Tier III considerations
|
|
- Arline Nicholson
- 5 years ago
- Views:
Transcription
1 Tier III considerations
2 IMO Tier III Regulations NECA IMO Tier III Regulation for NOx From 2016 in the North American Emission Control Areas or the US Caribbean Sea Emission Control Areas It is a fact!
3 ECA: Emission Control Areas
4 NOx (g/kwh) IMO NO x Limit Curves Tier I, II & III % engines Tier I % - 20 % Tier I: (global) Tier II: 2011 (global) Tier III: 2016 (ECA s) Rated engine speed (rpm)
5 NOx Reduction Techniques Primary methods ( Process application) Reduction % Expected Proved by test Engine tuning (Tier III or NECA timing)?? Water emulsification? 40? Separate Water injection? 70 (MHI) EGR: Exhaust Gas Recirculation System HP 80 Secondary methods (after treatment) SCR: Selective Catalytic Reduction System HP or LP 95
6 Engine Design/Builders MAN DIESEL & TURBO MITSUBISHI propose: EGR and SCR WÄRTSILÄ propose: SCR
7 IMO Tier III for NOx and SOx Emission For 2-stroke engines Tier III NOx levels in ECAs will be met by installation of a Selctive Catalytic Reactor, SCR or installation of an Exhaust Gas Recirculation, EGR system The sulphur content has an influence on the performance and design of both SCR and EGR. If it is decided always to run on low suphur fuels in ECA the design and/or running cost for EGR and SCR can be lowered. SCR and EGR can be designed for operation on HFO with the normal sulphur contents. If HFO is used in ECAs together with either EGR or SCR it is necessary to install a full flow exhaust gas scrubber to reduce the SOx.
8 State of art Status from ONE of the engine designers
9 EGR Test Conclusions for MAN engines Conclusion on Extreme EGR Test 2009 at MAN EGR feasible for all engine loads Tier III level feasible with approx. 40% EGR ME technology secures optimized EGR operation
10 Investments and Operational Costs Can we minimize CAPEX and OPEX for EGR and SCR? Yes High Low Sulphur CAPEX EGR - 30% SCR - 10%
11 SCR CAPEX SCR CAPEX -16 MW Tier III on High sulphur fuel Excluded: Electric work; Urea tank; EGE by-pass SCR engine equipment (Reactor/Mixer) Engine modification (valves and control system) Auxiliary system (Urea dosing) Installation excl. tanks SCR CAPEX -16 MW Tier III on Low sulphur fuel Excluded: Electric work; Urea tank; EGE by-pass MAN PP MAN Diesel & Turbo MDT IGC Seminar Emission Reduction Technology - Tier III < 11 >
12 EGR CAPEX EGR CAPEX - 16 MW Tier III on High sulphur fuel Excluded: Electric work; NaOH and sludge tank; EGR engine equipment (scrubber, blower, cooler)) Engine modification (valves and control system) Auxiliary system (WTS) Installation excl. tanks EGR CAPEX - 16 MW Tier III on Low sulphur fuel Excluded: Electric work; NaOH and sludge tank; MAN PP MAN Diesel & Turbo MDT IGC Seminar Emission Reduction Technology - Tier III < 12 >
13 EGR - SCR capital cost Capital cost: EGR SCR Rough estimatet MAN PP MAN Diesel & Turbo < 13 >
14 OPEX EGR and SCR Total Cost Note: The LP-SCR OPEX adds to the HP-SCR calculation the extra fuel consumption for LP-SCR burner to decomposition of Urea is show with the green colour. MAN PP MAN. Diesel & Turbo, Low Speed LEE5 / Bent Ørndrup Nielsen < 10 >
15 SFOC Consumption Comparison MAN PP
16 CIMAC 2010 PAPER NO.: 186 Cutting edge technologies of UE engine for higher efficiency and environment Figure 24 shows the independent fuel water injection system and its test results. The water injection valves were installed separately from the fuel injection valves. Therefore, a large amount of water can be injected without limiting the fuel injection system capacity, and a large amount of NOx can also be reduced. However, since excessive water is still required, the water injection timing and atomizer have to be further optimized
17 CIMAC Water / fuel amount ratio (%)
18 STATUS OF INTERESTS Deciding factors of Tier III technology Yard preference First cost (CAPEX) Space requirements Installation flexibility Owner preferences Operation cost (OPEX) Operation simplicity Reliability Maintenance cost Waste disposal cost
19 Proposal to reduce Emission, Investments and Operational Costs The most effective countermeasures reducing emission in general is to reduce the speed of the vessel.
20 Proposal to reduce Emission, Investments and Operational Costs Power reduction Speed reduction 0% 0% 10% 3% 20% 6% 30% 10% 40% 14% 50% 18%
21 Proposal to reduce Emission, Investments and Operational Costs Tier III only for NECA It must be ensured that the motor does not exceed the limited power in Tier III mode. Could be relevant and acceptable for all type of vessels operated only partly at NECA? If Yes then is possible to apply dual certification
22 Proposal to reduce Emission Investments and Operational Costs Dual Certification Tier II Tier III for open Sea for NECA only
23 Proposal to reduce Emission, Investments and Operational Costs Adopting a limited speed for the NECA areas for Tier III will be possible of applying a reduced Tier III application i.e. EGR or SCR on engines limited in power output by NECA sailing. In mean time other possibilities and less polluted as: NECA tuning or separate water injection or water emulsification or Combination WITH the proved systems can be selected. The overall efficiency will be better and the absolute level of emission will be minimized simultaneous that the CAPEX and OPEX for the shipping companies will be considerable lower.
24 Limit Capacity of Tier III NOx control Proposal for dual-no x certificate with reduced Equipment Capacity Outside NECA Tier II Available power NECA Tier III Available power NECA Tier III 60 MW 60 MW Tier II 60 MW 60 MW Tier II EEDI requirement restrictions 60 MW, Same as for Tier II 60 MW Tier III 30 MW, Reduced in Tier III MCR reduced: 30 MW Tier III Minimum power requirements Test cycle loads (% SMCR) Tier II MW 30 MW 40 MW 60 MW Tier III MW 30 MW 40 MW 60 MW Test cycle loads (% SMCR) Tier II MW 30 MW 40 MW 60 MW Tier III MW 15 MW 22.5 MW 30 MW Equivalence/NO X rule amendment? 50% power reduction equals ~ 20% ship speed reduction Could be relevant and acceptable for ALL kind of vessels? MAN PP
25 IMO Tier III Regulations From 2016 in NECA Areas Action must be taken from: Shipyards Engine Designers Engine Builders Classification Societies Shipping Companies
26 Thank you
MDT TIER III options with low sulphur fuels
Greener Shipping Summit Athens, Greece, 10.11. 2015 MDT TIER III options with low sulphur fuels Michael Jeppesen Promotion Manager Sales & Customer Support Marine Low Speed < 1 > Agenda Greener Shipping
More informationEffect of SOx and NOx Regulation Implementation, ECA s and NOx Tier III Current Developments in General
Effect of SOx and NOx Regulation Implementation, ECA s and NOx Tier III Current Developments in General ASEF 2013, KOBE, November 6, 2013 Toru Nakao Hitachi Zosen Corporation, Japan 2 ECA status Emission
More informationMarket Update Note. EcoEGR coming to your Tier III engine soon MUN
MUN2018-02-07 EcoEGR coming to your Tier III engine soon MAN B&W two-stroke diesel engines use selective catalytic reduction (SCR) or exhaust gas recirculation (EGR) to comply with IMO Tier III requirements.
More informationNOx Reduction Technologies for 2-stroke Diesel Engines to Meet IMO Tier III
NOx Reduction Technologies for 2-stroke Diesel Engines to Meet IMO Tier III 6 th Asian Shipbuilding Expert s Forum, Guangzhou, November 22, 2012 Takahiro Fujibayashi Hitachi Zosen Corporation, Japan Topics
More informationECO optimization with NOx equipment
Greener Shipping Summit Athens Greece, 14 th November 2017 ECO optimization with NOx equipment Michael Jeppesen Promotion Manager Promotion & Sales, Two Stroke < 1 > Agenda 1 Influencers of emission compliance
More informationSOx scrubbers Engine Makers view MDT points, markets and Tier III combinations. Greener Shipping Summit Jesper Arvidsson
SOx scrubbers Engine Makers view MDT points, markets and Tier III combinations Greener Shipping Summit 2017 Athens, Greece 2017-11-14 Jesper Arvidsson Engineering/Operation/ Emission Reduction Technology
More informationNOx Tier III SELECTION, CERTIFICATION & OPERATIONS SHIPOWNERS PERSPECTIVE INTERTANKO TRIPARTITE 2016 TOKYO
NOx Tier III SELECTION, CERTIFICATION & OPERATIONS SHIPOWNERS PERSPECTIVE INTERTANKO TRIPARTITE 2016 TOKYO NOx emissions limits YEAR OPEN SEA NECA 1 Jan. 2010 Tier I - 1 Jan. 2011 Tier II - 1 Jan. 2016
More informationTrainMos II. Madrid-November LNG and New Fuels for the Maritime Industry. Is the Technology Ready?
MAN DIESEL & TURBO TrainMos II. Madrid-November-2.015 LNG and New Fuels for the Maritime Industry. Is the Technology Ready? Fernando Marcos +34 670 416 409 Fernando.Marcos@man.eu < 1 > Disclaimer All data
More informationInternationaler Congress für Schiffstechnik
Internationaler Congress für Schiffstechnik Technologien zur Reduzierung der Betriebskosten bei Einhaltung aktueller und zukünftiger Emissionen, Peter Balle, Hamburg, 10.09.2015 CourtesyMAN of Nordic Diesel
More informationTechnical Update December 2016, Athens, Greece TIER III is now!
Technical Update December 2016, Athens, Greece TIER III is now! Michael Jeppesen Promotion Manager, Customer Support Two Stroke Marine MAN Diesel & Turbo < 1 > Agenda 1 Tier III uncertainty, motivation,
More informationSCR under pressure - pre-turbocharger NOx abatement for marine 2-stroke diesel engines
SCR under pressure - pre-turbocharger NOx abatement for marine 2-stroke diesel engines CIMAC Congress paper no.: 111, Helsinki 2016, prepared by Sandelin/Peitz Emission control areas for sea going vessels
More informationGlobal Greenship, September 2009 Low Sulfur Fuel and Emissions Advances
Global Greenship, September 2009 Low Sulfur Fuel and Emissions Advances ECA and SECA Trends Top Container Ports : 1. Singapore 2. China, Shanghai 3. China, Hong Kong 4. China, Shenzhen 5. South Korea,
More informationCIMAC NMA Norway 27 January 2010
CIMAC NMA Norway 27 January 2010 Ole Skeltved Head of the Marine Installation Department Marine Low Speed, Engineering < 1 > System solutions for reduction of exhaust gas emissions Agenda : NOx limitations
More informationTier III programme Status and Outlook. Dominik Schneiter
Tier III programme Status and Outlook Dominik Schneiter Agenda 1 Regulations & Markets 2 Selective Catalytic Reduction (SCR) 3 Exhaust Gas Recirculation (EGR) 4 Conclusion 2 IMO/MARPOL Summary International
More informationEffShip. Love Hagström D.E.C. Marine AB
WP3 Exhaust Gas Cleaning Love Hagström D.E.C. Marine AB WP3 Layout NOx Primary reduction methods After treatment SCR SOx PM Wet Scrubber Dry Scrubber Particulate filter DPF Primary NOx reduction methods
More informationReducing Exhaust Emissions from Wärtsilä Marine Engines Moottoritekniikan seminaari Teknologiateollisuus ry 18 May 2010 Göran Hellén
Reducing Exhaust Emissions from Wärtsilä Marine Engines Moottoritekniikan seminaari Teknologiateollisuus ry 18 May 2010 Göran Hellén 1 Reducing exhaust emissions from Wärtsilä marine engines 18 May 2010
More informationINTEGRATION TRENDS OF PROPULSION SYSTEMS
6 th Sep. INTEGRATION TRENDS OF PROPULSION SYSTEMS Wang Feng Shanghai Marine Diesel Engine Research Institute Tel: 008621 31310459 Email: wangfeng@csic711.com CONTENT CIMAC CIRCLE Challenge of Propulsion
More informationChallenges for sustainable freight transport Maritime transport. Elena Seco Gª Valdecasas Director Spanish Shipowners Association - ANAVE
Challenges for sustainable freight transport Maritime transport Elena Seco Gª Valdecasas Director Spanish Shipowners Association - ANAVE Index 1. Shipping air emissions vs other transport modes. 2. How
More informationECA Compliance & PM. Thomas Kirk Director of Environmental Programs. Ottawa, Canada 9 September 2014
ECA Compliance & PM Thomas Kirk Director of Environmental Programs Ottawa, Canada 9 September 2014 MARINE BLACK CARBON EMISSIONS: IDENTIFYING RESEARCH GAPS Overview Air Emission Regulations Exhaust Gas
More informationCompetitive Edge through Environmental Performance
Competitive Edge through Environmental Performance Bo Cerup-Simonsen, Vice President Ph.D. Naval Architect, MBA Shipping & Logistics Blue Event no. 23 - Copenhagen, 3rd February 2011 (MMT) is a highly
More informationSOLVANG ASA. Emission reduction technologies---advantages and disadvantages Fleet director Tor Øyvind Ask
Emission reduction technologies---advantages and disadvantages Fleet director Tor Øyvind Ask A family controlled company traditional innovative a long term shipping partner 7 VLGC (+ 1) HQ Chartering Crewing
More informationEmission controls for NOx compliance Challenges & Applications. Greener Shipping Summit November 2017
Emission controls for NOx compliance Challenges & Applications Presentation @ Greener Shipping Summit November 2017 Dr. John Emmanuel Kokarakis Bureau Veritas 2 High pressure SCR (NH 2 ) 2 CO NO x N 2
More informationPacific Ports Air Quality Collaborative Conference Dec
Pacific Ports Air Quality Collaborative Conference Dec. 2006. How engine manufacturers are meeting the challenge by refining their technologies within Exhaust gas emission Kjeld Aabo Director Customer
More informationIMPLEMENTATION OF TIER II AND III
IMPLEMENTATION OF TIER II AND III TECHNICAL SEMINAR 2009 3.MAJ MOTORI I DIZALICE d.d. AND WÄRTSILÄ SWITZERLAND Ltd. GERMAN WEISSER 1 Wärtsilä September 22, 2009 IMPLEMENTATION OF TIER II AND III / GERMAN
More informationFront-running NOx abatement technology approaches 3500 hours of real-world operation at sea
Editorial May 2014 Front-running NOx abatement technology approaches 3500 hours of real-world operation at sea The Exhaust Gas Recirculation (EGR) solution being developed by MAN Diesel & Turbo with Alfa
More informationMAN Technical Symposium 2016 MAN Turbochargers Ready for tomorrow
MAN Technical Symposium 2016 MAN Turbochargers Ready for tomorrow Sephardim Koblenz < 1 > MAN Turbochargers Product Portfolio More than 250 Millions of operating hours TCA Almost 7500 deliveries TCR Almost
More informationDr Diamantis Andriotis, Technical Manager, Stealth Maritime Corporation SA
"Bunker Fuels in the Era of Clean Shipping" Dr Diamantis Andriotis, Technical Manager, Stealth Maritime Corporation SA Contribution of shipping to GHG emissions In accordance with the updated 2000 IMO
More informationEmission Project Guide MAN B&W Two-stroke Marine Engines
MAN B&W Two-stroke Marine Engines MAN B&W Two-stroke Marine Engines Preface for Marpol Annex VI Regulations The intention of the is to give sufficient information to decide and design solutions for emission
More informationExhaust Gas Cleaning Systems. (Scrubber / SCR) Dual Fuel Engines
Exhaust Gas Cleaning Systems (Scrubber / SCR) Dual Fuel Engines Agenda Legislation Sulfur Limits Scrubber Systems Legislation NOx SCR System Legislation Sulphur Limit Requirements 5,0% global S u lp h
More informationAsian Marine Engineering Conference 2015 MAN Diesel & Turbo SE Turbocharger. Malte Oltmanns Promotion Manager October 2015
Asian Marine Engineering Conference 2015 MAN Diesel & Turbo SE Turbocharger Malte Oltmanns Promotion Manager October 2015 MAN Diesel & Turbo Malte Oltmanns Asian Marine Engineering Conference 2015 / MDT
More informationMarine Engine. IMO Tier ll and Tier lll Programme 2018
Marine Engine IMO Tier ll and Tier lll Programme 2018 All data provided in this document is non-binding. This data serves informational purposes only and is especially not guaranteed in any way. Depending
More informationZero NOx Customised SCR
Zero NOx Customised SCR XEAMOS SOLUTION FOR IMO TIER III MARINE PROPULSION AND AUXILIARY ENGINES With all eyes focussed on the new Emission Control Area s that will come into force January 2021, Xeamos
More informationEmission Project Guide MAN B&W Two-stroke Marine Engines
MAN B&W Two-stroke Marine Engines MAN B&W Two-stroke Marine Engines Preface for Marpol Annex VI Regulations The intention of the is to give sufficient information to decide and design solutions for emission
More informationKAWASAKI Environment-friendly New engine technology
Norway-Japan Maritime Green Innovation Seminar 4th June, 2015 KAWASAKI Environment-friendly New engine technology 0 Yosuke NONAKA Diesel Engine Dep t. Machinery Div. Kawasaki Heavy Industries, Ltd. F4C-04-0035
More informationHYBRID & LNG SOLUTIONS FOR FERRIES
HYBRID & LNG SOLUTIONS FOR FERRIES Andrzej Buczkowski - Nicola Spiga MARKET TRENDS MARKET TRENDS SOURCE: EIA.gov (2017/08), monthly sampling OIL & GAS LOW AND STABLE PRICES, INCREASING LNG AVAILABILITY
More information11,000 teu container vessel
11,000 teu container vessel An ME-GI powered vessel fitted with fuel gas supply system and boil-off gas handling 2 MAN Energy Solutions 11,000 teu container vessel Future in the making 3 Contents Main
More informationWärtsilä NO X Reducer. Environmental Efficiency
Wärtsilä NO X Reducer Environmental Efficiency Environmental efficiency Stringent legislations concerning NO X. Retroactive legislations are introduced. Regulations in the shape of fees, taxes or incentive
More informationGas Fuelled Container Ship
SAMSUNG HEAVY INDUSTRIES Company name Gas Fuelled Container Ship ( Evaluation of Economic Analysis ) H.C. Jung October 16, 2015 1 Contents Background - Environmental Issue - IMO Future Regulation Gas Fuelled
More informationWÄRTSILÄ 2-STROKE LOW PRESSURE DUAL-FUEL ENGINES
WÄRTSILÄ 2-STROKE LOW PRESSURE DUAL-FUEL ENGINES Contents Introduction...2 Q&A... 3-7 2013 Wärtsilä Corporation All rights reserved No part of this publication may be reproduced or copied in any form or
More informationUSE OF MDO BY SHIPS PART OF A HOLISTIC APPROACH
USE OF MDO BY SHIPS PART OF A HOLISTIC APPROACH BUNKER SUMMIT GREECE 2007 dragos.rauta@intertanko.com WHAT DID INTERTANKO SUGGEST 1. Include one Fuel Oil specification in Annex VI 2. Simplify monitoring
More informationAmmonia measurement challenges in SCR units
Ammonia measurement challenges in SCR units CEM-2014, 16.5.2014 Olli Antson, Kati Lehtoranta VTT Technical Research Centre of Finland Engines and Emissions team Ammonia measurement challenges in SCR units
More informationField experience with considerably reduced NOx and Smoke Emissions
Field experience with considerably reduced NOx and Smoke Emissions Author: Horst W. Koehler, MAN B&W Diesel More than 95 % of the world s trade goes by sea and there are approximately 86,000 ocean going
More informationUpgrade on Environmentally-friendly Mitsui MAN-B&W Engine
Environmental Technology Seminar 11.04.2014 環境に優しい三井 MAN-B&W エンジン開発の最新状況 Upgrade on Environmentally-friendly Mitsui MAN-B&W Engine Mitsui Engineering & Shipbuilding Co., Ltd Diesel Design Department Ichiro
More informationMarine Engine. IMO Tier ll and Tier lll Programme 2nd edition 2016
Marine Engine IMO Tier ll and Tier lll Programme 2nd edition 2016 All data provided in this document is non-binding. This data serves informational purposes only and is especially not guaranteed in any
More informationShip Energy Efficiency and Air Pollution. Ernestos Tzannatos Department of Maritime Studies University of Piraeus
Ship Energy Efficiency and Air Pollution Ernestos Tzannatos Department of Maritime Studies University of Piraeus Today s agenda Introduction: Drivers for improved energy efficiency Ship Energy Efficiency:
More informationNews & Updates on MAN Dual Fuel Engines. Colin Peesel Sales Manager Engine & Marine Systems Inspectors Day Bremen,
News & Updates on MAN Dual Fuel Engines Colin Peesel Sales Manager Engine & Marine Systems Inspectors Day Bremen, 06.06.2018 MAN Diesel & Turbo [optional: Brand] Author Current topic 00.00.2012 < 1 > Agenda
More informationCase study -MARPOL emission standards ECA Compliance. Your Trusted Partner
Case study -MARPOL emission standards ECA Compliance Your Trusted Partner MARPOL emission standards Regulation 14 SOx NOx Regulation N/A for existing vessels Outside ECA 4.5% m/m prior to 1 January 2012
More informationPossible Change of Ship Design Including Engine Room about Emissions of NOx and SOx
Possible Change of Ship Design Including Engine Room about Emissions of NOx and SOx Masaki Ohtsu Mitsui Engineering & Shipbuilding Co., Ltd. February 28, 2007 Introduction of Mitsui -3 rd position in production
More informationEnvironmentally Superior VLGC with LPG as Fuel. "Achievements and Prospects for the Near Future" International LP Gas Seminar 2018.
International LP Gas Seminar 2018 Environmentally Superior VLGC with LPG as Fuel "Achievements and Prospects for the Near Future" 7th March 2018 Takashi Unseki Chief Engineer, Energy & Environment Ship
More informationThe ME-LGIP Engine fueled by LPG
The ME-LGIP Engine fueled by LPG Niels B. Clausen Senior Manager EELEE/Engine and System Application Marine Two-Stroke, Engineering < 1 > Towards Greener Future Portfolio of solutions Countermeasures for
More informationME-GI Engine Fuelled by LNG
ME-GI Engine Fuelled by LNG Andrzej Krupa Managing Director MAN Diesel & Turbo Poland Sp. z o.o. < 1 > Disclaimer All data provided on the following slides is for information purposes only, explicitly
More informationMAN Diesel & Turbo SE Exhaust gas emissions & solutions
MAN Diesel & Turbo SE Exhaust gas emissions & solutions Marcel Lodder Upgrade & Retrofit PrimeServ Augsburg MAN Diesel & Turbo SE Exhaust gas emissions & solutions MAN Diesel & Turbo 20.06.2011 < 1 > Agenda
More informationLaivanrakennuksen kilpailutekijät tulevaisuudessa- vanha toimiala, uudet kujeet Jari Anttila, STX Finland
Laivanrakennuksen kilpailutekijät tulevaisuudessa- vanha toimiala, uudet kujeet 15-16.1.2013 Jari Anttila, STX Finland Index New vessels in the horizon How to reduce emissions with design LNG as a fuel
More informationMHI-MME WHRS - STG. Environment friendly and economical solution MITSUBISHI HEAVY INDUSTRIES, LTD. All Rights Reserved.
MHI-MME WHRS - STG Environment friendly and economical solution 2017.01.24 2016 MITSUBISHI HEAVY INDUSTRIES MARINE MACHINERY & ENGINE CO., LTD. All Rights Reserved. 1 Contents Overview 1. Outline, WHRS-STG
More informationMARITIME GLOBAL SULPHUR CAP. Know the different choices and challenges for on-time compliance SAFER, SMARTER, GREENER
MARITIME GLOBAL SULPHUR CAP 2020 Know the different choices and challenges for on-time compliance SAFER, SMARTER, GREENER Global sulphur cap 2020 DNV GL 3 INTRODUCTION The global 0.5% sulphur cap will
More informationMAN Diesel & Turbo Presents New High-Pressure SCR for Two-Stroke Engines
MAN Diesel & Turbo Presents New High-Pressure SCR for Two-Stroke Engines Copenhagen, 26/04/2017 Compact, MAN-developed SCR-HP based on proven, four-stroke counterpart At an event in Tamano, Japan on April
More informationEmission project guide
Emission project guide MAN B&W Two-stroke marine engines MAN B&W Two-stroke Marine Engines Preface for Marpol Annex VI Regulations The intention of the is to give sufficient information to decide and
More informationThe environmental challenge ahead and The way forward. - Sulphur Cap 2020/ ECA zone - LNG as fuel
The environmental challenge ahead and The way forward - Sulphur Cap 2020/ ECA zone - LNG as fuel Yufeng Liu, Director Sales China Marine Money Shanghai, 10 th May 2017 Global sulphur Cap by 2020 A game
More informationOFFSHORE EMISSIONS & TEC NOLOGY. Micki J. Jain Product Definition Manager Offshore Global Petroleum Houston, Texas
OFFSHORE EMISSIONS & TEC NOLOGY Micki J. Jain Product Definition Manager Offshore Global Petroleum Houston, Texas OFFSHORE EMISSIONS & OFFSHORE EMISSIONS & TECHNOLOGY TECHNOLOGY OFFSHORE EMISSIONS & TECHNOLOGY
More informationMAN Diesel & Turbo s Solutions for LNG Fuelled Vessels. Christodoulopoulos Dionissis Managing Director Poseidon Med, 8/12/16 Piraeus
MAN Diesel & Turbo s Solutions for LNG Fuelled Vessels Christodoulopoulos Dionissis Managing Director Poseidon Med, 8/12/16 Piraeus < 1 > Agenda 1 Evironmental Regulations 2 Product Portfolio 3 References,
More informationThiel Christian CIMAC NMA Norge 2014 ABB Turbocharging
Thiel Christian 24.09.2014 CIMAC NMA Norge 2014 ABB Turbocharging Agenda ABB Turbocharging in Norway A200-L for two stroke engines Engine tunings high pressure tuning method Retrofit and upgrades 4 stroke
More informationBaltic Sea Parliamentary Conference. MARPOL Annex VI TECHNOLOGY & COMPLIANCE. Ramona Zettelmaier Lloyd s Register
Baltic Sea Parliamentary Conference MARPOL Annex VI TECHNOLOGY & COMPLIANCE Ramona Zettelmaier Lloyd s Register Overview International Regulations SOx reduction CO2 reduction NOx reduction Conclusion and
More informationLean and clean dredging for a better future
Lean and clean dredging for a better future Bernadete Goncalves-Castro, Leo van Ingen, Alex Roosendaal, Sergio Ooijens, Marcel Boor Presented by Leo W. van Ingen, August 26 th Preface Why this paper? IHC
More informationLNG. DME Ethane. Coal Slurry MSAR. Biofuel ULSFO (Ultra Low Sulphur Fuel Oil) Methanol Glycerine Hydrogen
LPG Gasoline HFO LNG Presentation to CIMAC Circle at Nor shipping 2017 Oslo, Norway, 31st May 2017 Marine market: Future Fuels 2020 and Beyond DME Ethane Distillates Biofuel ULSFO (Ultra Low Sulphur Fuel
More informationIntroduction to LNG Fueled Cargo Vessels and Bunkering Issues
Introduction to LNG Fueled Cargo Vessels and Bunkering Issues Raffaele Piciocchi ABS LNG Center - Greece Limassol 9 October 2012 CYPRUS SHIPPING FORUM Outline Background and Key Drivers Regulatory Framework
More informationLow Container Ship. Speed Facilitated by Versatile ME/ME-C Engines
Low Container Ship Speed Facilitated by Versatile ME/ME-C Engines Contents Introduction...5 ME/ME-C Engines...6 Part Load Optimisation, ME/ME-C Engines...7 Low Load Mode...8 Low Load Operation with MC/MC-C
More informationSimply clean GE Marine L250 and V250 Series Diesel Engines
GE Transportation EPA Tier 4 / IMO III Simply clean GE Marine L250 and V250 Series Diesel Engines No aftertreatment. No kidding. A World Leader in Manufacturing Diesel Engines For over 40 years, GE Marine
More informationPress Release. CIMAC Circle at SMM 2008 takes on emissions issue. October 2008
CIMAC Circle at SMM 2008 takes on emissions issue Press Release October 2008 The 2008 CIMAC Circle took on the hotly discussed issue of maritime emissions at its traditional Thursday afternoon event during
More informationMAN B&W Engines in ECA Areas
MAN B&W Engines in ECA Areas For internal use only LNG tanks Dual Fuel ME-GI 9000 Teu Gas Fuelled Container Ship DNV & MDT Project < 1 > This series of slides is based on information from IHS-Fairplay
More information"Exhaust Gas Scrubbers Abatement System as an Alternative under IMO MARPOL Annex VI''
"Exhaust Gas Scrubbers Abatement System as an Alternative under IMO MARPOL Annex VI'' What have we learned in the meantime? Prepared by: Ljubomir Markulin, Naval Architect SAACKE Marine Systems - Zagreb,
More informationPropulsion of 2,200-2,800 teu. Container Vessel
Propulsion of 2,2-2,8 teu Container Vessel Content Introduction...5 EEDI and Major Ship and Main Engine Parameters...6 Energy Efficiency Design Index (EEDI)...6 Major propeller and engine parameters...7
More informationMarine Bunkers 2020 & Beyond
Marine Bunkers 2020 & Beyond 8 th International Istanbul Bunker Conference Donald Gregory, C Eng., Director Exhaust Gas Cleaning Systems Association EGCSA Objectives To protect and promote the interests
More informationModule 5 Propulsion and Power Generation of LNG driven Vessels (23 th November to 27 th November University of Piraeus, Greece)
Module 5 Propulsion and Power Generation of LNG driven Vessels (23 th November to 27 th November 2015- University of Piraeus, Greece) Presentation Principles of Marine Main Engines running on LNG 23 th
More informationFOUR STROKE MARINE ENGINES
FOUR STROKE MARINE ENGINES Cost-cutting dual fuel engine solutions LNG Shipping Page 02 03 MAN Diesel & Turbo is the world s leading provider of large-bore diesel engines and turbomachinery. Our portfolio
More informationBlue ocean green future
Blue ocean green future EU Transport Attachés 2016 Tor Christian Sletner Director - Head of Environment, Research and Innovation Norwegian Shipowners Association Oslo, 30.June 2016 maritime innovations
More informationEMISSION ABATEMENT TECHNOLOGIES
EMISSION ABATEMENT TECHNOLOGIES CLIA LEADERSHIP FORUM FRED DANSKA Disclaimer TECHNOLOGY CAN BE THE ANSWER TO TECHNICAL ISSUES AND ECONOMICAL ISSUES BUT IT IS NOT THE ANSWER TO POLITICAL ISSUES Agenda Emission
More informationImproving engine Performance through innovation and design
Gino Rizzetto Engine Performance Manager, Testing & Performance WÄRTSILÄ Italia S.p.a. Improving engine Performance through innovation and design 1 Wärtsilä G. Rizzetto List of content WÄRTSILÄ in brief
More informationCapital Link's 4th Annual Invest in International Shipping Forum. Dr Hermann J. Klein, Member of Executive Board of GL
Capital Link's 4th Annual Invest in International Shipping Forum The Added Value of Classification to Financial Institutions & Owners in Today's Capital Markets Dr Hermann J. Klein, Member of Executive
More informationAlternative fuels and abatement technology for future shipping an overview
MARITIME Alternative fuels and abatement technology for future shipping an overview BMU-Conf. Blue Sky over the Sea, Berlin Torsten Mundt 17. November 2016 1 SAFER, SMARTER, GREENER Agenda DNV GL, the
More informationGASEOUS FUELS SAFETY ASPECTS
Ship Efficiency Conference by The German Society for Maritime Technology Hamburg, 29 September 2009 GASEOUS FUELS SAFETY ASPECTS Bruno DABOUIS 1. REGULATORY CONTEXT 2. USE OF GAS FUEL ENGINES ON SHIPS
More informationRESEARCH ON INFLUENCE OF SELECTED FAILURES ON THE EXHAUST GAS CONTENT OF SHIP DIESEL ENGINE WORKING ON HEAVY FUEL OIL
Journal of KONES Powertrain and Transport, Vol. 16, No. 4 2009 RESEARCH ON INFLUENCE OF SELECTED FAILURES ON THE EXHAUST GAS CONTENT OF SHIP DIESEL ENGINE WORKING ON HEAVY FUEL OIL Kazimierz Witkowski
More informationMAN B&W Marine Engines MAN Holeby GenSets. IMO Tier ll 2012
MAN B&W Marine Engines MAN Holeby GenSets IMO Tier ll 2012 All data provided in this document is non-binding. This data serves informational purposes only and is especially not guaranteed in any way. Depending
More information2013 Vessel General Permit -
2013 Vessel General Permit - Requirements for Vessels Visiting US Ports Elias Kariambas Manager, Marine Business Development Global Marine Organization Athens, Greece 9 June 2016 TRADING IN US WATERS SEMINAR
More informationSAFETY DESIGN FOR MARINE GAS ENGINE
6 th CIMAC CASCADES Seminar SAFETY DESIN FOR MARINE AS ENINE Sadao Kuwazuru YANMAR Co., LTD. Large Power Products Operation Division Emission restriction schedule CO 2 Kyoto Protocol (2008~2012) Post-Kyoto
More informationMAN B&W two stroke engines in China. MAN Diesel & Turbo The road to 100 % Local Production in China of Environmental Friendly Engines
MAN B&W two stroke engines in China The road to 100 % Local Production in China of Environmental Friendly Engines < 1 > New ME-C Mk. 10 Design Platform Top Controlled Exhaust Valve/ Fuel Booster Injection
More informationImproved Efficiency and Reduced CO 2
Improved Efficiency and Reduced CO 2 Content Introduction...5 Major Propeller and Main Engine Parameters...5 Propeller...6 Main engine...6 Ship with reduced design ship speed...6 Case Study 1...6 75,000
More informationAssessing Ship Emissions Reduction Strategies. Pacific Ports Clean Air Collaborative Conference March 2018 San Pedro, California
Assessing Ship Emissions Reduction Strategies Pacific Ports Clean Air Collaborative Conference March 2018 San Pedro, California Still Need to do More 2020 Ozone Estimated Reduction from ECA 2020 PM 2.5
More informationMAN Diesel & Turbo a member of the MAN Group
All data provided in this document is non-binding. This data serves informational purposes only and is especially not guaranteed in any way. Depending on the subsequent specific individual projects, the
More informationDual Exhaust After Treatment System with Electric Heater
Dual Exhaust After Treatment System with Electric Heater XEAMOS SUPPORTS YACHTS TO BE FUTURE PROOF Harmful NOx emissions in diesel exhaust gases are limited by the IMO Tier III legislation that is mandatory
More informationRefining Fitness Check Concawe Step 2 data Highlights
ENVIRONMENTAL SCIENCE FOR THE EUROPEAN REFINING INDUSTRY Refining Fitness Check Concawe Step 2 data Highlights Concawe Symposium Brussels 24 February 2015 C. Caiado, Research Associate Concawe data collection
More informationAbatement of emissions from ships A Baltic perspective
Abatement of emissions from ships A Baltic perspective Lars J. Pettersson Chemical Engineering and Technology Vaasa Pohjoisen Itämeren alueen kestävä kemia ja prosessiteknologia (POKE), Vaasa, 22-23 October,
More information5 TH CIMAC CASCADES, BUSAN MARCEL OTT
5 TH CIMAC CASCADES, BUSAN MARCEL OTT 23.10.2014 1 Wärtsilä 23 October 2014 Wärtsilä 2s Dual Fuel - 5th CIMAC CASCADES Development drivers - environment LOCAL LOCAL NO x Acid rains Tier II (2011) Tier
More informationProviding clean DPF technology for Iran. Soot-free Teheran
Providing clean DPF technology for Iran 1 Soot-free Teheran Jorge Soria Galvarro, M.Sc Senior Technical Adviser Vehicle Regulations, R&D SCANIA since 1891 2 3 Premium products 4 Modular system The world
More informationRESEARCH ON EXHAUST EMISSIONS REDUCTION TECHNOLOGIES FROM LARGE MARINE DIESEL ENGINES
Prepared by: Ramani Srinivasan Matson Navigation Company Inc. Background The exhaust emissions from large marine diesel engines on ocean going vessels contains among other pollutants a significant amount
More informationPreliminary Report of MEPC 71
External Affairs Department Vol. 2017-03 (10 July 2017) Preliminary Report of MEPC 71 The 71th session of the IMO Marine Environment Protection Committee (MEPC 71) was held at the headquarters of the IMO
More informationExtent of Delivery. W-X35-B/40-B Engines. Extent of Delivery / Order Specifications. Instructions. All quantities to be stated for one vessel
Extent of Delivery Instructions All quantities to be stated for one vessel or Included in extent of delivery The purpose of the Extent of Delivery (EOD) is to provide a guideline for the technical specification
More informationLNG: Legal and regulatory framework. Canepa Monica World Maritime University
LNG: Legal and regulatory framework Canepa Monica World Maritime University Source: Verisk Maplecroft AIR QUALITY INDEX 2017 Policies and legal instruments for clean energy to support LNG GLOBAL REGIONAL
More informationMAN B&W ME-GI. Dual fuel low speed engine
Dual fuel low speed engine The ME-GI Engine Supreme fuel flexibility The technology used in the design of the new two-stroke ME-GI engine combines MAN Diesel & Turbo s ME-C design with the GI-design from
More informationMAN Diesel & Turbo. Main Engine Room Data. Project name BrasNave 25 Project type Project number 3 Date 2010 Yard
MAN Diesel & Turbo Main Engine Room Data Main Engine Compliance 6S80MC6.1-TI IMO-NOx Tier I Project name BrasNave 25 Project type Project number 3 Date 2010 Yard Country Brasil Made by BrasNave Department
More informationCIRCULAR IMO FAQ on the sulphur limits in Emission Control Areas (ECAs)
12 JANUARY 2015 / C15001 CIRCULAR IMO FAQ on the sulphur limits in Emission Control Areas (ECAs) The International Maritime Organization (IMO) has published Frequently Asked Questions about sulphur limits
More information