New Model Information
|
|
- Horatio Wood
- 5 years ago
- Views:
Transcription
1 Distribute to: Sales div. Service div. Parts div. Accounting div. No New Model Information The next generation of direct fuel injection outboard motor equipped with a 32 bit ECU (Engine Control Units) that commands the fuel control system to inject fuel of the most suitable amount at optimum moment to the operating conditions that vary momentarily according to information from sensors arranged on various areas of the engine. This product meats requirements of EPA emission regulations and the self-regulation by the Japan Boating Industry Association. This is the TLDI (Two stroke Low pressure Direct Injection) model that provides both linear acceleration responding directly to the throttle operation and ecological performance that makes the machine earth-friendly. Individual sensors During operations, the ECU controls the engine to achieve the highest possible efficiency according to information from six kinds of sensors. Idle noise reduction system Reduces the exhaust noise to offer more quiet and comfortable boating. 1 of 10
2 Specifications MD115 Model Unit MD115A Overall Length in.(mm) 31.5(800) Overall Width in.(mm) 19.5(495) Overall Height (L) in.(mm) 64.6(1,640) Overall Height (UL) in.(mm) 69.7(1,767) Transom Height (L) in.(mm) 20.4(517) Transom Height (UL) in.(mm) 25.4(644) Weight (L) lbs(kg) 393(178) Weight (UL) lbs(kg) 399(181) Engine Type Two-stroke gasoline engine with direct fuel injection Maximum Output HP(Kw)/rpm 115(84.6)/5500 Maximum Torque ft.lb(kgm)/rpm 119(16.5)/4500 Displacement CC(cu.in) 1,768(107.9) Bore Stroke in.(mm) ( ) Number of Cylinder 4 Max. RPM Range rpm 5,1505,850 Idling Speed (In neutral) rpm Trolling Speed (In gear) rpm Fuel Consumption l/hr 45 Starting System Intake System Scavenging System Exhaust System Lubrication System Cooling System Water Temp. Control Ignition System Ignition Timing Electric starter motor Reed valve 5-port loop charge Through hub Oil injection Water-cooling Thermostat (with pressure relief valve) Inductive Firing Order Spark Plug Alternator ECU NGK : IZFR5J 12V-490W More than 0 C (32 F) 12V 100AH (CCA: 800A, MCA: 1000A) Battery 0 C (32 F) & Below 12V 120AH (CCA: 900A, MCA: 1100A) Trim Angle degree 8 24 Number of Trim Position 2 Maximum Tilt Angle degree 75 Maximum Thickness of Transom in.(mm) (3170) Steering Angle degree 66 Clutch Gear Ratio Engine Oil Dog clutch (F-N-R) ) Genuine MD Platinum or Equivalent Engine Oil Capacity L 6.7 Recommended Fuel Unleaded regular gasoline Gear Oil Genuine gear oil or GL5, SAE #80 to #90 Capacity of Gear Oil fl.oz(ml) 30.4 (900) Warning System Over-revolution Protection rpm Approx. 6,000 Over Heat Protection rpm Approx. 3,000 Engine Oil Pressure Warning Indicator rpm Approx. 3,000 Optional Parts Optional Propeller Pitch 11, 13, 15, 16, 17, 19, 21 Specifications and descriptions are subject to change without notices. 2 of 10
3 Dimensions 634mm (25.0in) (kg/lbs) Model Dry Weight EPTOL 178 (393) EPITOUL 181 (399) (mm/in) A B C Transom L: 1640 (64.6) 517 (20.4) 970 (38.2) Transom UL: 1767 (69.7) 644 (25.4) 1084 (42.7) 3 of 10
4 Warning Indicator Definition TableWhile Operating Engine Warning Indicators Buzzer Sounding ESG Speed Control (*1) Fault Description Reference Remedy Indicator A Indicator B Indicator C Continuous High speed ESG Engine over-rev. Approx. 6,000 r/min Readjust propeller and outboard engine mounting height and trim. Intermittent (3 beeps for every 2 minutes) Flashing - Low oil level Approx. 1400mL or less Replenish engine oil. Continuous Flashing Low speed ESG Cooling water temp. high 85 Continuous Flashing Forced idling Cooling water temp. abnormally high temp. 90 Continuous Flashing - Air compressor cooling water temp. high 90 Continuous Flashing Low speed ESG Air compressor cooling water temp. abnormally high 100 Refer to troubleshooting. 4 of 10 - Flashing Low speed ESG Battery voltage abnormally low Approx. or less - Flashing - Battery voltage low Approx. or less - Flashing Flashing Flashing Low speed ESG Battery voltage high Approx. or more - Flashing Flashing Flashing Engine stop Battery voltage abnormally high Approx. or more - Flashing Flashing Flashing - Faulty (*2)Idle position - Flashing Flashing Flashing Forced idling Faulty TPS1 and TPS2 - Flashing Flashing Flashing Low speed ESG Faulty TPS1 or TPS2 Refer to Fault Indication Table. - Flashing Flashing Flashing Forced idling Faulty power supply TPS1 and TPS2 - Flashing Flashing Flashing Low speed ESG Faulty power supply TPS1 or TPS2 *1. Speed control High speed ESG - Flashing Flashing Flashing - Faulty air injector Regulated to approx., rpm. - Flashing Flashing Flashing - Faulty fuel injector Low speed ESG - Flashing Flashing Flashing - Faulty ignition coil Regulated to approx., rpm. Forced idling Regulated to idling speed. - Flashing Flashing Flashing - Faulty (*3) *2. Throttle position sensor - Flashing Flashing Flashing - Faulty (*4) - Flashing Flashing Flashing - Faulty temp. sensor Engine or air compressor *3. Fuel feed pump (electric) - Flashing Flashing Flashing - Faulty MAP sensor *4. Crank position sensor - Flashing Flashing Flashing - Faulty MAT sensor - Flashing Flashing Flashing - Faulty main power relay Intermittent (3 beeps for every 2 minutes) Flashing Note: Items marked with are additions of M115A. Flashing Flashing Forced idling Faulty oil pump
5 Engine Operating Hours Table (self-diagnosing mode 2) Engine Operating Hours Tachometer Reading (h) (r/min) Indicator A Indicator B Indicator C 0 1 1, , , , , , , On On ,000 On ,000 On ,000 On ,000 On ,000 On ,000 On ,000 On On On On On ,000 On On ,000 On On ,000 On On ,000 On On ,000 On On ,000 On On ,000 On On On On On On On On ,000 On On On ,000 On On On ,000 On On On 5 of 10
6 Fault Indication Table (self-diagnosing mode 3 Fault Log Malfunction / Failure indication Fault Fault Log (Yes) Description of Problem Remedial Measures and Added Notes Tachometer (r/min) Indicator A Indicator B Indicator C 0 Off No malfunction or failure Off Off 0 0 On Flashing Battery voltage high Battery voltage abnormally high fault. fault. Refer to troubleshooting. 1,000 Off Faulty #1 air injector 1,000 On Faulty #1 fuel injector 1,000 Flashing Faulty #1 ignition coil 2,000 Off Faulty #2 air injector 2,000 On Faulty #2 fuel injector 2,000 Flashing Faulty #2 ignition coil 3,000 Off Faulty #3 air injector 3,000 On Faulty #3 fuel injector Off Stays off even when line is severed or component is faulty. Refer to *1. Refer to *2. Replace components, or check the wiring and connections for abnormalities and repair as necessary. *1. In the case of injector and ignition coil faults, indicator B does not illuminate when self-diagnosing modes are enabled while the engine is off. This is to determine whether operation is under ECU control. *2. Indicator C illuminates to indicate that there is a severed line or fault in a component. Remedy; Delete current fault log(using Mode 4), operate the engine(or simply turn it over for 5 seconds or longer), and run the self-diagnosing function again to determine the type of fault. In instances when Indicator C again illuminates for the same malfunction or failure take remedial measures. In case of injector problems Replace with new injector. If the fault remains, check the wiring. 6 of 10 3,000 Flashing Faulty #3 ignition coil 4,000 Off Faulty #4 air injector 4,000 On Faulty #4 fuel injector 4,000 Flashing Faulty #4 ignition coil 650 Off Low oil level On indicates low oil level. On indicates low oil level history. In case of ignition coil problems If only one ignition coil is indicated as faulty replace with a new coil. If the fault remains, check the wiring. If all three ignition coils are indicated as faulty it means that there could be a short in the wiring or in one of the coils. Replenish engine oil. *Fault indicator remaining illuminated after engine oil has been replenished indicates a severed or shorted line or faulty component On Flashing Battery voltage low Battery voltage abnormally low On indicates battery voltage low. On indicates low battery voltage history. Refer to troubleshooting. 4,500 Flashing Faulty oil pump Replace components or check wiring and connections for abnormalities and repair as necessary. Replace components or check wiring and connections for abnormalities and repair as necessary. fault. fault history. 5,000 Off Faulty *3 *When engine speed fluctuation is great a fault may be indicated even if there is no fault or abnormality with components or wiring. 5,000 On #1 TPS(*4) idling position error 5,000 Flashing #2 TPS idling position error On indicates incorrect TPS initial settings. On indicates incorrect TPS initial settings history. Refer to the procedure for restoring TPS initial values. 5,500 Off Faulty #1 5,500 On #1 TPS power supply high 5,500 Flashing #1 TPS power supply low 6,000 Off Faulty #2 6,000 On #2 TPS power supply high fault. fault history. Replace component or check wiring and connections for abnormalities and repair as necessary. 6,000 Flashing #2 TPS power supply low 6,500 Off Faulty engine water temp. sensor 3,500 Off Faulty air compressor water temp. sensor
7 Malfunction / Failure indication Fault Fault Log Fault Log (Yes) Description of Problem Remedial Measures and Added Notes Tachometer (r/min) Indicator A Indicator B Indicator C 6,500 On Cooling water temp. high 6,500 Flashing Cooling water temp. abnormally high 7,000 On Air compressor cooling water temp. high On indicates cooling water temperature is high. On indicates high cooling water temperature history. Refer to troubleshooting. 7,000 Flashing Air compressor cooling water temp. abnormally high 7,000 Off Faulty *5 Off Off Refer to troubleshooting. 4,500 Off Faulty MAP sensor 4,500 Off Faulty MAT sensor fault. fault history. Refer to troubleshooting. 2,500 Off Faulty main power relay 7 of 10
8 <Shipment of Product> The shipment of 115A does not include the propeller, remote control box and pre-rigging kit. It is necessary to select a pre-rigging kit described below depending on the remote control box to be used. These items are available from Tohatsu Parts Center by using the same process for ordering other parts. 1 Propeller No.17 No change No.10 No.9 (Color: Black) No.11 (Color: No change) No.8 <Notes> The newly available propeller is dedicated only to MD115A. For models M60C/70C, MD70B/90B, M90A or M120A2/140A2, use a propeller ass y with the part number 3N4W series(example: 3N4W ) or a propeller hub kit (3Y ). No. Part Name Part Number Q'ty 1 Propeller assy 11 3T1W Propeller assy 13 3T1W Propeller assy 15 3T1W Propeller assy 16 3T1W Propeller assy 17 3T1W Propeller assy 19 3T1W Propeller assy 21 3T1W Propeller hub kit 3T Drive sleeve assy Not available 1 10 Drive sleeve adapter Not available 1 11 Forward thrust washer 3E no change 1 8 of 10
9 2 Remote control boxes Top Mount and Flush Mount Remote Controls No. Part Number Part Name 1 3U Single top mount control 2 3U Twin top mount control 3 3U Flush mount control The installation of the above remote control requires the use of the following pre-rigging kit. For twin top mount control, two(2) sets of the pre-rigging kit are needed. Note: The pre-rigging kit does not include a control box. No. Q'ty Part Number Part Name Remarks 3Z Pre-rigging kit For top mount and flush mount remote control box 1 1 3Y Rigging cord kit Outboard motor to switch, remote control box and meters Y Main switch panel assy Y Main switch panel Y Main switch assy Y Stop switch assy Y Overheat warning buzzer Y Cord assy Outboard motor to switch, remote control box and meters Y Cord assy Remote control box to main harness 2 1 3Z Tachometer with oil lamp 3 1 3T Meter lead wire 4 1 3E Trim meter assy Meters to main harness 5 1 3F Extension cord (trim sensor) Trim meter to trim sender 6 1 3B Primer bulb assy Assist cord (black) Meters to meter lead wire, grounding wire for meters 9 of 10
10 Side Mount Remote Control For the installation of the side mount remote control box, it is necessary to use the following pre-rigging kit. No. Q 'ty Part Number Part Name Remarks kit includes a side mount 3Y7Q Pre-rigging kit For Tohatsu side mount remote control box 1 1 3T5Q Remote control head ass y 2 1 3Z Tachometer with oil lamp 3 1 3T Meter lead wire 4 1 3E Trim meter assy Meters to main harness 5 1 3F Extension cord (trim sensor) Trim meter to trim sender 6 1 3B Primer bulb assy Note: A pre-rigging remote control box Assist cord (black) Meters to meter lead wire, grounding wire for meters 3 Optional parts No. Part Number Part Name Remarks 1 3Y Lamp panel ass y Warning lamp (To be used for tachometers made by other than Tohatsu.) 2 3U Lead wire Power supply cord for twin remote control box 3 3U Fuel filter assy UNIKAS, OB of 10
MULTIPOINT FUEL INJECTION (MPI) <4G9>
MULTIPOINT FUEL INJECTION (MPI) 13C-1 MULTIPOINT FUEL INJECTION (MPI) CONTENTS GENERAL................................. 2 Outline of Changes............................ 2 GENERAL INFORMATION...................
More information13A-1 FUEL CONTENTS MULTIPOINT FUEL INJECTION (MPI) FUEL SUPPLY... 13B
13A-1 FUEL CONTENTS MULTIPOINT FUEL INJECTION (MPI)... 13A FUEL SUPPLY... 13B 13A-2 MULTIPOINT FUEL INJECTION (MPI) CONTENTS GENERAL INFORMATION... 3 SERVICE SPECIFICATIONS... 6 SEALANT... 6 SPECIAL TOOLS...
More informationOWNER S MANUAL M 40D2 50D2 MW 50D2. OB No B
OWNER S MANUAL M 40D2 0D2 MW 0D2 OB No.003-11038-B ! READ THIS MANUAL BEFORE USING THE OUTBOARD MOTOR. FAILURE TO FOLLOW THE INSTRUCTIONS AND SAFETY PRECAUTIONS IN THIS MANUAL CAN RESULT IN SERIOUS INJURY
More informationMULTIPOINT FUEL INJECTION (MPI) <4G63-Non-Turbo>
13A-1 GROUP 13A MULTIPOINT FUEL INJECTI (MPI) CTENTS GENERAL INFORMATI........ 13A-2 FUEL INJECTI CTROL...... 13A-6 IDLE SPEED CTROL (ISC)..... 13A-7 IGNITI TIMING AND DISTRIBUTI CTROL........
More informationsmall hp fourstroke outboard 2.5 HP 3.5 HP 4 HP 5 HP 6 HP 8 HP 9.9 HP 9.9 HP BigFoot 9.9 HP Pro Kicker 15 HP 15 HP ProKicker 20 HP
small hp fourstroke outboard 2.5 HP 3.5 HP 4 HP 5 HP 6 HP 8 HP 9.9 HP 9.9 HP BigFoot 9.9 HP Pro Kicker 15 HP 15 HP ProKicker 20 HP 25 HP EFI 30 HP EFI 54 46 55 2.5hp 2.5hp S P E C I F I C A T I O N S K
More informationOWNER S MANUAL M 60C M 70C M 70CX M 90A2 M 115A2 M 140A2. OB No EAH1
OWNER S MANUAL M 60C M 70C M 70CX M 90A M 5A M 40A OB No.00-09-EAH ENOM0000-0 READ THIS MANUAL BEFORE USING THE OUTBOARD MOTOR. FAILURE TO FOLLOW THE INSTRUCTIONS AND SAFETY PRES IN THIS MANUAL CAN RESULT
More informationOWNER S MANUAL MFS 40A MFS 50A. OB No AG
OWNER S MANUAL MFS 40A MFS 50A OB No.003-05-5AG California Proposition 65 This engine contains or exhaust chemicals known to the state of California to cause cancer, birth defects or other reproductive
More informationItems Vehicles with 4G63 engine Vehicles with 4D56 engine. Type 4-speed full automatic 4-speed full automatic. 2nd rd
23-2 AUTOMATIC TRANSMISSION General Information/ Service Specifications GENERAL INFORMATION 23100010141 Items Vehicles with 4G63 engine Vehicles with 4D56 engine Transmission model R4AW2-6 V4AW2-6 Type
More informationOWNER S MANUAL. M 40D2 M 50D2 OB No CAF1
OWNER S MANUAL M 40D M 50D OB No.003-038-CAF ENOM0000-0 READ THIS MANUAL BEFORE USING THE OUTBOARD MOTOR. FAILURE TO FOLLOW THE INSTRUCTIONS AND SAFETY PRES IN THIS MANUAL CAN RESULT IN SERIOUS INJURY
More informationTO INDEX IGNITION SYSTEM
TO INDEX IGNITION SYSTEM IG IGNITION SYSTEM CIRCUIT... IG 2 SPARK TEST... IG 4 SPARK PLUG... IG 4 POWER SUPPLY... IG 5 CRANK ANGLE SENSOR... IG 7 CAM ANGLE SENSOR... IG 8 EFI ECU... IG 8 IGNITION TIMING...
More informationDF100A DF300AP PERFORMANCE MARINE ENGINES
DF100A DF300AP PERFORMANCE MARINE ENGINES THE POWER OF CHOICE AVAILABLE IN COOL WHITE Limited edition, subject to delivery times. T&Cs and additional charges apply. V6 DF300AP THE ULTIMATE HIGH-PERFORMANCE
More informationPowertrain DTC Summaries EOBD
Powertrain DTC Summaries Quick Reference Diagnostic Guide Jaguar X-TYPE 2.0 L 2002.25 Model Year Refer to page 2 for important information regarding the use of Powertrain DTC Summaries. Jaguar X-TYPE 2.0
More informationREAD THIS MANUAL BEFORE USING THE OUTBOARD MOTOR. KEEP THIS MANUAL IN A SAFE LOCATION FOR FUTURE REFERENCE.
California Proposition 65 Operating, servicing and maintaining an outboard motor can expose you to chemicals including engine exhaust, carbon monoxide, phthalates, and lead, which are known to the State
More informationB WASH OIL LEVEL OIL SERVICE MANUAL
SERVICE MANUAL 1 Chapter 1 Specifications 1. Specifications Table...1-3 2. Outline Dimensions...1-4 3. ackground on TLDI...1-6 1-2 1. Specifications Table Item MODEL 40A 50A EPTO EFTO EFO Overall length
More informationManual. Engine SOLO type i
for the Engine SOLO type Serial - no.... Manufactured... Aircraft - type... Registration no.... Owner... Log of revisions no. Edition date revised page no. date of entry 1 01.09.2010 1-9 01. September
More informationOWNER S MANUAL AAAA. Original instructions MFS 40A MFS 50A. OB No AH1
OWNER S MANUAL AAAA Original instructions MFS 40A MFS 50A OB No.003-06-8AH ENOM0000-0 READ THIS MANUAL BEFORE USING THE OUTBOARD MOTOR. FAILURE TO FOLLOW THE INSTRUCTIONS AND SAFETY PRES IN THIS MANUAL
More informationFUEL 13-1 CONTENTS MULTIPOINT INJECTION (MPI)... 2 GENERAL INFORMATION... 2 SERVICE SPECIFICATIONS... 3 SEALANT... 3 SPECIAL TOOLS...
13-1 FUEL CONTENTS MULTIPOINT INJECTION (MPI)....... 2 GENERAL INFORMATION................ 2 SERVICE SPECIFICATIONS.............. 3 SEALANT............................... 3 SPECIAL TOOLS........................
More informationFUEL 13-1 CONTENTS MULTIPOINT INJECTION (MPI)... 2 FUEL SUPPLY ON-VEHICLE SERVICE GENERAL SERVICE SPECIFICATIONS... 4 SEALANT...
13-1 FUEL CONTENTS MULTIPOINT INJECTION (MPI)....... 2 GENERAL............................... 2 Outline of Change......................... 2 SERVICE SPECIFICATIONS.............. 4 SEALANT...............................
More informationE50PL4SSC 4-Stroke, Elec Start, TNT, 20 IN. shaft 2000 : CAMSHAFT & TIMING [1/21] Page 1 of 44
E50PL4SSC 4-Stroke, Elec Start, TNT, 20 IN. shaft 2000 : CAMSHAFT & TIMING [1/21] Page 1 of 44 E50PL4SSC 4-Stroke, Elec Start, TNT, 20 IN. shaft 2000 : CAMSHAFT & TIMING [1/21] 1 5031326 1 CAMSHAFT, Intake
More informationTHROTTLE BODIES 7-6. c. Connect the pressure gauge 2 and adapter 3 to the fuel hose (fuel tank to primary
THROTTLE BODIES EAS26980 CHECKING THE INJECTORS 1. Check: Injectors Damage Replace. EAS26990 CHECKING THE THROTTLE BODIES 1. Check: Throttle bodies Cracks/damage Replace the throttle bodies as a set. 2.
More information2.8 Liter VR6 2V Fuel Injection & Ignition, Engine Code(s): AAA m.y
2.8 Liter VR6 2V Fuel Injection & Ignition, Engine Code(s): AAA m.y. 1996-1997 01 - On Board Diagnostic (OBD) On Board Diagnostic (OBD II) Malfunction Indicator Lamp (MIL) On Board Diagnostic (OBD II),
More informationMULTIPOINT FUEL INJECTION (MPI) <4G63-Turbo>
13B-1 GROUP 13B MULTIPOINT FUEL INJECTI (MPI) CTENTS GENERAL INFORMATI........ 13B-2 SENSOR....................... 13B-8 THROTTLE VALVE OPENING ANGLE CTROL.............. 13B-9 FUEL INJECTI
More informationDF40A DF90A MID-RANGE MARINE ENGINES
DF40A DF90A MID-RANGE MARINE ENGINES THE REVOLUTION IS HERE AGAIN! DF90A / DF80A / DF70A Suzuki s A series engines are designed from the ground up to deliver exciting performance and outstanding fuel efficiency.
More informationOB No NB-2600
4 Stroke OB No.00-054- 06-0 NB-600 Introduction Before reading this manual This service manual provides information that is needed for inspection, service and repair of applicable outboard motors. For
More informationOWNER S MANUAL MFS 25C MFS 30C. OB No AG1
OWNER S MANUAL MFS 5C MFS 30C OB No.003-8-AG California Proposition 65 This engine contains or exhaust chemicals known to the state of California to cause cancer, birth defects or other reproductive harm.
More informationTelephone: Fax: VAT Registration No.:
Telephone: Fax: VAT Registration No.: K143 AC compressor clutch relay X88 AC connector S63 AC refrigerant pressure switch S341 AC refrigerant triple pressure switch A16 Anti-lock braking system (ABS) control
More informationOWNER S MANUAL AAAA MFS 8B MFS 9.8B. OB No AH1
OWNER S MANUAL AAAA MFS 9.8B MFS 8B OB No.003-4-5AH California Proposition 65 Operating, servicing and maintaining an outboard motor can expose you to chemicals including engine exhaust, carbon monoxide,
More informationOWNER S MANUAL MANUEL DE L UTILISATEUR MANUAL DEL PROPIETARIO BENUTZERHANDBUCH MFS 15C 20C. OB No
E OWNER S MANUAL F MANUEL DE L UTILISATEUR ES MANUAL DEL PROPIETARIO D BENUTZERHANDBUCH MFS 5C 20C OB No.003-090-6 OWNER S MANUAL MFS 5C 20C OB No.003-090-6 ENOM0000-0 READ THIS MANUAL BEFORE USING THE
More informationAll-new Yamaha F25 is the Lightest 25-hp in the Industry. Period!
BOAT PROPELLER OUTBOARD BOAT PROPELLER OUTBOARD yamaha-motor.ca F 25 NEW EFFECTIVE APRIL 1, 2016 All-new Yamaha F25 is the Lightest 25-hp in the Industry. Period! The smallest of the Yamaha midrange models
More informationG - TESTS W/CODES - 2.2L
G - TESTS W/CODES - 2.2L 1994 Toyota Celica 1994 ENGINE PERFORMANCE Toyota 2.2L Self-Diagnostics Celica INTRODUCTION If no faults were found while performing F - BASIC TESTING, proceed with self-diagnostics.
More informationH - TESTS W/O CODES Nissan 240SX INTRODUCTION TROUBLE SHOOTING SYMPTOMS DIAGNOSIS WILL NOT START
H - TESTS W/O CODES 1990 Nissan 240SX 1990 ENGINE PERFORMANCE Trouble Shooting - No Codes Nissan; 240SX, Axxess, Maxima, Pathfinder, Pickup, Pulsar, Sentra, Van, INTRODUCTION Before diagnosing symptoms
More informationAUTOMATIC TRANSMISSION
23A-1 GROUP 23A AUTOMATIC TRANSMISSION CONTENTS SERVICE SPECIFICATIONS....... 23A-3 LUBRICANTS.................. 23A-3 SPECIAL TOOLS................ 23A-4...... 23A-7 STANDARD FLOW OF DIAGNOSIS TROUBLESHOOTING................
More informationDownload Service & repair manual Yamaha F250, LF PDF Service Manual
Download Service & repair manual Yamaha F250, LF250 2006 - PDF Service Manual DOWNLOAD HERE "Download Service & repair manual Yamaha F250, LF250 2006 - PDF Service Manual Do you want to service & repair
More informationDTC P0341 Camshaft Position (CMP) Sensor Performance
Page 1 of 5 1999 Buick Century Century, Regal VIN W Service Manual Document ID: 345654 DTC P0341 Camshaft Position (CMP) Sensor Performance Circuit Description During cranking, the Ignition Control Module
More informationE70PL4EEC 1999 : CAMSHAFT [1/23] Page 1 of 49
E70PL4EEC 1999 : CAMSHAFT [1/23] Page 1 of 49 E70PL4EEC 1999 : CAMSHAFT [1/23] 1 5030657 1 CAMSHAFT 2 5030658 1 PLATE, Camshaft thrust 3 5030549 1 SEAL, Camshaft 4 5030989 2 BOLT, Plate 5 5030663 8 ARM,
More informationNew F90 is Strongest 90-hp Outboard Money Can Buy!
BOAT PROPELLER OUTBOARD BOAT PROPELLER OUTBOARD yamaha-motor.ca F 90/F 75 NEW New F90 is Strongest 90-hp Outboard Money Can Buy! The new Yamaha F90 achieves what every next- generation Yamaha outboard
More informationCHECKING THE ELECTRONIC FUEL INJECTION SYSTEM.
CHECKING THE ELECTRONIC FUEL INJECTION SYSTEM. IMPORTANT:- No checks can be carried out without the use of the Special Bosch EF AW 220 Test Unit, which enables every part of the Electronic Fuel Injection
More informationSERVICE DATA. Item Standard Limit Valve diam. IN (1.42) EX (1.30) Tappet clearance (When cold)
Model: LT-A750XK9 P-17, 24, 28, 33 LT-A750XZK9 P-17, 28, 33 4 STROKE Camshaft + Cylinder Head SERVICE DATA Valve + Guide Valve diam. IN. 36.0 (1.42) EX. 33.0 (1.30) Tappet clearance (When cold) IN. 0.10
More informationFrom Japan to The World
From Japan to The World Tohatsu s sole factory, located in the city of Komagane in Nagano Prefecture, Japan, boasts the world s largest production capacity for outboard motors. Engines manufactured in
More informationOWNER S MANUAL MFS 15D MFS 20D. OB No AG1
OWNER S MANUAL MFS 5D MFS 20D OB No.003-6-2AG California Proposition 65 This engine contains or exhaust chemicals known to the state of California to cause cancer, birth defects or other reproductive harm.
More informationTROUBLESHOOTING FOR EFI ELECTRONIC CIRCUIT WITH VOLT/OHMMETER
FI118 TROUBLESHOOTING FOR EFI ELECTRONIC CIRCUIT WITH VOLT/OHMMETER HINT: Because the following troubleshooting procedures are designed for inspection of each separate system, the actual troubleshooting
More informationSERVICE DATA. Unit: mm (in) ITEM STANDARD LIMIT Valve diam. IN (1.42) EX ( ) EX.
4 STROKE VALVE + VALVE GUIDE CAMSHAFT + CYLINDER HEAD SERVICE DATA Valve diam. 36.0 (1.42) 33.0 (1.30) Tappet clearance (when cold) 0.10 0.20 (0.004 0.008) 0.20 0.30 (0.008 0.012) Valve guide to valve
More informationOWNER S MANUAL MFS 8B MFS 9.8B. OB No AG1
OWNER S MANUAL MFS 8B MFS 9.8B OB No.003-4-3AG California Proposition 65 This engine contains or exhaust chemicals known to the state of California to cause cancer, birth defects or other reproductive
More informationOU TBOARD MOTORS 2019
OU TBOARD MOTORS 2019 See it, Hear it, Feel the Wind Operating since 1922, Tohatsu has never stopped asking ourselves the essential question of - what makes a great engine? Aiming to deliver quality engines
More informationSuzuki Instruments. Suzuki Genuine Instruments are. custom-designed to provide the. quality, reliability and value you. expect from Suzuki Products.
Suzuki Instruments Suzuki Genuine Instruments are custom-designed to provide the quality, reliability and value you expect from Suzuki Products. The wide selection allows you to accurately monitor a variety
More informationNEW FEATURES 3E E ENGINE. 1. Description 12 TERCEL NEW FEATURES
12 TERCEL NEW FEATURES NEW FEATURES 3E E ENGINE 1. Description The 3E E engine is based on the 1.5 liter, 12 valve, OHC 3E engine, but with fuel injection, ignition timing and other engine functions controlled
More information11A-1 ENGINE CONTENTS ENGINE <4G9>...
11A-1 ENGINE CONTENTS 11109000276 ENGINE ... ENGINE ... 11A 11B 11A-2 ENGINE CONTENTS GENERAL INFORMATION... 3 SERVICE SPECIFICATIONS... 3 SEALANTS... 4 SPECIAL TOOLS... 5 ON-VEHICLE SERVICE...
More information75/90 FOURSTROKE EFI WIRING DIAGRAM
75/0 FOURSTROKE EFI WIRING DIAGRAM 0-87725 MARCH 2005 Page 8A-3 75/0 FourStroke EFI Wiring Diagram - Electronic control module (ECM) 2 - Engine water temperature sensor 3 - Ignition coil for cylinder #
More informationOU TBOARD MOTORS 2018
OUTBOARD MOTORS 2018 Feel the Wind. Tohatsu delivers a smarter, more exciting boating experience for boaters all around the world. 1 TOHATSU OUTBOARD MOTORS 2018 CONTENTS 01 Introduction 03 Our Mission
More informationFUEL INJECTION SYSTEM - MULTI-POINT
FUEL INJECTION SYSTEM - MULTI-POINT 1988 Jeep Cherokee 1988 Electronic Fuel Injection JEEP MULTI-POINT 4.0L Cherokee, Comanche, Wagoneer DESCRIPTION The Multi-Point Electronic Fuel Injection (EFI) system
More informationSERVICE DATA Date: August 1, 2007
SERVICE DATA Date: August 1, 2007 Model: LT-A450XK8 VALVE + VALVE GUIDE Valve diam. 30.6 IN. (1.20) EX. 27.0 (1.06) Tappet clearance (when cold) 0.05 0.10 IN. (0.002 0.004) EX. 0.17 0.22 (0.007 0.009)
More informationSERVICE DATA GT-220ES SRM-220ES TRIMMER/BRUSHCUTTER. (Serial nember : and after) (Serial nember : and after) INDEX INTRODUCTION
10-21P-02, 1 1 SERVICE DATA TRIMMER/BRUSHCUTTER INTRODUCTION We are constantly working on technical improvement of our products. For this reason, technical data, equipment and design are subject to change
More informationDiagnostic Trouble Code (DTC) List - Vehicle
Document ID# 850406 2002 Pontiac Firebird Diagnostic Trouble Code (DTC) List - Vehicle DTC DTC 021 and/or 031 DTC 022 and/or 032 DTC 023 or 033 DTC 24/34 DTC 025 and/or 035 DTC 041 DTC 042 DTC 043 DTC
More informationTROUBLESHOOTING WITH VOLT OHMMETER LOCATION OF FUSES AND FUSIBLE LINKS FI 27
HINT: The following troubleshooting procedures are designed for inspection of each separate system, and therefore the actual procedure may vary somewhat. However, troubleshooting should be performed referring
More informationError Codes TOYOTA SUPRA MA70
Code Error 11 (+B) Error Codes TOYOTA SUPRA MA70 Momentary interruption in power supply to. Ignition switch circuit Ignition switch Main relay circuit Main relay 12 RPM Signal No "NE" or "G" signal to
More informationMID-RANGE MARINE ENGINES
MID-RANGE MARINE ENGINES Suzuki A series engines are designed from the ground up to deliver exciting performance and outstanding fuel efficiency. The DF70A, DF80A and DF90A are leading the 4-stroke revolution.
More informationPowertrain DTC Summaries EOBD
Powertrain DTC Summaries Quick Reference Diagnostic Guide Jaguar S-TYPE V6, V8 N/A and V8 SC 2002.5 Model Year Refer to pages 2 9 for important information regarding the use of Powertrain DTC Summaries.
More informationENGINE 6G74 3.5L-SOHC-24 VALVE
11A ENGINE General Information/Service Specifications ENGINE 6G74 3.5L-SOHC-24 VALVE GENERAL INFORMATION Items Specifications Type V-type, Over Head Camshaft Number of cylinders 6 Bore mm 93.0 Stroke mm
More informationREMOTE CONTROL CONVERSION KIT, P/N INSTALLATION INSTRUCTIONS
REMOTE CONTROL CONVERSION KIT, P/N 5036662 INSTALLATION INSTRUCTIONS APPLICATION This kit is designed for use on 2005 (SO) and newer Johnson 9.9 and 5 HP (302 cc) 4-Stroke outboards. DO NOT install on
More informationDTC P0172 Fuel Trim System Rich
Page 1 of 6 1997 Chevrolet Cavalier Cavalier, Sunfire (VIN J) Service Manual Document ID: 47788 DTC P0172 Fuel Trim System Rich System Description A Closed Loop air/fuel metering system is used to provide
More informationELECTRONIC FUEL INJECTION
Table of Contents ELECTRONIC FUEL INJECTION Section 3B - Troubleshooting and Diagnostics TROUBLESHOOTING AND DIAGNOSTICS Specifications........................... 3B-1 Special Tools...........................
More informationPowertrain DTC Summaries EOBD
Powertrain DTC Summaries Quick Reference Diagnostic Guide Jaguar X-TYPE 2.5L and 3.0L 2001.5 Model Year Revised January, 2002: P0706, P0731, P0732, P0733, P0734, P0735, P0740, P1780 POSSIBLE CAUSES Revised
More informationPRODUCT INFORMATION. FOUR-STROKE / Electronic Fuel Injection
PRODUCT INFORMATION FOUR-STROKE / Electronic Fuel Injection Suzuki s Award Winning Technology The product of unrivaled expertise and world class technology, Suzuki s four-stroke outboards have long been
More informationsolo KLEINMOTOREN GMBH
Engine 2 489 the Engine SOLO type 2 489 Serial - no.... Manufactured... Aircraft - type... Registration no.... Owner... Log of revisions no. edition date revised page no. date of entry edition 1 revised
More informationTABLE OF CONTENTS PREFACE... 3
TABLE OF CONTENTS PREFACE.......................................................................... 3 EVINRUDE E-TEC ENGINES............................................. 5 40, 50, 60 EVINRUDE E-TEC...........................................................
More informationINDEX INTRODUCTION. Reference No L-01 REVISED:
12-21L-01 1 1 INTRODUCTION We are constantly working on technical improvement of our products. For this reason, technical data, equipment and design are subject to change without notice. All specifications
More informationSERVICE DATA. Unit: mm (in) ITEM STD/SPEC. LIMIT Valve diam. 29 IN. (1.14) EX IN. ( ) EX.
4 STROKE VALVE + GUIDE SERVICE DATA Date: November 23, 2000 Valve diam. 29 (1.14) 24 (0.94) Valve clearance (when cold) 0.10 0.20 (0.004 0.008) 0.20 0.30 (0.008 0.012) Valve guide to valve stem 0.010 0.037
More informationDTC P1223, P1226, P1229, P1232, P1235, P1238, P1241, or P1244
Page 1 of 5 005 Chevrolet Kodiak C-Series (Conventional) C/C5 Kodiak, TopKick C-Series Service Manual Document ID: 16600 DTC P13, P16, P1, P13, P135, P138, P11, or P1 Circuit Description The engine control
More informationThrottle-by-wire. MasterCraft Technical Training Vonore, Tennessee USA. A MasterCraft Technical Services Publication
Throttle-by-wire MasterCraft Technical Training Vonore, Tennessee USA A MasterCraft Technical Services Publication MasterCraft University 2008-2009 Throttle-by-wire Page 1 Electronic Throttle Control Description
More informationG - TESTS W/CODES Nissan 240SX * PLEASE READ THIS FIRST * INTRODUCTION SELF-DIAGNOSTIC SYSTEM DESCRIPTION HARD FAILURES INTERMITTENT FAILURES
G - TESTS W/CODES 1990 Nissan 240SX 1990 ENGINE PERFORMANCE Self-Diagnostics Nissan 240SX and Axxess * PLEASE READ THIS FIRST * NOTE: This article has been revised according to Technical Service Bulletin
More information4-STROKE ENGINES 40HP 90HP
4-STROKE ENGINES 40HP 90HP BOATING MADE BETTER There is no other outboard brand like it in the world. Suzuki Marine is truly unique. You may think all outboards look the same, but once you get under the
More information35A-1 SERVICE BRAKES CONTENTS BASIC BRAKE SYSTEM ANTI-SKID BRAKING SYSTEM (ABS) <2WD> ACTIVE STABILITY CONTOROL (ASC) SYSTEM
35A-1 SERVICE BRAKES CONTENTS BASIC BRAKE SYSTEM... 35A ANTI-SKID BRAKI SYSTEM (ABS) ... 35B ACTIVE STABILITY CONTOROL (ASC) SYSTEM... 35C 35A-2 BASIC BRAKE SYSTEM General/On-vehicle Service GENERAL
More informationEvinrude_Johnson HP Service Manual Outboard - PDF Service Manual
1973 1990 Evinrude_Johnson 48 235 HP Service Manual Outboard - PDF Service Manual DOWNLOAD HERE "1973 1990 Evinrude/Johnson 48 235 HP Service Manual Outboard - PDF Service Manual Johnson - Evinrude Service
More informationMERCURY DOWNLOAD Service Manual 90 to 300 HP Outboard - PDF Service Manual
MERCURY DOWNLOAD 1965 1989 Service Manual 90 to 300 HP Outboard - PDF Service Manual DOWNLOAD HERE "MERCURY DOWNLOAD 1965 1989 Service Manual 90 to 300 HP Outboard - PDF Service Manual MERCURY DOWNLOAD
More informationENGINE CONTROL SYSTEM. 1. General ENGINE 3VZ FE ENGINE
ENGINE 3VZ FE ENGINE 69 ENGINE CONTROL SYSTEM 1. General The engine control system for the 3VZ FE engine has the same basic construction and operation as for the 2VZ FE engine. However, the sequential
More informationMARINE.HONDA.COM.AU. BF250 (250hp Outboard)
MARINE.HONDA.COM.AU BF250 (250hp Outboard) The BF250 outboard engine takes Honda into the next power range. This flagship engine combines a new 3.6L, V6 EFI engine with the world s first direct air induction
More information1. Connect the Honda PGM Tester or an OBD II scan tool to the 16P Data Link Connector (DLC) located behind the right side of the center console.
Troubleshooting Procedures I. How To Begin Troubleshooting When the Malfunction indicator Lamp (MIL) has been reported on, or there is a driveability problem, use the appropriate procedure below to diagnose
More informationDRIVE_UNIT_ / TRANSOM PLATE
DRIVE_UNIT_989 989 / TRANSOM PLATE Part List DRIVE_UNIT_989 989 / TRANSOM PLATE REF - NO PART NUMBER PART NAME QUANTITY REMARKS 6T4-4583-00-EK PLATE, TRANSOM 2 6T4-09-00-00 MOUNT, RUBBER 2 2 3 6T4-029-00-00
More informationOWNER S MANUAL MX 40D3 MX 50D3. Original instructions. OB No AG1
OWNER S MANUAL MX 40D3 MX 50D3 Original instructions OB No.003-098-4AG ENOM0000-0 READ THIS MANUAL BEFORE USING THE OUTBOARD MOTOR. FAILURE TO FOLLOW THE INSTRUCTIONS AND SAFETY PRES IN THIS MANUAL CAN
More informationPowertrain DTC Summaries OBD II
Powertrain DTC Summaries Quick Reference Diagnostic Guide Jaguar X-TYPE 2.5L and 3.0L 2002 Model Year Revised January, 2002: P0706, P0731, P0732, P0733, P0734, P0735, P0740, P1780 POSSIBLE CAUSES Revised
More informationOWNER S MANUAL. Original instructions MFS 4C MFS 5C MFS 6C. OB No AH1
OWNER S MANUAL Original instructions MFS 4C MFS 5C MFS 6C OB No.003--5AH ENOM0000-0 READ THIS MANUAL BEFORE USING THE OUTBOARD MOTOR. FAILURE TO FOLLOW THE INSTRUCTIONS AND SAFETY PRES IN THIS MANUAL CAN
More informationMD PRODUCT BULLETIN V8 500 VGT. Turbocharged Diesel Marine Propulsion System PRODUCT BULLETIN.
V8 500 VGT Turbocharged Diesel Marine Propulsion System PRODUCT BULLETIN 1 V8 500 VGT Axis Drive INTRODUCTION Caudwell Marine Axis Drives are the world s most technologically advanced marine propulsion
More informationTelephone: Fax: VAT Registration No.:
Telephone: Fax: VAT Registration No.: Name: Manufacturer: Ford Address: Model: Year: 1994 Registration: Tel - Private: Tel - Business: Mileage: Job number: Terminal side Wire side Component/circuit description
More informationAudi A3 Current Flow Diagram No. 75 / 1 Edition Audi A3 (1,8 l litre fuel injection engine, 110 kw, Motronic, 4-cylinder) engine codes AQA
Strona 1 z 10 Audi A3 Current Flow Diagram No. 75 / 1 Edition 09.1999 Audi A3 (1,8 l litre fuel injection engine, 110 kw, Motronic, 4-cylinder) engine codes AQA From model year 1999 Audi A3 (1,8 l litre
More informationData Unit Value Coolant temperature 0.436V (130 ) ~4.896V (-40 )
149000 153 1. ENGINE DATA LIST Data Unit Value Coolant temperature 0.436V (130 ) ~4.896V (40 ) Intake air temperature 40~130 (varies according to ambient air temperature or engine mode) Idle speed rpm
More informationTIGHTENING TORQUE CHART For other nuts and bolts not listed in the preceding page, refer to this chart:
TIGHTENING TORQUE ENGINE ITEM N m kgfm lbft Cylinder head cover bolt 14 1.4 10.0 Spark plug 11 1.1 8.0 Cylinder head bolt (M10) 47 4.7 18.0 (M6) 10 1.0 7.0 Cylinder bolt 10 1.0 7.0 Camshaft journal holder
More information2016 GENUINE RIGGING-PARTS AND ACCESSORIES
2016 GENUINE RIGGING-PARTS AND ACCESSORIES Dear Customer, Quality. Dependability. Innovation. Everything that you expect from your outboard motors is delivered with style by SUZUKI. Demand no less from
More informationA rotary solenoid type ISC system is used, which controls the fast idle and idle speeds.
44 ENGINE 5S FE ENGINE ENGINE CONTROL SYSTEM 1. General Basic functions of the engine control system of the new 5S FE engine for the new Camry are the same as those in the 5S FE engine for the 90 model
More informationECT SENSOR 2 2P CONNECTOR. Clamp the main wire harness and the ECT sensor 3 wire as shown.
CABLE/ ROUTING VIEWED FROM THE UPPER RIGHT REAR SIDE: Clamp the main wire harness and the ECT sensor 3 wire as shown. After securing the cables and harnesses with the harness band clips, cut the end of
More informationDIAGNOSTIC TROUBLE CODE CHART HINT:
DIAGNOSTICS DIAGNOSTIC TROUBLE CODE CHART HINT: SFI SYSTEM (1MZFE) 05241 Parameters listed in the chart may not be exactly the same as your reading due to the type of instrument or other factors. If a
More informationCONTENTS 4 CYLINDER. ENGINE MECHANICAL GM V6 AND va ENGINES SPECIFICATIONS 4-41 ENGINE MECHANICAL. FORD va ENGINES SPECIFICATIONS 5-23 ENGINE OVERHAUL
CONTENTS HOW TO USE THIS MANUAL 1 2 BOATING SAFElY 1-4 SAFETY IN SERVICE 1 11 TROUBLESHOOTING 1 11 TOOLS AND EQUIPMENT 1-15 TOOLS 1-17 FASTENERS, MEASUREMENTS AND CONVERSIONS 1-24 1-25 ENGINE AND DRIVE
More informationDTC Summaries. NipponDenso V12 Engine Management
DTC Summaries NipponDenso V12 Engine Management OBD II MONITORING CONDITIONS: When testing for DTC reoccurrence, it can be determined if the Service Drive Cycle was of sufficient length by performing a
More informationH - TESTS W/O CODES INTRODUCTION SYMPTOMS
H - TESTS W/O CODES 1995 Volvo 850 1995 ENGINE PERFORMANCE Volvo - Trouble Shooting - No Codes 850 INTRODUCTION Before diagnosing symptoms or intermittent faults, perform steps in the F - BASIC TESTING
More informationENGINE MANAGEMENT SYSTEM. System Sensors
ENGINE MANAGEMENT SYSTEM System Sensors Throttle position sensor - Used to relay throttle position information to the ECU. Throttle opening angle is used by the ECU to determine fuelling and ignition requirements
More informationFuel Metering System Component Description
1999 Chevrolet/Geo Tahoe - 4WD Fuel Metering System Component Description Purpose The function of the fuel metering system is to deliver the correct amount of fuel to the engine under all operating conditions.
More informationDI 3 ENGINE DIAGNOSTICS DI PRE CHECK
FI0534 PRECHECK DI3 DI09603 1. DIAGNOSIS SYSTEM (a) Description When troubleshooting OBD II vehicles, the only difference from the usual troubleshooting procedure is that you connect to the vehicle the
More informationBASIC DIAGNOSTIC PROCEDURES
BASIC DIAGNOSTIC PROCEDURES 2001 Chevrolet Camaro 2001 ENGINE PERFORMANCE Basic Diagnostic Procedures - Cars Except Metro & Prizm MODEL IDENTIFICATION MODEL IDENTIFICATION Body Code (1) Model C... Park
More informationThe engine is running. DTC P0351, P0352, P0353, and P0354 run continuously once the above condition has been met.
Page 1 of 6 DTC P0351-P0354 Circuit Description DTCs P0351 through P0354 Ignition Coil Primary/Secondary Feedback Circuit diagnostic monitors the primary circuitry of individual ignition coils for the
More information01 02B ON-BOARD DIAGNOSTIC [ENGINE CONTROL SYSTEM (FS)]
ON-BOARD DIAGNOSTIC [ENGINE CONTROL SYSTEM (FS)] CONTROL SYSTEM WIRING DIAGRAM [FS]............................ 2 CONTROL SYSTEM DEVICE AND CONTROL RELATIONSHIP CHART [FS]........ 4 Engine Control System............
More informationBombardier Recreational Products Inc.
Bombardier Recreational Products Inc. REMOTE CONTROL CONVERSION KIT, P/N 5035775 INSTALLATION INSTRUCTIONS APPLICATION This kit is designed for use on 000 (SS) and newer Evinrude or Johnson 5 and 30 HP
More information