Fitting Instructions

Size: px
Start display at page:

Download "Fitting Instructions"

Transcription

1 Tow-Pro Wiring Kit Fitting Instructions Suitable for: Toyota Hilux / Fortuner Accessory Kit Estimated Fitting Time: 90 Minutes FI807 Page 0 of Issue: Date: /08/08 08

2 General Notes Safety Notes Suitable for: Hilux / Fortuner Read through the fitting instructions before installation of the accessory. Install the accessory following the fitting instructions. Failure to do so may cause damage to the vehicle or the accessory. Ensure all recyclables, discarded vehicle accessory components and packaging are recycled following local recycling regulations. It is always recommended that this accessory is fitted by a qualified automotive Technician. Safely store and protect any removed vehicle components. Ensure all bare metal surfaces are protected using automotive bare metal primer and touch-up paint, or suitable automotive rust inhibitor. Remove all metals swarf and dust from all vehicle surfaces if surfaces are used for accessory installation. Check that all work practices comply with safety standards. Please wear appropriate clothing and use safety equipment. Parts Supplied A B C D E F Electric Brake Harness x -way connector x Switch Insert x Brake Controller Bracket x Butt Splice x Heat Shrink x G H I J K L M6 Spring Washer x M Flat Washer x M Spring Washer x M Pan Head Bolt x M6 Flat Washer x M6 Bolt x M N 900mm x0 00mm x0 Cable Tie x0 Fitting Instruction x Tools Required Phillips Head Screw Driver Ratchet Socket Set Side Cutters Trim Removal Tool PVC Tape FI807 Page 0 of Issue: Date: /08/08 08

3 Wiring Diagram FI807 Page 0 of Issue: Date: /08/08 08

4 Step Important Always refer to the vehicle s Workshop Manual when removing vehicle components. Note down all clock and radio settings. In the engine bay, disconnect the negative battery terminal (). Step Unclip the glove box dampener (). Remove LH retaining clip () by rotating anti-clockwise. Remove the glove box (). Remove the passenger s lower dash garnish (). Step In the LHS front cabin, remove the LHS front scuff plate (). Remove the plastic nut () securing the driver s kick panel () and remove the kick panel (). FI807 Page 0 of Issue: Date: /08/08 08

5 Step In the passenger side footwell area, remove the white plastic cap (). Using a large screwdriver, dislodge the carpet (). Step In the engine bay on the passenger side, remove the smaller grommet (). Insert a sharp object through the hole to pierce the firewall insulation. Note: If required, inside the cabin use a knife to enlarge the in hole in the firewall insulation. Feed the Electric Brake Harness through the grommet hole until the grommet is seated correctly and makes a good seal. Step 6 Route the Electric Brake Harness () towards the driver side. FI807 Page 0 of Issue: Date: /08/08 08

6 Step 7 Continue routing the Electric Brake Harness () across the centre console and towards the driver side lower dash area. Secure the harness () to the vehicle using supplied cable ties every 00mm. Step 8 Inside the vehicle, using the table below, house the terminals () from the Electric Brake Harness into the supplied -Way Connector (), ensuring the terminals lock into the housing. Snap off the secondary lock () from behind the -Way Connector (). Fit the secondary lock () to the underside of the -Way Connector (). Terminal Wire Colour Red Blue White Black Rear View of Connector (Wire Entry Side) Step 9 Secure the Brake Controller ECU () onto the Brake Controller Bracket () using supplied M Screws () M Spring Washer () and M Flat Washers (). FI807 Page 06 of Issue: Date: /08/08 08

7 Step 0 Connect the -Way connector () from the Electric Brake Harness to the Brake Controller ECU (). Connect the supplied cat- cable () to the Brake Controller ECU (). Step Underneath the RHS of the dash, secure the ground ring terminal () from the Electric Brake Harness to the vehicle earth point () using the existing fastener (). Secure the Brake Controller bracket assembly () to the vehicle using the supplied M6 fasteners () in the existing holes. Step Fit the switch insert () into the dash. FI807 Page 07 of Issue: Date: /08/08 08

8 Step Plug the cat- cable () into the remote head (). Secure the remote head to the switch insert () as shown, (image A). Torque the nut ()to 0.8 Nm. Rotate the shaft () fully anti-clockwise and fit the knob to the shaft () with 0" pointing upwards as shown (image B). A B Step In the engine bay, secure the fused link ring terminal () to the positive battery terminal (). Secure the harness with the supplied Cable Ties. Step Route the RED, RED/WHITE & BLUE wire branch on the Electric Brake Harness down the transmission tunnel. Continue routing the Electric Brake Harness () down the chassis rail. Route the Electric Brake Harness () across the rear bumper towards the trailer socket head. Secure the Electric Brake Harness using the supplied cable ties every 00mm. FI807 Page 08 of Issue: Date: /08/08 08

9 Step 6 Remove the BLUE wire () from the trailer wiring harness socket head (). Tape back and isolate. Insert new BLUE wire with brass ferrule from the Electric Brake Harness into the same position in the trailer socket. Pin No. Function Cable Colour 6 7 Left-hand turn signal Reversing signal Earth return Right-hand signal Service brakes Stop lamp signal Rear lamps, clearance and side marker lamps Yellow Black White Green Blue Red Brown 7 6 Step 7 Locate RED wire () on the trailer wiring harness socket head. Cut the wire 0mm from the base of the socket. 0mm Pin No. Function Cable Colour 6 7 Left-hand turn signal Reversing signal Earth return Right-hand signal Service brakes Stop lamp signal Rear lamps, clearance and side marker lamps Yellow Black White Green Blue Red Brown 7 6 X Step 8 Butt-splice and heat shrink the previously cut RED wire on the vehicle end, to the RED/WHITE wire on the Electric Brake Harness. Remove the cut RED wire from the trailer socket. Insert new RED wire with brass ferrule from the Electric Brake Harness into the same position in the trailer socket. Keep heatshrink away from joint until after soldering is complete and cooled. Crimp both wires to the butt splice using indent type crimpers. Solder the wires to the butt splice. Ensure that a good connection is made. Wait for the butt splice to cool, slip heatshrink over the joint and heat. FI807 Page 09 of Issue: Date: /08/08 08

10 Step 9 Re-connect the negative battery terminal. Test the operation of the Tow-Pro system as per the Tow-Pro user manual. Dispose of any parts not used from the fitment. Important Secure all harnesses to the vehicle using cable ties. Refit all removed parts and secure all fasteners to the Service Manual torque specifications. Important Reprogram all radio stations and clock settings by referring to the vehicle's Owner's Manual. Please place the Fitting Instructions and Owner s Manual in the glovebox after the installation is completed. E. & O.E. This document is copyright and must not be used except as permitted below or under the Copyright Act 968. You may reproduce and publish this document in whole or in part for your or your organisation's own personal or internal compliance, educational or noncommercial purposes. You must not alter or amend this document in any way. You must not reproduce or publish this document for commercial gain without the prior written consent of the copyright owner. FI807 Page 0 of Issue: Date: /08/08 08

11 Suitable for: Hilux / Fortuner FI Issue: Date: /08/08

Accessory Kit Estimated Fitting Time: 120 Minutes (Prado) Estimated Fitting Time: 140 Minutes (Kluger)

Accessory Kit Estimated Fitting Time: 120 Minutes (Prado) Estimated Fitting Time: 140 Minutes (Kluger) Tow-Pro Wiring Kit - Toyota Kluger / Prado Accessory Kit Estimated Fitting Time: 0 Minutes (Prado) Estimated Fitting Time: 0 Minutes (Kluger) FI99 Page 0 of Issue: Date: 0/0/0 0 General Notes Read through

More information

Accessory Kit Estimated Fitting Time: 120 Minutes

Accessory Kit Estimated Fitting Time: 120 Minutes Landcruiser LC00 Tow-Pro Wiring Kit - Landcruiser LC00 Kit Part No: TPWKIT - 005 Accessory Kit Estimated Fitting Time: 0 Minutes FI88 Page 0 of Issue: Date: 7/09/07 07 General Notes Safety Notes Parts

More information

Fitting Instructions

Fitting Instructions Tow-Pro Wiring Kit Fitting Instructions Holder Colorado / Colorado 7 Accessory Kit Estimated Fitting Time: 0 Minutes FI7 Page 0 of General Notes Read through the fitting instructions before installation

More information

Fitting Instructions

Fitting Instructions Reverse Park Assist Suitable for: Nissan Navara Kit Part No: 5466XX NP00 Tow-Pro Wiring Kit Fitting Instructions Accessory Kit Estimated Fitting Time: 0 Minutes FI98 Page 0 of 5 General Notes Read through

More information

Fitting Instructions

Fitting Instructions Reverse Park Assist Suitable for: Isuzu MU-X Kit Part No: / 5466XX D-Max Tow-Pro Wiring Kit Fitting Instructions Suitable for: Isuzu MU-X / D-Max Accessory Kit Estimated Fitting Time: 0 Minutes FI967 Page

More information

Fitting Instructions

Fitting Instructions Kit Part No: TPWKIT-00 Tow-Pro Wiring Kit Fitting Instructions Suitable for: Mitsubishi Triton Kit Part No: TPWKIT-00 Accessory Kit Estimated Fitting Time: 90 Minutes FI705 Page 0 of Issue: Date: /08/08

More information

Mazda CX-9. Trailer Wiring Harness Fitting Instructions

Mazda CX-9. Trailer Wiring Harness Fitting Instructions Towbar Kit Part No: TCACTB Harness Kit Part No: TCACTWH Towbar Fitting Time: 5 minutes Harness Fitting Time: 0 minutes Trailer Wiring Harness Fitting Instructions FI Doc No: FI5 - Issue: - 08/0/6 Lumen

More information

CANOPY WIRING PATCH KIT INSTALLATION INSTRUCTIONS Holden Colorado RG

CANOPY WIRING PATCH KIT INSTALLATION INSTRUCTIONS Holden Colorado RG CANOPY WIRING PATCH KIT INSTALLATION INSTRUCTIONS Holden Colorado RG IMPORTANT! Read instructions carefully before installation. It is strongly recommended that installation is conducted by an authorized

More information

PART No: PRODUCT: BRAKE CONTROLER HARNESS MAKE & MODEL: FORD RANGER - MAZDA BT-50 INSTALLATION INSTRUCTIONS

PART No: PRODUCT: BRAKE CONTROLER HARNESS MAKE & MODEL: FORD RANGER - MAZDA BT-50 INSTALLATION INSTRUCTIONS Page 1 1. In the engine bay, locate the vehicle battery jumper (1). 2. Route the power input harness (2) from the battery (1) towards the LHS of the firewall. Note: Do not connect the power input harness

More information

LEXUS GS 350/450h ILLUMINATED DOOR SILLS Preparation

LEXUS GS 350/450h ILLUMINATED DOOR SILLS Preparation Preparation Part Number: PT922-30120 (GS350) PT922-30130 (GS450h) NOTE: Part number of this accessory may not be the same as the part number shown. Kit Contents Item # Quantity Req'd. Description 1 1 Illuminated

More information

MAZDA BT-50 (October 2011 Production Onwards) 1 & 3 PIECE HARD TONNEAU REMOTE LOCKING KIT INSTALLATION INSTRUCTIONS

MAZDA BT-50 (October 2011 Production Onwards) 1 & 3 PIECE HARD TONNEAU REMOTE LOCKING KIT INSTALLATION INSTRUCTIONS MAZDA BT-50 (October 0 Production Onwards) & 3 PIECE HARD TONNEAU REMOTE LOCKING KIT INSTALLATION INSTRUCTIONS Installation Time: Approx. 0 Minutes Care Instructions: Clean Tonneau Cover with a mild detergent

More information

CARAVAN. Tow Vehicle Requirements Instructions. Various Models with 12-pin Plug. Fitting Time: 30 minutes

CARAVAN. Tow Vehicle Requirements Instructions. Various Models with 12-pin Plug. Fitting Time: 30 minutes Fitting Time: 30 minutes Tow Vehicle Requirements Instructions FI Doc No: JAY-12PIN-FI - Issue: 2-25/07/14 Page 01 of 05 General Notes - Read through the fitting instructions before installation. - Always

More information

PART No: 04997, & PRODUCT: Body Harness MAKE & MODEL: TOYOTA 400A/125A KLUGER INSTALLATION INSTRUCTIONS

PART No: 04997, & PRODUCT: Body Harness MAKE & MODEL: TOYOTA 400A/125A KLUGER INSTALLATION INSTRUCTIONS Issue Date 23-11-10 Page 1 1. In the LHS of the vehicle cabin, locate the main harness grommet nipple (1). 2. Cut off the tip of the main harness grommet nipple (1). 3. In the engine bay, locate the vehicle

More information

PART No: 04997, & PRODUCT: Body Harness MAKE & MODEL: T5 VOLKSWAGEN TRANSPORTER INSTALLATION INSTRUCTIONS

PART No: 04997, & PRODUCT: Body Harness MAKE & MODEL: T5 VOLKSWAGEN TRANSPORTER INSTALLATION INSTRUCTIONS 1. In the engine bay, locate the vehicle battery (1). 2. From the battery, route the power input harness (2) behind the battery shield and along the firewall. Note: Do not connect the power input harness

More information

PLEASE READ THESE INSTRUCTIONS CAREFULLY, BEFORE YOU START INSTALLATION

PLEASE READ THESE INSTRUCTIONS CAREFULLY, BEFORE YOU START INSTALLATION PART NUMBER: L0SSJ000 INSTALLATION INSTRUCTIONS DESCRIPTION: FORESTER TRAILER HITCH PLEASE READ THESE INSTRUCTIONS CAREFULLY, BEFORE YOU START INSTALLATION SAFETY PRECAUTION: When installing Trailer Hitch,

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application 2011 PILOT Publications No. AII 43339-47543 Issue Date JAN 2012 PARTS LIST Trailer Harness Kit P/N 08L91-SZA-100 Towing Kit P/N 08L92-SZA-100 Ball mount

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory P/N 08E10-TA0-100 Application 2008 ACCORD 2-AND 4-DOOR Publications No. AII 35358 Issue Date AUG 2007 PARTS LIST Ambient Light Kit 2 Ambient lights Fuse label Washer

More information

PLEASE READ THIS INSTRUCTIONS CAREFULLY, BEFORE YOU START INSTALLATION

PLEASE READ THIS INSTRUCTIONS CAREFULLY, BEFORE YOU START INSTALLATION INSTALLATION INSTRUCTIONS PART NUMBER: L0SXC000 DESCRIPTION: 09 ASCENT TRAILER HITCH PLEASE READ THIS INSTRUCTIONS CAREFULLY, BEFORE YOU START INSTALLATION SAFETY PRECAUTION: When installing Trailer Hitch,

More information

Part Number: T4R-2N1. Hardware Bag Contents. General Applicability Models with factory fog light. Conflicts -

Part Number: T4R-2N1. Hardware Bag Contents. General Applicability Models with factory fog light. Conflicts - Date: 07.30.2015 TOYOTA TUNDRA 2014-2016 LED Fog Light & DRL 2 in 1 Part Number: T4R-2N1 Kit Contents Item # Quantity Reqd. Description 1 2 DRL + Fog Light Housing 2 1 Driver Box 3 1 Harness bag 4 1 User

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application 2009 PILOT Publications No. AII 39422 Issue Date MAY 2008 PARTS LIST Trailer Harness Kit P/N 08L91-SZA-100 Sold Separately Trailer socket harness Control

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. P/N 08E49-S2A-100 2004 S2000 AII 26325 Issue Date OCT 2003 PARTS LIST Hood switch harness TOOLS AND SUPPLIES REQUIRED #2 Phillips screwdriver

More information

BBT033/ BBC033/ BBCD033 TOYOTA HILUX 10/2011

BBT033/ BBC033/ BBCD033 TOYOTA HILUX 10/2011 INSTALLATION GUIDE BBT033/ BBC033/ BBCD033 TOYOTA HILUX 10/2011 Ironman 4x4 BBT/ BBC/ BBCD033 Bull Bars fit to a Toyota Hilux 10/2011 It will take about 3 hours to install. NOTE: This product has been

More information

HAYMAN REESE PART No: 03099RW BMW X4 F26 Series May 2014 Onwards INSTALLATION INSTRUCTIONS

HAYMAN REESE PART No: 03099RW BMW X4 F26 Series May 2014 Onwards INSTALLATION INSTRUCTIONS PART No: 03099RW BMW X4 F26 Series May 2014 Onwards PLEASE ENSURE THAT ALL INSTRUCTIONS ARE UNDERSTOOD PRIOR TO FITMENT PLACE THESE INSTRUCTIONS IN THE VEHICLE S GLOVEBOX AFTER INSTALLATION IS COMPLETED

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Rear Vision System Tailgate Emblem Camera Mirror Display 2009-Current Ford F-150 and 2010-Current Super Duty (Kit part number 1008-9527) Kit Contents: Mirror Tailgate Emblem Mount with Camera Interior

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AUTOMATIC AII 27160 2005 CR-V Issue Date ATTACHMENT KIT SEP 2004 PARTS LIST Automatic Day/Night Mirror Attachment Kit (sold separately)

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publications No. INSTALLATION INSTRUCTIONS S (LX, EX) CIVIC 2- AND 4- DOOR AII 25449 Issue Date SEP 2003 NOTE: Fog Lights cannot be installed if the vehicle is equipped with an optional

More information

MY F150 CrewCab 1. Tools Required E F G. Page 1 of 10 9L3J-19A014-AA Copyright Ford 2013 FoMoCo

MY F150 CrewCab 1. Tools Required E F G. Page 1 of 10 9L3J-19A014-AA Copyright Ford 2013 FoMoCo 2009-2014MY F150 CrewCab 1 Tools Required A B C D 3X E F G H 2X I 6X 3X Page 1 of 10 9L3J-19A014-AA Copyright Ford 2013 FoMoCo 2009-2014MY F150 CrewCab 2 Subwoofer Power Wire Routing All Vehicles WARNING:

More information

BX8848 Installation Instructions 4 Diode Wiring Kit For Motorhomes With Red Tail Lights

BX8848 Installation Instructions 4 Diode Wiring Kit For Motorhomes With Red Tail Lights For Motorhomes With Red Tail Lights WARNG: Incorrect wiring may result in blown fuses, damaged wiring, fire, or bodily injury. Blue Ox recommends installation of this kit by a trained professional. Blue

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Rear Vision System Liftgate Emblem Camera Mirror Display 2009-2012 Ford Flex (Kit part number 1008-9527) Kit Contents: Mirror Liftgate Emblem Mount with Camera Interior (shorter) Harness Chassis (longer)

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application 2011 PILOT Publications No. AII 43339 Issue Date MARCH 2010 PARTS LIST Trailer Harness Kit P/N 08L91-SZA-100 Towing Kit P/N 08L92-SZA-100 Ball mount Trailer

More information

Part Number: TTU-BGB14-DRL TTU-BGP14-DRL

Part Number: TTU-BGB14-DRL TTU-BGP14-DRL 11/15/16 TOYOTA TUNDRA 2014-17 Billet Grille w/led DRL Part Number: TTU-BGB14-DRL TTU-BGP14-DRL Kit Contents Item # Quantity Reqd. Description 1 2 LED DRL 2 1 Driver Box 3 1 Switch 4 1 User Card 5 2 Hardware

More information

TOYOTA RAV TRAILER WIRE HARNESS Preparation

TOYOTA RAV TRAILER WIRE HARNESS Preparation Preparation Part Number: PU322-42013-UW Kit Contents Item # Qty Description 1 1 Trailer Module Harness 2 1 Trailer 4-Flat Harness 3 1 Trailer Power Wire Harness 4 1 Mounting Bracket, 4-Flat 5 2 Screw #10-24

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Installation Time: Approx 45 Mins Towbar Installation Instructions Towbar capacity Part Number 02910RW 3 Door: Max Towing Braked 3000 kg Rating Unbraked 750 kg Max Static Ball Load 300 kg 5 Door: Max Towing

More information

MY F150 SuperCab 1. Tools Required. Page 1 of 12 9L3J-19A014-BA Copyright Ford 2013 FoMoCo

MY F150 SuperCab 1. Tools Required. Page 1 of 12 9L3J-19A014-BA Copyright Ford 2013 FoMoCo 2009-2014MY F150 SuperCab 1 Tools Required A B C D E F G 3X 6X 3X H I J 2X 3X 3X K L M N 3X Page 1 of 12 9L3J-19A014-BA Copyright Ford 2013 FoMoCo 2009-2014MY F150 SuperCab 2 Subwoofer Power Wire Routing

More information

C15C C15C. Page 1 of 20

C15C C15C. Page 1 of 20 2 x Lid Front Hinge 1135 8 x M8 Bolt 8 x M8 Washer (3mm Thick) 4 x M6 Large washers 4 x M6 Spring washers 4 x M6 x 40mm Bolts 6 x M6 20mm Bolts 6 x M6 Washers 20 x Screws 2 x Lid mount gas strut bracket

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory HITCH Application 2013 MDX Publications No. BII 13442 Issue Date JULY 2012 PARTS LIST Receiver cover Trailer hitch Hitch pin Left bracket Hitch pin clip Trailer Harness

More information

VOLKSWAGEN AMAROK MY17> 1 & 3 PIECE HARD TONNEAU REMOTE LOCKING KIT INSTALLATION INSTRUCTIONS

VOLKSWAGEN AMAROK MY17> 1 & 3 PIECE HARD TONNEAU REMOTE LOCKING KIT INSTALLATION INSTRUCTIONS VOLKSWAGEN AMAROK MY7> & PIECE HARD TONNEAU REMOTE LOCKING KIT INSTALLATION INSTRUCTIONS Care Instructions: Clean Tonneau Cover with a mild detergent and water solution. Do not use abrasive cleaners or

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory TRAILER Application 2013 PILOT Publications No. AII 13332 Issue Date AUG 2012 PARTS LIST Trailer Harness Kit P/N 08L91-SZA-100A Relay cover Control unit harness 4 Wire

More information

Splicing Procedures 4. 2 Insert the new wire between the parted strands. If more than one wire is being spliced, wrap them in opposite directions. Use

Splicing Procedures 4. 2 Insert the new wire between the parted strands. If more than one wire is being spliced, wrap them in opposite directions. Use Splicing Procedures 1 Splicing Procedures Refer to applicable wiring diagrams for circuit information. This procedure contains multiple splicing techniques. Review splicing procedures prior to performing

More information

ACD-PRO Install in 2008 EvoX

ACD-PRO Install in 2008 EvoX Turning in a counter clockwise direction, unscrew ift knob ACD-PRO Install in 2008 EvoX Slide back and remove the floor console panel assembly Pull up to remove the center console tray Disconnect the plug

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. BII 25830 2004 MDX Issue Date SEP 2003 PARTS LIST 2 Clips Trailer Hitch Kit: P/N 08L92-S3V-200A Receiver cover Trailer hitch Harness Kit:

More information

PART No: 04997, & PRODUCT: Body Harness MAKE & MODEL: PF3, PF4 & PF5 Subaru Forester INSTALLATION INSTRUCTIONS

PART No: 04997, & PRODUCT: Body Harness MAKE & MODEL: PF3, PF4 & PF5 Subaru Forester INSTALLATION INSTRUCTIONS 1. In the engine bay, remove the engine shroud (1), by first removing the four plastic scrivets (2). Issue Date 10-09-10 Page 1 2. Remove the vehicle grommet (1) located on the LHS of the firewall. Note:

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory P/N 08E10-TA0-110A Application 2012 ACCORD 2- AND 4-DOOR Publications No. AII 46501 Issue Date AUG 2011 PARTS LIST Ambient Light Kit Fuse label 2 Ambient lights Washer

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory HARNESS P/N 08L91-SJC-100C Application 2013 RIDGELINE Publications No. AII 13373 Issue Date SEP 2012 PARTS LIST 3 Rivet nuts, 6 mm Trailer socket harness Subharness

More information

BBT020/ BBC020/ BBCD020 HOLDEN RODEO RA7 & ISUZU DMAX 07+ 2WD & 4WD Models

BBT020/ BBC020/ BBCD020 HOLDEN RODEO RA7 & ISUZU DMAX 07+ 2WD & 4WD Models INSTALLATION GUIDE BBT020/ BBC020/ BBCD020 HOLDEN RODEO RA7 & ISUZU DMAX 07+ 2WD & 4WD Models Ironman 4x4 BBT/ BBC/ BBCD020 Bull Bars fit to a Holden Rodeo & Isuzu DMAX. It will take about 3 hours to install.

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. ELEMENT AII 33021 Issue Date JULY 2006 PARTS LIST Trailer Hitch Kit P/N 08L92-SCV-101 4 Bolts, 12 x 35 mm Trailer hitch U-bolt 2 Nuts, 8

More information

Part Number: TTA-2N1. Hardware Bag Contents. General Applicability SR5, TRD Sport, TRD Off-Road, Limited

Part Number: TTA-2N1. Hardware Bag Contents. General Applicability SR5, TRD Sport, TRD Off-Road, Limited Date: 2.10.2016 TOYOTA TACOMA 2016-2 in 1 LED UPGRADE KIT Part Number: TTA-2N1 Kit Contents Item # Quantity Reqd. Description 1 2 DRL + Fog Light Housing 2 1 Driver Box 3 1 Harness bag 4 1 User s card

More information

PART NUMBER: H630SSJ000. Kit Contents: A. Amplifier with Bracket (1) D. Badge (2) with push nuts (4)

PART NUMBER: H630SSJ000. Kit Contents: A. Amplifier with Bracket (1) D. Badge (2) with push nuts (4) Kit Contents: A. Amplifier with Bracket (1) D. Badge (2) with push nuts (4) E. Clip B. Harness (1) C. Cable tie (8) F. Mounting Hardware (2) G. Replacement Speaker (2) H. HVAC Duct extension (2) IMPORTANT:

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. P/N 08L92-S0X-100 ODYSSEY AII 22049 Issue Date AUG 2000 PARTS LIST Trailer hitch Receiver cover 2 Small wire ties (1 not used) Ball mount

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 23642 P/N 08L91-S9V-100 2003 PILOT Issue Date MAY 2002 PARTS LIST Trailer hitch harness 2 Short wire ties 2 Long wire ties Clip Bolt

More information

BBT029/ BBC029/ BBCD029 TOYOTA PRADO 150. Ironman 4x4 BBT/ BBC/ BBCD029 Bull Bars fit to a Toyota Prado 150. It will take about 3 hours to install.

BBT029/ BBC029/ BBCD029 TOYOTA PRADO 150. Ironman 4x4 BBT/ BBC/ BBCD029 Bull Bars fit to a Toyota Prado 150. It will take about 3 hours to install. INSTALLATION GUIDE BBT029/ BBC029/ BBCD029 TOYOTA PRADO 150 Ironman 4x4 BBT/ BBC/ BBCD029 Bull Bars fit to a Toyota Prado 150. It will take about 3 hours to install. NOTE: This product has been tested

More information

BMW Parts and Accessories Installation Instructions

BMW Parts and Accessories Installation Instructions BMW Parts and Accessories Installation Instructions 46 77 B BMW subwoofer module retrofit kit BMW 3 Series compact (E 46/5) LHD Technical and electrical knowledge required Installation time approx. 1.5-2.5

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Accessory Application Publications No. INSTALLATION INSTRUCTIONS S (DX, HX, VP) 2005 CIVIC 2- AND 4- DOOR AII 27865-30866 Issue Date SEP 2005 NOTE: Fog Lights cannot be installed if the vehicle is equipped

More information

LGT-306L / LB Club Car Precedent LED Light Bar Bumper Kit Installation Instructions

LGT-306L / LB Club Car Precedent LED Light Bar Bumper Kit Installation Instructions LGT-306L / LB Club Car Precedent LED Light Bar Bumper Kit Installation Instructions Caution: Please read through the instructions carefully. Before starting this project, remove the system s positive and

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory P/N 08E50-TK6-100 Application 2010 FIT (BASE MODEL) Publications No. AII 42212 Issue Date AUG 2009 The security system will only work if the vehicle is equipped with

More information

LED Fog Light. Conflicts Note: 1226, General Applicability Fits Models Additional Items Required For Installation

LED Fog Light. Conflicts Note: 1226, General Applicability Fits Models Additional Items Required For Installation LED Fog Light Year & Model Part Number Conflicts Note: 1226, 1228 2017 Prius TPR-817 General Applicability Fits Models 1221 1225 1223 1227 1224 Additional Items Required For Installation Items 1 N/A 2

More information

BBT006/ BBC006/ BBCD006 TOYOTA LANDCRUISER 100 SERIES IFS

BBT006/ BBC006/ BBCD006 TOYOTA LANDCRUISER 100 SERIES IFS INSTALLATION GUIDE BBT006/ BBC006/ BBCD006 TOYOTA LANDCRUISER 100 SERIES IFS Ironman 4x4 BBT/ BBC/ BBCD006 Bull Bars fit to a Toyota Landcruiser 100 Series (IFS). It will take about 2 hours to install.

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory S P/N 08E10-TK6-100 Application 2013 FIT Publications No. AII 13198 Issue Date JULY 2012 PARTS LIST Ambient light kit 2 Ambient lights 6 Wire ties Fuse label 2 Grommets

More information

BBT007/ BBC007/ BBCD007 TOYOTA PRADO 90 Series

BBT007/ BBC007/ BBCD007 TOYOTA PRADO 90 Series INSTALLATION GUIDE BBT007/ BBC007/ BBCD007 TOYOTA PRADO 90 Series Ironman 4x4 BBT/ BBC/ BBCD007 Bull Bars fit to a Toyota Prado 90 Series. It will take about 3 hours to install. NOTE: This product has

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AUTOMATIC PILOT AII 23597 Issue Date MAY 2002 PARTS LIST Automatic Day/Night Mirror Attachment Kit P/N 08V03-S9V-100A Day/night mirror Upper

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. S CIVIC 2 AND 4-DOOR (EX, LX) AII 24188 Issue Date AUG 2002 NOTE: Fog Lights cannot be installed if the vehicle is equipped with an optional

More information

Rear Vision System Liftgate Emblem Camera for Aftermarket Display Ford Flex (Kit part number )

Rear Vision System Liftgate Emblem Camera for Aftermarket Display Ford Flex (Kit part number ) Rear Vision System Liftgate Emblem Camera for Aftermarket Display 2009-2012 Ford Flex (Kit part number 1008-6509) Kit Contents: Liftgate Emblem Mount with Camera Chassis Harness with RCA (Note: In some

More information

INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 38133-38406 HITCH 2008 ODYSSEY Issue Date NOV 2007 NOTE: A required heavy-duty power steering cooler, ATF cooler and air duct are required

More information

INSTALLATION INSTRUCTIONS Accessory Application Publications No. All 38163 XM SATELLITE RADIO SYSTEM 2008 ODYSSEY Issue Date OCT 2007 PARTS LIST XM Radio Attachment (sold separately): P/N 08B15-SHJ-100A

More information

TOYOTA RAV TRAILER WIRE HARNESS Section I Installation Preparation

TOYOTA RAV TRAILER WIRE HARNESS Section I Installation Preparation Section I Installation Preparation Part Number: 08921-42900 Kit Contents Item # Quantity Reqd. Description 1 1 Converter 2 1 Wire harness 3 1 Sub wire harness No.1 4 2 Plastic Tie (300mm) 5 21 Plastic

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory TRAILER Application 2012 PILOT Publications No. AII 46408 Issue Date AUG 2011 PARTS LIST Trailer Harness Kit P/N 08L91-SZA-100A Relay cover Control unit harness 4 Wire

More information

Part Number: T4R-2N1. Hardware Bag Contents. General Applicability XLE, Limited

Part Number: T4R-2N1. Hardware Bag Contents. General Applicability XLE, Limited Date: 2.10.2016 TOYOTA RAV4 2016 2 in 1 LED UPGRADE KIT Part Number: T4R-2N1 Kit Contents Item # Quantity Reqd. Description 1 2 DRL + Fog Light Housing 2 1 Driver Box 3 1 Harness bag 4 1 User s card 5

More information

PRELIMINARY INSTALLATION INSTRUCTIONS PARTS LIST. Combination light switch Right fog light. 4 Self-tapping washer-screws.

PRELIMINARY INSTALLATION INSTRUCTIONS PARTS LIST. Combination light switch Right fog light. 4 Self-tapping washer-screws. INSTALLATION INSTRUCTIONS Accessory S P/N 08V31-SCV-100D Application 2009 ELEMENT (SC) Publications No. AII 40515 Issue Date OCT 2008 PARTS LIST Combination light switch Right fog light Left fog light

More information

TOYOTA TACOMA FOG LIGHT

TOYOTA TACOMA FOG LIGHT TOYOTA TACOMA 2012 - FOG LIGHT Part Number: 00016-35220 Accessory Code: LF10 Conflicts - Factory Fog Lights Kit Contents Item # Quantity Reqd. Description 1 2 Fog Lamps 2 1 Hardware bag 3 1 Switch Assembly

More information

TOYOTA VENZA 2009 TRAILER WIRE HARNESS Procedure

TOYOTA VENZA 2009 TRAILER WIRE HARNESS Procedure Part Number: PT791-0T099 Kit Contents Item # Quantity Reqd. Description 1 1 Trailer Wire Harness Module 2 1 4-Flat Harness 3 1 Battery Power Wire Harness 4 1 Mounting Bracket, 4-Flat 5 2 Screw #10-24 6

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory HITCH Application 2009 CR-V Publications No. AII 40373 Issue Date AUG 2008 PARTS LIST Plain washer, 12 mm Trailer Hitch Kit P/N 08L92-SWA-100 Trailer hitch 6 Spring

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 27367 HITCH 2005 ODYSSEY Issue Date DEC 2004 NOTE: An optional heavy-duty power steering cooler, ATF cooler and air duct are required

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS Rear Vision System Tailgate Emblem Camera Aftermarket Display 2009-Current Ford F-150 and 2010-Current Super Duty (Kit part number 1008-6509) Kit Contents: Tailgate Emblem Mount with Camera Chassis Harness

More information

D40C HINGE # x Support Plate x M8 Bolt 8 x M8 Washer 6 x M6 20mm Bolts 6 x M6 Washers 19 x Screws

D40C HINGE # x Support Plate x M8 Bolt 8 x M8 Washer 6 x M6 20mm Bolts 6 x M6 Washers 19 x Screws HINGE # 1017 2 x Support Plate 1018 8 x M8 Bolt 8 x M8 Washer 6 x M6 20mm Bolts 6 x M6 Washers 19 x Screws 2 x Lid mount gas strut bracket 1041 2 x Self tap strut mount 1040 1 x Central Lock bracket 1510

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS FUEL SURGE TANK INSTALL KIT Honda S2000 Document# 19-0063 Support: info@radiumauto.com WARNING: DO NOT SMOKE WHILE WORKING ON FUEL SYSTEMS. KEEP SPARKS AND OPEN FLAMES AWAY FROM

More information

Toyota 4RUNNER With/MR Overhead Video

Toyota 4RUNNER With/MR Overhead Video Toyota 4RUNNER With/MR 2010-10.2 Overhead Video Part Number: 00016-00110; Fit Kit-00110-14, Beige 00016-00120; Fit Kit-00120-14, Gray Accessory Code: ED7 Conflicts: Vehicles without a sunroof Kit Contents:

More information

LEXUS RC 350/RC-F ILLUMINATED DOOR SILLS Preparation

LEXUS RC 350/RC-F ILLUMINATED DOOR SILLS Preparation Preparation Part Number: PT944-24150 Kit Contents Item # Quantity Reqd. Description 1 2 Inner LED Scuff 2 2 Outer Scuff 3 1 Hardware Bag Hardware Bag Contents Item # Quantity Reqd. Description 1 15 20

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. CIVIC AII 24171 S 2- AND 4-DOOR Issue Date (DX, HX) AUG 2002 NOTE: Fog Lights cannot be installed if the vehicle is equipped with an optional

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. KIT P/N 08E49-S9V-100 2003 PILOT LX AII 23629 Issue Date MAY 2002 PARTS LIST Illustration of the Security System installed on the Vehicle

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory ACCESSORY HANDSFREELINK Application 2010 ACCORD 2 AND 4-DOOR Publications No. AII 42231 Issue Date AUG 2009 PARTS LIST HFL retainer HFL Attachment Kit P/N 08E02-TA0-100

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. AII 25877 PILOT Issue Date AUG 2003 Optional ATF and power steering coolers are required when installing the trailer hitch. 2 Spacers PARTS

More information

PART NUMBER: H630SXC001. Kit Contents: A. Amplifier with Bracket (1) D. Badge (2) with push nuts (4)

PART NUMBER: H630SXC001. Kit Contents: A. Amplifier with Bracket (1) D. Badge (2) with push nuts (4) Kit Contents: A. Amplifier with Bracket (1) D. Badge (2) with push nuts (4) E. Clip B. Interface / Power Harness (1) C. Cable tie (8) F. Mounting Nuts (2) G. Replacement Front Speaker (2) H. Badge mounting

More information

Conflicts - Fog Lights

Conflicts - Fog Lights TOYOTA CAMRY 2013 - BLACKOUT LED DRL Part Number: 00016-32270 Accessory Code: LDBO10 Conflicts - Fog Lights Kit Contents Item # Quantity Reqd. Description 1 2 DRL Housing 2 2 DRL s bezels 3 1 Driver Box

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. SYSTEM S2000 AII 26324 Issue Date OCT 2004 PARTS LIST Headrest Speaker System P/N 08A54-S2A-100 3 Small wire ties 2 Headrest speakers 9

More information

Ranger PX Series II. BT-50 UR(Series II)

Ranger PX Series II. BT-50 UR(Series II) Service Bulletin Ford Ranger PX II / BT-50 UR towbar fitment Product category Number Year Month TB 0008 05 Page of Affected Vehicles Ford Mazda Ranger PX Series II BT-50 UR(Series II) Aug-5 to current

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory HARNESS P/N 08L91-SJC-100C Application 2009 RIDGELINE Publications No. AII 40322 Issue Date AUG 2008 PARTS LIST 3 Riv nuts, 6 mm Trailer socket harness Subharness kit

More information

TOYOTA SIENNA TRAILER WIRE HARNESS Preparation

TOYOTA SIENNA TRAILER WIRE HARNESS Preparation Preparation Part Number: PT791-08150 (non-se) PT791-08102 (SE only) Kit Contents Item # Quantity Reqd. Description 1 1 Trailer Module Harness 2 1 4-Flat Harness 3 1 Battery Power Wire Harness 4 1 Mounting

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. SYSTEM P/N 08E60-SLN-100 2007 FIT AII 31719 Issue Date MAR 2006 PARTS LIST Fuse label B Keyless entry harness User s information Fuse label

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. XM RADIO SYSTEM (EXCEPT LX) 2006 ODYSSEY All 30392 Issue Date AUG 2005 PARTS LIST XM Radio Attachment (sold separately): P/N 08B15-SHJ-100

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. CIVIC All 30175-31616 2 AND 4-DOOR P/N 08E10-SNA-100 Issue Date DEC 2005 NOTE: The interior illumination lights cannot be installed on 2-door

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory BACKUP S Application 2012 ODYSSEY Publications No. AII 46724 Issue Date SEP 2011 PARTS LIST Backup Sensor Attachment Kit P/N 08V67-TK8-100A Right center sensor clip

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Accessory Hands Free Link Application 2009 ACCORD 2 AND 4-DOOR Publications No. AII 40055 Issue Date JULY 2008 PARTS LIST HFL Attachment Kit P/N 08E02-TA0-100 HFL trim

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application CR-V Publications No. AII 32953-34081 Issue Date NOV 2006 PARTS LIST 2 Corner sensor clips Backup Sensor Attachment Kit P/N 08V67-SWA-100A Back-up sensor

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS Accessory Application Publications No. BII 39889 HITCH 2009 MDX Issue Date JULY 2008 PARTS LIST Trailer Hitch Kit P/N 08L92-STX-200 Trailer Harness Kit P/N 08L91-STX-200 Trailer

More information

Conflicts Note: Toyota Tacoma 2015 LED Bed Lights Preparation. Part Number: Accessory Code: BU1000

Conflicts Note: Toyota Tacoma 2015 LED Bed Lights Preparation. Part Number: Accessory Code: BU1000 Toyota Tacoma 2015 LED Bed Lights Preparation Part Number: 00016-34089 Accessory Code: BU1000 Conflicts Note: Kit Contents Item # Quantity Reqd. Description 1 1 Hardware Kit 2 1 Driver s Side LED assembly

More information

Conflicts: Vehicles with a sunroof

Conflicts: Vehicles with a sunroof Toyota 4Runner Non/MR 2010-10.2 Overhead Video Part Number: 00016-00110; Fit Kit -00110-15, Beige 00016-00120; Fit Kit -00120-15, Gray Accessory Code: ED6 Conflicts: Vehicles with a sunroof Kit Contents:

More information

Stand Alone Kit Installation Instructions

Stand Alone Kit Installation Instructions Before installation: Stand Alone Kit Installation Instructions Read all information in this manual carefully Check the product for all components before starting the installation Remove the negative battery

More information

Installation of Auto Meter Cobalt Boost/Vacuum Gauge:

Installation of Auto Meter Cobalt Boost/Vacuum Gauge: Installation of Auto Meter Cobalt Boost/Vacuum Gauge: Fitment: All 79-14 models. This installation was completed on a 2004 Mustang GT, and should be identical for all 1999-2004 model Mustangs. Time needed:

More information

BBT009/ BBC009/ BBCD009 NISSAN PATROL GU Series 1,2 & (Coil Spring Only)

BBT009/ BBC009/ BBCD009 NISSAN PATROL GU Series 1,2 & (Coil Spring Only) INSTALLATION GUIDE BBT009/ BBC009/ BBCD009 NISSAN PATROL GU Series 1,2 & 3 1998-2004 (Coil Spring Only) Ironman 4x4 BBT/ BBC/ BBCD011 Bull Bars fit to Nissan GU Patrol Series 1,2 & 3 (1998-2004). It will

More information

INSTALLATION INSTRUCTIONS Accessory Application Publications No. 2010 CIVIC All 42479 2- AND 4-DOOR P/N 08E10-SNA-110 Issue Date AUG 2009 NOTE: The interior illumination lights cannot be installed on 2-door

More information