PIÈCES DÉTACHÉES ELT19RD ELT22RD. Tondeuses autoportées ELT19540RD ( ) ELT2240RD ( )

Transcription

1 PIÈCES DÉTACHÉES Tondeuses autoportées ELT19RD ELT22RD ELT19540RD ( ) ELT2240RD ( ) Yvan Béal - 21, av. de l Agriculture - B.P. 16 Z.I. du Brézet Clermont-Ferrand Cedex 2 Tél : Télécopie : info@yvanbeal.fr R.C.S. Clermont-Fd B S.A.S. au capital de Revision Pr, 4/15/

2

3 Parts Manual for YARD TRACTOR ELECTRIC CLUTCH HYDRO DRIVE RD RMO EUROPEAN PRELIMINARY SERIES MODEL ELT19540RD ( ) ELT2240RD ( ) Briggs & Stratton Yard Power Products Group 535 Macon Road McDonough, GA, U.S.A Revision Pr, 4/15/2008 Manual No

4

5 Table Of Contents PAGE GROUP 4 Wheels & Tires Group 6 Hood, Grille & Dash Group 8 Seat Deck & Fuel Group 10 Steering Group 12 Frame & Front Axle Group 14 Engine Group 16 Controls Group 20 Decals Group 22 Electrical Group 26 Lift Group - Manual 30 40" Mower Deck - Belt & Idler Arm Group 34 40" Mower Deck - Housing, Hitch, Arbors & Blades Group 36 Back Plate Group 40 Collector Group 42 Mulching Flap Group YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 3 Manual No

6 Manual No YARD TRACTOR ELECTRIC CLUTCH 4 PRELIMINARY SERIES

7 Wheels & Tires Group Item Part No Qty Description Note Wheel & Tire 22 x Wheel & Tire Assembly Front, 14.4 x Spacer, Axle, Rear PM Hunter Key, Parallel PLN.187x.187 x 3.0 STL Cap, Hub D, Grey Poly 1.3H, VIPER Washer, SPCL D THK YEL Ring, Klipring EXT For.75 Dia Shaft blk Washer 0.75 x 0.761D x 1.62D x 12 THK), Yel Washer 0.75" Washer Footnotes: YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 5 Manual No

8 Hood, Grille & Dash Group Manual No YARD TRACTOR ELECTRIC CLUTCH 6 PRELIMINARY SERIES

9 Hood, Grille & Dash Group Item Part No Qty Description Note D 1 Hood - With Scoop Duct - Air Inlet D 1 Panel - Hood RH Side D 1 Panel - Hood LH Side D 1 Grille Hinge, Hood LH CS, Hex LK ¼-20 x Nut, Hex-Flange LK Dashboard Knob, Brake Lock Knob, Cruise Lock Nut, Push Pal CS, Hex Tapit 5/16-18 x Washer Cover, Steering Shaft Headlight Assembly Insert, Light Bar Screw, Phillips HD Rod, Dash Support Nut, Flange Screw, Self Tap Guide, Hood LH Guide, Hood RH Braid, Steel-Insert Hinge, Hood RH Bumper, Front Bolt M8 x Washer Washer Nut M Ending Rubber Footnotes: YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 7 Manual No

10 Seat Deck & Fuel Group Manual No YARD TRACTOR ELECTRIC CLUTCH 8 PRELIMINARY SERIES

11 Seat Deck & Fuel Group Item Part No Qty Description Note D 1 Deck, Seat With Foot Rests Bol, x Pad, Footrest, RH Pad, Footrest, LH Tank, Fuel Cap, Fuel Pod, Cup Holder, LH Seat, High Back Spacer Support, Seat Latch, Seat Screw, Flange 5/16-18 x 1.0 DOG PT Washer Cove, Spring Nut, Hex-Flange 5/ Washer, Spring Spring, Compression Bolt, RD 5/16-18 x Pivot, Seat Bolt, Shoulder 5/16-18x Pod, Lift, RH Screw, Hex, PLASTT 0.250x Bolt M8 x Washer Washer Bolt M8 x Nut M Distance, Lift Bolt M6 x Nut M Braid, Steel Insert Hose, Air Escape Clip UM Washer Screw, ST 5,5x Holder, Tank Footnotes: YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 9 Manual No

12 Steering Group Manual No YARD TRACTOR ELECTRIC CLUTCH 10 PRELIMINARY SERIES

13 Steering Group Item Part No Qty Description Note Shaft, Steering Gear & Spline Washer Bushing Steering Wheel Nut, Hex-Lock 5/ Cap, Steering Wheel Snapper Nut M Bracket, Sector Support Bolt M8x Gear, Steering.250 THK 26 teeth Spacer, Sector Gear Screw, Hex LK Falnge 3/8-16x Nut, Hex-Flange 3/8-16LK Ring, Klipring Washer Washer 8 Footnotes: YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 11 Manual No

14 Frame & Front Axle Group Manual No YARD TRACTOR ELECTRIC CLUTCH 12 PRELIMINARY SERIES

15 Frame & Front Axle Group Item Part No Qty Description Note Cap, Hub 1.51D Ring, Klipring Washer, 828 x 1.62 x Axel, Front (Includes Ref. Nos. 1, 2, 3, 17, & 19) Bushing, Axel Pivot A 1 Hook, Hitch.312 THK Capscrew, HD 7/16-14 x Nut, Hex-Falnge 5/8-11 LK Nut, Hex-Flange 5/16-18 LK Capscrew, Hex 3/8-16 x Spacer A 1 Rod, Tie A 1 Spindle & Cup Assembly RH Nut, Hex-Flange 3/8-16LK A 1 Spindle & Cup AssemblyLH Tower Frame Bolt M8 x Nut M Washer Washer Screw, Tap 5/16-18 x Bolt M8x Pivot, Hood Support, Muffler Bolt, RD HD 5/16-18x Washer Capscrew - Hex 5/8-11x Link, Drag Ball-Joint, CS16 M10-M Nut M Distance, Front axle Nut M10 DIN Footnotes: YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 13 Manual No

16 Engine Group Manual No YARD TRACTOR ELECTRIC CLUTCH 14 PRELIMINARY SERIES

17 Engine Group Item Part No Qty Description Note 1 * 1 * Engine, 19.5HP B&S Intek Single, Mod. 31P B1 1 * 1 * Engine, 22HP B&S Intek Twin, Mod B Valve, Shut-off Shield, Heat Screw, TAPTT 5/16-18 x Shield, Heat (19.5HP) Shield, Heat (22HP Twin) Muffler, B&S Twin (22HP Twin) Bracket, Muffler Mount Pipe, Exhaust, LH Side (22HP Twin) Pipe, Exhaust, RH Side (22HP Twin) Muffler, B&S Single (19.5HP) Pipe, Exhaust (19.5HP) Screw, TAPTT 1/4-20x Clip, Wire Control, Throttle Single (19.5HP) Control, Throttle (22HP Twin) Clamp, Hose UM Hose, Fuel Clip, Hose Screw,TAPTT 3/8-16 x 1.00 (19.5HP) Washer, LK EXT-TOOTH Washer, Flat Pulley & Hub Assembly Rod, Clutch Retainer, Long (BLK) Clutch, Electric (LONG OGURA) Washer, Hex Lockwasher 7/ Capscrew, Hex-Head 7/16-20x Gasket, Exhaust Screw, Hex-Head T/R.38-16x Screw Lockwasher Footnotes: NOTE: * See your local Briggs & Stratton distributor for parts and service. YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 15 Manual No

18 Controls Group Manual No YARD TRACTOR ELECTRIC CLUTCH 16 PRELIMINARY SERIES

19 Controls Group Item Part No Qty Description Note Pedal, Forward Ratchet Arm Pedal, Brake Lever, Parking Brake Lever, Brake Rod, Traveling Rod, Brake Pulley, Tensioning Pulley, Idler (Incl. Ref. Nos. 52, 71, 72, 73, 74, 75, 76, 77, & 78) Holder, Left Holder, Right Support, Switch A 1 Latch, Brake Lock Pedal, Reverse Pad, Foot Pedal Latch, Cruise Rod, Cruise.312DIA 2.83LG Bolt, Shoulder 5/ LG Spacer, Foot Pedal Rod, Cruise Latch, Upper Rod,.250dia lg Bushing Washer, Lock Spring, Flat V-Belt, 13x2580 Li BBT Pulley, Compensa C-00237/ Pedal, Forward Rubber Bolt Pedal, Brake Pad Spring TLZ Yellow Spacer, Pivot Distance, Pedal Bushing Ball-Joint CS 13 DIN M8, Silver Clip, Linkage.250 dia Spring TZ 2x14x62, Yellow Footnotes: YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 17 Manual No

20 Controls Group Manual No YARD TRACTOR ELECTRIC CLUTCH 18 PRELIMINARY SERIES

21 Controls Group Item Part No Qty Description Note Pedal, Forward, Top Bolt, Eye M6x80 BN Bolt M6 x Washer Nut, M Spindle 2 x Pin, Flex. 5 x Lock Ring Bolt, RD HD SH SQ NK 5/16-18x Nut, Hex-Flange 5/ LG Bolt M10 x Washer Washer Nut M Lock Ring Screw, Tap 5/16-18 x Nut M Nut M8 DIN Yellow, Tooth Bolt M8 x Washer Nut M Washer Bolt M8 x Bolt Shoulder 5/ LG Transmission, K-46HD Nut M Spring Washer 14x26/ Nut M Bolt M8 x Screw, M10 x Lock Ring, Bushing, Pulley, Tension Pulley Ball-Bearing, Pulley, 62032RS Washer, 11, Zinc Arm, Pulley, Tension Bearing, Slide Footnotes: YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 19 Manual No

22 Decals Group Manual No YARD TRACTOR ELECTRIC CLUTCH 20 PRELIMINARY SERIES

23 Decals Group Item Part No Qty Description Note Decal, 19.5HP Decal, 22HP Decal, Snapper LH Stripe Decal, Snapper LH Stripe Decal, Snapper Steering Wheel Decal, Tunnel Decal, Fuel level Decal, Trans/Tow Release Lever Decal, Ignition Switch White/Blk Decal, Noise Decal, Safety Decal, Mower Height Footnotes: YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 21 Manual No

24 Electrical Group Manual No YARD TRACTOR ELECTRIC CLUTCH 22 PRELIMINARY SERIES

25 Electrical Group Item Part No Qty Description Note Harness, Main Support, Battery Screw, Hex-Washer-Head, TAPTITE x Battery, 12V 230 AMP CCA DRY Hold Down, Battery Bolt, RD HD Carriage x Washer, Flat Nut, Push Nut.25 ESNA Solenoid 12V Screw, Hex-Washer-Head, TAPTITE x Switch Assembly, Ignition (Incl. Ref. Nos. 13, 14, 15, & 16) Washer Lock Washer, Int. Tooth Nut, Hex-Flange IGN Switch Cover, Ignition Switch Hour Meter (22HP Twin) Plug, Hour Meter Switch, PTO Switch,RMO Module Switch, Head lights Plug Switch, Push (foot pedal) Switch, Push NC (Seat) Cable, # Lg Red Cable, # Lg Red Cable, # Lg Black Lockwasher, Spring Nut, Hex KEPS LK Capscrew, Hex.25-20x Washer, Flat Nut, Hex Boot, Insulator, Battery Boot, Insulator, Red Tie, RT 360 /L=150/ V AUX. PLUG, With Cover Switch, NO (RMO) Footnotes: YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 23 Manual No

26 Electrical Group Manual No YARD TRACTOR ELECTRIC CLUTCH 24 PRELIMINARY SERIES

27 Electrical Group Item Part No Qty Description Note Nut, Flange, Whiz Key, RMO Module Microswitch MKH 12 D13 S Beeper, PF 27 A 29 EP Wire Wire Cable, Clip WSBH Clip, Speed Wire Plug, Shut-Off Clip, Cable WCK /A Socket Assembly Bulb, V 21CP Reflector, Headlight Lens, Headlight Headlight Assembly (Includes Ref. Nos. 56, 57, 58, & 59) Key, Ignition (Set of 2) Fuse Footnotes: YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 25 Manual No

28 Lift Group - Manual Manual No YARD TRACTOR ELECTRIC CLUTCH 26 PRELIMINARY SERIES

29 Lift Group - Manual Item Part No Qty Description Note Mowing Mechanism Hinge, Front Arm, Lift Rod, Lift Tie Rod, Lift Distance, Lift Pin Pin, Mowing Distance, Lift Hitch Pïn Spring Spring Handle, Extend, Left Handle, Extend, Right Rod, Lift Grip, Black Washer, Rod, Lift.375 dia Spring, TORS Clevis, Lift Spacer, Pivot Pin, Hitch A 1 Hanger, Front Decal, Height of Cut Quadran, Lift Height Capscrew, HD 5/16-18x Capscrew, HD 5/16-18x0.62 TAP Nut-Hex-Flange LK 5/ Bolt, RD 1/4-20 x Nut, Hex-Flange-Whiz 1/ Bushing Lock Ring Spindle, Spring Clip, Pin Safety Spindle 3.2x Bolt M12x Washer 13 Footnotes: YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 27 Manual No

30 Lift Group - Manual Manual No YARD TRACTOR ELECTRIC CLUTCH 28 PRELIMINARY SERIES

31 Lift Group - Manual Item Part No Qty Description Note Washer Nut M Nut M V-Belt 17x1200 Li, BBT, ARAMID Footnotes: YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 29 Manual No

32 40" Mower Deck - Belt & Idler Arm Group Manual No YARD TRACTOR ELECTRIC CLUTCH 30 PRELIMINARY SERIES

33 40" Mower Deck - Belt & Idler Arm Group Item Part No Qty Description Note COVER, Plastic MAIN BOARD FOOTING, Complete WASHER, Zinc NUT M BELT, Pulley 28 Z BEARING, RS C 66IB SAFETY RING WASHER NUT M WASHER BELT, Pulley WASHER NUT M REINFORCEMENT REINFORCEMENT SCREW M8 x NUT M STUD WASHER SCREW, Zinc, M8 x WASHER WASHER NUT M SCREW M 8 x NUT M SCREW M6 x WASHER, Zinc BELT, Two Side Toothed, K+K20DS V-BELT, 17x1200 Li, BBT, ARAMID HOLDER, Complete STUD, ROLLER, W FOOTING WASHER, Zinc WASHER NUT M8 Footnotes: YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 31 Manual No

34 40" Mower Deck - Belt & Idler Arm Group Manual No YARD TRACTOR ELECTRIC CLUTCH 32 PRELIMINARY SERIES

35 40" Mower Deck - Belt & Idler Arm Group Item Part No Qty Description Note NUT M SCREW M8 x ZN DIN WASHER WASHER BELT, Pulley, , Complete WASHER NUT M SCREW M 8 x WASHER WASHER REINFORCEMENT COVER, Belt Pulley WASHER, Zinc NUT M SPRING, Footnotes: YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 33 Manual No

36 40" Mower Deck - Housing, Hitch, Arbors & Blades Group Manual No YARD TRACTOR ELECTRIC CLUTCH 34 PRELIMINARY SERIES

37 40" Mower Deck - Housing, Hitch, Arbors & Blades Group Item Part No Qty Description Note COVER, Cutting knife, Complete HOUSING REINFORCEMENT BEARING RS C 66IB SCREW M 8 x WASHER NUT M SHAFT TONGUE 6 H 9 x 6 x TONGUE 6 H 9 x 6 x SHAFT TONGUE 6 H 9 x 6 x RING, Safety, HOUSING SHEAR STUD CUTTING KNIFE, Rotary, Right CUTTING KNIFE, Rotary, Left SCREW M WASHER WASHER BN x 16.3 x 2 x SCREW M10, Left Thread QUICK FASTENER RING 13 x 2 NBR NUT M CUTTING WHEEL, Right ETOP 100-8, SCREW M8 x NUT M FRONT MOUNT STUD PIN, Flexible MOWING STUD PIN, Flexible Footnotes: YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 35 Manual No

38 Back Plate Group Manual No YARD TRACTOR ELECTRIC CLUTCH 36 PRELIMINARY SERIES

39 Back Plate Group Item Part No Qty Description Note Tunnel Back Plate Brace Holder, Back Plate Left Holder, Back Plate Right Holder, Collector Right Holder, Collector, Left Hitch Switch, full collector Tie Rod, Bypass Tie Rod, Latch Latch Cover, Switch Pad, Rubber Transition Part, Plastic Spring, Collector Lock Holder, Adjustable Right Holder, Adjustable, Left Screw, ST 5.5 x 19 DIN 7504-K BN Screw, ST 4.2 x 9.5 DIN 7504-K BN Bolt M12 x Nut M Washer Washer Bolt M8 x 25 DIN Nut M Washer Washer Nut M Bolt M8 x 30 DIN Bolt M8 x Bolt M5 x Nut M Washer Washer Bolt M5 x Nut M5 Footnotes: YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 37 Manual No

40 Back Plate Group Manual No YARD TRACTOR ELECTRIC CLUTCH 38 PRELIMINARY SERIES

41 Back Plate Group Item Part No Qty Description Note Bolt M6 x Washer Nut M Spindle 2 x Bolt M4 x Washer Nut M Pad, Packing Footnotes: YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 39 Manual No

42 Collector Group Manual No YARD TRACTOR ELECTRIC CLUTCH 40 PRELIMINARY SERIES

43 Collector Group Item Part No Qty Description Note Frame,Top Tube, Front Brace Tube, Bottom Tube, Connecting Reinforcement Left Reinforcement Right Handle, Full Coat, Fabric Top, Collector Lever, Dumping Handle, Rubber RC/M Bolt M5 x Bolt M5 x Plug, Plastic Bolt M5 x Bolt M5 x Washer Washer Lock Nut M Bolt M8 x Washer Washer, Lock Nut M Washer Nut M Bolt M5 x Spring, Flat Reinforcement, Top Screw 6.3 x 32 DIN 7504-K Footnotes: YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 41 Manual No

44 Mulching Flap Group Manual No YARD TRACTOR ELECTRIC CLUTCH 42 PRELIMINARY SERIES

45 Mulching Flap Group Item Part No Qty Description Note Mowing Flange Tube Holder Full Tube Handle 02/ RED Split Pin Screw M8 x 45 CSN Nut M8 CSN Screw M8 x 35 CSN Washer 8 CSN Nut M8 CSN Spring TLZ Casing Screw M8 x 12 CSN Footnotes: YARD TRACTOR ELECTRIC CLUTCH PRELIMINARY SERIES 43 Manual No

46