Affected , RX, , and RX alternators in Service Station stock should be returned to Cessna.
|
|
- Cuthbert Gardner
- 6 years ago
- Views:
Transcription
1 Single Engine Service Bulletin December 18, 2006 TITLE 60 AMPERE ALTERNATOR BRUSH REPLACEMENT EFFECTIVITY The following airplanes currently equipped with part number , RX, or RX alternator that was manufactured or overhauled on August 23, 1995 through August 17, 2004 and has 700 hours or less time in service (TIS): Model Serial Numbers 172R thru S 172S8001 thru 172S S thru T thru H thru T206H T thru T Affected , RX, , and RX alternators in Service Station stock should be returned to Cessna. REASON To transmit Kelly Aerospace Turbine Rotables Service Information Letter: Accelerated Brush Wear Series Alternators. DESCRIPTION It has been determined that alternators manufactured and/or overhauled on August 23, 1995 through August 17, 2004 may have brushes made of material that could reduce the service life of the alternator. It is recommended that these alternators be replaced. Page 1 of 4 To obtain satisfactory results, procedures specified in this publication must be accomplished in accordance with accepted methods and prevailing government regulations. Cessna Aircraft Company cannot be responsible for the quality of work performed in accomplishing the requirements of this publication. Cessna Aircraft Company, Product Support, P.O. Box 7706, Wichita, Kansas 67277, U.S.A. (316) , Facsimile (316) COPYRIGHT 2006
2 COMPLIANCE Recommended; should be accomplished at the next scheduled 100 hour/annual type inspection, not to exceed 12 months. APPROVAL FAA approval has been obtained on technical data in this publication that affects airplane type design. MANPOWER 1.0 man-hour per airplane when accomplished during a scheduled 100 hour/annual type inspection. REFERENCES Model 172 Series 1996 And On Maintenance Manual Model 182/T182 Series 1997 And On Maintenance Manual Model 206H/T206H Series 1998 And On Maintenance Manual NOTE: Make sure all publications used are complete and current. OTHER PUBLICATIONS AFFECTED Model 172R and Model 172S Illustrated Parts Catalog Model 182S/182T/T182T Illustrated Parts Catalog Model 206H/T206H Illustrated Parts Catalog NOTE: Make sure all publications used are complete and current. MATERIAL PRICE AND AVAILABILITY The following are available from Cessna Parts Distribution through an appropriate Cessna Service Station for the suggested list price shown. Part Number Description Qty/Airplane Price RX Alternator (172, 182) 1 (if required) $ (C) ea. (Plus a core deposit of $700.00) RX Alternator (206) 1 (if required) $ (C) ea. (Plus a core deposit of $700.00) ALL PRICES SUBJECT TO CHANGE WITHOUT NOTICE Page 2 December 18, 2006
3 CREDIT INFORMATION Affected , RX, , and RX alternators in Service Station stock should be returned to Cessna for credit per standard procedures. A. For airplanes that are within warranty and have an affected alternator with 700 hours or less TIS: Applicable parts credit and a labor allowance credit of 1.0 man-hour per airplane will be provided to remove and replace the affected alternator as described in this Service Bulletin. Freight will be credited at the most economical method unless pre-approved by Cessna. For pre-approval contact Cessna Parts Distribution Warranty Administration at Telephone: , Fax: or cpd2claims@cessna.textron.com. B. For airplanes that are beyond warranty and have an affected alternator with 700 hours or less TIS: Aproratedparts credit will be provided toward a remanufactured replacement alternator as follows: $ for the RX and $ for the RX. If the current installed alternator is a previous replacement alternator, a copy of the logbook entry for when the replacement alternator was installed must be included with the Warranty Claim. NOTE: Distributor/Service Station will be credited 50% of the purchase price for the replacement alternator. Shipping and replacement labor costs are not covered. To receive credit, the work must be completed and a Warranty Claim submitted by a Cessna Single Engine Service Station within 30 calendar days of Service Bulletin compliance before the credit expiration dates shown below. The removed alternator must be returned with the Warranty Claim. Domestic... December18,2007 International... December18,2007 ACCOMPLISHMENT INSTRUCTIONS Weight And Balance Information WEIGHTCHANGE... Negligible 1. Determine if the alternator is affected by review of the attached Kelly Aerospace Turbine Rotables Service Information Letter: Accelerated Brush Wear Series Alternators dated June 19, 2006 and/or applicable airplane paperwork such as logbooks and/or applicable work orders and sales/shipping receipts or by visually inspecting the alternator. A. If not affected, proceed to Step 11. B. If affected, proceed to Step Electrically ground the airplane and turn all switches to the "OFF" position. If external power is connected to the airplane, disconnect external power from receptacle. 3. Disconnect the airplane battery. (Refer to the applicable airplane model Maintenance Manual, Chapter 24, Electrical Power.) 4. Attach maintenance warning tags to the battery and external power receptacle with the following instruction: DO NOT CONNECT ELECTRICAL POWER - MAINTENANCE IN PROGRESS. 5. Remove the existing alternator from the airplane. (Refer to applicable sections of the appropriate airplane model Maintenance Manual.) 6. Remove the external capacitor from the removed alternator and install it in the same location on the replacement alternator. 7. Install the replacement alternator on the airplane. (Refer to applicable sections of the appropriate airplane model Maintenance Manual.) 8. Remove maintenance warning tags from battery and external power receptacle. December 18, 2006 Page 3
4 9. Reconnect the airplane battery. (Refer to the applicable airplane model Maintenance Manual, Chapter 24, Electrical Power.) 10. Perform an alternator operation check by verifying bus voltage of approximately 28 volts. 11. Make an entry in the airplane logbook stating compliance and method of compliance with this Service Bulletin. OWNER NOTIFICATION On January 2, 2007 the following Owner Advisory message will be sent to applicable owners of record in. Dear Cessna Owner: This Owner Advisory is to inform you that Service Bulletin has been issued to transmit Kelly Aerospace Turbine Rotables Service Information Letter: Accelerated Brush Wear Series Alternators. It has been determined that alternators manufactured and/or overhauled on August 23, 1995 through August 17, 2004 may have brushes made of material that could reduce the service life of the alternator. It is recommended that these alternators be replaced if the alternator has 700 hours or less time in Service (TIS). Your airplane is affected if it is currently equipped with a part number , RX, or RX alternator that was manufactured or overhauled on August 23, 1995 through August 17, 2004 and has 700 hours or less time in service (TIS): Compliance is recommended, should be accomplished at the next scheduled 100 hour/annual type inspection, not to exceed 12 months. The information contained in the referenced Cessna Service Bulletin shall be considered an amendment to the Cessna Manufacturer s Service/Maintenance Manual and should be accomplished within the specified time requirement. A. For airplanes that are within warranty and have an affected alternator with 700 hours or less TIS: Applicable parts credit and a labor allowance credit of 1.0 man-hour per airplane will be provided to remove and replace the alternator as described in. B. For airplanes that are beyond warranty and have an affected alternator with 700 hours or less TIS: A prorated parts credit will be provided toward a remanufactured replacement alternator as follows: $ for the RX and $ for the RX. Shipping and labor costs are not covered. To receive credit, the work must be completed and a Warranty Claim submitted by a Cessna Single Engine Service Station within 30 calendar days of Service Bulletin compliance before the credit expiration dates shown below. Domestic... December 18, 2007 International... December18,2007 Please contact a Cessna Single Engine Service Station for detailed information and arrange to have Cessna Service Bulletin accomplished on your airplane. * * * * * * * Page 4 December 18, 2006
5 Owner Advisory January 2, 2007 A Dear Cessna Owner: This Owner Advisory is to inform you that Service Bulletin has been issued to transmit Kelly Aerospace Turbine Rotables Service Information Letter: Accelerated Brush Wear Series Alternators. It has been determined that alternators manufactured and/or overhauled on August 23, 1995 through August 17, 2004 may have brushes made of material that could reduce the service life of the alternator. It is recommended that these alternators be replaced if the alternator has 700 hours or less time in Service (TIS). Your airplane is affected if it is currently equipped with a part number , RX, or RX alternator that was manufactured or overhauled on August 23, 1995 through August 17, 2004 and has 700 hours or less time in service (TIS): Compliance is recommended, should be accomplished at the next scheduled 100 hour/annual type inspection, not to exceed 12 months. The information contained in the referenced Cessna Service Bulletin shall be considered an amendment to the Cessna Manufacturer s Service/Maintenance Manual and should be accomplished within the specified time requirement. A. For airplanes that are within warranty and have an affected alternator with 700 hours or less TIS: Applicable parts credit and a labor allowance credit of 1.0 man-hour per airplane will be provided to remove and replace the alternator as described in. B. For airplanes that are beyond warranty and have an affected alternator with 700 hours or less TIS: A prorated parts credit will be provided toward a remanufactured replacement alternator as follows: $ for the RX and $ for the RX. Shipping and labor costs are not covered. To receive credit, the work must be completed and a Warranty Claim submitted by a Cessna Single Engine Service Station within 30 calendar days of Service Bulletin compliance before the credit expiration dates shown below. Domestic... December18,2007 International... December18,2007 Please contact a Cessna Single Engine Service Station for detailed information and arrange to have Cessna Service Bulletin accomplished on your airplane. * * * * * * * Page1of1 To obtain satisfactory results, procedures specified in this publication must be accomplished in accordance with accepted methods and prevailing government regulations. Cessna Aircraft Company cannot be responsible for the quality of work performed in accomplishing the requirements of this publication. Cessna Aircraft Company, Product Support, P.O. Box 7706, Wichita, Kansas 67277, U.S.A. (316) , Facsimile (316) COPYRIGHT 2006
6 Service Information Letter Issue Date: June 19, 2006 Accelerated Brush Wear Series Alternators INTRODUCTION: Kelly Aerospace Turbine Rotables recognizes that certain alternators were manufactured with brushes that historically have exhibited accelerated wear. This condition may result in premature brush exhaustion, which results in the loss of output from the alternator. On August 18, 2004, a new brush was introduced in these alternators, in order to increase the reliability. Since the introduction of the new brushes, data indicates that brush life has increased substantially. SCOPE: Series: Vendor Part Number, ASG , and ASG with Serial Numbers A through A manufactured on August 23, 1995 through August 17, Note: Vendor Part Numbers ASG , and ASG contain second-generation brushes and are not affected by this SIL. On Black and Silver data plates (New, Figure 1) the two key values required for eligibility are: 1. VENDOR P.N. = ASG or ASG AND 2. SER NO. = A thru A On Red and Silver data plates (Overhauled, Figure 2) the two key values required for eligibility are: 1. ORIGINAL MFG. = AERO ELECTRIC AND 2. S.N. = A thru A Figure 1 Figure 2 Data Plate (Black/Silver) for New Alternator Data Plate (Red/Silver) for Overhauled Alternator COMPLIANCE: Kelly Aerospace recommends that all affected units be replaced at the next 100-hour/annual inspection. Alternators with more than 700 hours of time in service are not affected by this bulletin. Page 1 of 1
Service Information Letter
Service Information Letter Open Rotor Circuit 9910591 Series Alternators Issue Date: December 20, 2006, Revision 1 Original Issue Date: November 29, 2006 INTRODUCTION: Kelly Aerospace Turbine Rotables
More informationIt has been determined that some airplanes may have a hose plug installed in the inflatable belt assembly hose end.
Single Engine Service Bulletin November 19, 2007 TITLE AMSAFE INFLATABLE RESTRAINTS HOSE PLUG INSPECTION EFFECTIVITY Group A airplanes: The following airplanes were delivered from the factory equipped
More informationThis Service Bulletin is applicable only to airplanes equipped with placards that are written in English.
Caravan Service Bulletin June 25, 2007 TITLE FUEL CAPACITY PLACARD REPLACEMENT EFFECTIVITY This Service Bulletin is applicable only to airplanes equipped with placards that are written in English. The
More informationFAA approval has been obtained on technical data in this publication that affects airplane type design.
Caravan Service Bulletin July 20, 2010 TITLE RIGHT INBOARD FLAP BELL CRANK BEARING INSPECTION / REPLACEMENT EFFECTIVITY The airplanes that follow that have had part number S3952-5 Bearing(s) installed
More informationSingle Engine. Service Bulletin TITLE ELEVATOR TRIM TAB ACTUATOR ASSEMBLY INSPECTION EFFECTIVITY. Group A airplanes: Serial Numbers
Single Engine Service Bulletin March 12, 2007 TITLE ELEVATOR TRIM TAB ACTUATOR ASSEMBLY INSPECTION EFFECTIVITY Group A airplanes: Model Serial Numbers 172R 17281353 thru 17281364, 17281369 thru 17281372
More informationSUBJECT: Single Engine Service Bulletin SB Revision 1: Cosmetic Window Repair
Revision Transmittal TO: Cessna Distributors, Single Engine Service Stations SUBJECT: Single Engine Service Bulletin Revision 1: Cosmetic Window Repair REASON FOR REVISION To revise the Compliance section
More informationSERVICE LETTER. Single Engine SEL TITLE LANDING GEAR - DRAG LINK REPLACEMENT
SERVICE LETTER TITLE LANDING GEAR - DRAG LINK REPLACEMENT EFFECTIVITY Group A Airplanes: The following airplane serial numbers were delivered with a suspect 1243600-1 Drag Link Assembly: MODEL SERIAL NUMBERS
More informationSingle Engine. Service Bulletin TITLE PILOT AND COPILOT SECONDARY SEAT STOP INSTALLATION
Single Engine Service Bulletin May 14, 2007 TITLE PILOT AND COPILOT SECONDARY SEAT STOP INSTALLATION EFFECTIVITY Model Year Serial Numbers 170 1948 18000 thru 18729 170A 1949 thru 1951 18730 thru 19400
More informationPlease replace any copy of SEB07-2 with the attached copy of SEB07-2 Revision 1 which is printed in its entirety.
Revision Transmittal May 14, 2007 TO: Cessna Distributors, Single Engine Service Stations and CPC's SUBJECT: Single Engine Service Bulletin SEB07-2 Revision 1: Engine Mount Bracket Inspection. REASON FOR
More informationNOTE: SB is a WAAS only supported build. If the autopilot is not WAAS equipped, the unlock card cannot be used at this time.
Single Engine Service Bulletin July 22, 2011 TITLE GARMIN G1000 / FLINT AERO, INC AUXILIARY FUEL GALLON REMAINING ENABLEMENT EFFECTIVITY The following airplanes equipped with the Garmin G1000 Nav III Avionics
More informationATTACHMENT DAMAGE REPORT FORM. Page: 1 of Pages Includes this cover sheet Date: (month/day/year) This form is for the: Left Wing: Right Wing: Other:
ATTACHMENT DAMAGE REPORT FORM TO: Cessna Aircraft Company Propeller Aircraft Customer Service/Dept 753 P.O. Box 7706 Wichita, Kansas 67277-7706 Phone Number: 316-517-5800 Fax Number: 316-942-9006 Page:
More informationSingle Engine. Service Bulletin TITLE ENGINE MOUNT BRACKET INSPECTION
Single Engine Service Bulletin April 16, 2007 TITLE ENGINE MOUNT BRACKET INSPECTION EFFECTIVITY Model Year Serial Numbers 172 1956 thru 1959 28000 thru 29999 172 1956 thru 1959 36000 thru 36999 172 1956
More informationATTACHMENT. Orders for the required parts listed below must be placed by using this form only. Service Station/Company Code: Company Name:
Single Engine ATTACHMENT CREW SEAT RECLINE MODIFICATION SB04-25-01 Revision 4 Orders for the required parts listed below must be placed by using this form only. NOTE: All web orders for these kits/parts
More informationSERVICE BULLETIN. COMPLIANCE MANDATORY. This service bulletin must be accomplished at the next 100-hour or 12-month (annual-type) inspection.
TITLE EQUIPMENT/FURNISHINGS - SEAT BELT BRACKET INSPECTION EFFECTIVITY MODEL SERIAL NUMBERS 120 8000 thru 15075 140 8000 thru 15075 REASON Cessna Aircraft Company wishes to update the seat belt bracket
More informationSERVICE LETTER. SERIAL NUMBERS 210 & T thru P thru P
TITLE SERVICE LETTER WINGS - LOWER MAIN SPAR CAP INSPECTION EFFECTIVITY REASON MODEL SERIAL NUMBERS 210 & T210 21058819 thru 21065009 P210 P2100001 thru P2100874 Reports have been received of cracks found
More informationSERVICE BULLETIN. Citation CIB TITLE FUEL - FIREWALL SHUTOFF VALVE GROUND IMPROVEMENT
TITLE FUEL - FIREWALL SHUTOFF VALVE GROUND IMPROVEMENT EFFECTIVITY MODEL SERIAL NUMBERS 525 (CJ1+) -0680, -0685 thru -0799 525A (CJ2+) -0417, -0439 thru -0524 525B (CJ3) -0263, -0294 thru -0414 REASON
More informationSERVICE LETTER SERIAL NUMBERS. 550/ thru -0505, thru -0733, thru -0969
TITLE FUSELAGE - DORSAL FIN VANE INSPECTION EFFECTIVITY MODEL SERIAL NUMBERS 550/551-0002 thru -0505, -0550 thru -0733, -0801 thru -0969 REASON The equivalent of this service letter has been incorporated
More informationSingle Engine MODIFICATION KIT
Single Engine MODIFICATION KIT TITLE SECURITY LOCK INSTALLATION EFFECTIVITY Model Serial Numbers 172R 17280001 and On 172S 172S8001 and On 182S 18280001 thru 18280944 182T 18280945 and On T182T T18208001
More informationSERVICE BULLETIN. This service bulletin provides parts and instructions to install fuel caps that have a locking feature.
TITLE FUEL - LOCKING FUEL CAP INSTALLATION EFFECTIVITY MODEL SERIAL NUMBERS 510 (Citation Mustang) -0001 and On NOTE: If the marketing designation for your airplane does not appear in the EFFECTIVITY section,
More informationSERVICE BULLETIN REVISION TRANSMITTAL
REVISION TRANSMITTAL This sheet transmits Revision 1 to, which: A. Rearranges the sub-steps in Step 5 for better flow. NOTE: There are no technical changes in Step 5. B. Adds Steps 6 thru 9 to the Accomplishment
More informationSERVICE LETTER REVISION TRANSMITTAL
REVISION TRANSMITTAL This sheet transmits Revision 1 to, which: A. Changes the Inspection warranty time to 0.2 from 3.0. B. Adds the note in the LABOR HOURS section. C. Adds the QR Code and internet address
More informationSERVICE BULLETIN SERIAL NUMBERS. The equivalent of this service bulletin has been incorporated on production airplanes and On.
TITLE FUSELAGE - TAILCONE GROUND RECEPTACLE INSTALLATION EFFECTIVITY MODEL SERIAL NUMBERS 560-0539 thru -0649 REASON The equivalent of this service bulletin has been incorporated on production airplanes
More informationCessna Distributors and Single Engine Authorized Service Facilities and CPC's
Revision Transmittal June 11, 2015 TO: Cessna Distributors and Single Engine Authorized Service Facilities and CPC's SUBJECT: Single Engine Service Bulletin, Pilot and Copilot Secondary Seat Stop Installation.
More informationSERVICE BULLETIN. EFFECTIVITY SERIAL NUMBERS 680 (Citation Sovereign) thru (Citation Sovereign+) thru -0549
TITLE DOORS - CABIN DOOR SUPPORT STRUT FITTING MODIFICATION EFFECTIVITY MODEL SERIAL NUMBERS 680 (Citation Sovereign) -0001 thru -0349 680 (Citation Sovereign+) -0501 thru -0549 REASON The equivalent of
More informationSERVICE BULLETIN REVISION
Revision 1 REVISION TRANSMITTAL SHEET This sheet transmits Revision 1 to, which: A. Adds a Note to the EFFECTIVITY section and Step 1 to the ACCOMPLISHMENT INSTRUCTIONS section to include a reference to
More informationSERVICE LETTER. COMPLIANCE DISCRETIONARY. This service letter should be accomplished at a scheduled Check 1, Check 2, or HSI. LABOR HOURS KEY WORD
Citation SERVICE LETTER SL525C-71-01 TITLE POWER PLANT - TRANSMITTAL OF WILLIAMS INTERNATIONAL SERVICE BULLETIN ENGINE OIL BREATHER TUBE ASSEMBLY & FRONT BYPASS DUCT RH BOSS ASSEMBLY INSTALL EFFECTIVITY
More informationSERVICE LETTER REVISION TRANSMITTAL
REVISION TRANSMITTAL TO: Cessna Distributors, Multi-Engine Authorized Service Facilities, and CPC's SUBJECT: Multi-Engine Service Letter Revision 1: Hydraulic Power Pack Inspection REASON To add a coarse-threaded
More informationSERVICE BULLETIN SB
TITLE LIGHTS - LED POSITION, TAIL POSITION, AND ANTI-COLLISION (PTA) LIGHT INSTALLATION EFFECTIVITY MODEL SERIAL NUMBERS 560 (Citation Encore) -0539 thru -0707 560 (Citation Encore+) -0751 thru -0802 NOTE:
More informationALERT SERVICE LETTER
Citation TITLE ALERT SERVICE LETTER ASL525-32-21 LANDING GEAR - TRANSMITTAL OF GOODRICH 2-1559-32-4, MAIN LANDING GEAR - BRAKE ASSEMBLY - P/N S 2-1559-1 AND 2-1559-2 - CESSNA CITATION AIRCRAFT - INTRODUCTION
More informationSERVICE BULLETIN REVISION TRANSMITTAL
REVISION TRANSMITTAL This sheet transmits Revision 1 to, which: A. Adds HDWR kit to the MATERIAL INFORMATION section. NOTE: This revision replaces the original issue of in its entirety. REVISION COMPLIANCE
More informationSERVICE BULLETIN. To prevent the wing fuel boost pump wiring from chafing on the wing structure and/or fuel tube assemblies.
TITLE FUEL - WING FUEL BOOST PUMP WIRE ROUTING IMPROVEMENT EFFECTIVITY MODEL SERIAL NUMBERS 560-0001 thru -0538 REASON To prevent the wing fuel boost pump wiring from chafing on the wing structure and/or
More informationSERVICE BULLETIN MANDATORY. SB , Rev Planning Information
SERVICE BULLETIN TITLE: STABILIZERS - INSPECTION/REPLACEMENT OF ELEVATOR BALANCE WEIGHT ASSEMBLIES SYNOPSIS OF CHANGE This Service Bulletin has been revised to add a balance weight inspection every 100
More informationSERVICE LETTER. Multi-engine TITLE NACELLES/PYLONS - NACELLE FITTING INSPECTION EFFECTIVITY
TITLE NACELLES/PYLONS - NACELLE FITTING INSPECTION EFFECTIVITY REASON MODEL 402C 414A SERIAL NUMBERS 402C0001 thru 402C1020 that have SK402-47 - Lower Front Wing Spar Cap Inspection/Modification (Original
More information201F Fuel Pump Valve Housing Cap Screw Replacement
Service Bulletin 2900 Selma Highway Montgomery, AL 36108 USA Tel: 334-386-5400 Fax: 334-386-5450 http://www.hartzell.aero 201F Fuel Pump Valve Housing Cap Screw Replacement 1. Planning Information A. Effectivity
More informationSERVICE BULLETIN. NO.: 0713 Revision C. All Garmin Aviation Service Centers and Aircraft OEM Service Centers DATE: 29 May 2007
SERVICE BULLETIN NO.: 0713 Revision C TO: All Garmin Aviation Service Centers and Aircraft OEM Service Centers DATE: 29 May 2007 SUBJECT: GSM 85 Inspection Procedure REVISION B: Revision C changes some
More informationEFFECTIVITY Serial Numbers thru , 698
Conquest TITLE AILERON HINGE BRACKET REPLACEMENT EFFECTIVITY Model Serial Numbers 441 441-0001 thru 441-0349, 698 DESCRIPTION To install stainless-steel aileron hinge brackets as a replacement for aluminum
More informationSERVICE BULLETIN SB
TITLE COMMUNICATIONS - AUTOMATIC FLIGHT INFORMATION SYSTEM (AFIS) DATA MANAGEMENT UNIT (DMU) UPGRADE EFFECTIVITY MODEL SERIAL NUMBERS 750 (Citation X) -0001 thru -0283 The equivalent of this service bulletin
More informationSERVICE BULLETIN CERTIFICATION REQUIREMENTS - FOREIGN CERTIFICATION PLACARD INSTALLATION
TITLE CERTIFICATION REQUIREMENTS - FOREIGN CERTIFICATION PLACARD INSTALLATION EFFECTIVITY MODEL UNIT NUMBERS 550-1040 NOTE: This Service Bulletin may only be accomplished at a Cessna-owned or an authorized
More informationAlert Service Bulletin
Alert Service Bulletin 2900 Selma Highway Montgomery, AL 36108 USA Tel: 334-386-5400 Fax: 334-386-5450 1. Planning Information A. Effectivity (1) All Hartzell Engine Technologies LLC (HET) turbochargers:
More information41001 thru incorporating a retrofitted LA nose strut,
Service Newsletter SNL08-15 TITLE LA71325000 NOSE STRUT ASSEMBLY SEALS REPLACEMENT TO Cessna Distributors, Service Stations MODELS AFFECTED Model 300/LC40-550FG Serial Numbers 41001 thru 40079 incorporating
More informationSERVICE BULLETIN. The equivalent of this service bulletin has been incorporated on production airplanes and On.
TITLE ICE AND RAIN PROTECTION - WING ANTI-ICE SYSTEM IMPROVEMENT EFFECTIVITY MODEL SERIAL NUMBERS 525B -0002 thru -0012 The equivalent of this service bulletin has been incorporated on production airplanes
More informationSeptember 8, Cessna Distributors, Authorized Service Facilities, CPC's, CSTARS, ASR's, and affected Owners of Record
Service Newsletter September 8, 2011 SNL11-23 TITLE P&WC PROPELLER-SHAFT OIL SEAL MODIFICATION TO Cessna Distributors, Authorized Service Facilities, CPC's, CSTARS, ASR's, and affected Owners of Record
More informationPROPELLERS - PROPELLER SLIP RING MOUNTING PLATE INSPECTION AND REPAIR
Beechcraft TITLE: PROPELLERS - PROPELLER SLIP RING MOUNTING PLATE INSPECTION AND REPAIR 1. Planning Information A. Effectivity (1) Airplanes Airplanes that have accomplished installation of Hartzell STC
More informationSERVICE BULLETIN REVISION
Revision 1 REVISION TRANSMITTAL SHEET This sheet transmits Revision 1 to. A. Adds Sheet 4 to Figure 1. B. Adds instructions to make the cutouts in the stiffener on the upper engine cowl larger. NOTE: This
More informationService Information Letter
Service Information Letter The technical content of this letter is FAA Approved Letter No. A-110B Issue Date: Dec. 20, 2004 RECOMMENDED SERVICE/INSPECTION FOR MODEL 91E93-1 & 91E92-1 HEATER FUEL PUMP REASON
More informationSERVICE LETTER. Hartzell Alert Service Bulletin No. 069, 200F, 201F, 202F Fuel Pump Leak Inspection And Diaphragm
Single Engine SERVICE LETTER SEL-73-06 TITLE ENGINE FUEL AND CONTROL - TRANSMITTAL OF HARTZELL ALERT SERVICE BULLETIN NO. 069, 200F, 201F, 202F FUEL PUMP LEAK INSPECTION AND DIAPHRAGM REPLACEMENT EFFECTIVITY
More informationSERVICE LETTER TITLE EXHAUST - TRANSMITTAL OF LYCOMING SERVICE BULLETIN NO 627C, EXHAUST SYSTEM INSPECTION SERIAL NUMBERS
Single Engine MANDATORY SERVICE LETTER SEL-78-03 TITLE EXHAUST - TRANSMITTAL OF LYCOMING SERVICE BULLETIN NO 627C, EXHAUST SYSTEM INSPECTION EFFECTIVITY REASON MODEL T206H SERIAL NUMBERS T20608001 and
More informationSERVICE BULLETIN. The equivalent of this service bulletin has been incorporated on production airplanes and On. REASON
Citation TITLE SERVICE BULLETIN SB560XL-73-02 ENGINE FUEL AND CONTROL - TRANSMITTAL OF PRATT & WHITNEY CANADA SERVICE BULLETIN PW500-72-30290 TURBOFAN ENGINE HYDROMECHANICAL FUEL CONTROL - REPLACEMENT/MODIFICATION
More information201F Fuel Pump Valve Assembly Leakage
2900 Selma Highway Montgomery, AL 36108 USA Tel: 334-386-5400 Fax: 334-386-5450 201F Fuel Pump Valve Assembly Leakage 1. Planning Information A. Effectivity (1) Hartzell Engine Technologies LLC (HET) 201F
More informationThe parts that follow are available from Cessna Parts Distribution through an appropriate Cessna Service Station.
Service Newsletter June 15, 2010 TITLE MECHANICAL AIR CONDITIONER COMPRESSOR DRIVER SHEAVE / PULLEY ALIGNMENT TO Cessna Distributors and Single Engine Service Stations MODELS AFFECTED The following airplanes
More informationThe engine cowling installation and firewall should be inspected and modified as specified in this Service Bulletin.
Single Engine Service Bulletin August 25, 2008 TITLE ENGINE COWLING ALIGNMENT INSPECTION AND MODIFICATION EFFECTIVITY Model Serial Numbers 172R 17280001 thru 17280724 172S 172S8001 thru 172S8201 REASON
More informationFAA approval has been obtained on technical data in this publication that affects airplane type design.
Single Engine Service Bulletin January 28, 2008 TITLE ENGINE COWLING ALIGNMENT INSPECTION AND MODIFICATION EFFECTIVITY Model Serial Numbers 172R 17280725 thru 17281262 172S 172S8202 thru 172S10006 REASON
More informationSNS SUBJECT: NOSE GEAR - Nose Landing Gear Assembly Inspection and Reinforcement
CIRRUS SR22 Service Bulletin Number: Issued: SNS SUBJECT: 32-20 NOSE GEAR - Nose Landing Gear Assembly Inspection and Reinforcement 1. COMPLIANCE Mandatory: Cirrus Design considers this Service Bulletin
More informationSingle Engine Service Bulletin SEB08-4 Revision 1, Unision Industries SLICK 4200/4300/6200/6300 Magnetos Inspection.
Revision Transmittal April 27, 2009 TO: Cessna Distributors, Single Engine Service Stations and CPC's SUBJECT: Single Engine Service Bulletin SEB08-4 Revision 1, Unision Industries SLICK 4200/4300/6200/6300
More informationSERVICE BULLETIN TITLE ENGINE CONTROLS - FULL AUTHORITY DIGITAL ENGINE CONTROL (FADEC) SOFTWARE UPGRADE VERSION C10
Citation SB750-76-12 TITLE ENGINE CONTROLS - FULL AUTHORITY DIGITAL ENGINE CONTROL (FADEC) SOFTWARE UPGRADE VERSION C10 EFFECTIVITY REASON MODEL SERIAL NUMBERS 750 (Citation X) -0001 thru -0313 NOTE: Airplanes
More informationSERVICE BULLETIN. To prevent the wing fuel boost pump wiring from chafing on the wing structure and/or fuel tube assemblies.
TITLE FUEL - WING FUEL BOOST PUMP WIRE ROUTING IMPROVEMENT EFFECTIVITY MODEL UNIT NUMBERS 500/501-0001 thru -0689 REASON To prevent the wing fuel boost pump wiring from chafing on the wing structure and/or
More information201F Fuel Pump Shaft Seal Leak
2900 Selma Highway Montgomery, AL 36108 USA Tel: 334-386-5400 Fax: 334-386-5450 201F Fuel Pump Shaft Seal Leak 1. Planning Information A. Effectivity* (1) Hartzell Engine Technologies LLC (HET) 201F Series
More informationSERVICE BULLETIN SB
TITLE LIGHTS - LED TAIL POSITION LIGHT INSTALLATION EFFECTIVITY MODEL UNIT NUMBERS 500 (Citation) -0001 thru -0349 with SB500-33-07 incorporated 500 (Citation I) -0350 thru -0528 with SB500-33-07 incorporated,
More informationCIRRUS SR2X SB 2X Service Bulletin. Issued: February 27, SNS SUBJECT: TEMPERATURE CONTROL - Cabin Air Coupler Actuator Rigging
CIRRUS SR2X Service Bulletin Number: Issued: February 27, 2012 SNS SUBJECT: 21-60 TEMPERATURE CONTROL - Cabin Air Coupler Actuator Rigging 1. COMPLIANCE Recommended, On Condition: Accomplish this Service
More informationService Bulletin. Service Bulletin No. 064 Alternator Model ALV-9610 Series Through Bolt Inspection for Proper Torque
2900 Selma Highway Montgomery, AL 36108 USA Tel: 334-386-5400 Fax: 334-386-5450 http://www.hartzell.aero Service Bulletin Alternator Model ALV-9610 Series Through Bolt Inspection for Proper Torque 1. Planning
More informationSUBJECT: ELECTRICAL POWER SYSTEM UNIT AND ROTORCRAFT FLIGHT MANUAL TEMPORARY REVISION, CANCELLATION OF
MODEL AFFECTED: 505 ALERT SERVICE BULLETIN 505-17-03 PSL 7000000247 28 November 2017 Revision A, 14 February 2018 Revision B, 6 March 2018 Revision C, 18 September 2018 SUBJECT: ELECTRICAL POWER SYSTEM
More informationRevision Transmittal Sheet
2 APPROVED WHITE IN LEARJET 31 RT 31-32-24 Revision Transmittal Sheet This page transmits Revision 1 to No. 31-32-24, Main Landing Gear Torque Link Replacement. Rework: No rework is required for aircraft
More informationSERVICE BULLETIN REVISION
Revision 7 REVISION TRANSMITTAL SHEET This sheet transmits Revision 7 to Service Bulletin. A. Replaces the AN960PD10L Washers with NAS1149D0316K Washers. B. Removes the optional Aviation Brake System antiskid
More informationSERVICE KIT. TITLE McCAULEY 2A34C203/90DCA-2 TWO BLADED THREADLESS PROPELLER INSTALLATION
TITLE McCAULEY 2A34C203/90DCA-2 TWO BLADED THREADLESS PROPELLER INSTALLATION EFFECTIVITY: The following airplanes that are in a landplane, ski plane, seaplane, or amphibian configuration. MODEL SERIAL
More informationCessna Aircraft Company: Amendment ; Docket No. FAA ; Directorate Identifier 2012-NM-020-AD.
2013-09-11 Cessna Aircraft Company: Amendment 39-17453; Docket No. FAA-2012-1001; Directorate Identifier 2012-NM-020-AD. (a) Effective Date. This AD is effective July 5, 2013. (b) Affected ADs None. (c)
More informationCIRRUS SR2X SB 2X R2. Service Bulletin. Issued: Revised: June 26, 2012 July 31, 2012
CIRRUS SR2X Service Bulletin Number: Issued: Revised: June 26, 2012 SNS SUBJECT: 57-40 ATTACH FITTINGS - Lower Landing Gear Attach Bracket Torque 1. COMPLIANCE Mandatory: Cirrus Design considers this Service
More informationALERT SERVICE LETTER ASL
Citation TITLE ALERT SERVICE LETTER ASL550-72-29 ENGINE - TRANSMITTAL OF P&WC SERVICE DOCUMENTS - INTERCOMPRESSOR BLEED VALVE/SERVO-VALVE-INSPECTION/REPLACEMENT OF EFFECTIVITY MODEL SERIAL NUMBERS 550
More informationMODIFICATION KIT. Serial Numbers 300 (LC40-550FG) thru (LC42-550FG) thru (LC41-550FG) thru
Single Engine MODIFICATION KIT MK400-71-01 TITLE ENGINE OIL COOLER WINTERIZATION MODIFICATION EFFECTIVITY Model Serial Numbers 300 (LC40-550FG) 40004 thru 40079 350 (LC42-550FG) 42001 thru 421018 400 (LC41-550FG)
More informationFOR THE MOST RECENT REVISION LEVEL OF THIS SERVICE BULLETIN.
2900 Selma Highway Montgomery, AL 36108 USA Tel: 334-386-5400 Fax: 334-386-5450 SERVICE BULLETIN 1. Planning Information A. Effectivity (1) Plane-Power Jasco series alternators manufactured by Hartzell
More informationALERT SERVICE BULLETIN PSL September 2015 Revision A, 6 October 2017
MODEL AFFECTED: 212 ALERT SERVICE BULLETIN 212-15-155 PSL 7000000123 15 September 2015 Revision A, 6 October 2017 SUBJECT: FUEL CHECK VALVE 209-062-607-001, INSPECTION AND REPLACEMENT OF HELICOPTERS AFFECTED:
More informationALERT SERVICE BULLETIN
2900 Selma Highway Montgomery, AL 36108 USA Tel: 334-386-5400 Fax: 334-386-5450 ALERT SERVICE BULLETIN Alert Service Bulletin No. 074 1. Planning Information A. Effectivity (1) Aeroforce turbocharger center
More informationSERVICE LETTER. Model 1A162 Propeller, and the McCauley Fixed Pitch Propeller Service Manual.
September 4, 2009 TITLE MODEL 1A162/TCD6754 PROPELLER SERVICE INFORMATION UPDATE TO: FAA-Approved Propeller Repair Stations, Aircraft Manufacturers, Owners and Operators EFFECTIVITY Model 1A162 Propeller,
More informationMANDATORY SERVICE BULLETIN
CONTINENTAL MOTORS AIRCRAFT ENGINE MANDATORY SERVICE BULLETIN The Subject Matter Of The Service Bulletin Is Incorporated In Whole Or In Part In An FAA Issued Airworthiness Directive CATEGORY 1 TECHNICAL
More informationSUBJECT: FUEL FITTING P/N AND , VERIFICATION OF.
ALERT SERVICE BULLETIN 212-18-159 13 September 2018 MODEL AFFECTED: 212 SUBJECT: FUEL FITTING P/N 50-040-1 AND 50-040-3, VERIFICATION OF. HELICOPTERS AFFECTED: Serial numbers 30502 through 30603, 30611
More informationTable 1: Alternator Models ES (CMI ), ALX-9524 (CMI ), ALX-9524R, & ALV-9610 Affected Serial Numbers
2900 Selma Highway Montgomery, AL 36108 USA Tel: 334-386-5400 Fax: 334-386-5450 Service Bulletin Alternator Inspection for Burrs in the Rotor Shaft Hex Key Socket 1. Planning Information A. Effectivity
More informationKELLY AEROSPACE POWER SYSTEMS
Page 1 2008-08-17 KELLY AEROSPACE POWER SYSTEMS Amendment 39-15471 Docket No. FAA-2008-0314; Directorate Identifier 2008-NE-09-AD PREAMBLE Effective Date (a) This airworthiness directive (AD) becomes effective
More informationSERVICE BULLETIN THIS BULLETIN IS FAA APPROVED FOR ENGINEERING DESIGN
MOONEY AIRPLANE COMPANY, INC. SERVICE BULLETIN Louis Schreiner Field Kerrville, Texas 78028 DATE: October 30, 2003 THIS BULLETIN IS FAA APPROVED FOR ENGINEERING DESIGN SERVICE BULLETIN M20-282 DATE: October
More information[Docket No. FAA ; Directorate Identifier 2008-NE-09-AD; Amendment ; AD ]
[Federal Register: April 21, 2008 (Volume 73, Number 77)] [Rules and Regulations] [Page 21222-21225] From the Federal Register Online via GPO Access [wais.access.gpo.gov] [DOCID:fr21ap08-3] DEPARTMENT
More informationAirworthiness Directive
Airworthiness Directive Federal Register Information Header Information DEPARTMENT OF TRANSPORTATION Federal Aviation Administration 14 CFR Part 39 [62 FR 40262 NO. 144 07/28/97] [Docket No. 97-ANE-26-AD;
More informationROLLS-ROYCE CORPORATION (FORMERLY ALLISON ENGINE COMPANY)
Page 1 2010-19-01 ROLLS-ROYCE CORPORATION (FORMERLY ALLISON ENGINE COMPANY) Amendment 39-16429 Docket No. FAA-2009-0811; Directorate Identifier 2008-NE-41-AD PREAMBLE Effective Date (a) This airworthiness
More informationG600 PFD/MFD System Instructions for Continued Airworthiness as installed in
Instructions for Continued Airworthiness as installed in (Make and Model Airplane) Reg. No. S/N Dwg. Number: 190-00601-00 Rev. A Garmin Ltd. Or its subsidiaries c/o Garmin International, Inc. 1200 E. 151st
More informationThe Subject Matter Of This Service Bulletin Is Incorporated In Whole Or In Part In An FAA Issued Airworthiness Directive
TELEDYNE CONTINENTAL AIRCRAFT ENGINE MANDATORY SERVICE BULLETIN The Subject Matter Of This Service Bulletin Is Incorporated In Whole Or In Part In An FAA Issued Airworthiness Directive Category 1 MSB08-5
More informationDEPARTMENT OF TRANSPORTATION
DEPARTMENT OF TRANSPORTATION Federal Aviation Administration 14 CFR Part 39 [62 FR 40262 No. 144; 07/28/97][SN] [Docket No. 97-ANE-26-AD; Amendment 39-10085; AD 97-15-11] RIN 2120-AA64 Avco Lycoming /
More informationCRITICAL SERVICE BULLETIN Compliance Necessary to Maintain Safety
TELEDYNE CONTINENTAL AIRCRAFT ENGINE CRITICAL SERVICE BULLETIN Compliance Necessary to Maintain Safety CATEGORY 2 CSB04-6 TECHNICAL PORTIONS FAA APPROVED SUBJECT: INSPECTION OF TSIO-550 AND TSIOL-550 ENGINES
More information[Docket No. FAA ; Directorate Identifier 2008-SW-44-AD; Amendment ; AD ]
[Federal Register: June 12, 2009 (Volume 74, Number 112)] [Rules and Regulations] [Page 27915-27917] From the Federal Register Online via GPO Access [wais.access.gpo.gov] [DOCID:fr12jn09-6] DEPARTMENT
More informationThe following information is for planning purposes only: Estimated man-hours: 10 hours. Suggested number of men: 1 man. Estimated man-hours: 8 hours.
CLASS I SERVICE INSTRUCTIONS 76 SUBJECT: EFFECTIVITY: No. 1054 ATA Code 28-20 FUEL -, INSTALLATION OF A CHECK VALVE ON THE FUEL TANK OUTLET;, INSTALLATION OF AN IMPROVED FUEL SELECTOR VALVE BEECHCRAFT
More informationService Bulletin. ATA 52-10: Passenger and Crew Doors Door Latching Assembly Upgrade
Service Bulletin Issued: 5 Oct 00 Models SR0 and SR ATA 5-10: Passenger and Crew Doors Door Latching Assembly Upgrade COMPLIANCE Optional: Accomplishment of this Service Bulletin is at the owner s option.
More informationREASON FOR REVISION: To clarify effectivity by including RAM P/N cross reference. INTRODUCTION:
Service Bulletin Compliance is Considered Mandatory The technical content of this letter is FAA Approved Bulletin No. 030 Rev. A Issue Date: April 1, 2008 TURBOCHARGER EXHAUST FLANGE INSPECTION AND/OR
More informationCESSNA AIRCRAFT COMPANY
Page 1 2011-06-02 CESSNA AIRCRAFT COMPANY Amendment 39-16626 Docket No. FAA-2010-1243; Directorate Identifier 2010-CE-058-AD PREAMBLE Effective Date (a) This AD is effective May 26, 2011. Affected ADs
More informationSERVICE BULLETIN REVISION TRANSMITTAL
REVISION TRANSMITTAL This sheet transmits Revision 2 to, which: A. Adds the CI401-460 GPS Antenna to Step 10A and Step 10B. B. Adds the CI401-460 GPS Antenna to Figure 5. C. Adds the CI401-460 GPS Antenna
More information[Docket No. FAA ; Directorate Identifier 2010-CE-058-AD; Amendment ; AD ]
[Federal Register Volume 76, Number 77 (Thursday, April 21, 2011)] [Rules and Regulations] [Pages 22298-22301] From the Federal Register Online via the Government Printing Office [www.gpo.gov] [FR Doc
More informationSERVICE INFORMATION LETTER Page: 1 of 2
SERVICE INFORMATION LETTER Page: 1 of 2 19 Oct 10 NOTE: SERVICE INFORMATION LETTER NO. SIL20A1-006 Service Information Letters are used only: 1. To distribute information from Diamond Aircraft Industries
More informationSERVICE BULLETIN REVISION TRANSMITTAL
REVISION TRANSMITTAL This sheet transmits Revision 2 to, which: A. Adds the reference to Figure 7, Sheet 1 and Sheet 2 to Step 10D. B. Adds Step 10D(7). C. Removes the After Modification view for PN343
More informationSERVICE LETTER. REASON To incorporate new software changes to the engine electronic control and engine diagnostics unit.
Citation SERVICE LETTER SL680-76-02 TITLE ENGINE CONTROLS - TRANSMITTAL OF PRATT AND WHITNEY CANADA, ELECTRONIC ENGINE CONTROL AND ENGINE DIAGNOSTICS UNIT - REPLACEMENT/MODIFICATION EFFECTIVITY MODEL SERIAL
More informationService Bulletin. ATA 27-00: Flight Controls Rudder-Aileron Interconnect Modification
Service Bulletin Issued: 09 May 2007 Models SR20 and SR22 ATA 27-00: Flight Controls Rudder-Aileron Interconnect Modification COMPLIANCE Mandatory: Accomplish this Service Bulletin within 25 Flight Hours
More informationSERVICE BULLETIN. Citation SB TITLE DOORS - WIDE DOOR INSTALLATION MODIFICATION
TITLE DOORS - WIDE DOOR INSTALLATION MODIFICATION EFFECTIVITY MODEL SERIAL NUMBERS 560 (Citation Encore) -0539 thru -0707 560 (Citation Encore+) -0751 thru -0815 NOTE: This modification may only be accomplished
More informationPRATT AND WHITNEY CANADA CORP.
Page 1 2010-17-06 PRATT AND WHITNEY CANADA CORP. (FORMERLY PRATT & WHITNEY CANADA, INC.) Amendment 39-16398 Docket No. FAA-2010-0245; DIRECTORATE IDENTIFIER 2010-NE-15-AD. PREAMBLE Effective Date (a) This
More informationALERT SERVICE BULLETIN NO.
DATE REV ALERT SERVICE BULLETIN NO. DATE PAGE 210-10-07 Dec 10, 2010 1 of 9 MODEL AFFECTED: 210 SUBJECT: ELEVATOR AND DIRECTIONAL FLIGHT CONTROL BEARINGS P/N MS27643-4; INSPECTION AND REPLACEMENT OF. HELICOPTERS
More informationLYCOMING ENGINES AND TELEDYNE CONTINENTAL MOTORS
Page 1 011-13-03 LYCOMING ENGINES AND TELEDYNE CONTINENTAL MOTORS (TYPE CERTIFICATE PREVIOUSLY HELD BY TEXTRON LYCOMING) AND TELEDYNE CONTINENTAL MOTORS (TCM) TURBOCHARGED RECIPROCATING ENGINES Amendment
More information[Docket No. FAA ; Directorate Identifier 2010-CE-058-AD; Amendment ; AD ]
[Federal Register Volume 76, Number 91 (Wednesday, May 11, 2011)] [Rules and Regulations] [Page 27239] From the Federal Register Online via the Government Printing Office [www.gpo.gov] [FR Doc No: 2011-11260]
More information