JOYSTICK STEERING CONTROL & RELATED PARTS (continued)

Transcription

1 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL COUNTRY CLIPPER " ZETON BRAT" ZERO TURN RADIUS MOWER TABLE OF CONTENTS PAGE... CONTENTS SECTION MOWER DECKS AND RELATED S.... " DECK ASSEMBLY.... " DECK ASSEMBLY.... DECK SPINDLE ASSEMBLY.... DRIVE BELT IDLER & RELATED S.... LIFT HANDLE ASSEMBLY & RELATED S....LIFT ASSEMBLY & RELATED S.... DOUBLE IDLER & RELATED S SECTION TRACTOR FRAME AND RELATED S.....CASTER WHEEL ASSEMBLY.....FRAME SIDES & RELATED S 0....FENDER ASSEMBLY....SEAT, FOOT DECK & RELATED S SECTION TRACTOR DRIVE AND RELATED S....FUEL TANK ASSEMBLY....JOYSTICK STEERING CONTROL & RELATED S....JOYSTICK STEERING CONTROL & RELATED S (continued)....right HAND STEERING CONTROL & RELATED S....LEFT HAND STEERING CONTROL & RELATED S....PARKING BRAKE ASSEMBLY & RELATED S....GEAR MOTOR WHEEL ASSEMBLY....MOTOR ASSEMBLY & RELATED S 0....HIGH PRESSURE LINES & FITTINGS....OIL RETURN LINES & COOLER ASSEMBLY....MOTOR TO PUMP SINGLE IDLER....WIRE HARNESS & RELATED S

2 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL " DECK ASSEMBLY 0 0,, 0 0,, 0A " DECK W/DECALS 0A PULLEY COVER RH, W/DECAL 0A PULLEY COVER LH, W/DECAL 0 0W 0A 0W 0BP D D 0P H 0P OUTLET STIFFENER " DECK CHUTE W/DECAL DECK HANGER PULLEY, /" DIA. GROOVE VBELT (KEVLAR) A VBELT, MOTOR TO DECK SINGLE IDLER ASSEMBLY (SEE BREAKDOWN PAGE) SPINDLE ASSEMBLY (SEE BREAKDOWN PAGE) REAR SCALPER BRACKET ROLLER, / DIA. X / WHEEL BUSHING F / X " GR. F / LOCKNUT F000 / FLAT WASHER F / X / GR. 0 F00 /" LOCKWASHER F CARRIAGE BOLT, / X / F /0 X / GR. F00 /" LOCKWASHER 0 F000 F F000 F F0 H0 F F H /" FLAT WASHER CARRIAGE BOLT / X / /" FLAT WASHER / LOCKNUT / X " GR. PIN, /" X /" PIN, /" X / /" FLAT WASHER RUE RING /" P0 DECAL, "GREASE SPINDLE" P0 DECAL,"MISSING CHUTE" P0 DECAL, "ROTATING..." P0 DECAL, "MULTI PERIL" P DECAL, "HOIST POINT" H SAFETY TREAD 0 P0 DECAL, "WARNING" F000 LOCKNUT, / STOVER 00W F F 0P 0W AFTER SERIAL # DECK HANGER /0 LOCKNUT AIR BAFFLE DUST BAFFLE WLDT, " CARRIAGE BOLT, / X / F CARRIAGE BOLT, / X /

3 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL " DECK ASSEMBLY 0 0,, 0 0,, AFTER SERIAL #0 0A " DECK WLDT, W/DECALS F /0 X / GR. 0A PULLEY COVER RH, W/DECAL F00 /" LOCKWASHER 0A PULLEY COVER LH, W/DECAL F000 /" FLAT WASHER 0W OUTLET STIFFENER F CARRIAGE BOLT / X / 0A " DECK CHUTE W/DECAL F000 /" FLAT WASHER 00W DECK HANGER F / LOCKNUT 0AP PULLEY, " DIA. GROOVE F0 / X " GR. D VBELT (KEVLAR) A00 H0 PIN, /" X /" D VBELT, MOTOR TO DECK 0 F PIN, /" X / 0 SINGLE IDLER ASSEMBLY F /" FLAT WASHER (SEE BREAKDOWN PAGE) H RUE RING /" SPINDLE ASSEMBLY P0 DECAL, "GREASE SPINDLE" (SEE BREAKDOWN PAGE) P0 DECAL,"MISSING CHUTE" DRIVE BELT IDLER P0 DECAL, "ROTATING..." P0 (SEE BREAKDOWN PAGE) DECAL, "MULTI PERIL" P DECAL, "HOIST POINT" 0P REAR SCALPER BRACKET H 0P ROLLER, / DIA. X / WHEEL BUSHING F / X " GR. F / LOCKNUT F000 / FLAT WASHER F / X / GR. 0 F00 /" LOCKWASHER F CARRIAGE BOLT, / X / H SAFETY TREAD 0 P0 DECAL, "WARNING" F000 LOCKNUT, / STOVER F LOCKNUT, /0 F CARRIAGE BOLT, / X / F CARRIAGE BOLT, / X / 0P AIR BAFFLE W DUST BAFFLE WLDT, "

4 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL DECK SPINDLE ASSEMBLY 0 0 0F0A SPINDLE ASSEMBLY H0 GREASE FITTING 0P SPINDLE SHAFT 0P SPINDLE HOUSING D0 BEARING, #0RS H SNAP RING INT. MM 0P BLADE SPACER D000 KEY, WOODRUF, / X / F / X /" HHCS GR. F /" LOCK WASHER 0 F0 WASHER, /" CUPPED 0P WASHER, SEAL 00P ARBOR SPACER H0 GREASE VENT LBS. F / NUT, HEX JAM F /" LOCK WASHER F0 /" WASHER, FLAT STD. 0P PULLEY, GROOVE " F / X /" HHCS GR. 00P SPINDLE SPACER REINFORCEMENT 0 0BP PULLEY, GROOVE " 0AP PULLEY, GROOVE " F00 /" LOCK WASHER F / LOCKNUT, MF H BLADE, LOW L, " CUT " H BLADE, LOW L, " CUT " OPTIONAL BLADES H BLADE, HIGH L, " CUT " H BLADE, HIGH L, " CUT "

5 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL DRIVE BELT IDLER & RELATED S SINGLE IDLER ASSEMBLY & RELATED S 0 0 TOP OF DECK TOP OF DECK TOP OF DECK 00W 0W 00P 00P SINGLE IDLER, " DECK SINGLE IDLER, " DECK SPACER, " DIA. X " BEARING CAP 0P D H0 F F00 F 0 F F000 F F PIN PULLEY, FLAT IDLER SPRING, /" X " / X " GR. / SHCS X /" / X /" GR. / LOCKNUT / FLAT WASHER / LOCK NUT /" FLAT WASHER F /" LOCK NUT F CARRIAGE BOLT, / X /" 00P REINFORCEMENT WASHER

6 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL LIFT HANDLE ASSEMBLY & RELATED S 0 SEE ASSEMBLY NUMBER PAGE 0 NOTE: BEFORE SERIAL #, THERE WAS () # WASHER ON EITHER SIDE OF LIFT HANDLE, () HANDLE LINK AND () F0 BOLT. 0 0P 00W 0P 00P 0P 0P P P H0 0W F000 F 0W F F000 F F00 F0 F0 LIFT HANDLE FRAME WELDMENT, LH. SPRING EXTENSION SPRING ANCHOR PLATE HANDLE LINK HANDLE PIVOT BRACKET TOP PEG LATCH PLATE TOP PEG SPACER PLATE SPRING, /" OD. X " SPRING TIGHTENER WLDT. FLAT WASHER, /" CARRIAGE BOLT, / X /" SPRING ANCHOR WELDMENT / X /" GR. NUT, / LOCKNUT / X " FULL THREAD HEX NUT, / UNCB / X /" GR. / X " GR. F 0 0P F000 F F H H D H0 F F P / X /" GR. HANDLE PIVOT PIN NUT, / LOCKNUT (STOVER) CLEVIS PIN, / X /" /" FLAT WASHER RUE RING, /" VINYL GRIP, / X /" /" CHROME STEEL BALL SPRING,. OD X.0 WIRE / X /", G. NUT. /" STOVER LATCH F00 / X /" GR.

7 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL LIFT ASSEMBLY & RELATED S THIS CONFIGURATION FOR EARLIER MODELS W FRONT AXLE WELDMENT 00W FRAME WELDMENT, LH 0W FRAME WELDMENT, RH 0W FRONT PIVOT CHANNEL 0P LINK BAR 00P DECK LATCH (FLIP UP) 0P TOP HANGER PIN 00P LIFT BAR 0 0P 0P LIFT SLEEVE, FRONT LIFT SLEEVE, REAR 000P LINK BAR 0P ADJUSTABLE HANGER ROD H F0 RUE RING, /" F F 0P ROLLER 0 0P F0 F000 0 F F F F CLEVIS PIN, / X /" CLEVIS PIN, / X /" RUE RING, // PIN SPACER, TOP PEG ROLL PIN, / DIA. X.0 FLAT WASHER, /" LOCK NUT / / X / HH GR. / X /" HH GR. CLEVIS PIN, / X " F / JAM NUT F NUT, / STOVER F CLEVIS PIN, / X /" F WASHER, / NARROW P SPRING ANCHOR F W ROLL PIN, / X " HANGER END WELDMENT H0 EXT. SPRING, / X. F0 CAPSCREW, / X " F HOOK BOLT, / X " P ADJUSTABLE HANGER END HANGER PIN P F / X /, " THREAD 0 F NUT. /" JAM REAR DECK HANGER ASSEMBLY A P F F H0 W D LATCH / X /", G. NUT. /" STOVER SPRING,. OD X.0 WIRE REAR DECK HANGER WLDT /" CHROME STEEL BALL

8 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL DOUBLE IDLER & RELATED S 0 D D H0 0W 0P 00P F F000 F000 0 F F D F000 F0 F F F FLAT IDLER PULLEY VIDLER PULLEY SPRING IDLER ARM PIN BEARING CAP /" FLAT WASHER, (NARROW) /" FLAT WASHER, (STANDARD) /" LOCK NUT / X " GR. / X /" GR. BUSHING DX / X / / FLAT WASHER / X /" GR. / LOCK NUT / LOCK NUT / X /" GR.

9 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL CASTER ASSEMBLY WHEEL 0 W P 00P P D P D CASTER WELDMENT BEARING SPACER BEARING CAP BEARING SHIELD BEARING, / ID X / OD DECAL,, PSI TIRE,. X W/WHEEL 0 F F000 F D000 F000 F00 F0 H0 / X " GR. BOLT / LOCK NUT / ROLL PIN BEARING, SPD SF /" FLAT WASHER /" LOCK WASHER /0 X / W/NYLON PATCH SEE PAGE / GREASE ZERK

10 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL FRAME SIDES & RELATED S 0 0 0W FRAME SIDE RH. 00W 000W 00W 0P 00P 0P 0P FRAME SIDE LH. FRONT AXLE MOTOR MOUNT WLDT. SIDE PANEL RH. SIDE PANEL LH. ENGINE GUARD ENGINE GUARD MNT. LEG F000 F F F F F /" LOCK NUT / X " GR. / X " GR. / X /" GR. / X /" GR. / X /" GR. 0 0P 0P DRAG BAR TAB BRAKE ROD MOUNT 0 F F F0 F 0 / X /" GR. / X /" GR. / X /" GR. / LOCK NUT 0W SPRING ANCHOR 0

11 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL FENDER ASSEMBLY 0 0 COUNTRY CLIPPER BRAT A FENDER CAP RH W/DECAL 0A FDR. CAP RH. LEV. W/DECAL 0A FDR. CAP RH W/EFI DECAL 0A FDR. CAP RH. LEV. W/EFI DECAL A A 00A FENDER SKIRT RH W/DECAL FENDER SKIRT LH W/DECAL FRONT PANEL ASS'Y. W/DECAL A LATCH PLATE RH W/DECAL 0 P P 0P 00P 0P 00P F000 F F0 F F0 LATCH PLATE DECAL, BRAT LH. SIDE PANEL RH. SIDE PANEL LH. TRIM, FUEL TANK TRIM, OIL TANK / FLAT WASHER / LOCK NUT /" X. CLEVIS PIN W/SASH / X /" GR. / X " GR. 0A FENDER CAP LH. W/DECAL A FDR. CAP LH. LEV. W/DECAL F0 / UNUT P0 DECAL, "CUT HEIGHT" 0 P0 DECAL, "CAUTION" P0 P DECAL, "WARNING" DECAL, RH. FENDER CAP P DECAL, PARK BRAKE F00 P / LOCK WASHER DECAL, "COUNTRY CLIPPER" 0

12 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL SEAT, FOOTDECK & RELATED S P 0P P P 0W P 00P A SEAT BRACKET REAR BRACE ARM REST RH. (JOYSTICK) ARM REST, (TWIN STICK) ARM REST LH. (JOYSTICK) ARM REST, (TWIN STICK) LIFT BAR FOOT DECK ASSEMBLY 0 H0 ROUND GRIP BALL F F00 F00 F H / X /" GR. / LOCK WASHER / LOCK WASHER / X /" GR. SAFETY TREAD F0 / X " GR. 00P TRIM, UCHANNEL, /" A ARM REST PAD 00P FLAT WASHER H SEATDELUXE 0 H F0 F F F000 F00 F000 F000 0 SEATSTANDARD UNUT / / X " GR. / LOCK NUT / FLAT WASHER / PLAIN NUT / LOCK NUT / FLAT WASHER

13 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL FUEL TANK ASSEMBLY H GALLON TANK H 0P GAS CAP /" FUEL LINE H H HOSE BARB, 0 DEG. HOSE CLAMP H HOSE CLAMP, /"

14 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL JOYSTICK STEERING CONTROL AND RELATED S 0 NOTE; ITEM'S # AND # MUST BE REPLACED AT THE SAME TIME FOR MAXIMUM PERFORMANCE. 0 A P H 0P F0 H 0P F 0P H JOYSTICK ASSEMBLY JOYSTICK YOKE PIVOT SHAFT PIVOT BLOCK BALL PLUNGER SNAP RING, SPIRLOCK PIVOT BLOCK PLATE # X /" SCREW SLOT JOYSTICK TOP PLATE GASKET, FOAM 0 H BOOT, BELLOWS F F00 /0 X /" FHCS GR. /0 X " HHCS GR. F00 /" LOCK WASHER F H /0 LOCK NUT BUSHING, BALL JOUNT F /0 X " GR. F00 / NUT, JAM H0 GRIP, BALL 0 0A JOYSTICK SHAFT ASSEMBLY H LINKAGE ASSEMBLY

15 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL JOYSTICK STEERING CONTROL AND RELATED S (continued) FRONT OF TRACTOR 0 0P 0A 0W 00P 0P 00P F000 F F00 F F00 F F0 H F H F SHIFT LINKAGE DISK ASSEMBLY SHIFT SWIVEL LOWER LINKAGE ROD SEE PAGE 0 THRUST ARM ROD ARM WASHER /" FLAT WASHER /0 LOCK NUT /" LOCK WASHER /0 X /" GR. /0 X " GR. ROLL PIN, MM X MM ROLL PIN, /" X " UPPER LINKAGE SPIROL RING BALL JOINT / NUT

16 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL RIGHT HAND STEERING CONTROL AND RELATED S H00 H0 00A F F0 H0 H0 0P F 0 F H 0P D F00 F000 0P F00 F00 F 0 H END PLUG, /" BLACK FOAM GRIP, " CONTROL LEVER ASSEMBLY HOSE CLAMP BOOT, TAPERED " CUFF LEVER, DUALEVER / JAM NUT WASHER, FIBER PIVOT BLOCK, DUALEVER BEARING /" LOCK WASHER WASHER, FLAT STD. /" BASE DUALEVER /" LOCK WASHER / LOCK NUT / X /" HHCS GR. SETSCREW, / X /" /0 X " HHCS GR. / X /" HHCS GR. WASHER, SPRING F F F 0 F00 F 0P F F000 0A F F00 F0 0P 0 F H F0 H 0P 0P F /" LOCK WASHER / X /" HHCS GR. / X " HHCS GR. /0 PLAIN NUT /" LOCK WASHER LINKAGE LINKAGE DISK ASSEMBLY SETCREW, /0 X /" /0 PLAIN NUT / X /" HHCS GR. DAMPER BOLT, X /" /0 X /" HHCS GR. STEERING UPPER LOWER PINTLE /0 LOCK NUT /" FLAT WASHER DAMPER ERING FOR /" SHAFT LINKAGE LINKAGE DAMPER BOLT, /0 NUT, HEX / UNF 00P SHOULDER BOLT, /" OD 0P SHIFT ARM 0P BUSHING, STAND OFF F /" LOCK NUT 0P BUSHING, PIVOT BLOCK F /0 X /" HHCS GR. 0P WASHER, FLAT 0 H BUSHING, LARGE F GROMMET, # X /" SQ. H BUSHING, SMALL 0P TOP PLATE, DUALEVER H BALL JOINT

17 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL LEFT HAND STEERING CONTROL AND RELATED S H00 H0 00A F F0 H0 H0 0P F F H 0P D F00 F000 0P F00 F00 F H 00P 0P 0P 0P F 0P END PLUG, /" BLACK FOAM GRIP, " CONTROL LEVER / LOCK NUT / X /" HHCS GR. HOSE CLAMP BOOT, TAPERED " CUFF LEVER, DUALEVER SETSCREW, / X /" / JAM NUT WASHER, FIBER PIVOT BLOCK, DUALEVER BEARING /" LOCK WASHER WASHER, FLAT STD. /" BASE DUALEVER ASSEMBLY /" LOCK WASHER /0 X " HHCS GR. / X /" HHCS GR. WASHER, SPRING SHOULDER BOLT, /" OD BUSHING, STAND OFF BUSHING, PIVOT BLOCK WASHER, FLAT GROMMET, # X /" SQ. TOP PLATE, DUALEVER F F F F00 F 0P F F000 0A F F00 F0 0P F00 H F0 H 0P 0P F 0P F F H H /" LOCK WASHER / X /" HHCS GR. / X " HHCS GR. /0 PLAIN NUT /" LOCK WASHER LINKAGE /0 LOCK NUT /" FLAT WASHER LINKAGE DISK ASSEMBLY SETCREW, /0 X /" /0 PLAIN NUT / X /" HHCS GR. DAMPER BOLT, X /" /0 X " HHCS GR. STEERING ERING FOR /" SHAFT UPPER LOWER DAMPER BOLT, /0 NUT, HEX / UNF SHIFT /" LOCK NUT /0 X /" HHCS GR. BUSHING, SMALL BALL LINKAGE LINKAGE ARM JOINT PINTLE DAMPER

18 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL PARKING BRAKE ASSEMBLY & RELATED S W BRAKE ROD WELDMENT 0P BRAKE ROD MOUNT 0W BRAKE ARM SHORT, LH. 0W BRAKE ARM SHORT, RH. 0P BRAKE LINK 0P BRAKE HANDLE 0P BRAKE SWITCH BRACKET 0P FRONT PANEL F000 / FLAT WASHER 0P BRAKE PIVOT TUBE F RUE RING 0 F /" PIN F / X /" GR. F /0 X /" GR. F000 /" FLAT WASHER F000 /0 LOCK NUT F00 /" LOCK WASHER F / X " ROLL PIN F / X /" ROLL PIN F COTTER PIN, / X " F CLEVIS PIN, / X /" 0 F CLEVIS PIN, / X /" 00P BRAKE ANCHOR LINK D BRAKE BAND 0P TOP HANGER PIN 00P BRAKE YOKE LINKAGE F / LOCK NUT F / X " GR. 0W BRAKE ARM WLDT., LONG F0 /" X /" ROLL PIN 0 H HANDLE GRIP

19 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL GEAR MOTOR,WHEEL ASSEMBLY W D 0P D 0P 0P 00P F0 F0 H 0P H F P0 F000 MOTOR WHEEL SPACER, SHORT CAPSCREW, / X " GR. NUT, / CASTLE NUT GREASE WASHER MOUNT MOTOR WHEEL HUB W/STUDS TIRE W/RIM,.0 BRAKE MOUNT PLATE SPACER, LONG CAP COTTER PIN, / X /" LUG NUT, /0 X 0 DEG. DECAL, TIRE PRESSURE / LOCK NUT F WHEEL STUD, (REPLACEMENT) D000 KEY, / X " WOODRUFF

20 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL 0 MOTOR ASSEMBLY & RELATED S 0 0 M HP. KAWASAKI ENGINE F0 /0 X /" P KEY, / SQ. X /" H0 / X " PIPE NIPPLE H /" PIPE ELBOW 0 M0 E D 0P F00 H H P00 F H0 HP. KAWASAKI ENGINE CLUTCH, MAGSTOP " HYDRO PUMP BELT WASHER / LOCK WASHER CHOKE CABLE THROTTLE CABLE DECAL, "CLEAN" SETSCREW, /" X /" PLUG, /" NPT 0 D H 0P 0P 00W F000 F000 F0 F F 0P D / PORT ORING DRAIN NUT, / STOVER / FLAT WASHER / X /" GR. MM X MM GR. MM WASHER ADAPTER MOTOR PULLEY HYDRO PUMP PULLEY SEE PAGE 0 MOTOR WASHER KEY, MM. MOUNT F0 / X /" GR. 0 F00 /" LOCK WASHER F00 / PLAIN NUT 0W CLUTCH STOP WELDMENT F /0 X /" GR. F /0 LOCK NUTS H MUFFLER ASSEMBLY

21 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL HIGH PRESSURE LINES & FITTINGS 0 VIEWED FROM RIGHT REAR H H0 H H H H D D TUBE ASS'Y, RH. FORWARD TUBE ASS'Y, RH. REVERSE TUBE ASS'Y, LH. FORWARD TUBE ASS'Y, LH. REVERSE FITTING, 0 DEG. ELBOW, / FITTING, STRAIGHT, / WHEEL HYDRAULIC MOTOR PUMP F0 /0 X " GR. (FOR HANDLE) 0 F /0 LOCK NUT 0

22 F COUNTRY CLIPPER "ZETON" MOWER REPAIR S MANUAL OIL RETURN LINES & COOLER ASSEMBLY W BRACKET, OIL COOLER H OIL COOLER SEE PAGE 0 H0 TANK, QUART 0A 0P H0 H0 F F000 F00 F000 F H F00 H0 H H H / X / GR. 0 / FLAT WASHER /0 X " GR. /" FLAT WASHER CAP, HYDRO TANK TANK MOUNT BRACKET FILTER, HYDRO FILTER BASE /" LOCK NUT HOSE CLAMP LOCK WASHER ADAPTER ELBOW CAPLUG, / X " HOSE CLAMP 0 H HOSE, SUCTION H HOSE, RETURN H HOSE, " HITEMP H HOSE, " HITEMP H ELBOW, / PIPE & HOSE BARB F / STOVER NUT F00 / LOCK WASHER F /0 X /" GR.

23 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL TOP OF MOTOR MOUNT 0 MOTOR TO PUMP SINGLE IDLER 0 0 A 0W D 0P 0P H0 D F0 SINGLE IDLER ASSEMBLY SINGLE IDLER WELDMENT BUSHING, DX / X /" SPRING EXTENSION MOUNTING PIN SPRING FLAT IDLER PULLEY / X /" HHCS GR. 0 0 F000 F F F F F 0P F F0 F000 P /" FLAT WASHER / LOCK NUT / X " HHCS GR. / LOCK NUT /" FLAT WASHER /" LOCK WASHER IDLER STAND / X " GR. / X " GR. / FLAT WASHER SPRING ANCHOR BUSHING

24 COUNTRY CLIPPER "ZETON BRAT" MOWER REPAIR S MANUAL WIRE HARNESS & RELATED S S SHOWN IN BOX ARE USED ONLY ON TWINSTICK MODEL YELLOW 0 0 BLK. BLUE () BLUE BLUE BLUE YELLOW BLK. BLK. TO STARTER RED () BLUE RED GREEN TO ENGINE BLK. BLK. () BLUE BLUE RED YELLOW BLK. () RED TO STARTER YELLOW () BLUE RED BLK. RED TO CLUTCH RED BLK. RED RED GREEN () RED 0 () BLUE () RED () RED BLK. E E E E0 E E 0P F LOCK NUT F0 E X / SCREW BRAKE SWITCH 0 E0 SWITCH, SPDT MINI E0 USED ON TWINSTICK 0 X / SCREW F F USED ON TWINSTICK F STAR WASHER F USED ON TWINSTICK F F F000 00A BATTERY USED ON HP BATTERY USED ON HP HOUR SOLENOID START BRAKE METER SWITCH CLUTCH SWITCH SWITCH BRACKET /0 X /" GR. /0 LOCK NUT /" FLAT WASHER BATTERY HOLD DOWN E 0 00W F F0 F00 F E E0 E0 F0 F WIRE HARNESS LOCK NUT X /" MACHINE SCREW /0 X /" GR. / NUT COVER (KEY SWITCH) NOT OIL PRESSURE SWITCH NOT WIRE HARNESS ADAPTER NOT BATTERY SHOWN SHOWN SHOWN BOX / X " GR. / LOCK NUT F000 / WASHER