RAM Truck (4500/5500 Cab Chassis)
Dealer Service Instructions for: Safety Recall R16 / NHTSA 13V-527 Steering Linkage May 2015 NOTE: Safety Recall N63 is being cancelled. All vehicles involved in Safety Recall N63 must have this recall
More informationAugust 2010 Dealer Service Instructions for: Customer Satisfaction Notification K16 Automatic Transmission Shift Lever Interlock Spring
August 2010 Dealer Service Instructions for: Customer Satisfaction Notification K16 Automatic Transmission Shift Lever Interlock Spring Models 2007-2008 (JS) Dodge Avenger, Chrysler Sebring Convertible
More informationEach dealer to whom vehicles in the recall were invoiced will receive enough Wiring Harness Packages to service about 5% of those vehicles.
April 2003 Dealer Service Instructions for: Safety Recall No. C11 Blower Motor Wiring Models 2002 (DR) Dodge Ram 1500 Pick-up Trucks IMPORTANT: Some of the involved vehicles may be in dealer used vehicle
More information2017 (KL) Jeep Cherokee
Dealer Service Instructions for: Safety Recall S84 / NHTSA 16V-799 Knee Blocker Airbag Assembly November 2016 Models 2017 (KL) Jeep Cherokee NOTE: This recall applies only to the above vehicles built from
More information2009 (DH) Dodge Ram Truck 2500 series (DM) Dodge Ram Truck 4500/5500 series (D1) Dodge Ram Truck 3500 series
Dealer Service Instructions for: Safety Recall J37 Brake Pedal Linkage Clip January 2010 Effective immediately all repairs on involved vehicles are to be performed according to this notification. Rapid
More informationDealer Service Instructions for: Safety Recall E14 Transmission Cup Plug Bracket
Dealer Service Instructions for: Safety Recall E14 Transmission Cup Plug Bracket November, 2005 Models 2005-2006 (TJ) JeepB BWrangler 2005-2006 (HB) Dodge Durango 2005-2006 (KJ) JeepB B Liberty 2005-2006
More informationDecember 2000 Dealer Service Instructions for:
December 2000 Dealer Service Instructions for: Safety Recall No. 964 -- Starter Terminal Block Models 2001 (PL) Dodge Neon R/T NOTE: This recall applies only to the above vehicles equipped with a 2.0L
More informationDealer Service Instructions for: Safety Recall S61 Occupant Restraint Controller
Dealer Service Instructions for: Safety Recall S61 Occupant Restraint Controller NOTE: Revised Owner Letter (page 31). Models September 2017 2010 (JS) Chrysler Sebring 2011-2014 (JS) Chrysler 200 2010-2014
More informationDealer Service Instructions for: Safety Recall N28 / NHTSA 13V-234 Transmission Oil Cooler Tube
Dealer Service Instructions for: Safety Recall N28 / NHTSA 13V-234 Transmission Oil Cooler Tube September 2013 Models 2012-2013 (JK) Jeep Wrangler NOTE: This recall applies only to the above vehicles equipped
More informationTHE SOFTWARE WILL BE AVAILABLE ON TechCONNECT ON FEBRUARY 3, 2004.
NUMBER: 18-002-04 GROUP: Vehicle Performance DATE: February 3, 2004 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,
More informationOVERVIEW: This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software.
NUMBER: GROUP: 18-026-03 REV. A Vehicle Performance DATE: September 12, 2003 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication
More informationDealer Service Instructions for: Customer Satisfaction Notification No. B27 Transaxle Low/Reverse Accumulator Cover
Dealer Service Instructions for: Customer Satisfaction Notification No. B27 October 2002 Effective immediately, all repairs on involved vehicles are to be performed according to this notification. Rapid
More information(KJ) Jeep Liberty
Dealer Service Instructions for: Safety Recall N46 Rear Structural Reinforcement Revised August 2014 NOTE: An additional labor operation has been added to the recall that includes additional labor time
More informationSafety Recall H46 - Mopar Steering Linkage
Dealer Service Instructions for: Revised May 2009 Safety Recall H46 - Mopar Steering Linkage NOTE: The service procedure for this recall has been revised and additional labor operations have been added.
More informationNOTE: BEFORE ATTEMPTING THIS RECALL, REVIEW VIP OR VEHICLE HISTORY TAB TO VERIFY THAT THE RECALL APPLIES TO THIS VEHICLE AND HAS NOT BEEN COMPLETED.
NOTE: BEFORE ATTEMPTING THIS RECALL, REVIEW VIP OR VEHICLE HISTORY TAB TO VERIFY THAT THE RECALL APPLIES TO THIS VEHICLE AND HAS NOT BEEN COMPLETED. To: All California Dodge, Chrysler-Plymouth And Jeep
More informationJune 17,2011
@CHRVSLER June 17,2011 Mr. Claude Harris Associate Administrator for Enforcement National Highway Traffic Safety Administration 1200 New Jersey Ave. S.W. Washington, D.C. 20590 Dear Mr. Harris: Reference:
More informationRevised : September 2015 September 2015 Dealer Service Instructions for: Safety Recall R36 Steering Wheel Wiring
Revised : September 2015 September 2015 Dealer Service Instructions for: Safety Recall R36 Steering Wheel Wiring NOTE: Revised the parts information notes. Models 2012 2014 (DS) RAM 1500 Pickup 2012 2014
More informationOVERVIEW: This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software.
NUMBER: 18-032-03 GROUP: Vehicle Performance DATE: Sep. 12, 2003 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,
More informationDealer Service Instructions for: Emissions Recall J25 Mopar Value Line Catalytic Converters
Dealer Service Instructions for: Emissions Recall J25 Mopar Value Line Catalytic Converters October 2009 Models 1997 1999 (AN) Dodge Dakota 1998 1999 (BE) Dodge Ram Truck 1995 1999 (BR) Dodge Ram Truck
More informationAugust Models (PL) Dodge and Plymouth Neon
Dealer Service Instructions for: Safety Recall No. 886 PCV System Make-Up Air Tube August 2000 Models 2000 (PL) Dodge and Plymouth Neon IMPORTANT: Some of the involved vehicles may be in dealer new vehicle
More informationDealer Service Instructions for: Safety Recall J33 Instrument Panel Top Cover
Dealer Service Instructions for: Safety Recall J33 Instrument Panel Top Cover November 2009 Models 2010 (WK) Jeep Grand Cherokee NOTE: This recall applies only to the above vehicles built from October
More informationJuly Models. Subject
Dealer Service Instructions for: July 2001 Safety Recall No. 970 Models 1994-1996 (BR) Dodge Ram Pickup Trucks NOTE: This recall applies only to the above vehicles equipped with a 5.9L Cummins turbo diesel
More informationTHE DRBIII FLASH FILES FOR THIS BULLETIN ARE AVAILABLE ON DealerCONNECT.
NUMBER: 18-042-14 GROUP: Vehicle Performance DATE: July 30, 2014 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,
More informationTHE DRBIII FLASH FILES FOR THIS BULLETIN ARE AVAILABLE ON DealerCONNECT.
NUMBER: 18-033-04 GROUP: Vehicle Performance DATE: August 20, 2004 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,
More informationDirector P. O. Box 1904 Service Engineering Operations Dearborn, Michigan Ford Customer Service Division
David J. Johnson Ford Motor Company Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan 48121 Ford Customer Service Division TO: All U.S. Ford and Lincoln Dealers March 1, 2018 SUBJECT:
More informationTHE DRBIII FLASH FILES FOR THIS BULLETIN ARE AVAILABLE ON DealerCONNECT.
NUMBER: GROUP: 18-006-04 REV. B Vehicle Performance DATE: September 13, 2004 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication
More informationTHIS BULLETIN IS BEING PROVIDED IN ADVANCE. THE SOFTWARE WILL BE AVAILABLE ON TechCONNECT ON OR AFTER DECEMBER 15, 2003.
NUMBER: 18-042-03 GROUP: Vehicle Performance DATE: November 28, 2003 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,
More informationTHE SOFTWARE FOR THE DRB III WILL BE AVAILABLE ON DealerCONNECT JUNE 1, 2004.
NUMBER: 18-024-04 GROUP: Vehicle Performance DATE: June 1, 2004 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,
More informationTHE witech SOFTWARE LEVEL MUST BE AT RELEASE OR HIGHER TO PERFORM THIS PROCEDURE.
NUMBER: 18-006-12 GROUP: Vehicle Performance DATE: February 04, 2012 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,
More informationTHE witech SOFTWARE IS REQUIRED TO BE AT THE LATEST RELEASE BEFORE PERFORMING THIS PROCEDURE.
NUMBER: 18-095-15 GROUP: Vehicle Performance DATE: November 25, 2015 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,
More information(RT) Dodge Grand Caravan / Chrysler Town & Country
Revised September 2015 Dealer Service Instructions for: Safety Recall R03 / NHTSA 14V-373 Wireless Ignition Node Module NOTE: The Parts Return section has been updated. NOTE: This recall replaces Safety
More informationCUSTOMER SATISFACTION NOTIFICATION L10 COOLANT RESERVOIR OUTLET HOSE
IMPORTANT DEALER SERVICE INSTRUCTIONS CUSTOMER SATISFACTION NOTIFICATION COOLANT RESERVOIR OUTLET HOSE Effective immediately all repairs on involved vehicles are to be performed according to this notification.
More information(RT) Dodge Grand Caravan / Chrysler Town & Country
Revised September 2015 Dealer Service Instructions for: Wireless Ignition Node Module NOTE: The Parts Return section has been updated. NOTE: This recall replaces Safety Recall L25. Safety Recall L25 is
More informationSERVICE PROGRAM BULLETIN
ATTENTION: GENERAL MANAGER PARTS MANAGER CLAIMS PERSONNEL SERVICE MANAGER IMPORTANT - All Service Personnel Should Read and Initial SERVICE PROGRAM BULLETIN APPLICABILITY: SUBJECT: 2000MY Subaru Legacy
More informationZoom and Print Options
1 of 6 11/16/2017, 7:43 PM Vehicle» Powertrain Management» Computers and Control Systems» Engine Control Module» Technical Service Bulletins» All Technical Service Bulletins» Campaign SA120 - MIL ON/DTC
More informationTHE witech SOFTWARE IS REQUIRED TO BE AT THE LATEST RELEASE BEFORE PERFORMING THIS PROCEDURE.
NUMBER: GROUP: 21-021-15 REV. E Transmission and Transfer Case DATE: October 01, 2015 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication
More information#12187C: Customer Satisfaction - Automatic Crash Response System - Reprogram SDM - (Sep 23, 2014)
Page 1 of 5 Document ID: 3988462 #12187C: Customer Satisfaction - Automatic Crash Response System - Reprogram SDM - (Sep 23, 2014) Subject: 12187C Automatic Crash Response System Reprogram SDM Models:
More informationTHE witech SOFTWARE LEVEL MUST BE AT OR HIGHER TO PERFORM THIS PROCEDURE.
NUMBER: 21-001-15 GROUP: and Transfer Case DATE: January 10, 2015 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,
More informationSB THE witech SOFTWARE IS REQUIRED TO BE AT THE LATEST RELEASE BEFORE PERFORMING THIS PROCEDURE.
SB-10058327-8669 NUMBER: GROUP: 18-009-15 REV. F Vehicle Performance DATE: September 19, 2015 This bulletin is supplied as technical information only and is not an authorization for repair. No part of
More informationDirector P. O. Box 1904 Service Engineering Operations Dearborn, Michigan Ford Customer Service Division
Michael A. Berardi Ford Motor Company Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan 48121 Ford Customer Service Division TO: All U.S. Ford and Lincoln Dealers November 14, 2016
More informationFOR HELP WITH USING witech FOR ECU FLASH REPROGRAMMING, CLICK ON THE APPLICATION S HELP TAB.
NUMBER: GROUP: 18-087-16 REV. A Vehicle Performance DATE: August 24, 2016 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may
More informationTECHNICAL SERVICE BULLETIN
GROUP ENG MODEL 2015MY K900 (KH) NUMBER DATE 141 (REV 1, 04/25/2014) April 2014 TECHNICAL SERVICE BULLETIN This bulletin has been revised to include additional information. New/revised sections of this
More informationDirector P. O. Box 1904 Service Engineering Operations Dearborn, Michigan Ford Customer Service Division
David J. Johnson Ford Motor Company Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan 48121 Ford Customer Service Division TO: SUBJECT: All U.S. Ford and Lincoln Dealers April 24,
More informationFOR HELP WITH USING witech FOR ECU FLASH REPROGRAMMING, CLICK ON THE APPLICATION S HELP TAB.
NUMBER: GROUP: 18-003-17 REV. B Vehicle Performance DATE: February 21, 2017 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may
More informationDirector P. O. Box 1904 Service Engineering Operations Dearborn, Michigan Ford Customer Service Division
Michael A. Berardi Ford Motor Company Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan 48121 Ford Customer Service Division TO: SUBJECT: AFFECTED VEHICLES All U.S. Ford and Lincoln
More informationSafety Recall Circular
IMPORTANT INFORMATION Please inform and provide a copy of this document to every person in your dealership with campaign-related responsibilities, including Service, Parts and Accounting personnel. By
More informationTHE witech SOFTWARE IS REQUIRED TO BE AT THE LATEST RELEASE BEFORE PERFORMING THIS PROCEDURE.
NUMBER: 18-094-15 GROUP: Vehicle Performance DATE: November 25, 2015 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,
More informationFOR HELP WITH USING witech FOR ECU FLASH REPROGRAMMING, CLICK ON THE APPLICATION S HELP TAB.
NUMBER: GROUP: 18-022-17 REV. B Vehicle Performance DATE: April 07, 2017 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may
More informationDealer Service Instructions for: Safety Recall T59 / NHTSA 17V-572 Brake Booster Water Shield
Dealer Service Instructions for: Safety Recall T59 / NHTSA 17V-572 Brake Booster Water Shield November 2017 STOP Brake booster water shield must be installed correctly in order to function properly. STOP
More informationTHE witech SOFTWARE IS REQUIRED TO BE AT THE LATEST RELEASE BEFORE PERFORMING THIS PROCEDURE.
NUMBER: GROUP: 18-021-15 REV. C Vehicle Performance DATE: June 10, 2015 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be
More informationDirector P. O. Box 1904 Service Engineering Operations Dearborn, Michigan Ford Customer Service Division
Michael A. Berardi Ford Motor Company Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan 48121 Ford Customer Service Division TO: All U.S. Ford and Lincoln Dealers June 27, 2017
More informationDirector P. O. Box 1904 Service Engineering Operations Dearborn, Michigan Ford Customer Service Division
Michael A. Berardi Ford Motor Company Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan 48121 Ford Customer Service Division TO: All U.S. Ford and Lincoln Dealers November 11, 2015
More informationTHE witech SOFTWARE LEVEL MUST BE AT RELEASE OR HIGHER TO PERFORM THIS PROCEDURE.
NUMBER: 18-014-10 GROUP: Vehicle Performance DATE: April 28, 2010 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,
More informationTECHNICAL SERVICE BULLETIN
File Under: x GROUP FUEL NUMBER Circulate To: General Manager Service Manager Parts Manager x Service Advisor(s) x x x x MODEL 2014MY Forte (YD) w/2.0l GDI DATE 027 (REV 1, 11/15/2013) November
More informationDirector P. O. Box 1904 Service Engineering Operations Dearborn, Michigan Ford Customer Service Division
Michael A. Berardi Ford Motor Company Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan 48121 Ford Customer Service Division TO: SUBJECT: REF: All U.S. Ford and Lincoln Dealers
More information2004 Dodge Pickup R1500 MIL ILLUMINATION DIAGNOSTIC TROUBLE CODES P0401, P0403, P0404, P0405, P0406 TECHNICAL SERVICE BULLETIN
TECHNICAL SERVICE BULLETIN Reference Number(s): 18-021-04, Date of Issue: May 4, 2004 GROUP: Vehicle Performance SUBJECT MIL Illumination Diagnostic Trouble Codes P0401, P0403, P0404, P0405, P0406 OVERVIEW
More informationIMPORTANT SAFETY RECALL
DEPARTMENT OF COMPLIANCE VEHICLE SAFETY AND RECALL MANAGEMENT BUILDING 11 423 N MAIN ST MIDDLEBURY, INDIANA 46540-9218 NHTSA RECALL: 17V707 CANADA RECALL: NONE
More informationDirector P. O. Box 1904 Service Engineering Operations Dearborn, Michigan Ford Customer Service Division
Michael A. Berardi Ford Motor Company Director P. O. Box 1904 Service Engineering Operations Dearborn, Michigan 48121 Ford Customer Service Division TO: All U.S. Ford and Lincoln Dealers August 26, 2014
More informationFOR HELP WITH USING witech FOR ECU FLASH REPROGRAMMING, CLICK ON THE APPLICATION S HELP TAB.
NUMBER: 21-019-17 GROUP: and Transfer Case DATE: April 22, 2017 This bulletin is supplied as technical information only and is not an authorization for repair. No part of this publication may be reproduced,
More informationSERVICE BULLETIN FIREBOLT HEADLIGHTS PRODUCT PROGRAM 0501 Reason For Revision. Purpose. Kit Ordering Information. Motorcycles Affected
SERVICE BULLETIN B-076A July 10, 2008 2003-2006 FIREBOLT HEADLIGHTS PRODUCT PROGRAM 0501 Reason For Revision This revised bulletin includes corrected part information in the credit procedure tables, and
More information