Tadiran Lithium Batteries. Product Data Catalogue

Transcription

1 Tadiran Lithium Batteries Product Data Catalogue

2 Customized battery packs The design and assembly of battery packs require special skills, expertise and experience. Therefore it is not recommended that the end user attempt to self-assemble battery packs. It is preferable that any battery using lithium cells be fabricated by Tadiran to ensure proper battery design and construction (see figure ). A full battery assembly service is available from Tadiran who can be contacted for further information. If for any reason, this is not possible, Tadiran can review the pack design in confidence to ensure that the design is safe (in assembly and use) and capable of meeting stated performance requirements. Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. Figure : Upon request, Tadiran designs, tests, and manufactures customized battery packs. Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

3 Overview Product Line Page Contents About Tadiran Lithium Thionyl Chloride (LTC) Batteries Model Terminations Catalogue number ) Size Nominal voltage Nominal capacity Nominal current Max. cont. discharge current Temperature range Dimensions (mm) SL-00 series: for standard use and stand-by 6 SL-0 /S /T /P /PR /PT 00x 00 /AA.6 V. Ah 0.6 ma 6 ma... 8 C Ø. x 7 SL-6 /S /T /P /PR /PT 06x 00 AA.6 V.6 Ah ma 0 ma... 8 C Ø. x 8 SL-60 /S /T /P /PR /PT 060x 00 AA.6 V. Ah ma 0 ma... 8 C Ø. x 0 SL-00 series: for extended temperature range 9 SL-0 /S /T /P /PR /PT 00x 00 /AA.6 V 0.9 Ah 0.6 ma 0 ma... Ø. x 0 SL-6 /S /T /P /PR /PT 06x 00 AA.6 V. Ah ma 7 ma... Ø. x SL-60 /S /T /P /PR /PT 060x 00 AA.6 V.8 Ah ma 00 ma... Ø. x 0 SL-700 / SL-700 series: for enhanced start SL-70 /S /T /P /PR /PT 070x 00 /AA.6 V. Ah ma 0 ma... 8 C Ø. x SL-76 /S /T /P /PR /PT 076x 00 AA.6 V. Ah. ma 7 ma... 8 C Ø. x SL-760 /S /T /P /PR /PT 0760x 00 AA.6 V. Ah ma 00 ma... 8 C Ø. x 0 SL-770 /S /T /P 770x 00 C.6 V 8. Ah ma 0 ma... 8 C Ø 6 x 0 6 SL-780 /S /T /P 780x 00 D.6 V 9 Ah ma 0 ma... 8 C Ø x 60 7 SL-790 /S /T 790x 00 DD.6 V Ah 0 ma 0 ma... 8 C Ø x 8 TL-0 /P (with insolation) C.6 V 0. Ah 0. ma ma... 8 C Ø x.6 TL-0 /P (without insolation) 76 0C.6 V 0. Ah 0. ma ma... 8 C Ø x.6 SL-800 / SL-800 series: XOL for extended operating life 9 SL-889 Solder pins D.6 V Ah 0. ma 0 ma... 8 C Ø x 6 0 SL-886 Solder pins D.6 V. Ah 0. ma 0 ma... 8 C Ø x 0 SL-80 /S /T /P /PR /PT 080x 00 /AA.6 V. Ah 0. ma 0 ma... 8 C Ø. x SL-86 /S /T /P /PR /PT 086x 00 AA.6 V.6 Ah 0. ma 0 ma... 8 C Ø. x SL-860 /S /T /P /PR /PT 0860x 00 AA.6 V. Ah ma 60 ma... 8 C Ø. x 0 SL-870 /S /T /P 870x 00 C.6 V 8. Ah ma 7 ma... 8 C Ø 6 x 0 SL-880 /S /T /P 880x 00 D.6 V 9 Ah ma 00 ma... 8 C Ø x 60 6 PulsesPlus TM Batteries Model Termination Catalogue number Configuration Nominal Primary cell HLC voltage Nominal capacity Max. pulse current ) Dimensions (mm) 7 TLP-9/A/SM Flying leads AA 0.6 V.0 Ah A x x 6 8 TLP-9/A/SM Pressure contacts AA 0.6 V.0 Ah A Ø 6. x 7 8 TLP-9/A/ST Solder tags AA 0.6 V.0 Ah A Ø 6. x 7 9 TLP-9/A/SM Flying leads C 0.6 V 8.0 Ah A x x 8 0 TLP-9/A/SM Flying leads C 0.6 V 8.0 Ah A Ø 9 x 67 TLP-9/A/SM Flying leads D 0.6 V 9.0 Ah A 6 x 0 x TLP-9/A/SM Flying leads D 0.6 V 9.0 Ah A Ø x 78 TLP-96/A/SM Flying leads /AA 0.6 V. Ah A x x 6 TLP-96/A/SM Pressure contacts /AA 0.6 V. Ah A Ø 6. x 0 TLP-96/A/ST Solder tags /AA 0.6 V. Ah A Ø 6. x 0 TLP-97/A/SM Flying leads AA 0.6 V.6 Ah A x x 6 6 TLP-97/A/SM Pressure contacts AA 0.6 V.6 Ah A Ø 6. x 8 6 TLP-97/A/ST Solder tags AA 0.6 V.6 Ah A Ø 6. x 8 7 Hybrid Layer Capacitors (HLC) for use in PulsesPlus TM Batteries Model Maximum charge voltage Maximum charging current Max. cont. discharge current Max. pulse discharge current Maximum capacity (.67 V) Maximum capacity (.9 V) Discharge end voltage Cell impedance Dimensions (mm) 8 HLC-00.9 V 8 ma 0. A 0.7 A. mah 0 mah. V 00 mω Ø 0 x 0 8 HLC-00L.9 V 6 ma 0. A 0. A 8 mah. mah. V 600 mω Ø 0 x 0 9 HLC-0A.9 V ma 0. A A 9 mah 8 mah. V 0 mω Ø x 0 0 HLC-0A.9 V 0 ma 0.7 A A 70 mah 0 mah. V 0 mω Ø x 7 HLC-0A.9 V 00 ma A A mah 6 mah. V 00 mω Ø x 0 Tadiran Lithium Metal Oxide (TLM) Batteries Model Nominal Max. cont. discharge Max. pulse dis- Maximum End Cell Capacity Dimensions voltage current charge current capacity voltage impedance retention ) (mm) TLM-0HPM.0 V.7 A.7 A mah.8 V 00 mω 89 % Ø x 0 TLM-0HPM.0 V. A 6.8 A mah.8 V 00 mω 89 % Ø x 7 TLM-0HPM.0 V 7 A A 00 mah.8 V 00 mω 89 % Ø x 0 6 Tadiran Lithium Ion (TLI) Batteries RECHARGEABLE Model Max. charge voltage Max. charging current Max. cont. discharge current Max. pulse discharge current Maximum capacity End voltage Cell impedance Dimensions (mm) 7 TLI-00A. V 8 ma 0.6 A 0. A mah. V 600 mω Ø 0 x 0 8 TLI-0A. V ma 0. A. A 90 mah. V 0 mω Ø x 0 9 TLI-0A. V 0 ma A. A 0 mah. V 7 mω Ø x 7 0 TLI-0A. V 00 ma A A 0 mah. V 00 mω Ø x 0 Safety and Transport Regulations ) complete catalogue number depends on termination; see product page ) pulse duration s to V ) after 0 years of storage at RT Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) réserve de modifications. PDC7Eng PDCFra

4 About Tadiran Tadiran Batteries GmbH Tadiran Batteries GmbH is one of the leading manufacturers of primary (non rechargeable) lithium batteries in Europe. The company was founded as a Joint Venture between Tadiran and Sonnenschein in 98 and under the name of Sonnenschein Lithium has successfully served the market for more than 0 years. Together with its parent company Tadiran Batteries Ltd., the company is continuously improving its performance with regard to products, highest quality and customer service. Tadiran Batteries Ltd. is fully owned by Saft groupe S.A. (Euronext: SAFT). The main focus of the company is to achieve a maximum customer satisfaction. Thus the guide line is to be the best in design-in, in full technical support and logistics. The company is committed to the world class philosophy. The management system is certified to ISO 900 (Quality) and since 999 to ISO 00 (Environment). Tadiran Batteries GmbH employs approx. 00 people and has its production facilities in Büdingen, close to Frankfurt, Germany. The company is a leader in the development of lithium batteries for industrial use. Its Lithium Thionyl Chloride (LTC) technology is well established for more than years. Tadiran LTC batteries are suitable where a.6 Volt high energy primary battery is required for up to years and more stand alone operation. The PulsesPlus TM technology, providing high current pulses in combination with high energy, has been successfully introduced into the market and plays a significant role especially for long distance communication (e.g. GSM) modules. The TLM technology has been developed for applications requiring high power discharge after a long storage time, e.g. as a back up battery for emergency call devices in automotive telematic systems. The RECHARGEABLE TLI series is specifically designed for long-term use in harsh environments and represents an important breakthrough in lithium-ion battery technology. Customer benefits Tadiran has focused its ongoing efforts on promoting the understanding and further development of lithium batteries. This determination offers to the customer a number of decisive benefits such as: Access to over 0 years of experience in research and development, production and marketing Adaptability and reliability in meeting rapidly evolving customer needs Detailed technical support in terms of design and application before, during and after the purchase Highly qualified experts available for support on short notice Customized production of single- and multi-cell batteries to meet specific requirements Reliable delivery, secured by contractual agreements and second sourcing. For successful use of a battery, the co-operation between the supplier and the customer must commence at the earliest possible point: at times it is simply more economical to design a circuit for the characteristics of the best suitable energy supply, rather than having to forgo its advantages because it is too late for changes. Environment The European Battery Directive 006/66/EC restricts the use of certain hazardous substances in batteries and establishes rules for the collection, treatment, recycling and disposal of waste batteries and accumulators. It is transposed individually in each EU member state. The following information is important for end users of batteries: Batteries are marked with the crossed-out wheeled bin symbol. The symbol reminds end users that batteries must not be disposed as municipal waste, but collected separately. Used batteries can be returned at the point of sale at no charge. The reason for these regulations is that there are a number of environmental concerns which arise when dealing with the waste management of batteries and accumulators. These relate for the most part to the metals contained in these batteries. Mercury, lead and cadmium are by far the most problematic substances in the battery waste stream. Other metals commonly used in batteries, such as zinc, copper, manganese, lithium and nickel, may also constitute environmental hazards. However, the regulations apply to all batteries and not just to hazardous ones because all batteries contain substances which are more or less harmful to the environment and because experience with previous regulations showed that all battery collection schemes are more efficient than separate schemes for certain types of portable batteries. Batteries should be recycled because battery recycling helps to save resources by allowing for the recovery of valuable metals such as nickel, cobalt and silver and requires less energy consumption. For example, using recycled cadmium and nickel requires respectively 6 % and 7 % less primary energy than the extraction and refining of virgin metals. This information is based on the Q&A on the Batteries Directive 006/66/EC document and was downloaded from the European Commission website. A Technical Notice is available upon request with details on the disposal service offered by Tadiran. PDC7Eng PDCFra Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0)

5 Lithium Thionyl Chloride (LTC) Batteries Introduction The Lithium Thionyl Chloride (LTC) battery The Tadiran lithium thionyl chloride inorganic electrolyte battery is a power source that is suited to the requirements of the new generation in microelectronics. For example, CMOS memories as well as utility meters require a lightweight power source to provide a safe and reliable performance over a wide range of environmental conditions, for long periods of time. The Tadiran lithium battery is a component that can be permanently connected to a circuit and, in many cases, will last the entire lifetime of the equipment. Battery characteristics The major advantages of the Tadiran lithium battery are: High cell voltage The battery has a nominal voltage of.6 Volts, which is considerably higher than any other commercially available primary cell. Wide temperature range The batteries are capable of operating in a wide temperature range normally from C to 8 C. One series, however, has an extended temperature range of up to. High energy density The electrochemical system offers the highest energy density of any available primary battery: up to ~60 Wh / kg and ~80 Wh / dm (see figure ). Superior shelf life and reliability The Tadiran lithium battery has an outstandingly long shelf life. Tests have shown that storage for ten years at room temperature results in a capacity loss of less than % per year. Tadiran lithium batteries are also extremely reliable. Failure rates in memory back-up applications were found to be below 00 fit (fit: Failures in Time. fit = failure in 0 9 component hours). Safe design The battery s design has a major influence on its safety characteristics (see figure ). In the bobbin version, the cathode is cylindrical in shape. The anode is swaged against the inner wall of the battery case. This offers several advantages in terms of safety. In the event of an unintentional short-circuit, the discharge currents do not become very strong. The heat generated, primarily at the contact surface between the anode and cathode, can easily be channelled to the outside. This design leads to a safe battery that needs no additional rupture vent. In the flat battery versions, the anode is pressed onto the bottom of the case, and the cathode is disk-shaped. Flat batteries are wider than they are high. They are just as safe as the bobbin type batteries. Hermetically sealed case The hermetically sealed case is essential for the long shelf life and inherent safety of the devices in which the batteries are used. The cover is welded to the can. A glass-to-metal seal is used to insulate the positive terminal. The chemical reaction The battery consists of a lithium (Li) anode, a carbon (C) cathode, and a non-aqueous electrolyte (a solution of lithium tetra-chloroaluminate in thionyl chloride). This solution performs a dual task: as the electrolyte for ion transport, and as an active depolarizer. Positive terminal Plastic cover Welding seam Cell cover Glass-to-metal seal Insulator Current collector Lithium anode Cathode Separator Insulating sleeve Cell can Negative terminal Figure : Cross sectional view of a ½AA size cell (bobbin-design) The Teflon -bonded carbon cathode serves as a catalyst for cathodic reduction. The generally accepted reaction mechanisms are as follows: Anodic reaction: Li Li e Cathodic reaction: SOCl e SO S Cl Overall reaction: Li SOCl S LiCl SO Most of the sulphur dioxide generated during discharge dissolves in the electrolyte, preventing pressure build-up within the battery. Long-term behaviour The long shelf life of the Tadiran lithium batteries is a result of the fact that a thin protective layer of LiCl forms on the anode as soon as the lithium first comes into contact with the electrolyte. This layer prevents further reaction or loss of capacity on stand. The problem of anode corrosion, as occurs in aqueous systems, is thus eliminated. On the other hand, the protective layer on the anode may cause a delay in the voltage build-up if relatively high loads are applied, or after extended storage at elevated temperatures. This voltage delay is not experienced at all in microampere applications, such as in typical CMOS circuits. Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. Features and attributes of the various series SL-00 series Keywords: standard use and stand-by Excellent shelf life (0 years) Extremely low self-discharge ( % or less per year) Suited for long-term use with low current For operation at low current levels with long stands Intermittent discharge with medium current level provided the average is not below the active current level ( µa / cm² anode surface area) Temperature range from C to 8 C SL-00 series Keywords: extended temperature range Extension of temperature range up to Somewhat smaller capacity Otherwise like the SL-700 series SL-700 series Keywords: for enhanced start Major improvement of voltage delay (TMV) at the start of discharge at medium current levels Intermittent discharge at medium current levels Best results if used after no more than years of storage Otherwise like the SL-00 series SL-700 series (ixtra) Keywords: for fast voltage recovery after long term storage and/or use Higher voltage under pulse load even with low background currents Improved voltage delay behaviour at ambient and elevated temperatures Fast voltage recovery after long term storage More capacity Higher discharge rate No orientation effect SL-800/800 series (XOL) Keywords: for extended operation life More capacity Extra low self discharge Extra low passivation during long term use Ah / dm Figure : Comparison of different battery systems. The curves represent typical best values of commercial cylindrical cells when discharged at C at the 000 hour rate. The area under the curves corresponds to the energy density listed below. Li/SOCl 80 Wh / dm Li/SO 0 Wh / dm Li/CF x 0 Wh / dm Li/MnO 80 Wh / dm Li/FeS 0 Wh / dm 6 Alkaline 80 Wh / dm Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

6 LTC Piles Batteries LTC SL-0 Size: /AA Standard use and stand-by (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Thionyl Chloride.6 V. Ah 0.6 ma Max. continuous discharge current 6 ma Anode surface area 6 cm 0. g 9.6 g Volume cm Temperature range C... 8 C Typical Discharge Curves at C : 60 Ω ~6 ma 0.90 Ah. :.8 kω ~ ma.0 Ah :.6 kω ~0.6 ma.0 Ah.0 : 8 kω ~0. ma. Ah : 6 kω ~6 ma.0 Ah 0. 6: 80 kω ~ ma 0.9 Ah 7: 60 kω ~06 ma 0.8 Ah Time / h SL-0/S Ø ±0. 7 ±0..7 SL-0/T Capacity to Volts / Ah : : : : : 7 C C C Ø thick SL-0/P Operating Voltage.8 SL-0/PR SL-0/PT : : : : : 6 ma ma 0.6 ma 0. ma ma thick 0. thick SL-0/S Standard SL-0/T Tags SL-0/P Pins SL-0/PR Pins radial SL-0/PT Polarized tags Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above 0, incinerate, or expose contents to water. Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. 6 Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

7 LTC Batteries SL-6 Size: AA Standard use and stand-by (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Thionyl Chloride.6 V.6 Ah ma Max. continuous discharge current 0 ma Anode surface area 9 cm 0. g. g Volume. cm Temperature range C... 8 C Typical Discharge Curves at C : 0 Ω ~0 ma.00 Ah :.0 kω. ~ ma. Ah :. kω ~ ma.60 Ah.0 : 0 kω ~0. ma.60 Ah : kω ~0. ma.0 Ah 0. 6: 7: 00 kω 0 kω ~ ma ~ ma. Ah.0 Ah Time / h SL-6/S 0. Ø ± ±0. Capacity to Volts / Ah : 7 C : : C : : C Operating Voltage.8 Ø.7. SL-6/PT : : : : : 6: 0 ma ma ma 0. ma 0. ma ma thick.7 SL-6/T SL-6/P SL-6/PR thick 0. thick SL-6/S Standard SL-6/T Tags SL-6/P Pins SL-6/PR Pins radial SL-6/PT Polarized tags Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above 0, incinerate, or expose contents to water. Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. 7 Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

8 .. LTC Piles Batteries LTC SL-60 Size: AA Standard use and stand-by (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Thionyl Chloride.6 V. Ah ma Max. continuous discharge current 0 ma Anode surface area cm 0.6 g 8 g Volume 8 cm Temperature range C... 8 C Typical Discharge Curves at C : 80 Ω ~0 ma. Ah : 60 Ω. ~6 ma. Ah :.8 kω ~ ma. Ah.0 :.6 kω ~0.6 ma. Ah : 8 kω ~0. ma. Ah 0. 6: 7: 6 kω 80 kω ~6 ma ~ ma. Ah.9 Ah Time / h. SL-60/S 0. Ø. 0. SL-60/PR Ø ± ±0. 0. thick.7 SL-60/T SL-60/P SL-60/PT Capacity to Volts / Ah : : : : : 7 C C C Operating Voltage : : : : : 0 ma 6 ma ma 0. ma ma , 0, thick 0. thick SL-60/S Standard SL-60/T Tags SL-60/P Pins SL-60/PR Pins radial SL-60/PT Polarized tags Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above 0, incinerate, or expose contents to water. Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. 8 Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

9 LTC Batteries SL-0 Size: /AA Extended temperature range ixtra long term high performance (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Thionyl Chloride.6 V 0.9 Ah 0.6 ma Max. continuous discharge current 0 ma Pulse current capability 00 ma Anode surface area 6 cm 0. g 9.6 g Volume cm Temperature range C... Typical Discharge Curves at C : 80 Ω ~0 ma 0.0 Ah. 7 : 60 Ω ~6 ma 0.80 Ah :.8 kω ~ ma 0.8 Ah.0 :.6 kω ~0.6 ma 0.90 Ah : 8 kω ~0. ma 0.8 Ah 0. 6: 6 kω 0 6 s 0 ~6 ma 0.80 Ah 7: 80 kω ~ ma 0.70 Ah h Time / Volts Ø ±0. 7 ±0..7 Ø.7. SL-0/PR 0. thick SL-0/P SL-0/PT SL-0/S SL-0/T Capacity to Volts / Ah : 6 0. : 8 : : C 0. : 6: Operating Voltage : 6 ma : ma : 0.6 ma : 6 ma : 06 ma thick 0. thick SL-0/S Standard SL-0/T Tags SL-0/P Pins SL-0/PR Pins radial SL-0/PT Polarized tags Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above, incinerate, or expose contents to water. Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. 9 Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

10 LTC Piles Batteries LTC SL-6 Size: AA Extended temperature range ixtra long term high performance (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Thionyl Chloride.6 V. Ah ma Max. continuous discharge current 7 ma Pulse current capability 0 ma Anode surface area 9 cm 0. g. g Volume. cm Temperature range C... Typical Discharge Curves at C : 00 Ω ~0 ma 0.60 Ah. 6 7 : 0 Ω ~0 ma 0.80 Ah : kω ~ ma.00 Ah.0 :. kω ~ ma.0 Ah : 0 kω ~0. ma.0 Ah s 0 6: kω ~0. ma.00 Ah 7: 00 kω ~ ma 0.8 Ah h Time / Volts.6. SL-6/S 0. Ø ±0. SL-6/T Ø.7. SL-6/PT Operating Voltage : 0 ma : ma : ma : 0. ma : ma : : 8 : : C :.. 7 ±0. 0. thick Capacity to Volts / Ah SL-6/PR SL-6/P thick 0. thick SL-6/S Standard SL-6/T Tags SL-6/P Pins SL-6/PR Pins radial SL-6/PT Polarized tags Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above, incinerate, or expose contents to water. Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. 0 Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

11 .. LTC Batteries SL-60 Size: AA Extended temperature range ixtra long term high performance (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Thionyl Chloride.6 V.8 Ah ma Max. continuous discharge current 00 ma Pulse current capability 00 ma Anode surface area cm 0.6 g 8 g Volume 8 cm Temperature range C... Typical Discharge Curves at C : 6 Ω ~60 ma.0 Ah. 6 7 : 80 Ω ~0 ma.60 Ah : 60 Ω ~6 ma.70 Ah.0 :.8 kω ~ ma.80 Ah :.6 kω ~0.6 ma.70 Ah s 0 6: 8 kω ~0. ma.60 Ah 7: 6 kω ~6 ma.0 Ah h Time / Volts. SL-60/S 0. Ø. 0. SL-60/PR Ø ± ±0. 0. thick.7 SL-60/T SL-60/P SL-60/PT Capacity to Volts / Ah Operating Voltage : : 8 : : C : : 0 ma : 6 ma : ma : 0. ma : ma , 0, thick 0. thick SL-60/S Standard SL-60/T Tags SL-60/P Pins SL-60/PR Pins radial SL-60/PT Polarized tags Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above, incinerate, or expose contents to water. Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

12 LTC Piles Batteries LTC SL-70 Size: /AA ixtra long term high performance (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Thionyl Chloride.6 V. Ah ma Max. continuous discharge current 0 ma Pulse current capability 00 ma Anode surface area 6 cm 0. g 9.6 g Volume cm Temperature range C... 8 C Typical Discharge Curves at C : 80 Ω ~0 ma 0. Ah. : 60 Ω ~6 ma.0 Ah :.8 kω ~ ma. Ah.0 :.6 kω ~0.6 ma. Ah s 0 : 8 kω ~0. ma. Ah 6: 6 kω ~6 ma.0 Ah 7: 80 kω ~ ma 0.9 Ah Volts Time / h. SL-70/S Ø ±0. 7 ±0..7 SL-70/T Capacity to Volts / Ah : 7 C 0. : C : C : Ø.7. SL-70/PR 0. thick SL-70/P SL-70/PT Operating Voltage : 6 ma : ma : 0.6 ma : 6 ma : 06 ma thick. 0. SL-70/S Standard SL-70/T Tags SL-70/P Pins SL-70/PR Pins radial SL-70/PT Polarized tags thick Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above 0, incinerate, or expose contents to water. Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. Voltage Response at C, Pulse: 0 ma.8 Basic current (bc).6 None µa 0 µa : after year at bc : after years at bc : after years at bc : after 7 years at bc. : after years at bc 6: after 0 years at bc Time / s Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

13 LTC Batteries SL-76 Size: AA ixtra long term high performance (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Thionyl Chloride.6 V. Ah. ma Max. continuous discharge current 7 ma Pulse current capability 0 ma Anode surface area 9 cm 0. g. g Volume. cm Temperature range C... 8 C Typical Discharge Curves at C Volts s 0 : : : : : 6: 7: 00 Ω 0 Ω.0 kω. kω 0 kω kω 00 kω ~0 ma ~0 ma ~ ma ~ ma ~0. ma ~0. ma ~ ma 0.80 Ah. Ah.0 Ah.0 Ah.0 Ah. Ah.0 Ah Time / h SL-76/S 0. Ø. 0. SL-76/PR Ø ± ±0. 0. thick.7 SL-76/T SL-76/P SL-76/PT Capacity to Volts / Ah : 7 C 0. : C : C 0. : Operating Voltage : : : : : 0 ma ma ma 0. ma ma thick SL-76/S Standard SL-76/T Tags SL-76/P Pins SL-76/PR Pins radial SL-76/PT Polarized tags thick Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. 0.6 Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above 0, incinerate, or expose contents to water. Voltage Response at C, Pulse: ma.8 Basic current (bc).6 None 7. µa µa : after year at bc : after years at bc : after years at bc : after 7 years at bc. 6: after 0 years at bc Time / s Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

14 .. LTC Piles Batteries LTC SL-760 Size: AA ixtra long term high performance (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Thionyl Chloride.6 V. Ah ma Max. continuous discharge current 00 ma Pulse current capability 00 ma Anode surface area cm 0.6 g 8 g Volume 8 cm Temperature range C... 8 C Typical Discharge Curves at C : 6 Ω ~60 ma. Ah. : 80 Ω ~0 ma.8 Ah 6 7 : 60 Ω ~6 ma. Ah.0 :.8 kω ~ ma. Ah :.6 kω ~0.6 ma. Ah 0. 6: 8 kω 0 6 s 0 ~0. ma. Ah 7: 6 kω ~6 ma.0 Ah h Time / Volts. SL-760/S 0. Ø ±0. SL-760/T Capacity to Volts / Ah : : : : 7 C C C SL-760/PR Ø ±0. 0. thick.7 SL-760/P SL-760/PT Operating Voltage : : : : : 0 ma 6 ma ma 0. ma ma , thick SL-760/S Standard SL-760/T Tags SL-760/P Pins SL-760/PR Pins radial SL-760/PT Polarized tags , 0. thick Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. 0.6 Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above 0, incinerate, or expose contents to water. Voltage Response at C, Pulse: 0 ma.8 Basic current (bc).6 None 0 µa 0 µa : after years at bc : after years at bc. : after years at bc : after 7 years at bc 6: after 0 years at bc Time / s Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

15 LTC Batteries SL-770 Size: C ixtra long term high performance (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Thionyl Chloride.6 V 8. Ah ma Max. continuous discharge current 0 ma Pulse current capability 00 ma Anode surface area 0 cm. g 9. g Volume 6 cm Temperature range C... 8 C Typical Discharge Curves at C Volts s Time / h : : : : : 6: 7: Ω 00 Ω 0 Ω.0 kω. kω 0 kω kω ~00 ma ~0 ma ~0 ma ~ ma ~ ma ~0. ma ~0. ma. Ah.8 Ah 7.9 Ah 8. Ah 8. Ah 7.8 Ah 6.9 Ah 0 SL-770/S 0. Ø. 0. Ø ±0. 6 SL-770/T 0. thick.7 SL-770/P Capacity to Volts / Ah 8 6 : : : : : 7 C C C Operating Voltage : : : : : 6: 7: 60 ma 0 ma 0 ma ma ma 0. ma 0. ma SL-770/S Standard SL-770/T Tags SL-770/P Pins Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above 0, incinerate, or expose contents to water Voltage Response at C, Pulse: 0 ma.8 Basic current (bc).6 None µa µa : after years at bc : after 8 years at bc : after years at bc : after 0 years at bc Time / s Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

16 LTC Piles Batteries LTC SL-780 Size: D ixtra long term high performance (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Thionyl Chloride.6 V 9 Ah ma Max. continuous discharge current 0 ma Pulse current capability 600 ma Anode surface area cm g 9 g Volume cm Temperature range C... 8 C Typical Discharge Curves at C : Ω ~00 ma 9.0 Ah : 6 Ω ~60 ma. Ah : 80 Ω ~0 ma 6.9 Ah.0 : 60 Ω ~6 ma 8.7 Ah :.8 kω ~ ma 8.6 Ah s 0 6:.6 kω ~0.6 ma 7. Ah 7: 8 kω ~0. ma. Ah Time / h Volts 0 SL-780/S 0. Ø ±0. SL-780/T Capacity to Volts / Ah 0 : : : : : 7 C C C Operating Voltage.8 Ø thick.7 SL-780/P : : : : : 6: 7: 00 ma 60 ma 0 ma 6 ma ma 0.6 ma 0. ma SL-780/S Standard SL-780/T Tags SL-780/P Pins Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above 0, incinerate, or expose contents to water. 6 Voltage Response at C, Pulse: 60 ma.8 Basic current (bc).6 None 0 µa 00 µa : after years at bc : after 8 years at bc. : after years at bc : after 0 years at bc Time / s Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

17 LTC Batteries SL-790 Size: DD ixtra long term high performance (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Thionyl Chloride.6 V Ah 0 ma Max. continuous discharge current 0 ma Pulse current capability 000 ma Anode surface area 90 cm 0 g 90 g Volume 0 cm Temperature range C... 8 C Typical Discharge Curves at C : 0 Ω ~00 ma 0. Ah. : : Ω 00 Ω ~00 ma ~0 ma 8.7 Ah. Ah.0 : : 0 Ω.0 kω ~0 ma ~ ma.0 Ah. Ah 0. 6:. kω ~ ma 0. Ah 7: 0 kω ~0. ma 7. Ah Time / h 0 SL-790/S Ø ± 0.7±0.. SL-790/T Capacity to Volts / Ah : 7 C : C : C : : Operating Voltage : : : : : 6: 7: 00 ma 00 ma 0 ma 0 ma ma ma 0. ma Ø SL-790/S Standard SL-790/T Tags Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. 0. thick.7 Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above 0, incinerate, or expose contents to water. 7 Voltage Response at C, Pulse: 0 ma.8 Basic current (bc).6. None 00 µa 00 µa : after years at bc : after 8 years at bc : after years at bc : after 0 years at bc Time / s Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

18 LTC Piles Batteries LTC TL-0 Size: 0C ixtra long term high performance (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Thionyl Chloride.6 V 0. Ah 0. ma Max. continuous discharge current ma Pulse current capability 0 ma Anode surface area. cm 0. g 8.8 g Volume.6 cm Temperature range C... 8 C A high temperature version TLH-0 is also available. For more information please refer to Tadiran s website. TL-0 (with insolation disc) Ø 0.78 ( ) () Ø.0 0. max ± max. TL-0 (without insolation disc).6 ± max. Capacity to Volts / Ah Typical Discharge Curves at C :. kω ~ ma 0. Ah : 0 kω ~0. ma 0. Ah : kω.0 ~0. ma 0. Ah : 00 kω ~ ma 0.0 Ah : 0 kω 0. ~ ma 0. Ah 0 6 s 0 6: 000 kω ~0 ma 0. Ah h Time / Volts : : : : : 8 C Operating Voltage : ma. : 0. ma : ma Ø TL-0/P Pins (with insolation disc) 76 0 TL-0/P Pins (without insolation disc) 76 Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above 0, incinerate, or expose contents to water. Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. 8 Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

19 LTC Batteries SL-889 Size: 0D XOL extended operating life (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Thionyl Chloride.6 V Ah 0. ma Max. continuous discharge current 0 ma Pulse current capability 0 ma Anode surface area 7. cm 0. g 6 g Volume cm Temperature range C... 8 C Typical Discharge Curves at C :.0 kω ~ ma 0.98 Ah :. kω ~ ma.00 Ah : 0 kω ~0. ma 0.98 Ah.0 : kω ~0. ma 0.9 Ah : 00 kω 0. ~ ma 0.9 Ah 0 6 s 0 6: 0 kω ~ ma 0.8 Ah h Time / Volts. SL-889 ( ) ( ) (). Capacity to Volts / Ah : : : : : 8 C Ø Operating Voltage.8. ±0. Ø ±0. min. (9.6) : : : ma 0. ma ma SL-889/P Pins Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above 0, incinerate, or expose contents to water. Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. 9 Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

20 LTC Piles Batteries LTC SL-886 Size: 6D XOL extended operating life (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Thionyl Chloride.6 V.7 Ah 0. ma Max. continuous discharge current 0 ma Pulse current capability 0 ma Anode surface area 7. cm 0. g g Volume 8. cm Temperature range C... 8 C Typical Discharge Curves at C :.0 kω ~ ma.0 Ah :. kω ~ ma.70 Ah : 0 kω ~0. ma.6 Ah.0 : kω ~0. ma.60 Ah : 00 kω 0. ~ ma.0 Ah 0 6 s 0 6: 0 kω ~ ma.0 Ah h Time / Volts.0 SL-886 ( ) ( ) (). Capacity to Volts / Ah : : : : : 8 C Ø ±0. (.) Operating Voltage.8.6. ±0. Ø min : : : ma 0. ma ma SL-886/P Pins Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above 0, incinerate, or expose contents to water. Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. 0 Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

21 LTC Batteries SL-80 Size: /AA XOL extended operating life (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Thionyl Chloride.6 V. Ah 0. ma Max. continuous discharge current 0 ma Pulse current capability 0 ma Anode surface area 6 cm 0. g 9.6 g Volume cm Temperature range C... 8 C Typical Discharge Curves at C :.8 kω ~ ma 0.80 Ah :.6 kω ~0.6 ma.0 Ah : 8 kω.0 ~0. ma. Ah : 6 kω ~6 ma.0 Ah : 80 kω 0. ~ ma.00 Ah 0 6 s 0 6: 60 kω ~06 ma 0.90 Ah h Time / Volts. SL-80/S Ø ±0. 7 ±0..7 SL-80/T Capacity to Volts / Ah : : : : : 7 C C C Ø thick SL-80/P Operating Voltage : : : ma 0. ma ma SL-80/PR SL-80/PT thick 0. thick SL-80/S Standard SL-80/T Tags SL-80/P Pins SL-80/PR Pins radial SL-80/PT Polarized tags Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above 0, incinerate, or expose contents to water. Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

22 LTC Piles Batteries LTC SL-86 Size: AA XOL extended operating life (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Thionyl Chloride.6 V.6 Ah 0. ma Max. continuous discharge current 0 ma Pulse current capability 7 ma Anode surface area 9 cm 0. g. g Volume. cm Temperature range C... 8 C Typical Discharge Curves at C :.0 kω ~ ma.0 Ah :. kω ~ ma.60 Ah : 0 kω ~0. ma.60 Ah.0 : kω ~0. ma. Ah : 00 kω 0. ~ ma. Ah 0 6 s 0 6: 0 kω ~ ma. Ah h Time / Volts SL-86/S 0. Ø ±0. SL-86/T Capacity to Volts / Ah : 7 C : : C : : C 7 ± Operating Voltage.8 Ø : : : ma 0. ma ma thick.7 SL-86/P SL-86/PR SL-86/PT thick 0. thick SL-86/S Standard SL-86/T Tags SL-86/P Pins SL-86/PR Pins radial SL-86/PT Polarized tags Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above 0, incinerate, or expose contents to water. Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

23 .. LTC Batteries SL-860 Size: AA XOL extended operating life (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Thionyl Chloride.6 V. Ah ma Max. continuous discharge current 60 ma Pulse current capability 0 ma Anode surface area cm 0.6 g 8 g Volume 8 cm Temperature range C... 8 C Typical Discharge Curves at C : 60 Ω ~6 ma.90 Ah :.8 kω ~ ma.0 Ah :.6 kω ~0.6 ma.0 Ah.0 : 8 kω ~0. ma.0 Ah : 6 kω 0. ~6 ma. Ah 0 6 s 0 6: 80 kω ~ ma.00 Ah h Time / Volts. SL-860/S 0. Ø ± ±0. 0. thick.7 SL-860/T SL-860/P Capacity to Volts / Ah : : : : : 7 C C C Operating Voltage.8 Ø SL-860/PR SL-860/PT.6. : : : 6 ma 0.6 ma 6 ma , 0, thick 0. thick SL-860/S Standard SL-860/T Tags SL-860/P Pins SL-860/PR Pins radial SL-860/PT Polarized tags Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above 0, incinerate, or expose contents to water. Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

24 LTC Piles Batteries LTC SL-870 Size: C XOL extended operating life (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Thionyl Chloride.6 V 8. Ah ma Max. continuous discharge current 7 ma Pulse current capability 00 ma Anode surface area 0 cm. g 9. g Volume 6 cm Temperature range C... 8 C Typical Discharge Curves at C : 0 Ω ~0 ma 6.0 Ah :.0 kω ~ ma 8. Ah.0 :. kω ~ ma 8. Ah : 0 kω ~0. ma 8. Ah s 0 : kω ~0. ma 7.7 Ah h Time / Volts 0 SL-870/S 0. Ø. 0. Ø ±0. 6 SL-870/T 0. thick.7 Capacity to Volts / Ah 8 6 : : : : : 7 C C C Operating Voltage SL-870/P.6. : : : 0 ma ma 0. ma SL-870/S Standard SL-870/T Tags SL-870/P Pins Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above 0, incinerate, or expose contents to water. Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

25 LTC Batteries SL-880 Size: D XOL extended operating life (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Thionyl Chloride.6 V 9 Ah ma Max. continuous discharge current 00 ma Pulse current capability 0 ma Anode surface area cm g 9 g Volume cm Temperature range C... 8 C Typical Discharge Curves at C : 80 Ω ~0 ma. Ah.0 : 60 Ω ~6 ma 7. Ah :.8 kω ~ ma 8.8 Ah 0. :.6 kω ~0.6 ma 8. Ah 0 6 s 0 : 8 kω ~0. ma 7.0 Ah Time / h Volts 0 SL-880/S 0. Ø. 0. Capacity to Volts / Ah 0 : : : : : 8 C Operating Voltage.8 0. thick : : : 0 ma ma 0. ma ±0. SL-880/T 6. Ø SL-880/P SL-880/S Standard SL-880/T Tags SL-880/P Pins Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above 0, incinerate, or expose contents to water. Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

26 PulsesPlus TM Batteries Introduction The PulsesPlus TM battery The PulsesPlus TM battery series was introduced by Tadiran Batteries in order to extend the range of applications for the Lithium Thionyl Chloride (LTC) battery by eliminating the voltage delay, increasing the pulse current capability and minimizing the impedance loss of the battery. A proprietary Hybrid Layer Capacitor (HLC) was developed for this purpose. A PulsesPlus TM battery is formed by connecting one or more primary lithium thionyl chloride batteries in parallel with one or more HLCs. The Hybrid Layer Capacitor This HLC is a secondary element. Its electrodes comprise Lithium Intercalated Compounds and are spirally wound. The HLC has been optimized with respect to self discharge, temperature range and durability by carefully selecting the material properties of the electrodes and the hermetical glass to metal seal. Impedance Loss and how to Overcome it.0 R-0..0 C cont. load: 68 kω (~0 µa). pulse load: 0 ma : Voltage on background current : Pulse voltage HLC-0 connected Working time / years Figure : Impedance Loss and how to Overcome it Performance As a result, the PulsesPlus TM battery outperforms conventional high rate lithium batteries such as lithium sulphur dioxide (Li/SO ) batteries, lithium manganese dioxide (Li/MnO ) batteries as well as spirally wound lithium thionyl chloride (Li/SOCl ) batteries. Compared to these battery systems, PulsesPlus TM batteries deliver higher voltage and higher capacity. These batteries also offer unmatched service life due to their extremely low self-discharge. Advantages The performance advantages of the PulsesPlus TM battery include: Higher voltage.6 V versus.0 V Higher capacity e.g. 9 Ah for D size cell (versus 7 Ah for other Lithium batteries) Lower self discharge less than % per year (versus % per year with spiral wound) Lower impedance (internal resistance) High pulse current capability No passivation effect High reliability (hermetic laser sealing, glass-to-metal seal) Widest operating temperature to 8 C (versus to 6) Greater safety, UL registration of the component cells No impedance loss The PulsesPlus TM battery overcomes the impedance loss which occurs when an LTC battery is used to deliver high pulse currents over a long time. This effect is demonstrated in figure where a D-size cell was discharged under a continuous load of ~0 µa and short pulses of 0 ma. The battery is able to deliver this current at a voltage level of Volts, at least for a period of years. From the low average current draw of 0 µa, one would be misled to assume that the battery could continue to deliver these pulse currents for more than 0 or 0 years. However, after years, the voltage level under pulse load starts to decline reaching as low as. Volts after years. At this voltage level, most applications would stop to work and the battery would be considered as discharged. However, it is not, as can be seen from the red curve showing the battery voltage under background load. It stays at.6 Volts, even after and 0 years. Connecting Tadiran s Hybrid Layer Capacitor (HLC) in parallel solves the problem. The HLC maintains its low internal resistance throughout the remaining battery life. During that time period the pulse voltage stays always above. Volts. The duration for that test is more than years. Application in GSM modules One major application for PulsesPlus TM batteries is in GSM communication modules for data exchange. GSM is the global system for mobile communication also used for mobile phones. The GSM network uses a multiplexing technology called time division multiple access (TDMA) in order to provide multiple communication channels with the same signal, dividing it into 8 time slots. A typical TDMA transmission requires a basic current of 0 ma and a pulse current of A for 77 µs every.6 ms. Figure shows the voltage behaviour of a PulsesPlus TM battery with one HLC-0A under these conditions at Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. GSM Discharge Curves HLC-0A charged to.6 V. GSM profile (TDMA, Slot) 0 ma continuous current A peak current for 77 µs every.6 ms : C : 6: : 7: : : 0 0 Time / min Figure : GSM Discharge Curves 6 Max. avg. current draw / μa How to Design a Long Life Application : 7 : C : C TLP-9/A (SL-880, D-size, XOL cell, 9 Ah nominal capacity, with HLC-0A) Typical battery design life / years Figure : How to Design a Long Life Application various temperature levels between and C. The chart shows two curves for each temperature level. The upper curve corresponds to the voltage level under the background current of 0 ma while the lower curve corresponds to the voltage level under the peak current of A. Curves at higher temperatures are not shown but can be considered to lie slightly above the curves for C. Extremely low self discharge The PulsesPlus TM battery can be used where 0 years of continuous power are required for applications including GSM and radio modules. This is due to the stability of both Tadiran s primary LTC battery and the HLC with respect to the sealing system, the internal resistance, and the self-discharge. Fit for 0 years of life Figure shows the maximum average current draw of a TLP- 9/A PulsesPlus TM battery as a function of the design life of the battery. This battery will typically deliver 0 years operation life when the average current is not more than 87. µa at C. Under these conditions, the accumulated self discharge loss of the battery is less than % during its operating life. As a result it is fair to say that Tadiran s PulsesPlus TM battery is the smallest and most cost effective battery for a 0 year stand alone power supply. Variable design PulsesPlus TM batteries can be assembled in a great variety of combinations. The primary cell can be selected from Tadiran s large range of.6 Volt LTC batteries. A special range of LSC (Lithium Sulphuryl Chloride) cells with a nominal voltage of.9 Volts is also available, often allowing a more economic approach where equipment needs to operate at very low temperatures. Each of these primary cells can be combined with one or more HLCs from a range of four sizes. Series and parallel combinations of more primary cells extend the voltage range and capacity range where necessary. Only a few standard combinations can be shown in this catalogue. Contact Tadiran for a customized application proposal. Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

27 TLP-9/A High energy Up to A pulse capability Instant voltage response No passivation effect (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) LTC and HLC.6 V. Ah ma Max. s pulse to V A Max. pulse 0. A to.8 V 000 s Delay time to 0. A none g Temperature range... 8 C Capacity retention after 0 year storage 87 % Voltage during a Pulse at C : 00 ma : 70 ma : 00 ma Pulse duration / s TLP-9/A/SM max. 00 ±0 Pulse amplitude / A Maximum Pulse Width from.6 V to.8 V.0 :. : :.0 : C : 8 C..0 & Pulse width / s max. B C B = LTC battery C = HLC F = PTC (optional) Both the LTC battery and the HLC are UL recognized. F Pulse Voltage after s : : : 00 ma 600 ma 000 ma 6 max. TLP-9/A/SM Flying leads Risk of fire or explosion. Do not charge, incinerate, disassemble, heat above 0, or expose contents to water. Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. 7 Capacity to Volts / Ah : 7 C 0. : C : C : : Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

28 TLP-9/A High energy Up to A pulse capability Instant voltage response No passivation effect (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) LTC and HLC.6 V. Ah ma Max. s pulse to V A Max. pulse 0. A to.8 V 000 s Delay time to 0. A none 0 g Temperature range... 8 C Capacity retention after 0 year storage 90 % Voltage during a Pulse at C : 00 ma : 0 ma : 00 ma Pulse duration / s TLP-9/A/SM Ø 7 TLP-9/A/ST Ø 7 8 ± Pulse amplitude / A Maximum Pulse Width from.6 V to.8 V : : : : : C 8 C & Pulse width / s 7 max. 7 max. F Pulse Voltage after s.0.8 Ø 6. max. Ø 6. max. ± B C B = LTC battery C = HLC F = PTC (optional) Both the LTC battery and the HLC are UL recognized : : : 00 ma 00 ma 00 ma. TLP-9/A/SM Pressure contacts TLP-9/A/ST Solder tags Do not charge. Battery can explode if disassembled, heated above 0, incinerated, or contents exposed to water. Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. 8 Capacity to Volts / Ah.0..0 : 7 C 0. : C : C : : Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

29 TLP-9/A High energy Up to A pulse capability Instant voltage response No passivation effect (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) LTC and HLC.6 V 8. Ah ma Max. s pulse to V A Max. pulse 0. A to.8 V 000 s Delay time to 0. A none 00 g Temperature range... 8 C Capacity retention after 0 year storage 9 % Voltage during a Pulse at C : 00 ma : 70 ma : 00 ma Pulse duration / s TLP-9/A/SM max. max. 00 ±0 Note: For best performance battery should be mounted in the application in upright or horizontal orientation. B C B = LTC battery C = HLC F = PTC (optional) Both the LTC battery and the HLC are UL recognized. F Pulse amplitude / A Maximum Pulse Width from.6 V to.8 V.0 :. : :.0 : C : 8 C..0 & Pulse width / s Pulse Voltage after s : : : 00 ma 600 ma 000 ma 8 max. 0 TLP-9/A/SM Flying leads Risk of fire or explosion. Do not charge, incinerate, disassemble, heat above 0, or expose contents to water. Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. 9 Capacity to Volts / Ah 8 6 : 7 C : C : C : : Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

30 TLP-9/A High energy Up to A pulse capability Instant voltage response No passivation effect (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) LTC and HLC.6 V 8. Ah ma Max. s pulse to V A Max. pulse 0. A to.8 V 000 s Delay time to 0. A none 80 g Temperature range... 8 C Capacity retention after 0 year storage 9 % Voltage during a Pulse at C : 00 ma : 0 ma : 00 ma Pulse duration / s TLP-9/A/SM 67 max. 7 ±0 Note: For best performance battery should be mounted in the application in upright or horizontal orientation. Pulse amplitude / A Maximum Pulse Width from.6 V to.8 V : : : : : C 8 C & Pulse width / s Pulse Voltage after s.0 F.8 Ø 9 max. B C B = LTC battery C = HLC F = PTC (optional) Both the LTC battery and the HLC are UL recognized : : : 00 ma 00 ma 00 ma 0 TLP-9/A/SM Flying leads Risk of fire or explosion. Do not charge, incinerate, disassemble, heat above 0, or expose contents to water. Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. 0 Capacity to Volts / Ah 8 6 : 7 C : C : C : : Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

31 TLP-9/A High energy Up to A pulse capability Instant voltage response No passivation effect (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) LTC and HLC.6 V 9 Ah ma Max. s pulse to V A Max. pulse 0. A to.8 V 000 s Delay time to 0. A none 0 g Temperature range... 8 C Capacity retention after 0 year storage 96 % Voltage during a Pulse at C : 00 ma : 70 ma : 00 ma Pulse duration / s TLP-9/A/SM 00 ±0 Pulse amplitude / A Maximum Pulse Width from.6 V to.8 V.0 :. : :.0 : C : 8 C..0 & Pulse width / s 6 max. Note: For best performance battery should be mounted in the application in upright or horizontal orientation. B C F Pulse Voltage after s : : : 00 ma 600 ma 000 ma 0 max. B = LTC battery C = HLC F = PTC (optional) Both the LTC battery and the HLC are UL recognized max. TLP-9/A/SM Flying leads Risk of fire or explosion. Do not charge, incinerate, disassemble, heat above 0, or expose contents to water. Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. Capacity to Volts / Ah 0 : : : : : 8 C Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

32 TLP-9/A High energy Up to A pulse capability Instant voltage response No passivation effect (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) LTC and HLC.6 V 9 Ah ma Max. s pulse to V A Max. pulse 0. A to.8 V 000 s Delay time to 0. A none 0 g Temperature range... 8 C Capacity retention after 0 year storage 96 % Voltage during a Pulse at C : 00 ma : 0 ma : 00 ma Pulse duration / s TLP-9/A/SM 7 ±0 Pulse amplitude / A Maximum Pulse Width from.6 V to.8 V : : : : : C 8 C & Pulse width / s 78 max. Note: For best performance battery should be mounted in the application in upright or horizontal orientation. B C F Pulse Voltage after s : : : 00 ma 00 ma 00 ma Ø max. B = LTC battery C = HLC F = PTC (optional) Both the LTC battery and the HLC are UL recognized TLP-9/A/SM Flying leads Risk of fire or explosion. Do not charge, incinerate, disassemble, heat above 0, or expose contents to water. Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. Capacity to Volts / Ah 0 : : : : : 8 C Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

33 TLP-96/A High energy Up to A pulse capability Instant voltage response No passivation effect (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) LTC and HLC.6 V. Ah 0.6 ma Max. s pulse to V A Max. pulse 0. A to.8 V 000 s Delay time to 0. A none g Temperature range... 8 C Capacity retention after 0 year storage 78 % Voltage during a Pulse at C : 00 ma : 70 ma : 00 ma Pulse duration / s TLP-96/A/SM max. 00 ±0 Pulse amplitude / A Maximum Pulse Width from.6 V to.8 V.0 :. : :.0 : C : 8 C..0 & Pulse width / s max. B C B = LTC battery C = HLC F = PTC (optional) Both the LTC battery and the HLC are UL recognized. F Pulse Voltage after s : : : 00 ma 600 ma 000 ma 6 max. TLP-96/A/SM Flying leads Risk of fire or explosion. Do not charge, incinerate, disassemble, heat above 0, or expose contents to water. Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. Capacity to Volts / Ah : : : : : 7 C C C Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

34 TLP-96/A High energy Up to A pulse capability Instant voltage response No passivation effect (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) LTC and HLC.6 V. Ah 0.6 ma Max. s pulse to V A Max. pulse 0. A to.8 V 000 s Delay time to 0. A none 0 g Temperature range... 8 C Capacity retention after 0 year storage 8 % Voltage during a Pulse at C : 00 ma : 0 ma : 00 ma Pulse duration / s TLP-96/A/SM Ø 7 0 max. TLP-96/A/ST Ø 7 0 max. 8 ± Pulse amplitude / A Maximum Pulse Width from.6 V to.8 V : : : : : C 8 C & Pulse width / s Pulse Voltage after s.0.8 Ø 6. max. Ø 6. max. ±.6.. : : : 00 ma 00 ma 00 ma.0 B C F TLP-96/A/SM Pressure contacts TLP-96/A/ST Solder tags B = LTC battery C = HLC F = PTC (optional) Both the LTC battery and the HLC are UL recognized. Do not charge. Battery can explode if disassembled, heated above 0, incinerated, or contents exposed to water. Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. Capacity to Volts / Ah : : : : : 7 C C C Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

35 TLP-97/A High energy Up to A pulse capability Instant voltage response No passivation effect (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) LTC and HLC.6 V.6 Ah ma Max. s pulse to V A Max. pulse 0. A to.8 V 000 s Delay time to 0. A none g Temperature range... 8 C Capacity retention after 0 year storage 80 % Voltage during a Pulse at C : 00 ma : 70 ma : 00 ma Pulse duration / s TLP-97/A/SM max. 00 ±0 B C F Pulse amplitude / A Maximum Pulse Width from.6 V to.8 V.0 :. : :.0 : C : 8 C..0 & Pulse width / s B = LTC battery C = HLC F = PTC (optional) Pulse Voltage after s.0 max. Both the LTC battery and the HLC are UL recognized : : : 00 ma 600 ma 000 ma max. TLP-97/A/SM Flying leads Risk of fire or explosion. Do not charge, incinerate, disassemble, heat above 0, or expose contents to water. Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. Capacity to Volts / Ah : 7 C : : C : : C Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

36 TLP-97/A High energy Up to A pulse capability Instant voltage response No passivation effect (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) LTC and HLC.6 V.6 Ah ma Max. s pulse to V A Max. pulse 0. A to.8 V 000 s Delay time to 0. A none g Temperature range... 8 C Capacity retention after 0 year storage 8 % Voltage during a Pulse at C : 00 ma : 0 ma : 00 ma Pulse duration / s TLP-97/A/SM Ø 7 8 max. Ø 6. max. TLP-97/A/ST Ø 7 8 max. Ø 6. max. 8 ± ± B C B = LTC battery C = HLC F = PTC (optional) Both the LTC battery and the HLC are UL recognized. F Pulse amplitude / A Maximum Pulse Width from.6 V to.8 V : : : : : C 8 C & Pulse width / s Pulse Voltage after s : : : 00 ma 00 ma 00 ma TLP-97/A/SM Pressure contacts TLP-97/A/ST Solder tags Do not charge. Battery can explode if disassembled, heated above 0, incinerated, or contents exposed to water. Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. 6 Capacity to Volts / Ah : 7 C : : C : : C Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

37 Hybrid Layer Capacitors (HLCs) Introduction Properties Hybrid Layer Capacitors are a kind of rechargeable battery. They are used as a capacitor in PulsesPlus TM batteries, where they are connected in parallel to Tadiran Lithium Batteries. The electrodes of HLCs comprise Lithium intercalation compounds. They have low impedance and can deliver high current pulses. The performance and reliability properties of HLCs have been carefully optimized to match those of Tadiran Lithium Batteries. The result is a battery with a maximum of both energy and power density for stand alone use of up to years. Safety HLCs are designed for use in PulsesPlus TM batteries. When used independently, they must not be fast charged. Temperature range... 8 C for operation in PulsesPlus TM batteries... 6 for storage and independent use Electrical characteristics Discharge end voltage. V Discharge below. V at C and discharge below V at may lead to an increase of the internal resistance. Max. charge voltage.9 V Shelf life in PulsesPlus TM batteries used C 0 years 6 7 years 8 C year week Cycle life at.6 V at.9 V to % DOD ) cycles cycles to 0 % DOD 0000 cycles 0000 cycles to 00 % DOD 000 cycles 000 cycles ) DOD = depth of discharge Overcharge above.9 V may lead to capacity loss and/or an increase of internal resistance. Overcharge above. V may lead to excessive internal pressure. This may result in explosion or rupture. HLCs must not be charged after a deep discharge below. Volts. Transport HLCs have passed the UN transport tests. They contain less than 0. g lithium equivalent and are not restricted under international dangerous goods regulations. For more information on classification and transport regulations, please refer to Tadiran s technical notice: regulations/ Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. 7 Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

38 HLC-00 Delivering high current pulses Low self discharge Up to years lifetime and more Wide operating temperature range (Typical (pour des values piles in stockées PulsesPlus à TM C batteries pendant stored an) at C) Lithium Intercalated Compounds Version HLC-00 (HLC-00L).67 V / optional.9 V V 70 V (0 V) ( V) ma Max. continuous discharge current 0 ma (0 ma) Pulse current capability 70 ma (00 ma) Max. charge voltage.9 V Max. charge current 8 ma (6 ma) Discharge end voltage. V Cell impedance max. 00 mω (max. 600 mω) g. g For more data please refer to page 7. HLC-00(L)/S Ø 0 ±0..7 ±0. 7 ±.7 HLC-00(L)/T HLC-00(L)/TP Pulse amplitude / A Voltage during a Pulse at C Pulse duration / s Maximum Pulse Width from.6 V to.8 V : : : : : C 8 C Pulse width / s Pulse Voltage after s.0.8 : : : 0 ma 7 ma 0 ma & 0.7 ± : : : 0 ma 60 ma 00 ma HLC-00/S Standard HLC-00/T Tags HLC-00/TP Polarized tags HLC-00L/S Standard HLC-00L/T Tags HLC-00L/TP Polarized tags CAUTION: Fire, explosion, and severe burn hazard. Do not disassemble, heat above 0, or incinerate. Use as part of PulsesPlus battery only. Do not charge above.9 V. Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. 8 Open circuit voltage / V Voltage Curve at C ma discharge Available capacity / As Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

39 HLC-0A Delivering high current pulses Low self discharge Up to years lifetime and more Wide operating temperature range (Typical (pour des values piles in stockées PulsesPlus à TM C batteries pendant stored an) at C) Lithium Intercalated Compounds.67 V, optional.9 V 0 As (9 V 0 As (8 V ma Max. continuous discharge current 00 ma Pulse current capability 000 ma Max. charge voltage.9 V Max. charge current ma Discharge end voltage. V Cell impedance max. 0 mω (@ khz, RT) V V 7.7 g For more data please refer to page 7. HLC-0/S Ø. Ø ± 0..7 HLC-0/T HLC-0/TP Pulse amplitude / A Voltage during a Pulse at C : 00 ma : 0 ma : 00 ma Pulse duration / s Maximum Pulse Width from.6 V to.8 V : : : : : C 8 C & Pulse width / s Pulse Voltage after s ±0..0 ± : : : 00 ma 00 ma 00 ma 0.7 ± HLC-0A/S Standard 0 0 HLC-0A/T Tags 0 0 HLC-0A/TP Polarized tags CAUTION: Fire, explosion, and severe burn hazard. Do not disassemble, heat above 0, or incinerate. Use as part of PulsesPlus battery only. Do not charge above.9 V. Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. 9 Open circuit voltage / V Voltage Curve at C ma discharge Available capacity / As Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

40 HLC-0A Delivering high current pulses Low self discharge Up to years lifetime and more Wide operating temperature range (Typical (pour des values piles in stockées PulsesPlus à TM C batteries pendant stored an) at C) Voltage during a Pulse at C.0 Lithium Intercalated Compounds.67 V, optional.9 V 0 As (70 V 80 As (0 V 0 ma Max. continuous discharge current 70 ma Pulse current capability 000 ma Max. charge voltage.9 V Max. charge current 0 ma Discharge end voltage. V Cell impedance max. 0 mω (@ khz, RT) V V 0. g For more data please refer to page 7. HLC-0/S Ø ±.7 HLC-0/T Pulse amplitude / A Pulse duration / s Maximum Pulse Width from.6 V to.8 V : : : : : C 8 C : 0 ma : 00 ma : 70 ma & Pulse width / s HLC-0/TP Pulse Voltage after s.0 Ø ± ±.0 ± : : : 0 ma 00 ma 00 ma HLC-0A/S Standard 0 0 HLC-0A/T Tags 0 0 HLC-0A/TP Polarized tags CAUTION: Fire, explosion, and severe burn hazard. Do not disassemble, heat above 0, or incinerate. Use as part of PulsesPlus battery only. Do not charge above.9 V. Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. 0 Open circuit voltage / V Voltage Curve at C ma discharge Available capacity / As Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

41 HLC-0A Delivering high current pulses Low self discharge Up to years lifetime and more Wide operating temperature range (Typical (pour des values piles in stockées PulsesPlus à TM C batteries pendant stored an) at C) Lithium Intercalated Compounds.67 V, optional.9 V 60 As ( V 80 As (0 V 0 ma Max. continuous discharge current 000 ma Pulse current capability 000 ma Max. charge voltage.9 V Max. charge current 00 ma Discharge end voltage. V Cell impedance max. 00 mω (@ khz, RT) V V 0 g For more data please refer to page 7. HLC-0/S Ø ± 0..7 HLC-0/T HLC-0/TP Pulse amplitude / A Voltage during a Pulse at C : 00 ma : 70 ma : 00 ma Pulse duration / s Maximum Pulse Width from.6 V to.8 V.0 :. : :.0 : C : 8 C..0 & Pulse width / s Pulse Voltage after s ±0..0 ± : : : 00 ma 600 ma 000 ma Ø ± HLC-0A/S Standard 0 0 HLC-0A/T Tags 0 0 HLC-0A/TP Polarized tags CAUTION: Fire, explosion, and severe burn hazard. Do not disassemble, heat above 0, or incinerate. Use as part of PulsesPlus battery only. Do not charge above.9 V. Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. Open circuit voltage / V Voltage Curve at C ma discharge Available capacity / As Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

42 Introduction Comparison TLM versus Li/MnO : TLM-0/HPM under C : TLM-0/HPM under : CRA under C : CRA under Capacity / Ah Figure : Comparison TLM versus Li/MnO The TLM battery The Tadiran TLM series, the newest product innovation from Tadiran Batteries, is distinguished by its extremely high power in the decisive moment when it really matters! It stands for guaranteed power even after long storage or stand-by up to more than 0 years. Its outstanding properties make it the ideal back-up battery for the ecall system, surgical instruments, and other special applications. Military version TLM batteries are also available in a more robust version for military applications. For more information see >> products >> TLM batteries >> Military version. Advantages High voltage.0 V Very high pulse current capability Immediate response, no passivation effect Wide operating temperature range ( to 8 C) High reliability (hermetic laser sealing, glass-to-metal seal) Outstanding storage capability (up to 0 years) Recognized safety (UL) Very low self discharge Easy health monitoring during storage Outperforms competition Compared to other commercial high rate lithium batteries, TLM batteries are superior with respect to their voltage, energy content, and temperature behaviour. Figure shows a comparison with CRA batteries. These batteries have almost the same volume as TLM-0HPM and belong to the Lithium Manganese Dioxide Volt system. Under a Ampere discharge at room temperature, they deliver almost the same capacity as TLM-0HPM but at much lower voltage. Under Ampere discharge at, CRA delivers almost no capacity above Volts, while TLM-0HPM still delivers more than 70 % of its nominal capacity. Application in ecall modules One major application for TLM batteries is the so-called Autonomous Telematics Box or Advanced Telematics Module where the TLM battery serves as the back-up battery for ecall, the automatic emergency call system for cars in Europe. The requirements for this system include operation under high pulse currents at low temperature at any time up to 0 years after installation. Even under these severe conditions, an air time of more than 0 minutes is required. During this air time, the system exchanges both car condition and position data and voice signals between the car and an emergency call centre. Smallest high power battery Figure shows the behaviour of TLM-0HPM under these conditions. The battery was subjected to accelerated ageing by storing it at 7 C for weeks prior to the test. Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. Internal resistance / mω CDMA Discharge after Accelerated Ageing TLM-0HPM after weeks 7 C : 0. A for.7 ms every 6. ms, followed by :. A for. ms 0 0 Time / min It was then cooled down to and discharged under a simulated application load profile comprising. A of. ms duration every 6. ms on a basic load of 0. A. The upper curve () shows the voltage on the basic load while the lower curve () Impedance Growth during Storage Time / days shows the voltage during the. A pulses. The discharge duration is clearly in excess of 0 minutes. TLM-0HPM is the smallest battery commercially available on the market that can fulfil these requirements. Figure : CDMA Discharge after Accelerated Ageing Figure : Impedance Growth during Storage TLM-0HPM RT 7 C Enduring low impedance For demanding applications like the back-up battery in ecall systems, the durability of the battery in a wide temperature range is a decisive factor. Especially two parameters need to be sufficiently low and stable: self discharge and internal resistance. The development of self discharge, expressed as capacity loss over storage time, is shown in the data sheets of TLM batteries on the following pages while Figure shows the development of the internal resistance of TLM-0HPM over time at two different storage temperatures. It remains within the specified limits, even after storage at 7 C for years. Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

43 TLM-0HPM High power Volt cell No voltage delay Long shelf life End of life indication capability (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Metal Oxide.0 V mah ma Max. continuous discharge current.7 A Pulse current capability.7 A Cell impedance max. 00 mω Anode surface area 90 cm g 9 g Volume. cm Temperature range... 8 C Discharge Capability at RT.... : A : ma : ma Capacity / mah TLM-0HPM/S Ø ±.7 TLM-0HPM/T Discharge at 0 ma and several Temperatures.... : : : C 0. : 8 C Capacity / mah Ø. 0. TLM-0HPM/TP 0 Ageing during Storage.7 ±0..0 ± ± Accumulated capacity loss ) / % : C : C : 7 ) when tested at RT under ma to.8 V Time / years.0 Voltage Curve. TLM-0HPM/S Standard 0 0 TLM-0HPM/T Tags 0 0 TLM-0HPM/TP Polarized tags Fire, explosion, and severe burn hazard. Do not charge, disassemble, heat above 0, incinerate, or short circuit. Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications Capacity / mah Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

44 TLM-0HPM High power Volt cell No voltage delay Long shelf life End of life indication capability (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Metal Oxide.0 V mah 9 ma Max. continuous discharge current. A Pulse current capability 6.8 A Cell impedance max. 00 mω Anode surface area 60 cm 0. g g Volume. cm Temperature range... 8 C Discharge Capability at RT : : : :.8 A 0 ma ma 9 ma Capacity / mah TLM-0HPM/S Ø ±.7 TLM-0HPM/T Discharge at 0 ma and several Temperatures.... : : : C 0. 0 : 8 C Capacity / mah Ø ±0..0 ± ± TLM-0HPM/TP Accumulated capacity loss ) / % Ageing during Storage : C : C : Time / years ) when tested at RT under 0 ma to.8 V.0 Voltage Curve. TLM-0HPM/S Standard 0 0 TLM-0HPM/T Tags 0 0 TLM-0HPM/TP Polarized tags Fire, explosion, and severe burn hazard. Do not charge, disassemble, heat above 0, incinerate, or short circuit. Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification Capacity / mah Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

45 TLM-0HPM High power Volt cell No voltage delay Long shelf life End of life indication capability (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Metal Oxide.0 V 00 mah 00 ma Max. continuous discharge current 7 A Pulse current capability A Cell impedance max. 00 mω Anode surface area 60 cm 0. g 0 g Volume 8 cm Temperature range... 8 C TLM-0HPM/S Ø, - Ø, 0, ±0. 7 ±.7.0 ± ± 7. TLM-0HPM/Z/T TLM-0HPM/Z/TP Accumulated capacity loss ) / % Discharge capability at RT... : A. : :. A 0. A Capacity / mah Discharge A at several temperatures.00 : : :.0 : C : 7 C Ageing during Storage Capacity / mah : C : C : 7 ) when tested at RT under 0 ma to.8 V Time / years.0 Voltage Curve. TLM-0HPM/S Standard 0 0 TLM-0HPM/Z/T Tags* 0 TLM-0HPM/Z/TP Polarized tags* 7 0 * with PTC SRP 00 Fire, explosion, and severe burn hazard. Do not charge, disassemble, heat above 0, incinerate, or short circuit. Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications Capacity / mah Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

46 Introduction TLI-Battery The TLI series is specifically designed for long-term use in harsh environments. It represents an important breakthrough in rechargeable lithium-ion battery technology. Standard rechargeable lithium ion cells have inherent drawbacks which have an impact on long term applications. These include short operating life (maximum years), low maximum cycle life (000 cycles), high self-discharge (up to 60 % per year), and limited temperature range ( to 6) with no possibility of charging at low and high temperatures. By contrast, TLI series batteries utilize technology found in Tadiran s patented hybrid layer capacitor (HLC). Tadiran s technology has been fieldproven in millions of cells to deliver years and more service life. TLI series batteries modify this technology to deliver reliable, long-term performance under extreme environmental conditions. Characteristics Wide operating temperature ( to 8 C) Short time storage up to 9 possible Ability to deliver high current pulses (up to A) Low self-discharge (less than % per year) Up to times extended cycle life (000 full charge/ discharge cycles) Long operating time (0 years) Charging possible at extreme temperatures (0h-rate) Hermetically sealed cell (glass-to-metal seal) Certified safety (UL) Easy monitoring of cell fitness during storage Table shows a comparison of a standard lithium ion cell 860 with the TLI-0. It can be seen that the characteristics of the TLI series are superior in terms of power, self-discharge and operating temperature range. Characteristics 860 Li-Ion TLI-0A Dimensions Ø 8 mm x 6 mm Ø mm x 0 mm Capacity. Ah 0. Ah C 8W 8 < W > 6 W Temperature range: Storage to 6 to 8 C Discharge to 6 to 8 C Charge ± to C to 8 C Self discharge 0 % per year < % per year Operating life years 0 years Table : Comparison of TLI-0 versus a standard lithium ion cell Charging Principle CCCV : Voltage : Current.0 Time Figure : Charging principle CCCV. Example for TLI-0 Figure shows the constant current/constant voltage (CCCV) charging principle which is recommended for the TLI series. The battery is charged with a constant current until the maximum voltage is reached. Afterwards, the charging current is decreased to maintain constant voltage. Charging may be discontinued when a predefined end-of-charge current is reached. With the maximum current, charging takes approximately 6. hours in the temperature range between and. In the extended temperature range between and 8 C the maximum charging current is five times lower, resulting in a five times longer charging time. TLI in ecall applications The TLI battery ensures constant power supply even under high current pulses. This is required for applications like bidirectional wireless communication modules. One major application for TLI batteries is Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification the so-called Autonomous Telematics Box or Advanced Telematics Module where the TLI battery serves as the back-up battery for ecall, the automatic emergency call system for cars in Europe. The requirements for this system include operation under high pulse currents at low temperature at any time up to 0 years after installation. Even under these severe conditions, an air time of more than 0 0 GSM Discharge Curves :.0 A / 77 µs.0 : 0 ma /.6 ms Time / min Figure : Discharge behaviour of TLI-0 under the GSM profile after storage at 7 C for one month 6 minutes is required. During this air time, the system exchanges both car condition and position data and voice signals between the car and an emergency call centre. Figure shows the behaviour of TLI-0 in a typical ecall application after an ageing period of one month at 7 C. The GSM transmission profile of the application requires a A pulse for the duration of 77 µs followed by a 0 ma pulse for.6 ms. This load alternation is continuously repeated. Even at a temperature of a TLI-0 cell ensures an air time of more than minutes. Protection In order to ensure a high level of safety, TLI cells 0 and 0 should be protected by a PTC either on the battery or on the PC-board. Recommended PTC types include SRP0 and SRP00, respectively, as follows: SRP0 limits the discharge current to. A and SRP00 to A. In special cases cells can be used without PTC. TLI batteries have no integrated overcharge protection. The protection circuit should be designed by the customer and be approved by Tadiran. Please refer to the TLI guidelines posted on Tadiran s website under products >> TLI-batteries. Approval by Tadiran The design of the following items should be approved by Tadiran: Implementation of the protection circuit against overcharge, e.g. by limitation of the charging voltage and charging current to the values given in the individual data sheets Implementation of low voltage protection against deep discharge Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

47 TLI-00A RECHARGEABLE Up to 000 cycles Extremely low self discharge rate Charging possible at extreme temperatures (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Intercalated Compounds V Max. capacity mah Max. continuous discharge current 60 ma Pulse current capability 00 ma Discharge end voltage. V Max. charge voltage. V Max. charge current 8 ma.6 ma Temperature range C Cell khz, RT max. 600 mω Nominal energy max. 9 Wh. g For more information please refer to page Discharge Curve at C Capacity / mah Discharge Curve at 00 ma : 00 ma : 00 ma : 00 ma : 0 ma TLI-00A/S Ø 0 ±0. 7 ±.7 TLI-00A/T : : : : : C TLI-00A/TP Capacity / mah.7 ±0. 0 Cycling Performance 0.7 ± 7. Capacity / mah Cycles TLI-00A/S Standard 0 0 TLI-00A/T Tags 0 0 TLI-00A/TP Polarized tags 07 0 Warning: Fire, explosion, and severe burn hazards. Do not disassemble, heat above 0, short circuit, incinerate or expose contents to water. Do not charge above. V. Please refer to TLI-guidelines. Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. 7 Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

48 TLI-0A RECHARGEABLE Up to 000 cycles Extremely low self discharge rate Charging possible at extreme temperatures (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Intercalated Compounds V Max. capacity 90 mah Max. continuous discharge current 00 ma Pulse current capability. A Dischage end voltage. V Max. charge voltage. V Max. charge current ma ma Temperature range C Cell khz, RT max. 0 mω Nominal energy max. 0. Wh 9 g For more information please refer to page Discharge Curve at C : 0 ma : 6 ma : 0 ma : 0 ma Capacity / mah Discharge Curve at 00 ma TLI-0A/Z Ø. 7 ± TLI-0A/Z/T : : : : : C Capacity / mah Ø. 0. TLI-0A/Z/TP 0 Cycling Performance 0..7 ±0..0 ± ± 7. Capacity / mah Cycles TLI-0A/Z/T Tags* 0 TLI-0A/Z/TP Polarized tags* 7 0 * with PTC SRP 00 Warning: Fire, explosion, and severe burn hazards. Do not disassemble, heat above 0, short circuit, incinerate or expose contents to water. Do not charge above. V. Please refer to TLI-guidelines. Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. 8 Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

49 TLI-0A RECHARGEABLE Up to 000 cycles Extremely low self discharge rate Charging possible at extreme temperatures (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Intercalated Compounds V Max. capacity 0 mah Max. continuous discharge current A Pulse current capability. A Dischage end voltage. V Max. charge voltage. V Max. charge current 0 ma 0 ma Temperature range C Cell khz, RT max. 7 mω Nominal energy max. 0. Wh 0 g For more information please refer to page Discharge Curve at C Capacity / mah Discharge Curve at A : 00 ma : 0 ma : 00 ma : 0 ma TLI-0A/Z Ø ±.7 TLI-0A/Z/T Capacity / mah : : : : : C TLI-0A/Z/TP Cycling Performance 60 Ø ±0..0 ± ± 7. Capacity / mah Cycles TLI-0A/Z/T Tags* 0 TLI-0A/Z/TP Polarized tags* 7 0 * with PTC SRP 00 Warning: Fire, explosion, and severe burn hazards. Do not disassemble, heat above 0, short circuit, incinerate or expose contents to water. Do not charge above. V. Please refer to TLI-guidelines. Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. 9 Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

50 TLI-0A (Typical (pour des values piles for stockées batteries à stored C pendant at C an) for one year) Lithium Intercalated Compounds V Max. capacity 0 mah Max. continuous discharge current A Pulse current capability A Discharge end voltage. V Max. charge voltage. V Max. charge current 00 ma 0 ma Temperature range C Cell khz, RT max. 00 mω Nominal energy max.. Wh 0 g For more information please refer to page 6. TLI-0A/Z Ø. - Ø ±0. 7 ±.7.0 ± ± 7. TLI-0A/Z/T TLI-0A/Z/TP RECHARGEABLE Up to 000 cycles Extremely low self discharge rate Charging possible at extreme temperatures Capacity / mah Discharge Curve at C Capacity / mah Discharge Curve at A 6 : : : :.0 A. A.0 A 0. A Capacity / mah Cycling Performance : : : : : 6: 7: C Cycles TLI-0A/Z/T Tags* 0 TLI-0A/Z/TP Polarized tags* 7 0 * with PTC SRP 00 Warning: Fire, explosion, and severe burn hazards. Do not disassemble, heat above 0, short circuit, incinerate or expose contents to water. Do not charge above. V. Please refer to TLI-guidelines. Any Toutes values les valeurs given here sont are exclusivement for informational données purposes à titre only. d information. They also depend Elles dépendent on actual conditions également of des use conditions and are not d utilisation warranties et of ne future constituent performance. donc pas Subject une garantie to change. de performance. Sous réserve de toute modification. 0 Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0) PDC7Eng PDCFra

51 Safety & Transport Regulations Standards General safety recommendations for lithium batteries have been published in the standards UL 6 and IEC UL-recognition Tadiran Lithium Batteries are recognized by UL under file MH 87, please refer to UL ONLINE CERTIFICATIONS DIRECTORY for further information. The following text or a modified version thereof appears on each battery: Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above 0, incinerate, or expose contents to water. Protection against charging Whenever lithium batteries are not the single power source in a circuit the following measures are recommended by the Underwriters Laboratories: The battery should not be connected in series with an electrical power source that would increase the forward current through the battery. The circuit shall include one of the following: A. Two suitable diodes in series with the battery to prevent any reverse (charging) current. The second diode provides protection if the other one fails; or B. A blocking diode or the equivalent to prevent any reverse (charging) current and a resistor to limit current in case of a diode failure. The resistor should be sized to limit the reverse (charging) current to the maximums I R max shown in table. In addition to this UL requirement, which gives the safety limits, Tadiran Batteries recommend to limit the reverse (charging) current to values below 0 µa. This will ensure that service life is not affected. Type SL-0 SL-60 SL-6 SL-0 SL-60 SL-6 SL-70 SL-760 SL-76 SL-80 SL-80 SL-860 SL-86 SL-886 SL-889 SL-770 SL-780 SL-790 SL-870 SL-880 TLM-0HPM TLM-0HPM TLM-0HPM I R max ma 0 ma 0 ma ma 0 ma ma ma 0 ma 0 ma ma ma 0 ma 0 ma ma 0 ma ma 0 ma 00 ma ma 0 ma 00 ma 00 ma 00 ma Protection against forced discharge Forced discharge of a cell can occur when it is connected in series with other cells. A bypass diode should be provided in parallel with each cell in a series connection. The effect of a by-pass diode is that current passes through the diode if a cell has been discharged, preventing forced discharge. REACH and RoHS All Tadiran cell are compliant with REACH regulation and RoHS directive. Table : Maximum reverse current Classification of lithium batteries Lithium metal batteries are dangerous goods, UN No Lithium ion batteries are dangerous goods, UN No. 80. Table indicates which Tadiran Lithium cells are exempted from the dangerous goods regulations and which are not. In air transport, exemptions are limited. For more information on classification and transport regulations, please refer to Tadiran s technical notice: regulations/ UN tests Table also shows the status of UN-tests for Tadiran Lithium Batteries according to the UN Handbook of Tests and Criteria, part III, sub-section 8.. Regarding Tadiran Lithium Batteries not listed in table, please apply to Tadiran Batteries for a confirmation. Size Type Exempted ) Lithium content [g] Lithium Thionyl Chloride (LTC) Hybrid Layer Capacitors (HLC) UN Test passed UN Number BEL SL-80 Yes 0. Yes 090/9 0C TLH-0 TL-0 Yes 0.8 Yes 090/9 0D SL-786 SL-886 Yes 0. Yes 090/9 6D SL-789 SL-889 Yes ) 0. Yes 090/9 AA SL-0 SL-0 SL-70 SL-80 Yes ) 0. Yes 090/9 AA SL-6 SL-6 SL-76 SL-86 Yes ) 0. Yes 090/9 AA SL-60 SL-60 SL-760 SL-860 Yes ) 0.6 Yes 090/9 C SL-770 SL-870 No. Yes 090/9 D SL-780 SL880 No Yes 090/9 DD SL-790 No 0 Yes 090/9 AAA HLC-00 (.67 V and.9 V) Yes Yes 090/9 AA HLC-0 (.67 V) Yes Yes 090/9 AA HLC-0 (.67 V) Yes Yes 090/9 AA HLC-0 (.67 V) Yes Yes 090/9 AA HLC-0 (.9 V) Yes Yes 090/9 AA HLC-0 (.9 V) Yes Yes 090/9 AA HLC-0 (.9 V) Yes 0. Yes 090/9 TLM batteries AA TLM-0HPM Yes Yes 090/9 AA TLM-0HPM Yes 0. Yes 090/9 AA TLM-0HPM Yes 0. Yes 090/9 TLI batteries AAA TLI-00A Yes < 9 Wh Yes 80/8 AA TLI-0A Yes < 0. Wh Yes 80/8 AA TLI-0A Yes < 0. Wh Yes 80/8 AA TLI-0A Yes <. Wh Yes 80/8 Table : Classification of Tadiran Lithium Batteries ) if conditions mentioned in Tadiran s technical notice are fulfilled ) see also IATA DGR under UN 090 / PI 968 / Table 968-II PDC7Eng PDCFra Any Toutes values les valeurs given here données are for ici ont informational but d informer purposes uniquement. only. They Elles also dépendent depend on aussi actual des conditions réelles of use and d utilisation are not warranties et ne sont of pas future des garanties performance. de performance Subject to change. future. Sous réserve de modifications. Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY ALLEMAGNE Tel.: Tel.: 9 9 (0)

52 Tadiran Lithium Batteries Applications Military Emergency Power supply for UAVs Fuzes Gas masks Guidance systems Night vision goggles Targeting devices Ejection seats High end consumer Diving computers Set top boxes Sports electronics Utility Metering Automatic meter reading (AMR) Electricity, gas, water, heat, calorimeters Heat cost allocators Prepayment meters Communication modules Smart electricity meters with a GSM module Tracking Animals Corrosion Data loggers Electronic toll collection On-board units Personal Pipelines Railways Trucks, containers, trailers Alarm and security systems Smoke detectors Wireless alarm systems PIR detectors Cash transport and asset protection systems Offender monitoring systems Beacons Buoys Life jacket lights Oil drilling / MWD Seismic sensors Underwater positioning systems Off-shore Defibrillators Dispensers Implantable devices Infusion pumps Surgical instruments Medical Electronic scales Gambling machines Taximeters Vending machines Instrumentation Cash machines Point of sale terminals Telephone exchange boards Office automation Airbags Automatic collision devices Belt tensioners Brake controllers Communication modules Digital tachographs Doors / latches Engine controllers In-car computers Stolen vehicle recovery systems Telematics / ecall Tyre pressure monitoring systems Automotive Process automation Wireless sensor networks Controllers Fault detectors Industrial PCs Process logic control Industrial automation Your Distributor Lithium Thionyl Chloride (LTC) Batteries PulsesPlus TM Batteries Tadiran Lithium Metal Oxide (TLM) Batteries Tadiran Lithium Ion (TLI) Batteries Tadiran Batteries GmbH Industriestr. 66 BÜDINGEN GERMANY Tel.: 9 (0) PDC7Eng