VERY LOW TEMPERATURE, CONDENSING, PRESSURIZED BOILER. From 69 kw Output (67 kw Input) to 1550 kw Output (1520 kw Input)
|
|
- Christian Kelley
- 5 years ago
- Views:
Transcription
1 (oil/gas) RY LOW TEPERATURE, CONDENSIN, PRESSURIZED BOILER OUTPUT RANE From 69 kw Output (67 kw Input) to 1550 kw Output (1520 kw Input) OPERATION TEPERATURE no limit on the return temperature SUPPLY ODELS Pressure jet oil burner, in version two stage, two stage progressive and modulating, biodiesel or dual fuel (gas / oil) ENERETIC CLASS according to ex Dir. 92/42/EC Large water content special smoke pipes in AISI 316L, with inserts and turbulators in AISI 304
2 Stainless steel condensing boilers AIN COPONENTS 1. Furnace 2. Smoke pipes with smoke diverters 3. Door with flame sight glass 4. Smoke chamber 5. Body insulation 6. Panel board Flow Low temperature return igh temperature return (Burner isn t supplied with) PLUS PRODOTTO EFFICIENCY 102% at full load 104% at part load in condensation mode COBUSTION CABER in stainless steel AISI 316L, entirely water cooled, above the tube bundle, so that the assembly could form a structure apt to favour the thermal exchange and the evacuation of the condensate. WATER RUN guided and braked inside the body Special progressive and PATENTED SOKE PIPES in stainless steel AISI 316L with, inside, 6 special sectorial pipes and turbulators in AISI 304, that guarantee a very high heat exchange and resistance to the condensate. Tube bundle slightly inclined towards the smoke chamber in order: - to let the condensate to be collected over there - to avoid the acidic wet deposits remain in the pipes - to clean, thanks to the gravity, the exchange surfaces OPTIU QUIETNESS of operation thanks to the low counterpressure in the smoke side FRONT DOOR IN STEEL with insulation in special superlight refractory cement (able to reduce more than 30% the heat losses by radiation) C.. Flow connection placed on the rear upper part and two return connections, for low and high temperature, in the lower part. For models 69 and 100 the Flow and Return connections are towards the back side; for models 250 to 1550 Flow and Return connections are towards the upper side (as shown in the picture) The high temperature return connection is placed so that it doesn t interfere with the low temperature return connection The low temperature return connection is placed on the extension of the lower outer shell to that it can exploit at the maximum the heat recover ADJUSTABLE DOOR with reversible opening (from R side or from L side: standard execution with the hinges on the L side) CONTROL PANEL BOARD with electronic thermoregulation E8, that allows the control of modulating burners PRESETTIN FOR CASCADE OPERATION up to 8 boilers, with an additional optional E8 Easy installation of the burner through burner supporting plate, predrilled on request Two bulb holders ½, with internal dia. 15 mm for temperature sensors and thermostat bulbs (3 bulbs each) REAR SOKE CABER in stainless steel AISI 304, with connection for condensate drain RY STRON INSULATION of the boiler body in fabric-finish mineral wool, 100 mm thick CONSTRUCTION according to EN CLEANIN AND SERVICIN made easy by the self-drain of the condensate in the smoke pipes, inclined towards the smoke chamber LIFTIN OOKS for transport and handling Option: Acidic condensate inhibitor, specific for oil - 2 -
3 Stainless steel condensing boilers DIENSIONS A F B E I L D 1 2 T1 T4 T4 T C T2 T2 3 N O P Q R S A F I B L T2 - T 3 T1 T4 N E T2 - T 1 - T 4 O D 1 2 C 3 P Q R S 1 Panel board 2 Flame sight glass T1 C.. flow T2 Low temperature C.. return T4 igh temperature C.. return Expansion vessel connection Boiler drain Burner connection Chimney connection Condensation drain ax Temperature allowable Boiler capacity aximum operating pressure boiler Weight CONNECTIONS T1 - T2 T4 ISO 7/1 ISO 7/1 Ø Øi Øe C l bar kg UNI 2276 PN6 UNI 2276 PN6 ISO 7/1 ISO 7/1 mm mm mm Rp 2 Rp 2 Rp ¼ Rp ¼ Rp 2 Rp 2 Rp ¼ Rp ¾ DN 65 DN 65 Rp 1 ½ Rp ¾ DN 80 DN 80 Rp 2 Rp DN 80 DN 80 Rp 2 Rp DN 100 DN 100 Rp 2 Rp DN 100 DN 100 Rp 2 Rp A B C D E F I L N O P Q* R* S mm mm mm mm mm mm mm mm mm mm mm mm mm mm mm mm mm * * * * * (*) inimum dimensions for boiler room access
4 Stainless steel condensing boilers DIENSIONS A F I B L T 2 - T 3 T 1 T 4 N E T 2 - T 1 - T 4 T 3 O D 1 2 T 6 T 6 C T 7 3 P T 5 T 5 Q T 8 R S T 8 1 Panel board 2 Flame sight glass T1 C.. flow T2 Low temperature C.. return T4 igh temperature C.. return Expansion vessel connection Boiler drain Burner connection Chimney connection Condensation drain ax Temperature allowable Boiler capacity aximum operating pressure boiler Weight CONNECTIONS T1 - T2 T4 Ø C l bar kg UNI 2276 PN6 UNI 2276 PN6 UNI 2276 PN6 ISO 7/1 mm mm mm DN 125 DN 125 DN 65 Rp DN 125 DN 125 DN 65 Rp DN 150 DN 150 DN 80 Rp 1 ½ DN 150 DN 150 DN 80 Rp 1 ½ DN 200 DN 200 DN 100 Rp 1 ½ DN 200 DN 200 DN 100 Rp 1 ½ Øi Øe A B C D E F I L N O P* Q* R* S mm mm mm mm mm mm mm mm mm mm mm mm mm mm mm mm mm (*) inimum dimensions for boiler room access. BURNER EAD TUBE DIENSIONS BOILER TYPE øa mm L mm
5 Stainless steel condensing boilers TYPE AND SAPE OF FURNACE boilers are equipped with a blind cylindrical furnace, in which the central flame of the burner is reversed peripherally towards the front. When the combustion gases have reached the front part, they are sent through the door into the tubes of the third pass to reach the rear flue gas chamber and then the chimney. DETAIL OF TE OUTER SELL Flow Low temperature return igh temperature return The combustion chamber is always pressurised while the burner is operating, within the power range of the boiler. The chimney must be calculated so that no positive pressure is detected at its base. SPECIAL SOKE PIPES (patented) Smoke pipes made in stainless steel AISI 316L, completely rolled on the six internal 60 sectorial pipes in AISI 304, with turbulators in AISI 304, assuring very high thermal exchange and resistance to the acidic condensate. The tube bundle is slightly inclined towards the smoke chamber, in order: - to let the condensate to be collected over there - to avoid the acidic wet deposits remain in the pipes - to clean, thanks to the gravity, the exchange surfaces. Smoking section tubes with placed turbulators Place on the edge of smoke turbolator Note: Smoke turbolator are long as flue pipe - 5 -
6 Stainless steel condensing boilers BASIC SCEES OF SYSTE OPERATION EXTERNAL PROBE (AF) CONTROL PANEL KF 1 direct high temperature zone + 1 low temperature zone controlled by a motorised mixer valve + domestic hot water production KF1 Pz1 Pb IR/AT SPF Pz2 VF Vmix2 Ps IR/BT Key: Vmix2 Pz1 Pz2 IR/AT IR/BT Ps Pb SPF KF KF 1 VF AF flow I temperature return LOW temperature return zone mixer valve (motorised) I TEPERATURE zone heating system pump LOW TEPERATURE zone heating system pump expansion vessel I TEPERATURE heating system distribution LOW TEPERATURE heating system distribution DW recirculation pump DW production charge pump storage tank probe E heat control boiler probe Lago Basic 0201 RV 1 heat control boiler probe flow probe external probe BOILER D..W. PRODUCER BASIC SCEES OF SYSTE OPERATION WIT BOILERS IN BATTERY 2 boilers in cascade serving 1 high temperature zone + 1 low temperature zone controlled by a motorised mixer valve + domestic hot water production. EXTERNAL PROBE (AF) CONTROL PANEL CONTROL PANEL IR/AT IR/BT Pz1 Pz2 VF Vmix2 P1 P1 KF SPF Pb KF1 KF1 Ps BOILER 1 BOILER 2 ENTUAL WATER SEPARATOR FOR TE PERFECT BALANCE OF D..W. PRODUCER YDRAULIC SYSTE Key: Vmix2 Pz1 Pz2 IR/AT flow I temperature return (NOT USED) LOW temperature return zone mixer valve (motorised) I TEPERATURE zone heating system pump LOW TEPERATURE zone heating system pump expansion vessel I TEPERATURE heating system distribution IR/BT Ps P1 Pb SPF KF KF 1 VF AF LOW TEPERATURE heating system distribution DW recirculation pump circulation pump DW production charge pump storage tank probe E heat control boiler probe Lago Basic 0201 RV 1 heat control boiler probe flow probe external probe Note: the references of these and further schemes are better described in the installation manuals that can be unloaded from the web site
7 Stainless steel condensing boilers TECNICAL DATA ELECTRICAL, YDRAULIC, INSTALLATION DIARAS AND CONTROLLERS can be unloaded from the web site at the page of the product (oil fired) Nominal heat output (80-60 C) kw Nominal heat output (50-30 C) kw Nominal eat input kw eat efficiency full load (80-60 C) % eat efficiency full load (50-30 C) % eat efficiency partial load 30% (retourn 30 C) % Flue gas temperature 80 C - 60 C (Tf - Ta) C Flue gas temperature 50 C-30 C (Tf - Ta) C CO 2 content % Flue gas mass kg/h Combustion Efficiency 80 C-60 C % Combustion Efficiency 50 C-30 C % eat loss at shell C % eat loss at shell C % eat loss at chimney with burner ON C % eat loss at chimney with burner ON C % eat loss at chimney with burner OFF % aximum condensation production l/h aximum boiler pressure from standard mm c.a Boiler pressure mm c.a ead losses 2 0 Dt 15 kpa CO (0% O 2 ) mg/kwh (gas fired) Nominal heat output (80-60 C) kw Nominal heat output (50-30 C) kw Nominal eat input kw eat efficiency full load (80-60 C) % eat efficiency full load (50-30 C) % eat efficiency partial load 30% (retourn 30 C) % Flue gas temperature 80 C - 60 C (Tf - Ta) C Flue gas temperature 50 C-30 C (Tf - Ta) C CO 2 content % Flue gas mass kg/h Combustion Efficiency 80 C-60 C % Combustion Efficiency 50 C-30 C % eat loss at shell C % eat loss at shell C % eat loss at chimney with burner ON C % eat loss at chimney with burner ON C % eat loss at chimney with burner OFF % aximum condensation production l/h aximum boiler pressure from standard mm c.a Boiler pressure mm c.a ead losses 2 0 Dt 15 kpa CO (0% O 2 ) mg/kwh
8 Stainless steel condensing boilers TECNICAL DATA ACCORDIN TO ErP DIRECTI ELECTRICAL, YDRAULIC, INSTALLATION DIARAS AND CONTROLLERS can be unloaded from the web site at the page of the product (oil fired) EFFECTI NOINAL OUTPUT P n kw SEASONAL ENERY EFFICIENCY TO EAT TE ROO η s % SEASON EFFICIENCY CLASS TO DISCARE A A A A A A A FOR BOILERS TO EAT TE ROO AND IXED BOILERS: USEFUL EAT OUTPUT USEFUL EAT OUTPUT with high temperature capacity (Tr 60 C / Tm 80 C) RATED EAT OUTPUT EFFICIENCY with high temperature capacity (Tr 60 C / Tm 80 C) USEFUL POWER AT 30% OF TE RATED EAT OUTPUT with low temperature capacity (Tr 30 C) PERFORANCE AT 30% OF TE RATED EAT OUTPUT with low temperature capacity (Tr 30 C) P 4 kw η 4 % P 1 kw η 1 % BOILER WIT OUTPUT RANE ADJUSTENT: YES / NO NO NO NO NO NO NO NO AUXILIARY ELECTRICITY CONSUPTION WIT A FULL LOAD el max kw WIT A PARTIAL LOAD el min kw STANDBY ODE P SB kw OTER ELEENTS EAT DISPERSION ON STANDBY P stby kw NITROEN OXIDES EISSIONS NO x mg/kwh The models with an Output higher than 400 kw are not covered by the Directive 2009/125/CE (gas fired) EFFECTI NOINAL OUTPUT P n kw SEASONAL ENERY EFFICIENCY TO EAT TE ROO η s % SEASON EFFICIENCY CLASS TO DISCARE A A A A A A A FOR BOILERS TO EAT TE ROO AND IXED BOILERS: USEFUL EAT OUTPUT USEFUL EAT OUTPUT with high temperature capacity (Tr 60 C / Tm 80 C) RATED EAT OUTPUT EFFICIENCY with high temperature capacity (Tr 60 C / Tm 80 C) USEFUL POWER AT 30% OF TE RATED EAT OUTPUT with low temperature capacity (Tr 30 C) PERFORANCE AT 30% OF TE RATED EAT OUTPUT with low temperature capacity (Tr 30 C) P 4 kw η 4 % P 1 kw η 1 % BOILER WIT OUTPUT RANE ADJUSTENT: YES / NO NO NO NO NO NO NO NO AUXILIARY ELECTRICITY CONSUPTION WIT A FULL LOAD el max kw WIT A PARTIAL LOAD el min kw STANDBY ODE P SB kw OTER ELEENTS EAT DISPERSION ON STANDBY P stby kw NITROEN OXIDES EISSIONS NO x mg/kwh The models with an Output higher than 400 kw are not covered by the Directive 2009/125/CE - 8 -
PRESSURIZED STEEL BOILER WITH REVERSED FLAME
smoke pipes PRESSURIZED STEEL BOILER WITH REVERSED FLAME OUTPUT RANGE from 340 to 7000 WORKING TEMPERATURE minimum return temperature 55 OPERATION WITH gas or oil fired jet burners MODELS 340 420 510 630
More informationavailable in battery up to 4 units for a total of 560 kw
MODULATING CONDENSING BOILER with double premix low NOx burner and double heat exchanger EXPANDABLE IN BATTERY for indoor and outdoor installations (IPX5D) OUTPUT RANGE from 10 to 560 kw (in battery) WORKING
More informationM K. MK is a pressurized steel boiler for heating system with hot water production up 90 C. High efficiency
M K MK is a pressurized steel boiler for heating system with hot water production up 90 C. High efficiency Gas/ gas oil working Output from 44 to 291,7 (from 37.840 to 250.862 of water efficiency). Pipe
More informationINDUSTRIAL GENERATORS. steam or overheated water 97/23/CE - P.E.D. certified
05-0514 INDUSTRIAL GENERATORS steam or overheated water 97/23/CE - P.E.D. certified TECHNIQUE, COMPETENCE, EXPERIENCE OR INDUSTRY The steam and overheated water production cost is a decisive factor for
More informationPower HT kw. Outputs from 115 to 320 kw
Power T -0 kw luminium-silicon exchanger with glass wool insulation: high efficiency and reliability and long life Low emissions pre-mixing burner Digital control panel with back-lighted LCD display and
More informationSTAINLESS STEEL CONDENSING GENERATOR RANGE RATED. MODEL Heat thermal input 65,5. 62,0 Heat output (80 C/60 C) 14,0
QUADRIFOGLIO B STAINLESS STEEL CONDENSING GENERATOR > PRODUCT PLUSES: - Steel vertical module with low thermal load, huge water content - The exchanger in stainless steel AISI 31 Ti consists in a tubes
More informationVICTRIX PRO Wall-hung modular condensing boiler for heating only
PRO Wall-hung modular condensing boiler for heating only Wide range (5 models) High efficiency and low pollutant emissions thanks to condensing technology Modulating heat output from 10 to 100% Possible
More informationHEAT TRANSFER HOT WATER BOILER
OT WTR OILR R - (60 TO 290) RVRS LM IR TU OILR Compact dimensions simplifies the transport and the positioning in boiler house Thermal exchange optimisation by driven water passage into the boiler Tube
More informationSPARE PARTS EXPLODED VIEW GAS WALL BOILERS Model ACO. R EN - Edition 04-01/04/2008
SPARE PARTS EXPLODED VIEW GAS WALL BOILERS Model ACO R8215222-04EN - Edition 04-01/04/2008 Domestic Gas Boilers ACO 537060 ACO 27 MFFI MET...... 537061 ACO 27 MFFI GPL...... 537062 ACO 27 RFFI SYSTEM MET......
More informationREX/REX F/REX K/REX K F REX DUAL/REX DUAL F
TECHNICAL MANUAL REX/REX F/REX K/REX K F REX DUAL/REX DUAL F PRESSURISED STEEL BOILERS INDEX 1 GENERAL WARNINGS... 4 2 TECHNICAL SPECIFICATIONS... 5 2.1 REX/REX K/REX F/REX K F 7-130 BOILER... 5 2.2 REX/REX
More informationSPARE PARTS EXPLODED VIEW GAS WALL BOILERS
SPARE PARTS EXPLODED VIEW GAS WALL BOILERS Model GENUS 27 BFFI PLUS Edition 4 Current from Serial No: 2320317800001 to: ------------------ Add to Edition 3 1 71 70 9 8 7 5 9 3 4 3 5 7 5 1 2 1 8 9 120 0
More informationGREENOx BT LOW RETURN TEMPERATURE DUAL BT WITH TILED BOILERS. GREENOx BT COND LOW RETURN TEMPERATURE WITH CONDENSER
TECHNICAL MANUAL GREENOx BT LOW RETURN TEMPERATURE DUAL BT WITH TILED BOILERS GREENOx BT COND LOW RETURN TEMPERATURE WITH CONDENSER GREENOx/GREENOx.e/K WITH THREE GAS PASSES DUAL GRX/DUAL GRX.e THREE GAS
More informationSPARE PARTS EXPLODED VIEW GAS WALL BOILERS Model ACO. R EN - Edition 06-01/12/2010
SPARE PARTS EXPLODED VIEW GAS WALL BOILERS Model ACO R8215222-06EN - Edition 06-01/12/2010 Domestic Gas Boilers ACO 537060 ACO 27 MFFI MET...... 537061 ACO 27 MFFI GPL...... 537062 ACO 27 RFFI SYSTEM MET......
More informationVIESMANN VITODENS 222-F
VISMNN VITONS 222- atasheet or part no. and prices: see pricelist VITONS 222- Type 2T as condensing storage combi boiler, 3.2 to 35. kw for natural gas and LP VITONS 222- Type 2S as condensing storage
More informationInoxSabiana 50 Flues Stainless Steel Double Wall ENVIRONMENTAL COMFORT
Flues Stainless Steel Double Wall ISO 9001 - Cert. n 0545/4 Unit heaters Radiant panels Fan coils Air handling units Flues ENVIRONMENTAL COMFORT Introduction and main constructional characteristics Double
More informationECONOMATIC STEEL SHELL BOILERS
ECONOMATIC STEEL SHELL BERS ECONOMATIC SERIES Since 1985 Stokvis has been supplying high quality products to the heating industry. The Economatic boilers are no exception.they are 3 pass reverse fl ame,
More informationSPARE PARTS EXPLODED VIEW GAS WALL BOILERS Model UNO. R EN - Edition 01-15/10/2007
SPARE PARTS EXPLODED VIEW GAS WALL BOILERS Model R8216080-01EN - Edition 01-15/10/2007 537255 24 MFFI (RO) MET...... 537256 24 MFFI (RO) GPL...... 537632 24 MFFI MET (PL, CZ, UCR)...... 537633 24 MFFI
More informationVIESMANN VITORONDENS 200-T Oil Unit condensing boilers 20.2 to kw
VISMANN VITORONDNS 200-T Oil Unit condensing boilers 20.2 to 107. kw Datasheet Part no. and prices: see pricelist VITORONDNS 200-T Type BR2A 20.2 to 5.7 kw Cast iron low temperature oil boiler with condensing
More informationVIESMANN. Datasheet Part no.: see pricelist, price upon request Not suitable for sizing the boiler. For this, see the separate technical guide.
VIESMANN VITOMAX 200 HW Hot water boilers for permissible flow temperatures in excess of 120 C Three-pass boiler Combustion output 4.0 to 18.2 MW Datasheet Part no.: see pricelist, price upon request Not
More informationSteam output 0.3 to 3.0 t/h Operating Pressure 10 to 16 bar
DATASHEET PSB SERIES Steam output 0.3 to 3.0 t/h Operating Pressure 10 to 16 bar Oil / Gas / HFO Fired Steam Boiler Three pass reverse flame steam boiler Without Economiser Maximum Permissible operating
More informationRS/E-EV MZ SERIES. Modulating Gas Burners FIRING RATES
The RS/E-EV MZ burners series covers a firing range from 44 to 2650 kw, and it is based on a new Digital Burner Management System, Riello REC27, which is able to manage the air-fuel ratio by independent
More informationRL/M BLU SERIES. Low NOx Modulating Light Oil Burners FIRING RATES. LOW NOx T. M 190/ kw M 223/ kw
LOW NOx T The RL/M BLU burners series covers a firing range from 360 to 1023 kw, and it has been designed for use in hot or superheated water boilers, hot air or steam generators and diathermic oil boilers.
More informationThermowell For sanitary applications Model TW61, for orbital welding
Thermowells Thermowell For sanitary applications Model TW61, for orbital welding WIKA data sheet TW 95.61 74-06 Applications Sanitary applications Food and beverage industry Bio and pharmaceutical industry,
More informationCOMPONENTS FOR SOLAR THERMAL SYSTEMS
COMPONENTS FOR SOLAR THERMAL SYSTEMS 2012 2 The CALEFFI SOLAR product range has been specially developed for use in solar thermal systems, where high temperatures can normally be reached and where, depending
More information4 relays DIN actuator
TECHICA SHEET relays DI actuator Description By means of internal relays, this device executes the controls received from the central unit or from the probe. It is needed to control loads such as - -coils,
More informationHYDRAULIC SEPARATOR PRODUCTION RANGE. Code Size Max. flow rate (l/h) " "1/ "1/ " 8.
HYDRAULIC SEPARATOR CT0617.0_03 EN March 2016 o o o Threaded versions equipped with flat seat F union connections, therefore, easy installation and/or maintenance; Self-cleaning: Dirt separator equipped
More informationDB Series. Technical Data Leaflet. Industrial Dual Block Oil, Gas and Dual Fuel Burners. Industrial TS0086UK00
Technical Data Leaflet Industrial TS0086UK00 DB Series Industrial Dual Block Oil, Gas and Dual Fuel Burners DB 4 1000/2500 5000 kw DB 6 1400/4000 7800 kw DB 9 1500/5000 9500 kw DB 12 1700/7000 12500 kw
More informationComponents for central heating
01 01 Components for central heating Booster units and spare parts 18 Hydraulic separator and spare parts 21 Dirt separators - Deaerators 23 By-Pass differential valve - Air separator units 32 Filling
More informationGVK Series (Steam-to-Steam) Clean Steam Generators
Page 1 of 5 TI-P486-03 CH Issue 1 Cert. No. LRQ 0963008 ISO 9001 GVK Series (Steam-to-Steam) Clean Steam Generators Description Unfired clean steam generators with 'U' type extractable tube bundle and
More informationTECHNICAL INFORMATION BIOMASS SOLUTIONS FOR A MORE ECOLOGICAL AND ECONOMICAL WORLD
TECHNICAL INFORMATION BIOMASS SOLUTIONS FOR A MORE ECOLOGICAL AND ECONOMICAL WORLD TECHNICAL INFORMATION Easy handling by microprocessor-control! Logically organized menus makes for easy operation of the
More informationUpdated technical data can be found in this document, supplemented by the Riello BX Burner Manual regarding commissioning checks and adjustments.
Riello BX Low NOx Manual Addendum Introduction To ensure compliance with commission Regulation (EU) No 813/2013, implementing Directive 2009/125/EC of the European Parliament and of the Council with regard
More informationRS SERIES. Two Stage Progressive Gas Burners FIRING RATES
The RS burners series covers a firing range from 44 to 2290 kw, and it has been designed for use in low or medium temperature hot water boilers, hot air or steam boilers, diathermic oil boilers. Operation
More informationMATERIALS ORIENTATION OF THE SUCTION AND DELIVERY CONNECTORS:
KV 3-6-1 MULTISTAGE VERTICAL CENTRIFUGAL ELECTRIC PUMPS WIT COUPLING TECNICAL DATA Operating range: fro 1,8 to 13,5 3 /h with head up to 139 etres. Puped liquid: clean, free of solids and abrasives, non-viscous,
More informationVIESMANN. VITOMAX 100-HS High pressure steam boiler Steam output 1.0 to 6.4 t/h. Datasheet. VITOMAX 100-HS Type M33A. Part no. and prices on request
VIESMANN VITOMAX 100-HS High pressure steam boiler Steam output 1.0 to 6.4 t/h Datasheet Part no. and prices on request VITOMAX 100-HS Type M33A Oil/gas high pressure steam boiler Compliant with the requirements
More informationON/OFF zone valves AMZ 112, AMZ 113
Data sheet ON/OFF zone valves AMZ 112, AMZ 113 Description Features: Indication of actual valve position; LED indication of turning direction; Manual valve turning mode enabled by a permanent clutch; No
More informationON/OFF zone valves AMZ 112, AMZ 113
Data sheet ON/OFF zone valves AMZ 112, AMZ 113 Description The ON/OFF zone valves type AMZ 112 and AMZ 113 are typical used in connection with: Domestic and commercial central heating applications Domestic
More informationSEASONAL MAINTENANCE CHECKLISTS Johnson Controls
SPRING CHECK LIST ABSORPTION CHILLERS Check starter and control panel. Leak test. Check hand valve diaphragms and replace as required. Check operation of purge unit. Change oil in the purge pump. Lubricate
More informationSIHI multi Type MSC. Modular multistage pumps. Description. Construction. Applications. Optional special designs. Materials.
Modular multistage pumps SIHI multi Type MSC Description The SIHI multi MSC range of horizontal, ring-section multistage pumps have been designed for long-term reliability when pumping high pressure liquids.
More informationTWO STAGE PROGRESSIVE AND MODULATING GAS BURNERS RIELLO 40 GS/M SERIES GS 10/M 22/ kw GS 20/M 43/ kw
TWO STAGE PROGRESSIVE AND MODULATING GAS BURNERS RIELLO GS/M SERIES GS /M / 5 3/8 19 The Riello GS/M series of two stage progressive or modulating gas burners, is a complete range of products developed
More informationFan-coil valves Series
Fan-coil valves Series 11-11 - 411 Main features Complete range in the following versions : -way - DN: 1/, /4, 1 -way - DN: 1/, /4, 1 -way with 4 ports - DN: 1/, /4 - The -way version and the -way versions
More informationECONOMATIC REX/REXF REX/REXF DUAL STR
TECHNICAL MANUAL ECONOMATIC REX/REXF REX/REXF DUAL STR PRESSURISED STEEL BOILERS 96R WALTON ROAD, EAST MOLESEY, SURREY, KT8 0DL Tel. 08707 707 747 Fax. 08707 707 767 info@stokvisboilers.com - www.stokvisboilers.com
More informationThermowell For sanitary applications Model TW61, for orbital welding
Temperature For sanitary applications Model TW61, for orbital welding WIKA data sheet TW 95.61 Applications for further approvals see page 5 Sanitary applications Food and beverage industry Bio and pharmaceutical
More informationMachine for Industrial Applications LH 80 M
Machine for Industrial Applications LH M litronic` : 7, 7,9 kg Engine: 3 kw / 313 HP Stage IIIB / Tier i Max. Syste Perforance: 3 kw Technical Data Engine Rating per ISO 99 Model Type Bore/Stroke Displaceent
More informationRS/M SERIES. Modulating Gas Burners FIRING RATES
The RS/M burners series covers a firing range from 45 to 2650 kw, and it has been designed for use in low or medium temperature hot water boilers, hot air or steam boilers, diathermic oil boilers. Operation
More informationLight oil - kerosene burner
Installation, use and maintenance instructions Light oil - kerosene burner One stage operation CODE MODEL TYPE 3747455 G0KI 474T5 90403 (4) - 0/008 TECHNICAL DATA Thermal power output 95 3 kw 8 8 kg/h
More informationMOTORISED BALL VALVE. Uni/Bi-directional. patented. 3 points 2 points Price list root SR... SS... SY... Connection with ball valve.
USE motorised ball valve can be used in the interception and regulation of: zoned heating/cooling systems water plants, with suitable ball valve alternative energy plants solar thermal plants general automation
More information1070 SERIES ULTRA LOW NO X
CAPABILITIES High release rates with moderate air Good turndown with flame characteristics and direction maintained Stable flames can be from highly oxidizing for tempered flame operation to highly reducing
More informationVF VFH. elektrogas.com. Butterfly valves DN40 DN150 EE155-11/11
VF VFH Butterfly valves DN40 DN150 elektrogas.com EE155-11/11 VF VFH Butterfly valves Contents Description.. 2 Features...... 2 Functioning and application.. 3 Technical specifications.... 4 Flow chart
More informationSOLAR THERMAL Forced circulation solar thermal system with selective flat plate collectors SELECTIVE SLIM
Forced circulation solar thermal system with selective flat plate collectors SEETIVE SIM SEETIVE 2.0 V flat plate collector vertical arrangement SEETIVE 2.0 O flat plate collector horizontal arrangement
More informationCombustion Equipment. Combustion equipment for. Solid fuels Liquid fuels Gaseous fuels
Combustion Equipment Combustion equipment for Solid fuels Liquid fuels Gaseous fuels Combustion equipment Each fuel type has relative advantages and disadvantages. The same is true with regard to firing
More informationHP14/20/28 P50 P75 P100/120 P150/170/200 P500
Wood pellet range: HP14/20/28 P50 P75 P100/120 P150/170/200 P500 performance max. cons. part cons. range load at max. ** load at part ** efficiency kw kw kg/h kw kg/h % Wood pellet units: HP14 4-14 18
More informationSELF-CLEANING FILTER
SELF-CLEANING FILTER CT0126.0_00 UK November 2008 PRODUCTION RANGE Connections Standard Mesh [μm] Size Code Kv [m³/h] THREADED FF UNI-EN-ISO 228 100 3/8 126.03.10 1,80 1/2 126.04.10 3,10 3/4 126.05.10
More informationApplication technology, 5th edition. Volume III: Fonterra radiant heating and cooling
Application technology, 5th edition Volume III: Fonterra radiant heating and cooling Regulation components, manifolds and manifold cabinets Regulation components, manifolds and manifold cabinets System
More informationOperation when directly connected to chimney Cupola Hot air exchanger
HAKA 78/57Th A Operation when directly connected to chimney Cupola Hot air exchanger Tested according to EN 13229 EN 13229 Nominal heat power 8 kw 13 kw Efficiency > 80 % > 80 % Consumption of wood 2,4
More informationLinea 28 Mark 1. Serial Number up to VOKERA SPARE PARTS BREAKDOWN
Linea 28 Mark 1 Serial Number up to 164370001 Outer Casing 1 RIVET 5093 5 LABEL 1781 2 LOCATING CLIP R/H 1881 6 CASE 1922 3 CLIP 5230 7 LOCATING CLIP L/H 1882 4 SELF ADHESIVE ALUM SHEET 5333 1 Main Frame
More information1032 SERIES LARGE CAPACITY DUAL FUEL OIL/GAS, AMBIENT OR PREHEATED AIR BURNER
CAPABILITIES Short, compact, clear and bushy flame Suitable for rich gases and most oils 10% to 300% excess air through burner with rich gaseous fuels and light oils 10% to 100% excess air through burner
More informationDUO-TEC COMPACT + SPARE PARTS CATALOGUE
DUO-TEC COMPACT + SPARE PARTS CATALOGUE - July 2015 - HOW TO READ THE SPARE PARTS CATALOGUE In the spare part catalogue, after the exploded diagrams, there are the components lists of the boilers; this
More informationWeishaupt Monarch oil burners Sizes 5 to 11 1/2002 GB
Weishaupt Monarch oil burners Sizes 5 to 11 1/ GB 1 Description, Types of regulation, Model overview Weishaupt Monarch oil burners are of the fully automatic pressure atomising type. Their design has been
More informationIWAKI MAGNETIC DRIVE PUMPS MDW. Patent JAPAN / U.S.A. / EU / CHINA / TAIWAN
IWAKI MAGNETIC DRIVE PUMPS Patent JAPAN / U.S.A. / EU / CHINA / TAIWAN Max. flow capacity of 300 3 /hr and ax. discharge head of 98. The world s largest class fluoroplastic agnetic drive pup. The series
More informationMTU Friedrichshafen 3B bar 19,96. bar 21,92
Sheet 1 of 8 Technical Sales Docuentation Printout: (yd) 0110719 ENGINE DATA MTU Project No. No. Index Unit 1V1600G10F Intake air teperature Chargeair coolant teperature Baroetric pressure Rawwater inlet
More informationProduct Information. Model: LNVG, LNVLG Burner Sizes: 13, 15, 17, 20, 21, 25 GENERAL DESCRIPTION U.L. STANDARD EQUIPMENT
The LNV/Series gas, oil, and combination gas/oil burner is a forced draft packaged burner system. A balanced blower wheel mounted in a fabricated housing provides combustion air for various furnace pressures
More informationMTU Friedrichshafen 3B
Sheet 1 of 8 Printout: (yd) 200707 ENGINE DATA MTU Project No. No. Index Unit 18V2000G85TB Chargeair coolant teperature Rawwater inlet teperature 0 0. DATARELEVANT ENGINE DESIGN CONFIGURATION 1 Fuelconsuption
More informationMTU Friedrichshafen 3D bar - bar 24,15
Sheet of 8 Technical Sales Docuentation Printout: (yd) 20079 ENGINE DATA MTU Project No. No. Index Unit 2V600G80F Intake air teperature Chargeair coolant teperature Baroetric pressure Rawwater inlet teperature
More informationALME / ALPE ELECTRONIC IN-LINE PUMPS FOR CIRCULATION SYSTEMS TECHNICAL DATA
LME / LPE FOR CIRCULTION SYSTEMS TECNICL DT Operating range: fro 1 to, ³/h with head up to 1 etres. Liquid teperature range: fro -1 C to +1 C. Puped liquid: clean, free of solids and abrasives, non-viscous,
More informationDUO-TEC COMPACT + SPARE PARTS CATALOGUE
DUO-TEC COMPACT + SPARE PARTS CATALOGUE - April 2016 - HOW TO READ THE SPARE PARTS CATALOGUE In the spare part catalogue, after the exploded diagrams, there are the components lists of the boilers; this
More informationTechnical Sales Documentation
Technical Sales Docuentation 12V1600G80S 2011712 Description: EPA Tier 2 Status: Current Application Group 3D No. Intake air teperature Chargeair coolant teperature Rawwater inlet teperature 0. DATARELEVANT
More informationVAILLANT SPARE PART CATALOGUE TURBOmax boilers VU 182 E, 242 E, 282 E TURBOmax combination boilers TURBOmax VUW 242 E, 282 E 8026 74 GB 09/96 View of appliances VU 182, 242, 282 E VUW 242, 282 E Content
More informationVAILLANT SPARE PART CATALOGUE
VAILLANT SPARE PART CATALOGUE TURBOmax boilers VU 182 E, 242 E, 282 E TURBOmax combination boilers TURBOmax VUW 242 E, 282 E 8026 74 GB 09/96 View of appliances VU 182, 242, 282 E VUW 242, 282 E Content
More informationZone manifold DN 25, DN 32, DN 50. Mounting and operating instructions
Zone manifold DN 25, DN 32, DN 50 Mounting and operating instructions WOMIX Sportowa 31 89-200 Szubin, Poland phone/fax +48 52 382 44 50, +48 52 382 44 51 www.womix.com.pl e-mail: export@womix.com.pl Central
More informationControls and Accessories Part Number Controls and Accessories Part Number
Linea 24 Mark 1 Serial Number Up to 161380001 Controls and Accessories Part Number Controls and Accessories Part Number CLOCK - MECHANICAL 201 CLOCK - DIGITAL 202 CONVERSION KIT LPG - NG 01005225 CONVERSION
More informationDUO-TEC COMPACT SPARE PARTS CATALOGUE
DUO-TEC COMPACT SPARE PARTS CATALOGUE - Aprile 2016 - HOW TO READ THE SPARE PARTS CATALOGUE In the spare part catalogue, after the exploded diagrams, there are the components lists of the boilers; this
More informationPRESS P/N - P/N ECO SERIES
The PRESS P/N series of burners covers a firing range from 800 to 5130 kw. They have been designed in three versions for use in commercial and industrial installation, to burn different oil viscosity from
More informationCOMPONENTS FOR SOLAR THERMAL SYSTEMS
COMPONENTS FOR SOLAR THERMAL SYSTEMS The Caleffi Solar product range has been specially developed for use in solar thermal systems, where high temperatures can normally be reached and where, depending
More informationR&D on Oil-Burning, Environment - Friendly, High-Efficiency Boiler
2001.M4.3.1 R&D on Oil-Burning, Environment - Friendly, High-Efficiency Boiler (Environment-Friendly, High-Efficiency Boiler Group) Takashi Murakawa, Hiroshi Kato, Hiroshi Matsumoto, Kentaro Sato, Yasuhiro
More informationVIESMANN VITOTRANS 100 Plate heat exchanger
VIESMANN VITOTRANS 100 Plate heat exchanger Datasheet Part numbers and prices: see pricelist VITOTRANS 100 Type PWT For transfer stations from heat supply networks, for system separation in heating systems
More informationm-csg Ultra-compact Clean Steam Generation System
Local regulations may restrict the use of this product to below the conditions quoted. In the interests of development and improvement of the product, we reserve the right to change the specification without
More informationKARL SCHNELL GRINDER SPECIFICATION: KS Process Automat B 22 Type l
KARL SCHNELL GRINDER SPECIFICATION: KS Process Automat B 22 Type 250 300l Execution - total volume mixer bowl approx. 380 l, nominal volume approx. 300 l - stationary design, with four height adjustable
More informationCATÁLOGO TÉCNICO COMERCIAL
CATÁLOGO TÉCNICO COMERCIAL ENFRIADORAS DE AGUA CONDENSADAS POR AIRE Series LCAEX De 350 a 1600 Kw. Compresor de tornillo R-134A Index Identification code Identification code and index... pag. 2 General
More informationPRESS G SERIES. Two Stage Light Oil Burners FIRING RATES
The PRESS G series of burners covers a firing range from 107 to 1660 kw and they have been designed for use in civil installations of average dimensions, like building areas and large apartment groups
More informationWeishaupt WKGL70 dual fuel burner Version 3LN (Low NO x ) multiflam 1/2003 GB
Weishaupt WKGL70 dual fuel burner Version 3LN (Low NO x ) multiflam 1/2003 GB Description Weishaupt WK series industrial burners have been especially designed for industrial capacity ranges. The construction
More informationCOMMERCIAL BOILERS Eco-HK / Eco-PK KW
www.hargassner.com COMMERCIAL BOILERS Eco-HK / Eco-PK 150 225 KW COMMERCIAL BOILERS Eco-HK / Eco-PK Features and benefits of the Eco-HK & Eco-PK Energy-saving -Operation Speed-controlled EC-exhaust fan
More informationCONDENSING GAS FIRED FLOOR OR WALL MOUNTED BOILER. Model UCS-240 PARTS, KITS & OPTIONAL ACCESSORIES
CONDENSING GAS FIRED FLOOR OR WALL MOUNTED BOILER Model UCS-240 PARTS, KITS & OPTIONAL ACCESSORIES ORDERING INSTRUCTIONS ORDER PARTS THROUGH YOUR NEAREST SUPPLIER. WHEN ORDERING PARTS, OBTAIN MODEL NUMBER
More informationCALEFFI. Pre-assembled distribution manifolds for. heating and air-conditioning systems. 663 series 01065/18 GB. replaces dp 01065/06 GB.
Pre-assembled distribution manifolds for heating and air-conditioning systems 663 series FM 21654 003 065/18 GB replaces dp 065/06 GB Function The pre-assembled distribution manifolds are designed to optimise
More informationAirejet. Low NOx Coal Burner. Type: Design features: NO X removal efficiencies:
Airejet Low NOx Coal Burner Unique low NO X coal burner with center air jet for use with overfire air (OFA) systems. Sleeve Damper Actuator Core Air Inlet Duct and Damper Pitot Grid Outer Spin Vanes Inner
More informationOil - kerosene burner
Installation, use and maintenance instructions Oil - kerosene burner One stage operation CODE MODEL TYPE 374445 G5 444T50 9038 () TECHNICAL FEATURES Thermal power output 8 0 kw.3 5 kg/h Fuel Gas oil 35s,
More information... Cabinet Heaters Gas & Oil Fired Heaters ... ErP. ErP Lot 21 Seasonal Efficiency and NOx compliant
abinet eaters as & Oil ired eaters rp 2018 rp Lot 21 Seasonal fficiency and NOx compliant abinet eaters... abinet heaters combine innovative design with a proven four pass heat exchanger technology to
More informationETHERMA 4-SPEED CIRCULATOR PUMPS
-SPEED CIRCULATOR PUMPS -speed circulator pups with otor ounted directly into the pup body. The switch allows to obtain different perforance curves guaranteeing greater flexibility and haroniously satisfying
More informationCONDENSING GAS FIRED FLOOR OR WALL MOUNTED BOILER. Model DMG-240 PARTS, KITS & OPTIONAL ACCESSORIES
CONDENSING GAS FIRED FLOOR OR WALL MOUNTED BOILER Model DMG-240 PARTS, KITS & OPTIONAL ACCESSORIES ORDERING INSTRUCTIONS ORDER PARTS THROUGH YOUR NEAREST SUPPLIER. WHEN ORDERING PARTS, OBTAIN MODEL NUMBER
More informationThermowell For sanitary applications Model TW61, for orbital welding
s For sanitary applications Model TW61, for orbital welding WIKA data sheet TW 95.61 for further approvals see page 5 Applications Sanitary applications Food and beverage industry Bio and pharmaceutical
More informationInstallation- and maintenance instruction B20K-2
Installation- and maintenance instruction B20K-2 1 171 615 51 05-01 178 017 09 DESCRIPTION COMPONENTS 1. Damper motor 2. Air damper 3. Photocell 4. Scale, nozzle assembly 5. Test nipple 6. Nozzle assembly
More informationProduct range Solex Technical data and dimensioning. 5 Years
Qualität made in Germany Product range Solex Technical data and dimensioning Quality made in Germany 5 Years Handwerkergarantie m anufacturer s warranty Product range Solex Dimensioning High-Flow system
More informationRS/1 SERIES. One Stage Gas Burners RS 34/1 MZ RS 44/1 MZ kw kw GAS
The RS/1 series of burners covers a firing range from 70 to 550 kw, and they have been designed for use in low or medium temperature hot water boilers, hot air or steam boilers, diathermic oil boilers.
More informationIssue 09/2014 * *
*1756203420* 17562.0342.0 REV3 19/09 2014 Spare s List Advance Plus 25C 47---583---29 Advance Plus 30C 47---583---30 Advance Plus 35C 47---583---31 Advance Plus 16S 41---583--- Advance Plus 25S 41---583---23
More informationGRUNDFOS DATA BOOKLET NS, PF. 50 Hz
GRUNDFOS DATA BOOKLET 50 Hz Table of contents 1. PF 3 General description 3 Features 3 Constructional features 3 Material specification 3 Marks 3 Technical data 4 Performance curves 4 Dimensions 5 Product
More informationCODE OF GOOD PRACTICE
CODE OF GOOD PRACTICE FOR THE OPERATION OF LIQUID FUEL FIRED COMMERCIAL, INDUSTRIAL AND DOMESTIC APPLIANCES 1st June 1972 PRINTED BY THE GOVERNMENT PRINTER HONG KONG 94157 140K 7/72 INTRODUCTION CONTENTS
More informationAZURA. Air/water multifunctional chiller&heat pump, kw
AZURA STM Air/water multifunctional chiller&heat pump, 31-211 kw General Air/water unit with indipendent production of chilled water and hot water equipped with axial fans and hermetic scroll compressors.
More informationHeating and Gas Installations - December 2014
This is an example of good practice maintenance specifications. It is not exhaustive and should only be used to assist with facilities management or specification of a maintenance contract. Emergency Gas
More informationNEXTRON MONOBLOCK BURNERS kw
NEXTRON MONOBLOCK BURNERS 25-112 kw www.elco-burners.com MAIN CHARACTERISTICS OF THE RANGE Combustion Unique and efficient Developed and improved by ELCO R&D department, the Free Flame technology is a
More informationG23 Bulletin # September 1998 Supersedes June 1995
ENGINEERING DATA ELITE 80Z UP-FLOW GAS FURNACES *80.0% to 80.8% A.F.U.E. 50,000 to 150,000 Btuh (14.7 to 44.0 kw) Gas Heating Input 1 thru 6 Tons (3.5 thru 21.1 kw) Nominal Add-On Cooling *Isolated Combustion
More informationUniversal is a family of commercial gas water heaters that are designed to fit into tight retrofit applications
Ruud Commercial Gas Universal Water Heaters Universal is a family of commercial gas water heaters that are designed to fit into tight retrofit applications Features & Benefits The tighter the commercial
More information