Additions, Revisions, or Updates
|
|
- Isaac Fisher
- 6 years ago
- Views:
Transcription
1 SUBJECT DATE SPN 3250 (ACM) December 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 and GHG14 DD Platform SPN 3250/FMI 8 - EPA10 SPN 3250/FMI 8 - GHG14 Wiggle test steps have been removed from these procedures. All information subject to change without notice. 3
2 2 SPN 3250/FMI 8 - EPA10 2 SPN 3250/FMI 8 - EPA10 Diesel Oxidation Catalyst Outlet Temperature - Signal Spike Table 1. Description Monitored Parameter Typical Enabling Conditions Monitor Sequence Execution Frequency Typical Duration Dash Lamps Engine Reaction Verification SPN 3250/FMI 8 This Fault Indicates the Aftertreatment Control Module (ACM) has Detected a Sudden Temperature Shift on the Diesel Oxidation Catalyst (DOC) Outlet Temperature Sensor DOC Outlet Temperature DOC Outlet Temperature Greater Than 150 C (302 F) 10 Seconds CEL, MIL Low Temp ATD Check NOTE: The most likely cause is an intermittent wiring concern (poor terminal fit, corrosion, chaffing etc.). 1. Connect DiagnosticLink. 2. Turn the ignition ON (key ON, engine OFF). 3. Check for other fault codes. Are SPN 3250/FMI 3 or 4 also present? a. Yes; repair the other faults codes first. b. No; Go to step Turn the ignition OFF. 5. Remove the DOC outlet temperature sensor. Refer to section "Removal of the EPA10 Diesel Oxidation Catalyst Outlet Temperature Sensor". 6. Allow the DOC outlet temperature sensor to cold soak for several minutes until the sensor has reached ambient temperature. 7. Measure the resistance between pins 1 and 2 of the DOC outlet temperature sensor electrical connector. Does the DOC outlet temperature sensor match the resistance specification in the chart below? Table 2. Resistance Values Temp C (F ) Min. Resistance (Ω) Max. Resistance (Ω) Min. Voltage Max. Voltage 0 (32) (50) (77) (122) (212) (302) (392) (572) (752) a. Yes; Go to step 8. b. No; replace the DOC outlet temperature sensor. Refer to section "Removal of the EPA10 Diesel Oxidation Catalyst Outlet Temperature Sensor". Verify repair. 4 All information subject to change without notice. Copyright 2015 DETROIT DIESEL CORPORATION
3 8. Using appropriate test probes from J connector test kit and terminal repair kit J-47410, drag test and inspect all harness connector terminals between the DOC outlet temperature sensor and the ACM including the chassis extension harness and Aftertreatment Device (ATD) sensor box. Repair as necessary. All information subject to change without notice. 5
4 3 SPN 3250/FMI 8 GHG14 3 SPN 3250/FMI 8 GHG14 Diesel Oxidation Catalyst Outlet Temperature - Signal Spike Table 3. Description Monitored Parameter Typical Enabling Conditions Monitor Sequence Execution Frequency Typical Duration Dash Lamps Engine Reaction Verification SPN 3250/FMI 8 This Fault Indicates the Aftertreatment Control Module (ACM) has Detected a Sudden Temperature Shift on the Diesel Oxidation Catalyst (DOC) Outlet Temperature Sensor DOC Outlet Temperature DOC Outlet Temperature Greater Than 150 C (302 F) 10 Seconds CEL, MIL Low Temp ATD Check NOTE: The most likely cause is an intermittent wiring concern (poor terminal fit, corrosion, chaffing etc.). 1. Connect DiagnosticLink. 2. Turn the ignition ON (key ON, engine OFF). 3. Check for other fault codes. Are SPN 3250/FMI 3 or 4 present? a. Yes; repair the other fault codes first. b. No; Go to step Turn the ignition OFF. 5. Remove the DOC outlet temperature sensor. Refer to section "Removal of the GHG14 Diesel Oxidation Catalyst Outlet Temperature Sensor". 6. Allow the DOC outlet temperature sensor to cold soak for several minutes until the sensor has reached ambient temperature. 7. Measure the resistance between pins 1 and 2 of the DOC outlet temperature sensor connector. Does the DOC outlet temperature sensor match the resistance specification in the chart below? Table 4. Temp C ( F) Min Resistance (Ω) Max Resistance (Ω) Min Voltage Max Voltage 0 (32) (50) (77) (122) (212) (302) (392) (572) (752) a. Yes; Go to step 8. b. No; replace the DOC outlet temperature sensor. Refer to section "Removal of the GHG14 Diesel Oxidation Catalyst Outlet Temperature Sensor". 6 All information subject to change without notice. Copyright 2015 DETROIT DIESEL CORPORATION
5 8. Using appropriate test probes from J connector test kit and terminal repair kit J-47410, drag test and inspect all harness connector terminals between the DOC outlet temperature sensor and the ACM including the chassis extension harness and Aftertreatment Device (ATD) sensor box. Repair as necessary. All information subject to change without notice. 7
Additions, Revisions, or Updates
1 5 03-14 SUBJECT DATE SPN 3599/FMI 3 and 4 (ACM) May 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3599/FMI 3-1 DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform
More informationAdditions, Revisions, or Updates
11 54-16 1 11 54-16 SUBJECT SPN 3242 (ACM) (EPA10;GHG14) SPN 3250 (ACM) (EPA10;GHG14) SPN 3251 (ACM) (GHG14) DATE November 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section
More informationAdditions, Revisions, or Updates
1 8 02-14 SUBJECT DATE SPN 4334 (ACM) (GHG14) August 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 4334/FMI 3 - DDC-SVC-MAN-0084 GHG14 DD Platform GHG14
More informationAdditions, Revisions, or Updates
1 06 10-16 SUBJECT SPN 111 (CPC) (GHG17) and SPN 111 (CPC) (EPA07;EPA10;GHG14) DATE June 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0191
More informationAdditions, Revisions, or Updates
1 6 07-15 SUBJECT DATE SPN 3464 (MCM) (EPA10;GHG14) June 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3464/FMI 3 - DDC-SVC-MAN-0084 EPA10/ GHG14 DD
More informationAdditions, Revisions, or Updates
1 8 09-14 SUBJECT DATE SPN 3361 (ACM) (GHG14) August 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 3361/FMI 3, 4, 5, 31
More informationAdditions, Revisions, or Updates
1 02 01-14 SUBJECT DATE SPN 1761/FMI 3, 4 ( ACM2-EPA10) (ACM2.1-GHG14) February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform
More informationAdditions, Revisions, or Updates
1 4 09-14 SUBJECT DATE ACM2.1 SPN 3597/FMI 3, 4 - GHG14 April 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 3597/FMI 3,
More informationAdditions, Revisions, or Updates
1 01 06-15 SUBJECT DATE SPN 3251 (ACM) (EPA10) and (GHG14) January 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3251/FMI 0 - GHG14 DDC-SVC-MAN-0084
More informationAdditions, Revisions, or Updates
1 6 13-14 SUBJECT DATE SPN 4259/FMI 4 (MCM) (EPA07) June 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA07 DD Platform SPN 4259/FMI 4
More informationAdditions, Revisions, or Updates
1 10 09-14 SUBJECT DATE SPN 5016 (ACM) (GHG14) October 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 5016/FMI 3 - DDC-SVC-MAN-0084 GHG14 DD Platform
More informationAdditions, Revisions, or Updates
1 01 06-16 SUBJECT SPN 4334/FMI 4 (ACM) (GHG14) SPN 4334/FMI 4 (ACM) (GHG17) DATE January 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084
More informationAdditions, Revisions, or Updates
10 15-13 1 10 15-13 SUBJECT DATE SPN 4257/FMI 3, 4 October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform SPN 4257/FMI
More informationAdditions, Revisions, or Updates
1 10 16-13 SUBJECT DATE SPN 3216/FMI 13 - EPA10/GHG14 October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 GHG14 DD Platform SPN
More informationAdditions, Revisions, or Updates
1 6 05-13 SUBJECT DATE SPN 625/FMI 9 EPA10 - GHG14 June 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform SPN 625/FMI
More informationAdditions, Revisions, or Updates
1 01 11-16 SUBJECT DATE SPN 647 (MCM)(EPA07-EPA10-GHG14) January 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DDC-SVC-MAN-S084 DD Platform
More informationSPN 3509 (MCM) (EPA10) and SPN 3509 (MCM) (GHG14) June 2014 SPN 3509/FMI 3 - EPA10 SPN 3509/FMI 4 - EPA10 SPN 3509/FMI 3 - GHG14
1 SUBJECT DATE SPN 3509 (MCM) (EPA10) and SPN 3509 (MCM) (GHG14) June 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3509/FMI 3 - EPA10 The diagnostic
More informationAdditions, Revisions, or Updates
1 8 08-14 SUBJECT DATE SPN 4364 (ACM) (EPA10) August 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 4364/FMI 1 - EPA10 SPN
More informationAdditions, Revisions, or Updates
1 01 29-14 SUBJECT DATE SPN 3511/FMI 3 and 4 - GHG14 January 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3511/FMI 3 - DDC-SVC-MAN-0084 GHG14 DD Platform
More informationAdditions, Revisions, or Updates
03 57-17 1 03 57-17 SUBJECT DATE SPN 625 (CPC) (GHG17) March 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0191 GHG17 DD Platform SPN 625/FMI
More informationAdditions, Revisions, or Updates
1 3 01-15 SUBJECT SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM) (EPA10;GHG14), and 5298 (ACM) (EPA10;GHG14) DATE March 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section
More informationAdditions, Revisions, or Updates
1 10 28-13 SUBJECT DATE SPN 625/FMI 9 EPA10 - GHG14 (ACM) October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform
More informationAdditions, Revisions, or Updates
1 29-13 1 1 29-13 SUBJECT DATE DD Platform GHG 14 SPN 3361 FMI 3, 4, 5 UPDATE January 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG
More informationAdditions, Revisions, or Updates
1 3 21-15 SUBJECT DATE SPN 4364 (ACM) (GHG14) March 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 4364/SPN 18 - GHG14
More informationAdditions, Revisions, or Updates
1 SUBJECT DATE SPN 3659/FMI 5 GHG14 MCM2.1 May 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 3659/FMI 5 GHG14 This
More informationAdditions, Revisions, or Updates
1 5 20-12 SUBJECT DATE SPN 3664/FMI 5 GHG14 June 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 3664/FMI 5 GHG14 This
More informationAdditions, Revisions, or Updates
1 8 05-12 SUBJECT DATE SPN 4354/FMI 5, 4356/FMI 5, 4355/FMI 5, 4357/FMI 5 August 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 4354/FMI 5 DDC-SVC-MAN-0084
More informationSPN 5443 (ACM)(GHG17) and SPN (ACM)(GHG17) May 2016 SPN 5443/FMI 0 - GHG17 SPN 5443/FMI 15 - GHG17 SPN 5443/FMI 16 - GHG17
1 05 18-16 SUBJECT DATE SPN 5443 (ACM)(GHG17) and SPN 520372 (ACM)(GHG17) May 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 5443/FMI 0 - GHG17 SPN 5443/FMI
More informationAdditions, Revisions, or Updates
1 12 05-16 SUBJECT SPN 636 (MCM) (GHG17) SPN 636 (MCM) (EPA07;EPA10;GHG14) SPN 636 (MCM) (GHG14) DATE December 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change
More informationAdditions, Revisions, or Updates
1 8 04-12 SUBJECT DATE SPNs 4354/FMI 5, 4355/FMI 5, 4356/FMI 5, 4357/FMI 5 August 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 4354/FMI 5 DDC-SVC-MAN-0084
More informationAdditions, Revisions, or Updates
6 12-14 1 6 12-14 SUBJECT DATE SPN 5741 (ACM) (GHG14) May 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 5741/FMI 4 DDC-SVC-MAN-0084 GHG14 DD Platform
More informationAdditions, Revisions, or Updates
1 8 03-13 SUBJECT DATE SPN 51/FMI 2, 10, 18 August 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DD Platform SPN 51/FMI 2 All Years Most steps have been
More informationAdditions, Revisions, or Updates
1 06 13-16 SUBJECT DATE SPN 1590 (CPC) (GHG17) June 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 GHG17 Medium Duty SPN 1590/FMI 9 - GHG17
More informationSPN (ACM) (GHG17) and SPN (ACM) (GHG17) February Publication Number / Title Platform Section Title Change
1 02 11-17 SUBJECT DATE SPN 520371 (ACM) (GHG17) and SPN 520372 (ACM) (GHG17) February 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 GHG17
More informationSPN 3480 (MCM)(EPA07;EPA10;GHG14) June Publication Number / Title Platform Section Title Change
6 06-15 1 6 06-15 SUBJECT DATE SPN 3480 (MCM)(EPA07;EPA10;GHG14) June 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Revised step 3,14, and 29. DDC-SVC-MAN-0084
More informationAdditions, Revisions, or Updates
1 2 22-14 SUBJECT DATE SPN 4334/FMI 7 (ACM) (EPA10) February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform - EPA10- ACM SPN
More informationAdditions, Revisions, or Updates
1 01 06-17 SUBJECT DATE SPN 520296 (MCM) (GHG14) and SPN 520296 (MCM) (GHG17) January 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DDC-SVC-MAN-0191
More informationAdditions, Revisions, or Updates
1 SUBJECT DATE SPN 51/FMI 10 and 18 March 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 51/FMI 10 SPN 51/FMI 18 The
More informationAdditions, Revisions, or Updates
1 2 30-14 SUBJECT DATE SPN 4375/FMI 6 - EPA10 February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 DD Platform SPN 4375/FMI 6 -
More informationAdditions, Revisions, or Updates
1 02 10-17 SUBJECT DATE SPN 4364 (ACM) (GHG17) February 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 GHG17 Medium Duty SPN 4364/FMI 1
More informationAdditions, Revisions, or Updates
01 04-15 1 01 04-15 SUBJECT DATE SPN 3464/ FMI 16, 18 (MCM) (GHG14) January 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN
More informationAdditions, Revisions, or Updates
1 2 19-11 SUBJECT DATE Revised ACM SPN 3364/FMI 1, 2, and 17 February 2011 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 DD Platform SPN
More informationSPN 4364 (ACM)(EPA10); SPN 4364 (ACM)(GHG14) January Publication Number / Title Platform Section Title Change SPN 4364/FMI 18 - EPA10
01 01-18 1 01 01-18 SUBJECT DATE SPN 4364 (ACM)(EPA10); SPN 4364 (ACM)(GHG14) January 2018 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD
More informationSPN 723/FMI 3, 8, 10, 11, 31 - All Years February SPN 723/FMI 3 - All Years. SPN 723/FMI 8 - All Years. SPN 723/FMI 10 - All Years
1 49-13 1 1 49-13 SUBJECT DATE SPN 723/FMI 3, 8, 10, 11, 31 - All Years February 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 723/FMI 3 - All Years
More informationAdditions, Revisions, or Updates
1 9 19-13 SUBJECT DATE SPN 102/FMI 18 - GHG14 MCM2.1 October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 102/FMI 18 Complete
More informationAdditions, Revisions, or Updates
1 9 14-14 SUBJECT DATE SPN 3563 (MCM) (GHG14) September 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 3563/FMI 21
More informationAdditions, Revisions, or Updates
6 22-12 1 6 22-12 SUBJECT DATE SPN 4335/FMI 1 - EPA10 June 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10 DD Platform SPN 4335/FMI
More informationPublication Number / Title Platform Section Title Change SPN 5246/FMI 0- EPA10 SPN 5246/FMI 15 - EPA10 SPN 5246/FMI 16 - EPA10 SPN 5246/FMI 0 - GHG14
1 3 04-14 SUBJECT SPN 5246/FMI 0, 15, 16 (ACM2)(EPA10) SPN 5246/FMI 0, 15, 16 (ACM2.1)(GHG14) DATE March 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN
More informationAdditions, Revisions, or Updates
2 27-14 1 2 27-14 SUBJECT DATE SPN 4335/FMI 7 - EPA10 February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 4335/FMI 7
More informationAdditions, Revisions, or Updates
1 03 12-17 SUBJECT DATE SPN 157 (MCM) GHG17 March 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 DD Platform - Med Duty SPN 157/FMI 16 -
More informationAdditions, Revisions, or Updates
1 SUBJECT SPN 3216 (ACM) (GHG17) SPN 3217 (ACM) (GHG17) DATE March 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 GHG17 Medium Duty SPN
More informationRev Rev. Additions, Revisions, or Updates
1 4 89-12Rev SUBJECT DATE SPN 5927/FMI 2 and 7 - GHG14 April 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 5927/FMI 2 - DDC-SVC-MAN-0084 DD Platform
More informationAdditions, Revisions, or Updates
1 03 13-17 SUBJECT DATE SPN 520268 (MCM) (GHG17) March 2017 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0193 DD Platform Med Duty SPN 520268/ FMI
More informationAdditions, Revisions, or Updates
1 SUBJECT DATE SPN 3250/FMI 0, 15 - EPA10 October 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3250/FMI 0 - DDC-SVC-MAN-0084 EPA10 DD Platform EPA10
More informationThe Aftertreatment System Technician's Guide (7SE63) was revised to include three new procedures.
NUMBER: 07 ATS 3 S.M. REF.: Listed in Table 1 ENGINE: ATS DATE: December 2007 SUBJECT: ADDITIONAL PROCEDURES WERE ADDED TO AFTERTREATMENT SYSTEM PUBLICATION: 7SE63 The Aftertreatment System Technician's
More informationAdditions, Revisions, or Updates
1 3 30-12 SUBJECT DATE SPN 1761/FMI 2, 9 - MY13 March 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 MY13 DD Platform SPN 1761/FMI 2 - MY13
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA10 DD Platform DATE: August 2010
NUMBER: 815 10 S.M. REF.: Listed in Table ENGINE: EPA10 DD Platform DATE: August 2010 SUBJECT: SPN 3226 FMI 13 SCR OUTLET NOX SENSOR SIGNAL NOT AVAILABLE ADDITIONS, REVISIONS, OR UPDATES Publication Number
More informationAdditions, Revisions, or Updates
1 10 26-13 SUBJECT DATE SPN 3216/FMI 16 and 18 October 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 GHG14 DD Platform SPN 3216/FMI 16
More informationAdditions, Revisions, or Updates
1 11 19-13 SUBJECT DATE SPN 3216/FMI 2, 18 GHG14 (MCM2.1) November 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3216/FMI 2 DDC-SVC-MAN-0084 GHG14 DD
More informationFuel Filter Maintenance Intervals July EPA10/GHG14 DD Series Preventive Maintenance Tables
1 7 14-13 SUBJECT DATE Fuel Filter Maintenance Intervals July 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0080 EPA10/ GHG14 DD Platform EPA10/GHG14
More informationAdditions, Revisions, or Updates
6 08-15 1 6 08-15 SUBJECT DATE NOx Sensors June 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal of the GHG14 1-BOX Aftertreatment DDC-SVC-MAN-0083
More informationSPN 4364/FMI 17 - GHG17 SPN /FMI 16 - GHG17 SPN /FMI 14 - GHG17 SPN 3216/FMI 16 - GHG17 SPN 3216/FMI 18 - GHG17 SPN 3217/FMI 2 - GHG17
11 29-16 1 11 29-16 SUBJECT SPN 4364 (ACM) (GHG17) SPN 520371 (ACM) (GHG17) SPN 520372 (ACM) (GHG17) SPN 3216 (ACM) (GHG17) SPN 3217 (ACM) (GHG17) SPN 3226 (ACM) (GHG17) SPN 3227 (ACM) (GHG17) Diagnostic
More informationAdditions, Revisions, or Updates
1 8 33-13 SUBJECT DATE SPN 3364/FMI 1, 17 (ACM2-EPA10) August 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 3364/FMI 1,
More informationEPA10 DOC Inlet Pressure Sensor November Removal of the EPA10 Diesel Oxidation Catalyst Inlet Pressure Sensor. without Sensor Box
11 10-14 1 11 10-14 SUBJECT DATE EPA10 DOC November 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal of the EPA10 DDC-SVC-MAN-0083 EPA10 DD Platform
More informationAdditions, Revisions, or Updates
1 5 25-13 SUBJECT DATE SPN 2791/FMI 7 ALL YEARS May 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 2791/FMI 7 Deleted part
More informationAdditions, Revisions, or Updates
4 68-12 1 4 68-12 SUBJECT DATE SPN 5018/FMI 18 - GHG14 September 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform SPN 5018/FMI
More informationAdditions, Revisions, or Updates
08 09-16 1 08 09-16 SUBJECT DATE Symptom Diagnostics : Noisy 1- Box Aftertreatment August 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Symptom Diagnostics
More informationAdditions, Revisions, or Updates
1 4 97-12 SUBJECT DATE EPA10 Aftertreatment Regeneration Strategy May 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0083 EPA10 DD Platform EPA10
More informationAdditions, Revisions, or Updates
1 12 02-12 SUBJECT DATE Test E - Three-Filter Fuel System December 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform Test E - Three-Filter
More informationAdditions, Revisions, or Updates
1 3 03-15 SUBJECT DATE Contaminated Fluids March 2015 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DD Platform Fuel in Oil This is a new section.
More informationNUMBER: 08 DDEC VI 16 S.M. REF.: listed in Table 1 ENGINE: DD15 DATE: April 2008 SUBJECT: SPN 1636 AND SPN 2630 PUBLICATION: DDC-SVC-MAN-0029
NUMBER: 08 DDEC VI 16 S.M. REF.: listed in Table 1 ENGINE: DD15 DATE: April 2008 SUBJECT: SPN 1636 AND SPN 2630 PUBLICATION: DDC-SVC-MAN-0029 The procedure and direction for SPN 1636 have changed. SPN
More informationNotice Added to Sections Listed Below February Removal of the Bypass Valve. Removal of the Pressure Relief Valve
2 15-12 1 2 15-12 SUBJECT DATE Notice Added to Sections Listed Below February 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0082 Removal of
More informationAdditions, Revisions, or Updates
1 SUBJECT DATE Parked Regeneration October 2018 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0190 GHG17 DD Platform Parked Regeneration DDC-SVC-MAN-0083
More informationPublication Number / Title Platform Section Title Change. Description and Operation of the Diesel Particulate Filter End Cap
04 04-18 1 04 04-18 SUBJECT GHG17 DD8 - Aftertreatment Systems - Diesel Particulate Filter End Cap DATE April 2018 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change
More informationAftertreatment System December Removal of the 1-BOX from the Vehicle. Installation of the 1- BOX to the Vehicle
12 13-18 1 12 13-18 SUBJECT DATE Aftertreatment System December 2018 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal of the 1-BOX from the Vehicle Installation
More informationAdditions, Revisions, or Updates
1 9 04-11 SUBJECT DATE SPN 3250 / FMI 16 DOC Outlet Temperature High August 2011 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA07 DD13/DD15
More informationSPN 1176/FMI 3 SPN 1176/FMI 4
NUMBER: 8 01 13 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 900 DATE: August 2013 SUBJECT: SPN 1176/FMI 3, 4 ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change DDC-SVC-MAN-0015
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: April 2009
NUMBER: 4 7 09 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: April 2009 SUBJECT: SPN 27 ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page Number(s) DDC-SVC-MAN-0009
More informationAdditions, Revisions, or Updates
1 7 18-12 SUBJECT DATE SPN 520268/FMI 16, 18 (MCM2.1) July 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 520268/FMI 16 DDC-SVC-MAN-0084 GHG14 DD Platform
More informationAdditions, Revisions, or Updates
2 15-14 1 2 15-14 SUBJECT DATE Check for Rough Running or Stalling - Three-Filter Fuel System February 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Check
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: October 2010
NUMBER:10 02 10 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: October 2010 SUBJECT: DOUBLEHYSTERESISTEST ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page
More informationAdditions, Revisions, or Updates
1 4 30-12 SUBJECT DATE SPN 164/FMI 15 (MCM2.1) MY13 April 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 MY13 DD Platform SPN 164/FMI 15
More informationSPN 3480/FMI 0, 1, 3, 4, 14, 21, 31 October 2012 SPN 3480/FMI 0 SPN 3480/FMI 1 SPN 3480/FMI 3 SPN 3480/FMI 4 SPN 3480/FMI 14 SPN 3480/FMI 21
1 10 85-12 SUBJECT DATE SPN 3480/FMI 0, 1, 3, 4, 14, 21, 31 October 2012 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change SPN 3480/FMI 0 SPN 3480/FMI 1 DDC-SVC-MAN-0084
More informationPublication Number / Title Platform Section Title Change. Removal of DD15 and DD16 Delphi Exhaust Gas Recirculation Valve Actuator
7 02-15 1 7 02-15 SUBJECT DD15 and DD16 Delphi Exhaust Gas Recirculation Valve Actuator and DD15 and DD16 Sonceboz Exhaust Gas Recirculation Valve Actuator DATE July 2015 Additions, Revisions, or Updates
More informationExhaust and Exhaust Gas Recirculation September Testing of the DD13. Exhaust Gas Recirculation Cooler Water Manifold Assembly - In Chassis
1 09 04-16 SUBJECT DATE Exhaust and Exhaust Gas Recirculation September 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Testing of the DD13 DDC-SVC-MAN-0190
More informationHigh Pressure Fuel Rail Feed Lines September Platform Section Title Change
9 10-14 1 9 10-14 SUBJECT DATE High Pressure Fuel Rail Feed Lines September 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0082 DDC-SVC-MAN-0182
More informationAdditions, Revisions, or Updates
1 02 23-16 SUBJECT DATE Diesel Oxidation Catalyst Air Cleaning February 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 DDC-SVC-MAN-0191
More informationPublication Number / Title Platform Section Title Change. Removal of the High Pressure Fuel Pump Drive Gear - Three-Filter System
5 34-13 1 5 34-13 SUBJECT Removal and Installation of the High Pressure Fuel Pump Drive Gear - Three-Filter System DATE June 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section
More informationSymptom Diagnostics - Belt Coming Off, Shredding or Misalignment September Symptom Diagnostics - Belt Coming Off, Shredding or Misalignment
09 02-16 1 09 02-16 SUBJECT DATE Symptom Diagnostics - Belt Coming Off, Shredding or Misalignment September 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change
More informationSPN 51 or Suspect Parameter Number (SPN) and Failure Mode Indicator (FMI) Description
SPN 51 or 3673 Suspect Parameter Number (SPN) and Failure Mode Indicator (FMI) Description SPN FMI Description Possible Causes 51 3 TPS1 Sensor Signal Voltage High Open/high resistance in low Short to
More informationHydrocarbon Fuel Doser Injector Valve Fuel Supply Line December Publication Number / Title Platform Section Title Change
1 SUBJECT DATE Hydrocarbon Fuel Doser Injector Valve Fuel Supply Line December 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change Removal of the Hydrocarbon
More informationSPN 110. Suspect Parameter Number (SPN) and Failure Mode Indicator (FMI) Description. SPN FMI Description Possible Causes
SPN 110 Suspect Parameter Number (SPN) and Failure Mode Indicator (FMI) Description SPN FMI Description Possible Causes 110 0 Engine Coolant Temperature Stuck thermostat Overheating Low coolant Cooling
More informationAdditions, Revisions, or Updates
1 10 18-16 SUBJECT DATE Symptom Diagnostics - Noise October 2016 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change EPA07/10/ DDC-SVC-MAN-0084 GHG14 DD Platform Overhead
More informationNUMBER: 08 DDEC VI 10 S.M. REF.: 92 ENGINE: EPA07 Series 60 DATE: March 2008
NUMBER: 08 DDEC VI 10 S.M. REF.: 92 ENGINE: EPA07 Series 60 DATE: March 2008 SUBJECT: SPN 2659 PUBLICATION: DDC-SVC-MAN-0009 (6SE567) Section SPN 2659/FMI 0, refer to section 92.1 SPN 2659/FMI 17, refer
More informationSPN 609 or Suspect Parameter Number (SPN) and Failure Mode Indicator (FMI) Description
SPN 609 or 3464 Suspect Parameter Number (SPN) and Failure Mode Indicator (FMI) Description SPN FMI Description Possible Causes 609 12 Main Processor Heartbeat Synchronization Fault Intermittent or poor
More informationTwo SPNs and their FMIs have been reassigned numbers as listed in Table 1. The troubleshooting procedures are the same.
NUMBER: 07 DDEC VI 36 S.M. REF.: 129, 130 ENGINE: EPA07 Series 60 DATE: November 2007 SUBJECT: REASSIGNED SPN NUMBERS PUBLICATION: 6SE567 Two SPNs and their FMIs have been reassigned numbers as listed
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: April 2009
NUMBER: 4 11 09 S.M. REF.: Listed in Table ENGINE: EPA07 MBE 4000 DATE: April 2009 SUBJECT: SPN 2631 ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page Number(s) DDC-SVC-MAN-0010
More informationSPN 3227 or Suspect Parameter Number (SPN) and Failure Mode Indicator (FMI) Description
SPN 3227 or 3266 Suspect Parameter Number (SPN) and Failure Mode Indicator (FMI) Description SPN FMI Description Possible Causes 3227 4 EGO Bank A Sensor 2 Open or short to ground on Voltage Low signal
More informationAdditions, Revisions, or Updates
1 01 28-14 SUBJECT Symptom Diagnostics - Rough Running or Stalling - Two Filter Fuel System DATE January 2014 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084
More informationNUMBER: S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: February 2011
NUMBER: 2 15 11 S.M. REF.: Listed in Table ENGINE: EPA07 Series 60 DATE: February 2011 SUBJECT: FAULTY FUEL INJECTOR ADDITIONS, REVISIONS, OR UPDATES Publication Number Platform Section Title Change Page
More information