Pressure Distribution Design

Size: px
Start display at page:

Download "Pressure Distribution Design"

Transcription

1 1 Pressure Distribution Design 2 Let s Start with Nonpressurized systems Historically the norm 3 Distribution Systems 4 Distribution Systems Non-pressurized Distribution Non-pressurized Distribution (cont.) 5 Progressive Failure 6 Why use Pressure Distribution 1

2 7 The Benefits 8 Distribution Systems Creates Unsaturated Flow Minimizes movement through pore spaces Slows the flow through the soil Better distribution of effluent Lower hydraulic loading rate Lower organic loading rate Resting periods improves oxygenation Air is pulled in behind the effluent Allows flow monitoring Basically better treatment and longer system life Pressure Dosed mounds and beds 9 Distribution Systems 10 Distribution Systems Pressure Dosed - trenches Pressure Dosed sand filters 11 Example Configurations 12 Non-Level Pressure Distribution End Feed System Center Feed System Mulit-zone Feed System 2

3 13 Design Options for Balancing 14 Valves to Balance Head Adjust distribution network design Perforation size, spacing Pipe diameter Split system into zones which are at the same elevation Distributing valves (pressure actuated or solenoid) Duplex pump system Use valves to balance head pressure Need to pressurize lines (fill with water) Adjust valves so squirt heights are even 15 Flow regulating valves Adding one increases friction Should NOT be a ball valve Gate valve is better Globe valve is best but most expensive 16 System Design 17 Rules of Thumb 18 Rules of Thumb (cont) Transport Line Size (from pump to PDS) Consider Head Losses smaller pipe = higher head loss (larger pump) Consider Drainback Larger pipe = more drainback Consider Cost Larger pipe costs more 1.5 to 2 is typical Manifold Line Size Typically match the transport line or larger Lateral Line Size Maintain less than 10% flow differential from 1 st to last orifice Laterals are typically smaller than Manifolds (each lateral transports a smaller flow rate than the manifold) 1 to 1.5 is typical Orifice Spacing Try to maintain a grid (i.e. 2 by 2 or 3 by 3 etc.) More orifices provides better distribution More orifices causes high flow rates 3

4 19 Rules of Thumb (cont) 20 Rules of Thumb (cont) Residual Head at Last Orifice (squirt height) 1/8 orifice = minimum 3 5 squirt 3/16 orifice = minimum 3 5 squirt 1/4 orifice = minimum 2 squirt Orifice Size 1/4 orifice Often not used due to high flow rates from each orifice 3/16 orifice Requires larger pumps Larger dose volume may not maintain unsaturated flow Can be used with most applications Minimum size recommended with low-head pumps 1/8 orifice Can be used with screened or pretreated effluent, and highhead pumps 21 Squirt Height vs. Flow per Orifice 22 Pump Curve Comparison 23 Rules of Thumb (cont) 24 Rules of Thumb (cont) Dose Volume Distribution is poor during filling and draining the network (before and after pressurized) Especially important with larger orifices Dose at least 4 times the volume of the distribution network; plus 1 times the volume of the transport pipe Minimize the diameter of long transport lines that drain back When to Use an Automatic Distributing Valve For large systems, a valve keeps zones small, which allows smaller, more reasonably-sized pumps. For multiple zones at different elevations. For multiple zones in different areas. To alternately dose different zones. 4

5 25 Hydraulic Switching Valves 26 Hydraulic Switching Valves Pressure actuated (no power needed) Have clear PVC pipes where flow can be verified Have ball valve for testing the zone cycling Can be removed, disassembled, and cleaned Need occasional servicing DO NOT Install Upside Down! 27 Sequencing Valve Concerns 28 Other Recommendations for Pressure Distribution Systems Should be used with screened effluent High head pumps tend to make them more reliable More reliable with pre-treated effluent Must have access Maintenance - taking them apart, cleaning the internal components and reassembling Must have periodic servicing Must have freeze protection Liquid in the legs of the valve Screen septic tank effluent Use higher-head pumps to scour pipes and clear orifices Use orifice shields to prevent gravel from masking the orifices Face orifices downward in cold climates Use flushing valves to clear debris 29 Flushing Valves 30 Lateral Cleanouts 5

6 31 Valve boxes 32 Choosing a Pump Size a Pump to meet the Goal Obtain a design Gallon per Minute (GPM) and a Total Dynamic Head (TDH), which is needed to choose a pump. 33 Total Dynamic Head 34 Design References US EPA Onsite Wastewater Treatment System Manuals, 1980 and Otis, R.J Design of Pressure Distribution Networks for Septic Tank Soil Absorption Systems. Small Scale Waste Management Project. Converse, James C Pressure Distribution Network Design. Basically extracted and modified version of the Otis paper. WA State Dept. of Health. July Pressure Distribution Systems. This is a design guidance document. Several Health Departments have similar documents. Utah On-Site Wastewater Treatment Training Program 35 Design Tables and Charts 36 Design Software Streamline - by Miller Environmental Corp PumpSelect - by Orenco Systems, Inc. 6

7 37 Squirt Test 38 Management of Pressure Distribution 39 Determining Distal Head 40 Impacts on Management Attach the clear stand pipe to lateral end [Pressure gauge] Turn on pump Measure and record pressure head in feet Compare this to initial design and code requirements Smaller holes = Higher Frequency ¼ ~ 3 years 1/8 ¼ ~ 2 years 1/16 ~ 1 year Switching valves ~ 1 year Pressure Control Valves ~ 1 year 41 Questions? 7

Pressure Distribution. Western Canada Onsite Wastewater Management Association

Pressure Distribution. Western Canada Onsite Wastewater Management Association Pressure Distribution EFFLUENT DISTRIBUTION Get even distribution Space the doses Layout the distribution system Make choices for: piping, orifices, volumes Use worksheets for calculations Dose or flush

More information

EQUAL DISTRIBUTION OF WASTEWATER USING LOW-PRESSURE DISTRIBUTION Larry D. Stephens, P.E. *

EQUAL DISTRIBUTION OF WASTEWATER USING LOW-PRESSURE DISTRIBUTION Larry D. Stephens, P.E. * EQUAL DISTRIBUTION OF WASTEWATER USING LOW-PRESSURE DISTRIBUTION Larry D. Stephens, P.E. * INTRODUCTION Experience with onsite systems has proven that equal application of wastewater over the entire soil

More information

Washtenaw County DESIGN PROCEDURES AND ENGINEERING STANDARDS FOR PRESSURE DISTRIBUTION NETWORKS

Washtenaw County DESIGN PROCEDURES AND ENGINEERING STANDARDS FOR PRESSURE DISTRIBUTION NETWORKS Washtenaw County Department of Planning & Environment Development Services Division DESIGN PROCEDURES AND ENGINEERING STANDARDS FOR PRESSURE DISTRIBUTION NETWORKS 705 N. Zeeb Road Phone: (734) 222-3800

More information

PUMP TYPES. Pump Sizing. Dose to Gravity. Pumping to Gravity Distribution. Systems that need a Lift. Distribution Box and Tiered Trenches.

PUMP TYPES. Pump Sizing. Dose to Gravity. Pumping to Gravity Distribution. Systems that need a Lift. Distribution Box and Tiered Trenches. PUMP TYPES Sump Clean Water Only Systems that need a Lift Effluent Multi stage Single stage Sewage Grinder Pumping to Gravity Distribution When STA is at higher elevation than septic tank Pump Sizing TDH

More information

Worksheet for pressure distribution system design Long form with instructions and tables Rev. August 2007

Worksheet for pressure distribution system design Long form with instructions and tables Rev. August 2007 Job: Date: Designer: Design number: Option number: Worksheet for pressure distribution system design Long form with instructions and tables Rev. August 2007 This is an iterative process, so each step might

More information

AMERICAN RECIRCULATING SAND FILTER SYSTEMS

AMERICAN RECIRCULATING SAND FILTER SYSTEMS American Manufacturing Company, Inc. P.O. Box 549, Manassas, VA 20108 1-800-345-3132 AMERICAN RECIRCULATING SAND FILTER SYSTEMS ENGINEERING DESIGN GUIDELINES FOR COMMUNITY AND COMMERCIAL SIZED TREATMENT

More information

PRESSURE DISTRIBUTION COMPONENT MANUAL FOR PRIVATE ONSITE WASTEWATER TREATMENT SYSTEMS (VERSION 2.0) January 30, 2001

PRESSURE DISTRIBUTION COMPONENT MANUAL FOR PRIVATE ONSITE WASTEWATER TREATMENT SYSTEMS (VERSION 2.0) January 30, 2001 PRESSURE DISTRIBUTION COMPONENT MANUAL FOR PRIVATE ONSITE WASTEWATER TREATMENT SYSTEMS (VERSION 2.0) January 30, 2001 State of Wisconsin Department of Commerce Division of Safety and Buildings SBD-10706-P

More information

Orenco Automatic Distributing Valve Assemblies

Orenco Automatic Distributing Valve Assemblies This article may describe design criteria that was in effect at the time the article was written. FOR CURRENT DESIGN CRITERIA, call Orenco Systems, Inc. at 1-800-348-9843. Orenco Automatic Distributing

More information

Flood Dosed System Worksheet

Flood Dosed System Worksheet Number of bedrooms Flood Dosed System Worksheet Septic tank size Minimum 1000 gallons Dosing tank size Minimum 800 gallons or 1 bedroom smaller than septic tank size whichever is larger Filter: gravity(in

More information

COURSE # 343 UNIT 4: ADVANTEX WASTEWATER TREATMENT SYSTEM. What you will learn in this lesson

COURSE # 343 UNIT 4: ADVANTEX WASTEWATER TREATMENT SYSTEM. What you will learn in this lesson What you will learn in this lesson IN THIS LESSON, YOU WILL LEARN... Installation steps for an AdvanTex Treatment System Important inspection points for installation inspection UNIT 4-1 Installation Steps

More information

To ensure proper installation, digital pictures with contact information to before startup.

To ensure proper installation,  digital pictures with contact information to before startup. Check List for Optimal Filter Performance? There should be no back-pressure on the flush line. A 1 valve should have a 2 waste line, and 2 valve should have a 3 waste line. Do not use rubber hosing or

More information

Check List for Optimal Filter Performance

Check List for Optimal Filter Performance Check List for Optimal Filter Performance There should be no back-pressure on the flush line. A 1 valve should have a 2 waste line, and a 1.5" or 2 valve should have a 3 waste line. Do not use rubber hosing

More information

PF Series 60-Hz, 4-inch (100-mm) Submersible Effluent Pumps

PF Series 60-Hz, 4-inch (100-mm) Submersible Effluent Pumps PF Series 6-Hz, 4-inch (1-mm) Submersible Effluent Pumps Applications Our 4-inch (1-mm) Submersible Effluent Pumps are designed to transport screened effluent (with low TSS counts) from septic tanks or

More information

Technical Data Sheet PF Series 4" (100 mm) Submersible Effluent Pumps. 1 8-inch (3-mm) bypass orifice (patent pending) to ensure flow

Technical Data Sheet PF Series 4 (100 mm) Submersible Effluent Pumps. 1 8-inch (3-mm) bypass orifice (patent pending) to ensure flow Technical Data Sheet PF Series 4" (1 mm) Submersible Effluent Pumps Applications Our 4" (1 mm) Submersible Effluent Pumps are designed to transport screened effluent (with low TSS counts) from septic tanks

More information

5220 SERIES Z-Cell OWNER'S MANUAL

5220 SERIES Z-Cell OWNER'S MANUAL 3649 Cane Run Road Louisville, KY 40211-1961, USA 1-800-928-7867 1-502-778-2731 Fax: 1-502-774-3624 clarusenvironmental.com CL0180 0817 Supersedes New 5220 SERIES Z-Cell OWNER'S MANUAL Register your Clarus

More information

M-8100EP. Installation Guide ENGINEERED PLASTIC MANIFOLD SERIES. Introduction. A. Assemble Manifold Components

M-8100EP. Installation Guide ENGINEERED PLASTIC MANIFOLD SERIES. Introduction. A. Assemble Manifold Components Introduction The Pro Manifolds with Integrated adaptor are designed for use in Hydronic radiant panel heating and cooling applications. They are available in various sizes, configurations, and options

More information

Septic Tanks. Effluent Screen Cleaning. Effluent Screens. Surveying Abbreviations. Installation Keys. Septic Tanks, Holding Tanks & Pump Tanks

Septic Tanks. Effluent Screen Cleaning. Effluent Screens. Surveying Abbreviations. Installation Keys. Septic Tanks, Holding Tanks & Pump Tanks Septic Tanks Gravity treatment Separation Sludge sinks Scum floats Storage Septic Tanks, Holding Tanks & Pump Tanks Bacteria SCUM breakdown CLEAR ZONE Chemical SLUDGE WW Strength= Organic Load Effluent

More information

EJECTORS GENERAL OPERATION & MAINTENANCE MANUAL

EJECTORS GENERAL OPERATION & MAINTENANCE MANUAL EJECTORS GENERAL OPERATION & MAINTENANCE MANUAL The information contained in this manual was current at the time of printing. The most current versions of all Hydro Instruments manuals can be found on

More information

APOLLO DISC-KLEEN FILTERS

APOLLO DISC-KLEEN FILTERS FILTRATION APOLLO DISCKLEEN FILTERS OPERATION, INSTALLATION & MAINTENANCE GUIDE ANGLE CONFIGURATION TWIN CONFIGURATION TABLE OF CONTENTS Specifications...3 Filter Dimensions... Water Quality & Maximum

More information

PRESSURE GAGES AND TEST TAPS

PRESSURE GAGES AND TEST TAPS CAT 500.1 FRF series filters. Polyglass 100 psi vessels with top mount Task Master II 1 ½ valve and single point PVC internals. FMF series filters. Carbon steel epoxy lined and coated vessels with side

More information

Turbine STEP System SIMPLEX OR DUPLEX

Turbine STEP System SIMPLEX OR DUPLEX 3649 Cane Run Road Louisville, KY 211-1961, USA 1-800-928-7867 1-502-778-2731 Fax: 1-502-774-3624 www.clarusenvironmental.com SECTION: C1.20.120 CL0019 0816 Supersedes 1212 Turbine STEP System SIMPLEX

More information

GREASE INTERCEPTOR REQUIREMENTS Lakeway Municipal Utility District

GREASE INTERCEPTOR REQUIREMENTS Lakeway Municipal Utility District Last Updated on October 27, 2011 Grease interceptors are required to separate out Fats, Oils and Greases (FOGs) and solids normally found in food preparation waste from the rest of the wastewater being

More information

Hydraulic Power Supply and Motors Concept and Theory

Hydraulic Power Supply and Motors Concept and Theory Hydraulic Power Supply and Motors Concept and Theory Graco, Inc. P.O. Box 1441 Minneapolis, MN 55440-1441 1996 Graco Inc. Form No. 321-046 1/96 Rev 2 SL Training 11/14 Hydraulic Systems Component Identification

More information

Modify Section by adding subsection.02 per the following. Remainder of section is unchanged.

Modify Section by adding subsection.02 per the following. Remainder of section is unchanged. Modify Section 23 21 00 by adding subsection.02 per the following. Remainder of section is unchanged. 23 21 00 HYDRONIC PIPING AND PUMPS.02 Flow Balance and Differential Pressure Control A. General: Professional

More information

ONSITE WASTEWATER TREATMENT SYSTEM Property Transfer Certification Instructions and Inspection Report

ONSITE WASTEWATER TREATMENT SYSTEM Property Transfer Certification Instructions and Inspection Report ONSITE WASTEWATER TREATMENT SYSTEM Property Transfer Certification Instructions and Inspection Report These instructions are for homeowners and inspectors completing the onsite wastewater treatment system

More information

WATER SYSTEM SIZING Introduction Residential Water System Sizing

WATER SYSTEM SIZING Introduction Residential Water System Sizing WATER SYSTEM SIZING Introduction It is crucial that water supply systems are properly sized. Well owners are often concerned about whether or not there will be enough water for their needs. The area geology

More information

DT34 and DT54 Series Rotary Sprinklers

DT34 and DT54 Series Rotary Sprinklers DT34 and DT54 Series Rotary Sprinklers Installation & Service Instructions Introduction The DT34 and DT54 series full-circle rotary sprinklers are designed specifically for golf course applications. Manufactured

More information

26 Series Stainless Steel 2-way Ball Valves

26 Series Stainless Steel 2-way Ball Valves 1-800-899-0553 26 Series Stainless Steel 2-way Ball Valves Users Manual Installation, Operation, & Maintenance 1. General Precaution 1.1. Material Section Material deterioration is determined by the contained

More information

2000 Series Heavy-Duty Irrigation Valves Recommended Applications Golf Courses Landscapes Parks Right-of-ways

2000 Series Heavy-Duty Irrigation Valves Recommended Applications Golf Courses Landscapes Parks Right-of-ways 2000 Series Heavy-Duty Irrigation Valves Recommended Applications Golf Courses Landscapes Parks Right-of-ways Absolute Control. Optimized Efficiency. Features and Installation Self-cleaning: No filters

More information

New Filtration Products from LAKOS

New Filtration Products from LAKOS New Filtration Products from LAKOS Disc Filters Screen Filters January 11, 2018 8:00 am Pacific Time Presented by: Randy Delenikos LAKOS Filtration Systems Randy.Delenikos@lakos.com Ver3.12/6/2017 Why

More information

RAIN BIRD - AQUAGATOR AQUAGATOR INSTALLATION & TROUBLESHOOTING MANUAL

RAIN BIRD - AQUAGATOR AQUAGATOR INSTALLATION & TROUBLESHOOTING MANUAL AQUAGATOR INSTALLATION & TROUBLESHOOTING MANUAL Cozz GT27069-A Revised July 2002 P/N 632360 AQUAGATOR TABLE of CONTENTS DESCRIPTION PAGE INTRODUCTION....... 1 SECTION 1 - PRE-INSTALLATION REQUIREMENTS.

More information

Manifold Isolation Valves

Manifold Isolation Valves 300 N. Opdyke Rd. Introduction The Stainless Manifolds are designed for use in Hydronic radiant panel heating and cooling applications. They are available in various sizes, configurations, and options

More information

BERMAD Irrigation. Media Filtration Systems. Model Filters. Features and Benefits. Typical Applications

BERMAD Irrigation. Media Filtration Systems. Model Filters. Features and Benefits. Typical Applications BERMAD Irrigation Media Systems Model 4000 BERMAD sand media filtration systems offer a low maintenance and efficient method to filter organic material and fine inorganic particulate from irrigation system

More information

Mark Howell Florida Crystals September 26, 2013

Mark Howell Florida Crystals September 26, 2013 Flat Land, Low Level Farm Drainage Mark Howell Florida Crystals September 26, 2013 Pumping Head Pump Size Power Discharge Arrangement Problems To Avoid Pump Stations Head From The Field To The Pump Start

More information

Sludge Thickening. Wastewater Treatment Review. Gravity Thickening

Sludge Thickening. Wastewater Treatment Review. Gravity Thickening Wastewater Treatment Review 10 Sludge Thickening nw ate rc oll e ge 20 Gravity Thickening ca Principle of Operation 1. Uses gravitational forces to separate water from sludge 2. Solids settle to bottom

More information

Pump Control Ball Valve for Energy Savings

Pump Control Ball Valve for Energy Savings VM PCBVES/WP White Paper Pump Control Ball Valve for Energy Savings Table of Contents Introduction............................... Pump Control Valves........................ Headloss..................................

More information

Clean Water Made Easy

Clean Water Made Easy Clean Water Made Easy http://www.cleanwaterstore.com Pro-OX 2510 Manual Backwash Iron Filter Installation & Start-Up Guide Thank you for purchasing a Clean Water System! With proper installation and a

More information

SPN II. S h a r p e T o l l Free (877) F a x (708)

SPN II. S h a r p e T o l l Free (877) F a x (708) SPN II S h a r p e T o l l Free (877) 774-2773 F a x (708) 562-9250 www.sharpevalves.com 1 SPN II Pneumatic Actuator Rack & pinion design The standard actuator configuration has hard anodized aluminum

More information

M Installation Guide. PRECISION Manifold Series. Introduction. A. Assemble Manifold Components

M Installation Guide. PRECISION Manifold Series. Introduction. A. Assemble Manifold Components Page 1 Introduction The M-8200 Precision Manifolds are designed for use in Hydronic radiant panel heating and cooling applications. They are available in various sizes, configurations, and options with

More information

Tekleen LPF USERS AUTOMATIC FILTERS, INC. MANUAL

Tekleen LPF USERS AUTOMATIC FILTERS, INC. MANUAL AUTOMATIC FILTERS, INC. 2672 S. LA CIENEGA BLVD. LOS ANGELES, CA 90034 310 839 2828 800 336 1942 FAX 310 839 6878 www.tekleen.com info@tekleen.com Tekleen LPF USERS MANUAL Table of Contents SECTION I INTRODUCTION

More information

730 Series Rotary Sprinklers Installation & Service Instructions

730 Series Rotary Sprinklers Installation & Service Instructions 730 Series Rotary Sprinklers Installation & Service Instructions Introduction The 730 Series Full Circle Rotary Sprinklers are designed for irrigation of large turf areas such as golf courses, parks, recreational

More information

Technical Bulletin # 1251

Technical Bulletin # 1251 Transmission: Subject: Application: Issue Date: CD4E TCC Slip Code Diagnosis Ford, Mercury and Mazda May 2009 CD4E TCC Slip Code Diagnosis Once the check engine light illuminates, the transmission will

More information

Installation and Operation Instruction Manual INSMAN-201. Industrial Multi Media Single Tank

Installation and Operation Instruction Manual INSMAN-201. Industrial Multi Media Single Tank Installation and Operation Instruction Manual INSMAN-201 Industrial Multi Media Single Tank Phone: 951.656.6716 Toll-Free: 800.854.4788 www.yardneyfilters.com 1 Yardney Water Management Systems, Inc. 6666

More information

Recirculating Media Filters OWNER'S MANUAL

Recirculating Media Filters OWNER'S MANUAL 3649 Cane Run Road Louisville, KY 40211-1961, USA 1-800-928-7867 1-502-778-2731 Fax: 1-502-774-3624 clarusenvironmental.com SECTION: C3.20.140 CL0064 0515 Supersedes 1011 Recirculating Media Filters Register

More information

GL0098P Beta+ Septic Tanks Installation & Operation Guidelines

GL0098P Beta+ Septic Tanks Installation & Operation Guidelines 000535 GL0098P Beta+ Septic Tanks Installation & Operation Guidelines Kingspan Environmental Service Contact Numbers: UK: 0844 846 0500 NI: 028 3025 4077 IRL: 048 3025 4077 Enclosed Documents DS1151P Beta+

More information

MAINTENANCE MANUAL DI 16

MAINTENANCE MANUAL DI 16 MAINTENANCE MANUAL DI 16 0.2-1.6% Press Ctrl + L for full screen 1 STANDARD INSTALLATION Inlet Outlet Optional accessories: Pressure regulator Solenoid valves Water meter Flow restrictor 200 Mesh/ 80 micron

More information

DT35 and DT55 Series Rotary Sprinklers Installation & Service Instructions

DT35 and DT55 Series Rotary Sprinklers Installation & Service Instructions O N DT35 and DT55 Series Rotary Sprinklers Installation & Service Instructions Introduction The DT35 and DT55 series adjustable part circle and full circle rotary sprinklers are designed specifically for

More information

BERMAD Irrigation. IR-300 Basic Valve. 300 Series. ??????? Basic Valve

BERMAD Irrigation. IR-300 Basic Valve. 300 Series. ??????? Basic Valve ??????? Basic Valve I-300 Basic Valve The BEMAD basic diaphragm actuated Model I-300/305 valve is a hydraulically operated globe valves in either the standard oblique (Y) or angle pattern design in diameter

More information

Installation Manual. AdvanTex -AX20-RT Treatment Systems. Residential Applications. An illustrated guide to installing an Orenco AdvanTex

Installation Manual. AdvanTex -AX20-RT Treatment Systems. Residential Applications. An illustrated guide to installing an Orenco AdvanTex Installation Manual AdvanTex -AX20-RT Treatment Systems Residential Applications An illustrated guide to installing an Orenco AdvanTex AX20-RT Treatment System. Rev. 1.0, 1/10 Orenco Systems, Inc. Orenco

More information

TREASURE VALLEY IRRIGATION CONFERENCE

TREASURE VALLEY IRRIGATION CONFERENCE TREASURE VALLEY IRRIGATION CONFERENCE CORBY GARRETT AQUA IRRIGATION Four Rivers Cultural Center Ontario, Oregon December 14, 2017 DRIP IRRIGATION MAINTENANCE DRIP IRRIGATION MAINTENANCE SYSTEM STARTUP

More information

Operation and Maintenance

Operation and Maintenance E-Z Set Company requires regular inspection and maintenance of the E-Z Treat Re- Circulating Sand/Media Filter, as a condition of purchase and ongoing operation compliance. The mandatory service contract

More information

Secondary Coolant 301

Secondary Coolant 301 Secondary Coolant 301 Instructor Rusty Walker Hill PHOENIX Learning Center Secondary Coolant 301 Start-Up Procedures Secondary Coolant 301 Objectives Describe the initial startup procedures for a medium

More information

DT35 and DT55 Series Rotary Sprinklers Installation & Service Instructions

DT35 and DT55 Series Rotary Sprinklers Installation & Service Instructions O N DT35 and DT55 Series Rotary Sprinklers Installation & Service Instructions Note: For preliminary use only. Introduction The DT35 and DT55 series full-circle/adjustable part-circle rotary sprinklers

More information

Figure 1.1. From left to right: PVC, GRP and AISI 316L. Filter type Filter body material Max pressure Max temperature BSP PVC 150 psig 104 F, 40 C

Figure 1.1. From left to right: PVC, GRP and AISI 316L. Filter type Filter body material Max pressure Max temperature BSP PVC 150 psig 104 F, 40 C 1. The filter body The filter bodies come in three different materials: PVC (PolyVinyl Chloride), AISI 316L (stainless steel) and GRP (Glass-fiber Reinforced Polyester). Filter bodies in PVC and GRP have

More information

Aqua-Clear Fiberglass Sand Filters

Aqua-Clear Fiberglass Sand Filters Aqua-Clear Fiberglass Sand Filters Addendum to the Installation & Users Guide Automatic Backwash Filter Assembly See Installation & User s Guide for important Safety Instructions System Contents... 3 Overview...

More information

BNT 85 /185 Valve Operation Manual

BNT 85 /185 Valve Operation Manual BNT 85 /185 Valve Operation Manual Note: 1. Read all instructions carefully before operation. 2. Avoid pinched o-rings during installation by applying (provided with install kit) NSF certified lubricant

More information

Septage Land Application Module

Septage Land Application Module Septage Land Application Module Bruce Lesikar Texas Cooperative Extension Service University Curriculum Development for Decentralized Wastewater Management NDWRCDP Disclaimer This work was supported by

More information

ONYX VALVE CO. The Pinch Valve Authority

ONYX VALVE CO. The Pinch Valve Authority ONYX VALVE CO The Pinch Valve Authority David David Gardellin, P.E. P.E. President President A DISCUSSION OF CORROSION PROBLEMS INCURRED AT THE BONNYBROOK WASTEWATER TREATMENT PLANT By ARNY VANWIEREN,

More information

1/2" AIR DRIVEN DIAPHRAGM PUMP

1/2 AIR DRIVEN DIAPHRAGM PUMP 1/2" DRIVEN DIAPHRAGM PUMP OPERATION AND SERVICE GUIDE O-1225D NOV. 2008 Page 1 of 6 Refer to Bulletin P-605, Parts List P-9151 DRIVEN, DOUBLE DIAPHRAGM PUMP MANUAL Congratulations on purchasing one of

More information

Model 6518FR. NOTE TO INSTALLER: Please leave this information with the Maintenance Department. LIMITED WARRANTY

Model 6518FR. NOTE TO INSTALLER: Please leave this information with the Maintenance Department. LIMITED WARRANTY INSTALLATION, OPERATION & MAINTENANCE INSTRUCTIONS 1455 Kleppe Lane Sparks, NV 89431-6467 (775) 359-4712 Fax (775) 359-7424 E-mail: haws@hawsco.com website: www.hawsco.com Model 6518FR No. 2077777(21)

More information

CENTRAL SLURRY SYSTEMS Model 911

CENTRAL SLURRY SYSTEMS Model 911 CENTRAL SLURRY SYSTEMS Model 911 Installation and Operating Instructions Revised 6/04/08 PRACTICAL SYSTEMS, INC. 11617 Prospect Road Odessa, FL 33556 (800) 237-8154 Fax (800) 330-3800 (727) 376-7900 Fax

More information

Installation and Service Instructions

Installation and Service Instructions FLX35-6 & FLX55-6 Series Rotary Sprinklers Installation and Service Instructions Introduction The FLX35-6 and FLX55-6 series full and part circle rotary sprinklers are designed specifically for golf course

More information

MagicStream Laminar. Installation and User s Guide IMPORTANT SAFETY INSTRUCTIONS READ AND FOLLOW ALL INSTRUCTIONS SAVE THESE INSTRUCTIONS

MagicStream Laminar. Installation and User s Guide IMPORTANT SAFETY INSTRUCTIONS READ AND FOLLOW ALL INSTRUCTIONS SAVE THESE INSTRUCTIONS 1 MagicStream Laminar Installation and User s Guide IMPORTANT SAFETY INSTRUCTIONS READ AND FOLLOW ALL INSTRUCTIONS SAVE THESE INSTRUCTIONS 2 IMPORTANT SAFETY PRECAUTIONS Important Notice: Attention Installer:

More information

SERVICE THE GORMAN-RUPP COMPANY P.O. Box 1217 MANSFIELD, OH FX

SERVICE THE GORMAN-RUPP COMPANY P.O. Box 1217 MANSFIELD, OH FX GORMAN-RUPP AT YOUR SERVICE THE GORMAN-RUPP COMPANY P.O. Box MANSFIELD, OH. 90 9..0 FX 9.. EMAIL GRSALES@GORMANRUPP.COM How To Read Pump Performance Curves The subject of this bulletin covers the reading

More information

CENTRAL SLURRY SYSTEMS Model 915

CENTRAL SLURRY SYSTEMS Model 915 CENTRAL SLURRY SYSTEMS Model 915 Installation and Operating Instructions 08/02/18 PRACTICAL SYSTEMS, INC. 11617 Prospect Road Odessa, FL 33556 (800) 237-8154 Fax (800) 330-3800 (727) 376-7900 Fax (727)

More information

CAUTION: The first section of the guide deals with the UP SECTION, while the second deals with the DOWN SECTION.

CAUTION: The first section of the guide deals with the UP SECTION, while the second deals with the DOWN SECTION. The information contained herein is for use by skilled hydraulic elevator professionals. Before disassembly of the valve, make sure the power is off by turning the main disconnect switch off and that the

More information

TABLE OF CONTENTS. Minimum Parallel Component Thickness, Type II...8. Minimum Perpendicular Component Thickness, Type III (40'-L, 9'-OC)...

TABLE OF CONTENTS. Minimum Parallel Component Thickness, Type II...8. Minimum Perpendicular Component Thickness, Type III (40'-L, 9'-OC)... Sheridan, Arkansas Toledo, Ohio Westfield, Massachusetts St. Felix, Quebec, Canada Salt Lake City, Utah Albany, Oregon Suffolk, Virginia Bethlehem, Pennsylvania Rockford, Illinois St Paul, Minnesota Macon,

More information

GENERAL PUMPA member of the Interpump Group

GENERAL PUMPA member of the Interpump Group FEATURES Innovative drive design eliminates need for auxiliary hydraulic drive HWB Series Hydraulic Drive - Triplex Plunger Pump HWB2512 & HWB2112 Forged brass manifold No scheduled maintenance required

More information

Cummins 6.7 Litre 2500/3500 Diesel EGR System. Always wear gloves and safety glasses when performing this service

Cummins 6.7 Litre 2500/3500 Diesel EGR System. Always wear gloves and safety glasses when performing this service Cummins 6.7 Litre 2500/3500 Diesel EGR System Always wear gloves and safety glasses when performing this service EGR System Consists of: Cold side EGR valve (after EGR cooler) controls exhaust gases for

More information

Penn Valley Pump Company Design Information for Double Disc Pumps

Penn Valley Pump Company Design Information for Double Disc Pumps Penn Valley Pump Company Design Information for Double Disc Pumps INTRODUCTION The Penn Valley Double Disc Pump utilizes a unique principle of operation whereby the discs perform the duties of pumping

More information

by Instrumentation Pumps 1 / 8

by Instrumentation Pumps 1 / 8 600-000 by Instrumentation Pumps 1 / 8 1. Safety Requirements... 3 2. Pump Mounting... 3 3. General Set Up... 4 3.1. Quick Start... 4 3.2. Speed... 5 3.3. Fluidics... 5 4. Maintenance... 5 4.1. Idle Position...

More information

WSB clean: Installation Manual

WSB clean: Installation Manual WSB clean: Installation Manual Models: WSB 400 WSB 1250 WSB 500 WSB 1500 WSB 600 WSB 1600 WSB 750 WSB 1800 WSB 1000 TABLE OF CONTENTS 1 INTRODUCTION...3 2 SAFETY INFORMATION...3 3 WSB CLEAN SYSTEM OPERATION...4

More information

OWS OPERATIONS & MAINTENANCE

OWS OPERATIONS & MAINTENANCE SUPPLEMENTAL INSTRUCTIONS 1. INTRODUCTION 1.1. Containment Solutions manufactures Oil/Water Separator (OWS) tanks with internal coalescing plates. These units are available in single or double-wall model

More information

Pump ED 101. Variable, Fixed Speed Control - - Float Switch Activation. Introduction

Pump ED 101. Variable, Fixed Speed Control - - Float Switch Activation. Introduction Pump ED 11 Variable, Fixed Speed Control - - Float Switch Activation Joe Evans, Ph.D http://www.pumped11.com Introduction It has been said that there is more than one way to skin a cat. In fact, there

More information

Model AM2 M40 Panel Installation, Operation, and Maintenance Manual

Model AM2 M40 Panel Installation, Operation, and Maintenance Manual Model AM2 M40 Panel Installation, Operation, and Maintenance Manual RECEIVING AND INSPECTION Upon receiving unit, check for any interior and exterior damage, and if found, report it immediately to the

More information

Balancing Basics. Mike Weisman, ASHRAE Treasurer. ASHRAE Golf Outing: May 18 th, 2018! HEATHERWOODE

Balancing Basics. Mike Weisman, ASHRAE Treasurer. ASHRAE Golf Outing: May 18 th, 2018! HEATHERWOODE Balancing Basics Mike Weisman, ASHRAE Treasurer ASHRAE Golf Outing: May 18 th, 2018! HEATHERWOODE Agenda: Why balance? Manual Balancing Valves Manual Balancing Process Automatic Flow Controllers Partial

More information

Operator s Manual. Model PSI GPM CS CS

Operator s Manual. Model PSI GPM CS CS Operator s Manual Model CS1000.22 CS1300.22 PSI 1000 1300 GPM 2.2 2.2 HP 1.5 2.0 Thank you Thank you for selecting our products. Our personnel have proudly made every effort to ensure that your new pressure

More information

Installation Manual. AdvanTex AX20 Treatment Systems. Residential Applications

Installation Manual. AdvanTex AX20 Treatment Systems. Residential Applications Installation Manual AdvanTex AX20 Treatment Systems Residential Applications 1-800-348-9843 +1-541-459-4449 www.orenco.com Orenco Installation Manual: AX20 Treatment Systems How To Use This Manual... Page

More information

Commercial Softeners

Commercial Softeners Commercial Softeners Product Index Page General System Specifications 35 Fleck Commercial Valve Configurations 36 Fleck 9500 1-1/" Systems 37 Fleck 850 1-1/" Systems 38 Fleck 3150 " Systems 39 Fleck 900

More information

TECHNICAL DATA. Q= C v P Cv = Flow Factor (GPM/1 PSI P)

TECHNICAL DATA. Q= C v P Cv = Flow Factor (GPM/1 PSI P) 1 of 9 1. DESCRIPTION The Viking 2 (DN50) is a quick-opening, differential diaphragm, flood valve with one moving part. The deluge valve is used to control water flow in deluge and preaction sprinkler

More information

CAUTION: The possible problems and causes are listed in order of likelihood and ease of checking.

CAUTION: The possible problems and causes are listed in order of likelihood and ease of checking. The information contained herein is for use by skilled hydraulic elevator professionals. Before disassembly of the valve, make sure the power is off by turning the main disconnect switch The possible problems

More information

INDIAN INSTITUTE OF TECHNOLOGY KHARAGPUR NPTEL ONLINE CERTIFICATION COURSE. On Industrial Automation and Control

INDIAN INSTITUTE OF TECHNOLOGY KHARAGPUR NPTEL ONLINE CERTIFICATION COURSE. On Industrial Automation and Control INDIAN INSTITUTE OF TECHNOLOGY KHARAGPUR NPTEL ONLINE CERTIFICATION COURSE On Industrial Automation and Control By Prof. S. Mukhopadhyay Department of Electrical Engineering IIT Kharagpur Topic Lecture

More information

CAUTION: The possible problems and causes are listed in order of likelihood and ease of checking.

CAUTION: The possible problems and causes are listed in order of likelihood and ease of checking. The information contained herein is for use by skilled hydraulic elevator professionals. Before disassembly of the valve, make sure the power is off by turning the main disconnect switch off and that the

More information

Calibration of Chemical Applicators Used in Vegetables1

Calibration of Chemical Applicators Used in Vegetables1 HS12 Calibration of Chemical Applicators Used in Vegetables1 M. R. Miller and P. J. Dittmar2 includes information about calibration to help growers properly apply pesticides. Definition of Terms GPA: Gallons

More information

Skill Module Number: 1.1

Skill Module Number: 1.1 Name Skill Module Number: 1.1 Subject: 722.9 Transmission D & A Objective: At the conclusion of this module, you will be able to: Explain how to disassemble the 722.9 transmission Explain how to assemble

More information

Piping Systems. J. David Bankston, Jr., and Fred Eugene Baker*

Piping Systems. J. David Bankston, Jr., and Fred Eugene Baker* SRAC Publication No. 373 December 1994 Piping Systems J. David Bankston, Jr., and Fred Eugene Baker* Whether you are pumping water to fill a pond or to aerate, it pays to do it as economically as possible.

More information

Q= C. v P S Refer to Table 1 for part numbers and shipping weights. Accessories: Table 1: Valve Part Numbers and Specifications

Q= C. v P S Refer to Table 1 for part numbers and shipping weights. Accessories: Table 1: Valve Part Numbers and Specifications 1 of 9 1. DESCRIPTION The Viking Flow Control Valve is a quick opening, differential diaphragm flood valve with a spring loaded floating clapper. The Flow Control Valve can be used to facilitate manual

More information

Operation and Maintenance of Mechanical Self-Cleaning Filters. Maynard King CB Tubecraft div of K&D Pratt

Operation and Maintenance of Mechanical Self-Cleaning Filters. Maynard King CB Tubecraft div of K&D Pratt Operation and Maintenance of Mechanical Self-Cleaning Filters Maynard King CB Tubecraft div of K&D Pratt Filtration Terms Filter Area The total area of a filter element, usually expressed in square inches

More information

Installation And Operation Instruction Manual INSMAN-101. Sand Media Filters. Phone: Toll-Free:

Installation And Operation Instruction Manual INSMAN-101. Sand Media Filters. Phone: Toll-Free: Installation And Operation Instruction Manual INSMAN-101 Sand Media Filters Phone: 951.656.6716 Toll-Free: 800.854.4788 www.yardneyfilters.com 1 Yardney Water Management Systems, Inc. 6666 Bo Springs Blvd.

More information

Installation Manual. Model # SF-4W rev.4 (02/28/14) 1200 Lower River Road, P.O. Box 800 Charleston, TN PULSAR

Installation Manual. Model # SF-4W rev.4 (02/28/14) 1200 Lower River Road, P.O. Box 800 Charleston, TN PULSAR Installation Manual Model # SF-4W 1200 Lower River Road, P.O. Box 800 Charleston, TN 37310-0800 1-800-4-PULSAR is now a part of www.lonza.com Product Stewardship MAKING THE WORLD A BETTER PLACE Lonza is

More information

CL2-B INSTRUCTION BOOKLET CONTENTS

CL2-B INSTRUCTION BOOKLET CONTENTS CONTENTS PAGE SUBJECT 1 Contents 2 Health & Safety Notice 3 Operating instructions 3 Extracting Old Rivets & Hints of Extracting 4 5 Clinching New Rivets & tooling selection 6 Anvil Height Adjustment 7

More information

MICROPROCESSOR CONTROL WATER SUPPLY SYSTEM (MPR-01AW)

MICROPROCESSOR CONTROL WATER SUPPLY SYSTEM (MPR-01AW) MICROPROCESSOR CONTROL WATER SUPPLY SYSTEM (MPR-01AW) Installation, Operation, and Maintenance Manual REV. "B" REV. "C" PLEASE READ ENTIRE DOCUMENT BEFORE PROCEEDING WITH INSTALLATION Energy Saver has

More information

AXLE MOUNT MODELS: FILM ROLLER MODELS: OPERATING & SERVICE PARTS MANUAL TABLE TOP OVERWRAPPERS MODEL 625A MODEL 625A MINI MODEL 825A MODEL 875A

AXLE MOUNT MODELS: FILM ROLLER MODELS: OPERATING & SERVICE PARTS MANUAL TABLE TOP OVERWRAPPERS MODEL 625A MODEL 625A MINI MODEL 825A MODEL 875A OPERATING & SERVICE PARTS MANUAL TABLE TOP OVERWRAPPERS Model 625A AXLE MOUNT MODELS: MODEL 625A SINGLE ROLL WITH MOUNTING AXLES MODEL 625A MINI COMPACT SINGLE ROLL WITH MOUNTING AXLES MODEL 825A DUAL

More information

Installation Suggestions

Installation Suggestions Installation Suggestions P/N 52200-98 Suggestions For Installing The Balboa 05-28-14 Introduction The Balboa consists of a controller that opens and closes valves that supply water to four groups of jets.

More information

HAWLE-AIR RELEASE VALVES

HAWLE-AIR RELEASE VALVES HAWLE-AIR RELEASE VALVES HAWLE-AIR RELEASE VALVES Contents: Dimensions of Air Release Valve Page 2 Why use Air Release Valves? Page 3 Application: Potable water Air Release Valves, DN 1" - DN 2" Page 4

More information

TECHNICAL DATA. Viking Technical Data may be found on Style: 90 Degree Pattern (inlet to outlet)

TECHNICAL DATA. Viking Technical Data may be found on Style: 90 Degree Pattern (inlet to outlet) Flow Control 500a DESCRIPTION The Viking 1-1/2 is a quick opening, differential type flood valve with a spring loaded rolling diaphragm clapper. The can be used to facilitate manual or automatic on/off

More information

Permitting and Tracking Waste Haulers

Permitting and Tracking Waste Haulers Permitting and Tracking Waste Haulers NACWA 2017 National Pretreatment & Pollution Prevention Workshop May 17, 2017 Maurice Akech Senior Program Manager Water Utilities Department City of Dallas Presentation

More information

Components of Hydronic Systems

Components of Hydronic Systems Valve and Actuator Manual 977 Hydronic System Basics Section Engineering Bulletin H111 Issue Date 0789 Components of Hydronic Systems The performance of a hydronic system depends upon many factors. Because

More information

When is Septage Really Septage? GLAD TO SEE YOU MADE THE MOVE!

When is Septage Really Septage? GLAD TO SEE YOU MADE THE MOVE! When is Septage Really Septage? GLAD TO SEE YOU MADE THE MOVE! GREASE TRAP WASTE GREASE TRAP WASTE IS NOT CONSIDERED SEPTAGE UNDER THE FEDERAL 503 RULE Definition of Septage Domestic septage as described

More information

E-Z Treat Installation Guidelines

E-Z Treat Installation Guidelines E-Z Treat Installation Guidelines E-Z Treat Company or its representative will conduct on-site training with each installer before they are certified to install E-Z Treat systems. The training will include

More information