egr and butterfly valve pics

Size: px
Start display at page:

Download "egr and butterfly valve pics"

Transcription

1 Page 1 of 16 Forum Gallery Shop Sponsors Home FAQ New Posts Private Messages Search Members Members Map Calendar Groups Profile Donate Log Out [heine] Announcement: Please provide feedback on electronic park brake faults. Click here for more info. DISCO3.CO.UK > Technical egr and butterfly valve pics Watch this topic for replies Page 1 of > j,moore egr and butterfly valve pics as i said here are some pics to show i did my conversion, Joined: 26 Nov 2007 Location: n.lincs Posts: 89

2 Page 2 of 16 take off the covers and ducting, be sure to cover the air intakes to prevent anything entering,

3 Page 3 of 16 remove the air intake duct shown, remove the actuator, the round thing whith the wires on the end, this is very fiddly and i ended up removing the black bracket undernieth and the long bolt in the top,then i didnt put the back bottom stud back in the actuator, three is enough i think, make sure you replace the black bracket though,

4 Page 4 of 16 carefuly remove the butterfly rod as shown, remove the butterfly valve,

5 Page 5 of 16 then reassemble the rod as removed whith out the valve,

6 Page 6 of 16 then put the whole assembly back together, dont forget to conect the actuator inkage to the rod, this is a basic run down of what to do to remove this valve, just be verry careful not to let anything get into any of the air intake ducts because if you do and then you start the engine it will f k it up big style. also can i please state i cannot be held responsible for any damage caused from any advice given, thanks anyway. Last edited by j,moore on Thu Mar :09am; edited 2 times in total Wed Mar :31pm 10forcash So, errr... what benefit does removing the butterfly valve give? the EGR pipes behind the valve appear to still be connected and not blanked off so will still pump exhaust gases into the inlet manifold - won't they?

7 Page 7 of 16 for Freelander 2 Diesel, Discovery 3 / RR Sport TDV6 & RR Sport TDV8, Defender (TD5 & Puma) - available Now! Vehicle modifications, preparation, training and equipment also available Joined: 10 Jun 2005 Location: In the naughty corner... eligible for parole 2025 Posts: Wed Mar :35pm j,moore now to blank off the egrs, Joined: 26 Nov 2007 Location: n.lincs Posts: 89

8 Page 8 of 16 thease are the pipes, use a suitable tool to remove the top clips,

9 Page 9 of 16 remove the two studs on the flange of the stainless pipe, do not loose the gasket,

10 Page 10 of 16 remove the pipe and then reasemble whith a suitable blanking plate maide out of stainless plate, and reassemble whith the plate ontop of the gasket. you could put a gasket on the top and bottom if you prefered, this is a picture of the pesky egr valve,

11 Page 11 of 16 as re assembled,

12 Page 12 of 16 and do the same procedure for the other side, there is alot less room so be carefull and dont loose your cool, and then dont forget to put the clips back on the pipes and reclip any wires and put the whole thing back together and thats about it. please be carefull and as said above please dont hold me responsible for any damage. my disco has done over 17000miles cince this was done and i have had no problems so i dont see why this wont work for all other cars. i have more pics on my gallery to help so good luck. regards jim. Wed Mar :51pm j,moore sorry 10forcash, you beat my second post, im not as fast at typing sorry,

Fitting the Bell Auto Services (B-A-S) TDV6 EGR Blanking Kit to a 2006 model Discovery 3 TDV6 HSE

Fitting the Bell Auto Services (B-A-S) TDV6 EGR Blanking Kit to a 2006 model Discovery 3 TDV6 HSE Fitting the Bell Auto Services (B-A-S) TDV6 EGR Blanking Kit to a 2006 model Discovery 3 TDV6 HSE Before I describe how I did this, I must first thank other members of the Disco3.co.uk forum (namely J,moore

More information

Page 1 of 11 Welcome, goldeneye006 Notifications My Profile Settings Log Out Forum What's New? Home Classifieds Vendors Vendor Specials Store New Rules Posts Private Advertising Messages FAQ Calendar Community

More information

2k2GT Registered User

2k2GT Registered User 1 of 44 7/22/2009 01:17 Corral Forums > Modular Tech Forums > GT & SOHC My J.R. Granatelli K-member install story...56k death Welcome, xomp. You last visited: Today at 12:07 AM Private Messages: Unread

More information

Fitting Instructions For The TDV6 EGR Blanking Kit To A 2006 Model Discovery 3 TDV6 GHSE

Fitting Instructions For The TDV6 EGR Blanking Kit To A 2006 Model Discovery 3 TDV6 GHSE Part Number DA1112 Fitting Instructions For The TDV6 EGR Blanking Kit To A 2006 Model Discovery 3 TDV6 GHSE You do this modification at your own risk. Britpart won t be held responsible for what is written

More information

M60/M62 Camshaft Sensor Replacement

M60/M62 Camshaft Sensor Replacement Page 1 of 10 Welcome, goldeneye006 Notifications My Profile Settings Log Out Forum What's New? Home Classifieds Vendors Vendor Specials Store New Rules Posts Private Advertising Messages FAQ Calendar Community

More information

Ford Super Duty 5.4L Spark Plug Change F250 4x4 XLT Sport Crew Cab

Ford Super Duty 5.4L Spark Plug Change F250 4x4 XLT Sport Crew Cab 1 of 32 Ford Super Duty 5.4L Spark Plug Change 2004 F250 4x4 XLT Sport Crew Cab Back to 2004 F250 Main Page Click Here for a PDF version of this article At close to 100k miles, I figured it was time for

More information

Steve Saunders Goldwing Forums > Steve Saunders Goldwing Forums > Reference and FAQ Forum > Balancing GL1500 Carbs

Steve Saunders Goldwing Forums > Steve Saunders Goldwing Forums > Reference and FAQ Forum > Balancing GL1500 Carbs Skype update. You can now easily activate Skype in your forum profile, allowing you to talk in real time with other forum members. Just go to MY ACCOUNT, click PROFILE and scroll down to the Skype field,

More information

The $375 Milemarker PE8000 Winch Deal Is Back!

The $375 Milemarker PE8000 Winch Deal Is Back! 1 de 6 19/4/2007 19:14 Home TRS Chat Tech Library Events TRS Fab & Off-Road Apparel & Decals TheRangerStation.com Forum Rules Gallery Help Search Members Calendar Welcome Guest ( Log In Register ) TRS

More information

E46 FUEL FILTER CHANGE Pics from CI

E46 FUEL FILTER CHANGE Pics from CI 1 of 10 5/3/2010 1:48 PM E46 FUEL FILTER CHANGE Pics from 2001 330CI Bellows Expansion Joints Metal Bellows Expansion Joints in Every Style from Flexicraft www.flexicraft.com/metal_bellows Ask a BMW Mechanic

More information

Page 1 of 8 membership rennlist gallery sponsors chat upload photo classifieds Rennlist Discussion Forums > Water Cooled Technical Discussion Areas > 928 Forum Differential adjusments Welcome, TheoJ. You

More information

Here's the difference (externally) in the and 04+ bumper and headlights: (00-03 on top, 04 on bottom)

Here's the difference (externally) in the and 04+ bumper and headlights: (00-03 on top, 04 on bottom) OK guys, I've been meaning to post this for awhile.. well here it goes. I did the '04 front end conversion on my '01 about 4-5 months ago, but then the dealer had to buy the car back for legal reasons.

More information

YOUR CAR's COOLANT MUST BE COLD TO DO THIS. DON'T BE STUPID AND SCALD YOURSELF.

YOUR CAR's COOLANT MUST BE COLD TO DO THIS. DON'T BE STUPID AND SCALD YOURSELF. I just read through the service manual, checked out Billman's recommendations, and tackled the coolant change on my 2003 s2000. I'm not a mechanic by trade but have done valve adjustments, head gaskets,

More information

2007 Crown Victoria Police Interceptor (P71) Blend Door Actuator Replacement (If I did it, you can too.)

2007 Crown Victoria Police Interceptor (P71) Blend Door Actuator Replacement (If I did it, you can too.) 2007 Crown Victoria Police Interceptor (P71) Blend Door Actuator Replacement (If I did it, you can too.) I'm not saying this is the only way, or even the right way, but it worked for me. First time I've

More information

Page 1 of 17 My Profile Active Users Help Search Google Search You are logged in as Massboykie, Log out VWvortex Forums Brakes Girling 54 rebuild/ mk3 upgrade hookdub Member DIY: Girling 54 rebuild/ mk3

More information

User CP FAQ Members List Calendar New Posts Search Quick Links Log Out

User CP FAQ Members List Calendar New Posts Search Quick Links Log Out 1 of 6 1/10/2008 9:51 PM SVRider Board > Workshop > 03 + SV650 Tech Reload this Page Shocking Developement...ZX10 rear shock on a '06 VS650S Welcome, wamanning. You last visited: Today at 02:24 PM Private

More information

Disco 2 Workshop Manual READ ONLINE

Disco 2 Workshop Manual READ ONLINE Disco 2 Workshop Manual READ ONLINE Land Rover Discovery 2 Parts ebay - Find great deals on ebay for Land Rover Discovery 2 Parts in Other Parts. Shop with confidence. Land Rover Discovery 2 1999-2004

More information

Dawson Tool-Less Guide-Rod Problem s Updated

Dawson Tool-Less Guide-Rod Problem s Updated Dawson Tool-Less Guide-Rod Problem s Updated On Brian Enos Forum 2005: Dawson was making Tool-Less Guide-Rods Purchase History: Invoice # 013512 2014-05-21 and #014408 2014-05-30 first Tool-Less Guide-Rod

More information

Pajero EGR Modification. By members of the Pajero Owners Club.

Pajero EGR Modification. By members of the Pajero Owners Club. Pajero EGR Modification By members of the Pajero Owners Club www.pocuk.com Hi all, in reference to the latest posts regarding blocking the EGR valve I'd like to thank our wise fellow members for their

More information

Super how to Mod your Vr6 intake manifold/polish and paint. - Dubnet Volkswagen Enth... Page 1 of 33 www.bluenile.com Feedback - Ads by Google Dubnet Volkswagen Enthusiast Forum > Volkswagen And Audi >

More information

Page 1 of 19 Welcome, goldeneye006 Notifications My Profile Settings Log Out Forum What's New? Home Classifieds Vendors Vendor Specials Store New Rules Posts Private Advertising Messages FAQ Calendar Community

More information

Page 1 of 14 Welcome, goldeneye006 Notifications My Profile Settings Log Out Forum What's New? Home Classifieds Vendors Vendor Specials Store New Rules Posts Private Advertising Messages FAQ Calendar Community

More information

JRSC + BBK Install on SVTF. Neil A. Shah medicnas on focaljet September 2006

JRSC + BBK Install on SVTF. Neil A. Shah medicnas on focaljet September 2006 JRSC + BBK Install on SVTF Neil A. Shah medicnas on focaljet September 2006 ECU up here. When removing make sure the smaller bundles of wires don t get wrapped around the bottom edge and break - this almost

More information

MASSEY FERGUSON PROBLEMS. Download Free PDF Full Version here!

MASSEY FERGUSON PROBLEMS. Download Free PDF Full Version here! MASSEY FERGUSON PROBLEMS Download Free PDF Full Version here! MASSEY FERGUSON TRACTORS DISCUSSION FORUM Advice on massey ferguson tractors and information on massey ferguson tractor parts and service manuals

More information

Land Rover Hse Repair Manual

Land Rover Hse Repair Manual Land Rover Hse Repair Manual If you are searching for the book Land rover hse repair manual in pdf format, then you've come to faithful website. We present complete version of this ebook in txt, epub,

More information

E28/30 Homelink Install by Brad Denton

E28/30 Homelink Install by Brad Denton Page 1 of 7 e30tech.com Forums> Technical> Electronics & Lighting DIY Homelink Install User Name User Name Password Remember Me? Log in Register FAQ Members List Sponsors Advertise Shop Today's Posts Search

More information

Brake Caliper Rebuild - Part Numbers & Tips Per Jim Millet, 3/15/2005

Brake Caliper Rebuild - Part Numbers & Tips Per Jim Millet, 3/15/2005 Per Jim Millet, 3/15/2005 Not too difficult a job. Rears are easier than fronts to access. You ll need the following gasket sets: Front caliper gasket set, P/N 34 11 1 157 037, MSRP $13.58 Rear caliper

More information

2007 Lexus RX350 AFS 3phase motor Pinout (Koito HLSA-33001)

2007 Lexus RX350 AFS 3phase motor Pinout (Koito HLSA-33001) 1 z 5 8. 3. 2014 7:30 User Name Password Log in Remember Me? Help Register The Buzz Main Forum Search New Posts Gallery TRS Store Mark Forums Read Search Main Forum General Discussion General Discussion

More information

Found a great injector cleaning DIY! - R3VLimited Forums

Found a great injector cleaning DIY! - R3VLimited Forums Page 1 of 9 R3VLimited Forums > Technical Forums > General Technical Found a great injector cleaning DIY! User Name User Name Password Remember Me? Log in Register Gallery FAQ Members List Calendar Today's

More information

How to change Swirl Flaps, on Diesel BMW

How to change Swirl Flaps, on Diesel BMW How to change Swirl Flaps, on Diesel BMW I am now going to show you how i did it on my car. May'sedition of Total BMW (still in WHSmiths) did a cover on how to change and modify Swirl flaps on a 330d engine,

More information

Door panel removal F07 5 GT

Door panel removal F07 5 GT Things needed Decent plastic trim removal tools Torx 30 Spare door clips 07147145753 I got away with a set of 5 but if I did it again I d be cautious and get 10. From prior experience if they are damaged

More information

Rear Wheel Removal (by BassCliff)

Rear Wheel Removal (by BassCliff) Rear Wheel Removal (by BassCliff) Hello to my GS riding friends! After picking up a nail in my rear tire (while on the freeway at 75mph!) I thought I would take a few pictures to help illustrate the rear

More information

ALLDATA Online Chevy Truck S10/T10 Blazer 2WD V6-4.3L VIN W - Intake... Intake Manifold Replacement (Upper)

ALLDATA Online Chevy Truck S10/T10 Blazer 2WD V6-4.3L VIN W - Intake... Intake Manifold Replacement (Upper) ALLDATA Online - 2001 Chevy Truck S10/T10 Blazer 2WD V6-4.3L VIN W - Intake... Page 1 of 21 Home Account Contact ALLDATA Log Out Help PAUL REDEHOFT Select Vehicle New TSBs Technician's Reference Component

More information

I cannot believe it has been so long since my last update. A lot has happened and I will try to bring everyone up to speed. First of all, I had my

I cannot believe it has been so long since my last update. A lot has happened and I will try to bring everyone up to speed. First of all, I had my I cannot believe it has been so long since my last update. A lot has happened and I will try to bring everyone up to speed. First of all, I had my left knee replaced about 5 weeks ago. Needless to say

More information

Extreme Customs Oshkosh Wisconsin almost killed me. davidbates65. Extreme Customs Oshkosh Wisconsin almost killed me.

Extreme Customs Oshkosh Wisconsin almost killed me. davidbates65. Extreme Customs Oshkosh Wisconsin almost killed me. davidbat Forums Gallery Tools Marketplace New Posts How-Tos Site Guidelines Go Premium! Ford Truck Enthusiasts Forums > Super Duty/Heavy Duty > 1999 to 2016 Super Duty > Extreme Customs Oshkosh Wisconsin

More information

Home User CP Go Premium Search Quick Links Log Out Create a Member Journal Vendor Deals Member

Home User CP Go Premium Search Quick Links Log Out Create a Member Journal Vendor Deals Member 1 of 17 7/27/2009 5:41 PM STI Forum Shop Sponsors Advertise Rules FAQ Membe Home User CP Go Premium Search Quick Links Log Out Create a Member Journal Vendor Deals Member IWSTI Mechanic Gloves for the

More information

Page 1 of 33 Welcome, goldeneye006 Notifications My Profile Settings Log Out Forum What's New? Home Classifieds Vendors Vendor Specials Store New Rules Posts Private Advertising Messages FAQ Calendar Community

More information

DIY: Shiver Valve Check, Illustrated

DIY: Shiver Valve Check, Illustrated DIY: Shiver Valve Check, Illustrated By Petemoss, AF1 Forum Tools needed: 4mm allen wrench to remove all the fairing pieces 2.5mm allen wrench to remove battery holder 5mm allen wrench for valve cover

More information

Superior Wheel Installation Guide (No Turbo removal)

Superior Wheel Installation Guide (No Turbo removal) Superior Wheel Installation Guide (No Turbo removal) This is the process used to install the Turbo Wheel without having to remove the Turbo from your Engine. It should take a maximum of 5 hours. Tools:

More information

Connecting the rear fog light on the A4 Jetta, while keeping the 5 Light Mod

Connecting the rear fog light on the A4 Jetta, while keeping the 5 Light Mod Connecting the rear fog light on the A4 Jetta, while keeping the 5 Light Mod DISCLAIMER: I'm human and make mistakes. If you spot one in this how to, tell me and I'll fix it This was done on my 99.5 Jetta.

More information

Lincoln Mark VII T5 Swap Version submitted by 5.0 bird

Lincoln Mark VII T5 Swap Version submitted by 5.0 bird Lincoln Mark VII 1984-1989 T5 Swap Version 20070611 submitted by 5.0 bird I've decided to make an article to assist with the T5 swap for the 84-89 Mark VIIs, since I was just in there because my DOA didn't

More information

S Type Manual Gearbox

S Type Manual Gearbox S Type Manual Gearbox If you are searched for the ebook S type manual gearbox in pdf format, then you have come on to the right site. We present complete version of this ebook in PDF, txt, doc, DjVu, epub

More information

This reissue replaces all previous versions. Please destroy all previous versions.

This reissue replaces all previous versions. Please destroy all previous versions. Page 1 of 10 LTB00445V3 TECHNICAL BULLETIN 15 AUG 2012 Jaguar Land Rover Limited All rights reserved. I N F O R M A T I O N This reissue replaces all previous versions. Please destroy all previous versions.

More information

Manual Shift Transmission Fluid Change How Often Honda Civic

Manual Shift Transmission Fluid Change How Often Honda Civic Manual Shift Transmission Fluid Change How Often Honda Civic 1997 Honda Civic Manual transmission drain and refill. Tools: 3/8 How To Change Honda. If your engine will rev up, but the car won't shift into

More information

Yikes98 My $0.02 DIY Steering Angle Sensor (SAS) Repair on BMW i e92

Yikes98 My $0.02 DIY Steering Angle Sensor (SAS) Repair on BMW i e92 Yikes98 My $0.02 DIY Steering Angle Sensor (SAS) Repair on BMW 07 328i e92 First, thanks to all who posted on their SAS problems and pics. Using all that info I was able to piece together how to attack

More information

BMW E31 AMBIENT INTERIOR LIGHTS MODIFICATION

BMW E31 AMBIENT INTERIOR LIGHTS MODIFICATION Page 1 of 7 Welcome, goldeneye006 Notifications My Profile Settings Log Out Forum What's New? Home Classifieds Vendors Vendor Specials Store New Rules Posts Private Advertising Messages FAQ Calendar Community

More information

RANDY Then it basically leaves and moves over into the paint shop.

RANDY Then it basically leaves and moves over into the paint shop. KIA Motors Manufacturing Georgia Today on Fast Forward, we re visiting the west side of the state, West Point to be exact, looking for another great Georgia company for this episode. So we uh oh great.

More information

Attached Images. Attached Images

Attached Images. Attached Images Results from May 9 th : I'm sorry to say... I should have stayed home!.. Well, actually I'm glad I went, but the day was NOT a success from a competitive standpoint. It's always risky to take an untested

More information

There is hence three things you can do - add oil, adjust the temp that the clutch begins to engage, or do both.

There is hence three things you can do - add oil, adjust the temp that the clutch begins to engage, or do both. As most of you may be aware, I have been doing a lot of research lately on our cooling system in the 80's including the fact that we have a dead spot on the OEM temp gauge which prompted me to not rely

More information

How To Guide: Replace airbag steering wheel with non-airbag wheel - e30tech.com Foru... Page 1 of 10

How To Guide: Replace airbag steering wheel with non-airbag wheel - e30tech.com Foru... Page 1 of 10 How To Guide: Replace airbag steering wheel with non-airbag wheel - e30tech.com Foru... Page 1 of 10 e30tech.com Forums> Technical> Appearance How To Guide: Replace airbag steering wheel with non-airbag

More information

Page 1 of 6 FDP Home Page / FDP Forum / Classifieds / FAQ's / Links The FDP is made possible by the following companies and individual members like you. Please use the links below to show them we value

More information

Manual Transmission Hard To Get Into Gear. When Cold >>>CLICK HERE<<<

Manual Transmission Hard To Get Into Gear. When Cold >>>CLICK HERE<<< Manual Transmission Hard To Get Into Gear When Cold For the last month or so, it has been difficult to shift into gear (manually, not when the car is I can get it into reverse and to neutral with some

More information

How to Replace the B2 Piston Bore Seal

How to Replace the B2 Piston Bore Seal Page 1 Home Cars for sale Trucks for sale Where we are Links to other diesel sites About us Why diesel? Diesel Videos How they work How they sound FAQ Dodge Diesel Maintenance tips, parts and DIY DVD's

More information

If searching for the ebook 92 acura manual in pdf format, then you have come on to the right site. We furnish the utter option of this book in doc,

If searching for the ebook 92 acura manual in pdf format, then you have come on to the right site. We furnish the utter option of this book in doc, 92 Acura Manual If searching for the ebook 92 acura manual in pdf format, then you have come on to the right site. We furnish the utter option of this book in doc, DjVu, epub, txt, PDF forms. You can read

More information

Extreme Customs Oshkosh Wisconsin almost killed me. Chuck-B

Extreme Customs Oshkosh Wisconsin almost killed me. Chuck-B davidbat Forums Gallery Tools Marketplace New Posts How-Tos Site Guidelines Go Premium! Ford Truck Enthusiasts Forums > Super Duty/Heavy Duty > 1999 to 2016 Super Duty > Extreme Customs Oshkosh Wisconsin

More information

WARNING These following pages are instruction for C5 CE stripes; however, it is the same method applying vinyl. Please spend time to read thru these

WARNING These following pages are instruction for C5 CE stripes; however, it is the same method applying vinyl. Please spend time to read thru these WARNING These following pages are instruction for C5 CE stripes; however, it is the same method applying vinyl. Please spend time to read thru these pages. At the end, it is your C5/C6 ME stripes' instruction.

More information

Днепр) Russian Motorcycle Carburetors Part 2B: PZ-24 and PZ-28 Carburetor Assembly and Jet Drilling

Днепр) Russian Motorcycle Carburetors Part 2B: PZ-24 and PZ-28 Carburetor Assembly and Jet Drilling Ural (Урал( Урал) - Dnepr (Днепр( Днепр) Russian Motorcycle Carburetors Part 2B: PZ-24 and PZ-28 Carburetor Assembly and Jet Drilling (applies also to K-37 K and K-38 K carbs) Ernie Franke eafranke@tampabay.rr.com

More information

Product In Focus - Suzi Coils by

Product In Focus - Suzi Coils by In this Issue: Product In Focus New Products Supersessions Getting Technical Staff Profile Advertising Product In Focus - Suzi Coils by E-10746 E-10744 Euclid Suzi Coils with hang sell tags Meets current

More information

850 M-Technic Body Parts (CSi)

850 M-Technic Body Parts (CSi) 850 M-Technic Body Parts (CSi) Part Description BMW Part No. Qty List Price Front Spoiler 51-11-2-253-000 1 $ Rear Valance 51-12-2-253-005 1 $ Installation Kit 82 11 9 402 709 1 $ Flap Cover for Rear

More information

Repairing Standing Lamp That Won't Turn On

Repairing Standing Lamp That Won't Turn On Repairing Standing Lamp That Won't Turn On Some standing lamps have a safety switch inside them that, if not pressed down properly, will cause the lamp to remain off. This is a simple fix for repairing

More information

1985 TOYOTA TRUCK 22RE USERS MANUAL ARCHIVE

1985 TOYOTA TRUCK 22RE USERS MANUAL ARCHIVE 05 February, 2019 1985 TOYOTA TRUCK 22RE USERS MANUAL ARCHIVE Document Filetype: PDF 498.27 KB 0 1985 TOYOTA TRUCK 22RE USERS MANUAL ARCHIVE I have the same truck EFI and have spent over 600 on. 1985 TOYOTA

More information

Toyota Auris Hybrid 2017 User Manual

Toyota Auris Hybrid 2017 User Manual Toyota Auris Hybrid 2017 User Manual If searching for the book Toyota auris hybrid 2017 user manual in pdf form, then you've come to the right site. We presented the complete version of this book in doc,

More information

05/06 Gsxr 1000 Clutch Mod

05/06 Gsxr 1000 Clutch Mod By: Ali (Jetspeedz) 05/06 Gsxr 1000 Clutch Mod Parts: 21472-41G10 - WASHER, CLUTCH - $10.09 From 06 Gsxr 750 Opt: 11482-40F00 - GASKET, CL COVER - $8.29 Tools: 13/64 Drill bit, 30mm, 12mm, 10mm, 8mm sockets,

More information

2017+ L5P Duramax 3 ½ Down Pipe & EGR Fix Kit

2017+ L5P Duramax 3 ½ Down Pipe & EGR Fix Kit 2017+ L5P Duramax 3 ½ Down Pipe & EGR Fix Kit Covers installation of PN s: WCF100630, WCF100829 Note: This Kit is for off road competition use only! Off Road Competition Use Tuning & Exhaust System is

More information

PDF // VOLVO XC90 SERVICE MESSAGE RESET DOCUMENT

PDF // VOLVO XC90 SERVICE MESSAGE RESET DOCUMENT 20 April, 2019 PDF // VOLVO XC90 SERVICE MESSAGE RESET DOCUMENT Document Filetype: PDF 137.01 KB 0 PDF // VOLVO XC90 SERVICE MESSAGE RESET DOCUMENT Come to an Authorized Volvo Retailer for Complimentary

More information

How to install the Barnett clutch and the stronger Oil Pump Drive Gear

How to install the Barnett clutch and the stronger Oil Pump Drive Gear How to install the Barnett clutch and the stronger Oil Pump Drive Gear Written by WildFred I m from Germany so please excuse my English and the spelling. The following procedure is a combination of the

More information

DIY: Bake Caliper Rebuild - Bimmerforums - The Ultimate BMW Forum

DIY: Bake Caliper Rebuild - Bimmerforums - The Ultimate BMW Forum Page 1 of 16 Bimmerforums - The Ultimate BMW Forum > Bimmerforums - BMW Car/Model Specific > 3 series (E21, E30, E36, E46, E9x, F30) > 1983-1991 (E30) DIY: Bake Caliper Rebuild Welcome, bdbernard. You

More information

Page 1 of 6 Fuel Charging and Controls - Turbocharger - 2.7L V6 - TdV6 - Turbocharger RH Removal and Installation Special Tool(s) Engine support beam 303-021 Engine lifting brackets 303-1129 Removal 1.

More information

The Basics. What goes wrong?

The Basics. What goes wrong? The Basics Let's cover some basic information on AH, TC, and ABS. In simple terms, these three systems combine data from wheel speed sensors, yaw rate sensors, steering wheel position sensors, along with

More information

Civic Manual Transmission Fluid Change Interval

Civic Manual Transmission Fluid Change Interval Civic 06 09 Manual Transmission Fluid Change Interval Basically I'm just wondering how often I should replace my transmission fluid? My car has Answer 1. The best bet is to follow the change interval described

More information

Daniel : James, does the operational temp have to be achieved before ful power or where at during warm up does it gain its power?

Daniel : James, does the operational temp have to be achieved before ful power or where at during warm up does it gain its power? 1 of 5 12/5/2012 12:52 AM Question List NEW Question List (beta) PM Feedback Reports My Questions My Account Dodge Originating region: United States Category: Chrysler Sub-category: Dodge 3500: i have

More information

How To: Thermostat change - D8 V6 194bhp

How To: Thermostat change - D8 V6 194bhp How To: Thermostat change - D8 V6 194bhp Firstly, take off the Air Filter hoses and connectors and lift off. This leaves you with this workable space... I started with taking the two bolts out of the cable

More information

2017 Land Rover Discovery Td5 Service Manual

2017 Land Rover Discovery Td5 Service Manual 2017 Land Rover Discovery Td5 Service Manual Landrover Discovery TD5 ebay - Land Rover Discovery Series 2 Workshop Manual on CD. Condition: New: Land Rover Discovery TD5 Defender TD5 Filter Service Kit.

More information

Grid connected rooftop solar and the end of the solar bonus feed-in tariff where to get advice.

Grid connected rooftop solar and the end of the solar bonus feed-in tariff where to get advice. Grid connected rooftop solar and the end of the solar bonus feed-in tariff where to get advice. The other topic that has been occupying us lately is the end of the solar feed-in tariff. We apologize that

More information

VW 1998 Jetta GLX or VR6 GTI PCV valve Modification

VW 1998 Jetta GLX or VR6 GTI PCV valve Modification Disclaimer: This is how I ended up modifying my stock PCV so I did not have to buy a complete intake hose (+/- $150). Don t blame me if this does not work or if it makes it worse You are doing this at

More information

Photos of the repair by Tim Miller 1. Handles off

Photos of the repair by Tim Miller 1. Handles off 35 Commander Shower drip solution By Tim Miller and Bruce Harkness Introduction: Some time ago Bruce Harkness posted that he was attacking the dreaded shower drip and replaced original plastic valve seats

More information

Prerequisites: Shop Manual (recommended) pages 3-9 through 3-13.

Prerequisites: Shop Manual (recommended) pages 3-9 through 3-13. Prerequisites: Order your gaskets average about $25.00 bucks X 2 so $50.00 4NK-11193-00-00 Obtain a shim kit (Should have several 265 and 270s) (Some dealers will exchange) Obtain a Valve Bucket Tool YM-33961

More information

2004 Yamaha 300 Hpdi Service Manual

2004 Yamaha 300 Hpdi Service Manual 2004 Yamaha 300 Hpdi Service Manual Yamaha Repair Manuals. i have a 2004 yamaha 300 hpdi i went to the keys for mini season and filled my boat up at a marina several times there when i got back Mar 04,

More information

At Mark's suggestion I thought I'd write this up so future Coupe lovers can have as much fun* as I did with this job.

At Mark's suggestion I thought I'd write this up so future Coupe lovers can have as much fun* as I did with this job. At Mark's suggestion I thought I'd write this up so future Coupe lovers can have as much fun* as I did with this job. My enormous thanks to forum members, particularly glorfindel, for their advice when

More information

Squeaking in the center console??? - Page 7 - GreenHybrid - Hybrid Cars. Register FAQ Members List Today's Posts Search

Squeaking in the center console??? - Page 7 - GreenHybrid - Hybrid Cars. Register FAQ Members List Today's Posts Search GreenHybrid - Hybrid Cars > Hybrid Cars > Toyota Camry Hybrid Squeaking in the center console??? User Name User Name Remember Me? Password Log in Register FAQ Members List Today's Posts Search Toyota Camry

More information

Hole-y plastic bumper front! (How-to: cover license plate holes in bumper trim) Pics!

Hole-y plastic bumper front! (How-to: cover license plate holes in bumper trim) Pics! Hole-y plastic bumper front! (How-to: cover license plate holes in bumper trim) Pics! - e3... Page 1 of 13 e30tech.com Forums> Technical> Appearance Hole-y plastic bumper front! (How-to: cover license

More information

DOWNLOAD OR READ : MANUAL LOCKING HUBS TOYOTA TACOMA PDF EBOOK EPUB MOBI

DOWNLOAD OR READ : MANUAL LOCKING HUBS TOYOTA TACOMA PDF EBOOK EPUB MOBI DOWNLOAD OR READ : MANUAL LOCKING HUBS TOYOTA TACOMA PDF EBOOK EPUB MOBI Page 1 Page 2 manual locking hubs toyota tacoma manual locking hubs toyota pdf manual locking hubs toyota tacoma Toyota Manual Locking

More information

CanuckMark Altimoderator

CanuckMark Altimoderator Navigation Tuning Emotion Forums > BMW > DIY/Tech Tips Water Pump Replacement DIY User Name Password User Name Remember Me? Log in Register FA Members List Calendar Today's Posts Search Thread Navigation

More information

e36_remove_clutch_pedal_slop

e36_remove_clutch_pedal_slop http://www.unofficialbmw.com/e36/drivetrain/.html Page 1 of 12 UnofficialBMW.com [Top Links Search FAQ Parts Used Cars FTP Images New Bulletin Board Garage] Unofficial Homepages: [02 E12 E28 E30 E32 E34

More information

Owners Manual Ford Explorer Sport Trac 2002

Owners Manual Ford Explorer Sport Trac 2002 Owners Manual 2006 2003 Ford Explorer Sport Trac 2002 In case you find 2004 explorer manual, you'll still might require outside Dealing with your owner's manual in this way can help you learn everything

More information

Setup Guide and Chassis Tuning Tips (simple version) By Jim Daniels

Setup Guide and Chassis Tuning Tips (simple version) By Jim Daniels This document is released into the public domain and may be reproduced and distributed in its entirety so long as all credit to Jim Daniels remains. If you find this guide helpful please consider donating

More information

Cummins 6.7 Litre 2500/3500 Diesel EGR System. Always wear gloves and safety glasses when performing this service

Cummins 6.7 Litre 2500/3500 Diesel EGR System. Always wear gloves and safety glasses when performing this service Cummins 6.7 Litre 2500/3500 Diesel EGR System Always wear gloves and safety glasses when performing this service EGR System Consists of: Cold side EGR valve (after EGR cooler) controls exhaust gases for

More information

Exhaust Gas Recirculation Valve, Replace J S file://c:\program Files\cosids\DATA\TMP\ rtf.html. Remove

Exhaust Gas Recirculation Valve, Replace J S file://c:\program Files\cosids\DATA\TMP\ rtf.html. Remove 1 Page 1 of 20 Exhaust Gas Recirculation Valve, Replace J982500 Remove 1. Disconnect battery negative lead 2. Disconnect hose (1) from oil filler on air cleaner assembly, then move to one side Release

More information

Corrado Club of Canada. VR6 Engine FAQ. By: Dennis

Corrado Club of Canada. VR6 Engine FAQ. By: Dennis Corrado Club of Canada VR6 Engine FAQ By: Dennis I thought I would snap a few pics of the engine compartment on my 1994 VR6 Corrado. First, this is the updated engine management system so it does have

More information

USER MANUAL

USER MANUAL USER MANUAL helpdesk@ambermobility.com 085 301 15 13 version 2.0 August 2017 1 Contents Instruction videos 3 The Amber Mobility app 4 Logging in 4 Reservations 4 Reserve a car 4 My trip 4 Profile 5 Other

More information

List of parts needed below. Tools needed

List of parts needed below. Tools needed 1 BMW 645 Coolant leak repair (Cap with Seal Repair and Expanding Coolant Pipe Installation w Pics) By Michael R. Brown (Estimated time to complete the job is 6-8 hrs) List of parts needed below. BMW PART

More information

CLEVOR ENGINE BUILDS

CLEVOR ENGINE BUILDS CLEVOR ENGINE BUILDS The most popular, low-buck heads for making power from a small-block Ford are the 351W versions with a nice port job, which makes for a snappy 289/302 without selling the farm. But

More information

Hood stripes Tools needed from AutoZone or any auto parts store: bottle spray, squeegee, a towel that you re using to clean you car up after washing,

Hood stripes Tools needed from AutoZone or any auto parts store: bottle spray, squeegee, a towel that you re using to clean you car up after washing, WARNING These following pages are instruction for C5 CE stripes; however, it is the same method applying vinyl. Please spend time to read thru these pages. At the end, it is your C5 GS1 stripes instruction.

More information

W123 Transmission Vacuum Modulator Adjustment DIY - measure it the 'right' way

W123 Transmission Vacuum Modulator Adjustment DIY - measure it the 'right' way W123 Transmission Vacuum Modulator Adjustment DIY - measure it the 'right' way Why do you need to do this?: You need to do this to properly check the internal hydraulic pressure of the transmission, either

More information

ESS INSTALL. The donor car /6 Cosmos Black/Sand UUC Short Shifter Brembo cross drilled rotors Phillips Nav System 16:9

ESS INSTALL. The donor car /6 Cosmos Black/Sand UUC Short Shifter Brembo cross drilled rotors Phillips Nav System 16:9 ESS INSTALL The donor car.. 1997 540/6 Cosmos Black/Sand UUC Short Shifter Brembo cross drilled rotors Phillips Nav System 16:9 The install went in several stages. Disconnect the battery Stage 1 Remove

More information

CHAPTER 9: CONRODS, PISTONS AND BARRELS BACK ON

CHAPTER 9: CONRODS, PISTONS AND BARRELS BACK ON CHAPTER 9: CONRODS, PISTONS AND BARRELS BACK ON Posted on the Wildguzzi forum by Pete Roper: January 17, 2006: Contents: Assembling the engine. Conrods, pistons and barrels back on. Pic 9-1: OK, this is

More information

perelet Member 1 of 26 7/26/2014 9:31 AM Thread: E39 6cyl oil pan gasket replacement illustrated E39 6cyl oil pan gasket replacement illustrated

perelet Member 1 of 26 7/26/2014 9:31 AM Thread: E39 6cyl oil pan gasket replacement illustrated E39 6cyl oil pan gasket replacement illustrated 1 of 26 7/26/2014 9:31 AM User Name Password Log in Remember Me? Help Register Forum What's New? Home Classifieds Vendors Vendor Specials Store New Rules Posts FAQ Advertising Calendar Community Forum

More information

1 of 12 12/30/2012 6:06 PM

1 of 12 12/30/2012 6:06 PM 1 of 12 12/30/2012 6:06 PM Search Welcome, Guest. Please login or register. Did you miss your activation email? Forever Login Login with username, password and session length News: Home Help Facebook Login

More information

99 Ford Expedition Owners Manual READ ONLINE

99 Ford Expedition Owners Manual READ ONLINE 99 Ford Expedition Owners Manual READ ONLINE My 1998 Ford expedition keeps. 1999 Ford Answered on Jun 05, 2015. 1 Answer I have a 1999 Ford Expedition without an owners manual. 1998 Ford Expedition Owners

More information

Installation Directions for FINGER STICK and Blocker Plate

Installation Directions for FINGER STICK and Blocker Plate Installation Directions for FINGER STICK and Blocker Plate What is a Finger Stick? A Finger Stick is a simple circuit that modifies the MAF signal on LLY and LBZ engines (not LB7 engines) to expected levels

More information

U-Score U-Score AAC Rank AAC Rank Vocabulary Vocabulary

U-Score U-Score AAC Rank AAC Rank Vocabulary Vocabulary go 1 927 you 2 7600 i 3 4443 more 4 2160 help 5 659 it 6 9386 want 7 586 in 8 19004 that 9 10184 like 10 1810 what 11 2560 make 12 1264 is 13 10257 on 14 6674 out 15 2350 do 16 2102 here 17 655 eat 18

More information