ELECTRONIC FUEL INJECTION

Size: px
Start display at page:

Download "ELECTRONIC FUEL INJECTION"

Transcription

1 Table of Contents ELECTRONIC FUEL INJECTION Section 3B - Troubleshooting and Diagnostics TROUBLESHOOTING AND DIAGNOSTICS Specifications B-1 Special Tools B-2 Control and Function B-3 EFI System Diagnostic Procedures B-3 Pressure Regulator Test B-3 Mechanical Fuel Pump Test B-4 Injector Operation Test B-5 Fail Safe Function Table B-6 Self-Diagnosis B-7 Diagnosis Code Information B-7 Diagnosis of Electronic Control System.. 3B-7 Diagnostic Code Chart B-10 3 B Specifications FUEL SYSTEM FUEL INJECTION Fuel Pump Type Fuel Pump: Discharge (@ 3000 rpm) Pressure (Maximum) Plunger Stroke Fuel Tank Capacity Fuel Injection System Idle rpm (In Neutral) Warm Idle rpm (In Forward Gear) Warm Fuel 1500rpm External (Plunger/Diaphragm) 65 L/h (17 gph) 49 kpa (7 psi) mm ( in.) Accessory Batch (1 & 4) - (2 & 3) 750 ± 50 rpm 700 ± 50 rpm kpa (41-44 psi) R02 APRIL 2003 Page 3B-1

2 TROUBLESHOOTING AND DIAGNOSTICS Special Tools 1. Fuel Pressure Gauge A7 or Fuel Pressure Gauge A A7 2. Mityvac vacuum gauge (obtain locally) A3 3. Malfunction Indicator Lamp 99056A1 or Diagnostic Lamp A A A Page 3B R02 APRIL 2003

3 Control and Function TROUBLESHOOTING AND DIAGNOSTICS Ignition Timing Fuel Injection Timing Air/Fuel Control Function Crank Position Sensor Detects the crankshaft position and engine speed Throttle Position Sensor Detects the open degree of the throttle valve Water Temperature Sensor Detects engine temperature Manifold Absolute Pressure (MAP) Sensor Intake Air Temperature Sensor Detects intake air pressure of the intake manifold Detects intake air temperature Shift Position Switch Determines the shift position. (Neutral: ON, Forward or Reverse: OFF) Oil Pressure Switch Detects Oil Pressure EFI System Diagnostic Procedures Pressure Regulator Test 1. Install the fuel pressure gauge onto the pressure check valve (located on top of the fuel rail). 2. Start the engine. Fuel pressure should be within specification. a b c A7 a - Fuel pressure gauge b - Pressure check valve c - Pressure regulator R02 APRIL 2003 Page 3B-3

4 TROUBLESHOOTING AND DIAGNOSTICS Mechanical Fuel Pump Test NOTE: Do not over-pressurize the fuel pump. Excessive pressure may cause air to leak out. 1. Install the Mityvac onto the fuel pump as shown. 2. Test 1: Pressurize the fuel pump to 50 kpa (7psi). Fuel pump should hold this amount of pressure. Perform this test on input and output side of fuel pump. 3. Test 2: Apply 14 kpa (4 in. Hg) vacuum to fuel pump. Fuel pump should hold this amount of vacuum. a Test 1 b Test 1 Test 2 a - Fuel pump b - Mityvac Page 3B R02 APRIL 2003

5 Injector Operation Test TROUBLESHOOTING AND DIAGNOSTICS 1. Start the engine. Fully close the throttle valves. 2. Hold the screwdriver so it is making contact with the fuel injector body. The fuel injector should have a solenoid valve operating sound. Verify this on all injectors. IMPORTANT: If no sound is coming from the injector then no fuel is being sprayed. Verify the high pressure fuel pump is operating properly. a b a - Screwdriver b - Fuel injector (4) NOTE: Refer to Section 2A for testing of the Throttle Position Sensor and Engine Temperature Sensor R02 APRIL 2003 Page 3B-5

6 TROUBLESHOOTING AND DIAGNOSTICS Fail Safe Function Table Symptoms Abnormal signal from crank position sensor Abnormal signal from throttle position sensor Abnormal signal from Manifold Absolute Pressure (MAP) sensor Abnormal signal from water temperature sensor Abnormal signal from intake air temperature sensor Abnormal signal from engine stop switch FAIL SAFE FUNCTION Ignition Fuel Injection IAC Engine Conditions Four cylinder ignition is fixed at 4 ATDC When throttle opening angle is less than -10 or more than 100 : Ignition is fixed at 10 BTDC When the intake air pressure is less than 13 kpa (1.9 psi) or more than 100 kpa (17.4 psi): Ignition is fixed at 10 BTDC When less than 0.1 V or more than 4.52 V are detected (substitutes the intake air temperature sensor): Ignition is fixed at 10 BTDC When less than 0.1 V or more than 4.52 V are detected (the intake air temperature sensor is fixed at 4 : Ignition is fixed at 10 BTDC On is detected Ignition is cut Cylinders with no input signal will be stopped When the throttle opening angle is less than -10 or more than 100 : Injection is controlled only by the boost map When the intake air pressure is less than 13 kpa (1.9 psi) or more than 100 kpa (17.4 psi): Injection is controlled with throttle opening map When less than 0.1 V or more than 4.52 V are detected (substitutes the intake air temperature sensor): Normal Operation When less than 0.1 V or more than 4.52 V are detected (the intake air temperature sensor is fixed at 4 : Normal Operation On is detected Ignition is cut 900 rpm 900 rpm 900 rpm 900 rpm 900 rpm IAC is stopped Engine idling speed increases. Top speeds cannot be reached. Engine idling speed increases. Top speeds cannot be reached. Engine idling speed increases. Top speeds can be reached. Engine idling speed increases. Top speeds can be reached. Engine idling speed increases. Top speed can be reached. Engine is stopped. Shift switch open 900 rpm Engine idling speed increases. Top speeds can be reached. Page 3B R02 APRIL 2003

7 Self-Diagnosis TROUBLESHOOTING AND DIAGNOSTICS Diagnosis Code Information 1. Normal condition (no defective part or irregular processing is found). Single flash is given every 5 seconds. a. Light on, 0.33 second b. Light off, 5 seconds 2. Trouble code indication. Example: The illustration indicates code number 23. a. Light on, 0.33 second b. Light off, 0.33 second c. Light off, 1.65 seconds d. Light off, 5 seconds. Diagnosis of the Electronic Control System 1. Remove wire connector test plug cap R02 APRIL 2003 Page 3B-7

8 TROUBLESHOOTING AND DIAGNOSTICS 2. Install Malfunction Indicator Lamp a. Model Year 2001 and Prior Install Malfunction Indicator Lamp (MIL) p/n 99056A1, or create your own test light. (1.) Remove rubber plugs from engine harness bullet connectors. (2.) Connect leads of the Malfunction Indicator Lamp (MIL) p/n 99056A1 to the engine harness connectors. RED/BLACK 99056A1 BLUE/WHITE NOTE: When performing this diagnosis, all of the electrical wires must be properly connected. BLUE/WHITE RED/BLACK Page 3B R02 APRIL 2003

9 b. Model Year 2002 and Newer Install Malfunction Indicator Lamp (MIL) p/n A1. TROUBLESHOOTING AND DIAGNOSTICS NOTE: This new service tool must be used on 2002 model year product. The new tool consists of the previous diagnostic lamp 99056A1 and an additional harness with a 3 pin terminal connector. (1.) Remove rubber plug from engine harness bullet connector. (2.) Connect the harness terminal to the diagnostic test terminal. (3.) Connect the lamp wire bullet terminal to the BLUE/WHITE wire bullet terminal on the engine harness. a b c d a - Lamp wire b - Lamp wire c - GREEN/RED wire (not used) d - Harness terminal a b a - Harness terminal b - Bullet terminal R02 APRIL 2003 Page 3B-9

10 TROUBLESHOOTING AND DIAGNOSTICS 3. Check diagnosis codes (reference chart) a. Code 1 is indicated - normal b. Code indicated - Check the applicable parts. c. Code indicated - Microcomputer processing information. CHECKING STEPS 1. Start the engine and let it idle. 2. Check the malfunction indicator lamp s flash pattern to determine if there are any malfunctions. Diagnostic Code Chart NOTE: The ignition key must be returned to the OFF position for 5 seconds to clear a corrected failure code. NOTE: When more than one problem is detected, the malfunction indicator lamp light flashes in the pattern of the lowest numbered problem. After that problem is corrected and the failure code is cleared, the lamp flashes in the pattern of the next lowest numbered problem. This continues until all of the problems are detected and corrected. Code Symptoms 13 Incorrect crank position sensor input signal 15 Incorrect engine cooling water temperature sensor input signal 18 Incorrect throttle position sensor input signal 19 Incorrect battery positive voltage 23 Incorrect intake air temperature sensor input signal 28 Incorrect shift position switch 29 Incorrect manifold air pressure sensor input signal (out of normal operating range) (33) Ignition timing is being slightly corrected (when starting a cold engine) (37) Intake passage air leakage (44) Engine stop switch control operating Page 3B R02 APRIL 2003

11 DIAGNOSIS/CORRECTION COMPLETED 1. Remove Malfunction Indicator Lamp (MIL). 2. Reinstall rubber plugs in engine harness bullet connectors. 3. Reinstall connector test plug cap. TROUBLESHOOTING AND DIAGNOSTICS a a - Plug cap R02 APRIL 2003 Page 3B-11

12

G - TESTS W/CODES - 2.2L

G - TESTS W/CODES - 2.2L G - TESTS W/CODES - 2.2L 1994 Toyota Celica 1994 ENGINE PERFORMANCE Toyota 2.2L Self-Diagnostics Celica INTRODUCTION If no faults were found while performing F - BASIC TESTING, proceed with self-diagnostics.

More information

FUEL 13-1 CONTENTS MULTIPOINT INJECTION (MPI)... 2 FUEL SUPPLY ON-VEHICLE SERVICE GENERAL SERVICE SPECIFICATIONS... 4 SEALANT...

FUEL 13-1 CONTENTS MULTIPOINT INJECTION (MPI)... 2 FUEL SUPPLY ON-VEHICLE SERVICE GENERAL SERVICE SPECIFICATIONS... 4 SEALANT... 13-1 FUEL CONTENTS MULTIPOINT INJECTION (MPI)....... 2 GENERAL............................... 2 Outline of Change......................... 2 SERVICE SPECIFICATIONS.............. 4 SEALANT...............................

More information

1. Connect the Honda PGM Tester or an OBD II scan tool to the 16P Data Link Connector (DLC) located behind the right side of the center console.

1. Connect the Honda PGM Tester or an OBD II scan tool to the 16P Data Link Connector (DLC) located behind the right side of the center console. Troubleshooting Procedures I. How To Begin Troubleshooting When the Malfunction indicator Lamp (MIL) has been reported on, or there is a driveability problem, use the appropriate procedure below to diagnose

More information

DTC P1415 Secondary Air Injection (AIR) System Bank 1

DTC P1415 Secondary Air Injection (AIR) System Bank 1 Page 1 of 5 2000 GMC Truck GMC K Sierra - 4WD Sierra, Silverado, Suburban, Tahoe, Yukon (VIN C/K) Service Manual Document ID: 546887 DTC P1415 Secondary Air Injection (AIR) System Bank 1 Circuit Description

More information

ON-VEHICLE INSPECTION

ON-VEHICLE INSPECTION Last Modified: 4-26-2007 Service Category: Engine/Hybrid System 1.6 G Section: Engine Mechanical Model Year: 2007 Model: 4Runner Doc ID: RM0000017L8004X Title: 1GR-FE ENGINE MECHANICAL: ENGINE: ON-VEHICLE

More information

5. Control System CONTROL SYSTEM FUEL INJECTION (FUEL SYSTEM) A: GENERAL FU(H4DOTC)-29

5. Control System CONTROL SYSTEM FUEL INJECTION (FUEL SYSTEM) A: GENERAL FU(H4DOTC)-29 W1860BE.book Page 29 Tuesday, January 28, 2003 11:01 PM 5. Control System A: GENERAL The ECM receives signals from various sensors, switches, and other control modules. Using these signals, it determines

More information

SPN 106. Suspect Parameter Number (SPN) and Failure Mode Indicator (FMI) Description

SPN 106. Suspect Parameter Number (SPN) and Failure Mode Indicator (FMI) Description SPN 106 Suspect Parameter Number (SPN) and Failure Mode Indicator (FMI) Description SPN FMI Description Possible Causes 106 3 MAP Sensor Signal Voltage High Open/high resistance in low reference circuit

More information

DTC P0172 Fuel Trim System Rich

DTC P0172 Fuel Trim System Rich Page 1 of 6 1997 Chevrolet Cavalier Cavalier, Sunfire (VIN J) Service Manual Document ID: 47788 DTC P0172 Fuel Trim System Rich System Description A Closed Loop air/fuel metering system is used to provide

More information

5. Engine Control Module (ECM) I/O Signal

5. Engine Control Module (ECM) I/O Signal 5. A: ELECTRICAL SPECIFICATION B134 B135 B136 B137 17 16 15 14 13 12 11 10 9 8 27 26 25 24 23 22 21 20 19 18 34 33 32 31 30 29 28 19 18 17 16 15 14 13 12 11 10 9 8 27 26 25 24 23 22 21 20 35 34 33 32 31

More information

DTC P0171, P0172, P0174, or P0175

DTC P0171, P0172, P0174, or P0175 Page 1 of 6 2009 Pontiac G8 G8 Service Manual Document ID: 2076050 DTC P0171, P0172, P0174, or P0175 Diagnostic Instructions Perform the Diagnostic System Check - Vehicle prior to using this diagnostic

More information

The following flow charts and schematics are courtesy of General Motors Corp. Chart No. No Malfunction Indicator Lamp (MIL)

The following flow charts and schematics are courtesy of General Motors Corp. Chart No. No Malfunction Indicator Lamp (MIL) Page 1 of 13 DIAGNOSTIC CHARTS NOTE: The following flow charts and schematics are courtesy of General Motors Corp. DIAGNOSTIC CHARTS Malfunction (1) Chart No. No Malfunction Indicator Lamp (MIL) (2) A1-1

More information

Evaporative Emission Control System Operation Description (Enhanced)

Evaporative Emission Control System Operation Description (Enhanced) Page 1 of 7 1999 Chevrolet Chevy Suburban - 2WD Escalade, Pickup (Classic), Suburban, Tahoe, Yukon (VIN C/K) Service Manual Document ID: 222842 Evaporative Emission Control System Operation Description

More information

MULTIPOINT FUEL INJECTION (MPI) <4G9>

MULTIPOINT FUEL INJECTION (MPI) <4G9> MULTIPOINT FUEL INJECTION (MPI) 13C-1 MULTIPOINT FUEL INJECTION (MPI) CONTENTS GENERAL................................. 2 Outline of Changes............................ 2 GENERAL INFORMATION...................

More information

DTC P1223, P1226, P1229, P1232, P1235, P1238, P1241, or P1244

DTC P1223, P1226, P1229, P1232, P1235, P1238, P1241, or P1244 Page 1 of 5 005 Chevrolet Kodiak C-Series (Conventional) C/C5 Kodiak, TopKick C-Series Service Manual Document ID: 16600 DTC P13, P16, P1, P13, P135, P138, P11, or P1 Circuit Description The engine control

More information

13A-1 FUEL CONTENTS MULTIPOINT FUEL INJECTION (MPI) FUEL SUPPLY... 13B

13A-1 FUEL CONTENTS MULTIPOINT FUEL INJECTION (MPI) FUEL SUPPLY... 13B 13A-1 FUEL CONTENTS MULTIPOINT FUEL INJECTION (MPI)... 13A FUEL SUPPLY... 13B 13A-2 MULTIPOINT FUEL INJECTION (MPI) CONTENTS GENERAL INFORMATION... 3 SERVICE SPECIFICATIONS... 6 SEALANT... 6 SPECIAL TOOLS...

More information

Honda Accord/Prelude

Honda Accord/Prelude Honda Accord/Prelude 1984-1995 In Tank Fuel Pumps TEST 1. Turn the ignition OFF. 2. On the Accord, remove the screws securing the underdash fuse box to its mount. Remove the fuel cut off relay from the

More information

DTC P0174 Fuel Trim System Lean Bank 2

DTC P0174 Fuel Trim System Lean Bank 2 2000 Chevrolet/Geo S10 Pickup - 4WD DTC P0174 Fuel Trim System Lean Bank 2 Circuit Description In order to provide the best possible combination of driveability, fuel economy, and emission control, the

More information

2002 ENGINE PERFORMANCE. Self-Diagnostics - RAV4. Before performing testing procedures, check for any related Technical Service Bulletins (TSBs).

2002 ENGINE PERFORMANCE. Self-Diagnostics - RAV4. Before performing testing procedures, check for any related Technical Service Bulletins (TSBs). 2002 ENGINE PERFORMANCE Self-Diagnostics - RAV4 INTRODUCTION NOTE: Before performing testing procedures, check for any related Technical Service Bulletins (TSBs). To properly diagnosis and repair this

More information

Fuel System Diagnosis

Fuel System Diagnosis Page 1 of 6 2001 Chevrolet Malibu Malibu (VIN N) Service Manual Engine Engine Controls - 3.1L (LG8) Diagnostic Information and Procedures Document ID: 704675 Fuel System Diagnosis System Description When

More information

TEST CHART. Voltage Supply

TEST CHART. Voltage Supply ALL MEASUREMENTS ARE MADE ON THE TERMINALS OF THE DISCONNECTED WIRING HARNESS PLUG TO THE CONTROL UNIT (ECU) WITH IGNITION OFF UNLESS OTHERWISE INDICATED. Voltage Supply Ignition Voltage supply to the

More information

INTAKE AND EXHAUST GROUP CONTENTS GENERAL INFORMATION SERVICE SPECIFICATION AIR CLEANER

INTAKE AND EXHAUST GROUP CONTENTS GENERAL INFORMATION SERVICE SPECIFICATION AIR CLEANER 15-1 GROUP 15 INTAKE AND EXHAUST CONTENTS GENERAL INFORMATION 15-2 SERVICE SPECIFICATION 15-2 DIAGNOSIS 15-2 INTRODUCTION 15-2 TROUBLESHOOTING STRATEGY 15-2 SYMPTOM CHART 15-2 SYMPTOM PROCEDURES 15-3 SPECIAL

More information

5. Engine Control Module (ECM) I/O Signal

5. Engine Control Module (ECM) I/O Signal 5. Engine Control Module (ECM) I/O Signal A: ELECTRICAL SPECIFICATION B134 B135 B136 B137 17 16 15 14 13 12 11 10 9 8 27 26 25 24 23 22 21 20 19 18 34 33 32 31 30 29 28 19 18 17 16 15 14 13 12 11 10 9

More information

A: ENGINE CONTROL MODULE (ECM) I/O SIGNAL FOR MT VEHICLES. Signal (V) Ignition SW ON (Engine OFF) B B B

A: ENGINE CONTROL MODULE (ECM) I/O SIGNAL FOR MT VEHICLES. Signal (V) Ignition SW ON (Engine OFF) B B B 5. Specified Data A: ENGINE CONTROL MODULE (ECM) I/O SIGNAL FOR MT VEHICLES B2M2267A Crankshaft Camshaft Throttle Rear oxygen Front oxygen (A/F) heater Rear oxygen heater Engine coolant temperature Signal

More information

DIAGNOSIS SYSTEM DESCRIPTION EG2 170

DIAGNOSIS SYSTEM DESCRIPTION EG2 170 EG2170 DIAGNOSIS SYSTEM DESCRIPTION The ECM contains a builtin self diagnosis system by which troubles with the engine signal network are detected and a malfunction indicator lamp on the combination meter

More information

DIAGNOSTIC TROUBLE CODE CHART

DIAGNOSTIC TROUBLE CODE CHART DI158 DIAGNOSTIC TROUBLE CODE CHART HINT: ENGINE (2JZGTE) Parameters listed in the chart may not be exactly the same as your reading due to the type of instrument or other factors. If a malfunction code

More information

EG1 189 EFI SYSTEM 5S FE ENGINE DIAGNOSIS SYSTEM

EG1 189 EFI SYSTEM 5S FE ENGINE DIAGNOSIS SYSTEM 5SFE ENGINE EG1189 DIAGNOSIS SYSTEM DESCRIPTION The ECU contains a builtin selfdiagnosis system by which troubles with the engine signal network are detected and a CHECK engine warning light on the combination

More information

5. Control System CONTROL SYSTEM FUEL INJECTION (FUEL SYSTEM) A: GENERAL. FU(STi)-27

5. Control System CONTROL SYSTEM FUEL INJECTION (FUEL SYSTEM) A: GENERAL. FU(STi)-27 W1860BE.book Page 27 Tuesday, January 28, 2003 11:01 PM 5. Control System A: GENERAL The ECM receives signals from various sensors, switches, and other control modules. Using these signals, it determines

More information

DIAGNOSIS SYSTEM DESCRIPTION

DIAGNOSIS SYSTEM DESCRIPTION EFI SYSTEM FI21 DIAGNOSIS SYSTEM DESCRIPTION The ECU contains a builtin selfdiagnosis system by which troubles with the engine signal network are detected and a CHECK engine warning light on the instrument

More information

DIAGNOSIS SYSTEM DESCRIPTION CHECK ENGINE WARNING LIGHT CHECK

DIAGNOSIS SYSTEM DESCRIPTION CHECK ENGINE WARNING LIGHT CHECK FI146 EFI SYSTEM (3VZE) DIAGNOSIS SYSTEM DESCRIPTION The engine (engine and ECT) ECU contains a builtin, selfdiagnosis system which detects troubles within the engine signal network and flashes the warning

More information

Fuel System Diagnosis

Fuel System Diagnosis Page 1 of 6 2001 Chevrolet Express Express, Savana (VIN G) Service Manual Engine Engine Controls - 5.0L and 5.7L Diagnostic Information and Procedures Document ID: 720867 Fuel System Diagnosis Circuit

More information

DTC 51 Switch Condition Signal Circuit

DTC 51 Switch Condition Signal Circuit EG614 EINE TROUBLESHOOTI DT 51 Switch ondition Signal ircuit IRUIT DESRIPTION Park/Neutral Position Switch Signal The EM uses the signals from the Park/neutral position switch to determine whether the

More information

DTC P0300-P0308. Diagnostic Instructions. DTC Descriptors. Circuit/System Description. Conditions for Running the DTC

DTC P0300-P0308. Diagnostic Instructions. DTC Descriptors. Circuit/System Description. Conditions for Running the DTC Page 1 of 5 2009 GMC Truck Sierra - 2WD Sierra, Silverado (VIN C/K) Service Manual Engine Engine Mechanical - 4.8L, 5.3L, 6.0L, 6.2L, or 7.0L Description and Operation DTC P0300-P0308 Diagnostic Instructions

More information

Diag. Code 71 EGR System Malfunction CIRCUIT DESCRIPTION. TR-92 ENGINE TROUBLESHOOTING - Circuit Inspection

Diag. Code 71 EGR System Malfunction CIRCUIT DESCRIPTION. TR-92 ENGINE TROUBLESHOOTING - Circuit Inspection TR-92 EINE TROUBLESHOOTI - Circuit Inspection Diag. Code 71 EGR System Malfunction CIRCUIT DESCRIPTION The EGR system is designed to recirculate the exhaust gas properly controlled according to the driving

More information

GROUP 17 CONTENTS WARNINGS REGARDING SERVICING OF SUPPLEMENTAL RESTRAINT SYSTEM (SRS) EQUIPPED VEHICLES

GROUP 17 CONTENTS WARNINGS REGARDING SERVICING OF SUPPLEMENTAL RESTRAINT SYSTEM (SRS) EQUIPPED VEHICLES 17-1 GROUP 17 CONTENTS ENGINE CONTROL 17-4 GENERAL DESCRIPTION 17-4 ENGINE CONTROL SYSTEM DIAGNOSIS 17-4 INTRODUCTION TO ENGINE CONTROL SYSTEM DIAGNOSIS 17-4 ENGINE CONTROL SYSTEM DIAGNOSTIC TROUBLESHOOTING

More information

Powertrain DTC Summaries OBD II

Powertrain DTC Summaries OBD II Powertrain DTC Summaries Quick Reference Diagnostic Guide Jaguar X-TYPE 2.5L and 3.0L 2002 Model Year Revised January, 2002: P0706, P0731, P0732, P0733, P0734, P0735, P0740, P1780 POSSIBLE CAUSES Revised

More information

G - TESTS W/CODES Nissan 240SX * PLEASE READ THIS FIRST * INTRODUCTION SELF-DIAGNOSTIC SYSTEM DESCRIPTION HARD FAILURES INTERMITTENT FAILURES

G - TESTS W/CODES Nissan 240SX * PLEASE READ THIS FIRST * INTRODUCTION SELF-DIAGNOSTIC SYSTEM DESCRIPTION HARD FAILURES INTERMITTENT FAILURES G - TESTS W/CODES 1990 Nissan 240SX 1990 ENGINE PERFORMANCE Self-Diagnostics Nissan 240SX and Axxess * PLEASE READ THIS FIRST * NOTE: This article has been revised according to Technical Service Bulletin

More information

A rotary solenoid type ISC system is used, which controls the fast idle and idle speeds.

A rotary solenoid type ISC system is used, which controls the fast idle and idle speeds. 44 ENGINE 5S FE ENGINE ENGINE CONTROL SYSTEM 1. General Basic functions of the engine control system of the new 5S FE engine for the new Camry are the same as those in the 5S FE engine for the 90 model

More information

H - TESTS W/O CODES Nissan 240SX INTRODUCTION TROUBLE SHOOTING SYMPTOMS DIAGNOSIS WILL NOT START

H - TESTS W/O CODES Nissan 240SX INTRODUCTION TROUBLE SHOOTING SYMPTOMS DIAGNOSIS WILL NOT START H - TESTS W/O CODES 1990 Nissan 240SX 1990 ENGINE PERFORMANCE Trouble Shooting - No Codes Nissan; 240SX, Axxess, Maxima, Pathfinder, Pickup, Pulsar, Sentra, Van, INTRODUCTION Before diagnosing symptoms

More information

ENGINE CONTROL SYSTEM. 1. General ENGINE 3VZ FE ENGINE

ENGINE CONTROL SYSTEM. 1. General ENGINE 3VZ FE ENGINE ENGINE 3VZ FE ENGINE 69 ENGINE CONTROL SYSTEM 1. General The engine control system for the 3VZ FE engine has the same basic construction and operation as for the 2VZ FE engine. However, the sequential

More information

Miata - Workshop Manual - Engine

Miata - Workshop Manual - Engine Page 1 of 8 2003 - Miata - Workshop Manual - Engine NO.6 CRANKS NORMALLY BUT WILL NOT START 6 Cranks normally but will not start Starter cranks engine at normal speed but engine will not run. DESCRIPTION

More information

DTC P0102 Mass Air Flow (MAF) Sensor Circuit Low Frequency

DTC P0102 Mass Air Flow (MAF) Sensor Circuit Low Frequency Page 1 of 5 1997 Pontiac Grand Prix Grand Prix (VIN W) Service Manual Engine Engine Controls - 3.8L Diagnostic Information and Procedures Document ID: 106986 DTC P0102 Mass Air Flow (MAF) Sensor Circuit

More information

Service Bulletin. Rough Idle at Cold Start; MIL Comes On With DTC P0107 or P0108 (Supersedes , dated March 5, 2004)

Service Bulletin. Rough Idle at Cold Start; MIL Comes On With DTC P0107 or P0108 (Supersedes , dated March 5, 2004) Applies To: 1998 02 Accord V6 ALL 1996 00 Civic DX, LX ALL 1999 00 Odyssey ALL Service Bulletin 04-004 August 10, 2004 Rough Idle at Cold Start; MIL Comes On With DTC P0107 or P0108 (Supersedes 04-004,

More information

GROUP 13Ab. 13Ab-2 CONTENTS TROUBLESHOOTING STRATEGY.. DATA LIST REFERENCE TABLE... 13Ab-28 TROUBLE CODE DIAGNOSIS...

GROUP 13Ab. 13Ab-2 CONTENTS TROUBLESHOOTING STRATEGY.. DATA LIST REFERENCE TABLE... 13Ab-28 TROUBLE CODE DIAGNOSIS... 13Ab-1 GROUP 13Ab CONTENTS TROUBLESHOOTING STRATEGY.. 13Ab-2 DATA LIST REFERENCE TABLE... 13Ab-28 TROUBLE CODE DIAGNOSIS..... 13Ab-2 FAIL-SAFE/BACKUP FUNCTION TABLE........................ 13Ab-20 DIAGNOSTIC

More information

5. Engine Control Module (ECM) I/O Signal S008526

5. Engine Control Module (ECM) I/O Signal S008526 5. Engine Control Module (ECM) I/O Signal S008526 A: ELECTRICAL SPECIFICATION S008526A08 1. MT VEHICLES S008526A0801 B2M2267A Crankshaft Camshaft Throttle Rear oxygen Front oxygen (A/F) heater Rear oxygen

More information

NEW FEATURES 3E E ENGINE. 1. Description 12 TERCEL NEW FEATURES

NEW FEATURES 3E E ENGINE. 1. Description 12 TERCEL NEW FEATURES 12 TERCEL NEW FEATURES NEW FEATURES 3E E ENGINE 1. Description The 3E E engine is based on the 1.5 liter, 12 valve, OHC 3E engine, but with fuel injection, ignition timing and other engine functions controlled

More information

Intake Manifold Tuning (IMT)

Intake Manifold Tuning (IMT) Page 1 of 11 24-154 Intake Manifold Tuning (IMT) system Notes: The change-over of the manifold from long to short intake path occurs at approx. 4500 RPM. Component location page 24-1 Required special tools

More information

ENGINE 01 02A 1. Toc of SCT ON-BOARD DIAGNOSTIC [ENGINE. Toc of SCT 01 02A ON-BOARD DIAGNOSTIC [ENGINE CONTROL SYSTEM (ZM)] 01 02A

ENGINE 01 02A 1. Toc of SCT ON-BOARD DIAGNOSTIC [ENGINE. Toc of SCT 01 02A ON-BOARD DIAGNOSTIC [ENGINE CONTROL SYSTEM (ZM)] 01 02A ENGINE 01 SECTION Toc of SCT ON-BOARD DIAGNOSTIC [ENGINE CONTROL SYSTEM (ZM)]...01-02A ON-BOARD DIAGNOSTIC [ENGINE CONTROL SYSTEM (FS)]...01-02B ON-BOARD DIAGNOSTIC [CRUISE CONTROL SYSTEM].......01-02C

More information

D - ADJUSTMENTS Article Text 1992 Dodge Colt For a a a a a Copyright 1998 Mitchell Repair Information Company, LLC Saturday, April 27, :46PM

D - ADJUSTMENTS Article Text 1992 Dodge Colt For a a a a a Copyright 1998 Mitchell Repair Information Company, LLC Saturday, April 27, :46PM Article Text ARTICLE BEGINNING 1992 ENGINE PERFORMANCE Chrysler Motors/Mitsubishi On-Vehicle Adjustments Dodge; Colt, Colt 200 Eagle; Summit Mitsubishi: Mirage Plymouth; Colt, Colt 200 ENGINE MECHANICAL

More information

INTAKE AND EXHAUST GROUP CONTENTS CHARGE AIR COOLER <2.0L ENGINE> GENERAL DESCRIPTION SERVICE SPECIFICATIONS...

INTAKE AND EXHAUST GROUP CONTENTS CHARGE AIR COOLER <2.0L ENGINE> GENERAL DESCRIPTION SERVICE SPECIFICATIONS... 15-1 GROUP 15 INTAKE AND EXHAUST CONTENTS GENERAL DESCRIPTION 15-2 SERVICE SPECIFICATIONS 15-2 DIAGNOSIS 15-2 INTRODUCTION 15-2 TROUBLESHOOTING STRATEGY 15-2 SYMPTOM CHART 15-2 SYMPTOM PROCEDURES 15-3

More information

DTC P0100 MASS OR VOLUME AIR FLOW CIRCUIT DTC P0102 MASS OR VOLUME AIR FLOW CIRCUIT LOW INPUT DTC P0103 MASS OR VOLUME AIR FLOW CIRCUIT HIGH INPUT

DTC P0100 MASS OR VOLUME AIR FLOW CIRCUIT DTC P0102 MASS OR VOLUME AIR FLOW CIRCUIT LOW INPUT DTC P0103 MASS OR VOLUME AIR FLOW CIRCUIT HIGH INPUT 0564 DIAGNOSTICS DTC P0100 MASS OR VOLUME AIR FLOW CIRCUIT 059VF10 DTC P0102 MASS OR VOLUME AIR FLOW CIRCUIT LOW INPUT DTC P0103 MASS OR VOLUME AIR FLOW CIRCUIT HIGH INPUT CIRCUIT DESCRIPTION The MAF (Mass

More information

01 02B ON-BOARD DIAGNOSTIC [ENGINE CONTROL SYSTEM (FS)]

01 02B ON-BOARD DIAGNOSTIC [ENGINE CONTROL SYSTEM (FS)] ON-BOARD DIAGNOSTIC [ENGINE CONTROL SYSTEM (FS)] CONTROL SYSTEM WIRING DIAGRAM [FS]............................ 2 CONTROL SYSTEM DEVICE AND CONTROL RELATIONSHIP CHART [FS]........ 4 Engine Control System............

More information

SERVICE MANUAL. Common Rail System for HINO J08C/J05C Type Engine Operation. For DENSO Authorized ECD Service Dealer Only

SERVICE MANUAL. Common Rail System for HINO J08C/J05C Type Engine Operation. For DENSO Authorized ECD Service Dealer Only For DENSO Authorized ECD Service Dealer Only Diesel Injection Pump No. E-03-03 SERVICE MANUAL Common Rail System for HINO J08C/J05C Type Engine Operation June, 2003-1 00400024 GENERAL The ECD-U2 was designed

More information

DTC P0134 OXYGEN SENSOR CIRCUIT NO ACTIVITY DETECTED (BANK 1 SENSOR 1)

DTC P0134 OXYGEN SENSOR CIRCUIT NO ACTIVITY DETECTED (BANK 1 SENSOR 1) 05114 DIAGNOSTICS 05CRQ04 DTC P0134 OXYGEN SENSOR CIRCUIT NO ACTIVITY DETECTED (BANK 1 SENSOR 1) CIRCUIT DESCRIPTION Refer to DTC P0130 on page 0596. DTC No. DTC Detecting Condition Trouble Area After

More information

ENGINE COOLING GROUP CONTENTS RADIATOR GENERAL DESCRIPTION SPECIAL TOOLS THERMOSTAT

ENGINE COOLING GROUP CONTENTS RADIATOR GENERAL DESCRIPTION SPECIAL TOOLS THERMOSTAT 14-1 GROUP 14 CONTENTS GENERAL DESCRIPTION 14-2 SPECIAL TOOLS 14-3 DIAGNOSIS 14-3 INTRODUCTION 14-3 TROUBLESHOOTING STRATEGY 14-3 SYMPTOM CHART 14-4 SYMPTOM PROCEDURES 14-4 ON-VEHICLE SERVICE 14-17 ENGINE

More information

ENGINE 6G74 3.5L-SOHC-24 VALVE

ENGINE 6G74 3.5L-SOHC-24 VALVE 11A ENGINE General Information/Service Specifications ENGINE 6G74 3.5L-SOHC-24 VALVE GENERAL INFORMATION Items Specifications Type V-type, Over Head Camshaft Number of cylinders 6 Bore mm 93.0 Stroke mm

More information

1 of 14 9/4/2016 4:05 PM

1 of 14 9/4/2016 4:05 PM 1 of 14 9/4/2016 4:05 PM P0068-MANIFOLD PRESSURE/THROTTLE POSITION CORRELATION P0068-Manifold Pressure/Throttle Position Correlation Theory of Operation This DTC sets when an unexpected high intake manifold

More information

75/90 FOURSTROKE EFI WIRING DIAGRAM

75/90 FOURSTROKE EFI WIRING DIAGRAM 75/0 FOURSTROKE EFI WIRING DIAGRAM 0-87725 MARCH 2005 Page 8A-3 75/0 FourStroke EFI Wiring Diagram - Electronic control module (ECM) 2 - Engine water temperature sensor 3 - Ignition coil for cylinder #

More information

ENGINE AND EMISSION CONTROL

ENGINE AND EMISSION CONTROL 17-1 GROUP 17 ENGINE AND EMISSION CONTROL CONTENTS ENGINE CONTROL.......... 17-3 GENERAL DESCRIPTION...... 17-3 ENGINE CONTROL SYSTEM DIAGNOSIS.................. 17-3 INTRODUCTION TO ENGINE CONTROL SYSTEM

More information

On Board Diagnostics II PCED

On Board Diagnostics II PCED Page 1 of 5 1999 PCED On Board Diagnostics II SECTION 5: Pinpoint Tests HD: Misfire Detection Monitor HD: Introduction HD1 DTC P0301-P0310: CHECK FOR NO LOW FUEL te: Running out of fuel can turn on the

More information

DESCRIPTION Chevrolet Chevy Van 5.7L Eng G20. Service Manual: FUEL INJECTION SYSTEM - TBI

DESCRIPTION Chevrolet Chevy Van 5.7L Eng G20. Service Manual: FUEL INJECTION SYSTEM - TBI Service Manual: FUEL INJECTION SYSTEM - TBI DESCRIPTION 1989 Chevrolet Chevy Van 5.7L Eng G20 The throttle body fuel injection system consists of 7 major sub-assemblies: fuel supply system, throttle body

More information

IMPORTANT: Hoses touching the frame, body, or engine may cause system noise. Verify that the hoses do not touch any other part of the vehicle.

IMPORTANT: Hoses touching the frame, body, or engine may cause system noise. Verify that the hoses do not touch any other part of the vehicle. Page 1 of 16 BLEEDING THE POWER STEERING SYSTEM Tools Required J 35555 Metal Mityvac J 43485 Power Steering Bleeder Adapter IMPORTANT: Hoses touching the frame, body, or engine may cause system noise.

More information

A L L Diagnostic Trouble Codes ( DTC ): P Code Charts P161B DTC P161B ECM/PCM INTERNAL ERROR - TORQUE CALCULATION

A L L Diagnostic Trouble Codes ( DTC ): P Code Charts P161B DTC P161B ECM/PCM INTERNAL ERROR - TORQUE CALCULATION 2006 Kia Truck Sedona V6-3.8L Copyright 2013, ALLDATA 10.52 Page 1 A L L Diagnostic Trouble Codes ( DTC ): P Code Charts P161B DTC P161B ECM/PCM INTERNAL ERROR - TORQUE CALCULATION ENERAL DESCRIPTION Component

More information

DI 3 ENGINE DIAGNOSTICS DI PRE CHECK

DI 3 ENGINE DIAGNOSTICS DI PRE CHECK FI0534 PRECHECK DI3 DI09603 1. DIAGNOSIS SYSTEM (a) Description When troubleshooting OBD II vehicles, the only difference from the usual troubleshooting procedure is that you connect to the vehicle the

More information

GROUP 13Ab. 13Ab-2 CONTENTS TROUBLESHOOTING STRATEGY.. DATA LIST REFERENCE TABLE... 13Ab-29 TROUBLE CODE DIAGNOSIS...

GROUP 13Ab. 13Ab-2 CONTENTS TROUBLESHOOTING STRATEGY.. DATA LIST REFERENCE TABLE... 13Ab-29 TROUBLE CODE DIAGNOSIS... 13Ab-1 GROUP 13Ab CONTENTS TROUBLESHOOTING STRATEGY.. 13Ab-2 DATA LIST REFERENCE TABLE... 13Ab-29 TROUBLE CODE DIAGNOSIS..... 13Ab-2 FAIL-SAFE FUNCTION REFERENCE TABLE........................ 13Ab-20 DIAGNOSTIC

More information

Propane and Gasoline Electronic Fuel Injection

Propane and Gasoline Electronic Fuel Injection Zenith Electronic Engine Management System Propane and Gasoline Electronic Fuel Injection 1 Slide 1 2 Slide 2 Home Page System Advantages Block Diagram, Electronic Control Unit Inputs Output Controls System

More information

F - BASIC TESTING Infiniti G20 INTRODUCTION PRELIMINARY INSPECTION & ADJUSTMENTS VISUAL INSPECTION MECHANICAL INSPECTION

F - BASIC TESTING Infiniti G20 INTRODUCTION PRELIMINARY INSPECTION & ADJUSTMENTS VISUAL INSPECTION MECHANICAL INSPECTION F - BASIC TESTING 1992 Infiniti G20 1992 ENGINE PERFORMANCE Infiniti Basic Diagnostic Procedures G20, M30, Q45 INTRODUCTION The following diagnostic steps will help prevent overlooking a simple problem.

More information

H - TESTS W/O CODES Volvo 960 INTRODUCTION SYMPTOMS SYMPTOM DIAGNOSIS ENGINE PERFORMANCE Volvo Trouble Shooting - No Codes

H - TESTS W/O CODES Volvo 960 INTRODUCTION SYMPTOMS SYMPTOM DIAGNOSIS ENGINE PERFORMANCE Volvo Trouble Shooting - No Codes H - TESTS W/O CODES 1994 Volvo 960 1994 ENGINE PERFORMANCE Volvo Trouble Shooting - No Codes Volvo; 850, 940, 960 INTRODUCTION Before diagnosing symptoms or intermittent faults, perform steps in appropriate

More information

1993 ENGINE PERFORMANCE Volkswagen System & Component Testing - Digifant. EuroVan

1993 ENGINE PERFORMANCE Volkswagen System & Component Testing - Digifant. EuroVan Article Text ARTICLE BEGINNING 1993 ENGINE PERFORMANCE Volkswagen System & Component Testing - Digifant EuroVan INTRODUCTION Since many computer-controlled and monitored components set a trouble code if

More information

I - SYSTEM/COMPONENT TESTS - TURBO

I - SYSTEM/COMPONENT TESTS - TURBO I - SYSTEM/COMPONENT TESTS - TURBO 1995 Volvo 850 1995 ENGINE PERFORMANCE Volvo - System & Component Testing 850 - Turbo INTRODUCTION In this article, Engine Control Module (ECM) may also be referred to

More information

Diagnostic Trouble Code (DTC) Charts

Diagnostic Trouble Code (DTC) Charts SECTION 307-01: Automatic Transaxle/Transmission 5R55S 2009 Mustang Workshop Manual DIAGNOSIS AND TESTING Procedure revision date: 06/30/2009 Diagnostic Trouble Code (DTC) Charts DTC Chart **May also be

More information

FUEL INJECTION SYSTEM - MULTI-POINT

FUEL INJECTION SYSTEM - MULTI-POINT FUEL INJECTION SYSTEM - MULTI-POINT 1988 Jeep Cherokee 1988 Electronic Fuel Injection JEEP MULTI-POINT 4.0L Cherokee, Comanche, Wagoneer DESCRIPTION The Multi-Point Electronic Fuel Injection (EFI) system

More information

Powertrain DTC Summaries EOBD

Powertrain DTC Summaries EOBD Powertrain DTC Summaries Quick Reference Diagnostic Guide Jaguar X-TYPE 2.0 L 2002.25 Model Year Refer to page 2 for important information regarding the use of Powertrain DTC Summaries. Jaguar X-TYPE 2.0

More information

ENGINE AND EMISSION CONTROL

ENGINE AND EMISSION CONTROL 17-1 GROUP 17 ENGINE AND EMISSION CONTROL CONTENTS ENGINE CONTROL.......... 17-3 GENERAL INFORMATION...... 17-3 SERVICE SPECIFICATIONS..... 17-3 TROUBLESHOOTING.......... 17-3 INTRODUCTION TO ENGINE CONTROL

More information

A. Perform a vacuum gauge test to determine engine condition and performance.

A. Perform a vacuum gauge test to determine engine condition and performance. ENGINE REPAIR UNIT 2: ENGINE DIAGNOSIS, REMOVAL, AND INSTALLATION LESSON 2: ENGINE DIAGNOSTIC TESTS NOTE: Testing the engine s mechanical condition is required when the cause of a problem is not located

More information

DTC P0505: IDLE AIR CONTROL (IAC) SYSTEM CIRCUIT

DTC P0505: IDLE AIR CONTROL (IAC) SYSTEM CIRCUIT Page 1 of 5 DTC P0505: IDLE AIR CONTROL (IAC) SYSTEM CIRCUIT CAUTION: If ECM replacement is instructed in following testing, always ensure ECM connectors and ground circuit are okay. If either are suspect,

More information

F - BASIC TESTING Toyota Celica INTRODUCTION PRELIMINARY INSPECTION & ADJUSTMENTS VISUAL INSPECTION MECHANICAL INSPECTION

F - BASIC TESTING Toyota Celica INTRODUCTION PRELIMINARY INSPECTION & ADJUSTMENTS VISUAL INSPECTION MECHANICAL INSPECTION F - BASIC TESTING 1994 Toyota Celica 1994 ENGINE PERFORMANCE Toyota 4-Cylinder Basic Diagnostic Procedures Celica INTRODUCTION The following diagnostic steps will help prevent overlooking a simple problem.

More information

Fuel Metering System Component Description

Fuel Metering System Component Description 1999 Chevrolet/Geo Tahoe - 4WD Fuel Metering System Component Description Purpose The function of the fuel metering system is to deliver the correct amount of fuel to the engine under all operating conditions.

More information

Troubleshooting Self-diagnostic Procedures

Troubleshooting Self-diagnostic Procedures Self-diagnostic Procedures I. When the Malfunction Indicator Lamp (MIL) has been reported on, do the following: 1. Connect the Service Check Connector terminals with a jumper wire as shown. (The 2P Service

More information

11A-1 ENGINE CONTENTS

11A-1 ENGINE CONTENTS 11A-1 ENGINE CONTENTS ENGINE ENGINE ... 11A... 11B 11A-2 ENGINE CONTENTS GENERAL... 3 Outline of Changes... 3 GENERAL INFORMATION... 3 SERVICE SPECIFICATIONS... 3 SEALANT... 3 SPECIAL

More information

H - TESTS W/O CODES INTRODUCTION SYMPTOMS

H - TESTS W/O CODES INTRODUCTION SYMPTOMS H - TESTS W/O CODES 1995 Volvo 850 1995 ENGINE PERFORMANCE Volvo - Trouble Shooting - No Codes 850 INTRODUCTION Before diagnosing symptoms or intermittent faults, perform steps in the F - BASIC TESTING

More information

DTC P0300 RANDOM/MULTIPLE CYLINDER MISFIRE DETECTED DTC P0301 CYLINDER 1 MISFIRE DETECTED DTC P0302 CYLINDER 2 MISFIRE DETECTED

DTC P0300 RANDOM/MULTIPLE CYLINDER MISFIRE DETECTED DTC P0301 CYLINDER 1 MISFIRE DETECTED DTC P0302 CYLINDER 2 MISFIRE DETECTED DTC P0300 RANDOM/MULTIPLE CYLINDER MISFIRE DETECTED 05157 059VJ13 DTC P0301 CYLINDER 1 MISFIRE DETECTED DTC P0302 CYLINDER 2 MISFIRE DETECTED DTC P0303 CYLINDER 3 MISFIRE DETECTED DTC P0304 CYLINDER 4

More information

FUEL 13-1 CONTENTS MULTIPOINT INJECTION (MPI)... 2 GENERAL INFORMATION... 2 SERVICE SPECIFICATIONS... 3 SEALANT... 3 SPECIAL TOOLS...

FUEL 13-1 CONTENTS MULTIPOINT INJECTION (MPI)... 2 GENERAL INFORMATION... 2 SERVICE SPECIFICATIONS... 3 SEALANT... 3 SPECIAL TOOLS... 13-1 FUEL CONTENTS MULTIPOINT INJECTION (MPI)....... 2 GENERAL INFORMATION................ 2 SERVICE SPECIFICATIONS.............. 3 SEALANT............................... 3 SPECIAL TOOLS........................

More information

SYTY Trouble Code: ALDL INFORMATION

SYTY Trouble Code: ALDL INFORMATION SYTY Trouble Code: ALDL INFORMATION A -- Ground G -- Fuel Pump B -- Diagnostic Terminal H -- Brake Sense Speed Input F -- TCC M -- Serial Data (special tool needed - Do Not Use) For ECM Trouble Codes,

More information

Fuel System (Central SFI)

Fuel System (Central SFI) Page 1 of 6 1997 GMC Truck GMC K Pickup - 4WD Chevy Pickup, GMC Pickup, Suburban, Tahoe, Yukon (VIN C/K) Service Manual Engine Engine Controls - 5.0L, 5.7L, and 7.4L Description and Operation Document

More information

IGNITION TIMING (GASOLINE)

IGNITION TIMING (GASOLINE) IGNITION TIMING (GASOLINE) 4-CYLINDER IGNITION TIMING 2.5L (VIN E) 1. Set parking brake, block drive wheels and place transmission in Neutral or Park. Warm engine to normal operating temperature. Turn

More information

EMISSION CONTROL SYSTEM

EMISSION CONTROL SYSTEM XJ EMISSION CONTROL SYSTEM 25-1 EMISSION CONTROL SYSTEM TABLE OF CONTENTS ON-BOARD DIAGNOSTICS 2.5L DIESEL ENGINE... 1 EXHAUST EMISSION CONTROLS 2.5L DIESEL ENGINE... 6 ON-BOARD DIAGNOSTICS 2.5L DIESEL

More information

Code 32. Diagnostic Trouble Code 32

Code 32. Diagnostic Trouble Code 32 Code 32 Diagnostic Trouble Code 32 EGR Solenoid Circuit CIRCUIT DESCRIPTION The ECM operates a solenoid to control the Exhaust Gas Recirculation (EGR) valve. This solenoid is normally close EGR valve.

More information

EMISSION CONTROL SYSTEM

EMISSION CONTROL SYSTEM XJ EMISSION CONTROL SYSTEM 25-1 EMISSION CONTROL SYSTEM CONTENTS EXHAUST EMISSION CONTROLS 2.5L DIESEL ENGINE... 6 ON-BOARD DIAGNOSTICS 2.5L DIESEL ENGINE... 1 ON-BOARD DIAGNOSTICS 2.5L DIESEL ENGINE INDEX

More information

ENGINE COOLING GROUP CONTENTS GENERAL INFORMATION SERVICE SPECIFICATIONS COOLANT SEALANT THERMOSTAT...

ENGINE COOLING GROUP CONTENTS GENERAL INFORMATION SERVICE SPECIFICATIONS COOLANT SEALANT THERMOSTAT... 14-1 GROUP 14 CONTENTS GENERAL INFORMATION 14-2 SERVICE SPECIFICATIONS 14-2 COOLANT 14-3 SEALANT 14-3 DIAGNOSIS 14-3 INTRODUCTION 14-3 TROUBLESHOOTING STRATEGY 14-3 SYMPTOM CHART 14-3 SYMPTOM PROCEDURES

More information

1994 ENGINE PERFORMANCE TOYOTA SYSTEM & COMPONENT TESTING

1994 ENGINE PERFORMANCE TOYOTA SYSTEM & COMPONENT TESTING 1 of 65 12/5/2014 1:13 PM 1994 ENGINE PERFORMANCE TOYOTA SYSTEM & COMPONENT TESTING INTRODUCTION Before testing separate components or systems, perform procedures in articles listed below: BASIC TESTING

More information

Powertrain DTC Summaries EOBD

Powertrain DTC Summaries EOBD Powertrain DTC Summaries Quick Reference Diagnostic Guide Jaguar X-TYPE 2.5L and 3.0L 2001.5 Model Year Revised January, 2002: P0706, P0731, P0732, P0733, P0734, P0735, P0740, P1780 POSSIBLE CAUSES Revised

More information

DI 244 DIAGNOSTICS AUTOMATIC TRANSMISSION DIB30 01 PRE CHECK

DI 244 DIAGNOSTICS AUTOMATIC TRANSMISSION DIB30 01 PRE CHECK DI244 DIAGNOSTICS PRECHECK DIB3001 1. DIAGNOSIS SYSTEM (a) Description When troubleshooting OBD II vehicles, the only difference from the usual troubleshooting procedure is that you connect to the vehicle

More information

DTC No. DTC Detection Condition Trouble Area

DTC No. DTC Detection Condition Trouble Area EINE (5VZFE) DI205 DI8YZ02 DTC P0171 System too Lean (Fuel Trim) DTC P0172 System too Rich (Fuel Trim) CIRCUIT DESCRIPTION Fuel trim is related to the feedback compensation value, not to the basic injection

More information

ENGINE COOLING GROUP CONTENTS GENERAL INFORMATION SERVICE SPECIFICATIONS COOLANT SEALANT THERMOSTAT...

ENGINE COOLING GROUP CONTENTS GENERAL INFORMATION SERVICE SPECIFICATIONS COOLANT SEALANT THERMOSTAT... 14-1 GROUP 14 CONTENTS GENERAL INFORMATION 14-2 SERVICE SPECIFICATIONS 14-2 COOLANT 14-3 SEALANT 14-3 DIAGNOSIS 14-3 INTRODUCTION 14-3 TROUBLESHOOTING STRATEGY 14-3 SYMPTOM CHART 14-3 SYMPTOM PROCEDURES

More information

PRE CHECK DI 456. w/ Tachometer. w/o Tachometer. Hand held Tester AUTOMATIC TRANSMISSION (A340E, A340F) 2003 TOYOTA TACOMA (RM1002U) D10837 D00729

PRE CHECK DI 456. w/ Tachometer. w/o Tachometer. Hand held Tester AUTOMATIC TRANSMISSION (A340E, A340F) 2003 TOYOTA TACOMA (RM1002U) D10837 D00729 DI456 w/ Tachometer w/o Tachometer D10837 PRECHECK DI8Z403 1. DIAGNOSIS SYSTEM (a) Description When troubleshooting OBD II vehicles, the only difference from the usual troubleshooting procedure is that

More information

GROUP 13Aa. 13Aa-5 CONTENTS GENERAL DESCRIPTION... SPECIAL TOOLS... ON-VEHICLE SERVICE... INJECTOR... 13Aa-25. THROTTLE BODY ASSEMBLY...

GROUP 13Aa. 13Aa-5 CONTENTS GENERAL DESCRIPTION... SPECIAL TOOLS... ON-VEHICLE SERVICE... INJECTOR... 13Aa-25. THROTTLE BODY ASSEMBLY... 13Aa-1 GROUP 13Aa CONTENTS GENERAL DESCRIPTION SPECIAL TOOLS 13Aa-2 13Aa-4 13Aa-5 COMPONENT LOCATION 13Aa-5 THROTTLE BODY CLEANING 13Aa-11 ACCELERATOR PEDAL POSITION ADJUSTMENT 13Aa-12 FUEL PRESSURE TEST

More information

DTC Summaries. NipponDenso V12 Engine Management

DTC Summaries. NipponDenso V12 Engine Management DTC Summaries NipponDenso V12 Engine Management OBD II MONITORING CONDITIONS: When testing for DTC reoccurrence, it can be determined if the Service Drive Cycle was of sufficient length by performing a

More information

COMMON RAIL SYSTEM (CRS)

COMMON RAIL SYSTEM (CRS) MITSUBISHI 4N13, 4N14 ENGINES COMMON RAIL SYSTEM (CRS) Issued : November 2010 Applicable Vehicle : Vehicle Manufacturer MITSUBISHI Vehicle Name LANCER ASX OUTLANDER 50000023E 2010 DENSO CORPORATION All

More information

Engine Cranks But Does Not Run

Engine Cranks But Does Not Run Page 1 of 5 2000 GMC Truck GMC K Sierra - 4WD Sierra, Silverado, Suburban, Tahoe, Yukon (VIN C/K) Service Manual Engine Engine Controls - 4.8L, 5.3L, and 6.0L Diagnostic Information and Procedures Engine

More information

I - SYSTEM/COMPONENT TESTS

I - SYSTEM/COMPONENT TESTS I - SYSTEM/COMPONENT TESTS 1995 Volvo 850 1995 ENGINE PERFORMANCE Volvo - System & Component Testing 850 INTRODUCTION NOTE: In this article, Engine Control Module (ECM) may also be referred to as Engine

More information