PROBLEM SYMPTOMS TABLE
|
|
- Clare Floyd
- 5 years ago
- Views:
Transcription
1 A750F AUTOMATIC TRANSMISSION: AUTOMATIC TRANSMISSION SYSTEM (for 1GRFE)... Last Modified: Service Category: Drivetrain 1.6 T Section: Automatic Transmission/Transaxle Model Year: 2007 Model: 4Runner Doc ID: RM000000W73048X Title: A750F AUTOMATIC TRANSMISSION: AUTOMATIC TRANSMISSION SYSTEM (for 1GRFE): PROBLEM SYMPTOMS TABLE (2007 4Runner) PROBLEM SYMPTOMS TABLE HINT: If a normal code is displayed during the diagnostic trouble code check although the trouble still occurs, check the electrical circuits for each symptom in the order given in the s on the following pages and proceed to the page given for troubleshooting. The Matrix Chart is divided into 3 chapters. Chapter 1: Refer to the table below when the trouble cause is considered to be electrical. If the instruction "Proceed to next circuit inspection shown on matrix " is given in the flow of each circuit, proceed to the circuit with the next highest number in the table to continue the check. If the trouble still occurs even though there are no abnormalities in any of the other circuits, check and replace the ECM. 1. Chapter 1: Electronic Circuit Matrix Chart SYMPTOM SUSPECTED AREA SEE PAGE No upshift (A particular gear, from 1st to 4th gear, is not upshifted) (S1) circuit 2. Shift solenoid valve (S2) circuit circuit (D 4) 2. Engine coolant temp. sensor No upshift (4th > 5th) 3. Speed sensor NT 4. Shift solenoid valve (SL1) 5. Shift solenoid valve (SL2)
2 A750F AUTOMATIC TRANSMISSION: AUTOMATIC TRANSMISSION SYSTEM (for 1GRFE) Shift solenoid valve (SR) circuit 7. ECM 1. Engine coolant temp. sensor No upshift (3rd > 4th) 2. Shift solenoid valve (S2) circuit circuit (2 L) No upshift (1st > 2nd) 2. Shift solenoid valve (S2) circuit circuit (D 4) 2. Shift solenoid valve (SL1) No downshift (5th > 4th) 3. Shift solenoid valve (SL2) 4. Shift solenoid valve (SR) circuit 5. ECM circuit (2 L) No downshift (2nd > 1st) 2. Shift solenoid valve (S2) circuit No downshift (A particular gear, from 1st to 4th gear, is not downshifted) (S1) circuit 2. Shift solenoid valve (S2) circuit 1. ATF temperature sensor circuit 2. Transfer L4 position switch 3. Stop light switch
3 A750F AUTOMATIC TRANSMISSION: AUTOMATIC TRANSMISSION SYSTEM (for 1GRFE) Speed sensor NT No lockup 5. Shift solenoid valve (SLU) 6. Engine coolant temp. sensor 7. ECM No lockup off (SLU) (SLT) 2. Speed sensor NT 3. Speed sensor SP2 Shift point too high or too low 4. Throttle position sensor circuit 5. ATF temperature sensor circuit 6. Transfer L4 position switch 7. ECM Upshift to 5th from 4th while shift lever is in 4 position Upshift to 5th from 4th while engine is cold Upshift to 4th from 3rd while shift lever is in 3 position Upshift to 3rd from 2nd while shift lever is in 2 position Upshift to 2nd from 1st while shift lever is in L position circuit (D 4) 1. Engine coolant temp. sensor 1. Park/neutral position switch 1. Park/neutral position switch circuit (2 L) 1. Speed sensor NT 2. Shift solenoid valve (SL1)
4 A750F AUTOMATIC TRANSMISSION: AUTOMATIC TRANSMISSION SYSTEM (for 1GRFE)... Harsh engagement (N > D) 3. Shift solenoid valve (SLT) 4. ECM 1. Speed sensor NT 2. Speed sensor SP2 Harsh engagement (Lockup) 3. Shift solenoid valve (SLU) 4. ECM Harsh engagement (Any driving position) ECM 1. ATF temperature sensor No. 2 circuit Poor acceleration 2. Engine coolant temp. sensor 3. Shift solenoid valve (SLT) 4. ECM No engine braking No kickdown Engine stalls when starting off or stopping AT Oil Temp. warning light remains on, Lockup at 3rd gear and/or shift point too high ECM ECM (SLU) 1. ATF temperature sensor No. 2 circuit 2. Engine coolant temp. sensor circuit Malfunction in shifting 1. Park/neutral position switch 2. Chapter 2: Onvehicle Repair SYMPTOM SUSPECTED AREA SEE PAGE 1. Transmission control cable
5 A750F AUTOMATIC TRANSMISSION: AUTOMATIC TRANSMISSION SYSTEM (for 1GRFE)... Vehicle does not move with shift lever in any forward position and reverse position Vehicle does not move with shift lever in R position No upshift (1st > 2nd) No upshift (2nd > 3rd) No upshift (3rd > 4th) No upshift (4th > 5th) No downshift (5th > 4th) No downshift (4th > 3rd) No downshift (3rd > 2nd) No downshift (2nd > 1st) No lockup or No lockup off 2. Manual valve 3. Parking lock pawl 4. Offvehicle repair matrix 2. Offvehicle repair matrix 2. Offvehicle repair matrix 2. Offvehicle repair matrix 2. Offvehicle repair matrix 2. Offvehicle repair matrix 2. Offvehicle repair matrix 2. Offvehicle repair matrix 2. Offvehicle repair matrix 2. Offvehicle repair matrix (SLU) 3. Offvehicle repair matrix
6 A750F AUTOMATIC TRANSMISSION: AUTOMATIC TRANSMISSION SYSTEM (for 1GRFE)... (SL1) Harsh engagement (N > D) 3. C1 accumulator 4. Offvehicle repair matrix (SLU) Harsh engagement (Lockup) 3. Offvehicle repair matrix (SLT) Harsh engagement (N > R) 2. Shift solenoid valve (SLU) 3. Valve body assembly 4. C3 accumulator 5. Offvehicle repair matrix (SLT) Harsh engagement (1st > 2nd > 3rd > 4th > 5th) 2. Shift solenoid valve (SL1) Harsh engagement (1st > 2nd) Harsh engagement (2nd > 3rd) Harsh engagement (3rd > 4th) 3. Valve body assembly 2. B3 accumulator 3. Offvehicle repair matrix 2. C3 accumulator 3. Offvehicle repair matrix 2. C2 accumulator 3. Offvehicle repair matrix
7 A750F AUTOMATIC TRANSMISSION: AUTOMATIC TRANSMISSION SYSTEM (for 1GRFE)... (SL1) Harsh engagement (4th > 5th) 2. Shift solenoid valve (SL2) 3. Valve body assembly 4. Offvehicle repair matrix (SL1) Harsh engagement (5th > 4th) 2. Shift solenoid valve (SL2) 3. Valve body assembly 4. Offvehicle repair matrix 1. Transmission control cable Slip or shudder (Forward and reverse) 3. Oil strainer 4. Offvehicle repair matrix No engine braking (1st: L position) No engine braking (2nd: 2 position) No kickdown Shift point too high or too low Poor acceleration Engine stalls when starting off or stopping 2. Offvehicle repair matrix 2. Offvehicle repair matrix Valve body assembly (SLT) 2. Shift solenoid valve (SL1) 3. Valve body assembly (SLT) (SLU)
8 A750F AUTOMATIC TRANSMISSION: AUTOMATIC TRANSMISSION SYSTEM (for 1GRFE) Chapter 3: OffVehicle Repair SYMPTOM SUSPECTED AREA SEE PAGE Vehicle does not move with shift lever in any forward position and reverse position 1. Rear planetary gear unit 2. Torque converter clutch 1. Brake No. 4 (B4) Vehicle does not move with shift lever in R position 2. Clutch No. 3 (C3) 3. Oneway clutch No Brake No. 3 (B3) No upshift (1st > 2nd) 2. Oneway clutch No Oneway clutch No. 2 (F2) No upshift (2nd > 3rd) No upshift (3rd > 4th) No upshift (4th > 5th) No lockup or No lockup off Clutch No. 3 (C3) Clutch No. 2 (C2) 1. Brake No. 1 (B1) 2. Clutch No. 1 (C1) Torque converter clutch 1. Clutch No. 1 (C1) Harsh engagement (N > D) 2. Oneway clutch No. 3 (F3) 1. Clutch No. 3 (C3) Harsh engagement (N > R) 2. Brake No. 4 (B4) 3. Oneway clutch No Brake No. 3 (B3) Harsh engagement (1 > 2) 2. Oneway clutch No Oneway clutch No. 2 (F2) Harsh engagement (2 > 3) Harsh engagement (3 > 4) Clutch No. 3 (C3) Clutch No. 2 (C2) 1. Brake No. 1 (B1)
9 A750F AUTOMATIC TRANSMISSION: AUTOMATIC TRANSMISSION SYSTEM (for 1GRFE)... Harsh engagement (4 > 5th) Harsh engagement (Lockup) 2. Clutch No. 1 (C1) Torque converter clutch 1. Oneway clutch No. 1 Slip or shudder (Forward and reverse: After warmup) 2. Clutch No. 3 (C3) 3. Torque converter clutch Slip or shudder (Particular position: Just after engine starts) Torque converter clutch 1. Brake No. 4 (B4) Slip or shudder (R position) 2. Oneway clutch No Clutch No. 3 (C3) 1. Clutch No. 1 (C1) Slip or shudder (1st) 2. Oneway clutch No. 3 (F3) 1. Clutch No.1 (C1) 2. Brake No. 3 (B3) Slip or shudder (2nd) 3. Oneway clutch No Oneway clutch No. 2 (F2) 1. Clutch No. 1 (C1) Slip or shudder (3rd) Slip or shudder (4th) 2. Clutch No. 3 (C3) 3. Oneway clutch No Clutch No. 1 (C1) 2. Clutch No. 2 (C2) 1. Clutch No. 2 (C2) Slip or shudder (5th) 2. Clutch No. 3 (C3) 3. Brake No. 1 (B1) No engine braking (1st 4th: D position) No engine braking (1st: L position) No engine braking (2nd: 2 position) No engine braking (3rd: 3 position) Clutch No. 1 (C1) Brake No. 4 (B4) Brake No. 2 (B2) Brake No. 1 (B1)
10 A750F AUTOMATIC TRANSMISSION: AUTOMATIC TRANSMISSION SYSTEM (for 1GRFE)... Poor acceleration (All positions) Torque converter clutch 1. Clutch No. 1 (C1) 2. Clutch No. 3 (C3) Poor acceleration (5th) 3. Brake No. 1 (B1) 4. Front planetary gear unit Engine stalls when starting off or stopping Torque converter clutch
PROBLEM SYMPTOMS TABLE
Last Modified: 4262007 Service Category: Drivetrain 1.6 T Section: Automatic Transmission/Transaxle Model Year: 2007 Model: 4Runner Doc ID: RM000000W7304AX Title: A750E AUTOMATIC TRANSMISSION: AUTOMATIC
More informationPROBLEM SYMPTOMS TABLE
DI476 PROBLEM SYMPTOMS TABLE HINT: If a normal code is displayed during the DTC check but the trouble still occurs, check the circuits for each symptom in the order given in the charts on the following
More informationDIAGNOSTIC TROUBLE CODE CHART
Last Modified: 4-26-2007 Service Category: Drivetrain 1.6 S Secti: Automatic Transmissi/Transaxle Model Year: 2007 Model: 4Runner Doc ID: RM000000W71043X Title: A750F AUTOMATIC TRANSMISSION: AUTOMATIC
More informationTROUBLESHOOTING BASIC TROUBLESHOOTING AT1 14 A340E A340F AUTOMATIC TRANSMISSION
AT114 BASIC Before troubleshooting an electronically controlled transmission, first determine whether the problem is electrical or mechanical. To do this, just refer to the basic troubleshooting flowchart
More informationA750F AUTOMATIC TRANSMISSION: AUTOMATIC TRANSMISSION SYSTEM (for 1GR-FE)... Model Year: 2007 Model: 4Runner Doc ID: RM000000W80023X
Last Modified: 4-26-2007 Service Category: Drivetrain 1.6 C Section: Automatic Transmission/Transaxle Model Year: 2007 Model: 4Runner Doc ID: RM000000W80023X Title: A750F AUTOMATIC TRANSMISSION: AUTOMATIC
More informationA750E AUTOMATIC TRANSMISSION: AUTOMATIC TRANSMISSION SYSTEM (for 1GR-FE)... Model Year: 2007 Model: 4Runner Doc ID: RM000000XP101WX
Last Modified: 4-26-2007 Service Category: Drivetrain 1.6 C Section: Automatic Transmission/Transaxle Model Year: 2007 Model: 4Runner Doc ID: RM000000XP101WX Title: A750E AUTOMATIC TRANSMISSION: AUTOMATIC
More informationELECTRONIC CONTROLLED AUTOMATIC TRANSAXLE [ECT] (Apr., 2003)
DIAGNOSTICS TRANSAXLE [ECT] (Apr., 2003) PRECAUTION NOTICE: 05345 Perform the RESET MEMORY (AT initialization) when replacing the automatic transaxle assy, engine assy or ECM (See page 05371). HINT: Initialization
More informationDI 244 DIAGNOSTICS AUTOMATIC TRANSMISSION DIB30 01 PRE CHECK
DI244 DIAGNOSTICS PRECHECK DIB3001 1. DIAGNOSIS SYSTEM (a) Description When troubleshooting OBD II vehicles, the only difference from the usual troubleshooting procedure is that you connect to the vehicle
More informationShift Solenoid "B" Performance (Shift Solenoid Valve S2)
88 A750F AUTOMIC TRANSMISSION AUTOMIC TRANSMISSION SYSTEM DTC P0756 Shift Solenoid "B" Performance (Shift Solenoid Valve S2) DESCRIPTION The ECM uses signals from the output shaft speed sensor and input
More informationShift Solenoid "B" Performance (Shift Solenoid Valve S2)
86 A750E AUTOMIC TRANSMISSION AUTOMIC TRANSMISSION SYSTEM DTC P0756 Shift Solenoid "B" Performance (Shift Solenoid Valve S2) DESCRIPTION The ECM uses signals from the output shaft speed sensor and input
More informationMechanical System Tests
AT196 Mechanical System Tests STALL TEST The object of this test is to check the overall performance of the transmission and engine by measuring the stall speeds in the D and R positions. NOTICE: Perform
More information(c) Remove the solenoids.
ONVEHICLE REPAIR AT117 4. WHEN REPLACING 3 SOLENOIDS (a) Disconnect the connectors from the solenoids. (b) Remove the solenoid mounting bolts. Torque: 10 N m (100 kgf cm, 7 ft lbf) (c) Remove the solenoids.
More informationPRE CHECK DI 456. w/ Tachometer. w/o Tachometer. Hand held Tester AUTOMATIC TRANSMISSION (A340E, A340F) 2003 TOYOTA TACOMA (RM1002U) D10837 D00729
DI456 w/ Tachometer w/o Tachometer D10837 PRECHECK DI8Z403 1. DIAGNOSIS SYSTEM (a) Description When troubleshooting OBD II vehicles, the only difference from the usual troubleshooting procedure is that
More informationElectronic Control System
AT440 AUTOMATIC TRANSMISSION A340F 4WD Electronic Control System PRECAUTION Do not open the cover or the case of the ECU and various computer unless absolutely necessary. (If the IC terminals are touched,
More informationShift Solenoid "A" Performance (Shift Solenoid Valve S1)
78 DTC P0751 Shift Solenoid "A" Performance (Shift Solenoid Valve S1) DESCRIPTION The ECM uses signals from the output shaft speed sensor and input speed sensor to detect the actual gear position (1st,
More informationAUTOMATIC TRANSAXLE SYSTEM
AUTOMATIC TRANSAXLE SYSTEM PRECAUTION 2008 TRANSMISSION U241E Automatic Transaxle - RAV4 NOTE: Perform the RESET MEMORY procedures (A/T initialization) when replacing the automatic transaxle assembly,
More informationA140E AUTOMATIC TRANSAXLE
AUTOMATIC TRANSAXLE AX11 A140E AUTOMATIC TRANSAXLE AX12 AUTOMATIC TRANSAXLE DESCRIPTION DESCRIPTION PRECAUTIONS When working with FIPG material, you must observe the following. Using a razor blade and
More informationElectronic Control System
Electronic Control System PRECAUTION AT79 Do not open the cover or the case of the ECM and various computer unless absolutely necessary. (If the IC terminals are touched, the IC may be destroyed by static
More informationTIME LAG TEST Check the automatic transmission (each clutch, brake and gear) for wear.
AT2 TROUBLESHOOTING 1. GENERAL INFORMATION (a) Troubles occurring with the automatic transmission can be caused by either the engine, electrical control or the transmission itself. These 3 areas should
More informationELECTRONIC CONTROL SYSTEM. 1. General CH-16 CHASSIS - U340E AUTOMATIC TRANSAXLE
CH-16 ELECTRONIC CONTROL SYSTEM 1. General The electronic control system of the U340E automatic transaxle consists of the controls listed below. System Clutch Pressure Control (See page CH-20) Line Pressure
More informationCHASSIS AUTOMATIC TRANSAXLE. Destination New Model Previous Model Change (from previous model)
CHASSIS AUTOMATIC TRANSAXLE CH-37 U341E AUTOMATIC TRANSAXLE 1. General The compact and high-capacity 4-speed U341E automatic transaxle [Super ECT (Electronic Controlled Transaxle)] is used. The following
More information1994 Toyota LAND CRUISER TROUBLESHOOTING. Submodel: Engine Type: L6 Liters: 4.5 Fuel Delivery: FI Fuel: GAS
1994 Toyota LAND CRUISER Submodel: Engine Type: L6 Liters: 4.5 Fuel Delivery: FI Fuel: GAS TROUBLESHOOTING Trouble occurring in the electronically controlled transmission can stem from one of three sources:
More informationCH-23 CHASSIS AA80E AUTOMATIC TRANSMISSION. Function of Shift Solenoid Valves. Spool Valve. Hydraulic Pressure. Sleeve. Current. Shift Solenoid Valve
CH-23 Spool Valve Hydraulic Sleeve Shift Solenoid Valve SL2 Current 036CH29TE Spool Valve Hydraulic Sleeve Shift Solenoid Valve SLU Current 036CH27TE Spool Valve Hydraulic Sleeve Shift Solenoid Valve SLT
More informationContinuously Variable Transaxle Specification. Forward/Reverse Switching Mechanism Double Pinion Type Planetary Gear
CVT SYSTEM > GENERAL OUTLINE 1. A newly developed K41A Continuously Variable Transaxle (CVT) is used for the1kr-fe engine models. 2. The K41A CVT, including a pair of the pulleys and the belt in the shift
More informationPressure Control Solenoid "D" Performance (Shift Solenoid Valve SLT)
116 750E UTOMIC TRNSMISSION UTOMIC TRNSMISSION SYSTEM DTC DESCRIPTION P2714 Pressure Control Solenoid "D" Performance (Shift Solenoid Valve SLT) Line Pressure Control Pressure Current Flow to Solenoid
More informationU140E AND U241E AUTOMATIC TRANSAXLE
CH-125 U140E AND U241E AUTOMATIC TRANSAXLE DESCRIPTI The 02 Camry line-up uses the following types of automatic transaxles: 2AZ-FE U241E 1MZ-FE U140E These automatic transaxles are compact and high-capacity
More informationOPERATION AT-2. Clutch No.3 (C 3 ) Clutch No.1 (C 1 ) One-way Clutch
AT2 OPERATION AT13K01 Clutch No.3 (C 3 ) Clutch No.1 (C 1 ) Clutch No.2 (C 2 ) Oneway Clutch No.2 (F 2 ) Brake No.3 (B 3 ) Oneway Clutch No.1 (F 1 ) Brake No.1 (B 1 ) Brake No.2 (B 2 ) Oneway Clutch No.3
More informationContinuously Variable Transaxle Specification. Forward/Reverse Switching Mechanism Double Pinion Type Planetary Gear
CVT SYSTEM > GENERAL OUTLINE 1. A newly developed K41B Continuously Variable Transaxle (CVT) is used for the1nr-fe engine models. 2. The K41B CVT, including a pair of the pulleys and the belt in the shift
More information12.Electrohydraulic Control System
W1860BE.book Page 67 Tuesday, January 28, 2003 11:01 PM 12.Electrohydraulic Control System A: DESCRIPTION The electrohydraulic system for the transmission and transfer consists of various sensors and switches,
More informationGeo Prizm ( LSi) Toyota Celica 1.8L (1994)
Page 1 of 140 ARTICLE BEGINNING APPLICATION TRANSMISSION APPLICATIONS Application Geo Prizm (1993-94 LSi) Toyota Celica 1.6L (1993) Celica 1.8L (1994) Celica 2.2L (1993) Corolla 1.8L MR2 Paseo Transaxle
More informationDTC Table (Extended Code)
In4 DTC Table (Extended Code) DTC Document Title See Page P0010 OCV for VVT Monitor Co13 P0011 P0012 Valve Timing i Monitor Co6 P0016 P0018 VVT System Monitor Co8 P0020 OCV for VVT Monitor Co13 P0021 P0022
More informationTechnical Service Information
TOYOTA/LEXUS U/U0 PRELIMINARY INFORMATI Starting at the beginning of production for the 00 model year for Lexus and 00 for Toyota, a spin-off of the U10/U0 Four speed transaxle, designated as the U/U0
More informationU340E AND U441E AUTOMATIC TRANSAXLES
ASSIS U340E AND U441E AUTOMATIC TRANSAXLES -41 U340E AND U441E AUTOMATIC TRANSAXLES DESCRIPTION The new model uses 2 types (U340E, U441E) of automatic transaxle. A U340E automatic transaxle is provided
More informationThe Toyota A750E was first
A Closer Look at the Toyota A750E Valve Body by Mike Brown members.atra.com Figure 1 The Toyota A750E was first introduced in the 2003 4-Runner and Land Cruiser, and the Lexus LX400 and GX470. Since then
More informationDIAGNOSTIC TROUBLE CODE CHART (SAE Controlled)
1MZFE ENGINE EG2404 (SAE Controlled) HINT: Parameters listed in the chart may not be exactly the same as your reading due to the type of instrument or other factors. DTC No. Detection Item Diagnostic Trouble
More informationDiagnostic Procedures
Diagnostic Procedures Lesson Objectives 1. Perform all preliminary checks prior to test driving. 2. Relate the importance that verifying the customer concern plays in diagnosis. 3. Explain the types of
More informationElectronic Cautions. Resetting Shift Adapts. Post-Adapt Road Test. Solenoids. 5th Off Off ON ON ON ON
Toyota u5e-u250e zip Kit PaRT NUMBER u5e-u250e-zip Installation & TESTING BOOKLET Torque Specifications Pan Filter to Valve Body 8 ft-lb Oil Pan to Transaxle 9 in-lb Component Pack Clearance Forward (C)
More informationATF (AUTOMATIC TRANSMISSION FLUID) WS
CH-8 CHASSIS - U250E AUTOMATIC TRANSAXLE ATF (AUTOMATIC TRANSMISSION FLUID) WS ATF WS is used to reduce the resistance of the ATF and improve the fuel economy by reducing its viscosity in the practical
More informationItems Vehicles with 4G63 engine Vehicles with 4D56 engine. Type 4-speed full automatic 4-speed full automatic. 2nd rd
23-2 AUTOMATIC TRANSMISSION General Information/ Service Specifications GENERAL INFORMATION 23100010141 Items Vehicles with 4G63 engine Vehicles with 4D56 engine Transmission model R4AW2-6 V4AW2-6 Type
More informationDESCRIPTION. Chrysler NCV3 Service Info Section 08 > Electronic Modules > MODULE, Transmission Control Information
DESCRIPTION The transmission control module (TCM) receives, processes and sends various digital and analog signals related to the automatic transmission. In addition, it processes information received
More informationAISIN AW 60-41SN (AF-17)
AISIN AW 60-41SN (AF-17) zip Kit PaRT NUMBER AW60-41SN-ZIP Installation & TESTING BOOKLET Torque Specifications Manual Shaft Detent Spring Bolt 89 in-lb Manual Shift Shaft Retaining Nut 61 in-lb Transmission
More informationAUTOMATIC TRANSMISSION (DIAGNOSTICS) AT
AUTOMATIC TRANSMISSION (DIAGNOSTICS) AT Page 1. Basic Diagnostic Procedure...2 2. Check List for Interview...4 3. General Description...5 4. Electrical Components Location...7 5. Transmission Control Module
More informationAUTOMATIC TRANSMISSION (DC 5-SPEED) GENERAL 1. AUTOMATIC TRANSMISSION OVERVIEW
02-4 AUTOMATIC TRANSMISSION () GENERAL 1. AUTOMATIC TRANSMISSION OVERVIEW DC 5-speed Automatic Transmission Assembly T-Tronic DC 5-speed automatic transmission is an electronically controlled 5-speed transmission
More informationPage 1 of 13 437: Transmission control module (TCM), TF-80SC AWD XC90, 2007, D5244T4, TF-80SC AWD, L.H.D, YV1CM714671338226, 338226 7/7/2016 PRINT 437: Transmission control module (TCM), TF-80SC AWD Adaptation
More informationDTC 51 Switch Condition Signal Circuit
EG614 EINE TROUBLESHOOTI DT 51 Switch ondition Signal ircuit IRUIT DESRIPTION Park/Neutral Position Switch Signal The EM uses the signals from the Park/neutral position switch to determine whether the
More informationTOYOTA U151E-U250E ZIP KIT
TOYOTA U5E-U50E ZIP KIT PART NUMBER U5E-U50E-ZIP QUICK GUIDE Parts are labeled here in order of installation. See other side of sheet for details on Zip Kit contents. installation Diagram Upper Valve Body
More informationAUTOMATIC TRANSMISSION SECTIONAT CONTENTS IDX
AUTOMATIC TRANSMISSION SECTIONAT GI MA EM LC EC CONTENTS FE TROUBLE DIAGNOSIS - INDEX...4 Alphabetical & P No. Index for DTC...4 PRECAUTIONS...6 Supplemental Restraint System (SRS) AIR BAG and SEAT BELT
More informationTransmission Description
Page 1 of 23 Published: Feb 1, 2007 Transmission Description COMPONENT LOCATION Item Part Number Description 1 Transmission selector lever assembly 2 Cable bracket 3 Automatic transmission 4 Transmission
More informationDSI M78 6-SPEED A/T / / / / / DSI M78 6-SPEED A/T GENERAL INFORMATION OVERVIEW AND OPERATION PROCESS
DSI M78 6SPEED A/T 311001/365001/366001/368001/372101/921001 DSI M78 6SPEED A/T GENERAL INFORMATION 1. DSI M78 6SPEED AUTOMATIC TRANSMISSION GENERAL... 2. STRUCTURE CHARACTERISTICS AND SPECIFICATIONS...
More informationDIAGNOSTIC TROUBLE CODE CHART HINT:
DIAGNOSTICS DIAGNOSTIC TROUBLE CODE CHART HINT: SFI SYSTEM (1MZFE) 05241 Parameters listed in the chart may not be exactly the same as your reading due to the type of instrument or other factors. If a
More informationTOYOTA/LEXUS U151E, U151F, U250E Zip Kit
TOYOTA/LEXUS U5E, U5F, U50E Zip Kit PART NUMBER U5E-U50E-ZIP QUICK GUIDE Parts are labeled here in order of installation. See other side of sheet for details on Zip Kit contents. installation Diagram Upper
More informationAUTOMATIC TRANSMISSION SECTIONAT CONTENTS IDX
AUTOMATIC TRANSMISSION SECTIONAT GI MA EM LC EC CONTENTS FE CL TROUBLE DIAGNOSIS - INDEX...4 Alphabetical & P No. Index for DTC...4 PRECAUTIONS...6 Precautions for Supplemental Restraint System (SRS) AIR
More informationAWTF80SC / 81SC (AF21/AF40-6)
AWTF80SC / 81SC (AF21/AF40-6) FWD 6 Speed 15 35 11 10 40 41 65 50 66 A Pump Assembly 2-6 (B1) Brake Band 3-5 Reverse (C3) Drum 75 Filter 80 20 21 51 52 57 16 17 58 B 24 3-5 Reverse (C3) Clutch 25 81 Front
More informationLX AUTOMATIC TRANSMISSION NAG1 - SERVICE INFORMATION TABLE OF CONTENTS
LX AUTOMATIC TRANSMISSION NAG1 - SERVICE INFORMATION 21-495 AUTOMATIC TRANSMISSION NAG1 - SERVICE INFORMATION TABLE OF CONTENTS page AUTOMATIC TRANSMISSION NAG1 - SERVICE INFORMATION DESCRIPTION...496
More information1. GENERAL INFORMATION
368001 023 1. GENERAL INFORMATION DSI M78 Automatic Transmission is based on the transmission in the vehicle with D20DT engine for EURO III or EURO IV. Differences: changed some components (torque converter
More information2000 Jeep Truck Cherokee 4WD L6-4.0L VIN S
2000 Jeep Truck Cherokee 4WD L6-4.0L VIN S Vehicle» Transmission and Drivetrain» Automatic Transmission/Transaxle» Service and Repair» 30-40LE (AW4) 4 Speed» Overhaul (Transmission)» Disassembly DISASSEMBLY
More informationDC-5 SPEED AUTOMATIC TRANSMISSION
01-3 DC-5 SPEED AUTOMATIC TRANSMISSION GENERAL 1. SPECIFICATIONS 01-4 01-5 OVERVIEW AND OPERATION PROCESS 1. OVERVIEW 2WD 4WD DC 5-Speed Automatic Transmission DCAG 5-speed automatic transmission is an
More informationAW55-50SN / AF23/33-5 / RE5-F22A
AW55-50SN / AF23/33-5 / RE5-F22A FWD 5 Speed 11 10 51 A Pump Assembly 65 B Filter C 12 Case D 84 SLT SLU 82 83 116 SLS Differential 150 Valve Body 115 81 1 80 Shift Solenoids Band Servo Linkage Assembly
More informationAUTOMATIC TRANSMISSION (5AT)
(5AT) GENERAL 1. General To improve the dynamic performance and fuel efficiency of the vehicle, a new 5-speed automatic transmission is developed. The features of this new automatic transmission are as
More informationDiagnostic Trouble Code (DTC) Charts
SECTION 307-01: Automatic Transaxle/Transmission 5R55S 2009 Mustang Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 06/30/2009 Diagnostic Trouble Code (DTC) Charts DTC Chart **May also be
More informationVAGABOND S HANDBOOK TRANSMISSION
03/24/07 TRANSMISSION Transmission won t engage into Gear This is caused usually by too low a Voltage to get into the ECM. This unit requires a minimum of 9VDC in order to operate at all. Almost all erratic
More informationDC 5-SPEED AUTOMATIC TRANSMISSION
03 1. OVERVIEW 2WD 4WD DCAG 5speed automatic transmission is an electronically controlled 5speed transmission with a lockup clutch in the torque converter. The ratios for the gears are realized by three
More informationAUTOMATIC OF TRANSMISSION
AT-1 AUTOMATIC TRANSMISSION DESCRIPTION OPERATION TROUBLESHOOTING General Notes General Troubleshooting Preliminary Check Mechanical System Tests Automatic Shift Schedule Neutral Start Switch O/D Solenoid
More informationA750F AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION SYSTEM
140 A750F AUTOMIC TRANSMISSION AUTOMIC TRANSMISSION SYSTEM P2740 P2742 P2743 Circuit Circuit Low Input Circuit High Input DESCRIPTION The No. 2 Automatic Transmission Fluid (F) temperature sensor is on
More informationABBREVIATIONS USED IN THIS
IN10 INTRODUCTION ABBREVIATIONS USED IN THIS MANUAL ABBREVIATIONS USED IN THIS MANUAL ATF Automatic Transmission Fluid B 0 Overdrive Brake B 2 Second Brake B 3 No. 3 Brake C 0 Overdrive Direct Clutch C
More informationG - TESTS W/CODES - 2.2L
G - TESTS W/CODES - 2.2L 1994 Toyota Celica 1994 ENGINE PERFORMANCE Toyota 2.2L Self-Diagnostics Celica INTRODUCTION If no faults were found while performing F - BASIC TESTING, proceed with self-diagnostics.
More informationThe AW55-50SN transmission
TECHNICAL TRAINING Shift Pointers Author: Jesse Zacarias Subject: Drive and Reverse engagement problems Unit: AW55-50SN (Nissan RE5F22A, GM AF33-5) Vehicle Applications: 2005 Nissan Altima Essential Reading:
More informationL (L36) F-car 4L60-E TRANSMISSION DIAGNOSTIC PARAMETERS. 97c38K_F at.doc
Vehicle Speed Sensor - Low input Vehicle Speed Sensor - Intermittent Trans Fluid Temp Sensor Circuit - Range / Performance P0502 P0503 0 RPM to 6000 RPM low vehicle speed when the vehicle has a large engine
More informationTable of Contents INTRO
GENERAL ALL Wheel Drive Systems General System Overview...2 Transfer Coupling...3 Diagnostics, Tire Wear, Codes...4 Rolling Circumference Test...5 Getrag 760 T-Case Introduction and Service Information...6
More informationL (LS1) F-car (Camaro, Firebird), Y-car (Corvette) 4L60-E TRANSMISSION DIAGNOSTIC PARAMETERS. 99c57G_FY_aT.DOC
SECONDRY S ND Vehicle Speed Sensor - Low input Vehicle Speed Sensor - Intermittent P0502 0 RPM to 6000 RPM low vehicle speed when the vehicle has a large engine speed in a drive gear range. P0503 0 RPM
More informationPROBLEM SYMPTOMS TABLE
3MZ-FE ENGINE CONTROL SYSTEM SFI SYSTEM 29 SFI SYSTEM PROBLEM SYMPTOMS TABLE Symptom Suspected area See page 1. Starter ST-8 Engine does not crank (Does not start) 2. ST relay ST-2 3. Park/neutral position
More informationTRANSMISSION DIAGNOSTIC PARAMETERS
TCM, Internal P0605 ROM checksum or RAM error Calculated checksum differs from stored. Ignition ON Number of failed calculations: 2 Lost communication with ECM (Engine) U0100 Frame missing from ECM Detect
More informationAUTOMATIC TRANSAXLE SECTIONAT CONTENTS IDX
AUTOMATIC TRANSAXLE SECTIONAT GI MA EM LC EC CONTENTS FE TROUBLE DIAGNOSIS - INDEX...5 Alphabetical & P No. Index for DTC...5 PRECAUTIONS...7 Supplemental Restraint System (SRS) AIR BAG and SEAT BELT PRE-TENSIONER...7
More informationToyota A750 E/F A760 E/F A761 Introduction. Sponsored By: Presented by: Steve Garrett ATRA
Toyota A750 E/F A760 E/F A761 Introduction Sponsored By: Presented by: Steve Garrett ATRA Today s Presentation Sponsored By: Lwiggins@ATRA.com Connections Handout Questions Survey Toyota A750 E/F Common
More informationDiagnosis System DESCRIPTION AT 109
AT109 Diagnosis System DESCRIPTION 1. A selfdiagnosis function is built into the electrical control system. Warning is indicated by the overdrive OFF indica tor light. HINT: Warning and diagnostic trouble
More informationDISASSEMBLY TRANSAXLE DISASSEMBLY AND ASSEMBLY. Part 1 Of 3
2004 Mitsubishi Truck Endeavor V6-3.8L SOHC Vehicle > Transmission and Drivetrain > Automatic Transmission/Transaxle > Service and Repair > Overhaul > F4A5A > Disassembly and Assembly DISASSEMBLY TRANSAXLE
More informationCRUISE CONTROL SYSTEM
CRUISE CONTROL SYSTEM CONTROL SYSTEM PARTS LOCATION CRUISE CONTROL CRUISE CONTROL SYSTEM 1 ENGINE ROOM R/B AND J/B MAIN BODY ECU (INSTRUMENT PANEL J/B) B142328E05 2 CRUISE CONTROL CRUISE CONTROL SYSTEM
More information1. DO NOT HANDLE REFRIGERANT IN AN ENCLOSED AREA OR NEAR AN OPEN FLAME
2006 Toyota 4Runner 4.0L Eng Limited 1Search AIR CONDITIONER REQUESTED INFORMATION PRECAUTION 1. DO NOT HANDLE REFRIGERANT IN AN ENCLOSED AREA OR NEAR AN OPEN FLAME 2. ALWAYS WEAR EYE PROTECTION Fig 1:
More information2001 FORESTER SERVICE MANUAL QUICK REFERENCE INDEX
2001 FORESTER SERVICE MANUAL QUICK REFERENCE INDEX TRANSMISSION SECTION This service manual has been prepared to provide SUBARU service personnel with the necessary information and data for the correct
More informationDIAGNOSTIC TROUBLE CODE CHART
DIAGNOSTIC TROUBLE CODE CHART HINT: DI231 Parameters listed in the chart may not be exactly the same as your readings due to the type of instrument or other factors. If a malfunction code is displayed
More informationCRUISE CONTROL SYSTEM
Negative (-) Battery Terminal CRUISE CONTROL CRUISE CONTROL SYSTEM Cable System name METER / GAUGE SYSTEM D033496E01 CRUISE CONTROL SYSTEM PRECAUTION 1 1. DISCONNECT AND RECONNECT CABLE OF NEGATIVE BATTERY
More informationAUTOMATIC TRANSMISSION
23A-1 GROUP 23A AUTOMATIC TRANSMISSION CONTENTS SERVICE SPECIFICATIONS....... 23A-3 LUBRICANTS.................. 23A-3 SPECIAL TOOLS................ 23A-4...... 23A-7 STANDARD FLOW OF DIAGNOSIS TROUBLESHOOTING................
More informationALLISON IDENTIFICATION TAG
ALLISON IDENTIFICATION TAG 1000 2000 2000MH 2400 Heavy duty automatic transmission with parking pawl. maximum GVW = 19850 lb. Heavy duty automatic transmission without parking pawl. maximum GVW = 30000
More informationDTC P0717 Input Speed Sensor Circuit No Signal
A750F AUTOMIC TRANSMISSION AUTOMIC TRANSMISSION SYSTEM 65 DTC P0717 Input Speed Sensor Circuit No Signal DESCRIPTION This sensor detects the rotation speed of the turbine which shows the input revolution
More informationProECU Nissan GT-R & Juke
ProECU Nissan GT-R & Juke DTC List 2008-onward Model Year v1.23 1.1. Engine DTC List U0101 Lost communication with TCM U0164 Lost communication with HVAC U1001 CAN Communication Line Error P0011 Intake
More informationDI 3 ENGINE DIAGNOSTICS DI PRE CHECK
FI0534 PRECHECK DI3 DI09603 1. DIAGNOSIS SYSTEM (a) Description When troubleshooting OBD II vehicles, the only difference from the usual troubleshooting procedure is that you connect to the vehicle the
More informationTRANSMISSION DIAGNOSTIC PARAMETERS
Transmission Fluid Overtemperature Vehicle Speed Sensor - Low input Vehicle Speed Sensor - Intermittent Trans Fluid Temp Sensor ircuit - Performance Test P0218 This DT detects a high transmission temperature
More informationModel Year: 2007 Model: Tacoma Doc ID: RM H800NX
Page 1 of 12 Last Modified: 5-7-2008 5.1 C From: 200608 Model Year: 2007 Model: Tacoma Doc ID: RM0000013H800NX Title: 2TR-FE ENGINE CONTROL SYSTEM: SFI SYSTEM: P2A00: A/F Sensor Circuit Slow Response (Bank
More informationTechnical Bulletin Listing 2008
Technical Bulletin Listing 2008 December, 2008 Transmission Bulletin # # Pages Subject January 5R55N/S/W 1149 1 Soft 1-2, 2-3 Shift, Possible Skipped Shift Honda/Acura 1150 1 Filling and Checking the Oil
More information3. Engine Control System Diagram
ENGINE - 2UZ-FE ENGINE 59 3. Engine Control System Diagram Ignition Switch Fuel Pump Relay Fuel Pump Resister Circuit Opening Fuel Relay Filter Intake Temp. Mass Air Flow Meter Throttle Position Fuel Pump
More informationP0733 DTC P0733 A/T 3RD GEAR FUNCTION
2003 Nissan-Datsun Altima L4-2.5L (QR25DE) Vehicle > ALL Diagnostic Trouble Codes ( DTC ) > Testing and Inspection > P Code Charts P0733 DTC P0733 A/T 3RD GEAR FUNCTION Description - This is an OBD-II
More informationTRANSMISSION CONTROL SYSTEM (4L30 E)
TRANSMISSION CONTROL SYSTEM (4L30 E) 7A1 1 RODEO TRANSMISSION TRANSMISSION CONTROL SYSTEM (4L30 E) CONTENTS Service Precaution...................... 7A1 2 General Description..................... 7A1 2
More informationAUTOMATIC TRANSMISSIONS. General Motors Corp. Hydra-Matic 4L60-E Overhaul
1997-98 AUTOMATIC TRANSMISSIONS General Motors Corp. Hydra-Matic 4L60-E Overhaul APPLICATION TRANSMISSION APPLICATIONS Application Corvette Transaxle 4L60-E IDENTIFICATION The 4L60-E transmission can be
More informationDIAGNOSIS SYSTEM DESCRIPTION EG2 170
EG2170 DIAGNOSIS SYSTEM DESCRIPTION The ECM contains a builtin self diagnosis system by which troubles with the engine signal network are detected and a malfunction indicator lamp on the combination meter
More informationAUTOMATIC TRANSMISSIONS Mitsubishi F3A20 Series TRANSMISSION APPLICATION TABLE
Article Text ARTICLE BEGINNING AUTOMATIC TRANSMISSIONS Mitsubishi F3A20 Series APPLICATION TRANSMISSION APPLICATION TABLE Vehicle Application Transmission Model Colt 3-Speed (1990-94)... F3A21 Colt Vista
More informationAUTOMATIC TRANSMISSION SYSTEM
AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION SYSTEM PRECAUTION AUTOMATIC TRANSMISSION SYSTEM If the vehicle is equipped with a mobile communication system, refer to the precautions in the IN section.
More informationFront automatic transmission 722.7, BR 168. Transmission. Notes on complaints relating to shift quality
tes on complaints relating to shift quality 1 Use the flow diagram "Shift quality" for the following complaints: Harsh engagement from N to D. Harsh engagement from N to R. Hard upshifts. Hard downshifts.
More information2002 Ford Explorer AUTOMATIC TRANSMISSIONS' '5R55W/S Diagnosis 2002 AUTOMATIC TRANSMISSIONS. 5R55W/S Diagnosis
2002 AUTOMATIC TRANSMISSIONS 5R55W/S Diagnosis APPLICATION WARNING: Vehicles are equipped with Supplemental Inflatable Restraint (SIR) system. When servicing vehicle, use care to avoid accidental air bag
More information2002 ENGINE PERFORMANCE. Self-Diagnostics - RAV4. Before performing testing procedures, check for any related Technical Service Bulletins (TSBs).
2002 ENGINE PERFORMANCE Self-Diagnostics - RAV4 INTRODUCTION NOTE: Before performing testing procedures, check for any related Technical Service Bulletins (TSBs). To properly diagnosis and repair this
More informationValve Body Rebuild Tips & Techniques
Ford 4r44e, 4r55e, 5r44e, 5r55e zip Kit PaRT NUMBER 4r44e-5r55e-zip Installation & TESTING BOOKLET Torque Specifications Band Adjuster Lock Nut 35 to 45 ft-lb Transmission Oil Pan Bolt 115 to 133 in-lb
More information