Double Check Backflow Preventer 314" to 2"
|
|
- Moris Johnston
- 5 years ago
- Views:
Transcription
1
2 p e x 6 n Backflo w Specialties (800) 66BKFLO (69) 5755 Fax: (69) APPLCATON AND DESCRPTON The 4 00 Series Double Check device prevents backflow of water in low hazard applications. t consists of two independently operating check valves with shutoff valves and test cocks. They protect against backsiphonage and backpressure. Used in irrigation systems, fire protection systems, industrial plant protection, and other nontoxic applications. FEATURES AND BENEFTS 400 Series Double Check Backflow Preventer 34" to " MODEL DESCRPTONS DMENSONS inches MODEL SlZE N P Height Width Length m Certification by USC Foundation for Cross Connection Control and Hydraulic Research, ASSE, AWWA, APMO, and City of New York. Optional replaceable brass valve seats for improved serviceability. Spring loaded Y check valves reduce friction loss. All internal parts are easily serviceable without removing the valve body. Available with or without resilient seated ball valves. Operates when installed in any position. Pressure rated to 75 psi and hydrostatically tested to 350 psi. Temperature rated to 80 degrees F. Corrosion resistant internal parts. All test cocks are blowout resistant. OPTONS Without ball valves NBV.(l60) BSPT without ball valves BSPTNBV (55) Replaceable brass seats RS (5) PERFORMANCE HOW TO SPECFY 5DCRS t T t SZE TYPE OPTON This specifies a '/!" double check backflow preventer with replaceable seats. MATERALS Body: cast brass nternal assemblies: engineered polymer check valves Guides: engineered polymer Springs: stainless steel Rubber seats: BunaA or EPDM FLOW N GPM
3 Assembly must be installed where accessible for testing and maintenance. Flush pipeline thoroughly before installation. Assembly should be installed " above grade (30" max). Consult local codes for installation requirements. When threading the device onto the line, place wrench only on the ball valve hex ends. After install, open the inlet ball valve to fill device. Bleed air from unit via the test cocks. f check valve fails to hold PS, close ball valves, bleed test cocks, remove check valve bonnet and check the seat andlor seat disc for fouling. Device must be protected from freezing. \ Commercially Available Parts for Series 4000 Valves 4 0 0Ring 6 0Ring BUNAN AS5686 AS5686 AS56836 AS56836 AS56836 Parts TEM?above listed parts in addition to nonlisted items such as ball valves, test cocks, flange! distributors or retailers.,isting BUNAN AS5687 'h0 x 3/~" 3'4" DESCRPTON QTY. 400 Bodv Assemblv. Check Valve ncludes: replaceable brass seats AS5687 h0 x %" Seat, Replaceable Potmet Seat Assemblv ncludes: Poppet Seat Disc Washer S~rina Bonnet Assembly ncl Bonnet Seal. 0rina Test Cock Valve Assembly, Ball Upstream Valve Assembly, Ball Downstream (Whole Goods) 080 (800) 6 ~rican Backflow Specialties AS56844 lh0 x %" AS56844 lh0 x %" AS56844 '/a0 x 3/8" ~skets, etc. ar~ commercially available thrc ~gh most www. arnericanhackcjlow. corn Fax: (69) 5757
4 =F'," p e n c a n Backflow Specialties (800) 66BKFLO (69) 5755 Fax: (69) 5757 APPLCATON AND DESCRPTON MODEL 50RP The 4000 Series Reduced Pressure device prevents backflow of water in high hazard applications. t consists of two spring loaded check valves with a differential pressure valve situated between the check valves. These valves are used in irrigation systems, water service to industrial plants, hospitals, morgues, mortuaries, chemical plants, wells used for chemical or fertilizer injection, and other toxic applications Series Reduced Pressure Backflow Preventer HOW TO SPECFY FEATURES AND BENEFTS 0 Certification by USC Foundation for Cross Connection Control and Hydraulic Research. ASSE, AWWA, APMO, and City of New York. 0 Optional replaceable brass valve seats for improved serviceability. 0 Spring loaded Y check valves reduce friction loss. 0 All internal parts are easily serviceable without removing the valve body. 0 nternal sensing passages for relief valve, eliminating the damage that occurs to external tubing. Pressure rated to 75 psi and hydrostatically tested to 350 psi. Temperature rated to 80 degrees F. Corrosion resistant internal parts. 0 All test cocks are blowout resistant. OPTONS Without ball valves NBV.(l60) 0 BSPT without ball valves BSPTNBV (.55) Replaceable brass seats RS (5) PERFORMANCE CAT. MODEL SlZE N PT SZE TYPE OPTON '~uckner This specifies a W reduced pressure backflow preventer with replaceable seats. MODEL DESCRPTONS CATALOG MODEL MATERALS SlZE N PT DMENSONS inches Body: cast brass nternal assemblies: engineered polymer check valves Guides: engineered polymer Springs: stainless steel Rubber seats: BunaA or EPDM FLOW N GPM Height Width Length 075RP 00RP 5RP 50RP 00RP %" " %' %" T
5 NSTALLATON Assembly must be installed where accessible for testing and maintenance. Flush pipeline thoroughly before installation. Assembly should be installed " above grade (30" max). Consult local codes for installation requirements. When threading the device onto the line, place wrench only on the ball valve hex ends. After install, open the inlet ball valve to fill device. Bleed air from unit via the test cocks. f check valve fails PS, close ball valves, bleed test cocks, remov valve bonnet and check the seat andlor seat d fouling. Device must be protected from freezing. 6" Min. Clearance Recommended ' Min. clearance Recommended SERVCE KTS Check Valve Rubber Kit (#8 & 6) Relief Valve Repair Kit (#3,4,30,3,36, & 40) Check Valve Kit (#6,6,, & ) Ring Seal Kit (#3)* Relief Valve Kit (# & 40) Commercially Available Parts for Series 4000 Valves TEM DESCRPTON 5 0Ring Ring 0Ring Capscrew 0Ring 0Ring Bolt MATERAL BUNAN BUNAN BUNAN. BUNAN BUNAN 3/4" AS5687 /'0 x 3/s" AS5686 AS56808 lh0 x 543'' Allen AS5683 'h0 x 3/8" AS5680 lh0 x %" 5/i68x3/4 American Backflow Specialties " AS5687 '/40 x %" AS5686 AS56808 lh0 x %" Allen AS5683 %0 x?'a" AS5680 lh0 x 5/8" %68 xy4" '/4" AS56844 lh0 x 3/8 AS56836 AS /i68x 3/4" Allen AS5680 lh0 x 3/8" AS5687 lh0 x 5/8) 3/86 x %" (800) 66BKFLO (69) 5755 www. arnericanhackcjlow. corn Fax: (69) 5757 '" AS56844 lh0 x 3/8 AS56836 AS /6 8 x 3/4 Allen AS5680 '/40 x %" AS5687 lh0 x 5%" 3h6 x %" " AS56844 '/a0 x 3/8( AS56836 AS56808 i5/~~8~3/4" Allen AS5680 '/40 x 3/8 AS5687 '/a0 x %" 3/a6 x '/a'
6 T e x 6 n Backflo w Specialties. (800) 66BKFLO (69) 5755 Fax: (69) 5757 i RP Series 4000 Replacement Parts Bonnet Seal, Oring TestCock Valve Assembly, Ball Upstream Valve Assembly, Ball Downstream Body Assembly, Relief Valve ncludes: Body, Relief Valve Quil Seal, Oring, Socket Cap Washer, Nylon Relief valve Assembly, ncludes: Piston Seat Assembly, ncludes: Piston Seal Assembly Piston Seal, Oring Seat Disc Washer Cylinder Assembly Cylinder Seal, Oring Spring Button Diaphragm Bonnet Assembly, Relief Valve ncludes: Bonnet Applies to units with optional replaceable bronze seats.
7 APPLCATON AND DESCRPTON The 400 series Pressure Vacuum Breaker device is designed to prevent backflow of contaminated water into the potable water supply where back pressure is not present. The vacuum breaker may be installed under continuous pressure conditions. Pressure vacuum breakers are generally installed on potable water systems where the possibility of contamination is present. These devices are used in lawn sprinkler systems, cooling towers, laboratories, laundries, swimming pools, and industrial plant applications. Consult your local codes prior to installing any backflow prevention device. FEATURES AND BENEFTS Bronze body for strength and durability. Certification in process by USC Foundation for Cross Connection Control and Hydraulic Research, ASSE, AWWA, APMO, City of New York and CSA. Replaceable bronze valve seats for improved se&ceability. 400 Series Pressure Vacuum Breaker Backflow Preventer " to " MODEL DESCRPTONS.ODE. b DMENSONS inches BK HOW TO SPECFY T T T SZE TYPE OPTON This specifies a %" double check backflow preventer with replaceable seats. OPTONS Without ball valves (60) All internal parts are easily serviceable without removing the valve body. BSPT without ball valves (55) Pressure rated to 75 PS and hydrostatically tested to 350 PS. Temperature rated to 80 degrees F. All test cocks are blowout resistant. Minimum head loss design. Available with or without resilient seat ball valves. PERFORMANCE CAT. N MODEL 050PVB 075PVB 00PVB 5PVB 50PVB 00PVB SlZE NPT %' ' %' %' " American Backflow Specialties MATERALS Body: cast brass nternal assemblies: engineered polymer Vent poppet: engineered polymer Check valve: engineered polymer Guides: engineered polymer Springs: stainless steel Rubber seats: BunaA or EPDM (800) 66BKFLO (69) 5755 www. americanhackcjlow. coin Fax: (69) ,80 6.
8 mezh Backflo w Specialties,, (800) 66BKFLO (69) 5755 Fax: (69) NSTALLATON The PVB must be installed where accessible for testing and maintenance. Flush pipeline thoroughly before installation. The air vent must be in the vertical position Assembly should be installed " above highest outlet. Consult local codes for installation requirements. nstall the PVB where spillage will not be objectionable. After install, open the inlet ball valve to pressurize. Slowly open the outlet ball valve to pressurize the line. f check valve fails to hold PS, the unit is foul and must be disasseembled and cleaned. Device must be protected from freezing. PVB SZES " 34" " Commercially Available Parts for l/", 3/4", and " Models '''4 TEM DESCRPTON MATERAL %" 3/4" " 5 0Ring BUNAN AS5687 AS5687 AS5687 LockNut '/4"8 UNF l/'"8 UNF '/4"8 UNF Nylon Locknut Nylon Locknut Nylon Locknut 7 #03x7h" #lo3 x l/" #lo3x '/z" Phillips Phillips Phillips Round Round Round 30 Oring BUNAN AS56840 AS56840 AS56840 NOTE: The above listed parts in addition to nonlisted items such as ball valves, test cocks, flange gaskets, etc. are cornrnerc~ally available through most hardware distributors or retailers. SERVCE KTS ~~~ 3/." in Rubber Kit (#5, 8, 6, & 30) Check Valve Kit (#3 & 8) Canopy Kit (#0 & ) ,, P.V.B. Bonnet Kit (#, 4, & 30) * Applies to units with optional replaceable brass seats Parts Listing (W, W, and " Models). DESCRPTON Bodv Assemblv ncludes: Body Test Cock Replaceable Ring Seal Assembly* ncludes: Seat, Replaceable Seal. 0rina Poooet Seat Assemblv. Air nlet ncludes: Poppet Seat Disc Bonnet Assembly ncludes: Bonnet Stem. Guide Seal. 0rina Bonnet Spring, Poppet Canow Nut, Lock Guide Assembly, Check Valve ncludes: Guide Valve Seat Disc Retainer, Spring Spring, Check Ball Valve Assembly
9 Rubber Kit (#5, 8,6 & 30) Check Valve Kit (#3 & 8) Canopy Kit (#0 & ) P.V.B. Bonnet Kit (# & 30) * Applies to units with optional replaceable brass seats Commercially Available Parts for l/4", %", and " Models TEM DESCRPTON MATERAL j/4" %" " 5 0Ring BUNAN AS56844 AS56844 AS56844 Phillips Phillips screw #lo3x/" #lo3x/" #lo3x/z" :%ad R: Round Round 7 St.Steel %d'8x%" 5/6"8~%" 5/6''8~%" Phillips Phillips Phillips Round Round Round 30 0rina BUNAN AS56847 AS56847 AS Cap St.Steel %6"8x%" %6"8x'h" 5/6"8~7/8" Parts Listing ( l/q", 4, and " Models) TEM DESCRPTON QTY Body Assembly ncludes: Body 7 Test Cock 3 Replaceable Ring Seal Assembly* ncludes: 4 Seat, Replaceable 5 Seal, Oring 6 Poppet Seat Assembly, Air nlet ncludes: 7 Poppet 8 Seat Disc Bonnet Assembly ncludes: Bonnet 4 Stem, Guide 30 Seal, Oring Bonnet 8 Washer 9 Spring, Poppet 3, Cap Bonnet 6 0 Canopy, Canopy 3 3 Guide Assembly, Check Valve ncludes: 4 Guide 5 Valve 6 Seat Disc! 7 8 Retainer, Spring 9 Spring, Check 3 Ball Valve Assembly (Thandles on V" " only) American Backflow Specialties (800) 66BP 0 (69) 5755 Fax: (6 9) 5757
Backflow Preventers TABLE OF CONTENTS
backflow preventers TABLE OF CONTENTS Selection Guide........................................................................3 Double Check Valve (Series 40-100).....................................................4,5
More informationDC-501 Double Check Backflow Preventer OPERATIONS, MAINTENANCE AND TROUBLESHOOTING GUIDE
DC-501 Double Check Backflow Preventer OPERATIONS, MAINTENANCE AND TROUBLESHOOTING GUIDE Table of Contents Features, Applications and Specifications...3 Installation...4 Operation...5 Testing Procedure...6
More informationDCAP Series 40-4 X X - X X X. Dual Check w/ Atmospheric Port Backflow Preventers
Dual Check w/ Atmospheric Port DCAP Series DUAL CHECK WITH ATMOSPHERIC PORT BACKFLOW PREVENTER The Apollo DCAP Series Backflow Preventer is designed to protect residential and commercial water supply lines
More informationMaintenance Manual Reduced Pressure Assembly Models 860 & 880V 2 1 /2" 10"
IOM-F-860_880V INSTALLATION, OPERATION, MAINTENANCE Maintenance Manual Reduced Pressure Assembly Models 860 & 880V 2 1 /2" 10" 860 880V Standard Configuration 880V Vertical Configuration INDEX Vandalism..............................................
More informationMADE IN THE USA BACKFLOW PREVENTERS
MADE IN THE USA BACKFLOW PREVENTERS TABLE OF CONTENTS Selection Guide........................................................................3 Double Check Valve (Series 40-100)......................................................4,5
More information4P-300 4V-500 CONTINUOUS PRESSURE THERMOPLASTIC DUAL. PRINCIPLE (U & Z Flow) DUAL CHECK VALVE. PRINCIPLE (Stn.Steel) REDUCED PRESSURE
BFCA9000 5/01 TABLE OF CONTENTS Selection Guide................................................. 2 Double Check Valve (Series 40-100)................................. 3-8 Double Check Valve (Model DC)...................................
More informationBACKFLOW PREVENTION CATALOG
ouble Check etector Backflow Preventers CA 4SG SERIES CA 4SG SERIES OUBLE CHECK ETECTOR ASSEMBLY The Apollo CA 4SG Series ouble Check etector Assembly is designed to prevent contamination of the potable
More informationMAINTENANCE MANUAL. Covering Models: Series (1/4-10 ) S Series (1/4-1 ) Series (3-10 )
BFMM4000 1-09 MAINTENANCE MANUAL Covering Models: 40-200 Series (1/4-10 ) 40-200S Series (1/4-1 ) 40-700 Series (3-10 ) REDUCED PRESSURE PRINCIPLE (RPZ) BACKFLOW PREVENTERS 1/4" - 10" AND REDUCED PRESSURE
More informationCash-Flo. Operation & Maintenance Manual. BackFLOW PREVENTERS. A Division of the Reliance Worldwide Corporation
Cash-Flo BackFLOW PREVENTERS Operation & Maintenance Manual A Division of the Reliance Worldwide Corporation TAble of Contents Operating & Maintenance Procedures.... 3 Specification Sheet RPZ /2" - 2"....
More informationINSTALLATION, OPERATION, AND MAINTENANCE MANUAL
INSTALLATION, OPERATION, AND MAINTENANCE MANUAL MODEL 4D-200 REDUCED PRESSURE PRINCIPLE (RPZ) & MODEL 4D-700 REDUCED PRESSURE DETECTOR ASSEMBLY (RPDA) BACKFLOW PREVENTERS 2 ½ 10 Conbraco Industries Inc.
More informationBFMM DC4A SBF EFFECTIVE AUGUST 1, 2016
BACKFLOW INSTALLATION, OPERATION & MAINTENANCE MANUAL BFMM DC4A SBF EFFECTIVE AUGUST 1, 2016 Model DC4A / DCLF4A 1/2-2 Double Check Valve (DC) Backflow Preventer INSTALLATION, OPERATION, & MAINTENANCE
More informationT e n c a n Backflo w Specialties
=m, T e n c a n Backflo w Specialties. (800) 66BKFLO (619) 5272525 Fax: (619) 5272527 www.americanbackflow.com Performance is standard: Design and features incorporated into every Watts ACV means consistent,
More informationHERSEY 6CM SIZE 2 1/2", 3", 4", 6", 8", 10"
SIZE 2 1/2", 3", 4", ", 8", 10" HERSEY CM DESCRIPTION This is a reduced pressure assembly. Production began approximately in 1977 and was discontinued in 2004. The bodies are constructed of both bronze
More informationMODEL 106/206-PG POWER OPERATED GLOBE VALVE Sizes 1/2" to 8" (106-PG) 3" to 10" (206-PG) Installation, Operating and Maintenance Instructions
MODEL 106/206-PG POWER OPERATED GLOBE VALVE Sizes 1/2" to 8" (106-PG) 3" to 10" (206-PG) Installation, Operating and Maintenance Instructions DESCRIPTION: This valve is the basic component used for most
More informationMaintenance Manual Double Check and Double Check Detector Assemblies Series 850, 856, 870V & 876V 2 1 /2" - 10" (65 250mm)
IOM-F-DC/DCDA INSTALLATION, OPERATION, MAINTENANCE Maintenance Manual Double Check and Double Check Detector Assemblies Series 850, 856, 870V & 876V 2 1 /2" - 10" (65 250mm) Series 850 Series 876V Table
More informationTHIS WARRANTY IS IN LIEU
Installation, Operation, Maintenance and Parts Manual for Backflow Prevention Assemblies Double Check Valve Assembly Series 2000DCA 4" 10" Double Check Detector Assembly Series 3000DCDC 4" 10" Reduced
More informationINSTALLATION & MAINTENANCE MODEL mm
MODEL 65-25mm INSTALLATION INSTRUCTIONS CAUTION: Installation of Backflow Preventers must be performed by qualified, licensed personnel. The installer should be sure the proper device has been selected
More informationSeries 957, 957N, 957Z, 957RPDA, 957NRPDA, 957ZRPDA
Series 957, 957N, 957Z, 957RPDA, 957NRPDA, 957ZRPDA Reduced Pressure Zone Assemblies Reduced Pressure Detector Assemblies Sizes: 2 1 2" 10" (65 250mm) Installation Service Repair Kits Maintenance RP/IS-957/957RPDA
More informationBACKFLOW PREVENTION CATALOG
Pressure Vacuum Breaker Backflow Preventers PVB 4A SERIES Sizes 1/2, 3/4, 1, 1-1/4,1-1/2, 2 4A FREEZE RESISTANT PRESSURE VACUUM BREAKER The Apollo Model PVB 4A Pressure Vacuum Breakers are designed to
More informationProposition 65 Warning This product contains chemicals known to the State of California to cause cancer or birth defects or other reproductive harm.
Model RPHBM Hydrant Backflow Meter Installation Testing Maintenance Instructions CAUTION: Installation of Backflow Preventers must be performed by qualified, licensed personnel. The installer should be
More information2 ½ 12. Model RP 4A Model RPDA 4A Model RPDA2 4A. Installation, Operation, and Maintenance Manual
BFMM4ARPLBF 08/10 Model RP 4A Model RPDA 4A Model RPDA2 4A Installation, Operation, and Maintenance Manual 2 ½ 12 Reduced Pressure Principle Backflow Preventer Reduced Pressure Detector Assembly Conbraco
More informationPRESSURE REDUCING CONTROL VALVE
PRESSURE REDUCING CONTROL VALVE 06/08 Schematics Throttles to reduce high upstream pressure to constant lower downstream pressure Reducing setpoint is adjustable 2 (AOS) X P/L Standard Components 1 Main
More informationAddendum No. 1 ADDENDUM # 1
Addendum No. 1 Wicomico County Purchasing 12 N. Division St. Room B-3 Salisbury, MD 21801 Ph. 4-48-480 Fax 4-334-3130 purchasing@wicomicocounty.org Date: 9/16/1 ADDENDUM # 1 Bid: Irrigation Installation
More informationColt Series C400, C500
Colt Series C400, C500 RP/IS-A-C400/C500 C400 OSY Reduced Pressure Zone Assemblies Reduced Pressure Detector Assemblies Sizes: 2 1 2" 10" (65 250mm) Installation Service Repair Kits Maintenance For other
More informationw w w. w a t t s. c o m
w w w. w a t t s. c o m PG-Irrigation Table of Contents General Information...5 Section Backflow Preventers Double Check Valve ssemblies 007...8 79...0 757, 757N...2 775...4 709...5 Reduced Pressure Zone
More information4000SS. For other repair kits and service parts, send for Ames Repair Parts Price List, PL-A-RP-BPD.
Series 4000SS RP/IS-A-4000SS 4000SS Reduced Pressure Zone Assemblies Sizes: 8" 10" (200 250mm) Installation Service Repair Kits Maintenance For other repair kits and service parts, send for Ames Repair
More informationLaboratory Evaluation Report for: Laboratory Faucet Backflow Preventer
American Society of Sanitary Engineering Seal (Certification) Program Laboratory Evaluation Report for: Laboratory Faucet Backflow Preventer Tested under ASSE Standard 1035 Revised: April, 2008 Laboratory
More informationBackflow Preventers & Accessories
BEECO-2016 Go to beecobackflow.com for the most current product specification sheets. Backflow Preventers & Accessories LIT- 071 (Rev. 1) BEECO, Inc. 1321 West 119th Street, Chicago, Illinois 60643-5109,
More informationSECTION GENERAL-DUTY VALVES FOR PLUMBING PIPING
SECTION 22 05 23 GENERAL-DUTY VALVES FOR PLUMBING PIPING PART 1 - GENERAL 1.1 DESCRIPTION A. This section describes the requirements for general-duty valves for domestic water and sewer systems. B. A complete
More informationTHE DEFENDER 4D-200 SERIES
THE DEFENDER 4D-200 SERIES SPECIFICATIONS The Reduced Pressure Principle Assembly shall protect against backflow by either backpressure or back-siphonage from a crossconnection between potable water system
More informationLEAD FREE * PVS-7000 Engineered Flood Protection Valve Station with SentryPlus Alert
Engineering Sheet ES-PVS-7000 Job Name Contractor Job Location Approval Engineer Contractor s P.O. No. Approval Representative LEAD FREE * PVS-7000 Engineered Flood Protection Valve Station with SentryPlus
More informationMustang Series PRESSURE REDUCING CONTROL VALVE. M115 (Globe) M1115 (Angle) Schematic. Standard Components. Options & Accessories.
PRESSURE REDUCING CONTROL VALVE 02/09 Schematic Throttles to reduce high upstream pressure to constant lower downstream pressure Reducing setpoint is adjustable 2 (AOS) P/L Standard Components 1 Main Valve
More informationAwide choice of devices
Chapter Four Methods and Devices for the Prevention of Backflow and Back-Siphonage Awide choice of devices exists that can be used to prevent backsiphonage and backpressure from adding contaminated fluids
More informationLEAD FREE * LFF113RFP Flood Protection Shut Down Valve
Technical Bulletin TB-ACV-LFF11RFP LEAD FREE * LFF11RFP Flood Protection Shut Down Valve Installed upstream of Reduced Zone Backflow Preventer. Normally Open Valve - Closes when continuous discharge from
More informationPRESSURE REDUCING VALVE
Schematic Throttles to reduce high upstream pressure to constant lower downstream pressure Low Flow By-Pass controls at low flows 4 PRESSURE REDUCING VALVE with LOW-FLOW BY-PASS FEATURE Main Line valve
More informationPRESSURE REDUCING VALVE
Schematic Throttles to reduce high upstream pressure to constant lower downstream pressure Low Flow By-Pass controls at low flows 4 PRESSURE REDUCING VALVE with LOW-FLOW BY-PASS FEATURE Main Line valve
More informationPRESSURE REDUCING VALVE
Schematic Throttles to reduce high upstream pressure to constant lower downstream pressure Closes quickly when downstream pressure exceeds reduced pressure setpoint 3 PRESSURE REDUCING VALVE with SURGE
More informationCROSS-CONNECTION CONTROL MANUAL
1.1 INTRODUCTION 1.2 MATERIALS CROSS-CONNECTION CONTROL MANUAL As water purveyor, the Orange Water and Sewer Authority (OWASA) is responsible for providing safe drinking water to its customers. One way
More informationDOROT CONTROL VALVES CATALOGUE
DOROT CONTROL VALVES CATALOGUE Content SERIES 80 Globe & Angle Irrigation Valves 4 SERIES 80 80-1, 80-3/4 Turf Irrigation Valves 6 SERIES 75 Gal Plastic Valves 8 SERIES 95/96 UPVC Valves 10 Plastic Control
More information2 ½ 12. Installation, Operation, and Maintenance Manual. Reduced Pressure Principle Backflow Preventer. Reduced Pressure Detector Assembly
BFMM4ARPLBF 11/11 Model RP4A and RPLF4A Model RPDA4A and RPDALF4A Model RPDA24A and RPDA2LF4A Installation, Operation, and Maintenance Manual 2 ½ 12 Reduced Pressure Principle Backflow Preventer Reduced
More informationBEECO FLOW CONTROL
FLOW CONTROL CERTIFIED MANAGEMENT SYSTEM ISO 9001:2015 BEECO FLOW CONTROL - 2018 Go to www.mifab.com for the most current product specification sheets. Valves and Accessories LIT-085 BEECO, Inc. 1321 West
More informationLEAD FREE * LFF115 (Globe) LFF1115 (Angle)
ES-ACV-SB-LFF115_LFF1115 LEAD FREE * Pressure Reducing Control Valve Schematics Throttles to reduce high upstream pressure to constant lower downstream pressure Reducing setpoint is adjustable 2 (AOS)
More informationSECTION GENERAL-DUTY VALVES FOR PLUMBING PIPING
SECTION 22 05 23 PART 1 - GENERAL 1.1 SUMMARY A. Work Included: 1. Valves, General 2. Gate Valves 3. Balancing Valves 4. Ball Valves 5. Swing Check Valves 6. Backflow Prevention Assemblies 7. Pressure
More informationSeries 990/990RPDA. Reduced Pressure Zone Backflow Preventer. Sizes: 4", 6", 8" (100mm, 150mm, 200mm)
Series /RPDA Reduced Pressure Zone Backflow Preventer Sizes: 4", 6", 8" (100mm, 150mm, 200mm) RP/IS-/RPDA BACKFLOW PREVENTION CONTAINMENT CROSS CONNECTION CONTROL A reduced pressure zone backflow prevention
More information35 Dealing with Type II and N Pattern Assemblies Pete Chapman
35 Dealing with Type II and N Pattern Dealing with a Type II Detector Assembly Bypass Single Check An Obstruction In the Pipeline to Slow OR Divert Flow Function Mainline Non Testable single check Swing
More informationSECTION GENERAL-DUTY VALVES FOR PLUMBING PIPING
SECTION 22 05 23 SPEC WRITER NOTES: 1. Use this section only for NCA projects. 2. Delete between //----// if not applicable to project. Also delete any other item or paragraph not applicable in the section
More informationA. This Section includes the following domestic water piping specialties:
SECTION 221119 - DOMESTIC WATER PIPING SPECIALTIES PART 1 - GENERAL 1.1 SUMMARY A. This Section includes the following domestic water piping specialties: 1. Backflow preventers. 2. Water pressure-reducing
More informationLEAD FREE * LFM115 (Globe) LFM1115 (Angle)
ES-ACV-SB-LFM115_LFM1115 LEAD FREE * Pressure Reducing Control Valve Schematic Throttles to reduce high upstream pressure to constant lower downstream pressure Reducing setpoint is adjustable 2 (AOS) P/L
More information1 Air Operated Diaphragm Pump
Air Operated Diaphragm Pump Model SP00-0X-XX-XXX-X : Ratio (Non-metallic ) nstallation and Operation Manual Read this manual carefully and completely PROR to installing, operating, or servicing this equipment.
More informationBERMAD Waterworks. Pressure Relief/Sustaining Valve. Model: WW Series. Features and Benefits. Major Additional Features
Pressure Relief/Sustaining Valve Prioritizing pressure zones Ensuring controlled pipeline fill-up Preventing pipeline emptying Pump overload & cavitation protection Safeguarding pump minimum flow Excessive
More informationLaboratory Evaluation Report for: Backflow Preventer for Beverage Dispensing Equipment
American Society of Sanitary Engineering Seal (Certification) Program Laboratory Evaluation Report for: Backflow Preventer for Beverage Dispensing Equipment Tested under ASSE Standard 1022 ASSE: 2003 ANSI:
More informationSERIES 2000 TEMPERATURE REGULATOR SERIES 2000 TEMP. REGULATOR. SIZES 1/2" 2" CONTROLS -25 to 400 F
SERES 2000 TEMP. SERES 2000 TEMPERATURE APPLCATON DATA DRECT ACTNG Bottle Washing Machinery Steam Tables Plating Tanks Heating Ducts Fuel Oil Heaters Cooking Vats Water Heaters Heat Exchangers Parts Washer
More informationSeries 867 Reduced Pressure Zone Assemblies
RP/IS-F-867 INSTALLATION INSTRUCTIONS Series 867 Reduced Pressure Zone Assemblies 2 1 2" 3" (65 80mm) INDEX 867-NRS Installation Instructions....................................... 2-3 Service, Repair
More informationMARFAID Solenoid Valves
Series 125 2-Way Normally Closed Pilot Operated Diaphragm Type Bronze Construction Wide Variety of Voltages Maximum Temperature 190 F Pressure Range 5-150 psi Horizontal or Vertical Installation 1-15 4"
More informationLEAD FREE * LFF113RFP Wireless Smart Flood Protection Shut Down Valve with SentryPlus Alert Technology
Technical Bulletin TB-ACV-LFF11RFP_SentryPlus LEAD FREE * LFF11RFP Wireless Smart Flood Protection Shut Down Valve with SentryPlus Alert Technology Installed upstream of Reduced Zone Backflow Preventer.
More informationTHE WARRANTY SET FORTH HEREIN IS GIVEN EXPRESSLY AND IS THE ONLY WARRANTY GIVEN BY THE COMPANY WITH RESPECT TO THE PRODUCT.
Series 909 Reduced Pressure Zone Backflow Preventers Sizes: 3 /4" 2" (20 50mm) Installation Service Repair Kits Maintenance No. 1 1 2" shown Patent Number 4,241,752 IMPORTANT: Inquire with governing authorities
More informationDWS 41. Installation Data 44 Performance Specs DWS & DW-PRV Series
IRRIGATION Title Description Details Page Intro 3 2000 Series 4 Model 2000 Solenoid 1 3 12 Model 2000 Solenoid 4 8 15 Model 2030 Low Power Solenoid 1 3 17 Model 2030 Low Power Solenoid 4 8 19 Model 2160
More informationAMERICAN FLOW CONTROL 3-16 SERIES 2100 RESILIENT SEATED CHECK VALVE
AMERICAN FLOW CONTROL 3-16 SERIES 2100 RESILIENT SEATED CHECK VALVE CONSTRUCTION STAINLESS STEEL PIPE PLUG Allows installation of pressure gauge. STAINLESS STEEL FASTENERS Helps provide corrosion resistance.
More informationPROJECT TITLE PROJECT NO: CONTRACT TITLE GRANT NO: UNIVERSITY OF CALIFORNIA, DAVIS CITY, CALIFORNIA
The following standard specification is intended to be edited according to the specifics of the project. Brackets [ ] and areas shaded in gray [e.g. format] indicate requirements that are optional depending
More informationBackflow Prevention Products and Parts
Ames Fire & Waterworks Product Catalog Backflow Prevention Products and Parts For Fire Protection and Municipal Waterworks AmesFireWater.com Excellence Matters Specify It Since 19 Ames Fire & Waterworks
More informationSee Water Pressure Reducing Valves Catalog (PHBRWPRV) for more detailed information about the products in this section.
See Catalog (PHBRWPRV) for more detailed information about the products in this section. Water pressure reducing valves PR (36LF) Series Residential and commercial applications The Apollo 36LF pressure
More informationSECTION VALVES PART 1 -GENERAL
SECTION 1571 0 VALVES PART 3- EXECUTION General Shut-off Valves Balancing Valves Drain Valves RELATED WORK Section 15430- Plumbing Specialties Section 15450- Plumbing Equipment PART 1 -GENERAL SCOPE This
More informationFLOOD PROTECTION SHUT DOWN VALVE (3 and smaller)
FLOOD PROTECTION SHUT DOWN VALVE ( and smaller) 01/10 2 6 To Floor Drain L X JB11 4 FS99 5 Installed upstream of Reduced Zone Backflow Preventer. Normally Open Valve - Closes when discharge from RPZ Relief
More informationSee Water Pressure Reducing Valves Catalog (PHBRWPRV) for more detailed information about the products in this section.
See Catalog (PHBRWPRV) for more detailed information about the products in this section. WATER PRESSURE REDUCING VALVES PR (36LF) SERIES RESIDENTIAL AND COMMERCIAL APPLICATIONS The Apollo 36LF pressure
More informationHoffman Specialty Service Parts Catalog PARTS LIST HS-800C
Hoffman Specialty Service Parts Catalog PARTS LIST HS-800C Hoffman Specialty Table of Contents STEAM TRAPS FLOAT AND THERMOSTATIC SERIES PAGE INVERTED BUCKET SERIES PAGE C 6 B0 H B I B X 6 B 6 8 B 6 0
More informationRAM Company USA Products Line
RAM Company USA Products Line Trunnion Mounted Ball Valves Metal Seated Ball Valve 3-Way Ball Valve Jacket Ball Valve Ball Valves with Actuator Trunnion Mounted Ball Valves Main Features DOUBLE PISTON
More informationInstallation, Maintenance, & Repair Series 919 and LF919
Installation, Maintenance, & Repair Series 99 and LF99 Reduced Pressure Zone Assemblies Sizes: 4" 2" (8 50mm) RP/IS-99 Read this Manual BEFORE using this equipment. Failure to read and follow all safety
More informationEasy Riser swing check valve Models E-1 & F-1
Page 1 of 7 1. DESCRIPTION The Viking Easy Riser Swing Check Valve is a general purpose rubber-faced approved for use in fire service systems. The valve is for use in wet system risers, preaction system
More informationVALVES std $ fp $ fp $
std = standard port POLY BOLTED STAINLESS STEEL BOLTS, NUTS & WASHERS fp = full port Code No. Part No. Size Price 5143361 60540 1/2 fp $ 29.29 5143362 60541 3/4 fp $ 29.29 5143363 60542 1 std $ 29.29 5143364
More informationAppendix E Part Details for the PZ7 with Standard Bypass Valve
Appendix E Part Details for the PZ7 with Standard Bypass Valve No. Part No. Description Qty. 568 Pump case 66-X6R Rotor-shaft assembly 57 Vane 6 4 46-X Vane driver 5 9 Sideplate 44-XA Seal assbly. (Buna-N
More informationSECTION MISCELLANEOUS VALVES
SECTION 05140 - PART 1 - GENERAL 1.1 WORK OF THIS SECTION A. The WORK of this Section includes providing miscellaneous valves as indicated, complete and operable, including accessories and operators. 1.2
More informationSeries 995/995RPDA. Sizes: 3" - 6" Reduced Pressure Zone Backflow Preventer/ Reduced Pressure Detector Assemblies RP/IS-995/995RPDA
RP/IS-995/995RPDA Series 995/995RPDA Reduced Pressure Zone Backflow Preventer/ Reduced Pressure Detector Assemblies Sizes: 3" - 6" Installation Service Repair Kits Maintenance For field testing procedure,
More informationBEECO-2018 LIT mifab.com/ index.html. Distributed by:
Distributed by: http://www. mifab.com/ index.html LIT-071 BEECO, Inc. 1321 West 119 th Street, Chicago, Illinois 60643-5109, USA Toll Free 1-800-465-2736, Fax 1-773-341-3049 PRODUCT PAGE NO. PRODUCT PAGE
More informationPASSAIC COUNTY TECHNICAL INSTITUTE CCA 1422 NEW S.T.E.M. BUILDING 2017
SECTION 221119 - DOMESTIC WATER PIPING SPECIALTIES PART 1 - GENERAL 1.1 SUMMARY A. Section Includes: 1. Vacuum breakers. 2. Backflow preventers. 3. Water pressure-reducing valves. 4. Balancing valves.
More informationSECTION PIPING SPECIALTIES PART 1 GENERAL 1.1 SUMMARY
SECTION 230533 - PIPING SPECIALTIES PART 1 GENERAL 1.1 SUMMARY A. Section Includes: 1. Pressure gages. 2. Pressure gage taps. 3. Thermometers. 4. Thermometer supports. 5. Test plugs. 6. Static pressure
More informationBRASS & BRONZE VALVES
BRASS & BRONZE VALVES V200 series Cast Brass are economical general service valves. Ball valves feature chrome plated balls with teflon seats, adjustable packing glands and blowout-proof stems. V205 gate
More informationSeries 009. Reduced Pressure Zone Assemblies. Installation Service Repair Kits Maintenance. Sizes: 8 80mm. 80mm 009LF RP/IS-009-AUS
Series 009 Reduced Pressure Zone Assemblies RP/IS-009-AUS Sizes: 8 80mm Installation Service Repair Kits Maintenance For other repair kits and service parts, send for PL-RP-BPD. For technical assistance,
More informationTechnical Data TYPE A SERIES AIR ADJUSTED PILOT SPENCE ENGINEERING COMPANY, INC. 150 COLDENHAM ROAD, WALDEN, NY SD 4011 OPERATING PRINCIPLE
Technical Data SD 4011 SPENCE ENGINEERING COMPANY, INC. 150 COLDENHAM ROAD, WALDEN, NY 12586-2035 TYPE A SERIES AIR ADJUSTED PILOT PRINTED IN U.S.A. SD 4011/9504 Type A or A83 (wt 6 lb) Type A53 or A 85
More informationKunkle Models 91/218/228 liquid relief valves Safety and relief products
Cast iron liquid relief valves with bronze trim including models UL and FM approved for fire pump installations Model 228 Features Bolted bonnet allows easy inspection and servicing without removal from
More informationPRODUCT OVERVIEW. Our BDB (Bolted Body) and BW3 (Fully Welded Body) trunnion-mounted ball valves are designed and manufactured
PRODUCT OVERVIEW For over 30 years, FluoroSeal has been manufacturing and customizing a wide range of valves, and accessories for many industries including Oil & Gas, Petrochemical, Chemical, Mining, Pharmaceutical,
More informationPRESSURE RELIEF VALVE CONTROL VALVE
PRESSURE RELIEF VALVE CONTROL VALVE LEHRY Pressure Relief Valve, Sustaining or Backpressure Control Valve is designed to permitting flow when upstream pressure is above the adjustable setpoint of the control
More informationKunkle Models 91/218/228 liquid relief valves Safety and relief products
Cast iron liquid relief valves with bronze trim including models UL and FM approved for fire pump installations Model 8 Features Bolted bonnet allows easy inspection and servicing without removal from
More informationPneumatics, Automation & Control Solutions
www.baccara-geva.com 500 series hydraulic control valves 500 Series hydraulic control valves general 500 series valves are direct diaphragm closing automatic hydraulic control valves which work with line
More informationP99 Pressure Reducing Regulator
P99 Pressure Reducing Regulator Applications City / District gate operation Commercial buildings Boilers, furnace, oven Plant air service Features 5 Pilot choices for low to extra high pressure Up to 1,000
More informationTECHNICAL DATA. Q= C v P Cv = Flow Factor (GPM/1 PSI P)
1 of 9 1. DESCRIPTION The Viking 2 (DN50) is a quick-opening, differential diaphragm, flood valve with one moving part. The deluge valve is used to control water flow in deluge and preaction sprinkler
More informationELECTRIC & HYDRAULIC VALVES
ELECTRIC & HYDRAULIC VALVES G500 500 Series Hydraulic Control Valves... 72 Operating Principals..... 73 Available Models... 74 Hydraulic Performance.... 75 G500-S Hydraulic with Manual 1-1/2" - 3"....
More informationTECHNICAL DATA. Q= C v P S
1 of 9 1. DESCRIPTION The Viking Model E-1 Deluge Valve is a quick-opening, differential diaphragm, flood valve with one moving part. The deluge valve is used to control water flow in deluge and preaction
More informationPage Concealed Flush Valve (1976 on)
8T _ Series Concealed Flush Valve (16 on) 2 10 14 11 15 1 8 OSC. HANDLE 16 1 10 14 1 12 15 8 4 1 /8" PUSH BUTTON 16 5/8" PUSH BUTTON 5 " PUSH PLATE OUTLETS See Page 40 18 21 2 22 20 6 FOOT PEDAL REPAIR
More informationLB601B PARTS LIST COMPRESSORS CB-5E /06. Bulletins Needed For Complete Parts List. Gasket Set, Repair Kits and Special Tools
COMPRESSORS CB-5E-051 2011/06 LB601B PARTS LIST Serial # ID# Gasket Set, Repair Kits and Special Tools Gasket Set Buna-N & Aluminum 794099 Top End Repair Kit 794237 Includes Piston Rings & Expanders, Packing
More informationAmerican Society of Sanitary Engineering PRODUCT (SEAL) LISTING PROGRAM
American Society of Sanitary Engineering PRODUCT (SEAL) LISTING PROGRAM ASSE STANDARD #1012 - REVISED: 2009 Backflow Preventers with an Intermediate Atmospheric Vent Separate, complete laboratory evaluation
More informationBS 5163 Resilient Wedge Gate Valve
BS 516 Resilient Wedge Gate Valve BS 516 Flanged Resilient OS&Y Gate Valve, Type A, (XZ41X), /16, Gate valves serve to cut the medium flow in the piping system, widely used in the field of potable water,
More informationVALVCHEQ BACKFLOW PREVENTERS FIGURE DC03
Double check valves for medium hazard rated applications Flanged and roll grooved end connections FEATURES GENERAL APPLICATION The DC0 provides protection from both backsiphonage and backpressure of the
More informationService and Parts Manual. Minimum Filtration Required:
R GRESEN Hydraulics Model V0 Sectional Body Directional Control Valve Service and Parts Manual Maximum Operating Pressure: Minimum Filtration Required: 00 PSI ( bar) 0 Micron The information in this Service
More informationIrrigation Series. Backflow Preventers, Water Pressure Regulators, and Water Control Products for Irrigation Applications
Irrigation Series Backflow Preventers, Water Pressure Regulators, and Water Control Products for Irrigation Applications Zurn Wilkins Irrigation Series Zurn Wilkins provides control solutions for pressure
More information26 Series Stainless Steel 2-way Ball Valves
1-800-899-0553 26 Series Stainless Steel 2-way Ball Valves Users Manual Installation, Operation, & Maintenance 1. General Precaution 1.1. Material Section Material deterioration is determined by the contained
More informationNYLON & PVC VALVES MINING DIVISION PRESSURE REDUCING VALVES ENSURE DOWNSTREAM PRESSURE PVC NYLON
MINING DIVISION NYLON & PVC VALVES PRESSURE REDUCING VALVES ENSURE DOWNSTREAM PRESSURE NYLON For Gold Mines DESCRIPTION The valve maintains a preset downstream pressure, regardless of upstream pressure
More informationTitle of Presentation. Prevention Name of Person, Assistant Director
Title of Presentation Water Presentation Protection Date and Backflow Prevention Name of Person, Assistant Director Who are we? The Water Protection Workgroup is part of the Special Services Division of
More informationAUTOMATIC FLOW CONTROL VALVE. INSTRUCTIONS Installation - Operation - Inspection - Maintenance
AUTOMATIC FLOW CONTROL VALVE INSTRUCTIONS Installation - Operation - Inspection - Maintenance 4" - 36" ROSS MODEL - 42AFCV FIGURE 14A Serial #L AUTOMATIC FLOW CONTROL VALVE GLOBE FLAT SEAT STYLE ROSS VALVE
More informationDOUBLE CHECK VALVES SERIES PRODUCT CODES OPERATION MEDIUM HAZARD RATING. 20mm - 50mm FEATURES APPLICATION SPECIFICATION STATEMENT DESCRIPTION
PRODUCT CODES DCV20DO DCV25DO DCV32DO DCV40DO DCV50DO DCV20 DCV25 DCV32 DCV40 DCV50 20mm Double Check Valve - Device Only 25mm Double Check Valve - Device Only 32mm Double Check Valve - Device Only 40mm
More informationVELAN TRUNNION-MOUNTED
VELAN TRUNNION-MOUNTED Velan s standard trunnion-mounted ball valves offer increased value by incorporating advanced design features. TRUNNION-MOUNTED BALL The ball is fixed and the seat rings are floating,
More information