3-Way Mixing and Sequencing Globe Valves, Flared (5/8 in. O.D.) with Electric, Hydraulic, and Pneumatic Actuators

Transcription

1 lectric, Hydraulic, and Pneumatic ctuators TL 1. Select Valve ody including P ode (Valve Size, v Rating, Port ode) or select Valve ssemly correct (refer to Tale 3 and Tale 3 also) less ctuator ode (XXX) including the P ode (Size, v Rating, Port ode). (Refer to Pages 172 to 179 for Valve Sizing.) NOT: These charts are color coded as shown elow to assist valve selection. Note it is possile to select either a valve assemly or component parts (actuator, valve linkage, valve ody). Size 1. Valve ssemly.. VS Valve ody..... V ctuator MP-521 Linkage V-7-1 Valve ody ata less P ode (Size, v Rating, Port ode) or Valve ssemly less ctuator ode (XXX) and less P ode (Size, v Rating, Port ode) P ode (Size, v Rating, Port ode) ctuator or ctuator ode (XXX) for Valve ssemlies Valve Linkage pplication hilled or Hot Water Flared Flared Flared 1/2 in. O.. Tue S Flare 5/8 in. O.., S Flare 5/8 in. O.., S Flare Valve ody V V P V P Valve ssemly Floating SPT VF-39-2XX-5-4 VF-7312-XXX-4-P Valve ssemly Pneumatic Input VK-7312-XXX-4-P VK-7332-XXX-4-P Valve ssemly 2 to 15 Vdc System Input. 4 to m. to 1 m VS-39-2XX-5-4 VS-7312-XXX-4-P VS-7332-XXX-4-P Valve ssemly Two-Position SPST V-39-2XX-5-4 V-7312-XXX-4-P Flow Type 3-Way Mixing, Top Port Normally losed, ottom Port Normally Open Mixing Sequencing ody rass ronze ronze Seat rass ronze ronze Material Stem Stainless Steel Stainless Steel Stainless Steel Plug rass rass rass Packing PTF Spring Loaded TF Spring Loaded TF isc None None None NSI Pressure lass (psig) a 25 (Refer to page 169) llowale ontrol Media Temp llowale ifferential Pressure for Water psig (kpa) c to 281 F (-7 to 138 ) to 281 F (-7 to 138 ) 35 psi (1) max. for normal life (See page 172 for cavitation limits) 3-Way Mixing and Sequenc ing Gloe Valves, Flared (5/8 in. O..) lectric, Hydrauli c, and Pneumat ic ctuator s TO SLT PORT O (P). P ode Valve Size in. d v e -2 d /2 or 5/ a c d e UTION: Fittings and/or pipe schedules must meet or exceed working static pressure requirements. UTION: Freeze protection required for temperatures elow 32 F ( ). void ice formation on stems. With fluid temperatures elow F (4 ) use V-1 hydraulic actuators for thermal isolation. Less than psi recommended for quiet service. Factory assemlies are not availale for two-position applications using reduced port valve odies. UTION: When valves are in series at oth ends of the coil as shown in the four-pipe diagram, the v of the comination is less than that of a single valve. See piping diagram chart for flow calculations. 7

2 lectric, Hydraulic, and Pneumatic ctuators TL 2. SPST and 2 to 15 Vdc System inputs, select ctuator Type or ctuator ode (XXX) correct having sufficient close-off for the application. If selecting omponent Parts, select Valve Linkage. Normal Position Stem Up Stem Up Flow to Stem Up Flow to Factory vailale Valve ssemly V-39-2XX-5-4 VF-39-2XX-5-4 VK-39-2XX-5-4 VS-39-2XX-5-4 V XX-4-P VF X-4-P VS XX-4-P Non-Spring Return Floating or SPT 2 to 1 Vdc 4 to m 2 to 15 Vdc a Valve Linkage Included actuator V-7-1 Spring Return - Up a o not use on 4 pipe, single coil sequencing systems. MP-541X, MPR-561X, MPR-571X, and MPR-581X use V-7-1 and V-1. c MF-223 for hot water and steam applications only. d lose-off ratings for mixing valves: (SU = port, S = port). port (SU) ratings equal pressure at port minus pressure at port ; port (S) ratings equal pressure at port minus pressure at port. e 35 psi from either or port to. SPST V-7-1 Floating SPT V-7-1 MP-521X-XXX, MPR-561X ctuator Type MF-22XX3 c MS MP-541X, MPR-571X M-521X-XXX MF-5X1X MP-551X ctuator ode (XXX) 25X 256 2XX 2XX 22X Valve ody P ode Size in. V /2 V P /8 TUTOR LOS -OFF PRSSUR RTING (psi) d SU c S c SU c S c SU c S c SU c S c VS XX-4-P V P e 1 35 e 71

3 lectric, Hydraulic, and Pneumatic ctuators TL 2. Pneumatic Input, select ctuator Type or ctuator ode (XXX) series correct having sufficient close-off for the application. If selecting omponent Parts, select Valve Linkage and Positive Positioner if required. Pneumatic Valve Linkage V-7 V-1 Positive Positioner K K ctuator ode (XXX) ctuator Type MK-269 MK-41 MK-4611 MK-4621 MK Spring Range (psig) 3 to 7 5 to 1 8 to 13 3 to 6 5 to 1 1 to 13 1 to TUTOR LOS-OFF PRSSUR RTING (psi) a Supply ir Pressure (psig) 15/ 15 15/ 15 15/ 15 15/ 15 15/ 15 15/ 15 15/ 15 Stem Position c SU S S SU S S SU SU S SU S S SU S S SU S S SU S S NP d Valve ssemly Valve ody P ode Size in. V-39-XXX-5-4 VF-39-XXX-5-4 VK-39-XXX-5-4 VS-39-XXX-5-4 V , -2, -3 1/ c VK-7312-XXX-4-P V P SU / VK-7332-XXX-4-P V P e 35 e 35 e 35 e 35 e 35 e a lose-off ratings for mixing valves: (SU = port, S = port) port (SU) ratings equal pressure at Port minus pressure at port ; port (S) ratings equal pressure at port minus pressure at port. lose-off ratings in the tale are true only when the indicated supply air pressure is applied to the actuator. change in air pressure at the actuator alters the actual close-off pressure. lose-off pressure ratings descrie only the differential pressure which the actuator can close-off to standards adequate seating force. onsult valve ody specifications for the limitations. c SU Stem Up (Flow to ); S Stem own (Flow to ); Normal Position Step Up (Flow to ). d NP = Normal Position. e VK X is used as the inlet valve and VK X is used as the outlet valve on a four pipe angle coil system. psig signal is required. Neutral valve position (oth parts just close) have 35 psig close-off pressure etween or port minus port for all actuators. (Refer to page 74 for four-pipe details.) 72

4 lectric, Hydraulic, and Pneumatic ctuators TL 3. Factory ssemlies (Two-Position SPST, System 2 to 15 Vdc, 4 to m), select exact ctuator ode (XXX). ny M-52XX, MF-22XX3, MP-5XXX, MPR-5X1X, MS can e assemled to 1/2 in. to 1-1/4 in. valve odies the close-off pressure ratings listed in Tale 2 and Tale 2. Select elow listed Hydraulic ctuators or ctuator odes (XXX) for factory availale assemlies. For applications that factory assemlies are not availale, select actuator, linkage, ody and field assemle. Voltage Vac 5/ Hz V ux. Switch ctuator Part No. ctuator ode (XXX) for Factory vailale ssemly V-7312 VS-7312, 7332 VF-7312 M Two-Position SPST 1 18 M M Floating SPT MF-223 a MF MF to 15 Vdc, System, Stroke Occurs 6 to 9 Vdc pproximately 2 to 15 Vdc, System, 3 Volt Span, Start 6 Vdc Factory Set, dj. 2to12Vdc, Positive Positioning to 1 Vdc, System, Start.5 Vdc Factory Set, Positive Positioning MP MP MP MP MP No MP MP MP MP MPR to m 1 18 MPR MPR Floating SPT 21 MF a 21 MF a 2 to 1 Vdc 4 MS to m a MF-223 for hot water and steam applications only. Includes V-1.. TL 3. Factory ssemlies (Pneumatic ctuators), select exact ctuator ode (XXX). ffective rea (sq. in.) Spring Range (ls) ctuator Part No. ctuator ode (XXX) for Factory vailale ssemly Pneumatic to to 1 MK to 13 3 a 3 to 6 MK to 1 MK to 13 MK a 1 to MK a a VK-7332 factory assemlies availale only these codes. TL 4. Optional Interface to Pneumatic. Type Two-Position, SPST (lectric) Two-Position, SPT Snap cting (lectric) Voltage 2 to 15 Vdc System urrent Input 4 to m etc. Interface Module Required L-1XX L-1XX P-8511-XXX P-8511-XXX, P

5 lectric, Hydraulic, and Pneumatic ctuators figure TK-1.. Room Thermostat M Port ode v Port ode v Port ode v M WS V HWS Four Pipe Single oil VK P Supply Valve (OM) oil VK P Return Valve V (OM) Flow alculation hart. HWR WR Supply Return omined hilled Water Flow % hilled Water Return % Hot Water Flow % Hot Water Return % hilled Water Flow (Supply Valve Flow to ) hilled Water Return (Return Valve Flow to ) Hot Water Flow (Supply Valve Flow to ) Hot Water Return (Return Valve Flow to ) Room Thermostat ranch Pressure TL 5. imensions in Inches (Millimeters). Part Numer Series V-7312 V-7332 Valve ody VK-73X2-2XX (MK-269) Valve ssemly (ctuator Type) VK-73X2-3XX (MK-46X1) V X1, VS-73X2-2X1 (MX-5X1X, PR-5X1X) a VF XX VS XX (MF-22XX3, MS-22353) Size (in.) 5/8 4 (12) 2-1/4 (57) 4-13/16 (122) 5 (127) 7-7/8 () 4-1/8 (15) a dd 2-1/32 in. (52 mm) to the dimension for a valve assemly using an V-1 linkage extension. NOT: llow 3 inches clearance aove actuator for removal. 3-1/4" 4-13/16" 3-3/4" 5-1/2" 6-3/4" Top View 5" 2-1/4" 3-11/16" MK-46X1 V-7312 V /16" (141 mm) M-521X MP-5X1X a MPR-5X1X a MF-5X1X a MP-5X1X a V-7312 V-7332 MK-269 V-7312 V " (76 mm) a V-1 linkage extension (not shown) required for hot water applications. Refer to Tale 3. MF-223 for hot water and steam applications only. MF-22XX3 MS V P 74

6 lectric, Hydraulic, and Pneumatic ctuators TL 6. 3-Way Valve imensions in Inches (millimeters). Valve ody ctuator Part Numer Size In. F G H J K L M N P Q R S T U V-39-2X VS-39-2X1-5-4 VF-39-22X-5-4 VS-39-X-5-4 VS-39-26X /8 (6) 1-5/32 (258) VK-39-X /8 1-5/8 3/4 1-7/8 1-5/8 V Valve 1/2 (79) (41) (19) (48) (41) MK-46X1 ctuator (Factory ssemly Not vailale) V-39-XXX-5-4 VF-39-XXX-5-4 VK-39-XXX-5-4 VS-39-XXX /4 (171) 8-25/32 (223) 3-1/4 (83) 5 3-5/8 (127) (92) 5 (127) 1-1/16 2-1/4 (27) (57) 5-1/4 3-7/8 4-3/4 (133) (98) (121) 4-3/4 5-9/16 (121) (141) 3 (76) H H F G V-1 Linkage F G V-39-2X1-5-4, VS-39-2X1-5-4 Valve ssemly Solid State Two-Position or Proportional ctuator VF-39-22X-5-4, VS-39-X-5-4, VS-39-26X-5-4 Valve ssemly Solid State Floating or Proportional ctuator R L N P Q J K M VK-39-X-5-4 Valve ssemly MK-269 Pneumatic ctuator V Valve ody MK-46X1 Pneumatic ctuator (Factory ssemly Not vailale) 5-9/16" (141 mm) 3" (76 mm) VK-39-2XX-5-4 Valve ssemly MF-22XX3 Floating ctuator 75