Efficient Working of CI Engine with Utilization of Exhaust Gas

Size: px
Start display at page:

Download "Efficient Working of CI Engine with Utilization of Exhaust Gas"

Transcription

1 Advance Research and Innovations in Mechanical, Material Science, Industrial Engineering and Management - ICARMMIEM Efficient Working of CI Engine with Utilization of Exhaust Gas Hirday Ram and J.M.L. Gupta Abstract--- Fuel in any engine is burnt with air. Air is a mixture of gases and it contains approximately 78% nitrogen and 21% oxygen. Some of the oxygen is used to burn the fuel during the combustion process and the rest is supposed to just pass through unreacted. But when the peak temperatures are high enough for long periods of time, the nitrogen and oxygen combine to form a class of compounds called nitrogen oxides, collectively referred to as NOx. These compounds are one of the chief constituents of smog, which have an adverse effect on ecological systems. They also contribute to the formation of acid rain. NOx emissions can be reduced by lowering the cylinder temperatures. This can be done by two ways - 1) Enriching the air fuel mixture 2) reducing the amount of Oxygen in the cylinder that inhibits the combustion process. The first method reduce the efficiency of combustion and so the best way is to reduce the amount of Oxygen. This is done by re-circulating some exhaust gas and mixing it into the engine inlet air. This process is known as Exhaust Gas Recirculation. The goal of Exhaust Gas Recirculation (EGR) is to reduce the amount of NOx produced. The EGR valve recirculates gases into the intake stream. Exhaust gases have already combusted, so they do not burn again when they are re-circulated. These gases displace some of the normal intake charge. This chemically slows and cools the combustion process by several hundred degrees thus reducing NOx formation. A Keywords--- Diesel Engine, NO x, EGR and Pollution I. INTRODUCTION LL INTERNAL COMBUSTION(IC) engines generate power by creating explosions using air and fuel. These explosions occur inside the engine's cylinders and push the pistons down, which results in turns the crankshaft. Thus power produced is used to prepare the cylinders for the next explosion by forcing the exhaust gases out of the cylinder, drawing air in (or fuel-air mixture in non-diesel engines), and compressing the air or air-fuel mixture before the fuel is ignited. There are several differences between diesel engines and gasoline engines. Gasoline engines combine a fuel mist with air before the mixture is taken into the cylinder, while diesel engines inject fuel into the cylinder after the air is taken Hirday Ram, College of Engineering Roorkee, Mechanical Engineering Department, Uttarakhand, India. hridaysirola09@gmail.com Dr.J.M.L. Gupta, Associate Professor of Mechanical Department, College of Engineering Roorkee, Uttarakhand, India. nigraj0000@gmail.com in and compressed. Gasoline (Non-diesel) engines use a spark plug to ignite the fuel-air mixture, while diesel engines use the heat created by compressing the air in the cylinder to ignite the fuel, which is injected into the hot air after compression. In order to create the high temperatures needed to ignite diesel fuel, diesel engines have much higher compression ratios than gasoline engines. Because diesel fuel is made of larger molecules than gasoline, burning diesel fuel produces more energy than burning the same volume of gasoline. The higher compression ratio in a diesel engine and the higher energy content of diesel fuel allow diesel engines to be more efficient than gasoline engines. A. Formation of Nitrogen Oxides (NOx) Since the diesel engine is more efficient than the gasoline engine and it also runs at a higher temperature than the gasoline engine. This lead to a pollution problem, the creation of Nitrogen Oxides(NOx) and other harmful gases. As we see that the excess air is introduced for the complete burning of fuel. This air is approximately 21% Oxygen by volume and 79% Nitrogen. When air is compressed inside the cylinder during compression stroke of the diesel engine the temperature of the air increase to a certain level ( i.e. self ignition temperature of the fuel) to ignite diesel fuel. When diesel fuel ignites, the temperature of air increases to more than 1500F and air expands pushing the piston downward direction and rotating the crankshaft. As mentioned earlier that at higher temperature the engine is more efficient because more heat developed more power inside the cylinder. Some of the content of the oxygen is used to burn the fuel and rest is supposed to pass through the engine unreacted. The nitrogen does not participate in combustion process and is also pass though the engine unchanged. When the peak temperature high enough for long duration, the Nitrogen and Oxygen with air combine to form new compounds namely Nitrogen Oxides and Nitrogen dioxides(no2).these are collectively known as NOx. The principle reaction governing the formation of NO form moleculer Nitrogen of NO. N2 + O NO + N; N + O2 NO + O; N + OH NO + H Chemical equilibrium consideration indicates that for burnt gases at typical flame temperatures, NO2/NO ratios should be negligibly small. While experimental data show that this is true for spark ignition engines, in diesels, NO2 can be 10 to

2 Advance Research and Innovations in Mechanical, Material Science, Industrial Engineering and Management - ICARMMIEM % of total exhaust emissions of oxides of nitrogen. A plausible mechanism for the persistence of NO2 is as follows. NO formed in the flame zone can be rapidly converted to NO2 via reactions such as NO + HO2 NO2 + OH: Subsequently, conversion of this NO2 to NO occurs via NO2 + O NO + O2; unless the NO2 formed in the flame is quenched by mixing with cooler fluid. B. Problem of NOx Nitrogen oxides(nox) are one of the main pollutants emitted by vehicle engines. Once they enter into the atmosphere, they are spread over a large area by the wind. When it rains, water then combines with the nitrogen oxides to form acid rain. This has been known to damage buildings and have an adverse effect on ecological systems. Too much NOx in the atmosphere also contributes to the production of SMOG. When the sunrays hit these pollutants SMOG is formed. NOx also causes breathing illness in human lungs. C. How can be NOx Reduce Since the higher temperatures(2000k) of cylinder causes NOx formation and the NOx can be reduced by lowering the cylinders temperatures. Air cooler is already commonly used for this purpose. Reduced cylinder temperature can be achieved in two ways: Enriching the Air-Fuel ratio and Lowering the amount of Oxygen. The first technique lowers the efficiency of the engine and affects other parameter too. But second technique lowers the cylinder temperature, reducing NOx, but it also reduces fuel economy and performance, and creates excess soot, which results in more frequent oil changes. So, the best way is to limit the amount of Oxygen in the cylinder. Reduced oxygen results in lower cylinder temperatures. This is done by circulating some exhaust gas and mixing it into the engine inlet air. This process is known as Exhaust Gas Re-circulation(EGR). II. LITERATURE SURVEY NOx formation in diesel engine is a highly temperaturedependent phenomenon and takes place when the temperature in the combustion chamber exceeds 2000 K. So in order to reduce NOx emissions in the exhaust, it is necessary to keep peak combustion temperatures under control. One simple way of reducing the NOx emission of a diesel engine is by late injection of fuel into the combustion chamber. This technique is effective but increases fuel consumption by 10 16%, which necessitates the use of more effective NOx reduction techniques like exhaust gas recirculation (EGR). Re-circulating part of the exhaust gas helps in reducing NOx but appreciable particulate emissions are observed at high loads, therefore there is a trade-off between NOx and smoke emission. To get maximum benefit from this trade-off, a particulate trap may be used to reduce the amount of un-burnt particulates in EGR, which in turn reduce the particulate emission also. An experimental investigation was conducted to observe the effect of exhaust gas re-circulation on the exhaust gas temperatures and exhaust opacity. The experimental setup for the proposed experiments was developed on a one-cylinder, direct injection, water-cooled, compression ignition engine. No. of experiments was conducted for observing the effect of different quantities of EGR on exhaust gas temperatures and opacity. Over recent past years, stringent emission legislations have been imposed on NOx, smoke and particulate emissions emitted from automotive diesel engines worldwide. Diesel engines are typically characterized by low fuel consumption and very low CO emissions. However, the NOx emissions from diesel engines still remain high. Hence, in order to meet the environmental Legislations, it is highly desirable to reduce the amount of NOx level in the exhaust gas. Diesel engines are most commonly used to drive tractors, heavy lorries and trucks. Owing to their low fuel consumption, they have become increasingly attractive for smaller lorries and Passenger cars also. But higher NOx emissions from diesel engine remain a major problem in the pollution aspect. In order to reducing vehicular emissions, baseline technologies are being used which include direct injection, turbo-charging, air-to-air inter-cooling, combustion optimization with and without swirl support, multi-valve cylinder head, advanced high pressure injection system i.e. split injection or rate shaping, electronic management system, lube oil consumption control etc. However, technologies like exhaust gas recirculation (EGR), soot traps and exhaust gas after treatment are essential to cater to the challenges posed by increasingly stringent environmental emission legislations. A major obstruction in understanding the mechanism of formation and controlling its emission is that combustion is highly heterogeneous and transient in diesel engines. While NO and NO2 are react together at peak higher temperatures to form NOx, there are some distinctive differences between these two pollutants. NO is a colourless and odourless gas, while NO2 is a reddish brown gas with pungent odour. Both gases are considered toxic, but NO2 having a level of toxicity 5 times greater than that of NO. Although NO2 is largely formed from oxidation of NO, attention had been given on how NO can be controlled before and after combustion process. Nitrogen Oxides are formed during the post flame combustion process in a high temperature region. The most widely accepted technique/mechanism was suggested by Zeldovich (Heywood 1988). The principal source of NO formation is the oxidation of the nitrogen present in atmospheric air. The nitric oxide formation chain

3 Advance Research and Innovations in Mechanical, Material Science, Industrial Engineering and Management - ICARMMIEM reactions are initiated by atomic oxygen, which forms from the dissociation of oxygen molecules at the high temperatures reached during the combustion process. In diesels, NO2 can be 10 to 30% of total exhaust emissions of oxides of nitrogen. A plausible mechanism for the persistence of NO2 is described in previous section. The local atomic oxygen concentration depends on molecular oxygen concentration as well as local temperatures. Formation of NOx is almost absent at temperatures below 2000 K. Hence EGR technique that can keep the instantaneous local temperature in the combustion chamber below 2000 K, will be able to reduce NOx formation. Recirculation System Part of the exhaust gas is to be recirculated and put back to the combustion chamber along with the intake air. The quantity of this EGR has to be measured and controlled accurately hence a by-pass for the exhaust gas is provided along with the manually controlled EGR valve. The exhaust gas comes out of the engine during the exhaust stroke at high pressure. It is pulsating in nature. It is desirable to remove these pulses in order to make the volumetric flow rate measurements of the re-circulating gas possible. For this purpose, another smaller air box with a diaphragm is installed in the EGR route. An orifice meter is designed and installed to measure the volumetric flow rate of the EGR. A U-tube manometer is mounted across the orifice in order to measure the EGR flow rate. Suitable instrumentation is provided to acquire useful data from various locations. Thermocouples are provided at the intake manifold, exhaust manifold and various points along the EGR route. An AVL smoke-meter is used to measure the smoke opacity of the exhaust gas. The pressure difference across the orifice is used to calculate the EGR rate. A matrix of test conditions is used to investigate the effect of EGR on exhaust gas temperature and exhaust smoke opacity. III. OBJECTIVE Our main objective is to reduce the NOx level by recirculating the exhaust gas inside the engine cylinder with air so that the amount of excess Oxygen can be reduced and hence reduction in cylinder temperature can be achieved. IV. EXPERIMENTAL SETUP A one cylinder constant speed engine is used for the purpose. This is is basically a Direct Injection, water cooled, vertical four stroke engine. The setup mainly consists of air box. pressure gauges, regulating valve, thermocouples. orifice plate U-Tube manomter etc. Air box is designed for measuring the volumetric flow of intake air to the engine. It is mounted on Inlet pipe between the inlet manifold and air filter of the the engine as shown in figure 1. The air box dampens out the fluctuation of intake air. A diaphragm is provided at the side of air box for damping out the undulation effectively. The air box is fitted withan orifice for volumetric flow rate measurement of air. A U-Tube manometer is mounted across the orifice plate to measure the pressure difference in the air box and atmosphere. Pressure gauges are used to measuring the pressure at high pressure side and low pressure side. Orifice plate is also coupled which measures the rate of flow of mixture of air and exhaust gas. Thermocouples are used to measure the temperature at different sites as shown in figure1. Regulating valve is used to control the firinf of exaust gas to the air box so that a constant mass of exhaust gas is introduced to the air box. A valve is provided at inlet pipe to control the air intake. From the experiment we observed that at different EGR rate the NOx level are different that is when increasing the EGR, the NOx level is reduced to a great extent. The objective of developing this experimental setup is to investigate the effect of various EGR rates and other engine parameter on exhaust emission from the engine. A study conducted on two cylinder vertical air cooled four stroke engine shown that at the rated speed 1500 RPM the engine developed approximately 9 to 10 KW power output. The inlet valve opens 4.5 degree BTDC and closes at 45.5 degree ABDC. The exhaust valve opens at 35.5 BBDC and closes at 4.5 degree ATDC. The engine is coupled with 220 volts AC generator (Avinas Kumar Agarwal). We can see in fig.2 that when the % EGR is zero and that time the PPM count of NOx is about 120 at 30 % load condition. Similarly when % EGR is Zero at 60% load condition then the PPm count of NOx is about 140.But when the % EGR is increasing then the ppm count of NOx is appreciably reduced to a great extent at different load condition. So we can conclude from fig.2 that at different EGR rate and different load condition, the NOx level is reduced. From the fig.1, when the fresh air is taken by the engine during suction stroke, then it is compressed during the compression stroke. At the time of compression the temperature of air inside the cylinder increases to a maximum level (self ignition temperature of fuel).after that fuel is injected to the cylinder in the form of fine. Fuel is ignited due to self ignition temperature of the fuel is attained and combustion takes place. After combustion, combustion product (exhaust gas) comes out from exhaust manifold. About 20% of Exhaust gas is delivered to air box where it passes through a regulating valve and rest of exhaust gas will goes to atmosphere as shown in fig.1.

4 Advance Research and Innovations in Mechanical, Material Science, Industrial Engineering and Management - ICARMMIEM Air is also drawn to air box (Mixing chamber) so that mixing takes place and a temperature difference is observed which result in reduction of temperature of exhaust gas. Now we have a control temperature exhaust gas which is again pass through a orifice plate where a manometer measures its pressure and orifice plate measures the rate of flow of exhaust gas. Here thermocouples measures the temperature at different sites of combustion chamber. Now this air is circulated to the engine by inlet pipe where it reduce the level of excess Oxygen so that temperature inside the engine cylinder can be controlled and cycle is repeated again and again. This process is known as Exhaust gas re-circulation by which the temperature inside the engine cylinder can be control to a great extent and appreciable amount of NOx can be controlled. Fig. 1: Line Diagram of Exhaust Gas Re-circulating System Table 1: The Technical Specifications of the Engine S.No. Engine Description Specification 1. Type of Injection Direct Injection 2. Engine Manufacturer Kirlosker 3. No. of Cylinder One 4. Bore/ Stroke 80mm/110mm 5. Max. Power/Engine Speed 5 BHP/1500RPM 6. Compression Ratio 16.5:1 V. RESULT AND DISCUSSION At fixed power conditions, as the percentage EGR increases (0 21%), the temperature of the exhaust gas continuously decreases. Earlier it had been mentioned that the most important reason for the formation of NOx in the combustion chamber is extremely high temperature. Our experimental results indicate a decrease in the exhaust temperatures with increasing EGR, therefore it can be concluded that the combustion chamber temperatures also decrease and thus the formation of NOx is decreased. Fig.2: Effect of EGR on Knox (Avinas Agarwal) This reduction in exhaust gas temperature does not affect the thermal efficiency. It is clear that thermal efficiency remains unaffected by EGR. However, at high loads and at EGR rates above 15%, thermal efficiency tends to decrease slightly. This may be due to the fact that the amount of fresh oxygen available for combustion gets decreased due to mixing of exhaust gas with air. Opacity of the exhaust gas increases as the rate of EGR is increased. At low loads, the rate of increase in opacity is almost the same with increase in EGR but at higher loads and higher rates of EGR, opacity increases rapidly. Further it was also found that the brake specify fuel consumption (BSFC) is

5 Advance Research and Innovations in Mechanical, Material Science, Industrial Engineering and Management - ICARMMIEM fairly independent of EGR. As load increases, BSFC decreases rapidly. At 3kW the BSFC gets almost saturated at 0.22 kg/kw. VI. CONCLUSION AND FUTURE ENHANCEMENT An experimental set-up to measure the effects of exhaust gas recirculation on engine characteristics like exhaust gas temperature, thermal efficiency, brake specific fuel consumption and smoke opacity has been developed. Experiments had been carried out using the setup to prove the efficiency of EGR as a technique for NOx reduction. It had seen that the exhaust gas temperatures reduce drastically by employing EGR. This indirectly shows the potential for reduction of NOx emission. Here we can concluded from the fact that the most important reason for the formation of NOx in the combustion chamber is the high temperature of about 2000K at the site of combustion. Thermal efficiency and brake specific fuel consumption are not affected significantly by EGR. However particulate matter emission in the exhaust increases, as evident from smoke opacity observations. Diesel engines score higher than that of other engines in most aspects like fuel consumption and low CO emissions, but loses in NOx emissions. EGR has been proved to be one of the most efficient methods of NOx reduction in diesel engines. The increase in particulate matter emissions due to EGR can be taken care by employing particulate traps and adequate regeneration techniques. CartellieriW1998 Cooled EGR A technology for future efficient HD diesels. SAE , vol.11, pp.25-36, August 1951, Hirday Ram Pursuing in B. Tech 4 th year, Mechanical Engineering, College of Engineering Roorkee, Uttarakhand, India. DOB: 20/05/1991. My work is under the guidance of Dr.J.M.L. Gupta, Associate Professor of Mechanical Department. ACKNOWLEDGEMENT I express my gratitude and appreciation to my project guide Mr.J.M.L. GUPTA for his constant supervision, inspiration and encouragement right from the beginning of this paper entitled. EFFICIENT WORKING OF CI ENGINES WITH UTILISATION OF EXHAUST GAS I am also grateful and indebted to Mr. Thiru Ph.d Student at IIT Roorkee, Physics Department and Mr. Uday for both of them help and advice in the completion of this paper. I further take this opportunity to thanks all my classmates for taking active participation during the preparation of my work so as to make it lively and a great success. REFERENCES [1] Avinas Kumar Agarwal and Shrawan Kumar Singh Effect of EGR on the Exhaust gas Temperature and Exhaust Opacity in Compression Ignition Engines Bonafiring Sadhana publication Indian journal of Mechanical Engineering Department, Vol. 29, Part 3, pp ,June [2] Sher E Handbook of Air Pollution from IC Engine Pollolutant Formation and Control Bonafiring San Diego, CA: Academic Press, vol.02, pp.9-10, [3] Mehta S, Oey F, Sumburg C L, Levendis Y A An aerodynamically regenerated diesel particulate trap with a flow-through soot incinerator section. Bonafiring published by SAE under section , vol.09, pp19-25, May [4] Stearns R F, Johnson R R, Jackson R M, Larson C A Derivation of flow equations, Flow measurements with orifice meters. Bonafiring (Princeton, N J: D V N Com.) p-4, zelenka P, Aufinger H, ReczekW,

Case Study of Exhaust Gas Recirculation on Engine Performance

Case Study of Exhaust Gas Recirculation on Engine Performance IOSR Journal of Computer Engineering (IOSR-JCE) e-issn: 2278-0661,p-ISSN: 2278-8727 PP 13-17 www.iosrjournals.org Case Study of Exhaust Gas Recirculation on Engine Performance Jagadish M. Sirase 1, Roshan

More information

Prediction on Increasing the Efficiency of Single Cylinder DI Diesel Engine Using EGR System

Prediction on Increasing the Efficiency of Single Cylinder DI Diesel Engine Using EGR System International OPEN ACCESS Journal Of Modern Engineering Research (IJMER) Prediction on Increasing the Efficiency of Single Cylinder DI Diesel Engine Using EGR System P.Muni Raja Chandra 1, Ayaz Ahmed 2,

More information

PERFORMANCE AND EMISSION ANALYSIS OF DIESEL ENGINE BY INJECTING DIETHYL ETHER WITH AND WITHOUT EGR USING DPF

PERFORMANCE AND EMISSION ANALYSIS OF DIESEL ENGINE BY INJECTING DIETHYL ETHER WITH AND WITHOUT EGR USING DPF PERFORMANCE AND EMISSION ANALYSIS OF DIESEL ENGINE BY INJECTING DIETHYL ETHER WITH AND WITHOUT EGR USING DPF PROJECT REFERENCE NO. : 37S1036 COLLEGE BRANCH GUIDES : KS INSTITUTE OF TECHNOLOGY, BANGALORE

More information

Effect of EGR on NO x & Performance Parameters in single cylinder four stroke CI engine.

Effect of EGR on NO x & Performance Parameters in single cylinder four stroke CI engine. International Journal of Engineering Research and Development e-issn: 2278-067X, p-issn: 2278-800X, www.ijerd.com Volume 10, Issue 6 (June 2014), PP.59-67 Effect of EGR on NO x & Performance Parameters

More information

THE STUDY OF EGR EFFECT ON DIESEL ENGINE PERFORMANCE AND EMISSION - A REVIEW Srinath Pai 1, Amriya Tasneem H.R. 2, Shivaraju N 3 & Dr.

THE STUDY OF EGR EFFECT ON DIESEL ENGINE PERFORMANCE AND EMISSION - A REVIEW Srinath Pai 1, Amriya Tasneem H.R. 2, Shivaraju N 3 & Dr. THE STUDY OF EGR EFFECT ON DIESEL ENGINE PERFORMANCE AND EMISSION - A REVIEW Srinath Pai 1, Amriya Tasneem H.R. 2, Shivaraju N 3 & Dr. Sreeprakash B 4 1, 2, 3 Department of Mechanical Engineering, Srinivas

More information

Improving The Emission Characteristics of Diesel Engine by Using EGR at Different Cooling Rates

Improving The Emission Characteristics of Diesel Engine by Using EGR at Different Cooling Rates Improving The Emission Characteristics of Diesel Engine by Using EGR at Different Cooling Rates G SujeevaRaju 1, G Naresh Babu 2 1M.Tech Student, Dept. Of Mechanical Engineering, Siddhartha Institute of

More information

EXPERIMENTAL ANALYSIS OF A DIESEL ENGINE WITH COOLED EGR USING BIODIESEL

EXPERIMENTAL ANALYSIS OF A DIESEL ENGINE WITH COOLED EGR USING BIODIESEL International Journal of Mechanical and Production Engineering Research and Development (IJMPERD ) ISSN 2249-6890 Vol.2, Issue 2 June 2012 60-67 TJPRC Pvt. Ltd., EXPERIMENTAL ANALYSIS OF A DIESEL ENGINE

More information

EXPERIMENTAL INVESTIGATION OF THE EFFECT OF HYDROGEN BLENDING ON THE CONCENTRATION OF POLLUTANTS EMITTED FROM A FOUR STROKE DIESEL ENGINE

EXPERIMENTAL INVESTIGATION OF THE EFFECT OF HYDROGEN BLENDING ON THE CONCENTRATION OF POLLUTANTS EMITTED FROM A FOUR STROKE DIESEL ENGINE EXPERIMENTAL INVESTIGATION OF THE EFFECT OF HYDROGEN BLENDING ON THE CONCENTRATION OF POLLUTANTS EMITTED FROM A FOUR STROKE DIESEL ENGINE Haroun A. K. Shahad hakshahad@yahoo.com Department of mechanical

More information

Impact of Cold and Hot Exhaust Gas Recirculation on Diesel Engine

Impact of Cold and Hot Exhaust Gas Recirculation on Diesel Engine RESEARCH ARTICLE OPEN ACCESS Impact of Cold and Hot Exhaust Gas Recirculation on Diesel Engine P. Saichaitanya 1, K. Simhadri 2, G.Vamsidurgamohan 3 1, 2, 3 G M R Institute of Engineering and Technology,

More information

ANALYSIS OF EXHAUST GAS RECIRCULATION (EGR) SYSTEM

ANALYSIS OF EXHAUST GAS RECIRCULATION (EGR) SYSTEM ANALYSIS OF EXHAUST GAS RECIRCULATION (EGR) SYSTEM,, ABSTRACT Exhaust gas recirculation (EGR) is a way to control in-cylinder NOx and carbon production and is used on most modern high-speed direct injection

More information

Research Article. Effect of exhaust gas recirculation on NOx emission of a annona methyl ester operated diesel engine

Research Article. Effect of exhaust gas recirculation on NOx emission of a annona methyl ester operated diesel engine Available online www.jocpr.com Journal of Chemical and Pharmaceutical Research, 2015, 7(5):723-728 Research Article ISSN : 0975-7384 CODEN(USA) : JCPRC5 Effect of exhaust gas recirculation on NOx emission

More information

REDUCTION OF EMISSIONS BY ENHANCING AIR SWIRL IN A DIESEL ENGINE WITH GROOVED CYLINDER HEAD

REDUCTION OF EMISSIONS BY ENHANCING AIR SWIRL IN A DIESEL ENGINE WITH GROOVED CYLINDER HEAD REDUCTION OF EMISSIONS BY ENHANCING AIR SWIRL IN A DIESEL ENGINE WITH GROOVED CYLINDER HEAD Dr.S.L.V. Prasad 1, Prof.V.Pandurangadu 2, Dr.P.Manoj Kumar 3, Dr G. Naga Malleshwara Rao 4 Dept.of Mechanical

More information

CHAPTER 1 INTRODUCTION

CHAPTER 1 INTRODUCTION 1 CHAPTER 1 INTRODUCTION 1.1 GENERAL Diesel engines are the primary power source of vehicles used in heavy duty applications. The heavy duty engine includes buses, large trucks, and off-highway construction

More information

Module7:Advanced Combustion Systems and Alternative Powerplants Lecture 32:Stratified Charge Engines

Module7:Advanced Combustion Systems and Alternative Powerplants Lecture 32:Stratified Charge Engines ADVANCED COMBUSTION SYSTEMS AND ALTERNATIVE POWERPLANTS The Lecture Contains: DIRECT INJECTION STRATIFIED CHARGE (DISC) ENGINES Historical Overview Potential Advantages of DISC Engines DISC Engine Combustion

More information

Emissions of Diesel Engine Using Exhaust Gas Recirculation by Molecular Diffusion

Emissions of Diesel Engine Using Exhaust Gas Recirculation by Molecular Diffusion Emissions of Diesel Engine Using Exhaust Gas Recirculation by Molecular Diffusion ADEL A. ABDEL-RAHMAN Mechanical Engineering Department Alexandria University, Alexandria 21544, Egypt E-mail: adel.abdel-rahman@alexu.edu.eg

More information

EFFECT OF INJECTION ORIENTATION ON EXHAUST EMISSIONS IN A DI DIESEL ENGINE: THROUGH CFD SIMULATION

EFFECT OF INJECTION ORIENTATION ON EXHAUST EMISSIONS IN A DI DIESEL ENGINE: THROUGH CFD SIMULATION EFFECT OF INJECTION ORIENTATION ON EXHAUST EMISSIONS IN A DI DIESEL ENGINE: THROUGH CFD SIMULATION *P. Manoj Kumar 1, V. Pandurangadu 2, V.V. Pratibha Bharathi 3 and V.V. Naga Deepthi 4 1 Department of

More information

Study of Performance and Emission Characteristics of a Two Stroke Si Engine Operated with Gasoline Manifold Injectionand Carburetion

Study of Performance and Emission Characteristics of a Two Stroke Si Engine Operated with Gasoline Manifold Injectionand Carburetion Indian Journal of Science and Technology, Vol 9(37), DOI: 10.17485/ijst/2016/v9i37/101984, October 2016 ISSN (Print) : 0974-6846 ISSN (Online) : 0974-5645 Study of Performance and Emission Characteristics

More information

Module 3: Influence of Engine Design and Operating Parameters on Emissions Lecture 14:Effect of SI Engine Design and Operating Variables on Emissions

Module 3: Influence of Engine Design and Operating Parameters on Emissions Lecture 14:Effect of SI Engine Design and Operating Variables on Emissions Module 3: Influence of Engine Design and Operating Parameters on Emissions Effect of SI Engine Design and Operating Variables on Emissions The Lecture Contains: SI Engine Variables and Emissions Compression

More information

EFFECT OF EXHAUST GAS RECIRCULATION ON PERFORMANCE AND EMISSION CHARACTERISTICS OF DIESEL ENGINE FUELED WITH WASTE COOKING OIL METHYL ESTER

EFFECT OF EXHAUST GAS RECIRCULATION ON PERFORMANCE AND EMISSION CHARACTERISTICS OF DIESEL ENGINE FUELED WITH WASTE COOKING OIL METHYL ESTER EFFECT OF EXHAUST GAS RECIRCULATION ON PERFORMANCE AND EMISSION CHARACTERISTICS OF DIESEL ENGINE FUELED WITH WASTE COOKING OIL METHYL ESTER K Srinivasa Rao 1, K Bhaskara Mutyalu 2 and A Ramakrishna 3 1,2

More information

EXPERIMENTAL INVESTIGATION ON 4 STROKE SINGLE CYLINDER DIESEL ENGINE BLENDED WITH TYRE OIL

EXPERIMENTAL INVESTIGATION ON 4 STROKE SINGLE CYLINDER DIESEL ENGINE BLENDED WITH TYRE OIL EXPERIMENTAL INVESTIGATION ON 4 STROKE SINGLE CYLINDER DIESEL ENGINE BLENDED WITH TYRE OIL D.Sravani 1, R.Jyothu Naik 2, P. Srinivasa Rao 3 1 M.Tech Student, Mechanical Engineering, Narasaraopet Engineering

More information

A REVIEW OF SCAVENGING PROCESS OF TWO STROKE ENGINE

A REVIEW OF SCAVENGING PROCESS OF TWO STROKE ENGINE A REVIEW OF SCAVENGING PROCESS OF TWO STROKE ENGINE Prakash Kumar Sen 1, Lalit Kumar 2, Shailendra Kumar Bohidar 3 1 Student of M.Tech. Manufacturing Management, BITS Pilani (India) 2 Student of Mechanical

More information

EFFECT OF EGR AND CYCLONIC SEPARATOR ON EMISSIONS IN DI DIESEL ENGINES

EFFECT OF EGR AND CYCLONIC SEPARATOR ON EMISSIONS IN DI DIESEL ENGINES Proceedings of the International Conference on Mechanical Engineering 27 (ICME27) 29-31 December 27, Dhaka, Bangladesh ICME7-TH-9 EFFECT OF EGR AND CYCLONIC SEPARATOR ON EMISSIONS IN DI DIESEL ENGINES

More information

Biodiesel as an Alternate Fuel in a Diesel Engine with the Cooled Exhaust Gas Recirculation A Measure to Reduce Harmful Emissions

Biodiesel as an Alternate Fuel in a Diesel Engine with the Cooled Exhaust Gas Recirculation A Measure to Reduce Harmful Emissions Biodiesel as an Alternate Fuel in a Diesel Engine with the Cooled Exhaust Gas Recirculation A Measure to Reduce Harmful Emissions S. Adinarayana 1, YMC Sekhar 2, BVA Rao 3 & M. Anil Prakash 4 1,2&4 Mechanical

More information

An Experimental Analysis of IC Engine by using Hydrogen Blend

An Experimental Analysis of IC Engine by using Hydrogen Blend IJSTE - International Journal of Science Technology & Engineering Volume 2 Issue 11 May 2016 ISSN (online): 2349-784X An Experimental Analysis of IC Engine by using Hydrogen Blend Patel Chetan N. M.E Student

More information

MODERN DIESEL ENGINES NOX PARTICLES EMISSION

MODERN DIESEL ENGINES NOX PARTICLES EMISSION Journal of KONES Powertrain and Transport, Vol. 20, No. 3 2013 MODERN DIESEL ENGINES NOX PARTICLES EMISSION Konrad Krakowian, Andrzej Ka mierczak Technical University of Wroc aw Department of Motor Vehicles

More information

Effect of Tangential Grooves on Piston Crown Of D.I. Diesel Engine with Retarded Injection Timing

Effect of Tangential Grooves on Piston Crown Of D.I. Diesel Engine with Retarded Injection Timing International Journal of Engineering Research and Development e-issn: 2278-067X, p-issn : 2278-800X, www.ijerd.com Volume 5, Issue 10 (January 2013), PP. 01-06 Effect of Tangential Grooves on Piston Crown

More information

Module 6:Emission Control for CI Engines Lecture 31:Diesel Particulate Filters (contd.) The Lecture Contains: Passive/Catalytic Regeneration

Module 6:Emission Control for CI Engines Lecture 31:Diesel Particulate Filters (contd.) The Lecture Contains: Passive/Catalytic Regeneration Module 6:Emission Control for CI Engines The Lecture Contains: Passive/Catalytic Regeneration Regeneration by Fuel Additives Continuously Regenerating Trap (CRT) Syatem Partial Diesel Particulate Filters

More information

ME 74 AUTOMOTIVE POLLUTION AND CONTROL Automobile Engineering-vii sem Question Bank( )

ME 74 AUTOMOTIVE POLLUTION AND CONTROL Automobile Engineering-vii sem Question Bank( ) ME 74 AUTOMOTIVE POLLUTION AND CONTROL Automobile Engineering-vii sem Question Bank(2013-2014) UNIT I INTRODUCTION 1. How the transient operation of S.I engine will cause CO formation? (may /June 2007)

More information

PM Exhaust Characteristics from Diesel Engine with Cooled EGR

PM Exhaust Characteristics from Diesel Engine with Cooled EGR Proceedings of International Symposium on EcoTopia Science 07, ISETS07 (07) PM Exhaust Characteristics from Diesel Engine with Yutaka Tsuruta 1, Tomohiko Furuhata 1 and Masataka Arai 1 1. Department of

More information

The influence of thermal regime on gasoline direct injection engine performance and emissions

The influence of thermal regime on gasoline direct injection engine performance and emissions IOP Conference Series: Materials Science and Engineering PAPER OPEN ACCESS The influence of thermal regime on gasoline direct injection engine performance and emissions To cite this article: C I Leahu

More information

A REVIEW ON EXHAUST GAS RECIRCULATION (EGR) SYSTEM IN IC ENGINES

A REVIEW ON EXHAUST GAS RECIRCULATION (EGR) SYSTEM IN IC ENGINES A REVIEW ON EXHAUST GAS RECIRCULATION (EGR) SYSTEM IN IC ENGINES Jitender Singh 1, Vikas Bansal 2 1,2 Department of Mechanical Engineering, University College of Engineering, Rajasthan Technical University,

More information

Experimental Investigations on a Four Stoke Diesel Engine Operated by Jatropha Bio Diesel and its Blends with Diesel

Experimental Investigations on a Four Stoke Diesel Engine Operated by Jatropha Bio Diesel and its Blends with Diesel International Journal of Manufacturing and Mechanical Engineering Volume 1, Number 1 (2015), pp. 25-31 International Research Publication House http://www.irphouse.com Experimental Investigations on a

More information

Comparative performance and emissions study of a lean mixed DTS-i spark ignition engine operated on single spark and dual spark

Comparative performance and emissions study of a lean mixed DTS-i spark ignition engine operated on single spark and dual spark 26 IJEDR Volume 4, Issue 2 ISSN: 232-9939 Comparative performance and emissions study of a lean mixed DTS-i spark ignition engine operated on single spark and dual spark Hardik Bambhania, 2 Vijay Pithiya,

More information

A Study of EGR Stratification in an Engine Cylinder

A Study of EGR Stratification in an Engine Cylinder A Study of EGR Stratification in an Engine Cylinder Bassem Ramadan Kettering University ABSTRACT One strategy to decrease the amount of oxides of nitrogen formed and emitted from certain combustion devices,

More information

Study of the Effect of CR on the Performance and Emissions of Diesel Engine Using Butanol-diesel Blends

Study of the Effect of CR on the Performance and Emissions of Diesel Engine Using Butanol-diesel Blends International Journal of Current Engineering and Technology E-ISSN 77 416, P-ISSN 47 5161 16 INPRESSCO, All Rights Reserved Available at http://inpressco.com/category/ijcet Research Article Study of the

More information

CHAPTER 8 EFFECTS OF COMBUSTION CHAMBER GEOMETRIES

CHAPTER 8 EFFECTS OF COMBUSTION CHAMBER GEOMETRIES 112 CHAPTER 8 EFFECTS OF COMBUSTION CHAMBER GEOMETRIES 8.1 INTRODUCTION Energy conservation and emissions have become of increasing concern over the past few decades. More stringent emission laws along

More information

EXPERIMENTAL INVESTIGATION OF THERMAL PERFORMANCE OF PETROL ENGINE USING FUEL CATALYST

EXPERIMENTAL INVESTIGATION OF THERMAL PERFORMANCE OF PETROL ENGINE USING FUEL CATALYST EXPERIMENTAL INVESTIGATION OF THERMAL PERFORMANCE OF PETROL ENGINE USING FUEL CATALYST Sagar.A.Patil 1, Priyanka.V.Kadam 2, Mangesh.S.Yeolekar 3, Sandip.B.Sonawane 4 1 Student (Final Year), Department

More information

EFFECT OF EXHAUST GAS RECIRCULATION (EGR) IN INTERNAL COMBUSTION ENGINE

EFFECT OF EXHAUST GAS RECIRCULATION (EGR) IN INTERNAL COMBUSTION ENGINE EFFECT OF EXHAUST GAS RECIRCULATION (EGR) IN INTERNAL COMBUSTION ENGINE 1 Ajinkya B. Amritkar, 2 Nilesh Badge 1ajinkyaamritkar333@gmail.com, 2 badgenilesh6@gmail.com 1,2B.E.Student, Department of Mechanical

More information

INFLUENCE OF INTAKE AIR TEMPERATURE AND EXHAUST GAS RECIRCULATION ON HCCI COMBUSTION PROCESS USING BIOETHANOL

INFLUENCE OF INTAKE AIR TEMPERATURE AND EXHAUST GAS RECIRCULATION ON HCCI COMBUSTION PROCESS USING BIOETHANOL ENGINEERING FOR RURAL DEVELOPMENT Jelgava, 2.-27..216. INFLUENCE OF INTAKE AIR TEMPERATURE AND EXHAUST GAS RECIRCULATION ON HCCI COMBUSTION PROCESS USING BIOETHANOL Kastytis Laurinaitis, Stasys Slavinskas

More information

International Research Journal of Engineering and Technology (IRJET) e-issn: Volume: 04 Issue: 11 Nov p-issn:

International Research Journal of Engineering and Technology (IRJET) e-issn: Volume: 04 Issue: 11 Nov p-issn: International Research Journal of Engineering and Technology (IRJET) e-issn: 2395-56 Performance and emission characteristics of a constant speed diesel engine fueled with Rubber seed oil and Jatropha

More information

Numerically Analysing the Effect of EGR on Emissions of DI Diesel Engine Having Toroidal Combustion Chamber Geometry

Numerically Analysing the Effect of EGR on Emissions of DI Diesel Engine Having Toroidal Combustion Chamber Geometry Numerically Analysing the Effect of EGR on Emissions of DI Diesel Engine Having Toroidal Combustion Chamber Geometry Jibin Alex 1, Biju Cherian Abraham 2 1 Student, Dept. of Mechanical Engineering, M A

More information

EXPERIMENTAL INVESTIGATIONS ON 4- STROKE SINGLE CYLINDER DIESEL ENGINE (C.I) WITH CHANGING GEOMETRY OF PISTON

EXPERIMENTAL INVESTIGATIONS ON 4- STROKE SINGLE CYLINDER DIESEL ENGINE (C.I) WITH CHANGING GEOMETRY OF PISTON International Journal of Mechanical Engineering and Technology (IJMET) Volume 9, Issue 13, December 218, pp. 693 7, Article ID: IJMET_9_13_72 Available online at http://www.iaeme.com/ijmet/issues.asp?jtype=ijmet&vtype=9&itype=13

More information

EVERY ALTERNATIVE ISLG Combustion Air and Emission Devices. Why Cooled EGR? 4/23/2013. Why Exhaust Gas Recirculation.

EVERY ALTERNATIVE ISLG Combustion Air and Emission Devices. Why Cooled EGR? 4/23/2013. Why Exhaust Gas Recirculation. EVERY ALTERNATIVE. 2007 ISLG Combustion Air and Emission Devices Why Exhaust Gas Recirculation Basic Science NOx (Oxides of Nitrogen) pollution occurs due to high cylinder temperatures during the combustion

More information

Experimental Investigation on Engine Performance and Emissions of A Four Cylinder Diesel Engine using Hot and Cooled Exhaust Gas Recirculation.

Experimental Investigation on Engine Performance and Emissions of A Four Cylinder Diesel Engine using Hot and Cooled Exhaust Gas Recirculation. Experimental Investigation on Engine Performance and Emissions of A Four Cylinder Diesel Engine using Hot and Cooled Exhaust Gas Recirculation. Bhosale Amrut P. 1 1 Research Scholar, Department of Automobile

More information

Simulation of Performance Parameters of Spark Ignition Engine for Various Ignition Timings

Simulation of Performance Parameters of Spark Ignition Engine for Various Ignition Timings Research Article International Journal of Current Engineering and Technology ISSN 2277-4106 2013 INPRESSCO. All Rights Reserved. Available at http://inpressco.com/category/ijcet Simulation of Performance

More information

The influence of non-cooled exhaust gas recirculation on the indicator diagrams and heat release parameters in diesel engine cylinder

The influence of non-cooled exhaust gas recirculation on the indicator diagrams and heat release parameters in diesel engine cylinder Article citation info: CISEK, J. The influence of non-cooled exhaust gas recirculation on the indicator diagrams and heat release parameters in diesel engine cylinder. Combustion Engines. 2017, 171(4),

More information

Chapter 4 ANALYTICAL WORK: COMBUSTION MODELING

Chapter 4 ANALYTICAL WORK: COMBUSTION MODELING a 4.3.4 Effect of various parameters on combustion in IC engines: Compression ratio: A higher compression ratio increases the pressure and temperature of the working mixture which reduce the initial preparation

More information

Experimental investigation on influence of EGR on combustion performance in SI Engine

Experimental investigation on influence of EGR on combustion performance in SI Engine - 1821 - Experimental investigation on influence of EGR on combustion performance in SI Engine Abstract M. Božić 1*, A. Vučetić 1, D. Kozarac 1, Z. Lulić 1 1 University of Zagreb, Faculty of Mechanical

More information

Internal Combustion Engines

Internal Combustion Engines Emissions & Air Pollution Lecture 3 1 Outline In this lecture we will discuss emission control strategies: Fuel modifications Engine technology Exhaust gas aftertreatment We will become particularly familiar

More information

GASOLINE DIRECT INJECTION IN SI ENGINES B. PAVAN VISWANADH P. ASHOK KUMAR. Mobile No : Mobile No:

GASOLINE DIRECT INJECTION IN SI ENGINES B. PAVAN VISWANADH P. ASHOK KUMAR. Mobile No : Mobile No: GASOLINE DIRECT INJECTION IN SI ENGINES SUBMIT TED BY B. PAVAN VISWANADH P. ASHOK KUMAR Y06ME011, III/IV B. Tech Y06ME003, III/IV B. Tech Pavan.visu@gmail.com ashok.me003@gmail.com Mobile No :9291323516

More information

CONTROLLING COMBUSTION IN HCCI DIESEL ENGINES

CONTROLLING COMBUSTION IN HCCI DIESEL ENGINES CONTROLLING COMBUSTION IN HCCI DIESEL ENGINES Nicolae Ispas *, Mircea Năstăsoiu, Mihai Dogariu Transilvania University of Brasov KEYWORDS HCCI, Diesel Engine, controlling, air-fuel mixing combustion ABSTRACT

More information

1, 2,3,4,5. HIT Nidasoshi 1, 2,3,4,5

1, 2,3,4,5. HIT Nidasoshi 1, 2,3,4,5 www.ijecs.in International Journal Of Engineering And Computer Science ISSN:2319-7242 Volume 4 Issue 6 June 215, Page No. 12492-12498 Study of Characteristics Performance of VCR Engine for Different Fuels

More information

Simultaneous reduction of NOx and smoke emission of CI engine fuelled with biodiesel

Simultaneous reduction of NOx and smoke emission of CI engine fuelled with biodiesel International Journal of Renewable Energy, Vol. 8, No. 2, July - December 2013 Simultaneous reduction of NOx and smoke emission of CI engine fuelled with biodiesel ABSTRACT S.Saravanan Professor, Department

More information

Experimental Investigation on Diesel Engines by Swirl Induction with Different Manifolds

Experimental Investigation on Diesel Engines by Swirl Induction with Different Manifolds Research Article International Journal of Current Engineering and Technology E-ISSN 2277 416, P-ISSN 2347-5161 214 INPRESSCO, All Rights Reserved Available at http://inpressco.com/category/ijcet Experimental

More information

Experimental Investigation of Oxygen Enriched IC Engine

Experimental Investigation of Oxygen Enriched IC Engine Experimental Investigation of Oxygen Enriched IC Engine 1 B.SARAVANAN, 2 N.SAKTHIVEL, 3 T.VENKATESH, 4 K.VIGNESHWARAN, 5 D.VIMAL 1 Assistant Professor, Dept. of Mechanical Engineering, Jay Shriram Group

More information

ENGINE TECHNOLOGY. Bobcat Engine_B _ _EN_reworked.indd 1

ENGINE TECHNOLOGY. Bobcat Engine_B _ _EN_reworked.indd 1 ENGINE TECHNOLOGY Bobcat Engine_B4459500_01-2015_EN_reworked.indd 1 1/30/2015 10:07:51 AM A COMPANY THAT S GROWING WITH SOCIETY Bobcat prides itself on innovations that shape the future. For decades, we

More information

Effect of Preheating Air in Petrol Engine by Using Exhaust Gas Heat Energy

Effect of Preheating Air in Petrol Engine by Using Exhaust Gas Heat Energy ISSN 2395-1621 Effect of Preheating Air in Petrol Engine by Using Exhaust Gas Heat Energy #1 Ghorpade Sangram D., #2 Lokhande Akshay R., #3 Lagad Pradeep B. #4 Jangam Raviraj S. 1 sangramghorpade1996@gmail.com

More information

Analysis of Emission characteristics on Compression Ignition Engine using Dual Fuel Mode for Variable Speed

Analysis of Emission characteristics on Compression Ignition Engine using Dual Fuel Mode for Variable Speed International Journal of Engineering Research and Development e-issn: 2278-067X, p-issn: 2278-800X, www.ijerd.com Volume 4, Issue 3 (October 2012), PP. 23-27 Analysis of Emission characteristics on Compression

More information

[Kurrey*, 4.(10): October, 2015] ISSN: (I2OR), Publication Impact Factor: 3.785

[Kurrey*, 4.(10): October, 2015] ISSN: (I2OR), Publication Impact Factor: 3.785 IJESRT INTERNATIONAL JOURNAL OF ENGINEERING SCIENCES & RESEARCH TECHNOLOGY A REVIEW ON PERFORMANCE AND EMISSION CHARACTERISCS OF C.I. ENGINE WITH OXYGENATED FUEL ADDITIVES Satish Kumar Kurrey*, Gopal Sahu,

More information

THE EFFECTS OF OXYGENATED ADDITIVE AND EGR IN A DIESEL ENGINE

THE EFFECTS OF OXYGENATED ADDITIVE AND EGR IN A DIESEL ENGINE THE EFFECTS OF OXYGENATED ADDITIVE AND EGR IN A DIESEL ENGINE Seung-Hun, Choi Department of Automatic Mechanical Engineering, VISION University of Jeonju,Cheonjam-ro, Wansan-gu, Jeonju-si, Republic of

More information

Parametric Study on Design of a Heat Exchanger for an Exhaust Gas Recirculation System

Parametric Study on Design of a Heat Exchanger for an Exhaust Gas Recirculation System Parametric Study on Design of a Heat Exchanger for an Exhaust Gas Recirculation System P. Sai Chaitanya, K. Vijaya Kumar Asst.Professor, Department of Mechanical Engineering, B.I.E.T, Hyderabad, India

More information

Experimental Investigation of Performance and Exhaust Emission Characteristics of Diesel Engine by Changing Piston Geometry

Experimental Investigation of Performance and Exhaust Emission Characteristics of Diesel Engine by Changing Piston Geometry Experimental Investigation of Performance and Exhaust Emission Characteristics of Diesel Engine by Changing Piston Geometry 1 Vaibhav Bhatt, 2 Vandana Gajjar 1 M.E. Scholar, 2 Assistant Professor 1 Department

More information

SWIRL MEASURING EQUIPMENT FOR DIRECT INJECTION DIESEL ENGINE

SWIRL MEASURING EQUIPMENT FOR DIRECT INJECTION DIESEL ENGINE SWIRL MEASURING EQUIPMENT FOR DIRECT INJECTION DIESEL ENGINE G.S.Gosavi 1, R.B.Solankar 2, A.R.Kori 3, R.B.Chavan 4, S.P.Shinde 5 1,2,3,4,5 Mechanical Engineering Department, Shivaji University, (India)

More information

UNIT IV INTERNAL COMBUSTION ENGINES

UNIT IV INTERNAL COMBUSTION ENGINES UNIT IV INTERNAL COMBUSTION ENGINES Objectives After the completion of this chapter, Students 1. To know the different parts of IC engines and their functions. 2. To understand the working principle of

More information

POLLUTION CONTROL AND INCREASING EFFICIENCY OF DIESEL ENGINE USING BIODIESEL

POLLUTION CONTROL AND INCREASING EFFICIENCY OF DIESEL ENGINE USING BIODIESEL POLLUTION CONTROL AND INCREASING EFFICIENCY OF DIESEL ENGINE USING BIODIESEL Deepu T 1, Pradeesh A.R. 2, Vishnu Viswanath K 3 1, 2, Asst. Professors, Dept. of Mechanical Engineering, Ammini College of

More information

Engine Exhaust Emissions

Engine Exhaust Emissions Engine Exhaust Emissions 1 Exhaust Emission Control Particulates (very challenging) Chamber symmetry and shape Injection characteristics (mixing rates) Oil control Catalyst (soluble fraction) Particulate

More information

Influence of Injection Timing on the Performance of Dual Fuel Compression Ignition Engine with Exhaust Gas Recirculation

Influence of Injection Timing on the Performance of Dual Fuel Compression Ignition Engine with Exhaust Gas Recirculation International Journal of Engineering Research and Development ISSN: 2278-067X, Volume 1, Issue 11 (July 2012), PP. 36-42 www.ijerd.com Influence of Injection Timing on the Performance of Dual Fuel Compression

More information

Experimental Investigation of Emission Reduction by Blending Methanol, Ethanol and Biodiesel with diesel on C.I. Engine

Experimental Investigation of Emission Reduction by Blending Methanol, Ethanol and Biodiesel with diesel on C.I. Engine Experimental Investigation of Emission Reduction by Blending Methanol, Ethanol and Biodiesel with diesel on C.I. Engine V. Veeraragavan1, M. Sathiyamoorthy 2 1. Assistant Professor, Department of Mechanical

More information

GRD Journals- Global Research and Development Journal for Engineering Volume 1 Issue 12 November 2016 ISSN:

GRD Journals- Global Research and Development Journal for Engineering Volume 1 Issue 12 November 2016 ISSN: GRD Journals- Global Research and Development Journal for Engineering Volume 1 Issue 12 November 2016 ISSN: 2455-5703 Effect of Brake Thermal Efficiency of a Variable Compression Ratio Diesel Engine Operating

More information

PERFORMANCE AND EMISSION CHARACTERISTICS OF A VARIABLE COMPRESSION SI ENGINE USING ETHANOL- GASOLINE BLENDS AS FUEL

PERFORMANCE AND EMISSION CHARACTERISTICS OF A VARIABLE COMPRESSION SI ENGINE USING ETHANOL- GASOLINE BLENDS AS FUEL Proceedings of the International Conference on Mechanical Engineering 2011 (ICME2011) 18-20 December 2011, Dhaka, Bangladesh ICME11-TH-001 PERFORMANCE AND EMISSION CHARACTERISTICS OF A VARIABLE COMPRESSION

More information

Module 2:Genesis and Mechanism of Formation of Engine Emissions Lecture 3: Introduction to Pollutant Formation POLLUTANT FORMATION

Module 2:Genesis and Mechanism of Formation of Engine Emissions Lecture 3: Introduction to Pollutant Formation POLLUTANT FORMATION Module 2:Genesis and Mechanism of Formation of Engine Emissions POLLUTANT FORMATION The Lecture Contains: Engine Emissions Typical Exhaust Emission Concentrations Emission Formation in SI Engines Emission

More information

EXPERIMENTAL INVESTIGATION OF FOUR STROKE SINGLE CYLINDER DIESEL ENGINE WITH OXYGENATED FUEL ADDITIVES

EXPERIMENTAL INVESTIGATION OF FOUR STROKE SINGLE CYLINDER DIESEL ENGINE WITH OXYGENATED FUEL ADDITIVES EXPERIMENTAL INVESTIGATION OF FOUR STROKE SINGLE CYLINDER DIESEL ENGINE WITH OXYGENATED FUEL ADDITIVES 1 Bhavin Mehta, 2 Hardik B. Patel 1,2 harotar University of Science & Technology, Changa, Gujarat,

More information

C. DHANASEKARAN AND 2 G. MOHANKUMAR

C. DHANASEKARAN AND 2 G. MOHANKUMAR 1 C. DHANASEKARAN AND 2 G. MOHANKUMAR 1 Research Scholar, Anna University of Technology, Coimbatore 2 Park College of Engineering & Technology, Anna University of Technology, Coimbatore ABSTRACT Hydrogen

More information

REVIEW ON GASOLINE DIRECT INJECTION

REVIEW ON GASOLINE DIRECT INJECTION International Journal of Aerospace and Mechanical Engineering REVIEW ON GASOLINE DIRECT INJECTION Jayant Kathuria B.Tech Automotive Design Engineering jkathuria97@gmail.com ABSTRACT Gasoline direct-injection

More information

INFLUENCE OF FUEL TYPE AND INTAKE AIR PROPERTIES ON COMBUSTION CHARACTERISTICS OF HCCI ENGINE

INFLUENCE OF FUEL TYPE AND INTAKE AIR PROPERTIES ON COMBUSTION CHARACTERISTICS OF HCCI ENGINE ENGINEERING FOR RURAL DEVELOPMENT Jelgava, 23.-24.5.213. INFLUENCE OF FUEL TYPE AND INTAKE AIR PROPERTIES ON COMBUSTION CHARACTERISTICS OF HCCI ENGINE Kastytis Laurinaitis, Stasys Slavinskas Aleksandras

More information

Comparison of Swirl, Turbulence Generating Devices in Compression ignition Engine

Comparison of Swirl, Turbulence Generating Devices in Compression ignition Engine Available online atwww.scholarsresearchlibrary.com Archives of Applied Science Research, 2016, 8 (7):31-40 (http://scholarsresearchlibrary.com/archive.html) ISSN 0975-508X CODEN (USA) AASRC9 Comparison

More information

Variations of Exhaust Gas Temperature and Combustion Stability due to Changes in Spark and Exhaust Valve Timings

Variations of Exhaust Gas Temperature and Combustion Stability due to Changes in Spark and Exhaust Valve Timings Variations of Exhaust Gas Temperature and Combustion Stability due to Changes in Spark and Exhaust Valve Timings Yong-Seok Cho Graduate School of Automotive Engineering, Kookmin University, Seoul, Korea

More information

Performance, Combustion and Emission Characteristics of Corn oil blended with Diesel

Performance, Combustion and Emission Characteristics of Corn oil blended with Diesel Performance, Combustion and Emission Characteristics of Corn oil blended with Diesel U. Santhan Kumar 1, K. Ravi Kumar 2 1 M.Tech Student, Thermal engineering, V.R Siddhartha Engineering College, JNTU

More information

Comprehensive Review of Three way Catalytic Converter

Comprehensive Review of Three way Catalytic Converter Comprehensive Review of Three way Catalytic Converter Kuldeep Kumar 1 Narender Kumar 2 Hardial Singh 3 1 Assistant Professor, Mechanical Engineering, Amity University Haryana, India 2 Assistant Professor,

More information

International Journal of Scientific & Engineering Research, Volume 7, Issue 8, August-2016 ISSN

International Journal of Scientific & Engineering Research, Volume 7, Issue 8, August-2016 ISSN ISSN 2229-5518 2417 Experimental Investigation of a Two Stroke SI Engine Operated with LPG Induction, Gasoline Manifold Injection and Carburetion V. Gopalakrishnan and M.Loganathan Abstract In this experimental

More information

EFFECT OF EXHAUST GAS RECIRCULATION ON ENGINE PERFORMANCE AND EMISSION ON VARIABLE COMPRESSION RATIO ENGINE

EFFECT OF EXHAUST GAS RECIRCULATION ON ENGINE PERFORMANCE AND EMISSION ON VARIABLE COMPRESSION RATIO ENGINE EFFECT OF EXHAUST GAS RECIRCULATION ON ENGINE PERFORMANCE AND EMISSION ON VARIABLE COMPRESSION RATIO ENGINE Bharat Namdev Kharad VACOE,A.Nagar Department of Mechanical Engineering,Pune University / Ahmednagar,

More information

Module 5: Emission Control for SI Engines Lecture20:ADD-ON SYSTEMS FOR CONTROL OF ENGINE-OUT EMISSIONS

Module 5: Emission Control for SI Engines Lecture20:ADD-ON SYSTEMS FOR CONTROL OF ENGINE-OUT EMISSIONS ADD-ON SYSTEMS FOR CONTROL OF ENGINE-OUT EMISSIONS The Lecture Contains: Crankcase Emission Control (PCV System) Evaporative Emission Control Exhaust Gas Recirculation Water Injection file:///c /...%20and%20Settings/iitkrana1/My%20Documents/Google%20Talk%20Received%20Files/engine_combustion/lecture20/20_1.htm[6/15/2012

More information

TECHNICAL PAPER FOR STUDENTS AND YOUNG ENGINEERS - FISITA WORLD AUTOMOTIVE CONGRESS, BARCELONA

TECHNICAL PAPER FOR STUDENTS AND YOUNG ENGINEERS - FISITA WORLD AUTOMOTIVE CONGRESS, BARCELONA TECHNICAL PAPER FOR STUDENTS AND YOUNG ENGINEERS - FISITA WORLD AUTOMOTIVE CONGRESS, BARCELONA 2 - TITLE: Topic: INVESTIGATION OF THE EFFECTS OF HYDROGEN ADDITION ON PERFORMANCE AND EXHAUST EMISSIONS OF

More information

The Effect of Turbocharging on Volumetric Efficiency in Low Heat Rejection C.I. Engine fueled with Jatrophafor Improved Performance

The Effect of Turbocharging on Volumetric Efficiency in Low Heat Rejection C.I. Engine fueled with Jatrophafor Improved Performance The Effect of Turbocharging on Volumetric Efficiency in Low Heat Rejection C.I. Engine fueled with Jatrophafor Improved Performance R. Ganapathi *, Lecturer, Mechanical Engineering department, JNTUA College

More information

INFLUENCE OF THE NUMBER OF NOZZLE HOLES ON THE UNBURNED FUEL IN DIESEL ENGINE

INFLUENCE OF THE NUMBER OF NOZZLE HOLES ON THE UNBURNED FUEL IN DIESEL ENGINE INFLUENCE OF THE NUMBER OF NOZZLE HOLES ON THE UNBURNED FUEL IN DIESEL ENGINE 1. UNIVERSITY OF RUSE, 8, STUDENTSKA STR., 7017 RUSE, BULGARIA 1. Simeon ILIEV ABSTRACT: The objective of this paper is to

More information

Influence of Fuel Injector Position of Port-fuel Injection Retrofit-kit to the Performances of Small Gasoline Engine

Influence of Fuel Injector Position of Port-fuel Injection Retrofit-kit to the Performances of Small Gasoline Engine Influence of Fuel Injector Position of Port-fuel Injection Retrofit-kit to the Performances of Small Gasoline Engine M. F. Hushim a,*, A. J. Alimin a, L. A. Rashid a and M. F. Chamari a a Automotive Research

More information

TNV Series Common Rail. Final Tier 4 19kW to 56kW WATER-COOLED DIESEL ENGINES. EPA Tier 4 (19-56kW) EU Stage IIIB (37-56kW)

TNV Series Common Rail. Final Tier 4 19kW to 56kW WATER-COOLED DIESEL ENGINES. EPA Tier 4 (19-56kW) EU Stage IIIB (37-56kW) Final Tier 4 19kW to 56kW WATER-COOLED DIESEL ENGINES TNV Series Common Rail EPA Tier 4 (19-56kW) EU Stage IIIB (37-56kW) TNV SERIES COMMON RAIL ENGINES EPA TIER 4 (19-56kW) EU Stage IIIB (37-56kW) * DPF

More information

Smoke Reduction Methods Using Shallow-Dish Combustion Chamber in an HSDI Common-Rail Diesel Engine

Smoke Reduction Methods Using Shallow-Dish Combustion Chamber in an HSDI Common-Rail Diesel Engine Special Issue Challenges in Realizing Clean High-Performance Diesel Engines 17 Research Report Smoke Reduction Methods Using Shallow-Dish Combustion Chamber in an HSDI Common-Rail Diesel Engine Yoshihiro

More information

Emission from gasoline powered vehicles are classified as 1. Exhaust emission 2. Crank case emission 3. Evaporative emission. Table 1.

Emission from gasoline powered vehicles are classified as 1. Exhaust emission 2. Crank case emission 3. Evaporative emission. Table 1. Introduction: Main three types of automotive vehicle being used 1. Passenger cars powered by four stroke gasoline engines 2. Motor cycles, scooters and auto rickshaws powered mostly by small two stroke

More information

Homogeneous Charge Compression Ignition combustion and fuel composition

Homogeneous Charge Compression Ignition combustion and fuel composition Loughborough University Institutional Repository Homogeneous Charge Compression Ignition combustion and fuel composition This item was submitted to Loughborough University's Institutional Repository by

More information

Experimental Study on the Use of EGR in a Hydrogen-Fueled SI Engine. P. Tamilarasan, M. Loganathan

Experimental Study on the Use of EGR in a Hydrogen-Fueled SI Engine. P. Tamilarasan, M. Loganathan International Journal of Scientific & Engineering Research, Volume 7, Issue 8, August - 2016 Experimental Study on the Use of EGR in a Hydrogen-Fueled SI Engine P. Tamilarasan, M. Loganathan 336 Abstract

More information

Thermo-Kinetic Model to Predict Start of Combustion in Homogeneous Charge Compression Ignition Engine

Thermo-Kinetic Model to Predict Start of Combustion in Homogeneous Charge Compression Ignition Engine Thermo-Kinetic Model to Predict Start of Combustion in Homogeneous Charge Compression Ignition Engine Harshit Gupta and J. M. Malliarjuna Abstract Now-a-days homogeneous charge compression ignition combustion

More information

Effect of Direct Water Injection on Performance and Emission Characteristics of Diesel Engine Fueled with Bio Diesel and Hydrogen

Effect of Direct Water Injection on Performance and Emission Characteristics of Diesel Engine Fueled with Bio Diesel and Hydrogen IJSTE - International Journal of Science Technology & Engineering Volume 3 Issue 05 November 2016 ISSN (online): 2349-784X Effect of Direct Water Injection on Performance and Emission Characteristics of

More information

Experimental Investigation of Performance and Emission Characteristics of Hybrid Fuel Engine

Experimental Investigation of Performance and Emission Characteristics of Hybrid Fuel Engine IJIRST International Journal for Innovative Research in Science & Technology Volume 1 Issue 11 April 2015 ISSN (online): 2349-6010 Experimental Investigation of Performance and Emission Characteristics

More information

Experimental Analysis of Utilization of Heat Using Methanol - Diesel Blended Fuel in Four Stroke Single Cylinder Water Cooled Diesel Engine

Experimental Analysis of Utilization of Heat Using Methanol - Diesel Blended Fuel in Four Stroke Single Cylinder Water Cooled Diesel Engine Experimental Analysis of Utilization of Heat Using Methanol - Diesel Blended Fuel in Four Stroke Single Cylinder Water Cooled Diesel Engine T. Singha 1, S. Sakhari 1, T. Sarkar 1, P. Das 1, A. Dutta 1,

More information

EFFECT OF INJECTING HYDROGEN PEROXIDE INTO DIESEL ENGINE

EFFECT OF INJECTING HYDROGEN PEROXIDE INTO DIESEL ENGINE EFFECT OF INJECTING HYDROGEN PEROXIDE INTO DIESEL ENGINE Nagaprasad K. S. 1, D. Madhu 2 1 Senior Lecturer, Department of Mechanical Engineering K. S. Institute of Technology, Bangalore, India. nagaprasad_k_s@yahoo.com

More information

State of the Art (SOTA) Manual for Internal Combustion Engines

State of the Art (SOTA) Manual for Internal Combustion Engines State of the Art (SOTA) Manual for Internal Combustion Engines July 1997 State of New Jersey Department of Environmental Protection Air Quality Permitting Program State of the Art (SOTA) Manual for Internal

More information

Eects of Exhaust Gas Recirculation on Emission and Performance of Diesel Engines. March 30, Piyush Rai. Roll No

Eects of Exhaust Gas Recirculation on Emission and Performance of Diesel Engines. March 30, Piyush Rai. Roll No Eects of Exhaust Gas Recirculation on Emission and Performance of Diesel Engines March 30, 2011 Piyush Rai Roll No. 10105070 Mechanical Engineering Department piyushr@iitk.ac.in Abstract The Exhaust Gas

More information

INTERNATIONAL JOURNAL OF ADVANCED RESEARCH IN ENGINEERING AND TECHNOLOGY (IJARET)

INTERNATIONAL JOURNAL OF ADVANCED RESEARCH IN ENGINEERING AND TECHNOLOGY (IJARET) INTERNATIONAL JOURNAL OF ADVANCED RESEARCH IN ENGINEERING AND TECHNOLOGY (IJARET) International Journal of Advanced Research in Engineering and Technology (IJARET), ISSN ISSN 0976-6480 (Print) ISSN 0976-6499

More information

ACTUAL CYCLE. Actual engine cycle

ACTUAL CYCLE. Actual engine cycle 1 ACTUAL CYCLE Actual engine cycle Introduction 2 Ideal Gas Cycle (Air Standard Cycle) Idealized processes Idealize working Fluid Fuel-Air Cycle Idealized Processes Accurate Working Fluid Model Actual

More information