POWER SYSTEM MODE STATUS

Size: px
Start display at page:

Download "POWER SYSTEM MODE STATUS"

Transcription

1 SX Generic Anti Spin Valve Control System System Description 7,7 POWER SYSTEM MODE STATUS 60, 8, 8, 0 9 0, 0, AMP Stecker AMP Connector 8 9

2 SX Generic Anti Spin Valve Control System Overview DESCRIPTION The Sauer-Danfoss Antispin Valve Control System combines the capabilities of modern digital electronics with the worldwide proven Sauer-Danfoss hydrostatic components, to enhance the machine performance and operation. The microprocessor-based SX provides flexibility and is designed for the future. With easy-to change parameters (in software) it is possible to make an individual setup for different machine types. FEATURES Environmentally hardened for mobile applications. Supply voltage V DC or V DC. Software changes without hardware operations. Easy to service. Flexibility: - motors. Active while steering. Individual setup per software: - Selection of different steering modes - Vehicle geometric - Track width - Wheel base - Wheel diameter - etc. SYSTEM COMPONENTS SX-6 G AMP K96 SX Electronic w/o CAN SX-6 G AMP K96C SX Electronic w CAN ASC Twin Valves - Volt, standard piston (0779) - Volt, special piston (078) - Volt, standard piston (078) - Volt, special piston (078) Steering Sensor MCX0B00 (788760) Manual Graphic Interface, english (70) Manual SUSMIC-DIA, english (706) 00, Sauer-Danfoss Sauer-Danfoss can accept no responsibility for possible errors in catalogues, brochures and other printed material. Sauer -Danfoss reserves the right to alter its products without prior notice. This also applies to products already ordered provided that such alterations can be made without subsequent changes being necessary in specifications already agreed. All trademarks in this material are properties of the respective companies. Sauer-Danfoss and the Sauer-Danfoss logotype are trademarks of the Sauer-Danfoss Group. All rights reserved. BLN E Rev. E 0/00

3 SX Generic Anti Spin Valve Control System SX Mobile Microcomputer LED OVERVIEW POWER SYSTEM,7 MODE STATUS 60, 8, 8, 0 9 0, 0, 8 9 SX Mounting slots AMP connector Diagnostic LED red Error check (STATUS) Lights up if an error is detected. Diagnostic LED yellow Software check (MODE) Flashes with approx. 0.Hz (slow) if the program is running fine. Flashes with approx. Hz (fast) if no program is loaded. No flashing if in setup mode. 6 Diagnostic LED green V DC internal (SYSTEM) Lights up if V DC internal is O.K. 7 Diagnostic LED green Battery after ignition switch (POWER) Lights up if the battery voltage is connected after ignition. BLN E Rev. E 0/00 S0697b

4 SX Generic Anti Spin Valve Control System ASC Twin Valve ASC TWIN VALVE AMP Junior Timer Gage port M7 control pressure for port A ISO UNF-B [7/6-0 UNF-B] M7 A Main port A ISO UN-B [-/6- UN-B] Supply port P DN Typ III 0 MPa series per ISO 66 [SAE.00] Thread: 0.7-UNC-B [7/6-UNC-B] [.00] min. full thread depth X P L Drain port L ISO UNF-B [9/6-8 UNF-B] B Control pressure supply X ISO UNF-B [9/6-8 UNF-B] M8 Main port B ISO UN-B [-/6- UN-B] Gage port M8 control pressure for port B ISO UNF-B [7/6-0 UNF-B] A M7 X M8 B P L S089a TECHNICAL DATA Max. flow rate at inlet port P: l/min Max. absolute system pressure: Pressure droop at max. flow rate: Control pressure at port X: 80 bar (T = 0 C, n = 8 cst) = bar 0..0 bar Response time at stepped current input: 0 msec Max. flow at closed valve: Drainage from flapper system: (00 bar delta, T = 0 C, n = 8 cst) = l/min about. l/min continuously BLN E Rev. E 0/00

5 SX Generic Anti Spin Valve Control System System Block Diagram SYSTEM BLOCK DIAGRAM PPU PPU Engine PPU PPU Timer PID Timer Timer Calculate controller setpoint PID PID Timer PID ASC Main switch DI ASC switch rear (Option) DI ASC Status Transport switch (Option) DI nd offset switch (Option) (Optional: pump neutral switch) DI Potentiometer front steering (Optional: FNR lever) A D Calculate steering difference Potentiometer rear steering (Optional: Slope sensor) A D F 0A Voltage regulator V t Sensors Output driver System check RS Interface for SUSMIC-DIA to + Batt. - /V DC S086a BLN E Rev. E 0/00

6 SX Generic Anti Spin Valve Control System Theory of Operation GENERAL REMARKS The ASC System is an antislip control for hydrostatic driving systems. It is possible to use this system in wheeled machines of up to wheels driven individually. The ASC System is especially useful for applications with fixed motors, but can also be combined with variable displaced motors. The ASC System consists of a central digital controller SX, speed sensors for each motor, el. proportional flow devider (double valve in one case) and if necessary a max. of steering sensors. Each motor is fitted with a speed sensor. It is important to take note that the amount of impulses per wheel rotation show the highest possible frequency resolution to be able to guarantee a good performance of the antislip control. The pressure ports of the favoured driving direction of the individual motors are combined at port A and B by means of a flow devider. The flow devider provides both motors with the required flow, generally these are the motors for one axle. The P-port of the flow devider must be connected to the pump. The port for leakages must be connected to the reservoir directly. If it is required to keep the ASC System active while steering, the machine needs to be fitted with steering sensors respectively. FUNCTION The system determines the current speed of each motor and calculates the speed of the wheel with the help of the respective machine data (wheel circumference, gear change, pulse/rpm, etc.). When driving straight forward the speed of the slowest wheel is used as a reference for the remaining wheels. When driving in a curve the speed of the wheels is proportionally set to their turning circles. The wheel with the smallest relative speed is used as a reference in this case. The turning circles are calculated out of the steering information according to the respective calculation modules relative to the steering mode. Considering the reference speed (vehicle speed), the theoretical wheel speed is defined in taking the steering influence into account. The difference between the actual speed and the theoretical wheel speed results in the slip for each wheel. If the controller detects slip on one or more wheels, the respective flow to the motor will be reduced by the ASC valve. Throttling continuous until the general speed lies below the boundary speed. STEERING MODES All steering modes must be based on Ackermann s geometrical steering algorithms. The different modes are as follows: no steering front wheel steering front steering WD rear wheel steering combined front and rear wheel steering articulated steering bogie steering combined articulated and bogie steering hill mode The output of the steering sensor needs to be direct proportional to the steering angle of the wheel. 6 BLN E Rev. E 0/00

7 MENU CODE COMMAND ESC ENTER SX Generic Anti Spin Valve Control System Connectors CONNECTORS Crimp tool for power timer, Id. No. 097 Die set for power timer, Id. No Crimp tool for micro timer, Id. No (Measuring Adapter Id. No. 0987) SX POWER SYSTEM MODE STATUS Recommendation MCX0B00, Id. No If a potentiometer is used, it should have a resistance value of kω and 0kΩ.If there is a need for the whole range, then the potentiometer must have series resistors. The series resistor has to be approximately 7% of the resistance value. The voltage of the analog input must increase, if the pedal is pushed. Example: 68Ω kω 68Ω We do not supply FNR and mode switches, therefore no connectors can be recommended. If an external speed sensor is used, the device must have an open collector output (NPN) PC (only for optimization) AMP Connector Id. No. 6 RS Cable Id. No. RS Connector (female) Id. No. 0 For field service SUSMIC-DIA Id.-No Metri Pack Connector Id. No. 77 MCX0B Steering sensor PPU with Turck Connector part of the motor Id. No. 007 (straight) or Id. No. 007 rightangle) AMP Junior Timer Id. No BLN E Rev. E 0/00 ASC valve S079a 7

8 SX Generic Anti Spin Valve Control System System Connection Diagram SYSTEM CONNECTION DIAGRAM * Contact capability min. 6A Malting fuse 0A Position shown: ASC OFF Position shown: Transport OFF Max.,A each pin = Option ASC Main switch AMP Stecker, polig AMP connector, pin nd offset switch * (Optional: Pump neutral switch) Sensor (-) Digital Input 0 ASC switch rear * Digital Input * Digital Input * Digital Input * High Current 0 (+) 6 Transport switch * High Current (+) High Current 0 FB (-) 7 8 Valve Motor front left High Current FB (-) Low Current 0 FB (-) * 9 0 Valve Motor front right Low Current FB (-) * nc RS Ground PPU Motor front left Sensor (+) Battery (-) PPU Motor front right PPU Input 0 PPU Input 6 7 PPU Motor rear left PPU Input 8 PPU Input RS TxD 9 0 PPU Motor rear right RS RxD High Current (+) * High Current FB (-) High Current (+) * High Current FB (-) SUB-D Diagnostic connector (female), 9pin Terminals Batt. (+) Terminals Batt. (-) High Current (+) High Current (+) 6 7 Valve Motor rear left Battery (+) Battery (-) nc Valve Motor rear right Analog Input 0 Analog Input Low Current FB (-) * Low Current FB (-) * nc nc CAN High CAN Low CAN Shield Digital Output 0 Digital Output * Terminals Sensor (+) Terminals Sensor (-) Rv cw Rv cw cw Potentiometer front steering (Optional: FNR lever) Potentiometer rear steering (Optional: Slope sensor) CAN Bus Terminals ASC Status front/rear * S F + Batt. - /V DC Battery (+) ASC Status rear * BLN E Rev. E 0/00

9 SX Generic Anti Spin Valve Control System Notes BLN E Rev. E 0/00 9

10 OUR PRODUCTS Hydrostatic transmissions Hydraulic power steering Electric power steering Closed and open circuit axial piston pumps and motors Gear pumps and motors Bent axis motors Radial piston motors Orbital motors Transit mixer drives Planetary compact gears Proportional valves Sauer-Danfoss Hydraulic Power Systems Market Leaders Worldwide Sauer-Danfoss is a comprehensive supplier providing complete systems to the global mobile market. Sauer-Danfoss serves markets such as agriculture, construction, road building, material handling, municipal, forestry, turf care, and many others. We offer our customers optimum solutions for their needs and develop new products and systems in close cooperation and partner ship with them. Sauer-Danfoss specializes in integrating a full range of system components to provide vehicle designers with the most advanced total system design. Sauer-Danfoss provides comprehensive worldwide service for its products through an extensive network of Authorized Service Centers strategically located in all parts of the world. Directional spool valves Cartridge valves Hydraulic integrated circuits Hydrostatic transaxles Integrated systems Fan drive systems Electrohydraulic controls Digital electronics and software Battery powered inverter Sensors Sauer-Danfoss (US) Company 800 East th Street Ames, IA 000, USA Phone: , Fax: Sauer-Danfoss (Neumünster) GmbH & Co. OHG Postfach 60, D- Neumünster Krokamp, D-9 Neumünster, Germany Phone: , Fax: Sauer-Danfoss (Nordborg) A/S DK-60 Nordborg, Denmark Phone: , Fax: Sauer-Danfoss (US) Company 00 Annapolis Lane North Minneapolis, MN 7, USA Phone: , Fax: BLN E Rev. E 0/00

POWER SYSTEM MODE STATUS

POWER SYSTEM MODE STATUS SX NFPE Control System System Description 4, 60,2 8, 8, 0 9 0 2, 0, AMP Stecker AMP Connector 4 28 29 42 Overview DESCRIPTION The Sauer-Danfoss NFPE (Non-Feedback Proportional Electric) System for Automotive

More information

S5X Shift On The Go (SOTG) Control System. System Description 223,5 82,25 77,75 8,5 8,5 164,5 10,3. AMP Stecker AMP Connector 52,5 POWER SYSTEM MODE

S5X Shift On The Go (SOTG) Control System. System Description 223,5 82,25 77,75 8,5 8,5 164,5 10,3. AMP Stecker AMP Connector 52,5 POWER SYSTEM MODE SX Shift On The Go (SOTG) Control System System escription 47, POWER SYSTEM 8, 77,7 8, MOE STTUS 8, 0 0 64, 0, MP Stecker MP Connector 4 6 8 4 8, SX Shift On The Go (SOTG) Control System Overview ESCRIPTION

More information

S1X Generic Speed Control System

S1X Generic Speed Control System MAKING MODERN LIVING POSSIBLE System Description S1X Generic Speed Control System powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev August 2015 Danfoss Layout 0600 September

More information

Series TMM Axial Piston Motor. Technical Information

Series TMM Axial Piston Motor. Technical Information Series TMM Axial Piston Motor Technical Information General Description GENERAL DESCRIPTION These motors are designed primarily to be combined with other products in closed circuit systems to transfer

More information

OMEW Standard and with Low Speed Option. Orbital Motors. Technical Information

OMEW Standard and with Low Speed Option. Orbital Motors. Technical Information Standard and with Low Speed Option Orbital Motors Technical Information Contents Revision History Table of Revisions Date Page Changed Rev Jan 2009 Many major change BA Mar 2010 16 Japan location BB Contents

More information

Directional Control Valve Model Technical Information. Phased Out OUT BASE BKT CYL ROD

Directional Control Valve Model Technical Information. Phased Out OUT BASE BKT CYL ROD BASE BKT CYL ROD OUT IN Directional Control Valve Model 1480 Technical Information History of Revisions Revisions Table of Revisions Date Page Changed Rev. May 2008 - first edition AA 2008 Sauer-Danfoss.

More information

Series 20 Axial Piston Pumps. Technical Information

Series 20 Axial Piston Pumps. Technical Information Series 20 Axial Piston Pumps Technical Information General Description INTRODUCTION Sauer-Danfoss a world leader in hydraulic power systems has developed a family of axial piston pumps. DESCRIPTION Sauer-Danfoss

More information

Series 20 Axial Piston Pumps. Technical Information

Series 20 Axial Piston Pumps. Technical Information Series 20 Axial Piston Pumps Technical Information General Description INTRODUCTION Sauer-Danfoss a world leader in hydraulic power systems has developed a family of axial piston pumps. DESCRIPTION Sauer-Danfoss

More information

OML and OMM Orbital motors. Technical Information

OML and OMM Orbital motors. Technical Information OML and OMM Orbital motors Technical Information OML and OMM A wide range of orbital motors F300030.TIF A WIDE RANGE OF ORBITAL MOTORS Sauer-Danfoss is a world leader within production of low speed orbital

More information

OMR Technical Information Versions

OMR Technical Information Versions Versions Versions Mounting flange Spigot diam,eter (front /rear end) Bolt circle diameter (BC) Shaft Port size European version US version Side port version End port version Flange port version Standard

More information

Orbital Motors Type OMP, OMR and OMH. Technical Information

Orbital Motors Type OMP, OMR and OMH. Technical Information Orbital Motors Type OMP, OMR and OMH Technical Information OMP, OMR and OMH A Wide Range of Hydraulics Motors F 301 245 A Wide Range of Hydraulic Motors Sauer-Danfoss is a world leader within production

More information

Series 20 Axial Piston Motors. Technical Information

Series 20 Axial Piston Motors. Technical Information Series 20 xial Piston Motors Technical Information General Description INTRODUCTION Sauer-Danfoss a world leader in hydraulic power systems has developed a family of axial piston motors. DESCRIPTION Sauer-Danfoss

More information

OSPB, OSPC, OSPR, OSPD Open Center Steering units OSPB Closed Center Steering units TAD Torque amplifiers. Technical Information

OSPB, OSPC, OSPR, OSPD Open Center Steering units OSPB Closed Center Steering units TAD Torque amplifiers. Technical Information OSPB, OSPC, OSPR, OSPD Open Center Steering units OSPB Closed Center Steering units TAD Torque amplifiers Technical Information A wide range of steering components A WIDE RANGE OF STEERING COMPONENTS F300599

More information

PVG 120 Proportional Valves. Service Parts Manual

PVG 120 Proportional Valves. Service Parts Manual PVG 120 Proportional Valves Service Parts Manual Contents and Data Survey CONTENTS AND DATA SURVEY Page Sectional drawing... 3 Identification...4 Installation PVG... 5 Spare parts... 22 Pos. 1: PVP, pump

More information

Series 40 M25 Axial Piston Pump. Service Parts Manual

Series 40 M25 Axial Piston Pump. Service Parts Manual Series 40 M25 Axial Piston Pump Service Parts Manual 1996, 2004 Sauer-Danfoss. All rights reserved. Printed in U.S.A. Sauer-Danfoss accepts no responsibility for possible errors in catalogs, brochures

More information

Directional Control Valve

Directional Control Valve Directional Control Valve Service and Parts Manual powersolutions.danfoss.com Directional Control Valves Service and Parts Manual: Contents SERVICE PARTS Inlet cover... 3-4 Outlet cover... 5-6 Standard

More information

PVG 120 Proportional Valves. Specifications

PVG 120 Proportional Valves. Specifications PVG 120 Proportional Valves s Ordering guidance and remote control units ORDERING GUIDANCE The module selection chart and the order form are both divided into fields. Each module has its own field: 0:

More information

Series cc Axial Piston Motor. Parts Manual

Series cc Axial Piston Motor. Parts Manual Series 90 130 cc Axial Piston Motor 2007 Sauer-Danfoss. All rights reserved. Sauer-Danfoss accepts no responsibility for possible errors in catalogs, brochures and other printed material. Sauer-Danfoss

More information

Mobile solutions for aerial lifts

Mobile solutions for aerial lifts Mobile solutions for aerial lifts The Sauer-Danfoss system development phase model: inquiry Project specification Concept phase Detailed project plan Technical system specifications Different system proposals

More information

Series 20 Axial Piston Motors. Technical Information

Series 20 Axial Piston Motors. Technical Information Series 20 xial Piston Motors Technical Information General Description INTRODUCTION Sauer-Danfoss a world leader in hydraulic power systems has developed a family of axial piston motors. DESCRIPTION Sauer-Danfoss

More information

Series ASC Anti Spin Control Valve

Series ASC Anti Spin Control Valve MAKING MODERN LIVING POSSIBLE Technical Information Series ASC Anti Spin Control Valve powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev March 2014 Converted to Danfoss layout

More information

Sensor Steering Angle Sensor Absolute (SASA)

Sensor Steering Angle Sensor Absolute (SASA) MAKING MODERN LIVING POSSIBLE Electrical Installation Sensor (SASA) powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev September 2015 Minor layout revision BB April 2014 Converted

More information

Series 40 MMF035D and MMV035D Axial Piston Motors. Parts Manual

Series 40 MMF035D and MMV035D Axial Piston Motors. Parts Manual Series 40 MMF035D and MMV035D Axial Piston Motors 2003, 2008 Sauer-Danfoss. All rights reserved. 2 520L0602 Rev AA January 2008 Sauer-Danfoss accepts no responsibility for possible errors in catalogs,

More information

MAKING MODERN LIVING POSSIBLE. Technical Information. Orbital Motors TMVW. powersolutions.danfoss.com

MAKING MODERN LIVING POSSIBLE. Technical Information. Orbital Motors TMVW. powersolutions.danfoss.com MAKING MODERN LIVING POSSIBLE Orbital Motors TMVW powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev September 2015 New curve for permissible shaft load 0201 November 2014

More information

Hydrostatic Steering Unit Type OSPB, OSPC and OSPF. Service Manual

Hydrostatic Steering Unit Type OSPB, OSPC and OSPF. Service Manual Hydrostatic Steering Unit Type OSPB, OSPC and OSPF Table of Contens Revision History Table of Revisions Date Page Changed Rev Dec 2008 26 Tightening torque changed BC Table of contens... 2 Exploded view

More information

Series 40 MMF044D and MMV044D Axial Piston Motors. Parts Manual

Series 40 MMF044D and MMV044D Axial Piston Motors. Parts Manual Series 40 MMF044D and MMV044D Axial Piston Motors 2003, 2008 Sauer-Danfoss. All rights reserved. 2 520L586 Rev AA January 2008 Sauer-Danfoss accepts no responsibility for possible errors in catalogs, brochures

More information

60+ countries served by our global manufacturing facilities ensures market proximity

60+ countries served by our global manufacturing facilities ensures market proximity Power and control for all your work function needs Series 45 Open Circuit Axial Piston Pumps 60+ countries served by our global manufacturing facilities ensures market proximity powersolutions.danfoss.com

More information

Series 51-1 Motor Pressured Compensated Controls TA

Series 51-1 Motor Pressured Compensated Controls TA MAKING MODERN LIVING POSSIBLE Series 51-1 Motor Pressured Compensated Controls TA powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev August 2015 Converted to Danfoss layout

More information

H1B Motor Two-Position Control E1, E2

H1B Motor Two-Position Control E1, E2 MAKING MODERN LIVING POSSIBLE Electrical Installation H1B Motor Two-Position Control E1, E2 powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev July 2015 Converted to Danfoss

More information

Technical Information Series 45 G Frame powersolutions.danfoss.com

Technical Information Series 45 G Frame powersolutions.danfoss.com MAKING MODERN LIVING POSSIBLE Technical Information Series 45 G Frame powersolutions.danfoss.com Contents Frame G Design... 4 Specifications... 5 Performance G74B... 6 Performance G9C... 7 Order code...

More information

Quick Reference Parts Manual Variable Displacement Motor Series 20, series powersolutions.danfoss.com

Quick Reference Parts Manual Variable Displacement Motor Series 20, series powersolutions.danfoss.com MAKING MODERN LIVING POSSIBLE Quick Reference Parts Manual Variable Displacement Motor Series 20, 20-27 series powersolutions.danfoss.com 2 Contents Service parts Exploded view drawing (20 thru 23 series)...4

More information

MCX106A Hall Effect Level Sensor. Technical Information

MCX106A Hall Effect Level Sensor. Technical Information MCX106A Hall Effect Level Sensor Technical Information Revisions Revision History Table of Revisions Date Page Changed Rev 21 Jan, 2011 Initial release AA 2011 Sauer-Danfoss. All rights reserved. 2 Sauer-Danfoss

More information

H1B Motor Electric Two-Position Control T1, T2

H1B Motor Electric Two-Position Control T1, T2 MAKING MODERN LIVING POSSIBLE Electrical Installation H1B Motor Electric Two-Position Control T1, T2 powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev June 2015 Converted

More information

DH Technical Information. Versions. Versions

DH Technical Information. Versions. Versions Versions Versions Mounting flange Shaft Port size European version US version Side port version End port version Flange port version Standard shaft seal High pressure shaft seal Drain connection Check

More information

H1 Pump Filter Bypass Sensor

H1 Pump Filter Bypass Sensor MAKING MODERN LIVING POSSIBLE Electrical Installation H1 Pump Filter Bypass Sensor powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev September 2015 Minor layout revision BC

More information

MAKING MODERN LIVING POSSIBLE. Phased Out Products. Technical Information. Level Controller. powersolutions.danfoss.com

MAKING MODERN LIVING POSSIBLE. Phased Out Products. Technical Information. Level Controller. powersolutions.danfoss.com MAKING MODERN LIVING POSSIBLE Technical Information ACW112A,D Level Controller powersolutions.danfoss.com 2 BLN-95-8952-11 95-8952-11 August 2004 PRODUCT OVERVIEW Description... 4 Features... 4 Ordering

More information

Series cc Axial Piston Motor. Parts Manual

Series cc Axial Piston Motor. Parts Manual Series 90 100 cc Axial Piston Motor 2007 Sauer-Danfoss. All rights reserved. Sauer-Danfoss accepts no responsibility for possible errors in catalogs, brochures and other printed material. Sauer-Danfoss

More information

Series 51 Motor Electrohydraulic Two-Position Controls T1, T2

Series 51 Motor Electrohydraulic Two-Position Controls T1, T2 MAKING MODERN LIVING POSSIBLE Electrical Installation Series 51 Motor Electrohydraulic Two-Position Controls T1, T2 powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev August

More information

Technical Information Orbital Motors DH and DS powersolutions.danfoss.com

Technical Information Orbital Motors DH and DS powersolutions.danfoss.com MAKING MODERN LIVING POSSIBLE Technical Information Orbital Motors DH and DS powersolutions.danfoss.com and DS F 301 245 A Wide Range of Orbital Motors Danfoss Power Solutions is a world leader within

More information

Proportional Valve Group PVG 128/256

Proportional Valve Group PVG 128/256 Service and Parts Manual Proportional Valve Group powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev July 207 First edition 00 2 Danfoss July 207 AX00000346en-US00 Contents

More information

Steering Priority Valve OLS 160

Steering Priority Valve OLS 160 MAKING MODERN LIVING POSSIBLE Service Manual Steering Priority Valve OLS 160 powersolutions.danfoss.com Revision History Table of Revisions Date Changed Rev Mar 2014 Converted to Danfoss layout - DITA

More information

Service Parts Manual M25 Axial Piston Motor Series 40 powersolutions.danfoss.com

Service Parts Manual M25 Axial Piston Motor Series 40 powersolutions.danfoss.com MAKING MODERN LIVING POSSIBLE Service Parts Manual M25 Axial Piston Motor Series 40 powersolutions.danfoss.com 2 Contents General Information Service parts identification... 4 Nameplate... 4 Date code...

More information

Orbital Motors OMEW Standard and with Low Speed Option

Orbital Motors OMEW Standard and with Low Speed Option MAKING MODERN LIVING POSSIBLE Technical Information Orbital Motors OMEW Standard and with Low Speed Option powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev October 2014 Changed

More information

Orbital Motors DH and DS

Orbital Motors DH and DS MAKING MODERN LIVING POSSIBLE Orbital Motors DH and DS powersolutions.danfoss.com Orbital Motors, DH and DS F 301 245 A Wide Range of Orbital Motors Danfoss Power Solutions is a world leader within production

More information

Proportional Valve Group PVG 120

Proportional Valve Group PVG 120 MAKING MODERN LIVING POSSIBLE Specification Proportional Valve Group PVG 120 powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev May 2014 Converted to Danfoss layout DITA CMS

More information

Sensors KS10201 Microsyn Level Sensor

Sensors KS10201 Microsyn Level Sensor MAKING MODERN LIVING POSSIBLE Technical Information Sensors powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev November 2015 Converted to Danfoss layout 0001 August 2010 Initial

More information

Product Reliability Data (MTTF) for S90P

Product Reliability Data (MTTF) for S90P MAKING MODERN LIVING POSSIBLE Functional Safety Product Reliability Data (MTTF) for S90P042-250 powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev May 2015 Added Mission time

More information

Distribuíção, revenda emanutenção. CatálogosOnline. (11) (11)

Distribuíção, revenda emanutenção. CatálogosOnline. (11) (11) Distribuíção, revenda emanutenção CatálogosOnline (11)4174-3300-(11)4765-6775 www.hmc.com.br MAKING MODERN LIVING POSSIBLE Technical Information Axial Piston Pumps Series 20 powersolutions.danfoss.com

More information

Parts Manual Series cc Axial Piston Motor powersolutions.danfoss.com

Parts Manual Series cc Axial Piston Motor powersolutions.danfoss.com MAKING MODERN LIVING POSSIBLE Parts Manual Series 90 130 cc Axial Piston Motor powersolutions.danfoss.com 2 Contents General information Service parts identification...4 Nameplate...4 Date code...5 Service

More information

OSPB, OSPC, OSPF, OSPD, OSPQ, OSPL Load Sensing Steering Units. OLS Priority Valves. OSQ Flow Amplifiers. Technical Information

OSPB, OSPC, OSPF, OSPD, OSPQ, OSPL Load Sensing Steering Units. OLS Priority Valves. OSQ Flow Amplifiers. Technical Information OSPB, OSPC, OSPF, OSPD, OSPQ, OSPL Load Sensing Steering Units OLS Priority Valves OSQ Flow Amplifiers Technical Information A Wide Range of Steering Components Revision History Table of Revisions Date

More information

Parts Manual Closed Circuit Axial Piston Pump DDC20 powersolutions.danfoss.com

Parts Manual Closed Circuit Axial Piston Pump DDC20 powersolutions.danfoss.com MAKING MODERN LIVING POSSIBLE Parts Manual Closed Circuit Axial Piston Pump DDC20 powersolutions.danfoss.com 2 Contents General Information Variable pump & fixed motor Service parts identification...4

More information

OMP, OMP C, OMPW, and OMPW N Series 7 and 8. Repair Instructions

OMP, OMP C, OMPW, and OMPW N Series 7 and 8. Repair Instructions , C, W, and W N Series and 8 Orbital Motors, C, and W/N Series and 8 Table of Contents Revision View Safety Precautions Date Page Changed Revision 29 Jun, 200 all Changed from Danfoss to Sauer Danfoss

More information

MAKING MODERN LIVING POSSIBLE. Service Manual. Steering OSPM. powersolutions.danfoss.com

MAKING MODERN LIVING POSSIBLE. Service Manual. Steering OSPM. powersolutions.danfoss.com MAKING MODERN LIVING POSSIBLE Service Manual Steering OSPM powersolutions.danfoss.com Revision History Table of Revisions Date Changed Rev Mar 2014 Converted to Danfoss layout - DITA CMS BA Feb 1998 First

More information

Faster. Count on availability when you need it most H1B Bent Axis Motors Rapid Delivery Center. time to market. powersolutions.danfoss.

Faster. Count on availability when you need it most H1B Bent Axis Motors Rapid Delivery Center. time to market. powersolutions.danfoss. Count on availability when you need it most H1B Bent Axis Motors Rapid Delivery Center Faster time to market Danfoss RDCs ensure you have the product you want, when you want it powersolutions.danfoss.com

More information

Closed Circuit Axial Piston Pump DDC20

Closed Circuit Axial Piston Pump DDC20 Parts Manual Closed Circuit Axial Piston Pump powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev July 2017 Updated to Engineering Tomorrow design 0302 2 Danfoss July 2017 AX00000134en-US0302

More information

Phased Out Products. Proportional Valve Group PVG 83. Tech Note MAKING MODERN LIVING POSSIBLE

Phased Out Products. Proportional Valve Group PVG 83. Tech Note MAKING MODERN LIVING POSSIBLE MAKING MODERN LIVING POSSIBLE Tech Note Proportional Valve Group PVG 83 Valve system PVG 83 is a hydraulic load sensing valve designed to give the customer just the valve he needs. From a simple load sensing

More information

OMR, OMR C, and OMRW N Series 5 and 6. Repair Instructions

OMR, OMR C, and OMRW N Series 5 and 6. Repair Instructions , C, and W N Series and Orbital Motors, C and W N Series and Table of Contents Revision View Safety Precautions Date Page Changed Revision 29 Jun, 200 all Changed from Danfoss to Sauer Danfoss lay out

More information

MCX104A DC Microsyn Level Sensor. Technical Information

MCX104A DC Microsyn Level Sensor. Technical Information MCX104A DC Microsyn Level Sensor Technical Information Revisions Revision History Table of Revisions Date Page Changed Rev 06 Apr 2011 4 Ordering Information BA 07 Dec 2010 Cover Added PLUS+1 Compliant

More information

OMH. Repair Instructions

OMH. Repair Instructions OMH Table of Contents Revision View Date Page Changed Revision Jun 2006 New AA Apr 200 6 Japan location AB Sep 200 6 New back cover AC Safety Precautions Always consider safety precautions before beginning

More information

Sensors ACX104B Potentiometer Rotary Position Sensor

Sensors ACX104B Potentiometer Rotary Position Sensor MKING MODERN LIVING POSSILE Technical Information Sensors CX104 Potentiometer Rotary Position Sensor powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev November 2015 Conversion

More information

Transit Mixer Drives System Series TM

Transit Mixer Drives System Series TM MAKING MODERN LIVING POSSIBLE System Description Transit Mixer Drives System Series TM powersolutions.danfoss.com Revision History Table of Revisions Date Changed Rev Mar 2014 Converted to Danfoss layout

More information

Technical Information Axial Piston Motors Series 20 powersolutions.danfoss.com

Technical Information Axial Piston Motors Series 20 powersolutions.danfoss.com MKING MODERN LIVING POSSILE Technical Information xial Piston Motors Series 20 powersolutions.danfoss.com General Information Introduction Danfoss a world leader in hydraulic power systems has developed

More information

OSPB, OSPC, OSPF, OSPD, OSPQ, OSPL Load Sensing Steering Units. OLS Priority Valves. OSQ Flow Amplifiers. Technical Information

OSPB, OSPC, OSPF, OSPD, OSPQ, OSPL Load Sensing Steering Units. OLS Priority Valves. OSQ Flow Amplifiers. Technical Information OSPB, OSPC, OSPF, OSPD, OSPQ, OSPL Load Sensing Steering Units OLS Priority Valves OSQ Flow Amplifiers Technical Information A Wide Range of Steering Components Revision History Table of Revisions Date

More information

Closed Circuit Axial Piston Pumps H1 115/130 cc

Closed Circuit Axial Piston Pumps H1 115/130 cc MAKING MODERN LIVING POSSIBLE Conversion Manual Closed Circuit Axial Piston Pumps H1 115/130 cc powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev December 2015 First edition

More information

Steering Unit Type OSPB and OSPC Type ON and CN

Steering Unit Type OSPB and OSPC Type ON and CN MAKING MODERN LIVING POSSIBLE Service Manual Steering Unit Type OSPB and OSPC Type ON and CN powersolutions.danfoss.com Revision History Table of Revisions Date Changed Rev Mar 2014 Converted to Danfoss

More information

Efficient performance precise operation. PVG proportional valves

Efficient performance precise operation. PVG proportional valves Efficient performance precise operation. PVG proportional valves Modular system design enables customization for your varying vehicle control needs powersolutions.danfoss.com Flexible, efficient, and global

More information

OSPB, OSPC, OSPF, OSPD, OSPQ, OSPL Load Sensing Steering Units. OLS Priority Valves. OSQ Flow Amplifiers. Technical Information

OSPB, OSPC, OSPF, OSPD, OSPQ, OSPL Load Sensing Steering Units. OLS Priority Valves. OSQ Flow Amplifiers. Technical Information OSPB, OSPC, OSPF, OSPD, OSPQ, OSPL Load Sensing Steering Units OLS Priority Valves OSQ Flow Amplifiers Technical Information A Wide Range of Steering Components Revision History Table of Revisions Date

More information

Product Reliability Data (MTTF) for H1P

Product Reliability Data (MTTF) for H1P MAKING MODERN LIVING POSSIBLE Functional Safety Product Reliability Data (MTTF) for H1P069-250 powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev May 2015 Added CCO information

More information

OML and OMM Orbital Motors. Repair Instructions

OML and OMM Orbital Motors. Repair Instructions OML and OMM Orbital Motors Table of Contents, Revision View and Safety Precautions Revision View Date Page Changed Revision Jan 2008 all Changed from Danfoss to Sauer Danfoss lay out AA Mar 2008 13 Service

More information

Steering Valve EHPS and EHPS with OLS 320

Steering Valve EHPS and EHPS with OLS 320 Service Manual Steering Valve EHPS and EHPS with OLS 320 powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev July 2016 Updated EHPS spare parts list 0102 June 2015 First version

More information

Parts Manual Axial Piston Motors Series 40 MMF044D and MMV044D powersolutions.danfoss.com

Parts Manual Axial Piston Motors Series 40 MMF044D and MMV044D powersolutions.danfoss.com MAKING MODERN LIVING POSSIBLE Parts Manual Axial Piston Motors Series 40 MMF044D and MMV044D powersolutions.danfoss.com Front cover illustrations: P100 606 2 520L0586 Rev BB Nov 2013 Contents General Information

More information

PVG 100 Proportional Valve. Technical Information

PVG 100 Proportional Valve. Technical Information PVG 100 Proportional Valve Technical Information Contents GENERAL FUNCTION PVG 100 TECHNICAL DATA MODULES AND CODE NUMBERS General... 4 Valve system... 4 General features PVG 100... 4 PVP - Pump side module...

More information

OMT Series 2. Orbital Motors. Service Manual

OMT Series 2. Orbital Motors. Service Manual OMT Series 2 Orbital Motors Table of Contens, Special Versions Revision History Table of Revisions Date Page Changed Rev Sept 2003 CA Feb 200 4-5 Drain plug updated, Layout adjusted CB Sep 200 6 New back

More information

Orbital X Modular Program

Orbital X Modular Program Service Manual Orbital X Modular Program www.danfoss.com Revision history Table of revisions Date Changed Rev May 2018 Updated document with new S-Spring tool and information 0201 Apr 2018 Removed S-Spring

More information

Orbital Motors Seal Kits

Orbital Motors Seal Kits Technical Information Orbital Motors Seal Kits powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev October 2017 Added OMP X and OMR X data to table and updated to Engineering

More information

Automotive on PLUS+1 for MC-024

Automotive on PLUS+1 for MC-024 Technical Information Automotive on PLUS+1 for MC-024 powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev Aug 2016 Updated order numbers 0202 Dec 2015 Converted to DITA CMS

More information

TMVW Orbital Motors. Technical Information

TMVW Orbital Motors. Technical Information Orbital Motors Technical Information A Wide Range of Orbital Motors A Wide Range of Orbital Motors F300030 Tif Sauer-Danfoss is a world leader within production of low speed orbital motors with high torque.

More information

Orbital Motors with Speed Sensor

Orbital Motors with Speed Sensor MAKING MODERN LIVING POSSIBLE Technical Information Orbital Motors with Speed Sensor powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev June 2015 Code numbers deleted under

More information

Hydraulic and Electronic Control Solutions Concrete Pump Truck

Hydraulic and Electronic Control Solutions Concrete Pump Truck Hydraulic and Electronic Control Solutions Concrete Pump Truck Best Partner for a future of intelligence Quality products and systems indicate lower maintenance cost and longer service life. Our global

More information

Orbital Motors OMS, OMT and OMV Orbital Motors

Orbital Motors OMS, OMT and OMV Orbital Motors MAKING MODERN LIVING POSSIBLE Technical Information Orbital Motors OMS, OMT and OMV Orbital Motors powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev November 2014 Converted

More information

MCH Customizing the Basic Control Handle

MCH Customizing the Basic Control Handle Installation Guide MCH powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev July 2017 Removed part numbers of obsolete product 0102 August 2016 Replaces BLN 95-9051 0101 2 Danfoss

More information

Orbital Motor EMD Speed Sensor

Orbital Motor EMD Speed Sensor MAKING MODERN LIVING POSSIBLE Technical Information Orbital Motor EMD Speed Sensor powersolutions.danfoss.com Revision History Table of Revisions Date Changed Rev Feb 2014 Converted to Danfoss layout -

More information

Steering OSPB, OSPC, OSPD Open Center and OSPB Closed Center

Steering OSPB, OSPC, OSPD Open Center and OSPB Closed Center echnical Information Steering OSB, OSC, OSD Open Center and OSB Closed Center powersolutions.danfoss.com evision history able of revisions Date Changed ev April 2016 Updated to Engineering omorrow design

More information

H1 Axial Piston Pump Size 147/165, Single. Technical Information

H1 Axial Piston Pump Size 147/165, Single. Technical Information H1 Axial Piston Pump Size 147/165, Single Technical Information Revisions Revision History Table of revisions Date Page Changed Rev 30 Jul, 2009 First edition AA Jul, 2010 4-6, 10, 12-13 New EC directive

More information

Technical Information. Steering Unit OSPU. powersolutions.danfoss.com

Technical Information. Steering Unit OSPU. powersolutions.danfoss.com Technical Information Steering Unit OSPU powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev March 2016 Updated to Engineering Tomorrow design 0202 May 2014 Converted to Danfoss

More information

Technical Information Series 45 H Frame powersolutions.danfoss.com

Technical Information Series 45 H Frame powersolutions.danfoss.com MAKING MODERN LIVING POILE Technical Information eries 45 H Frame powersolutions.danfoss.com Contents Frame H Design... 4 pecifications... 5 Performance H57... 6 Performance H75D... 7 Order code... 8 Controls...

More information

D Series Gear Motors Including Fan Drive. Technical Information

D Series Gear Motors Including Fan Drive. Technical Information D Series Gear Motors Including Fan Drive Technical Information Revisions History of Revisions Table of Revisions Date Page Changed Rev. February 09 - First edition AA 09 Sauer-Danfoss. All rights reserved.

More information

T1P Transit Mixer Axial Piston Pump Size 069/089

T1P Transit Mixer Axial Piston Pump Size 069/089 Technical Information T1P Transit Mixer Axial Piston Pump Size 069/089 powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev May 2016 Updated to Engineering Tomorrow design. 0201

More information

Light and safe steering. with steering components from Sauer-Danfoss

Light and safe steering. with steering components from Sauer-Danfoss Light and safe steering with steering components from Sauer-Danfoss There are many good reasons for choosing Sauer-Danfoss for vehicle steering The prime objective of Sauer-Danfoss is to be a good partner

More information

Series 40 MMF035D and MMV035D Axial Piston Motors

Series 40 MMF035D and MMV035D Axial Piston Motors Series 40 MMF035D and MMV035D Axial Piston Motors powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev March 2018 Added shaft option B 0303 March 2018 Corrected cover image 0302

More information

Transit Mixer Axial Piston Motor Size 070/084/089

Transit Mixer Axial Piston Motor Size 070/084/089 Technical Information Transit Mixer Axial Piston Motor Size 070/084/089 powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev June 2017 Update to Engineering Tomorrow 0202 Mar

More information

Genuine Parts Original Ersatzteile. Series cc - Axial Piston Pump Service Parts Manual

Genuine Parts Original Ersatzteile. Series cc - Axial Piston Pump Service Parts Manual 250 cc - Axial Piston Pump Service Parts Manual sauecontents Genuine Parts Unit and Service Parts Identification... 3-4 Order Code... 5 Housing... 6-7 Swashplate... 6-7 Displacement Limitation... 8-9 End

More information

L and K Frame Variable Motors. Technical Information

L and K Frame Variable Motors. Technical Information L and K Frame Variable Motors Technical Information Revisions Revisions Table of Revisions Date Page Changed Rev. April 2008 6 corrected the schematic drawings BE January 2008 17 removed displacement limiter

More information

Series 90 Axial Piston Motors. Technical Information

Series 90 Axial Piston Motors. Technical Information Series 90 Axial Piston Motors Technical Information HISTORY OF REVISIONS Table of Revisions Date Page Changed Rev. Fourth edition 2 520L0604 Contents GENERAL DESCRIPTION Cross section Cross section Cross

More information

2/4/6.3, PAH 10/12.5, PAH 50/63/70/80/100 pumps

2/4/6.3, PAH 10/12.5, PAH 50/63/70/80/100 pumps Data sheet PAH pumps 2/4/6.3, PAH 10/12.5, PAH 2/4/6.3, PAH 10/12.5, PAH 20/25/32 and and PAH 50/63/70/80/100 PAH 50/63/70/80/100 pumps danfoss.high-pressurepumps.com hpp.danfoss.com Table of Contents

More information

Energy Recovery Device isave 21-40

Energy Recovery Device isave 21-40 MAKING MODERN LIVING POSSIBLE Data sheet Energy Recovery Device isave 21-40 www.isave.danfoss.com Table of Contents 1. General information....3 2. Benefits...3 3. Technical data...4 3.1 isave without motor...4

More information

TTT802 Gearshift Controller, Part # R1N-S (Standard), -P (Paddleshift)

TTT802 Gearshift Controller, Part # R1N-S (Standard), -P (Paddleshift) First, Sign and Date Bln 2009-03-9 Updated, Sign and Date Bln 200-04-29 (0) User Manual TTT802 Gearshift Controller Firmware for R--N-2- TTT802 Gearshift Controller, Part # 2-620-9-RN-S (Standard), -P

More information

PVG 120 Proportional Valves. Technical Information

PVG 120 Proportional Valves. Technical Information PVG 120 Proportional Valves Technical Information Contents CONTENTS General...3 Function...5 Hydraulic systems...7 Technical data...9 Electrical actuation... 12 Modules and code numbers... 16 PVP, pump

More information

SCM DIN. Other advantages:

SCM DIN. Other advantages: SCM 012-130 DIN SCM 012-130 DIN is a series of axial piston motors particularly suitable for mobile hydraulics. SCM 012130 DIN is of the bent-axis type with spherical pistons. Other advantages: The design

More information

Series 51 - HZ, HA, HB, HE, HS, H1, H2, K1, K2, HP, HC, J1, J2, J3, J4, JA Hydraulic Proportional Controls

Series 51 - HZ, HA, HB, HE, HS, H1, H2, K1, K2, HP, HC, J1, J2, J3, J4, JA Hydraulic Proportional Controls MAKING MODERN LIVING POSSIBLE Service Manual Series 51 - HZ, HA, HB, HE, HS, H1, H2, K1, K2, HP, HC, J1, J2, J3, J4, JA Hydraulic Proportional Controls powersolutions.danfoss.com Revision history Table

More information